548007 4 Zoeller M212 Technical Data
: Pump 548007 4 Zoeller M212 Technical Data 548007_4_Zoeller M212 Technical Data pdf
Open the PDF directly: View PDF 
.
Page Count: 2
SECTION: 2.20.015
FM2850
1115
Supersedes
1015
TECHNICAL DATA SHEET
AQUA-MATE SERIES
15 7/8"
(403 mm)
4 1/4"
(108 mm)
3 7/16"
(87.6 mm)
3 3/8
(86 mm)
6 15/32"
(164 mm)
2" NPT
5 3/4"
(146 mm)
4 23/32"
(120 mm)
NOTE: The sizing of effluent systems normally requires variable level
float(s) controls and properly sized basins to achieve required pumping
cycles or dosing timers with nonautomatic pumps.
MOTOR
Horse Power 1/2
Voltage 115
Phase 1 Ph
Hertz 60 Hz
RPM 3400
Type Permanent split capacitor
Insulation Class B
Amps 6.6
PUMP
Operation Automatic
Auto On/Off Points 11 1/2” (29 cm) / 5 1/4” (13 cm)
Discharge Size 2" NPT
Solids Handling 2" (50 mm) spherical solids
Cord Length 10' (3 m) standard
Cord Type UL listed 3-prong plug
Max. Head 19.5' (5.9 m)
Max. Flow Rate 82 GPM (310 LPM)
Max. Operating Temp. 104° F (40° C)
Cooling Oil filled
Motor Protection Auto reset thermal overload (1 Ph)
MATER IALS
Motor Housing Cast iron
Pump Housing Engineered plastic
Base Engineered plastic
Upper Bearing Ball bearing
Lower Bearing Ball bearing
Mechanical Seals Carbon and ceramic
Impeller Type Non-clogging vortex
Impeller Engineered plastic
Hardware Stainless steel
Motor Shaft SUS420J2 stainless steel
Gasket NBR
Product information presented
here reects conditions at time
of publication. Consult factory
regarding discrepancies or
inconsistencies.
®
Your Peace of Mind is Our Top Priority
®
R
Tested to UL778 and
CSA22.2 108 Standard
NOTE: See model comparison chart for specific details.
© Copyright 2015 Zoeller® Co. All rights reserved.
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com
SK3054
FLOW PER MINUTE
0
LITERS
GALLONS
0
1208040
2010 30
200160
40 50
TOTAL DYNAMIC HEAD
10
2
5
15
4
METERS
25
6
FEET
PUMP PERFORMANCE CURVE
MODEL 212
19.5 ft. (5.9m)
80
280240
60 70
320
90
Gal.
Shut-off Head:
15
10
5
Feet
4.6
3.0
32
53
1.5
Meters
82
MODEL
121
201
310
Liters
212
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
SEWAGE AND DEWATERING
20
NOTE: recommended for 2" pipe only
All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be
followed including the most recent National Electrical Code (NEC) and the Occupational Safety and Health Act (OSHA).
CAUTION
Model
MODEL COMPARISON
Seal Mode Volts Ph Amps HP Hz Lbs. Kg
M212 Single Auto 115 1 6.6 1/2 60 16.8 7. 6
© Copyright 2015 Zoeller® Co. All rights reserved.
502-778-2731 | 800-928-7867 | 3649 Cane Run Road | Louisville, KY 40211-1961 | www.zoeller.com
153444
FLOW PER MINUTE
0
LITERS
GALLONS
0
1208040
2010 30
200160
40 50
TOTAL DYNAMIC HEAD
10
2
5
15
4
METERS
25
6
FEET
PUMP PERFORMANCE CURVE
MODEL 212
19.5 ft. (5.9m)
80
280240
60 70
320
90
Gal.
Shut-off Head:
15
10
5
Feet
4.6
3.0
32
53
1.5
Meters
82
MODEL
121
201
310
Liters
212
TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
SEWAGE AND DEWATERING
20
1. Integral float-operated mechanical switch, no external control required.
2. See FM1663 for a residential alternator system.
