Paris2 Nokia 7380 Rm 111 Service Schematics V1

User Manual: Phone Nokia 7380 RM-111 - Service manuals and Schematics, Disassembly / Assembly. Free.

Open the PDF directly: View PDF .
Page Count: 3

Table of Contents Page

Module schematics

Front page

Component finder

Service Schematics

RM-111

Exploded view and component disposal

IMPORTANT:

This document is intended for use by authorized NOKIA service centers only.

Introduction

“Service Schematics” was created with focus on customer care.

The purpose of this document is to provide further technical repair information for

NOKIA mobile phones on Level 3/4 service activities.

It contains additional information such as e.g. “Component finder”,

“Frequency band table” or “Antenna switch table”.

The “Signal overview” page gives a good and fast overview about the most

important signals and voltages on board.

Saving process time and improving the repair quality is the aim of this document.

It is to be used additionally to the service manual and other training

or service information such as Service Bulletins.

All measurements were made using following equipment:

Nokia repair SW : Phoenix version 2005.36.7.112

Oscilloscope : Fluke PM 3380A/B

Spectrum Analyzer : Advantest R3162 with an analog probe

RF-Generator / GSM Tester : Rhode & Schwarz CMU 200

Multimeter : Fluke 73 Series II

While every endeavour has been made to ensure the accuracy of this document, some

errors may exist. If the reader finds any errors, NOKIA should be notified in writing.

Please send E-Mail to: training.sace@nokia.com

This material, including documentation and any related computer programs is protected

by copyright, controlled by NOKIA. All rights are reserved. Copying, including reproducing,

modifying, storing, adapting or translating any or all of this material requires the prior

written consent of NOKIA. This material also contains companyconfidential information,

which may not be disclosed to others without the prior written consent of NOKIA.

Page 1(3)

Front page

Customer Care / Service & Support Readiness / Content Creation Management

Version: 1.0 2.10.2005 7380 / RM-111

Board version: 1QCA_07

EAR(1:0)

GENIO(31:0)

G_AUDIO(11:0)

HEADINT(1:0)

HOOKINT

IHF(1:0)

IHF_XEAR(1:0)

MCBSP2(5:0)

MIC(2:0)

PUSL(3:0)

SLOWAD(6:0)

UIDRV(5:0)

XAUDIO(17:0)

XEAR(3:0)

XMIC(2:0)

AUDIO

APE_AUDIO(4:0)

APE_GPIO(15:0)

AUDIO(6:0)

AUDUEMCTRL(3:0)

LCDUI(2:0)

PUSL(3:0)

PWRONX

RFCLK_I

SIM2MMCIF(3:0)

SIMIF(3:0)

SLOWAD(6:0)

UIDRV(5:0)

USB_DIG(6:0)

XAUDIO(17:0)

CHARGER(4:0)

DIFCTRL(3:0)

DIFDATA(7:0)

G_AUDIO(11:0)

G_FMRADIO(11:0)

G_KEY_UI(67:0)

G_LPRF(23:0)

G_SYS_CONN(11:0)

IACCDIF(5:0)

engine

ACCDIF(2:0)

AUDIO(6:0)

AUDUEMCTRL(3:0)

IHF_XEAR(1:0)

KEYB(10:0)

LCDUI(2:0)

MIC(2:0) PUSL(3:0)

SIM2MMCIF(3:0)

SLOWAD(6:0)

UIDRV(5:0)

USB_DIG(6:0)

XEAR(3:0)

XMIC(2:0)

KEY_UI

AUDUEMCTRL(3:0)

DIFCTRL(3:0)

DIFDATA(7:0)

EAR(1:0)

GENIO(31:0)

G_KEY_UI(67:0)

HEADINT(1:0)

G_SYS_CONN(11:0)

HEADINT(1:0)

HOOKINT

IACCDIF(5:0)

IHF(1:0)

MIC(2:0)

PUSL(3:0)

PWRONX

SLOWAD(6:0)

UIDRV(5:0)

SYS_CONN

ACCDIF(2:0)

AUDUEMCTRL(3:0)

FMANT

VCharln

C2006

2C2023

V2000

1PMT16AT3

2.0A

F1000

GND

X2003

Board ID Component

GND

X2005

1PS79SB30

D2020

R2020

R2021

1PS79SB30

D2021

V2020

SI6913DQ-T1-E3

GND

Q2022

2SK3541

C2000

V2020

SI6913DQ-T1-E3

C2005

C2001

VBAT_CON

GND

C2021

X2000 VBAT_PA

GND

R2027 R2026

GND

C2020

R2023

R2022

GND

VBAT

GND

3.0mOhm

GND

C2081

CURRENT_SEN_30um

R2080

C2080

VIO

R2081

D3 CBusDa

R2082

SENSE-

DetClk

Zint

C3 CBusClk

Vio

Gnd

GND

N2080

LM3820TLX_NOPB

A1 SENSE+

A2 Vdd

A3 CBusEnX

To SW

SIM_SWITCH

SIM_SW_OR

STROBE from camera

FLASH-

FLASH+

C2500

GND

X2501

VBAT

R2506

C2503

GND

VIN

3GND

VFB

4EAOUT 5

OVP

SW 7

PGND 8

N2500

U//U

2GND

GND

L2503

R2507

V2502

X2502

GND

X2500

L2502

C2501

GND

VBACK

C2405

R2401

VOUT

VINN2400

-2.85-NOPB

LP3987ITLX

VEN

MODE

GND

C2406

VBAT_PA

GND

C2407

SOFT RIGHT

SELECT

ROW2

SELECT

ROW1

COL0

SELECT

ROW2

ROLLER_C

COL2

ROW0

COL1

ROW0

PWR/END

ROLLER_A

SOFT LEFT

ROLLER_B

SEND

ROW1

COL1

COL2

COL0

PWRONX

IN1

IN2

OUT1

OUT2

OUT1

OUT2

EMIF02-MIC02F2

Z2430

EMIF02-MIC02F2

Z2440

IN1

IN2

C2465

C2460

C2483

C2481

OUT3

E4 OUT4

E5 OUT5

D2 OUT7

D3 OUT8

D4 OUT9

OUT10

E1 OUT1

E2 OUT2

IN10

GND C1

GND

C3 GND

C4 GND

C5 GND

D1 OUT6

IN4

IN5 B1

IN6 B2

IN7

IN8

IN9 B5

EMIF10-COM01F2

Z2460

IN1 A2

IN2 A3

IN3

C2462

VBAT

Vin

Cpump+

REG710NA-5

N2480

1 Vout

2 GND

3ENA 4

Cpupm-

GND

R2161

VAUX3

GND

C2482

R2167

C2461

R2168

X2460

C2480

J2404

J2402

J2403

J2400

J2401 0

GND

GNDGND

GND

KLIGHT

GND

R2432

LVM8L3FVA

M2450

VBAT

V2429

EMH25T2R

47k

4k7

GND

!RD

VDD

ResetX

!RD

TearingEffect

WriteX

LED1+

WriteX

D/!C

LED-

VDDI

D/!C

LED2+

LED3+

C2435

L2427

C2436

C2438

GND GND

GND

C2429

GND

C2421

R2422 2

32SK3541

V2426

VFLASH1

C2420

R2420

C2422

R2421

VIO

V2425

2SK3541

C2428

X2420

C2427

C2426

LINE9

LINE8

LINE7 D5

E1 LINE10

E2 LINE9

GND

LINE10

C3 GND

LINE6

LINE5

D1 LINE8

D2 LINE7

GND

LINE1

LINE4

B2 LINE3

LINE4

LINE3

LINE6

C2 LINE5

Z2420

A1 LINE2

A2 LINE1

GND

LINE2

BGF109

C2437

R2425

L2426

R2427

ISET

GND D2

C2- E1

E5 C1+

A3 POUT

C2+ A5

SD A7

C1- B2

BRGT B6

VIN

N2425

LM2795TLX-NOPB

VBAT

C2430 C2431 C2432

GND GND

GND

GND GND

GND GND GND GND

GND GND

GND

GND GND

DLIGHT

R2426

RTC circuit

SIM interface

LED flash driver

Navispinner flex connector

Display connector

Charger plug

Battery connector

Zocus

UEMEK / TESP

VBAT

VBACK

VIO

VFLASH1

VAUX3

VSIM

UART_CTS_P

UART_RX

UART_TX

BT_RESETX

SleepX

SleepCLK

INTX

FM_ANT

PCM_OUT

BT_WAKEUP

HOST_WAKEUP

PCM_IN

PCM_CLK

PCM_SYNC

SYSCLK

PURX

MIC3P

MIC3PR

UART_RTS_P

CLK_REQ

MIC3N

MIC3NR

NC 47

GND 41

SPI_CSB 42

SPI_CLK

SPI_MOSI 44

SPI_MISO

PIO1 36

VREG_EN

GND 38

MPX_OUT

4BT_WAKEUP

SLEEPX

GND

32 VIO(1.8V)

33 BT_RESETX

UART_WAKEUP

GND 35

BT_UART_RTS

BT_PCM_CLK

BT_PCM_IN

BT_PCM_SYNC 29

GND

BT_PCM_OUT 30

INTX 21

REF_CLK 22

BT_UART_TX

24 BT_UART_RX

25 BT_UART_CTS

BUSMODE

SLEEPCLK

VAFL

VAFR

12 CBUSENX_IN

13 FMANTENNA

GND 14

VBAT

VFMRAD 16

LBMA48EBR2-TEMP

D6000

GND 1

CBUSCLK/SCL

CBUSDA/SDA

GND

R6003

C6000

C6004

C6002

GND

C6001

GND

R6002

C6184

GND

C6185

GND

VFLASH2

GND

J6000

2J6020

VBAT

R6162

GND

C6003

VIO

BT/FM module

BT_ANT

BT_ANTENNA

FREQ

8TX_CONFX

STATUS

RF_ACTIVE

2ANTENNA

E6099

E6098

J6099

GND

J6098

Page 2(3)Customer Care / Service & Support Readiness / Content Creation Management

Version: 1.0 27.10.2005 7380 / RM-111

Board version: 1QCA_07

Module schematics

R2028

GND

R2508

GND

R2433

C2466

GND

C2467

GND

C2451

G_CAMERA(11:0)

CCP(4:0)

Camera connector

CamClk

V_DIG

STBY LDO 1V2

CCPCLK_P

CCPCLK_N

CCPCLK_P

CamVctrl

CCPDATA_P

CCI_SDA

SCL

VANA

XSHUTDOWN

CCPDATA_N

CCPCLK_N

EN LDO 1V2

SDA

VCAP

CCPCLK_N

CCPDATA_N

CCPDATA_P

EXT_CLK

(shutdown)

CCI_SCL

C3304

ADC_IN

AGND

LDO_EN K4

PIEZO2

K7 GPIO5

J7 GPIO6

J8 DC_GPIO

J9 GPIO2

VANA

K10 GPIO1

VDD1V2

J10 GPIO0

PCLK1P

LDO_STBY

1V2_OUT

PIEZO1

H7 GPIO7

H8 GPIO4

SSDA

PDATA1P

H10

SSCL

PDATA1N

PDATA2P

SYSCLK F8

G2 DC1V8

PCLK1N

PCLK2N E1

PCLK2P E2

E9 NC

PDATA2N

TDO

HDATAP

HDATAN

HCLKN

MSDA C2

C3 TCK

C4 HCLKP

MSCL C5

TDI

B4 VDD1V2

B5 NC

A4 TMS

DC1V8/2V8

VDD1V2

PDN A7

TEST A9

K8,A8,C1,J3,F3,H9,J6,E3,K6=

D3300

STV0984N

RST

TMS_OCI

RST_DIR A3

C3305

C3303 C3302

L3300

R3313

C3310

R3305

R3304

VCORE_LIN

L3320

C3314 C3301

VFLASH1

C3308

J3004

J3003

J3005

C3309

J3002

C3307

GND

J3001

R3308

R3307

C3306

R3303

GND

GND GND

GND

VDD_GPIO K9

VDD1V8 J2

VDD1V8 J4

VDD_PIEZO J5

VDD1V8 G1

F10

VDD1V8/2V8 C9

VDD1V8/2V8

GND

GND GND GND

GND GND

GND

GND GND

GND

X3320

HWA

G8 GPIO3

2.8V

1.8V

2.8V

1.2V

2.8V

C2425

GND

1.8V

2.8V

3.6V

1.8V

2.8V

1.8/3V

2.8V

1.8V

VFLASH2

2.8V

EMI filter

DC/DC converter

Reset circuit

3BT/FM-

module

HWA

SIM reader

Red marked components are for measurement purposes only;

only parts written in black fonts may be exchanged - for details

refer to corresponding spare parts Service Bulletin!

Please note:

Navispinner flex connector

Display-

connector

Camera connector

Battery

connector

Flashlight

connections

Page 3(3)Customer Care / Service & Support Readiness / Content Creation Management

Version: 1.0 27.10.2005 7380 / RM-111

Board version: 1QCA_07

Component finder,

Signal overview

Bottom side

TOP side

2) VSIM at C2700

1) SLEEPCLOCK at R6003

3) Camera clock at R3305

VIO = 1.8V

VEL = 5V

Vcore_lin = 1.8V

VFlash2 = 2.8V

VBAT ~ 4V

VBack = 2.8V

VFlash1 = 2.8V

VBAT ~ 4V

VAUX3 = 2.8V

C2405 J2 C2429 J4 C2461 S5 C2501 M5 C3307 M3 C6184 M4 N2425 J3 R2023 M2 R2420 N6 R2508 M6 R3313 N5 V2502 M5 X3320

C2000 M2 C2406 J2 C2430 J4 C2462 S5 C2503 M5 C3308 L5 C6185 M4 L2426 J4 N2480 N6 R2026 M2 R2421 N6 R2700 N5 R6002 M3

C2001 L2 C2407 J2 C2431 K4 C2465 U4 C2700 O5 C3309 M4 L2427 J4 N2500 L5 R2027 M2 R2422 N6 R2701 O5 R6003 N3 X2000 L4 Z2430

C2005 N2 C2420 N6 C2432 J4 C2466 R6 C2701 O6 C3310 M5 D2020 L2 L2502 L6 R2028 M4 R2425 J3 R2702 O6 R6162 N3 X2005

Z2440

C2006 H6 C2421 N6 C2435 K4 C2467 Q6 C3301 N4 C3314 L3 D2021 M2 L2503 K6 Q2022 L2 R2081 L3 R2426 J3 R2703 O6 X2420

Z2460

C2020 M2 C2422 N5 C2436 J4 C2480 N6 C3302 M4 C6000 N3 D3300 L4 L3300 K4 Q2700 O6 R2082 L3 R2427 J3 R3303 M5 V2000 O6 X2460

C2021 L2 C2425 J3 C2437 J4 C2481 M6 C3303 M4 C6001 N3 D6000 N4 L3320 M4 R2161 T5 R2432 S4 R3304 L5 V2020 K2 X2500

C2023 C6 C2426 K3 C2438 J4 C2482 M6 C3304 M4 C6002 N5 R2020 L2 R2167 T5 R2433 M3 R3305 M4 V2425 J3 X2501

C2080 L3 C2427 K4 C2451 T2 C2483 N6 C3305 L5 C6003 N5 F1000 U6 N2080 K3 R2021 L2 R2168 T4 R2506 L6 R3307 M4 V2426 J4 X2502

C2081 M3 C2428 J4 C2460 S4 C2500 K5 C3306 K4 C6004 O3 N2400 J2 R2022 L2 R2401 J2 R2507 L5 R3308 M4 V2429T4X2700

Paris2 Nokia 7380 Rm 111 Service Schematics V1

Navigation menu

Versions of this User Manual:

Views

Navigation