YFM700RV Service Manual 2006 Yamaha Raptor YFM 700

• YFM700RV Service Manual
• How to use this Manual
• Table of Contents
• Chapter 1 General Information
  • Vehicle Identification
  • Features
  • Important Information
  • Special Tools
• Chapter 2 Specifications
  • General Specifications
  • Engine Specificaitons
  • Chassis Specifications
  • Electrical Specifications
  • Tightening Torques
  • How to Use the Conversion Table
  • General Tightening Torque Specifications
  • Lubrication Points and Lubricant Types
  • Coolant Flow Diagrams
  • Oil Flow Diagrams
  • Cable Routing
• Chapter 3 Periodic Checks and Adjustments
  • Introduction
  • Periodic Maintenance Chart for the Emission Control System
  • General Maintenance and Lubrication Chart
  • Seat, Fenders and Fuel Tank
  • Engine
  • Chassis
  • Electrical System
• Chapter 4 Engine
  • Engine Removal
  • Cylinder Head
  • Rocker Arms and Camshaft
  • Valves and Valve Springs
  • Cylinder and Piston
  • AC Magneto
  • Clutch
  • Oil Pump
  • Shift Shaft
  • Crankcase
  • Crankshaft
  • Transmission
• Chapter 5 Cooling System
  • Radiator
  • Thermostat
  • Water Pump
• Chapter 6 Fuel Injection System
  • Fuel Injection System
  • Throttle Body
• Chapter 7 Chassis
  • Rear Axle and Rear Axle Hub
  • Front and Rear Brakes
  • Steering System
  • Front Arms and Front Shock Absorber Assemblies
  • Rear Shock Absorber and Relay Arm
  • Swingarm and Drive Chain
• Chapter 8 Electrical
  • Electrical Components
  • Checking Switch Continuity
  • Checking Switches
  • Checking the Bulbs and Bulb Sockets
  • Ignition System
  • Electrical System
  • Starter Motor
  • Charging System
  • Lighting System
  • Signaling System
  • Cooling System
• Chapter 9 Troubleshooting
  • Starting Failure/Hard Starting
  • Poor Idle Speed Performance
  • Poor Medium and High-Speed Performance
  • Faulty Gear Shifting
  • Clutch Slipping/Dragging
  • Overheating
  • Overcooling
  • Faulty Brake
  • Shock Absorber Malfunction
  • Unstable Handling
  • Lighting System
• Wiring Diagram