Ozark Trail Wmt 1390S 1 Users Manual Inst_03

WMT-1390S-1 wmt-1390s-inst_03

WMT-1390S-1 to the manual 16e27307-3168-4679-bb84-7e049213eca5

2015-01-21

: Ozark-Trail Ozark-Trail-Wmt-1390S-1-Users-Manual-220483 ozark-trail-wmt-1390s-1-users-manual-220483 ozark-trail pdf

Open the PDF directly: View PDF .
Page Count: 7

OWNER’S MANUAL

Model #WMT-1390S-1

13' x 10' Screenhouse

SAFETY CARE

WARNING: KEEP ALL FLAME AND HEAT

SOURCES AWAY FROM THIS TENT FABRIC.

This tent meets the flammability require-

ments of CPAI-84. The fabric may burn if left

in continuous contact with any flame source.

The application of any foreign substance to

the tent fabric may render the flame-resis-

tant properties ineffective.

DO NOT...

1. Do not pitch tent near an open flame.

2. Do not leave campfires unattended.

3. Do not allow CHILDREN or ADULTS

to use lighted candles, matches or

other flame sources in or near tents.

4. Do not use heating, lighting or

cooking equipment with open

flames in or near tents.

5. Do not use fuel burning/oxygen

consuming devices (i.e. heaters,

lanterns, or other flame sources)

inside your tent at any time.

6. Do not use other than recommended

water repellent compounds on your

tent.(See:“Seal the Seams”)

7. Do not spray the tent with insecticide.

8. EXTREME CAUTION: Never use any

fuel burning/oxygen consuming

device, or any device that produces

fumes (including stoves, lanterns,

candles, hibachis, or heaters) in or

around your tent. Inhalation of fumes

may result in carbon monoxide

poisoning, injury and/or death.

DO...

1. Always extinguish campfire before

leaving area.

2. Exercise care when using electricity

and lighting in and near tents.

3. Disassemble and store tent properly

after camping to ensure the tent’s

longevity.

4. Always use a hammer/mallet when

driving stakes into the ground.

This recreational item is not intended for

use as a permanent structure, as fabric

will quickly degrade if exposed to UV

light. No (sun shelter, screenhouse, tent)

can withstand prolonged exposure to

sunlight. UV damage is not covered under

the limited 90 day warranty.

Structural Integrity

Although our tents and screenhouses are

constructed to rigid specifications, periods

of wind or rain soaking the ground may

loosen the stakes and cause the uprights to

sink into the ground. This will weaken the

rigidity of the overall structure.Water pock-

ets may also form in the roof if the unit is

not assembled taut, the weight of which

may cause broken frames and torn fabric.

Storage

Tents/screenhouses must never be rolled

up or packed while damp, as mildew will

form within a few days. Allow tent to dry

completely before rolling and storing.

LIMITED 90 DAY WARRANTY

For 90 days from the date of purchase, Ozark Trail will

replace, at our option, defects in material or workman-

ship that appear in this product, free of charge. Product

must be original factory packaging and unmodified.

You must have a copy of your Wal-Mart receipt.

Warranty service is available by calling:

toll free 1-800-775-1965

Mon.–Fri, 7:00 a.m. to 4:00 p.m. (PST-West Coast)

Ozark Trail

3333 Yale Way • Fremont, CA 94538-6169

This warranty gives you specific legal rights.You may

also have other rights which vary from state to state.

RPL2-03 Roof pole “2” 3

RP2B-03 Roof pole “2B” 9

SPL1-03 Side pole “1” 4

MPL5-03 Middle (roof ) pole ”5” with hook 2

MP5B-03 Middle (roof) pole “5B” with hook 2

LPL4-03 Leg pole “4” with holes 4

PL1B-03 Pole “1B” used on side and leg 12

GBLL-03 3 way hub Gable L 2

GBLR-03 3 way hub Gable R 2

GBLT-03 3 way hub Gable T 2

CBAG-03 Carry bag 1

PBAG-03 Pole bag 1

SBAG-03 Stake bag 1

UN-GROPE Guy rope 4

UN-75ABSSTK 7.5" Steel Stake 18

UN-DRING Steel D-ring 8

UN-STSHOOK Steel S-hook 4

PSET-03 Poles/ set of 36 1

SSET-03 Stakes/ set of 18 1

REPLACEMENT PARTS

PART NO. DESCRIPTION QTY. REQ.

1GBLL-03

Model # WMT-1390S-1

HOW TO ORDER REPLACEMENT PARTS

Always mention the Model number in all correspondence regarding your tent and when ordering

replacement parts. To order replacement parts listed below, or for any questions regarding your tent,

call 1-800-775-1965 Mon.–Fri, 8:00 a.m. to 5:00 p.m. (PST-West Coast)

or write to: Ozark Trail • 3333 Yale Way • Fremont, CA 94538-6169

WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING INFORMATION:

1. Model Number 2. Part Number 3. Part Descriptions

GBLL-03

GBLT-03

GBLR-03

GBLT-03

2B 2B 2B 2

GBLR-03

Step 1 – Lay Out the Screenhouse and Poles

Select a smooth, level site and spread out your

screenhouse.

Sort the poles by number and connect the

sections together. See diagrams below for

numbering.

Step 2 – Install the Poles

Insert the ends of each of the three roof poles

into the 3-way hubs . See Diagram 1.

Insert the four side roof poles into the 3-way

hubs. See Diagram 2.

Insert the leg poles into the hubs to raise the

screenhouse frame. Make sure that the pole

end with the holes in the sides ( ) is pointing

down. See Diagram 3.

Step 3 –Secure the Screenhouse

Drape the screenhouse body over the frames.

Hook the S-Hooks into one of the holes

located at the bottom of the leg poles.

Wrap the velcro tape , located inside the

screenhouse, around the poles to secure them.

When the screenhouse is in its proper location,

stake it down by driving stakes through the

four D-rings located on at the corners.

Step 4 – Install the Guy Lines

Tie the loose end of a guy line through D-ring

Repeat for the other three guy lines.

Make a loop at the end of the guy line with the

slider. Stake the looped end of the line out

about 3' from the base of the pole. Adjust the

slider until the line is taut .

ASSEMBLY INSTRUCTIONS: WMT-1390S-1

2B 2B

Diagram 1

Diagram 2

Diagram 3

slider for adjusting

guy line tension

IMPORTANT: WE ADVISE YOU TO ASSEMBLE THE TENT ONCE BEFORE GOING CAMPING TO ASSURE THAT

ALL PARTS ARE PRESENT AND TO BECOME FAMILIAR WITH THE ASSEMBLY OF THE TENT.

To prolong the life of the tent floor, select a level, clean area for the campsite.

hub

Taking Down Your Tent

–Unzip doors and windows and collapse the tent,

removing and disassembling the poles. Place

poles in the pole storage bag and tie shut.

–Remove stakes. Do not remove stakes from the

ground by pulling on the stake loops.This may

cause the stake loops to tear out of the seam.

–Spread tent out flat with all loose fabric and

rainfly (if tent has one) within the edges of the

tent base.Try to flatten tent as much as possible.

–Fold tent in half, thirds or quarters. (Folding

depends on the length of the tent pole sections.)

–Place pole bag on back end of tent (trapped air is

more easily forced out of the open door when

you are rolling up the tent.) The folded tent

should be the width of the pole bag.

–Beginning at the back end, roll your tent tightly

around the pole bag, forcing out excess air as you

roll. Keep tent edges straight and pole bag

centered as you roll.

–When tent is rolled up, tie strap around it and

place into tent carry bag with stake bag, instruc-

tion sheet, and other miscellaneous parts. If tent

won’t fit into bag, unroll and reroll more tightly.

Dimension A should

be close to but not

exceed the length of

the pole bag.

Fold tent into a

rectangular shape.

front of tent

(door unzipped)

(inside screenhouse)

CAMPER’S CHECKLIST AND HELPFUL HINTS

SAFETY AND HEALTH AIDS

•Insect repellents

•Suntan lotions

•First aid kit

•Life preservers

CAMP NEEDS

•Axe or hatchet

•Pocket knife

•Sewing kit

•Heavy-duty tape

•Rope and clothes pins

•Small shovel (to extinguish fires)

•Fishing rod and other sporting gear

•Broom

•Whisk broom

•Compact tool kit

•Hammer or mallet

CAMPING EQUIPMENT

•Tent

•Sleeping bags

•Ground sheet

•Air mattress and repair kit

•Portable stove

•Cooler

•Water jug

•Pail

•Toilet tissue

•Wash basin

•Mirror

•Folding table

•Lounge chairs

•Funnel for fueling appliances

•Camp lantern with extra mantles

•Flashlight

•Small fire extinguisher

•Rain coats

•Waterproof tarpaulins

•Waterproof matches

KITCHEN EQUIPMENT

•Camp stove

•Grill top and charcoal

•Fire starter

•Fry pan

•Sauce pans

•Coffee pot

•Heavy-duty aluminum foil

•Pot holders

•Mixing and serving spoons

•Cooking fork,tongs,spatula

•Kitchen knives

•Can/bottle opener

•Storage containers

•Cooler

•Ice pack

•Insulated jug

•Water container

•Tablecloth, napkins, plates

•Mugs,glasses

•Table knives, forks, spoons

•Dish pan

•Detergent

•Pot scrubbers

•Plastic garbage bags

•Paper towels

TRAVEL AIDS

•Road maps

•Sunglasses

•Litter bags

•Games

•Binoculars

•Camera and film

•Waterproof tarpaulins

•Waterproof matches

THANK YOU FOR PURCHASING A SUPERIOR QUALITY OZARK TRAIL TENT. THIS TROUBLESHOOTING GUIDE IS

DESIGNED TO GIVE YOU YEARS OF FUN AND ENJOYMENT FROM YOUR CAMPING EQUIPMENT.

TROUBLESHOOTING GUIDE

PROBLEM SOLUTION

1. CONDENSATION THIS IS CAUSED BY LOWER TEMPERATURES ON THE OUTSIDE OF THE TENT

COMBINED WITH BODY HEAT ON THE INSIDE OF THE TENT.WHEN THIS OCCURS,

AVOID TOUCHING WALLS TO REDUCE CONTACT LEAKAGE. LEAVING THE DOORS

AND WINDOWS OPEN WILL REDUCE CONDENSATION OF MOISTURE .

2. SEAM LEAKAGE TO PROTECT AGAINST SEAM LEAKAGE, APPLY A GENEROUS AMOUNT OF SEAM SEALER

ON ALL INTERIOR SEAMS.

3. MILDEW TO AVOID MILDEW, NEVER PUT YOUR TENT AWAY WET OR DAMP. HOWEVER, IF

MILDEW OCCURS, USE A SOFT BRISTLE BRUSH OR SPONGE WITH MILD DISH

WASHING SOAP OR FELS NAPTHA SOAP TO CLEAN. LET THE TENT DRY IN THE

SUNLIGHT AND APPLY SEAM SEALER COMPOUND ON INSIDE SEAMS.

4. REPAIRING A TEAR FOR SMALL TEARS USE A SELF-ADHESIVE PATCH KIT. WE RECOMMEND A CANVAS

OR AWNING REPAIR SHOP FOR LARGER TEARS.

5. FAULTY ZIPPER ALL OF OUR TENTS ARE MANUFACTURED WITH ZIPPERS WHICH, IF THE ZIPPER

SEPARATES, CAN BE FIXED BY MOVING THE SLIDER TO THE BEGINNING OF THE ZIPPER

TAPE AND REWORKING THE ZIPPER. IF THIS DOESN’T WORK, A REPLACEMENT ZIPPER

MAY BE ORDERED FROM OUR PARTS DEPARTMENT, AND MAY BE INSTALLED BY A LOCAL

CANVAS OR AWNING REPAIR SHOP IN YOUR AREA.

6. FLOOR CONDENSATION A GROUND CLOTH UNDER THE TENT PREVENTS THE FLOOR FROM FEELING DAMP

AND HELPS PROLONG ITS LIFE. THE CLOTH SHOULD BE SMALLER THAN THE TENT

FLOOR TO PREVENT RAIN FROM RUNNING UNDER THE TENT.

7. REMOVING STAKES STAKE SHOULD BE PULLED WITH ANOTHER STAKE, HAMMER OR STAKE PULLER,

BUT NEVER BY PULLING ON THE TENT. AVOID STAKING TENT SO TIGHT THAT IT

STRETCHES THE FABRIC. OVERSTRETCHING MAY CAUSE STAKE LOOPS TO TEAR.

PERHAPS WE’VE MISSED SOMETHING IN OUR TROUBLESHOOTING GUIDE. FEEL FREE TO GIVE US YOUR IDEAS ON

“TRICKS OF CAMPING”, REPAIR PROCEDURES, FEATURES YOU’D LIKE TO SEE, OR JUST YOUR THOUGHTS. SEND THEM TO:

TENT CUSTOMER SERVICE

3333 YALE WAY

FREMONT, CA 94538-6169

To order replacement parts, call toll free

1-800-775-1965 Mon.– Fri, 7:00 a.m. to 4:00 p.m. (PST-West Coast).

Mention complete model numbers.

Ozark Trail Wmt 1390S 1 Users Manual Inst_03

WMT-1390S-1 wmt-1390s-inst_03

WMT-1390S-1 to the manual 16e27307-3168-4679-bb84-7e049213eca5

Navigation menu

Versions of this User Manual:

Views

Navigation