LENNOX Air Handler Auxiliary Heater Kit Manual L0805590

User Manual: LENNOX LENNOX Air Handler Auxiliary Heater Kit Manual LENNOX Air Handler Auxiliary Heater Kit Owner's Manual, LENNOX Air Handler Auxiliary Heater Kit installation guides

Open the PDF directly: View PDF PDF.
Page Count: 18

uTeohnca@0 0S
blications
Lithe U.S.A.
_c_2005
ELECTRIC HEAT SECTIONS
505,053M
5/2005
Supersedes 4/2005
EHA102/360
ELECTRIC HEAT
See unit nameplate for manufacturer's
name and address.
INSTALLATION INSTRUCTIONS FOR EHA102/360 ELECTRIC HEAT ASSEMBLIES
USED WITH LC/LH/TC/TH 090/360 UNITS
Package 1 of 1 contains:
,WARNING
1- Electric heat assembly
1- Bag assembly containing:
1- Wiring diagram sticker
14- Screws
Inspect package upon receiving. If damage is found,
contact last carrier immediately.
F4 Fuse Block
Fuse block assembly (F4) is not furnished with electric
heat and must be ordered extra. The fuse block is
required in single point power installations only.
Terminal Block
TB2 is not required when unit has S48 disconnect or
CB10 circuit breaker. Power can be distributed from S48
and CB10 instead of TB2.
ACAUTION
EHA102, 150, 156,240 & 360 electric heat sections
are used as primary heaters for packaged cooling units
and as a secondary heat source for packaged heat
pump units. See table 1 for match-ups. Two electric
heat assemblies are used in 156 through 360 units;
only one electric heat assembly is used in 090 through
150 units.
LC/LH Units and TC/TH090-150 Units
A separately ordered TB2 is required when:
-Unit TB2 has single connection points on the load side
-Single power supply applications
NOTE -For ordering purposes, F4 fuse block and TB2
terminal block may be referred to as LAFB and LTB2
respectively. For use in this manual and on wiring
schematics, F4 and TB2 nomenclature is used.
TC/TH180-300S Units
TB15 is provided in the electric heat control kit.
Electric Heat Control Module
The EHA series heaters are CGA and ETL design
certified.
Installation of electric heaters must conform with
standards of the National Fire Protection Association
(NFPA) "Standard for Installation of Air Conditioning and
Ventilation Systems NFPA No. 90A;" "Standard for the
Installation dResidence Type Warm Air Heating and Air
Conditioning Systems NFPA No. 90B;" in Canada, CSA
C22.1 Canadian Electrical Code -- Part I and all
applicable CSA requirements; manufacturer's
installation instructions and local municipal building
codes. Heaters are approved for clearances to
combustible materials as listed on heater rating plate.
The electric heat control module kit is not furnished with
electric heat and must be ordered extra.
The kit is required on TC/TH units. The kit is required on
LC/LH 156-360 units when EHA150-30, 60; or
EHA360-22.5, 45 are being installed.
05/05
IIIIIIIIIIIIIIIIIIIIIIIIIIIIfllllllllll
Accessibility and service clearances must take
precedence over fire protection clearances. All wiring
must conform with local building codes and the current
National Electric Code (NEC) ANSI-C1 and in Canada,
CSA C22.1 Canadian Electrical Code--Part I and the
applicable CSA requirements.
505,053M
Page1 IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
1- Disconnect all power to unit,
2- Remove or open unit heat and compressor access
panels. Remove screws and discard rectangular
vestibule cover(s), See unit installation instruction
dimension page,
3- Insert electric element heat assembly into
rectangular vestibule opening and secure assembly
using screws provided. See figure 1,
4- Single Power Point Only -
Install F4 fuse block assembly (ordered separately)
using screws provided, See figure 1 for location,
5- Insert fuses from bag assembly in fuse block assembly.
6- Affix F4 and fuse amp stickers next to fuse block,
.Install electric heat control module kit when required
(ordered separately). Refer to module installation
instructions for proper installation and electrical
connections.
TABLE 1
KW
Packaged Units Electric Heat Output
Cooling 090, 102 (7-1/2, 8-1/2 Ton) EHA102-7.5 7.5
Heat Pump 090, 102 (7-1/2 Ton, 8-1/2 Ton)
Cooling 090, 102, 120, 150 (7-1/2, 8-1/2, 10, 12-1/2 Ton)
Heat Pump 090, 102, 120, 150 (7-1/2, 8-1/2, 10 Ton, 12-1/2 Ton)
EHA150-15
EHA360-22.5
EHA150-30
EHA150-45
15
22.5
3O
45
Cooling 120, 150 (10, 12-1/2 Ton) EHA150-60 60
Heat Pump 120, 150 (10 Ton, 12-1/2 Ton)
Cooling 156 (13 Ton)
EHA240-7.5 and EHA240S-7.5
EHA156-15 and EHA156S-15
EHA156-22.5 (2)
EHA156-30 (2)
EHA240-7.5 and EHA240S-7.5
15
3O
45
6O
15
Cooling 180, 210, 240,300S (15, 17-1/2, 20, 25 Ton)
Heat Pump 180, 240 (15, 20 Ton)
EHA360-15 and EHA360S-15 30
EHA360-22.5 (2) 45
EHA150-30 (2) 60
Field
Wiring
Figure
2&3
2&3
4&5
4&5
4&5
4&5
6&9
6,7,9,10
8&11
6&9
6, 7,9,&
10
8&11
Cooling 210, 240, 300S (17-1/2, 20, 25 Ton) EHA360-45 (2) 90 8 & 11
Heat Pump 240 (20 Ton)
EHA360-15 and EHA360S-15
EHA360-22.5 (2)
EHA150-30 (2)
EHA150-45 (2)
EHA150-60 (2)
3O
45
6O
9O
120
Cooling 248, 300H, 360 (21, 25, 30 Ton)
6&7
8
8
8
8
(2) Two electric heat assemblies.
Page2
WiringmustconformtolocalcodesandNEC/CEC,Refer
closelyto wiringdiagramin this instructionand the
followinginformation:If electricheatassemblyis being
installedin anexistingunit,a changein powersupply
wiringanddisconnectswitchorcircuitbreakermaybe
required,Removetheoriginalsupplywiresordisconnect
atpowersource.Refertoheaternameplateforminimum
circuitampacityandmaximumfusesize.
unit.Forlowvoltagewiringconnections,referto unit
and electric heat control module installation
instruction,
2- Make24 volt harnessjack/plugconnectionsas
follows.ConnectelectricheatjackJ7toelectricheat
plugP7.For156through360unitswhichcontain
twoheatsections,alsoconnectelectricheatjack
J37toelectricheatplugP37,
3- Placeelectricheatwiringdiagram(provided)onthe
innersideofcompressoraccesspanel.
,&,WARNING EHA electric heater applications require specific blower
air volumes. Refer to tables 2 through 6 for proper blower
speeds.
Note -Minimum air requirements are shown in tables; do
not set CFM lower than minimum CFM listed.
-Review heater installed nameplate for MCA values
and enlarge power entry knockouts as needed, Refer
to table 1 for appropriate field wiring diagram. When
multiple figures are listed, use diagram which has the
same factory and/or field optional components as the
Set room thermostat for proper heat or auto operation if
switching subbase is used, Apply power to unit and
position heat setpoint lever above room temperature.
Refer to unit installation instructions for additional
information on start-up operations and adjustments.
Page 3
ELECTRICHEATINSTALLATION
(EHA150-45 SHOWN IN LC/LH UNIT)
TB3
J7 OR J37
_S48 DISCONNECT SWITCH,
OR CB10 CIRCUIT BREAKER
(OPTION)
ELECTRIC HEAT CONTROL
MODULE KIT ORDERED SEP-
ARATELY, FIELD-INSTALLED
\
TB15 ON TC/TH ONLY;
ORDERED SEPARATE- \
LY (FIELD-INSTALLED)
TB13 (LC/LH)
TB2 (TC/TH) UNIT
TERMINAL BLOCK
F4 FUSE BLOCK ASSEMBLY; OR-
DERED SEPARATELY, FIELD-
INSTALLED. USED ONLY WITH SINGLE
POINT POWER INSTALLATIONS
ELECTRIC ELEMENT
FACEPLATE ACCESS COVER
NOTE -Install electric heat
components in approximately
the same locations shown
regardless of unit size. 13 THROUGH 30-TON UNITS HAVE
TWO HEAT SECTIONS
FIGURE 1
Page 4
LC/LH090-150 UNITS AND TC/TH090-150 UNITS
0_
-L
F
L
T
T
K2
2L
2
LI L2 L3
POWER SUPPIY TO FUSEO
DISCONNECT SWITCH
(NOT FURNISHED)
rh
L L2 L3
MOOEL
EHAI02 7.5 Y,G,J
EHAISO-15- Y,G, J
SINGLE POWER SUPPLY - NO CB10/$48
GROUND
POWER SUPPLY #1
TO FUSED DISCONNEC]
SWITCH (NOT FURNISHED)
L L2 L3 LI LZ L3
POWER
L
SUPPLY _2
MODEL
EHA}O2-7,5-Y,O,J
EHAI50-15-Y,G,J
MULTIPLE POWER SUPPLY - NO CB10/$48
CB10-Circuit Breaker
F3- Electric Heat Fuse Block
F4- Unit Fuse Block
K2- Contactor (wire to K2 only when unit
does not contain TB13)
$48- Disconnect
TB2- Unit Terminal Block
TB13-Unit Terminal Block
POWER
SUPPLY
fO FUSED
DISCONNECT
SWITCH
..................i-iTo.............
I Js
1.2 13
(NOT FURNISHED) MODEL
EHAI02 7,,_ Y,G,J
EHAI50 15 Y,G,J
LI L2 L3
ROOND
L2 L3
POWER
SUPPLY _E
]0 FUSED
DISCONNEC1
SWITCH
CNOT FURNISHED)
K2
,._ _7.......
i
L I L2 L3
POWER
S(PPI Y #2
MODEL
EHAIO2-7.5-Y,G,J
EHAI50-I5-Y,G,J
SINGLE POWER SUPPLY WITH CB10/$48 MULTIPLE POWER SUPPLY WITH CB10/$48
FIGURE 2
Page 5
TC/TH090-150 UNITS
CB10-Circuit Breaker
F3- Electric Heat Fuse Block
F4- Unit Fuse Block
K2- Contactor (wire to K2 only when unit
does not contain TB13)
$48- Disconnect
TB2- Unit Terminal Block
POWER SUPPLY TO FUSED
DISCONNECT SWITCH
(NOI _URN!SHED)
A
L L2 L3
YODEL
EItAI02 7.5 Y,6,J
EHAI50 15 Y,G,J
SINGLE POWER SUPPLY WITH CB10/$48 - NO TB13
FIGURE 3
TC/TH090-150 UNITS
CB10-Circuit Breaker
F4- Unit Fuse Block
K2- Contactor (wire to K2 only when unit
does not contain TB13)
$48- Disconnect
TB2- Unit Terminal Block
TB3- Electric Heat Terminal Block
LI L2 L3
POWER SUPPLY TO FUSED
DISCONNECT SWI [CR
(NOr FURNISPED)
MODEL
EHAE50-30- Y,O, J
EFAI50-45- Y,6, J
EhAISO-60- Y,6, J
EHA560-22.5-Y, 6, J
SINGLE POWER SUPPLY WITH CB10/848 - NO TB13
FIGURE 4
Page 6
T_ TS....
OF K2
.1L2L
F
_2
LE L2 L3
POWER SUPPLY TO FUSED
DISCONNECT SWITCH
(NOT FURNISHED)
LC/LH UNITS AND TC/TH090-150 UNITS
]/-
IL_
L
El
L2
L3
MODEL
EHAI5030-Y,G,J
EHAISO-45-Y,G,J
EHAE50 60 Y,O,J
EHAIOO-22.5Y,G,J
EHAIOO-SO-Y,G,J
EHAIOD-45-Y,O,J
EHASBO-22.5-Y,G,J
GROUND
POWER SUPPLY _1
]0 FUSED DISCONNECT
SWITCH (NOT FURNISHED)
S
LI L2 L5 L112 L5
POWER
SUPPLY #2
LI
L5
MODEl....
E:HAI50 30 Y,G,J
EHAI50-¢5-Y,G,J
EHAI50-60-Y,G,J
EHAIO0-22.5 Y,G,J
EHAIOO-DO-Y,G,J
EblAIOO 45 Y,G,J
EHA560-22.DY,G,J
SINGLE POWER SUPPLY - NO CB10/$48 MULTIPLE POWER SUPPLY - NO CB10/$48
CB10-Circuit Breakers
F4- Unit Fuse Block
K2- Contactor; (wire to K2 only when unit
does not contain TB13)
$48- Disconnect
TB2- Unit Terminal Block
TB3- Electric Heat Terminal Block
TB13-Unit Terminal Block
L
L} L2 L3
3R
LIL2 L3
POWER SUPPLY TO FUSED
DISCONNECT SWlTCII
(NOT FURNISHED)
J
LI
L2
I¸¸¸¸3
MODEl....
EHAI50 30 Y,G,J
EHAI50-45-Y,G,J
EHAIDO-6OY,G,J
EHAIO0 22.5 Y,G,J
EHAIOO-SO-Y,G,J
EHAIOO45-Y,G,J
EHA360 22.5 Y.G,J
LI
GROUNDr" "l
LI L2 LS
POWER SUPPLY #}
TO FUSED DISCONNECT
SWITCH (NOT FURNISHED)
OF K2
L2 L,S ]
I
L5
MODEL
LI L2 L5 EHAI50_SOY,G,J
POWER EHAIDO-45-Y,D,J
SUPPLY #2 EHAI50-60-Y,D,J
EHA560 22,5 Y,G,J
SINGLE POWER SUPPLY WITH CB10/$48
FIGURE 5
MULTIPLE POWER SUPPLY WITH CB10/$48
Page 7
I E2 L5
LC/LH 180-360 UNITS
POWER SUPPLY TO FUSED
DISCONNECT SWITCH
(NOT FURNISHED) MODEL
EHA2#O-7,5- Y, G, J
EHA560-15-G,J
EHA56-5 O,J
MODEL
EHA240S 7,5 Y,G,J
EHA360S-15-G,J
EHAI56S+I5-G,J
GROUND
LI L2L3 L 2+3
POWER POWER
SUPPLY +I SUPPLY +2
TO FUSED
DISCONNECT
SWITCH
(NOT FURNiSHEDI
MODEL MODEL
EHA240+715-Y,G,J EHA240S+7,5-Y,G,J
EHA360-15+G,J EHASGOS-15-G+J
EHM56 15G,J EMAI55S 15-G,J
SINGLE POWER SUPPLY - NO CB10/$48 MULTIPLE POWER SUPPLY - NO CB10/$48
CB10-Circuit Breaker
F3- Electric Heat Fuse Block
F4- Unit Fuse Block
$48- Disconnect
TB2- Unit Terminal Block
TB13-Unit Terminal Block
I+
GROUND
LI L2 L3
I
+1
GROUND
MODEL
EHA2¢O 7,5 Y,G,J
EHA56015+ G,J
EHAI56 +15+ G,J
MODEL
EHA240S 7,5 Y+G,J
EHA360S-15-G,J
EHAI56S-+5 G,J
MODEL MODEL
EHA24OT,5+Y,O,J EHA240S-7.5-Y,G,J
EHA360-15-G,J EHA3605-+5-G,J
EHA+56 +5+G,J EHM56Sq5 G,J
SINGLE POWER SUPPLY WITH CB10/$48 MULTIPLE POWER SUPPLY WITH CB10/$48
FIGURE 6
Page 8
LC/LH 180-360 UNITS
TE I
_ILZL
F_
l
!r- }
}
MODEL
LI L2 L5 EHA560 15 Y
POWER EHAI56 I5-Y
SUPPLY
TO FUSED
DISCONNECT
SWITCH
{NOT FURNISHED)
MODEL
EHA360S-15-Y
EllAI56S IS-Y
GROUND
!l L2 L3 LI LZ L3
POWER DOWER
SUPPLY _I SUPPLY _2
TO FUSED
DISCONNECT
SWITCH
(NOT FURNISHED}
MODEL MODEL
EHA560-15-Y EHA360S-15-Y
EHM56 15-Y EHA]56S }5 Y
SINGLE POWER SUPPLY - NO CB10/$48 MULTIPLE POWER SUPPLY - NO CB10/$48
CB10-Circuit Breakers
F3- Electric Heat Fuse Block
F4- Unit Fuse Block
$48- Disconnect
TB2- Unit Terminal Block
TB3- Electric Heat Terminal Block
TB13-Unit Terminal Block
SUPPLY
SWITCH
(NO] FURNISHED)
GROUND
......Li ...................................................................................
LZ_ r............................................
MODEL
EHAS60 15 Y
EHA!56 5-Y
SINGLE POWER SUPPLY WITH CB10/$48
MODEL
EHA36OS-IS-Y
EHAI56545-Y
LI L2 L5
LI L2L3 I _,,
POWER
SUPPLY
TO FUSED
DISCONNECT
SWITCH
[NOT FURNISHED_ L
L I L2 L3
POWER
SUPPLY .2
LI
L2
F...................................WIRING
u L Lfl ELEMENT
MODEL MODEL
EHA560-15-Y EHA560S-15-Y
EHAI56 15-Y EHAI565 IS-Y
MULTIPLE POWER SUPPLY WITH CB10/$48
FIGURE 7
Page 9
LC/LH 180-360 UNITS
F
T
GROUND
LI L2 L3
ROWER
SUPPLY
TO FUSED
DISCONNECT
SWITCH
(NOT FURNISHED)
MODEL MODEL
EItA360-22.5=Y,G,J EHA360-22.5-Y,G,J
EHAI50=SO-Y,G,J EHAISO-30-Y,O,J
EHASGO=45-Y,G,J EHAS60_45_Y,O,J
EHAIEO=60-Y,G,J EHAISO-60_Y,O_J
ENAI5622.5Y,G,J EHAI56-22,5-Y,G,J
EHAI56-30-Y,G,J EHAI56 30 Y,G,J
GROUND
LI L2 L3 L2 E3
POWER POWER
SUPPLY _I
TO FUSEO SUPPLY _2
OISCONNECT
SWITCH
(NOT FURNISHED}
l
L_ ] rlLll
_3
MODEL MODEL
EHA360-22.5-Y, G, J EHA360-22.5-Y, G, J
EHAI50 30 Y,G,J EHAI50 30 Y,G,J
EHA360 '#5 Y,G,J EHA360 45 Y,G,J
EHAISO-60-Y,G, J EHAI50-GO-Y, G, J
EHA56 22.5-Y,G,J EHAI56 22.5 Y,G,,J
E A56 30 Y,G,J EHAI56_30-Y+G,j
SINGLE POWER SUPPLY - NO CB10/$48 MULTIPLE POWER SUPPLY - NO CB10/$48
[2 L_
POWER
SUPPLY
TO FUSED
DISCONNECT
SWITCH
[NOT FURNISHED)
GROUNO
CB10-Circuit Breakers
F4- Unit Fuse Block
$48- Disconnect
TB2- Unit Terminal Block
TB3- Electric Heat Terminal Block
TB13-Unit Terminal Block
-LI
• L2
MODEL
EMA36022,5Y,G,J
ERAISO3OY,O,J
EHA36045Y,O,J
EHAISOGOY,O,J
EHAI56 22.5-Y,O,J
EHAIS6 30 Y,G,J
MODEL
EHA360-22.BY,G,J
EHAISO-30-Y,G,J
EHA360-#5_Y,G,J
EHAIBO_60_Y,G,J
EHAI56 22.5 Y,G,J
EHAIS6 30 Y,G,J
GROUND
LI L2 L3
L1_213
POWER
SUPPLY _1
TO FUSED
DISCONNECT
SWITCH
INOT FURNISHE0)
I
I _MPREL , MODEL
EHA&6022.SY,G,J EHA36022.5_Y,G,J
L I L2 L3 EHA 15D-&O_Y, G, J EHA 15D_30-Y, 0, J
RAWER EHA36045Y,G,J EHA36045Y,G,J
SUPPLY _2 EHAiSO_GO-Y,G,J EHAISO_60-Y,O,J
EHAISG 22.5 Y,G,J EHAI56 22.5 Y,G,J
EllAI5G 30 Y,G,J EHAI56-30-Y,G,J
SINGLE POWER SUPPLY WITH CB10/$48 MULTIPLE POWER SUPPLY WITH CB10/$48
FIGURE 8
Page 10
TC/TH 180-300S UNITS
t2 L3
POWER
SUPPLY
TO FUSED
OISCONNECT
SWITCH
(NOT FURNISHEO)
MODEL
EHA240-7,5- Y, G, J
EI4A560-15- G, J
EHA56- 5 G,,_
MODEL
EHA2+OS 7.5 Y.G,J
EHA360S-15-G,J
EHAI56S+I5- G,J
I
LI L2 L5
GROUND
LI L2 L3 L+L215
POWER POWER
SUPPLY ,I SUPPLY _
TO FUSED
D]GCONNEOY
5WITCH
(NOT FURNISHED) MODEL MODEL
EHA240 7.5 Y,O,J EHA240S+715+Y.O,J
EHA360_IB+O,J EHA560S_I5G,J
EHAI56 +156,J EMAI56S 15-S,J
SINGLE POWER SUPPLY - NO CB10/$48 MULTIPLE POWER SUPPLY - NO CB10/$48
POWER
SUPPLY
10 FUSED
DISCONNECt
SWI[CH
(NO_
_URN]SHED)
GROUND
CB10-Circuit Breaker
F3- Electric Heat Fuse Block
F4- Unit Fuse Block
$48- Disconnect
TB2- Unit Terminal Block
TB13-Unit Terminal Block
MODEL
EHA240S 7.5 Y.G.J
EMA560S-15G,J
EHM56Sq5 G,J
MODEL MODEL
EHA2407,5Y.O,J EHA24OS+7,5-Y,G,J
EHA360 15 O,J EHA360S-+5-G,J
EHA+56 +5+G,J EHM56Sq5 G,J
SINGLE POWER SUPPLY WITH CB10/$48 MULTIPLE POWER SUPPLY WITH CB10/$48
FIGURE 9
Page 11
TC/TH 180-300S UNITS
IL..........................................................
!#-
LI L2 L3
POWER
SUPPLY
TO FUSED
DISCONNECT
SWITCH
(NOT
FURNISHED)
MODEL
EHA360 15 Y
EHAI56 I5-Y
MODEL
EItA36OS-IS-Y
EllAI56S }5-Y
SINGLE POWER SUPPLY - NO CB10/$48
GROUND MODEL MODEL
L! L2 L3 LI LZ L3 ERA360-IS_Y EHA360S-15-Y
POWER POWER EHM56 15-Y EHAI56S }5 Y
SUPPLY ,I SUPPLY #2
TO FUSED
DISCONNECT
SWllCH
(NOT FURNISHED)
MULTIPLE POWER SUPPLY - NO CB10/$48
CB10-Circuit Breakers
F3- Electric Heat Fuse Block
F4- Unit Fuse Block
$48- Disconnect
TB2- Unit Terminal Block
TB3- Electric Heat Terminal Block
TB13-Unit Terminal Block
L} L2L3
POWER
SUPPLY
TO FUSED
DISCONNEC1
SWITCH
{NOT
FURN]SHED}
GROUND
MODEL MODEL
EHA360-15- Y EHA360S 15 Y
EHA56 5_Y EHAI565 IS-Y
SINGLE POWER SUPPLY WITH CB10/$48
T
E
LI L2 L5
GROUNDr"
LI L2 L3
POWER
SUPPLY _I
TO FUSED
OISCONNECT
SWITCH
(NOT FURNISHED}
LI L2 L3
POWER
SUPPLY .2
MODEL MODEL
EHA360-15-Y EHA360S-15-Y
EHAI56 15-Y EHAI56S IS-Y
MULTIPLE POWER SUPPLY WITH CB10/$48
FIGURE 10
Page 12
I t 2 L_
F
TI
GROUND
LI L2 L3
POWER
SUPPLY
TO FUSED
DISCONNECT
SWITOI
(NOT FURNISIIEO)
TC/TH 180-300S UNITS
MODEL MODEL
EItA56O-22.5=Y,G,J EHA360-22.5-Y,G,J
EHAISO=SO-Y,G,J EHAISO-50-Y,G,J
EItASGO=45-Y,G,J EHA360-45-Y,G,J
EHAISO=60-Y,G,J EHAI50-60-Y,G_J
ENAI5622.SY,G,J EHAI56-22,5-Y,G,J
EHAI56-30-Y,G,J EHAI56 30 Y,G,J
_r
II
GROUND
LI L2 L3 L£ E3
POWER POWER
SUPPLY * I
TO FUSED SUPPLY _2
DISCONNECT
SWITCH
(NO FURNISHED1
MODEL
EHA560-22.5-Y,G,J EHA36O-22.5-Y,G,J
EHAI50 30 Y,G,J EHAI50 30 Y,G,J
EHA360 45 Y,G,J EHA560 45 Y,G,J
EHAI50-60-Y,G,J EHAI50-60-Y,G,J
ENAI56 22.5-Y,G,J EHAI56 22.5 Y,G,J
EHAI56 30 Y,G,J EHAI56-30-Y+G,j
SINGLE POWER SUPPLY - NO CB10/$48 MULTIPLE POWER SUPPLY - NO CB10/$48
L1 L2 L5
_HO
Flt_iL_ .......
POWER
SUPPLY
TO FUSEO
DISCONNECT
SWITCH
(NOT
FURNISHED)
GROUND
CB10-Circuit Breakers
F4- Unit Fuse Block
$48- Disconnect
TB2- Unit Terminal Block
TB3- Electric Heat Terminal Block
TB13-Unit Terminal Block
I
_2 L2
L51
MODEL MODEL
EHA360-22,5Y,G,J EHA360-22,5_Y,G,J
ERAI5030_Y,G,J EHAI50_30_Y,G,J
EHASBO45Y,G,J EHA360_45-Y,G,J
EMAISO-6OY,G,J EHAI50_60_Y,G,J
EHAI56 22,5-Y,G,J EHAI56 22.5 Y,G,J
EHAI56 30 Y,G,J EHAI56 30 Y,G,J
--'Rh
LI L2 L3
II
I
it
GROUNDI'--
Lll2L3
POWER
SUPPLY _I
TO FUSED
DISCONNEC] ....
SWITCH
(NOT FURNISHED)
LI L2 L3
POWER
SUPPLY _2
MODEL MODEL
EHA360_22,5Y,G,J EHA360_22,5Y,G,J
EHAIS()-S()-Y,G,J ERAISO-30-Y,G,,I
EHAS6045-Y,G,J EHA36045_Y,G,J
EHAISO-60-Y,G,J EHAI50-60-Y,G_J
EHAI56-22.5 Y,G,J EHAI56 22,5 Y,G,J
EllAI56 30 Y,G,J EHAI56_SO_Y,G,J
SINGLE POWER SUPPLY WITH CB10/$48 MULTIPLE POWER SUPPLY WITH CB10/$48
FIGURE 11
Page 13
TABLE 2
PACKAGED COOLING AND HEAT PUMP 090, 102, 120, 150 BLOWER PERFORMANCE
Total Static Pressure - in, w,g. (Pa)
Air
Volume .20 (50) .40 (100) .60 (150) .80 (200) 1,00 (250) 1,20 (300) 1.40 (350) 1.60 (400) 1.80 (450) 2.00 (495) 2.20 (545) 2.40 (595) 2.60 (645)
cfm
(L!s) RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP
(kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW)
2250 455 0.30 555 0.45 640 0.60 720 0.80 790 1.00 855 1.20 9t5 1.40 975 1.60 t030 1.85 t080 2.05 t130 2.30 t175 2.55 t220 2.80
(t060) (0.22) (0.34) (0.45) (0.60) (0.75) (0.90_ (1.04_ (1.19_ (1.38_ (1.53_ (t.72_ (t.90_ (2.09)
2500 475 0.40 575 0.55 660 0.70 735 0.90 805 1.10 870 1.30 930 1.55 986 1.75 1040 2.00 1090 2.25 1140 2,50 1185 2,75 1230 3,00
(tt80) (0.30) (0.41) (0.52) (0.67) (0.82) (0.97_ (t.t6_ (t.3t_ (t.49_ (t.68_ (t.87_ (2.05_ (2.24)
2750 495 0.45 595 0.65 675 0.85 750 1.05 820 1.25 885 1.45 940 1.70 995 1.90 t050 2.20 tt00 2.45 t145 2.65 t195 2.95 t240 3.25
(t300) (0.34) (0.48) (0.63) (0.78) (0.93) (t.08_ (t .27_ (t .42_ (t .64_ (t .83_ (t.98_ (2.20_ (2.42)
3000 525 0.55 615 0.75 695 0.95 770 1.20 835 1.40 895 1.60 955 1.85 t010 2.10 t060 2.35 tt10 2.65 t160 2.90 t205 3.2C t250 3.45
(1415) (0.41 (0.56) (0.71) (0.90) (1.04) (1.19_ (1.38 _, (1.57_ (1.75 _, (1.98 _, (2.16_ (2.39 _, (2.57)
3250 550 0.65 640 0.90 715 1,10 790 1,35 865 t,60 915 t,80 970 2,05 1025 2.35 1075 2,60 1125 2,85 1170 3.15 1215 3.4C 1260 3.70
(1535) (0.48) (0.67) (0.82) (1.0t) (1.19) (1.34} (t.53} (t.75} (t.94} (2.t3_ (2.35} (2.54} (2.76)
3500 580 0.80 665 1.05 740 1,25 810 1,50 870 t,75 930 2,00 985 2,25 1040 2.55 1090 2,85 1135 3,10 1185 3.40 1230 3.7C 1270 4.00
(1650) (0.60) (0.78) (0.93) (1.t2) (1.3t) (1.49_ (t.68_ (t.90} (2.t3_ (2.3t} (2.54} (2.76} (2.98)
3750 605 0.95 690 1.20 760 1.45 830 1.70 890 1.95 950 2.25 t005 2.50 t055 2.80 tt05 3.t0 tt50 3.35 t195 3.65 t240 3.95 t285 4.30
(t770) (0.71) (0.90) (t.08) (t.27) (t.45) (t.68_ (1.87_ (2.09 _, (2.31_ (2.50_ (2.72_ (2.95_ (3.21)
4000 635 1.11] 715 1.40 785 1.65 850 1.90 9t0 2.20 965 2.45 t020 2.75 t070 3.05 tt20 3.35 tt65 3.65 t2t0 3.95 t255 4.3C t295 4.60
(t890) (0.82) (1.04) (t.23) (t.42) (t.64) (t.83_ (2.05_ (2.28_ (2.50_ (2.72_ (2.95_ (3.21_ (3.43)
4250 665 1.3(] 740 1.60 810 1.85 870 2.t5 930 2.45 985 2.75 1040 3.05 1090 3.35 1135 3.65 1185 4.00 1226 4,30 1270 4,65 13t0 4,95
(2005) (0.97) (t.t9) (t.38) (t.60) (t.83) (2.05_ (2.28_ (2.50_ (2.72_ (2.98_ (3.2t_ (3.47_ (3.69)
4500 695 1.50 770 1.80 835 2.10 895 2.40 955 2.70 1005 3,00 1060 3,35 1105 3,65 1155 4.00 1200 4.30 1245 4,65 1286 5,0C 1325 5,30
(2t25) (t.t2) (t.34) (t.57) (t.79) (2.0t) (2.24_ (2.50_ (2.72_ (2.98_ (3.2t_ (3.47_ (3.73_ (3.95)
4750 725 1.75 795 2.05 860 2.40 920 2.70 975 3.00 t030 3.35 t080 3.65 tt25 3.95 tt75 4.35 t215 4.65 t260 5.00 t300 5.35 t340 5.70
(2240) (1.3t) (1.53) (1.79) (2.01) (2.24) (2.50_ (2.72_ (2.95_ (3.25_ (3.47_ (3.73_ (3.99_ (4.25)
5000 760 2,05 825 2,35 885 2,65 945 3,00 1000 3.35 1050 3.65 1100 4.00 1145 4.35 1190 4,70 1235 5,05 1280 5.45
(2360) (t.53) (t.75) (1.98) (2.24) (2.50) (2.72_ (2.98_ (3.25_ (3.5t_ (3.77_ (4.07_
5250 790 2,30 855 2,65 910 2,95 970 335 1020 3.65 1070 4.00 1120 4.35 1165 4.70 1210 5,t0 1255 5,45
(2475) (t .72) (t .98) (2.20) (2.50) (2.72) (2.98_ (3.25_ (3.5t_ (3.80_ (4.07_
5500 820 2.60 880 2.95 940 3.30 995 3.70 t045 4.05 t095 4.40 tt45 4.80 tt90 5.15 t230 5.50
(2595) (1.94) (2.20) (2.46) (2.76) (3.02) (3.28_ (3.58_ (3.84_ (4.10_
5750 850 2.95 9t0 3.30 965 3.70 t020 4.05 t070 4.45 t120 4.80 tt65 5.20 t210 5.60
(2715) (2.20) (2.46) (2.76) (3.02) (3.32) (3.58_ (3.88_ (4.18_
6000 886 3.35 940 3.70 995 4.10 1045 4,45 1095 4,85 1145 5,25 1190 5,65 ........................
(2830) (2.50) (2.76) (3.06) (3.32) (3.62) (3.92_ (4.21_
o-090 & 102 models require 3000 cfm (1415 L/s) minimum air with electric heat,
o-120 & 150 models require 4000 cfm (1225 L/s) minimum air with electric heat.
Page 14
TABLE 3
LCE120 ONLY BLOWER PERFORMANCE
RPM TOTAL STATIC PRESSURE EXTERNAL TO UNIT -- inches water gauge (Pa)
Air Volume & Motor
cfm (L/s) Output 0.1 (25) 0.2 (50) 0.3 (75) 0.4 (100) 0.5 (125) 0.6 (150) 0.7 (175) 0.8 (200) 0.9(225) 1.0 (250)
RPM 475 515 550 590 625 665 700 740 775 810
3000
(1415) BHP 0.60 0.70 0.75 0.85 0.95 1.10 1.20 1.35 1.50 1.65
kW 0.5 0.5 0.6 0.6 0.7 0.8 0.9 1.0 1.1 1.2
RPM 490 530 565 605 640 675 715 750 785 820
3200
(1510) BHP 0.65 0.75 0.85 1.00 1.10 1.20 1.35 1.50 1.65 1.80
kW 0.5 0.6 0.6 0.8 0.8 0.9 1.0 1.1 1.2 1.3
RPM 510 545 580 615 655 690 725 760 795 830
3400
(1605) BHP 0.80 0.85 1.00 1.10 1.20 1.35 1.50 1.65 1.80 1.95
kW 0.6 0.6 0.8 0.8 0.9 1.0 1.1 1.2 1.3 1.5
RPM 525 560 595 630 670 705 740 775 805 840
3600
(1700) BHP 0.90 1.00 1.10 1.20 1.35 1.50 1.65 1.80 1.95 2.10
kW 0.7 0.8 0.8 0.9 1.0 1.1 1.2 1.3 1.5 1.6
RPM 545 580 615 650 685 720 755 785 820 850
3800
(1795) BHP 1.00 1.10 1.25 1.35 1.50 1.65 1.80 1.95 2.10 2.25
kW 0.8 0.8 0.9 1.0 1.1 1.2 1.3 1.5 1.6 1.7
RPM 565 595 630 665 700 735 770 800 830 865
4000 BHP 1.15 1.25 1.40 1.50 1.65 1.80 2.00 2.15 2.30 2.50
(1890) kW 0.9 0.9 1.0 1.1 1.2 1.3 1.5 1.6 1.7 1.9
RPM 580 615 650 685 715 750 785 815 845 875
4200
(1980) BHP 1.30 1.40 1.55 1.70 1.85 2.00 2.15 2.35 2.50 2.65
kW 1.0 1.0 1.2 1.3 1.4 1.5 1.6 1.8 1.9 2.0
RPM 605 635 670 700 735 770 800 830 860 890
4400 BHP 1.45 1.60 1.75 1.85 2.05 2.20 2.35 2.55 2.70 2.90
(2075) kW 1.1 1.2 1.3 1.4 1.5 1.6 1.8 1.9 2.0 2.2
RPM 625 655 690 720 755 785 815 845 875 905
4600
(2170) BHP 1.65 1.75 1.95 2.10 2.25 2.40 2.60 2.75 2.95 3.15
kW 1.2 1.3 1.5 1.6 1.7 1.8 1.9 2.1 2.2 2.3
RPM 645 680 710 740 775 805 835 865 890 920
4800
(2265) BHP 1.85 2.00 2.15 2.30 2.50 2.65 2.85 3.05 3.20 3.40
kW 1.4 1.5 1.6 1.7 1.9 2.0 2.1 2.3 2.4 2.5
RPM 670 700 730 765 795 825 850 880 910 935
5000
(2360) BHP 2.05 2.20 2.35 2.55 2.75 2.90 3.10 3.30 3.50 3.65
kW 1.5 1.6 1.8 1.9 2.1 2.2 2.3 2.5 2.6 2.7
NOTES: 1-Alldata is measuredexternat to the unit cabinet with electric heat, dry coil, 2 in. (51 mm) filters in place, and roof mounting frame.
2-4000 cfm (1890 L/s) minimum air with electric heat.
Page 15
TABLE 4
PACKAGED COOLING AND HEAT PUMP 156, 180, 210, 240, 300S BLOWER PERFORMANCE
Air TOTAL STATIC PRESSURE -- Inches Water Gauge (Pa)
Volume ,40 (100) ,60 (150) ,80 (200) 1,00 (250) 1,20 (300) 1,40 (350) 1,60 (400) 1,80 (450) 2,00 (495) 2,20 (545)
cfm RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP
(L/s) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW)
4000 545 0.85 635 1.10 715 1.40 785 1.70 850 2.00 910 2.30 965 2.60 1020 2,90 1070 3,25 1115 3,55
(1890) (0.63) (0.82) (1.04) (1.27_ (1.49) (1.72) (1.94) (2.t6_ (2.42) (2.65)
4250 555 0.90 645 1.25 725 1.55 795 1.85 855 2.t5 9t5 2.45 970 2.8( t025 3.10 t075 3.45 tt20 3.75
(2005) (0.67) (0.93) (t.16) (t.38_ (t.60) (t.83) (2.09) (2.31_ (2.57) (2.80)
4500 565 1.00 655 1.35 730 1.65 800 2.00 865 2.35 925 2.65 980 3.00 t030 3.30 t080 3.65 tt30 4.05
(2t25) (0.75) (t.0t) (t.23) (t.49_ (t.75) (t.98) (2.24) (2.46_ (2.72) (3.02)
4750 575 1.t0 660 1.45 740 1.80 810 2.15 870 2.50 930 2.85 985 3.20 1040 3.55 1085 3.90 1135 4.25
(2240) (0.82) (1.08) (1.34) (1.60} (1.87) (2.13) (2.39) (2.65} (2.9t) (3.17)
5000 585 t.25 670 1.60 750 1.95 815 2.30 880 2.70 940 3.05 995 3.40 1045 3.80 1095 4.15 1140 4.50
(2360) (0.93) (t.19) (t.45) (t.72_ (2.01) (2.28) (2.54) (2.83} (3.10) (3.36)
5250 595 1.35 680 1.70 755 2.10 825 2.50 890 2.90 945 3.25 t000 3.65 t050 4.00 tt00 4.40 tt50 4.80
(2475) (1.0I) (1.27) (1.57) (1.87} (2.t6) (2.42) (2.72) (2.98_ (3.28) (3.58)
5500 605 1.45 690 1.85 765 2.25 835 2.65 895 3.05 955 3.45 t010 3.8, _ t060 4.25 tt10 4.70 tt55 5.10
(2595) (1.08) (1.38) (1.68) (1.98_ (2.28) (2.57) (2.87) (3.17} (3.5t) (3.80)
5750 615 t.60 700 2.00 775 2.45 840 2.85 905 3.25 960 3.65 1015 4.10 1065 4.50 1115 4.95 1160 5.35
(27t5) (t.19) (t.49) (t.83) (2.13} (2.42) (2.72) (3.06) (3.36} (3.69) (3.99)
6000 630 1.75 710 2.15 785 2.60 850 3.05 910 3.45 970 3.90 1025 4.35 1075 4.80 1120 5.20 1170 5.65
(2830) (1.3t) (1.60) (1.94) (2.28_ (2.57) (2.91) (3.25) (3.58_ (3.88) (4.21)
6250 640 1.90 720 2.35 795 2.8( 860 3.25 920 3.70 975 4.t, _ t030 4.60 t080 5.05 tt30 5.50 tt75 5.95
(2950) (t.42) (t.75) (2.09) (2.42_ (2.76) (3.10) (3.43) (3.77} (4.10) (4.44)
6500 650 2.05 730 2.50 805 3.00 870 3.45 930 3.95 985 4.40 1040 4.85 1090 5.35 1140 5.85 1185 6.30
(3065) (t .53) (t .87) (2.24) (2.57} (2.95) (3.28) (3.62) (3.99} (4.36) (4.70)
6750 665 2.20 745 2.70 815 3.20 880 3.70 940 4.20 995 4.65 1045 5.t0 1095 5.60 1145 6.t0 1190 6.60
(3185) (1.64) (2.01) (2.39) (2.76} (3.t3) (3.47) (3.80) (4.t8} (4.55) (4.92)
7000 675 2.35 755 2.90 825 3.40 890 3.95 950 4.45 t005 4.9, _ t055 5.40 tt05 5.95 tt55 6.45 t200 6.95
(3305) (t.75) (2.16) (2.54) (2.95} (3.32) (3.69) (4.03) (4.44} (4.81) (5.18)
7250 690 2.60 765 3.10 835 3.65 900 4.15 955 4.65 t015 5.25 t065 5.75 tt15 6.25 tt60 6.75 t205 7.30
(3420) (t.94) (2.3t) (2.72) (3.10} (3.47) (3.92) (4.29) (4.66} (5.04) (5.45)
7500 700 2.75 775 3.30 845 3.8,' 910 4.45 965 4.95 1020 5.50 1075 6.05 1125 6.60 1170 7.t5 1215 7.65
(3540) (2.05) (2.46) (2.87) (3.32} (3.69) (4.10) (4.5t) (4.92} (5.33) (5.7t)
7750 715 3.00 790 3.55 855 4.10 920 4.70 975 5.25 1030 5.80 1080 6.35 1130 6.90 1180 7.50 1225 8.05
(3655) (2.24) (2.65) (3.06) (3.51} (3.92) (4.33) (4.74) (5.15} (5.60) (6.01)
8000 725 3.20 800 3.80 865 4.35 930 4.95 985 5.50 t040 6.10 t090 6.70 tt40 7.25 tt85 7.85 t230 8.40
(3775) (2.39) (2.83) (3.25) (3.69} (4.t0) (4.55) (5.00) (5.41} (5.86) (6.27)
8250 740 3.40 8t0 4.00 880 4.6, _ 940 5.25 995 5.85 t050 6.45 tt00 7.05 tt50 7.65 tt95 8.25 t240 8.8, _
(3895) (2.54) (2.98) (3.47) (3.92} (4.36) (4.8t) (5.26) (5.7t} (6.15) (6.60)
8500 750 3.65 825 4.30 890 4.90 950 5.55 1005 6.t5 1060 6.80 1110 7.40 1160 8.05 1205 8.65 1250 9.25
(40t0) (2.72) (3.2t) (3.66) (4.14} (4.59) (5.07) (5.52) (6.0t} (6.45) (6.90)
8750 765 3.90 835 4.55 900 5.20 960 5.85 1015 6.45 1070 7.t5 1120 7.75 1165 8.35 1215 9.05 1255 9.6,_
(4130) (2.9t) (3.39) (3.88) (4.36} (4.81) (5.33) (5.78) (6.23} (6.75) (7.20)
9000 780 4.20 850 4.85 9t0 5.5( 970 6.15 t025 6.80 t080 7.50 tt30 8.15 tt75 8.75 t220 9.40 t26510.10
(4245) (3.13) (3.62) (4.10) (4.59} (5.07) (5.60) (6.08) (6.53} (7.01) (7.53)
9250 790 4.45 860 5.15 925 5.85 985 6.55 t040 7.20 t090 7.85 tt40 8.55 tt85 9.20 t230 9.85 127510.55
(4365) (3.32) (3.84) (4.36) (4.89} (5.37) (5.86) (6.38) (6.86} (7.35) (7.87)
9500 805 4.75 875 5.45 935 6.15 995 6.90 1050 7.60 1100 8.25 1150 8.95 1195 9.60 1240 t0.30 1285 11.05
(4485) (3.54) (4.07) (4.59) (5.15} (5.67) (6.15) (6.68) (7.16} (7.68) (8.24)
9750 820 5.05 885 5.75 950 6.55 t005 7.20 t060 7.95 tt10 8.65 tt60 9.40 t205 10.05 t250 10.80 t295 11.50
(4600) (3.77) (4.29) (4.89) (5.37} (5.93) (6.45) (7.01) (7.50} (8.06) (8.58)
10000 835 5.40 900 6.15 960 6.85 t015 7.60 t070 8.35 tt20 9.05 tt70 9.80 t215 10.50 t260 11.25
(4720) (4.03) (4.59) (5.tl) (5.67} (6.23) (6.75) (7.31) (7.83} (8.39)
10250 845 5.65 910 6.45 970 7.2( 1030 8.00 1080 8.75 1135 9.55 1180 t0.25 1225 11.00
(4835) (4.21) (4.8t) (5.37) (5.97} (6.53) (7.12) (7.65) (8.2t}
10500 860 6.00 925 6.85 985 7.65 1040 8.40 1095 9.20 1145 10.00 1190 10.70 1235 tt.45
(4955) (4.48) (5.11) (5.71) (6.27} (6.86) (7.46) (7.98) (8.54}
10750 875 6.40 940 7.25 t000 8.05 t055 8.85 tt05 9.65 tt55 10.45 t200 11.20
(5075) (4.77) (5.41) (6.01) (6.60} (7.20) (7.80) (8.36)
11000 890 6.80 950 7.60 t010 8.4,' t065 9.30 tt15 10.05 tt65 10.90
(5t90) (5.07) (5.67) (6.30) (6.94} (7.50) (8.13)
2.40 (595) 2.60 (645)
RPM BHP RPM BHP
(kW) (kW)
1160 3,85 1205 4.15
(2.87) (3.t0)
tt65 4.10 t210 4.45
(3.06) (3.32)
tt75 4.35 t215 4.70
(3.25) (3.51)
1180 4.6,' 1225 5.00
(3.47) (3.73)
1185 4.90 1230 5.30
(3.66) (3.95)
tt95 5.20 t235 5.60
(3.88) (4.t8)
t200 5.50 t240 5.90
(4.10) (4.40)
1205 5.8( 1250 6.25
(4.33) (4.66)
1215 6.t0 1255 6.55
(4.55) (4.89)
t220 6.45 t265 6.90
(4.81) (5.15)
1225 6.75 1270 7.25
(5.04) (5.41)
1235 7.t0 1275 7.60
(5.30) (5.67)
t240 7.45 t285 8.00
(5.56) (5.97)
t250 7.85 t290 8.35
(5.86) (6.23)
1260 8.2, _ 1300 8.75
(6.15) (6.53)
1265 8.60 1305 9.15
(6.42) (6.83)
t275 9.00 t3t5 9.60
(6.71) (7.t6)
t280 9.40 t325 10.05
(7.0t) (7.50)
1290 9.85 1330 10.45
(7.35) (7.80)
1300 t0.30 1340 10.90
(7.68) (8.t3)
131010.80 t350 11.40
(8.06} (8.50}
t3t5 11.20
(8.36)
o-156H units require 5200 cfm (2455 L/s) minimum air with electric heat.
o-All other packaged cooling units require 6000 cfm (2830 Lls) minimum air with electric heat.
o-Packaged heat pump units with 15, 22.5, 30 or 45 kW electric heat require 6400 cfm (3020 L/s) minimum air.
o-Packaged heat pump units with 60 or 90 kW electric heat require 7000 cfm (3305 L/s) minimum air.
Page 16
TABLE 5
LCE240 ONLY BLOWER PERFORMANCE
Air Volume RPM & Motor TOTAL STATIC PRESSURE EXTERNAL TO UNIT -- inches water gauge (Pa)
cfm(L/s) Output 0.1(25) 0.2(50) 0.3(75) 0.4(100) 0.5(125) 0.6(150) 0.7(175) 0.8(200) 0.9(225) 1.0(250) 1.1(275) 1.2(300)
RPM 480 520 560 600 640 675 715 750 785 815 850 880
6000 BHP 1.15 1.30 1.45 1.60 1.75 1.95 2.15 2.30 2.50 2.70 2.90 3.10
(2830) kW 0.9 1.0 1.1 1.2 1.3 1.5 1.6 1.7 1.9 2.0 2.2 2.3
RPM 510 545 580 620 655 690 725 760 795 825 860 890
6400 BHP 1.40 1.55 1.70 1.85 2.00 2.20 2.35 2.55 2.80 2.95 3.20 3.40
(3020) kW 1.0 1.2 1.3 1.4 1.5 1.6 1.8 1.9 2.1 2.2 2.4 2.5
RPM 525 560 595 630 665 700 735 770 800 835 865 895
6600 BHP 1.55 1.70 1.85 2.00 2.15 2.35 2.55 2.75 2.90 3.15 3.35 3.60
(3115) kW 1.2 1.3 1.4 1.5 1.6 1.8 1.9 2.1 2.2 2.3 2.5 2.7
RPM 535 570 605 640 675 710 740 775 810 840 870 900
6800 BHP 1.65 1.80 1.95 2.15 2.30 2.50 2.65 2.85 3.10 3.30 3.50 3.75
(3210) kW 1.2 1.3 1.5 1.6 1.7 1.9 2.0 2.1 2.3 2.5 2.6 2.8
RPM 550 585 615 650 685 720 750 785 815 845 875 905
7000 BHP 1.80 1.95 2.10 2.25 2.45 2.65 2.85 3.05 3.25 3.45 3.70 3.90
(3310) kW 1.3 1.5 1.6 2.7 1.8 2.0 2.1 2.3 2.4 2.6 2.8 2.9
RPM 565 595 630 660 695 725 760 790 820 855 885 910
7200 BHP 1.95 2.10 2.25 2.45 2.60 2.80 3.00 3.20 3.40 3.65 3.90 4.10
(3400) kW 1.5 1.6 1.7 1.8 1.9 2.1 2.2 2.4 2.5 2.7 2.9 3.1
RPM 580 610 640 675 705 735 770 800 830 860 890 920
7400 BHP 2.15 2.30 2.45 2.60 2.80 2.95 3.20 3.40 3.60 3.85 4.05 4.30
(3490) kW 1.6 1.7 1.8 1.9 2.1 2.2 2.4 2.5 2.7 2.9 3.0 3.2
RPM 595 625 655 685 715 745 775 805 835 865 895 925
7600 BHP 2.30 2.45 2.60 2.80 2.95 3.15 3.35 3.55 3.80 4.00 4.25 4.50
(3585) kW 1.7 1.8 1.9 2.1 2.2 2.3 2.5 2.6 2.8 3.0 3.2 3.4
RPM 605 635 665 695 725 755 785 815 845 875 905 930
7800 BHP 2.45 2.60 2.80 2.95 3.15 3.35 3.55 3.75 4.00 4.20 4.45 4.70
(3680) kW 1.8 1.9 2.1 2.2 2.3 2.5 2.6 2.8 3.0 3.1 3.3 3.5
RPM 620 650 680 705 735 765 795 825 855 880 910 940
8000 BHP 2,65 2,80 3,00 3,15 3,35 3,55 3,75 4,00 4,20 4,40 4,65 4,95
(3775) kW 2.0 2.1 2.2 2.3 2.5 2.6 2.8 3.0 3.1 3.3 3.5 3.7
RPM 635 665 690 720 750 775 805 835 860 890 920 945
8200 BHP 2.85 3.05 3.20 3.40 3.60 3.75 3.95 4.20 4.40 4.65 4.90 5.15
(3870) kW 2.1 2.3 2.4 2.5 2.7 2.8 3.0 3.1 3.3 3.5 3.7 3.8
RPM 650 675 705 730 760 785 815 845 870 900 925 955
8400 BHP 3.05 3.20 3.40 3.60 3.80 3.95 4.20 4.45 4.65 4.90 5.10 5.40
(3965) kW 2.3 2.4 2.5 2.7 2.8 3.0 3.1 3.3 3.5 3.7 3.8 4.0
RPM 665 690 715 745 770 800 825 855 880 905 935 960
8600 BHP 3.30 3.45 3.60 3.80 4.00 4.25 4.45 4.65 4.90 5.10 5.40 5.60
(4060) kW 2.5 2.6 2.7 2.8 3.0 3.2 3.3 3.5 3.7 3.8 4.0 4.2
RPM 680 705 730 755 785 810 835 865 890 915 940 970
8800 BHP 3.50 3.70 3.85 4.05 4.25 4.45 4.65 4.90 5.15 5.35 5.60 5.90
(4155) kW 2.6 2.8 2.9 3.0 3.2 3.3 3.5 3.7 3.8 4.0 4.2 4.4
RPM 690 715 745 770 795 820 845 875 900 925 950 975
9000 BHP 3.75 3.90 4.10 4.30 4.50 4.70 4.90 5.15 5.40 5.65 5.90 6.15
(4245) kW 2.8 2.9 3.1 3.2 3.4 3.5 3.7 3.8 4.0 4.2 4.4 4.6
RPM 705 730 755 780 805 830 855 885 910 935 960 985
9200 BHP 4.00 4.15 4.35 4.55 4.75 4.95 5.15 5.45 5.65 5.90 6.15 6.40
(4340) kW 3.0 3.1 3.2 3.4 3.5 3.7 3.8 4.1 4.2 4.4 4.6 4.8
RPM 720 745 770 795 820 845 870 895 920 945 970 995
9400 BHP 4.25 4.45 4.65 4.85 5.05 5.25 5.50 5.70 5.95 6.20 6.45 6.75
(4435) kW 3.2 3.3 3.5 3.6 3.8 3.9 4.1 4.3 4.4 4.6 4.8 5.0
RPM 735 760 780 805 830 855 880 905 930 955 975 1000
9600 BHP 4.50 4.70 4.90 5.10 5.30 5.55 5.75 6.00 6.25 6.50 6.70 7.00
(4530) kW 3.4 3.5 3.7 3.8 4.0 4.1 4.3 4.5 4.7 4.8 5.0 5.2
RPM 750 775 795 820 845 865 890 915 940 965 985 1010
9800 BHP 4.80 5.00 5.20 5.40 5.60 5.80 6.05 6.30 6.55 6.80 7.05 7.30
(4625) kW 3.6 3.7 3.9 4.0 4.2 4.3 4.5 4.7 4.9 5.1 5.3 5.4
RPM 765 785 810 830 855 880 900 925 950 975 995 1020
10000 BHP 5.10 5.25 5.50 5.65 5.90 6.15 6.35 6.60 6.85 7.15 7.35 7.65
(4720) kW 3.8 3.9 4.1 4.2 4.4 4.6 4.7 4.9 5.1 5.3 5.5 5.7
NOTES: 1-AlIdata is measuredexternal to the unit cabinet with electric heat, dry coil, 2 in. (51 mm) filters in place, and roof mounting frame.
2-6000 cfm (2830 L/s) minimum air with electricheat.
Page 17
TABLE 6
PACKAGED COOLING 248, 300H, 360 BLOWER PERFORMANCE
TOTAL STATIC PRESSURE -- Inches Water Gauge (Pa)
Air 1.00 1.20 1.40 1.60 1.80 2.00 2.20 2.40 2.60
Volume .20 (50) .40 (100) .60 (150) .80 (200) (250) (300) (350) (400) (450) (495) (545) (595) (645)
cfm
(L/s) RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP RPM BHP
(kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW) (kW)
6000 4-35 1,20 525 1.45 570 1,60 630 2,00 700 2,35 750 2,80 795 3.15 840 3.40 880 3.80 920 4.2C 960 4,65 995 5,t0
(2830) (0.90) (1.08) (1.19} (1.49} (t.75} (2.09} (2.35} (2.54} (2.83} (3.13} (3.471 (3.80)
6500 4-45 1.30 530 1.60 580 1,80 640 2,20 705 2,60 755 3,05 800 3.40 845 3.70 885 4.15 925 4.6C 965 5,00 1000 5.45
(3065) (0.97) (1.19) (t.34} (t.64} (1.94} (228} (2.54} (2.76} (3.10} (4.43} (3.731 (4.07)
7000 4-55 1.40 535 1.75 590 2,05 650 2,45 710 2,85 760 3,30 805 3.70 850 4.05 890 4.50 930 4.95 970 5,40 1005 5.85
(3305) (1.04) (1.31) (t.53} (t .83} (2.13} (2.46} (2.76} (3.02} (3.36} (3.69} (4.031 (4.36)
7500 380 1.05 465 1.50 540 1.90 600 2.30 660 2.70 715 3.15 765 3.60 8t0 4.00 855 4.45 895 4.90 935 5.35 975 5.85 t010 6.30
(3540) (0.78) (1.12) (1.42) (t.72} (2.0t} (2.35} (2.69} (2.98} (3.32} (3.66} (3.99} (4.361 (4.70)
8000 390 1.25 475 1.65 545 2.10 610 2.55 665 2.95 720 3.45 770 3.90 8t5 4.35 860 4.85 900 5.30 940 5.75 980 6.30 t015 6.75
(3775) (0,93) (1,23) (137) (1.90} (2.20} (2.57} (2.91} (3.25} (3.62} (3.95} (4.29} (4.701 (5.04)
8500 405 1.40 485 1.90 555 2.35 620 2.80 675 3.30 725 3.75 775 4.20 820 4.70 865 5.20 905 5.70 945 6.2C 985 6.75 t020 7.25
(4010) (1,04) (1,42) (1,75) (2.09} (2.46} (2.80} (3.t3} (3.51} (3.88} (4.25} (4.63} (5.04: (5.41)
9000 415 1.60 495 2.10 565 2.60 625 3.10 685 3.60 738 4.10 788 4.60 830 5.10 870 5.60 918 6.t5 958 6.70 990 7.2C 1028 7.70
(4245) (1,19) (1,57) (t.94) (2.3t} (2.69_ (3.06} (3.43} (3.80} (4.18} (4.59_ (5.00} (5.371 (5.74)
9500 430 1.85 505 2.35 578 2.90 638 3.40 690 3.90 745 4.50 790 4.95 838 5.50 880 6.05 920 6.60 960 7.15 998 7.70 1038 8.30
(4485) (1,38) (1,75) (2.16) (2.54} (2.9t} (3.36} (3.69_ (4.10} (4.5t} (4.92_ (5.33} (5.741 (6.t9)
t0,000 445 2.10 520 2.65 585 3.20 645 3.75 700 4.30 750 4.85 800 5.40 845 5.95 885 6.50 925 7.05 965 7.65 t000 8.2C t040 8.85
(4720) (1,57) (1,98) (2.39) (2.80_ (3.2t_ (6.49_ (4.03_ (4.44_ (4.85_ (5.26_ (5.7t_ (6.t2', (6.60)
t0,500 455 2.35 530 2.95 595 3.50 655 4.10 710 4.70 760 5.25 805 5.80 850 6.40 895 7.00 935 7.60 970 8.15 t010 8.8C t045 9.40
4955) (1.75) (2.20) (2.61) (3.06_ (3.03_ (3.92} (4.33} (4.77_ (5.22_ (5.67_ (608_ (6.561 (7.01)
tl,000 470 2.60 545 3.25 505 3.85 665 4.45 720 5.t0 765 5.66 8t5 6.30 860 6.90 900 7.50 940 8.10 980 8.75 t015 9.35
(5190) (1.94) (2.42) (2.87) (3.32_ (3.80_ (4.22} (4.70} (8.15} (5.60} (6.04} (6.53} (6.981
tt,500 485 2.95 555 3.60 620 4.25 675 4.85 730 5.55 775 6.10 820 6.70 865 7.40 9t0 8.05 945 8.65 985 9.3C t020 9.95
(5428) (2.20) (2.69) (3.17) (3.62_ (4.14} (4.55} (8.00} (8.52_ (6.01_ (6.45} (6.94} (7.421
12,000 500 3.30 670 4.00 630 4.6! 685 5,30 740 6,00 785 6,60 830 7,25 875 7.95 915 8.60 985 9.25 995 9.95 103010.60
(5665) (2.46) (2.98) (3.47) (3.95} (4.480 (4.92_ (5.4t_ (5.93_ (6.42} (6.90} (7.42} (7.91_
12,500 515 3.65 680 4.3! 640 5.05 695 5,75 750 6,50 795 7,10 840 7,80 885 8.55 925 9.20 965 9.90 100010.55 103811.25
(5900) (2.72) (3.25) (3.77) (4.29_ (4.85} (5.30} (5.82} (6.38_ (6.86} (7.39_ (7.87_ (8.39_
I010 11.3
t3,000 530 4.05 595 4.80 655 5.55 710 6.25 760 7.00 805 7.65 850 8.40 890 9.05 930 9.75 970 10.5C
(6135) (3,02) (3.58) (4.t4) (4.66} (5.22} (5.71_ (6.27_ (6.75_ (7.27_ (7.83} (8.43}
t3,500 545 4.45 6t0 5.25 665 6.00 720 6.75 770 7.50 815 8.25 860 9.00 900 9.70 940 10.45 980 11.20
(6370) (3.32) (3.92) (4.48) (5.04} (5.60_ (6.15} (6.71_ (7.24} (7.80} (8.36}
t4,000 560 4.90 620 5.70 680 6.55 730 7.30 780 8.10 825 8.85 870 9.65 9t0 10.40 950 11.15
(6605) (3.66} (4.25) (4.89) (5.45} (6.04} (6.60} (7.20} 7.76} (8.31_
14,500 575 5.40 635 6.25 690 7.05 745 7,90 790 8,65 835 9,45 880 10.30 920 11.10
(6845) (4.03} (4.66) (5.26) (5.89_ (6.45} (7.05} (7.68_ (8.28_
15,000 590 5.90 650 6.80 ?'05 7.65 755 8,50 800 9,30 845 t0,t0 890 11,00
(7080) (4.40} (5.07) (5.7t) (6.340 (6.94} (7.53} (8.2t_
o-Units require 10,500 cfm (4955 L/s) minimum air with electric heat,
Page 18

Navigation menu