HCD CP555/NXM1 CMT CP555 2013100128

User Manual: CMT-CP555

Open the PDF directly: View PDF PDF.
Page Count: 64

HCD-CP555/NXM1
AEP Model
HCD-CP555/NXM1
UK Model
E Model
HCD-CP555
SERVICE MANUAL
HCD-CP555
MICRO Hi-Fi COMPONENT SYSTEM
HCD-NXM1
MiNi Hi-Fi COMPONENT SYSTEM
Sony Corporation
Audio Group
Published by Sony Engineering Corporation
9-877-825-02
2005E02-1
© 2005.05
SPECIFICATIONS
Ver. 1.1 2005.05
– Continued on next page –
•HCD-CP555 is the Amplifier, CD player,
tape deck and tuner section in CMT-CP555.
•HCD-NXM1 is the Amplifier, CD player,
tape deck and tuner section in MHC-NXM1.
Model Name Using Similar Mechanism NEW
CD CD Mechanism Type CDM81B-F1BD81A
Section Base Unit Name BU-F1BD81A
Optical Pick-up Name KSM-215DCP/C2NP
TAPE Model Name Using Similar Mechanism NEW
Section
Photo : HCD-CP555
Amplifier section
AUDIO POWER SPECIFICATIONS
The following measured at AC 120 – 127/220 – 240 V, 50/60 Hz
(Saudi Arabian model only)
The following measured at AC 230 V, 50/60 Hz
(European and Russian models only)
The following measured at AC 120/220 – 240 V, 50/60 Hz
(except for European, Russian and Saudi Arabian models)
DIN power output (rated): 55 + 55 watts
(6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference):
75 + 75 watts
(6 ohms at 1 kHz, 10% THD)
Inputs
VIDEO/MD IN (phono jacks): Sensitivity 250/450 mV,impedance
47 kilohms
Outputs
DIGITAL (OPTICAL) OUT: Optical Wavelength: 660 nm
PHONES (mini jack): accepts headphones with an
impedance of 8 ohms or more
SPEAKER: Use only the supplied speakers
SS-CP555S
(HCD-CP555)
SS-NXM1
(HCD-NXM1)
CD player section
System Compact disc and digital audio system
Laser Semiconductor laser
(λ=770 – 810 nm)
Emission duration: continuous
Frequency response 2 Hz – 20 kHz (±0.5 dB)
Tape deck section
Recording system 4-track 2-channel stereo
Frequency response 50 – 13,000 Hz (±3 dB), using Sony
TYPE I cassettes
http://www.xiaoyu163.com
http://www.xiaoyu163.com
2
HCD-CP555/NXM1
Tuner section
FM stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning range
Russian model: 65.0 – 74.0 MHz (10-kHz step)
(There is no stereo effect)
87.5 – 108.0 MHz (50-kHz step)
Other models: 87.5 – 108.0 MHz (50-kHz step)
Antenna FM lead antenna
Antenna terminals 75 ohms unbalanced
Intermediate frequency 10.7 MHz
AM tuner section
Tuning range
Pan-American model: 530 – 1,710 kHz
(with the tuning interval set at 10 kHz)
531 – 1,710 kHz
(with the tuning interval set at 9 kHz)
European, Russian and Saudi Arabian models:
531 – 1,602 kHz
(with the tuning interval set at 9 kHz)
Other models: 531 – 1,602 kHz
(with the tuning interval set at 9 kHz)
530 – 1,710 kHz
(with the tuning interval set at 10 kHz)
Antenna AM loop antenna
Antenna terminals External antenna terminal
Intermediate frequency 450 kHz
General
Power requirements
European and Russian models: 230 V AC, 50/60 Hz
Saudi Arabian model: 120 – 127 V or 220 – 240 V AC,
50/60 Hz
Adjustable with voltage selector
Other models: 120 V, 220 – 240 V AC, 50/60 Hz
Adjustable with voltage selector
Power consumption
European and Russian models: 110 watts
0.3 watts (in Power Saving mode)
Other models: 115 watts
Dimensions (w/h/d) incl. projecting parts and controls
Amplifier/Tuner/Tape/CD section:
Approx. 230 x 292 x 355 mm
Mass
Amplifier/Tuner/Tape/CD section:
Approx. 6.5 kg
Supplied accessories Remote Commander (1)
Size AA (R6) batteries (2)
AM loop antenna (1)
FM lead antenna (1)
Speaker pads (8)
Design and specifications are subject to change without notice.
Notes on chip component replacement
•Never reuse a disconnected chip component.
•Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
•Keep the temperature of soldering iron around 270˚C
during repairing.
•Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
•Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous
radiation exposure.
This appliance is classified as
a CLASS 1 LASER product.
This label is located on the rear
exterior.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
http://www.xiaoyu163.com
http://www.xiaoyu163.com
3
HCD-CP555/NXM1
TABLE OF CONTENTS
1. SERVICING NOTES ................................................ 4
2. GENERAL
Location of Controls ........................................................ 5
3. DISASSEMBLY
3-1. Disassembly Flow ........................................................... 7
3-2. Case ................................................................................. 8
3-3. Main Board ...................................................................... 8
3-4. Back Panel ....................................................................... 9
3-5. CD Mechansm Deck (CDM81B-F1BD81A),
Front Panel ...................................................................... 9
3-6. Front Amp Board ............................................................. 10
3-7. Tape Mechanism Deck .................................................... 10
3-8. Panel Board ..................................................................... 11
3-9. Tray .................................................................................. 11
3-10. M761 (LD/ST Motor), M762 (BU U/D Motor) .............. 12
3-11. Base Unit (BU-F1BD81A) .............................................. 12
3-12. BD Board ......................................................................... 13
4. TEST MODE .............................................................. 14
5. MECHANICAL ADJUSTMENTS ....................... 17
6. ELECTRICAL ADJUSTMENTS
Deck section .................................................................... 17
CD Section ...................................................................... 18
7. DIAGRAMS
7-1. Circuit Board Location .................................................... 21
7-2. Block Diagram – CD Servo Section –............................ 22
7-3. Block Diagram – Tuner/Tape Deck Section – ................ 23
7-4. Block Diagram – Main Section – ................................... 24
7-5. Block Diagram – Front Amp Section – .......................... 25
7-6. Printed Wiring Board – BD Board – .............................. 26
7-7. Schematic Diagram – BD Board – ................................. 27
7-8. Printed Wiring Board – CD Mechanism Board – ........... 28
7-9. Schematic Diagram – CD Mechanism Board – ............. 29
7-10. Printed Wiring Boards – Main Board – .......................... 30
7-11. Schematic Diagram – Main Board (1/3) – ..................... 31
7-12. Schematic Diagram – Main Board (2/3) – ..................... 32
7-13. Schematic Diagram – Main Board (3/3) – ..................... 33
7-14. Printed Wiring Boards – Panel Board – ......................... 34
7-15. Schematic Diagram – Panel Board – ............................... 35
7-16. Printed Wiring Board – Disc SW, Vol, HP Board – ....... 36
7-17. Schematic Diagram – Disc SW, Vol, HP Board – .......... 37
7-18. Printed Wiring Board – Front Amp Board – .................. 38
7-19. Schematic Diagram – Front Amp Board – ..................... 39
7-20. IC Block Diagram ........................................................... 40
7-21. IC Pin Function Description ............................................ 41
8. EXPLODED VIEWS
8-1. Case, Rear Panel Section ................................................. 46
8-2. Front Panel Section ......................................................... 47
8-3. Chassis Section ................................................................ 48
8-4. CD Mechanism Deck Section-1
(CDM81B-F1BD81A) .................................................... 49
8-5. CD Mechanism Deck Section-2
(CDM81B-F1BD81A) .................................................... 50
8-6. CD Mechanism Deck Section-3
(CDM81B-F1BD81A) .................................................... 51
9. ELECTRICAL PARTS LIST ................................ 52
http://www.xiaoyu163.com
http://www.xiaoyu163.com
4
HCD-CP555/NXM1
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK
OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pick-
up block. Therefore, when checking the laser diode emission, observe
from more than 30 cm away from the objective lens.
LASER DIODE AND FOCUS SEARCH OPERATION CHECK
Carry out the “S curve check” in “CD section adjustment” and check
that the S curve waveform is output several times.
•MODEL IDENTIFICATION
– Back Panel –
MODEL PART No.
AEP, UK models 4-252-542-0[]
RU model 4-252-542-1[]
E3 model 4-252-542-2[]
E51 model 4-252-542-3[]
EA model 4-252-542-5[]
•Abbreviation
E3 : 240 V AC Area in E model
E51 : Chilean and Peruvian model
EA : Saudi Arabia model
RU : Russian model
PART No.
•SERVICE POSITION FOR TAPE MECHANISM DECK
Jig (J-2501-271-A)
Jig (J-2501-270-A)
tape mechanism deck
CN302
CN301
http://www.xiaoyu163.com
http://www.xiaoyu163.com
5
HCD-CP555/NXM1
SECTION 2
GENERAL This section is extracted
from instruction manual.
LOCATING THE CONTROLS
Main u nit
ALBUM +/– qa
BASS control w;
CD wk
CD SYNC ws
Deck A qj
Deck B qg
DIMMER wd
DISC 1 – 5 3
Disc tray 9
DISPLAY wf
Display window 4
DSGX qs
PHONES jack qh
Remote sensor 2
TAPE A/B wh
TREBLE control ql
TUNER/BAND wj
TUNING +/– 0
VIDEO/MD wg
VOLUME control qd
?/1 (power) 1
nN (play) 5
X (pause) 6
x (stop) 7
CD Z (eject) 8
.m/M> (rewind/fast
forward, go back/go forward)
0
TAPE Z B(eject) qf
A TAPE Z (eject) qk
z START wa
List of button locations and reference pages
ALPHABETICAL ORDER
A – O P – Z
BUTTON DESCRIPTIONS
12 3 4
5
6
7
8
9
0
qa
qs
qd
qf
wj
wk
wh
wg
wf
wd
ws
wa
w;
ql
qk
qj
qh
qg
http://www.xiaoyu163.com
http://www.xiaoyu163.com
6
HCD-CP555/NXM1
This section is extracted
from instruction manual.
Remote c ontrol
ALBUM – qd
ALBUM + qa
CD qk
CLEAR qg
CLOCK/TIMER SELECT 2
CLOCK/TIMER SET 3
DISC SKIP 0
DISPLAY wa
ENTER 9
EQ qf
FM MODE 4
FUNCTION 6
PLAY MODE w;
REPEAT 4
SLEEP ws
TAPE qj
TUNER BAND 5
TUNER MEMORY ql
TUNING MODE w;
VOLUME +/– qs
?/1 (power) 1
m/M (rewind/fast forward) 7
N (play) 8
X (pause) 8
x (stop) 8
./> (go back/go forward)
qh
–/+ (tuning) qh
ALPHABETICAL ORDER
A – E F – Z
BUTTON DESCRIPTIONS
4
5
6
7
8
9
q;
ws 1
qd
qg
qf
wa
w;
ql
qk
qj
qh
qa
qs
3
2
http://www.xiaoyu163.com
http://www.xiaoyu163.com
7
HCD-CP555/NXM1
SECTION 3
DISASSEMBLY
• This set can be disassembled in the order shown below.
3-1. DISASSEMBLY FLOW
3-2.CASE
(Page 8)
3-3.MAIN BOARD
(Page 8)
3-12.BD BOARD
(Page 13)
3-7.TAPE MECHANISM DECK
(Page 10)
3-10.M761 (LD/STMOTOR),
M762 (BU U/D MOTOR)
(Page 14)
3-9.TRAY
(Page 12)
3-6.FRONT AMP BOARD
(Page 10)
3-8.PANEL BOARD
(Page 11)
3-11.BASE UNIT
(Page 13)
3-4.BACK PANEL
(Page 9)
SET
3-5.CD MECHANISM DECK,
FRONT PANEL
(Page 9)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
8
HCD-CP555/NXM1
Note: Follow the disassembly procedure in the numerical order given.
3-2. CASE
3-3. MAIN BOARD
1
three
screws
(CASE 3 TP2)
2
three
screws
(CASE 3 TP2)
3
two
screws
(+BVTP 3X8
)
4
two
screws
(+BVTP 3X8)
5
screw
(+BVTP 3X8)
6
7
CASE
1
two
screws
(+BVTP 3X8)
2
two
screws
(+BVTP 3X8)
3
connector
(CN102)
4
connector
(CN103)
5
MAIN board
6
connector
(CN304)
7
connector
(CN101)
8
CNP112
9
connector
(CN401)
0
CNP204
qa
CNP372
qs
CNP371
qd
CNP109
qf
CNP110
qj
CNP303
qg
connector
(CN301)
qh
connector
(CN302)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
9
HCD-CP555/NXM1
3-4. BACK PANEL
3-5. CD MECHANISM DECK (CDM81B-F1BD81A), FRONT PANEL
1
screw
(+BVTP 3
X
8)
2
two
screws
(+BVTP 3
X
8
)
3
three
screws
(+BVTP 3
X
8)
4
back panel section
5
connector
(CN506)
1
screw
(+BVTP 3
X8
)
2
two
screws
(+BVTP 3
X
10)
3
bracket
4
two
screws
(+BVTP 3
X
8)
5
screw
(+BVTP 3
X8
)
6
screw
(+BVTP 3
X8
)
7
screw
(+BVTP 3
X8
)
8
CD mechanism deck
(CDM81B-F1BD81A
)
9
CNP701
0
CNP201
qd
connector
(CN505)
qa
two
screws
(+BVTP 3X8)
qs
front panel section
http://www.xiaoyu163.com
http://www.xiaoyu163.com
10
HCD-CP555/NXM1
3-6. FRONT AMP BOARD
3-7. TAPE MECHANISM DECK
1
two
screws
(+BV (B3
)
)
2
two
screws
(+BV (B3
)
)
3
FRONT AMP board
5
screw
(+BVTP 3
X8
)
4
connector
(CN502)
6
screw
(+BVTP 3
X8
)
7
two
screws
(+BVTP 3
X8
)
8
bracket
9
two
screws
(+BVTP 3
X8
)
0
bracket
3
two
screws
(+P 2.6X3)
4
two
screws
(+BVTP 2.6X8)
5
tape mechanism dec
k
2
1
http://www.xiaoyu163.com
http://www.xiaoyu163.com
11
HCD-CP555/NXM1
3-8. PANEL BOARD
3-9. TRAY
1
two
screws
(+BTP 2.6X8)
2
two
screws
(+BTP 2.6X8)
3
bracket
5
tray
4
1
four
screws
(+BVTP 2.6X8)
2
screw
(+BVTP 2.6X8)
3
screw
(+BVTP 2.6X8)
4
bracket (main)
5
screw
(+BVTP 2.6X8)
6
three
screws
(+BVTP 2.6X8)
7
PANEL board
http://www.xiaoyu163.com
http://www.xiaoyu163.com
12
HCD-CP555/NXM1
3-10. M761 (LD/ST MOTOR), M762 (BU U/D MOTOR)
3-11. BASE UNIT (BU-F1BD81A)
1
two
screws
(+BTP 2.6X8)
2
MOTOR board
3
Remove soldering from the two points.
5
Remove soldering from the two points.
6
M762 (BU U/D MOTOR)
4
M761 (LD/ST MOTOR)
1
two floating
screw
s
(+PTPWH2.6)
2
base unit (BU-F1BD81A)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
13
HCD-CP555/NXM1
3-12. BD BOARD
1
floating
scre
w
(+PTPWH2.6
)
2
coil spring
(insulator)
3
insulator
4
floating
screw
(+PTPWH2.6)
5
coil spring
(insulator)
6
insulator
7
floating
screw
(+PTPWH2.6)
8
coil spring
(insulator)
9
insulator
0
floating
screw
(+PTPWH2.6)
qa
coil spring
(insulator)
qs
insulator
qd
qf
optical pick-up
(KSM-215DCP/C2NP)
qj
screw
(+BVTP 2.6X8)
qg
CN101
qh
Remove the four solderings of motor.
qk
BD board
http://www.xiaoyu163.com
http://www.xiaoyu163.com
14
HCD-CP555/NXM1
SECTION 4
TEST MODE
[Change-over of AM Tuner Step between 9 kHz and 10 kHz]
•A step of AM channels can be changed over between 9 kHz
and 10 kHz.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “TUNER”, and press [TUNER/BAND]
button to select the BAND “AM”.
3. Press ?/1 button to turn the set OFF.
4. Press x and ?/1 buttons simultaneously, and the display
of fluorescent indicator tube changes to “AM 9 kHz step” or
“AM 10 kHz step”, and thus the channel step is changed over.
[Cold Reset]
•The cold reset clears all data including preset data stored in
the RAM to initial conditions. Execute this mode when
returning the set to the customer.
Procedure:
1.
Press three buttons x , [DIMMER] ,and
?/1
simultaneously.
[Switching MD/VIDEO Functions]
Procedure:
1. Press the ?/1 button to turn the set ON.
2. Press the ?/1 button while holding the VIDEO/MD button
depressed to toggle between “MD” and “VIDEO.” The
selected mode is displayed.
[Error code indication]
Procedure:
1. Press the ?/1 button to turn the set ON.
2. Select the “CD” function.
3. Press the x , X , and [DISPLAY] buttons simultaneously.
4. The error code is displayed.
5. Press the [TUNING +] button to display the next error code.
Press the [TUNING -] button to display the previous error
code.
[Aging Mode]
This mode can be used for operation check CD section and Tape
deck section.
•If an error occurred:
The aging operation stops and is displayed status.
•If no error occurs:
The aging operation continues repeatedly
1. Aging mode in CD section
Procedure:
1. Press ?/1 button on the set ON
2. Select the function “CD”
3. Press three buttons x , X , and [DISC 3] simultaneously.
The “Aging in” display and aging mode is set.
4. Press [DISC 1] button, starts aging mode of all trays check.
5. Press [DISC 2] button ,starts measurement loading time.
6. To exit from the aging mode perform [Cold Reset].
1) Error display
Disc error
Display Error
E00D01022 Focus error (No disc)
E00D02022 Sub Q error (Focus is good)
E00D02023 TOC reading error
E00D02014 Access error (Unable within regular time)
Mechanism error
Display Error
E00M__E_0 Error during opening tray
E00M__C_2 EX-CHANGE disc error
E00M__D_0 Error during closing tray
E00M__F_3 EX-OPEN error
E00M__D_5 EX-CLOSE error
E00M__C_2 Chuck-up error
E00M__C_3 Unchucking error
2. Aging mode in Tape Deck section
Procedure:
1. Load the tapes into the decks A and B respectively.
2. Press ?/1 button on the set ON
3. Select the function “TAPE A”
4. Press three buttons x , X , and [TAPE A/B]
simultaneously, and aging mode is started.
5. To exit from the aging mode perform [Cold Reset].
•In the aging mode ,the program is executed in the following
sequence.
Step Operation Display
1Rewind the TAPE A TAPE A AG-1
2Rewind the TAPE B TAPE B AG-1
3Play the TAPE A (t) (2 minute) TAPE A AG-2
4F•F. (AMS) the TAPE A TAPE A AG-3
5Play the TAPE A (T) (2 minute) TAPE A AG-4
6Rewind the TAPE A TAPE A AG-5
7Play the TAPE B (t) (2 minute) TAPE B AG-2
8 F•F.(AMS) the TAPE B TAPE B AG-3
9Play the TAPE B (T) (2 minute) TAPE B AG-4
10 Rewind the TAPE B TAPE B AG-5
http://www.xiaoyu163.com
http://www.xiaoyu163.com
15
HCD-CP555/NXM1
[GC Test Mode]
•All fluorecent segments and LEDs are tested.
•Microprocessor virsion.
•Keyboard check.
•Display check.
Procedure:
1. To enter the test mode, press the three buttons x , X and
[TUNER/BAND] simultaneously.
2. All segments and LEDs (without STANDBY LED) are turned
on.
3. Press the [TUNING -] button to increment the microprocessor
software version.
4. Press the [TUNING +] button to change the indication for the
microprocessor software version.
3. Press the b B button to set the check mode for the entries
(KEY, JOG, etc.).
4. Press the X button to display the current VACS level.
7. Press the x button to enter the mode to check the display. If
you press this button repeatedly, the display will change
sequentially as the button is pressed.
8. Press the x , X and [TUNER/BAND] buttons simultaneously
to set the standby mode.
[CD Service Mode]
•This mode can run the CD sled motor freely. Use this mode,
for instance, when cleaning the pick-up.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. To enter the test mode, press three buttons x , X , and [DISC
1] simultaneously.
4. The CD service mode is selected.The message ‘‘CD SERVICE
MODE’’ is displayed.
5. While holding the [TUNING -] button depressed, to move the
sled to the inside. “SLED IN” is displayed.
While holding the [TUNING +] button depressed, to move
the sled to the outside. “SLED OUT” is displayed.
6. Press the [CD SYNC] button so that “LD ON” and “LD OFF”
are displayed to switch between Laser ON/OFF.
7. To exit from this mode, perform as follows:
1) Move the pick-up to the most inside track.
2) Press ?/1 button to turn the set OFF.
Note: • Always move the pick-up to most inside track when exiting from
this mode. Otherwise, a disc will not be unloaded.
•Do not run the sled motor excessively, otherwise the gear can be
chipped.
[MC Test Mode] (Amplifier SECTION)
•This mode is used to test the function of the amplifier section.
Procedure:
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press the three buttons x , X and
z START simultaneously.
3. Turn [VOLUME] knob to counter-clockwise, the function of
the equalizer is set to “MIN”.
4. Turn [VOLUME] knob to clockwise, the function of the
equalizer is set to “MAX”.
5. Whenever turn [BASS] knob to clockwise, the display switches
as follows.
“TONE MAX” t“TONE MIN” t“TONE FLAT”
6. To exit from this mode, press ?/1 button to turn the set
OFF.
[MC Test Mode] (Tape section)
•This mode is used to test the functions of the Tape Procedure.
Procedure:
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press the three buttons x , X and
z/START simultaneously.
3. While holding the [DIMMER] button depressed, turn the ALC
ON.
4. Press the z/START button to start REC (recording).
5. While recording, press the [TUNING +] button to perform
automatic rewind and automatic playback (for FF version).
Also, press the [TUNING -] button to perform automatic rewind
and automatic playback (for FR version).
6. Select the function “TAPE A” or “TAPE B”
7. Press the [CD SYNC] button while “TAPE A” or “TAPE B”
is selected, to perform AMS check. “EDG[ ]” is displayed.
A number appears inside[ ].
8. To exit from this mode, press ?/1 button to turn the set
OFF.
[CD Ship Mode (LOCK) ]
•This mode moves the pick-up to the position durable to
vibration. Use this mode when returning the set to the customer
after repair.
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. Press x button and [CD] button simultaneously.
4. The “STANDBY” display blinks instantaneously, and the CD
ship mode is set.
5. To fluorescent indicator tube displays ‘‘LOCK’’.
[CD Ship (LOCK) & COLD RESET MODE]
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3.
Press three buttons x , X and VIDEO/MD simultaneously.
4. The “STANDBY” display blinks instantaneously and CD ship
mode is set.
5. To fluorescent indicator tube displays “LOCK” and the set is
reset.
[CD power -manage function]
Procedure:
1. Press ?/1 button to the set ON
2. Select the function “CD”.
3. Press ?/1 button to turn the set OFF.
4. Press x and ?/1 buttons simultaneously ,and the display
of fluorescent indicator tube changes “CD POWER OFF” or
“CD POWER ON”.
5. Press ?/1 button to turn the set OFF.
http://www.xiaoyu163.com
http://www.xiaoyu163.com
16
HCD-CP555/NXM1
[DISC Tray Lock]
Procedure:
1. Press ?/1 button to the set ON.
2. Select the function “CD”.
3. Press x and CD Z buttons simultaneously for 5 seconds.
And the displays of fluorescent indicator tube changes to
“LOCKED” or “UNIOCKED”.
4. Press ?/1 button to turn the set OFF.
[CD Repeat 5 Times Limit Release Mode]
Procedure:
1. Press ?/1 button to turn the set ON.
2. Select the function “CD”.
3. Press three buttons x , X and [CD SYNC] simultaneously.
4. The message “LIMIT OFF” is displayed.
5. Press ?/1 button the set OFF.
[AMP TEST MODE]
Procedure:
1. Press ?/1 button to turn the set ON.
2. To enter the test mode, press three buttons x , X and [DSGX]
simultaneously.
3. Display will changes ‘‘VACS ON’’ to ‘‘VACS OFF’’.
4. Press ?/1 button to turn the set OFF.
http://www.xiaoyu163.com
http://www.xiaoyu163.com
17
HCD-CP555/NXM1
SECTION 5
MECHANICAL ADJUSTMENTS
SECTION 6
ELECTRICAL ADJUSTMENTS
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads pinch rollers
erase head rubber belts
capstan idlers
2. Demagnetize the record/playback head with a head
demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to
the parts adjusted.
5. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
Torque Measurement
3.06 N • m to 6.96 N • m
FWD CQ-102C 31 to 71 g • cm
(0.43 – 0.98 oz • inch)
FWD
0.19 N • m to 0.58 N • m
back tension
CQ-102C 2 to 6 g • cm
(0.02 – 0.08 oz • inch)
3.06 N • m to 6.96 N • m
REV CQ-102RC 31 to 71 g • cm
(0.43 – 0.98 oz • inch)
0.19 N • m to 0.58 N • m
REV
CQ-102RC 2 to 6 g • cm
back tension
(0.02 – 0.08 oz • inch)
6.96 N • m to 14.02 N • m
FF/REW CQ-201B 71 to 143 g • cm
(0.98 – 1.99 oz • inch)
9.80 N • m
FWD tension CQ-403A 100 g or more
(3.53 oz or more)
9.80 N • m
REV tension CQ-403R 100 g or more
(3.53 oz or more)
Mode Torque meter Meter reading
0 dB=0.775 V
DECK SECTION
1. Demagnetize the record/playback head with a head
demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
3. After the adjustments, apply suitable locking compound to the
parts adjust.
4. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in
this service manual. (As a general rule, playback circuit
adjustment should be completed before performing recording
circuit adjustment.)
6. The adjustments should be performed for both L-CH and R-
CH.
7. Switches and controls should be set as follows unless otherwise
specified.
•Test Tape
RECORD/PLAYBACK HEAD AZIMUTH ADJUST-MENT
DECK A DECK B
Note: Perform this adjustments for both decks
Procedure:
1. Mode: Playback
Tape Signal Used for
P-4-A100 10 kHz, –10 dB Azimuth Adjustment
set
MAIN board
CN304
Pin
1
(L-CH)
Pin
3
(R-CH)
MAIN board
CN304
Pin
2
(GND)
+
–
level meter
test tape
P-4-A100
(10 kHz, –10 dB)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
18
HCD-CP555/NXM1
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.
3. Mode: Playback
4. After the adjustments, apply suitable locking compound to
the pats adjusted.
Adjustment Location: Playback Head (Deck A).
Record/Playback/Erase Head (Deck B).
Screw
position
L-CH
peak
within
1dB
Output
level
L-CH
peak
R-CH
peak
within
1dB
Screw
position
R-CH
peak
MAIN
board
CN301
set
test tape
P-4-A100
(10 kHz, –10 dB)
pin
3
oscilloscop
L-CH
R-CH
VH
waveform of oscilloscope
in phase 45
°
90
°
135
°
180
°
good wrong
pin
2
pin
1
L
R
CD SECTION
Note:
1. CD Block is basically designed to operate without adjustment.
Therefore, check each item in order given.
2. Use YEDS-18 disc (3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10MW impedance.
4. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with the
following checks.
S-curve Check
Connection:
Procedure:
1. Connect an oscilloscope to test point TPO102 (FE1) and TP
117(VC) on the CD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in and turned power switch on again
and actuate the focus search. (actuate the focus search when
disc table is moving in and out)
4. Check the oscilloscope waveform (S-curve) is symmetrical
between A and B. And confirm peak to peak level within 2.4
± 1 Vp-p.
S-curve waveform
Note:
•Try to measure several times to make sure than the ratio
of A : B or B : A is more than 10 : 7.
•Take sweep time as long as possible and light up the
brightness to obtain best waveform.
Checking Location: CD board (SIDE B)
(See page 20.)
+
–
CD board
TPO102 (FE1)
TP117 (VC)
oscilloscope
A
B
symmetry
within 2.4
±
1 Vp-p
forward reverse
http://www.xiaoyu163.com
http://www.xiaoyu163.com
19
HCD-CP555/NXM1
RFAC Level Check
Connection:
Procedure:
1. Connect an oscilloscope to test point TP124 (RFAC) and TP
117(VC) on the CD board.
2. Turn the power on.
3. Put the disc (YEDS-18) in to playback the number five track.
4. Confirm that oscilloscope waveform is clear and check RFAC
signal level is correct or not.
Note: A clear RFAC signal waveform means that the shape “◊” can be
clearly distinguished at the center of the waveform.
RFAC signal waveform
Checking Location: CD board (SIDE B)
(See page 20.)
E-F Balance Check
Connection:
Procedure:
1. Connect an oscilloscpe to test point TPO103 (TE1) and TP117
(VC) on the CD board.
2. Turn the power on.
3. Select the function “CD”.
4. Press three buttons of [ENTER],M, and
[SURRUUND MODE] simultaneously to set the CD service
mode.
5. Put the disc (YEDS-18) in to playback the number five track.
6. Press the . button. The message “TRAVERSE” is
displayed. (The tracking servo and the sledding servo are
turned OFF)
7. Check the level B of the oscilliscope's waveform and the A
(DC voltage) of the center of the Traverse waveform.
Confirm the following :
A/B x 100 = less than ± 22%
Traverse Waveform
8. Press the . button. The message “TRAVERSE” is
displayed. (The tracking servo and sledding servo are turned
ON)
Confirm the C (DC voltage) is almost equal to the A (DC
voltage) is step 5.
9. To exit from this mode, perform as follows.
1) Move the optical pick-up to the most inside track.
2) Press three buttons of x, [CLEAR], and [DISPLAY]
simultaneously. (cold reset)
Notes:
•Always move the optical pick-up to most inside track
when exiting from this mode. Otherwise, a disc will not
be unloaded.
•Do not run the sled motor excessively, otherwise the gear
can be chipped.
Traverse Waveform
Checking Location: CD board (SIDE B) (See page 20.)
+
–
CD board
TP124 (RFAC)
TP117 (VC)
oscilloscope
VOLT/DIV: 200 mV
TIME/DIV: 500 ns
level: 0.9
±
0.4 Vp-p
+
–
CD board
TPO103 (TE1)
TP117 (VC)
oscilloscope
0V
B
level: 1.0
±
0.5 Vp-p
Center of
the waveform
A (DC
voltage)
0V
Tracking servo
Sled servo
ON
C (DC
voltage)
Tracking servo
Sled servo
OFF
http://www.xiaoyu163.com
http://www.xiaoyu163.com
20
HCD-CP555/NXM1
Checking Location:
– CD BOARD (SIDE B) –
TP117 (VC)
TP124 (RFAC)
JPO103 (TE1)
JPO102 (FE1)
IC101
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2121
HCD-CP555/NXM1
•WAVEFORMS
– MAIN BOARD –
IC401 0 XC-IN
VOL/DIV : 0.5 V AC
TIME/DIV : 2.0
µ
sec
2IC401 qg X-IN
VOL/DIV : 0.5 V AC
TIME/DIV : 50 nsec
1
1.5Vp-p
32.768KHz
1.5Vp-p
16MHz
– BD BOARD –
IC101 wa TEI
VOL/DIV : 0.2 V AC
TIME/DIV : 0.2 msec
2IC101 wd FEI
VOL/DIV : 0.1 V AC
TIME/DIV : 1 msec
3IC101 ra RFACO
VOL/DIV : 0.2 V AC
TIME/DIV : 0.5
µ
sec
1
0.15Vp-p
0.4Vp-
p
0.96Vp-p
SECTION 7
DIAGRAMS
For schematic diagrams.
Note:
•All capacitors are in µF unless otherwise noted. (p: pF)
50 WV or less are not indicated except for electrolytics
and tantalums.
•All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•%: indicates tolerance.
•f: internal component.
•2: nonflammable resistor.
•5: fusible resistor.
•C: panel designation.
•A: B+ Line.
•B: B– Line.
•H: adjustment for repair.
•Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark: TUNER (FM/AM)
( ): CD PLAY
<>: TAPE PLAY
[]: TAPE REC
*: Impossible to measure
•Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal produc-
tion tolerances.
•Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal produc-
tion tolerances.
•Signal path.
F: TUNER (FM/AM)
E: TAPE PLAY (DECK A)
d: TAPE PLAY (DECK B)
G: RECORD
J: CD PLAY (ANALOG OUT)
c: CD PLAY (DIGITAL OUT)
•Abbreviation
E3 : 240V AC Area in E model
E51 : Chilean and Peruvian model
EA : Saudi Arabia mdoel
RU : Russian model
Note: The components identified by mark 0 or dotted line
with mark ! are critical for safety.
Replace only with part number specified.
(The other layers' patterns are not indicated.)
•Indication of transistor.
•Abbreviation
E3 : 240V AC Area in E model
E51 : Chilean and Peruvian model
EA : Saudi Arabia mdoel
RU : Russian model
Caution:
Parts face side: Parts on the parts face side seen from
(Side A) the parts face are indicated.
Pattern face side: Parts on the pattern face side seen from
(Side B) the pattern face are indicated.
C
B
These are omitted.
E
Q
B
These are omitted.
CE
Q
B
These are omitted.
CE
Q
Note on Printed Wiring Boards:
Note:
•X: parts extracted from the component side.
•: Pattern from the side which enables seeing.
7-1. CIRCUIT BOARD LOCATION
MAIN board
PANEL board
DISC SW board
VOL board
HP board FRONT AMP board
switching regulator
SW(2) board
SW(1) board
MOTOR board
SENSOR board
ENCODER board
BD board
RELAY board
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2222
HCD-CP555/NXM1
7-2. BLOCK DIAGRAM – CD SERVO SECTION –
OPTICAL PICK-UP
BLOCK
(KSM-215DCP)
LD
DRIVER
+1.7V
+3.3V
LD
GND
FOCUS
COIL
F+
F
T+
T
TRACKING
COIL
X171
16.9MHz
IC251
SL/SP MOTOR
DRIVER
RF AMP
16
7
15
17
18
VR
PD
19
20
21
22
5
30
3
24
MUTE
CH2OUT-F
CH1FIN
CH1RIN
CH2FIN
CH3FIN
OPIN+
CH2OUT-R
CH1OUT-R
CH1OUT-F
CH4OUT-R
CH4OUT-F
CH3OUT-F
CH3OUT-R
M
M
M101
(SPINDLE)
M102
(SLED)
VC
VCC
A
B
C
D
E
F
DETECTOR
A
B
E
19
F
20
LD
36
PD
37
TFDR
11
FFDR
13
SFDR
9
MPD
6
95
XTACN
100
XRST
102
DATA
104
XLAT
105
CLOCK
AOUT2
AOUT1
DOUT
61
PCMDI
62
LRCKI
63
LRCK
65
PCMD
IC301
DIGITAL
SIGNAL PROCESSOR
21
40
SDO0
11
LRCKIA
16
SFSY/LRCKIB
19
SDIO
14
77 XTAO
78 XTAI
55
VDD
VDD
VDDM
26
27
C
28
D
29
107
SENS
XTACN
XRST
DATA
XLT
CLOCK
SENS
TRDR
12
29
CH3RIN SRDR
CH2RIN FRDR
66
BCK
60
BCKI
BCKIA
15
SBSY/BCKIB
18
6
+3.3V
8
5 1
3
STANBY
36
PO11/BUCK/AD1
8
MIACK
7
MICK
6
MIDIO
4
MICS
5
MILP
2
RESET
115
SCOR SCOR
REG
MP3STB
MP3REQ
MIACK
MICK
MIDIO
MILP
MICS
MP3RST
SCOR
SENS
CLOCK
XLT
DATA
XRST
XTACN
SCOR
SENS
CLOCK
XLT
DATA
XRST
XTACN
DOUT
ROUT
LOUT
A
MAIN
SECTION
(Page 24)
B
TUNER/TAPE DECK
SECTION
(Page 23)
IC751
(DISC SENSOR)
Q751
ROTARY
ENCODER
(MD)
ROTARY
ENCODER
(ST U/D)
IC701
LD/ST MOTOR DRIVER
IC711
U/DOTOR DRIVER
4
2
9
7
RIN
FIN
OUT1
OUT2
4
2
9
7
RIN
FIN
OUT1
OUT2
D
MAIN
SECTION
(Page 24)
M761
(LD/ST)
M762
(U/D)
S781
(SUB TRAY OUT)
(SUB TRAY OUT)
OPEN MAIN TRAY
OPEN/IN
CLOSE
S731
S761
S721
SENSE
SWITCH
S771
M
M
D+3.3V
LD/ST MTR NEG
LD/ST MTR POS
BU U/D MTR NEG
BU U/D MTR POS
CN701
SW3 SUB TRAY OUT
SW2 SUB TRAY OUT
SW4SUB TRAY OUT
SW1 SUB TRAY OUT
MD-E4
MD-E3
MD-E2
MD-E1
ST-E4
ST-E3
ST-E2
ST-E1
D.SEMSOR
CN201
86
81
71
10
14
XRST
100
113
GFS
2
FOK
1
3
114
C2P0
IC303
Q10
IC101
•Signal path
J: CD PLAY (ANALOG)
c: CD PLAY (DIGITAL)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2323
HCD-CP555/NXM1
7-3. BLOCK DIAGRAM – TUNER/TAPE DECK SECTION –
TUNER
R-CH Q25,26
Q270
R-CH
L OUT
R OUT
CD SERVO
SECTION
(Page 22)
D OUT
RDS INT
RDS DATAAEP,UK
L OUT
R OUT
ST-MUTE
TUNER
ST-CE
ST D OUT
ST D IN
ST CLK
STEREO
DECK-A
DECK-B
L
R
HP2
HP1
L
R
HE
HRP2
HRP1
TAPE
F REC
B SHUT
A HALF
A PLAY
B PLAY
A HALF
A PLAY
B PLAY
R-REC
B HALF
A SHUT
CAPM+
A TRIG+
B TRIG+
R-CH
R-CH
Q303
Q314,315
Q301,302
Q311-313
Q104
Q31,22
R-CH
L
R
VIDEO(MD)
MECHANISM DECK
64
61
66
27
18
49
CN371
IC301
18
50
51
52
53
54
55
63
5
10
3
11
REC/PB
SWITCH
MUTE
SWITCH
DIGITAL
OUT
REC/PB
SWITCH
BIAS
OSC
Q318
T301
Q316,317
BIAS
REC/PB
BIAS
SWITCH
TC REC
MUTE
12
CAP M
DRIVE
Q326,327
Q323,324
Q321,322
A TRIG
DRIVE
90
91
86
89
87
88
67 4
68 26
69 25
65
58
97
100
92
LINE MUTE
A MUTE
RDS-DATA
RDS-INT
ST-MUTE
TUNED
ST-CE
ST-DIN
ST-CLK
B HALF
FDRONT RELAY
57
STK-MUTE
56
TA MUTE
STBY RELAY
I/O EXP CLK
M16537 CLK
M16537 DATA
SPEC-IN
VACS IN
AMS IN
I/O EXP LAT
I/O EXP DATYA IN
I/O EXP DATA OUT
CLK
DATA
D182
A SHUT
A TRIG
B TRIG
CAPM-CNT1
TC REC MUTE
60 TC REC/PB
59 BIAS
B SHUT
ON/OFF
(SWITCHING REGULATOR)
ST-DOUT
80
81
19
8
20
21
22
23
18
17
9
R-CH
CN102
FRONT AMP
SECTION
(Page 25)
FRONT AMP
SECTION
(Page 25)
CN103
Q21,22
Q1
L-CH
PROTECT
STK-MUTE
FRONT RELAY
HP SW
FAN CTL
63
62
71
70
68 67 66 65
7 8 11 53 51 50 48 34 35
R-CH
Q341-343
Q103
Q29,30
Q140
Q33,34
SELECTOR
R-CH
AMS DPL-2
42 41 37
S2
FL
CLK DATA
CLK DATA
EQ
MD BUS
TONE
TRE
AMS
MUTE
AMS
BUFFER
PB MUTE
LED
SWITCH
LED
SWITCH
AMS-MUTE
STEREO
Q1026
D1021
D1001-1005
Q1001-1005
B PLAY
A PLAY
A HALF
CLK
LED 9V
VCC
LATCH
DI 1
DO 2
IC951
I/O EXPANDER
IC401 (1/2)
SYSTEM CONTROL
IC101
INPUT SELECT SWITCH
ELECTRICAL VOLUMEI
HP IN
HALF PLAY
AMS MUTE
DISC1
DISC2
DISC3
DISC4
DISC5
PROTECT
24
FAN
MUTE
SWITCH
B TRIG
DRIVE
SURR
3
IC903
REG 1
3
IC901
REG 1
3
IC902
REG 1
3
Q906
UNREG+5V
SWITCHING
REGULATOR
UNREG+12V
D+3.3V
CD+3.3V
AUDIO+9V
M+9V
LED9V
REG 1
MCU
I/F
B
C
E
AEP,UK
•R-ch is omitted due to same as L-ch.
•Signal path
K: TUNER (FM/AM)
E: PLAYBACK (DECK A)
d: PLAYBACK (DECK B)
G: RECORD
J: CD PLAY (ANALOG)
c: CD PLAY (DIGITAL)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2424
HCD-CP555/NXM1
7-4. BLOCK DIAGRAM – MAIN SECTION –
28
MP3STB
CN371
IC401 (2/2)
SYSTEM CONTROL
IC1020
DISPLAY CONTROL/KEY CONTROL
MP3REQ
MIACK
MICK
MID10
MILP
MICS
HP3RST
CD SERVO
SECTION
(Page 22)
SCOR
SENS
CLOCK
XLT
DATA
XRST
XTACN
MP3STB
MP3REQ
MP3 ACK
MP3 CK
MP3 DATA OUT
MP3 LP
MP3 CS
RESET
SCOR
SENS
FL-DATA
FL-CLK
FL-CS
FL-RESET
CD-CLK
XLT
CD-DATA
XRST
XTCN
SIRCD
AD-KEY2
AD-KEY1
JOG2-A
JOG1-A
VOL-A
POWER KEY
DISPLAY KEY
XC-IN
X-OUT
XC-OUT
X-IN
31
3
7
5
2
1
32
19
21
23
24
22
25
26
CN372
85
84
83
33 LD-ST MTR POS
BU U/D MTR NEG
BU U/D MTR POS
SW3 SUB TRAY OUT
SW3 SUB TRAY IN
SW4 TRAY CLOSE SW
SW1 TRAY OPEN SW
ST-E1
ST-E2
ST-E3
ST-E4
MD-E1
MD-E2
MD-E3
MD-E4
D,SENSER
EVER+4V
EVER+4V
47
34
46
35
45
CDN-MOT-NEG-1(LD)
CDN-MOT-POS-1(LD)
CDN-MOT-NEG-2(U/D)
CDN-MOT-POS-2(U/D)
CDN-MAIN-SW-OPEN(SW2)
CDN-MAIN-SW-CLOSE(SW4)
CDN-SUB-SW-OPEN(SW2)
CDN-SUB-SW-CLOSE(SW3)
CDN-ENC-B-3(MDM4)
CDN-ENC-B-2(MDM3)
CDN-ENC-B-1(MDM2)
CDN-ENC-B-0(MDM1)
CDN-ENC-A-3(STE4)
CDN-ENC-A-2(STE3)
CDN-ENC-A-1(STE2)
CDN-ENC-A-0(STE1)
DISC SENS
LED-STANDBY
RESET
AC-CUT
48 LD/ST MTR NEG
36
44
43
38
42
39
37
41
40
75
72
12
20
OUT SIRCS
IC1050
41
KEY2-1KEY2-2
S1043
S1001-1005
S1051
KEY
NETWORK
94
ROTARY
ENCODER
ROTARY
ENCODER
ROTARY
ENCODER
TREBLE 78
JOG2-B
79
S1050
76
JOG1-B
77
S1052
S1042
70
VOL-B
71
74
95
BASS
BASS
X401
36.768kHz
X402
16MHz
VOLUME
S1021-1027,1029-1031
S1032-1036
REMOTE
CONTROL
RECEIVER
KEY
NETWORK
S1028 73
DISPLAY
10
11
13
15
8
7
6
82 5
51
I
15
3
•
2
•
1
•
64
I
57
56
•
55
4
54
LED
SWITCH
Q1041
D1050
IC391
RESET
Q391
3 1
LEVEL
DETECT
GREID
DRIVE
Q1021
GRID
DRIVE
Q1022
55 GRID
DRIVE
Q1023
SDATA
SCK
CS
RESET
SEG00
I
SEG35
DEG01
FL1020
FLUORESCENT
INDICATOR
TUBE
F1
F2
DEG11
DEG12/SEG36
DEG13/SEG37
DG00
DIG14SEG38
VF1
VP D/D CON+9V
Q1024
T801
D1023-1026
VF2
VP
RECT
BIAS
OSC
A
DCD SERVO
SECTION
(Page 22)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2525
HCD-CP555/NXM1
7-5. BLOCK DIAGRAM – FRONT AMP SECTION –
14
STK
MUTE
SWITCH
8 9
FRONT-L
FRONT-R
CN501
R-CH
STK MUTE
FRONT RELAY
HPSW
FANCTRL
PROTECT
CN508
FAN
3
1
4
6
7
-VH
SUPP
TEMP
DETECT
MUTE
SWITCH
-VH
D501
Q507,508
D507 Q854
RELAY
DRIVE
Q509
R-CH
R-CH
L
Q854
IC850
OVER CURRENT PROTECTER
IC502
POWER AMP
Q850-852
Q501,502Q503
Q858-861
MUTE
CONTROL
OCP
OUT
CT
Q868,869,890
Q505
-PRE +PRE
TM501
+VH
OVER
LOAD
DETECT
SPEAKER
PROTECT
RELAY
DRIVE
R
SPEAKER
OUT
PHONES
J1063
FAN
MOTOR
DRIVE
C
E
MAIN
SECTION
(Page 23)
MAIN
SECTION
(Page 23)
•R-ch is omitted due to same as L-ch.
•Signal path
F: AUDIO
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2626
HCD-CP555/NXM1
7-6. PRINTED WIRING BOARD – BD SECTION – •See page 21 for Circuit Boards Location.
C10
C260
C14
C15
C16
C18
C11
R405
C316
R354
R353
R352
R351
R302
R253
C315
R191
R172
R171
R162
R313
X171
R121
R12
R11
R10
Q10
C116
C312
C184
C183
C303
C302
C305
C259
C258
C257
C255
C203
C196
C195
C201
C182
C171
C172
C308
C151
C134
C125
C314
C123
R165
R13
C17
FB301
C318
R201
C174
R173
R205
C209
C210
12
(12)
1-860-502-
BD BOARD (SIDE A)
E
R419
R412
R411
R410
R409
R408
R407
R406
R404
R403
R402
1
R401
R305
R303
R301
R252
JPO103 (TE1)
JPO102 (FE1)
TP117
(VC)
TP124
(RFAC)
R251
R182
R181
R163
R151
R143
R142
R141
R133
R132
R131
R114
R113
R112
R111
R307
C313
C311
C310
C309
C307
C306
IC251
C252
C251
C194
C181
C320
S101
(LIMIT)
IC101
C163
C162
C143
C142
C141
C133
C132
C131
C124
C111
C122
C115
C114
C113
C112
IC301
C185 C186
R306
CN101
IC303
CN201
C206
36 28 27 19
1910 18
C317
R203
R161
C161
C211
C212
R204
C213
1
3
45
M101
SPINDLE
MOTOR
M102
SLED
MOTOR
M
M
BD BOARD (SIDE B)
12
(12)
1-860-502-
OPTICAL PICK-UP
BLOCK
(KSM-215DCP)
A
MAIN
BOARD
(Page 30)
16
17
32 49
48
64
1
33
27
23 4 5 6 7 89 10
A
1
B
C
D
E
F
Ref. No. Location
IC101 D-8
IC251 C-6
IC301 C-8
IC303 B-8
Q10 E-4
• Semiconductor
Location
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2727
HCD-CP555/NXM1
7-7. SCHEMATIC DIAGRAM – BD BOARD –
TP165
TP166
TP178
TP144
TP147
TP153
TP186
TP187
TP167
TP160
TP162
TP177
TP145
TP148
TP121
TP122
TP123
JPO004
JPO10
TP250
TP301
TP302
TP303
TP304
TP103
TP104
TP105
TP146
JPO102
JPO103
TP420
TP421
TP422
TP423
TP424
TP426
TP427
TP428
TP429
TP430
TP431
TP432
TP433
TP436
TP401
TP407
TP406
TP405
TP404
TP403
TP402
TP408
TP410
TP434
TP417
TP416
TP415
TP414
TP413
TP412
TP419
TP411
TP435
TP409
TP19
TP18
TP17
TP16
TP15
TP102
TP14
TP13
TP12
TP11
TP10
TP253
TP252
TP251
IC301
TP125
TP124
TP142
TP149
C308
C309
R303
C310
C311 R306
C312
IC303
FB301 C302 C303 C305
CN201
R205
R411
R410
R409
R408
R407
R406
R412
C213
C212 C211
C209
C203
R201
C201
C210 R162
R165 C163
R163
C196
C260 C255
C252
C257
M101
M102
IC251
R253
C258 C259
R252
R251
C251
C195
C115
R111
C116
R112
R114
R113
C111
C112
C113
C114
CN101
C15
C10
C11
Q10
C16 R13
R10
R11
C17
R12
C18
C122
R121
C123
C124
C134
C142
R143
C132
C133
R133
R132
C141
R142
R141
C143
R151
C151
C131
R131
R352
R353
R354
C161
C174
R173
C162
R171
C172
X171
C171
R172
R161
R182
R181
C185
C186
C181
C182 C184
C183
C194
R351
R302
C313
C314
C316
C315
R313
C317
R305
R301
R401
C318
R203
C320
C306
R405
R404
R419
R403
R402
R307
C307
C125
IC101
R191
R204
MIRR
DFCT
FOK
XUGF
XPCK
GFS
MVDD
MGND
LOCK
WDCK
COUT
VC
WFCK
SBSO
RFDCO
MDP
APC
SP-
LRCK
PCMD
BCK
C2PO
FEI
TEI
AGND
DGND
MP3GND
IOP1
IOP2
SW-
PCMDI
FRDR
FFDR
TRDR
TFDR
MDP
MP3VDD
AVDD
MP3STB
MICS
MILP
MIDIO
MICK
MIACK
MP3REQ
MP3RST
ROUT
AVDD
SCOR
SENS
CLK
XLT
DATA
XRST
XTCN
LOUT
DVDD
DOUT
F-
T-
F-
F+
PD
F
C
B
A
D
E
SL-
SL+
SP+
TC94A34FG-002
RFACI
RFACO
EXCK
47
4V
0.1
100k
0.1
0.1 0
0.1
BH15FB1W
0.1 0.1 220
4V
27P
0
100
100
100
100
100
100
100
22p
22p 220p
0.01
100
10V
0
100
10V
0.1 47k
0.1
100
0.1
220
10V 0.1
0.1
0.1
BA5947FM
(HSOP28)
10k
0.1 0.1
22k
10k
0.0068
0.1
0.1
1k
100 10V
15k
15k
1k
0.0033
470p
0.0033
470p
16P
0.1
10
10
2SB1690K
11
3.3
0
220
4V
100k
0.001
0.1
15k
0.1
330p
0.1
0.0015
3.3k
0.47
0.01
180k
10k
0.1
1k
4.7k
0.1
0
100
10V
100p
1M
100
100
100
0.1
0.1
0
0.1
470
27p
16.9MHz
22p
1M
100
100
100
2200p
2200p
0.1
0.1 22
6.3V
22
6.3V
0.1
100
10k
0.1
47
4V
0.0022
0.1
220
0.01
100k
100k
100
0.01
0
0
0.1
100
100
100
100
100
10k
0.1
0.1
CXD3059AR
0
0
SRDR
SFDR
D3.3V
MDP
SQSO
DDC2.5V
DDC2.5V
DVSS
DVSS
D3.3V
A3.3V
A3.3V
AVSS
DOUT
LOUT
ROUT
DVSS
D3.3V
AVSS
A3.3V
VSSX
VSSP
VSS
A3.3V DDC
A3.3V
D3.3V
DGND
AGND
E
F
F
E
D
A
B
C
MIACK
MICK
MIDIO
MILP
MICS
SCOR
SENS
CLOCK
DATA
XRST
XLT
CLOCK
SENS
SCOR
XRST
MP3REQ
DATA
MP3STB
XTACN
XTACN
MP3STB
D
C
B
A
MP3RST
XLT
MP3REQ
MIACK
MICK
MIDIO
MILP
MICS
MP3RST
*
BOARD
(3/3)
(Page 33)
MAIN
•See page 41 for IC Pin Function Description.
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2828
HCD-CP555/NXM1
7-8. PRINTED WIRING BOARD – CD MECHANISM BOARD – •See page 21 for Circuit Boards Location.
JW701
S761
(SUB TRAY OUT)
R753
R754
R751
C702
JW713
Q751
R752
R755
JW712
JW709
JW710
JW711
JW714
IC711 R712
R711
C701
JW702
R701
R702
CN761
CN751
JW705
JW707
JW708
JW706
IC701
CN705
CN731
CN771
CN701
C703
IC751
JW703
JW704
S721
(MAIN TRAY IN/OUT)
S731
(SUB TRAY N)
S771
ROTARY ENCODER
(MD)
S781
ROTARY ENCODER
(ST U/D)
CN721
JW715
JW716
JW718
JW719
JW720
JW717
CN706
CN702
CN707
CN703
C762
C761
D701
D711
MOTOR BOARD
SENSOR BOARD
SW(2) BOARD
SW(1) BOARD
ENCODER BOARD
RELAY BOARD
11
(11)
1-861-241-
11
(11)
1-861-242-
11
(11)
1-861-243-
11
(11)
1-861-245-
11
(11)
1-861-244-
11
(11)
1-861-240-
MAIN
BOARD
(Page30)
B
M761
(LD/ST MOTOR)
M762
(BU U/D MOTOR)
4
3
2
1
G
1
1
1
1
1
1
1
1
6
2
3
3
3
3
1
1
2
2
3
4
1
2
3
4
G
G
9
9
20
21
1
6
23 4 5 6 7
A
1
B
C
D
E
F
Ref. No. Location
D701 D-4
D711 D-4
IC701 D-4
IC711 E-3
IC751 B-6
Q751 D-2
• Semiconductor
Location
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
2929
HCD-CP555/NXM1
7-9. SCHEMATIC DIAGRAM – CD MECHANISM BOARD –
M761
M762
S761
S731 CN731 CN703
IC751
CN751 CN705
R711
R712
D711
IC711
D701
C762
C761 R702
R701
C701
IC701
CN702 CN721
S721
CN701
C702
R751
R754
Q751
R753
R752 R755
CN707 CN771
S771
S781
CN706
CN761
RF500TB
RF500TB
(SUB TRAY OUT)
(SUB TRAY IN) 2P 2P
RPR-359F
3P 3P
680
100
MTZJ-T-77-4.3A
BA6956AN
MTZJ-T-77-4.7B
0.01
0.01 100
680
47
16V
BA6956AN
3P 3P
(MAIN TRAY
IN/OUT)
21PIN
10
16V
91
12k
2SC2785-HFE
10k
10k
10k
5P 5P
ROTARY ENCODER
(MD)
ROTARY
ENCODER
6P
6P
ST-E2
ST-E3
ST-E4
ST-E1
ST-E4
ST-E3
ST-E2
ST-E1
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3030
HCD-CP555/NXM1
7-10. PRINTED WIRING BOARD – MAIN BOARD – •See page 21 for Circuit Boards Location.
E
E
E
E
E
E
E
E
E
E
E
E
E
EE
E
R339
R338
R337
R340
R333
R330
R336
R332
R335
R331
R334
R18
R208
C205
C255
R206
R256 R220
R221
C223
R222
JR200
R231
R232
R298
R294
Q270
R272
R299
R270
R273
R296
R275
Q271
JR115
R325
R326
R324
Q323
C324
C323
D322
Q321
R321
R322
R323
C322
C321
D321
Q326
R327
R329
R328
JR108
Q26
R29
R28
R27
Q25
JR107
JR109
JR106
R123
Q153
R159
R161
R180
R160
Q140
R133
C351
C301
R162
R129
R122
C131
R121
R132
R131
R151
C303
C353
R164
R163
C157
C160
R153
C158
R154
R155
C161
IC101
R158
C123
R127
40
41
64 65
1
80
25 24
C110
R105
C108
C107
R104
R189
R101
C111
JR116
R188
R341
R342
Q341
R343
R345
R344
Q342
Q343
JR117
R126
R3
R1
R103
R2
Q1
JR118
JR119
R5
R6
Q2
R4
Q29
Q30
R33
R35
Q32
Q31
R36
R34
R38
R37
Q33
Q34
R110
Q103
R109
Q316
R314
R315
R317
R318
R320 R316
R319
Q314
R303
R353
Q353
Q303
Q315
R113
R112
R114
R111
R352
Q352
R302
Q302
Q301
Q311
R312
Q312
Q313
R311
R313
R351
Q351
R301
R79
R89
CN102
Q22
Q21
R22
CN103
R21
R23
JR261
JR120
R914
Q906
JR1
L951
C952
R959
R958
R957
JR121
IC951
R955
JR112
JR111
R970
R956
C953
R952
JR104
R450
R449
R243
R241
R145
R142
R192
C191
R191
C100
J102 C141
R141
L370
R247
R246
R451
R452
R448
C383
R387
R385
JR110
R383
R381
R379
R377
R433
R378
R384
R386
R388
R440
R439
R438
R382
R380
R434
R435
R436
R437
R441
R443
R445
E3,
E51,
EA,
RU
R455
R442
R444
R446
31
50
100
81
30
1
1
80
R447
JR449
R453
R454
R416
R430
R429
R415
R424
R422
R421
R418
R419
JR418
R423
R425
R426
R420
R417
C416
R413
R411
R431 R432
JR105
FB373
FB372
C373 FB371
FB374
C412
JR101
R391
Q391
R393
D392
R394
C411
C410
R409
R406
JR103
R407
D391
R392
R396
R405
R403
R402
R401
R404
R395
D393
D394
JR114
JR113
R187
D181
D183
R498
R186
R499
D182
R495
R494
R456 R458
R457
D397
D395
D396
R412
R465
C463
C475
R470
C476
R472
R474
R477
R476
R473
R471
R414
R408
R410
R493 R479
R478
R466
R467
R482
R483
R468
R469 R484
R486 JR102
R490
R489
R485
R496
R492
R497
C499
C497
D905
JR122
JR124
R39
IC401
C168
R304
R354
C305
C355
R305
R355
C306
C356
C357
C307
R306
R356
R357 R307
R309
R359 C308
C358
Q104
Q154
R102
R152
R118
R168
R119
R169
C35
C32
C40
C41
C368
JW171
JW172
JW103
JW102
JW106
CN109
JW108
JW129
JW130
JW125
JW158
JW166
JW165
Q324
JW110
JW274
JW109
JW113
JW114
JW116
JW118
JW119
JW120
JW121
JW476
JW159
JW160
JW236
JW150
JW149
JW174
JW173
JW151
JW143
JW140
JW141
JW142
JW131
C270
JW138
JW137
JW154
JW126
JW127
JW128
JW418
JW175
JW176
CN371
JW136
1
10 20
21 15 1
5
10
27
C382
JW133
JW132
C372
C379
JW134
JW144
JW145
JW146
JW148
Q322
JW276
Q327
JW411
JW412
JW413
JW105
JW111
JW112
C207
C257
C222
JW273
JW474
JW480
JW305
JW278
JW468
JW281
JW282
JW284
JW420
C135
C156
C134
C154
C122
C159
C133
C132
C152
C151
C166
C167
CN301
C352
C302
C121
C155
C162
C165
C304
C354
C119
CN302
C117
C118
C115
C116
JW261
JW301
C314
C315
T301
C313
C311
C312
Q318
L311
Q317
JW454
C101
C102
C106
JW312
JW378
JW379
JW380
JW381
C103
C109
C112
C105
C104
JW331
C1
C124
C390
JW315
JW428
JW911
C75
C25
C26
JW472
JW309
JW471
JW310
JW270
JW269
JW268
JW267
JW266
JW246
JW179
JW170
JW152
JW153
JW157
CN110
JW163
JW164
JW162
JW167
JW168
JW169
JW177
JW178
C183
JW317
JW260
JW190
C498
JW397
JW396
JW388
JW389
JW385
C2
JW395
JW362
JW394
JW482
JW481
JW354
JW429
C22
C21
JW382
JW384
JW490
JW904
JW500
JW903
JW375
JW374
JW365
JW373
JW371
JW376
JW349
JW322
JW323
JW351
JW347
JW346
JW348
JW377
JW8
CN304
JW475
JW421
JW297
JW422
JW423
JW467
JW318
JW319
IC391
C393
C391
C392
X402
X401
JW209
C417
D373
JW189
JW206
JW101
JW124
CN372
CN401
JW224
C384
JW192
JW191
D371
JW466
D372
JW251
JW252
C462
JW402
JW405
JW355
JW6JW3
JW241
JW244
JW242
JW485
JW424
JW404
JW406
JW408
JW409
JW410
JW403
JW245
JW215
JW194
JW416
JW195
JW198
JW199
JW200
JW197
CN204
JW202
JW201
JW239
C370
C142
IC301
JW383
JW499
JW455
JW483
C192
JW229
JW230
JW231
JW232
JW233
JW234
JW235
JW426
JW435
JW243
JW9
JW7
JW425
321
1
7
321321
CN112
JW414
JW464
C901
C902
IC901
C905
C906
IC903
C904
C903
JW436
JW489
IC902
C920
C919
JW431
JW447
JW496
JW450
JW438
JW452
CN101
JW443
JW444
JW498
JW449
C930
JW465
JW901
JW320
C900
JW497
JW902
JW453
JW445
JW493
JW161
JW442
JW900
EP901
JW463
CN303
C127
JW488
JW5
JW139
JW147
JW386
JW387
JW495
JW10
JW280
JW352
JW469
JW344
JW343
JW283
JW193
JW222
C125
C126
JW250
JW240
JW216
JW446
JW462
JW491
JW214
JW415
JW223
JW249
JW205
JW203
JW930
JW427
JW407
JW439
JW353
JW204
JW401
JW350
15P(AEP,UK)
TUNER
SWITCHING
REG
TAPE
MECHANISM
DECK
11P(E3,E51,,EA,RU)
1
11
15
C271
JW298
L301
L351
JW334
JW417 JW296
JW363
JW366
JW372
JW299
C375
JW399
C169
DGND
IC301
DIGITAL OUT
J102
VIDEO(MD)
OPTICAL
3.3V
DOUT
11
(11)
1-861-417-
CHASSIS
CHASSIS
VOL
BOARD
(Page 36)
D
RELAY
BOARD
(Page 28)
BRD81A
BOARD
(Page 26)
A
PANEL
BOARD
(Page 34)
E
VOL
BOARD
(Page 36)
C
AEP,UK
11P
E3,E51,
EA,RU E3,E51,EA,RU
15P
AEP,UK
AEP,UK
MAIN BOARD
C38
C36 C39
FB80
FB50
FB30
FB34
FB54
FB84
AEP,UK,,EA,RU
AEP,UK,,EA,RU
AEP,UK,,EA,RU
AEP,UK,,EA,RU
AEP,UK,,EA,RU
C37
AEP,UK,,EA,RU
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
E
FRONT AMP
BOARD
(Page 38)
JFRONT AMP
BOARD
(Page 38) I
1
10 1
8
L
IN
R
R CH
L CH
HP901
PB HEAD
R CH
L CH
HE901
ERASE
HEAD
HRP901
REC/PB
HEAD
FRONT AMP
BOARD
(Page 38)
H
AC IN
23 4 5 6 7 89 10 11 12
A
1
B
C
D
E
F
G
H
J
I
Ref. No. Location
D181 E-7
D182 D-6
D183 E-7
D321 D-11
D322 C-11
D371 B-5
D372 B-5
D373 B-6
D391 D-6
D392 C-7
D393 D-7
D394 D-7
D395 E-5
D396 E-5
D397 E-5
D903 B-10
D904 F-2
D905 G-4
IC101 G-8
IC301 B-2
IC391 C-7
IC401 D-6
IC901 F-4
IC902 F-2
IC903 F-3
IC951 E-3
Q1 H-7
Q2 I-6
Q21 I-5
Q22 I-5
Q25 E-8
Q26 E-8
Q29 I-6
Q30 I-6
•Semiconductor Location
Ref. No. Location
Q31 I-6
Q32 I-7
Q33 I-7
Q34 I-7
Q103 I-8
Q104 I-8
Q140 G-9
Q153 G-9
Q154 I-8
Q270 C-8
Q271 C-9
Q301 I-9
Q302 H-9
Q303 I-9
Q311 I-8
Q312 I-8
Q313 I-8
Q314 I-9
Q315 I-9
Q316 J-7
Q317 J-8
Q318 J-8
Q321 C-11
Q322 D-11
Q323 C-11
Q324 C-11
Q326 D-11
Q327 D-11
Q341 F-7
Q342 G-7
Q343 G-7
Q351 I-9
Q352 H-9
Q353 I-9
Q391 D-6
Q906 G-4
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3131
HCD-CP555/NXM1
7-11. SCHEMATIC DIAGRAM – MAIN BOARD (1/3) –
R315
R314
C304
C354
R303
R353
R305 R355
R311 R313
R318 R317
R319
C313 R341
R342
R343 R345
C311
R320
R312
R130
C151
C152
C154
C156
R122
R151
R111
C312
C305 C355
CN301
CN302
C133
T301
C121
C131
C155
C122
C308
C358
R102
R152
R118
R307
R357
R131
R132
C169
R241
R243
CN304
C117
R113
C125
C126
C167
R163
R112
C118
R114
R162
R164
C119
C116
C146
R109
R33
R34
R35
R36
R39
R344
C390
C40
C36 C37 C38
R306
R356
L351
C307
C357
L301
C306
C356
C315
C314
CN204
C157
C158
C160
C161
C162
R154
R155
R121
C135
R123
C132
R129
C196
R180
R159
C166 R161
C107
C108
C110
C111
C112
C106
C105
R101
C104
C103
C109
R103 R105
R104
C124
C123
R141 C141 R142 C142
R191 C191 R192 C192
C134
R133
C165
R38 R37
C159
FB84
FB54
FB34
C302
C352
R359
R309
R168
R246
R247
J102
IC101
R316
FB50
L311
R298 C101
R294
R119
R169
C115
C102
C127
C301
C351
C303
C353
R301 R351
R302 R352
R304 R354
R160
R127
R126
C129
C128
R110
Q103
Q301 Q351
Q302 Q352
Q311
Q312
Q313
Q315
Q314
Q303
Q353
Q154
Q104
Q317
Q318
Q316
Q32
Q31
Q30
Q29
Q34
Q341 Q342
Q343
Q153
Q140
Q33
FB30
FB80
C35
C168
R153
4.7k
47k
10 50V
10 50V
1k
1k
4.7k 4.7k
10k 10k
47 10k
3.3k
47
10V
10k
4.7k
22k 10k
0.0068
PET
33
10k
100
10 50V
10 50V
10 50V
1050V
15k
15k
1k
0.01
PET
0.001
B0.001
B
3P
PH-L
8P
PH-L
0.01 PET
SUMIDA
1MF
22p CH
0.1 MF
4.7
50V
0.01 B
0.01 B
47k
47k
100
10k
10k
2.2k
27k
47
16V
0
0
3P
150V
330k
100 10V
100 10V
150V
330k
12k
0.01 PET
180
12k
180
47
16V
10
50V
0.0068
B
47k
100k
22k
100k
22k
0
10k
22
50V
0.1
0.1 0.1 0.1
8.2k
8.2k
27mH
330p
330p
27mH
100p
100p
0.0047
0.01 100V
0.022 B
0.022 B
0.047 B
0.0082B
10 50V
2.2k
10k
2.2M
150V
1M
0.01
PET
15k
0.0068
100
47k
10
50V 1k
0.022 B
0.022 B
0.047B
0.0082 B
1050V
10 50V
0.1 MF
15k
1050V
10 50V
10
50V
2.2k 10k
2.2k
100
10V
0.1
F
1k 220p
B100k 10
50V
1k 220p
B100k 10
50V
10
50V
10k
10
50V
22k 100k
10
50V
0
0
0
10
50V
10
50V
2.2k
2.2k
100
10k
10k
M61537FP
10
0
1k 10
50V
1k
10k
10k
10
50V
10
50V
100
10V
470p
470p
470p
470p
1k 1k
1k 1k
33k 33k
10k
1k
1k
0.022 B
10 50V
10k
2SC3624A
PB MUTE
2SC3624A 2SC3624A
2SC3624A 2SC3624A
2SA812
DTC114EKA
DTC114EKA
DTC114EKA
DTA114EKA
2SC3624A
2SC3624A
2SC3624A
2SC3624A
RT1P137L
BIAS SWITCH
2SC2001
BIAS OSC
DTC114EKA
BIAS SWITCH
DTA114EKA
DTC114EKA
DTA114EKA
DTC114EKA
DTA114EKA
2SC1623 DTC114EKA
DTC114EKA
2SC3624A
PB MUTE
2SC3624A
DTC114EKA
0
0
0.1
0.01
PET
2.2k
B-1
GND
B-4
ST A+9V
AUDIO A+4.5V
CDM D+ 3.3V
53
B-7
B-6
-B
B-5
GND
CDM D+ 3.3V
B-5
100
50
51
52
53
54
55
A5
63
18
81
80
B19
B18
B17
49
A18
FR
FL
DM-L
DM-R
*
TUNER
AEP,UK
AEP,UK
15P
11P
*CN204
(CHASSIS)
R
L
IN
ELECTRICAL VOLUME
INPUT SELECT SWITCH,
REC/PB SWITCH
Q301-303,
Q311-315
EXCEPT
AEP,UK
R-CH
L-CH
HEAD
PB
HEAD
REC/PB
HEAD
ERASE
HE901
R-CH
L-CH
DECK
DECK
A
B
HP901
HRP901
(FOR CHECK)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3232
HCD-CP555/NXM1
7-12. SCHEMATIC DIAGRAM – MAIN BOARD (2/3) – •See page 44 for IC Pin Function Description.
C410
R411
R413
R409
R417
R429
R430
R415
R416
R408
R410
R412
R414
R393 R395
R396
C391
C392
C393
C183
R424
R425
R426
R433
R434
R435
R436
R437
R438
R439
R440
R441
R442
R443
R444
R445
R446
R447
R448
R452
R453
R454
R455
R470
R471
R472
R473
R474
R476
R477
R478
R479
R486
R489
R490
R956
R957
R958
R959
R485
R484
R483
R482
R187
R189
R955
R952
R493
R970
R451
R466
R467
R468
R469
R186
R188
L951
R402
R403
R405
R406
R407
R404
R401
R419
R421
R422
R423
R420
R432
R431
R450
R392
R391
JW3
R394
JW6
R465
CN401
C476
C475
C463
C462
C412 C416
C497
C498
C499
R497
R494
R495
R498
R499
R492
R496
JR418
JR449
R449
R969
C411
C417
JW456
JW458
JW457
JW459
JW460
JW461
IC401
IC391
Q391
D181
D182
D183
D395 D396
D392 D393
D397
D394
D391
IC951
X401
X402
C952
C953
R418
18p CH
330k
0
10k
10k
100
100
10k
10k
10k
10k
10k
10k
22k 220
10k
0.1 MF
0.1 MF
10 50V
150V
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
100
470k
47k
100
100
100
10k
100
10k
10k
10k
10k
0
330
0
3216
100
100
100
100
100
100
100
100
100
100
100
4.7k
100
100
100
22k
10k
4.7k
100
4P
AMP-S
0.01
0.01
0.1
100
10V
0.1 0.1
0.1
F
10
50V
0.1
F
10k
3.3k
3.3k
10
10
0
0
100
10k
15p CH
2200
6.3V
M30622MGN-B28FP
M62703
2SC1623
1SS355
1SS355
1SS355
1SS355 1SS355
1SS355 1SS355
1SS355
1SS355
1SS355
PT8300R
32.768kHz
16MHz
0.1
0.1
100
B-1
B-2
B-3
EVER+4V
GND
53
B-5
B-7
CDM D+ 3.3V
B-8
TC D+3.3V
B-10
GND
CDM D+ 3.3V
B-5
A-MUTE
1
2
3
5
7
19
21
22
23
24
25
26
28
32
31
73
74
77
78
79
4
94
95
86
87
88
89
90
91
100
76
65
63
50
49
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
A8
A9
A10
A11
A12 A17
A19
A20
A21
A22
A23
A5
53
54
55
52
51
70
71
72
66
67
68
69
66
67 68
69
18
82
83
84
85
75
93
A18
81
80
B20
B21
B22
C7
A24
B17
B18
B19
*
*
1K
4.7K
0
*R496
EA
E3
AEP,UK
I/O EXPANDER
SYSTEM CONTROL
LEVEL DETECT
(FOR CHECK)
EXCEPT E3,EA
*R492
1K
4.7K
0AEP,UK
E3,EA
E51
RU
150
EXCEPT
AEP,UK AEP,UK
EXCEPT
AEP,UK
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3333
HCD-CP555/NXM1
7-13. SCHEMATIC DIAGRAM – MAIN BOARD (3/3)–
R1
R3
R4
R6
C1
C2
C919
C920
R914
C903 C902
C904
R22
R21
C901
CN372
R377
R378
R379
R380
R381
R382
R383
R384
R385
R386
R387
R388
C21
C22
R915
C905
C906
CN101
R78
R88
R60
R50
C85
C75
R273
R275
C270 R270
R272
R299
R296
C271
JR1
FB371
FB374
CN371
C900
R323
R326
R329
R338
R339
R337
JW900
C39
CN112
JW930
CN109
CN110
JW8
JW7
C372
C373
FB372
C379
C383 C384
R335
R332
R336
R330
R333
R340
R334
R331
C324 C322
R321
R322
R324
R325
R327
R328
R28
C25
R27
C26
C370
L370
C930
R29
JW10
R23
R2
R5
CN303
EP901
C375
CN103
JW911
JW961 R89
R79
IC301
IC902 IC901 IC903
Q270
Q271
Q906
Q26
Q25
Q22
Q21
Q327 Q324 Q322
Q1
Q2
Q321
Q323
Q326
D373
D372
D371
D322 D321
D904
D905
CN102
FB373
C382
2.2k
1k
2.2k
1k
10 50V
10 50V
10
50V
10
50V
1k
10
50V 100
10V
100
10V
22k
4.7k
0.1
50V
21P
1MMFFC-S
10k
10k
10k
10k
10k
10k
10k
10k
10k
10k
10k
10k
4.7
50V
4.7
50V
1k
0.1
50V
100
10V
6P
EH-S(2X)
1k
1k
47k
47k
10
50V
10
50V
2.2k
1k
10
50V 2.2k
1k
10k
10k
10
50V
0
0
0
27P
1MMFFC-S
4700
16V
1k
1k
47k
10k
47k
22k
0.1
5P
1.25MMFFC-S 13P
1.25MMFFC-S
15P
1.25MMFFC-S
470
6.3V
0.1
0
470
6.3V
0.1 470
6.3V
47k
4.7k
47k
4.7k
47k
4.7k
47k
47k
0.0047 0.0047
2.2k
2.2k
2.2k
2.2k
2.2k
2.2k
22k
4.7
50V
4.7k
4.7
50V
100
10V
2200
16V
100k
100k
10k
10k
13P
1.25MMFFC-S
470
6.3V
9P
B-TO-B
0
0
TOTX141
TA7809S TA7809S TA78033LS
2SC3624A
MUTE SWITCH
2SC3624A
MUTE SWITCH
2SC1623
DTA114EKA
MUTE SWITCH
DTC114EKA
MUTE SWITCH
DTA114EKA
MUTE SWITCH
DTC114EKA
MUTE SWITCH
2SB1116
CAP M
DRIVE
2SB1116
A TRIG
DRIVE
2SB1116
B TRIG
DRIVE 2SC3624A
MUTE SWITCH
2SC3624A
MUTE SWITCH
DTC114EKA
B TRIG
DRIVE
DTC114EKA
A TRIG
DRIVE
DTC114EKA
CAP M
DRIVE
10EDB40
10EDB40
10EDB40
1SS355 1SS355
1SS355
UDZS-TE-17-4.3B
7P
0
470
10V
B-2
B-3
A-MUTE
B-4
GND
ST A+9V
AUDIO A+4.5V
CDM D+ 3.3V
B-6
CDM D+ 3.3V
B-8
B-5
B-10
TC D+3.3V
-B
EVER+4V
GND
B-5
3
7
5
2
1
32
19
21
24
22
25
26
FL
FR
23
65
B22
93
28
31
89
A12
90
A11
91
A10
88
87
86
71
72
74
76
77
78
79
4
94
70
A23
A22
A21
73
82
83
84
85
A17
A20
A19
95
75
34
33
48
47
40
41
39
42
38
43
37
44
36
45
35
46
DM-R
DM-L
A9
B21
A8
C7
B20
A24
TAPE MECHANISM
DECK
DIGITAL OUT
+9V REG +9V REG +3.3V REG
+3.3V REG
DIGITAL OUT
(CHASSIS)
SWITCHING
REGULATOR AC IN
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3434
HCD-CP555/NXM1
7-14. PRINTED WIRING BOARD – PANEL BOARD – •See page 21 for Circuit Boards Location.
R1020
IC1020
Q1026
R1037 R1036
R1034
R1024
R1023
R1021
C1025
R1025
C1021
C1048
R1027
R1028
R1032
R1029
R1030
R1031
C1029
R1045
R1051
C1052
C1050 R1052
R1046
D1022
Q1024
Q1022
Q1023
R1041
R1042
R1102
R1101
R1043
Q1021 R1100
D1023
R1033
R1035
R1040
D1024
D1025
D1026
C1054
R1038
R1039
R1022
R1026
C1006
JW1020
JW1022
JW1032
JW1033
JW1034
JW1035
JW1037
JW1023
JW1021
JW1050
JW1039
JW1049
JW1071
JW1043
JW1040
JW1081
C1053
CN1021
T801
C1051
S1036
S1030
S1032
S1034 +
–
S1035
S1031
S1029 b B
z START
CD
TAPE A/B
CD SYNC
TUNING
ALBUM
DIMMER
DISPLAY
TUNER/
BAND
VIDEO
(MD)
X
x
CD Z
M>
.m
D1021
S1021
S1022
S1023
S1024
S1028
S1025
S1026
S1027
C1028
C1026
JW1025
JW1048
JW1024
JW1026
JW1027
FL1020
FLOURESCENT INDICATOR TUBE
JW1036
JW1045
JW1046
JW1029
JW1030
JW1031
1
54
1
E3
5
10
15
20
25
30
35
40
45
50
55
56 60
JW1038
JW1047
JW1028
48
49
17
16
33 32
64 1
JW1041
JW1042
S1033
L1021
LP1001
PANEL BOARD
11
(11)
1-861-474-
MAIN
BOARD
(Page30)
E
E
E
E
23 4 5 6 7 89 10
A
1
B
C
D
E
F
G
Ref. No. Location
D1021 B-1
D1022 B-2
D1023 B-3
D1024 B-2
D1025 B-2
D1026 B-2
IC1020 B-6
Q1021 B-4
Q1022 B-5
Q1023 A-5
Q1024 A-2
Q1026 B-1
• Semiconductor
Location
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3535
HCD-CP555/NXM1
7-15. SCHEMATIC DIAGRAM – PANEL BOARD –
R1046
R1052
C1048
L1021
Q1024
SWICHING
REGULATOR
R1045
C1053
C1050
R1020
C1028
R1039 R1040
R1038
R1036 R1037
R1034 R1035
R1033
R1025 C1025
R1023
R1022
C1021
R1021
R1024
R1043 R1042 R1041
R1102
R1101
R1100
C1029
R1027
R1026 R1028 R1030
R1029 R1031
R1032
S1021 S1022 S1023 S1024 S1025 S1026 S1027
S1028 S1029 S1030 S1031
S1032 S1033 S1034 S1035 S1036
FL1020
CN1021
R1051
C1051
C1052
C1006
C1026
IC1020
Q1024(1/2)
Q1024(2/2)
Q1021 Q1022 Q1023
Q1026
D1022 D1023
D1025
D1024
D1026
D1021
T801
C1054
10k
100
0.1
35V
3.3k
22
50V
0.01
100
10
50V
10k 33k
4.7k
1.5k 2.2k
4.7k 10k
2.2k
10k 220p
100
100
0.001
1k
1k
100k 100k 100k
10k
10k
10k
0.1
330
220 470 1k
680 1.5k
2.2k
13P
100
220
50V
0.01
0.1
10
50V
M66005
-0131AHPRBOT
CPH5504-TL-E
CPH5504-TL-E
2SC1623 2SC1623 2SC1623
DTC114EKA
LED SWITCH
RD6.2FM 1SS355
1SS355
1SS355
1SS355
SEL5423
DC-DC CONVERTER
0.0047
36
35
34
33
32
31
30
29
27
26
25
24
23
22
21
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
50
49
48
47
46
45
44
43
42
41
39
38
28
40
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
51
52
/START
(MD)
VIDEO
DISPLAY TAPE A/B
TUNER/BAND
CD DIMMER CD SYNC
/KEY CONTROL
DISPLAY CONTROL
DRIVE
GRID
Q1021-1023
LIQUID CRYSTAL DISPLAY
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3636
HCD-CP555/NXM1
7-16. PRINTED WIRING BOARD – DISC SW, VOL, HP BOARD – •See page 21 for Circuit Boards Location.
R1049
R1094
C1001
R1001
R1002
Q1001
C1002
R1003
R1004
R1011
Q1002
R1012
C1003
R1005
R1006
Q1003
R1013
R1014
C1004
R1007
R1008
Q1004
C1005
R1010
R1009
R1095
C1016
D1051
R1059 Q1041
R1048
R1050
R1093
R1092
R1054
R1091
R1090
Q1005
E
E
EE
E
C1008
C1007
1
10
C1009
JW1051
JW1052
JW1053
JW1002 JW1003 JW1004
W1001
NO1001
JW1076
D1001
D1002
D1003
D1005 D1004
CN1051
S1043
D1050
CN1050
S1004
S1005
DISC 5
VOLUME
S1052
TREBLE
S1051
BASS
S1050
DISC 4 DISC 3 DISC 2 DISC 1
S1003 S1002 S1001
JW1056
JW1055
JW1054
JW1057
C1013
IC1050
S1042
JW1058
JW1059
JW1078
JW1073
JW1069
JW1077
NO1052
JW1001
DISC SW BOARD
VOL BOARD
11
(11)
1-861-475-
11
(11)
1-861-476-
MAIN
BOARD
(Page30)
C
MAIN
BOARD
(Page30)
D
1
10
1 2 3
E
R1088
JR1081
JR1080
C1094
C1093
C1096
EP1060
EP1061
CN1062
JW1097
JW1099
JW1075
JW1072
JW1098
JW1083
JW1070
FRONT AMP
BOARD
(Page38)
F
CHASSIS
CHASSIS
J1063
PHONES
FB1001
FB1002
11
(11)
1-861-477-
HP BOARD
23 4 5 6 7 89 10 11
A
1
B
C
D
E
F
G
Ref. No. Location
D1001 C-6
D1002 C-5
D1003 C-4
D1004 C-4
D1005 C-3
D1050 E-6
D1051 E-5
IC1050 E-5
Q1001 B-6
Q1002 C-5
Q1003 C-4
Q1004 C-3
Q1005 C-2
Q1041 E-6
• Semiconductor
Location
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3737
HCD-CP555/NXM1
7-17. SCHEMATIC DIAGRAM – DISC SW, VOL, HP BOARD –
R1004 R1008
R1006 R1010
R1002 R1009
R1007
R1005
R1003
R1001
R1012
R1011 R1013 R1014 C1009
R1049
R1050
C1013
R1059 R1090 R1091
R1092
R1093
R1094 R1095
R1048
R1088
JR1080
FRONT AMP
BOARD
(Page 39)
C1093
C1094
FB1001
FB1002
C1008
S1050 S1051 S1052
S1042
CN1051
CN1050
S1043
JW1099
JR1081
JW1098
C1007
NO1052
NO1001
J1063
S1001 S1002 S1003 S1004 S1005
IC1050
Q1001 Q1002 Q1003 Q1004 Q1005
D1005
D1004
D1003
D1002
D1001
Q1041
D1050
D1051
CN1062
C1096
EP1061
680 680
680 680
680 680
680
680
680
680
330
220 470 680 0.1
1k
220
47
16V
47 1k
1k
1k
1k
1k 1k
2.2k
0
0
0.001
0.001
0.1
5P
15P
0
0.1
10P
10P
NJM74M400A
DTC114EKA
LED DRIVE DTC114EKA
LED DRIVE DTC114EKA
LED DRIVE DTC114EKA
LED DRIVE DTC114EKA
LED DRIVE
SEL5823A
SEL5823A
SEL5823A
SEL5823A
SEL5823A
DTC114EKA
SEL5223S
1SS355
4P
1000p
1
2
3
4
5
5
4
3
2
1
7
1
2
3
4
5
6
7
8
9
10
11
12
8
9
10
11
12
1
2
3
4
5
6
I/
(CHASSIS)
(CHASSIS)
REMOTE
CONTROL
RECEIVER
SWITCH
Q1001-1005
LED
SWITCH
LED
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3838
HCD-CP555/NXM1
7-18. PRINTED WIRING BOARD – FRONT AMP BOARD – •See page 21 for Circuit Boards Location.
C537 C538
C540
C539
D851
C858
R862
R863
R864
Q861
R866
R867
R865
C857
R511
R512
R517
R518
R519
Q501
Q859
Q860
Q502
D852
R553
C557
R895
C513
R559
R522
R523
E
E
E
E
E
EE
E
E
E
Q503
D501
R560
Q509
D507
Q851
D505
Q852
Q850
R851
R850
IC850
R506
R509
D504
R505
C503
R507
C504
R870
R871
R872
Q868
Q869
R564 R565
R860
D509
R890
Q890
R530
R535
R513
R516 R515
C508 C511
R534
R531
R533
R532
R568
R569
C529
Q507
R547
R545
R548
Q508
R546
R549
R550
R876
R875
Q853
Q854
R854
R857
R562
JW504
R561
E3,E51
E3,E51
AEP,UK,EA,RU
AEP,UK,EA,RU
AEP,UK,EA,RU
AEP,UK,EA,RU
R566
R563
JW505
JW507
JW509
JW514
JW511
TH531
L501
L502
EP502
TM501
C531
C530
JW562
JW608
JW673
CN508
CN501
JW653
C509
C510
C860
C859
JW654
JW601
R580
JW678
JW522
EP510
JW610
CN506
RY501
C853
C525 C524
C852
C851
C861
C854
C856
C523
R524
C522
C855 C862
R542
R543
JW578
JW680
JW681
JW682
JW621
JW688
JW618
JW617
JW574
JW616
JW615
JW614
JW612
JW613
JW689
JW619
JW623
JW549
JW632
C528
Q505
IC502
C560
C505
JW583
JW664
C850
JW605
JW607
JW627
JW606
JW683
JW684
JW603
JW675
JW593 JW674
JW633
JW597
JW596
JW595
JW651 JW591
JW521
JW655
JW638
JW635
JW634
JW636
JW594
JW637
JW550
JW551 JW552
JW553
CN502
JW586
JW691
JW676
JW602
JW584
Q858
JW640
JW609
JW567
JW671
JW672
JW694
JW695
JW564
JW565
JW566
JW660
JW661
JW690
JW575
JW685
JW604
JW600
JW571
JW570
JW666
JW645
JW646
JW648
JW658
JW652
JW649
JW650
R520
JW668
JW669
JW692
JW581
JW580
JW579
C516
C518
JW657
R521
JW687
JW582
JW630
JW629
JW628
JW693
JW663
JW585
JW686
JW626
JW670
JW576
JW577
Q504
JW588
JW590
JW625
JW561
JW563
R529
R528
R537
R536
R855
R858
CN505
JW639
JW665
BOARDFRONT AMP
11
(11)
1-861-478-
F
HP
BOARD
(Page 37)
I
MAIN
BOARD
(Page 30)
J
MAIN
BOARD
(Page 30)
E
E
E
EE
E
E
E
E
L
R
SPEAKER
+
–
+
–
M961
DC FAN
H
MAIN
BOARD
(Page 30)
23 4 5 6 7 89
A
1
B
C
D
E
F
G
Ref. No. Location
D501 F-2
D504 E-3
D505 E-3
D507 D-2
D508 G-6
D509 F-5
D851 A-5
D852 D-6
IC502 C-4
IC850 F-3
Q501 E-2
Q502 E-2
Q503 E-2
Q504 D-3
• Semiconductor
Location
Ref. No. Location
Q505 E-3
Q507 D-4
Q508 D-4
Q509 G-4
Q850 F-3
Q851 F-3
Q852 F-3
Q853 A-2
Q854 B-2
Q858 B-6
Q859 A-5
Q860 B-5
Q861 B-4
Q868 B-4
Q869 B-4
Q890 B-4
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
3939
HCD-CP555/NXM1
7-19. SCHEMATIC DIAGRAM – FRONT AMP BOARD –
R505
R509
EP501
C508
R513
C511
CN501
R506 C503
R507 C504
R516
R515
C513
R528
R537
R860
R850
C850
Q850 C851
R851
Q851 Q852
C852
C854 C853
IC850
C516
R521
R523
C518
Q503
R522
D504
R531
R530
Q504
R532
R542 D501
C523
D505
R534
R535
Q505
R536
R533 R543
C524
C525
D507
R549
C528
R548
R550
Q508
R547
R546
R545
C522
R529
JW521
R520
Q507
Q501
Q502
R518
R517
TH531
R519
C530
C531 JW551
JW553
C529
R872
EP502 C540
R566
R562
C538
C537 C539
RY501
D509
Q509
R560
R559
Q853
Q854
R854
R857
Q868
R890
R871
R870
Q869
Q890
C862
C861
C855
C856
R855
R876
R875
R858
R568
R569
R563
R565
JW505
L502
R561
JW504
L501
R564
C557
EP510
CN502
JW552
JW550
Q861
D852
C860
R867
R866
Q860
R864
R865
C859
Q859
R862 R863
Q858
R895
D851
C858
C857
CN506
CN505
CN508
IC502
C560
C505
R511 R512
C509
C510
TM501
R524
1k
1k
220p
47k
220p
8P
47k 470p
47k 470p
47k
22k
0.001
0.22
2W
0.22
2W
4.7k
2.2k
10
50V
2SC1623 100
10V
4.7k
2SC1623 2SC1623
2.2
50V
10
50V
220
10V
RT8H015C
47
50V
100
1/4W
FR
33k
47
50V
2SC2713G-TE85L
-VH SUPP
47k
1SS355
15k
1k
2SC1841
100k
10
1/2W
1SS355
0.1
100V
1SS355
15k
1k
2SC1841
0.22
2W
150k
10
1/2W
0.1
0.1
1SS355
2.2k
47
100V
100k
2.2k
2SC1623
68k
47k
2.2k
0.1
0.22
2W
100
1/4W
FR
2SA1163G-TE85L
2SC1623
2SC1623
100k
22k
100k
2200
50V
2200
50V
0.01
100k
100000p
10
1/2W
10
1/2W
100000p
100000p 100000p
1SS355
2SC1623
RELAY SWITCH
10k
2.2k
2SC3624A
MUTE
2SC3624A
MUTE
1k
1k
DTA114EKA
10k
470
220
DTC114EKA
DTC114EKA
4.7
50V
4.7
50V
4.7
100V
4.7
100V
680
2W
220
220
680 2W
68k
47k
10
1/2W
47k
10
1/2W
47k
0.1
5P
DTC114EKA
1SS355
4.7
50V
4.7k
47k
2SC1623
220k
100
47
35V
2SC1623
22k 22k
2SD2525
0
UDZS-TE-17-6.8B
0.01
0.01
3P
4P
10P
STK442-090
10
50V
10
50V
750 750
47
35V
47
35V
1
1/4W
RF
PROTECTER
OVER CURRENT
(CHASSIS)
EXCEPT
DETECT
OVER LOAD
DETECT
OVER LOAD
SWITCH
MUTE
SWITCH
Q501,502
TEMPERATURE
DETECT
Q850-852
PROTECT
RELAY DRIVE
SPEAKER
Q507,508
STK
FAN MOTOR DRIVE
Q858-861
Q868-890
MUTE CONTROL
POWER AMP
(CHASSIS)
AEP,UK,EA,RU
AEP,UK,EA,RU
AEP,UK,EA,RU
AEP,UK,EA,RU
M961
FAN
R
L
SPEAKER
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
4040
HCD-CP555/NXM1
7-20. IC Block Diagram
– BD Board –
IC251 BA5947FM
– RELAY Board –
IC701, 711 BA6956AN
15
16
17
18
19
20
21
22
23
24
25
26
27
36
28
29
30
31
32
33
34
35
1
2
3
4
5
6
7
8
9
10
11
12
13
14
LEVEL
SHIFT
F
R
R
F
R
F
F
19k
6.5k
50k 50k
100k
50k
PIN3
10k
Vref
50k 50k
PIN26
(ch1, 2)
POW
VCC
(ch3, 4)
SW
Pre
Vcc
INTER
FACE
INTER
FACE
INTER
FACE
R
F
50k 50k
POW
VCC
MUTE
Vref
POW
VCC
R
F
10k
CH1PUTF
CH1OUTR
CH2OUTF
CH2OUTR
POWVCC
CNF4
GND
C-M
C-P
VG
CH2RIN
CH2FIN
CH1RIN
CH1FIN
SW
OPIN+
OPIN-
NC
CH4OUTR
CH4OUTF
CH3OUTF
CH3OUTR
POWVCC
MUTE
GND
GND
PREGND
CT
CH3RIN
CH3FIN
CH4IN
CH4CAPA
OUTVREF
DPOUT
TREVCC
NC
D
D
D
D
D
D
D
D
123456789
CONTROL LOGIC
TSD
VREF
OUT2
OUT1
RNF
VM
VCC
FIN
GND
RIN
– BD Board –
IC301 TC94A34FG-002
33
34
35
36
37
38
39
40
41
42
1
8
43
61 62 63 646059565250
47
46
45
44
48
49
2526272829303132 1718192021222324
9
10
11
2
3
4
5
6
7
5857555351
12
13
14
15
16
54
CS/RAS/ADO2
AD15/CAS/PD12
SDO3/OE
WE/SDO1
PIO7/BUS3/IO7
PIO6/FI3/BUS2/IO7
PIO5/FI2/BUS1/IO5
PIO4/FI1/BUS0/IO4
Bus
Switch
PO11/BUCK/AD14
PO10/CCE/AD13
PO9/AD12
PO08/AD11
General
In/Output Port
Address Calc.
2sets
Y- Pointer
register
C-Pointer
register
X-Pointer
register
VDDM
SRMSTB
VDDT
AD10
AD9
ERAM
2k word
CRAM
4k word
CROM
4k word
YRAM
4k word
XRAM
4k word
SRAM/
DRAM I/F
SRAM I/F
1Mbit
SRAM
X-Bus
Y-Bus
PO07/AD7
PO06/AD6
PO05/AD5
AD8
VC0 Timing
Generator
PRAM
Instruction
Decoder
Program
Control
MCU. I/F
register
XO • X1 • X2
Y0 • Y1 • Y2
MX MY MZ
MAC
A0 A1
AX AY
ALU
A2 A3
DIT
round & limit round & limit
Audio I/F
LRCKIA
BCKIA
SDI0
LRCKO
BCKO
SDO0
VSS
VDDT
MIACK
MICK
MIDIO
MILP
MICS
STANBY
RESET
VDDP
AD4/PO04
AD3/PO03
AD2/PO02
AD1/PO01
AD0/PO00
VSS
VDD
CKO/PO13/AD16
VDDX
XO
TEST
VCOI
VSSX
XI
MIMD
VSSP
PIO3/IO3
PIO2/IO2
PIO1/SDI3/IO1
PIO0/SDI2/IO0
VSS
CKI/CLOCK/IRQ/FIO
VDD
TXO
SFSY/LRCKIB
SBSY/BCKIB
SDI1/DATA
POM
Sub code
I/F
CDP Cont
I/F
http://www.xiaoyu163.com
http://www.xiaoyu163.com
41
HCD-CP555/NXM1
7-21. IC Pin Function Descriptions
• IC101 CXD3059AR (RF AMP) (BD BOARD)
Pin No. Pin Name I/O Description
1MIRR I/O Mirror signal input/output(Not used)
2DFCT I/O Defect signal input/output (Not used)
3FOK I/O Focus OK signal input/output (Not used)
4VSS — Internal digital ground
5LOCK I/O Not used
6MDP O Spindle motor servo control output
7SSTP I Disk innermost detection signal input
8IOVSS1 — I/O digital ground
9SFDR O Sled drive output
10 SFDR O Sled drive output
11 TFDR O Tracking drive output
12 TRDR O Tracking drive output
13 FFDR O Focus drive output
14 FFDR O Focus drive output
15 IOVDD1 — I/O digital power supply
16 AVDD0 — Analog power supply
17 AVSS0 — Analog ground
18 NC — Not used
19 E I E signal input
20 F I F signal input
21 TEI I Tracking error signal input
22 TEO O Tracking error signal output
23 FEI I Focus error signal input
24 FEO O Focus error signal output
25 VC I/O Center voltage output from RF amplifier block
26 A I A signal input
27 B I B signal input
28 C I C signal input
29 D I D signal input A
30 NC — Not used
31 AVDD4 — Analog power supply
32 RFDCO O RFDC signal output (Not used)
33 PDSENS I Reference voltage pin
34 AC_SUM O RFAC summing amplifier output
35 EQ_IN I Equalizer circuit input
36 LD O APC output
37 PD I APC input
38 NC — Not used
39 RFC I Equalizer cut-off frequency adjustment pin
40 AVSS4 — Analog ground
41 RFACO O RFAC signal output
42 RFACI I RFAC signal input or EFM signal input
43 AVDD3 — Analog power supply
44 BIAS I Asymmetry circuit constant current input
45 ASYI I Asymmetry comparator voltage input
46 ASYO O EFM full-swing output
47 VPCO O Not used
48 VCTL I Wide-band EFM PLL VCO2 control voltage input
http://www.xiaoyu163.com
http://www.xiaoyu163.com
42
HCD-CP555/NXM1
Pin No. Pin Name I/O Description
49 AVSS3 — Analog ground
50 CLTV I Multiplier VCO1 control voltage input
51 FILO O Master PLL (slave = digital PLL) filter output
52 FILI I Master PLL filter input
53 PCO O Master PLL charge pump output
54 AVDD5 — Analog power supply
55 DDVROUT O DC/DC converter output
56 DDVRSEN I DC/DC converter output voltage monitor input
57 AVSS5 — Analog ground
58 DDCR I DC/DC converter reset input
59 NC — Not used
60 BCKI I D/A interface bit clock input
61 PCMDI I D/A interface serial data input (2’s COMP, MSB first)
62 LRCKl I D/A interface LR clock input
63 LRCK O D/A interface LR clock output f = Fs
64 VSS — Internal digital ground
65 PCMD O D/A interface serial data output (2’s COMP, MSB first)
66 BCK O D/A interface bit clock output
67 VDD — Internal digital power supply
68 EMPH O High when the playback disc has emphasis, low it has not
69 EMPHI I High when de-emphasis is ON, low when input OFF
70 IOVDD2 — I/O digital power supply
71 DOUT O Digital Out output
72 TEST I Test pin Normally ground
73 TES1 I Test pin Normally ground
74 IOVss2 — I/O digital ground
75 NC — Not used
76 XVSS — Master clock ground
77 XTAO O Crystal oscillation circuit output
78 XTAI I Crystal oscillation circuit input
79 XVDD — Master clock power supply
80 AVDD1 — Analog power supply
81 AOUT1 O Lch analog output
82 VREFL O Lch reference voltage
83 AVSS1 — Analog ground
84 AVSS2 — Analog ground
85 VREFR O Rch reference voltage
86 AOUT2 O Rch analog output
87 AVDD2 — Analog power supply
88 NC — Not used
89 IOVDD0 — I/O digital power supply
90 RMUT O Rch “0” detection flag (Not used)
91 LMUT O Lch “0” detection flag (Not used)
92 NC — Not used
93 XTSL I Crystal selection input (Not used)
94 IOVSS0 — I/O digital ground
95 XTACN I
Oscillation circuit control
Self-oscillation when high, oscillation stop when low
96 SQSO O Subcode Q 80-bit and PCM peak and level data output (Not used)
97 SQCK I SQSO readout clock input
http://www.xiaoyu163.com
http://www.xiaoyu163.com
43
HCD-CP555/NXM1
Pin No. Pin Name I/O Description
98 SBSO O Subcode P to W serial output (Not used)
99 EXCK I SBSO readout clock input (Not used)
100 XRST I System reset input
101 SYSM I Mute input
102 D ATA I Serial data input from CPU
103 VSS — Internal digital ground
104 XLAT I Latch input from CPU
105 CLOCK I Serial data transfer clock input from CPU
106 VDD — Sled drive output Internal digital power supply Tracking drive output
107 SENS O SENS output to CPU
108 SCLK I SENS serial data readout clock input
109 ATSK I/O Anti-shock input/output (Not used)
110WFCK O WFCK output (Not used)
111 XUGF O XUGF output (Not used)
112XPCK O XPCK output (Not used)
113 GFS O GFS output (Not used)
114C2PO O C2PO output (Not used)
115 SCOR O High output when the subcode sync, S0 or S1, is detected
116 VDD — Internal digital power supply
117 C4M O 4 2336MHz output (Not used)
118WDCK O Word clock output f = 2Fs (Not used)
119 COUT I/O Track number count signal input/output (Not used)
120 NC — Not used
http://www.xiaoyu163.com
http://www.xiaoyu163.com
44
HCD-CP555/NXM1
• IC401 M30622MGN-B27FPUO (SYSTEM CONTROL) (MAIN Board)
Pin No. Pin Name I/O Description
1MP3 CS O Chip select signal to CD Digital Processor
2 MP3 LP O Latch pulse output to CD Digital Processor and Motor signal output
3 MP3 ACK I ACK input from CD Digital Processor and Motor signal input
4SIRCS I Remote commander signal input
5MP3 DATA OUT O Serial data output to the MP3 circuit
6MP3 DATA IN I Serial data input from the MP3 circuit
7MP3 CLK O Serial clock output to the MP3 circuit
8BYTE I External data bus width select input (connected to ground)
9CN VSS I Processor modes switch
10 XC-IN I Sub clock input (32.768kHz)
11 XC-OUT O Sub clock output (32.768kHz)
12 RESET I System reset input
13 X-OUT O Main system clock output (16MHz)
14 VSS – Ground
15 X-IN I Main system clock input (16MHz)
16 VCC – Power supply
17 NMI I Non-maskable interrupt input
18 RDS-INT I RDS signal input
19 SCOR I CD Q-DATA request
20 AC-CUT I AC cut-off detection signal input
21 SENS I Internal status(SENSE) signal input from CXD3059AR
22 CD-DATA O Serial data output
23 CD-CLK O Serial data transfer clock signal output
24 XLT O Serial data latch pulse output
25 XRST O Reset signal output to the CD mechanism
26 XCTN O XCTN signal output (for Tuner noise reduction)
27 A-MUTE O Audio muting on/off control signal output
28 MP3STB O Standby signal output to the MP3 circuit
29 IIC-CLK I/O Communication data reading clock signal input or transfer clock signal output
30 IIC-DATA I/O Communication data bus with CD mechanism and Fluorescent indicater
31 MP3 REQ I REQ signal input from MP3 circuit
32 MP3 RESET O RESET signal output to the MP3 circuit
33 CDM-MOT-POS-1 O Motor drive signal output (L/D)
34 CDM-MOT-POS-2 O Motor drive signal output (U/D)
35 CDM-MAIN-SW-CLS I Detection signal input from disc tray close detect main switch
36 CDM-SUB-SW-OPN I Detection signal input from disc tray open detect sub switch
37 CDM-ENC-A-1 I Detection signal input from the disc tray address detect rotary encoder
38 CDM-ENC-A-3 I Detection signal input from the disc tray address detect rotary encoder
39 CDM-ENC-B-1 I Detection signal input from the disc tray address detect rotary encoder
40 CDM-ENC-B-3 I Detection signal input from the disc tray address detect rotary encoder
41 CDM-ENC-B-2 I Detection signal input from the disc tray address detect rotary encoder
42 CDM-ENC-B-0 I Detection signal input from the disc tray address detect rotary encoder
43 CDM-ENC-A-2 I Detection signal input from the disc tray address detect rotary encoder
44 CDM-ENC-A-0 I Detection signal input from the disc tray address detect rotary encoder
45 CDM-SUB-SW-CLS I Detection signal input from disc tray close detect sub switch
46 CDM-MAIN-SW-OPN I Detection signal input from disc tray open detect main switch
47 CDM-MOT-NEG-2 O Motor drive signal output (U/D)
48 CDM-MOT-NEG-1 O Motor drive signal output (L/D)
49 RDS-DATA I RDS data input
50 ST-MUTE O Tuner muting control signal output to tuner unit
http://www.xiaoyu163.com
http://www.xiaoyu163.com
45
HCD-CP555/NXM1
Pin No. Pin Name I/O Description
51 TUNED IN I Tuning detecton signal input from tuner unit
52 ST-CE O PLL chip enable signal output to tuner unit
53 ST-DOUT O PLL serial data output to tuner unit
54 ST-DIN I PLL serial data input from tuner unit
55 ST-CLK O PLL serial tansfer clock signal output to tuner unit
56 TA-MUTE O Tuner line mute signal output (H:mute on)
57 STK-MUTE O Power amplifier muting on/off selection signal output
58 FRONT-RELAY O Relay drive signal output for speaker protect
59 BIAS O Recording bias on/off selection signal output
60 REC/PB O Recording/playback selection signal output
61 TC-LINE-MUTE O Line mute on/off selection signal output
62 VCC – Power supply
63 TC-REC-MUTE O Recording muting on/off selection signal output
64 VSS – Ground
65 STBY-RELAY O Main power on/off control signal output
66 IO-EXP:CLK O Serial data transfer outout to PT8300R
67 IO-EXP:LAT O Serial data latch pulse output to PT8300R
68 IO-EXP DATA IN I Serial data input from PT8300R
69 IO-EXP DATA OUT O Serial data output to PT8300R
70 VOL-A I Jog dial pulse input from the rotary encoder (Volume)
71 VOL-B I Jog dial pulse input from the rotary encoder (Volume)
72 LED-STANDBY O Standby signal output to the LED driver
73 DISPLAY KEY I Display key input signal
74 POWER KEY I Power key input sigal
75 DISC-SENS I Disc status detection signal input
76 JOG 1-A I Jog dial pulse input from the rotary encoder (Bass)
77 JOG 1-B I Jog dial pulse input from the rotary encoder (Bass)
78 JOG 2-A I Jog dial pulse input from the rotary encoder (Treble)
79 JOG 2-B I Jog dial pulse input from the rotary encoder (Treble)
80 AMP-DATA O Serial data output to M61537FP
81 AMP-CLK O Serial clock output to M61537FP
82 FL-RESET O Reset signal output to M66005-0131AHPROT
83 FL-CS O Chip select signal output to M66005-0131AHPROT
84 FL-CLK O Serial clock output to M66005-0131AHPROT
85 FL-DATA O Serial data output to M66005-0131AHPROT
86 CAMP-CNT1 O Capstan motor draive signal output
87 A TRG O Deck-A side trigger plunger drive signal output
88 B TRG O Deck-B side trigger plunger drive signal output
89 A SHUT I Shut off detection signal input from the deck-A side reel pulse detector
90 B SHUT I Shut off detection signal input from the deck-B side reel pulse detector
91 B HALF I Detection input from the deck-B half detect switch
92 SPEC-IN I Setting terminal for the version
93 MAIN-TRANS-CUT I Main transformer cut detect signal input
94 AD-KEY 2 I AD key 2 signal input
95 AD-KEY 1 I AD key 1 signal input
96 AVSS – Ground
97 VACS IN I VACS signal input
98 VREF I Reference voltage input
99 AVCC – Analog power supply
100 AMS-IN I Automatic music senser signal input
http://www.xiaoyu163.com
http://www.xiaoyu163.com
46
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
SECTION 8
EXPLODED VIEWS
8-1. CASE, REAR PANEL SECTION
NOTE:
•-XX, -X mean standardized parts, so they may
have some differences from the original one.
•Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
•The mechanical parts with no reference number
in the exploded views are not supplied.
•Abbreviation
E3 : 240V AC Area in E model
E51 : Chilean and Peruvian model
EA : Saudi Arabia model
RU : Russian model
The components identified by mark 0 or
dotted line with mark 0 are critical for
safety.
Replace only with part number specified.
#1
#1
#1
#1
#1
#1
#1
#1
not supplied
1
2
2
34
5
6
7
7
7
7
9
10
11
M961
#1
#1
#1
#1 #1
#1
1A-1052-024-A MAIN BOARD, COMPLETE (EA)
1A-4750-842-A MAIN BOARD, COMPLETE (AEP, UK)
1A-4750-905-A MAIN BOARD, COMPLETE (NXM1)
1A-4750-910-A MAIN BOARD, COMPLETE (E3)
1A-4750-915-A MAIN BOARD, COMPLETE (E51)
21-500-497-11 FILTER, CLAMP (FERRITE CORE)
31-769-984-11 WIRE (FLAT TYPE) (13 CORE)
41-765-332-11 WIRE (FLAT TYPE) (15 CORE)
51-769-869-11 WIRE (FLAT TYPE) (5 CORE)
61-769-939-11 WIRE (FLAT TYPE) (11 CORE) (EXCEPT AEP, UK)
61-773-003-11 WIRE (FLAT TYPE) (15 CORE) (AEP, UK)
73-363-099-22 SCREW (CASE 3 TP2)
94-252-541-11 CASE
10 4-252-538-01 PANEL, TOP
11 1-693-603-31 TUNER (FM/AM) (E3, E51, EA)
11 1-693-604-11 TUNER (FM/AM) (AEP, UK)
11 1-693-654-11 TUNER (FM/AM) (NXM1)
M961 1-787-099-11 FAN, DC
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
Ver.1.1
http://www.xiaoyu163.com
http://www.xiaoyu163.com
47
HCD-CP555/NXM1
8-2. FRONT PANEL SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
not supplied not supplied
not supplied
#1
not supplied
not supplied
not
supplied
not supplied
not supplied
51
52
53
57
57
56
57 57
57
57
57
57
57
57
58
57
57
57
59
60
61
57
57
55
55
62 63
51 4-252-535-01 KNOB (VOL)
52 4-252-536-01 KNOB (B/T)
53 X-4956-196-1 PANEL ASSY (CP555), FRONT (AEP, UK)
53 X-4956-261-1 PANEL ASSY, FRONT (E3, E51, EA)
53 X-4956-332-1 PANEL ASSY, FRONT (RU)
55 4-240-965-01 SCREW 2.6X3 +P, S-TITE
56 A-4750-851-A VOL BOARD, COMPLETE
57 4-951-620-01 SCREW (2.6X8), +BVTP
58 A-4750-849-A FL COM BOARD, COMPLETE
59 1-796-902-11 DECK, MECHANISM (W)
60 X-4956-197-1 HOLDER (A) (TC) ASSY
61 X-4956-198-1 HOLDER (B) (TC) ASSY
62 4-252-530-01 SPRING (HB) (US)
63 4-252-529-01 SPRING (HA)
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
Ver.1.1
http://www.xiaoyu163.com
http://www.xiaoyu163.com
48
HCD-CP555/NXM1
8-3. CHASSIS SECTION
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
#1 #1
#1
#1
#1
#2
#1
#1
#1
#1
not supplied
not supplied
CDM81B-F1BD81A
not supplied
101
102
105
106
106
103
104
106
106
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
101 A-4750-852-A FRONT AMP BOARD, COMPLETE
(AEP, UK, EA, RU)
101 A-4750-913-A FRONT AMP BOARD, COMPLETE (E3)
101 A-4750-918-A FRONT AMP BOARD, COMPLETE (E51)
0102 1-468-812-11 REGULATOR, SWITCHING (AEP, UK, RU)
0102 1-468-824-11 REGULATOR, SWITCHING (E3, E51, EA)
0103 1-775-786-21 CORD, POWER (UK, EA)
0103 1-777-071-53 CORD, POWER (AEP, E51, RU)
0103 1-827-226-11 CORD, POWER (E3)
*104 3-703-244-00 BUSHING (2104), CORD (EXCEPT E3)
104 3-703-571-11 BUSHING (S) (4516), CORD (E3)
105 1-500-497-11 FILTER, CLAMP (FERRITE CORE)
106 3-970-608-01 SUMITITE (B3), +BV
#1 7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
#2 7-685-647-79 SCREW +BVTP 3X10 TYPE2 TT (B)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
49
HCD-CP555/NXM1
8-4. CD MECHANISM DECK SECTION-1
(CDM81B-F1BD81A)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
#5
#3
#3
#5
#5
#3
#3
153
154
151
152
155
156
157
158
159
160
161
162
163
164
165
166
167
151 4-251-849-01 LEVER (SW2)
152 4-251-991-01 SPRING (SW2), TORSION
153 4-251-860-01 LEVER (LOCK)
154 4-251-867-01 SPRING (LOCK), TORSION
155 4-251-828-01 TRAY (MAIN)
156 4-252-533-01 PANEL, LOADING
157 4-251-857-01 COVER (R)
158 4-251-830-01 SLIDER (ST)
159 4-251-858-01 COVER (L)
160 4-251-829-01 TRAY (SUB)
161 X-4955-707-2 PULLEY (A5) ASSY, CHUCKING
162 1-471-035-11 MAGNET ASSY
163 4-251-821-01 BRACKET (TOP)
164 4-231-189-01 PULLEY (B), CHUCKING
165 4-251-824-01 LIFTER
166 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING
167 4-251-822-01 JOINT (LIFTER)
#3 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S
#5 7-685-102-19 SCREW +P 2X4 NON-SLIT TYPE 2
http://www.xiaoyu163.com
http://www.xiaoyu163.com
50
HCD-CP555/NXM1
8-5. CD MECHANISM DECK SECTION-2
(CDM81B-F1BD81A)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
#4 #4
#4
#3
#3
#3
S771
not supplied
not supplied
#4 #4
#4
#4
#3
not supplied
M761
M762
#4
#4
#4
#4 #4
#4
201
208
208
208
211
212
213
203 203
203
204
209 214 214
210
215
205
206
207
202
201 4-251-870-01 BELT (BU)
202 4-251-869-01 BELT (MAIN TRAY)
203 4-251-841-01 GEAR (SUB TRAY 1)
204 4-251-873-01 SPRING (MODE), COMPRESSION
205 4-239-618-02 SCREW (+PWH, 2X6), STEP TAPPING
206 4-251-872-01 SPRING (LEVER), TORSION
207 4-251-868-01 BELT (SUB TRAY)
208 4-251-853-01 PULLEY (BU)
209 4-251-834-01 LEVER (MAIN TRAY)
210 4-251-852-01 GEAR (MAIN TRAY 3)
211 4-251-854-01 GEAR (BU1)
212 4-251-850-01 GEAR (MAIN TRAY 1)
213 4-251-856-01 GEAR (BU2)
214 4-251-842-01 GEAR (SUB TRAY 2)
215 4-251-851-01 GEAR (MAIN TRAY 2)
M761 A-4713-174-A MOTOR (81) ASSY (LD/ST MOTOR)
M762 A-4713-174-A MOTOR (81) ASSY (BU U/D MOTOR)
S771 1-478-552-11 ENCODER, ROTARY
#3 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S
#4 7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
51
HCD-CP555/NXM1
8-6. CD MECHANISM DECK SECTION-3
(CDM81B-F1BD81A)
not supplied
not supplied
not supplied
BU-F1BD81A
not supplied
#3 #4 #4 #4
#4 #3
#3
S781
#4
#4
#4
#4
#4
#3
#3
#4
251
251
252
256
257
273
272
270
259
255
271
260
254
272
269
268
258
253
251
261
262
262 263 263
263
262
264
265
266
267
252
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
251 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING
252 4-251-873-01 SPRING (MODE), COMPRESSION
253 4-251-874-01 SPRING (SW), TENSION
254 4-251-844-01 GEAR (SS2)
255 4-251-835-01 GEAR (STOCKER 1)
256 4-251-833-01 LEVER (SUB TRAY)
257 4-251-843-01 LEVER (RELEASE)
258 4-251-831-01 LEVER (MODE)
259 4-251-862-01 SHUTTER (TRAY)
260 4-251-845-01 GEAR (SS3)
261 4-251-829-01 TRAY (SUB)
262 4-251-827-01 CAM (STOCKER)
263 4-251-836-01 GEAR (STOCKER 2)
264 4-251-838-01 GEAR (STOCKER 3)
265 4-251-823-01 CHASSIS (CDM81)
266 A-4750-232-A RELAY MOUNTED PC BOARD
267 4-239-618-02 SCREW (+PWH, 2X6), STEP TAPPING
268 4-251-825-01 CAM (BU)
269 4-251-832-01 LEVER (STOCKER)
270 4-251-861-01 LEVER (SW)
271 4-251-839-01 GEAR (STOCKER 4)
272 4-251-840-01 GEAR (SUB TRAY)
273 4-251-847-01 GEAR (SS4)
S781 1-478-551-11 ENCODER, ROTARY
#3 7-685-534-19 SCREW +BTP 2.6X8 TYPE2 N-S
#4 7-685-902-21 SCREW +PTPWH 2.6X8 (TYPE2)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
52
HCD-CP555/NXM1
8-7. BASE UNIT (BU-F1BD81A)
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
308
307
305
305
305
305
304
304
304
304
303
303
303
303
302
301
306
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
301 X-4956-102-1 HOLDER (215) ASSY
0302 8-820-244-01 OPTICAL PICK-UP (KSM-215DCP/C2NP)
303 4-227-549-11 INSULATOR
304 4-227-045-11 SPRING (INSULATOR), COIL
305 4-985-672-01 SCREW (+PTPWHM2.6), FLOATING
306 1-827-992-11 WIRE (FLAT TYPE) (16 CORE)
307 A-4751-045-A CD (A) BOARD, COMPLETE
308 4-951-620-01 SCREW (2.6X8), +BVTP
http://www.xiaoyu163.com
http://www.xiaoyu163.com
53
HCD-CP555/NXM1
SECTION 9
ELECTRICAL PARTS LIST
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
NOTE:
•Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
•-XX, -X mean standardized parts, so they
may have some difference from the original
one.
•Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
•CAPACITORS:
uF: µF
•RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
•COILS
uH: µH
•SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
•Abbreviation
E3 : 240V AC Area in E model
E51 : Chilean and Peruvian model
EA : Saudi Arabia model
RU : Russian model
BD
The components identified by mark 0
or dotted line with mark 0 are critical
for safety.
Replace only with part number specified.
When indicating parts by reference
number, please include the board.
A-4751-045-A BD BOARD, COMPLETE
*****************
< CAPACITOR >
C10 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3V
C11 1-165-989-11 CERAMIC CHIP 10uF 10% 6.3V
C14 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C15 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C16 1-115-156-11 CERAMIC CHIP 1uF 10V
C17 1-126-246-11 ELECT CHIP 220uF 20% 4V
C18 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C111 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50V
C112 1-164-315-11 CERAMIC CHIP 470PF 5% 50V
C113 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50V
C114 1-164-315-11 CERAMIC CHIP 470PF 5% 50V
C115 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C116 1-128-995-21 ELECT CHIP 100uF 20% 10V
C122 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C123 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C124 1-162-959-11 CERAMIC CHIP 330PF 5% 50V
C125 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C131 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C132 1-117-863-11 CERAMIC CHIP 0.47uF 10% 6.3V
C133 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C134 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C141 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C142 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V
C143 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C151 1-128-995-21 ELECT CHIP 100uF 20% 10V
C161 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C162 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C163 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C171 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C172 1-162-920-11 CERAMIC CHIP 27PF 5% 50V
C174 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C181 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C182 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C183 1-124-778-00 ELECT CHIP 22uF 20% 6.3V
C184 1-124-778-00 ELECT CHIP 22uF 20% 6.3V
C185 1-164-315-11 CERAMIC CHIP 470PF 5% 50V
C186 1-164-315-11 CERAMIC CHIP 470PF 5% 50V
C194 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C195 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C196 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C201 1-128-995-21 ELECT CHIP 100uF 20% 10V
C203 1-128-995-21 ELECT CHIP 100uF 20% 10V
C209 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C210 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C211 1-164-230-11 CERAMIC CHIP 220PF 5% 50V
C212 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C213 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C251 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V
C252 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C255 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C257 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C258 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C259 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C260 1-128-394-11 ELECT CHIP 220uF 20% 10V
C302 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C303 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C305 1-126-246-11 ELECT CHIP 220uF 20% 4V
C306 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C307 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C308 1-126-208-21 ELECT CHIP 47uF 20% 4V
C309 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C310 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C311 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C312 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C313 1-164-360-11 CERAMIC CHIP 0.1uF 16V
C314 1-126-208-21 ELECT CHIP 47uF 20% 4V
C315 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V
C316 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V
C317 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C318 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C320 1-216-864-11 SHORT CHIP 0
< CONNECTOR >
CN101 1-770-425-11 CONNECTOR, FFC/FPC 16P
CN201 1-818-350-11 CONNECTOR (FFC) 27P
< FERRITE BEAD >
FB301 1-500-445-21 FERRITE, EMI (SMD) (2012)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
54
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
BD DISC SW
< IC >
IC101 8-752-425-12 IC CXD3059AR
IC251 6-705-808-01 IC BA5947FM
IC301 6-705-365-01 IC TC94A34FG-002
IC303 6-705-807-01 IC BH15FB1WG
< TRANSISTOR >
Q10 6-550-363-01 TRANSISTOR 2SB1690KT146
< RESISTOR >
R10 1-216-791-11 METAL CHIP 3.3 5% 1/10W
R11 1-216-864-11 SHORT CHIP 0
R12 1-216-845-11 METAL CHIP 100K 5% 1/10W
R13 1-218-446-11 METAL CHIP 1 5% 1/10W
R111 1-216-821-11 METAL CHIP 1K 5% 1/10W
R112 1-216-835-11 METAL CHIP 15K 5% 1/10W
R113 1-216-821-11 METAL CHIP 1K 5% 1/10W
R114 1-216-835-11 METAL CHIP 15K 5% 1/10W
R121 1-216-835-11 METAL CHIP 15K 5% 1/10W
R131 1-216-857-11 METAL CHIP 1M 5% 1/10W
R132 1-216-833-11 METAL CHIP 10K 5% 1/10W
R133 1-216-848-11 METAL CHIP 180K 5% 1/10W
R141 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R142 1-216-821-11 METAL CHIP 1K 5% 1/10W
R143 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R151 1-216-864-11 SHORT CHIP 0
R161 1-216-809-11 METAL CHIP 100 5% 1/10W
R162 1-216-841-11 METAL CHIP 47K 5% 1/10W
R163 1-216-809-11 METAL CHIP 100 5% 1/10W
R165 1-216-864-11 SHORT CHIP 0
R171 1-216-817-11 METAL CHIP 470 5% 1/10W
R172 1-216-857-11 METAL CHIP 1M 5% 1/10W
R173 1-216-295-91 SHORT CHIP 0
R181 1-216-809-11 METAL CHIP 100 5% 1/10W
R182 1-216-809-11 METAL CHIP 100 5% 1/10W
R191 1-216-864-11 SHORT CHIP 0
R201 1-500-445-21 FERRITE, EMI (SMD) (2012)
R203 1-216-864-11 SHORT CHIP 0
R204 1-500-445-21 FERRITE, EMI (SMD) (2012)
R205 1-216-864-11 SHORT CHIP 0
R251 1-216-833-11 METAL CHIP 10K 5% 1/10W
R252 1-216-837-11 METAL CHIP 22K 5% 1/10W
R253 1-216-833-11 METAL CHIP 10K 5% 1/10W
R301 1-216-845-11 METAL CHIP 100K 5% 1/10W
R302 1-216-833-11 METAL CHIP 10K 5% 1/10W
R303 1-216-845-11 METAL CHIP 100K 5% 1/10W
R305 1-216-845-11 METAL CHIP 100K 5% 1/10W
R306 1-216-864-11 SHORT CHIP 0
R307 1-216-833-11 METAL CHIP 10K 5% 1/10W
R313 1-216-813-11 METAL CHIP 220 5% 1/10W
R351 1-216-809-11 METAL CHIP 100 5% 1/10W
R352 1-216-809-11 METAL CHIP 100 5% 1/10W
R353 1-216-809-11 METAL CHIP 100 5% 1/10W
R354 1-216-809-11 METAL CHIP 100 5% 1/10W
R401 1-216-809-11 METAL CHIP 100 5% 1/10W
R402 1-216-809-11 METAL CHIP 100 5% 1/10W
R403 1-216-809-11 METAL CHIP 100 5% 1/10W
R404 1-216-809-11 METAL CHIP 100 5% 1/10W
R405 1-216-809-11 METAL CHIP 100 5% 1/10W
R406 1-216-809-11 METAL CHIP 100 5% 1/10W
R407 1-216-809-11 METAL CHIP 100 5% 1/10W
R408 1-216-809-11 METAL CHIP 100 5% 1/10W
R409 1-216-809-11 METAL CHIP 100 5% 1/10W
R410 1-216-809-11 METAL CHIP 100 5% 1/10W
R411 1-216-809-11 METAL CHIP 100 5% 1/10W
R412 1-216-809-11 METAL CHIP 100 5% 1/10W
R419 1-216-809-11 METAL CHIP 100 5% 1/10W
< SWITCH >
S101 1-771-853-11 SWITCH, DETECTION (LIMIT)
< VIBRATOR >
X171 1-767-408-21 VIBRATOR, CRYSTAL (16.9MHz)
************************************************************
1-861-475-11 DISC SW BOARD
*************
< CAPACITOR >
C1009 1-164-156-11 CERAMIC CHIP 0.1uF 25V
< DIODE >
D1001 8-719-058-64 DIODE SEL5823A-TP15 (DISC 1)
D1002 8-719-058-64 DIODE SEL5823A-TP15 (DISC 2)
D1003 8-719-058-64 DIODE SEL5823A-TP15 (DISC 3)
D1004 8-719-058-64 DIODE SEL5823A-TP15 (DISC 4)
D1005 8-719-058-64 DIODE SEL5823A-TP15 (DISC 5)
< TRANSISTOR >
Q1001 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q1002 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q1003 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q1004 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q1005 8-729-027-43 TRANSISTOR DTC114EKA-T146
< RESISTOR >
R1001 1-216-819-11 METAL CHIP 680 5% 1/10W
R1002 1-216-819-11 METAL CHIP 680 5% 1/10W
R1003 1-216-819-11 METAL CHIP 680 5% 1/10W
R1004 1-216-819-11 METAL CHIP 680 5% 1/10W
R1005 1-216-819-11 METAL CHIP 680 5% 1/10W
R1006 1-216-819-11 METAL CHIP 680 5% 1/10W
R1007 1-216-819-11 METAL CHIP 680 5% 1/10W
R1008 1-216-819-11 METAL CHIP 680 5% 1/10W
R1009 1-216-819-11 METAL CHIP 680 5% 1/10W
R1010 1-216-819-11 METAL CHIP 680 5% 1/10W
R1011 1-216-813-11 METAL CHIP 220 5% 1/10W
R1012 1-216-815-11 METAL CHIP 330 5% 1/10W
R1013 1-216-817-11 METAL CHIP 470 5% 1/10W
R1014 1-216-819-11 METAL CHIP 680 5% 1/10W
< SWITCH >
S1001 1-762-875-21 SWITCH, KEYBOARD (DISC 1)
S1002 1-762-875-21 SWITCH, KEYBOARD (DISC 2)
http://www.xiaoyu163.com
http://www.xiaoyu163.com
55
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
S1003 1-762-875-21 SWITCH, KEYBOARD (DISC 3)
S1004 1-762-875-21 SWITCH, KEYBOARD (DISC 4)
S1005 1-762-875-21 SWITCH, KEYBOARD (DISC 5)
******************************************************
A-4750-852-A FRONT AMP BOARD, COMPLETE
(AEP, UK, EA, RU)
A-4750-913-A FRONT AMP BOARD, COMPLETE (E3)
A-4750-918-A FRONT AMP BOARD, COMPLETE (E51)
***********************
< CAPACITOR >
C503 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C504 1-162-962-11 CERAMIC CHIP 470PF 10% 50V
C505 1-126-964-11 ELECT 10uF 20% 50V
C508 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C509 1-126-947-11 ELECT 47uF 20% 35V
C510 1-126-947-11 ELECT 47uF 20% 35V
C511 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C513 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C515 1-126-967-11 ELECT 47uF 20% 50V
C516 1-126-967-11 ELECT 47uF 20% 50V
C518 1-126-967-11 ELECT 47uF 20% 50V
C522 1-137-749-11 MYLAR 0.1uF 100V
C523 1-137-749-11 MYLAR 0.1uF 100V
C524 1-137-749-11 MYLAR 0.1uF 100V
C525 1-137-749-11 MYLAR 0.1uF 100V
C528 1-128-562-11 ELECT 47uF 20% 100V
C529 1-162-974-11 CERAMIC CHIP 0.01uF 50V
C530 1-128-550-11 ELECT 2200uF 20% 50V
C531 1-128-550-11 ELECT 2200uF 20% 50V
C537 1-131-992-91 CERAMIC CHIP 100000PF 35V
(AEP, UK, EA, RU)
C538 1-131-992-91 CERAMIC CHIP 100000PF 35V
(AEP, UK, EA, RU)
C539 1-131-992-91 CERAMIC CHIP 100000PF 35V
(AEP, UK, EA, RU)
C540 1-131-992-91 CERAMIC CHIP 100000PF 35V
(AEP, UK, EA, RU)
C557 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C560 1-126-964-11 ELECT 10uF 20% 50V
C850 1-126-964-11 ELECT 10uF 20% 50V
C851 1-104-658-91 ELECT 100uF 20% 10V
C852 1-126-961-11 ELECT 2.2uF 20% 50V
C853 1-126-923-91 ELECT 220uF 20% 10V
C854 1-126-964-11 ELECT 10uF 20% 50V
C855 1-107-721-11 ELECT 4.7uF 20% 100V
C856 1-107-721-11 ELECT 4.7uF 20% 100V
C857 1-162-974-11 CERAMIC CHIP 0.01uF 50V
C858 1-162-974-11 CERAMIC CHIP 0.01uF 50V
C859 1-126-947-11 ELECT 47uF 20% 35V
C860 1-126-963-11 ELECT 4.7uF 20% 50V
C861 1-104-658-91 ELECT 100uF 20% 10V
C862 1-104-658-91 ELECT 100uF 20% 10V
< CONNECTOR >
CN501 1-766-724-11 CONNECTOR, BOARD TO BOARD 7P
*CN502 1-564-520-11 PLUG, CONNECTOR 5P
CN505 1-785-330-11 PIN, CONNECTOR (LIGHT ANGLE) 4P
*CN506 1-564-518-11 PLUG, CONNECTOR 3P
CN508 1-784-041-41 CONNECTOR, BOARD TO BOARD 9P
< DIODE >
D501 8-719-988-61 DIODE 1SS355TE-17
D504 8-719-988-61 DIODE 1SS355TE-17
D505 8-719-988-61 DIODE 1SS355TE-17
D507 8-719-988-61 DIODE 1SS355TE-17
D509 8-719-988-61 DIODE 1SS355TE-17
D851 8-719-977-28 DIODE DTZ10B
D852 8-719-988-61 DIODE 1SS355TE-17
< EARTH TERMINAL >
*EP501 1-537-738-21 TERMINAL, EARTH (AEP, UK, EA, RU)
*EP502 1-537-738-21 TERMINAL, EARTH
*EP510 1-537-738-21 TERMINAL, EARTH
< IC >
IC502 8-749-017-12 IC STK442-090
IC850 6-703-610-01 IC RT8H015C-T112-1
< COIL >
L501 1-420-872-52 COIL, AIR-CORE (AEP, UK, EA, RU)
L502 1-420-872-52 COIL, AIR-CORE (AEP, UK, EA, RU)
< TRANSISTOR >
Q501 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q502 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q503 8-729-271-31 TRANSISTOR 2SC2713-G
Q504 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
Q505 8-729-140-84 TRANSISTOR 2SC1841-PAFAEA
Q507 8-729-216-31 TRANSISTOR 2SA1163-G
Q508 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q509 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q850 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q851 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q852 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q853 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q854 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q858 8-729-026-68 TRANSISTOR 2SD2525 (TP)
Q859 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q860 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q861 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q868 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q869 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q890 8-729-027-43 TRANSISTOR DTC114EKA-T146
< RESISTOR >
R505 1-216-821-11 METAL CHIP 1K 5% 1/10W
R506 1-216-841-11 METAL CHIP 47K 5% 1/10W
R507 1-216-841-11 METAL CHIP 47K 5% 1/10W
R509 1-216-821-11 METAL CHIP 1K 5% 1/10W
R511 1-218-484-11 METAL CHIP 750 5% 1/10W
R512 1-218-484-11 METAL CHIP 750 5% 1/10W
R513 1-216-841-11 METAL CHIP 47K 5% 1/10W
R515 1-216-837-11 METAL CHIP 22K 5% 1/10W
R516 1-216-841-11 METAL CHIP 47K 5% 1/10W
R517 1-216-842-11 METAL CHIP 56K 5% 1/10W
DISC SW FRONT AMP
http://www.xiaoyu163.com
http://www.xiaoyu163.com
56
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description RemarksRef. No. Part No. Description Remarks
MAIN
R518 1-216-845-11 METAL CHIP 100K 5% 1/10W
R519 1-216-845-11 METAL CHIP 100K 5% 1/10W
0R520 1-245-605-51 FUSIBLE 100 5% 1/4W
0R521 1-245-605-51 FUSIBLE 100 5% 1/4W
R522 1-216-841-11 METAL CHIP 47K 5% 1/10W
R523 1-216-839-11 METAL CHIP 33K 5% 1/10W
0R524 1-217-637-00 FUSIBLE 1 5% 1/4W
0R528 1-220-755-11 METAL 0.22 10% 2W
0R529 1-220-755-11 METAL 0.22 10% 2W
R530 1-216-821-11 METAL CHIP 1K 5% 1/10W
R531 1-216-835-11 METAL CHIP 15K 5% 1/10W
R532 1-216-845-11 METAL CHIP 100K 5% 1/10W
R533 1-216-845-11 METAL CHIP 100K 5% 1/10W
R534 1-216-835-11 METAL CHIP 15K 5% 1/10W
R535 1-216-821-11 METAL CHIP 1K 5% 1/10W
0R536 1-220-755-11 METAL 0.22 10% 2W
0R537 1-220-755-11 METAL 0.22 10% 2W
R542 1-249-625-31 CARBON 10 5% 1/2W
R543 1-249-625-31 CARBON 10 5% 1/2W
R545 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R546 1-216-841-11 METAL CHIP 47K 5% 1/10W
R547 1-216-843-11 METAL CHIP 68K 5% 1/10W
R548 1-216-845-11 METAL CHIP 100K 5% 1/10W
R549 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R550 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R559 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R560 1-216-833-11 METAL CHIP 10K 5% 1/10W
R561 1-249-625-31 CARBON 10 5% 1/2W
(AEP, UK, EA, RU)
R562 1-249-625-31 CARBON 10 5% 1/2W
(AEP, UK, EA, RU)
R563 1-249-625-31 CARBON 10 5% 1/2W
(AEP, UK, EA, RU)
R564 1-216-841-11 METAL CHIP 47K 5% 1/10W
R565 1-216-841-11 METAL CHIP 47K 5% 1/10W
R566 1-249-625-31 CARBON 10 5% 1/2W
(AEP, UK, EA, RU)
R568 1-216-843-11 METAL CHIP 68K 5% 1/10W
R569 1-216-841-11 METAL CHIP 47K 5% 1/10W
R850 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R851 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R854 1-216-833-11 METAL CHIP 10K 5% 1/10W
R855 1-215-891-11 METAL OXIDE 680 5% 2W
R857 1-216-833-11 METAL CHIP 10K 5% 1/10W
R858 1-215-891-11 METAL OXIDE 680 5% 2W
R860 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R862 1-216-837-11 METAL CHIP 22K 5% 1/10W
R863 1-216-837-11 METAL CHIP 22K 5% 1/10W
R864 1-216-849-11 METAL CHIP 220K 5% 1/10W
R865 1-216-809-11 METAL CHIP 100 5% 1/10W
R866 1-216-841-11 METAL CHIP 47K 5% 1/10W
R867 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R870 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R871 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R872 1-216-845-11 METAL CHIP 100K 5% 1/10W
R875 1-216-813-11 METAL CHIP 220 5% 1/10W
R876 1-216-813-11 METAL CHIP 220 5% 1/10W
R890 1-216-833-11 METAL CHIP 10K 5% 1/10W
R895 1-216-864-11 SHORT CHIP 0
< RELAY >
RY501 1-755-373-11 RELAY
< THERMISTOR >
TH531 1-807-796-11 THERMISTOR
< TERMINAL >
TM501 1-537-114-21 TERMINAL BOARD (SPEAKER)
******************************************************
HP BOARD
********
< CAPACITOR >
C1093 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V
C1094 1-162-971-11 CERAMIC CHIP 0.001uF 10% 50V
< CONNECTOR >
CN1062 1-785-330-11 PIN, CONNECTOR (LIGHT ANGLE) 4P
< FERRITE BEAD >
FB1001 1-500-245-11 INDUCTOR, FERRITE BEAD
FB1002 1-500-245-11 INDUCTOR, FERRITE BEAD
FB1003 1-500-245-11 INDUCTOR, FERRITE BEAD
FB1004 1-500-245-11 INDUCTOR, FERRITE BEAD
< JACK >
J1063 1-750-032-11 JACK (DIA. 3.5) (PHONES)
< SHORT >
JR1080 1-216-864-11 SHORT CHIP 0
JR1081 1-216-864-11 SHORT CHIP 0
< RESISTOR >
R1088 1-216-864-11 SHORT CHIP 0
************************************************************
A-1052-024-A MAIN BOARD, COMPLETE (EA)
A-4750-842-A MAIN BOARD, COMPLETE (AEP, UK)
A-4750-905-A MAIN BOARD, COMPLETE (RU)
A-4750-910-A MAIN BOARD, COMPLETE (E3)
A-4750-915-A MAIN BOARD, COMPLETE (E51)
*******************
7-685-646-79 SCREW +BVTP 3X8 TYPE2 IT-3
< CAPACITOR >
C1 1-126-964-11 ELECT 10uF 20% 50V
C2 1-126-964-11 ELECT 10uF 20% 50V
C21 1-126-963-11 ELECT 4.7uF 20% 50V
C22 1-126-963-11 ELECT 4.7uF 20% 50V
C25 1-126-963-11 ELECT 4.7uF 20% 50V
C26 1-126-963-11 ELECT 4.7uF 20% 50V
C35 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C36 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C37 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C38 1-164-156-11 CERAMIC CHIP 0.1uF 25V
FRONT AMP HP
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
http://www.xiaoyu163.com
http://www.xiaoyu163.com
57
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
MAIN
C39 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C40 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C100 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C101 1-126-964-11 ELECT 10uF 20% 50V
C102 1-126-964-11 ELECT 10uF 20% 50V
C103 1-126-964-11 ELECT 10uF 20% 50V
C104 1-126-964-11 ELECT 10uF 20% 50V
C105 1-136-497-81 FILM 0.1uF 5% 50V
C106 1-126-964-11 ELECT 10uF 20% 50V
C107 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C108 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C109 1-126-964-11 ELECT 10uF 20% 50V
C110 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C111 1-164-174-11 CERAMIC CHIP 0.0082uF 10% 25V
C112 1-126-964-11 ELECT 10uF 20% 50V
C115 1-126-964-11 ELECT 10uF 20% 50V
C116 1-126-964-11 ELECT 10uF 20% 50V
C117 1-126-960-11 ELECT 1uF 20% 50V
C118 1-130-483-00 MYLAR 0.01uF 5% 50V
C119 1-126-947-11 ELECT 47uF 20% 35V
C121 1-136-177-00 FILM 1uF 5% 50V
C122 1-126-963-11 ELECT 4.7uF 20% 50V
C123 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C124 1-104-658-91 ELECT 100uF 20% 10V
C125 1-104-658-91 ELECT 100uF 20% 10V
C126 1-104-658-91 ELECT 100uF 20% 10V
C127 1-104-658-91 ELECT 100uF 20% 10V
C131 1-162-919-11 CERAMIC CHIP 22PF 5% 50V
C132 1-130-483-00 MYLAR 0.01uF 5% 50V
C133 1-130-483-00 MYLAR 0.01uF 5% 50V
C134 1-126-964-11 ELECT 10uF 20% 50V
C135 1-126-960-11 ELECT 1uF 20% 50V
C141 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C142 1-126-964-11 ELECT 10uF 20% 50V
C146 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V
C147 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C148 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C150 1-163-077-00 CERAMIC CHIP 0.1uF 50V
C151 1-126-964-11 ELECT 10uF 20% 50V
C152 1-126-964-11 ELECT 10uF 20% 50V
C154 1-126-964-11 ELECT 10uF 20% 50V
C155 1-136-497-81 FILM 0.1uF 5% 50V
C156 1-126-964-11 ELECT 10uF 20% 50V
C157 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C158 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V
C159 1-126-964-11 ELECT 10uF 20% 50V
C160 1-165-176-11 CERAMIC CHIP 0.047uF 10% 16V
C161 1-164-174-11 CERAMIC CHIP 0.0082uF 10% 25V
C162 1-126-964-11 ELECT 10uF 20% 50V
C165 1-126-964-11 ELECT 10uF 20% 50V
C166 1-126-964-11 ELECT 10uF 20% 50V
C167 1-126-960-11 ELECT 1uF 20% 50V
C168 1-130-483-00 MYLAR 0.01uF 5% 50V
C169 1-126-947-11 ELECT 47uF 20% 35V
C173 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C174 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C183 1-126-960-11 ELECT 1uF 20% 50V
C191 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C192 1-126-964-11 ELECT 10uF 20% 50V
C196 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25V
C197 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C198 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C270 1-126-964-11 ELECT 10uF 20% 50V
C271 1-126-964-11 ELECT 10uF 20% 50V
C301 1-162-961-11 CERAMIC CHIP 330PF 10% 50V
C302 1-126-964-11 ELECT 10uF 20% 50V
C303 1-162-961-11 CERAMIC CHIP 330PF 10% 50V
C304 1-126-964-11 ELECT 10uF 20% 50V
C305 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C306 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C307 1-162-961-11 CERAMIC CHIP 330PF 10% 50V
C308 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C311 1-130-481-00 MYLAR 0.0068uF 5% 50V
C312 1-130-483-00 MYLAR 0.01uF 5% 50V
C313 1-126-947-11 ELECT 47uF 20% 35V
C314 1-137-150-11 FILM 0.01uF 5% 100V
C315 1-130-479-00 MYLAR 0.0047uF 5% 50V
C322 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V
C324 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V
C351 1-162-961-11 CERAMIC CHIP 330PF 10% 50V
C352 1-126-964-11 ELECT 10uF 20% 50V
C353 1-162-961-11 CERAMIC CHIP 330PF 10% 50V
C354 1-126-964-11 ELECT 10uF 20% 50V
C355 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C356 1-162-927-11 CERAMIC CHIP 100PF 5% 50V
C357 1-162-961-11 CERAMIC CHIP 330PF 10% 50V
C358 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C370 1-104-658-91 ELECT 100uF 20% 10V
C372 1-104-655-91 ELECT 470uF 20% 6.3V
C373 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C375 1-126-916-11 ELECT 1000uF 20% 6.3V
C379 1-104-655-91 ELECT 470uF 20% 6.3V
C382 1-126-925-91 ELECT 470uF 20% 10V
C383 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C384 1-104-655-91 ELECT 470uF 20% 6.3V
C390 1-126-965-91 ELECT 22uF 20% 50V
C391 1-136-497-81 FILM 0.1uF 5% 50V
C392 1-136-497-81 FILM 0.1uF 5% 50V
C393 1-126-964-11 ELECT 10uF 20% 50V
C410 1-162-918-11 CERAMIC CHIP 18PF 5% 50V
C411 1-162-918-11 CERAMIC CHIP 18PF 5% 50V
C412 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C416 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C417 1-126-916-11 ELECT 1000uF 20% 6.3V
C462 1-104-658-91 ELECT 100uF 20% 10V
C463 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C475 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C476 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V
C497 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C498 1-126-964-11 ELECT 10uF 20% 50V
C499 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C900 1-126-937-11 ELECT 4700uF 20% 16V
C901 1-126-956-91 ELECT 0.1uF 20% 50V
C902 1-104-658-91 ELECT 100uF 20% 10V
C903 1-126-964-11 ELECT 10uF 20% 50V
http://www.xiaoyu163.com
http://www.xiaoyu163.com
58
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
MAIN
C904 1-104-658-91 ELECT 100uF 20% 10V
C905 1-126-956-91 ELECT 0.1uF 20% 50V
C906 1-104-658-91 ELECT 100uF 20% 10V
C919 1-126-964-11 ELECT 10uF 20% 50V
C920 1-126-964-11 ELECT 10uF 20% 50V
C930 1-126-768-11 ELECT 2200uF 20% 16V
C952 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C953 1-164-156-11 CERAMIC CHIP 0.1uF 25V
< CONNECTOR >
CN101 1-691-768-11 PLUG (MICRO CONNECTOR) 6P
CN102 1-766-600-21 CONNECTOR, BOARD TO BOARD 7P
CN103 1-784-038-21 CONNECTOR, BOARD TO BOARD 9P
CN109 1-784-774-11 CONNECTOR, FFC 13P
CN110 1-784-776-11 CONNECTOR, FFC 15P
CN112 1-784-766-11 CONNECTOR, FFC 5P
CN204 1-568-830-11 CONNECTOR, FFC 11P (EXCEPT AEP, UK)
CN204 1-784-776-11 CONNECTOR, FFC 15P (AEP, UK)
*CN301 1-564-719-11 PIN, CONNECTOR (SMALL TYPE) 3P
*CN302 1-564-724-11 PIN, CONNECTOR (SMALL TYPE) 8P
CN303 1-784-774-11 CONNECTOR, FFC 13P
*CN304 1-568-449-11 HOUSING, CONNECTOR (PC BOARD) 3P
CN371 1-779-295-11 CONNECTOR, FFC (LIF (NON-ZIF)) 27P
CN372 1-779-289-11 CONNECTOR, FFC (LIF (NON-ZIF)) 21P
CN401 1-785-316-11 PIN, CONNECTOR (STRAIGHT) 4P
< DIODE >
D181 8-719-988-61 DIODE 1SS355TE-17
D182 8-719-988-61 DIODE 1SS355TE-17
D183 8-719-988-61 DIODE 1SS355TE-17
D321 8-719-988-61 DIODE 1SS355TE-17
D322 8-719-988-61 DIODE 1SS355TE-17
D371 6-500-522-31 DIODE 10EDB40-TB5
D372 6-500-522-31 DIODE 10EDB40-TB5
D373 6-500-522-31 DIODE 10EDB40-TB5
D391 8-719-988-61 DIODE 1SS355TE-17
D392 8-719-988-61 DIODE 1SS355TE-17
D393 8-719-988-61 DIODE 1SS355TE-17
D394 8-719-988-61 DIODE 1SS355TE-17
D395 8-719-988-61 DIODE 1SS355TE-17
D396 8-719-988-61 DIODE 1SS355TE-17
D397 8-719-988-61 DIODE 1SS355TE-17
D903 6-500-522-31 DIODE 10EDB40-TB5
D904 8-719-988-61 DIODE 1SS355TE-17
D905 8-719-083-58 DIODE UDZSTE-173.9B
< EARTH TERMINAL >
EP901 1-537-738-21 TERMINAL, GROUND
< FERRITE BEAD >
FB30 1-469-125-21 FERRITE, EMI (SMD) (1608)
FB34 1-469-125-21 FERRITE, EMI (SMD) (1608)
FB50 1-469-125-21 FERRITE, EMI (SMD) (1608)
FB54 1-469-125-21 FERRITE, EMI (SMD) (1608)
FB80 1-469-125-21 FERRITE, EMI (SMD) (1608)
FB84 1-469-125-21 FERRITE, EMI (SMD) (1608)
FB371 1-216-864-11 SHORT CHIP 0
FB372 1-216-864-11 SHORT CHIP 0
FB373 1-216-864-11 SHORT CHIP 0
FB374 1-216-864-11 SHORT CHIP 0
< IC >
IC101 6-705-667-01 IC M61537FP-RF0G
IC301 8-749-019-25 IC TOTX141 (DIGITAL OUT)
IC391 8-759-532-64 IC M62703SL-TP
IC401 6-803-925-01 IC M30622MGN-B27FPU0
IC901 8-759-701-59 IC NJM78M09FA
IC902 8-759-701-59 IC NJM78M09FA
IC903 6-702-771-01 IC TA78033LS
IC951 6-703-679-11 IC PT8300R-TP
< JACK >
J102 1-778-940-11 JACK 2P (VIDEO (MD))
< SHORT >
JR1 1-216-864-11 SHORT CHIP 0
JR7 1-216-864-11 SHORT CHIP 0
JR101 1-216-864-11 SHORT CHIP 0
JR102 1-216-864-11 SHORT CHIP 0
JR103 1-216-296-11 SHORT CHIP 0
JR104 1-216-296-11 SHORT CHIP 0
JR105 1-216-296-11 SHORT CHIP 0
JR106 1-216-864-11 SHORT CHIP 0
JR107 1-216-296-11 SHORT CHIP 0
JR108 1-216-296-11 SHORT CHIP 0
JR109 1-216-296-11 SHORT CHIP 0
JR110 1-216-864-11 SHORT CHIP 0
JR111 1-216-296-11 SHORT CHIP 0
JR112 1-216-864-11 SHORT CHIP 0
JR113 1-216-296-11 SHORT CHIP 0
JR114 1-216-864-11 SHORT CHIP 0
JR115 1-216-296-11 SHORT CHIP 0
JR116 1-216-864-11 SHORT CHIP 0
JR117 1-216-296-11 SHORT CHIP 0
JR118 1-216-864-11 SHORT CHIP 0
JR119 1-216-864-11 SHORT CHIP 0
JR120 1-216-864-11 SHORT CHIP 0
JR121 1-216-864-11 SHORT CHIP 0
JR122 1-216-296-11 SHORT CHIP 0
JR123 1-216-864-11 SHORT CHIP 0
JR124 1-216-296-11 SHORT CHIP 0
JR125 1-216-864-11 SHORT CHIP 0
JR126 1-216-296-11 SHORT CHIP 0
JR127 1-216-296-11 SHORT CHIP 0
JR128 1-216-864-11 SHORT CHIP 0
JR203 1-216-864-11 SHORT CHIP 0
JR204 1-216-296-11 SHORT CHIP 0
JR205 1-216-296-11 SHORT CHIP 0
JR206 1-216-296-11 SHORT CHIP 0
JR261 1-216-296-11 SHORT CHIP 0
JR418 1-216-864-11 SHORT CHIP 0 (EXCEPT AEP, UK)
JR449 1-216-864-11 SHORT CHIP 0 (EXCEPT AEP, UK)
< COIL >
L301 1-410-780-11 INDUCTOR 27mH
http://www.xiaoyu163.com
http://www.xiaoyu163.com
59
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
MAIN
L311 1-414-189-31 INDUCTOR 100uH
L351 1-410-780-11 INDUCTOR 27mH
L370 1-412-064-11 INDUCTOR 100uH
L951 1-216-296-11 SHORT CHIP 0
< TRANSISTOR >
Q1 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q2 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q21 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q22 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q25 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q26 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q29 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q30 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q31 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q32 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q33 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q34 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q103 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q104 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q140 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q153 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q154 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q270 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q271 6-550-889-01 TRANSISTOR 2SC5938-T112-1B
Q301 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q302 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q303 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q311 8-729-216-22 TRANSISTOR 2SA1162-G
Q312 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q313 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q314 8-729-027-23 TRANSISTOR DTA114EKA-T146
Q315 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q316 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q317 8-729-040-20 TRANSISTOR RT1P137L-TP
Q318 8-729-142-46 TRANSISTOR 2SC2001-LK
Q321 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q322 8-729-140-04 TRANSISTOR 2SB1116A-L
Q323 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q324 8-729-140-04 TRANSISTOR 2SB1116A-L
Q326 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q327 8-729-140-04 TRANSISTOR 2SB1116A-L
Q341 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q342 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q343 8-729-027-43 TRANSISTOR DTC114EKA-T146
Q351 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q352 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q353 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16
Q391 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q906 8-729-120-28 TRANSISTOR 2SC1623-L5L6
< RESISTOR >
R1 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R2 1-216-833-11 METAL CHIP 10K 5% 1/10W
R3 1-216-821-11 METAL CHIP 1K 5% 1/10W
R4 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R5 1-216-833-11 METAL CHIP 10K 5% 1/10W
R6 1-216-821-11 METAL CHIP 1K 5% 1/10W
R21 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R22 1-216-837-11 METAL CHIP 22K 5% 1/10W
R23 1-216-845-11 METAL CHIP 100K 5% 1/10W
R27 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R28 1-216-837-11 METAL CHIP 22K 5% 1/10W
R29 1-216-845-11 METAL CHIP 100K 5% 1/10W
R33 1-216-845-11 METAL CHIP 100K 5% 1/10W
R34 1-216-837-11 METAL CHIP 22K 5% 1/10W
R35 1-216-845-11 METAL CHIP 100K 5% 1/10W
R36 1-216-837-11 METAL CHIP 22K 5% 1/10W
R37 1-216-845-11 METAL CHIP 100K 5% 1/10W
R38 1-216-837-11 METAL CHIP 22K 5% 1/10W
R39 1-216-864-11 SHORT CHIP 0
R79 1-216-864-11 SHORT CHIP 0
R89 1-216-864-11 SHORT CHIP 0
R101 1-216-835-11 METAL CHIP 15K 5% 1/10W
R102 1-216-841-11 METAL CHIP 47K 5% 1/10W
R103 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R104 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R105 1-216-833-11 METAL CHIP 10K 5% 1/10W
R109 1-216-841-11 METAL CHIP 47K 5% 1/10W
R110 1-216-821-11 METAL CHIP 1K 5% 1/10W
R111 1-216-821-11 METAL CHIP 1K 5% 1/10W
R112 1-216-834-11 METAL CHIP 12K 5% 1/10W
R113 1-216-851-11 METAL CHIP 330K 5% 1/10W
R114 1-216-812-11 METAL CHIP 180 5% 1/10W
R118 1-216-809-11 METAL CHIP 100 5% 1/10W
R119 1-216-833-11 METAL CHIP 10K 5% 1/10W
R121 1-216-861-11 METAL CHIP 2.2M 5% 1/10W
R122 1-216-835-11 METAL CHIP 15K 5% 1/10W
R123 1-216-857-11 METAL CHIP 1M 5% 1/10W
R126 1-216-813-11 METAL CHIP 220 5% 1/10W
R127 1-216-813-11 METAL CHIP 220 5% 1/10W
R129 1-216-835-11 METAL CHIP 15K 5% 1/10W
R130 1-216-809-11 METAL CHIP 100 5% 1/10W
R131 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R132 1-216-838-11 METAL CHIP 27K 5% 1/10W
R133 1-216-833-11 METAL CHIP 10K 5% 1/10W
R141 1-216-821-11 METAL CHIP 1K 5% 1/10W
R142 1-216-845-11 METAL CHIP 100K 5% 1/10W
R151 1-216-835-11 METAL CHIP 15K 5% 1/10W
R152 1-216-841-11 METAL CHIP 47K 5% 1/10W
R153 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R154 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R155 1-216-833-11 METAL CHIP 10K 5% 1/10W
R159 1-216-841-11 METAL CHIP 47K 5% 1/10W
R160 1-216-821-11 METAL CHIP 1K 5% 1/10W
R161 1-216-821-11 METAL CHIP 1K 5% 1/10W
R162 1-216-834-11 METAL CHIP 12K 5% 1/10W
R163 1-216-851-11 METAL CHIP 330K 5% 1/10W
R164 1-216-812-11 METAL CHIP 180 5% 1/10W
R168 1-216-809-11 METAL CHIP 100 5% 1/10W
R169 1-216-833-11 METAL CHIP 10K 5% 1/10W
R180 1-216-809-11 METAL CHIP 100 5% 1/10W
R186 1-216-864-11 SHORT CHIP 0
R187 1-216-853-11 METAL CHIP 470K 5% 1/10W
R188 1-216-815-11 METAL CHIP 330 5% 1/10W
R189 1-216-841-11 METAL CHIP 47K 5% 1/10W
http://www.xiaoyu163.com
http://www.xiaoyu163.com
60
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
MAIN
R191 1-216-821-11 METAL CHIP 1K 5% 1/10W
R192 1-216-845-11 METAL CHIP 100K 5% 1/10W
R241 1-216-864-11 SHORT CHIP 0
R243 1-216-864-11 SHORT CHIP 0
R246 1-216-833-11 METAL CHIP 10K 5% 1/10W
R247 1-216-833-11 METAL CHIP 10K 5% 1/10W
R270 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R272 1-216-821-11 METAL CHIP 1K 5% 1/10W
R273 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R275 1-216-821-11 METAL CHIP 1K 5% 1/10W
R294 1-216-821-11 METAL CHIP 1K 5% 1/10W
R296 1-216-833-11 METAL CHIP 10K 5% 1/10W
R298 1-216-821-11 METAL CHIP 1K 5% 1/10W
R299 1-216-833-11 METAL CHIP 10K 5% 1/10W
R301 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R302 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R303 1-216-821-11 METAL CHIP 1K 5% 1/10W
R304 1-216-835-11 METAL CHIP 15K 5% 1/10W
R305 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R306 1-216-832-11 METAL CHIP 8.2K 5% 1/10W
R307 1-216-833-11 METAL CHIP 10K 5% 1/10W
R309 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R311 1-216-833-11 METAL CHIP 10K 5% 1/10W
R312 1-216-833-11 METAL CHIP 10K 5% 1/10W
R313 1-216-833-11 METAL CHIP 10K 5% 1/10W
R314 1-216-841-11 METAL CHIP 47K 5% 1/10W
R315 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R316 1-216-797-11 METAL CHIP 10 5% 1/10W
R317 1-216-833-11 METAL CHIP 10K 5% 1/10W
R318 1-216-805-11 METAL CHIP 47 5% 1/10W
R319 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R320 1-216-803-11 METAL CHIP 33 5% 1/10W
R321 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R322 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R323 1-216-821-11 METAL CHIP 1K 5% 1/10W
R324 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R325 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R326 1-216-821-11 METAL CHIP 1K 5% 1/10W
R327 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R328 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R329 1-216-841-11 METAL CHIP 47K 5% 1/10W
R330 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R331 1-216-841-11 METAL CHIP 47K 5% 1/10W
R332 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R333 1-216-841-11 METAL CHIP 47K 5% 1/10W
R334 1-216-841-11 METAL CHIP 47K 5% 1/10W
R335 1-216-841-11 METAL CHIP 47K 5% 1/10W
R336 1-216-841-11 METAL CHIP 47K 5% 1/10W
R337 1-216-837-11 METAL CHIP 22K 5% 1/10W
R338 1-216-833-11 METAL CHIP 10K 5% 1/10W
R339 1-216-841-11 METAL CHIP 47K 5% 1/10W
R340 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R341 1-216-833-11 METAL CHIP 10K 5% 1/10W
R342 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R343 1-216-837-11 METAL CHIP 22K 5% 1/10W
R344 1-216-833-11 METAL CHIP 10K 5% 1/10W
R345 1-216-833-11 METAL CHIP 10K 5% 1/10W
R347 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R351 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R352 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R353 1-216-821-11 METAL CHIP 1K 5% 1/10W
R354 1-216-835-11 METAL CHIP 15K 5% 1/10W
R355 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R356 1-216-832-11 METAL CHIP 8.2K 5% 1/10W
R357 1-216-833-11 METAL CHIP 10K 5% 1/10W
R359 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R377 1-216-833-11 METAL CHIP 10K 5% 1/10W
R378 1-216-833-11 METAL CHIP 10K 5% 1/10W
R379 1-216-833-11 METAL CHIP 10K 5% 1/10W
R380 1-216-833-11 METAL CHIP 10K 5% 1/10W
R381 1-216-833-11 METAL CHIP 10K 5% 1/10W
R382 1-216-833-11 METAL CHIP 10K 5% 1/10W
R383 1-216-833-11 METAL CHIP 10K 5% 1/10W
R384 1-216-833-11 METAL CHIP 10K 5% 1/10W
R385 1-216-833-11 METAL CHIP 10K 5% 1/10W
R386 1-216-833-11 METAL CHIP 10K 5% 1/10W
R387 1-216-833-11 METAL CHIP 10K 5% 1/10W
R388 1-216-833-11 METAL CHIP 10K 5% 1/10W
R391 1-216-833-11 METAL CHIP 10K 5% 1/10W
R392 1-216-837-11 METAL CHIP 22K 5% 1/10W
R393 1-216-837-11 METAL CHIP 22K 5% 1/10W
R394 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R395 1-216-813-11 METAL CHIP 220 5% 1/10W
R396 1-216-833-11 METAL CHIP 10K 5% 1/10W
R401 1-216-809-11 METAL CHIP 100 5% 1/10W
R402 1-216-809-11 METAL CHIP 100 5% 1/10W
R403 1-216-809-11 METAL CHIP 100 5% 1/10W
R404 1-216-809-11 METAL CHIP 100 5% 1/10W
R405 1-216-809-11 METAL CHIP 100 5% 1/10W
R406 1-216-809-11 METAL CHIP 100 5% 1/10W
R407 1-216-809-11 METAL CHIP 100 5% 1/10W
R408 1-216-833-11 METAL CHIP 10K 5% 1/10W
R409 1-216-833-11 METAL CHIP 10K 5% 1/10W
R410 1-216-833-11 METAL CHIP 10K 5% 1/10W
R411 1-216-851-11 METAL CHIP 330K 5% 1/10W
R412 1-216-833-11 METAL CHIP 10K 5% 1/10W
R413 1-216-864-11 SHORT CHIP 0
R414 1-216-833-11 METAL CHIP 10K 5% 1/10W
R415 1-216-833-11 METAL CHIP 10K 5% 1/10W
R416 1-216-833-11 METAL CHIP 10K 5% 1/10W
R417 1-216-833-11 METAL CHIP 10K 5% 1/10W
R418 1-216-809-11 METAL CHIP 100 5% 1/10W
(AEP, UK)
R419 1-216-809-11 METAL CHIP 100 5% 1/10W
R420 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R421 1-216-809-11 METAL CHIP 100 5% 1/10W
R422 1-216-809-11 METAL CHIP 100 5% 1/10W
R423 1-216-809-11 METAL CHIP 100 5% 1/10W
R424 1-216-809-11 METAL CHIP 100 5% 1/10W
R425 1-216-809-11 METAL CHIP 100 5% 1/10W
R426 1-216-809-11 METAL CHIP 100 5% 1/10W
R429 1-216-809-11 METAL CHIP 100 5% 1/10W
R430 1-216-809-11 METAL CHIP 100 5% 1/10W
R431 1-216-809-11 METAL CHIP 100 5% 1/10W
R432 1-216-809-11 METAL CHIP 100 5% 1/10W
http://www.xiaoyu163.com
http://www.xiaoyu163.com
61
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
R433 1-216-809-11 METAL CHIP 100 5% 1/10W
R434 1-216-809-11 METAL CHIP 100 5% 1/10W
R435 1-216-809-11 METAL CHIP 100 5% 1/10W
R436 1-216-809-11 METAL CHIP 100 5% 1/10W
R437 1-216-809-11 METAL CHIP 100 5% 1/10W
R438 1-216-809-11 METAL CHIP 100 5% 1/10W
R439 1-216-809-11 METAL CHIP 100 5% 1/10W
R440 1-216-809-11 METAL CHIP 100 5% 1/10W
R441 1-216-809-11 METAL CHIP 100 5% 1/10W
R442 1-216-809-11 METAL CHIP 100 5% 1/10W
R443 1-216-809-11 METAL CHIP 100 5% 1/10W
R444 1-216-809-11 METAL CHIP 100 5% 1/10W
R445 1-216-809-11 METAL CHIP 100 5% 1/10W
R446 1-216-809-11 METAL CHIP 100 5% 1/10W
R447 1-216-809-11 METAL CHIP 100 5% 1/10W
R448 1-216-809-11 METAL CHIP 100 5% 1/10W
R449 1-216-809-11 METAL CHIP 100 5% 1/10W
(AEP, UK)
R450 1-216-809-11 METAL CHIP 100 5% 1/10W
R451 1-216-809-11 METAL CHIP 100 5% 1/10W
R452 1-216-809-11 METAL CHIP 100 5% 1/10W
R453 1-216-809-11 METAL CHIP 100 5% 1/10W
R454 1-216-809-11 METAL CHIP 100 5% 1/10W
R455 1-216-809-11 METAL CHIP 100 5% 1/10W
R465 1-216-809-11 METAL CHIP 100 5% 1/10W
R466 1-216-833-11 METAL CHIP 10K 5% 1/10W
R467 1-216-833-11 METAL CHIP 10K 5% 1/10W
R468 1-216-833-11 METAL CHIP 10K 5% 1/10W
R469 1-216-833-11 METAL CHIP 10K 5% 1/10W
R470 1-216-809-11 METAL CHIP 100 5% 1/10W
R471 1-216-809-11 METAL CHIP 100 5% 1/10W
R472 1-216-809-11 METAL CHIP 100 5% 1/10W
R473 1-216-809-11 METAL CHIP 100 5% 1/10W
R474 1-216-809-11 METAL CHIP 100 5% 1/10W
R476 1-216-809-11 METAL CHIP 100 5% 1/10W
R477 1-216-809-11 METAL CHIP 100 5% 1/10W
R478 1-216-809-11 METAL CHIP 100 5% 1/10W
R479 1-216-809-11 METAL CHIP 100 5% 1/10W
R482 1-216-809-11 METAL CHIP 100 5% 1/10W
R483 1-216-809-11 METAL CHIP 100 5% 1/10W
R484 1-216-809-11 METAL CHIP 100 5% 1/10W
R485 1-216-809-11 METAL CHIP 100 5% 1/10W
R486 1-216-809-11 METAL CHIP 100 5% 1/10W
R489 1-216-809-11 METAL CHIP 100 5% 1/10W
R490 1-216-809-11 METAL CHIP 100 5% 1/10W
R492 1-216-811-11 METAL CHIP 150 5% 1/10W
(RU)
R492 1-216-821-11 METAL CHIP 1K 5% 1/10W
(E51)
R492 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
(E3, EA)
R492 1-216-864-11 SHORT CHIP 0 (AEP, UK)
R493 1-216-809-11 METAL CHIP 100 5% 1/10W
R494 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R495 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R496 1-216-821-11 METAL CHIP 1K 5% 1/10W
(EA)
R496 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
(EXCEPT E3, EA)
R496 1-216-864-11 SHORT CHIP 0 (E3)
R497 1-216-833-11 METAL CHIP 10K 5% 1/10W
R498 1-216-797-11 METAL CHIP 10 5% 1/10W
R499 1-216-797-11 METAL CHIP 10 5% 1/10W
R914 1-216-821-11 METAL CHIP 1K 5% 1/10W
R915 1-216-821-11 METAL CHIP 1K 5% 1/10W
R952 1-216-809-11 METAL CHIP 100 5% 1/10W
R955 1-216-809-11 METAL CHIP 100 5% 1/10W
R956 1-216-809-11 METAL CHIP 100 5% 1/10W
R957 1-216-809-11 METAL CHIP 100 5% 1/10W
R958 1-216-809-11 METAL CHIP 100 5% 1/10W
R959 1-216-809-11 METAL CHIP 100 5% 1/10W
R969 1-216-833-11 METAL CHIP 10K 5% 1/10W
R970 1-216-833-11 METAL CHIP 10K 5% 1/10W
< TRANSFORMER >
T301 1-433-372-11 TRANSFORMER, BIAS OSCILLATION
< VIBRATOR >
X401 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
X402 1-795-482-11 VIBRATOR, CERAMIC (16MHz)
************************************************************
MOTOR BOARD
***********
< SWITCH >
S761 1-786-704-11 SWITCH, LEVER (SUB TRAY OUT)
************************************************************
A-4750-849-A PANEL BOARD, COMPLETE
********************
< CAPACITOR >
C1006 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C1021 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V
C1025 1-162-960-11 CERAMIC CHIP 220PF 10% 50V
C1026 1-126-964-11 ELECT 10uF 20% 50V
C1028 1-126-964-11 ELECT 10uF 20% 50V
C1029 1-131-992-91 CERAMIC CHIP 100000PF 35V
C1048 1-131-992-91 CERAMIC CHIP 100000PF 35V
C1050 1-162-974-11 CERAMIC CHIP 0.01uF 50V
C1051 1-126-969-11 ELECT 220uF 20% 50V
C1052 1-162-974-11 CERAMIC CHIP 0.01uF 50V
C1053 1-126-965-91 ELECT 22uF 20% 50V
C1054 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V
< CONNECTOR >
CN1021 1-784-774-11 CONNECTOR, FFC 13P
< DIODE >
D1021 8-719-058-03 DIODE SEL5423E-TP15 (b B)
D1022 8-719-059-18 DIODE RD6.2FM-T1
D1023 8-719-988-61 DIODE 1SS355TE-17
D1024 8-719-988-61 DIODE 1SS355TE-17
D1025 8-719-988-61 DIODE 1SS355TE-17
MOTOR PANELMAIN
http://www.xiaoyu163.com
http://www.xiaoyu163.com
62
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
D1026 8-719-988-61 DIODE 1SS355TE-17
< FILTER >
FL1020 1-518-979-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC1020 6-705-745-01 IC M66005-0131AHPRB0T
< COIL >
L1021 1-410-671-31 INDUCTOR 47uH
< TRANSISTOR >
Q1021 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q1022 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q1023 8-729-120-28 TRANSISTOR 2SC1623-L5L6
Q1024 6-550-065-01 TRANSISTOR CPH5504-TL-E
Q1026 8-729-027-43 TRANSISTOR DTC114EKA-T146
< RESISTOR >
R1020 1-216-809-11 METAL CHIP 100 5% 1/10W
R1021 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1022 1-216-809-11 METAL CHIP 100 5% 1/10W
R1023 1-216-809-11 METAL CHIP 100 5% 1/10W
R1024 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1025 1-216-833-11 METAL CHIP 10K 5% 1/10W
R1026 1-216-813-11 METAL CHIP 220 5% 1/10W
R1027 1-216-815-11 METAL CHIP 330 5% 1/10W
R1028 1-216-817-11 METAL CHIP 470 5% 1/10W
R1029 1-216-819-11 METAL CHIP 680 5% 1/10W
R1030 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1031 1-216-823-11 METAL CHIP 1.5K 5% 1/10W
R1032 1-216-864-11 SHORT CHIP 0
R1033 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R1034 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R1035 1-216-833-11 METAL CHIP 10K 5% 1/10W
R1036 1-216-823-11 METAL CHIP 1.5K 5% 1/10W
R1037 1-216-825-11 METAL CHIP 2.2K 5% 1/10W
R1038 1-216-829-11 METAL CHIP 4.7K 5% 1/10W
R1039 1-216-833-11 METAL CHIP 10K 5% 1/10W
R1040 1-216-839-11 METAL CHIP 33K 5% 1/10W
R1041 1-216-845-11 METAL CHIP 100K 5% 1/10W
R1042 1-216-845-11 METAL CHIP 100K 5% 1/10W
R1043 1-216-845-11 METAL CHIP 100K 5% 1/10W
R1045 1-216-827-11 METAL CHIP 3.3K 5% 1/10W
R1046 1-216-833-11 METAL CHIP 10K 5% 1/10W
R1051 1-216-809-11 METAL CHIP 100 5% 1/10W
R1052 1-216-809-11 METAL CHIP 100 5% 1/10W
R1100 1-216-833-11 METAL CHIP 10K 5% 1/10W
R1101 1-216-833-11 METAL CHIP 10K 5% 1/10W
R1102 1-216-833-11 METAL CHIP 10K 5% 1/10W
< SWITCH >
S1021 1-762-875-21 SWITCH, KEYBOARD (CD)
S1022 1-762-875-21 SWITCH, KEYBOARD (TUNER/BAND)
S1023 1-762-875-21 SWITCH, KEYBOARD (TAPE A/B)
S1024 1-762-875-21 SWITCH, KEYBOARD (VIDEO(MD))
S1025 1-762-875-21 SWITCH, KEYBOARD (DIMMER)
S1026 1-762-875-21 SWITCH, KEYBOARD (CD SYNC)
S1027 1-762-875-21 SWITCH, KEYBOARD (z /START)
S1028 1-762-875-21 SWITCH, KEYBOARD (DISPLAY)
S1029 1-762-875-21 SWITCH, KEYBOARD (b B)
S1030 1-762-875-21 SWITCH, KEYBOARD (CD Z)
S1031 1-762-875-21 SWITCH, KEYBOARD (X)
S1032 1-762-875-21 SWITCH, KEYBOARD (M> TUNING +)
S1033 1-762-875-21 SWITCH, KEYBOARD (.m TUNING -)
S1034 1-762-875-21 SWITCH, KEYBOARD (ALBUM +)
S1035 1-762-875-21 SWITCH, KEYBOARD (ALBUM -)
S1036 1-762-875-21 SWITCH, KEYBOARD (x)
< TRANSFORMER >
T801 1-443-389-11 TRANSFORMER, DC-DC CONVERTER
******************************************************
A-4750-232-A RELAY BOARD, COMLETE
*******************
< CAPACITOR >
C701 1-126-786-11 ELECT 47uF 20% 16V
C702 1-126-791-11 ELECT 10uF 20% 35V
C761 1-162-306-11 CERAMIC 0.01uF 20% 16V
C762 1-162-306-11 CERAMIC 0.01uF 20% 16V
< CONNECTOR >
CN701 1-779-558-21 CONNECTOR, FFC (LIF (NON-ZIF)) 21P
< DIODE >
D701 8-719-921-40 DIODE MTZJ-4.7C
D711 8-719-982-10 DIODE MTZJ-4.3A
< IC >
IC701 8-759-598-69 IC BA6956AN
IC711 8-759-598-69 IC BA6956AN
< TRANSISTOR >
Q751 8-729-119-78 TRANSISTOR 2SC2785-HFE
< RESISTOR >
R701 1-249-415-11 CARBON 680 5% 1/4W
R702 1-247-807-31 CARBON 100 5% 1/4W
R711 1-249-415-11 CARBON 680 5% 1/4W
R712 1-247-807-31 CARBON 100 5% 1/4W
R751 1-247-806-11 CARBON 91 5% 1/4W
R752 1-249-429-11 CARBON 10K 5% 1/4W
R753 1-249-429-11 CARBON 10K 5% 1/4W
R754 1-249-430-11 CARBON 12K 5% 1/4W
R755 1-249-429-11 CARBON 10K 5% 1/4W
******************************************************
PANEL RELAY
http://www.xiaoyu163.com
http://www.xiaoyu163.com
63
HCD-CP555/NXM1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
SENSOR BOARD
************
< IC >
IC751 8-759-989-76 IC RPR-359F
******************************************************
1-861-241-12 SW (1) BOARD
***********
< SWITCH >
S721 1-786-084-11 SWITCH, DETECTION (MAIN TRAY IN/OUT)
******************************************************
1-861-242-12 SW (2) BOARD
************
< SWITCH >
S731 1-786-382-11 SWITCH, PUSH (1 KEY) (SUB TRAY IN)
******************************************************
A-4750-851-A VOL BOARD, COMPLETE
******************
< CAPACITOR >
C1007 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C1008 1-164-156-11 CERAMIC CHIP 0.1uF 25V
C1013 1-126-947-11 ELECT 47uF 20% 35V
< CONNECTOR >
CN1050 1-784-776-11 CONNECTOR, FFC 15P
CN1051 1-784-766-11 CONNECTOR, FFC 5P
< DIODE >
D1050 8-719-071-44 DIODE SELS5223C-TP15 (^/1)
D1051 8-719-988-61 DIODE 1SS355TE-17
< IC >
IC1050 6-600-349-31 IC NJL24H400A
< TRANSISTOR >
Q1041 8-729-027-43 TRANSISTOR DTC114EKA-T146
< RESISTOR >
R1048 1-216-864-11 SHORT CHIP 0
R1049 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1050 1-216-823-11 METAL CHIP 1.5K 5% 1/10W
R1059 1-216-805-11 METAL CHIP 47 5% 1/10W
R1090 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1091 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1092 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1093 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1094 1-216-821-11 METAL CHIP 1K 5% 1/10W
R1095 1-216-821-11 METAL CHIP 1K 5% 1/10W
< SWITCH >
S1042 1-762-875-21 SWITCH, KEYBOARD (^/1)
S1043 1-762-875-21 SWITCH, KEYBOARD (DSGX)
S1050 1-786-418-11 SWITCH, ROTARY (ENCODER) (BASS)
S1051 1-786-418-11 SWITCH, ROTARY (ENCODER) (TREBLE)
S1052 1-418-725-51 ENCODER, ROTARY (12 TYPE) (VOLUME)
******************************************************
MISCELLANEOUS
*************
31-769-984-11 WIRE (FLAT TYPE) (13 CORE)
41-765-332-11 WIRE (FLAT TYPE) (15 CORE)
51-769-869-11 WIRE (FLAT TYPE) (5 CORE)
61-769-939-11 WIRE (FLAT TYPE) (11 CORE) (EXCEPT AEP, UK)
61-773-003-11 WIRE (FLAT TYPE) (15 CORE) (AEP, UK)
11 1-693-603-31 TUNER (FM/AM) (E3, E51, EA)
11 1-693-604-11 TUNER (FM/AM) (AEP, UK)
11 1-693-654-11 TUNER (FM/AM) (NXM1)
59 1-796-902-11 DECK, MECHANISM (W)
0102 1-468-812-11 REGULATOR, SWITCHING (AEP, UK, RU)
0102 1-468-824-11 REGULATOR, SWITCHING (E3, E51, EA)
0103 1-775-786-21 CORD, POWER (UK, EA)
0103 1-777-071-53 CORD, POWER (AEP, E51, RU)
0103 1-827-226-11 CORD, POWER (E3)
162 1-471-035-11 MAGNET ASSY
256 1-827-992-11 WIRE (FLAT TYPE) (16 CORE)
0259 8-820-244-01 OPTICAL PICK-UP (KSM-215DCP/C2NP)
M761 A-4713-174-A MOTOR (81) ASSY (LD/ST MOTOR)
M762 A-4713-174-A MOTOR (81) ASSY (BU U/D MOTOR)
M961 1-787-099-11 FAN, DC
S771 1-478-552-11 ENCODER, ROTARY (ST U/D)
SENSOR SW (1) SW (2) VOL
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
Ver. 1.1
http://www.xiaoyu163.com
http://www.xiaoyu163.com
HCD-CP555/NXM1
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver. Date Description of Revision
1.0 2004.04 New
1.1 2005.05 Part No. change of the Ref. No. 3. (SPM-05029)
Illustration correction of the Ref. No. 53. (SPM-05031)
Part No. change of the Ref. No. 52. (SPM-05032)
http://www.xiaoyu163.com
http://www.xiaoyu163.com

Navigation menu