537424 1 Zoeller Waste Mate 290 Series Pump Brochure User Manual

537422 1 Zoeller Waste-Mate 290 Series Pump Brochure 537422_1_Zoeller Waste-Mate 290 Series Pump Brochure

537423 1 Zoeller Waste-Mate 290 Series Pump Brochure 537423_1_Zoeller Waste-Mate 290 Series Pump Brochure

User Manual: Pump 537424 1 Zoeller Waste-Mate 290 Series Pump Brochure

Open the PDF directly: View PDF PDF.
Page Count: 4

SECTION: 2.30.050
FM0450
0414
Supersedes
1013
COMPARE THESE FEATURES
• Non-clogging vortex impeller design. Bronze class
C89833
• Durable cast construction. Cast iron switch case, base,
motor and pump housing. No sheet metal parts
to rust or corrode. All cast iron class 30 30,000#
tensile strength
• Stainlesssteelscrews,bolts,oatrod,handle,guard,
arm and seal assembly
• 20' UL listed 3-wire neoprene cord and plug. Extra cord
lengths available in 25'-35'-50' lengths only.
• 3 phase models available
• Motor-60Hz,3450RPM,oil-lled,hermeticallysealed,
automatic reset, thermal overload protected (1 Ph only)
• Maximum temperature for sewage or dewatering
130°F (54°C), 120°F (49°C) for WD295. If over 130°F,
consult factory.
• Shaft seal - stainless steel carbon & ceramic rotary
• Corrosionresistantpowdercoatedepoxynish
• Upper & lower ball bearings running in bath of oil
• Square ring & gasket - neoprene
• All models pass 2" spherical solids
• Major width 12-7/8" • Height 19-5/16" (single seal)
• Automaticunitsavailablewithoatoperated,
submersible 2-pole mechanical switch.
On
point 15-3/4"
- Off point 5-1/4"
• Specify2"or3"NPTfemaleangedverticaldischarge.
• 100% computerized testing
MODELS 4292-4293-4294-4295
DOUBLE SEAL PUMPS (nonautomatic only)
• Gives motor extra protection from seal leaks
• Improved bearing lubrication
• Helps eliminate seal and bearing damage from dry runs
• Major width 12-7/8" Height 21-3/16"
Note: The sizing of efuent systems normally requires
variable level oat(s) controls and properly sized
basins to achieve required pumping cycles or dosing
timers with nonautomatic pumps.
© Copyright 2014 Zoeller Co. All rights reserved.
292 - 293 - 294 - 295 Single Seal Series
4292 - 4293 - 4294 - 4295 Double Seal Series
(For Pump Prex Identication see News & Views 0052)
HIGH HEAD
“WASTE-MATE”
SUBMERSIBLE
SEWAGE
OR DEWATERING PUMP
Double
Seal
Pump
Nonautomatic
models for
variable level
systems
Automatic units
available in
single phase 292,
293, 294 & 295
series
WD295 controlled
by variable level
oatswitch
*See back page for UL & CSA listings
Tested to UL
Standard UL778
R
L
U
*
*
R
Certied to CSA
Standard C22.2 No.108
Product information presented
here reects conditions at time
of publication. Consult factory
regarding discrepancies or
inconsistencies.
MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624
visit our web site:
www.zoeller.com
®
Your Peace of Mind is Our Top Priority
®
SK1415
SELECTION GUIDE
1. Integraloatoperatedmechanicalswitch,noexternalcontrolrequired.
2. For automatic use single piggyback variable level oat switch or
doublepiggybackvariableleveloatswitch.RefertoFM0477.
3. See FM1228 for correct model of simplex control panel.
4. See FM0712 for correct model of duplex control panel.
Single Seal Auto Design Weight 86-89 lbs.
For information on additional Zoeller products refer to catalog on explosion-proof models, FM1702; Simplex controls,
FM1596; Piggyback Variable Level Float Switches, FM0477; Electrical Alternator, FM0486; Mechanical Alternator,
FM0495; Sump/Sewage Basins, FM0487; Alarm Systems, FM0732; Disconnect/Rail Systems, FM0787; and Junction
Boxes FM1597.
CAUTION
All installation of controls, protection devices and wiring should be done by a qualied licensed electrician. All electrical and
safety codes should be followed including the most recent National Electrical Code (NEC) and the Occupational Safety and
Health Act (OSHA).
© Copyright 2014 Zoeller Co. All rights reserved.
PUMP PERFORMANCE CURVE
MODEL 292/4292/293/4293/294/4294/295/4295
0 80 160 240 320 400 480
220140130120110100908070605040302010
0
2
4
6
8
10
12
14
16
18
20
80
65
60
55
50
45
40
35
30
25
20
15
10
5
LITERS
GALLONS
FEET
METERS
TOTAL DYNAMIC HEAD
FLOW PER MINUTE
150 160 170 180 190 200 210
560 640 720 800
70
22
292/4292
293/4293
294/4294
295/4295
75
24
CAUTION
Model 293 should not
be subjected to less
than 15' TDH.
009919A
Double Seal Design / Weight 92-95 lbs.
294/4294
Gal. Liters
196 742
181 685
165 625
150 568
136 515
121 458
94 356
58 220
13 49
-- --
62 ft.(18.9m)
292/4292 293/4293
199 753
115
23
89
59
154
140
184
168
435
87
337
223
583
530
696
636
295/4295
Gal.
214 810
Liters
75 ft.(22.9m)
MODEL
Feet Meters Gal. Liters Gal. Liters
5 1.5 530140 -- --
10 3.0 469124 -- --
4.6 409108 118 44715
6.1 34491 108 40920
7.6 28475 96 36325
9.1 21256 82 310
30
12.2 3810 48 182
40
15.2 ---- -- --50
18.3 ---- -- --60
21.3 ---- -- --70
Shut-off Head: 42 ft.(12.8m) 50 ft.(15.2m)
2" NPT
OR
3" NPT
AVAILABLE IN A FLANGE
19 5/16" [491 mm]
6" [152 mm]
4 1/8" 8 3/4"
6 1/2"
4 1/8" [105 mm]
6 11/32" [161 mm]
[165 mm]
[222 mm]
[105 mm]
SK863
6 [152 mm]
4 1/8 8 3/4
6 1/2
4 1/8 [105 mm]
21 3/16 [538 mm]
4 1/8 [105 mm]
2" NPT
OR
3" NPT
AVAILABLE IN A FLANGE
[165 mm]
[222 mm]
[105 mm]
009919B
* No molded plug ** Single piggyback switch included (1) UL listed unit available with 20 amp plug (2) CSA approval with 20 amp plug
292 MODELS 4292 MODELS Standard all models - 20 ft. cord - ½ HP Control Selection Listings
Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL
M292 -- 115 1 Auto 15.0 1 -- Y Y(1)
N292 N4292 115 1 Non 15.0 2 or 3 2 or 4 Y Y(1)
D292 -- 230 1 Auto 7.5 1 -- Y N
E292 E4292 230 1 Non 7.5 2 or 3 4 Y N
* H292 -- 200 1 Auto 8.8 1 -- Y N
* I292 * I4292 200 1 Non 8.8 2 or 3 4 Y N
* F292 * F4292 230 3 Non 5.2 3 4 Y N
* J292 * J4292 200 3 Non 6.4 3 4 Y N
* G292 * G4292 460 3 Non 2.9 3 4 Y N
* BA292 * BA4292 575 3 Non 2.4 3 4 Y N
293 MODELS 4293 MODELS Standard all models - 20 ft. cord - 1 HP Control Selection Listings
Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL
D293 -- 230 1 Auto 10.2 1 -- Y Y
E293 E4293 230 1 Non 10.2 2 or 3 4 Y Y
* H293 -- 200 1 Auto 12.0 1 -- Y N
I293 I4293 200 1 Non 12.0 2 or 3 4 Y N
* F293 * F4293 230 3 Non 7.6 3 4 Y Y
* J293 * J4293 200 3 Non 8.2 3 4 Y Y
* G293 * G4293 460 3 Non 4.0 3 4 Y Y
* BA293 -- 575 3 Non 3.3 3 4 Y N
295 MODELS 4295 MODELS Standard all models - 20 ft. cord - 2 HP Control Selection Listings
Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL
D295 -- 230 1 Auto 17.1 1 -- Y(2) Y
E295 E4295 230 1 Non 17.1 2 or 3 4 Y (2) Y
WD295 -- 230 1 Auto 17.1 ** 4 Y N
* H295 -- 200 1 Auto 20.5 1 -- Y N
* I295 * I4295 200 1 Non 20.5 2 or 3 4 Y N
* F295 * F4295 230 3 Non 12.2 3 4 Y Y
* J295 * J4295 200 3 Non 14.3 3 4 Y Y
* G295 * G4295 460 3 Non 6.1 3 4 Y Y
* BA295 -- 575 3 Non 4.9 3 4 Y N
294 MODELS 4294 MODELS Standard all models -20 ft. cord -1½ HP Control Selection Listings
Single Seal Double Seal Volts Ph Mode Amps Simplex Duplex cCSAus UL
D294 -- 230 1 Auto 13.7 1 -- Y Y(1)
E294 E4294 230 1 Non 13.7 2 or 3 4 Y Y(1)
* H294 -- 200 1 Auto 17.8 1 -- Y N
* I294 * I4294 200 1 Non 17.8 2 or 3 4 Y N
* F294 * F4294 230 3 Non 9.5 3 4 Y Y
* J294 * J4294 200 3 Non 10.8 3 4 Y Y
* G294 * G4294 460 3 Non 4.8 3 4 Y Y
* BA294 -- 575 3 Non 3.8 3 4 Y N
© Copyright 2014 Zoeller Co. All rights reserved.
© Copyright 2014 Zoeller Co. All rights reserved.
MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624
®
®visit our web site:
www.zoeller.com

Navigation menu