Sears 625 3444 Users Manual
62534440 62534440 KENMORE KENMORE COUNTERTOP WATER PURIFIER - Manuals and Guides L0803294 View the owners manual for your KENMORE KENMORE COUNTERTOP WATER PURIFIER #62534440. Home:Plumbing Parts:Kenmore Parts:Kenmore KENMORE COUNTERTOP WATER PURIFIER Manual
KENMORE Reverse osmosis Manual L0803294 KENMORE Reverse osmosis Owner's Manual, KENMORE Reverse osmosis installation guides
625.3444 to the manual 92ea4b20-454f-44ac-8c80-7e3be6c4bd07
2015-02-05
: Sears Sears-625-3444-Users-Manual-399637 sears-625-3444-users-manual-399637 sears pdf
Open the PDF directly: View PDF .
Page Count: 6
Download | |
Open PDF In Browser | View PDF |
SEARS OWNERS MANUAL ! Kenmore ? MODEL NO. 625.34440 ] ] ] KenmoreCountertop WaterPurifier CAUTION READ THIS MANUAL CAREFULLY BEFORE YOU USE YOUR PURIFIER - HOW IT WORKS - CARE OF - REPAIR PARTS- SAVE THIS MANUAL Sears, Roebuck and Co., Chicago, II1. 60684 U.S.A. LIMITED WARRANTY FULL ONE YEAR WARRANTY ON WATER PURIFIER (Except Carbon Filter) For one year from the date of purchase, Sears will repair this Water Purifier, (except carbon filter), free of charge, if defective in material or workmanship. WARRANTY SERVICE IS AVAILABLE BY SIMPLY RETURNING THE WATER PURIFIER TO THE NEAREST SEARS SERVICE CENTER THROUGHOUT THE UNITED STATES. This warranty gives you specific legal rights, and you may have other rights which vary from state to state. Sears, Roebuck and Co., Dept. 702 !PSP, Sears Tower, Chicago, IL 60684 RULES FOR SAFE OPERATION • Before using your Purifier, read these rules and instructions carefully. OF YOUR WATER PURIFIER • Use your Purifier indoors on a dry, level surface, away from other heat sources. • THE HEATING ELEMENT IS IN THE BASE OF THE PURIFIER AND THE BO'I-I-OM DOES GET HOT DURING USE. BE SURE THE PURIFIER IS ON A SURFACE ABLE TO WITHSTAND THIS HEAT, AND AT LEAST 1 INCH AWAY FROM WALLS. • This Purifier is recommended for use with potable water supplies only. DO NOT use for anything other than purifying water. • Do not let the electrical cord hang over the edge of the counter, pinch in drawers, or lay on open burner or other hot surface. • DO NOT attempt to purify and make safe drinking water from non-potable water sources. • Do not use the Purifier if damaged, or if the electrical cord is defective. • Plug the Purifier into a 120 volt AC house electrical outlet only. • KEEP CHILDREN AWAY . . . HOT, BOILING water in the Purifier will scald if spilled on skin. • NEVER REMOVE THE COVER WHILE THE PURIFIER IS ON (FAN RUNNING). Let the unit cool at least 30 minutes after a cycle has finished. THE BOILING WATER OR STEAM COULD CAUSE SEVERE BURNS. • DO NOT immerse any part of the Purifier in water. • Unplug your Purifier from the wall outlet when not in use, when cleaning, or when filling with water. A. A short power-supply cord is provided to reduce the risks of becoming entangled in, or tripping over a longer cord. B. An extension cord may be used if care is exercised in its use. C. If an extension cord is used, (1) the marked electrical rating of the extension cord should be at least as great as the electrical rating of the appliance, (2) the longer cord should be arranged so that it will not drape over the countertop or tabletop where it can be pulled on by children or tripped over. HOW YOUR WATER PURIFIER WORKS The Purifier distills and turns ordinary tap water into clean, clear purified water. Uses for purified water include drinking, cooking, ice cubes, salt-restricted diets, baby formulas, steam irons, photo processing, and cleaning contact lenses. By heating water to boiling, the water is changed to steam, which rises. As the steam cools and turns back into water, it is collected in the storage jug. Impurities are left behind in the stainless steel tank. continued, page 3 HOW YOUR WATER PURIFIER WORKS continued from page 2 Order extra storage bottles from Sears, Stock No. 42-34552 so you can chill one bottle of purified water while you make more. It takes about 6 hours and 5 minutes (using cold tap water) to make 1 gallon of purified water. A plastic storage bottle that holds 4 quarts (1 gallon) is included with your Purifier. IMPORTANT: The Purifier uses small carbon filters in the spout to remove traces of odors before the purified water is collected in the storage bottle. The filters last about 2-3 months. A return of unwanted odor means the filters should be replaced. Order replacement carbon filter bags from Sears, Stock No. 42-34541. Purified water will remain fresher-tasting if it is kept tightly capped. Also shaking the bottle before pouring will aerate the water and make it taste better. BEFORE USING WATER FROM YOUR WATER PURIFIER FOR THE FIRST TIME Although care is taken so your Purifier and plastic storage bottle are clean, some harmless matter may remain from manufacturing, packaging, or shipping. This could leave an unwanted taste or odor in the purified water the first time you use it. To remove any taste or odor causing matter, do the following: 6. Put the cover onto the tank and plug the cover cord into the base receptacle. 7. The 2 carbon filter bags are packed in a separate plastic bag. Remove the carbon filter housing (push IN and pull DOWN... FIG. 2, page 5) and push 1 carbon bag firmly down into the housing. Follow with the second bag. PUSH BOTH BAGS INTO THE HOUSING AS FAR AS THEY WILL GO, OR WATER COULD OVERFLOW FROM THE HOUSING. Place the housing (push inward and upward) on the cover. 1. Set the Purifier on your counter or tabletop. 2. Looking at Fig. 1, unplug the cover cord from its receptacle. 3. Holding by the top strap, lift the cover upward to remove, then set aside. 8. Place the storage bottle under the spout, and plug the power cord into a wall outlet. 4. The storage bottle is insidethe Purifier. Pull it out and remove the cap. Keep the cap in a handy place. You will use it later. 9. Press the RESET button, if needed (pushed inward at the factory), to turn the Purifier on (fan motor begins to run). When the bottle contains 2 or 3 cupfuls of water, unplug the cover cord from the receptacle BUT DO NOT REMOVE THE COVER. 5. Rinse and fill the stainless steel tank with about 11/2quarts of water. continued, page 4. * ALWAYS LIFT BY Strap THE STRAP WHEN ,/ REMOVING THE COVER Strap _' Cover (Spout) Carbon Filter Housing Tank Storage Bottle Cord _._/ / Power Reset Button Plug Into 120V AC Electrical Outlet Cord BEFORE USING WATER FROM YOUR WATER PURIFIER FOR THE FIRST TIME continued from page 3 The remaining water will boil and pass through the system as steam to clean all surfaces. 10. The Purifier shuts off automatically when the water has boiled away (no more steam coming out of spout...takes about 3 hours). After this time, unplug the power cord at the wall outlet. 11. Shake the storage bottle, then discard the 2 or 3 cupfuls of water which may have some harmless carbon fines (very fine black particles) in it from the filter. MAKING PURIFIED WATER 1. Set the Purifier on your countertop or table. 2. Unplug the cover cord from its receptacle (FIG. 1). Holding by the top strap, lift the cover to remove, and set aside. 3. Fill the tank with tap water up to the max. fill line (4 quarts). The purifing cycle is shortened if you USE HOT WATER. NOTE: You can purify less than the full amount. Use this chart as a guide. DO NOT fill the tank with more than 4 quarts of water because the storage bottle will overflow. WHEN YOU FILL WITH COLD WATER TO... 1 2 3 4 qt. qt. qt. qt. (max. fill line) THE CYCLE TAKES ABOUT... 1 3 4 6 hr., 35 min. hrs., 5 min. hrs., 35 min. hrs., 5 rain. 4. Put the cover on the Purifier and plug the cover cord into the receptacle. 5. Check to be sure the cover spout containing the carbon filter is locked in place. 6. Set the storage bottle (cap removed) with the opening right under the spout. CARE AND CLEANING WARNING ALWAYS BE SURE TO UNPLUG THE PURIFIER POWER CORD FROM THE WALL OUTLET BEFORE CLEANING, OR BEFORE REPLACING PARTS. STAINLESS STEEL TANK INSIDE - After each use, rinse the inside with lukewarm tap water and remove any residue. If a deposit starts to form at the bottom, use Sears Distiller cleaner, Stock No. 42-34543. Follow the instructions on the cleaner bottle. Rub with a soft scouring pad and rinse thoroughly. 7. Plug the power cord into any 120 volt outlet. 8. Press the RESET button. The fan motor in the cover begins to run (check the cover cord plug-in if it does not). When the cycle is over the Purifier turns off automatically. AFTER THE FAN MOTOR GOES OFF, WAIT AT LEAST 30 MINUTES BEFORE REMOVING THE COVER... WARNING: NEVER REMOVE THE COVER WHILE THE FAN MOTOR IS RUNNING, OR FOR 30 MINUTES AFTER IT STOPS. YOU COULD GET SEVERE BURNS FROM THE BOILING WATER OR STEAM. 9. Unplug the Purifier power cord from the wall outlet. 10. Replace the cap on the storage bottle and store in the refrigerator until you neet it. 11. After the Purifier has cooled (wait for 30 minutes after the fan motor stops running) remove the cover and clean the tank. BE SURE TO HOLD THE COVER BY THE TOP STRAP AS YOU REMOVE IT OF YOUR WATER PURIFIER CAUTION: DO NOT IMMERSE IN WATER. THE PURIFIER OUTSIDE - Wipe the outside of your Purifier with a soft sponge and mild soap. NOTICE THERE ARE NO USER SERVICEABLE PARTS INSIDE. RETURN THE PURIFIER TO AUTHORIZED SERVICE PERSONNEL FOR REPAIR (SEE PAGE 6). CHANGING THE CARBON FILTER The carbon filters in the cover spout (FIG. 2, page 5), remove odors from the purified water. Replace the continued, page 5 CARE AND CLEANING OF YOUR WATER PURIFIER continued from page 4 carbon bags when you begin to get unwanted odor. The filters will last 2-3 months if the Purifier is used every day. They will last longer if you don't make purified water that often. Get new carbon bags from Sears, Stock No. 42-34541. Carbon Bag (2) Cover...,.! TO REPLACE // ...Remove the cover from the tank. ...Remove the carbon filter housing (push IN and pull DOWN) from the cover spout. Carbon ...Remove the used carbon bags and throw away. Rinse the inside of the housing with water. Filter Housing ...Push new carbon bags down intothe housing as far as they will go (see step 7 on page 3). ...Replace the housing onto the cover spout, and replace the cover on the tank. The next time you make purified water, discard the first 2 or 3 cupfuls which may have small, harmless, carbon fines in it. NOTE: The physiological effects of the operation of this appliance, beneficial or otherwise, have not been investigated by Underwriters Laboratories. See Product Data Sheet for test data obtained from an independent laboratory. PROBLEM 1. NOT MAKING ANY PURIFIED WATER NOT MAKING ENOUGH PURIFIED WATER EACH BATCH Purifier power cord not plugged into electrical outlet. 1. Cover cord not plugged into Purifier base receptacle. 2. No power to electrical outlet. , ° Cover cord not plugged into Purifier base receptacle. Did not press reset button to start cycle. 5. Did not fill the tank with tap water. 2. Did not fill tank with water to max. fill line. 3. Purifier cover gasket not sealing tightly on tank (be sure gasket is down, all the way around, against bottom lip on cover see Key No. 4, page 6). 4. Storage bottle not placed directly under spout. CHECK LIST STEAM COMING FROM SPOUT 1. Cover cord not plugged into Purifier base receptacle. WATER LEAKS FROM SPOUT 1. Carbon bags not pushed fully down into spout. 2. Spout not properly fastened to cover. REPAIR PARTS SEARS WATER PURIFIER, MODEL NO. 625.34440 KEY NO. 1 2 3 4 5 6 PART NO. 6550067 42-34541 6550011 6550013 6550068 42-34552 42-34543 6580181 DESCRIPTION OF PART Cover Assembly Carbon Filter (package of 4) Filter Housing Gasket Tank Assembly Storage Bottle [] Distiller Cleaner t Owners Manual [] Replacement bottle may look different than illustrated. • Not illustrated. t Not included with Purifier. NOTE: Other than listed above, the Sears Water Purifier has no other customer serviceable parts. Should service be required, take the purifier to any Sears Service Center. 6 I L i HOW TO ORDER REPAIR PARTS The model number of your Countertop Water Purifier is on the underside of the tank assembly. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING INFORMATION: - PART NUMBER - MODEL NUMBER - PART DESCRIPTION NAME OF ITEM ,All parts listed may be ordered from any Sears Service Center. If the parts you need are not stocked locally, your order will be electronically transmitted to a Sears Repair Parts Distribution center for handling. 6 6580181 (1/93)
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.2 Linearized : No Page Count : 6 Page Layout : SinglePage Page Mode : UseNone Producer : Goby Monitor Application version 4, 0, 0, 13 Create Date : Mon Jul 21 00:28:36 2008 Author : Title : Subject :EXIF Metadata provided by EXIF.tools