Rehsfil1 756 ROYCO756
User Manual: 756
Open the PDF directly: View PDF 
.
Page Count: 10
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
1 / 10
SDS Number: 400000001788
SECTION 1. PRODUCT AND COMPANY IDENTIFICATION
Product name : Royco 756
Product Use Description
:
Lubricant
Company: Manufacturer
Anderol Specialty Lubricants, a division of Chemtura Corporation
215 Merry Lane
East Hanover, NJ
07936
United States of America
Telephone: +1 203-573-4596, Toll Free: +1 888-263-3765
Emergency telephone
number: CHEMTREC: (24 hours) 800-424-9300
:
: 703-527-3887
For additional emergency telephone numbers see section 16 of the Safety
Data Sheet.
Prepared by
Product Safety Department
(US) +1 866-430-2775
MSDSRequest@chemtura.com
Additional advice:SYNTHETIC GEAR AND BEARING OIL, EP (ISO 680)
Recommended use of the chemical and restrictions on use
Recommended use : Lubricant
Restrictions on use : For industrial use only.
SECTION 2. HAZARDS IDENTIFICATION
Form liquid
Colour red
Odour aromatic
GHS Classification
Aspiration hazard :
Category 1
Acute aquatic toxicity :
Category 3
Chronic aquatic toxicity :
Category 3
GHS Label element
Signal word :
Danger
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
2 / 10
SDS Number: 400000001788
Hazard pictograms :
Hazard statements :
H304 May be fatal if swallowed and enters airways.
H412 Harmful to aquatic life with long lasting effects.
Other hazards :
None
Precautionary statements :
Prevention
:
P273 Avoid release to the environment.
Response:
P301 + P310 IF SWALLOWED: Immediately call a POISON
CENTER or doctor/ physician.
P331 Do NOT induce vomiting.
Storage:
P405 Store locked up.
Disposal:
P501 Dispose of contents/ container to an approved waste
disposal plant.
Carcinogenicity:
IARC
No component of this product present at levels greater than or
equal to 0.1% is identified as probable, possible or confirmed
human carcinogen by IARC.
Group 3: Not classifiable as to its carcinogenicity to humans
Distillates (petroleum),
hydrotreated middle 64742-46-7
Distillates (petroleum),
hydrotreated light 64742-47-8
2,6-di-tert-butyl-p-cresol 128-37-0
OSHA
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
No component of this product present at levels greater than or
equal to 0.1% is identified as a carcinogen or potential
carcinogen by OSHA.
NTP
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
No component of this product present at levels greater than or
equal to 0.1% is identified as a known or anticipated carcinogen
by NTP.
SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
3 / 10
SDS Number: 400000001788
Hazardous components
Chemical Name CAS-No. Concentration (%)
Distillates (petroleum), hydrotreated light naphthenic 64742-53-6 >= 50 - < 70 %
Distillates (petroleum), hydrotreated middle 64742-46-7 >= 20 - < 30 %
Distillates (petroleum), hydrotreated light 64742-47-8 >= 5 - < 10 %
NJTS# 136411-5778P Polyolefins >= 1 - < 5 %
Phenol, isobutylenated, phosphate (3:1) 68937-40-6 >= 0.1 - < 1 %
2,6-di-tert-butyl-p-cresol 128-37-0 >= 0.1 - < 1 %
SECTION 4. FIRST AID MEASURES
If inhaled :
If inhaled
Move to fresh air.
If not breathing, give artificial respiration.
If breathing is difficult, give oxygen.
In case of bluish discolouration (lips, ear lobes, fingernails),
give oxygen as quickly as possible.
Call a physician or poison control centre immediately.
In case of skin contact :
In case of skin contact
Wash off with soap and water.
Remove contaminated clothing and shoes.
Wash contaminated clothing before re-use.
Get medical attention if irritation develops and persists.
In case of eye contact
:
In case of eye contact
Flush with plenty of water.
If eye irritation persists, consult a specialist.
If swallowed
:
If swallowed, DO NOT induce vomiting.
Call a physician or poison control centre immediately.
Most important symptoms
and effects, both acute and
delayed
:
Aspiration may cause pulmonary oedema and pneumonitis.
Notes to physician :
For specialist advice physicians should contact the Poisons
Information Service.
SECTION 5. FIREFIGHTING MEASURES
Suitable extinguishing media :
Carbon dioxide (CO2)
Dry powder
Foam
Alcohol-resistant foam
Water mist
Unsuitable extinguishing
media :
Water
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
4 / 10
SDS Number: 400000001788
Specific hazards during
firefighting
:
Burning produces noxious and toxic fumes.
Specific extinguishing
methods
:
Use extinguishing measures that are appropriate to local
circumstances and the surrounding environment.
Use a water spray to cool fully closed containers.
Special protective equipment
for firefighters :
In the event of fire, wear self-contained breathing apparatus.
Use personal protective equipment.
SECTION 6. ACCIDENTAL RELEASE MEASURES
Personal precautions,
protective equipment and
emergency procedures
:
Use personal protective equipment.
Ensure adequate ventilation.
Environmental precautions :
Do not contaminate water.
Do not flush into surface water or sanitary sewer system.
Discharge into the environment must be avoided.
Methods and materials for
containment and cleaning up :
Contain spillage, soak up with non-combustible absorbent
material, (e.g. sand, earth, diatomaceous earth, vermiculite)
and transfer to a container for disposal according to local /
national regulations (see section 13).
SECTION 7. HANDLING AND STORAGE
Advice on safe handling :
Keep container closed when not in use.
Conditions for safe storage
:
Keep container tightly closed in a dry and well-ventilated
place.
Materials to avoid :
Strong acids and strong bases, Oxidizing agents
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Components with workplace control parameters
Components CAS-No. Form of
exposure Permissible
concentration
Basis
Distillates (petroleum),
hydrotreated light naphthenic 64742-53-6 TWA (Mist) 5 mg/m3 OSHA Z-1
TWA
(Inhalable
fraction)
5 mg/m3 ACGIH
TWA (Mist) 5 mg/m3 NIOSH REL
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
5 / 10
SDS Number: 400000001788
ST (Mist) 10 mg/m3 NIOSH REL
TWA (Mist) 5 mg/m3 OSHA P0
Distillates (petroleum),
hydrotreated middle 64742-46-7 TWA 500 ppm
2,000 mg/m3 OSHA Z-1
TWA (Mist) 5 mg/m3 OSHA Z-1
TWA 400 ppm
1,600 mg/m3 OSHA P0
TWA (Mist) 5 mg/m3 NIOSH REL
ST (Mist) 10 mg/m3 NIOSH REL
TWA (Mist) 5 mg/m3 OSHA P0
Distillates (petroleum),
hydrotreated light 64742-47-8 TWA 500 ppm
2,000 mg/m3 OSHA Z-1
TWA 200 mg/m3 ACGIH
TWA 400 ppm
1,600 mg/m3 OSHA P0
NJTS# 136411-5778P
Polyolefins TWA (Mist) 5 mg/m3 OSHA Z-1
TWA (Mist) 5 mg/m3 NIOSH REL
ST (Mist) 10 mg/m3 NIOSH REL
TWA (Mist) 5 mg/m3 OSHA P0
2,6-di-tert-butyl-p-cresol 128-37-0 TWA 10 mg/m3 OSHA P0
TWA
(Inhalable
fraction and
vapor)
2 mg/m3 ACGIH
TWA
(Inhalable
fraction and
vapor)
2 mg/m3 ACGIH
TWA 10 mg/m3 NIOSH REL
Engineering measures
:
Ensure that eyewash stations and safety showers are close to
the workstation location.
Effective exhaust ventilation system
Personal protective equipment
Respiratory protection
:
not required under normal use
When workers are facing concentrations above the exposure
limit they must use appropriate certified respirators.
Hand protection
Remarks :
Neoprene gloves
Eye protection :
Safety glasses with side-shields
or
Tightly fitting safety goggles
Skin and body protection :
impervious clothing
Hygiene measures :
Avoid contact with skin, eyes and clothing.
Handle in accordance with good industrial hygiene and safety
practice.
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
6 / 10
SDS Number: 400000001788
Wash hands before breaks and at the end of workday.
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance :
liquid
Color :
red
Odor :
aromatic
pH :
Not applicable
pour point :
< -60 °C
Boiling point/boiling range :
No data available
Flash point :
> 93.3 °C
Method: ASTM D 93
Upper explosion limit :
No data available
Lower explosion limit :
No data available
Vapour pressure :
No data available
Relative density :
ca. 0.86
Solubility(ies)
Water solubility :
No data available
Partition coefficient: n-
octanol/water :
No data available
Auto-ignition temperature :
No data available
Viscosity
Viscosity, kinematic :
13.9 mm2/s (40 °C)
SECTION 10. STABILITY AND REACTIVITY
Reactivity
:
No dangerous reaction known under conditions of normal use.
Chemical stability :
No decomposition if stored and applied as directed.
Possibility of hazardous
reactions
:
Hazardous polymerisation does not occur.
Stable under normal conditions.
Conditions to avoid
:
Heat, flames and sparks.
Contamination
Incompatible materials :
Strong acids and strong bases
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
7 / 10
SDS Number: 400000001788
Oxidizing agents
Hazardous decomposition
products
:
Carbon oxides
SECTION 11. TOXICOLOGICAL INFORMATION
Acute oral toxicity
2,6-di-tert-butyl-p-cresol
(Component) :
LD50: > 2,930 mg/kg
Species: Rat
Method: OECD Test Guideline 401
Acute dermal toxicity
2,6-di-tert-butyl-p-cresol
(Component) :
LD50: > 2,000 mg/kg
Species: Rat
Method: OECD Test Guideline 402
Skin irritation
NJTS# 136411-5778P
Polyolefins (Component) :
Result: No skin irritation
2,6-di-tert-butyl-p-cresol
(Component) :
Species: Rabbit
Result: No skin irritation
Eye irritation
NJTS# 136411-5778P
Polyolefins (Component) :
Result: No eye irritation
2,6-di-tert-butyl-p-cresol
(Component) :
Species: Rabbit
Result: No eye irritation
Sensitisation
2,6-di-tert-butyl-p-cresol
(Component) :
Species: Guinea pig
Classification: Did not cause sensitisation on laboratory animals.
CMR effects
NJTS# 136411-5778P
Polyolefins (Component) :
Carcinogenicity: Animal testing did not show any carcinogenic effects.
Mutagenicity: Animal testing did not show any mutagenic effects.
Teratogenicity: No effects on or via lactation, Did not show teratogenic
effects in animal experiments.
Reproductive toxicity: No toxicity to reproduction
2,6-di-tert-butyl-p-cresol
(Component) :
Mutagenicity: Animal testing did not show any mutagenic effects.
Teratogenicity: No effects on or via lactation
Reproductive toxicity: No toxicity to reproduction
Further information (Product) :
No data is available on the product itself.
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
8 / 10
SDS Number: 400000001788
SECTION 12. ECOLOGICAL INFORMATION
Ecotoxicity effects
Toxicity to fish (Product) :
Remarks:
No data available
Toxicity to daphnia and other aquatic invertebrates
NJTS# 136411-5778P
Polyolefins (Component) :
EC50: 190 mg/l
Exposure time: 48 h
Species: Daphnia magna (Water flea)
Phenol, isobutylenated,
phosphate (3:1)
(Component)
:
EC50: 0.202 mg/l
Exposure time: 48 h
Species: Daphnia magna (Water flea)
Toxicity to fish (Chronic toxicity)
Phenol, isobutylenated,
phosphate (3:1)
(Component)
:
NOEC: 0.093 mg/l
Exposure time: 90 d
Toxicity to daphnia and other aquatic invertebrates (Chronic toxicity)
Phenol, isobutylenated,
phosphate (3:1)
(Component)
:
NOEC: 0.0399 mg/l
Exposure time: 21 d
Elimination information (persistence and degradability)
Bioaccumulation (Product) :
Remarks:
No data available
Mobility (Product) :
Remarks:
No data available
Biodegradability (Product) :
Result: No data available
Further information on ecology
Ecotoxicology Assessment
Results of PBT assessment (Product)
This mixture contains no substance considered to be persistent, bioaccumulating and toxic (PBT).
Additional ecological
information (Product) :
The product itself has not been tested.
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
9 / 10
SDS Number: 400000001788
SECTION 13. DISPOSAL CONSIDERATIONS
Disposal methods
Waste from residues
:
Dispose of waste material in compliance with all federal, state,
and local regulations.
Contaminated packaging
:
Do not burn, or use a cutting torch on, the empty drum.
SECTION 14. TRANSPORT INFORMATION
ADR
Not dangerous goods
RID
Not dangerous goods
MERCOSUR
Not dangerous goods
DOT
Not dangerous goods
IATA
Not dangerous goods
IMDG
Not dangerous goods
SECTION 15. REGULATORY INFORMATION
EPCRA - Emergency Planning and Community Right-to-Know Act
CERCLA Reportable Quantity
Components CAS-No. Component RQ
(lbs) Calculated product RQ
(lbs)
xylene 1330-20-7 100 *
*: Calculated RQ exceeds reasonably attainable upper limit.
SARA304 Reportable Quantity
This material does not contain any components with a section 304 EHS RQ.
SAFETY DATA SHEET
Royco 756
Version: 1.0 Revision Date: 12/05/2014 Print Date: 05/05/2015
SAP 6.0 SDS 2012-2 NA GHS
10 / 10
SDS Number: 400000001788
SARA 311/312
Hazards
:
Acute Health Hazard
SARA 302
:
No chemicals in this material are subject to the reporting
requirements of SARA Title III, Section 302.
SARA 313
:
This material does not contain any chemical components with
known CAS numbers that exceed the threshold (De Minimis)
reporting levels established by SARA Title III, Section 313.
US State Regulations
California Prop 65
WARNING! This product contains a chemical known to the
State of California to cause cancer.
formaldehyde 50-00-0
The components of this product are reported in the following inventories:
US.TSCA
On TSCA Inventory
DSL
All components of this product are on the Canadian DSL.
AICS
On the inventory, or in compliance with the inventory
NZIoC
Not in compliance with the inventory
ENCS
On the inventory, or in compliance with the inventory
KECI
On the inventory, or in compliance with the inventory
PICCS
On the inventory, or in compliance with the inventory
IECSC
On the inventory, or in compliance with the inventory
SECTION 16. OTHER INFORMATION
Further information
Other Emergency Phone Number
Latin America: Brazil +55 113 711 9144
All other countries +44 (0) 1235 239 670
Mexico: +52 555 004 8763
The information provided in this Safety Data Sheet is correct to the best of our knowledge,
information and belief at the date of its publication. The information given is designed only as
a guidance for safe handling, use, processing, storage, transportation, disposal and release
and is not to be considered a warranty or quality specification. The information relates only to
the specific material designated and may not be valid for such material used in combination
with any other materials or in any process, unless specified in the text.
