E5767 PN2280D
User Manual: PN2280D
Open the PDF directly: View PDF 
.
Page Count: 22
| Download | |
| Open PDF In Browser | View PDF |
Clarion Co., Ltd. Published by Service Dept. Export Division - 22-3, Shibuya 2-chome, Shibuyaku, Tokyo, 150-8335 Japan Tel: 03-3400-1121 Service Dept.- 50 kamitoda,Toda-shi,Saitama,335-8511 Japan Tel: 048-443-1111 FAX:048-433-6996 298-5767-00 Sep.1999 P Printed in Japan Service Manual NISSAN Automobile Genuine AM/FM Radio Cassette Stereo CD Deck Model PN-2280D-A (Genuine No.28188 2Y900) (ID No.CN628) Model PN-2280D-B (Genuine No.28188 2Y900) (ID No.CN628) (Available from Serial No.15271) ■ SPECIFICATIONS Radio section CD section Tuning system: Receive range: Disc: 12cm,8cm Disc Frequency response: 17Hz to 20kHz(0.5W output) Separation: More than 50dB S/N ratio: More than 74dB PLL Frequency synthesizer system AM 530kHz to 1,710kHz FM 87.75MHz to 107.9MHz Intermediate frequency: AM 450kHz FM 10.7MHz Quieting sensitivity: AM Less than 37dBμ (at 20dB S/N) FM Less than 15dBμ (at 30dB S/N,Main) Separation: FM More than 20dB Auto tuning stop sensitivity: AM 39±6dBμ(at 1000k,1400kHz) FM 32±6dBμ AUX section Gain: FRONT/REAR 18±3dB (AUX input 1kHz,245mV,Vol.max) General Load impedance: 4Ω/ch Power output: 30W×4 Power supply voltage: DC13.2V(10.8V to 15.6V) Negative ground Back-up consumption: Less than 3mA Dimensions(mm): 180(W)×108(H)×160(D) Weight: 3.0kg Tape section Reproducting system: 4 track,2 program 2 channel stereo system Wow and flutter: Less than 0.15％(W.R.M.S) Separation: More than 35dB Cross talk: More than 45dB S/N ratio: Normal tape(120μs) 47dB/55dB(DOLBY B NR ON) Metal tape(70μs) 49dB/57dB(DOLBY B NR ON) FF/REW time: 110sec.(C-60) ※ Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. ※ "DOLBY" and the double-D symbol are trademarks of Dolby Laboratories Licensing Corporation. ※ Specifications and design are subject to change without notice for further improvement. -1- PN-2280D ploblems around the repaired spots. If extended damage is caused due to negligence of repair, the legal responsibility shall be with the repairing company. 4. Caution in removal and making wiring connection to the parts for the automobile. Disconnect the battery terminal after turning the ignition key off. If wrong wiring connections are made with the battery connected, a short circuit and/or fire may occur. If extensive damage is caused due to negligence of repair, the legal responsibility shall be with the repairing company. 5. Cautions regarding chips. Do not reuse removed chips even when no abnormality is observed in their appearance. Always replace them with new ones. (The chip parts include resistors, capacitors, diodes, transistors, etc). The negative pole of tantalum capacitors is highly susceptible to heat, so use special care when replacing them and check the operation afterwards. 6. Cautions in handling flexible PWB Before working with a soldering iron, make sure that the iron tip temperature is around 270℃. Take care not to apply the iron tip repeatedly(more than three times)to the same patterns. Also take care not to apply the tip with force. 7. Turn the unit OFF during disassembly and parts replacement. Recheck all work before you apply power to the unit. 8. Cautions in checking that the optical pickup lights up. The laser is focused on the disc reflection surface through the lens of the optical pickup. When checking that the laser optical diode lights up, keep your eyes more than 30cms away from the lens. Prolonged viewing of the laser within 30cms may damage your eyesight. 9. Cautions in handling the optical pickup The laser diode of the optical pickup can be damaged by electrostatic charge caused by your clothes and body. Make sure to avoid electrostatic charges on your clothes or body, or discharge static electricity before handling the optical pickup. 9-1. Laser diode The laser diode terminals are shorted for transportation in order to prevent electrostatic damage. After replacement, open the shorted circuit. When removing the pickup from the mechanism, short the terminals by soldering them to prevent this damage. 9-2. Actuator The actuator has a powerful magnetic circuit. If a magnetic material is put close to it. its characteristics will change. Ensure that no foreign substances enter through the ventilation slots in the cover. 9-3. Cleaning the lens Dust on the optical lens affects performance. To clean the lens, apply a small amount of isopropylalcohol to lens paper and wipe the lens gently. ■ COMPONENTS PN-2280D-A/PN-2280D-B Main unit −−−−− 1 ■ NOTE We cannot supply PWB with component parts in principle. When a circuit on PWB has failure , please repair it by component parts base. Parts which are not mentioned in service manual are not supplied. ■ CAUTIONS Use of controls,adjustment,or performance of procedures other than those specified herein,may result in hazardous radiation exposure. The compact disc player should not be adjusted or repaired by anyone except properly qualified service personnel. P N -2 2 8 0 D Top View of model PN-2280 ■ To engineers in charge of repair or inspection of our products. Before repair or inspection, make sure to follow the instructions so that customers and Engineers in charge of repair or inspection can avoid suffering any risk or injury. 1. Use specified parts. The system uses parts with special safety features against fire and voltage. Use only parts with equivalent characteristics when replacing them. The use of unspecified parts shall be regarded as remodeling for which we shall not be liable. The onus of product liability (PL) shall not be our responsibility in cases where an accident or failure is as a result of unspecified parts being used. 2. Place the parts and wiring back in their original positions after replacement or re-wiring. For proper circuit construction, use of insulation tubes, bonding, gaps to PWB, etc, is involved. The wiring connection and routing to the PWB are specially planned using clamps to keep away from heated and high voltage parts. Ensure that they are placed back in their original positions after repair or inspection. If extended damage is caused due to negligence during repair, the legal responsibility shall be with the repairing company. 3. Check for safety after repair. Check that the screws, parts and wires are put back securely in their original position after repair. Ensure for safety reasons there is no possibility of secondary PN-2280D -2- S U B 8 8 0 -1 5 1 7 E T U N E R P A C K (A M ) IF /N C /M P X F M F R O N T -E N D A M -T U N E R IF F M F R O N T -E N D -3- C D C H A N G E R S IG N A L R F -A M P IC 3 C X A 1 6 1 0 a e b f P R E -A M P D O L B Y -B ,A P S IC 1 H A 1 2 1 6 3 S IG N A L S O R S E R V O P R O C E S O R C X D 2 5 4 8 IT A L O C E S IT A L N A L u P D 7 8 0 0 2 C D C O N T R O L IC 5 M O T O R D R IV E R IC 4 0 0 T A 7 2 9 1 (P M -C D ) S E R V O -D R IV E R IC 1 ,2 B A 6 3 9 2 /T A 7 2 9 1 IC 4 D IG P R D IG S IG C D M E C H A N IS M D IV E R S IT Y N O IS E C A N C E L L E R IC 1 5 0 T U N E R P A C K (F M ) 8 8 0 -1 7 2 6 E T A P E M E C H A N IS M (G F N -1 ) M A IN L .P .F . Q 4 0 3 ,4 0 4 N J M 2 0 6 0 1 /2 D U T Y F L -T U B E F L -D R IV E R IC 7 0 0 L C 7 5 7 4 1 u P D 1 7 7 1 8 P O W E R -S U P P L Y C D -C H A N G E R IN T E R F A C E N J M 2 0 6 0 E Q U A L IZ E R IC 3 0 1 - 3 0 3 ,6 0 0 K E Y -M A T R IX B U F F E R -A M P IC 3 0 0 S Y S T E M -C O N T R O L IC 4 0 2 L C 7 5 3 8 6 E -V O L IC 2 0 0 T A 8 2 6 0 P O W E R IC IC 6 0 1 M G H C D h g J c k I j O N B F A E P L ■ BLOCK DIAGRAM PN-2280D ■ ADJUSTMENT Switch of diversity ※ How to fix the MAIN channel. While holding the buttons of CH1 and CH3, turn on the power switch. ※ How to fix the SUB channel. While holding the buttons of CH4 and CH6, turn on the power switch. ※ To release the MAIN or SUB channel, turn off the power switch. Measuring instrument Item Procedure FM noise convergence MAIN channel 1. Fix the MAIN channel. 2. Input the 98.1MHz/55dBμ(1kHz 30%MOD) signal. (VOL 1.4V=0dB) 3. Adjust the outputs to −18±1dB(−14±1dB) by VR101 when the SG output is set −20dBμ. SUB channel 1. Follow the same adjustment steps as MAIN above.(by VR100) SSG AC volt meter FM SD 1. Input a 98.1MHz/31dBμ(1kHz 30%MOD) signal. 2 Connect OSC to TP100(SD), and adjust VR102 so that the reading of OSC is 0V to 6V. 1. Insert a Dolby level test tape(400Hz,200nWb/m). 2. Adjust VR1(L)/VR2(R) so that an output of TP401(L)/TP400(R) is 300mV±1dB. (Dolby sw:off) SSG Oscilloscope Dolby level Dolby level tape Milli-volt meter ■ EXPLANATION OF IC ■ μPD17718GC-528-3B9 052-1147-30 Tuner / Tape / CD Auto changer / CD Controller 1.Outward Form : 80 pins QFP 2.Terminal Description pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin 1 : ACC IN 2 : CD EJ 3 : TAPE EJ 4 : VOL 1 5 : VOL 2 6 : FL DO 7 : FL CL 8 : FL CE 9 : KS 0 10 : KS 1 11 : KS 2 12 : KS 3 13 : KS 4 14 : KS 5 15 : POWER SW : : : : : : : : : : : : : : : IN IN IN IN IN O O O O O O O O O IN pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin pin 16 : KR 4 17 : FL ON 18 : SYS ON 19 : FM ON 20 : AM ON 21 : GND 22 : KR 3 23 : KR 2 24 : KR 1 25 : KR 0 26 : ILL DC 27 : REEL PULS 28 : AM IF 29 : FM IF 30 : VCC 31 : FM OSC 32 : AM OSC 33 : GND 34 : N.C. 35 : EO 36 : GND 37 : RE MUTE 38 : DX/LO : : : : : : : : : : : : : : : : : : : : : : : IN O O O O IN IN IN IN IN IN IN IN IN IN O O O O pin 39 : TWEET pin 40 : BEEP PN-2280D : O : O : Acc-ON-signal input. Negative logic. : CD-eject-signal input. Negative logic. : Tape-eject-signal input. Negative logic. : Main volume control signal input. : Main volume control signal input. : Serial data output to VFD-driver. : Serial data clock output to VFD-driver. : Chip-enable signal output to VFD-driver. : Key scan signal output. Ref. Table 3. : Key scan signal output. Ref. Table 3. : Key scan signal output. Ref. Table 3. : Key scan signal output. Ref. Table 3. : Key scan signal output. Ref. Table 3. : Key scan signal output. Ref. Table 3. : Power Key input(alternative). Negative logic. : Key scan signal input. Ref. Table 3. : Filament-ON signal output to VFD-driver. : System-ON signal output. (Hi-Z) : FM-ON signal output. (Hi-Z) : AM-ON signal output. (Hi-Z) : Ground. : Key scan signal input. Ref. Table 3. : Key scan signal input. Ref. Table 3. : Key scan signal input. Ref. Table 3. : Key scan signal input. Ref. Table 3. : VFD-brightness control signal input. : Reel pulse input. : AM-IF counter input. : FM-IF counter input. : Positive voltage input. : FM VCO ( Local Oscillation ) input. : AM VCO ( Local Oscillation ) input. : Ground. : Not in use. : Error out terminal. : Ground. : IF-output control. Output "H" in SEEK. : "L" = ( AM SEEK ) & ( ILL ON ) "H" = ( FM ) & ( Sub fixed ) : In AM mode, Output "L" in receiving 900kHz. In FM mode, Output "H" in Main-fixed mode. : Beep out. pin pin pin pin pin 41 : ILL PULSE 42 : TEL ON 43 : DOLBY 44 : T/R 45 : F/R : : : : : IN IN O O O pin 46 : MS : IN pin 47 : TAPE IN pin 48 : BIT 3 : IN : IN pin 49 : BIT 2 : IN pin 50 : BIT 1 : IN pin 51 : MSGV : O pin pin pin pin : : : : 52 : M-MOTOR 53 : P2 54 : P1 55 : VOL STB2 O O O O pin 56 : VOL STB1 : O pin 57 : VOL CLK : O pin 58 : VOL DATA pin 59 : AF MUTE : O : O pin pin pin pin pin pin pin : : : : : : : 60 : AMP ON 61 : R VOL DW 62 : R VOL UP 63 : MODE C 64 : MODE B 65 : MODE A 66 : CD RESET O IN IN O O O O pin 67 : CD SRQ : IN pin pin pin pin pin pin pin : : : : : : : 68 : NDS REQ 69 : NDS TXD 70 : NDS RXD 71 : CD SCK 72 : CD SI 73 : CD SO 74 : REG pin 75 : GND pin 76 : XOUT -4- IN O IN O IN O - : : O : ILL-pulse input. : Tel-on signal input. Negative logic. : "H" = DOLBY on. : "H" = Mechanism mute on. : "H" = forward ( Tape ). "L" = reverse ( Tape ). : Music sensing signal input. "H" = non-recorded. : Tape loading start signal input. : Mechanism mode switch signal input. Ref. Table 1. : Mechanism mode switch signal input. Ref. Table 1. : Mechanism mode switch signal input. Ref. Table 1. : Music sensing amplifier sensitivity control signal output. "H" = play, "L" = FF/Rew. : "H" = Main motor on. : Power motor control. Ref. Table 2. : Power motor control. Ref. Table 2. : STB2 output for electric volume IC TC9412F. : STB1 output for electric volume IC LC75386. : Serial data clock output for electric volume IC. : Serial data output for electric volume IC. : Audio frequency mute signal output. Negative logic. : "H" = Power amplifier on. : Remote control volume input. : Remote control volume input. : Remote control mode indicator output. : Remote control mode indicator output. : Remote control mode indicator output. : Reset signal output to CD mechanism controller. Negative logic. : C-BUS service request signal input. "L" = CD mechanism controller request. : Request input from NDS-A/C. : TX output to NDS-A/C. : RX input from NDS-A/C. : C-BUS clock output. : C-BUS serial data input. : C-BUS serial data output. : Connects a capacitor to reduce voltage regulator ripple. : Ground. : Connects a crystal. pin pin pin pin 77 : XIN 78 : CE 79 : VDD 80 : RESET : : : : IN IN IN : Connects a crystal. : Chip enable signal input. : Power supply terminal. : Reset signal input. Negative logic. pin 23 : XLAT pin 24 : VSS pin 25 : DATA pin 26 : SCLK pin 27 : N.C. pin 28 : SENS pin 29 : SQSO Table 1. Mechanism mode switch Mechanism mode Bit1 Bit2 Bit3 Eject H H H Loading H H L Stop L H L Fwd-FF ( Rev-Rew ) L L H Fwd-Rew ( Rev-FF ) H L L Fwd-Play H L H Rev-Play L H H P1 P2 pin 30 : N.C. pin 31 : SQCK Table 2. Power motor control Mechanism mode Loading, Head advance H L Eject, Head retreat L H Keeping a state H H Stop L L 3.Key Matrix Table 3. Key Matrix table KR 0 pin25 KR 1 pin24 KR 2 pin23 KR 3 pin22 KS 0 pin9 FM/ AM Tape Seek up/ Scan up Seek down/ Scan down KS 1 pin10 M1 APS Rew M2 APS-FF M3 Prog KS 2 pin11 M4 DOLBY M5 REW M6 FF KS 3 pin12 Sound Tune up/ Disc up/ Sound up Tune down/ Disc down/ Sound down Mode Seek up/ APS up ( Tr SW ) Seek down/ APS down ( Tr SW ) ILL on ST on ( Tr SW ) ( Tr SW ) ( Tr SW ) BAND 0 Ref.Table4 ( Di SW ) BAND 1 Ref.Table4 ( Di SW ) BAND 2 Ref.Table4 ( Di SW ) Clock on/off on=1 ( Di SW ) 2SP=1 4SP=0 ( Di SW ) BAND 0 BAND 1 BAND 2 KS 4 pin13 KS 5 pin14 KR 4 pin16 32 : SYSM 33 : N.C. 34 : N.C. 35 : RST 36 : SCOR 37 : ACC-CNT pin pin pin pin pin pin pin pin pin pin pin 38 : N.C. 39 : N.C. 40 : VDD 41 : X2 42 : X1 43 : IC0 44 : XT2 45 : XT 1/P04 46 : IC1 47 : N.C. 48 : SYS-1 CD/ CHG pin 49 : SYS-2 Table 4. Diode switch Diode switch pin pin pin pin pin pin Normal volume 0 1 0 BOSE6V volume 0 0 1 pin pin pin pin pin pin pin pin 0 = open , 1 = shorted with diode ■ μPD78002BGC-650-AB8 052-5018-03 PMCD Controller 1. Outward Form : 64pins, QFP 50 : N.C. 51 : N.C. 52 : N.C. 53 : N.C. 54 : N.C. 55 : IC2 56 : IC3 57 : K-0 pin 58 : K-1 2. Terminal Description pin 1 : SRQ : O : C-BUS service request signal output. Negative logic. pin 2 : CHU-SW : IN : CD disc chucking signal input. Negative logic. pin 3 : N.C. : O : Not in use. pin 4 : N.C. : O : Not in use. pin 5 : N.C. : O : Not in use. pin 6 : B : IN : Photo sensor input to detect CD disc status. pin 7 : A : IN : Photo sensor input to detect CD disc status. pin 8 : C : IN : Photo sensor input to detect CD disc status. pin 9 : VSS : − : Ground. pin 10 : MCCW : O : Loading motor control output. Ref. Table 1. pin 11 : MCW : O : Loading motor control output. Ref. Table 1. pin 12 : N.C. : O : Not in use. pin 13 : N.C. : O : Not in use. pin 14 : N.C. : O : Not in use. pin 15 : N.C. : O : Not in use. pin 16 : N.C. : O : Not in use. pin 17 : N.C. : O : Not in use. pin 18 : N.C. : O : Not in use. pin 19 : N.C. : O : Not in use. pin 20 : ACDT : IN : Not in use. pin 21 : XRST : O : Reset signal output to CXD2548. Negative logic. pin 22 : CLOCK : O : Clock signal output to CXD2548. Negative logic. -5- pin 59 : K-2 pin 60 : K-3 pin 61 : K-4 pin 62 : SI pin 63 : SO pin 64 : SCK : O : Latch signal output to CXD2548. Negative logic. : − : Ground. : O : Serial data output to CXD2548. : O : Serial clock output to read data from CDIC. Negative logic. : O : Not in use. : IN : CD status signal detect. Negative logic. : IN : Serial data input to read out SUB-Q-data from CXD2548. Negative logic. : O : Not in use. : O : Clock signal output to read SUB-Q-data from CXD2548. Negative logic. : O : Mute signal output. Negative logic. : O : Not in use. : O : Not in use. : IN : Reset signal input. Negative logic. : IN : Sub code synchronization. : IN : C-BUS ACC CNT input terminal. If "L" is input during disc rotation (Play,FF,FB,Search), it enters into power saving mode after disc rotation stops. If "L" is input in Loading or Ejecting, it enters into power saving mode after completion of motion. : O : Not in use. : O : Not in use. : − : Power supply voltage. : O : Connect ceramic resonator. : IN : Connect ceramic resonator. : − : Connected to ground. : O : Not in use. : − : Connected to ground. : − : Connected to ground. : O : Not in use. : O : Output terminal to control system power 1. Control terminal to switch between power for loading motor driver IC and that for CD driver IC (+8V). Outputs "H" when ACC-CNT input terminal is "H" while this micro computer is regular motion. Outputs "L" when ACC-CNT input terminal is "L" while this micro computer is in power saving mode. Power ON in "H" .Power OFF in "L" . : O : Output terminal to control system power 2. Control terminal to switch power to CDIC (+5V). Turns this terminal to "H" in CD PLAY. Other than that, "L" . Power ON in "H" . Power OFF in "L" . : O : Not in use. : O : Not in use. : O : Not in use. : O : Not in use. : O : Not in use. : − : Connected to ground. : − : Connected to ground. : I/O : Key input in test mode. Function as output terminal in C-BUS communication mode. : I/O : Key input in test mode. Function as output terminal in C-BUS communication mode. : I/O : Key input in test mode. Function as output terminal in C-BUS communication mode. : I/O : Key input in test mode. Function as output terminal in C-BUS communication mode. : IN : Terminal to detect Test mode starting. Checks the terminal logic during hard reset and ACC ON (during ACC-CNT = "H" ) just after start of program. Outputs "H" in C-BUS communication mode. Outputs "L" in Test mode. : IN : C-BUS serial data input. : O : C-BUS serial data output. : IN : C-BUS serial data clock input. Table 1 Loading Eject Brake MCW H L H Stop L MCCW L H H L PN-2280D ■ EXPLODED VIEW・PARTS LIST Escutcheon section 5 to M a in s e c tio n 9 to M a in s e c tio n 1 2 1 7 1 6 1 3 5 6 2 4 2 3 1 4 5 1 9 1 8 8 6 2 3 7 1 0 2 5 1 5 1 1 2 0 1 2 1 2 2 NO. 1 PART NO. 4 DESCRIPTION 940-7866-00 ESCUTCHEON-ASSY Q'TY NO. 1 14 016-0010-08 VARIABLE RESISTOR 1 15 039-1457-00 DISPLAY PWB (WITHOUT COMPONENT) 1 16 335-5989-00 DISC GUIDE 1 17 346-0112-00 LEATHER SHEET 1 18 382-5346-00 BUTTON 1 19 335-5975-00 ILLUMI-PLATE L 1 20 335-5976-00 ILLUMI-PLATE R 1 21 373-0904-01 DIAL COVER 1 22 380-5434-00 KNOB 1 23 320-0529-84 DUSTPROOF COVER 1 2 347-6075-00 SPACER 2 3 347-5985-00 COLOR PAPER 1 4 347-5961-02 SILENCER 3 5 716-1553-00 P-TIGHT SCREW(3×8) 6 6 714-2606-81 MACHINE SCREW(M2.6×6) 4 7 331-2624-00 ESCUTCHEON PLATE 1 8 716-0778-00 WAVE SCREW(2×6) 12 9 345-8090-00 CUSHION RUBBER 1 10 074-1151-16 OUTLET SOCKET(16P) 1 11 379-4023-20 INDICATOR 1 12 013-6200-60 TACT SWITCH 16 13 017-0420-28 PILOTLAMP(14V40mA) 6 PN-2280D PART NO. DESCRIPTION Q'TY 24 750-2626-00 SPRING 1 25 074-1151-12 OUTLET SOCKET(12P) 1 -6- Main section 2 8 3 0 8 3 4 1 2 8 2 9 3 0 1 6 1 3 1 4 2 7 2 8 3 2 3 0 2 8 1 7 1 8 1 0 2 8 2 8 3 0 2 8 2 8 7 9 2 8 2 8 1 1 3 3 2 5 2 8 2 6 3 6 1 5 3 1 5 2 8 2 4 1 9 1 2 2 0 2 1 2 2 2 3 3 5 NO. 1 PART NO. DESCRIPTION 310-1639-00 UPPER CASE 4 2 6 2 2 8 Q'TY NO. PART NO. DESCRIPTION 1 19 880-1517E TUNER PACK(AM) Q'TY 1 2 311-1726-00 LOWER CASE 1 20 074-1013-00 OUTLET SOCKET(12P) 1 3 305-0263-10 SIDE PLATE(LH) 1 21 074-1186-18 OUTLET SOCKET(18P) 1 4 305-0264-10 SIDE PLATE(RH) 1 22 076-0540-16 PLUG(16P) 1 5 309-0697-00 FRONT PLATE 1 23 076-0540-12 PLUG(12P) 1 6 331-2275-01 MECH-BRKT 1 24 076-0368-20 PLUG(20P) 1 7 331-2281-01 MECH BRKT(F) 1 25 074-0898-20 OUTLET SOCKET(20P) 1 8 331-2282-00 MECH BRKT(R) 1 26 039-1459-10 MAIN PWB (WITHOUT COMPONENT) 1 27 345-4138-00 SPACER 1 28 714-2606-81 MACHINE SCREW(M2.6×6) 23 29 714-2612-81 MACHINE SCREW(M2.6×12) 2 30 714-2303-81 MACHINE SCREW(M2.3×3) 6 31 076-0461-20 PLUG(20P) 1 32 347-2022-02 SHADE 1 33 347-5679-02 DOUBLE FACE 1 34 286-8153-25 SETPLATE 1 35 880-1726E 1 9 331-2270-20 ANT HOLDER 1 10 331-2271-00 OUTLET HOLDER 1 11 331-2301-00 IC HOLDER 1 12 331-2272-00 TR HOLDER 1 13 313-1712-00 HEAT SINK 1 14 816-2447-00 FLAT CABLE 1 15 930-0790-02 TAPE-MECHANISM 1 16 929-0068-02 CD-MECHANISM 1 17 074-1185-00 OUTLET SOCKET 1 18 051-2023-01 IC(TA8260AH) 1 -7- TUNER PACK(FM) PN-2280D Tape mechanism section 3 9 1 1 4 7 1 5 J 1 1 -1 5 4 3 9 4 0 X L 1 7 3 6 5 1 1 6 2 4 K 1 6 -1 I' 1 6 -2 1 6 -3 W 3 7 1 6 -4 5 0 2 2 3 9 E I 3 9 4 6 3 5 X 3 9 O 7 M M 3 9 1 9 F 3 4 3 9 L 3 9 O ' 8 O 2 8 1 8 5 2 3 2 O ' 2 3 A N 4 5 3 3 4 1 1 4 4 5 3 2 N ' 2 9 Q J P I' E A 2 6 P 3 0 Y ' 4 4 R 4 3 F 4 9 1 G N K C 3 8 I Q 4 8 G ' 5 Q ' H 3 1 9 B Z Y R 2 6 D ' N ' Q ' D C ' C H ' H ' 3 Y ''' Y '' 4 3 G 1 0 G ' C ' H 1 3 4 3 Y '' Y ' 4 2 D Z 6 2 7 W Y 2 0 4 3 1 2 -2 D ' 1 2 -3 B 2 1 1 2 -6 Y ''' 1 2 -5 4 3 1 2 -4 1 2 -1 1 2 3 9 PN-2280D -8- 2 5 NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY 1 960-4294-14 DECK PLATE ASSY 1 22 606-0101-08 PACK GUIDE 1 2 960-4261-05 HEAD PLATE ASSY 1 23 610-0342-01 HEAD-P-ROLLER 1 3 960-4262-03 FF/REW-P-ASSY 1 24 610-0343-00 GUIDE-A-ROLLER 1 611-0091-02 FLYWHEEL 2 613-0662-00 IDLER GEAR 2 4 960-4263-03 IDLER-P-ASSY L 1 25 5 960-4264-03 IDLER-P-ASSY R 1 26 6 960-4266-05 MODE PLATE ASSY 1 27 613-0286-02 FF/REW GEAR 2 7 960-4269-05 ROLLER ASSY F 1 28 613-0288-01 HELICAL GEAR 1 8 960-4270-05 ROLLER ASSY R 1 29 613-0289-01 GEAR A 1 613-0337-00 POWER GEAR 1 1 9 960-4348-03 REEL ASSY F 1 30 10 960-4349-03 REEL ASSY R 1 31 630-2597-01 CHANGE LINK 11 960-4298-09 EJECT SUB ASSY 1 32 630-2598-05 EJECT LINK 1 750-2948-01 SWITCH PLATE SPRING 1 33 630-2600-01 ADJUST LINK 1 960-4338-07 BOTTOM SUB ASSY 1 34 630-2601-02 MOTOR PLATE 1 630-2626-05 PWB FRAME 1 630-2605-02 GUIDE ARM 1 37 631-1992-02 PACK STOPPER 1 38 631-1993-01 SLIDE BUSH 2 39 716-0484-00 SCREW(M2×2.5) 13 40 716-1676-00 PWB SCREW(M2.6×6) 2 41 716-0833-10 SCREW(M2×5.6) 2 42 746-0624-00 WASHER 2 43 746-0724-00 WASHER 6 44 746-0761-00 WASHER 2 45 746-0762-00 WASHER 1 46 750-2946-02 PINCH SPRING 1 47 750-2947-03 EJECT-P-SPRING 1 48 750-2949-00 SLIDE SPRING 2 49 750-3017-02 IDLER-P-SPRING 1 50 800-4910-60 WIRE(BLK) 1 51 802-4911-60 WIRE(RED) 1 52 806-4914-60 WIRE(BLU) 1 53 809-4914-60 WIRE(WHT) 1 54 074-0898-10 OUTLET SOCKET(10P) 1 11-1 12 12-1 960-4295-02 BOTTOM-P-ASSY 1 35 12-2 099-9926-01 BOTTOM PWB (WITHOUT COMPONENT) 1 36 12-3 013-3951-11 SWITCH(MODE) 1 12-4 013-3953-01 SWITCH(METAL) 1 12-5 051-1776-00 IC 1 12-6 746-0767-00 WASHER 2 13 960-4282-06 DETECT SUB ASSY 1 14 960-4301-02 PLAY LINK ASSY 1 15 039-1436-00 SIDE PWB (WITHOUT COMPONENT) 1 16 990-0713-00 REAR PWB ASSY (WITH COMPONENT) 1 16-1 013-3906-00 SWITCH(TAPE IN) 1 16-2 074-1104-20 OUTLET SOCKET(20P) 1 16-3 076-0368-10 PLUG(10P) 1 16-4 039-0489-00 REAR PWB 1 17 SMA-130-100 MAIN MOTOR ASSY 1 18 SMA-131-100 POWER MOTOR ASSY 1 19 011-0307-34 HEAD 1 20 602-0118-00 BELT 1 21 604-0046-00 TENSION PULLEY 1 -9- PN-2280D CD mechanism section 1 -1 3 1 -3 1 -1 2 1 -2 5 1 -1 1 1 -3 3 1 1 -4 1 -3 5 1 -9 1 -1 0 1 -3 6 Z 1 -4 1 -5 1 -3 1 1 -1 4 1 -2 1 1 -2 3 7 1 -1 5 1 -4 1 -8 1 -4 1 -4 1 -3 0 1 -3 2 1 -4 1 -2 4 1 -2 8 1 -2 2 6 8 1 -2 9 1 -3 4 1 -4 9 1 -2 0 1 -1 8 1 -2 5 1 -1 7 1 -4 3 4 3 3 1 -4 1 -1 Z 1 -6 1 -7 2 1 -1 9 1 -2 7 1 -1 6 1 -2 6 4 NO. 1 PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY 968-0067-02 DRIVE UNIT ASSY 1 1-10 621-0205-02 CLAMPER RING 1 1-1 SMA-151-100 MOTOR ASSY(SPINDLE) 1 1-11 621-0251-03 LOCK LINK 1 1-2 750-3098-00 L-LINK SPRING 1 1-12 620-0198-03 CLAMPER PLATE 1 1-3 716-1468-00 SCREW(M2×2.5) 2 1-13 966-0314-21 STOP LINK-ASSY 1 1-4 716-2003-81 SCREW(M2×3) 10 1-14 966-0448-21 SIDE PLATE-ASSY 1 1-5 SMA-146-100 MOTOR ASSY(SLED) 1 1-15 621-0252-03 DISC STOPPER 1 1-6 969-0050-03 PICK UP UNIT 1 1-16 620-0491-03 SPRING PLATE 1 1-7 HBS-432-100 LS-GEAR ASSY 1 1-17 966-0454-00 SCREW H-RACK-ASSY 1 1-8 966-0447-22 DR-PLATE-ASSY 1 1-18 621-0358-02 LS-HOLDER-F 1 1-9 966-0449-22 CLAMP-LINK-ASSY 1 1-19 013-7100-00 SWITCH(LIMIT) 1 PN-2280D - 10 - 5 9 4 9 4 2 1 0 1 6 2 7 3 7 4 2 4 2 4 4 2 1 5 9 6 0 5 9 4 2 2 2 2 2 2 3 4 3 6 3 9 3 4 1 9 2 8 5 4 6 0 2 9 1 5 3 1 2 5 4 3 3 3 4 7 4 9 1 7 3 5 3 0 5 3 5 7 3 8 5 4 4 0 5 6 4 9 5 0 1 4 5 1 1 8 4 5 2 0 1 1 4 6 4 1 2 5 9 6 0 6 0 1 3 2 6 4 2 6 0 6 0 5 8 6 0 3 2 5 5 5 2 4 4 3 5 4 8 4 1 5 8 5 8 NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY 1-20 621-0357-03 PICK UP GUIDE 1 1-30 620-0690-01 RATTLE PLATE 1 1-21 621-0253-02 MOTOR HOLDER 1 1-31 746-0761-00 WASHER 2 1-22 621-0255-02 SECOND GEAR 1 1-32 716-1733-00 SCREW(M1.7×2.3) 2 1-23 622-1073-02 CLAMPER ROLLER 1 1-33 750-3099-00 ES-SPRING 1 1-24 621-0359-02 LS-HOLDER-R 1 1-34 750-3097-03 CLAMPER SPRING 1 1-25 621-0375-00 SH-BASE 1 1-35 816-2373-00 LEAD WIRE(WHT) 1 1-26 716-0675-00 SCREW(M2×5.5) 2 1-36 1-27 716-1555-00 WAVE SCREW(Φ2×8) 1 2 1-28 732-2004-11 SEMS SCREW(M2×4) 2 1-29 739-1735-17 PRECISION SCREW (M1.7×3.5) 2 - 11 - 816-2372-00 LEAD WIRE(BLU) 1 039-1101-02 CD PWB ASSY (WITH COMPONENT) 1 3 001-0563-00 LED 3 4 716-1670-00 SCREW(M2×4) 6 PN-2280D NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY 5 750-3202-00 CENTER SPRING-B 1 33 800-4910-60 VINYL-COAT-WIRE(BLK) 6 750-3096-01 DR-SPRING R 1 34 621-0402-01 U-DISC GUIDE-F 1 7 750-3164-00 DR-SPRING LR 1 35 621-0243-02 ROLLER SLEEVE 2 8 750-3188-00 DR-SPRING F-B 1 36 800-4904-60 VINYL-COAT-WIRE(BLK) 1 9 750-3201-00 DR-SPRING F-R 1 37 750-3189-00 SIDE-L-SPRING 1 10 966-0308-23 CHASSIS-ASSY 1 38 750-3098-00 L-LINK SPRING 1 11 966-0309-22 L-DISC-G-ASSY 1 39 750-3094-00 S-ARM SPRING 1 12 966-0310-21 SHIFT-P-CH-ASSY 1 40 621-0248-07 RACK GEAR 1 1 13 HBS-430-100 GEAR PLATE ASSY 1 41 621-0249-02 ROLLER GEAR 1 14 966-0312-21 SHIFT-PLATE-ASSY 1 42 621-0250-01 DAMPER HOLDER 4 15 966-0358-21 DRIVE-L-PLATE-ASSY 1 43 750-3092-03 SHIFT SPRING 1 16 966-0359-21 SIDE-L-PLATE-ASSY 1 44 750-3091-03 ROADING-SPRING-R 1 17 SMA-147-100 MOTOR ASSY(LOADING) 1 45 750-3090-02 ROADING-SPRING-L 1 18 013-3879-01 CHUCKING SWITCH 1 46 746-0877-02 WASHER 2 19 804-4910-60 VINYL-COAT-WIRE(YEL) 1 47 746-0762-00 WASHER 1 20 039-0586-01 CHUCKING SWITCH PWB (WITHOUT COMPONENT) 1 48 746-0712-03 WASHER 1 21 039-0588-01 SENSOR PWB (WITHOUT COMPONENT) 1 49 743-1500-10 E-RING 3 50 621-0258-03 LOADING ROLLER 2 22 060-0252-01 PHOTO-TR 3 51 716-1742-00 SCREW(M2×5) 1 23 345-7513-01 CLAMPER SHEET 1 52 716-1704-00 SCREW(M2×7) 1 716-1677-00 SCREW(M2×5) 1 24 345-7514-00 SENSOR PWB SHEET 1 53 25 802-4910-60 VINYL-COAT-WIRE(RED) 1 54 716-1507-00 SCREW(M2×3) 2 26 620-0485-20 FRONT PLATE 1 55 622-1072-05 ROLLER SHAFT 1 27 620-0488-20 S-L-LINK PLATE 1 56 716-1468-00 SCREW(M2×2.5) 2 28 620-0489-02 MOTOR PLATE 1 57 622-1219-01 SHIFT ROLLER 1 29 802-4904-60 VINYL-COAT-WIRE(RED) 1 58 714-2603-81 SCREW(M2.6×3) 5 30 620-0492-20 MOTOR BRACKET 1 59 629-0058-00 DAMPER-VA 4 31 801-4910-60 VINYL-COAT-WIRE(BRN) 1 60 714-2003-81 SCREW(M2×3) 8 32 620-0697-02 CD-MECH-BRKT 1 ■ ELECTRICAL PARTS LIST Main PWB section(B1) REF No. BL100 BL150 C102 C103 C105 C106 C108 C109 C111 C112 C120 C121 C122 C130 C150 C152 C153 C154 C155 C156 C157 C158 C159 C160 C161 PART No. 880-1726E 880-1517E 178-1045-79 043-0277-01 178-3932-78 178-3932-78 183-4763-32 178-1045-79 178-4742-78 178-4742-78 178-1022-78 176-1011-00 176-1011-00 166-1011-00 176-1007-00 042-0427-02 178-1045-79 168-1022-05 168-2232-05 178-1242-78 166-5601-00 183-1063-32 178-5632-78 042-0504-06 178-8232-78 PN-2280D DESCRIPTION FM TUNER AM TUNER 0.1μF 0.022μF 0.039μF 0.039μF 16V47μF 0.1μF 0.47μF 0.47μF 1000pF 100pF CH 100pF CH 100pF CH 10pF CH 16V33μF 0.1μF 1000pF 0.022μF 0.12μF 56pF CH 16V10μF 0.056μF 16V3.3μF 0.082μF REF No. C162 C163 C164 C165 C166 C167 C168 C169 C170 C171 C172 C173 C174 C175 C177 C180 C200 C202 C203 C204 C205 C206 C207 C208 C209 Note) Several different parts of the same reference number are alternative parts. One of those parts is used in the set. Some parts depend on each model.The model name is specified in the description. PART No. 168-4712-05 168-2732-05 168-4712-05 166-5601-00 166-4701-00 168-4722-05 168-1032-05 178-4732-78 168-1032-05 168-2232-05 183-4753-52 183-4753-52 178-6832-78 178-1032-78 178-1042-78 183-4763-32 042-0505-04 178-1842-78 042-0562-36 042-0562-36 042-0562-36 042-0562-36 178-1842-78 042-0562-36 042-0562-36 DESCRIPTION 470pF 16V 0.027μF 470pF 56pF CH 47pF CH 4700pF 0.01μF 0.047μF 0.01μF 0.022μF 35V4.7μF 35V4.7μF 0.068μF 0.01μF 0.1μF 16V47μF 10V33μF 0.18μＦ 50V1μF 50V1μF 50V1μF 50V1μF 0.18μＦ 50V1μF 50V1μF - 12 - REF No. C210 C211 C212 C213 C214 C215 C217 C218 C220 C221 C222 C223 C224 C225 C226 C250 C251 C252 C253 C255 C256 C257 C258 C300 C301 PART No. 042-0562-17 042-0562-17 042-0562-17 042-0562-17 042-0562-36 042-0562-36 178-1242-78 178-1242-78 168-1532-05 168-1532-05 168-3312-05 168-3312-05 042-0562-17 042-0562-17 178-3332-78 168-1022-05 168-1022-05 168-1022-05 168-2232-05 042-0562-17 042-0562-17 042-0562-17 042-0562-17 042-0562-17 042-0562-17 DESCRIPTION 16V10μF 16V10μF 16V10μF 16V10μF 50V1μF 50V1μF 0.12μF 0.12μF 0.015μF 0.015μF 330pF 330pF 16V10μF 16V10μF 0.033μF 1000pF 1000pF 1000pF 0.022μF 16V10μF 16V10μF 16V10μF 16V10μF 16V10μF 16V10μF REF No. C302 C303 C305 C306 C308 C309 C312 C313 C314 C315 C320 C321 C322 C323 C324 C325 C326 C327 C328 C329 C330 C331 C332 C333 C334 C335 C336 C337 C338 C339 C340 C341 C342 C343 C350 PART No. 042-0562-17 042-0562-17 168-4712-05 168-4712-05 166-2201-00 166-2201-00 168-3322-05 168-3322-05 166-2201-00 166-2201-00 178-2242-78 178-2242-78 043-0309-91 043-0309-91 043-0309-02 043-0309-02 178-2742-78 178-2742-78 178-1832-78 043-0309-02 043-0309-02 178-1832-78 178-3332-78 178-6832-78 178-6832-78 178-3332-78 178-1242-78 178-1842-78 178-1842-78 178-1242-78 178-6832-78 178-3332-78 178-3332-78 178-6832-78 168-2232-05 C351 168-2232-05 C352 168-2232-05 C400 C401 C402 C403 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C416 C418 C421 C424 C425 C426 C427 C429 C431 C432 C436 C439 C451 C456 C460 C461 C462 C464 C465 C467 C468 178-1045-79 178-1045-79 178-1045-79 178-1045-79 043-0277-01 183-1063-32 042-0458-00 168-1022-05 178-1045-79 183-4763-32 178-1045-79 178-1045-79 166-1201-00 182-1073-32 166-1201-00 178-1045-79 183-1073-22 166-1011-00 166-1011-00 166-1011-00 166-3301-00 178-1045-79 183-4763-12 178-1045-79 042-0562-20 042-0562-20 183-4753-52 183-4753-52 042-0548-02 183-1073-22 168-1022-05 166-1011-00 178-1045-79 166-1011-00 166-1011-00 DESCRIPTION REF No. 16V10μF C470 16V10μF C473 470pF C474 470pF C475 22pF CH C500 22pF CH C501 3300pF C502 3300pF C503 22pF CH C505 22pF CH C506 0.22μF C507 0.22μF C508 10V 0.82μF C510 10V 0.82μF C511 10V 0.68μF C512 10V 0.68μF C513 0.27μF C514 0.27μF C516 0.018μF C517 10V 0.68μF C518 10V 0.68μF C520 0.018μF C521 0.033μF C600 0.068μF C601 0.068μF C602 0.033μF C603 0.12μF C604 0.18μＦ C605 0.18μＦ C606 0.12μF C607 0.068μF C608 0.033μF C609 0.033μF C610 0.068μF C612 0.022μF C613 (PN-2280D-B ONLY) C614 0.022μF C615 (PN-2280D-B ONLY) C617 0.022μF C619 (PN-2280D-B ONLY) C900 0.1μF C903 0.1μF C904 0.1μF C905 0.1μF C906 0.022μF C907 16V10μF C908 50V1μF C909 1000pF C910 0.1μF C911 16V47μF C912 0.1μF C913 0.1μF C914 12pF CH C915 16V100μF C916 12pF CH C917 0.1μF C918 10V100μF C920 100pF CH C921 100pF CH C922 100pF CH C923 33pF CH CCT400 0.1μF CCT403 6.3V47μF CCT404 0.1μF CCT405 16V47μF CCT406 16V47μF CCT407 35V4.7μF CCT408 35V4.7μF D250 10V220μF D251 10V100μF D252 1000pF D253 100pF CH D401 0.1μF D402 100pF CH D404 100pF CH D405 PART No. 168-1022-05 178-2242-78 178-2242-78 178-4742-78 172-1041-11 042-0571-00 183-4753-52 042-0571-00 168-2222-05 168-2222-05 168-2222-05 168-2222-05 168-2222-05 168-2222-05 168-2222-05 168-2222-05 168-2222-05 183-1053-62 183-1063-32 172-1041-11 042-0548-03 042-0548-03 178-6832-78 178-6832-78 178-6832-78 178-6832-78 168-1032-05 178-6832-78 178-6832-78 168-2232-05 168-1032-05 178-6832-78 178-6832-78 172-2241-11 172-2241-11 172-2241-11 172-2241-11 042-0505-03 183-1053-62 176-1511-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 166-2201-00 176-2201-00 176-2201-00 176-2201-00 176-2201-00 050-0122-00 050-0122-03 050-0122-03 050-0122-03 050-0122-03 050-0122-03 050-0122-03 001-0589-00 001-0589-00 001-0421-38 001-0377-44 001-0516-00 001-0503-45 001-0377-38 001-0400-48 - 13 - DESCRIPTION 1000pF 0.22μF 0.22μF 0.47μF 0.1μF 16V2200μF 35V4.7μF 16V2200μF 2200pF 2200pF 2200pF 2200pF 2200pF 2200pF 2200pF 2200pF 2200pF 50V1μF 16V10μF 0.1μF 16V100μF 16V100μF 0.068μF 0.068μF 0.068μF 0.068μF 0.01μF 0.068μF 0.068μF 0.022μF 0.01μF 0.068μF 0.068μF 0.22μF 0.22μF 0.22μF 0.22μF 16V2.2μF 50V1μF 150pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 22pF CH 10kΩ×4 J 1kΩ×4 1kΩ×4 1kΩ×4 1kΩ×4 1kΩ×4 1kΩ×4 1SS145 1SS145 MTZJ36 MA4082M MA111 HZS9B1L MA4068M HZS9.1JB3 REF No. D406 D407 D408 D409 D411 D415 D416 D417 D418 D419 D420 D421 D422 D423 D424 D500 D503 D504 D505 D507 D509 D600 D601 D602 D603 D900 IC150 IC200 IC300 IC301 IC302 IC303 IC400 IC402 PART No. 001-0356-00 001-0377-69 001-0377-10 001-0516-00 001-0516-00 001-0516-00 001-0330-00 001-0516-00 001-0516-00 001-0516-00 001-0516-00 001-0516-00 001-0516-00 001-0516-00 001-0516-00 001-0503-31 001-0330-00 001-2015-00 001-0626-00 001-0377-34 001-0626-00 001-2606-90 001-2606-90 001-2606-90 001-2606-90 001-0516-00 051-4200-90 051-5012-00 051-3019-90 051-3019-90 051-3019-90 051-3019-90 051-1014-10 052-1147-30 IC404 IC600 IC601 J250 J400 J500 J501 L100 L101 L102 L150 L151 L152 L400 L401 P400 P401 P402 P403 Q100 Q101 Q102 Q103 Q104 Q105 Q251 Q252 Q253 Q254 Q400 Q402 Q403 Q404 Q405 Q406 Q407 Q412 Q415 Q416 Q417 051-3020-90 051-3019-90 051-2023-01 074-1013-00 074-1186-18 074-0898-20 074-1185-00 010-2230-76 010-2230-76 010-2230-64 010-2003-04 010-2230-76 010-6004-40 010-2230-76 010-2230-76 076-0461-20 076-0368-20 076-0540-12 076-0540-16 125-2005-01 100-1298-00 125-2005-01 125-9003-02 100-1298-00 125-2005-01 125-9006-00 103-0601-00 125-2005-01 125-0001-01 103-2012-00 125-9003-02 102-2458-51 102-2458-51 100-1428-00 125-2004-06 103-2012-00 103-1858-00 125-9003-02 103-2012-00 125-0006-00 DESCRIPTION 1SS184 MA4180M MA4030L MA111 MA111 MA111 1SS119 MA111 MA111 MA111 MA111 MA111 MA111 MA111 MA111 HZS6 A2L 1SS119 RL253 1A2 MA4062L 1A2 M1FS4 M1FS4 M1FS4 M1FS4 MA111 TA2051FN LC75386 NJM2060V NJM2060V NJM2060V NJM2060V TA7291S UPC17718GC-5283B9 NJM4565V NJM2060V TA8260AH 12P 18P 20P 16P 22μH 22μH 2.2μH COIL 22μH 2.2mH J 22μH 22μH 20P 20P 12P 16P UN2211 2SA1298 UN2211 IMD3 2SA1298 UN2211 IMX1 2SD601A UN2211 UN2111 2SD2012 IMD3 2SC2458Y.GR.BL 2SC2458Y.GR.BL 2SA1428 RN1406 2SD2012 2SD1858 IMD3 2SD2012 UN2110 PN-2280D REF No. Q419 Q423 Q424 Q426 Q500 Q501 Q502 Q503 Q504 Q505 Q511 Q512 Q513 R106 R109 R110 R113 R114 R115 R116 R117 R119 R151 R152 R153 R154 R155 R156 R158 R159 R160 R161 R162 R200 PART No. 125-0006-00 125-2005-01 125-2005-01 125-2005-01 103-1858-00 125-9003-02 100-1048-00 125-2005-01 103-0601-00 103-1858-00 125-2005-01 101-0709-00 100-1359-00 119-2221-10 119-1041-10 119-4731-10 119-2221-10 119-2221-10 119-1031-10 119-1031-10 119-2221-10 119-1521-10 119-1031-10 119-1031-10 119-1011-10 119-1031-10 119-1211-10 119-1231-10 119-6821-15 119-5631-10 119-3331-10 119-1021-10 119-2221-10 117-0000-00 R200 117-1211-10 R204 R205 R210 R211 R250 R251 R252 R253 R254 R255 R256 R257 R258 R259 R260 R261 R262 R263 R264 R265 R266 R267 R268 R269 R270 R271 R300 R301 R302 R303 R304 R305 R306 R307 R309 R310 R312 R313 119-4721-10 119-4721-10 119-4741-10 119-4731-10 119-5621-10 119-5621-10 119-5631-10 119-5631-10 119-1031-10 119-1031-10 119-5631-10 119-1031-10 119-1021-10 119-4731-10 119-2231-10 119-4731-10 032-0106-66 032-0106-66 032-0106-66 032-0106-66 032-0106-66 032-0106-66 032-0106-55 032-0106-55 032-0106-55 032-0106-55 119-1531-10 119-1531-10 119-1331-10 119-1331-10 119-3331-10 119-3331-10 119-3331-10 119-3331-10 119-1031-10 119-1031-10 119-1031-10 119-1031-10 PN-2280D DESCRIPTION REF No. R314 UN2110 R315 UN2211 R318 UN2211 R319 UN2211 R320 2SD1858 R321 IMD3 R322 2SA1048 R323 UN2211 R324 2SD601A R325 2SD1858 R326 UN2211 R327 2SB709A-Q.R.S R332 2SA1359 R333 1/16W 2.2kΩ R336 1/16W 100kΩ R337 1/16W 47kΩ R338 1/16W 2.2kΩ R339 1/16W 2.2kΩ R340 1/16W 10kΩ R341 1/16W 10kΩ R342 1/16W 2.2kΩ R343 1/16W 1.5kΩ R346 1/16W 10kΩ R347 1/16W 10kΩ R348 1/16W 100Ω R349 1/16W 10kΩ R350 1/16W 120Ω R351 1/16W 12kΩ R352 1/16W 6.8kΩ R353 1/16W 56kΩ R354 1/16W 33kΩ R355 1/16W 1kΩ R356 1/16W 2.2kΩ R357 1/10W 0Ω JW (PN-2280D-A ONLY) R358 R359 1/10W 120Ω (PN-2280D-B ONLY) R360 R361 1/16W 4.7kΩ R362 1/16W 4.7kΩ R363 1/16W 470kΩ R364 1/16W 47kΩ R365 1/16W 5.6kΩ R366 1/16W 5.6kΩ R367 1/16W 56kΩ R368 1/16W 56kΩ R369 1/16W 10kΩ R370 1/16W 10kΩ R371 1/16W 56kΩ R400 1/16W 10kΩ R401 1/16W 1kΩ R402 1/16W 47kΩ R403 1/16W 22kΩ R404 1/16W 47kΩ 1/10W 100Ω±0.5% R405 1/10W 100Ω±0.5% R406 1/10W 100Ω±0.5% R407 1/10W 100Ω±0.5% R408 1/10W 100Ω±0.5% R409 1/10W 100Ω±0.5% R411 R412 1/10W 4.7Ω±0.5% R417 1/10W 4.7Ω±0.5% R423 1/10W 4.7Ω±0.5% R424 1/10W 4.7Ω±0.5% R425 1/16W 15kΩ R426 1/16W 15kΩ R427 1/16W 13kΩ R431 1/16W 13kΩ R432 1/16W 33kΩ R436 1/16W 33kΩ R437 1/16W 33kΩ R438 1/16W 33kΩ R439 1/16W 10kΩ R440 1/16W 10kΩ R441 1/16W 10kΩ R442 1/16W 10kΩ PART No. 119-4721-10 119-4721-10 119-1631-10 119-1631-10 119-4721-10 119-4721-10 119-1031-10 119-1031-10 119-2221-10 119-2221-10 119-2221-10 119-2221-10 117-7521-10 117-7521-10 117-5611-10 117-5611-10 117-4731-10 117-4731-10 117-4731-10 117-4731-10 117-5611-10 117-5611-10 117-5121-10 117-5121-10 117-2021-10 117-9111-10 117-9111-10 117-2021-10 117-1511-10 117-1511-10 117-1511-10 117-1511-10 117-1541-10 117-1541-10 117-1541-10 117-1541-10 117-1541-10 117-1541-10 117-1541-10 117-1541-10 117-1511-10 117-1511-10 117-1511-10 117-1511-10 117-2021-10 117-3621-10 117-3621-10 117-2021-10 119-1031-10 119-1031-10 111-3311-91 119-2221-10 119-2721-10 111-1221-91 111-1221-91 119-4721-10 119-2221-10 119-1031-10 117-2221-10 119-1041-10 119-4721-10 119-4731-10 119-4731-10 119-4731-10 119-4731-10 119-4731-10 111-3311-91 119-1041-10 117-1021-10 119-4731-10 119-4721-10 119-4721-10 119-1031-10 119-4731-10 119-1031-10 DESCRIPTION 1/16W 4.7kΩ 1/16W 4.7kΩ 1/16W 16kΩ 1/16W 16kΩ 1/16W 4.7kΩ 1/16W 4.7kΩ 1/16W 10kΩ 1/16W 10kΩ 1/16W 2.2kΩ 1/16W 2.2kΩ 1/16W 2.2kΩ 1/16W 2.2kΩ 1/10W 7.5kΩ 1/10W 7.5kΩ 1/10W 560Ω 1/10W 560Ω 1/10W 47kΩ 1/10W 47kΩ 1/10W 47kΩ 1/10W 47kΩ 1/10W 560Ω 1/10W 560Ω 1/10W 5.1kΩ 1/10W 5.1kΩ 1/10W 2kΩ 1/10W 910Ω 1/10W 910Ω 1/10W 2kΩ 1/10W 150Ω 1/10W 150Ω 1/10W 150Ω 1/10W 150Ω 1/10W 150kΩ 1/10W 150kΩ 1/10W 150kΩ 1/10W 150kΩ 1/10W 150kΩ 1/10W 150kΩ 1/10W 150kΩ 1/10W 150kΩ 1/10W 150Ω 1/10W 150Ω 1/10W 150Ω 1/10W 150Ω 1/10W 2kΩ 1/10W 3.6kΩ 1/10W 3.6kΩ 1/10W 2kΩ 1/16W 10kΩ 1/16W 10kΩ 1/4WS 330Ω 1/16W 2.2kΩ 1/16W 2.7kΩ 1/4WS 1.2kΩ 1/4WS 1.2kΩ 1/16W 4.7kΩ 1/16W 2.2kΩ 1/16W 10kΩ 1/10W 2.2kΩ 1/16W 100kΩ 1/16W 4.7kΩ 1/16W 47kΩ 1/16W 47kΩ 1/16W 47kΩ 1/16W 47kΩ 1/16W 47kΩ 1/4WS 330Ω 1/16W 100kΩ 1/10W 1kΩ 1/16W 47kΩ 1/16W 4.7kΩ 1/16W 4.7kΩ 1/16W 10kΩ 1/16W 47kΩ 1/16W 10kΩ - 14 - REF No. R446 R452 R458 R460 R461 R470 R472 R473 R474 R475 R476 R479 R480 R487 R488 R489 R490 R491 R492 R493 R494 R495 R499 R500 R502 R503 R505 R506 R508 R509 R518 R519 R521 R522 R525 R526 R529 R530 R601 R602 R603 R604 R605 R606 R607 R608 R609 R610 R611 R612 R613 R615 R616 R618 R619 R625 R626 R627 R628 R629 R630 R631 R632 R633 R700 R702 R703 R704 R705 SUP100 T500 VR100 VR101 VR102 X400 PART No. 119-2231-10 111-1011-91 119-4731-10 119-4731-10 119-4731-10 119-1041-10 119-4721-10 119-4721-10 119-4721-10 119-4731-10 119-4731-10 119-4731-10 119-4731-10 111-1001-91 111-1001-91 111-1001-91 111-1001-91 119-4741-10 119-1031-10 119-1031-10 119-1031-10 119-1031-10 119-1021-10 111-1011-91 119-4721-10 117-0000-00 119-3321-10 119-1031-10 117-1031-10 111-1531-91 119-4721-10 111-1221-91 111-4791-91 111-4791-91 111-1531-91 114-2291-11 117-5611-10 119-1031-10 117-5131-10 117-5131-10 117-7521-10 117-7521-10 119-1231-10 117-1031-10 117-1031-10 117-5131-10 117-5131-10 117-5131-10 117-5131-10 117-1031-10 117-1031-10 117-7521-10 117-7521-10 117-5131-10 117-5131-10 119-1031-10 117-1031-10 117-1031-10 117-1031-10 117-1031-10 117-1031-10 117-1031-10 117-1031-10 117-1031-10 119-1021-10 119-1021-10 119-1021-10 119-1021-10 119-2231-10 060-0122-20 009-0658-02 012-5203-57 012-5203-56 012-5203-56 061-3501-90 DESCRIPTION 1/16W 22kΩ 1/4WS 100Ω 1/16W 47kΩ 1/16W 47kΩ 1/16W 47kΩ 1/16W 100kΩ 1/16W 4.7kΩ 1/16W 4.7kΩ 1/16W 4.7kΩ 1/16W 47kΩ 1/16W 47kΩ 1/16W 47kΩ 1/16W 47kΩ 1/4WS 10Ω 1/4WS 10Ω 1/4WS 10Ω 1/4WS 10Ω 1/16W 470kΩ 1/16W 10kΩ 1/16W 10kΩ 1/16W 10kΩ 1/16W 10kΩ 1/16W 1kΩ 1/4WS 100Ω 1/16W 4.7kΩ 1/10W 0Ω JW 1/16W 3.3kΩ 1/16W 10kΩ 1/10W 10kΩ 1/4WS 15kΩ 1/16W 4.7kΩ 1/4WS 1.2kΩ 1/4WS 4.7Ω 1/4WS 4.7Ω 1/4WS 15kΩ 1W 2.2Ω 1/10W 560Ω 1/16W 10kΩ 1/10W 51kΩ 1/10W 51kΩ 1/10W 7.5kΩ 1/10W 7.5kΩ 1/16W 12kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 51kΩ 1/10W 51kΩ 1/10W 51kΩ 1/10W 51kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 7.5kΩ 1/10W 7.5kΩ 1/10W 51kΩ 1/10W 51kΩ 1/16W 10kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 10kΩ 1/10W 10kΩ 1/16W 1kΩ 1/16W 1kΩ 1/16W 1kΩ 1/16W 1kΩ 1/16W 22kΩ DSP-141N-S00B 0.7mH 22kΩ 10kΩ 10kΩ 4.5MHz Display PWB section(B2) REF No. C700 C701 C702 C703 FL700 IC700 J700 J701 L700 PL700 PL701 PL702 PART No. 043-0206-61 043-0206-63 043-0206-63 043-0206-28 379-4023-20 051-6011-10 074-1151-12 074-1151-16 010-2230-76 017-0420-28 017-0420-28 017-0420-28 DESCRIPTION 0.1μF F 0.022μF F 0.022μF F 47pF SL VFD LC75741G 12P 16P 22μH 14V40mA(WHITE) 14V40mA(WHITE) 14V40mA(WHITE) REF No. PL703 PL704 PL705 R700 R701 S700 S701 S702 S703 S704 S705 S706 PART No. 017-0420-28 017-0420-28 017-0420-28 111-4741-91 111-1031-91 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 DESCRIPTION 14V40mA(WHITE) 14V40mA(WHITE) 14V40mA(WHITE) 1/4WS 470kΩ 1/4WS 10kΩ SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA REF No. S707 S708 S709 S710 S711 S712 S713 S714 S716 VR700 PART No. 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 013-6200-60 016-0010-08 DESCRIPTION SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA SKPLAA CD mechanism/CD PWB section(B3) REF No. PART No. DESCRIPTION C1 178-1032-78 0.01μF C2 178-1042-78 0.1μF C3 178-1032-78 0.01μF C4 182-4763-13 6.3V47μF C5 178-1042-78 0.1μF C6 182-4763-13 6.3V47μF C7 178-1042-78 0.1μF C8 176-1801-00 18pF CH C9 176-2096-00 2pF CJ C10 182-1073-15 6.3V100μF C12 178-1042-78 0.1μF C13 178-1042-78 0.1μF C14 178-1042-78 0.1μF C15 176-1007-00 10pF CH C16 178-2212-78 220pF C17 178-1032-78 0.01μF C18 178-1042-78 0.1μF C19 178-2212-78 220pF C20 178-4745-79 0.47μF C21 178-1032-78 0.01μF C22 178-2212-78 220pF C23 178-1042-78 0.1μF C24 178-1522-78 1500pF C25 178-4732-78 0.047μF C26 178-1042-78 0.1μF C27 178-1042-78 0.1μF C28 178-1042-78 0.1μF C29 178-1042-78 0.1μF C30 178-6812-78 680pF C31 176-1511-00 150pF CH C32 178-1042-78 0.1μF C33 176-1007-00 10pF CH C34 176-1007-00 10pF CH C35 178-6812-78 680pF C36 176-1511-00 150pF CH C37 178-1042-78 0.1μF REF No. PART No. DESCRIPTION C38 178-1042-78 0.1μF C39 182-1063-33 16V10μF C40 178-1042-78 0.1μF C41 182-1063-33 16V10μF C42 182-1063-33 16V10μF C43 182-1063-33 16V10μF C44 182-1063-33 16V10μF C45 182-1073-33 16V100μF C48 178-2225-79 2200pF D1 001-0563-00 GL380 D2 001-0563-00 GL380 D3 001-0563-00 GL380 D5 001-0528-32 MA8056-M IC1 051-1014-10 TA7291S IC2 051-6015-05 BA6392FP IC3 051-1971-00 CXA1610M IC4 051-6318-00 CXD2548R IC5 052-5018-03 μPD78002BGC650-AB8 J1 074-1143-06 6P J2 074-1138-17 17P L1 010-2155-03 10μH Q1 101-1237-50 2SB1237QR Q3 103-1754-64 2SD1754A-P,Q Q4 125-0002-02 RN2402 Q5 125-2004-02 RN1402 R1 117-8231-10 1/10W 82kΩ R2 117-1031-10 1/10W 10kΩ R3 111-2711-91 1/4WS 270Ω R4 117-1031-10 1/10W 10kΩ R5 117-1231-10 1/10W 12kΩ R6 117-1031-10 1/10W 10kΩ R7 117-6821-10 1/10W 6.8kΩ R8 117-5631-10 1/10W 56kΩ R9 117-2231-10 1/10W 22kΩ R10 117-1011-10 1/10W 100Ω REF No. PART No. DESCRIPTION R11 117-2201-10 1/10W 22Ω R12 117-1041-10 1/10W 100kΩ R13 117-3331-10 1/10W 33kΩ R14 117-3631-10 1/10W 36kΩ R15 117-1241-10 1/10W 120kΩ R16 117-3631-10 1/10W 36kΩ R17 117-1031-10 1/10W 10kΩ R18 117-1041-10 1/10W 100kΩ R19 117-1051-10 1/10W 1MΩ R20 117-1031-10 1/10W 10kΩ R21 117-3321-10 1/10W 3.3kΩ R22 117-6821-10 1/10W 6.8kΩ R23 117-1051-10 1/10W 1MΩ R24 117-1041-10 1/10W 100kΩ R25 117-4741-10 1/10W 470kΩ R26 117-1231-10 1/10W 12kΩ R27 117-1231-10 1/10W 12kΩ R28 117-1231-10 1/10W 12kΩ R29 117-4711-10 1/10W 470Ω R30 117-1231-10 1/10W 12kΩ R31 117-1231-10 1/10W 12kΩ R32 117-1231-10 1/10W 12kΩ R34 117-4731-10 1/10W 47kΩ R35 117-1041-10 1/10W 100kΩ R36 117-1041-10 1/10W 100kΩ R37 117-1041-10 1/10W 100kΩ R38 117-4741-10 1/10W 470kΩ R41 117-4741-10 1/10W 470kΩ R42 117-4741-10 1/10W 470kΩ R43 117-4741-10 1/10W 470kΩ R44 117-4741-10 1/10W 470kΩ R45 117-4731-10 1/10W 47kΩ R48 117-3911-10 1/10W 390Ω X1 061-1087-50 16.9344MHz X2 060-0322-00 4.0MHz REF No. PART No. DESCRIPTION Q102 060-0252-01 PT4850F REF No. PART No. DESCRIPTION Q103 060-0252-01 PT4850F Sensor PWB section(B4) REF No. PART No. DESCRIPTION Q101 060-0252-01 PT4850F Chucking SW PWB section(B5) REF No. PART No. DESCRIPTION S2 013-3879-01 SPPB12 Limit SW PWB section(B6) REF No. PART No. DESCRIPTION S1 013-7100-00 SPPB11 Tape mechanism/Side PWB section(B7) REF No. PART No. DESCRIPTION C1 178-5612-78 560pF C2 178-5612-78 560pF C3 178-5612-78 560pF C4 178-5612-78 560pF REF No. PART No. DESCRIPTION C5 172-1231-11 0.012μF C6 172-1231-11 0.012μF C7 172-4731-11 0.047μF C8 172-4731-11 0.047μF - 15 - REF No. PART No. DESCRIPTION C9 183-1053-61 50V1μF C10 178-5612-78 560pF C11 178-5612-78 560pF C12 178-1042-78 0.1μF PN-2280D REF No. PART No. DESCRIPTION C13 178-1042-78 0.1μF C14 178-4722-78 4700pF C15 183-2263-31 16V22μF C16 178-1032-78 0.01μF C17 183-1043-61 50V0.1μF C18 183-4753-51 35V4.7μF C20 176-2201-50 22pFCH C21 176-2201-50 22pFCH C22 176-2201-50 22pFCH C23 176-2201-50 22pFCH IC1 051-1777-00 HA12163 L1 010-2198-26 0.047μH L2 010-2198-26 0.047μH REF No. R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 PART No. 117-2731-10 117-2731-10 117-2731-10 117-2731-10 117-1811-10 117-1811-10 117-3341-10 117-3341-10 117-1131-10 117-1131-10 117-1531-10 117-1531-10 032-0098-03 DESCRIPTION 1/10W 27kΩ 1/10W 27kΩ 1/10W 27kΩ 1/10W 27kΩ 1/10W 180Ω 1/10W 180Ω 1/10W 330kΩ 1/10W 330kΩ 1/10W 11kΩ 1/10W 11kΩ 1/10W 15kΩ 1/10W 15kΩ 1/10W 18kΩ±2% REF No. R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 VR1 VR2 PART No. 117-3331-10 117-1831-10 117-1841-10 117-4731-10 117-1241-10 117-2231-10 117-2231-10 117-2231-10 117-1031-10 117-2231-10 012-4431-06 012-4431-06 DESCRIPTION 1/10W 33kΩ 1/10W 18kΩ 1/10W 180kΩ 1/10W 47kΩ 1/10W 120kΩ 1/10W 22kΩ 1/10W 22kΩ 1/10W 22kΩ 1/10W 10kΩ 1/10W 22kΩ 10kΩ 10kΩ Bottom PWB section(B8) REF No. PART No. DESCRIPTION IC2 051-1776-00 NJL5801K REF No. PART No. DESCRIPTION SW1 013-3953-01 SPPB32 REF No. PART No. DESCRIPTION SW2 013-3951-11 REF No. PART No. DESCRIPTION R24 111-5611-91 1/4WS 560Ω REF No. PART No. Rear PWB section(B9) REF No. PART No. DESCRIPTION P5 076-0368-10 10P P6 074-1104-20 20P PN-2280D - 16 - SW3 DESCRIPTION 013-3906-00 SPPB51 ■ CIRCUIT DIAGRAM Main PWB 1/3 (B1) section - 17 - PN-2280D ■ PRINTED WIRING BOARD Main PWB / Display PWB section No. A B C D E F G H No. a b c d e f g h i j k l Description FRONT SP Lch(＋) FRONT SP Rch(＋) LIGHTING SWITCH ACC FRONT SP Lch(−) FRONT SP Rch(−) ANT. SIGNAL BACK UP No. I J K L M N O P Description ILLUMI CONTROL EARTH NC REAR SP Rch(＋) EARTH REAR SP Lch(−) REAR SP Lch(＋) REAR SP Rch(−) Description CD Lch INPUT(＋) CD Rch INPUT(＋) TX(COMBI→CD) NC CD Lch INPUT(−) CD Rch INPUT(−) EARTH DATA EARTH NC REQ(CD→COMBI) RX(CD→COMBI) NC PN-2280D - 18 - ■ CIRCUIT DIAGRAM Main PWB 2/3 (B1) section - 19 - PN-2280D Main PWB 3/3 (B1) section Display PWB(B2) section CD mechanism section T O M 1 P W B (B 5 ) S 2 M 3 C H U C K IN G C D P W B (B 3 ) P W B (B 6 ) S 1 M 2 L IM IT S W P IC K U P U N IT S E N S O R P W B (B 4 ) Q 1 0 3 Q 1 0 1 Q 1 0 2 R 5 0 1 K T O J 4 0 0 O F M A IN P W B (P A G E 1 9 ) R 4 9 1 K PN-2280D - 20 - ■ PRINTED WIRING BOARD CD mechanism section M 2 S M A -1 4 6 -1 0 0 6 L IM IT S W 1 P W B (B 6 ) S 1 0 1 3 -7 1 0 0 -0 0 L IM IT S W S W P IC K U P U N IT R E D B L K C H U C K IN G M 1 S M A -1 5 1 -1 0 0 S P IN D L E M O T O R P W B (B 5 ) B L U B L K S 2 B L K R E D R E D J 1 C 3 1 4 8 2 3 9 7 N R 3 K 6 R 4 9 R C5 0 3 R 2 9 C 3 4 C 3 3 C 3 7 C 2 9 R 3 R 3 R 3 C 3 R 8 R 9 0 1 2 5 Q 3 D 5 C 4 8 R 3 8 3 2 IC 5 R 4 8 C 4 0 R 4 5 6 7 4 5 D 1 1 2 2 8 1 C 4 2 C 4 1 C 4 3 C 4 4 1 R 1 1 1 7 1 6 C 1 2 R 4 1 R 4 4 1 R 4 3 R 4 2 L R E Y E B R B L IC 4 C 3 8 Q 1 R 3 R 3 R 3 R 3 9 D 3 X 1 C 3 2 C 1 R 1 R 1 C 2 C 1 C 2 C 2 3 C 1 5 C 1 3 R 2 2 1 0 R 4 R 7 C 1 0 D 1 8 5 C 3 9 2 0 C 8 R 5 C 9 R 6 C 6 IC 3 R 1 0 C 7 C 1 C 4 5 R 2 5 C 2 7 L 1 C 5 1 4 1 5 1 2 1 2 0 1 8 1 7 R 2 4 R 1 5 RC 22 36 R 1 4 R 1 6 C 4 IC 1 C 2 4 IC 2 1 C 2 4 8 4 C 3 0 R 2 6 1 2 8 J 2 C 1 8 C 1 6 C 1 9 1 5 7 5 6 R 2 C 2 R 2 C C R R 5 1 0 R 1 C 3 M 3 L O A D IN G M O T O R S M A -1 4 7 -1 0 0 R 1 2 R 2 5 6 3 1 2 4 R 2 7 R 2 8 0 1 3 -3 8 7 9 -0 1 C H U C K IN G S W X 2 Q 4 Q 5 1 6 4 1 8 4 8 4 9 C D P W B (B 3 ) D 2 T O M A IN P W B Q 1 0 2 Q 1 0 3 B L K R E D B R N Q 1 0 1 Y E L S E N S O R P W B (B 4 ) - 21 - PN-2280D ■ CIRCUIT DIAGRAM・PRINTED WIRING BOARD Tape mechanism section C 1 4 4 7 0 0 p 5 5 5 6 R 1 3 1 8 k (2 % ) C 8 5 0 -0 .0 4 7 5 6 7 8 R 1 7 4 7 k 1 5 F /R C 1 7 5 0 -0 .1 R 1 R 2 R 2 R 2 1 0 1 1 1 2 1 3 1 4 9 1 3 M S O U T C 1 6 0 .0 1 R 1 8 1 2 0 k 9 2 0 2 1 2 2 1 1 1 M E T A L 1 6 M U T E (T /R ) 2 k 2 k 2 k 0 k 1 7 D O L B Y 1 8 A -G N D C 1 8 3 5 -4 .7 R 2 3 C 1 5 1 6 -2 2 4 3 to .M A IN P W B P 6 1 4 M S G V P 5 1 2 V C C 1 5 2 1 C 1 3 0 .1 (1 0 % ) L 1 IC 1 H A 1 2 1 6 3 (P R E -A M P /D O L B Y /A P S ) 5 1 5 2 5 3 5 4 R 1 0 1 1 k R 8 3 3 0 k R 4 C 4 P W B (B 8 ) 4 4 4 7 4 8 4 9 5 0 P 4 R 1 6 1 8 0 k 2 8 2 7 2 6 2 5 2 4 2 3 2 2 2 1 2 0 1 9 1 8 1 7 1 6 4 6 C 2 3 2 2 p C 6 0 .0 1 2 R 1 2 1 5 k V R 2 1 0 k B o tto m 4 3 4 5 C 2 1 2 2 p R 6 1 8 0 C 1 2 0 .1 (1 0 % ) C 1 0 5 6 0 p R 9 1 1 k R 7 V R 1 3 3 0 k 1 0 k C 2 0 2 2 p C 5 0 .0 1 2 C 2 2 2 2 p F R R 1 4 3 3 k R 1 5 1 8 k 4 2 4 1 4 0 3 9 3 8 3 7 3 6 3 5 3 4 3 3 3 2 3 1 3 0 2 9 1 5 k C 1 1 5 6 0 p C 3 R R R 1 C 1 C 2 R L R 1 1 R 5 1 8 0 R 2 F L C 7 5 0 -0 .0 4 7 R 3 H E A D 2 7 k x 4 5 6 0 p x 4 L 2 C 9 5 0 -1 S id e P W B ( B 7 ) 1 9 O U T L 2 2 k 2 0 O U T R 1 A N O D E R 2 4 5 6 0 IC 2 N J L 5 8 0 1 K 5 R E E L P U L S E 6 G N D 3 M O D E B IT 1 4 M O D E B IT 2 S W 2 M O D E S W 2 M O D E B IT 3 9 M A IN M O T O R S W 1 8 P O M O 7 P O M O 1 0 T A M T L M A IN M O T O R W E T O W E T O P E R R R R + -IN S W 3 T A P E -IN P O W E R M O T O R 1 0 k V R 2 V R 1 V R 2 L 1 R 9 1 1 k R 1 1 1 5 k C 8 0 .0 4 7 R 1 3 1 8 k S id e P W B ( B 7 ) B o tto m P W B (B 8 ) N J L 5 8 0 1 K S W 1 M E T A L S W IT C H 1 1 P 6 R e a r P W B (B 9 ) T A P E H E A D IC 2 8 R 2 4 5 6 0 B L K 1 S W 2 M O D E S W IT C H S P E E D V R R E D W H T P O W E R M O T O R B L U B L K R E D W H T 8 B L U M A IN M O T O R S W 3 T A P E -IN PN-2280D - 22 - 0 .0 4 7 L 2 0 .0 1 2 C 1 5 6 0 p C 7 C 5 R 2 2 7 k C 2 5 6 0 p R 1 2 7 k R 6 1 8 0 R 1 0 1 1 k F L R 2 3 2 2 k R 2 2 V R 1 0 .0 1 2 R 8 3 3 0 k R L C 2 3 2 2 p 5 6 C 3 5 6 0 p C 2 2 2 2 p 1 F R R R C 2 1 2 2 p IC 1 C 6 R 1 2 1 5 k R 4 2 7 k 5 6 0 p R 3 2 7 k C 2 0 2 2 p 4 3 C 4 R 5 1 8 0 R 7 3 3 0 k C O M C 1 2 0 .1 1 4 C 1 6 0 .0 1 C 1 1 5 6 0 p 2 2 k 2 2 k 1 8 0 k 1 5 2 2 k C 1 3 0 .1 R 1 9 R 2 0 R 1 6 R 2 1 C 1 0 4 2 5 6 0 p 2 9 2 8 R 1 5 1 8 k C 1 8 3 5 -4 .7 R 1 4 3 3 k R 1 8 1 2 0 k R 1 7 4 7 k C 1 7 5 0 -0 .1 1 1 0 2 0 5 0 -1 C 1 4 4 7 0 0 p P 4 1 1 0 5 6 C 9 C 1 5 1 6 -2 2 to . M A IN P 5 P W B 6 5 R e a r P W B (B 9 )
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.4 Linearized : Yes Encryption : Standard V2.3 (64-bit) User Access : Print, Copy, Extract, Print high-res Create Date : 2000:02:28 16:51:57Z Subject : E5767 Modify Date : 2002:12:02 09:24:14+09:00 Page Count : 22 Creation Date : 2000:02:28 16:51:57Z Producer : Acrobat Distiller 4.0 for Windows Author : iizu Keywords : Mod Date : 2002:12:02 09:24:14+09:00 Metadata Date : 2002:12:02 09:24:14+09:00 Description : E5767 Title : E5767 Creator : iizuEXIF Metadata provided by EXIF.tools