Thule Roof Rack Fit Information 460R Installation Instructions

User Manual: 460R

Open the PDF directly: View PDF .
Page Count: 4

Download
Open PDF In Browser	View PDF

460R RAPID PODIUM FIXPOINT FOOT PACK
PARTS INCLUDED

A

B

part

A

C

D

E

description

F

part number

qty.

460R Podium rapid foot

7520873001

4

B

460R Podium rapid foot cover

8522382001

4

C

endcap

753-2420

4

D

hex bolt M6 x 16

919061631

8

E

hex key M5

853-0930

1

lock plug

853-6395

4

F

PARTS NOT INCLUDED
THULE ONE KEY SYSTEM

1

a. Slide feet onto bar.

FIT KIT

LOAD BARS

Complete your Load Carrier with the recommended Fit Kit and Load Bar
for your vehicle.

INSTALLATION

b. Install rubber strip.

c. Install end cap.

2

FOOT OPERATION

• Check Fit Kit for specific installation instructions for your vehicle. Your unique Fit Kit will install to the 460R foot
with two M6 x 16mm hex bolts (included with foot pack). Attach Fit Kit to vehicle and center load bar on the
vehicle. Tighten the Fit Kit to the foot. This will secure the bar to the foot.

NOTE:
foot

The best way to make sure your bars are centered is to measure
how much bar sticks out from the outside of the foot (X) and then
to adjust the bar until those measurements are equal.

load bar

3

INSTALLING LOCK COVER PLUG

a. Insert lock cover plug into foot cover and move
to the "locked" position. This will keep the foot
cover secured to the foot.

NOTE:

Lock cover bump must face downward
to ensure proper connection.

b. Using your thumb to cover the Thule logo and
apply pressure to the cover. This will keep the
cover from “popping” while turning the
lock plug.

c. Use a coin, or flathead screw driver to turn the
lock plug clockwise; locking the cover in place.

4

a. Insert square key into cylinder.

INSTALLING LOCKS IF PURCHASED

b. Insert cylinder into foot.

c. Once you have installed the lock core, insert
the “N” series key. Press thumb against Thule
logo and hold. This will prevent the cover from
“popping” when turning the key clockwise to
the locked position.

• With your thumb, cover the Thule logo and
apply pressure to the cover. This will prevent
the cover from “popping”.

• With pressure applied turn the key clockwise
to lock the cover to the foot, which will prevent
access to the mounting hardware.

THULE RACK GUIDELINES
When using Thule Load Carries and accessories, the user
must understand the precautions. The points listed below
will assist you in using the rack system and will encourage
safety.
• For quality fits and safety, use only the recommended
rack or accessory as stated in Thule’s current Fit Guide.
Do not assume a rack will fit, always check the current
Fit Guide when obtaining a new vehicle.
• Unless stated otherwise in these instructions, do not
carry more than 75 kg (165 lbs.) on Thule Load Carriers.
Thule Load Carriers do not increase gutter or roof
strength. Thule can not warranty loads that exceed this
limit. Total load = cargo weight plus weight of
accessories used to carry cargo.
• Always make sure all doors are open when mounting a
roof rack system. Make sure all knobs, bolts, screws,
straps, and locks are firmly attached, tightened and
locked before every trip. Knobs, bolts, screws straps and
locks must be periodically inspected for signs of wear,
corrosion, and fatigue. Check your load at stops during
the trip to ensure continued fastening security.
• Check local and state laws governing projection of
objects beyond the perimeter of a vehicle. Be aware of
the width and height of your cargo since low clearance
branches, bridges, and parking garages can affect the
load. All cargo will affect the vehicle’s driving behavior.
Never drive with any lock, knob or rack in an open or
unlocked position. All long loads such as, but not limited
to, sailboards, surfboards, kayaks, canoes, and lumber
must be tied down front and rear to the bumpers or tow
hooks of the vehicle.
• Remove your Thule rack and accessories when they are
not in use and before entering automatic car washes.
• All locks must be turned and moved periodically to
ensure smooth operation. Use graphite or dry lubricant
to help this. Thule locks are designed to deter vandalism
and theft but should not be considered theft proof.
Remove valuable gear if your vehicle is unattended for
an extended period. Place at least one key in the
glove compartment.
• For safety to your vehicle and rack system, obey all
posted speed limits and traffic cautions. Adapt your
speed to the conditions of the road and the load being
carried.
• Do not use Thule load carriers and accessories for
purposes other than those for which they were designed.
Do not exceed their carrying capacity. Failure to follow
these guidelines or the product’s instructions will void
the warranty.
• Not for use on trailers or towed vehicles.
• Not for offroad use.
• Keep bicycle tires away from hot exhaust.

THULE will warranty all THULE brand car rack systems and its
accessories manufactured by THULE during the time that an
original retail purchaser owns the product. This warranty terminates if a purchaser transfers the product to any other person.
Subject to the limitations and exclusions described in this
warranty, THULE will remedy defects in materials or workmanship by repairing or replacing, at its option, a defective
product without charge for parts or labor. In addition, THULE
may elect, at its option, not to repair or replace a defective
product but rather issue to a purchaser a refund equal to the
purchase price paid for the product or a credit to be used
toward the purchase of a new THULE load carrier system.
No warranty is given for defects caused by normal wear and
tear, cosmetic rust, scratches, accidents, unlawful vehicle
operation, or modification of, or any types of repair of, a load
carrier system other than those authorized by THULE.
No warranty is given for defects resulting from conditions
beyond THULE’s control including, but not limited to, misuse,
overloading, or failure to assemble, mount or use the product
in accordance with THULE’s written instructions or guidelines
included with the product or made available to the purchaser.
No warranty is given for Thule products purchased outside of
the United States, Canada and Mexico.

In the event that a product needs to be returned to THULE, a
THULE technician at the address or telephone number listed
above will provide the purchaser with the appropriate mailing
address and any additional instructions. Please note that the
purchaser will be responsible for the cost of mailing the
product to THULE and that proof of purchase in the form of an
original purchase invoice or receipt and a detailed description
of the defect must be included in the mailing.
DISCLAIMER OF LIABILITY
REPAIR OR REPLACEMENT OF A DEFECTIVE PRODUCT OR THE
ISSUANCE OF A REFUND OR CREDIT (AS DETERMINED BY
THULE) IS A PURCHASER’S EXCLUSIVE REMEDY UNDER THIS
WARRANTY. DAMAGE TO A PURCHASER’S VEHICLE, CARGO
AND/OR TO ANY OTHER PERSON OR PROPERTY IS EXCLUDED.
THIS WARRANTY IS EXPRESSLY MADE IN LIEU OF ANY AND
ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, INCLUDING
THE WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A
PARTICULAR PURPOSE.
THULE’S SOLE LIABILITY TO ANY PURCHASER IS LIMITED TO
THE REMEDY SET FORTH ABOVE. IN NO EVENT WILL THULE BE
LIABLE FOR ANY LOST PROFITS, LOST SALES, OR FOR ANY
CONSEQUENTIAL, DIRECT, INDIRECT, INCIDENTAL, SPECIAL,
EXEMPLARY, OR PUNITIVE DAMAGES OR FOR ANY OTHER
DAMAGES OF ANY KIND OR NATURE.
SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION
OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE
LIMITATIONS MAY NOT BE APPLICABLE.
THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND
YOU MAY ALSO HAVE OTHER RIGHTS WHICH VARY FROM
STATE TO STATE.

Thule Cargo Carriers

Roof Racks



---

Source Exif Data:

File Type                       : PDF
File Type Extension             : pdf
MIME Type                       : application/pdf
PDF Version                     : 1.6
Linearized                      : No
Author                          : CARiD
Create Date                     : 2008:07:11 11:36:52-04:00
Keywords                        : racks, roof racks, roof bars, car top carriers, car carriers, cargo carriers, car roof racks, rooftop cargo carriers
Modify Date                     : 2014:09:08 11:35:17+03:00
Subject                         : Thule Roof Rack Fit Information
Has XFA                         : No
XMP Toolkit                     : Adobe XMP Core 5.4-c005 78.147326, 2012/08/23-13:03:03
Producer                        : Acrobat Distiller 8.1.0 (Macintosh)
Format                          : application/pdf
Creator                         : CARiD
Title                           : Thule Roof Rack Fit Information
Description                     : Thule Roof Rack Fit Information
Creator Tool                    : QuarkXPress 7.31
Metadata Date                   : 2014:09:08 11:35:17+03:00
Document ID                     : uuid:b70d2b2d-053e-3841-96ac-eb5aa4010753
Instance ID                     : uuid:6cb14077-3861-42ac-8692-fbfaaa9e3f6e
Page Count                      : 4

EXIF Metadata provided by EXIF.tools