KVT 50DVDRY_512_522DVD_522DVDY_532DVD

This product uses Lead Free solder.

This product complies with the RoHS directive for the European market.

B53-0621-00 (N) 519

SERVICE MANUAL

KVT-50DVDRY/512/522DVD

MONITOR WITH DVD RECEIVER

/522DVDY/532DVD/532DVDM

OFF

OPEN

/CLOSE

TEL

SCAN

MONITOR WITH DVD RECEIVER

V.OFF

SRC NAV

SF

KVT-522DVD

ATT

AUTO +FM

VOLUME

EJECT

TI

Illustrations is KVT-522DVD

Remote controller *

(A70-2083-15)

RC-DV340

Escutcheon

(B07-3159-02)

Mounting hardware assy

(J21-9716-03) Lever

(D10-4589-04) x2

Screw set *

(N99-1758-15)

SIZE AAA BATTERY *

(NOT SUPPLIED)

DC cord *

(E30-6815-05)

DC cord *

(E30-6816-05)

Cord with plug

(E30-6813-05)

* Depends on the models. Refer to the parts list.

REV: 5m

PRK: 2m

BU,GND: 1m

The IC3, and IC11 in the DVD unit (X37-1100-03) are not replaceable components.

When these ICs are defective, replace the whole DVD mechanism assembly (X92-6160-00).

You cannot replace only the board.

TEST MODE is the same as DDX512.

Please refer to the service manual (DDX512: B53-0620-00).

2

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171)

Observe the instructions described in this document when

you are going to replace the parts or components that are

shown in this document.

1. Replacement of motor ﬂ at spring

• When mounting the flat spring that shall be in contact

with the worm gear, press the spring toward the direction

shown with an arrow so that there will be no gap be-

tween the tip of the gear and the spring and then mount

the spring. The gear shall be pressure-inserted into the

motor.

• Note that there are two motors. Above operation of

mounting the ﬂ at spring is required on both of them.

Tilt drive gear train Slide drive gear train

Mount the flat spring

while pressing it

towards the direction

shown with an arrow

so that there will be no

clearance.

Mount the flat spring

while pressing it

towards the direction

shown with an arrow

so that there will be no

clearance.

DC Motor

Worm

Flat Spring

DC Motor

Worm

Flat Spring

3

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171)

2. Phase matching among gears

• Monitor tilt is driven under the control of the

rotary sensor and the phase matching among

gears and sensor is required.

The procedure for the phase matching is de-

scribed in the rest of this subsection.

1) Align the mark on the rack with the pin. (When

the monitor is folded down at 0 degree, the

rack is located at the position where the mark

and pin are aligned.

2) Insert the gear while keeping aligning the rack

pin with the notched section on the tilt gear 7.

3) Pre-assemble the tilt motor bracket assembly

(BKT Assy).

4) Align the notch on the sensor BKT with the

concave section of the sensor in the Assy.

5) While keeping the conditions stated in 3) and

4), insert the tilt motor BKT Assy transversally,

and ﬁ x the motor.

Tilt drive gear train

Location of mark

on the Rack

T-Rack-A Pin

Location of

notched section

Tilt Gear 7

Location of

notched section

Sensor Tilt Sensor Bkt

4

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

3. Insertion of slider

• This subsection describes cautions for inserting the

slider (slide section inside of the unit) into the outer

chassis.

1) On the rail at the left side of the slider, there is a part

called a stabilizer that is used to minimize play in

right and left sides.

The slide is made of resin. (Note that the rail is

shown at the right side of the slider in the picture.)

When inserting the slider, press the stabilizer towards

the direction shown with a blue arrow and insert it

into the groove on the rail.

2) PCB holder is pushed out towards the downside of

the picture due to the spring force and thus the chas-

sis and photo reﬂ ection sheet may be get caught by

the holder during the assembly.

Insert the slider while slightly lifting up the holder with

a pair of tweezers or any other similar device.

3) Insert the gear after confirming that the both of D

shaft gears at the right and left sides of the slider are

aliened with the tip of the right and left racks on the

chassis.

(Otherwise the slider will be inserted sidelong.

CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171)

(Slider -Slide section inside of the unit)

Stabilizer

PCB Holder

These portions

tend to be get

caught.

Hold and lift up the holder

with a pair of tweezers.

Push the opposite side of

the PCB holder towards

the downside of the picture

and lift up the portions

that may get caught.

D shaft gear

Rack gear

5

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

In assembling the Traverse UD arm, Drive cam assembly,

Drive gear 5 and Drive gear 4C, align register marks on

these components.

GEAR POSITION IN A DVD MECHANISM

BLOCK DIAGRAM

Drive gear 5

Drive cam assembly

Do not forcibly press gears to engage their teeth

but freely let the gears fall under their own weight

and engage their teeth.

Traverse UD arm

Drive gear 4C

Inscriptions

(register marks)

on gears

Align 6 marks as

shown in the

figure

DVS-8000V BLOCK DIAGRAM (X37-1100)

SPINDLE

MOTOR

DISC

OPTICAL PICKUP

STEPPING

2 PHASE

CN1

30PIN

28PIN

CN3

MOTOR &

DRIVER

ACTUATOR

M

DC MOTOR

LO/EJ

PROCESSOR

FRONT-END

IC1

IC12

IOP

DET

Q7,8

OPTICAL DISC

CONTROLLER

RESET IC CN2

50PIN

3.3V REG

IC7

D3.3V

A3.3V

A5V

D5V

1.5V REG

IC9

1.5V VOLTAGE DET

IC8

to

MAIN

Tr

APC

IC10

Q1,2

IC4

IC3

FLASH ROMEEPROM

IC11

HALL

IC

HFM3.3V

D7

SW LOEND

SW LOST

UNIT

U,V,W COIL

HALL BIAS

HALL SENSOR

DVD LD/CD LD

VREFH

IMON/VR DVD/VR CD

PDIC I/V OUT

FO+/-,TR+/-

THERMISTER

FO5,RO5

P5V

FO2,RO2

3

H1H,H1L,HB

A1,A2,A3

P5V

VHALF

FG

A5V

D5V

A3.3V

7

3

VHALF

IOP(AD)

VHALF(1.65V)

TRCRS

TE

SEN,SCK,STDI

FBAL,JLINE,

ARF,NARF

TSTSG

FG,EXCNT1

SDA,SCL

DRV.MUTE,LO.MTE,

FADR0-17,

TRDRV,PWM8,

BMS,STEP A,STEP B

NCE,NWE,NOE

FTD0-7

28

D5V A3.3V 1.5VD3.3V

16.897849MHz

NRST

D3.3V

ATAPI IF

D5V

P5V

DISC DET

ON/OFF

A5V

LIM-SW

4

SEN,SCK,STDI

VREF,EC

RF,FE1,FE2

A,B,C,D,E,F,

9

3

FE,AS,RFENV,RFDIFO

OFTR,BDO,VREF2

21

D3.3VD3.3V

9

DVDON/

CDON

TEMP

DET(AD)

2

D3.3V

HFM

A3.3V

2

VR

SPDRV,FODRV,

LPC1,2

VREFH

4

FO3,RO3

FO4,RO4

FO6,RO6

BMS,MUTE

HFM3.3V

PDIC VCC

HFM

SW EJEND

STBY,SPIN,IN2-6

A5V

SW

4

6

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

BLOCK DIAGRAM

J1

DC CN

MOLEX 15A

CN351

AUDIO

AV IN

DVS-8020V

DVD MECHA

CN701

WH UBS

W801

TV-BOX (E,M,X)

CN351

SAT I/F

CN353

AV IN

VIDEO

CN351

CN354

NAVI

IC701

(MAGNUM)

BE

FLASH ROM

IC702

CATION

i-Pod AUTHENTI-

IC851

J681

IC602

LPF

USB H/C

IC801

PROTECTION

OVER CURRENT

IC804

LPF

IC601

AUDIO

DAC

IC651

LPF

MUTE ISO-1

SEL

MUTE1 BUFF1

ISO-2 MUTE2 BUFF2

ISO-3 MUTE3 BUFF3

ISO-4

ISO-5

ISO-6

ISO-7 AUDIO BLOCK

IN-6

IN-5

VIDEO BLOCK

SEL

IN-4

IN-3

IN-2

IN-1

6dB

SW

IC358

iPod

CN352

F-ZB

SYNC-TIP

CLAMP

SYNC

RGB

SW

IC361

SDRAM 128MHz

IC703,704

D OUT

ISO

AMP

SEL

ISO

AMP

INPUT SEL &

VOL

OUT

MUTE

FM/AM

(S07 F/E)

A1

RDS

IC355

E2PROM

X86-403

IC351

PWIC

MUTE

ANT

FM/AM

W351

CN351

MUTE

CN351

MUTE

AV OUT

u-COM

IC9

ILLUMI

VARIABLE

VMUTE

MOTOR

IC5

DRIVER

X35-496

to

CN3

MOTOR

DRIVER

IC6

X15-110 B/2

to

CN4

BU14V

BU5V

A8.5V SIR SW14V

BU3.3V

BE A5V T P+5VA5V

SW+14V

DCDC DCDC

SW5V D3.3V

D5VV5VMECHA

D1.8V USB3.3VUSB1.8VTC3.3V

USB5V

SW3.3V V3.3V P5V

7.5V

X15-110 A/2

to

CN551

X15-110

to

CN101

REMO

IC551

11 LEDS

10 KEYS

PANEL MECHA

to

CN104

IC304

AMP

MEMORY

IC302

SERIAL

X35-496 B/2

to CN302

to LCD PANEL

X35-496 A/2

to CN502

CN503

to TOUCH PANEL

CN501

V ILLUMI

FUNCTION

SCREEN

OPEN/CLOSE

IC1

INVERTER

SRC NAVI

KEY

(BACK LIGHT)

to LCD

CN1

(SW5V)

P ON+5V SW+14V

TC3.3V MECHA3.3V

(SW3.3V)

T P+5V

DCDC

IC101

+12.5VD2.5V -12V

5V for IC1 D2.5V

-6V

IC357

DET

SLIDE

CHILT

CONTROL

DECODER

VIDEO

u-COM

USB5V

BU DET

ACC DET

REVERSE

PARKING

P CON

ANT CON

W REMO

ILLUMI

LINE MUTE

D3.3V

26

D+: USB3.3V

D-: USB1.8V

USB5V

BE A5V

V5V

AVSW SDA

AVSW SCL

AVSW PDN

u-COM

A5V V5V SW3.3V

BU14V

RST

SDATA

MREQ

JUDGE

SREQ

CLK

MDATA

u-COM

V5V

RX

TX u-COM

REMO

VIDEO DRIVERS

V5V

RGB SW1

TUNER

CD

MD

CDCH

AUX

MUXC VOL IN

MUXB AC IN 3

AC IN 1

AC IN 2

AC IN 0

PAOUT

LDOUT

AOUT MUTE

MUTEC

MUTE2

u-COM

EVOL SCL

MUTE0

MUTE1

EVOL SDA

DC DET

A8.35V

TUN IFC

AM+B

TUN SMET

TUN SDA

TUN SCL

R AFS H

R NOISE

u-COM

A8.35V SW5V

SW5V

u-COM

R CLK

R DATA

R QUAL

WININ u-COM

PW STBY

PW MUTE

BEEP

PRE

FRRE

PRE

VOUT

AV AV

AOUT

SW5V

3

21

NT PAL

COMPOSIT

SOG

NT PAL

VMUTE from u-COM

BE VMUTE from BE (MAGNUM)

MECHA7.5V

44

7RESET

LED R

EJECT

SW5V

SI

LED G

REMO

KEY2

GND

MAGNUM

SIGNAL

COMPOSIT

RGB

AUDIO

u-COMu-COM P ON SIR PON

u-COM

P ON

u-COM

P START

P GOOD

P PWM

MCNT

P ON

D5V

P5V

VOL-

AUTO

FM

REW

AM

VOL+

ATT

EJECT

RESET

FW

SW3.3V

BU14V

10

TC WAIT

TC RST

TC SCL

TC SDA

NT PAL

SOG

COMPOSIT

VMUTE

HSY

VSY

TC3.3V

4

D2.5V

TC3.3V

P ON+5V

DEH

STHR

STHL

CKV

L/R

DEV

STVR

STVL

VCOM

CPH1

VCOMOUT

VCOMDC

-6V

TC3.3V

+18V

P ON+5V

YDATA

Y0

X0

X1

XDATA

T P+5V

LED G

LED B

LED R

KEY1

OPEN/CLOSE

INV PWM

INV SW

PWM

ENABLE

5V for IC1

SW14V

u-COM

DISC DET

D3.3VV3.3V D1.8V

TX

RX

CON

MAGNUM

RST

BU5V

BU3.3V

SW5V

MECHA3.3V

12

SIR SW14V

(X15-) (A/2)

(X35-) (B/2)

(X35-) (A/2)

(X15-) (B/2)

7

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

● VIDEO CONTROL UNIT (X15-110x-xx)

Ref. No. Application / Function Operation / Condition / Compatibility

IC1 3-terminal regulator 9V→5V regulator

IC2 3-terminal regulator For AUDIO8.5V

IC3 DC/DC converter IC MECHA7.5V/D5V control

IC4 DC/DC converter IC USB5V/D3.3V control

IC5 Motor driver Slide

IC6 Motor driver Tilt

IC7 3.3V regulator TC3.3V

IC8 Buffer for remote controller Remote controller signal waveform shaping

IC9 System μ-com IC System control

IC10 E2PROM For saving the settings

IC12 Voltage detector μ-com reset voltage (3.5V) monitoring

IC13 OR For VMUTE

IC351 POWER IC Power ampliﬁ er for speaker output

IC354 VIDEO ISO AMP IPod video signal

IC355 RDS decoder IC For RDS signal processing and demodulation

IC356 AND*4 KAB IF 3.3V→5V LEVEL SHIFT

IC357 Electronic volume IC AUDIO -VOL_CTL/SIG_SELECT

IC358 AV SWITCH 7-input/3-output AUDIO and 6-input/3-output VIDEO

IC361 VIDEO SELECTOR DVD_BE and NAVI_RGB SELECT

IC401,402 INVERTER TV_SDATA OUT BUFFER

IC551 IR remote controller photoreceptor Remote controller signal detection

IC601 VIDEO AMP DVD_BE COMPOSITE SIG LPF/BUFFER

IC602 VIDEO AMP DVD_BE RGB SIG LPF/BUFFER

IC651 AUDIO DAC DVD_BE AUDIO D/A CONVERTER

IC652 OP-AMP*2 DVD_BE AUDIO LPF

IC691 INVERTER SPDIF OUT BUFFER

IC692 AND For DVD_BE IC RESET_SIG

IC701 MPEG DECODER DVD/USB MPEG DECODER

IC702 64M FLASH FLASH MEMORY (MP 4Z4) for MPEG DECODER

IC703,704 128M SDRAM SDRAM for MPEG DECODER

IC705 Regulator 3.3V→1.8V regulator for MPEG DECODER

IC801 USB HOST CONTROLLER 2PORT (External/GARMIN navigation) USB HOST CONTROLLER

IC804 Fixed Current Limit

Power Distribution Switch Large current distribution switch for USB

IC805 Regulator 5V→3.3V regulator for USB

IC806 Regulator SW3.3V→1.8V regulator for USB

IC807 D-TYPE LATCH X 8 Address latch for USB H/C

IC851 COPROCESSOR IPOD AUTHENTICATION

Q1 SW REVERSE detection

Q2 SW PARKING detection

COMPONENTS DESCRIPTION

8

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Ref. No. Application / Function Operation / Condition / Compatibility

Q3 SW ILLUMI detection

Q4-7 SW PCON output

Q8,9 SW ANT_CON output

Q11 SW ACC detection

Q12-20 SW Over voltage/Voltage reduction/BU_DET

Q21-25 SW BU5V circuit

Q26-28 SW BU3.3V circuit

Q29,30 SW T_P+5V circuit

Q35-37 SW P_ON SW+14V control

Q38 SW P_ON SW+14V ON/OFF

Q39 SW A8.5V circuit

Q40-42 SW A5V circuit

Q43,44 SW BE_A5V circuit

Q45 SW KAB SW+14V control

Q46 SW KAB SW+14V ON/OFF

Q51 SW DC/DC protection control

Q52 SW Z2-MECHA power supply voltage (7.5V/5V) switching

Q53 SW DC/DC protection control

Q54 SW DC/DC SW FET (MECHA7.5V)

Q55 SW DC/DC SW FET (D5V)

Q56,57 SW DC/DC protection control

Q58 SW DC/DC SW FET (USB5V)

Q59 SW DC/DC SW FET (D3.3V)

Q60,61 SW VILL_R power supply

Q62,63 SW VILL_G power supply

Q64,65 SW VILL_B power supply

Q66,67 SW LED_R power supply

Q68,69 SW LED_G power supply

Q71,72 SW A8.5V circuit

Q73 SW DETMUTE circuit (Trigger BU_DET), DETMUTE detection

Q74 SW DETMUTE circuit (Trigger RESET), DETMUTE detection

Q75 SW DETMUTE circuit (Trigger RESET), TV_RST detection

Q76 BUFFER HSY (3.3V→5V)

Q77 SW DC/DC PSTART

Q78 BUFFER AVSW_SDA (5V→3.3V)

Q79 BUFFER AVSW_SCL (5V→3.3V)

Q80 SW SI

Q82 SW KAB detection

Q350 SW KAB_RX error connection protection

Q351-353 SW Pre-Out_Mute circuit (FRONT)

Q354-356 SW Pre-Out_Mute circuit (REAR)

COMPONENTS DESCRIPTION

9

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Ref. No. Application / Function Operation / Condition / Compatibility

Q357-360 SW Pre-Out_Mute circuit (AVOUT)

Q361,362 SW ON when AM (TUNNER8.5V)

Q370 SW KAB_RX error connection protection

Q371-373 SW Tuner_Mute circuit (during ejection)

Q451 BUFFER HD

Q452 SW NT_PAL

Q453 BUFFER DVD_V

Q454,455 SW For KAB_TX control

Q651 SW DVD AUDIO MUTE LCH

Q652 SW DVD AUDIO MUTE RCH

Q653 SW DVD AUDIO MUTE control

Q654,655 SW DVD AUDIO neutral point circuit

Q681 BUFFER SPDIF OUT BUFFER

Q683 SW DVD AUDIO MUTE control

● VIDEO UNIT (X35-4960-10)

Ref. No. Application / Function Operation / Condition / Compatibility

IC1 Inverter IC Power supply for CCFL

IC101 Power supply IC for LCD Support 3 output (18V/12.5V/-12V)

IC102 Multi-vibrator IC For LCD power supply rising timing adjustment

IC103 Logic IC For LCD power supply rising timing adjustment

IC200 Op amp IC Buffer for VCOM signal

IC300 Power supply IC 2.5V output

IC302 Serial ﬂ ush F/W storage for video decoder IC

IC304 Video decoder IC For decoding video signal

Q1 For switching Bright PWM signal SW

Q2,3 Dual FET For DC/AC conversion

Q4 Register integrated transistor External synchronization: 121kHz/Free run: 56kHz→ON (On when it is 56kHz)

Q5 Power supply transistor For inverter IC power supply (5V)

Q101,102 Power supply transistor For generating -6V from -12V (-12V→-6V)

Q200,202 Buffer transistor For VCOM signal level conversion

Q203 Integrated transistor For VCOM signal level conversion

Q501 Register integrated transistor For touch panel XY coordinate import switching

Q502,503 Integrated Register integrated transistor For touch panel signal

● DVD UNIT (X37-1100-03)

Ref. No. Application / Function Operation / Condition / Compatibility

IC1 RF signal processing IC RF signal processing

IC3 FLASH ROM Maintain F/W for optical DISC control IC

COMPONENTS DESCRIPTION

10

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Ref. No. Application / Function Operation / Condition / Compatibility

IC4 Optical disc control IC in μ-com Optical DISC general control / ATAPI interface

IC5 Voltage detection IC For system resetting of optical DISC control IC

IC7 3.3V power supply 5V→3.3V

IC8 Voltage detection IC For 1.5V power supply IC voltage monitor

IC9 1.5V power supply 5V→1.5V

IC10 Driver IC Focus coil, Tracking coil, Spindle motor, Sled motor and Lo/Ej motor drive

IC11 EEPROM Maintain data for optical DISC control IC

IC12 OP-AMP for Iop measurement For IOP measurement

Q1 Register integrated transistor SL. MUTE control

Q2 Register integrated transistor For FG signal

Q3 Register integrated transistor LO.MUTE control

Q4 Register integrated transistor DRMU control

Q5 MOS-FET Laser diode ON/OFF control for DVD

Q6 MOS-FET Laser diode ON/OFF control for CD

Q12 Transistor for APC Laser diode brightness control for CD

Q13 Transistor for APC Laser diode brightness control for DVD

Q14 MOS-FET For IOP measurement

Q15 Register integrated transistor HFM ON/OFF control

Q18,19 Register integrated transistor 3.3V power supply IC ON timing control

COMPONENTS DESCRIPTION

11

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

● SYSTEM MICROCOMPUTER: 30878MJBA22GP (X15-110: IC9)

Pin No. Pin Name I/O Application Processing Operation Description

1 EVOL_SDA I/O Communication data with E-VOL

1 EVOL_SDA/E2P_SDA O Communication data with E2P

2 X1 O Touch panel control

3 SIR_PON O SAT power supply ON/OFF H: ON, L: OFF

4 VSYNC_DET I Video external input detection Detects if there is VSYNC signal or not.

5 AVSW_SDA I/O Communication data with AV switch

6 AVSW_SCL O Communication clock with AV switch

7 HSY I HD input Counts HD.

8,9 NC O

10

TV_SC_REQ/TV_SC_REQ

IRequest from TV μ-com

(For other destination than K and R)

10 TV_SC_REQ/NC O (K,R destination)

11

TV_MC_REQ/TV_MC_REQ

ORequest to TV μ-com

(For other destination than K and R)

11 TV_MC_REQ/NC O (K,R destination)

12

TV_SC_CON/TV_SC_CON

ORequest to start TV μ-com

(For other destination than K and R)

12 TV_SC_CON/NC O (K,R destination)

13 INV_PWM O Inverter frequency control

14 PWIC_MUTE O Power IC output mute control H: OFF, L: ON

15 BYTE

16 CNVSS

17 XCIN

18 XCOUT

19 RESET

20 XOUT

21 VSS

22 XIN

23 VCC1

24 NMI

25 ACC_DET I ACC detection H: ACC reduced power detection

26 BU_DET I Backup power supply detection H: Backup reduced power detection

27 R_CLK/R_CLK I Clock input from RDS decoder

(For other destination than X and (V))

27 R_CLK/NC O (X, (V) destination)

28 NC O

29 EJECT_MUTE O Mute control during loading/ejection

30 NC O

31 PWM O LCD brightness control PWM output synchronized with VSY

32 PRE_MUTEF O Pre-out mute (F/R) H: OFF, L: ON

33 BEEP O BEEP PWM output

MICROCOMPUTER’S TERMINAL DESCRIPTION

12

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Pin No. Pin Name I/O Application Processing Operation Description

34 PRE_MUTESW O Pre-out mute (SW) H: OFF, L: ON

35 POWER_PWM O Frequency control of DC-DC_IC

36 NAVI_RX I Communication with navigation system

37 NAVI_TX O Communication with navigation system

38

TV_MC_DATA/TV_MC_DATA

OData output to TV μ-com

(For other destination than K and R)

38 TV_MC_DATA/NC O (K,R destination)

39 VCC1

40

TV_SC_DATA/TV_SC_DATA

IData input from TV μ-com

(For other destination than K and R)

40 TV_SC_DATA/NC O (K,R destination)

41 VSS

42

TV_BP_CLK/TV_BP_CLK

OCommunication clock with TV μ-com

(For other destination than K and R)

42 TV_BP_CLK/NC O (K,R destination)

43 NC O

44 TUN_SDA I/O Communication data with tuner

45 TUN_SCL O Communication clock with tuner

46 R_DATA/R_DATA I DATA input from RDS decoder

(For other destination than X and (V))

46 R_DATA/NC O (X, (V) destination)

47 R_QUAL/R_QUAL I QUAL input from RDS decoder

(For other destination than X and (V))

47 R_QUAL/NC O (X, (V) destination)

48 EVOL_MUTE0 O E-VOL front mute L: ON, H: OFF

49 EVOL_MUTE1 O E-VOL rear mute L: ON, H: OFF

50 EVOL_MUTE2 O E-VOL C·SW mute L: ON, H: OFF

51 EVOL_MUTEB O E-VOL_B·AVOUT mute H: ON, L: OFF

52 EVOL_MUTEC O E-VOL_C mute L: ON, H: OFF

53 TV_JUDGE I Determination of TV_BOX if it is old or new H: Old, L: New

54 WRT_E2P I Used when writing into E2P L: Normal condition

H: When writing into E2P

55 AVSW_PDN O Communication clock with AV switch

56 VILL_R O Brightness control of “R” in variable illumination

57 VSS

58 VILL_G O Brightness control of “G” in variable illumination

59 VCC2

60 VILL_B O Brightness control of “B” in variable illumination

61 NT_PAL I NTSC/PAL determination signal input H: PAL, L: NTSC

62 VMUTE O LCD output mute control H: MUTE, L: Normal

63 X0 O Touch panel control

64 VILL_DET I Variable illumination identiﬁ cation terminal L: F3, H: F4

MICROCOMPUTER’S TERMINAL DESCRIPTION

13

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Pin No. Pin Name I/O Application Processing Operation Description

65 OPEN_CLOSE I Z-MECHA OPEN/CLOSE

66 Y0 O Touch panel control

67 INV_SW O Inverter free run frequency switching

68 BL_ENA O Back light ON/OFF control H: ON, L: OFF

69 NC I Reserve

70 Z_SWT I Detection of panel mechanism

71 SW_C I Detection of panel mechanism

72 SW_B I Detection of panel mechanism

73 SW_A I Detection of panel mechanism

74 VCC2

75 SMOTOR_M O Panel mechanism slide control

76 VSS

77 SMOTOR_P O Panel mechanism slide control

78 TMOTOR_M O Panel mechanism tilt control

79 TMOTOR_P O Panel mechanism tilt control

80 AM+B O Tuner AM power supply ON/OFF control H: ON, L: OFF

81 SI O SI control L: ON, H: OFF

82 EJECT I Disk ejection

83 BE_RESET O Reset request to back end L: Reset, H: Clear reset

84 BE_RESERVE2 I Operation identiﬁ cation terminal from back end H: Valid, L: Invalid

85 BE_STBY I Standby request from back end

86 BU_BUDET O

Notiﬁ cation of momentary power down detection to back end

87 BE_INI O Initial request to back end

88 BE_SDATA I Communication data from back end

89 BE_CLK I Communication clock with back end

90 BE_MDATA O Communication data to back end

91 VCC2

92 TYPE1 I Destination settings Refer to Destination settings

93 VSS

94 TYPE2 I Destination settings Refer to Destination settings

95 BE_CON O Control request to back end

96 BE_MREQ O Request to back end

97 DISC_DET I DVD mechanism function to detect if there is a disc or not. H: There is no disc, L: There is a disc

98 NC O

99 Z_CNT I Detection of panel mechanism

100 Z_SENS I Detection of panel mechanism

101 NC O

102 VSY I VD (VSYNC) input

103 BE_RESERVE1 CLK terminal for operation identiﬁ cation from back end CLK frequency: 1Hz

104 BE_SREQ I Request from back end

105 NC O

MICROCOMPUTER’S TERMINAL DESCRIPTION

14

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Pin No. Pin Name I/O Application Processing Operation Description

106 ILL_G O

ON/OFF of other GREEN illumination than variable illumination

H: ON, L: OFF

107 ILL_R O

ON/OFF of other RED illumination than variable illumination

H: ON, L: OFF

108 MCNT O

Switching of power supply voltage to the panel drive mechanism

H: 7.5V, L: 5V

109 PGOOD I DC-DC power supply error detection H: Normal, L: Error

110 P_START O DC-DC power supply ON/OFF control

111 PON O SW power supply ON/OFF control

112 NC O

113 REVERSE I Reverse detection L: Detection, H: Normal

114 PARKING I Parking detection L: Detection, H: Running

115 SIR_DET I Sirius connection detection L: Detection, H: Not-connected

116 ANT_CON O Power antenna control H: UP, L: DOWN

117 P_CON O P-CON control L: STANDBY, POWER OFF, H: EXCEPT

118 ILLUMI I Illumination detection L: ON, H: OFF

119-121

NC O

122 TYPE0 I Destination settings Refer to Destination settings

123 KEY2 I Key 2 input Refer to KEY2

124 TUN_IFC I F/E IFC input H: Station found, L: Station not found

125 TUN_SMET I S meter input

126 R_NOISE I FM noise input

127 R_AFS_H I/O Time constant switching when F/E noise is detected.

128,129

NC O

130 VSS

131 NC O

132 VCC1

133 KEY1 I Key 1 input Refer to KEY1

134 NC O

135 PWIC_STBY O Power IC standby H: ON, L: OFF

136 VCOM I For VCOM level automatic adjustment

137 X_DATA I Touch data input

138 Y_DATA I Touch data input

139 LINE_MUTE I LINE-MUTE input detection Normal: 1.6V, TEL MUTE: 1V or less,

NAVI MUTE: 2.5V or higher

140 AVSS

141 PWIC_DC_DET I SP output DC offset detection L: When detected

142 VREF

143 AVCC

144 EVOL_SCL/EVOL_SCL O Communication clock with E-VOL

144 EVOL_SCL/E2P_SCL O Communication clock with E2P

MICROCOMPUTER’S TERMINAL DESCRIPTION

15

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Destination settings of KVT/DDX/DNX

MODEL Destination TYPE2 TYPE1 TYPE0

KVT

K00 *

E00 *

M0 0 *

V/X 0 0 *

R00 *

DDX

K01 *

E01 *

M0 1 *

V/X 0 1 *

R01 *

DNX

K11 *

E11 *

M1 1 *

V/X 1 1 *

R11 *

TYPE0 is AD input.

Refer to the next table (TYPE0 Setup Voltage) for the “*”.

• TYPE0 Setup Voltage

Power supply voltage Number of destinations Pull up resistor

3.3 5 10

Destination

μ-com setup value Pull down

resistor

Pull up

resistor

min max

K 0.00 0.41 10 None

E 0.42 1.23 3.3 10

M 1.24 2.06 10 10

V/X 2.07 2.88 30 10

R 2.89 3.30 None 10

KEY1 Settings

Power supply voltage Number of keys Pull up resistor

5412

Name of

key

μ-com setup value Resister

value

min max

KEY1 SCRN/ 0.00 0.69 0.2

KEY2 FNC/■0.70 1.92 3.9

KEY3 SRC/SRC 1.93 3.15 8.2

KEY4 NAV/- 3.16 4.38 24

NO KEY 4.39 5.00

When opened / When closed

When being pushed and held for a while

KEY2: TEL, KEY4: V.OFF (E), RCAM (K,R,M,X)

KEY2 Settings

Power supply voltage Number of keys Pull up resistor

5812

Name of

key

μ-com setup value Resister

value

min max

KEY1 VOL- 0.00 0.42 0.3

KEY2 ATT 0.43 1.03 1.8

KEY3 VOL+ 1.04 1.64 2.2

KEY4 AUTO 1.65 2.25 3.3

KEY5 AM 2.26 2.86 5.1

KEY6 FM 2.87 3.47 8.2

KEY7

SEEK DOWN

3.48 4.08 16

KEY8 SEEK UP 4.09 4.69 51

NO KEY 4.70 5.00

When being pushed and held for a while

KEY2: LOUD (K,R,X)

MICROCOMPUTER’S TERMINAL DESCRIPTION

16

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

1. Flicker adjustment

● Condition

Video source: VIDEO

Video: RAMP

BRIGHT: MAX

MODE: FULL

● Adjustment procedure

q Display RAMP.

w Rotate VR200: X35-496 until the leading edge of black

area reaches far right of the screen. As shown in the

next picture, the edge is now located at about 1/5 of the

screen width from the left of the screen. (At the comple-

tion of this adjustment, most of the screen will be in

black.)

The position where the adjustment is best completed

can be shown darkest and clearest.

Adjust it by confirming this area

Example: Keep rotating the VR200 so that the black area

is gradually expanded (to the right), and if you rotate the

VR200 too much, the black area will start shrinking. So

when you see the black area starts shrinking, rotate the

VR200 backward a bit to make the adjustment relatively

stable.

2. VCOM Amplitude and AGC and WB

Automatic adjustments

● Adjustment Method

q Input 100% (white) in AV-IN.

w Press Auto Adjust on the Test Mode Main screen.

e Press Auto Adjust Start.

r After the automatic adjustment, “Auto Set OK” will be

shown to indicate the completion of the adjustment.

ADJUSTMENT

17

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

3. Adjustment of Horizontal display start

position and pixel

● Video displayed on Adjustment screen

GRAPHIC: Special screen used only for adjustment (See

below)

NAVI: Input KNA-DV3200 or KNA-G520

● Default Value

Pixel Adjustment key (DOT_PHASE): Adjustment of hori-

zontal display position of pixel (Default: 32)

Screen Position Adjustment key (HPOSI): Adjustment of

horizontal display starting position of the entire screen

(Default: 0)

Display Range Adjustment key (DOT_FREQ): Adjustment

of horizontal display range of the video (Default: 64)

● GRAPHIC Adjustment screen

Pixel Adjustment key

Proceed to the next

adjustment screen.

Horizontal

Screen Position

Adjustment OSD

Screen Position

Adjustment key

Display Range

Adjustment key

Return to the Menu

Horizontal

Screen Position

Adjustment OSD

● NAVI Adjustment screen

Adjustment screen changes depending on what type

(model) of NAVI is connected.

Screen Position

Adjustment key Proceed to the next

adjustment screen

● Adjustment Procedure

q Press HPOSI on the Test Mode Main screen.

w-1 Grafhic (DotPhase)

Then, adjust the Pixel Adjustment key so that the screen

becomes gray.

After the completion of the adjustment, press “NEXT”.

• Pixel Adjustment: GRAPHIC

OK

ADJUSTMENT

18

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

NG

Enlarge OK

Enlarge NG

w-2 Grafhic (HPOSI)

Adjust the Screen Adjustment key so that the screen be-

comes horizontally symmetrical.

• Screen Position Adjustment: GRAPHIC

w-3 Grafhic (DotFreq)

Then, adjust the Display Range Adjustment key so that

there is no vertical black stripes (blur) on the screen.

After the completion of the adjustment, press “NEXT”.

• Adjustment of display range: GRAPHIC

OK

NG

w-2-1 NAVI (In case of KNA-DV3200)

Adjust the Screen Adjustment key so that the NAVI

screen becomes horizontally symmetrical.

Adjust the screen such that KEY (gap) at the

right and left sides becomes symmetrical.

w-2-2 NAVI (In case of KNA-G520)

Adjust the Screen Adjustment key so that the NAVI

screen becomes horizontally symmetrical.

Adjust the space to become horizontal symmetry

ADJUSTMENT

19

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Enlarge OK

● Conﬁ rmation after adjustment

After the adjustment, check that the screen is horizon-

tally symmetrical and that there is no blur on the screen.

The “HPOSI OK” will be shown to indicate the comple-

tion of the adjustment.

4. Touch panel adjustment

● Adjustment procedure

q Press the Touch Key on the Test Mode Menu screen to

enter the Touch panel adjustment screen.

w Touch the center of “+” mark below in the following or-

der.

Upper left

→ Upper right → Lower left → Lower right

To touch, make sure to use the designated touch stick.

e After adjustment is completed for 4 areas, if “Write OK”

is displayed, the adjustment is completed.

Press Return to exit from the Touch screen.

Cancel Cancel

CancelCancel

∗ If the center of “+” mark wasn’t pressed accurately, press

Cancel to start over the adjustment.

Note

The touch panel adjustment data is finalized when the

touch stick is released from the mark.

Therefore, the Knack for Adjustment is not to release the

touch stick from the mark right after touching the center

of the “+” mark, but to conﬁ rm that the stick is exactly

on the center of the “+” mark while keeping touching the

screen. (If the stick is not exactly on the center of the

mark, move the stick onto the center of the mark while

keeping touching the screen.)

Then, quickly and vertically release the stick from the

screen.

ADJUSTMENT

20

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

ABCDE

1

2

3

4

5

6

7

PC BOARD (COMPONENT SIDE VIEW)

E

B

EB

EB EB

EB

BE

G

D

S

BE

GS

BE

R674

C475

C476

C28

C456

C229

C673

L13

C19

L12

C459

L702

L851

R

1

R492

C761

C763

R123

R286

R

L731

L741

R840

R847

R833

R834

R835

R836

R841

R844

C762

C764

R157

R276

R288

C466

R769 R245

R246

R247

R248

R269

R270

R271

R770

C161

C162

C424

C390

C392

R412

C751

C464

R156

C672

C163

C164

R883

C460 C467

C468

L361

C851

C852

R662

R661

R845

R281

C704

C655

C657 L451

L703

C741

C742

C743

C744

C745

C746

C747

C748

C752

C753

C754

C755

C756

C757

C758

C18

F2

R46 R48

C89

C500

R266

L355

C397

R702

C663

C664

R677

R884

R885

L751

C352

R837

R543

C455

C479

C480

C481

C482

R760

R488

R495

R676

C656

C658

R673

R843

C26

R283

R284

R47

R

C173

C183

C184

C185

C186

C187

C188

C189 C190

C191 C192

C193

C194

C196

C406

C407

C702

R480

C731

C732

C853

C854

C855

CP751

CP752

R204

R205

R207

R208

R221

R222

R223

R250

R251

R252

R253

R272 R273

R274

R831 R832

R761

X2

R762

R544

R548

R385

R489

C150

C151

C152 C153

C154

C155

C156

C157

R402

R428

R511

R516

R517

C353

C356

C377

C379

C423

C425

C457

C462

C465

C469

C470

C471

C472

C473

C474

C477

C478

C494

C495

C496

C497

C498

C499

C661

C662

C665

C666

C667

C668

R49

R50

R73

R159

R160

R161

R162

R163

R164

R165

R166

R167

R168

R170

R171

R183

R184

R185

R186

R187

R188

R206

R210

R211

R212

R213

R214

R215

R217

R218

R219

R220

R225

R227

R228

R229

R230

R231

R232

R233

R234

R235

R236

R237

R238

R239

R240

R241

R242

R243

R244

R254

C463

R256

R258

R259

R260

R262

R263

R264

R265

R267

R268

R275

R386

C454

R390

L2

R394

R280

R400

R401

R403

R404

R405

R406

R411

R438

R439

R452

R453

R454

R501

R502

R503

R481 R482

R510

R512

R513

R515

R518

R519

R669

R670

C376

C385

C389

C378

R664

R846

R663

R654

R763 R764

L3

R652

R838

R653 R651

R667

R668

R666

R665

R255

R282

R216

R224

C703

R494

R493

X351

X851

R848

C380

C383

X1

CP753

C443

R249

C359

C735

R278

R279

C203

BE

15

202

191

202

191

21

B

E

C431 C384

R361 R354

R370 R364

168

1

64 49

16

48

33

17 32

36

37

1

72

144

109

10873

1

27

54

28

54

2827

1

24 1

4825

11

20

1

51

161

98

5

8

4

1

20

11

40

31

30 21

10

1

16

98

1

C11

1

18151

111

2

27

26

BE

19

2

20

D14

Q80

CN4

CN2

Q655

Q653

CN701

Q452

CN3

Q361

CN354

Q23

Q

Q654

Q651

Q652

D32

Q76

D19

D20

D21

D22

D23

D24

D25

D27

D28

D29

D30

D31

D34

D35

D36

D37

D41

P5

P2

Q362

D365

D366

D367

D369

D370

D371

D372

D373

D374

D375

D376

D384

CN355

Q78

Q79

D396

Q683

D401

CN352

D651

D701

D413

Q451

Q77

Q453

Q372

Q373

D368 Q371

CN351

CN357 CN356

W351

Q39

IC9

IC358

IC652

IC851

IC651

IC703

IC704

IC361

IC702

I

C

IC705

IC351

VIDEO CONTROL UNIT

X15-110x-xx A/2

(J76-0505-12)

21

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Refer to the schematic diagram for the

values of resistors and capacitors.

JIHGF

1

2

3

4

5

6

7

BE

EB

BE

R68

R155

R123

R121

C836

C837

R812

R157

C32 F1

R81

R154

L357

R483

R21 R475

L803

L811

C843

R156

R281

C704

C131

C141

C143 R153

C130

C140

C142

R150

C78

C88

C90

R119

R193

R52

L1

C25

C69

C70

C72

C73

C122

C123

C125

C126

L6

L7

L10

L11

C77

C87

C89

R117

R118

R694

SPDIF

R695

L801

C801

R820

R814

R816

C15

C24

R817

R51 R53

R70

R72

C841

L805

C802

C803

C55

C58

C59

C61

C71

C74

C75

C76

C80

C81

C82

C83

C84

C85

C108

C111

C112

C114

C124

C127

C128

C129

C133

C134

C135

C136

C137

C138

C139

C804

C62 C64

C65 C67

C115

C117

C118

C120

C411

C414

C413

C681

L4

L5

L8

L9

L804

R49

R50

R69 R71

R80

R112

R113

R115

R116

R145

R146

R148

R149

C826

C829

R235

R254

L2

R418

R419

R420

R421

R422

R423

R424

R692

C412

R691

R425

R426

R427

R693

R477

R473

L3

R479

C827

C828

C842

C844

C834

C835

R815

X808

R551

R590

R578

R587

R562

R564

ATT

VOL-

VOL+

AUTO

AM

FM

EJECT

RESET

R566

R568

R570

R572

R574

R576

R588

R554

R577

R579 R581

R580

R589

R591

R561

R563

R565

R567

R569

R571

R573

R575

R556

C175 C178

C181

C180

C

P753

BE

GND

VCC VO

B

11

20

10

1

50

13

45

13

45

13

64

S

G

D

S

G

D

G

S

D

S

G

D

S

G

S

D

1

78

14

SSSG

DD D D

1

22

11

12

19

20 2

1

C8

C11

5

Q36

Q37

Q25

Q38

CN701

D682

CN353

Q46

Q21

D560

Q22

D561

Q23

Q24

P1

P4

Q681

D379

D380

D381

D382

D383

D681

Q54

Q55

Q45

Q58

Q59

D378

Q35

J681

D409

Q350

Q370

D415

D552

D554

D551

D553

D559

D555

D556

D557

D558

D591

D590

D589

D587

D588

D571

D572

D573

D574

D575

D576

D577 D578

D579 D580

D581

D582

D583

D584

D585

D586

S553

S552

S559

S560

S551

S554

S555

S556

S557

S558

Q454

Q455

W801

J1

IC804

IC356

IC806

IC805

IC807

IC551

X15 B/2

X15-110x-xx

Ref. No. Address Ref. No. Address

IC9 4D Q54 5G

IC351 2D Q55 4G

IC356 3G Q58 6G

IC358 3D Q59 5F

IC361 3B Q76 3E

IC551 6H Q77 4E

IC651 6D Q78 3D

IC652 6D Q79 3E

IC702 6E Q80 6B

IC703 5D Q350 3G

IC704 5D Q361 6B

IC705 5E Q362 6B

IC804 7F Q370 3G

IC805 6F Q371 6C

IC806 6F Q372 6C

IC807 6F Q373 6C

IC851 7C Q451 4D

Q21 3F Q452 4D

Q22 3F Q453 3D

Q23 3E Q454 3F

Q24 3F Q455 3F

Q25 3F Q651 6D

Q35 4G Q652 6D

Q36 4G Q653 6D

Q37 4G Q654 6C

Q38 4G Q655 6C

Q39 3E Q681 3G

Q45 3G Q683 6C

Q46 3G

22

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

KLMNO

1

2

3

4

5

6

7

PC BOARD (FOIL SIDE VIEW)

R854

R855

L704

C6

C9

C10

R33 R38

C27

R74

R76

R79

R856

R863

R474

R865

C31

C21

R58

R32

R54

R59

L706

L701

C701

C707

C709

C710

C712

C713

C714

C716

C718

C720

C202

R864

R1

R7

C197

R25

TH351

R866

C22

R772

C106 C107

R139

R135

C53

C54

R104

C50 R99

C66

C68

R114

C104

R133

C105 R134

C119

C121

R147

C708

C711

C715

C717

C719

C16

R28

R29

R31

C52

R98

R106

R40

C602

R202

R203

R823

R826

R729

C627

C43

C621

C622

C623

C624

C628

R765

R720

R718

R723

C428

C429

C432

R727

R470

R725

C1

C2

C3

C4

C5

C7

C13

C14

C29

R3

R4

R9

R10

R12

R15

R18

R26

R30

R35

R41

R42

R43

R44

R45

R56

R57

R75 R78

C195

C199

C200

R719

R715

R730

R257

R724

R716

R726

R721

R728

R717

R722

C35

C36

C37

C38

C39

C40

C41

C48

C57

C60

C91

C92

C93

C94

C95

C96

C97

C103

C110

C113

R88

R89

R91

R92

R94

R100 R101

R125

R124

R127

R128

R130

C360

R35

C629

C807

R612

R613

C811

C12

C44

C45

C46

C49

C51

C56

C63

C99

C100

C101

C109 C116

C812

C433

C434

C435

C815

C605

C606

C607

C

P

CP703

CP704

CP705

CP706

CP707

CP708

CP709

CP710

CP711

CP712

CP713

CP714

CP715

CP721

CP722

CP723

CP724

R2

R5

R6

R8

R11

R13

R14

R16

R17

R19 R20

R27

R34

R36

R37

R39 R55 R60

R77

R90

R93

R95

R102

R103

R105

R107

R108

R109

R110

R111

R129

R126

R136

R137

R138

R140

R141

R142

R143

R144

C817

C820

C821

C824

C833

R261

C808

C809

R859

R471

R472

R476

C813

C814

R773

R860

R857

R858

R614

R861

R201

R776

C816

R713

R711

R734

R732

R735

R712

R733

R710

C818

C819

R805

R806

C822

C823

C825

C830

C840

R810

R811

R825

C551

R586

R585

R584

R583

R582

R559

L806

CP754

R

R714

C733

C734

1

2

11

10

IOG

BE

EB

1

1415

28

GIO

1

64

16

17

12

34

129

64

65

128

1

14

15

28

97

128

96 65

321

64

33

BE

85

41

TP559

TP553

TP557

TP555

TP560

TP554

TP556

TP551

TP558

D5

Q4

Q5

Q14

Q16

Q41Q42

Q44

Q43

Q27

Q18

Q30

Q6

Q19

Q12 Q13

Q28

Q9

Q11

Q17

D1

D3

D4

D7D9

D11

D12

Q72

Q26

Q40

Q71

Q2

Q1Q3

D801

D802

Q7

Q15

Q20

Q29

Q52

D2

D6

D8

D13

D15 D16

D17 D18

D352

Q8

Q

D42

D592

Q82

CN551

Q51

Q53

Q56

Q57

IC1

IC701

IC10

IC4

IC3

IC2

IC12

IC801

VIDEO CONTROL UNIT

X15-110x-xx A/2

(J76-0505-12)

X15 B/2

BE BE

BE

EB

EB EB

EB

BE

EB

BE

EB

BE

EB

E

B

23

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

TSRQP

1

2

3

4

5

6

7

R681

R687

L705

C446

R474

R867

L706

R868

R869

R870

R871

C706

C707

C709

C723

C725

R872

R873

R874

R875

R876

R877

R878

R879

R880

L353

L356

TH351

R698

C427

R920

L601

L602

C387

C430

C144

C145

C146

C147

C148

C149

C708

C721

C724

C722 C728

C182

R196

C404

C405

C441

C391

C601

C602

C603

R852

C692

R699

R919

R743

C627

C630

C626

C638

C621

C622

C623

C624

C625

C628

C631

C632

C633

C634

C637

C363 C364

C368 C369

C373

C374

R759

2

C447

R742

R352

R360 R363

R369 R372

R378

R381

R739

R708

C29

C201

R75

R78

R915

C167

C168

C169

C170

C171

C172

C195

C199

C200

C409

C705

C726 C727

R176R179R182

R257

R740

R690

R747

R744

R754

R745

R756

R746

R755

R707

C361

C366

C371

C166

R545

R546

R547

C165

C351

C360

R357

C629

C636

R463

R464

R465

R466

R706

R612

R613

R620

R621

R622

R623

R624

R625

R627

C357

C358

C354

C355

C362

C365

C367

C370

C372

C375

C386

C388

C410

C417

C418

C419

C433

C434

C435

C436

C437

C438

C439

C440

C448

C449

C635

C604

C605

C606

C607

CP701

CP702

CP703

CP704

R172

R174

R175

R177

R178

R180

R181

R198

R277

R351

R353

R355

R356

R358

R359

R365

R366

R367

R368

R374

R375

R376

R377

R383

R384

R851

R887

R407

R408

R409

R410

R413

R416

R417

R440

R441

R442

R443

R444

R445

R446

R447 R448

R449

R450

R451

R455

R456

R457

R458

R459

R460

R461

R462

R467

R468

R469

R471

R472

R476

R478

R486

R487

L603

R614

R626

R881

R758

R704

R703

R750

R738

R688

R751

R749

R684

R748

R685

R736

R683

R737

R709

R710

R753

R752

R686

R696

X701

R697

R886

C381

C382

R195

R777

C729

C730

C693

R900

3

4

54

31

13

45

1

3

6

4

1

78

14

1

34

5

13 54

4531

GIO

1

64 49

16

3217

48

33

12

34

13

45

71

148

17

148

1

34

5

18

169

43

15

192

193

1

256

EBEB

BEBEBE

BE

D364

Q60Q62Q64

Q66

Q68

Q351

Q353

Q354

Q356

Q357

Q360

Q61Q63Q65

Q67 Q69

Q352

Q355

Q358

Q40

D33

D39

D40

Q359

D353

D354

D357

D358

D361 D362

D403

D389

D390

D391

D392

D397

D398

D399

D400

D414

D402

D393

D410

D351

D352

D355

D356

D359

D360

D363

D404

D405

D406

D407

D408

Q75

Q73

Q74

D388

D394

D395

D411

D412

IC357

IC354

IC8

IC701

IC7

IC5

IC6

IC355

IC601

IC602

IC691

IC13

IC12

IC692

IC401

IC402

EB

BE

EB

BE

EBEBEB

Refer to the schematic diagram for the

values of resistors and capacitors.

X15-110x-xx

Ref. No. Address Ref. No. Address

IC1 3N Q26 3N

IC2 3O Q27 3O

IC3 4N Q28 3N

IC4 5N Q29 3O

IC5 3R Q30 3O

IC6 4R Q40 2O

IC7 4Q Q41 2O

IC8 6R Q42 2O

IC10 4O Q43 3O

IC12 4O Q44 3O

IC13 5P Q51 5N

IC354 3R Q52 5N

IC355 6Q Q53 4M

IC357 3P Q56 6N

IC401 4P Q57 5M

IC402 4P Q60 4Q

IC601 4P Q61 4Q

IC602 5P Q62 4Q

IC691 5P Q63 4Q

IC692 5P Q64 4Q

IC701 6O Q65 4Q

IC801 6N Q66 6Q

Q1 3N Q67 7Q

Q2 3N Q68 6Q

Q3 3N Q69 7Q

Q4 3N Q71 3O

Q5 4N Q72 3O

Q6 4N Q73 4P

Q7 4M Q74 4P

Q8 3M Q75 4P

Q9 4M Q82 4O

Q11 3M Q351 2Q

Q12 4N Q352 2Q

Q13 4N Q353 2Q

Q14 4N Q354 2Q

Q15 4N Q355 2R

Q16 4N Q356 2R

Q17 3N Q357 2R

Q18 4N Q358 2R

Q19 4N Q359 3R

Q20 3N Q360 2R

24

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Refer to the schematic diagram for the values of resistors and capacitors.

UVWXY

1

2

3

4

5

6

7

PC BOARD (COMPONENT SIDE VIEW)

C2

C23

C24

F1

R10

C9

C11

C504

C501

C12

C14

C17

C502 L501

C8

C13

C22

C25

R6

R12

R14

R18

R22

R501

C200

C353

C351

C345

C307

C309

C310

C314

C360

C18

C28

C3

C361

C362

C363

C364

C16

C365

C313

C312

C311

R110

R113

C6

R114

C107

C145

C202

C205

C223

L105

L200

L106

L308 R

G

B

R21

R24

R9

R23

L303

L302

L104

R108

R109

R204

R15

R346

R350

R310

R312

R212

R311

R209

R210

C108

C101

C115

C302

C102

C352

2.5V

3.3V

C350

C134

C303

C118

C110

C301

C103

C130

C133

C135

C322

C340

C341

C203

C206

C317

C338

C318

C325 C326

C323

C333

C334

C343

L300

L100

R355

R347

R348

R349

R111

R354

C116

L101

L102

L103

R214

R215

C132

R105

L309

L310

L306

L307

C109

C300

C304

C114

F100

C104

C150

C151

C112

C113

C306

C315

C329

C330

C331

C357

R102

R104

R206

C327

C328

R375

C100 C140

C204

L314

X300

R101 R103

R371

R368

R216

R372

R366

R313

R373

R303

R336

R202

R201

R376

R208

R207

BE

50

261

1

BCE

BEC

BCE

CBE

14

10 1

20

11

119

41

8

5

128 103

102

65

6439

1

38

54

31

15

610

D7

Q5

CN502

D4

D5

D8

Q4

Q502

Q503

D6

CN501

Q102

D10

Q101

CN503

D104

D103

D101

CN104

D300

D302

Q202

Q200

D102

IC1

IC304

IC101

IC200

IC300

VR200

X35 B/2 VIDEO UNIT X35-4960-10 A/2 (J76-0519-12)

X35-4960-10

Ref. No. Address

IC1 4V

IC101 4W

IC200 2Y

IC300 3W

IC304 3X

Q4 4V

Q5 4V

Q101 5X

Q102 4X

Q200 2W

Q202 2W

Q502 3V

Q503 3V

25

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Refer to the schematic diagram for the values of resistors and capacitors.

ADACABAAZ

1

2

3

4

5

6

7

PC BOARD (FOIL SIDE VIEW)

BE

R453

C1

C401

OPEN/

CLOSE

SCREEN

FNC

SRC

NAVI

R1

R8

R3

R13

R17

R7

R11

R16

C506

C505

C503

C106

L1

R502

C122

C355 C319

C320

C321

C21

C5

C7

R457

C15

C344

C342

R112

R504

R505

R506

R503 R405

R225

C224

C225

C129

R454

R5

R404

L304

R402

R403

R205

R309

R343

R382

R342

R4

R341

C339

C221

C105

C120

C354

C316

C335

C337

C332

C336

C119

C121

C356

R406

R353

R358

C500

R100

R380

R222

R223

R224

C131

L305

L311

L312

R118

C117

C349

C346

C347 C222

C308

C324

C348

R119

R221

R356

R357

R344

R302

R352

R367

R301

R370

R351

R306

R369

R345

R314

R220

C507

R458

R455

R456

R441

BE

14

168

BCE

ECB

150

58

41

14

58

13

54

DDDD DDD

15

76

D

S

GSG

S

GSG

2

1

D1

D451

D2

D11

Q2 Q3

Q1

D9

D401

D501

D502

D503

D504

S401 S402 S403 S404 S405

D409

D410

D507

D505

D452

D453

D411

CN1

D506

D12 Q501

D3

CN302

Q203

CN101

CN102

D308

P100

CN103

IC302

IC102

IC103

X35 B/2

VIDEO UNIT X35-4960-10 A/2

(J76-0519-12)

-12V

+18V

MECHA+3.3V

3.3V

TP+3.3V

DGND

STVL

+12.5V

HD

VCOM

OEV

STHR

OEH

VD COMP

L/R

STVR

-6V

HD

CKV

VD

CPH-

STHL

X35-4960-10

Ref. No. Address

IC102 4AB

IC103 4AB

IC302 3AA

Q1 4AC

Q2 4AC

Q3 4AC

Q203 2AA

Q501 3AC

26

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Refer to the schematic diagram for the values of resistors and capacitors.

AE AF AG AH AI

1

2

3

4

5

6

7

PC BOARD (COMPONENT SIDE VIEW)

DVD UNIT X37-1100-03 (J76-0160-22)

Q15

CN1

Q18

D5 D6

Q5

Q6

Q19

Q12

Q13

Q14

S1

Q16

Q17

IC9

IC1

IC12

IC7

IC8

IC3

1

R283

R279

C101

C453

C21

C202

C222

C227

C437

L3

R278

R152 R153

R160

R166

R256

C104

R284

C100

C84

C103

R64

R65

R81

CP11

R201

R202

L2

C10

C23

C73

C90

C99

R113

C120

C121

C150

C151

C153

C207 C208

C210

C212

C213

C214

C215

C216

C217

C218

C219

C221

C223

C224

C436

R52

R56

R83

R84

R154

R155

R162 R163

R169

R257

C12

C13

C50

C55

C62

C63

C64

C220

C435

C451

R8

R9

R13

R19

R50

R51

R89

R90

R91

R92

R101

R150

R151

R158

R159

R164

R165

R167

R168

R200

R255

R266

R265

R18

R26

R27

R28 R29

R271

C445

BE

G

DD

SGS

BE BE

5

2

43

5

12

2536

37

48 13

24

25 48

3

54

1

30

G

D

S

EBEB

PPO

CD ON

DVD ON

FEO

TEO

IOP+

X37-1100-03

Ref. No. Address

IC1 3AH

IC3 3AI

IC7 2AG

IC8 2AF

IC9 2AI

IC12 4AG

Q5 4AG

Q6 4AG

Q12 4AH

Q13 4AH

Q14 3AG

Q15 2AG

Q18 2AF

Q19 2AF

27

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Refer to the schematic diagram for the values of resistors and capacitors.

ANAMALAKAJ

1

2

3

4

5

6

7

PC BOARD (FOIL SIDE VIEW)

P2

CN3

Q1

Q2

D8

Q3

Q4

P8

P6

P7

CN2 P1

D1

S2

IC5

IC4

IC11

IC10

DVD UNIT X37-1100-03 (J76-0160-22)

1

28

1

L6

C442

C443

C444 R280

R268

R258

R263

R262

R7

C9

R86 C83

C92

C86

C22

C51

C60

C61

R102

C78

C82

C94

C74

C75

C76

C77

C79

C80

C81

C85

C93

C5

R11

R31

R59

R85

R105

R120

R254

L4

L5

C19

C20

C3

C14

C15

C16

C18

C434

C438

C439

C440

C441

R1 R16

R281

R24

C17

C52

C53

C57

C58

C68

C96

C97

C143

C144

C152

C225

CP2

CP3

CP4

R60

R63

R96

R122

R259

C446

X1

C4

C447

C6

C7 C8

C11

C54

C56

C65

C66

C67

C69

C70

C71

C72

C95

CP5 CP6 CP7 CP8

CP9

CP10

L1

R3

R4

R275

R273

R10

R17

R21

R22

R23

R53

R54

R55

R57

R58

R87

R88

R97

R98

R99

R100

R121

R123 R124

R125

R126

R203

R270

R267

R261

R260

R282

C452

C448

C449

C450

R5

R6

R272

R274

BEEB

BE BE

176 133

132

45 88

89

44

48 37

2413

12 25

36

4

58

2

43

50

1

K

A5V

DGND

1.5V

D3.3V

PGND

AGND

DGND

U

V

W

A-

A+

B-

B+

ARF

NARF

D

C

A

E

F

IOP

D5V

P5V

VREF2

VHALF

AS

VREF1

PGND

P5V

TEST

PPI

HFM

DRAM 1.5V

A3.3

P6

LO.MUTE

FG

SPD

SLD2

SLD1

TRD

LOAD

DRV

1.65V

BMS

DRMU

LOAD-

LOAD+

H-

H+

U+ U-

LMIN

SW LOST

SW EJEND

BDO

FTR

FBAL

JLINE

T-

F+

T+

F-

RFP

PLFLT1

FE

FE1

DVD LD

MD

RXD

TXD

MON0

MON1

MON2

MON3

RFDIF0

NRST

SCLOCK

SD ATA

MON4

MON5

FE2

SEN

SCK

STDI

SDA

SCL

WBLIN

TEI

OFS

TE

RFENV

JITOUT

CD LD

LOEND

P7

B

FOD

X37-1100-03

Ref. No. Address

IC4 3AK

IC5 4AJ

IC10 6AK

IC11 2AJ

Q1 6AK

Q2 6AJ

Q3 7AK

Q4 6AJ

28

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

J681

USB

CN701

CN2

CN502

J1

CN302

NAVI

W351

FM/AM

CN104

CN501CN1

CN503

CN101

CN3

CN103CN102 CN356 CN357 CN4

CN551

AV IN

AV OUT

CAMERA

REAR VIEW

REAR/SUB-

WOOFER

FRONT

CN351 CN2

CN355

CN352 CN354

TV

CN353

W801

SAT IF

ANT

IF

SPD

FAN

iPod

AUDIO IN

(E30-6817)

RR+

RL-

FR+

RR-

FL-

FL+

FR-

RL+

P.CON

ACC

B31

42

57

68

A3

4

1

2

B.U

5

6

7

8

GND

BLU/WHT

RED

BLK

MUTE

BRN

YEL

ANT CONT

WHT/BLK

BLU/WHT

GRY/BLK

P CONT

FR+

FR-

FL-

GRY

FL+ WHT

GRN/BLK

VIOL

VIOL/BLK

RR+

RL-

RR-

GRN RL+

ORG/WHT

MUTE

BLK

GND

16

1

YEL

RED

BLU/WHT

BLU

GRY

GRY/BLK

WHT/BLK

WHT

FRONT R

P. CON

ANT CONT

ACC

FRONT L

REAR R

VIOL

ORG/WHT

14 15

32

BRN

12 13

54

ILLUMI

VIOL/BLK

GRN/BLK

1011 7 689

GRN

REAR L

BU

15A

150

150 12

11

22

1

FFC

(E39-0999)

(J86-0038-15)

FPC

201817 19 2221

VIO/WHT

LGRN PRK SW

REVERSE

LBLU REMO CONT

18

511 10 9

12 13 14

87 6

15 16 17 22

342

2019 21

1

VIO/WHT

LGRN

REVERSE

PRK SW

LBLU REMO CONT

15A

50 1

191

1412241

(E30-6775)

41

68

(J86-0052-05)

FPC

1

168

(E39-0665-05)

FPC

1441 18151111

111

(E39-1000)

FFC

191

202

(E30-6813)

21

15 201 201

WH

(E30-6818)

(E30-6812)

WH

201

WH

(E30-6814)

15

(E30-6778)

WH

BLACK

YELLOW

DC CORD

(X35- ) (B/2)

(X37-1100-03)

DVD UNIT

(X92-6160-00)

DVS-8020V

DVD MECHA

(S79-0858-05)

TOUCH PANEL

(B38-1196-05)

LCD PANEL

W02-5121

SWITCH ASSY WH (E30-6815)

K,M,R,X TYPE

DC CORD

WH (E30-6816)

E TYPE

(X35-4960-10) (A/2)

VIDEO UNIT

(A10-5171-51)

CHASSIS ASSY

(X15-110X-XX) (A/2)

(X86-403)

(X15- ) (B/2)

VIDEO CONTROL UNIT

SW UNIT

FM/AM FRONT-END

INTERCONNECTION DIAGRAM

29

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (1/11)

Q53

Q51

D16 D15

Q55

Q54

Q57

Q56

D18 D17

Q59

Q58

Q52

Q5

Q1

D5

Q6 Q7

J1

Q2

D2

to DC CORD

Q4

D3

Q3

D6

D8

D7

Q9

D9

Q8

D

CN3

D1

D4

∗ A

CN2

P1 P2 P4 P5

D11

Q11

D12

D13

P-CON

ANT-

CON

MECHA7.5V

DC/DC CONVERTER

5V

3.3V

FAN

R89

R92

220P

C40

C41

0.047

33K

R93

5.6K

0.01

C46

0

680

68K

47P

R99

C39

C38

R91

C35

R94

R102

R103

C45

0

0.022

100P

33K

0.01

C44

100P

10K

1000P

R88 R90

6.2K

220P

C37

0

R98

33K

C48

C36 0.047

R117

0.047

R118

0.047

R119

0.033

120u10

10uH C80 0.01

PLLFLTR R109

0.1

R104

0

BG1

VIN

PGND

INTVCC

EXTVCC

RUN/SS2

TG2

BOOST2

SW2

BG2

ITH2

OUT3.3V

VOSENSE2

SENSE2-

SENSE2+

1000P

C50 14

10

12

11

13

R107

0

PLLIN

FCB

ITH1

SGND

8

9

6

7

R110

19

15

16

17

18 0

22

R111

C63

0.1

C53

20

21

10

C54

24

23

22

0

C57

C60

10

0.1

C58

1000P

C67

1000P

C64

0.1

C61

0.01

10

R113

10uH

C68

2.2

C66

R114

10

0.1

C73

0.1

C70

0.01

L7

C72

0.1

C69

0.01

C78

C178 10

10

R116

220u6.3

1000P

C74

C76

1000P

C84 0.1

C85 0.01

C83

68u25

C81 0.1

68u25

C82

C88 0.01

C90 0.1

C87 0.01

C89 0.1

0.1

PGOOD

TG1

SW1

BOOST1

SENSE1-

VOSENSE1

SENSE1+

RUN/SS1

1000P

C49

3

4

5

2

1

R105 560

27 22

26

25

28 R108

C56

C55

C65

1000P

C62

L6

0.1

0.01

C59

10

R112

C175 10

C75

1000P

C71

C77

R115

10

TP39

0

R281 SW5V

TP38

R121

0MCHA7.5V

SW14V

C51 2200P

560

R100

C52 2200P

R106 560R101

560

R123

0D5V

V5V

180

BG2

47P 0

33K

C97

C96

0.047

220P

R134560

R125 R129

C101R128

68K 0.015

10K

0

C105 14

R139

SENSE2+

1000P

R140

0

RUN/SS2

SENSE2-

VOSENSE2

OUT3.3V

13

11

12

10

ITH2

SW2

BOOST2

TG2 22

15

0

18

17

16 R144

C116

0.1

C99R130 1000P

C95 R137

C100

68K

R127

47P

0.022

0

C91

C94 R136

10K

100P

0.01

C103

33K

R133

680

C93

220P

5.6K

R126R124

C92 0.1

SGND

9

8ITH1

INTVCC

PGND

PLLIN

7

6

FCB

VIN

BG1

EXTVCC 21

C110

R143

19

C107

C106

10

20

0.1

C113

0.1

10

23

0

22

24

C119

2.2

C104 TG1

SENSE1+

VOSENSE1

SENSE1-

PLLFLTR

2

5

4

3

1000P

BOOST1

SW1

RUN/SS1

1PGOOD

R142

25

26

C109

0.1

R141

28

22

27

C139 2.2 220u6.3

10uH

C117

C120

1000P

C114

C111

0.01

R146

10

0.1

10

R149

0.022

R153

1000P

C127

C129

1000P

R157

D3.3V

0

TP41

R156

0

SW3.3V

180

V3.3V

R147

C138 0.01

C137 0.1

C135

C134 0.1

68u25

C136 68u25

0.1

C123

SW14V

C126

L11

0.01

0.1

C122

C121

0.1

10

C125

0.01

C143 0.1

C141 0.01

C131

C142 0.1

C140 0.01

C133 0.01

C180 10

C115

C118

1000P

L10

10uH

C112

C108

0.01

R145

10

0.1

C128

C124

1000P

220u6.3

C130

10

R148

0.022

R150 USB5V

R154

0

TP40

R155

0P5V

R95

11K

0

R135

0

R138

TP45

L9 10uH

PGND

0

TP24

R13 1K

1/2W

R11 22K

C3

1

C1

1

R1

10K

R4

47K

C4

R7

100K

1

C12

0.1

C10

1

10K

TP18 PCON

FR+

RR+

RL-

FL+

RL+

RR-

FL-

FR-

R2

2.7K

1K

R3

R5

TP8 FR+

RR+

FL-

RR-

FR-

FL+

RL+

RL-

TP2

TP1

TP5

TP3

TP4

TP7

TP6

12

11

13

10 9

14

ANT

NC

LMUTE

REMO

NC

PRKING

REVERSE

NC

TP12

TP11

TP9

TP10

TP13

TP16

TP17

TP14

TP15

17

16

15

86

7

18

5

19

4

2.7K

1K

R6

R8

R9

1K R12 1K

1/2W

R10 4.7K

3.3

∗R14

ILLUMI

BU

ACC

GND

TP19

TP20

TP22 TP21

C7

0.01

C6

0.01

21

2

20

31

22

2200u16

R16

2.2K

R18

10K

10K 1/2W

TP36

TV GND

BASE

RIGHT

R19 1K

R20 1KR17

1/2W

LEFT

DGND

BUGND

AGND

VGND

ESDGND

MGND

RIGHTCENTER

PGND

LEFT

PWIC GND

TUN GND R21

0

SAT GND

BL GND

TP42

TP43

TP44

C150 0.1

C151 0.01

TP54

TP49

TP47

TP55

TP48

TP46

TP58

TP50

TP56

TP53

TP52

TP51

16

BL

RI M+

5

4

3

2

1

EX M+

EX M-

1514

1312

11

10

9

8

7

6

1.6A

F2

RI M-

RI M+

SW A

NC

MECHA

Z SWT

SW C

SW B

R SENS

Z CNT

2

19

18

17

SW+14V

NC

BL GND

L4 10uH

L5 10uH

L8 10uH

C11

C8

2200u16

C2 0.01

113

114

C5 0.01

118

C9

R15

4.7K

116

117

110

35

109

108

111

+B

GND

12

REAR-

FRONT-

REAR-

FRONT-

C153 0.01

C156 0.1

C154 0.1

C157 0.01

C155 0.01

C152 0.1

7

5

3

1

73

72

71

70

99

100

+3.3V

R31

15K

TP27

R26 47K

C13 0.01

139

47K

R32

25

R30

9.1K

0.47

C14

R25

100K

R27

10K

6.2K

R28

6.2K

R29

BU

SW14V

SW3.3VSW3.3V

SW3.3V

SW5V

SW14V-1 SW14V-1

SW3.3V

L2

L3

C181 2.2

C203

1000P

VGND

+

IC3

IC4

(X15-110x-xx) (A/2)

0.9V

1.2V

0V

0.6V

0V

0.9V

5.1V

1.0V

5.1V

5.3V

0V

2.7V

5.5V

5.0V

3.3V

5.5V

5.1V

3.3V

5.0V

0.9V

1.2V

0V

0.6V

0V

0.8V

0.9V

3.3V

5.5V

44

10

1010

49 49 49

50

5050

51

ABCDE

1

2

3

4

5

6

7

30

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (2/11)

FGHIJ

D36

CN4

D35

D34

D40

D41

D39

D37

Q66

Q67

Q68

Q69

Q60

D19

D22

D23

D21

D20 D28

D31

D30

D29

D24

D25

D27

D32

D33

Q61

Q62

Q63

Q64

Q65

Q39

Q35

Q37

Q36

Q72

Q40

Q71

Q41

Q44

Q43

Q42

Q38

Q45

Q46

D14

Q13

Q21

Q25

Q22 Q24

Q23

Q28Q26

Q29

Q27

Q30

Q17

Q20

Q16

Q18

Q19

Q15

Q12

Q14

A/2-

CN101

2/2

X15-

B/2-

1/2 CN551

NOT USED

Q80

X35-

S.M-DRV T.M-DRV

3.3V

REG

5V

REG

SW14V

A8.5V

A5V

BE A5V

SI

REMO

BUFF

ROM CO

R

C185

10

C184

10

REMO

4

GND

1

KEY2

GND

3

2

TP100

TP99

10

LED G

7

SI

RESET

6

5

EJECT

LED R

9

8

NC

SW5V

11

TP105

TP104

TP103

TP102

TP101

TP106

TP108

TP107

R184 100

100

C173

0.1 100

R185R186 1K

L13

120

L12

120

C144 0.1

C146 10

C145 0.01

OUT2 OUT4

IN1

VCC

2

1

VS1

OUT1

5

4

3IN3

GND2 13

14

VS2

OUT3

10

11

12

GND1

IN2

7

6

VC

IN4 8

9

C147 0.1

C149 10

C148 0.01

MGND

OUT1

IN1

VCC

3

2

1

6OUT2

VS1

5

4

GND1

IN2

7

OUT3

IN3

GND2

12

13

14

9

OUT4

VS2 10

11

VC

IN4 8

DGND

TP75

TP73

TP66

TP70

TP61

TP62

TP58

TP72

TP63

TP65

TP74

TP64

TP71

TP68

TP67

TP60

TP59

TP69

6

BL GND

1.6A

F2

MECHA

27

2625

24

23

22

21

20

19

18

17

R162 100

R161 100

R160 100

R159 100

R166 100

R165 100

R164 100

R163 100

INV PWM

SW+14V

NC

BL GND

ENABLE

INV SW

X1

Y0

PWM

38

37

3635

34

3332

31

3029

28

R168 100

R167 100

VCOM

XD ATA

YD ATA

X0

LED B

KEY1

LED R

LED G

NC(VG)

NC(VR)

VGND

TP82

TP89

TP91

TP77

TP92

TP93

TP88

TP81

TP76

TP96

TP86

TP85

TP79

TP80

TP109

TP84

TP90

TP83

TP78

TP97

TP87

TP94

TP95

VGND

C162

ESDGND

0.1

49

48

47

46

4544

4342

41

40

39

C161

0.01

TC3.3V

VGND

NC(VB)

VMUTE

VGND

TC WAIT

TC RESET

HSY

TC SCL

TC SDA

6059

58

57

56

55

54

5352

51

50

R171 100

R170 100

VSY

G

B

NT PAL

VGND

R

NC(VD)

T P+5V

COMP

D GND

SOG

BL GND

68

67

6665

64

6362

61

DGND

NC

CLOSE

TC WP

LED GND

D GND

NC

P ON+5V

C164

0.01

R172

C167

220P

R175

47K

R174

2.7K

0.1

C168

111

77

75

78

79

R176

R

220P

R178

47K

R179

47K

4.3K

R177

C169

G

0.1

C170

220P

R181

47K

R182

47K

4.3K

R180

C171

B

0.1

C172

13

67

68

31

66

2

B

138

G

R

63

137

133

136

7

10

SDA

SCL

9

61

B

G

R

102

SOG

COMP

8

100

65

C163

0.1

OPEN/

(GPI01)

+3.3V

R183

107

106

C32

AGND

C26

0.47

C43

0.01

220

R73

R71

R68

220K

R70

10K

R69

82K

R72

2.7K

R79

OUTIN

R75

GND

4.7K

C28

R77

39K

C29

4.7

R76

33K

100u16

3.3K

R78

R74

27K

C27

1

TP110

10

C31

TP57

33K

C24

0.1

220K

TP37

100u16

C25

10uH

47K100K

R193R80

R81

47K

F1

5A

0.1

220K

R47

680K

R36

220K

R42

0

R37

R40 91K

0

51K

R35

220K

R41

68K

R39 R38

C19

R50

R53

160K

C15

0.1

30K

C16

10

C18

220u16

220K

R51

100

L1

R49

2K

220K

R48

300K

R46

150K

R52

TP35

4.7K

18K

R57

R56

43K 150K

R55

100u6.3

R60

560

C21

4.7

R54

100K

IN

GND

OUT

R59

1

C22

R58

0

TP111

220K

R45

R44

220K

TP34

R43

R33R34

100K33K

BU5V

BU3.3V

T P+5V

SIR SW14V

T P+5V

A8.5V

A5V

BE A5V

1

3

5

7

SW5V

R

G

B

DGND

NC

VOUT

C165

2

1

GND

3

CE

1

VDD

4

5

1

C166

1

GND

A2

A1

3

4

2A0

139

R188

100

35

25

123

MUTE

47K

R196

R195

C182

0.1

DGND

1

2

3

VCC 5

GND 4

0

R198

0

SW3.3V

SW5V

81

100

R187

82

BU

BUBU

BU

SW14V

SW5V

SW14V-1 SW14V-1

SW3

.

3V

MCHA7.5V

T P+5V

BU3.3V-1 BU5V-1

T P+5V

SW5V

SW3.3V SW3.3V

+

IC5 IC6

IC2

IC1

A

IC7

B

IC11

IC8

0V

0V 0V

0V

5.0V

0V

3.3V

5.0V9.0V

0V

5.0V

0V

1.3V

0V

13.8V

8

10

7

10

8

10

41

44

45

44 44

44

46

10

47

48

4848 48

49

4949

49

50

5050 50

51

31

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (3/11)

ONMLK

D42

Q82

Q74

Q75

Q73

Q76Q78 Q79

Q77

N

OT USED

SYSTEM u-COM

RESET

SET MEMO

ROM COR

C185

10

C184

10

1000P

∗R207

C183

R204

∗R206

R203 10K

C202 0.01

R202 10K

118

63

2

1

R277

100K NCVDD

C200

3

4

0.1

OUT VSS

R266

4.7K

C190

R235

R216 R224

10K

R257

R253

R252 47K

R251 47K

R250 47K

R248 10K

R247 10K

10K 100

0.1

R256

R255

100

R233 22K

R232 1K

R234 1K

R228 2.2K

R229 2.2K

EVOL SCL

PWIC DC DET

LINE MUTE

PWIC STBY

EVOL SDA

1

144

143

142

AVCC

VREF

C189

0.1

X DATA

141

140

139

138

AVSS

Y DATA

137

136

135

134

VCOM

NC

7

AVSW SCL

AVSW SDA

VSYNC DET

SIR PON

X1

4

3

2

6

5

TV SC CON

TV MC REQ

TV SC REQ

10 NC

NC

HSY

9

8

12

11

NC(SAT TX(LX DATA M))

NC((LX CLK))

NC(SAT RX(LX DATA S))

TUN SMET

NC(ST RST(LX))

NC(SAT CON(LX))

NC((LX REQ M))

126

130

133

132

131

KEY 1

VCC

VSS

129

128

127 R AFS H

R NOISE

122

125

124

123

TUN IFC

KEY 2

TYPE0

121

120

119 ILLUMI

11.059MHz

R261

100

R263

15K

C195

32.768kHz

C193

18P

X1

C194

22P

X2

R262

0

0.01

C196

R264

R265

0.1

0.01

3

4GND

A2

2A1

A0

1

6

SDA

SCL 5

WP

VCC 7

8

R268

R267 100

R282 1K

R24

0

R24

1

R

EVOL MUTE0

EVOL MUTEB

EVOL MUTEC

35

24

XCONT/P86

VCONT/XCIN/P87

CNVSS

BYTE

PWIC MUTE

INV PWM

15

14

13

18

17

16

XOUT

RESET

21

20

19

VCC

XIN

VSS

23

22

EJECT MUTE

R CLK

BU DET

ACC DET

NMI

26

25

NC

29

28

27

PRE MUTESW

BEEP

PRE MUTEF

PWM

32

NC

31

30

34

33

TV SC DATA

NAVI RX

POWER PWM

36

NAVI TX

TV MC DATA

VCC

37

38

39

TUN SDA

TV BP CLK

BUSY

VSS

40

41

42

43

TUN SCL

R DATA

R QUAL

44

45

46

47

C192

0.1

R

10

0

55

51

EVOL MUTE1

EVOL MUTE2

48

49

50

TV JUDGE

WRT E2P

AVSW PDN

52

53

54

59

VILL R

VILL G

VCC

VSS 56

57

58

VILL B

NT PAL

VMUTE

X0

60

61

62

R237

TP114 TP115

TP116 TP117

T

P

R

R215

R231 100

R230

100

R201 100K

R208 47K

R211 12K

R210 12K

R212 47K

ANT CON

PARKING

REVERSE

NC((LX MUTE))

P START

MCNT

114

117

116

115

P CON

SIR DET

113

112

111 PON

108

110

109 PGOOD

BE RESERVE1

102

103

104

105

106

107

NC

KEY ILL

BE SREQ

97

98

99

100

101

Z SENS

NC

VSY

DISC DET

NC

Z CNT

R213

100

DGND

OPEN CLOSE

74

85

BE MDATA

VCC 91

92

93

94

95

96

TYPE2

BE CON

BE MREQ

TYPE1

VSS

86

87

88

89

90

BE CLK

BE BUDET

BE INI

BE SDATA

SMOTOR M

SMOTOR P

TMOTOR M

TMOTOR P

BE RESERVE2

AM+B 80

81

82

83

84

BE RESET

BE STBY

SI

EJECT

75

76

77

78

79

VSS

C187

0.1

SW C

67

INV SW

VILL DET

Y0

64

65

66

BL ENA

Z SWT

NC

68

69

70

73

SW B

SW A

VCC

71

72

R236

R223 100K

R249 47K

R225

R227 47K

R219 100

R218 100

R217 100

R220

C188

0.1

R221

R222 47K

C197

0.01

18

GND

A2

A1 6

SDA

SCL 5

WP 7

3

4

2A0 VCC

C198

0.1

C199

100

47K

27

34

32

33

47K 100

47K

14

31

13

12

11

10

7

6

10K10K

5

100

R254

100

4

8

5

2

4

9

5

0

R23

8

186

184

106

107

108

102

100

99

185

188

47K

10K

100

R214

211

209

210

189

196

197

198

81

82

77

78

79

75

100

R10K

X 30K 10K

M 10K 10K

E3.3K 10K

K 10K

PULL-DOWN PULL-UP

TYPE0MODEL

KVT

R205

10K

109

110

111

113

114

116

117

118

123

124

125

126

C186 0.1

127

133

136

137

138

139

100

R245

3GND

1

2

4

5

VCC

73

RST

135

R260

∗R259

R258

R246

2

SDA

SCL

SDA

SCL

RST

BU3.3V-1

BU3.3V-1 BU3.3V-1BU3.3V-1

BU5V-1

BU5V-1 BU5V-1 BU5

V

BU5V-1

SW3.3V

SW5V

47K

REMO

R279 47K

R278

47K

R288

10K

R286

29

IC12

IC10

IC9

IC13

IC11 5.0V

0V

5.0V

0V

5.0V

32.768kHz

11.0592MHz

0V

5.0V

0V

3.3V

3.2V

0V

2.7V

3.3V

0V

0V 3.3V

1.5V

2.3V

0V

5.0V

0V

3.3V

5.0V

3.3V

0

V

3.1V

5.0V

66

777

10

810

8

44

333

3

22

414141

41

1

42

43 43

44

45 46

46

45 45

47 47

4848

48

49

50

32

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (4/11)

PQRST

D415

D378

CN353

D382

D381

D380

D383 D409

D379

Q350

Q370

D384

CN351

D353

MUTE

Q352

D356

PRE-

D355

Q353

Q351

D354 D358 D357

Q355

D360 D359

MUTE

PRE-

Q354

Q356

PREOUT-FRONT

PREOUT-REAR

SATELITE TV-TUNER

RDS DECODER

CN357

Q361

Q362

CN356

ANT.

W351

∗ B

FM/AM F/E

3.3V 5V

Q455

Q454

Q372Q373

D368

Q371

TUNER MUTE

63

R283

R240 100

R241 100

R270 4.7K

R269 47K

R284 100K

R271 4.7K

0

B

C

A

X

A

C

37

38

39

A

K

Y

S

40

41

42

43

L

A

L

44

45

46

47

R242

C192

0.1

R239 100

100

55

51

E

1

2

48

49

50

E

P

N

52

53

54

59

R

G

C

S

56

57

58

B

L

E

X

0

60

61

62

R237 100

C191

0.1

R272 47K

47K

R273 47K

TP113

R275

TP118

47K

R276

R244 470

R243 470

C201

0.1

E

C

67

W

T

Y

0

64

65

66

A

T

C

68

69

70

B

71

72

R236

72

70

71

68

67

66

65

63

61

100 47K

B

G

R

R274

48

52

49

50

47

46

R238

45

44

42

40

100

38

RX

TX

1.5K

47K

141

3GND

1

2

4

5

VCC

55

MUTE

REMO

SW3.3V

SW5V

53

R479 4.7K

GND

EXTRES

RDCL

T57

OSCOUT

OSCIN

16

VS

15

14

13

12

RDDA

QUAL 1

VREF

MPX

OSEL

2

3

4

5

C410 330P

R416 2.2K

TP437

C407

C406

4.332MHz

DGND

4.7uH

C404

L356

C405

FSEL

TM

11

10

9

NU

FILOUT

6

7

8

X351

R413

2.2K

C409 10

R417

2.2K

GND

TP390

TP389

TP388

TP387

NC

8

SAT BU

2

1

GND

5

GND

4

3

NC

GND

7

6

SAT G

SGND

SAT L

SGND

SAT TX

SAT RX

SAT CON

RST/EN

1411

10

9

NC

1312

NC

16

15 1918

17

GND

DGND

R425

100

0.1

C414

SAT R

20

TP384

TP385

R418

10

4.7

TP386 R420

10

C411

1

C413

1

ESD

BU

1

GND

BU

4

3

2

B

G

R

7

6

5

TV GND

TP391

TP393

TP392

R428

1

JUDGE

MREQ

MD ATA

SREQ

SD ATA

VGND

COMP

1310

9

812

11 16

CON

CLK

1514

AL

RST

18

17

TP402

TP395

TP394

TP397

TP396

TP398

TP399

TP400

TP401

TP404

TP403

TP406

TP405

TP407

R426

100

R427

100

L357

120

R473

10K

R475

10K

R477

10K

C417 0.47

R447 10

TP429

TP350

TP425

TP424

TP423

TP426

TP427

TP428

RR

6

F AGND

FR

FL

3

2

1

RL

F AGND

5

4

AOUT GND

AIN R

9

R AGND

8

7

AOUT R

1

10

470

R359

R366

470

32

P-FL

P-FR

C362

C365

10

1000P1000P

C363 C364

R358

100

22K

R363R360

22K

R365

100

AGND

ESDGND

C361

0.1

R375

R368

470

P-RL C367

10

34

PRR

C370

ESDGND

22K

R369

C368

1000P

AGND

100

R367

C369

1000P

R374

R372

22K

C366

0.1

6

7GND 8

4

5

3

11

9

10

12

VCC

1

2

14

13

TX

CON

RST

RX

R421 100

R422 1K

R424 4.7K

R423 100

ESD

SAT

R419 C412

SAT-R

SAT-G

SAT-L

R439

R438

GND

R442 100

R441 1K

R440 1K

R444 100

R443 100

R448 1K

R446 1K

R445 0

R449 10

R450 4.7 C418 0.47

40

10

38

11

42

12

53

RST

TV-L

75

100

10

47

46

7P

27

0.01

10

R

15

SMETER

RDSOUT

DGND2

PLLGND

COM+B

DGND

VDD5V

AMIFOUT

QUALITY

RDSMUTE

STDGND

ANT

NC

RFGND

AM+B

OSCGND

TP375

TP381

TP382

TP383

TP380

123

TUN GND

0.01

TP376

TP379

TP377

TP378

VT

45

C392

R411

1K

0.01

TP373

TP374

TP372

7

IFC

12

SDA

SCL

3456

C391

TP371

TP370

TP368

TP369

8910 11 12 13 14

IFGND

0.01

TP367

TP366

L

IF+B

16 17 18

C390

3

2

1

L355

4.7uH

L353

4.7uH

124

44

45

125

126

127

TUN-L

TUN-R

22K

R412

A8.5V

SW5V

27,29,46,47

51

61

SW5V

SIR SW14V

BU

BU5V

241

DET

B

U3.3V-1

BU3.3V-1

BU5V-1

BU5V-1BU5V-1

SW5V

A8.5V

BU5V

R280

SW5V

R288

10K

R286

C397

0.1

C359

1000P

10K

R483

3GND 4

5

VCC

2

1

VCC

2

GND

3

1

4

5SW5V

0.1

C430

DGND

0.1

C427

D5V

R370

47K

R364

47K

470

R354

4.7

C384

R361

470

C431

4.7

AGND

29

BU5V

IC355

IC356

IC402IC401

0V

3.3V

3.2V

0V

2.7V

0V

5.0V

0V

5.0V

2.5V

2.4V

4.332MHz

5.0V

0V

3.3V

0V

V

5.0V

1

2

3

5

4

1

14

7

6

67

7

6

7

6

11

1414

10

810

8

10

8

10

8

10

8

10

8

7

5

4

5

4

1

3

1

2

3

2

13

2

1

38

40

41

4242 42

42

4343

43

44

45

33

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (5/11)

YXWVU

D392

CN354

D411

D412

D394

D395

D406

D408

D407

D389

D390

D391

D388

D393

D410

D405

D404

Q359

D352

D351

D365

D367

D366

D369

CN352

D373

D374

D375

D376

D372

D371

D370

POWER

IC

D357

MUTE

PRE-

Q356

D362 D361

Q358

D364 D363

MUTE

A-

Q357

Q360

AUDIO-OUT

AUDIO-IN

VIDEO-IN

VIDEO-OUT

E-VOL

iPod

FRONT

AV OUT

FRONT

REAR/SAB

WOOFER

CAMERA

REAR VIEW

∗ D

ISO

ESDGND

6

AG

19

JUDGE

16

AL

RST

18

17

TP404

TP406

TP405

TP407

TP408

DCERR

WINTC1

WINTC0

WININ

MUXCR

MUXCL

MUXBR

MUXBL

MUXAR

MUXAL

AUXR

R474 10K

C432

1

R471 1K

14

C429 3.3

C428 3.3

R472

R470

100K

10K

16

15

10

13

12

11

9

8

7

R478 100

R476 100

C440

1

C441

TP421

TP422

VOLINR

21 SACLK

SCL

SDA

SEL

18

17

20

19

VOLINL

REF5V5

SAIN

SAOUT

SARES

23

22

26

25

24

ACOUTR

ACOUTL

MUTE2

MUTE1

MUTE0

REF3V3

29

28

27

32

31

30

L

D

C417 0.47

R447 10

C352

TAB2

PWGND4

MUTE

VCC2

PWGND3

ACGND

IN4

IN2

SVR

PWGND2

VCC1

STBY

PWGND1

TAB1

27

1

5

3

9

7

13

11

15

17

19

21

25

23

PWIC GND

HSD

10

OUT1-

OUT2+

OUT2-

OFFDET 2

4

8

6

RR-

RR+

FR-

18

SGND

OUT1+

14

IN1 12

IN3 16

OUT4-

OUT4+

OUT3-

OUT3+

22

20

26

24

FR+

RL+

FL-

FL+

RL-

1

R351

33K

C351

TP352

TP351

AUXCOM

AUXL

CDCHR

CDCHCOM

CDCHL

2

5

4

3

1

PAOUT0L 55

56

57

58

59

60

61

62

63

64

MDR

CDL

CDR

MDL

MUTEA

TUNERL

TUNERR

MUTEC

MUTEB

TP420

49

50

51

52

53

54

L

D

L

LDOUT0R

PAOUT1R

PAOUT1L

PAOUT0R

LDOUT0L

VP

DGND

AOUT GND

12

TP429

C358

C357

C354

33u25

C381

R353

4.3K

R352

10 1

11

1

TP355

TP353

TP359

TH351

TP360

R355 22K

C360

R357 12K

R356 220

TP356

TP354

1

C353

TP358

1

C356

1

C380

1

C383

470

TP427

TP428

AOUT GND

AIN R

9

R AGND

R

AGND

8

7

AOUT R

11

10

TP430

TP432

TP431

TP434

TP433

TP436

TP435

15

AOUT L

AIN L

14

13

VGND

AIN GND

17

16

VOUT

VIN

VGND

20

19

18

ESD

R503

R502

0

R511

R510

1K

C387

R408

VGND

3

2

1

10

100.47

C376

0.01

R385

1K

R401

10

VGND

100

R400

75

R402

V+ VIN

ESDGND

VGND

GND

VOUT

4

5

R405 4.7

R404 10

R407

100

R410

C386

4.7

C388

R406 10

R409

56

ESDGND

R403

75

1000P

C385

TP362

TP361

TP363

TP364

TP365

1004.7

ESDGND

5

4

3

2

1

1000P

C389

GND

Lch

VIDEO

VGND

Rch

135

C355

1

C382

1

TP357

RR

RL

33

14

1

FL

FR

470

R375

34

P-RR C370

10

D

8

P

C369

1000P

100

R374

R372

22K

0.1

470

R384

R377

470

AVOUT-L C372

10

51

AVOUT-R C375

10

ESDGND

22K

R378

C373

1000P

AGND

100

R376

C374

1000P

100

R383

R381

22K

C371

0.1

C379

C378 10

R394

R390 4.7

R386C377

0.47 10

AVIN-L

AVIN-R

ESDGND

AVIN-G

iPod-G

iPod-L

iPod-R

iPod-V

0.47

C436

C434

1

C438

1

C433

1

C435

0.47

C437

SUB-L

SUB-R

MAIN-R

MAIN-L

TUN-R

TUN-L

FL

FR

RL

RR

AVIN-G

AVIN-L

AVIN-R

NAVI-R

NAVI-G

NAVI-L

CR

BL

CL

BR

CR

CL

141

SCL

SDA

1

C439

49

48

50

52

R501

0

R544

1

1M

OUT1

OUT

3

IN3A

C495 8

100

R513 7CTL3

6

5OUT

2

GND

2

4

C494 1

1

100

R512

3

IN1B

CTL1

2

1M

R543

NAVI-R

20

AR

R448 1K

R446

1K

R449 10

R450 4.7

R451 10

C418 0.47

C419 0.47

53

RST

TV-L

TV-G

TV-R

GND

MUTE

AVOUT-V

AVIN-V

V5V

SW5V

TV-V

61

BU

B

G

R

+

IC351

IC357

IC354

IC36

5.0V

1.0V

1.7V

0V

6.8V

7V

6.8V

14.4V

0V

14.4V

7.0V

3.5V

0V

7V

0V

3.3V

4.0V

3.5V

3.3V

6.8V

8.1V

2

3

4

5

10

8

13

8

67

111111

1313 14141414

8

810

455

4

3

13

1 1

34

3535

35

36

37 37

37

3838

38

39

8

4040

40

4040

34

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (6/11)

ZAA AB AC AD

Q453

D408

D407

∗Q452

Q451

CN355

D402

D414

D403

D398

D399

D400

D396

D413

D401

D397

NAVIGATION

L : OFF, H : MUTE ON

Q653

D651

Q651

Q652

Q683

Q654

Q65

AV SWITCH

VIDEO AMP

A-DAC

L.P.F

VIDEO SELECT

V+2 LPF

C603

0.01

7514

V

+

CLAMP

L603

759

6dB

GND2

10

6dB

12

13

11 75

6dB

CLAMP

8

BIAS

GN

D

P

S

BI/CL

LPF

PS

1

6dB

3

752

6

5

4

CLAMP

VCC

GND

180

DVD-R

DVD-G

DVD-B

C460

R494

270

20

61

CAD0

43

TP421

TP422

35

ACOUTR

ACOUTL

MUTE2

32

31

30

ACIN3R

ACIN3L

ACIN2R

33

34

LDOUT2R

39

ACIN2L

ACIN1R

ACIN1L

ACIN0R

36

37

38

ACIN0L

VCC

GND

40

41

42

ESDGND

C448 R486

C446

0.01

10 7P

R489 C455

AGND

C454

7P

R488

10

C456

47u16

R480

2.7K

R482

1.2K

∗C464

L451

10uH

0.1

C457

330u6.3

R492

14

C459

0.1

DGND

16

15

VFB2

VOUT2

TEST

17

19

18

VFB1

VOUT1

DVSS

13

12

11

10

9

8

7

Q2

DVDD

Q4

Q3

Q1

Q0

INT

49

50

51

LDOUT2L

LDOUT1R

LDOUT1L

LDOUT0R

PAOUT1R

LDOUT0L

VP

47

PGND

44

45

46

PREF 48

C447

10

6

5

4

3

2

1

PDN

SDA

SCL

CAD1

LIN+7

RIN+7

RIN+6

GND7

64

62

63

LOUT3

VGND

NAVI AG

NAVI R

NAVI AR

NAVI G

NAVI AG

NAVI B

VGND

17

20

NC

1819 15

16 1213

14

R456

R458

R460

NAVI TX

NAVI RX

NAVI

VGND

COMP

NAVI AL

NC

9

10

11

NC

6

7

83

NC

4

51

2

R466 75

R465 75

R464 75

75

100

R467 1K

R469 1K

R468 1K

ESD

R455

R457

R459

R495

C473

C470

∗C465

C462R493

270 1

1

VGND

10

C467

0.1

C468

C474

1

IICN

26 VVSS3

VIN1

VVSS2

VFB3

VOUT3

VVDD2

23

22

21

25

24

VIN4

VVSS1

VIN3

VVDD1

VIN2

29

28

27

31

30

35

VIN5

32

VIN6

AVDD

R

33

34

C443

0.01

C475

0.1

10

LOUT1

MUTET

VCOM

AVSS

36

37

38

ROUT1

LOUT2

ROUT2

39

40

41

42

C480

AGND

10

1KR517

1K

R519

R516

1K

R518

L361

120

C479

RIN+2

RIN+5

GND6

LIN+6

RIN+4

GND5

LIN+5

RIN+3

GND4

LIN+4

GND3

LIN+3

55

58

59

60

56

57

52

53

54

50

51

RIN+1

ROUT3

GND1

LIN+1

43

44

45

46

GND2

LIN+2

47

48

49

RR

P-FR

P-FL

P-RR

P-RL

1K1

R487C449

1K1

AVOUT-R

AVOUT-L

BL

BR

49

50

2.2

C471

C472

1

C469

2.2

SAT-G

SAT-L

SAT-R

iPod-G

iPod-R

iPod-L

TV-R

TV-L

TV-G

DVD-AL

DVD-AR

4.7

C478

1

SUB-L

SUB-R

MAIN-R

MAIN-L

C482

0.1

1

C481

C476

12K

C477

4.7

5

6

55

3.3K

R481

1.2K

R548

R546

R544

1

1M

OUT1

IN2A

OUT3

IN3A

8

1

00

R

513 7CTL3 1

IN3B 9C499

10

GND3

6

5OUT2

GND2

41

100

R515

C498

11

CTL2 12

V+ 13

0.01

C500

C496

161

0

2

3

IN1B

CTL1

21

C497

15

GND1

IN1A

IN2B 14

1M

R543

R547

1M

R545

DVD-R

NAVI-B

DVD-G

NAVI-G

R454

10

R452

R453 4.7

10 0.47

C423

C424 10

0.47

C425

R462

100

R463

GND

R461

10

NAVI-G

NAVI-L

NAVI-R

NAVI-B

NAVI-G

NAVI-R

REMO

TX

RX

20K

R661 15K

DVD-AL 47K

560

R667

R669

DVD-AR

560

R668

47K

R670

2200P

C663

C229

0.01

1

10

C667

GND

4

3

2

1K

R665

R663

220P

C665

VCC

10

C668

8

5

6

2

7

14 LRC

K

VCOM

ZEROA

R673

390K

R677

C673

C672

2.7K

10

1

10

C661

DEMP

TEST

AGND

9

11

12

13

10

C656

C658

0.1

100K

R676

2.7

K

R67

4

VOUTL

DGN

D

VOUTR

VC

C

N

C

SCK

FMT

16

MUTE

15

22

R651 BC

K

DATA

iPod-V

AVOUT-V

AVIN-V

A8.5V

SW3.3V

V5V

TV-V

DVD-B

SOG

COMP

V5V

REMO

V5V

A5V

VGND

AGND

A8.5V

68P

∗C466

∗C463

+

IC602

IC601

IC358

IC361

IC652

IC651

0.8Vp-p

0V

0.7Vp-p

0V

5.1V

0V

0.8Vp-p

0.7Vp-p

0.8Vp-p

0.7Vp-p

0V

8.1V

3.3V

0V

3.3V

4.0V

8.1V

3.3V

0V

0.2V

3.3V

0V

0.9V

0V

5.1V

1.6V

2.1V

0V

1.8V

5.2V

1.8V

0V

1.8V

0V

1.8V

5.0V

1.3V

2.5V

0V

2.5V

2.5V2.5V

0V

3.0Vp-p

4.0V

0V

5.0V

2.0Vp-p

0V

5.1V

1.5Vp-p

1.5

Vp

0V

4.0Vp-p

0V

2.5V

0V

1

4

14

66 7

67

1111

13 13

13

14 13

88

8

4

14

11

16

31

34

3434

3535

436

3636

37

37 37

38

35

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (7/11)

AIAHAGAFAE

USB HOST CONTROLLER

1.8

V

D701

CN701

1.8V REG3.3V REG

D801

D802 VBUS SW

W801

USB

to DVD MECHA (X37-110) CN2 (DVS-8020V)

NOT USE

D

3

D651

Q652

Q683

Q654

Q655

AMP

A-DAC

L

.P.F

LATCH

VBUSB

DISC DET

D6

D7

D6

D7

CP722 33

D4

D5

D4

D5

D0 D0

D2

D1

D3

D1

D2

D3

CP721 33

D3 D2 Q3 A4

DGND

D14

D15

D14

D15

CP724 33

D12

D13

D12

D13 8

D7

GND

D6

10

9

D8

D7

D3

D4

D5

D4 6

7

D5

D6

5

C844 0.1

A7

Q6

CP754 22

12

Q7

11

LE

A8

15

14

Q4

Q5 13

A5

A6

L702

180

TP752

0.1

VCC

D8 D8

D9

D10

D11

D9

D10

D11

CP723 33

1

D0

D1

OE

2

3

4

D1

D2

C814

0.1

C815

19

Q0

Q2

18

17

Q1

16

A1

A3

A2

CP753 22

20

0.1

C816

0.1

C817

C811C840

R823 10K

DIOR

CS3

12

DGND

C762

5

C764

PGND

1

P5V TP749

3

4

2

P5V

0.1

TP747

10

C761

7

8

6

PGND

TP745

TP743

11

9

10

NC

D5V

0.1

C763

TP741

PGND

DGND

10

A8

RST

A6

A5

A7

201

TP736

13

15

14

DASP

CS3FX

TP738

TP737

TP739

17

18

16

DA0

DA2

CS1FX

TP733

TP734

TP735

DET

180

183

200

208

22(DMACK)

21

19

20

INTRQ

DA1

PDIAG

TP730

TP731

TP732

25

23

24

DGND

DIOR

IORDY TP728

TP727

156

182

206

A1

A2

A3

A4

1K

10K

R826

R825

0.1

C813

0.1

C812

26

44

36

DIOW

35

33

34

R811

R810

155

154

IRQ

39

37

38

0

43

40

41

42

0

CA8

XCS

XRD

XWRH

30

31

32

VSS8

CVDD2

XWRL

CA5

CA6

CA7

27

28

29

XDACK0

XDREQ0

VSS9

XINT

VSS10

XDREQ1

XDACK1

LVDD4

54

D4

D3

D2

D1

D0

D6

D7

D5

49

48

45

46

47

53

50

51

52

D10

D11

D9

D8

D13

D12 59

58

56

55

57

60

61

CD4

CD3

CD0

CD1

CD2

CD6

CD7

CVDD3

VSS11

CD5

CD10

CD11

VSS12

CD8

CD9

CD12

CD13

CVDD1

CA1

CA3

CA2

CA4

24

25

23

XRESET

XBEL

20

21

22

17 LVDD3

VSS7

0.1

18

19

LVDD2

VSS6

NC

1

14

15

16

SEIKO EPSON

C809

TP712

TP719 D14

D15

DGND 29

27

28

26

(DMARQ)

DGND

DIOW

TP723

TP725

31

32

30

DD14

DD0

DD15 TP721

TP720

TP722

207

D0

D11

D13

D12

36

DD12

35

33

34

DD2

DD13

DD1

TP717

TP716

TP718

39

37

38

DD4

DD11

DD3

TP713

TP714

TP715

D2

D1

D4

D3

0.1

C808

D10

DD6 43

41

42

40

DD9

DD5

DD10

TP709

TP710

TP711

46

44

45

DGND

DD7

DD8

TP706

TP707

TP708 D6

D9

D5

D8

D7

48

49

47

NC

DGND

NC

TP703

50

RESET TP701

1

C807

LVDD1

9

DPB

HVDD2

11

12

13

DMB

VSS5

10

VSS3

HVDD1

VSS4

0.1

7

8

VSS2

R1B

4

5

6

DMA

24.000MHz

TMS

TDI

LVDD11

TRST

VSS1

XO

1

2

3

0

R820

124

125

128

127

126

XI

VSS20

TCK

HVDD9

TDO

TEST

VSS21

LVDD10

HVDD8

DPA

120

119

123

122

121

115

114

118

117

116

0.1

C830C833

C834

C835

8P

X808

8P

1

C829C828

10.1

10

C836

106

VBUSENA

VBUSFLGA

R1A

HVDD7

VSS19

VSS18

LVDD9

110

111

113

112

107

109

108

XHDASP

XHCS1

XHCS0

HDA2

HVDD6

VSS17

102

105

104

103

101

C827 C826

R815 6.2K

C837

0.1

10

1

R814 C825

C

10K 0.1

VIN

VOUT

155

C803

1

L801

600

VOUT

L803

600

NC

TP819

4VIN

1

2

3

CE

VSS

C801

TP818

4

180

L811 L804

VIN

GND

ENABLE

3

1180

1

DGND

C804

NC

R806

4.7

R805

4.7

22

R817

ESDGND

2

3

CE

VSS

C802

1

L805

L806

1

2

10

C843

180

A0

4

R816

FAULT

0.1

C842

22

DGND

2

3

4

10K

R812

A1

A2

GND

220u16

VOUT

CSLEW

C841

6

5

C

1

SHILD

D(-)

2

GND

54

D(+)

3

VBUS

1

USB5V

D3.3V

P5V

D5V

D3.3V

USB5V

3.3V

1.8V

3.3V

1.8V

3.3V

1.8V

3.3V

TP729

B

R

G

LPF

C602

0.01

V+1

CLAMP

21

1

BIAS

GND1

PS

BI/CL

LPF

6

4

3

1

C605

C606

5

LPF

1

10

7C607

C604

6

5

4

CLAMP

VCC

GND

0.1

C601

CVBS

R652 22

R653 22

R654 22

R662 R666 15KC662

20K

560

R668

47K

R670

C229

0.01

GND

VCC

10

C668

8

1K

220P

C666

R664

5

6

2200P

C664

7

LRCK

OM

ROA

6

73

9

0K

6

77

673

672

.7K

10

1

MP

S

T

G

ND

10

100K

R676

2.7K

R674

C657

0.1

VOUTL

DGND

VOUTR

VCC

NC

7

8

4

3

6

5

C

K

M

T

U

TE

1

BCK

DATA 2

BU5V

A8.5V

BE A5V

236

242 10

C655

240

238

248

BU5V

A8.5V

TP801

TP804

TP815

TP816

+

IC807

IC801

IC806IC805 IC804

IC79

C

652

6

51

4.0V

3.0Vp-p

8.3V

0V

5.0V

1.0Vp-p

0.8Vp-p

0V

5.1V

1.5Vp-p

5.1V

5.1V 3.4V

3.4V

0V0V

3.3V 1.8V

5.1V

0V

5.0V

0V

1.8V

3.3V

0V

3.3V

1.8V

0V

1.8V

0V

3.3V

0V

3.3V

0V

1.8V

0V

3.3V

0V

3.3V

1.8V

0V

3.3V

0V

3.3V

1.8V

0V

1.8V

0V

5.1V

0Vp-p

0V

3.3V

6

7

6

7

99

11 11

15 15

17

17 17

17

18

18 18

19

20

21 21

21

15

6

7

15

6

7

6

67

9

11

9

11

36

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (8/11)

AJ AK AL AM AN

1.8V REG.

D701

SPI I/F

VIDEO OUTPUT I/F

(CONPOSITE)

12C I/

F

ATAPI I/F

UART I/F

NOT USED

1.8V REG

81 0.1

VSSUB 1

10

DGND

64

C702

L702

180

P

752

0.1

C817

C818

D10

D11

D9

D15

D13

D12

D14

59

58

57

63

60

61

62

CD10

CD11

CD9

CD15

LVDD5

CD14

CD12

CD13

R740

R739

C722

R769

C704

1

56u6.3

C703

15K

4

R770

R702 2

3

0

1

5

12K

IRQ,RST

D3.3V

V3.3V

D5V

VGND

180

L602

180

L601

L701

TP753

VIN

GND1

VC

VOUT

ADJ

189

L703

180

L705

180

0

10K

R872

10K

188 0

R743

R742

R871

10K

R919

186

185 0

0

0.1

R873

10K

C723

200

197

196

201

R875

R874

10K

R745

0

10K

211

210

209

207

DIOW

CS3

206

DIOR

R877

R876

10K

R878

10K

208

R880

R879

10K

R754

0

R881

10K

IO3V3 11

HCS0

BE RESERVE 3

BE PALSE JUDG

BE STBY

BE BUDET

PLLGND 2

HCS1

196

0.1

R744

PLL1V8 3

180

195

22

R748

0

R749

22

200

199

198

197

BE INI

BE CON

179

178

BE SREQ(USB A4)

BE MREQ

ALE (BE SREQ)

176

175

177

SPIRDY

BE MDATA

BE SDATA

BE CLK

HRDY

HWR

HRD

HCS3

IOGND 12

IO HS 23

22

R750

22

R752

R751

22

0

R755

R753

22

R756

0

R614

33

TP779

TP780

TP782

67 0.1

0.1

CVDD4

66

65

VSS13

LVD D6

HVDD3

R736

10K

182

10K

R870

R869

183 22

22

R738

10K

R868

180 22

R737

0.1

C721

R867

0.1

C626

74

HDD6 70

69

68

HDD8

HDD7

XHRESET

0.1

C820

C819

73

72

71

VSS14

HDD5

HDD9

LVDD7 77

76

75

HDD11

HDD4

HDD10 0.1

C821

80

79

78

HDD3

HVDD4

VSS15

0.1R613C625

4.7

C624 0.1

C629300

0.1

C623

C628

0.1

C622

0.1

C621 164

170

HA1/(USB A2)

BE PALSE OUT

HA2/USB A3

174

173

HA0/(USB A1)

DIGGND 5

171

172

RAILVDD 1

DIG1V8 5

IO DV 16

169

168

AVD331

GUARDVSS 1

GUARDVDD 1

166

165

167 CVBS OUT

161

AVSS1

VREF1

RSET1

163

162

COMP1

AVSS 3

AVD33 3

160

159

158

154

AVD33 2

Y OUT

AVSS 2

155

157

156

AVSS 1

AVD33 1

C OUT

153

152

151

209

202

201

205

203

204

206

208

207

211

210

212

SCL

SDA

WP

VCC

98

HDA0

LVDD8

XHCS0

HDA2

HVDD6

VSS17

102

103

99

101

100

4

C825 C824

K

0.1 0.1

A0

DGND

2

3

4

A1

A2

GND

C791 0.1

1

BT RST

NAVI SEL

TP776

TP778

XHDMACK

88

VSS16

83

84

82

HDD13

HDD2

HDD12 C822

87

86

85

HDD0

HDD14

HDD1

90

89

91

HDMARQ

HDD15

HVDD5

0.1

C823

94

93

92

HIORDY

XHIOR

XHIOW

R734

0.1

C627

22

10K

R866

156

22

R735

D14

R865

10K

22 D15

R733

R864 D13

D12

D11

XHPDIAG

HDA1

96

95

HINTRQ

97

10K

0.1

D7

D10

D9

D8

D5

D6

C720 R776

R732

22

D2

D3

D4

139

145

IO DV 20

VDWELL 1

RAILVSS 1

150

149

148

INTRQ

DMACK

147

146

HD14

DMARQ

HD15

144

143

HD11

HD13

HD12

142

141

140

132

HD7

HD10

HD9

HD8

138

137

136

IOGND 11

HD6

HD5

134

133

135

ATA R ST

I2C SEL

IO3V3 10

IO VI 9

129

131

130

HD4

HD3

HD2

SCL2

SDA2

0

SDA

SCL

R860

7

6

5

0

R798

R799

R859

4.7K

8

C719

DGND

D1

D0

0.1

C701

10

TP751

SCL2

SDA2

R858

118

IOGND 10

HD0

HD1

PLLGND 1

PLL1V8 2

120

119

R730

L704

180

SAT CON

USB RST

USB IRQ

RXD2

116

117

114

115

RXD1

TXD1

SCL2

SDA2

TXD2 R725

R863

10K

0

R729

0

R728

R727

0

R726

0

IRQ

RST

CON

RX

R861

4.7K

0

R724

0

R723

R722

0

R721

0

TX

RST

SDA1

R720

D3.3V

3.3V

1.8V

3.3V

1.8V

3.3V

1.8V

1.8V-1 1.8V-1

1.8V-1

MS 3.3V

D3.3V D3.3V

V3.3V-1

V3.3V-2

V3.3V-1

V3.3V-2

V3.3V-1

D5V D5V

155

154

154,155

121

122

123

124

126

125

128

127

181

182

183

184

185

186

187

190

189

188

191

192

194

193

SDA,SCL

R746

0

198

184

R915

0

CVBS

DGND

TP783

MS 3.3V

75

R612

0

R747

TP791

TP774 TP772 TP770

+

IC705

IC791

1.8V

3.3V

1.8V

0V

1.8V

0V

3.3V

0V

1.8V

0V

3.3V

1.0V

1.8V

0V

3.3V

6

7

6 6 6

6

7

77

7

9

7

9 9

11

11 1111

15

15 15

18

18 18

20

20 20 20

21

20

2020

32

32 32 32

37

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (9/11)

ASARAQAPAO

SPI I/F VIDEO OUTPUT I/F (RGB) AUDIO PCM I/F

SDRAM I/F

12C I/F

SEMICONDUCTOR

MPEG DECODER

MAGNUM

ROM I/F

32

241

VSEL SCL

TP789

211

210 R880

0

R881

2K

10K

SPIRDY

BE MDATA

BE SDATA

0

R755

R756

0

TC WAIT

221

C638

R625 75

R624 75

R623 75

R622 75

R621 75

R620 75

R627

150

TP790

C630

0.1

B

G

0.14.7

R

0.1 0.1 0.10.1

G OUT

AVSS 4

AVD33 4

B OUT

VSSUB 2

VDWELL 2

RAILVSS 2

RGB MUTE

VSEL SDA

C632C631

GUARDVDD 2

GUARDVSS 2

AVD33 7

AVSS 7

VREF2

RSET2

COMP2

AVSS 6

AVD33 6

R OUT

AVSS 5

AVD33 5

214

0.1

C633 C634

C635

211

210

213

212

R626

36

C636

0.1

C637

217

216

215

220

219

218

R687 10K

C724

C729

R688 22

R686 22

R683 22

R681 10K

27.000MHz

240

238

236

0.1

22P

242

C725

22P

C730

0.1

C726

10P

248

C727

10P

X701

R758 1M

XTLCLKI

IO3V3 12

IO MI 14

BE AMUTE

BE VMUTE

AUDXCLK

DIGGND 6

AUDOBCK

DIG1V8 6

AUDOLR

RAILVDD 2

330

R685

R684

223

222

226

225

224

330

R690

R696 22

TP786

229

228

227

231

230

PLL1V8 1

PLLGND-3

(USB A8)

(USB A7)

(USB A6)

(USB A5)

SPDIFO

AUDOD0

IOGND 13

XTLCLKO

237

1K

R759

233

232

236

235

234

L706

240

239

238

4

IRIN

3

RSTN

TEST 5

6

VSEL

TC WP

HARDWARE CONTROL

SOFTWARE CONTROL

L

H

I2C SEL

19

MD29

9

TC RST

7

8

IO3V3 1

MDQM3

10

11

12

MD31

MD30

MA22 MD27

IOGND 1 15

13

14

MD28

MA20

MA21

16

17

18

MD26

MD25

IO3V3 2

MA16 MD21

MA17 MD22

DIG1V8 1

MA19

MA18

21

22

MD23

MD24

20

DIGGND 1

IOGND 2

23

24

25

MA13 MD18

MA15

MA14

26

27

28

MD20

MD19

MA12

MA11

31

MD16

29

30

MD17

IO3V3 3

SCL2

R858

113

114

115

SCL2

111

112

109

110

R721

0

57

GPIO HST(27:0)

GPIO MIS(21:0)

GPIO VIS(10:0)

GENERAL PORT

GPIO DVD(20:0)

28 1

22 3

11 6

OPEN

321

MD9

MD12

35

MD1M2

IOGND 3

33

34

MDQM1 36

37

38

MD14

MD13

MD15

39

40

MD11

IO3V3 4

41

IOGND 4

DIGGND 2

42

43

44

MD10

IOGND 5

48

DIG1V8 2 47

45

46

MD8

MD7 49

50

51

MD6

MD5

MD4

55

52

53

54

MD3

IO3V3 5

MD2

SIR RST 3

56

MD1

79

1.5K

RDY

SDA

SCL

RST

R857

D6

NVD6

IO3V3 9

CP RDY

SCL1

SDA1

107

108

105

106

DIG1V8 4

NVD7

CP RST

CP SDA

CP SCL

103

104

99

100

101

102

R855

TP767

R856

10K

R720

0

R719

0

R718

0 C718

0.1

10K

R854

10K

TP787

TP788

R717

0

R716

0

R715

0

D7

C717

89

MA0

NVD0

NVD1

NVD2

NVD3

NVD4

NVD5

IOGND 9

DIGGND 4

94

95

96

98

97

90

91

92

93

MA6

DIG1V8 3

MA5

DIGGND 3

IOGND 8

MA4

MA3

MA2

MA1

IO3V3 8

84

85

86

87

88

81

82

83

80

D3

D4

D5

A0

D2

D1

D0

0.1

A4

A3

A2

A1

A5

A6

0.1

C716

69

MRASN

MCASN

IOGND 7

MWEN

NVCEN

MA10

MA9

MA8

MA7

IO3V3 7

74

75

76

77

78

70

71

72

73

MD0

MD1M0

IOGND 6

IO3V3 6

MCLK

MAP

MBS1N

MDS0N

MCLK

65

66

67

68

A7

A8

A9

A10

RAS

CAS

WE

CE

BS1

MAP

CKE

BS0

NC

58

59

TYPE 3

ALE SEL

22

60

R712

C705

180

C728

0.1

100

R777

1K

R706 0

R704

R707 0

R708 0

CP701 2

2

CP702 2

2

CP703 2

2

CP704 2

2

CP706 2

2

CP705 2

2

CP707 2

2

CP708 2

2

10K

R773

DGN

D

1.8V-1 1.8V-1

0.1

C715

C714

0.1

C713

0.1

MS 3.3VMS 3.3V

MS 3.3V MS 3.3V

D3.3V D3.3V

V3.3V-2

V3.3V-1

V

1

2

61

62

64

63

241

242

243

244

245

246

247

248

249

250

251

252

253

254

255

256

D5V D5V

TP766

141PIN

P

772 TP770 TP768

ALE SEL

HALE : YES

ALE : NO

62PIN

L

0

TP761

C733 0.1

C734

C735

1000P

IC701

6 6 6

7 7 7

9

15

22 22

23 24 25

38

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (10/11)

AT AU AV AW AX

AUTHENTICATION

iPod

SDRAM

128M

SDRAM

128M

Q681

D682

D681

COAX.

OUT

SPDIF

J681

FLASH

VOL-

D571

D572

D551

AUTO

S553

S552

D578

D577

D576

D575

D574

D573

S551

ATT

VOL+

D552

D554

D553

S556

S555

S554

D584

D583

D582

D581

D580

D579

AM

FM

D555

D557

D556

S558

S557

D586

D585

D558

CN4 1/2

A/2-

X15-

GND LINE

SIGNAL LIN

E

B LINE

VIDEO LINE

R713

22

A10

D23

CKE

D22

D20

D21

D19

D17

D18

D16

C852

0.1

C851

10

R848

100K

R846

1K

C855

0.1

R847

10K

DGND

TP960

DQ11

DQ4

D27

47K

9

R837

R851

47K

C705

0.1

180

C728

0.1

100

R

777

1K

R703

1K

R706 0

R704

8

TP959

19

L851

TP957

TP958

180

20 SPISOMI

SPISIMO

SDA

R844 10K

R845 100K

TP956

17

16

18 ROSC

SPINSS

MODE2

R843

0

R841 10K

NC14

15

14

13

I2CSDA

MODE1

32

SPIUCLK

30

29

28

27

26

25

24

23

22

21

NC24

NC23

NC22

NC29

NC28

NC27

NC25

NC26

NC31

CLOCKOUT

NC30

31

SPI

RESERVED

I2C

MODE2

L

H

L

MODE1

H

X

L

MODE0

H

L

2.7V

3.3V

NC35

NC33

NC34 34

35

33

NC36

NC37

NRESET

36

37

38

RDY

I2CADDR1

ADDR2

R838

22

R840 10K

CP

12

11

MODE0

READY

I2C

9

10

SCL

R836 10K

R835 10K

0

TP951

32.768kHz

XOUT

I2CSCL

I2CADDR0

CLOCKENAB 4

NC6 5

6

7

8

NC5

0

3

VCC1

VSS

VCC2 39

40

XIN

1

2

X851

R832

R833

10K

R834 10K

5.1M

R831

C854

3P

4

3

C853

3P

1

2

CASCAS

D29

C706

0.1

R707 0

R708 0

R886

10 R887

47K

22

R709

D30

D31

C707

0.1

D27

CP701 22

D28

D24

D25

D26

BS0

CKE

BS1

MAP

RAS

BS0

BS1

MAP

CKE

CP709 22

RAS

A10

D20

C708

0.1

D23

CP702 22

D21

D22

WE

CE

D18

CP703 22

D19

CP704 22

D16

D17

A9

A8

A6

A7

CP710 22

CE

WE

A8

A9

A10

CP711 22

A6

A7

D28

D29

D30

D31

22

2

5

C693

0.1 R920

10K

1

VCC

DGND

C753

C752

0.1

4GND 3R900

VDDQ1

DQ0

3

2VDD1

1

8

VSSQ1

DQ2

DQ1

6

5

DQ3

7

4

DQ13

DQ14

DQ15

DQ12

VDDQ4

VSSQ4

VSS3

52

53

54

47

48

49

50

51

A3

A2

A1

A0

MAP

BS1

BS0

RAS

CAS

WE

D24

D25

D26

0.1

C754

0.1

C755

0.1

0

R885

C756

RAS

18

17

16

15

14

12

11

10

13 DQ7

VSSQ2

DQ6

DQ5

VDDQ2

9

CAS

WE

DQML

VDD2

27

26

25

24

23

22

21

20

19

A10

BA1

BA0

CS

VDD3

A3

A2

A1

A0

CKE

CLK

NC40

VSS2

DQ8

DQMU

DQ9

DQ10

VDDQ3

VSSQ3

43

44

45

46

42

37

38

39

40

41

VSS1

A4

A5

A6

A7

A8

A9

A11

NC36

32

33

34

35

36

28

29

30

31

D4

DQ11

DQ4

D11

10K

C748

180

C741

CP706 22

D6

D5

D7

A1

D12

C709

0.1

22

R710

22

D13

D14

D15 R711

A4

A5

A3

A2

C710

0.1

CP705 22

D11

D9

D10

D8

A0

A1

CP712 22

A5

A4

A3

A2

CP713 22

A0

MD5

MD6

MD7

D0

D2

D3

D4

D1

C711

0.1

CP707 22

D7

D6

D5

D4

C712

0.1

D2

D3

CP708 22

D0

D1

0

CP715 22

CP714 22

MD3

MD4

MD0

MD2

MD1

C743

C742

180

4.7

C751

L751

0.1

C758

D12

D13

D14

D15

0.1

3

2

1

8

7

6

5

4VDDQ1

DQ0

VDD1

VSSQ1

DQ2

DQ1

DQ3

VSSQ4

DQ15

VSS3

VDDQ4

DQ13

DQ14

DQ12

4.7

D3

D1

D2

D0

52

53

54

47

48

49

50

51 0.1

10K R772

R765

R773

DGND

L741

R764

C747

0.1

C746

C745

R884

C744

22

R763

C757

0.1

A9

A8

A5

A4

A7

A6

RAS

D8

D9

CAS

WE

D10

0.1

12

11

10

9

13

18

17

16

15

14

A2

A3

A1

A0

BS1

MAP

BS0

0

23

22

21

20

19

27

26

25

24

CKERAS

DQ7

VSSQ2

DQ6

DQ5

VDDQ2

CAS

WE

DQML

VDD2

DQ8

VDDQ3

DQ9

DQ10

VSSQ3

CLK

DQMU

NC40

VSS2

A10

BA1

BA0

CS

VDD3

A3

A2

A1

A0

A8

A9

A11

NC36

VSS1

A4

A5

A6

A7

CKE

22

D7

D6

D5

43

44

45

46

42

37

38

39

40

41

0.1

A4

A5

A6

A7

A8

A9

A10

32

33

34

35

36

28

29

30

31

1.8V-11.8V-1

MS3.3V

MS 3.3V

D3.3V

C681

0.1

R691

10

R692

150

R693

75 R695

0

R694

TP601

TP602

TP603

1

2

3

0

ESDGND

DGND

R697

0.1

2

43 GND

C692

VCC 5

1

150

R698

150

0

R699 MS 3.3V

REMO

RST

D5V

A-1/DQ15

43

DGND 48 A16

MD7

DQ14

DQ7

VSS2

45

46

47 BYTE

44

R762

DQ2MD2

38

MD4

MD6

MD5

CP752

10K

DQ4

DQ12

39

40

DQ13

DQ6

41

42

DQ5

MD3

0.1

C732

DQ10

DQ3

DQ11

35

36

34

VCC

37

OE

MD0

MD1

CP751

10K

DQ0

29

30

DQ9

33

DQ1

31

32

DQ8

10K

R883

10

C731

A0

CE

25

26

VSS1

28

27

L731

CE

0

MAP

A1

180

6

1

A15 D21

D22

A10

A11

A12

A13

A14

4

3

2

5D16

D19

D18

D17

D20

A0

RY/BY

WE

A9

A10

11

10

WE

A20

A8

A9

A19 9

8

7

D26

D25

13

14

12

WP/ACC

A21

RESET

D27

R761

0

A3

A4

A2

A6

A7

A5

A8

A5 19

18

16

15

17

A6

A17

A18

A7

D23

D24

21

20

24

23

22

A3

A1

A2

A4

MS 3.3V

TP551

TP555

TP554

TP553

TP556

TP557

TP558

TP559

TP560

R574 220

16K

R590

GREEN

R562 220

R561 560

R568 220

R567 560

R566 220

R565 560

R564 220

R563 560

R573 560

R572 220

R571 560

R570 220

R569 560

100

R551

RED

3.3K

R554 R588 R587

1.8K

RED

2.2K

RED

R556 R589

5.1K

RED

8.2K

RED

GREEN

R576 220

R575 560

R591

51K

RED

11

10

9

8

7

6

5

4

3

2

GND

KEY2

REMO

RESET

SI

LED G

LED R

EJECT

SW5V

R586

R559

0

R583

0

R585

0

R582

R584

0

MS3.3VMS3.3V

D5V D5V

D5VD5V D5V

0

R852

TP761

RST

22

R714

0

R760

IC851

IC692

IC704

IC703

IC691

IC702

B

KVT-50DVDRY/512/522DVD/522DVDY/53

2

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

32.768kHz

3.3V

0V

3.3V

0V

6

7

22

23

24

25

23

24

25

26

27

26

27

26 26

27

28 28

28

30

28

29

30

28

30

29

28

30

39

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X15-110x-xx (11/11)

BCBBBAAZAY

1

2

3

4

5

6

7

D351,355,356,359,360,363,

:

D369-376,384,397-400,

:

D365,367,378,393,396,401,

:

364,368,406-408,651,701

D801,802

D551-559,561

592,681

D560

409,410

AVRL1613R3FTA

CVL10C270M300

B30-1779-05

B30-1605-05

UDZW6.8(B)

DAP202U

PNA4S22M02KW:IC551

:

358,361,362,571-591

D24,25,37,39,353,354,357,

:

380,381,389-392

D19-23,27-31,33-36,40,41,

:

402,403,411-414

D3,13,366,379,388,394,395,

:

D1,2,4,5,12,42,352,404,405,

:

Q351,353,354,356,357,360,372,

:

Q41,43,350,370

:

Q27,40,42,44,60,62,64,

:

26,28,61,63,65,655

Q9,11-13,17,21,22,24,

:

Q7,15,20,29,45,52,683

:

Q5,14,16,25,36,37,453,654

:

Q1,3,72,359,362

341S2094

74AHC573PW

XC6219B182PR

XC6219B332PR

MIC2005-08YM6

S1R72C05F15

NOT USED

SI-3010KD

A2V28S40CTPG6

S29GL64A9I4Z4

MS8312A-IQG

74AHC1G04GW

NJM4565V-ZB

PCM1754DB

NJM2573V-ZB

MM1671XNRE

Q352,355,358,371

D14

D32,682

D15-18

D11

D6-9

415

Q361

Q67,69

Q76,78,79

373,651,652

Q77

Q75,653

Q73,74,454,455

Q71,82

Q54,55,58,59

Q51,53,56,57

Q66,68

Q39

Q38,46

Q35

Q18,452

451,681

Q30

Q23

Q6,19,80

Q4,8

Q2

:IC806

IC851

IC807

:

IC805

IC804

IC801

IC791

:

IC691

IC703,704

IC705

IC702

IC701

:

IC652

IC651

IC602

IC601

:

EP05Q04

DA204U

CVS10A180M

CVS10A120M

1SS357-F

UDZW4.7(B)

1SR154-400

UDZW6.2(B)

1SS355

2SA1577

DTC143EE

2SK3019

DTA144EE

DTC143TUA

DTA124XUA

DTA114EUA

DTC144EE

DTA124EE

DTB123YK

HAT2218R-E

DTC124XUA

2SC4081

KTA1046-P

TPC8110-F

DTC114YE

DTC143ZE

DTA114TUA

2SB1689

2SA1576A

2SB1184

2SC4617

DTA114EE

2SA1774

2SB1188(R)

DTA143ZE

DTC124EE

NJM2286V-ZB

AK4220

E-TDA7415CB

74AHCT08PW

E-TDA7478AD

NJM2505AF-ZB

E-TDA7850A

74AHC1G32GW

S-80835CNNB-G

NOT USED

∗

M30878 MJBA22GP

74AHC1G08GW

R1114N331B-TR

LB1836M-TLM-E

LTC3728LEGN

M5237ML-CF0J

XC6201P502PR:IC1

IC361

IC358

IC357

:

IC356

IC355

IC354

IC351

IC13

:

:IC8,692

IC12

IC11

IC10

IC9

:

IC7

IC5,6

IC3,4

IC2

:

-

O

+

EJECT

DISC

S559

D588

D559

D587

S560 RESET

D589

D590

D591

D561

D560

CN551

REMO

D592

G

ND LINE

S

IGNAL LINE

B LINE

V

IDEO LINE

(X15-110x-xx)

D382,383 : UDZS6.2B

IC401,402 74AHC1G04GW:

TP558

TP559

TP560

16K

R590

E

N

E

N

E

N

E

N

E

N

E

N

E

N

100

R551

E

D

3.3K

R554 R588 R587

1.8K

E

D

2.2K

E

D

E

D

R556 R589

5.1K

E

D

8.2K

E

D

E

D

E

N

R591

51K

E

D

GREEN

RED

R578 220

R577 560

R580 180

R581 390

5

4

3

2

1

LED

G

LED R

EJECT

SW5V

NC

100

R559

0

R582

VCC

VO

GND

3

2

1

C551

2.2

MODEL NAME

KVT-522DVD

KVT-532DVD

KVT-512

0-71

2-71

0-21

UNIT

0-10

No.

3-21

KVT532DVD

KVT-522DVDY

KVT-50DVDRY

KVT-532DVDM

KVT-532DVD

E

M

R

E

X

K

DESTI-

NATION

YES

R579

22

A

YES

B

YES

D

YES

Q452

YES

R14

YES

R206

YES

R207

YES

R259

YES

IC10

W05-1387-00

W05-1390-00

W05-1388-00

W05-1389-00

W05-1388-00

W05-1390-00

100P

120P

100P

C463

100P

10P

C466

10P

100P

C464,

C465

IC551

2DVDY/532DVD/532DVDM (1/2)

(X15- ) (B/2)

5.0V

0V

CAUTION : For continued safety, re place safe ty critical com po nents only

with manufacturer’s rec om mend ed parts (refer to parts list).

Indicates safety critical com po nents. To reduce the risk of electric shock,

leakage-cur rent or re sis tance mea sure ments shall be carried out (ex posed

parts are ac cept ably in su lat ed from the supply cir cuit) be fore the ap pli ance

is returned to the customer.

• DC voltages are as measured with a high impedance volt me ter. Val ues

may vary slight ly due to vari a tions between in di vid u al in stru ments or/and

units.

DTA114EE

DTA124EE

DTA143XE

DTA143ZE

DTA144EE

DTB123YK

DTC114EE

DTC114YE

DTC114YUA

DTC124EE

DTC143EE

DTC143TUA

DTC143ZE

DTC144EE

2SA1576A

2SC4617

2SB1188

2SB1184

2SA1774

2SC4081

DTA114EUA

DTA114TUA

TA75W558FU-F

KTA1046-P

DAP202U

DA204U

2SK3019

M5237ML-CF0J

TC7WH123FU-F

40

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X35-4960-10 (1/3)

BD BE BF BG BH

1

2

3

4

5

6

7

CN102

D102

D10

3

A/2-

CN3

1/2

CN101

P100

DC/DC

NOT

MONO MULTI

T/C

REWRITE

2.5V

X15-

TP303

TP308

TP307

TP304

TP360

TP157

TP306

TP155

L305

T

P

4

3

2

1

2

3GND

4

VCC

15

1

2

3

4

A

B

CLR

GND

8

7

6

5

VCC

RX/CX

CX

Q

6

7

8

9

10

VIN

SW2

SHDN

VO2

VON

5

4

3

2

1

GND

SW1

CT

FB2

FB1

F100

0.63A

10uH

L100

10

R100

750K

R118

0.01

0.1

C120

1000P

C117

0.01

C121

C119

C116

0.01

C118

0.1

C105

0.01

C110

0.15

C112

150P

0

R114

0

R113

0.1

C115

0.22

C114

150P

C100

R102

L102

3.3uH

L101

10uH

L106

4.7uH

L103

C101

10

C102

22

0.1

12K

R104

R103

160K

C140

SCL21

EX M+ 67

EX M+ 68

EX M-

RI M+

RI M-

NC

SW A

SW B

66

65

64

63

62

61

60

59

58

Z SWT

R SENS

MECHA+3.3V

SW+14V

BL GND

SW C

Z CNT

NC

57

56

55

54

53

52

51

50

49

BL GND

INV PWM

INV SW

ENABLE

YD ATA

XD ATA

PWM

Y0

X1

X0

48

47

46

45

44

43

42

41

40

39

VGND 29

LED B

KEY1

VCOM

LED G

LED R

VGND

NC(VR)

NC(VG)

NC(VB)

38

37

36

35

34

33

32

31

30

TC+3.3V

VGND

28

27

26

25

24

23

22

TP145

E_M+

R_M-

R_M+

E_M-

TP146

TP147

TP149

TP151

TP153

58

59

TP129

M+3.3V

SW+14V

TP138

TP139

TP141

TP142

TP143

TP144

54

55

56

57

TP130

TP132

TP131

TP133

TP134

TP135

TP137

TP136

39

40

41

42

43

44

45

46

47

TP126

TP125

TP124

TP127

TP128

34

35

TP164

TP116 SDA

64

37

38

5

TC+3.3V

NC 3

VGND

COMP

20

19

18

17

16

15

14

13

T P+5V

D GND

LED GND

TC WP

OPEN/CLOSE

NC

12

11

10

9

8

7

6

5

4

P ON+5V

2

1

TP+5V

TP112

TP114

TP113

TP148

TP150

TP115

83

63

TP102

TP105

TP104

TP107

TP106

TP108

TP103

124

123

TP100 +5V

VMUTE

HSY

TC RESET

TC SDA

TC SCL

TC WAIT(GPIO1)

NT PAL

VSY

B

G

R

TP123

TP122

TP121

TP140

SOG

NC

B

G

R

RST

HSY

TP117

TP118

TP109

R302

100

R301

100

TP119

TP120

TP110

TP101

128

127

126

125

124

123

122

121

120

39

40

41

42

43

44

45

46

47

48

49

50

51

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

GND15

AVDDMPLL

AVDDFSCPLL

GND14

HSYNCIN

VSYNCIN

XIN

XOUT

GND13

FB2

SENSE2

PWMOUT1

FB1

SENSE1

CP2FB

CP2N

CP2P

CP1FB

CP1N

CP1P

REFPWM

GND1

VMID

VCLAMP

REFM

REFP

AVDDADC1

SOGIN

BINP

BINM

GINP

GINM

RINP

RINM

AVDDADC2

GND2

C1INP

C1INM

YS1INP

YS1INM

CVBS1P

CVBS1M

CVBS2P

CVBS2M

GND3

AVDDGMC

CLKIN

VD0

VD1

VD2

VD3

VD4

VD5

VD6

VD7

VDDP1

GND4

AVDDPWM

PWMOUT2

10uH

L303

C350

C351

10

0.1

100

R306

1000P

C346

1000P

C347

1

2

3

VIN

VSS

ON/OFF

5

4

VOUT

NC

1

C300

1

C304

L300 10uH

0.01

C301

C302

0.01

10

C303

0.01

C325

0.01

C326

120

L307

120

L306

15P

C328

18P

C327

1M

R336

1K

R303

0.01

C316

C314 0.1

0.1

C344

0.01

C317

C352

0.1

0.01

C318

0.01

C322

0.01

C323

C309 0.1

C307 0.1

C310 0.1

10uH

L308

C353

10

R

G

B

0

R312

R311

0

R310

0.1

C313

C312

0.1

C311

C319 0.1

C320 0.1

C321 0.1

1K

R356

0.1

C342

120

L310

120

L309

0.

0

C3

X300

12.000MHz

124

123

TP317

TP316

36

WP

TP+5V

TC+3.3V

+18V

+5V-1

+5V-2

+5V-2+5V-2 +2.5V

+2.5V

+2.5V +2.5V

+2.5V

TC+3.3V-1

SW+14V

M+3.3V

GND

SCL

SDA

WP

TP111

R309

0

C360 0.1

C361 0.1

C365 0.1

C343 0.01

C364 0.1

C362 0.1

C363 0.1

1K

R357

R347

47K

R353

VSY

0

R304

0

R305

IC103

IC102

IC101

A

IC300

(X35-4960-10) (A/2)

5.0V

0V

4.9V

0V

4.9V

0V

1.3V

4.9V 0V

18.0V

2.6V

3.3V

0V

0.4V

0.9V

0.8V

1.6V

2.4V

0V

0.3V

0V

0.9V

0V

1.0V

0V

1.0V

0V

0.2V

0V

2.4V

0V

4.9V

0V

4.9V

0V

3.3V

4.9V

0V

2.5V

4.8V

54

3

4

3

1

2

3

4

5

7

8

41

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X35-4960-10 (2/3)

BMBLBKBJBI

Q203

Q101

Q102

Q202

Q200

CN302

D101

D104D103

D300

D302

CN103

CN104

to PANEL MECHA

to JIG

VIDEO DECODER

VCOM

FLASH ROM

VCOM BUFF

O

S

W

S

W

E

N

I

N

LE

D

T

B

D

Y

X

IN

V

C

L305

120

TP156

TP201

TP202

TP203

TP204

TP162

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

VCC

NC

DGND

STVR

STVL

CKV

OEV

L/R

OEH

STHL

VGL

VGH

NC

AVDD

NC

VCOM

VSS

STHR

VSS

CPH3

CPH2

CPH1

VSS

VR

VG

VB

VSS

LED R

LED G

LED B

KEY1

T P+5V

XD ATA

YD ATA

X0

X1

Y0

PWM

ENABLE

D GND

LED GND

INV SW

INV PWM

OPEN/CLOSE

BL GND

NC

SW+14V

0.1

C115

0.22

C114

150P

C100

100K

R10111K

R102

2.2

C113

0.01

1

C109

R111 47K

10

C104

10

C200

10K

R108

4.7K

R110

24K

R201

L102

3.3uH

10uH

L104

C103

10uH

L105

0

R205

R225

0

R204

10

C202

0.01

C203

10

C145

10

C107

10K

R109

0.1

C122

10

C106

0.1

C108

4.7K

R112

6

5

7

8VCC

GND 3

4

2

1

0.01

10

C205

C206

2.2K

R207

4.7K

R206

18K

R202

10K

VR200

R216 R209

47

R215

0

R212

100 0

0

R210

47

R214

R208

15K

C204

56P

TP200

C224

10

0.1

C221

2.2K

R222

47K

R223

10

C223

47K

R224

2K

1000P

C222

1.8K

10uH

L200

10

C225

R221 R220

0.01

0.1

0.01

C133

C134

0.01

10uH

L302

TP339

TP340

TP341

TP342

TP343

TP344

TP345

TP346

TP347

TP349

TP348

96

94

92

90

86

85

84

TP350

TP351

TP352

TP353

TP359

TP354

TP355

TP356

TP357

B

G

R

95

99

34

35

5

47

46

45

44

43

42

41

40

39

38

37

E_M+ 1

R_M-

R_M+

E_M-

4

3

2

54

55

R_M-

19

18

17

16

15

14

13

58 3

59

E_M-

R_M+

E_M+

12

11

10

9

8

7

6

5

4

56

57 2

1

EX M+

RI M-

RI M+

EX M-

MECHA+3.3V

DGND

Z CNT

R SENS

NC

RI M-

SW-B

RI M-

RI M+

EX M-

EX M+

NC

SW-A

SW-C

Z SWT

121

120

119

118

117

116

115

114

113

112

111

110

109

108

107

106

105

104

103

102

101

100

99

98

97

96

95

94

93

92

91

90

89

88

87

86

85

84

83

82

81

80

79

78

77

76

75

74

73

72

71

70

69

68

67

66

65

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

XOUT

GND13

AVDDXTAL

AVDDDAC4

VCOMOUT

VCOMDC

REFPDAC

REFMDAC

GND12

VB

AVDDDAC3

VG

GND11

VR

AVDDOPLL

GND10

GND9

VDDC2

ROMEN

INTOUT

GND8

VDDP3

TCON15

TCON14

TCON13

TCON12

TCON11

TCON10

TCON9

TCON8

GPIOP04

TCON7

TCON6

TCON5

TCON4

TCON3

TCON2

TCON1

GPIOP03

VDDP2

GND7

HSYNCO

VSYNCO

DEO

CLKO

FB

OSDB

OSDG

OSDR

RESET

PWMD1

PWMD2

GND6

CS

SCL

SDA

INT

CP1FB

CP1N

CP1P

REFPWM

PGOOD

SAR0

SAR1

SAR2

VDDC1

GND5

SCK

SDI

SDO

CSN

GPIOP24

GPIOP25

GPIOP01

GPIOP02

1

2

3

4

CS

SO

WP

GND

8

7

6

5

VCC

HOLD

SCLK

SI

100

R351

100

R352

0.1

C339

100

R345

100

R344

0.01

C336

58

57

59

60

4.7K

R358

10K

R380

120

L311

47K

1K

R354

0.1

C345

100

R313

0

0.01

C341

C306 100P

C308 100P

C315 100P

C324 100P

C348 100P

100

R314

1000P

C349

C329 100P

C330 100P

C331 100P

R366 100

R367 100

R368 100

R369 100

R370 100

R371 100

R372 100

R373 100

82

R375

100P

C357

30

R376

0.01

C340

0

R346

120

L312

0.01

C338

C333 0.01

15P

C328

6

1K

R303

58

57

60

59

64

63

83

R355

SCL

SDA

RST

R350

84

85

86

HSY

90

92

94

95

96

99

L314

820nH

0.01

C356

10uH

L304

R

G

B

0

R341

0

R342

0

R343

C334 0.01

10

C354

0.1

C355

0.01

C335

0.01

C337

0.01

C332

0

M

Hz

C135

10

R105

C132

C131

10

5.6K

R119

C130

C129

10

2.2K

WP

+12.5V

+12.5V+12.5V

+12.5V

TP+5V TP+5V

TP+5V

6V +18V

+18V

+5V-1 +5V-1

+5V-1

+5V-2 +2.5V

+2.5V +2.5-1V

+2.5-1V

TC+3.3V-1

TC+3.3V-1 TC+3.3V-1

TC+3.3V-1

TP+5V

M+3.3V

SW+14V

M+3.3V

SW+14V

36

TP358

47K

R349

47K

R348

47K

R347

VSY

C150

10

C151

TP205

TP216

TP542

TP541

0

R382

6V

IC200

IC304

IC302

-12.0V

1.3V

0V -12.1V

0V

3.3V

4.2V

2.6V

0V

3.2V

0V

3.3V

0V

3.3V

0V

2.5V

0V

4.9V

2.1V

0.5V

4.9V

2.5V

12.8V

5

1

22

2

5

4

3

5

4

3

4

3

6

9

42

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X35-4960-10 (3/3)

BRBQBPBOBN

1

2

3

4

5

6

7

CN502

BL INVERTER

Q1

D8

D3

D308

D7

Q5

D9

D6

Q3

D1

D2

Q2

Q501

Q502

Q503

CN1

D5

D4

CN501

GND LINE

B LINE

VIDEO LINE

to LCD(BL) to TOUCH PANEL

Q4

D10

D501

D502

D503

D504

to LCD PANEL

SW INVERTER

DRIVER

5V CONSTANT

VOLTAGE

TOUCH PANEL

Y1 SW

X1/Y0 SW

TOUCH PANEL

DIMMER

SW

CN503

D307

D12

D507

D506

D505

to

PANEL

MECHA

D11

S405S404S403S402S401

D401

OPEN/ SCREEN FNC SRC NAVI

D451

D452

D453

D454

D455

D410

D409

D411

CLOSE

IC1 : OZ964ISN-C-SN

IC101 : LT1947-PBF

IC102 : TC7WH123FU-F

IC103 : 74AHC1G04GW

IC200 : TA75W558FU-F

IC300 : S-1112B25MCG

IC302 : AT25F2048-4Z8

IC304 : MST7988LA-ALF

Q1,5,101 : 2SC4081

Q2,3 : SI5504DC-E3

Q4 : DTC114YUA

Q102 : 2SA1576A

Q200 : 2SC4097

Q202 : 2SA1577

Q203 : UMZ1N

Q501 : DTC114YE

Q502,503 : PUMD10

D1,2,7 : UDZW5.6(B)

D3,10 : 1SS355

D4,5,9,12,300,307,308

: DA204U

D6 : MA2S784-F

D8,11,302,401,505-507

: CVS10A120M

D101,103,104

: EP05Q04

D102 : EP05Q06

D409-411,501-504

: CVS10A180M

D451-455 : B30-3201-05

C28

C3

C18

TP56B

TP500

TP511

OPEN/

7

SW+14V

ENABLE

INV SW

LED GND

LED B

T P+5V

8

NC

BL GND

PWM

1

2

3

4

5

11

12

TP538

TP531

TP536

D GND

Y0

X1

X0

YD ATA

XD ATA

KEY1

9

10

13

14

15

16

17

19

20

18

TP528

TP540

TP526

TP529

TP532

TP524

TP527

TP523

TP525

TP533

39

LED G

LED R

INV PWM

21

22

6

23

24

25

26

27

28

TP517

TP519

TP518

29

30

31

32

33

34

35

36

37

38

C500

40

41

42

43

44

45

46

47

48

50

49

2.2

C503 0.01

R502 33K

R9

200K

0.01

NDR D

PDR C

LPWM

PGND

PDR A

NDR B

2.2

R7

OVP

C21

R15

51K

C22

C16

0.018

C9

R5

15K

R18 2.2K

22

C13

0.47

R22

5.1M

R4 43K

1500P

C17

2.2 2.2

CMP

FB

RT1

REF

GNDA

VDDA

SST

ENA

10

9

8

7

6

5

4

3

R3

22

C11

C14 R10

1.6A

F1

C24 0.01

C23 10

0.01 1.5K

R21

100K CTIMR

2

1R13

20 L1

22

11

R12

1M

R17

DIM

LCT

RT

CT

12

13

14

15

16

17

18

19

R6

56K

C8

220P

R16

22

C15

0.047

22 71

2

6

3

5

4

R8

R1

R11

22

C7

0.047

1

10uH

C504 10

C501 0.01

L501

R501 33K

C502 0.01

R14

470

TP50B

C5

10PC6 0.012

C25 2200P

1

2

TP51B EX M+

EX M-

R506 10

R505 10

R504 10

R503 10

2

3

4

1

X1

Y0

X0

Y1

5.1K

TP535

R24

4.7K

TP534

TP55B

TP60B

TP530

C1

10

C2

10

CLOSE

TP+5V

820K

R23 TP57B

C12 0.01

TP58B

Q2,3

Q5

Q501,503

Q502

VSS

VB

VG

VR

VSS

CPH1

CPH2

CPH3

VSS

STHR

VSS

VCOM

NC

AVDD

NC

VGH

VGL

STHL

OEH

L/R

OEV

CKV

STVL

STVR

DGND

NC

VCC

VG4

AVSS

AVDD

VB

1

2

3

STHR11

DGND

CPH1

CPH2

CPH3

VR

VCC

5

6

7

8

9

10

STHL

MOD

VCOM

OEH

L/R

12

13

14

15

16

17

STVL

STVR

OEV

U/D

CKV

VGH

VGL

18

19

20

21

22

23

24

DGND

VCC25

26

0

R507

B

G

R

G

B

41

42

43

44

43

42

41

45

46

47

45

46

47

C506

10 1

C507

TP510

TP509

1

C505

TP537

TP539

TP515

TP513

TP501

3.9K

R402

8.2K

R403

24K

R404

1000P

C401

1.5K

R456

620

R454

1.5K

R455

1.5K

R457

1.5K

R458

1.5K

R441

1.5K

R453

750

R407

1K

R405

750

R406

20

21

22

19

6

22

21

20

6

19

IC1

(X35- ) (B/2)

KVT-50DVDRY/512/522DVD/

522DVDY/532DVD/532DVDM (2/2)

5.0V

0V

1.0V

0V

CAUTION : For continued safety, re place safe ty critical com po-

nents only with manufacturer’s rec om mend ed parts (refer to parts

list).

Indicates safety critical com po nents. To reduce the risk of electric

shock, leakage-cur rent or re sis tance mea sure ments shall be car-

ried out (ex posed parts are ac cept ably in su lat ed from the supply

cir cuit) be fore the ap pli ance is returned to the customer.

• DC voltages are as measured with a high impedance volt me ter.

Val ues may vary slight ly due to vari a tions between in di vid u al in-

stru ments or/and units.

43

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X37-1100-03 (1/3)

BS BT BU BV BW

1

2

3

4

5

6

7

1.7V

5.0V

0V

5V

2.6V

2.2V

0V

3.3V

5V

0V

5.0V

0V

5V

0V

1.7V 0V

0V

5.0V

0V

3.3V

0.2V

1.7V

0V

5.0V

2.2V

0V

3.3V 0V 1.7V

1.7Vref

1.6Vp-p 0V

0V

2.3V

1.7V

1.4-1.9V

0V

2.2V

1.15Vp-p

1.5V

0V

2.1V

1.7V

1.6V

2.1V

2.2V

0.6Vp-p

5.0V

3.3V

0.75Vp-p

2.2V 0.45Vp-p

0.4Vp-p

2.2V

5.0V

0V 3.4V

0V

IC10

IC12

IC1

(X37-1100-0x)

OPTICAL

PICKUP

DRIVER

MOTOR

CN3

Q1

Q4

Q2

Q3

Q14

D5 D6

Q13

Q12

Q17

Q16

Q15

CN1

RF SIGNAL

PROCESSOR

IOP AMP

Q6

Q5

VPU1

M

VM3

LOAD

MOTOR

M

VM2

SLED

MOTOR

VM1

M

SPIMDLE

MOTOR

& LIM SW

R256

IN4

VMSP1

22

LOAD+ 2

LOAD+ 1

C438

C3

0.1

R282

B- 10

A+ 6

LOAD-

A+

3

4

5

A-

B-

7

8

9

B+

W

11

12

13

W

U

V

14

15

16

17

V

H-

HU+

H+

18

19

20

21

PGND

HU- 22

23

24

25

DGND

VCC

26

27

28

270

R17

R19

300

C452

1000P

29

C18

22

38 PGST

37

FO6

RO5

FO5

40

39

GND

RO6

43

42

41

33

RO4

FO4

VMST2

VMST1

36

35

34

MUTE

SFG

BMS

GSW

32

31

30

C435

0.01

C16

10

23

25

H1L

H1H

HB

VMSP2

28

27

26

A1 24

A3

A2

RCS2

21

22

CS

RCS1

18

19

20

C14

1

R16 10K

R1 10K

IN+

IN-

VSS

3

2

110

1

C440

C439

22

C441

22

R270

0

C4

470P

C447

1000P

C449

4700P

C448

C450

4700P

1000P

0.01

C6

C7

0.01

8

C11

0.01

46

IN6

IN5

45

44

SPIN

VREF

FB6

48

47

4

1

2

3

STBY

FG

VDD

IN1

5

6

7

FB1

IN2

FB2

IN3

C13

4700P

C15

0.1

15

RO1

FO1 16

17

RO2

PGAC

FO2

13

14

12

9

10

11

FB3

VMAC

RO3

FO3

10

L1

30

VDD

OUT 4

5

R279

1K

GND(PD) 1

2

R255

4.7

C202

22

C21

10

R158

1

R159

1

10K

R13

FE1 18

R280

4.7

GND(LD) 10

F+H/G+H

E+G/E+F

SW

3

4

5

6

LD CD

LD DVD

NC 7

8

9

33

L6

B14

HFM

GND(G)

RF

11

12

13

A

C

D

15

16

17

C444

1000P

NC 26

22

FE2

TH(-)

TH(+)

19

20

21

VR(CD)

VR(DVD)

NC 23

24

25

30

27

28

29

C224

C223

C222

C220

TP46

TP47

TP48

TP45

0.1

C221

R278

4.7

L2 30

L3 30

RFOUT

RFENV

TESTSG

37 24

6

45

VIN11

VIN4(B)

VIN3(A)

VCC1

48

47

46

LPCO2

LPCO1

LPC1

VIN12

3

2

1

LPC2

5

4

VIN2(D)

VIN1(C)

VREF1

VCC3

VIN8(FE2)

VIN7(FE1)

VCC2

41

44

43

42

40

39

38 VIN6

16

SCK

VFOSHORT

9DTRD

FBAL

8

7

SEN

IDGT

11

10

STDI

12

JLINE

TEOUT

GND3

ASOUT

13

14

15

20

VHALF

FEOUT

GND1

RFD1FO

17

18

19

DGFLT

VREF2

DFLTON

DFLTOP

21

22

23

31

RFINP

RFINN

VIN5

34

35

36

AGCO 32

33

DCRF

28

PEAK

AGCG

29

30

OFTR

BDO

26

27

25

C10

C210

0.1

C212

0.1

C213

3300P

VREF

IMON

SW EJEND

SW LMIN

470P

C8

10K

R22

10K

R21

12K

R6

6.8K

R272

1.2K

R273

12K

R5

6.8K

R274

1.2K

R275

16K

R10

SLD1

TP7

TP6

SLD2

10K

R3

10K

R4

0.01

C5

TP10

LOAD

TP5

SPD

1

R26

1

R27

1.2

R28

1.2

R29

27

R18

32

30

TP3

PGND

TP2

820

R262

33K

R7

1.3K

R260

2.4K

R263

10

C434

20K

R261

TP4

FG

TRD

FOD

TP9

TP8

0.01

C12

R152 100K

R153 100K

2.2

R160

TP209

IOP+

0.1

C215

1.2M

R169

470P

C216

0.047

C218

0.1

C219

0.1

C217

C23

22

C227

11K

R167

27K

R168

TP54

FE1

TP108

FE2

TP198

VREF1

TP111

SEN

SCK

TP112

STDI

TP113

100K

R162

100K

R163

0.1

C208

0.1

C207

TR(+)

FO(-)

TR(-)

FO(+)

VCC

TP63

F

TP62

E

4.7

C225

30

10K

R9

10K

R8

2.2M

R166

TP64 MD

0

R265

1K

R151

1K

R150

100

R165

100

R164

32

30

65

28

27

26

TP15

LOAD+

TP30

TP29

TP14

LOAD-

A+

TP28

A-

B-

TP26

TP31

B+

W

TP24

U

V

TP25

TP16

H-

TP17

TP18

U+

H+

TP19

U-

C214 0.1

VREF2

TP131

0.1

C437

41

40

35

36

39

38

21

26

24

22

27

28

TP12

15

13

11

12

13

15

99

98

102

111

110

109

113

TP204

A5V

112

1

42

48

DVD LD

TP61

1

48

EJEND

TP33

TP27

LMIN

62

66

LO.MUTE

BMS

132

CD LD

TP178

100P

C446

0

R284

IOP

TP81

TP49

RFP

115

67

55

42

DVD ON

TP123

10K

R154

10K

R155

117

CD ON

TP105

58

79

TP11

DRV1.65

A3.3V

TP22

12

11

83

82

DRMU

TP13

A

B

C

D

FE2

FE1

B

A

C

D

FE2

FE1

3

57

69

68

70

81

21

22

24

41

40

39

38

35

36

59

56

61

60

64

75

119

120

TP56 C

TP57 A

TP55 D

TP58 B

P5V

D5V-1

D3.3V

P5V

A5V

A3.3V

A5V

D3.3V

R286 0

R285 0

L4

0

R287

1

2

3

55,57,67-70,81

4

62,65,66

4

44

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X37-1100-03 (2/3)

BX BY BZ CA CB

0V

16.897

8

3.3V

0V

3.3V

0V

3.3V

0V

1.6V

3.3V

3.3V0V

1.5V

0V

3.3V

0V

3.3V

1.7V

3.3V

0V

3.3V

1.8Vp-p

1.7Vref

0V

1.3V

0V

0.6Vp-p

1.6V

2.2V

1.5V

1.7V

1.1V

3.3V

1.7V

2.3V 1.5Vp-p

1.7Vref

0.7V

1.6-1.8V

1.5V

1.4-1.8V

1.7V

0.6V

0V

3.3V

0V

1.7V

1.7Vref

0.4Vp-p

1.2V

3.3V

0V

0.4V

3.3V

0V

3.3V

0V

3.3V

0V

1.5V

3.3V

0V 0V

3.3V

0V

5V

0V

0.6V

0V0.6V

0.6V

0.6V 0V

0V

3.3V

0V

0.6V

0.6V 0V

3.3V

0V

0.6V

0.6V 0V

3.3V

0V

1.7V

5V

0V

IC4

IC8

D5,6

D8

Q15,18

Q19

D1

Q16,17

Q5,6

Q14

Q12,13

Q1-4

IC9

IC10

IC11

IC12

S1

D1

IC3

IC4

IC5

IC7

IC1

: S-80812CNPF-G

015AZ5.1-F(Y)

1SS387-F

:

DTA143ZE

DTC114EE

1SS402-F

2SA1774

:

S-24CS04AFT

SSM3J15FU-F

TA48S015AF-Q

DTA143XE

2SK3019

2SB1709

:

AN41250A-VB

NJU7042

:

S29AL04D55TFI

S1000N28I4T1G

TA48S033AF-Q

MN103S71F

:

AN22022ABV:

OPTICAL

CONTROLLER

DISC

SIGNAL LINE

B LINE

GND LINE

(X37-1100-0x)

AD8(TEMP DET)

AD5(OFS FOD)

AD4(RFDIFO)

4.7

C17

5

1

114

R105

10K

1000P

R268

0

R55

10K

C72

150P

1000P

C68

MSTPOL

R60 10K

R59 10K

NIOWR

DMARQ

134

133

DASPST

132

131

130

CP2 10K

C74

P9

P12

P11

P10

129

128

127

126

DTRD

IDGT

VDD35

125

124

123

122

118

VSS8

PWM1(TRD)

PWM0(FOD)

AVSSA

121

120

119

AD7(NC)

AD6(IOP)

117

116

115

C67

C66

1500P

C65

680P

C64

2200P

0

R267

4.7K

R54

C55

10P

98

TP156 JITOUT

R53

1M

106

110

AD3(ENV)

AD1(TE)

AD2(AS)

113

112

111

AD0(FE)

TECAPA

AVDDA

JITOUT

109

108

107

102

AVDDB

DSLF1

DSLF2

VREFH

105

104

103

RVI

VHALF

NARF

ARF

101

100

99

0.01

C51

90

94

AVSSB

PLFLT1

PLFLT2

AVSSC

97

96

95

RFDIF

CSLFLT

WBLIN

AVDDC

93

92

91

87

88

TRCRS

89

AVDDD

VCOF

C50

157

146

INTRQ

NDMACK

IORDY

NIORD

VSS9

VDD36

137

136

135

140

139

138

VSS10

NPDIAG

NIOCS16

143 DA1

142

141

DA0

145

144

HDD15

NDASP

NCS3FX

NCS1FX

VDD37

DA2

148

147

151

150

149

VDD38

HDD13

HDD1

HDD14

HDD0

154

153

152

156

155

168

HDD11

HDD3

HDD12

HDD2

VSS11

VDD153

159

158

162

161

160

VDD39

VSS12

HDD5

HDD10

HDD4

165

164

163

167

166

HDD9

169

64

75

VFOSHORT

JLINE 81

82

83

84

85

86

AVSSD

ROUT

LOUT

BDO

OFTR

76

77

78

79

80

TSTSG

TX

VDD152

VSS7

DRV9(BMS)

DRV11(HFM)

DRV12(FEPCK)

DRN13(FEPDT)

DRV14(FEPEN)

DRAMVSS2

DRAMVDD152

DRAMVDD33

70

71

72

73

74

VDD34

FG

65

66

67

68

69

(OFS TE)

DRV1(SPD)

DRV2(FBAL)

DRV3(DVDON)

DRV4(STEP A)

DRV5(STEP B)

DRV7(LO.MUTE)

DRV8(DRV.MUTE)

59

60

61

62

63

VSS6

54

55

56

57

58

VSS5

C92

C94

C2210K

R96

TP203

C121

0.022

R90

12K

R89

12K

TP39

C75 C76 C79

C77

C78

0.022

C120

R100 220

R99 220

C96 22

C97 0.1

TP38 OFTR

TP37 BDO

OFS

TP132

R92 27K

TP42 JLINE

2K

R98

0.1

C95

DRV6(LO/EJ)

DRV10(SW LMIN)

SW EJEND

SW LOST

TP126

TP53

FE

FEO

TE

TP99

TP155

TP154

RFENV

TP153

AS

TEO

PPO

TP127

TP129

PPI

TEI

NARF

TP51

TP52

ARF

6800P

C58

R52 15K

PLFLT1

TP50

WBLIN

TP125

TP103 MON4

TP104 MON5

TP98 MON3

TP97 MON2

TP96 MON1

TP95 MON0

131

TP32

SW LOST

R31 1K

0.1

C436

0.1

C73

2K

R257

4.7K

R56

0.022

C52

47P

C53

C57 680P

51

R50

1000P

C54

1000P

C56

51

R51

C60

C62 1000P

330P

C63

TP128

TP130

0

R266

C61

150P

C70

2K

R58

150P

C69

150P

C71

R57 2K

3

4

G

D

9

8

DRV0

27K

R101

72

FG

TX

98

99

113

112

111

110

102

RFDIFO

109

TP150

VHALF

TP151 TP20

AGND

TP21

22

R97

69

70

60

64

67

66

65

68

62

61

58

59

57

75

HFM

82

83

79

81

85

86

120

119

C90 0.01

R11 1K

C93

C99 0.1

117

115

.

3V

22

132

133

134

144

143

142

140

138

137

139

147

149

150

148

47

R102

DRMU

TP13

64

75

119

120

DD15

DD0

DD14

DD13

DD1

DD3

DD2

DD12

DD11

DD5

DD4

DD10

DD9

4.7K

R91

CN2

E41-2603-050-02

0-00

0-01

UNIT

No.

YES

99,100

R97, R259

YES

C96

E41-2598-05

R281

YES

3

FBAL

D5V-1

P5V

D3.3V

P5V

D3.3V

D5V-1 +1.5V

D3.3V

D5V-1

A3

.

3V

A3.3V

55

56

C10,

22,23

10

0-04

0-03

E41-2598-05

YES

10

4.7

10

1

0.1

1

C51,60,61,74-79,81,

82,85,93,94,221-224 443,452

YES

C438,439

E41-2603-05

L2-4

YES

YES YES

YES

Q16,

17 R2

Y

E

Y

E

Y

E

1

2

3

4

2

4

4 4

3

6

5

6

4

3

45

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

X37-1100-03 (3/3)

CGCFCECDCC

1

2

3

4

5

6

7

4.5V 1.5V

1.5V

0V 0V

4.2V

3.3V

0V

4.4V

4.1V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V

3.3V

0V 3.3V

0V

3.3V

0V

1.5V

0V

3.3V

0V0V

3.3V

0V

1.6V

0V

3.3V

0V

3.3V

0V

3.3V

0V

0.8V

2.0V

16.897849MHz

3.3V

0.8V

16.897849MHz

3.3V

3

V

0V

3.3V

0V

3.3V

0V

0.6V

0V

3.3V

0V

3.3V

0V

3.3V

5.0V

0V

IC7

IC9

IC8

IC11

IC3

IC5

X37-1100

CN2

Q18

Q19

P2

P8

S2

D8

3.3V AVR

1.5V AVR

1.5V DET

DATA

MEMORY

FLASH ROM

to MAIN UNIT

L5

30

NC

GND2

6

EN

IN

GND1

OUT

1

2

3

4

5

GND2

6

EN

IN 1

2

GND1

OUT

NC

3

4

5

R113

15K

C104

22

C103 C101

4.7

22

49

50

CP10 82

48

47

46

45

44

43

42

CP9 33

41

40

39

38

37

36

35

34

33

32

31

30

29

28

27

26

22

C100

CP7 33

CP8 33

25

24

23

22

21

20

19

18

CP6 33

17

16

15

14

13

12

11

10

R120

R65

4.7K

10K 2

CP5 33

1000P

C451

6

9

8

7

5

4

3

1

P5V

PGND

D5V

NC(S/PDIF)

DISC DET

D5V

DGND

DASP

CS3FX

CS1FX

DA2

DA0

PDIAG

DA1

INTRQ

DMACK

IORDY

DIOR

DGND

DIOW

DGND

DMARQ

DGND

DD15

DD0

DD14

DD1

DD13

DD2

DD12

DD3

DD11

DD4

DD10

DD5

NC

DD7

DD9

DD6

DD8

DGND

NC

DGND

RESET

VDD31

168 VDD39

VSS12

167

NRESET

VDDH

HDD7

HDD8

HDD6

HDD9

171

170

169

173

172

P1(SDA)

P0(SCL)

MASTER

176

175

174

P4(CDON)

P2(SEL)

FADR17

EXCNT1(FG)

VSS1

P6(NC)

FADR18

FADR11

FADR9

VDD151

FADR8

FADR13

FADR14

DRAMVDD151

NWE

FADR16

FADR15

DRAMVSS1

VSS2

FADR12

FADR7

FADR6

FADR5

FADR4

FADR3

FADR2

FADR1

FADR0

VSS3

VDD32

FDT0

FDT1

FDT2

53

(OFS TE)

54

55

VSS5

TXD/EXTRG0

RXD/EXTRG1

FDT3

FDT4

FDT5

FDT6

FDT7

NCE

FADR10

NOE

SD ATA 48

49

50

51

52

VDD33

OSCI

OSCO

45

46

47

NRST

VSS4

SCLOCK

MMOD

19

1336

C81

1

2

3

R271

470

C445

0.01

C82

4

5

6

7

8

9

10

11

15

12

13

14

16

17

18

C83

72

C80

SCL

SDA

6

5

0.1

A2

GND 3

4

VCC

WP

8A0

A1 1

R83

47K

1

2

3

4

5

6

7

8

9

10

11

12

44

48

47

46

45

A16 A15

BYTE

VSS2

DQ15

DQ7

A14

A13

A12

A11

40

43

42

41

39

38

37

DQ14

DQ6

DQ13

DQ5

A10

A9

A8

NC9

RESET

DQ12

DQ4

VCC

DQ11

NC10

WE

NC13

CP3 10K

CP4 10K

35

C85

27

23

20

21

22

24

25

26

31

28

29

30

32

33

34

43

39

36

37

38

40

41

42

44

14

15

16

17

18

19

20

21

22

23

24

A4OE

32

C84

1

35

34

33

31

30

29

DQ3

DQ10

DQ2

DQ9

NC14

RY/BY

NC16

A17

DQ1

DQ8

DQ0

A7

A6

A5

28

27

26

25

VSS1

CE

A0

A3

A2

A1

R84

47K

C121

0.022

R90

12K

R89

12K

C86

16.897849MHz

R86

X1

10K

1

C9

23

4

VDD

NC

1

VSS

OUT

R124 82

R125 82

R126 82

TP84

TP83

P5V

PGND

TP207

TP208

P5V

PGND

DGND

TP82 D5V

TP80

1.5V

D3.3

TP79

22

C443

22

C442

DGND

82

R121

R63 10K

TP117

SDA

4.7K

R64

SCL

TP118

SCL

SDA

R258 10K

R81 10K

R281 10K

10K

R259 TP202

TEST

C79

12P

C144

0.022

C120

12P

C143

1.5K

R88

1M

R87

TP94

TP93

TP101 SCLOCK

TP102 SDATA

TXD

RXD

OFS

TP132

3

41 VDDOUT

NC

2VSS

TP200

LOEND

10K

CP11

R123 33

10K

R122

TP205TP86

148

150

131

149

142

143

147

144

139

140

138

134

137

133

DRAM 1.5V

TP109

P3(SW LOEND)

DRV0

72

22K

R85

TX

D3.3V

TP152

SDA

SCL

D5

D0

D3

D4

D1

D2

CE

OE

A10

D7

D6

D7

D6

D5

D4

D3

D2

D1

D0

OE

CE

A10

A16

A11

A15

A14

A13

A12

A9

A8

A5

A17

A7

A6

A0

A4

A3

A2

A1

A18

WE

A6

A18

A8

A7

A5

A4

A2

A3

A1

WE

A9

A12

A16

A15

A14

A13

A11

A17

A0

FG

DD15

DD1

DD14

DD0

DD13

DD3

DD12

DD2

DD11

DD5

DD10

DD4

DD9

DD7

DD6

DD8

RST

DD9

RST

DD7

DD8

DD6

E

S

5

9 R281

E

S

YES

85

86

+1.5V

P5V

D5V-1

D3.3V

+1.5V D3.3V

D3.3V

E

S

E

S

R282 R285-

287

YES

5 5

6

7 7

7

CAUTION : For continued safety, re place safe ty critical com po nents only with manufacturer’s rec om mend ed

parts (refer to parts list).

Indicates safety critical com po nents. To reduce the risk of electric shock, leakage-cur rent or re sis tance mea-

sure ments shall be carried out (ex posed parts are ac cept ably in su lat ed from the supply cir cuit) be fore the ap-

pli ance is returned to the customer.

• DC voltages are as measured with a high impedance volt me ter.

Val ues may vary slight ly due to vari a tions between in di vid u al in stru ments or/and units.

46

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

3

2

1

BA

66x2

75

9

7

8

53 43

B

D

B

A

B

894

861

837x2

839

837

817

A

B

A

823

844

824

848

847

849

10

43

70

74

69

43

53

25

96

2

43

69

C

B

A

C

845

887

838

882x2

881x2

873x2

55x2

872

820

821

882

873

871

883

884

883

885

805

98

3

VM1

28

12

67

68

80

36

42

27

41 14

34

32

60

79

65

93

33

15

4

35

13

31

40

890

829

858

891

892

851

877

895

850

822

859

862

Ax2

54

70

A

B

C

D

M1.7x2

φ1.7x4

M2x2

φ2x10

: N09-6382-05

: N09-6408-15

: N09-6426-15

: N09-6104-05

1

EXPLODED VIEW (DVD MECHANISM)

Parts with the exploded numbers larger than 700 are not supplied.

47

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

3

2

1

DC

SIZE AAA BATTERY

(NOT SUPPLIED)

Vx2

Mx2

Vx2

Ux3

J

JJ

KK

U

J

F

V

Fx2

V

F

V

VV

V

T

L

K

V

F

J

K

L

M2.6x3.2

M2.0x4

: N09-6227-15

: N09-6302-04

: N09-6303-04

: N09-6355-05

M

T

U

V

M2.6x27

φ2x5

φ2x7

φ2.6x5

: N09-6491-05

: N82-2005-48

: N82-2007-47

: N86-2605-48

(X35-)

(B/2)

852 FPC2

325

PA1

(X15-)

(B/2)

(X15-)

(X35-)

(A/2)

236

218

212

228 206

DC1

210x2 RC1

226

DC2

211

220

W801

(X15)

208

202

FPC2

276

PA2

201

207

279

736

775

763

773

290

LCD1

274

333 344

284

338

277

852

FPC2

FC3

235

278

FC1

218

VME1

FPC1

PME1

855

859

717

786

820

219

FC2

FC1

854

858

857

724

729

723

725

729

703

853

227

216

213

227

221

215

W351

(X15)

A1

(X15)

F3

Depends on the models. Refer to the parts list.

EXPLODED VIEW (UNIT)

Parts with the exploded numbers larger than 700 are not supplied.

48

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

3

2

1

FE

N

A

B

C

D

E

H

N

P

Q

AA

AB

M2x2.2

M2x3.5

M1.7x2.2

WASHER (1.6x4)

WASHER

RETAINING RING

WASHER

: N09-6205-05

: N09-6206-05

: N09-6207-05

: N09-6211-05

: N09-6255-05

: N09-6270-05

: N19-2195-04

: N19-2303-04

: N29-0538-04

: N19-2327-04

: N19-2328-04

Hx2

Bx2

Cx4

Cx3

805

257

247

246

316

256

252

N

AA

AB

N

C

Q

E

B

A

N

C

H

D

H

N

B

P

734

783

231

295

260

254

256

232

318

296

249

300

348

320

258

250

238

296

292

321

PM2

PM1

243

237

296

233

328

302

308

240

FC3

239

251

253

252

329

244

347

259

310

319

248

294

314

293

309

806

EXPLODED VIEW (DISPLAY ASSY)

Parts with the exploded numbers larger than 700 are not supplied.

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

✽ New parts

Parts without Parts No. are not supplied.

Les articles non mentionnes dans le Parts No. ne sont pas fournis.

Teile ohne Parts No. werden nicht geliefert.

49

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

201 1D

✽

A21-6612-02+ DRESSING PANEL E3

201 1D

✽

A21-6662-12+ DRESSING PANEL KR1E1

201 1D

✽

A21-6662-12+ DRESSING PANEL

E2M1M2

201 1D

✽

A21-6662-12+ DRESSING PANEL X1

202 1D

✽

A21-6663-03+ DRESSING PANEL

PA1 3C

✽

A64-4489-02 PANEL ASSY KR1X1

PA1 3C

✽

A64-4491-02 PANEL ASSY

E1E2M1

PA1 3C

✽

A64-4491-02 PANEL ASSY M2E3

RC1 1C A70-2083-15

REMOTE CONTROLLER ASS(RC-DV340

E2M1M2

RC1 1C A70-2083-15

REMOTE CONTROLLER ASS (RC-DV340

X1E3

-

✽

B54-4637-00

INSTALLATION MANU (ENG.FRE.SPA)

KR1

-

✽

B54-4638-00 INSTALLATION MANUAL (POR.) R1

-

✽

B54-4639-00 INSTALLATION MANUAL (ENG.)

E1E2E3

-

✽

B54-4640-00

INSTALLATION MANU (F.G.D.I.S.P)

E1

-

✽

B54-4641-00 INSTALLATION MANUAL (RUS.) E2E3

-

✽

B54-4642-00

INSTALLATION MA (ENG.S-CHI.KOR)

M1M2X1

-

✽

B64-4021-00 INSTRUCTION MANUAL (ENG.) KR1

-

✽

B64-4022-00 INSTRUCTION MANUAL (FRE.) K

-

✽

B64-4023-00 INSTRUCTION MANUAL (SPA.) KR1

-

✽

B64-4024-00 INSTRUCTION MANUAL (POR.) R1

-

✽

B64-4025-00 INSTRUCTION MANUAL (ENG.)

E1E2E3

-

✽

B64-4026-00 INSTRUCTION MANUAL (FRE.) E1

-

✽

B64-4027-00 INSTRUCTION MANUAL (GER.) E1

-

✽

B64-4028-00 INSTRUCTION MANUAL (DUT.) E1

-

✽

B64-4029-00 INSTRUCTION MANUAL (ITA.) E1

-

✽

B64-4030-00 INSTRUCTION MANUAL (SPA.) E1

-

✽

B64-4031-00 INSTRUCTION MANUAL (POR.) E1

-

✽

B64-4032-00 INSTRUCTION MANUAL (RUS.) E2E3

-

✽

B64-4033-00 INSTRUCTION MANUAL (ENG.)

M1M2X1

-

✽

B64-4034-00 INSTRUCTION MANUAL (S-CHI.) M1

-

✽

B64-4035-00 INSTRUCTION MANUAL (KOR.) M1

206 1C B07-3159-02 ESCUTCHEON

207 1C B43-1518-04 BADGE

208 2C B43-1527-04 BADGE

210 1C D10-4589-04 LEVER

211 2D

✽

E30-6812-05 CORD WITH PLUG

E1E2M1

211 2D

✽

E30-6812-05 CORD WITH PLUG

M2X1E3

212 1C

✽

E30-6813-05 CORD WITH PINPLUG

213 3D

✽

E30-6814-05 CONNECTING CORD ASSY

215 3D

✽

E30-6817-05 CORD WITH PLUG (IPOD)

216 2D

✽

E30-6818-05 CORD WITH PLUG (NAVI)

DC1 1C

✽

E30-6815-05 DC CORD

KR1M1

DC1 1C

✽

E30-6815-05 DC CORD M2X1

DC2 1C

✽

E30-6816-05 DC CORD (ISO)

E1E2E3

FC1 2D

✽

E39-0999-05 FLAT CABLE (50P)

FC2 3C

✽

E39-1000-05 FLAT CABLE (11P)

218 1D

✽

F07-1189-04 COVER

219 3D F09-1206-04 SHEET

220 2D F09-2929-04 CAP

221 3D

✽

F09-2971-05 FAN

F3 1C F05-1537-05 FUSE 15A

-

✽

H54-4298-03 ITEM CARTON CASE K

-

✽

H54-4299-03 ITEM CARTON CASE R1

-

✽

H54-4300-03 ITEM CARTON CASE M1X1

-

✽

H54-4301-03 ITEM CARTON CASE E1

-

✽

H54-4302-03 ITEM CARTON CASE E2

-

✽

H54-4306-03 ITEM CARTON CASE M2

-

✽

H54-4382-03 ITEM CARTON CASE E3

226 1D J21-9716-03 MOUNTING HARDWARE ASSY

227 3D

✽

J32-1388-04 HEXAGON BOSS

228 1C

✽

N99-1758-15 SCREW SET

KR1M1

228 1C

✽

N99-1758-15 SCREW SET M2X1

F 3D N09-6227-15 MACHINE SCREW (M2.6X 3.2NI)

J 1D N09-6302-04 MACHINE SCREW

K 1D N09-6303-04 MACHINE SCREW

L 3C N09-6355-05 MACHINE SCREW (M2.0X4)

M 2D N09-6491-05 MACHINE SCREW (M2.6X27)

T 3C N82-2005-48

BINDING HEAD TAPTITE SCREW

V 3D N86-2605-48

BINDING HEAD TAPTITE SCREW

231 3F

✽

A10-5164-12 CHASSIS CALKING ASSY

232 2F

✽

A10-5166-33 CHASSIS CALKING ASSY

233 2F

✽

A10-5168-13 CHASSIS CALKING ASSY

235 1D

✽

A46-1857-22+ REAR COVER

PA2 2C

✽

A64-4481-11+ PANEL ASSY K

PA2 2C

✽

A64-4482-11+ PANEL ASSY R1

PA2 2C

✽

A64-4483-11+ PANEL ASSY E1E2

PA2 2C

✽

A64-4484-11+ PANEL ASSY

M1M2X1

PA2 2C

✽

A64-4611-01+ PANEL ASSY E3

PME1 1D A10-5171-51 CHASSIS ASSY

236 1C

✽

B07-3241-12 ESCUTCHEON K

236 1C

✽

B07-3242-12 ESCUTCHEON

M1M2X1

236 1C

✽

B07-3243-12 ESCUTCHEON E1E2

236 1C

✽

B07-3266-02 ESCUTCHEON R1

236 1C

✽

B07-3267-02 ESCUTCHEON E3

237 3F B11-1453-04 REFLECTION SHEET

LCD1 2C B38-1196-05 LCD (7INCH)

238 2F

✽

D10-4836-13 ARM ASSY

239 2F

✽

D10-4837-34 LEVER ASSY

240 2E D10-4840-03 ARM

243 3F D13-2335-03 RACK (GEAR)

244 3F D13-2336-03 RACK (GEAR)

246 1F D13-2338-04 GEAR

247 1F D13-2339-04 GEAR

248 2F D13-2340-04 GEAR

249 1F D13-2341-04 GEAR

250 1F D13-2342-04 GEAR

251 1F D13-2343-04 GEAR

252 1E D13-2344-04 GEAR

253 2F D13-2345-04 GEAR

254 2F D13-2346-04 GEAR

256 1E D13-2349-04 GEAR

257 1E D13-2350-04 GEAR

258 1F D13-2351-04 GEAR

KVT-50DVDRY/512/522DVD/522DVDY/532DVD/532DVDM

DISPLAY ASSY

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation Ref. No. A

d

N

e

wParts No. Description Desti-

nation

50

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

259 2F

✽

D13-2457-04 GEAR

260 2F

✽

D21-2446-13 EXTENSION SHAFT

FC3 2F E39-0665-05 FLAT CABLE

274 2C

✽

F09-2950-04 SHEET

276 1D

✽

F09-2951-04 SHEET

277 2D

✽

F09-2952-04 SHEET

278 1D

✽

F09-2953-04 SHEET

279 1D

✽

F09-2954-04 SHEET

284 3C

✽

F12-0966-04 SHIELDING SHEET

290 3C

✽

F20-2447-03 INSULATING SHEET

292 2F G01-3222-04 COMPRESSION SPRING

293 3E

✽

G01-3223-14 TORSION COIL SPRING

294 3E G01-3224-04 TORSION COIL SPRING

295 2F G01-3225-04 EXTENSION SPRING

296 2F G01-3226-04 COMPRESSION SPRING

300 1F G01-4653-04 COMPRESSION SPRING

302 2E G11-3587-04 CUSHION

308 2E J19-7004-03 HOLDER

309 2F J19-7005-04 STABILIZER

310 2F J19-7007-03 HOLDER

314 3E

✽

J22-0198-32 MOUNTING HARDWARE ASSY

316 1E

✽

J22-0200-14 MOUNTING HARDWARE ASSY

318 1F

✽

J22-0202-14 MOUNTING HARDWARE ASSY

319 1F

✽

J22-0203-23 MOUNTING HARDWARE ASSY

320 1F

✽

J22-0206-33 MOUNTING HARDWARE ASSY

321 1F J22-0212-04 MOUNTING HARDWARE

325 3C J39-0864-14 SPACER

328 2F J90-1092-03 GUIDE

329 2E J90-1093-03 GUIDE

FPC1 2D

✽

J86-0052-05 FPC (LEAD FREE) (68P)

FPC2 J86-0038-15 FPC (LEAD FREE) (50P)

333 2C

✽

K24-4866-03 PUSH KNOB (NAV)

338 2C

✽

K25-1925-02 PUSH KNOB (SRC/4KEY)

A 2E N09-6205-05 STEPPED SCREW

AA 1F N19-2327-04 FLAT WASHER

AB 1F N19-2328-04 FLAT WASHER

B 2F N09-6206-05 MACHINE SCREW (M2X2.2)

C 2E N09-6207-05 MACHINE SCREW (M2X3.5)

D 3F N09-6211-05 STEPPED SCREW

E 3F N09-6225-05 MACHINE SCREW

H 2E N09-6270-05 MACHINE SCREW (M1.7X2.2)

J 2D N09-6302-04 MACHINE SCREW

K 1D N09-6303-04 MACHINE SCREW

N 1F N19-2195-04

FLAT WASHER (1.6X4X0.25 BLUE)

P 2F N19-2303-04 FLAT WASHER

Q 2E N29-0538-04 RETAINING RING (2)

T 3C N82-2005-48

BINDING HEAD TAPTITE SCREW

U 1D N82-2007-47

BINDING HEAD TAPTITE SCREW

344 2C S79-0858-05 SWITCH ASSY (7INCH/T0.7)

PM1 1F T42-1097-04 MOTOR ASSY

PM2 1F T42-1099-04 MOTOR ASSY

347 2F W02-5121-05 ELECTRIC CIRCUIT MODULE

348 1F W02-5122-05 ELECTRIC CIRCUIT MODULE

F 2C N09-6227-15 MACHINE SCREW (M2.6X 3.2NI)

VME1 2C X92-6160-00

DVD MECHANISM ASSY (DVS-8020V)

D551-559 B30-1605-05 LED (2COLOR PG/RED)

D560 B30-1779-05 LED (1608_SR)

D561 B30-1605-05 LED (2COLOR PG/RED)

C1 CK73FB1C105K CHIP C 1.0UF K

C2 CK73HB1E103K CHIP C 0.010UF K

C3,4 CK73FB1C105K CHIP C 1.0UF K

C5-7 CK73HB1E103K CHIP C 0.010UF K

C8 C90-5670-05 ELECTRO 2200UF 16WV

C9 CK73FB1A335K CHIP C 3.3UF K

C10 CK73FB1C105K CHIP C 1.0UF K

C11 C90-5670-05 ELECTRO 2200UF 16WV

C12 CK73GB1H104K CHIP C 0.10UF K

C13 CK73HB1E103K CHIP C 0.010UF K

C14 CK73FB1E474K CHIP C 0.47UF K

C15 CK73GB1H104K CHIP C 0.10UF K

C16 CK73EB1C106K CHIP C 10UF K

C18 CE32BF1C221M CHIP EL 220UF 16WV

C19 CE32BF0J101M CHIP EL 100UF 6.3WV

C21 CK73FB0J475K CHIP C 4.7UF K

C22 CK73HB0J105K CHIP C 1.0UF K

C24 CK73GB1H104K CHIP C 0.10UF K

C25 CE32BF1C101M CHIP EL 100UF 16WV

C26 CK73FB1E474K CHIP C 0.47UF K

C27 CK73GB1A105K CHIP C 1.0UF K

C28 CE32BF1C101M CHIP EL 100UF 16WV

C29 CK73FB0J475K CHIP C 4.7UF K

C31 CK73GB0J106M CHIP C 10UF M

C32 CK73FB1E104K CHIP C 0.10UF K

C35 CC73HCH1H101J CHIP C 100PF J

C36 CK73HB1C473K CHIP C 0.047UF K

C37 CC73HCH1H221J CHIP C 220PF J

C38 CC73HCH1H101J CHIP C 100PF J

C39 CC73HCH1H470J CHIP C 47PF J

C40 CC73HCH1H221J CHIP C 220PF J

C41 CK73HB1C473K CHIP C 0.047UF K

C43,44 CK73HB1E103K CHIP C 0.010UF K

C45 CK73HB1E223K CHIP C 0.022UF K

C46 CK73HB1E103K CHIP C 0.010UF K

C48-52 CK73HB1H102K CHIP C 1000PF K

C53 CK73FB0J106K CHIP C 10UF K

C54 CK73GB1H104K CHIP C 0.10UF K

C55 CK73HB1E103K CHIP C 0.010UF K

C56 CK73GB1C104K CHIP C 0.10UF K

C57 CK73FB0J106K CHIP C 10UF K

C58 CK73HB1E103K CHIP C 0.010UF K

C59-61 CK73GB1H104K CHIP C 0.10UF K

C62 CK73HB1H102K CHIP C 1000PF K

DVD PLAYER ASSY

VIDEO CONTROL UNIT (X15-110x-xx)

DISPLAY ASSY

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

51

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

C63 CK73GB1C104K CHIP C 0.10UF K

C64,65 CK73HB1H102K CHIP C 1000PF K

C66 CK73EB1E225K CHIP C 2.2UF K

C67 CK73HB1H102K CHIP C 1000PF K

C68-70 CK73GB1H104K CHIP C 0.10UF K

C71 CK73HB1H102K CHIP C 1000PF K

C72,73 CK73HB1E103K CHIP C 0.010UF K

C74-76 CK73HB1H102K CHIP C 1000PF K

C77 CE32AV1A121M CHIP EL 120UF 10WV

C78 CE32AV0J221M CHIP EL 220UF 6.3WV

C80 CK73HB1E103K CHIP C 0.010UF K

C81 CK73GB1H104K CHIP C 0.10UF K

C82,83 CE32BQ1E680M CHIP EL 68UF 25WV

C84 CK73GB1H104K CHIP C 0.10UF K

C85 CK73HB1E103K CHIP C 0.010UF K

C87,88 CK73HB1E103K CHIP C 0.010UF K

C89,90 CK73HB1A104K CHIP C 0.10UF K

C91 CC73HCH1H101J CHIP C 100PF J

C92 CK73GB1C104K CHIP C 0.10UF K

C93 CC73HCH1H221J CHIP C 220PF J

C94,95 CC73HCH1H470J CHIP C 47PF J

C96 CC73HCH1H221J CHIP C 220PF J

C97 CK73HB1C473K CHIP C 0.047UF K

C99 CK73HB1E103K CHIP C 0.010UF K

C100 CK73HB1E223K CHIP C 0.022UF K

C101 CK73HB1E153K CHIP C 0.015UF K

C103-105 CK73HB1H102K CHIP C 1000PF K

C106 CK73FB0J106K CHIP C 10UF K

C107 CK73GB1H104K CHIP C 0.10UF K

C108 CK73HB1E103K CHIP C 0.010UF K

C109 CK73GB1C104K CHIP C 0.10UF K

C110 CK73FB0J106K CHIP C 10UF K

C111 CK73HB1E103K CHIP C 0.010UF K

C112-114 CK73GB1H104K CHIP C 0.10UF K

C115 CK73HB1H102K CHIP C 1000PF K

C116 CK73GB1C104K CHIP C 0.10UF K

C117,118 CK73HB1H102K CHIP C 1000PF K

C119 CK73EB1E225K CHIP C 2.2UF K

C120 CK73HB1H102K CHIP C 1000PF K

C121-123 CK73GB1H104K CHIP C 0.10UF K

C124 CK73HB1H102K CHIP C 1000PF K

C125,126 CK73HB1E103K CHIP C 0.010UF K

C127-129 CK73HB1H102K CHIP C 1000PF K

C130,131 CE32AV0J221M CHIP EL 220UF 6.3WV

C133 CK73HB1E103K CHIP C 0.010UF K

C134 CK73GB1H104K CHIP C 0.10UF K

C135,136 CE32BQ1E680M CHIP EL 68UF 25WV

C137 CK73GB1H104K CHIP C 0.10UF K

C138 CK73HB1E103K CHIP C 0.010UF K

C139 CK73EB1E225K CHIP C 2.2UF K

C140,141 CK73HB1E103K CHIP C 0.010UF K

C142-144 CK73HB1A104K CHIP C 0.10UF K

C145 CK73HB1E103K CHIP C 0.010UF K

C146 CK73EB1A106K CHIP C 10UF K

C147 CK73HB1A104K CHIP C 0.10UF K

C148 CK73HB1E103K CHIP C 0.010UF K

C149 CK73EB1A106K CHIP C 10UF K

C150 CK73HB1A104K CHIP C 0.10UF K

C151 CK73HB1E103K CHIP C 0.010UF K

C152 CK73HB1A104K CHIP C 0.10UF K

C153 CK73HB1E103K CHIP C 0.010UF K

C154 CK73HB1A104K CHIP C 0.10UF K

C155 CK73HB1E103K CHIP C 0.010UF K

C156 CK73HB1A104K CHIP C 0.10UF K

C157 CK73HB1E103K CHIP C 0.010UF K

C161 CK73HB1E103K CHIP C 0.010UF K

C162 CK73HB1A104K CHIP C 0.10UF K

C163 CK73HB1E103K CHIP C 0.010UF K

C164 CK73GB1C104K CHIP C 0.10UF K

C165,166 CK73HB0J105K CHIP C 1.0UF K

C167 CK73HB1A104K CHIP C 0.10UF K

C168 CK73HB1H221K CHIP C 220PF K

C169 CK73HB1A104K CHIP C 0.10UF K

C170 CK73HB1H221K CHIP C 220PF K

C171 CK73HB1A104K CHIP C 0.10UF K

C172 CK73HB1H221K CHIP C 220PF K

C173 CK73GB1H104K CHIP C 0.10UF K

C175 CK73EB1E106K CHIP C 10UF K

C178 CK73EB1E106K CHIP C 10UF K

C180 CK73EB1E106K CHIP C 10UF K

C181 CK73EB1E225K CHIP C 2.2UF K

C182 CK73HB1A104K CHIP C 0.10UF K

C183 CK73HB1H102K CHIP C 1000PF K

C184,185 CK73GB0J106M CHIP C 10UF M

C186-192 CK73HB1A104K CHIP C 0.10UF K

C193 CC73HCH1H180J CHIP C 18PF J

C194 CC73HCH1H220J CHIP C 22PF J

C195 CK73HB1E103K CHIP C 0.010UF K

C196 CK73HB1A104K CHIP C 0.10UF K

C197 CK73HB1E103K CHIP C 0.010UF K

C199-201 CK73HB1A104K CHIP C 0.10UF K

C202 CK73HB1E103K CHIP C 0.010UF K

C203 CK73HB1H102K CHIP C 1000PF K

C229 CK73HB1E103K CHIP C 0.010UF K

C351 CK73HB0J105K CHIP C 1.0UF K

C352 CE32CL1E330M CHIP EL 33UF 25WV

C353-358 CK73FB1C105K CHIP C 1.0UF K

C359 CK73HB1H102K CHIP C 1000PF K

C360 CK73HB0J105K CHIP C 1.0UF K

C361 CK73HB1A104K CHIP C 0.10UF K

C362 CK73EB1C106K CHIP C 10UF K

C363,364 CK73HB1H102K CHIP C 1000PF K

C365 CK73EB1C106K CHIP C 10UF K

C366 CK73HB1A104K CHIP C 0.10UF K

C367 CK73EB1C106K CHIP C 10UF K

C368,369 CK73HB1H102K CHIP C 1000PF K

C370 CK73EB1C106K CHIP C 10UF K

C371 CK73HB1A104K CHIP C 0.10UF K

C372 CK73EB1A106K CHIP C 10UF K

C373,374 CK73HB1H102K CHIP C 1000PF K

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation Ref. No. A

d

N

e

wParts No. Description Desti-

nation

52

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

C375 CK73EB1A106K CHIP C 10UF K

C376 CK73HB1E103K CHIP C 0.010UF K

C377 CK73GB1A474K CHIP C 0.47UF K

C378 CK73GB0J106M CHIP C 10UF M

C379 CK73GB1A474K CHIP C 0.47UF K

C380-383 CK73FB1C105K CHIP C 1.0UF K

C384 CK73FB1A475K CHIP C 4.7UF K

C385 CK73HB1H102K CHIP C 1000PF K

C386 CK73GB0J475K CHIP C 4.7UF K

C387 CK73GB0J106M CHIP C 10UF M

C388 CK73GB0J475K CHIP C 4.7UF K

C389 CK73HB1H102K CHIP C 1000PF K

C390-392 CK73HB1E103K CHIP C 0.010UF K

C397 CK73HB1A104K CHIP C 0.10UF K

C404 CK73EB1C106K CHIP C 10UF K KR1E1

C404 CK73EB1C106K CHIP C 10UF K

E2M1M2

C404 CK73EB1C106K CHIP C 10UF K E3

C405 CK73HB1E103K CHIP C 0.010UF K KR1E1

C405 CK73HB1E103K CHIP C 0.010UF K

E2M1M2

C405 CK73HB1E103K CHIP C 0.010UF K E3

C406,407 CC73HCH1H070D CHIP C 7.0PF D KR1E1

C406,407 CC73HCH1H070D CHIP C 7.0PF D

E2M1M2

C406,407 CC73HCH1H070D CHIP C 7.0PF D E3

C409 CK73EB1C106K CHIP C 10UF K KR1E1

C409 CK73EB1C106K CHIP C 10UF K

E2M1M2

C409 CK73EB1C106K CHIP C 10UF K E3

C410 CC73HCH1H331J CHIP C 330PF J KR1E1

C410 CC73HCH1H331J CHIP C 330PF J

E2M1M2

C410 CC73HCH1H331J CHIP C 330PF J E3

C411-413 CK73GB1A105K CHIP C 1.0UF K

C414 CK73HB1A104K CHIP C 0.10UF K

C417-419 CK73GB1A474K CHIP C 0.47UF K

E1E2M1

C417-419 CK73GB1A474K CHIP C 0.47UF K

M2X1E3

C423 CK73GB1A474K CHIP C 0.47UF K

C424 CK73GB0J106M CHIP C 10UF M

C425 CK73GB1A474K CHIP C 0.47UF K

C427 CK73HB1A104K CHIP C 0.10UF K

E1E2M1

C427 CK73HB1A104K CHIP C 0.10UF K

M2X1E3

C428,429 CK73FB1A335K CHIP C 3.3UF K

C430 CK73HB1A104K CHIP C 0.10UF K

E1E2M1

C430 CK73HB1A104K CHIP C 0.10UF K

M2X1E3

C431 CK73FB1A475K CHIP C 4.7UF K

C432-434 CK73HB0J105K CHIP C 1.0UF K

C435,436 CK73GB1A105K CHIP C 1.0UF K

C437,438 CK73HB0J474K CHIP C 0.47UF K

C439,440 CK73GB1A105K CHIP C 1.0UF K

C441 CK73HB0J105K CHIP C 1.0UF K

C443 CK73HB1E103K CHIP C 0.010UF K

C446 CK73HB1E103K CHIP C 0.010UF K

C447 CK73GB0J106M CHIP C 10UF M

C448,449 CK73FB1C105K CHIP C 1.0UF K

C454,455 CC73HCH1H070D CHIP C 7.0PF D

C456 CE32CL1C470M CHIP EL 47UF 16WV

C457 CE32BQ0J331M CHIP EL 330UF 6.3WV

C459,460 CK73HB1A104K CHIP C 0.10UF K

C462 CK73HB0J105K CHIP C 1.0UF K

C463 CC73GCH1H101J CHIP C 100PF J KR1

C463 CC73GCH1H121J CHIP C 120PF J

E1E2M1

C463 CC73GCH1H121J CHIP C 120PF J

M2X1E3

C464 CC73GCH1H680J CHIP C 68PF J

E1E2M1

C464 CC73GCH1H680J CHIP C 68PF J

M2X1E3

C465 CK73HB0J105K CHIP C 1.0UF K

E1E2M1

C465 CK73HB0J105K CHIP C 1.0UF K

M2X1E3

C466 CC73GCH1H100D CHIP C 10PF D

E1E2M1

C466 CC73GCH1H100D CHIP C 10PF D

M2X1E3

C466 CC73GCH1H101J CHIP C 100PF J KR1

C467 CK73HB1A104K CHIP C 0.10UF K

C468 CK73GB0J106M CHIP C 10UF M

C469 CK73GB1C225K CHIP C 2.2UF K

C470 CK73HB0J105K CHIP C 1.0UF K

C471 CK73GB1C225K CHIP C 2.2UF K

C472-474 CK73HB0J105K CHIP C 1.0UF K

C475 CK73HB1A104K CHIP C 0.10UF K

C476 CK73GB0J106M CHIP C 10UF M

C477,478 CK73EB1A475K CHIP C 4.7UF K

C479 CK73HB0J105K CHIP C 1.0UF K

C480 CK73HB1A104K CHIP C 0.10UF K

C481 CK73HB0J105K CHIP C 1.0UF K

C482 CK73EB1C106K CHIP C 10UF K

C494-499 CK73HB0J105K CHIP C 1.0UF K

C500 CK73HB1E103K CHIP C 0.010UF K

C551 CK73FB1A225K CHIP C 2.2UF K

C601 CK73HB1A104K CHIP C 0.10UF K

C602,603 CK73HB1E103K CHIP C 0.010UF K

C604-606 CK73HB0J105K CHIP C 1.0UF K

C607 CK73GB0J106M CHIP C 10UF M

C621-624 CK73HB1A104K CHIP C 0.10UF K

C625 CK73GB0J475K CHIP C 4.7UF K

C626-630 CK73HB1A104K CHIP C 0.10UF K

C631 CK73GB0J475K CHIP C 4.7UF K

C632-638 CK73HB1A104K CHIP C 0.10UF K

C655,656 CK73GB0J106M CHIP C 10UF M

C657,658 CK73HB1A104K CHIP C 0.10UF K

C661,662 CK73GB0J106M CHIP C 10UF M

C663,664 CK73HB1H222K CHIP C 2200PF K

C665,666 CK73HB1H221K CHIP C 220PF K

C667,668 CK73GB0J106M CHIP C 10UF M

C672 CK73HB0J105K CHIP C 1.0UF K

C673 CK73GB0J106M CHIP C 10UF M

C681 CK73HB1A104K CHIP C 0.10UF K

C692,693 CK73GB1C104K CHIP C 0.10UF K

C701,702 CK73GB0J106M CHIP C 10UF M

C703

✽

CE32BQ0J560M CHIP EL 56UF 6.3WV

C704 CK73HB0J105K CHIP C 1.0UF K

C705-725 CK73HB1A104K CHIP C 0.10UF K

C726,727 CC73GCH1H100D CHIP C 10PF D

C728 CK73HB1A104K CHIP C 0.10UF K

C729,730 CC73HCH1H220J CHIP C 22PF J

C731 CK73GB0J106M CHIP C 10UF M

C732,733 CK73HB1A104K CHIP C 0.10UF K

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

53

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

C734,735 CK73HB1H102K CHIP C 1000PF K

C741 CK73GB0J475K CHIP C 4.7UF K

C742-748 CK73HB1A104K CHIP C 0.10UF K

C751 CK73GB0J475K CHIP C 4.7UF K

C752-758 CK73HB1A104K CHIP C 0.10UF K

C761,762 CK73GB0J106M CHIP C 10UF M

C763,764 CK73HB1A104K CHIP C 0.10UF K

C801-804 CK73GB1A105K CHIP C 1.0UF K

C807 CK73HB0J105K CHIP C 1.0UF K

C808,809 CK73HB1A104K CHIP C 0.10UF K

C811 CK73HB0J105K CHIP C 1.0UF K

C812-825 CK73HB1A104K CHIP C 0.10UF K

C826 CK73HB0J105K CHIP C 1.0UF K

C827,828 CK73HB1A104K CHIP C 0.10UF K

C829 CK73HB0J105K CHIP C 1.0UF K

C830 CK73HB1A104K CHIP C 0.10UF K

C833 CK73HB0J105K CHIP C 1.0UF K

C834,835 CC73GCH1H080D CHIP C 8.0PF D

C836,837 CK73GB0J106M CHIP C 10UF M

C840 CK73HB1A104K CHIP C 0.10UF K

C841 CE32BF1C221M CHIP EL 220UF 16WV

C842 CK73HB1A104K CHIP C 0.10UF K

C843 CK73GB0J106M CHIP C 10UF M

C844 CK73HB1A104K CHIP C 0.10UF K

C851 CK73GB0J106M CHIP C 10UF M

C852 CK73HB1A104K CHIP C 0.10UF K

C853,854 CC73GCH1H030C CHIP C 3.0PF C

C855 CK73HB1A104K CHIP C 0.10UF K

CN2 E41-2735-05 PIN ASSY

CN3 E41-2608-05 FLAT CABLE CONNECTOR

CN4

✽

E41-2963-05 FLAT CABLE CONNECTOR

CN351

✽

E41-2962-05 PIN ASSY

CN352 E41-2806-05 PIN ASSY

CN353

✽

E41-2961-05 PIN ASSY

CN354

✽

E41-2960-05 PIN ASSY

E1E2M1

CN354

✽

E41-2960-05 PIN ASSY

M2X1E3

CN355

✽

E41-2958-05 PIN ASSY

CN356 E40-9106-05 SOCKET FOR PIN ASSY

CN357 E40-9093-05 SOCKET FOR PIN ASSY

CN551

✽

E41-2982-05 FLAT CABLE CONNECTOR

CN701 E41-2603-05 FLAT CABLE CONNECTOR

J1 E58-1043-05 RECTANGULAR RECEPTACLE

J681 E11-0638-05 PHONE JACK

W351

✽

E30-6775-05

CORD WITH PLUG (FM/AM ANT)

W801

✽

E30-6778-05

CORD WITH CONNECTOR (USB)

F1 F53-0306-05 FUSE (UL,CSA) 5A

F2 F53-0297-05 FUSE (UL,CSA) 1.6A

L1 L33-2369-05 CHOKE COIL

L2,3 L92-0373-05 CHIP FERRITE

L4,5

✽

L33-2455-05 CHOKE COIL

L6,7 L33-2369-05 CHOKE COIL

L8,9

✽

L33-2455-05 CHOKE COIL

L10,11 L33-2369-05 CHOKE COIL

L12,13 L92-0319-05 CHIP FERRITE

L353 L41-4795-33 SMALL FIXED INDUCTOR (4.7U)

L355 L41-4795-33 SMALL FIXED INDUCTOR (4.7U) X1

L355,356 L41-4795-33 SMALL FIXED INDUCTOR (4.7U) KR1E1

L355,356 L41-4795-33 SMALL FIXED INDUCTOR (4.7U)

E2M1M2

L355,356 L41-4795-33 SMALL FIXED INDUCTOR (4.7U) E3

L357 L92-0319-05 CHIP FERRITE

L361 L92-0319-05 CHIP FERRITE

L451 L41-1005-33 SMALL FIXED INDUCTOR (10U)

L601-603 L92-0373-05 CHIP FERRITE

L701-706 L92-0373-05 CHIP FERRITE

L731 L92-0373-05 CHIP FERRITE

L741 L92-0373-05 CHIP FERRITE

L751 L92-0373-05 CHIP FERRITE

L801 L92-0642-05 CHIP FERRITE

L803 L92-0642-05 CHIP FERRITE

L804,805 L92-0641-05 FERRITE CORE

L806 L92-0651-05 CHIP FERRITE

L811 L92-0373-05 CHIP FERRITE

L851 L92-0373-05 CHIP FERRITE

X1 L77-2921-05

CRYSTAL RESONATOR (32.768KHZ)

X2

✽

L78-1226-05 RESONATOR (11.059MHZ)

X351

✽

L77-2978-05

CRYSTAL RESONATOR (SMD 4.332M)

KR1E1

X351

✽

L77-2978-05

CRYSTAL RESONATOR (SMD 4.332M)

E2M1M2

X351

✽

L77-2978-05

CRYSTAL RESONATOR (SMD 4.332M)

E3

X701 L77-2866-05

CRYSTAL RESONATOR (27MHZ)

X808 L77-2943-05

CRYSTAL RESONATOR (24.000MHZ)

X851 L77-2921-05

CRYSTAL RESONATOR (32.768KHZ)

V 3D N86-2605-48

BINDING HEAD TAPTITE SCREW

CP701-715

RK74HB1J220J CHIP-COM 22 J 1/16W

CP721-724

RK74HB1J330J CHIP-COM 33 J 1/16W

CP751,752

RK74HB1J103J CHIP-COM 10K J 1/16W

CP753,754

RK74HB1J220J CHIP-COM 22 J 1/16W

R1 RK73HB1J103J CHIP R 10K J 1/16W

R2 RK73EB2E272J CHIP R 2.7K J 1/4W

R3 RK73HB1J102J CHIP R 1.0K J 1/16W

R4 RK73HB1J473J CHIP R 47K J 1/16W

R5 RK73EB2E103J CHIP R 10K J 1/4W

R6 RK73EB2E102J CHIP R 1.0K J 1/4W

R7 RK73HB1J104J CHIP R 100K J 1/16W

R8 RK73EB2E272J CHIP R 2.7K J 1/4W

R9 RK73HB1J102J CHIP R 1.0K J 1/16W

R10 RK73FB2B472J CHIP R 4.7K J 1/8W

R11 RK73HB1J223J CHIP R 22K J 1/16W

R12,13

✽

R92-5226-05 CHIP R 1K J 1/2W

R14 RK73HB1J000J CHIP R 0.0 J 1/16W

E1E2E3

R15 RK73FB2B472J CHIP R 4.7K J 1/8W

R16 RK73HB1J222J CHIP R 2.2K J 1/16W

KR1M1

R16 RK73HB1J222J CHIP R 2.2K J 1/16W M2X1

R17,18 RK73HB1J103J CHIP R 10K J 1/16W

KR1M1

R17,18 RK73HB1J103J CHIP R 10K J 1/16W M2X1

R19,20

✽

R92-5226-05 CHIP R 1K J 1/2W

KR1M1

R19,20

✽

R92-5226-05 CHIP R 1K J 1/2W M2X1

R21 RK73HB1J000J CHIP R 0.0 J 1/16W

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation Ref. No. A

d

N

e

wParts No. Description Desti-

nation

54

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

R25 RK73HB1J104J CHIP R 100K J 1/16W

R26 RK73HB1J473J CHIP R 47K J 1/16W

R27 RK73EB2E103J CHIP R 10K J 1/4W

R28,29 RK73EB2E622J CHIP R 6.2K J 1/4W

R30 RK73GB2A912J CHIP R 9.1K J 1/10W

R31 RK73HB1J153J CHIP R 15K J 1/16W

R32 RK73HB1J473J CHIP R 47K J 1/16W

R33 RK73GH2A104D CHIP R 100K D 1/10W

R34 RK73GH2A333D CHIP R 33K D 1/10W

R35 RK73GH2A513D CHIP R 51K D 1/10W

R36 RK73GH2A684D CHIP R 680K D 1/10W

R37,38 RK73GB2A000J CHIP R 0.0 J 1/10W

R39 RK73GH2A683D CHIP R 68K D 1/10W

R40 RK73GH2A913D CHIP R 91K D 1/10W

R41-45 RK73HB1J224J CHIP R 220K J 1/16W

R46 RK73HB1J304J CHIP R 300K J 1/16W

R47 RK73HB1J303J CHIP R 30K J 1/16W

R48 RK73HB1J224J CHIP R 220K J 1/16W

R49 RK73GB2A202J CHIP R 2.0K J 1/10W

R50 RK73HB1J101J CHIP R 100 J 1/16W

R51 RK73HB1J224J CHIP R 220K J 1/16W

R52 RK73GB2A154J CHIP R 150K J 1/10W

R53 RK73GB2A164J CHIP R 160K J 1/10W

R54 RK73GH2A104D CHIP R 100K D 1/10W

R55 RK73GH2A154D CHIP R 150K D 1/10W

R56 RK73GH2A433D CHIP R 43K D 1/10W

R57 RK73GB2A183J CHIP R 18K J 1/10W

R58 RK73HB1J000J CHIP R 0.0 J 1/16W

R59 RK73HB1J472J CHIP R 4.7K J 1/16W

R60 RK73HB1J561J CHIP R 560 J 1/16W

R68 RK73GB2A823J CHIP R 82K J 1/10W

R69 RK73HB1J103J CHIP R 10K J 1/16W

R70 RK73HB1J224J CHIP R 220K J 1/16W

R71 RK73HB1J333J CHIP R 33K J 1/16W

R72 RK73HB1J224J CHIP R 220K J 1/16W

R73 RK73FB2B221J CHIP R 220 J 1/8W

R74 RK73GH2A273D CHIP R 27K D 1/10W

R75 RK73GH2A472D CHIP R 4.7K D 1/10W

R76 RK73GH2A333D CHIP R 33K D 1/10W

R77 RK73GH2A393D CHIP R 39K D 1/10W

R78 RK73GH2A332D CHIP R 3.3K D 1/10W

R79 RK73HB1J272J CHIP R 2.7K J 1/16W

R80 RK73HB1J104J CHIP R 100K J 1/16W

R81 RK73HB1J473J CHIP R 47K J 1/16W

R88 RK73HB1J000J CHIP R 0.0 J 1/16W

R89 RK73GH2A681D CHIP R 680 D 1/10W

R90 RK73GH2A622D CHIP R 6.2K D 1/10W

R91 RK73HB1J333J CHIP R 33K J 1/16W

R92 RK73GB2A683J CHIP R 68K J 1/10W

R93 RK73GH2A562D CHIP R 5.6K D 1/10W

R94 RK73HB1J103J CHIP R 10K J 1/16W

R95 RK73GH2A113D CHIP R 11K D 1/10W

R98,99 RK73GH2A333D CHIP R 33K D 1/10W

R100,101 RK73GH2A561D CHIP R 560 D 1/10W

R102-104 RK73HB1J000J CHIP R 0.0 J 1/16W

R105,106 RK73GH2A561D CHIP R 560 D 1/10W

R107 RK73HB1J000J CHIP R 0.0 J 1/16W

R108 RK73HB1J220J CHIP R 22 J 1/16W

R109,110 RK73HB1J000J CHIP R 0.0 J 1/16W

R111 RK73HB1J220J CHIP R 22 J 1/16W

R112-116 RK73EB2E100J CHIP R 10 J 1/4W

R117,118 R92-5160-05 CHIP R 0.047 J 1/4W

R119 R92-5159-05 CHIP R 0.033 J 1/4W

R121 RK73HB1J000J CHIP R 0.0 J 1/16W

R123 RK73HB1J000J CHIP R 0.0 J 1/16W

R124 RK73GH2A681D CHIP R 680 D 1/10W

R125 RK73GH2A561D CHIP R 560 D 1/10W

R126 RK73GH2A562D CHIP R 5.6K D 1/10W

R127,128 RK73GB2A683J CHIP R 68K J 1/10W

R129 RK73GH2A103D CHIP R 10K D 1/10W

R130 RK73HB1J103J CHIP R 10K J 1/16W

R133,134 RK73GH2A333D CHIP R 33K D 1/10W

R135-140 RK73HB1J000J CHIP R 0.0 J 1/16W

R141 RK73HB1J220J CHIP R 22 J 1/16W

R142,143 RK73HB1J000J CHIP R 0.0 J 1/16W

R144 RK73HB1J220J CHIP R 22 J 1/16W

R145-149 RK73EB2E100J CHIP R 10 J 1/4W

R150 R92-5158-05 CHIP R 0.022 J 1/4W

R153 R92-5158-05 CHIP R 0.022 J 1/4W

R154-157 RK73HB1J000J CHIP R 0.0 J 1/16W

R159-168 RK73HB1J101J CHIP R 100 J 1/16W

R170-172 RK73HB1J101J CHIP R 100 J 1/16W

R174 RK73GB2A272J CHIP R 2.7K J 1/10W

R175,176 RK73HB1J473J CHIP R 47K J 1/16W

R177 RK73GB2A432J CHIP R 4.3K J 1/10W

R178,179 RK73HB1J473J CHIP R 47K J 1/16W

R180 RK73GB2A432J CHIP R 4.3K J 1/10W

R181,182 RK73HB1J473J CHIP R 47K J 1/16W

R183,184 RK73EB2E101J CHIP R 100 J 1/4W

R185 RK73HB1J101J CHIP R 100 J 1/16W

R186 RK73EB2E102J CHIP R 1.0K J 1/4W

R187,188 RK73EB2E101J CHIP R 100 J 1/4W

R193 RK73HB1J473J CHIP R 47K J 1/16W

R195 RK73HB1J000J CHIP R 0.0 J 1/16W

R196 RK73HB1J473J CHIP R 47K J 1/16W

R198 RK73HB1J000J CHIP R 0.0 J 1/16W

R201 RK73HB1J104J CHIP R 100K J 1/16W

R202-205 RK73HB1J103J CHIP R 10K J 1/16W K

R202-206 RK73HB1J103J CHIP R 10K J 1/16W

R1E1E2

R202-206 RK73HB1J103J CHIP R 10K J 1/16W

M1M2X1

R202-206 RK73HB1J103J CHIP R 10K J 1/16W E3

R207 RK73GB2A103J CHIP R 10K J 1/10W

KM1M2

R207 RK73GB2A303J CHIP R 30K J 1/10W X1

R207 RK73GB2A332J CHIP R 3.3K J 1/10W

E1E2E3

R208 RK73HB1J473J CHIP R 47K J 1/16W

R210,211 RK73HB1J123J CHIP R 12K J 1/16W

R212 RK73HB1J473J CHIP R 47K J 1/16W

R213-215 RK73HB1J101J CHIP R 100 J 1/16W

R216 RK73HB1J103J CHIP R 10K J 1/16W

R217-220 RK73HB1J101J CHIP R 100 J 1/16W

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

55

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

R221,222 RK73HB1J473J CHIP R 47K J 1/16W

R223 RK73HB1J104J CHIP R 100K J 1/16W

R224 RK73HB1J103J CHIP R 10K J 1/16W

R225 RK73HB1J473J CHIP R 47K J 1/16W

R227 RK73HB1J473J CHIP R 47K J 1/16W

R228,229 RK73HB1J222J CHIP R 2.2K J 1/16W

R230,231 RK73HB1J101J CHIP R 100 J 1/16W

R232 RK73HB1J102J CHIP R 1.0K J 1/16W

R233 RK73HB1J223J CHIP R 22K J 1/16W

R234 RK73HB1J102J CHIP R 1.0K J 1/16W

R235-242 RK73HB1J101J CHIP R 100 J 1/16W

R243,244 RK73HB1J471J CHIP R 470 J 1/16W

R245-248 RK73HB1J103J CHIP R 10K J 1/16W

R249-253 RK73HB1J473J CHIP R 47K J 1/16W

R254-256 RK73HB1J101J CHIP R 100 J 1/16W

R257 RK73HB1J473J CHIP R 47K J 1/16W

R258 RK73HB1J101J CHIP R 100 J 1/16W KR1

R258-261 RK73HB1J101J CHIP R 100 J 1/16W

E1E2M1

R258-261 RK73HB1J101J CHIP R 100 J 1/16W

M2X1E3

R260,261 RK73HB1J101J CHIP R 100 J 1/16W KR1

R262 RK73HB1J000J CHIP R 0.0 J 1/16W

R263 RK73HB1J153J CHIP R 15K J 1/16W

R264 RK73HB1J473J CHIP R 47K J 1/16W

R265 RK73HB1J101J CHIP R 100 J 1/16W

R266 RK73HB1J472J CHIP R 4.7K J 1/16W

R267,268 RK73HB1J101J CHIP R 100 J 1/16W

R269 RK73HB1J473J CHIP R 47K J 1/16W

R270,271 RK73HB1J472J CHIP R 4.7K J 1/16W

R272-276 RK73HB1J473J CHIP R 47K J 1/16W

R277 RK73HB1J104J CHIP R 100K J 1/16W

R278-280 RK73HB1J473J CHIP R 47K J 1/16W

R281 RK73HB1J000J CHIP R 0.0 J 1/16W

R282 RK73HB1J102J CHIP R 1.0K J 1/16W

R283 RK73HB1J152J CHIP R 1.5K J 1/16W

R284 RK73HB1J104J CHIP R 100K J 1/16W

R286 RK73HB1J103J CHIP R 10K J 1/16W

R288 RK73HB1J103J CHIP R 10K J 1/16W

R351 RK73HB1J333J CHIP R 33K J 1/16W

R352 RK73HB1J100J CHIP R 10 J 1/16W

R353 RK73GB2A432J CHIP R 4.3K J 1/10W

R354 RK73HB1J471J CHIP R 470 J 1/16W

R355 RK73HB1J223J CHIP R 22K J 1/16W

R356 RK73GB2A221J CHIP R 220 J 1/10W

R357 RK73GB2A123J CHIP R 12K J 1/10W

R358 RK73FB2B101J CHIP R 100 J 1/8W

R359 RK73HB1J471J CHIP R 470 J 1/16W

R360 RK73HB1J223J CHIP R 22K J 1/16W

R361 RK73HB1J471J CHIP R 470 J 1/16W

R363 RK73HB1J223J CHIP R 22K J 1/16W

R364 RK73HB1J473J CHIP R 47K J 1/16W

R365 RK73FB2B101J CHIP R 100 J 1/8W

R366 RK73HB1J471J CHIP R 470 J 1/16W

R367 RK73FB2B101J CHIP R 100 J 1/8W

R368 RK73HB1J471J CHIP R 470 J 1/16W

R369 RK73HB1J223J CHIP R 22K J 1/16W

R370 RK73HB1J473J CHIP R 47K J 1/16W

R372 RK73HB1J223J CHIP R 22K J 1/16W

R374 RK73FB2B101J CHIP R 100 J 1/8W

R375 RK73HB1J471J CHIP R 470 J 1/16W

R376 RK73FB2B101J CHIP R 100 J 1/8W

R377 RK73HB1J471J CHIP R 470 J 1/16W

R378 RK73HB1J223J CHIP R 22K J 1/16W

R381 RK73HB1J223J CHIP R 22K J 1/16W

R383 RK73FB2B101J CHIP R 100 J 1/8W

R384 RK73HB1J471J CHIP R 470 J 1/16W

R385 RK73HB1J102J CHIP R 1.0K J 1/16W

R386 RK73EB2E100J CHIP R 10 J 1/4W

R390 RK73EB2E4R7J CHIP R 4.7 J 1/4W

R394 RK73EB2E100J CHIP R 10 J 1/4W

R400 RK73EB2E101J CHIP R 100 J 1/4W

R401 RK73HB1J100J CHIP R 10 J 1/16W

R402 RK73HB1J750J CHIP R 75 J 1/16W

R403 RK73EB2E750J CHIP R 75 J 1/4W

R404 RK73EB2E100J CHIP R 10 J 1/4W

R405 RK73EB2E4R7J CHIP R 4.7 J 1/4W

R406 RK73EB2E100J CHIP R 10 J 1/4W

R407 RK73EB2E101J CHIP R 100 J 1/4W

R408 RK73HB1J100J CHIP R 10 J 1/16W

R409 RK73HB1J560J CHIP R 56 J 1/16W

R410 RK73EB2E101J CHIP R 100 J 1/4W

R411 RK73HB1J102J CHIP R 1.0K J 1/16W

R412 RK73HB1J223J CHIP R 22K J 1/16W

R413 RK73HB1J222J CHIP R 2.2K J 1/16W KR1E1

R413 RK73HB1J222J CHIP R 2.2K J 1/16W

E2M1M2

R413 RK73HB1J222J CHIP R 2.2K J 1/16W E3

R416,417 RK73HB1J222J CHIP R 2.2K J 1/16W KR1E1

R416,417 RK73HB1J222J CHIP R 2.2K J 1/16W

E2M1M2

R416,417 RK73HB1J222J CHIP R 2.2K J 1/16W E3

R418 RK73EB2E100J CHIP R 10 J 1/4W

R419 RK73EB2E4R7J CHIP R 4.7 J 1/4W

R420 RK73EB2E100J CHIP R 10 J 1/4W

R421 RK73EB2E101J CHIP R 100 J 1/4W

R422 RK73EB2E102J CHIP R 1.0K J 1/4W

R423 RK73EB2E101J CHIP R 100 J 1/4W

R424 RK73EB2E472J CHIP R 4.7K J 1/4W

R425-427 RK73HB1J101J CHIP R 100 J 1/16W

R428 RK73HB1J750J CHIP R 75 J 1/16W

E1E2M1

R428 RK73HB1J750J CHIP R 75 J 1/16W

M2X1E3

R438 RK73HB1J100J CHIP R 10 J 1/16W

E1E2M1

R438 RK73HB1J100J CHIP R 10 J 1/16W

M2X1E3

R439 RK73EB2E101J CHIP R 100 J 1/4W

E1E2M1

R439 RK73EB2E101J CHIP R 100 J 1/4W

M2X1E3

R440,441 RK73EB2E102J CHIP R 1.0K J 1/4W

E1E2M1

R440,441 RK73EB2E102J CHIP R 1.0K J 1/4W

M2X1E3

R442-444 RK73EB2E101J CHIP R 100 J 1/4W

E1E2M1

R442-444 RK73EB2E101J CHIP R 100 J 1/4W

M2X1E3

R445 RK73EB2E000J CHIP R 0.0 J 1/4W

E1E2M1

R445 RK73EB2E000J CHIP R 0.0 J 1/4W

M2X1E3

R446 RK73EB2E102J CHIP R 1.0K J 1/4W

E1E2M1

R446 RK73EB2E102J CHIP R 1.0K J 1/4W

M2X1E3

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation Ref. No. A

d

N

e

wParts No. Description Desti-

nation

56

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

R447 RK73HB1J100J CHIP R 10 J 1/16W

E1E2M1

R447 RK73HB1J100J CHIP R 10 J 1/16W

M2X1E3

R448 RK73EB2E102J CHIP R 1.0K J 1/4W

E1E2M1

R448 RK73EB2E102J CHIP R 1.0K J 1/4W

M2X1E3

R449 RK73EB2E100J CHIP R 10 J 1/4W

E1E2M1

R449 RK73EB2E100J CHIP R 10 J 1/4W

M2X1E3

R450 RK73EB2E4R7J CHIP R 4.7 J 1/4W

E1E2M1

R450 RK73EB2E4R7J CHIP R 4.7 J 1/4W

M2X1E3

R451,452 RK73EB2E100J CHIP R 10 J 1/4W

E1E2M1

R451,452 RK73EB2E100J CHIP R 10 J 1/4W

M2X1E3

R452 RK73EB2E100J CHIP R 10 J 1/4W KR1

R453 RK73EB2E4R7J CHIP R 4.7 J 1/4W

R454 RK73EB2E100J CHIP R 10 J 1/4W

R455 RK73HB1J100J CHIP R 10 J 1/16W

R456 RK73EB2E101J CHIP R 100 J 1/4W

R457 RK73HB1J100J CHIP R 10 J 1/16W

R458 RK73EB2E101J CHIP R 100 J 1/4W

R459 RK73HB1J100J CHIP R 10 J 1/16W

R460 RK73EB2E101J CHIP R 100 J 1/4W

R461 RK73HB1J100J CHIP R 10 J 1/16W

R462 RK73EB2E101J CHIP R 100 J 1/4W

R463-466 RK73HB1J750J CHIP R 75 J 1/16W

R467-469 RK73EB2E102J CHIP R 1.0K J 1/4W

R470 RK73HB1J104J CHIP R 100K J 1/16W

R471 RK73HB1J102J CHIP R 1.0K J 1/16W

R472-475 RK73HB1J103J CHIP R 10K J 1/16W

R476 RK73HB1J101J CHIP R 100 J 1/16W

R477 RK73HB1J103J CHIP R 10K J 1/16W

R478 RK73HB1J101J CHIP R 100 J 1/16W

R479 RK73GB2A472J CHIP R 4.7K J 1/10W

R480 RK73HB1J272J CHIP R 2.7K J 1/16W

R481,482 RK73HB1J122J CHIP R 1.2K J 1/16W

R483 RK73GB2A103J CHIP R 10K J 1/10W

R486,487 RK73HB1J102J CHIP R 1.0K J 1/16W

R488,489 RK73HB1J100J CHIP R 10 J 1/16W

R492 RK73HB1J332J CHIP R 3.3K J 1/16W

R493,494 RK73GH2A271D CHIP R 270 D 1/10W

R495 RK73GH2A123D CHIP R 12K D 1/10W

R501-503 RK73HB1J000J CHIP R 0.0 J 1/16W

R510,511 RK73GH2A102D CHIP R 1.0K D 1/10W

R512,513 RK73HB1J101J CHIP R 100 J 1/16W

R515 RK73HB1J101J CHIP R 100 J 1/16W

R516-519 RK73GH2A102D CHIP R 1.0K D 1/10W

R543-548 RK73HB1J105J CHIP R 1.0M J 1/16W

R551 RK73GB2A101J CHIP R 100 J 1/10W

R554 RK73GB2A332J CHIP R 3.3K J 1/10W

R556 RK73GB2A822J CHIP R 8.2K J 1/10W

R559 RK73EB2E101J CHIP R 100 J 1/4W

R561 RK73GB2A561J CHIP R 560 J 1/10W

R562 RK73GB2A221J CHIP R 220 J 1/10W

R563 RK73GB2A561J CHIP R 560 J 1/10W

R564 RK73GB2A221J CHIP R 220 J 1/10W

R565 RK73GB2A561J CHIP R 560 J 1/10W

R566 RK73GB2A221J CHIP R 220 J 1/10W

R567 RK73GB2A561J CHIP R 560 J 1/10W

R568 RK73GB2A221J CHIP R 220 J 1/10W

R569 RK73GB2A561J CHIP R 560 J 1/10W

R570 RK73GB2A221J CHIP R 220 J 1/10W

R571 RK73GB2A561J CHIP R 560 J 1/10W

R572 RK73GB2A221J CHIP R 220 J 1/10W

R573 RK73GB2A561J CHIP R 560 J 1/10W

R574 RK73GB2A221J CHIP R 220 J 1/10W

R575 RK73GB2A561J CHIP R 560 J 1/10W

R576 RK73GB2A221J CHIP R 220 J 1/10W

R577 RK73GB2A561J CHIP R 560 J 1/10W

R578 RK73GB2A221J CHIP R 220 J 1/10W

R579 RK73GB2A220J CHIP R 22 J 1/10W

R580 RK73GB2A181J CHIP R 180 J 1/10W

R581 RK73GB2A391J CHIP R 390 J 1/10W

R582-586 RK73EB2E000J CHIP R 0.0 J 1/4W

R587 RK73GB2A182J CHIP R 1.8K J 1/10W

R588 RK73GB2A222J CHIP R 2.2K J 1/10W

R589 RK73GB2A512J CHIP R 5.1K J 1/10W

R590 RK73GB2A163J CHIP R 16K J 1/10W

R591 RK73GB2A513J CHIP R 51K J 1/10W

R612 RK73GH2A750D CHIP R 75 D 1/10W

R613 RK73GH2A301D CHIP R 300 D 1/10W

R614 RK73GH2A330D CHIP R 33 D 1/10W

R620-625 RK73GH2A750D CHIP R 75 D 1/10W

R626 RK73GH2A360D CHIP R 36 D 1/10W

R627 RK73GH2A151D CHIP R 150 D 1/10W

R651-654 RK73HB1J220J CHIP R 22 J 1/16W

R661,662 RK73HB1J203J CHIP R 20K J 1/16W

R663,664 RK73HB1J102J CHIP R 1.0K J 1/16W

R665,666 RK73HB1J153J CHIP R 15K J 1/16W

R667,668 RK73HB1J561J CHIP R 560 J 1/16W

R669,670 RK73HB1J473J CHIP R 47K J 1/16W

R673,674 RK73HB1J272J CHIP R 2.7K J 1/16W

R676 RK73HB1J104J CHIP R 100K J 1/16W

R677 RK73HB1J394J CHIP R 390K J 1/16W

R681 RK73HB1J103J CHIP R 10K J 1/16W

R683 RK73HB1J220J CHIP R 22 J 1/16W

R684,685 RK73HB1J331J CHIP R 330 J 1/16W

R686 RK73HB1J220J CHIP R 22 J 1/16W

R687 RK73HB1J103J CHIP R 10K J 1/16W

R688 RK73HB1J220J CHIP R 22 J 1/16W

R690 RK73HB1J000J CHIP R 0.0 J 1/16W

R691 RK73HB1J100J CHIP R 10 J 1/16W

R692 RK73GB2A151J CHIP R 150 J 1/10W

R693 RK73EB2E750J CHIP R 75 J 1/4W

R694,695 RK73HB1J000J CHIP R 0.0 J 1/16W

R696 RK73HB1J220J CHIP R 22 J 1/16W

R697,698 RK73GB2A151J CHIP R 150 J 1/10W

R699 RK73HB1J000J CHIP R 0.0 J 1/16W

R702 RK73HB1J000J CHIP R 0.0 J 1/16W

R703 RK73HB1J102J CHIP R 1.0K J 1/16W

R704 RK73HB1J101J CHIP R 100 J 1/16W

R706-708 RK73HB1J000J CHIP R 0.0 J 1/16W

R709-714 RK73HB1J220J CHIP R 22 J 1/16W

R715-730 RK73HB1J000J CHIP R 0.0 J 1/16W

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

57

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

R732-738 RK73HB1J220J CHIP R 22 J 1/16W

R739,740 RK73HB1J000J CHIP R 0.0 J 1/16W

R742-747 RK73HB1J000J CHIP R 0.0 J 1/16W

R748-753 RK73HB1J220J CHIP R 22 J 1/16W

R754-756 RK73HB1J000J CHIP R 0.0 J 1/16W

R758 RK73HB1J105J CHIP R 1.0M J 1/16W

R759 RK73HB1J102J CHIP R 1.0K J 1/16W

R760-762 RK73HB1J000J CHIP R 0.0 J 1/16W

R763,764 RK73HB1J220J CHIP R 22 J 1/16W

R765 RK73HB1J000J CHIP R 0.0 J 1/16W

R769 RK73GH2A153D CHIP R 15K D 1/10W

R770 RK73GH2A123D CHIP R 12K D 1/10W

R772,773 RK73HB1J103J CHIP R 10K J 1/16W

R776 RK73HB1J103J CHIP R 10K J 1/16W

R777 RK73HB1J102J CHIP R 1.0K J 1/16W

R805,806 RK73EB2E4R7J CHIP R 4.7 J 1/4W

R810,811 RK73HB1J000J CHIP R 0.0 J 1/16W

R812 RK73HB1J103J CHIP R 10K J 1/16W

R814 RK73HB1J103J CHIP R 10K J 1/16W

R815 RK73GH2A622D CHIP R 6.2K D 1/10W

R816,817 RK73HB1J220J CHIP R 22 J 1/16W

R820 RK73HB1J000J CHIP R 0.0 J 1/16W

R823 RK73HB1J103J CHIP R 10K J 1/16W

R825 RK73HB1J102J CHIP R 1.0K J 1/16W

R826 RK73HB1J103J CHIP R 10K J 1/16W

R831 RK73HB1J000J CHIP R 0.0 J 1/16W

R832 RK73GB2A515J CHIP R 5.1M J 1/10W

R833-836 RK73HB1J103J CHIP R 10K J 1/16W

R837 RK73HB1J000J CHIP R 0.0 J 1/16W

R838 RK73HB1J220J CHIP R 22 J 1/16W

R840,841 RK73HB1J103J CHIP R 10K J 1/16W

R843 RK73HB1J000J CHIP R 0.0 J 1/16W

R844 RK73HB1J103J CHIP R 10K J 1/16W

R845 RK73GH2A104D CHIP R 100K D 1/10W

R846 RK73HB1J102J CHIP R 1.0K J 1/16W

R847 RK73HB1J103J CHIP R 10K J 1/16W

R848 RK73HB1J104J CHIP R 100K J 1/16W

R851 RK73HB1J473J CHIP R 47K J 1/16W

R852 RK73HB1J000J CHIP R 0.0 J 1/16W

R854-856 RK73HB1J103J CHIP R 10K J 1/16W

R857,858 RK73HB1J152J CHIP R 1.5K J 1/16W

R859-861 RK73HB1J472J CHIP R 4.7K J 1/16W

R863-880 RK73HB1J103J CHIP R 10K J 1/16W

R881 RK73GB2A202J CHIP R 2.0K J 1/10W

R883 RK73HB1J103J CHIP R 10K J 1/16W

R884,885 RK73HB1J000J CHIP R 0.0 J 1/16W

R886,887 RK73HB1J473J CHIP R 47K J 1/16W

R900 RK73HB1J220J CHIP R 22 J 1/16W

R915 RK73HB1J000J CHIP R 0.0 J 1/16W

R919 RK73HB1J000J CHIP R 0.0 J 1/16W

R920 RK73HB1J103J CHIP R 10K J 1/16W

S551-560 S70-0901-05 TACT SWITCH

D1,2 1SS355 DIODE

D3 UDZW6.2(B) ZENER DIODE

D4,5 1SS355 DIODE

D6-9 1SR154-400 DIODE

D11 UDZW4.7(B) ZENER DIODE

D12 1SS355 DIODE

D13 UDZW6.2(B) ZENER DIODE

D14 EP05Q04 DIODE

D15-18 1SS357-F DIODE

D19-23 CVS10A120M VARISTOR

D24,25 CVS10A180M VARISTOR

D27-31 CVS10A120M VARISTOR

D32 DA204U DIODE

D33-36 CVS10A120M VARISTOR

D37 CVS10A180M VARISTOR

D39 CVS10A180M VARISTOR

D40,41 CVS10A120M VARISTOR

D42 1SS355 DIODE

D351 DAP202U DIODE

D352 1SS355 DIODE

D353,354 CVS10A180M VARISTOR

D355,356 DAP202U DIODE

D357,358 CVS10A180M VARISTOR

D359,360 DAP202U DIODE

D361,362 CVS10A180M VARISTOR

D363,364 DAP202U DIODE

D365 UDZW6.8(B) ZENER DIODE

D366 UDZW6.2(B) ZENER DIODE

D367 UDZW6.8(B) ZENER DIODE

D368 DAP202U DIODE

D369-376 CVL10C270M300 VARISTOR

D378 UDZW6.8(B) ZENER DIODE

D379 UDZW6.2(B) ZENER DIODE

D380,381 CVS10A120M VARISTOR

D382,383 UDZS6.2B ZENER DIODE

D384 CVL10C270M300 VARISTOR

E1E2M1

D384 CVL10C270M300 VARISTOR

M2X1E3

D388 UDZW6.2(B) ZENER DIODE

E1E2M1

D388 UDZW6.2(B) ZENER DIODE

M2X1E3

D389-392 CVS10A120M VARISTOR

E1E2M1

D389-392 CVS10A120M VARISTOR

M2X1E3

D393 UDZW6.8(B) ZENER DIODE

E1E2M1

D393 UDZW6.8(B) ZENER DIODE

M2X1E3

D394,395 UDZW6.2(B) ZENER DIODE

E1E2M1

D394,395 UDZW6.2(B) ZENER DIODE

M2X1E3

D396 UDZW6.8(B) ZENER DIODE

D397-400 CVL10C270M300 VARISTOR

D401 UDZW6.8(B) ZENER DIODE

D402,403 UDZW6.2(B) ZENER DIODE

D404,405 1SS355 DIODE

D406-408 DAP202U DIODE

D409 UDZW6.8(B) ZENER DIODE KR1

D409,410 UDZW6.8(B) ZENER DIODE

E1E2M1

D409,410 UDZW6.8(B) ZENER DIODE

M2X1E3

D411-414 UDZW6.2(B) ZENER DIODE

E1E2M1

D411-414 UDZW6.2(B) ZENER DIODE

M2X1E3

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation Ref. No. A

d

N

e

wParts No. Description Desti-

nation

58

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

D413,414 UDZW6.2(B) ZENER DIODE KR1

D415 1SS355 DIODE

D571-591 CVS10A180M VARISTOR

D592 CVL10C270M300 VARISTOR

D651 DAP202U DIODE

D681 CVL10C270M300 VARISTOR

D682 DA204U DIODE

D701 DAP202U DIODE

D801,802 AVRL1613R3FTA VARISTOR

IC1 XC6201P502PR ANALOGUE IC

IC2 M5237ML-CF0J ANALOGUE IC

IC3,4 LTC3728LEGN ANALOGUE IC

IC5,6 LB1836M-TLM-E ANALOGUE IC

IC7 R1114N331B-TR ANALOGUE IC (3.3V LF)

IC8 74AHC1G08GW MOS-IC

IC9

✽

30878MJBA22GP MICROCONTROLLER IC

IC10 W05-1387-00 ROM IC K

IC10 W05-1388-00 ROM IC

E1E2E3

IC10 W05-1388-00 ROM IC M2

IC10 W05-1389-00 ROM IC M1

IC10 W05-1390-00 ROM IC R1X1

IC12 S-80835CNNB-G MOS-IC

IC13 74AHC1G32GW MOS-IC

IC351 E-TDA7850A ANALOGUE IC

IC354 NJM2505AF-ZB ANALOGUE IC

IC355 E-TDA7478AD ANALOGUE IC KR1E1

IC355 E-TDA7478AD ANALOGUE IC

E2M1M2

IC355 E-TDA7478AD ANALOGUE IC E3

IC356 74AHCT08PW MOS-IC

IC357 E-TDA7415CB ANALOGUE IC

IC358

✽

AK4220 ANALOGUE IC

IC361 NJM2286V-ZB ANALOGUE IC

IC401,402 74AHC1GU04GW MOS-IC

E1E2M1

IC401,402 74AHC1GU04GW MOS-IC

M2X1E3

IC551 PNA4S22M02KW ANALOGUE IC

IC601 MM1671XNRE ANALOGUE IC

IC602 NJM2573V-ZB ANALOGUE IC

IC651 PCM1754DB MOS-IC

IC652 NJM4565V-ZB ANALOGUE IC

IC691 74AHC1G04GW MOS-IC

IC692 74AHC1G08GW MOS-IC

IC701

✽

MS8312A-IQG MICROPROCESSOR IC

IC702

✽

S29GL64A9I4Z4 ROM IC

IC703,704 A2V28S40CTPG6 DRAM IC

IC705 SI-3010KD ANALOGUE IC

IC801 S1R72C05F15 MOS-IC

IC804 MIC2005-08YM6 MOS-IC

IC805 XC6219B332PR ANALOGUE IC

IC806 XC6219B182PR ANALOGUE IC

IC807 74AHC573PW MOS-IC

IC851 341S2094 MICROPROCESSOR IC

Q1 DTC124EE DIGITAL TRANSISTOR

Q2 DTA143ZE DIGITAL TRANSISTOR

Q3 DTC124EE DIGITAL TRANSISTOR

Q4 2SB1188(R) TRANSISTOR

Q5 2SA1774 TRANSISTOR

Q6 DTA114EE DIGITAL TRANSISTOR

Q7 DTC143ZE DIGITAL TRANSISTOR

Q8 2SB1188(R) TRANSISTOR

KR1M1

Q8 2SB1188(R) TRANSISTOR M2X1

Q9 2SC4617 TRANSISTOR

KR1M1

Q9 2SC4617 TRANSISTOR M2X1

Q11-13 2SC4617 TRANSISTOR

Q14 2SA1774 TRANSISTOR

Q15 DTC143ZE DIGITAL TRANSISTOR

Q16 2SA1774 TRANSISTOR

Q17 2SC4617 TRANSISTOR

Q18 DTA114TUA DIGITAL TRANSISTOR

Q19 DTA114EE DIGITAL TRANSISTOR

Q20 DTC143ZE DIGITAL TRANSISTOR

Q21,22 2SC4617 TRANSISTOR

Q23 2SB1184 TRANSISTOR

Q24 2SC4617 TRANSISTOR

Q25 2SA1774 TRANSISTOR

Q26 2SC4617 TRANSISTOR

Q27 2SA1576A TRANSISTOR

Q28 2SC4617 TRANSISTOR

Q29 DTC143ZE DIGITAL TRANSISTOR

Q30 2SB1689 TRANSISTOR

Q35 DTC114YE DIGITAL TRANSISTOR

Q36,37 2SA1774 TRANSISTOR

Q38 TPC8110-F FET

Q39 KTA1046-P TRANSISTOR

Q40 2SA1576A TRANSISTOR

Q41 2SC4081 TRANSISTOR

Q42 2SA1576A TRANSISTOR

Q43 2SC4081 TRANSISTOR

Q44 2SA1576A TRANSISTOR

Q45 DTC143ZE DIGITAL TRANSISTOR

Q46 TPC8110-F FET

Q51 DTC124XUA DIGITAL TRANSISTOR

Q52 DTC143ZE DIGITAL TRANSISTOR

Q53 DTC124XUA DIGITAL TRANSISTOR

Q54,55 HAT2218R-E DUAL FET

Q56,57 DTC124XUA DIGITAL TRANSISTOR

Q58,59 HAT2218R-E DUAL FET

Q60 2SA1576A TRANSISTOR

Q61 2SC4617 TRANSISTOR

Q62 2SA1576A TRANSISTOR

Q63 2SC4617 TRANSISTOR

Q64 2SA1576A TRANSISTOR

Q65 2SC4617 TRANSISTOR

Q66 DTB123YK DIGITAL TRANSISTOR

Q67 DTC143EE DIGITAL TRANSISTOR

Q68 DTB123YK DIGITAL TRANSISTOR

Q69 DTC143EE DIGITAL TRANSISTOR

Q71 DTA124EE DIGITAL TRANSISTOR

Q72 DTC124EE DIGITAL TRANSISTOR

Q73,74 DTC144EE DIGITAL TRANSISTOR

Q75 DTA114EUA DIGITAL TRANSISTOR

Q76 2SK3019 FET

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

59

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Q77 DTA124XUA DIGITAL TRANSISTOR

Q78,79 2SK3019 FET

Q80 DTA114EE DIGITAL TRANSISTOR

Q82 DTA124EE DIGITAL TRANSISTOR

Q350 2SC4081 TRANSISTOR

Q351 DTC143TUA DIGITAL TRANSISTOR

Q352 DTA144EE DIGITAL TRANSISTOR

Q353,354 DTC143TUA DIGITAL TRANSISTOR

Q355 DTA144EE DIGITAL TRANSISTOR

Q356,357 DTC143TUA DIGITAL TRANSISTOR

Q358 DTA144EE DIGITAL TRANSISTOR

Q359 DTC124EE DIGITAL TRANSISTOR

Q360 DTC143TUA DIGITAL TRANSISTOR

Q361 2SA1577 TRANSISTOR

Q362 DTC124EE DIGITAL TRANSISTOR

Q370 2SC4081 TRANSISTOR

Q371 DTA144EE DIGITAL TRANSISTOR

Q372,373 DTC143TUA DIGITAL TRANSISTOR

Q451 2SA1576A TRANSISTOR

Q452 DTC144EE DIGITAL TRANSISTOR

E1E2M1

Q452 DTC144EE DIGITAL TRANSISTOR

M2X1E3

Q453 2SA1774 TRANSISTOR

Q454,455 DTC144EE DIGITAL TRANSISTOR

Q651,652 DTC143TUA DIGITAL TRANSISTOR

Q653 DTA114EUA DIGITAL TRANSISTOR

Q654 2SA1774 TRANSISTOR

Q655 2SC4617 TRANSISTOR

Q681 2SA1576A TRANSISTOR

Q683 DTC143ZE DIGITAL TRANSISTOR

TH351 PRF18BE471QS2 POSITIVE RESISTOR

A1

✽

X86-4030-16 FRONT-END UNIT KR1X1

A1

✽

X86-4032-72 FRONT-END UNIT

E1E2M1

A1

✽

X86-4032-72 FRONT-END UNIT M2E3

D451-453 B30-3201-05 LED (RGB F3)

C1,2 CK73EB1E106K CHIP C 10UF K

C3 C93-1283-05 CHIP C 1.0UF K

C5 C93-1363-05 CHIP C 10PF

C6

✽

C93-1464-05 CHIP C 0.012UF F

C7 CK73GB1H473K CHIP C 0.047UF K

C8 C93-1383-05 CHIP C 220PF F

C9 CK73GB0J225K CHIP C 2.2UF K

C11 CK73GB0J225K CHIP C 2.2UF K

C12 CK73HB1E103K CHIP C 0.010UF K

C13 CK73GB1A474K CHIP C 0.47UF K

C14 CK73HB1E103K CHIP C 0.010UF K

C15 CK73GB1H473K CHIP C 0.047UF K

C16 CK73HB1C183K CHIP C 0.018UF K

C17 CK73HB1E103K CHIP C 0.010UF K

C18 C93-1283-05 CHIP C 1.0UF K

C21 CK73GB0J225K CHIP C 2.2UF K

C22 CK73HB1H152K CHIP C 1500PF K

C23 CK73EB1E106K CHIP C 10UF K

C24 CK73GB1H103K CHIP C 0.010UF K

C25

✽

C93-1460-05 CHIP C 2200PF F

C28 C93-1283-05 CHIP C 1.0UF K

C100 CC73GCH1H151J CHIP C 150PF J

C101 CK73GB1C104K CHIP C 0.10UF K

C102 CK73FB0J106K CHIP C 10UF K

C103 CK73GB1H103K CHIP C 0.010UF K

C104

✽

CK73FB1C106K CHIP C 10UF K

C105 CK73GB1C104K CHIP C 0.10UF K

C106 CK73EB1A106K CHIP C 10UF K

C107 CK73EB1C106K CHIP C 10UF K

C108 CK73GB1C104K CHIP C 0.10UF K

C109 CK73FB1C105K CHIP C 1.0UF K

C110 CK73GB1H103K CHIP C 0.010UF K

C112 CK73FB1E154K CHIP C 0.15UF K

C113 CK73EB1E225K CHIP C 2.2UF K

C114 CK73GB1C224K CHIP C 0.22UF K

C115 CK73GB1C104K CHIP C 0.10UF K

C116 CK73EB0J226K CHIP C 22UF K

C117 CK73HB1H102K CHIP C 1000PF K

C118 CK73GB1H103K CHIP C 0.010UF K

C119 CK73HB1E103K CHIP C 0.010UF K

C120 CK73GB1C104K CHIP C 0.10UF K

C121 CK73HB1E103K CHIP C 0.010UF K

C122 CK73HB1A104K CHIP C 0.10UF K

C129 CK73EB1C106K CHIP C 10UF K

C130 CK73GB1H103K CHIP C 0.010UF K

C131 CK73EB1E106K CHIP C 10UF K

C132 CK73GB1H104K CHIP C 0.10UF K

C133 CK73GB1H103K CHIP C 0.010UF K

C134 CK73FB0J106K CHIP C 10UF K

C135 CK73GB1H103K CHIP C 0.010UF K

C140 CC73GCH1H151J CHIP C 150PF J

C145 CK73EB1C106K CHIP C 10UF K

C150,151

✽

CK73FB1C106K CHIP C 10UF K

C200 CK73EB1A106K CHIP C 10UF K

C202 CK73EB1C106K CHIP C 10UF K

C203 CK73HB1E103K CHIP C 0.010UF K

C204 CC73HCH1H560J CHIP C 56PF J

C205 CK73EB1C106K CHIP C 10UF K

C206 CK73HB1E103K CHIP C 0.010UF K

C221 CK73GB1C104K CHIP C 0.10UF K

C222 CC73HCH1H102J CHIP C 1000PF J

C223-225 CK73EB1C106K CHIP C 10UF K

C300 CK73GB1A105K CHIP C 1.0UF K

C301 CK73GB1H103K CHIP C 0.010UF K

C302 CK73FB0J106K CHIP C 10UF K

C303 CK73GB1H103K CHIP C 0.010UF K

C304 CK73GB1A105K CHIP C 1.0UF K

C306 CC73HCH1H101J CHIP C 100PF J

C307 CK73HB1A104K CHIP C 0.10UF K

C308 CC73HCH1H101J CHIP C 100PF J

C309-314 CK73HB1A104K CHIP C 0.10UF K

C315 CC73HCH1H101J CHIP C 100PF J

C316-318 CK73HB1E103K CHIP C 0.010UF K

C319-321 CK73HB1A104K CHIP C 0.10UF K

VIDEO UNIT (X35-4960-10)

VIDEO CONTROL UNIT (X15-110x-xx)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation Ref. No. A

d

N

e

wParts No. Description Desti-

nation

60

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

C322,323 CK73HB1E103K CHIP C 0.010UF K

C324 CC73HCH1H101J CHIP C 100PF J

C325,326 CK73HB1E103K CHIP C 0.010UF K

C327,328 CC73GCH1H180J CHIP C 18PF J

C329-331 CC73HCH1H101J CHIP C 100PF J

C332-338 CK73HB1E103K CHIP C 0.010UF K

C339 CK73GB1C104K CHIP C 0.10UF K

C340,341 CK73HB1E103K CHIP C 0.010UF K

C342 CK73HB1A104K CHIP C 0.10UF K

C343 CK73HB1E103K CHIP C 0.010UF K

C344,345 CK73HB1A104K CHIP C 0.10UF K

C346,347 CK73HB1H102K CHIP C 1000PF K

C348 CC73HCH1H101J CHIP C 100PF J

C349 CK73HB1H102K CHIP C 1000PF K

C350 CK73FB0J106K CHIP C 10UF K

C351 CK73HB1A104K CHIP C 0.10UF K

C352 CK73FB0J106K CHIP C 10UF K

C353 CK73HB1A104K CHIP C 0.10UF K

C354 CK73FB0J106K CHIP C 10UF K

C355 CK73HB1A104K CHIP C 0.10UF K

C356 CK73HB1E103K CHIP C 0.010UF K

C357 CC73HCH1H101J CHIP C 100PF J

C360-365 CK73HB1A104K CHIP C 0.10UF K

C401 CK73HB1H102K CHIP C 1000PF K

C500 CK73GB0J225K CHIP C 2.2UF K

C501-503 CK73HB1E103K CHIP C 0.010UF K

C504 CK73FB0J106K CHIP C 10UF K

C505 CK73GB1A105K CHIP C 1.0UF K

C506 CK73FB0J106K CHIP C 10UF K

C507 CK73EB1E105K CHIP C 1.0UF K

CN1 E41-2874-05 PIN ASSY

CN101 E41-2608-05 FLAT CABLE CONNECTOR

CN102 E41-2264-05 PIN ASSY

CN103 E41-2359-05 PIN ASSY

CN104 E41-2444-05 FLAT CABLE CONNECTOR

CN302 E41-2761-05 FLAT CABLE CONNECTOR

CN501 E41-2087-05 FLAT CABLE CONNECTOR

CN502 E41-2762-05 FLAT CABLE CONNECTOR

CN503 E41-2901-15 FLAT CABLE CONNECTOR

F1 F53-0297-05 FUSE (UL,CSA) 1.6A

F100 F53-0280-05 FUSE 0.63A

L1 L19-0783-05

TRANSFORMER FOR CONVERTER

L100

✽

L33-2454-05 CHOKE COIL

L101,102 L41-3392-13

SMALL FIXED INDUCTOR (3.3UH)

L103 L41-4792-13

SMALL FIXED INDUCTOR (4.7UH)

L104-106 L41-1005-33 SMALL FIXED INDUCTOR (10U)

L200 L41-1005-33 SMALL FIXED INDUCTOR (10U)

L300

✽

L33-2454-05 CHOKE COIL

L302-304 L41-1005-33 SMALL FIXED INDUCTOR (10U)

L305-307 L92-0319-05 CHIP FERRITE

L308 L41-1005-33 SMALL FIXED INDUCTOR (10U)

L309-312 L92-0319-05 CHIP FERRITE

L314 L41-8281-15

SMALL FIXED INDUCTOR (0.82U)

L501 L41-1005-33 SMALL FIXED INDUCTOR (10U)

X300 L77-2963-05 CRYSTAL RESONATOR (12M)

R1 RK73HB1J512J CHIP R 5.1K J 1/16W

R3 RK73HB1J220J CHIP R 22 J 1/16W

R4 RK73GH2A433D CHIP R 43K D 1/10W

R5 RK73HB1J153J CHIP R 15K J 1/16W

R6 RK73HH1J563D CHIP R 56K D 1/16W

R7 RK73HB1J220J CHIP R 22 J 1/16W

R8 RK73HB1J512J CHIP R 5.1K J 1/16W

R9 RK73HH1J204D CHIP R 200K D 1/16W

R10 RK73FB2B152J CHIP R 1.5K J 1/8W

R11 RK73HB1J220J CHIP R 22 J 1/16W

R12 RK73HB1J105J CHIP R 1.0M J 1/16W

R13 RK73HB1J220J CHIP R 22 J 1/16W

R14 RK73GH2A471D CHIP R 470 D 1/10W

R15 RK73GH2A513D CHIP R 51K D 1/10W

R16,17 RK73HB1J220J CHIP R 22 J 1/16W

R18 RK73HB1J222J CHIP R 2.2K J 1/16W

R21 RK73HB1J104J CHIP R 100K J 1/16W

R22 RK73GB2A515J CHIP R 5.1M J 1/10W

R23 RK73HH1J824D CHIP R 820K D 1/16W

R24 RK73HB1J472J CHIP R 4.7K J 1/16W

R100 RK73HB1J100J CHIP R 10 J 1/16W

R101 RK73GH2A104D CHIP R 100K D 1/10W

R102 RK73GH2A113D CHIP R 11K D 1/10W

R103 RK73GH2A164D CHIP R 160K D 1/10W

R104 RK73GH2A123D CHIP R 12K D 1/10W

R105 RK73GB2A562J CHIP R 5.6K J 1/10W

R108,109 RK73GB2A103J CHIP R 10K J 1/10W

R110 RK73GB2A472J CHIP R 4.7K J 1/10W

R111 RK73HB1J473J CHIP R 47K J 1/16W

R112 RK73GB2A472J CHIP R 4.7K J 1/10W

R113,114 RK73GB2A000J CHIP R 0.0 J 1/10W

R118 RK73HB1J754J CHIP R 750K J 1/16W

R119 RK73FB2B222J CHIP R 2.2K J 1/8W

R201 RK73HB1J243J CHIP R 24K J 1/16W

R202 RK73HB1J183J CHIP R 18K J 1/16W

R204,205 RK73HB1J000J CHIP R 0.0 J 1/16W

R206 RK73HH1J472D CHIP R 4.7K D 1/16W

R207 RK73HH1J222D CHIP R 2.2K D 1/16W

R208 RK73HH1J153D CHIP R 15K D 1/16W

R209,210 RK73HB1J000J CHIP R 0.0 J 1/16W

R212 RK73HB1J000J CHIP R 0.0 J 1/16W

R214,215 RK73GB2A470J CHIP R 47 J 1/10W

R216 RK73HB1J101J CHIP R 100 J 1/16W

R220 RK73HH1J202D CHIP R 2.0K D 1/16W

R221 RK73HH1J182D CHIP R 1.8K D 1/16W

R222 RK73HB1J222J CHIP R 2.2K J 1/16W

R223,224 RK73HH1J473D CHIP R 47K D 1/16W

R225 RK73GB2A000J CHIP R 0.0 J 1/10W

R301,302 RK73HB1J101J CHIP R 100 J 1/16W

R303 RK73HB1J102J CHIP R 1.0K J 1/16W

R306 RK73HB1J101J CHIP R 100 J 1/16W

R309-312 RK73HB1J000J CHIP R 0.0 J 1/16W

R313,314 RK73HB1J101J CHIP R 100 J 1/16W

VIDEO UNIT (X35-4960-10)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

61

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

R336 RK73HB1J105J CHIP R 1.0M J 1/16W

R341-343 RK73HB1J000J CHIP R 0.0 J 1/16W

R344,345 RK73HB1J101J CHIP R 100 J 1/16W

R346 RK73HB1J000J CHIP R 0.0 J 1/16W

R347-349 RK73HB1J473J CHIP R 47K J 1/16W

R350 RK73HB1J000J CHIP R 0.0 J 1/16W

R351,352 RK73HB1J101J CHIP R 100 J 1/16W

R353-355 RK73HB1J473J CHIP R 47K J 1/16W

R356,357 RK73HH1J102D CHIP R 1.0K D 1/16W

R358 RK73HB1J472J CHIP R 4.7K J 1/16W

R366-373 RK73HB1J101J CHIP R 100 J 1/16W

R375 RK73HB1J820J CHIP R 82 J 1/16W

R376 RK73HB1J300J CHIP R 30 J 1/16W

R380 RK73HB1J103J CHIP R 10K J 1/16W

R382 RK73HB1J000J CHIP R 0.0 J 1/16W

R402 RK73HB1J392J CHIP R 3.9K J 1/16W

R403 RK73HB1J822J CHIP R 8.2K J 1/16W

R404 RK73HB1J243J CHIP R 24K J 1/16W

R405,406 RK73GB2A620J CHIP R 62 J 1/10W

R441 RK73GB2A820J CHIP R 82 J 1/10W

R453 RK73GB2A820J CHIP R 82 J 1/10W

R454 RK73GB2A620J CHIP R 62 J 1/10W

R455-458 RK73GB2A820J CHIP R 82 J 1/10W

R501,502 RK73HB1J333J CHIP R 33K J 1/16W

R503-506 RK73GB2A100J CHIP R 10 J 1/10W

R507 RK73GB2A000J CHIP R 0.0 J 1/10W

VR200 R32-0350-05

SEMI FIXED VARIABLE RESISTOR

S401-405 S70-0901-05 TACT SWITCH

D1,2 UDZW5.6(B) ZENER DIODE

D3 1SS355 DIODE

D4,5 DA204U DIODE

D6 MA2S784-F DIODE

D7 UDZW5.6(B) ZENER DIODE

D8 CVS10A120M VARISTOR

D9 DA204U DIODE

D10 1SS355 DIODE

D11 CVS10A120M VARISTOR

D12 DA204U DIODE

D101 EP05Q04 DIODE

D102 EP05Q06 DIODE

D103,104 EP05Q04 DIODE

D300 DA204U DIODE

D302 CVS10A120M VARISTOR

D307,308 DA204U DIODE

D401 CVS10A120M VARISTOR

D409-411 CVS10A180M VARISTOR

D501-504 CVS10A180M VARISTOR

D505-507 CVS10A120M VARISTOR

IC1 OZ964ISN-C-SN ANALOGUE IC

IC101 LT1947-PBF ANALOGUE IC

IC102 TC7WH123FU-F MOS-IC

IC103 74AHC1G04GW MOS-IC

IC200 TA75W558FU-F ANALOGUE IC

IC300 S-1112B25MCG ANALOGUE IC

IC302

✽

AT25F2048-4Z8 ROM IC

IC304 MST7988LA-ALF MOS-IC

Q1 2SC4081 TRANSISTOR

Q2,3 SI5504DC-E3 DUAL FET

Q4 DTC114YUA DIGITAL TRANSISTOR

Q5 2SC4081 TRANSISTOR

Q101 2SC4081 TRANSISTOR

Q102 2SA1576A TRANSISTOR

Q200 2SC4097 TRANSISTOR

Q202 2SA1577 TRANSISTOR

Q203 UMZ1N TRANSISTOR

Q501 DTC114YE DIGITAL TRANSISTOR

Q502,503 PUMD10 DUAL TRANSISTOR

C3 CK73HB1A104K CHIP C 0.10UF K

C4 CC73HCH1H471J CHIP C 470PF J

C5-7 CK73HB1E103K CHIP C 0.010UF K

C8 CC73HCH1H471J CHIP C 470PF J

C9 CK73HB0J105K CHIP C 1.0UF K

C10 CK73GB0J475K CHIP C 4.7UF K

C11,12 CK73HB1E103K CHIP C 0.010UF K

C13 CK73HB1H472K CHIP C 4700PF K

C14 CK73GB0J106M CHIP C 10UF M

C15 CK73HB1A104K CHIP C 0.10UF K

C16 CK73GB0J106M CHIP C 10UF M

C17 CK73GB0J475K CHIP C 4.7UF K

C18 CK73FB0J226M CHIP C 22UF M

C21 CK73GB0J106M CHIP C 10UF M

C22,23 CK73GB0J475K CHIP C 4.7UF K

C50 CK73HB1E103K CHIP C 0.010UF K

C51 CK73HB1A104K CHIP C 0.10UF K

C52 CK73HB1E223K CHIP C 0.022UF K

C53 CC73HCH1H470J CHIP C 47PF J

C54 CC73HCH1H102J CHIP C 1000PF J

C55 CC73HCH1H100D CHIP C 10PF D

C56 CC73HCH1H102J CHIP C 1000PF J

C57 CC73HCH1E681J CHIP C 680PF J

C58 CK73HB1H682K CHIP C 6800PF K

C60,61 CK73HB1A104K CHIP C 0.10UF K

C62 CC73HCH1H102J CHIP C 1000PF J

C63 CC73HCH1H331J CHIP C 330PF J

C64 CK73HB1H222K CHIP C 2200PF K

C65 CC73HCH1E681J CHIP C 680PF J

C66 CK73HB1H152K CHIP C 1500PF K

C67,68 CC73HCH1H102J CHIP C 1000PF J

C69-72 CC73HCH1H151J CHIP C 150PF J

C73-82 CK73HB1A104K CHIP C 0.10UF K

C83 C93-1228-05 CHIP C 1UF M

C84 CK73HB0J105K CHIP C 1.0UF K

C85 CK73HB1A104K CHIP C 0.10UF K

C86 C93-1228-05 CHIP C 1UF M

C90 CK73HB1E103K CHIP C 0.010UF K

C92 C93-1228-05 CHIP C 1UF M

C93-95 CK73HB1A104K CHIP C 0.10UF K

DVD UNIT (X37-1100-03)

VIDEO UNIT (X35-4960-10)

PARTS LIST

Indicates safety critical com po nents.

Ref. No. A

d

N

e

wParts No. Description Desti-

nation Ref. No. A

d

N

e

wParts No. Description Desti-

nation

62

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

C97 CK73HB1A104K CHIP C 0.10UF K

C99 CK73HB1A104K CHIP C 0.10UF K

C100 CK73FB0J226M CHIP C 22UF M

C101 CK73GB0J475K CHIP C 4.7UF K

C103,104 CK73FB0J226M CHIP C 22UF M

C120,121 CK73HB1E223K CHIP C 0.022UF K

C143,144 CC73HCH1H120J CHIP C 12PF J

C202 CK73FB0J226M CHIP C 22UF M

C207,208 CK73HB1A104K CHIP C 0.10UF K

C210 CK73HB1A104K CHIP C 0.10UF K

C212 CK73HB1A104K CHIP C 0.10UF K

C213 CK73HB1H332K CHIP C 3300PF K

C214,215 CK73HB1A104K CHIP C 0.10UF K

C216 CC73HCH1H471J CHIP C 470PF J

C217 CK73HB1A104K CHIP C 0.10UF K

C218 CK73HB1C473K CHIP C 0.047UF K

C219-224 CK73HB1A104K CHIP C 0.10UF K

C225 CK73GB0J475K CHIP C 4.7UF K

C227 CK73FB0J226M CHIP C 22UF M

C434 CK73GB0J106M CHIP C 10UF M

C435 CK73HB1E103K CHIP C 0.010UF K

C436,437 CK73HB1A104K CHIP C 0.10UF K

C440-442 CK73FB0J226M CHIP C 22UF M

C444 CC73HCH1H102J CHIP C 1000PF J

C445 CK73HB1E103K CHIP C 0.010UF K

C446 CC73HCH1H101J CHIP C 100PF J

C447,448 CC73HCH1H102J CHIP C 1000PF J

C449,450 CK73HB1H472K CHIP C 4700PF K

C451 CC73HCH1H102J CHIP C 1000PF J

CN1 E41-2594-05 FLAT CABLE CONNECTOR

CN2 E41-2603-05 FLAT CABLE CONNECTOR

CN3 E41-2596-05 FLAT CABLE CONNECTOR

L1 L92-0365-05 CHIP FERRITE

L5 L92-0365-05 CHIP FERRITE

L6 L92-0617-05 CHIP FERRITE

X1 L77-2870-05 CRYSTAL RESONATOR

CP2-4 RK74HB1J103J CHIP-COM 10K J 1/16W

CP5-9 RK74HB1J330J CHIP-COM 33 J 1/16W

CP10 RK74HB1J820J CHIP-COM 82 J 1/16W

CP11 RK74HB1J103J CHIP-COM 10K J 1/16W

R1 RK73HB1J103J CHIP R 10K J 1/16W

R3,4 RK73HB1J103J CHIP R 10K J 1/16W

R5,6 RK73HH1J123D CHIP R 12K D 1/16W

R7 RK73HH1J333D CHIP R 33K D 1/16W

R8,9 RK73HB1J103J CHIP R 10K J 1/16W

R10 RK73HB1J163J CHIP R 16K J 1/16W

R11 RK73HB1J102J CHIP R 1.0K J 1/16W

R13 RK73HB1J103J CHIP R 10K J 1/16W

R16 RK73HB1J103J CHIP R 10K J 1/16W

R17 RK73HB1J271J CHIP R 270 J 1/16W

R18 RK73HH1J270D CHIP R 27 D 1/16W

R19 RK73HB1J301J CHIP R 300 J 1/16W

R21,22 RK73HH1J103D CHIP R 10K D 1/16W

R26,27 R92-5146-05 CHIP R 1.0 D 1/4W

R28,29 R92-5147-05 CHIP R 1.2 D 1/4W

R31 RK73HB1J102J CHIP R 1.0K J 1/16W

R50,51 RK73HB1J510J CHIP R 51 J 1/16W

R52 RK73HH1J153D CHIP R 15K D 1/16W

R53 RK73HB1J105J CHIP R 1.0M J 1/16W

R54 RK73HB1J472J CHIP R 4.7K J 1/16W

R55 RK73HB1J103J CHIP R 10K J 1/16W

R56 RK73HH1J472D CHIP R 4.7K D 1/16W

R57,58 RK73HB1J202J CHIP R 2.0K J 1/16W

R59,60 RK73HB1J103J CHIP R 10K J 1/16W

R63 RK73HB1J103J CHIP R 10K J 1/16W

R64,65 RK73HB1J472J CHIP R 4.7K J 1/16W

R81 RK73HB1J103J CHIP R 10K J 1/16W

R83,84 RK73HB1J473J CHIP R 47K J 1/16W

R85 RK73HB1J223J CHIP R 22K J 1/16W

R86 RK73HB1J103J CHIP R 10K J 1/16W

R87 RK73HB1J105J CHIP R 1.0M J 1/16W

R88 RK73HB1J152J CHIP R 1.5K J 1/16W

R89,90 RK73HB1J123J CHIP R 12K J 1/16W

R91 RK73HB1J472J CHIP R 4.7K J 1/16W

R92 RK73HB1J273J CHIP R 27K J 1/16W

R96 RK73HB1J103J CHIP R 10K J 1/16W

R98 RK73HB1J202J CHIP R 2.0K J 1/16W

R101 RK73HH1J273D CHIP R 27K D 1/16W

R102 RK73GB2A470J CHIP R 47 J 1/10W

R105 RK73HB1J103J CHIP R 10K J 1/16W

R113 RK73HB1J153J CHIP R 15K J 1/16W

R120 RK73HB1J103J CHIP R 10K J 1/16W

R121 RK73HB1J820J CHIP R 82 J 1/16W

R122 RK73HB1J103J CHIP R 10K J 1/16W

R123 RK73HB1J330J CHIP R 33 J 1/16W

R124-126 RK73HB1J820J CHIP R 82 J 1/16W

R150,151 RK73HB1J102J CHIP R 1.0K J 1/16W

R152,153 RK73HB1J104J CHIP R 100K J 1/16W

R154,155 RK73HB1J103J CHIP R 10K J 1/16W

R158,159 RK73HB1J1R0J CHIP R 1.0 J 1/16W

R160 R92-3350-05 CHIP R 2.2 F 1/10W

R162,163 RK73HB1J104J CHIP R 100K J 1/16W

R164,165 RK73HH1J101D CHIP R 100 D 1/16W

R166 RK73HB1J225J CHIP R 2.2M J 1/16W

R167 RK73HH1J113D CHIP R 11K D 1/16W

R168 RK73HH1J273D CHIP R 27K D 1/16W

R169 RK73HB1J125J CHIP R 1.2M J 1/16W

R255 R92-5112-05 CHIP R 4.7 F 1/10W

R256 RK73HH1J111D CHIP R 110 D 1/16W

R257 RK73HH1J202D CHIP R 2.0K D 1/16W

R258,259 RK73HB1J103J CHIP R 10K J 1/16W

R260 RK73HH1J132D CHIP R 1.3K D 1/16W

R261 RK73HH1J203D CHIP R 20K D 1/16W

R262 RK73HB1J821J CHIP R 820 J 1/16W

R263 RK73HB1J242J CHIP R 2.4K J 1/16W

R265-268 RK73HB1J000J CHIP R 0.0 J 1/16W

R270 RK73HB1J000J CHIP R 0.0 J 1/16W

R271 RK73HB1J471J CHIP R 470 J 1/16W

R272 RK73HH1J682D CHIP R 6.8K D 1/16W

DVD UNIT (X37-1100-03)

PARTS LIST

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

E1 : KVT-522DVD E2 : KVT-522DVDY E3 : KVT-50DVDRY (Europe)

K : KVT-512 (North America) R1 : KVT-532DVD (Latin America)

X1 : KVT-532DVD (Australia) M1 : KVT-532DVD M2 : KVT-532DVDM (Other Areas)

Ref. No. A

d

N

e

wParts No. Description Desti-

nation

63

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

The IC3, and IC11 in the DVD unit (X37-1100-03) are not

replaceable components. When these ICs are defective,

replace the whole DVD mechanism assembly (X92-6160-00).

R273 RK73HH1J122D CHIP R 1.2K D 1/16W

R274 RK73HH1J682D CHIP R 6.8K D 1/16W

R275 RK73HH1J122D CHIP R 1.2K D 1/16W

R278 R92-5112-05 CHIP R 4.7 F 1/10W

R279 RK73HH1J102D CHIP R 1.0K D 1/16W

R280 RK73HB1J4R7J CHIP R 4.7 J 1/16W

R284 RK73HB1J000J CHIP R 0.0 J 1/16W

R285-287 RK73GB2A000J CHIP R 0.0 J 1/10W

S1 S68-0911-15 PUSH SWITCH

S2 S68-0914-05 PUSH SWITCH

D1 1SS402-F DIODE

D5,6 015AZ5.1-F(Y) ZENER DIODE

D8 1SS387-F DIODE

IC1 AN22022ABV ANALOGUE IC

IC3 - ROM IC

IC4 MN103S71F MOS-IC

IC5 S1000N28I4T1G ANALOGUE IC

IC7 TA48S033AF-Q ANALOGUE IC

IC8 S-80812CNPF-G ANALOGUE IC

IC9 TA48S015AF-Q ANALOGUE IC

IC10 AN41250A-VB ANALOGUE IC

IC11 - ROM IC

IC12 NJU7042 ANALOGUE IC

Q1-4 DTA143XE TRANSISTOR

Q5,6 2SK3019 FET

Q12,13 2SB1709 TRANSISTOR

Q14 SSM3J15FU-F FET

Q15 DTA143ZE TRANSISTOR

Q18 DTA143ZE TRANSISTOR

Q19 DTC114EE TRANSISTOR

1 1A A10-5331-51 CHASSIS

2 2B A10-5332-51 CHASSIS

3 1A A10-5333-31 CHASSIS

4 3A A10-5460-02 CHASSIS

7 1B D10-4918-22 ARM

8 1B D10-4919-22 ARM

9 1B D10-4920-02 LEVER

10 1B D10-4921-02 LEVER

12 2B D10-4922-12 SLIDER

13 2A D10-7011-02 ARM

14 2B D10-4924-13 ARM

15 2B D10-4925-12 ARM

25 2B D10-4973-04 SLIDER ASSY

27 2A D10-4945-04 LEVER

28 2B D12-0639-02 CAM

31 2B D13-2402-04 GEAR

32 2B D13-2403-04 GEAR

33 2B D13-2404-04 GEAR

34 2B D13-2405-04 GEAR

35 2B D13-2406-04 GEAR

36 2B D13-2407-04 GEAR

40 2A D13-2413-04 GEAR

41 2A D13-2415-04 GEAR

42 2A D13-2416-04 GEAR

43 1B D14-1013-14 ROLLER

53 1B D21-2487-24 SHAFT

54 2A D39-0275-05 DAMPER

55 2A D39-0276-05 DAMPER

60 3A F09-2825-23 SHEET

65 2B G01-3298-04 EXTENSION SPRING

66 1B G01-3299-04 EXTENSION SPRING

67 2A G01-3300-14 TORSION COIL SPRING

68 2B G01-4601-04 EXTENSION SPRING

69 1B G01-4602-04 EXTENSION SPRING

70 1B G01-4604-04 TORSION COIL SPRING

74 2B G01-4609-14 TORSION COIL SPRING

75 1B G02-1564-03 FLAT SPRING

79 2A J22-0475-21 MOUNTING HARDWARE

80 3B J22-0636-01 MOUNTING HARDWARE

A 1A N09-6382-05 MACHINE SCREW (M1.7X2.0)

B 3B N09-6408-15 TAPTITE SCREW (1.7X4 P-TITE)

C 1B N09-6426-15

MACHINE SCREW (LOAD ARM SCREW

D 3A N09-6104-05 MACHINE SCREW (2X10 S-TITE)

93 2A T99-0471-05 MAGNET

96 1B X94-2080-00 ROLLER ASSY

98 2A X94-2060-00

TRAVERSE ASSY (PICKUP,SPINDLE)

VM1 2A X94-2070-00 MOTOR ASSY (LOADING)

DVD MECHANISM ASSY (X92-6160-00) (DVS-8020V)

DVD UNIT (X37-1100-03)

64

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

Monitor section

Picture Size ................................ 6.97 inches (diagonal) wide

......................................... 154.08 mm (W) x 86.58 mm (H)

Display Sytem ............................. Transparent TN LCD panel

Drive System ..................................TFT active matrix system

Number of Pixels ....................336,960 (480H x 234V x RGB)

Effective Pixels ......................................................... 99.99 %

Pixel Arrangement .........................RGB striped arrangement

Back Lighting ......................Cold Cathode Fluorescent Tube

DVD player section

D/A Converter ................................................................24 bit

Audio Decoder

............Linear PCM/ Dolby Digital/ dts/ MP3/ WMA/ AAC

Video Decoder .............................................MPEG1/ MPEG2

Wow & Flutter .................................. Below Measurable Limit

Frequency Response

Sampling frequency; 96 kHz ......................20 – 44,000 Hz

Sampling frequency; 48 kHz ......................20 – 22,000 Hz

Sampling frequency; 44.1 kHz ...................20 – 20,000 Hz

Total Harmonic Distortion ............................. 0.010 % (1 kHz)

S/N Ratio (dB) .............................. 98 dB (DVD-Video 96 kHz)

Dynamic Range ........................... 98 dB (DVD-Video 96 kHz)

Disc Format ......................... DVD-Video/ VIDEO-CD/ CD-DA

Sampling Frequency ................................... 44.1/ 48/ 96 kHz

Quantifying Bit Number .................................... 16/ 20/ 24 bit

USB interface section

USB Standard ................................................... USB 1.1/ 2.0

File Sytem ..............................................................FAT 16/ 32

Maximum Power Supply Current .............................. 500 mA

D/A Converter ............................................................... 24 Bit

Audio Decoder ...........................................MP3/ WMA/ AAC

Video Decoder .............................................MPEG1/ MPEG2

FM tuner section

Frequency Range (200 kHz) .............. 87.9 MHz – 107.9 MHz

Usable Sensitivity (S/N : 30 dB) .......... 9.3 dBf (0.8 μV/ 75 Ω)

Quieting Sensitivity (S/N : 50 dB) ...... 15.2 dBf (1.6 μV/ 75 Ω)

Frequency Response (± 3.0 dB) .....................30 Hz – 15 kHz

S/N Ratio (dB) ................................................. 70 dB (MONO)

Selectivity (± 400 kHz) ............................................... ≥ 80 dB

Stereo Separation ............................................. 40 dB (1 kHz)

AM tuner section

Frequency Range (10 kHz) .....................530 kHz – 1700 kHz

Usable Sensitivity ....................................................... 28 dBμ

Video section

Color System of External Video Input .......................... NTSC

External Video Input Level (RCA jacks) ............. 1 Vp-p/ 75 Ω

External Audio Max Input Level (RCA jacks) .........2 V/ 25 kΩ

Video Output Level (RCA jacks) ........................ 1 Vp-p/ 75 Ω

Audio Output Level (RCA jacks) .........................1.2 V/ 10 kΩ

Analog RGB input ........................................... 0.7 Vp-p/ 75 Ω

Audio section

Maximum Power (Front & Rear) ...............................50 W x 4

Full Bandwidth Power (Front & Rear)

(4 Ω, 14.4 V, 1 % THD) .........................................22 W x 4

Preout Level (V) .....................................................2 V/ 10 kΩ

Preout Impedance ..................................................... ≤ 600 Ω

Speaker Impedance ................................................... 4 – 8 Ω

Tone action

Bass ............................................................100 Hz ± 8 dB

Middle ........................................................... 1 kHz ± 8 dB

Treble .......................................................... 10 kHz ± 8 dB

General

Operating voltage .......................14.4 V (11 – 16 V allowable)

Maximum Current Consumption .....................................15 A

Dimensions (W × H × D) ......................... 182 × 53 × 160 mm

............................................7-3/16 x 2-1/16 x 6-5/16 inch

Operational Temperature Range .................. -10 °C – +60 °C

Storage Temperature Range ........................ -20 °C – +85 °C

Weight ............................................................ 2.3 kg (5.1 lbs)

KENWOOD follows a policy of continuous advancements

in development. For this reason specifications may be

changed without notice.

Although the effective pixels for the liquid crystal panel is

given as 99.99% or more, 0.01% of pixels may not light

or may light incorrectly.

US and foreign patents licensed from Dolby Laboratories.

SPECIFICATIONS (K,R TYPE)

65

KVT-50DVDRY/512/522DVD

/522DVDY/532DVD/532DVDM

SPECIFICATIONS (M,X TYPE)