JHBL Installtion Instructions U219813 Installation Directions

: Pdf 169969-Installationsheet 169969-InstallationSheet B5 unilog

Open the PDF directly: View PDF .
Page Count: 5







LEDIMPORTANTSAFETYINSTRUCTIONS















 Toreducetheriskofdeath,personalinjuryorpropertydamagefromfire,electricshock,fallingparts,cuts/abrasions,and

otherhazardspleasereadallwarningsandinstructionsincludedwithandonthefixtureboxandallfixturelabels.

 Beforeinstalling,servicing,orperformingroutinemaintenanceuponthisequipment,followthesegeneralprecautions.

 Installationandserviceofluminairesshouldbeperformedbyaqualifiedlicensedelectrician.

 Maintenanceoftheluminairesshouldbeperformedbyperson(s)familiarwiththeluminaires’constructionandoperation

andanyhazardsinvolved.Regularfixturemaintenanceprogramsarerecommended.

 Itwilloccasionallybenecessarytocleantheoutsideoftherefractor/lens.Frequencyofcleaningwilldependonambient

dirtlevelandminimumlightoutputwhichisacceptabletouser.Refractor/lensshouldbewashedinasolutionofwarm

waterandanymild,non‐abrasivehouseholddetergent,rinsedwithcleanwaterandwipeddry.Shouldopticalassembly

becomedirtyontheinside,wiperefractor/lensandcleaninabovemanner,replacingdamagedgasketsasnecessary.

 DONOTINSTALLDAMAGEDPRODUCT!Thisluminairehasbeenproperlypackedsothatnopartsshouldhavebeen

damagedduringtransit.Inspecttoconfirm.Anypartdamagedorbrokenduringorafterassemblyshouldbereplaced.

 Recycle:ForinformationonhowtorecycleLEDelectronicproducts,pleasevisitwww.epa.gov. 

 Theseinstructionsdonotpurporttocoveralldetailsorvariationsinequipmentnortoprovideeverypossiblecontingency

tomeetinconnectionwithinstallation,operation,ormaintenance.Shouldfurtherinformationbedesiredorshould

particularproblemsarisewhicharenotcoveredsufficientlyforthepurchaser’sorowner’spurposes,thismattershouldbe

referredtoAcuityBrandsLighting,Inc.





























READANDFOLLOWALLSAFETYINSTRUCTIONS!

SAVETHESEINSTRUCTIONSANDDELIVERTOOWNERAFTERINSTALLATION



 Disconnectorturnoffpowerbefore

installationorservicing.

 Verifythatsupplyvoltageiscorrectby

comparingitwiththeluminairelabel

information.

 Makeallelectricalandgrounded

connectionsinaccordancewiththeNational

ElectricalCode(NEC)andanyapplicable

localcoderequirements.

 Allwiringconnectionsshouldbecapped

withULapprovedrecognizedwire

connectors.

WARNING

RISKOFELECTRICSHOCK 

 Allowlamp/fixturetocoolbeforehandling.

Donottouchenclosureorlightsource.

 Donotexceedmaximumwattagemarkedon

luminairelabel.

 Followallmanufacturer’swarnings,

recommendationsandrestrictionsfor:driver

type,burningposition,mounting

locations/methods,replacementand

recycling.







WARNING

RISKOFBURN



 Wearglovesandsafetyglassesatalltimes

whenremovingluminairefromcarton,

installing,servicingorperforming

maintenance.

 Avoiddirecteyeexposuretothelightsource

whileitison.

CAUTION

RISKOFINJURY 

 Keepcombustibleandothermaterialsthat

canburn,awayfromlamp/lens.

 Donotoperateincloseproximitytopersons,

combustiblematerialsorsubstances

affectedbyheatordrying.



CAUTION

RISK OF FIRE







LEDIMPORTANTSAFETYINSTRUCTIONS





Please see product specific installation instructions for additional warnings or any applicable FCC or other regulatory

statements.

Failure to follow any of these instructions could void product warranties. For a complete listing of product Terms and

Conditions, please visit www.acuitybrands.com.



OurBrands Indoor/Outdoor IndoorLighting  OutdoorLighting  Controls  Daylighting  

LithoniaLighting Gotham   AmericanElectricLighting DARKTOLIGHT SunOptics 

  Carandini  MarkArchitecturalLighting AntiqueStreetLamps  LC&D

HolophanePeerlessHydrelROAM

  RELOC  RenaissanceLighting  Tersen   SensorSwitch 

LightConceptsWinonaLightingSynergy



AcuityBrandsLighting,Inc.assumesnoresponsibilityforclaimsarisingoutofimproperorcarelessinstallationorhandlingofitsproducts.

ABLLEDGeneralWarnings,FormNo.503.203

©2010AcuityBrandsLighting,Inc.Allrightsreserved.12/01/10













 Neverconnectcomponentsunderload.

 Donotmountorsupportthesefixturesinamannerthatcancuttheouterjacketordamagewire

insulation.

 Unlessindividualproductspecificationsdeemotherwise:NeverconnectanLEDproductdirectlytoa

dimmerpacks,occupancysensors,timingdevices,orotherrelatedcontroldevices.LEDfixturesmustbe

powereddirectlyoffaswitchedcircuit.

 Unlessindividualproductspecificationsdeemotherwise:Donotrestrictfixtureventilation.Allowfor

somevolumeofairspacearoundfixture.AvoidcoveringLEDfixtureswithinsulation,foam,orother

materialthatwillpreventconvectionorconductioncooling.

 Unlessindividualproductspecificationsdeemotherwise:Donotexceedfixturesmaximumambient

temperature.

 Onlyusefixtureinitsintendedlocation.

 LEDproductsarePolaritySensitive.EnsureproperPolaritybeforeinstallation.

 ElectrostaticDischarge(ESD):ESDcandamageLEDfixtures.Personalgroundingequipmentmustbe

wornduringallinstallationorservicingoftheunit.

 DonottouchindividualelectricalcomponentsasthiscancauseESD,shortenlamplife,oralter

performance.

 Somecomponentsinsidethefixturemaynotbeserviceable.Intheunlikelyeventyourunitmayrequire

service,stopusingtheunitimmediatelyandcontactanABLrepresentativeforassistance.

 Alwaysreadthefixturescompleteinstallationinstructionspriortoinstallationforanyadditionalfixture

specificwarnings.

CAUTION:RISKOFPRODUCTDAMAGE







LEDIMPORTANTSAFETYINSTRUCTIONS











SECTION1:INSTALLATIONOFNEWLUMINAIRE

Caution:Protectlensandoccupancysensorwhensettingluminairedown.

1) Ifreplacingexistingfixtures,disconnectallpowertotheexistingluminaireandremovetheexistingluminairefromthe

ceiling.

2) RemovethenewLEDhighbayfrompackagingandinspectforanydamages.HandlenewLEDfixturewithcare.Donotset

thefixturedownonthelens.Ifdamageddonotuse;callyourlocalrepforreplacement.

3) Thisfixtureisdesignedtohangfromthesuppliedhookora¾‐14NPSorNPTschedule80pipe(notprovided).Ifusingpipe,

useathreadsealant(notprovided)tosealthethreadstopreventwaterfromenteringthefixture.Provideandinstalla

suitablemountingstructureinaccordancewithlocalcodesthatiscapableofsupportingthefullweight(43lbs)ofthe

luminaire.Ifinstallingluminaireontopipe,threadpipeaminimumof5fullturnsontoluminaireandtorquepipeto35ft.

lbs.Tightensetscrewonspliceboxto35in.lbs.Thisluminaireisnotsuitableforuseinhighvibrationareas.Theluminaire

shallnotbelocatedinareaswheretheluminaireexperiencesvibrationinexcessof1/2Gatitscenterofgravitypoint.To

determineifvibrationispresentatorneareachluminairelocation,useaportableaccelerationmonitoringdevice.

4) ConnecttheLEDhighbaywiringtolinewire,black‐to‐black,white‐to‐whiteandgreen‐to‐green.Purpleandgraywiresare

for0‐10Vdimmingandshallbecappedwithawirenut(notprovided)foreachwirewhennotused.UseonlyULlisted

wiringconnectors90C(orgreater)andULlistedwiring(90Corgreater).Wirescanbepulledthroughanyofthebelow

accessplatesperlocalcode.Leadwiresarenormallylocatedbehindthe“AccessPlateForSpliceBox”openingjustunder

thehook.

5) XpointwirelesscontrolsrequireasecondaryfieldcommissioningtoconnecttotheXpointnetwork.

6) Wipeoffexteriordirtanddebrisusingasoftcleancloth.Donotuseabrasivecleanersonopticalsurfacesasthismayresult

inlossofopticalefficiency.





Figure1







LEDIMPORTANTSAFETYINSTRUCTIONS















SECTION2:OptionalEquipment

ThisLEDhighbayfixturecanbeorderedwithmultipleoptionswhichmayormaynotbepresentonthefixtureyouareinstalling.

Commonsoptionsare:

1. WireGuard–protectsthelensfromdamage.

2. OccupancySensor–turnsfixtureonoroffbasedonmotiondetectedwithinthespace.

3. EmergencyTestSwitchandIndicatorLight–usedtotestthefunctionoftheemergencybatterypackwhichislocatedinside

thedriverhousing.Pushingtheswitchwillturnofftheincomingpowertothefixtureandswitchitovertobatterypower.

ItisnormalforonlyonesectionofLEDstolightupduringemergencybatterymode.

4. EmergencyLightingMaximumMountingHeight‐Fixturesequippedwithemergencybatterybackupsystemsmaybe

mountednohigherthan30ftperUL924.

5. Forluminaireswithacrylicorpolycarbonateopticallenses,pleasereferencethefollowinglinkforchemicalcompatibility

information:http://www.acuitybrandslighting.com/library/ll/documents/otherdocuments/acrylic‐polycarbonate‐

compatibility.pdf





Figure2







LEDIMPORTANTSAFETYINSTRUCTIONS







SECTION3:SERVICING

1) DisconnectallpowertotheLEDhighbaybeingservice.

2) Removethefixturefromceiling.Servicecannotbeperformedwhilefixtureisinstalled.

3) Allserviceshouldbeperformedbyaqualifiedlicensedelectrician.UseonlyULlistedcomponents.

4) Donotsetthefixtureonthelensorsensor.

5) Removethefourcornerscrewssothatthetophalfofthedriverhousingcanberemoved.Becarefulnottopinch,damage,

orpullanywiring.

6) TheLEDdriversmaybechangedbyremovingthemountingbracketshownbelow.

7) Fusesandsurgeprotectorscanbeservicedwithoutremovingthemountingbracket.





Figure3

Ifthereareanyquestionsregardingthisinstallationinstruction,pleasecontactourtechnicalsupportdepartment.Five‐yearlimited

warranty.Warrantytermsarelocatedat

www.acuitybrands.com/customerresources/term_and_conditions.aspx

U219813Rev“F”Issued8/18/2016