Lanier 117 0154 Users Manual TO

117-0154 to the manual 5666bc9b-2e3b-456f-aa66-f66709fedb08

: Lanier Lanier-117-0154-Users-Manual-570212 lanier-117-0154-users-manual-570212 lanier pdf

Open the PDF directly: View PDF .
Page Count: 3

Lanier Worldwide, Inc.

2300 Parklake Drive, NE

A

tlanta, GA USA 30345-2979

MATERIAL SAFETY DATA SHEET

Emergency Telephone: 800-551-3087

Section 1: Chemical Product and Company Information

Identity:

Toner for 6517/6717/6616/6720

MSDS No.

CP- 261

Product ID: 117-0154 Issued: 02/08/2005

Synonyms

& Common

Names:

Uses:

Chemical

Formula:

Black Toner for 6517, 6717, 6616,

6720

Lanier 6517, 6717, 6616, 6720

Mixture

Supersedes:

Date:

Prepared by:

Approved by:

European

Contact:

06/10/1998

02/08/2005

EH&S Department 770-496-9500

Larry Choskey, Manager, CEH&S

Walter Fricke, Manager, Safety &

Environment,

Lanier Worldwide, Inc.

Im Taubental D-41468 Neuss,

Germany +49-2131-387-177

Section 2: Composition / Information on Ingredients

Component Percent CAS No. Exposure Limits Source

Styrene-acrylic resin 85 – 90 25153-46-2 Not listed N/a

Carbon black 5 – 10 1333-86-4 3.5 mg/m3

3.5 mg/m3OSHA PEL

ACGIH TWA

Wax 1 – 6 9003-07-0 Not listed N/a

Organic pigment 1 – 6 116810-46-9 10 mg/m3

10 mg/m3OSHA PEL

ACGIH TWA

Silica < 1 7631-86-9 6 mg/m3

10 mg/m3OSHA PEL

ACGIH TWA

*PEL as the product: 15mg/m3 (total dust), 5mg/m3 (respirable dust)

*TLV as the product: 10mg/m3 (total dust), 5mg/m3 (respirable dust)

Section 3: Hazards Identification

HMIS Rating:

FLAMMABILITY = 1 HEALTH = 1

REACTIVITY = 0 SPECIAL = none

Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure

to any non-toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.

Health Hazards of Long Term exposure (Chronic): Prolonged inhalation of excessive dust may cause lung damage. It is

attributed to “lung overloading”, a generic response to excessive amounts of any dust retained in the lungs for a prolonged interval.

Use of this product, as intended, does not result in inhalation of excessive dust.

Carcinogenicity: Carbon Black was reclassified as a Group 2B by the IARC in 1996 based upon the result of only the inhalation

study in rats. However, there was not observed the incidence of tumors on the test results on dermal or oral studies. Also, 2-years

inhalation study using a typical toner containing carbon black showed no association between toner exposure and animal tumors.

Section 4: First Aid Measures

Inhalation: Gargle with water. Remove to fresh air if effects

occur. Get medical attention if needed.

Eye Contact: In case of contact, immediately flush eyes

with water for 15 minutes. Get medical

attention if needed.

Skin Contact: Wash with soap and water. Ingestion: Dilute stomach contents with several

glasses of water. Get medical attention.

Section 5: Fire Fighting Measures

Suitable extinguishing media: CO2, dry chemical, foam or water.

Extinguishing media which may not be used for safety

reasons: none

Special protective equipment for fire fighters: none

UEL: n/a LEL: n/a

your document management partner

MATERIAL SAFETY DATA SHEET

Page 2 of 3 CP-261

Section 6: Accidental Release Measures

Spill / leak Procedures: If spilled, sweep up using an approved toner vacuum with a 0.5 micron filter or smaller, such as the Atrix

AAA Toner Vacuum or 3M Toner Vacuum. Use of a vacuum cleaner not rated for toner particles, could result in a fire or personal

injury. Remove residue with soap and cold water.

Miscellaneous: Keep product out of sewers and watercourses.

Personal protection: Avoid inhalation of dust.

Section 7: Handling and Storage

Special Handling:

Cleanse skin after contact before breaks or meals, and end of workday.

Do not handle in areas where the wind blows.

Minimize the breathing of dust.

Special Storage: Avoid direct sunlight. Keep out of reach of children. Store in a cool, dry place. Below 35C (95F)

Section 8: Exposure Control and Personal Protection Information:

Respiratory Protection: none required under normal use. Hand Protection: none required under normal use.

Eye Protection: none required under normal use. Skin Protection: none required under normal use.

Section 9: Physical and Chemical Properties

CHARACTERISTICS:

Appearance: Black Melting point: 130° - 170° C

Form: Powder Vapor pressure: N/a

Odor: Practically odorless Vapor density: N/a

Solubility in Water: Negligible Evaporation rate: N/a

Specific gravity: 0.2 – 0.5 Boiling point: N/a

Section 10: Stability and Reactivity

Conditions to avoid: none Materials to avoid: none Stability: Stable

Hazardous decomposition products: Will not occur

Section 11: Toxicological Information:

Ames test negative Acute oral toxicity: n/a Acute allergenic effects: n/a

Special effects: Carcinogenicity: In 1996 the IARC reclassified Carbon Black as a Group 2B carcinogen (possible human

carcinogen). This evaluation is given to carbon black for which there is inadequate human evidence, but sufficient animal

evidence. The latter is based upon the development of lung tumors in rats receiving chronic inhalation exposures to free carbon

black at levels that induce particle overload of the lung. Studies performed in animal models other than rats have not

demonstrated an association between carbon black and lung tumors. Moreover, 2-years cancer bioassay using a typical toner

preparation containing carbon black did not demonstrate an association between toner exposure and tumor development in rats.

Section 12: Environmental / Ecological Information

Environmental Degradation: Not known Bioaccumulation: Not known in bioaccumulation

Section 13: Disposal Consideration

Used Toner should be disposed of under conditions that meet all federal, state and local environmental regulations. Disposal

regulations vary from locality to locality; therefore consult your local Lanier office or the EPA to determine the proper method for

disposal. Do not incinerate loose or spilled Toner.

Section 14: Transportation Information

International regulations:

RID/ADR Not applicable ICAO-TI/ATA-DGR Not applicable

DOT 49 CFR Not applicable UN Classification Number Not applicable

ADNR Not applicable IMDG Code Not applicable

Specific precautionary transport measures: Avoid direct sunlight. Do not keep over 35°C (95°F).

Specific material to avoid: None in normal use.

Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under

normal conditions. On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the

usual precautionary measures for dealing with chemicals.

MATERIAL SAFETY DATA SHEET

Page 3 of 3 CP-261

Section 15: Regulatory Information

Regulation: not available

Section 16: Miscellaneous Information

Judgment as to the suitability of information contained herein for user’s purposes is the responsibility of the purchaser.

Therefore, although reasonable care has been taken in the preparation of this information, Lanier Worldwide, Inc. extends no

warranties, makes no representations, and assumes no responsibility as to the accuracy or suitability of such information for

application to user’s intended purposes or for consequences of its use. All materials may present unknown hazards and

should be used with caution. Although certain hazards are described herein, we do not guarantee that these are the only

hazards that exist.

Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under

normal conditions. On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the

usual precautionary measures for dealing with chemicals.