Schwinn Roadster Trike Owners Manual
2015-05-15
: Schwinn Schwinn-Roadster-Trike-Owners-Manual-718244 schwinn-roadster-trike-owners-manual-718244 schwinn pdf
Open the PDF directly: View PDF 
.
Page Count: 12
OWNER’S MANUAL
Schwinn Roadster
ASSEMBLY
OPERATING
ADJUSTMENTS
MAINTENANCE
WARRANTY
In the interest of safety, make certain that you read
and understand all information and instructions
included with and pertaining to this product.
Ages 2-4 years
1
2
Rules for Children
To avoid accidents, teach children good riding skills with an
emphasis on safety from an early age.
1. Rider should always wear a properly fitted helmet that
complies with US Consumer Product Safety Commission
(CPSC) standard 16 CFR 1203
2. Continuos adult supervision required.
3. Allow only one rider.
4. Excessive weight may cause a hazardous or unstable
condition
5. Do not play in driveways or the road.
6. Do not ride on busy streets.
7. Do not ride at night.
8. Obey all the traffic laws, especially stop signs and red
lights.
9. Be aware of other road vehicles behind and nearby.
10.
If riding downhill, be extra careful. Slow down using the
brakes and maintain control of the steering.
11. Never take your hands off the handlebars, or your feet off
the pedals when riding downhill.
Children should be made aware of all possible riding hazards
and correct riding behavior before they take to the streets
- Do not leave it up to trial and error.
The Consumer Protection Safety Commission
advises that the riding of small wheel diameter
toys at excessive speeds can lead to instability
and is not recommended.
3
Schwinn Roadster Assembly Instructions
Tools needed:
13mm (1/2”) wrench, or 10mm crescent (adjustable) wrench,
Phillips screwdriver
Parts list:
1) Main frame assembly
2) Rear frame assembly - rear frame, standing deck, rear
wheels and fenders
2) Saddle assembly – saddle, carriage bolt, saddle-adjustment
knob
3) Fork assembly – front fork, front wheel, front fender
4) Handlebar assembly – handlebar, grips, stem clamp
Before beginning assembly, unpack and inspect all parts
listed above. If any parts are missing or damaged, DO NOT
RETURN TRICYCLE TO DEALER. Please call 1-800-626-2811
for replacement or missing parts.
A SPECIAL NOTE FOR PARENTS
This toy is intended for use by small children. As a parent or
guardian, you bear the responsibility of ensuring the safety of
your child. To make sure this toy is used safely, a responsible
adult must supervise any child playing with it. This includes
allowing it to be used only where and when it is clearly safe for
a small child to do so and making certain that it is in good repair
and secure operating condition.
4
Step 1.
Attach main frame to rear deck. Assemble by aligning the rear
axle against the “C” shaped support at the end of the main
frame, then rotate rear deck assembly so that the attachment
bolt protrudes through the frame. Secure frame with washer
and locknut, and insert the two flanking screws.
Step 2.
Position saddle on frame with carriage bolt protruding through
center hole in frame. Tighten knob onto carriage bolt to lock
saddle in position. Fore and aft saddle adjustment can be
accomplished by removing the saddle-adjustment knob and
re-tightening the knob and saddle in desired hole.
5
Step 3.
Insert fork assembly through head tube of frame assembly.
Be sure that fork is completely inserted through frame to allow
approximately 22mm (7/8”) of fork steer tube to show through
top of head tube. Push stem clamp onto fork steer tube.
Stem clamp must fully seat onto fork steer tube. There should
be no space between head tube and stem clamp. Insert han-
dlebar into fork steer. Be sure to insert far enough to cover
“Minimum Insertion” mark on handlebar. Align handlebar and
front wheel, tighten stem clamp with 13mm (1/2”) wrench.
Step 4.
Inspect all wheels to be sure that they turn freely. If any wheel
does not turn freely, check that fender is not rubbing on the
tire. If it is, flex fender to the opposite side that it is rubbing
on, until it is centered (see illustration). While holding front
wheel, check that handlebar cannot be turned independently
from wheel. Check that saddle carriage bolt and tightening
knob are holding saddle securely. If necessary, tighten saddle-
adjustment knob further.
6
7
Schwinn Roadster
Parts Diagram
8
Schwinn Roadster
Parts List
9
LIMITED WARRANTY AND POLICY ON REPLACEMENT PROCEDURES
AND RESPONSIBILITIES
Your purchase includes the following warranty which is in lieu of all other
express warranties. This warranty is extended only to the initial consumer
purchaser. No warranty registration is required. This warranty gives you
specific legal rights and you may have other rights which vary from state
to state.
The entire tricycle frame is guaranteed against faulty materials and work-
manship for as long as the initial consumer purchaser has the bike, subject
to the condition of the warranty listed below. If tricycle frame failure should
occur due to faulty materials or workmanship during the guarantee period,
the tricycle frame will be replaced. For frame replacement under this
Pacific Limited Warranty, contact us, stating the nature of the failure, model
number, date received and the name of the store from which the tricycle
was received, at the address given on this page. Tricycle frames must be
returned for inspection at customer’s expense.
All other parts of the unit except Normal Wear Parts are warranted against
defective materials and workmanship for a period of 1 year from the date
of purchase by the initial consumer purchaser, subject to the Terms and
Conditions of the warranty listed below. If failure of any part should occur
during the warranty period, the part will be replaced for you if the failure
was due to faulty materials or workmanship. All warranty claims must be
submitted to the address below and must be shipped prepaid and accompa-
nied by proof of purchase.
Any other warranty claims not included in this statement are void.
This especially includes installation, assembly, and disassembly costs.
This warranty does not cover paint damage, rust, or any modifications
made to the bike. Normal Wear Parts are defined as grips, tires, tubes, and
cables. These parts are warranted to be free from defects in material and
workmanship as delivered with the product. Any claim for repair or
replacement of Normal Wear Parts (grips, tubes, tires, cables, brake shoes,
and saddle covering) and missing parts must be made within thirty (30)
days of the date of purchase. The warranty does not cover normal wear
and tear, improper assembly or maintenance, or installation of parts or
accessories not originally intended or compatible with the tricycle as sold.
The warranty does not apply to damage or failure due to accident, abuse,
misuse, neglect, or theft. Claims involving these issues will not be honored.
Your tricycle has been designed for general transportation and recreational
use, but has not been designed to withstand abuse associated with stunt-
ing and jumping. This warranty ceases when you rent, sell, or give away the
tricycle, ride with more than one person, or use the tricycle for stunting or
jumping. This warranty does not cover ordinary wear and tear or anything
you break accidentally or deliberately.
It is the responsibility of the individual consumer purchaser to assure that
all parts included in the factory-sealed carton are properly installed, all
functional parts are initially adjusted properly, and subsequent normal
maintenance services and adjustments necessary to keep the bike in
goodoperating condition are properly made. This warranty does not apply
to damage due to improper installation of parts or failure to properly main-
tain or adjust the bike.
NOTICE: Specifications subject to change without notice.
4730 East Radio Tower Lane/PO Box 344
Olney, IL 62450
Call Toll Free 1-800-626-2811
Monday - Friday 8:00 a.m. to 5:00 p.m. Central Time
Customerservice@pacific-cycle.com
10
