Dimplex Dfb6016 Users Manual
2015-02-02
: Dimplex Dimplex-Dfb6016-Users-Manual-426022 dimplex-dfb6016-users-manual-426022 dimplex pdf
Open the PDF directly: View PDF .
Page Count: 19
![](asset-1.png)
Owner’s Manual
Model
DF3003
DFB6016
7205450200R12
IMPORTANT SAFETY INFORMATION:
![](asset-2.png)
Table of Contents
! NOTE:
CAUTION:
in damage to the equipment
WARNING:
3
4
7
10
Operation 10
13
Warranty16
19
![](asset-3.png)
3
Welcome & Congratulations
Please carefully read and save these instructions.
CAUTION:
NO NEED TO RETURN TO THE STORE
Questions with operation or assembly? Require Parts Information?
Contact us at: www.dimplex.com/customer_support
OR Toll-Free 1-888-DIMPLEX (1-888-346-7539)
Model Number
Serial Number
![](asset-4.png)
①
②
③
when any heater is used by or
whenever the unit is left operating
④
⑤ Do not operate any unit with
IMPORTANT INSTRUCTIONS
⑥
⑦
fall into a bathtub or other water
⑧
area and where it will not be
⑨
⑩ Do not insert or allow foreign
or exhaust opening as this may
CAUTION
![](asset-5.png)
5
SAVE THESE INSTRUCTIONS
⑪
⑫
liquids are used or stored or
where the unit will be exposed to
⑬
⑭ Avoid the use of an extension
If you must use an extension
AWG minimum size and rated no
⑮ Do not burn wood or other
⑯
⑰
⑱ Always use properly
⑲
⑳ When transporting or storing
vibration and store so as to avoid
WARNING: To prevent
IMPORTANT INSTRUCTIONS
![](asset-6.png)
WARNING:
If
WARNING: Do not install
battery types - may explode or
!NOTE:
approved by the party responsible
user's authority to operate the
CAUTION: This equipment
has been tested and found
These limits are designed to
IMPORTANT INSTRUCTIONS
be determined by turning the
between the equipment and
![](asset-7.png)
7
Site Selection and Preparation
Existing replace•
New wall construction•
Dimplex mantel surround •
kit or custom made mantel
surround
! NOTE 1:
fuse blows on a regular basis
WARNING:
sharp edge and ensure that
Do not attempt to wire your
! NOTE:
be required to prepare the site
The dimensions of the
CAUTION:
Do not install the replace
insert directly on carpet or
similar surfaces which may
![](asset-8.png)
restrict air circulation
Existing Fireplace
Installation
Seal all drafts and vents
debris from falling into the
that is prone to leaks or
the front of the hearth to an
WARNING: To prevent
personal injury you should
New Wall Construction
Use studs to frame an
Site Selection and Preparation
Figure 1
Rubber
Feet
![](asset-9.png)
9
Option #1
be lead from behind the trim and
along the wall to an outlet near
Option #2
installed inside the new frame
Dimplex Mantel Surround
Kit or Custom Made
Mantel Surround
Assemble the mantel
surround kit (refer to the
surround with an opening of
WARNING: Do not attempt
to wire your own new outlets
Site Selection and Preparation
Figure 2
![](asset-a.png)
10
Fireplace Installation
Plug the unit into a 15
to damage the base of the
Level the unit with shims if
Install the trim onto the
WARNING:
sharp edge and ensure that
Figure 3
ABD
Operation
A. Manual On/Off Switch
B. Light Dimmer
![](asset-b.png)
11
Operation
C. Flame Action Control
D. Manual Selection Switch
(“
Level 1 :
Level 2 :
illuminate
Level 3 :
Resetting the Temperature
Cutoff Switch
CAUTION: If you need to
Remote Control
Remote Control Initialization/
Reprogramming
Follow steps 1 through 6 to
![](asset-c.png)
12
at any point by pressing the OFF
Level 1 :
Level 2 :
Level 3 :
Operation
required every time there is a loss
(remove glass doors or pull
to the outside of the unit (if
marked “
Remote Control Usage
ON button on the transmitter is
ON
Button
Battery
OFF
Button
Battery
Figure 4
![](asset-d.png)
13
Battery Replacement
(Figure 4)
Operation
Maintenance
WARNING:
power before attempting any
Light Bulb Replacement
four (4) bulbs under the log set
behind the grill that illuminate the
Required Tools: Phillips #2
Approximate time: 15 minutes
Helpful Hints
light bulbs at one time if they are
the number of times you need
To open the light bulb area:
Remove the trim by turning
the retaining fasteners
until the trim releases from
![](asset-e.png)
14
Maintenance
Lift glass out and store in a
Lower Light Bulb Requirements
To replace the bottom light
bulbs:
Lift up the front edge of the
ember bed under the mirror
then push the front of the
log ember bed down into the
Figure 5
A
Figure 6
Removing
Glass
Glass
Retaining
B
![](asset-f.png)
15
Upper Light Bulb Requirements
-
To replace the top light bulbs:
Glass Cleaning
Maintenance
Figure 7
Ledge
Log
bed
Rear
Tab
Figure 8
be removed by dusting lightly with
Fireplace Surface
Cleaning
![](asset-10.png)
16
Warranty
Products to which this limited warranty
applies
This limited warranty applies to the
DF3003, DFB6016 and to newly
applies only to
any of the 50 States of the USA (and the
Products excluded from this limited
warranty
warranty and are the sole responsibility of
territories are sold AS IS without warranty
What this limited warranty covers and for
how long
limited warranty have been tested and
a period of 5 years from the date of the
material and workmanship for a period of
The above section is a summary only of
your warranty rights. Please review the
remaining provisions of this warranty
for your specic rights.
The limited 5 year warranty period for
(mantels) and trims and the limited 1 year
(mantels) and trims also applies to any
implied warranties that may exist under
allow limitations on how long an implied
![](asset-11.png)
17
What this limited warranty does not cover
This limited warranty does not apply to
limited warranty does further not apply
What you must do to get service under
this limited warranty
Dimplex at 1-888- (1-888-
model and serial numbers available when
What Dimplex will do in the event of a
defect
by this limited warranty is proven to be
during (i) the 5 year limited warranty
the 1 year limited warranty period for
agents of Dimplex authorized to
For products (other than surrounds •
(mantels) and trims) for the period
ending at midnight on the rst
anniversary of the date of rst
purchase
Dimplex will be responsible for all
site is beyond 30 miles (48 km) from
For products (other than surrounds •
(mantels) and trims) for the period
commencing at 12:01 a.m. on the
day after the rst anniversary of
the rst purchase and ending at
midnight on the fth anniversary
of the date of rst purchase
Warranty
![](asset-12.png)
18
removal of the part and installation
For surrounds (mantels) and trims •
for the period ending at midnight
on the rst anniversary of the
date of rst purchase
(mantels) and trims or part thereof
not be entitled to on-site or in-house
provided under this warranty may be
What Dimplex and its dealers and service
agents are also not responsible for
How State and Provincial law apply
the Sale of Goods shall not apply to this
Warranty
![](asset-13.png)
19
0438550100RP
2200490900RP
2500190500RP
4200090100RP
2800070200RP
3000430800RP
3000370600RP
3000240100RP
3000240200KIT
3000250100RP
4100040500RP
5900080700RP
Mirror - DFB6016 5900300400RP
DF3003 5900300300RP
Front Glass 5900310300RP
8800000200RP
2800070500RP
1009070159RP
8800090100RP
Dimplex North America Limited
1367 Industrial Road
Replacement Parts