Kirkland 720 0011 User Manual GAS GRILL Manuals And Guides 1303166L

User Manual: Kirkland 720-0011 720-0011 KIRKLAND GAS GRILL - Manuals and Guides View the owners manual for your KIRKLAND GAS GRILL #7200011. Home:Lawn & Garden Parts:Kirkland Parts:Kirkland GAS GRILL Manual

Open the PDF directly: View PDF .
Page Count: 26

Download
Open PDF In Browser	View PDF

Stainless Steel Gas Grill
With Rear and Side Burner
USE AND CARE GUIDE
fYl

FOR OUTDOOR

USE ONLY

FOR

YOUR

SAFETY

It you smell gas:
1. Shut off gas to the
2.

Extinguish

Open

If odor

appliance.

any open

flame.

lid
continues,

immediately

call you gas supplier

or your

fire department.

FOR YOUR SAFETY
1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this
or any other appliance.
2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any
other appliance.

Thank you for selecting The Kirkland Signature Grill.
Because this appliance contains s features not found on any other grill, we recommend that you read this entire booklet
before your first use. Keep it in a handy place as it has answers to questions that may occur during future use.
Feel free to contact us if we can help you. When you write please include the model number of the grill.
We thank you for buying The Kirkland Signature Grill and wish you many years of enjoyment.

Note:

This appliance

is NOT intended
PLEASE

SECTION ONE:
Precaution
Placement of the grill.
SECTION TWO:
Assembly/installation of
side shelf
Installation of utensil rack
Installation of push bar
Installing the strengthening bar
And serving tray.
Rotisserie kit assembly
Gas hook-upLeak testingInstaller final checklistSECTION THREE:
Operating instructionLighting instruction grill
/rotisserie
Lighting illustrationSECTION FOUR:
Using the side burner-

RETAIN

-2-3
3

to be installed
THIS

in or on recreational

MANUAL

vehicles

or boats.

FOR FUTURE

SECTION FIVE:
Care and maintenance of side burner--14
Troubleshooting
15
SECTION SIX:
Grill parts lis_

SECTION SEVEN:
Grilling hints
Grill cooking chart.

!7
!8

SECTION EIGHT:
Grill recipe suggestions-

-21

SECTION NINE:
Limited warranty

5
6
7
8
9
9
10

11
12
13

TESTED IN ACCORDANCE
WITH ANSI
Z21.58a-1995
STANDARD
FOR OUTDOOR
COOKING
GAS APPLIANCES.
THIS
GRILL IS FOR OUTDOOR
USE ONLY.
Check your local building codes for the proper
method of installation. In the absence of local
codes, this unit should be installed in accordance
with the National Fuel Gas Code No. Z223.11988 and the National Electrical Code
ANSI/NFPA No. 70-1990.
CALIFORNIA
WARNING

PROPOSITION

65-

The burning of gas fuel generates some
byproducts, which are on the list of substances
which are known by the State of California to
cause cancer or reproductive harm. California
law requires businesses to warn customers of
potential exposure to such substances. To
minimize exposure to these substances, always
operate this unit according to the use and care
manual, ensuring you provide good ventilation
when cooking with gas.
SAFETY
PERSONAL

PRACTICES

TO AVOID

INJURY

When properly cared for, your 720-0011 Grill will
give safe, reliable service for many years. However,
extreme care must be used since the grill produces
intense heat and can increase accident potential.
When using this appliance basic safety practices must
be followed, including the following:
Read this Care and Use Manual carefully and
completely before using your grill to reduce the risk
of fire, burn hazard or other injury.
Begin by ensuring proper assembly.

Do not repair or replace any part of the grill unless
specifically recommended in this manual. All other
service should be referred to a qualified technician.
CHILDREN SHOULD NOT BE LEFT ALONE OR
UNATTENDED
IN AN AREA WHERE THE GPdLL
IS BEING USED. NEVER ALLOW THEM TO SIT,
STAND OR PLAY ON OR AROUND THE GRILL AT
ANY TIME.
DO NOT STORE ITEMS OF INTEREST
TO
('HILDRENAROUND
OR BELOW THE GRILL OR
IN THE ('ART. NEVER ALLOW CHILDREN TO
CRAWL INSIDE OF THE ('ART.

Never let clothing, pot holders or other flanmmble
materials come in contact with or too close to any
grate, burner or hot surface until it has cooled. Fabric
may ignite and result in personal injury.
For personal safety, wear proper apparel. Loose
fitting garments or sleeves should never be worn
while using this appliance. Some synthetic fabrics are
highly flanmmble and should not be worn while
cooking.
Only certain types of glass, heat-proof glass ceramic,
earthenware, or other glazed utensils are suitable for
grill use. Theses types of materials may break with
sudden temperature changes. Use only on low or
medium heat settings according to the manufacturer's
directions.
Do not heat unopened food containers as a build-up
of pressure may cause the container to burst.
Use a covered hand when opening the grill lid. Never
lean over an open grill.
WHEN LIGHTING A BURNER, ALWAYS PAY
('LOSE ATTENTION
TO WHAT YOU ARE DOING.
BE CERTAIN YOU ARE TURNING THE IGNITER
LABELED FOR THE BURNER YOU INTEND ON
U57NG.

When using the grill, do not touch the grill rack, burner
grate or innnediate surrounding area as these areas
become extremely hot and could cause burns. Use only
dry potholders. Moist or damp potholders on hot surfaces
may cause burns from steam. Do not use a towel or
bulky cloth in place or pothotders. Do not let potholders
touch hot portions of the grill rack.
Grease is flammable. Let hot grease cool before
attempting to handle it. Avoid letting grease deposits
collect in the bottom of the grill. Clean often.
DO NOT _2S'EALUMINUM FOIL TO LINE THE GRILL
RACKS OR GRILL BOTTOM. This can severely upset
combustion air flow or trap excessive heat in the control
area. The result of this can be melted knobs, rotary
igniters and increased chance of personal injury.
For proper lighting and performance of the burners keep
the ports clean. It is necessary to clean them periodically
for optinmna performance. The burners wilt only operate
in one position and nmst be mounted correctly for safe
operation.
Clean the grill with caution. Avoid steam burns; do not
use a wet sponge or cloth to clean the grill while it is hot.
Some cleaners produce noxious fumes or can ignite if
applied to a hot surface.
INSECT
WARNING!!!
@iders and insects" can nest in
the burners of this and any other grill, and cause the
gas to flow from the front of the burner. This" is"a very
dangerous
condition which can cause afire to occur
behind the value panel, thereby damaging
the grill and
making it unsafe to operate. Inspect the grill twice a
year

around the grill. The chemical that produces the spraying
action could, in the presence of heat, ignite or cause
metal parts to corrode.
Do not use the grill for cooking excessively fatty meats
or products which promote flare-ups. Do not operate the
grill under unprotected combustible construction. Use
only in well ventilated areas. Do not use in buildings,
garages, sheds, breezeways or other such enclosed areas.
THIS UNIT IS FOR OUTDOOR USE ONLY.
Keep the area surrounding the grill free from
combustible materials, trash, or combustible fluids and
vapors such as gasoline or charcoal lighter fluid. Do not
obstruct the flow of combustion and ventilation air. If the
unit is stored indoors ensure that it is cool. If propane is
used, the cylinder nmst be unhooked and the propane
cylinder stored outside in a well ventilated area, out of
reach of children.
DO NOT
GRILL.

USE BRIQUETTES

OF ANY KIND IN THE

The Kirkland Signature Grill is designed for optimum
performance without the use of briquettes. Do not place
briquettes on the radiant as this will block off the area for
the grill burners to vent. Adding briquettes can damage
ignition components and knobs, and void the warranty.
Keep the back of the cart free and clear from debris.
Keep any electrical supply cord, or the rotisserie motor
cord away from the heated areas of the grill.
Never use the grill in windy conditions. If located in a
consistently windy area (oceanfront, mountaintop, etc.) a
windbreak will be required. Always adhere to the
specified clearance.

Be sure all grill controls are turned off and the grill is
cool before using any type of aerosol cleaner on or

NEVER

CLEARANCE
To Non-Combustible Construction
A nfinimum of 3" clearance from the back of the grill to
non-combustible construction is required for the lid to
open fully.

LOCATION
When determining a suitable location take into account
concerns such as exposure to wind, proximity to traffic
paths and keeping any gas supply lines as short as
possible. Locate the grill only in a well-ventilated area.
Never locate the grill in a building, garage, breezeway,
shed or other such enclosed areas without an approved
ventilation system. During heavy use, the grill will
produce a lot of smoke. Lock the wheels after the grill is
placed in a suitable position according to the sticker
located beneath the right door.

DO NOT INSTALL
EN('LOSURES.
I

THIS UNIT INTO ('OMB USTIBLE

USE A DENTED

OR RUSTYPROPANE

Thescrews
usedtoattachthesideshelfarealready
screwed
intotheleftpanel(seethefigurebelow).Remove
thescrews
fromtheleftpanel,alignwiththeholesinthesideshelf,andthenre-screw
intotheholesontheleftpanelofthegrill.

Thescrews
usedtoattachtheutensilrackarealready
screwed
intothebackoftheutensilrack.Unscrew
the2 screws,
align
theholesonthefrontsideofthesideshelf,andthentighten
upthescrews
toassemble
theutensilrack.

Thescrews
usedtoattach
thepushbararealready
screwed
intotherightpanel(seethefigurebelow).Remove
thescrews
fromtherightpanel,alignwiththeholesinthepushbar,andthenre-screw
intotheholesontherightpanelofthegrill.
Press
thecapagainst
theendsofthepushbar,andgentlytapthemintoplace.

Find the 4 screws used to attach the strengthening bar. Align the holes on the strengthening bar and the holes on the right
panel, and then tighten up the screws to assemble the strengthening bar. Tighten up the 2 screws from underneath also (see
the figure below) to further secure the strengthening bar.
Install the handles on the serving tray by align the holes on the serving tray and the handle, and then tighten up the screws.
Do this for the other side of the serving tray. Put the serving tray on top of the push bar to finish the assembly.

Thescrews
forrotisserie
mountarealready
screwed
intotherightsideofthegrillhousing.
Remove
thescrews
andinstall
therotisserie
motormountasshown
in thefigurebelow.Assemble
therotisserie
skewer
asshown
inthefigurebelow.

The pressure regulator and hose assembly supplied with
the grill must be used. Replacement pressure regulator
and hose assembO_ must be ,specified by the grill
lllaHllf(IctHrGr.

This is a liquid propane configured grill. Do not attempt
to use a natural gas supply unless the grill has been
reconfigured got natural gas use.
Total gas consumption (per hour) of The Kirkland
Signature Grill with all burners on "HI":
Main burners
Rotisserie burner
Side burner
Total

45,000
10,000
10,000
65,000

Btu/hr.
Bin/hr.
Btu/hr.
Btu/hr.

The installation of this appliance nmst conform with
local codes or, in the absence of local codes, with the
national fuel gas code, ANSI Z223. la-1988. Installation
in Canada must be in accordance with the Standard
Canl-b149.1 and/or .2 (installation code for gas burning
appliances and equipment) and local codes.
L.P. Tank Requirements
A dented or rusty L.P. tank may be hazardous and should
be checked by your L.P. supplier. Never use a cylinder
with a damaged valve. The L.P. gas cylinder must be
constructed and marked in accordance with the
specifications for L.P. gas cylinders of the U.S.
Depamnent of Transportation (DOT), or the National
Standard of Canada, CAN/CSA-B339, Cylinders,
Spheres and Tubes for Transportation of Dangerous
Goods; and Connnission.
The cylinder nmst be provided with a listed overfilling
presentation device and a shut valve terminating in an
L.P. gas supply cylinder valve outlet specified, as
applicable, for connection type QCC! in the standard for
compressed gas cylinder valve outlet and inlet
connection ANSI/CGA-V- 1.

Manifold pressure: (operating): 10" water cotunm.
L.P. GAS HOOK-UP:
Ensure that the black plastic grommets are in place and
that the hose does not come into contact with the heat
shield or the grill head.
CONNECTION:
Orifices for use with L.P. gas come equipped with a high
capacity hose/regulator assembly for connection to a
standard 20tb. L.P. cylinder (18-1/4" high, 12-1/4"
diameter).
To connect the L.P. gas supply cylinder, please follow
the steps below:
1. Make sure tank valve is in its full off position (turn
clockwise to stop)
2. Check tank valve to assure it has proper external
male threads (type 1 connection per ANSIZ21.81)
3. Make sure all burner valves are in their offposition.
4. Inspect valve connections port and regulator
assembly. Look for any damage or debris. Remove
any debris. Inspect hose for damage. Never attempt
to use damaged or plugged equipment. See your
local L.P. gas dealer for repair.
5. When connecting regulator assembly to the valve,
hand tighten nut clockwise to a positive stop. Do not
use a wrench to tighten. Use of a wrench may
damage quick coupling nut and result in a hazardous
condition.
6. Open tank valve fully (counterclockwise). Use a
soapy water solution to check all connections for
leaks before attempting to light grill. If a leak is
found, turn tank valve off and do not use grill until a
local L.P. gas dealer can make repairs.
To disconnect L.P. gas cylinder:
1. Turn the burner valve off.
2. Turn the tank valve off fully (turn clockwise to
stop).
3.

The cylinder supply system nmst be arranged for vapor
withdrawal. The cylinder nmst include a collar to protect
the cylinder valve.

GENERAL
Although all gas connections on the grill are leak tested
at the factory prior to shipment, a complete gas tightness
check nmst be performed at the installation site due to
possible mishandling in shipment, or excessive pressure
unknowingly being applied to the unit. Periodically

Detach the regulator assembly from tank valve by
turning the quick coupling nut counterclockwise.

check the whole system for leaks, or innnediately check
if the smell of gas is detected.
BEFORE TESTING
Make sure that all packing material is removed from the
grill including the burner tie-down straps.

DO NOTSMOKE
NEVER

LEAK

WHILE LEAK TESTING.

TEST

warranty. Do not use the grill until all connections have
been checked and do not leak.

WITH AN ()PEN FLAME.

ALWAYS CHECK FOR LEAKS AFTER
EVERY L.P. TANK CHANGE

Make a soap solution of one part liquid detergent and
one part water. You will need a spray bottle, brush, or
rag to apply the solution to the fittings. For the initial
leak test, make sure the L.P. cylinder is full.

Check all gas supply fittings for leaks before each use. It
is handy to keep a spray bottle of soapy water near the
shut-off valve of the gas supply line. Spray all the
fittings. Bubbles indicate leaks.

TO TEST
Make sure all control valves are in the "OFF" position.
Turn the gas supply on. Check all connections from the
L.P. cylinder up to and including the connection to the
manifold pipe assembly (the pipe that goes to the
burner). Soap bubbles will appear where a leak is
present. If a leak is present, innnediately turn off gas
supply, tighten any leaking fittings, turn gas on, and
recheck. Should the gas continue to leak from any or all
of the fittings, turn off the gas supply, and contact our
customer service at 1-800-913-8999.

Disconnected L.P. cylinders must have tln'eaded valve
plugs tightly installed, and must not be stored in a
building, garage or any other enclosed area.
The gas must be turned off at the supply cylinder when
the unit is not in use.
If the appliance is stored indoors the cylinder must be
disconnected and removed from the appliance. Cylinders
must be stored outdoors in a well-ventilated area out of
the reach of children.

Only those parts reconmlended by the manufacturer
should be used on the grill. Substitution can void the

Gas flow check:
Each grill burner is tested and adjusted at the factory
prior to shipment; however, variations in the local gas
supply may make it necessary to adjust the burners. The
flames of the burners should be visually checked.

Flames should be blue and stable with no yellow tips,
excessive noise or lifting. If any of these conditions exist,
check if the air shutter or burner ports are blocked by
dirt, debris, spider webs, etc.

Specified clearance maintained 24" from
combustibles.
All internal packaging removed.
Knobs turn freely.
Burners are sitting properly on orifices.
Pressure regulator connected and set for l 1.2" W.C.
L.P. gas. Gas connections to grill using hose &
PROPANE

a)
b)

regulator assembly provided (pre-set for l 1.0" water
colunm).
Unit tested and free of leaks.
User informed of gas supply shut off valve location.
USER, PLEASE RETAIN THESE INSTRUCTIONS
FOR FUTURE REFERENCE.

CYLINDER

CAUTIONS

Do Not store a spare LP-gas cylinder under or near this appliance.
NEVER fill the cylinder beyond 80 percent full.
c) If the information
in "a" and "b" is not followed exactly, a fire causing
injury may occur.

death or serious

General use of the grill and rotisserie
Each burner is rated at 15,000 Bin/hr. The grill burners
encompass the entire cooking area and are side ported to
minimize blockage from falling grease and debris.
Above the burners are stainless steel radiants. The igniter
knobs are located on the lower center portion of the
valve panel. Each rotary igniter is labeled on the
Lighting Instructions Plate.

motor mount. The rotisserie motor must be electrically
grounded in accordance with local codes or, in the
absence of local codes, with the National Electrical
Code, ANSI/NFPA 70-1990.
The skewer for the rotis is assembled into the motor
assembly by placing the pointed end into the motor, and
resting the grooved bushing on the support at the
opposite side of the grill. The thumbscrew should be
inside the grill body. With the skewer pushed as far as
possible into the motor, the skewer should rest on the left
side of the grill body. To load the skewer begin with the
handle in place, and slide one of the meat forks (prongs
toward the food) onto the skewer. Center the product to
be cooked on the skewer then push the meat forks finnty
together. Tighten the wing nuts as tight as possible.

USING THE GRILL:
Grilling requires high heat for searing and proper
browning. Most foods are cooked at the "HI" heat setting
for the entire cooking time. However, when grilling large
pieces of meat or poultry, it may be necessary to turn the
heat to a lower setting after the initial browning. This
cooks the food through without burning the outside.
Foods cooked for a tong time or basted with a sugary
marinade may need a lower heat setting near the end of
the cooking time.

It may also be necessary to wrap the food with butchers
string (never use nylon or plastic string) to secure any
loose portions. Once the food is secure insert the skewer
into the motor. It is normal for the skewer to flex when
larger cuts of meat are being cooked. It may also be
necessary to remove the grill rods for larger cuts of meat.
If the meat scrapes on the grill rods during any part of
the rotation, then the grill rods must be removed.
Assemble the counterweight with washers and handle to
counter balance the heaviest side of the meat. By suing
the counterweight the rotisserie motor should turn
smoothly through all 360 degrees of rotation.

Make sure the grill has been leak tested and is properly
located.
Remove any packing material.
Light the grill burners using the instructions in this
111anu al.

Turn the control knob to "HI" and preheat the grill for 15
minutes. The grill lid is to be closed during the appliance
preheat period.
Place the food on the grill and cook to the desired
doneness. Adjust heat setting, if necessary. The control
knob may be set to any position between "HI" and "LO".

After your first use of the rotis burner it is likely that the
stainless steel adjacent to the burner will darken to a dark
blue color. This is a normal property of the non-rusting,
type 304 stainless steel used on the grill.

NOTE: The Kirkland Signature grill is designed to grill
efficiently without the use of lava rocks or briquettes of
any kind. Heat is radiated by the stainless steel flame
tamers positioned beneath the solid stainless steel rods.

CAUTION: PLEASE TAKE OFF THE WARMING
RACK WHEN USING THE ROTIS BURNER. THE
HIGH HEAT COMING FROM THE ROTIS BURNER
MAY CAUSE THE WARMING RACK TO BEND.

NOTE: The hot grill sears the food, sealing in the juices.
The longer the preheat, the faster the meat browns and
the darker the grill marks.
DO NOT LEAVE THE GRILL UNATTENDED
WHILE COOKING.

USING ROTIS BURNER:
Your grill is capable of performing back burner rotis
cooking. Light the rear burner as described in the
lighting instructions. Once tit, the rotis burner will reach
cooking temperatures in about 1 minute.

WARNING
ELECTRICAL GROUNDING INSTRUCTIONS. This
appliance (rotisserie motor) is equipped with a plug and
should be plugged directly into a properly grounded
receptacle. DO NOT cut or remove the grounding prong
from this plug.
Keep the rotis motor electric cord away from the heated
surfaces of the grill. When not in use remove and store
the motor in a dry location.

The rotis motor is capable of turning up to a 12lb. cut of
meat or poultry. The motor slides onto the stainless steel

[

WARNING:

IMPORTANT!

If the burner will not light after several attempts then the
burner can be match lit.

BEFORE LIGHTING...
Inspect the gas supply piping or hose prior to turning the
gas "ON". If there is evidence of cuts, wear, or abrasion,
it nmst be replaced prior to use. Do not use the grill if the
odor of gas is present. The pressure regulator and hose
assembly supplied with the unit must be used. Never
substitute regulators for those supplied with the grill. If a
replacement is necessary, contact the factory for proper
replacement.

If you've just attempted to light the burner with the
igniter, allow 5 minutes for any accumulated gas to
dissipate. Keep your face and hands as far away from the
grill as possible. Insert a lit extended match or lighter
through the cooking grids to the burner. Press the control
knob and rotate left to the HI setting which should
release the gas. Burner will light immediately.
Push and turn the control knob which is centered on the
burner to "HI". If the burner does not light in 4 seconds
turn the knob off, wait 5 minutes and try again.

Screw the regulator (type QCC1) onto the tank. Leak
check the hose and regulator connections with a soap and
water solution before operating the grill (see assembly
instruction).

TO LIGHT THE ROTIS BURNER:
Open the lid, push the knob for about 5 seconds for the
gas to flow into the rear burner, then turn the knob to HI
position. If the burner does not light, turn the control
knob to "OFF". If the igniter does not function, the
burner can be lit by holding a lit match to the burner
(with the control knob at "HI").

TO LIGHT THE GRILL BURNER:
Turn all knobs to "OFF" then turn on the gas supply.
Always keep your face and body as far from the grill as
possible when lighting.
Open the lid, push and turn one control knob to the "HI"
position to light the burner. If the burner does not light,
wait for 5 minutes then retry.
TO MATCH

LIGHT

Keep a spray bottle of soapy water near the gas supply
valve and check the connections before each use.

[

Do not attempt to light the grill if odor of gas is present.
Call for service 1-800-913-8999.

THE GRILL:

1. Make sure the lid is open

2. Push and turn 1 knob to HI position

3. After the burner is lit, adjust the knob as desired

WARNING:IMPORTANT!
USINGTHESIDEBURNER:

cleaners available. Always use the mildest cleaning
procedure first, scrubbing in the direction of the grain.
To touch up noticeable scratches in the stainless steel,
sand very lightly with dry 100 grit emery paper in the
direction of the grain. Specks of grease can gather on the
surfaces of the stainless steel and bake on to the surface
and give the appearance of rust. For removal use an
abrasive pad in coniunction with a stainless steel cleaner.

Inspect the gas supply piping or hose prior to turning the
gas "ON". If there is evidence of cuts, wear or abrasion,
it nmst be replaced prior to use. Do not use the side
burner if the odor of gas is present.
WARNING:
Always keep your face and body as far
away from the burner as possible when lighting.

GRILL RACK
The easiest way to clean the grill is immediately after
cooking is completed and after turning off the flame.
Wear a barbeque mitt to protect your hand from the heat
and steam. Dip a brass bristle barbeque brush in tap
water and scrub the hot grill. Dip the brush frequently in
the bowl of water. Steam, created as water contacts the
hot grill, assists the cleaning process by softening any
food particles. The food particles wilt fall and burn. If
the grill is allowed to coot before cleaning, cleaning will
be more difficult.

LIGHTING INSTRUCTIONS
To light side burner, remove any cooking utensils from
the burner grate. Push and turn the control knob
counterclockwise to the "HI" position. If the burner does
not light, turn the control knob to "OFF". If the smell of
gas is detected and the igniter is not functioning,
innnediatety turn the control knob "OFF". Allow 5
minutes for any accunmtated gas to dissipate, then see
the following section for "MATCH LIGHTING".
MATCH LIGHTING
Hold a lit extended match or lighter near the burner
ports, turn the control knob counterclockwise to "HI".
Move your hand innnediately once the burner is lit.
Rotate the control knob to the desired setting. Check for
proper burner flame characteristics. Each burner is
adjusted prior to shipment; however, variations in the
local gas supply may take minor adjustments necessary.

GRILL BURNERS
Extreme care should be taken when moving a burner as it
nmst be correctly centered on the orifice before any
attempt is made to retight the grill. Frequency of
cleaning will depend on how often you use the grill.
GRILL BURNER CLEANING
Ensure the gas supply is off and the knobs are in the
"OFF" position. Make sure the grill is cool. Clean the
exterior of the burner with a wire brash. Clear stubborn
scale with a metal scraper. Clear any clogged ports with
a straightened paper clip. Never use a wooden toothpick
as it may break off and clog the port. Please note if
insects or other obstructions are blocking the flow of gas
through the burner, you will need to call our customer
service line.

Burner flames should be blue and stable with no yellow
tips, excessive noise, or lifting. If any of these conditions
exist call our customer service line. If the flame is
yellow, it indicates insufficient air. If the flame is noisy
and tends to lift away from the burner, it indicates too
nmch air.
STAINLESS STEEL
The grill is made from non-rusting and non-magnetic
stainless steel. There are many different stainless steel

GREASE TRAY CLEANING:
The grease tray should be emptied and wiped down
periodically and washed in a mild detergent and warm
water solution. A small amount of sand or cat litter may
be placed in bottom of grease tray to absorb the grease.

ENSURE
THAT THE GAS SUPPL Y AND THE
KNOBS ARE IN THE "OFF" POSITION.
MAKE
SURE THE RANGETOP
BURNER
IS COOL
BEFORE
REMOVAL.

BURNER CLEANING:
Clean the exterior of the burner with a wire brush. Clear
any clogged burner ports with a straightened paper clip.
Never enlarge the burner ports. Never use a wooden
toothpick as it may break off the clog the port.

STAINLESS STEEL:
There are many different stainless steel cleaners
available. Always use the mitdest cleaning procedure
first, scrubbing in the direction of the grain. Do not use
steel wool as it will scratch the surface. To touch up

noticeable
scratches
inthestainless
steel,sandvery
lightlywithdry100gritemery
paperinthedirection
of
thegrain.
TOP BURNER

The top burner grate is stainless steel. To avoid burns do
not clean a hot grate. They may be wiped while in place
with hot, soapy water, rinsed and wiped dry. Never
inm_erse a hot grate in water.

GRATE:

SPIDER AND INSECT WARNING!!!
Spiders and insects can nest in the burners of this or any
other grill, and cause the gas to flow from the front of the
burner. This is very dangerous condition which can cause
a fire to occur behind the valve panel, thereby damaging
the grill and making it unsafe to operate.

1.
2.
3.
4.

The smell of gas in conjunction with the burner
flames appearing yellow.
The grill does not reach temperature.
The grill heats unevenly.
The burners make popping noises.

BEFORE CALLING FOR SERVICE
If the grill does not function properly, use the following
checklist before contacting your dealer for service. You
may save the cost of a service call.

WHEN TO LOOK FOR SPIDERS
You should inspect the burners at least once a year or
inmlediately if any of the following conditions occur:

CHECKLIST
PROBLEMS
Grill won't light when the ignition
button is pushed.

WHAT TO DO
Check to see ifLP tank is empty
Clean wire(s) and/or electrode by rubbing with alcohol and clean swab
Wipe with dry cloth
Reconnect wire and/or electrode assembly
Do other burners on the unit operate?
Check the orifice for blockage.

Burner flame is yellow or orange, in
conjunction with the odor of gas.

Call our customer service line.

Low heat with knob in "HI" position.

Is the fuel hose bent or kinked?
Is the grill in a dusty area?
Is there adequate gas supply available? If it is only one burner that appears
low, does the orifice or burner need cleaning?
Is the gas supply, or gas pressure low?
Is the grill being preheated for 15 minutes?

MODEL

720-0011

PARTS

LIST

D_?SCR_PSION
25

FRe_?u lat:or

Rot

Me,or

sserie

Temperat_
Frort
Baffe

Gauge

02501

SEf

k160t

1 SET

8
@

Fss'_F,dG Ls+£
/

Har_/te
Assemb
I
1Rear
Pas_:_A

i i
12:, ,
12

Cockr_g

_ C:s, oki>Q
',,;,!arlsq ing
Grease

v,ki8

t SET

Cooking

5.220t
C0702

K070l

I 80701

k100t

00801

piOS
PO

B0903
2:}01

a, p(}l_;

'_e_

,L,eft

Push
Ba_'
Right
n frar,ed
E-}L,lrr_e "
(3as

C;olector,lsfrared

Door

41
42

B0601

Hight

Doo_

PC
PO
'3 PGS
'x%

Sholf

[3_;r

Bur*le

Bur_er

Doo_

:55B

"1 PC

,Fi_,d®

:34

00:_01

',_%Uhoe
[:_ack

B_,_r_'se_

Side

Gr'id

Lid.Side

2 PCS

B_Jr_{:_x s

_3de

I 8E'T

Bo'*a=/ Assembly,

C;rid;

@ Ta_T_

%4air_

£02DI

_2_ET

Cbiar'_et
Infrared

3 !

35A

Tray

_-/81s

k1401

Ove_
Batfe

/ k1602

1 SET

Cross
i:Rear

_Stx_r_er

Bracket

Utelssil

[q:ack

_}'_Uriser',

S id@

OF') Par@

_{_t4 Frier

: :[}ii)raw@_

Va Iv,e
Valve
Be;¢el
Co

taot

k06©i

43A

, Sde

Burr'_er

I F_C

kG6O2

43B

, Mair:_

i!);_rfle_

5 ROS

B2OO9

S P..,c;_

k1701

45,A

P_,4sP! Bal

Su, ppo_t,_t

I PS

k 1901

45B

Pc_sb_ Bar

Support,Left

_ S_Z1

X2101

2 PO,_

A32©3

isfra

_,(rsob

red

B_s_qe_

[::4',ight
i

Left
Serving

4 7
04

Pa_:,l

Par'_e

[)[c_wer

S_awer

q ray
gt]_

1S_w o?_,er Tray

_ 4S:

The doneness of meat, whether rare, medium, or well
done, is affected to a large degree by the thickness of the
cut. Expert chefs say it is impossible to have a rare
doneness with a thin cut of meat.

Sid_>

S_de

/__'}SSt

ro ni

S.I

sel

To get the juiciest meats, add seasoning or salt after the
cooking is finished on each side and turn the meat only
once @ices are lost when the meat is turned several
times). Turn the meat just after the juices begin to bubble
to the surface.

The cooking time is affected by the kind of meat, the size
and shape of the cut, the temperature of the meat when
cooking begins, and the degree of doneness desired.

Trim any excess fat from the meat before cooking. To
prevent steaks or chops from curling during cooking, slit
the fat around the edges at 2-inch intervals.

When defrosting meats it is recommended that it be done
overnight in the refrigerator as opposed to a microwave.
This in general yields a juicier cut of meat.

DO NOT LEAVE
THE GRILL
WHILE COOKING.

Use a spatula instead of tongs or a fork to turn the meat,
as a spamta will not puncture the meat and let the juices
run out.

UNATTENDED

WEIGHTOR
APPROXIMATE
TIME
FOOD
THICKNESSFLAMESIZE
VEGETABLES

Slice. Dot with butter or margarine.
Wrap in heavy-duty foil.
Grill, turning occasionally.

Fresh
Beets
Carrots

Turnips
Onion

Potatoes
Sweet
White

Medium

12 to 20 minutes

Grill, turning once. Brush
occasionally
with melted butter or margarine.

1/2inchslices

Medium

8 to 20 minutes
Wrap individually in heavyduty foil. Grill, rotating
occasionally.

Whole
6 to 8 ounces

Medium
High

40 to 60 minutes
45 to 60 minutes

Dot with butter or margarine.
Wrap in heavy-duty foil. Grill,
turning occasionally.

Frozen
Asparagus
Broccoli
Brussels
Sprouts
Green
beans
Peas

French
fries
MEATS
Beef

Hamburgers

SPECIAL INSTRUCTIONS
AND TIPS

1/2 to 3/4 inch

Medium

15 to 30 minutes

Medium

15 to 30 minutes

Medium
High

10 to 18 minutes
8 to 15 minutes

Place in aluminum foil pan.
Grill, stirring occasionally.

Grill, turning once when juices rise
to the surface.
Do not leave hamburgers
unattended since a flare-up could
occur quickly.

Steaks
Rib,
FOOD

WEIGHT OR
THICKNESS

FLAME SIZE

APPROXIMATE
TIME
18

SPECIAL INSTRUCTIONS
AND TIPS

Tenderloin,
Porterhouse,
T-Bone, Sirloin

Rare

1 inch

High

8 to 14 minutes

1-1/2 inch

High
Medium to

1! to ! 8 minutes

Medium

1 inch
1-1/2 inch

Welt-done

1 inch

High
Medium

1-1/2 inches

Medium

Remove excess fat from edge. Slash
remaining fat at 2-inch intervals.
Grill, turning once.

12 to 22 minutes
16 to 27 minutes
18 to 30 minutes
16 to 35 minutes

Lamb
Chops & Steaks

Rare

1 inch
1-1/2 inch

Medium

1 inch

High
Medium to

1-1/2 inch

High

18 to 25 minutes

1 inch

Medium

17 to 30 minutes

Welt-done

Pork
Chops
Welt-done

1 inch
1-1/2 inches

High

Medium
Medium

10 to 15 minutes
14 to 18 minutes

Remove excess fat from edge. Slash
remaining fat at 2-inch intervals.
Grill, turning once.

13 to 20 minutes

15 to 40 minutes
25 to 60 minutes

Ribs

Remove excess fat from edge. Slash
remaining fat at 2-inch intervals.
Grill, turning once. Cook welt done.

40 to 60 minutes

Grill, turning occasionally.
During last few minutes brush with
barbecue sauce, turn several times.

4 to 8 minutes

Remove excess fat from edge.
Slash remaining fat at 2-inch
intervals. Grill, turning once.

5 to 10 minutes

Slit skin. Grill, turning once.

Low or

1 to 1-1/2 hours

Place skin side up. Grill, turning
and brushing frequently
with melted butter, margarine, oil or
marinade.

Medium

40 to 60 minutes

Medium
Pork
Ham steaks

(precooked)

1/2 inch slices

Hot dogs
POULTRY

Broiler/fryer
Halved or

2 to 3 pounds

High
Medium

Quartered welldone
Breasts well-done
FOOD

Medium
WEIGHT OR
THICKNESS

30 to 45 minutes
APPROXIMATE
FLAME SIZE
TIME
19

SPECIAL INSTRUCTIONS
AND TIPS

FISHAND
SEAFOOD
Steaks
Halibut
Sahnon
Swordfish
Whole
Catfish
Rainbow
trout

Grill, turning once. Brush
withmelted butter, margarine or oil
to keep moist.

3/4to1inch

Medium to

8 to 15 minutes

High

4 to 8 ounces

Medium to

12 to 20 minutes

High

Grill, turning once. Brush with
melted
butter, margarine or oil.

BBQ SALMON

butter and sprinkled with chopped
parsley and a crisp lettuce salad.

2 large salmon steaks
2 tbs. Oil
Salt & pepper
2 oz. thin bacon slices
2 tbs. Butter
1 tbs. Lemon juice
Spring of parsley
Lemon wedges

Note: Substitute catfish, halibut or
cod for sahnon.
PORK CHOPS

Preheat the BBQ.
Brush the steaks with oil and
season with salt and pepper. Place
on BBQ grill and cook for 10
minutes, turning steaks over
halfway cooking time.
Meanwhile fry the bacon in a pan
on the side burner. Drain on paper
towels. Meld the butter in a small
saucepan taking care not to
discolor it. Arrange the fish and
bacon on serving plates. Pour the
butter over and sprinkle with
lemon juice. Garnish with parsley
springs and lemon wedges. Serve
with boiled potatoes tossed in
BAKED CHILI CORN
6 nledium ears corn, husked
3 tbs. Butter or margarine, melted
Dash ground cumin
Dash ground coriander
About */2hour before cooking, turn
the butter on for grill. Place each
corn on a heavy-duty foil. In a
bowl, combine remaining
ingredients. Mix welt. Brush 1-1/2
tsp. Butter mixture over each ear.
Close foil and fold up ends to seal.
Place on grill. Cook, turning
packets occasionally l0 to 12
minutes or until cooked through.
TANGY

SEAFOOD

KABOBS

1 lb. Large shrimp, shelled &
deveined
3/4lbs. sea scallops
2/3 c. chili sauce
*/4c. cider vinegar

4 Pork chops
Marinade
1 large onion
2 tbs. lemon juice or vinegar
2 tbs. oil
*/2tsp. powdered mustard
2 tsp. Worcestershire sauce
*/2tsp. freshly ground black pepper
1 tsp. sugar
*/2tsp. paprika
1 clove garlic
Peel, grate onion, add rest of the
ingredients except the pork chops.
Mix well. Pour over chops and
marinate one hour in a cool place.
Turn the BBQ grill on full. Heat
10 minutes. BBQ the chops
brushing with the marinade
occasionally. Serve with mixed
salad, dressed with vinaigrette
flavored with fresh dill.
3 tbs. chopped parsley
1 tbs. vegetable oil
1 tbs. Worcestershire sauce
*/2tsp. prepared horseradish
1 cove garlic, minced
1 20 oz. Can pineapple chunks in
juice, drained
In medium bowl, combine shrimp
and scallops. In small bowl
combine chili sauce and next six
ingredients. Pour over seafood.
Toss to coat. Cover, refrigerate 2
hours.
Half hour before cooking, turn the
burner to the grill on full. Drain
seafood reserving marinade. On
each of twelve 10" skewers, thread
2 shrimps and 2 scallops,
alternating with pineapple chunks.
Place skewers on grill. Cook 7-10
minutes, often basting and turning.

BARBECUED
BROIL

LONDON

4 to 6 servings
3Ac. Italian dressing
1 tsp. Worcestershire sauce
1 tsp. dry mustard
*/4tsp. thyme, crushed
1 medium onion, sliced
l pound flank steak, scored
2 tbs. butter, melted
Combine first 4 ingredients, add
onion and marinade flank steak
with it. Refrigerate at least 4 hours
or overnight. Remove steak and
grill on your preheated BBQ grill.
Grill 5 to 7 minutes on each side
basting frequently with the
marinade. In the meantime sautd
onions from the marinade in butter
in a skillet on your side burner for
3 minutes. To serve, slice steak
diagonally into thin slices, sprinkle
onions over top. Garnish with
vegetable kabobs.
BARBECUED
CHEESE

POTATOES

and

1-1/2 cups shredded cheddar
cheese
1 can (10-3/4 oz.) condensed
cream of mushroom soup
1/3 cup milk
2 tbs. barbecue sauce
*/4tsp. oregano
*/4tsp. salt
1/8 tsp. pepper
4 cups thinly sliced potatoes (4
medium-sized potatoes)
Preheat grill. Combine cheese,
condensed soup, milk, BBQ sauce,
oregano, salt and pepper in a large
mixing bowl. Stir in potatoes until
well coated. Turn into well
buttered l- l/2 quart rectangular
baking dish. Cover dish with
aluminum foil. Bake covered 25
minutes on medium with the lid of
your BBQ grill closed. Remove
foil and continue baking 15

minutes longer or until potatoes
are tender. Let stand 5 minutes
before serving.
VEGETABLE

KABOBS

3 medium-sized zucchini
12 cherry tomatoes
12 fresh mushrooms
Grated Parmesan cheese
Parboil whole zucchini 5 minutes
on your side burner or until just
tender. Drain and cut into 1/2inch
slices. Thread zucchini, tomatoes
and mushrooms alternately on
each of six skewers. Brush with
marinade made of Italian dressing,
Worcestershire sauce, mustard and
thyme. Grill 5 to 7 minutes turning
and basting occasionally. Sprinkle
liberally with Parmesan cheese.
FAJITAS
1-1/2 lb. flank steak or boned
chicken breasts
2 tbs. oil
1/2cup limejuice
1/2tsp. salt
1/2tsp. celery salt
1/4tsp. garlic powder
IAtsp. pepper
1/4tsp. oregano
1/4tsp. cumin
Flour tortillas lemon
Pound flank steak to 1/4inch
thickness or flatten chicken
breasts. Mix oil, lime juice and
seasonings in a zip lock bag. Add
meat and shake bag to coat the
meat. Refrigerate overnight or at
least 6 to 8 hours. Wrap tortillas in
foil. Remove meat from marinade.
Cook on a pre-heated gas grill for
5 to 8 minutes on each side. While
meat is cooking, heat tortillas on
grill. Slice meat across grain in
thin slices. Place on hot platter.
Squeeze lemon juice over. Wrap
meat and any of the following
toppings in tortillas: chopped
tomatoes, guacamote, sour cream,
taco sauce.
BEEF

AND LAMB

KABOBS

Serve 4
1/2lb. boneless sirloin or beef cut
into 1" cubes
IAlb. boneless loin of lamb cut into
1" cubes
2/3 c. water, divided
1/4c. chopped onion
2 tbs. soy sauce
1/4c. vegetable oil, divided
1 tbs. dark brown sugar
1 tbs. fresh lemon juice
2 cloves garlic, minced
1/4tsp. ground cumin
1/4tsp. ground coriander
1/4tsp. ground turmeric
1/8 tsp. ground red pepper
1/8 tsp. ground ginger
1 red pepper cut into chunks
1 large banana, cut into chunks
8 small mushrooms
1/3 c. smooth peanut butter
In blender, process 1/3 c. water,
onion, soy sauce, 2 tsp. oil and the
next 8 ingredients until smooth.
Pour over meat cubes and marinate
about 4 hours, turning
occasionally. Drain and reserve
marinade. Onto to four 12"
skewers alternately thread meat,
pepper, banana and mushrooms.
Preheat grill. Brash the kabobs
with oil. Grill 7-8 minutes each
side.
Bring marinade to boil on the side
burner in a saucepan. Add
remaining 1/3 c. water and peanut
butter. Stir to blend. Heat through.
If sauce gets too thick, add 1 tbs.
water. Serve sauce with kabobs.
EGGPLANT

CAVIAR

1 large eggplant
2 tbs. olive oil
2 tbs. wine vinegar
2 tbs. finely chopped onion
IAclove garlic, minced
1 medium tomato, chopped salt
and pepper
Roast eggplant on gas grill over
medium flame, turning
occasionally until thoroughly
cooked. This may take 30 minutes.
Remove from grill and coot for
handling. Strip off the skin and
22

chop eggplant finely. Add all the
seasonings. Chill thoroughly and
serve on toast.
CHICKEN

TANDOORI

STYLE

8 large chicken thighs or
drumsticks
1 c. plain nonfat yogurt
1/2c. lemon juice
2 tsp. salt
1/2tsp. cayenne
IAtsp. black pepper
IAtsp. crushed garlic
IAtsp. grated ginger
1 tbs. corn oil
Combine all the ingredients in a
large mixing bowl and marinate
the chicken for 8 hours in the
refrigerator. Drain the chicken and
spread on the spit running the rod
on the fleshier side of the bone.
Rotis using the rotis burner. Cook
on medium high heat for 40
minutes basting occasionally with
the remainder of the marinade
mixture. Serve with sliced onions
and lemon wedges.
SPARE RIBS
Marinade:
1 c. soy sauce
IAc. honey
IAc. vinegar
IAc. dry sherry
2 tsp. chopped garlic
2 tsp. sugar
1 c. water
1 chicken bouillon cube
1 can beer for basting sauce
Marinade ribs for 3 hours. Use
marinade for basting by adding
beer to it. Place pan under the ribs
and baste frequently. To cook ribs
select lean, meaty ribs and
accordion pleat them with your
spit. Slide four prong meat hook
down the length of spit and
tighten. At the beginning of the
rack and to its center, penetrate the
second rib with the pointed end of
the spit and push it between the
meat. Skip a couple and continue
the process until the entire rack is

accordion pleated. Fasten the
second meat hook into the rack.
Turn your rotis burner on high.
Rotis for 50 minutes or until done.
PORK ROAST
Apple cider vinegar basting sauce:
1 c. apple cider vinegar
6 oz. water
*Astick butter
Salt, pepper, parsley and garlic
seasoning
2 oz. lemon juice
10 lbs. pork roast
Time: 1-1/2 hours to 2 hours
Bring pork to room temperature
before placing it on the spit rod.
Place on the rod and test for
balance. Light rotis burner. Turn
control knob to high. Use the
above basting sauce for rotissing.
TURKEY
12 lb. turkey
Beer basting sauce:
1 can beer
12 oz. water
1 stick butter
1 tsp. salt
1 tsp. pepper
*ktsp. garlic flakes
1 tsp. parsley
Thaw the bird completely. Wash
inside out. Securely tie the legs
and wings. Light rotis burner. Turn
to high. Combine all the
ingredients for basting sauce in a
shallow pan. Place it under the
turkey 15 to 20 minutes. Cook for
approximately 3 hours. The
basting sauce combined with
turkey drippings makes a delicious
gravy.

LIMITED
WARRANTY
MODEL 720-0011
STAINLESS
STEEL OUTDOOR

GAS GRILL

Virco Associates Ii_c. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to
normal residential use, it is free from defects in workmanship and materials for the periods specified below. This
warranty excludes grills used in rental or commercial applications. There will be a shipping and handling charge for
the delivery of the warranty part(s).

Component

Warranty

Period:

Burners:
Stainless Steel Flame Tamer:

5 Years
3 Years

Stainless Steel Cooking Grids:
Valves:

3 Years
1 Year

Frame, Housing, Cart, Control Panel, Igniter, and Related Parts:
All Stainless Steel Parts

! Year
3 Years

Our obligation under this warranty is limited to repair or replacement, at our option, of the product during the
warranty period. The extent of any liability of Virco Associate Ii_c. under this warranty is limited to repair or
replacement. This warranty does not cover normal wear of parts, damage resulting from any of the following:
negligent use or misuse of the product, use on improper fuel/gas supply, use contrary to operating instructions, or
alteration by any person other than our factory service center. The warranty period is not extended by such repair or
replacement.

Warranty claim procedure: If you require service or parts for your grill, please contact our Warranty Service
Center for factory direct assistance. Our hours of operation are 8 AM to 5 PM PST. Our number is 1-909-5988799
and our FAX number is 1-909-5987699.
Please direct all correspondence to: Virco Associate, I_c. 145 Brea
Canyon Road, Walnut, ('A 91789ATTN." WarranO: Service ('el_ter.

Product repair as provided under this warranty is your exclusive remedy. Virco Associate, I_c. shall not be liable for
any incidental or consequential damages for breach of any express or implied warranty on its products. Except to
the extent prohibited by applicable law, any implied warranty or merchantability or fitness for a particular purpose
on this product to the duration of the above warranty. Some states do not allow the exclusion or limitation of
incidental or consequential damages, or allow limitations on how long an implied warranty lasts, so the above
limitations or exclusions may not apply to you. This warranty gives you specific legal rights, and you may have
other rights, which vary from state to state.

Source Exif Data:

File Type                       : PDF
File Type Extension             : pdf
MIME Type                       : application/pdf
PDF Version                     : 1.2
Linearized                      : No
Page Count                      : 26
Page Layout                     : SinglePage
Page Mode                       : UseNone
Producer                        : Goby Monitor Application version 3, 2, 1, 4
Create Date                     : Sat Mar 29 09:30:06 2014
Author                          : 
Title                           : 
Subject                         :

EXIF Metadata provided by EXIF.tools

Kirkland 720 0011 User Manual GAS GRILL Manuals And Guides 1303166L

Navigation menu

Versions of this User Manual:

Views

Navigation