Flowtron Outdoor Products Mosquito Powertrap Mt 200 Series Users Manual Generic Owner's

MT-200 Series to the manual 62d8bd3b-2234-4c5d-b519-cdfb3f3bd5c8

: Flowtron-Outdoor-Products Flowtron-Outdoor-Products-Mosquito-Powertrap-Mt-200-Series-Users-Manual-551390 flowtron-outdoor-products-mosquito-powertrap-mt-200-series-users-manual-551390 flowtron-outdoor-products pdf

Open the PDF directly: View PDF .
Page Count: 8

IMPORTANT

KEEP OUT OF REACH OF CHILDREN.

READ THE LABEL AND OPERATING

INSTRUCTIONS BEFORE USING.

Please retain operating instructions for

future reference.

DOMESTIC

REG. NO. 28457 PCPA

Flowtron Mosquito PowerTrap®

Operating Instructions

Flowtron Outdoor Products, 15 Highland Ave. Malden, MA 02148 • 1-800-343-3280 * www.flowtron.com

Page 2

Table of Contents

P a g e

Carton Contents. . . . . . . . . . . . . . . . . . . . . . . . . 2

Your Enemy – the Mosquito. . . . . . . . . . . . . . . . 3

How Your Mosquito Pow e r Tr a p Wo r k s . . . . . . 3

Rules for Safe Use. . . . . . . . . . . . . . . . . . . . . . . 4

P l a c e m e n t . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

I n s t a l l a t i o n . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

O p e r a t i o n . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

M a i n t e n a n c e . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Troubleshooting Chart . . . . . . . . . . . . . . . . . . . . 8

A c c e s s o r i e s . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Carton Contents

Q t y. . . . . . . . . . . . . . . .D e s c r i p t i o n

1 . . . . . . . . . . . . . . . . Mosquito PowerTr a p

1 . . . . . . . . . . . . . . . . Power Pack and Wi r e

1 . . . . . . . . . . . . . . . . Catch Tr a y

1 . . . . . . . . . . . . . . . .Octenol Cartridge

1 . . . . . . . . . . . . . . . . P o s t

1 . . . . . . . . . . . . . . . . Tank Support Strap *

1 . . . . . . . . . . . . . . . . Tank Stand A s s e m b l y

1 . . . . . . . . . . . . . . . . Tank Wr a p

1 . . . . . . . . . . . . . . . . Tank Cap

1 . . . . . . . . . . . . . . . .Tank Strap **

1 . . . . . . . . . . . . . . . . Owners Manual

Mosquito

PowerTrap

Tank Stand

Assembly

Wheels (MT-300 series only)

Tank Cap, Tank Wrap, Tank Strap, Octenol Cartridge

and Owner’s Manual are not shown

Post

Power Pack

and Low

Voltage Wire

Catch

Tray

Unpacking Instructions

Your Mosquito PowerTrap has been carefully packed

at the factory to prevent damage during shipment.

Carefully open the carton and:

1 . Remove contents from carton.

2 . Check parts against carton content list.

*M T-200 series only

* * M T-300 series only

Page 3

Your Enemy – the Mosquito

There are some 2,700 species (different kinds of

mosquitoes) in the world with about 170 species in

North America alone.

Most mosquitoes live and die close to where they

hatch, although some can travel miles (kilometres) in

search of a host. Only the female mosquito bites as

she requires a blood meal to produce eggs.

Mosquitoes require standing water in aquatic habitats

including fresh water, salt water marshes, brackish

water or in water found in containers, old tires, tree

holes, even flower pots. The female mosquito lays

her eggs on the surface of the water and if conditions

are right the eggs hatch and become larvae, then

pupae and finally adult mosquitoes; all in 10 to 14

days.

Both male and female mosquitoes feed regularly on

nectar obtained from flowers, but females require

blood to produce fertile eggs. Therefore, she must

find a human or animal host to blood feed before she

can lay her eggs.

Most mosquitoes that emerge in the wild never come

in contact with humans but obtain blood from birds

and other animals. Mosquito species that breed

around the home remain close to where they hatched

and are regarded as pests and carriers of disease.

Mosquitoes in search of a blood meal use visual,

thermal and olfactory (odour) stimuli to locate a host.

Of these, olfactory cues are the most important.

Out of the more than 100 compounds detected in

human breath only two have been isolated and identi-

fied as significant mosquito attractants; carbon diox-

ide (CO2) and octenol (1-OCTEN-3-OL). These

attractants serve as long-range airborne attractants

and can be detected by mosquitoes at distances of

100 feet to 125 feet (30 - 40 m).

At close range, body heat, moisture and lactic acid

serve as terminal attractants. Certain species show

strong preferences for biting different parts of the

human body.This is thought to be related to local

skin temperature and lactic acid output.

The attractiveness of different persons to mosquitoes

varies substantially. Men are bitten more readily than

women, adults more often than children and larger

persons attract more mosquitoes perhaps because of

their greater relative heat and carbon dioxide output.

How Your Flowtron

Mosquito PowerTrap Works

The revolutionary new Flowtron Mosquito PowerTr a p

replicates the attractants mosquitoes use to locate, bite

and annoy humans. It does this by producing carbon

dioxide, heat and moisture and combining these stimuli

with octenol to create an attractant to mosquitoes.

Your Flowtron Mosquito PowerTrap:

•Replicates the human attractants of respiration,

odor and body heat.

•Converts readily available propane gas into heat,

moisture and carbon dioxide, the acknowledged

leading mosquito and attractants emitted by

humans.

•Special super bright LED motion lighting provides

added lure.

•Produces a powerful vacuum to draw mosquitoes

into a convenient, removable catch tray where

they quickly dehydrate and die for safe, clean dis-

posal.

•Contains state-of-the-art computer controlled elec-

tronics to operate automatically in one of four

modes selected by you.

Mosquito PowerTrap does away with ultraviolet lights

and high voltage killing grids. Most importantly, it kills

only female mosquitoes.

Flowtron Mosquito PowerTrap uses an exclusive plat-

inum catalyst that converts air and propane gas into

heat, moisture and carbon dioxide. It does this in an

efficient, effective and economical manner.The cata-

lyst converter is completely safe, flameless and never

needs to be replaced.

Page 4

Rules for Safe Use

1 . Use outdoors only. Install the unit a

minimum of 10 feet (3 m) from

buildings and other structures.

2 . Never place fingers or insert any

object into the unit while it is operat-

i n g .

3 . Always disconnect unit from its

power source and wait for unit to

cool before handling, moving or

s e r v i c i n g .

4 . This device was designed for use

with propane gas. Never attempt to

use any other fuel, including liquid

fuels or natural gas. Fire or damage

to your Flowtron PowerTrap could

r e s u l t .

5 . Always operate the unit in an

upright position to prevent damage

to the CO2g e n e r a t o r.

6 . Do not abuse the power pack.

Never carry the power pack by its

cord or yank it to disconnect it from

a receptacle. Keep power cord

away from heat, oil and sharp

e d g e s .

7 . Never connect the unit to a

battery or other D.C. voltage. Such

an attempt will damage your unit.

8 . Store indoors when not in use.

Remove propane tank from unit

before storing and store tank out-

doors in a well ventilated space.

Placement

Your Mosquito PowerTrap is site specific and place-

ment is critical for successful results.

Your Flowrtron Mosquito PowerTrap emits a plume of

octenol-enhanced carbon dioxide which mosquitoes

follow in their search for a blood meal. Mosquitoes fly

up-wind toward the source of the plume in their

attempt to locate a host. Since the direction of the

plume is dependent upon the direction of the wind,

your unit should be positioned so it’s

attractant outlet faces downwind.

Female mosquitoes also feed on moisture laden nec-

tar and fruit juices when not in search of a blood

meal. They are usually found in shade; around flo w-

ers, trees, bushes and other vegetation; and adjacent

to standing water.

For best results locate your unit 20 to 40 feet

(6 -12 m) away from areas of human activity in a loca-

tion near (but not in) bushes, wooded areas, or adja-

cent to standing water (other than swimming pools).

Select a location which will result in the carbon diox-

ide plume blowing toward the area where mosquitoes

are likely to hide and emerge. A proper location will

ensure that mosquitoes encounter the plume and

fo l l ow it up-wind to the Flow t ron Mosquito

Pow e r Trap before they detect the presence of

h u m a n s .

See Illustration 1.

Illustration 1

Prevailing wind direction

HOUSE PATIO 20 – 40 ft. SOURCE OF

INSECTS

Attractant

Outlet

P l u m e

Page 5

Connect Propane Regulator

1 . Remove the plastic dust cover from your propane

tank valve.

2 . Screw the propane regulator coupling located on

the end of the propane hose onto the tank valve by

turning the black threaded coupling clockwise until

tight. Hand tighten only. See Illustration 4.

Note: Gas will not flow unless connection is tight.

Tighten by hand only.

Using a wrench or

other tool could

damage the regulator

coupling and could

cause a gas leak.

WARNING

Check for gas leaks by wetting the connec-

tions with a solution of soap and water and

watching for bubbles. If bubbles form or if a

bubble grows larger, there is a leak and

connection must be tightened.

Illustration. 4

4 . ( M T-300 series only )

Move your unit to the

desired location in your

yard. Remove catch tray

and grasp housing as

s h o w n .

See trap “Placement”

instructions on pg. 4.

Assembly

Tank Stand (MT-200

series only)

1. Insert tank support strap

into openings in tank stand

as shown. See Figure A.

2. On the underside of the

tank stand, loosen the two

hex nuts located on the

screws which extend from

the sides of the base plate.

Place the slots at the ends

of the tank support strap

over the screws and

secure by tightening the

two nuts. See Figure B.

PowerTrap (MT-200 &

MT-300 series)

1. Insert one end of the post

into the post opening at

the front of the tank stand.

Insert opposite end of

post into the post opening

located at the bottom of

the Flowtron Mosquito

P o w e r Tr a p ®. Align unit in

relation to the tank stand.

See Illustration 2.

Place a 20 lb. tank on

the tank stand and install

tank wrap around the

tank.

2. Install catch tray by fir s t

inserting the rear of the

tray into the housing.

Then push in upper part of

the latch and raise front of

catch tray into place.S e e

Illustration 3.

3 . Position and screw power

pack to either an outside

or inside wall adjacent to

a electrical outlet (screws

not provided). Run the low

voltage wire either above or below ground from the

power pack to the unit. plug the low voltage wire

into the power cord connector located at the bottom

of the Flowtron Mosquito PowerTr a p ®. Plug the

power pack into the electrical outlet.

Tank

Cap

Post

Tank

Strap

Tank

Wrap

Tank Stand

Illustration 2

Push

illustration 3

WARNING

Check for gas leaks every time you disconnect and

reconnect a gas fitting.

Be sure there are no sparks or open flame in the

area when you check for leaks.

Do not use a liquid propane tank with a damaged

valve. Have dented or rusty propane tanks checked

by your propane supplier.

Only use regulator supplied with your Flowtron

PowerTrap.

3. Place tank cap on top of tank.

Openings

Tank Stand

Tank Support

Strap

Figure B

Figure A

Base Plate Tank Strap

Screw & Nut

(2 places)

Page 6

Operation

Your Mosquito PowerTrap is fully automatic. It is

equipped with a photocell, temperature sensors and a

computer microprocessor.

The control panel is located on the top of the unit and

has the following operating modes:

•24/7 (on 24 hours, 7

days/week)

•3 Hours (on at dusk,

off 3 hours later)

•3 + 2 Hours (on at dusk,

off 3 hours later; on again at dawn, off 2 hours

later).

•4 + 3 Hours (on at dusk, off 4 hours later;

on again at dawn, off 3 hours later)

• Off/Reset (manual off)

To select the desired mode, first push the button

labeled “Off/Reset” to clear the computer memory.

Then push the button labeled “Mode”.

For continuous operation press the “Mode” button

once. The green light labeled “24/7” will light and the

unit will operate continuously 24 hours per day until

the “Off/Reset” button is pressed.

For timed operation, press and hold the “Mode” but-

ton. When the desired mode is selected as indicated

by its green light, release the button. No further con-

trol is necessary and your unit will function in the

mode selected every day until the “Off/Reset” button

is depressed or an interruption occurs in the electrical

power source.

When the 24/7 mode is selected, the unit will begin

its start cycle and approximately three minutes later,

the fan and LED lights located in the entrance to the

trap will come on intermittently. Once the catalyst

has reached operating temperature, which will take

five to ten minutes, the fan and LED lights will remain

on and the start cycle will be complete.

When a timed mode is selected, the fan and LED

lights will come on immediately and remain on. The

unit, however, waits for dusk and then checks the out-

side air temperature to determine if it is sufficiently

warm for insect activity i.e. above 55º – 60ºF

(13º - 15ºC). This is an important feature to conserve

propane fuel. The unit will automatically begin its start

cycle when the light level reaches dusk and remains

at the level of dusk for ten minutes (thus avoiding the

effects of transient light sources) and if the outside air

temperature is above the 55º – 60ºF (13º - 15ºC)

range.

The start cycle is also repeated at dawn when the

3 + 2 hr or the 4 + 3 hr mode is selected.

During start cycles, which are from five to ten

minutes in duration, the fan and LED lights operate

intermittently.

Ten to fifteen minutes after the unit detects a lack of

propane fuel (either due to an empty tank or due to

improper installation of the propane regulator to the

tank valve) the three green timed mode lights on the

control panel will flash. Simply switch the PowerTrap

off and refuel. If the unit is not out of propane and the

lights are flashing check that the tank valve is fully

open and that the regulator is properly attached to the

tank valve.

Mosquitoes are generally most active shortly after

dusk and again at dawn. Therefore, the 3 + 2, or

4 + 3 timed modes are usually the most economical

settings.

The 24/7 mode is desirable if day flying mosquitoes

are present or to operate at temperatures below

55º F (13ºC).

N o t e :

As mosquitoes pass through the fan, m o s t

are killed and thrown against the side of the

internal screen-lined funnel. Those that

escape the fan’s killing action end up in the

c a t c h tray where they quick l y dehydrate and

d i e. See page 7 for instructions for remov i n g

the screen-lined funnel and cleaning the

s c r e e n .

Note:

To resume operation following an electri-

cal disturbance or a loss of electrical

power, press the “Off/Reset” button to

clear the computer memory then reset

the unit to the desired operating mode.

In the event the Flowtron PowerTrap fails to

respond to its controls (mode selection)

unplug the unit for a few seconds, reattach

plug and then reset to the desired mode.

Page 7

Maintenance

1 . R e fi ll your propane tank as required. The green

timed mode lights on the control panel will fla s h

when a new supply of propane is needed.

2 . Replace the octenol cartridge after 450 hours of

o p e r a t i o n .

N OT E : The fo l l owing table may be used as a

general guide to determine approximate pro p a n e

r e fill times.

3 . Empty the catch tray periodically to ensure proper

air flow through the trap. To remove the catch tray

push in on the latch at the front of the catch tray

and pull tray down.

4 . Remove and clean the screen-lined funnel each

time the propane tank is refilled or more often dur-

ing periods of heavy infestation. To remove funnel,

proceed as follows:

Switch unit off and allow it to cool. Remove catch tray.

Push rear of bottom funnel

ring up into the unit’s hous-

ing until front tabs become

disengaged from housing.

See figure A .

Pull funnel down and for-

ward releasing rear sec-

tion of upper funnel ring

and remove funnel from

unit. See fig u r e B .

Remove insect debris

from screen surrounding

funnel. Wash screen with

water and shake off

excess water before re-

i n s t a l l i n g .

Re-install funnel by hold-

ing funnel at a slight

angle and insert the front

edge of the upper funnel

ring inside of unit’s hous-

ing. See figure C.

Push funnel upwards and

with the rear section of

the bottom funnel ring at

a slight angle compress

funnel until front tabs of

bottom funnel ring are up

inside of the housing. See

figure D.

Release funnel and it will

spring into place.

Replace catch tray and re-start unit.

Operating Mode

Hours per Day

Refill Times

(20 lb propane tank)

Octenol Cartridge

U.S. Government and university researchers have

demonstrated that o c t e n o l combined with c a r b o n

d i ox i d e (both components of respiration) are irresistible

attractants to mosquitoes.

The Flowtron Mosquito PowerTrap uses a specially

designed time release cartridge containing o c t e n o l ( 1 -

O C T E N - 3 - O L ) .

To Install the Octenol Cartridge:

1. Remove the octenol cartridge from the sealed

pouch and peel the protective cover from the face

of the cartridge. Avoid touching the openings in the

cartridge and always wash hands thoroughly after

c o n t a c t .

2 . Place the cartridge in the rectangle slot located at

the bottom of the plenum. Insert the cartridge with

the openings facing inward. See Illustration 5.

Illustration 5

Plenum

Cartridge

Shown in

Place

Insert

Cartridge

Octenol

Cartridge

Slot

Bottom

Funnel

Ring Push Up Here

Tabs

Housing

Up

Front

Tab

Forward

Upper

Funnel

Ring

Front

Edge

of Upper

Funnel Ring

Figure A

Figure B

Figure C

Figure D

Down

Up

Up

3 . . . hours

3 + 2 . . . hours

4 + 3 . . . hours

24 . . . . hours

6 – 7 months

3 – 4 months

2 – 3 months

3 – 4 weeks

Page 8

Symptom

Mode lights on control panel do

not light when “MODE” switch is

d e p r e s s e d .

Probable Cause

No power at outlet

Unit not properly connected to its power pack.

Remedy

Check for electrical power at outlet.

Check plug connections between unit and power pack low voltage cord.

Green lights on control panel

are fla s h i n g .

Lack of propane.

Propane tank valve closed.

Regulator coupling not properly attached.

R e fi ll propane tank.

Open tank valve.

Check propane regulator coupling for proper engagement and/or leaks.

The fan does not run

continuously after the unit has

been on for at least 10 minutes.

Lack of propane

Start cycle malfunction.

Same as for “green lights fla s h i n g ” .

Press “ R e s e t ” and restart in 24/7 mode.

Not catching mosquitoes when

the fan is running, the valve is

pulsing and the green lights on

the control panel are not

flashing.

Funnel end is not over catch tray

nozzle opening.

Funnel clogged with insect debris.

Trap is not located in a productive site.

Windy, cool or stormy weather.

Current mosquito population not readily

attracted to CO2+ Octenol.

Engage the funnel end with the catch tray nozzle opening.

Clean funnel. See page 7.

Move trap to a new site. See placement guidelines in the owner’s manual.

Wait for conditions more to the mosquito’s liking.

Notably the day flying Asian tiger Mosquito. Operate the trap with the

octenol cartridge removed.

The unit does not start up at

dusk when in an automatic

mode.

Unit has not sensed dusk or night for a

full 10 minutes.

Ambient temperature is below

55-60ºF.

Ambient light level is too high.

Wait for 10 minutes of darkness.

Unit will start automatically if temperature rises above 55º F

within 2 hours of dusk.

Shield unit from extraneous light.

Trouble Shooting Chart

Mosquito Attractant:

Octenol Cartridge – MA 1000

Makes your Mosquito PowerTr a p

more effective in attracting mosquitoes

and biting fli e s .

Extension Cord – EC-50

50 foot low voltage extension cord.

Allows placement of the Mosquito

P o w e r Trap an additional 50 feet away

from the power source.

Accessories

Accessories are available at your local retail outlet or on-line at www.flowtron.com

Any problems you encounter that are not corrected by the action recommended in this chart should be referred to the Flowtron Service Department • (800) 343-3280

WARRANTY

Flowtron warrants your Mosquito PowerTrap to be free from defects in materials or workmanship under normal use and service for one year from date of original purchase. All parts

which are defective will be replaced free of charge. Any implied warranties, including the implied warranty of merchantability are also limited in duration to the one year period from the

original purchase date.

The provisions of this warranty shall not apply to any product which as been subject to misuse, neglect or accident, nor which is used for a purpose for which it is not designed, or

which shall have been repaired or altered in any way so as to adversely affect its performance and reliability. Service by unauthorized parties voids your warranty. Warranty covers

only the original purchaser. Commercial and/or professional use is excluded from warranty coverage.

Flowtron neither assumes nor authorizes any person to assume for it any other liability in connection with its product. No responsibility is assumed for any consequential damages

that may result from the use of a Flowtron product, nor for damages due to accident, abuse, lack of responsible care, the affixing of any unauthorized attachment, loss of parts or

subjecting this unit to any but the specified voltage.

If the unit fails to operate during the warranty period, send the product, along with purchase receipt showing purchase date and description of the problem to: Flowtron Service

C e n t e r , 15 Highland Avenue, Malden, MA 02148. Transportation costs for returning any defective product are the responsibility of the consumer.

This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.

Flowtron Outdoor Products, 15 Highland Ave, Malden, MA 02148

1 - 8 0 0 - 3 4 3 - 3 2 8 0

557-10051