Arctic_cat_2012_425_service_manual Arctic Cat 2012 425 Service Manual
User Manual: arctic_cat_2012_425_service_manual
Open the PDF directly: View PDF
Page Count: 122 [warning: Documents this large are best viewed by clicking the View PDF Link!]
- FOREWORD
- TABLE OF CONENTS
- General Information
- Periodic Maintenance
- SPECIAL TOOLS
- Periodic Maintenance Chart
- Lubrication Points
- Air Filter
- Valve/Tappet Clearance
- Testing Engine Compression
- Spark Plug
- Liquid Cooling System
- Muffler/Spark Arrester
- Adjusting Throttle Cable
- Adjusting Engine RPM (Idle)
- Engine/Transmission Oil - Filter
- Front Differential/Rear Drive Lubricant
- Tires
- Driveshaft/Coupling
- Nuts/Bolts/Cap Screws
- Ignition Timing
- Lights
- Shift Lever
- Frame/Welds/Racks
- Hydraulic Brake Systems
- Burnishing Brake Pads
- Checking/Replacing V-Belt
- Engine/Transmission
- SPECIAL TOOLS
- Troubleshooting
- Removing Engine/ Transmission
- Top-Side Components
- Removing Top-Side Components
- Servicing Top-Side Components
- VALVE ASSEMBLY
- Cleaning/Inspecting Cylinder Head Cover
- Removing Valves
- Measuring Valve Stem Runout
- Measuring Valve Stem Outside Diameter
- Measuring Valve Face/Seat Width
- Measuring Valve Face Radial Runout
- Measuring Valve Guide/Valve Stem Deflection (Wobble Method)
- Measuring Valve Guide (Inside Diameter)
- Servicing Valves/Valve Guides/Valve Seats
- Measuring Rocker Arm (Inside Diameter)
- Measuring Rocker Arm Shaft (Outside Diameter)
- Installing Valves
- PISTON ASSEMBLY
- CYLINDER/CYLINDER HEAD ASSEMBLY
- Cleaning/Inspecting Cylinder Head
- Measuring Cylinder Head Distortion
- Cleaning/Inspecting Cylinder
- Inspecting Cam Chain Guide
- Honing Cylinder
- Measuring Camshaft Runout
- Measuring Camshaft Lobe Height
- Inspecting Camshaft Bearing Journal
- Measuring Camshaft to Cylinder Head Clearance
- Inspecting Camshaft Spring/Unloader Pin
- VALVE ASSEMBLY
- Installing Top-Side Components
- Left-Side Components
- Removing Left-Side Components
- Servicing Left-Side Components
- Installing Left-Side Components
- Right-Side Components
- Removing Right-Side Components
- Servicing Right-Side Components
- Installing Right-Side Components
- Center Crankcase Components
- Separating Crankcase Halves
- Disassembling Crankcase Half
- Servicing Center Crankcase Components
- Assembling Crankcase Half
- Joining Crankcase Halves
- Installing Engine/Transmission
- Fuel/Lubrication/Cooling
- Electrical System
- SPECIAL TOOLS
- Electrical Connections
- Battery
- RPM Limiter
- Testing Electrical Components
- Accessory Receptacle/Connector
- Brakelight Switch (Pressure)
- Engine Coolant Temperature (ECT) Sensor
- Fan Motor
- Fuse Block/Power Distribution Module
- Ignition Coil
- Speed Sensor
- Ignition Switch
- Handlebar Control Switches
- Front Drive Selector Switch
- Front Drive Selector Actuator
- Gear Position Switch
- Stator Coil
- Starter Relay
- Starter Motor
- Electronic Control Unit (ECU)
- Regulator/Rectifier
- Lights
- Ignition Timing
- Tilt Sensor
- Throttle Position Sensor (TPS)
- Diagnostic Trouble Codes (DTC)
- Troubleshooting
- Drive System
- Suspension
- Steering/Frame/Controls