2584 1 Zoeller Basement Sentry Brochure User Manual
6329 1 Zoeller Basement Sentry Brochure 6329_1_Zoeller Basement Sentry Brochure
User Manual: Pump 2584 1 Zoeller Basement Sentry Brochure
Open the PDF directly: View PDF 
.
Page Count: 2
THE BASEMENT SENTRY® SERIES
12 VOLT BACKUP SUMP PUMP SYSTEMS
MODEL 507 & MODEL 510
“TAKES OVER WHERE OTHER SYSTEMS QUIT”
Application:
For clear water, emergency backup usage when power is off or the primary pump(s) fail.
EXTRA PROTECTION
When the primary AC pump fails due to power outages.
• Storms • Brownouts • Wiring or electrical problems
No other system offers the reliability and protection provided by the Basement
Sentry® Series.
When the primary pump fails due to damage, mechanical malfunction or
obstructions in the pit.
When the primary pump fails to keep up with excessive water due to rain or overloading.
HIGH CAPACITY PROTECTION & RECOVERY
The Model 510 provides high capacity capabilities for dewatering in critical installations.
(See performance data)
• High-capacity residential locations • Communication vaults
• Commercial locations • Computer vaults
• Basement storage facilities
Features:
Zoeller's time tested design experience gives you the needed performance and reliability.
PUMPS: 12 volt highly efcient with noncorrosive pump construction. Supplied with
6' leads.
CONTROL BOXES: All models have battery burn out and overcharge protection. Models
507 and 510 have a self contained 10 amp battery recharger. All systems are fully solid
state automatic controllers with alarms, light indicators, and have warning systems.
LIGHT INDICATORS:
(Long Lasting LED)
• Power supply "on'' • Run light
• Battery partially charged • Battery fully charged
• Pump alarm "off''
ALARMS:
• Continuous steady beep - "low battery''
• Slow interrupted beep - “partially discharged battery” (Model 510 only)
• Pump Run / High Water Alarm
CONTROL DEVICE: Reliable low voltage oat switch.
BATTERY CASE: The included battery case will accommodate maximum battery
dimensions of 13"(L) x 7½"(W) x 9½"(H) and ts all group size 27 marine batteries.
Made from noncorrosive polyethylene. Contains lock strap. Model 510 can be used
with multiple batteries. Order extra battery case with hookup wire (P/N 007861).
FITTINGS: Furnished with ALL required ttings. Model 507 has an internal check
valve in the discharge and includes an additional check valve with integral weep hole
adaptable to 1½" pipe. Model 510 includes two heavy duty check valves to install with
pedestal/column or submersible pumps.
SECTION: 2.60.050
FM0861
0713
Supersedes
0711
© Copyright 2013 Zoeller Co. All rights reserved.
Product may not be exactly as shown.
MODEL 507 pictured
PRIMARY
SUMP PUMP
MUST BE
ORDERED
SEPARATELY
Product information presented
here reects conditions at time
of publication. Consult factory
regarding discrepancies or
inconsistencies.
MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624
visit our web site:
www.zoeller.com
®
Your Peace of Mind is Our Top Priority
®
Model 507
Basement
Sentry® I
Model 510
Basement
Sentry® II
Shipping weight: Model 507/18 lbs., Model 510/19 lbs.
NOTE: Not recommended for installation with over 15 ft. Total Dynamic Head for Model 507, or 17 ft. for Model 510.
CAUTIONS: See FM1311 (Model 507), or FM1139 (Model 510) Installation Instructions.
Note: Above performance chart based upon actual performance
achieved with a 12 Volt deep-cycle battery. Some manufacturers
publish performance data based upon D.C. Pump testing according
to Marine Industry standards which can reect a performance of 40%
- 80% higher than actual battery powered performance.
009926A
Products may not be exactly as illustrated.
Aquanot® Deep-cycle
Battery (purchase separately)
© Copyright 2013 Zoeller Co. All rights reserved.
0
5 10 15
0
5
10
15
20 40 60
2
4
GALLONS
LITERS
METERS
FEET
FLOW PER MINUTE
TOTAL DYNAMIC HEAD
PUMP PERFORMANCE CURVE
MODEL 507/510
20 25 30
80 100 120
25
35
507
510
20
6
P/N 10-1450 - AGM (shown)
P/N 10-0761 - Wet
Feet
MODEL
Gal. Liters
5 1.5 23 87
10 3.0 15 57
15 4.6 5 19
Shut-off Head: 17.5 ft.(5.3m)
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
Meters
507 510
22
11
34
Gal.
83
129
42
Liters
19.9 ft.(6.1m)
009926B
Warranty - 12 months from date of installation or 18 months from date of manufacture. However the 12 month warranty is extended
to 36 months with the purchase of an Aquanot® Battery by Zoeller. Note: Three year limited warranty valid only when a complete sys-
tem is purchased and used as a backup to a primary dewatering system. A complete system includes a Model 507 or 510 Basement
Sentry® and an Aquanot® Battery. To validate warranty, the warranty card (FM1679) included with a Basement Sentry® Pump must be
lled out and returned to the factory.
Battery Life - The estimated life of a fully charged (175 minute reserve capacity) battery when the pump is operating continuously
is approximately 7½ hours. Example - The Model 510 at 10 ft. head will pump 1,296 G.P.H. Most backup systems require intermittent
pump operation. All models will provide protection for extended periods of time dependent upon stop-start requirements. NOTE: The
510 offers extended backup protection if the regular primary sump pump fails.
Performance Data - Pump performance is based on the use of a fully charged 12 volt, (200 minute reserve capacity) for Models
507 and 510, deep-cycle battery with no deciency and less than two years old.
Aquanot® Battery - • Size 31 “Wet” P/N 10-0761 (69 lbs.) (Shipped via truckline only)
200 - minute reserve capacity
• Size 27 “AGM” P/N 10-1450 (66 lbs.)
175-minute reserve capacity
Min. battery requirements: Deep cycle, size 27, 175-minute
reserve capacity.
Min. pit size requirements: 18" diameter X 24" deep. For 18" x 22"
applications, consult factory.
MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624
Your Peace of Mind is Our Top Priority
®
®visit our web site:
www.zoeller.com
