LIMITS Technology REV1 LIMITS User Manual

LIMITS Technology Limited LIMITS

UserManual.wiki >

LIMITS Technology >

REV1 User Manual HTML Version

User manual

LIMITS™InstallationGuide

VisitYouTubechannel:LIMITS



WARNINGS– 

‐ LIMITShasbeendesignedforamaximumcyclistweightof90kg

(200lb).Cyclistsoverthisweightriskpersonalinjuryandproperty

damage.

‐ PleasereadthismanualcarefullybeforeinstallingLIMITS.Incorrect

installationormaintenance,especiallyfailuretotorqueLIMITSorthe

pedalproperlymayleadtoaccidentsandpossibleharmtopersons

and/orpossessions.Alwaysusecalibratedtorquewrench.IfLIMITS

showssignsofdamage,cracks,looseningand/orwearitmustbe

professionallychecked.Alwayscheckcarefullyafterfalloraccident.

‐ Ifyouareindoubtaboutyourabilitytoinstalltheproduct,seek

advicefromaqualifiedbikemechanic.

‐ Tightenallpartstothetorquesrecommendedinthisinstallguideand

whereapplicablethoserecommendedbyyourpedalmanufacturer.

‐ DonotuseLIMITSwithstandardshoesasthismaycauseirreparable

damagetothesensor.

‐ NevergripLIMITStoremoveLIMITSorpedalasthismaycause

irreparabledamagetothesensor.

‐ DonotpressurewashLIMITS.

‐ Itisrecommendedthatyouconsultadoctorbeforestartingphysical

activityormodifyingyourtrainingroutine.

1.PACKAGECONTENTS

❶‐1xLeftLIMITS.

❷‐1x9mmto8mmhexreducer.

❸‐2xPedalwashers.

❹‐2x8mmto6mmhexreducer. 

❺‐1x8mmto6mmhexextender.

❻‐1xSpanneradaptorreleasetool.

❼‐2xbatteryendcaps(spares).

❽‐2xSR44Batteries

1xRightNonSensingUnit.

Thankyoucard.

CyclingAnalyticsfreetrial.



2.REQUIREDTOOLS

‐ Torquewrench,minimum40Nm.

‐ 8mmhexdriver.

‐ Bikegrease

‐ 

3.QUICKSTART‐

1. Removeleftpedalusingapedalspannerorhexdriver.

2. FitLIMITStoleftcrankandtorquevia9mmhexto40Nm.

a. Ifyoudonothavea9mmhexdriverusethe8mmto9mmhex

reducerprovided.

3. FitpedaltoLIMITS.

4. Tightenpedaltomanufacturersrecommendedtorque.

5. Repeatforrightnonsensingunit.



4.LIMITSINSTALLATION

4.1Installtheleftsidefirst

1.Removetheleftpedalfromcrankarmusingaspannerorhexkey.

2.Cleanthepedalthreadsandapplyathinlayerofgreaseonthepedal

spindleandthesurfacewhereitcontactsLIMITS.

Notetheleftsidehasaleft‐hand(reverse)thread



4.2FitLIMITS

ApplyathinlayerofgreaseontheLIMITSspindleandthesurfacewhere

itcontactsthecrankarm.



ManuallytightenLIMITS❶tocrankarm.

Donotusetorquewrenchforthisoperationuntilyoudetermineifa

washerisrequired.



LIMITSshouldonlycontactthecrankarmatthemetalmountingface.If

theplastichousingcontactsthecrankarmitmayfracturewhentorqued.

Iftheplastichousingcontactsthecrankarmuseoneortwowashers

asprovided❸.Donotusemorethantwowashers.



Usinga9mmhexdriverandtorquewrenchtightenLIMITS❶to40nM.

Ifyoudonothavea9mmhexdriverfitthe9mmto8mmhexreducer

❷

providedtotheLIMITS.







4.3FitSpannerCompatiblePedals

ManuallytightenpedaltoLIMITS❶.

Using15mmspannertightenpedal.



4.4FitHexCompatiblePedals

Fit8mmto6mmhexreducer❹topedalbeforefittingpedal.



ManuallytightenpedaltoLIMITS❶.

Fit8mmto6mmhexextender❺to8mmhexdriver.

Tightenpedaltomanufacturersrecommendedtorque.



4.5NonSensingRightSide

Repeattheabovestepstofittherightnonsensingunit.

5.LIMITSREMOVAL

NevergripLIMITSduringremoval



5.1LIMITSRemoval–SpannerPedal

Usinga9mmhexdriverandtorquewrenchholdLIMITS❶inplace.

Ifyoudonothavea9mmhexdriverfitthe9mmto8mmhexreducer

❹



providedtotheLIMITS.



Usinga15mmspannerremovethepedal.

Usinga9mmhexdriverandtorquewrenchremoveLIMITS❶.



5.2LIMITSRemoval–HexPedal

Fitthespanneradaptorreleasetool❻intotheLIMITS❶.

Fit8mmto6mmhexextender❺to8mmhexdriveroftorquewrench.

Inserthexextender❺intotheLIMITS❶.



HoldLIMITS❶inplaceusing15mmspanneronspanneradaptorrelease

tool❻.

Removepedalusingtorquewrench.

RemoveLIMITS❶usingspannerandspanneradaptorreleasetool❻.



6.FITTINGBATTERIES

Removebatteryendcaps❼byrotatingclockwise.Takecarewhen

removingtoavoiddamageorlossofbatteryendcap.

FitSR44batteries❽.

Replacethebatteryendcapspre‐aligningandturninganticlockwiseto

tighten,stopatsecondclick.



Notedirectionarrowforremovingbatteryendcaps.

Itisrecommendedtouseacointoopenandclosethebatteryend

caps.

Overtighteningthebatteryendcapspasttheendstopswillcause

irreparabledamage.

Notebatterypolarity.Ifbatteriesareinstalledincorrectlyitwillnot

damageLIMITS.

Alwaysensurebatteryendcapsealsarecleanandfreefromgrit.



7.LEDSATUS

PoweringOn–SolidBluefor30seconds

Calibrating–BlinkGreen

Error–SolidRed



8.COMPATIBLEBICYCLECOMPUTERS

LIMITSiscompatiblewithallANT+™bicyclecomputers

LIMITSiscompatiblewithallBluetoothcompatiblebicyclecomputers



9.PAIRNGTOABICYCLECOMPUTER

TheANT+™IDnumberisshownontheexteriorofthepackaging.

Turnthepedals2or3timestowakeupLIMITS.

ToautomaticallyormanuallypairwithLIMITSreadthemanualprovided

withyourbicyclecomputer.



MakesuretherearenootherANT+™powermeterswithin10m.

MakesureLIMITSiswithin2mofthebicyclecomputer.



10.CONFIGURINGBICYCLECOMPUTER

Afterpairingwiththebicyclecomputer,readthebicyclecomputer

manual.Itisrecommendedthebicycleheadsetisconfiguredasfollows:

3secondpower.

30secondpower.

Cadence.



Disableorremovethirdpartycadencesensors.



11.CONFIGURINGCRANKARMLENGTHONBICYCLECOMPUTER

Setthecorrectcrankarmlength,readthebicyclecomputermanual.



12.CALIBRATION

Preformacalibrationbeforestartingtocycle.

TurnthepedalsuntilLIMITSisinthe3o’clockposition.



Performacalibration,readthebicyclecomputermanual



Carryoutcalibrationwithbikeonlevelsurface.Ensurebikeis

verticalandnotleaningatanangle.Itisrecommendedthatafterfirst

fittingtheLIMITSyoucarryouta10minridetobed‐inLIMITSthen

recalibrate.ForaccuracyyoushouldcalibrateLIMITSbeforeeachride.



13.INSPECTIONANDMAINTENANCE

CarefullyinspectLIMITSbeforestartingacyclingsession,checkall

partsfordamage,cracks,loosepartsandsignsofwear.Donotusethe

productunlessyouhavecarefullycheckedandreplacedanywornor

damagedparts.

TheuseofLIMITSnotinperfectconditionmaycauseaccidentsand

maycausepossibledamagetopossessionsand/orinjuryaswellasearly

degradationtotheproductsanditsperformance.



CleanLIMITSwithadampclothandremovedebriswithcare.

Donotcleanwithchemicals.Donotusehighpressurecleaners.Donot

immersetheproduct.Periodicallychecktheproductistorquedcorrectly.

Donotattempttoopenordisassembletheproductasyoumaydamage

it.Iftheproductisnotusedforalongtimeitisadvisabletoremove

LIMITSandstoreinitsoriginalpackaginginanenvironmentwhere

temperaturesarenothighandhumidityisnotexcessive.



14.DISPOSALOFPRODUCT

Attheendofitsusefullife,theproductshouldbedisposedofinan

environmentallycompatibleway,usingitspartsandrecycling

componentsandmaterials.



15.DECLARATIONOFCONFORMITY

Hereby,LIMITSTechnologyLtddeclaresthattheradioequipmenttype

“LIMITS”isincompliancewithdirective2014/53/EUand2011/65/EU.



FCCSTATEMENT

1. ThisdevicecomplieswithPart15oftheFCCRules.

Operationissubjecttothefollowingtwoconditions:

(1) Thisdevicemaynotcauseharmfulinterference,and

(2) Thisdevicemustacceptanyinterferencereceived,

includinginterferencethatmaycauseundesiredoperation.

2. Changesormodificationsnotexpresslyapprovedbytheparty

responsibleforcompliancecouldvoidtheuser’sauthorityto

operatetheequipment.

NOTE:Thisequipmenthasbeentestedandfoundtocomplywiththe

limitsforaClassBdigital,pursuanttoPart15ortheFCCRules.These

limitsaredesignedtoprovidereasonableprotectionagainstharmful

interferenceinaresidentialinstallation.Thisequipmentgenerates,uses

andcanradiateradiofrequencyenergyand,ifnotinstalledandusedin

accordancewiththeinstructions,maycasueharmfulinterferenceto

radiocommunications,However,thereisnoguaranteethatinterference

willnotoccurinaparticularinstallation.Iftheequipmentdoescause

harmfulinterferencetoradioortelevisionreception,whichcanbe

determinedbyturningtheequipmentoffandon,theuserisencouraged

totrytocorrecttheinterferencebyoneormoreofthefollowing

measures:

‐‐‐Reorientorrelocatethereceivingantenna.

‐‐‐Increasetheseparationbetweentheequipmentandreceiver.

‐‐‐Connecttheequipmentintoanoutletonacircuitdifferentfromthat

towhichthereceiverisconnected.

‐‐‐Consultthedealeroranexperiencedradio/TVtechnicianforhelp.



16.LIMITATIONSOFLIABILITY

LIMITSTechnologyLtd,ingeneral,cannotbeheldliableforanydamage,

directorindirect,regardlessofitsnature,resultingfromtheinformation

giveninthisdocumentorfromtheproductthatitdescribes.

LIMITS Technology REV1 LIMITS User Manual

LIMITS Technology Limited LIMITS

User manual

Navigation menu

Namespaces

Views

Navigation