Murphy Bc1524 Users Manual And BC3012 Battery Charger Bulletin
BC1524 to the manual f3cb8f33-d13e-4c67-a3be-6dce536ff413
2015-02-05
: Murphy Murphy-Bc1524-Users-Manual-396890 murphy-bc1524-users-manual-396890 murphy pdf
Open the PDF directly: View PDF 
.
Page Count: 2
| Download | |
| Open PDF In Browser | View PDF |
BC1524 and BC3012 ys6307 st revision A, 21 October 2004 catalogue section 40 Automatic Battery Chargers Heavy duty float charging: 15A (24V) or 30A (12V) output Simple, low cost design Lead acid or Ni-Cd calibrations Float or boost modes Charge fail relay output Description Product specification The BC1524 and BC3012 range provides fully automatic, heavy duty charging of vented lead acid or NiCd batteries. The chargers may be used in a wide range of industrial battery applications, including standby engines, pumps and generators. The charger uses an open frame construction, designed for surface mounting in an enclosed panel. Each unit consists of a transformer, rectifier and control circuit. The control circuit ensures that charger maintains the battery voltage at the pre-calibrated float level, while supplying any additional load current up to the specified maximum. A ‘boost’ operating mode can be used to provide increased voltage output. Selection of normal or boost mode is via three terminals, allowing activation by a remote panel switch or time relay – see calibration table overleaf for float and boost voltage levels. A self diagnostic ‘charge fail’ circuit and relay output is provided as standard. The volt free relay de-energises in the event of a charging fault. Power for the charger is from a 230VAC or 110VAC supply (please specify at order). All electrical connections are to stripped panel wiring via spring-loaded clamp terminals. CONTROL SYSTEMS AND SERVICES DIVISION PO Box 1819, Rosenberg, Texas 77471, USA tel: +1 281 633 4500 fax: +1 281 633 4588 email: sales@fwmurphy.com FW Murphy PO Box 470248 Tulsa, Oklahoma 74147, USA tel: +1 918 317 4100 fax: +1 918 317 4266 email: sales@fwmurphy.com web: www.fwmurphy.com MURPHY DE MEXICO S.A. DE C.V. Blvd. Antonio Rocha Cordero 300, Fracción del Aguaje San Luis Potosí, S.L.P. México 78384 tel: +52 444 8206264 fax: +52 444 8206336 Villahermosa office tel: +52 993 3162117 email: ventasmex@murphymex.com.mx web: www.murphymex.com.mx power supply: nominal operating voltages permissible voltage variation nominal operating frequency BC1524 BC3012 230 VAC or 110 VAC (specify) ± 10% of nominal 50/60 Hz. DC charge output: maximum current, A DC nominal voltage, V DC float/boost voltages 15 30 24 12 see table overleaf charge fail output: relay type contact rating volt free SPDT contacts, relay de-energised on fault 1A @ 30 VDC (resistive load) general: operating temperature overall dimensions (w x h x d) weight o –10 to +55 C 185 x 175 x 135 mm approx. 7.8 Kg Warranty A one year limited warranty on materials and workmanship is given with this Murphy product. Details are available on request and at www.fwmurphy.co.uk/warranty. FRANK W. MURPHY LTD. Church Rd, Laverstock, Salisbury, SP1 1QZ, UK tel: +44 1722 410055 fax: +44 1722 410088 email: sales@fwmurphy.co.uk web: www.fwmurphy.co.uk MACQUARRIE CORPORATION 1620 Hume Highway, Campbellfield, Victoria 3061, Australia tel: +61 3 9358 5555 fax: +61 3 9358 5558 email: murphy@macquarrie.com.au MURPHY SWITCH OF CALIFORNIA 41343 12th Street West, Palmdale, CA 93551-1442, USA tel: +1 661 272 4700 fax: +1 661 947 7570 email: sales@murphyswitch.com web: www.murphyswitch.com In order to consistently bring you the highest quality, full featured products, we reserve the right to change our specifications and designs at any time. Electrical connection Calibration charge fail (fault/power off state shown) F1, fuse type T, rating: 2 Amp (230 VAC) 4 Amp (110 VAC) L AC supply F1 0 N isolate AC supply during engine cranking + com + Lead acid (6 cells) 24V battery 0 float boost boost volts (VDC) 13.6 14.1 Battery type* 12V 230V 110V unit unit 230 110 float volts (VDC) – – Ni-Cd (10 cells) 14.2 14.7 Lead acid (12 cells) 27.2 28.2 Ni-Cd (18 cells) 25.6 26.6 Ni-Cd (20 cells) 28.4 29.4 *Note: the BC1524/BC3012 range is designed for use with vented batteries only. These chargers are NOT suitable for valve regulated lead acid (VRLA) or sealed type cells. Boost switch/timer Notes: 1) battery output is isolated from chassis 2) chassis must be connected to a low impedance earth 3) charge fail relay output is volt-free How to order Dimensions When ordering, please specify:- (mm) 4 x fixing holes, 5mm 41.70.0108 41.70.0109 41.70.0110 41.70.0111 BC3012/CLA BC3012/CNC10 BC3012/DLA BC3012/DNC10 110VAC, 110VAC, 230VAC, 230VAC, 12V lead acid 10 cell NiCd 12V lead acid 10 cell NiCd 140 160 CONTROL SYSTEMS AND SERVICES DIVISION PO Box 1819, Rosenberg, Texas 77471, USA tel: +1 281 633 4500 fax: +1 281 633 4588 email: sales@fwmurphy.com FW Murphy PO Box 470248 Tulsa, Oklahoma 74147, USA tel: +1 918 317 4100 fax: +1 918 317 4266 email: sales@fwmurphy.com web: www.fwmurphy.com 0 24V lead acid 18 cell NiCd 20 cell NiCd 24V lead acid 18 cell NiCd 20 cell NiCd + – I NP UT 230 110VAC, 110VAC, 110VAC, 230VAC, 230VAC, 230VAC, boost BC1524/CLA BC1524/CNC18 BC1524/CNC20 BC1524/DLA BC1524/DNC18 BC1524/DNC20 BOOST foat 41.70.0102 41.70.0103 41.70.0104 41.70.0105 41.70.0106 41.70.0107 N/ C Supply voltage, calibration N/ O Model COM Stock Number COM OUTPUT CHARGE FAI L MURPHY DE MEXICO S.A. DE C.V. Blvd. Antonio Rocha Cordero 300, Fracción del Aguaje San Luis Potosí, S.L.P. México 78384 tel: +52 444 8206264 fax: +52 444 8206336 Villahermosa office tel: +52 993 3162117 email: ventasmex@murphymex.com.mx web: www.murphymex.com.mx 175 140 185 FRANK W. MURPHY LTD. Church Rd, Laverstock, Salisbury, SP1 1QZ, UK tel: +44 1722 410055 fax: +44 1722 410088 email: sales@fwmurphy.co.uk web: www.fwmurphy.co.uk 135 MACQUARRIE CORPORATION 1620 Hume Highway, Campbellfield, Victoria 3061, Australia tel: +61 3 9358 5555 fax: +61 3 9358 5558 email: murphy@macquarrie.com.au MURPHY SWITCH OF CALIFORNIA 41343 12th Street West, Palmdale, CA 93551-1442, USA tel: +1 661 272 4700 fax: +1 661 947 7570 email: sales@murphyswitch.com web: www.murphyswitch.com In order to consistently bring you the highest quality, full featured products, we reserve the right to change our specifications and designs at any time.
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.4 Linearized : Yes Page Count : 2 XMP Toolkit : XMP toolkit 2.9.1-13, framework 1.6 About : uuid:8b865465-e144-41d5-b658-374232c46a1b Producer : Acrobat Distiller 6.0 (Windows) Keywords : ys6307,y56307,BC1524,1524,BC3012,3012,15A,30A,15 Amp,30 Amp,battery,DC,charge,charger,12V,12VDC,24V,24VDC,lead,acid,lead-acid,NiCd,Ni-Cd,constant voltage,float,taper,heavy,duty, monitor Create Date : 2005:01:25 15:28:24Z Creator Tool : PScript5.dll Version 5.2 Modify Date : 2005:01:25 15:30:00Z Metadata Date : 2005:01:25 15:30:00Z Document ID : uuid:29bc16b9-f492-41a9-8a10-b2d1292678e9 Format : application/pdf Title : BC1524 and BC3012 battery charger bulletin Creator : FW Murphy Description : BC1524 and BC3012 battery chargers Author : FW Murphy Subject : BC1524 and BC3012 battery chargersEXIF Metadata provided by EXIF.tools