ARRIS BLUENILE Blue Nile OEM User Manual CERTIFICATE OF COMPLIANCE

ARRIS Group, Inc. Blue Nile OEM CERTIFICATE OF COMPLIANCE

Manual

Rhein Tech Laboratories, Inc. Client: Motorola Inc. CHS 360 Herndon Parkway Model: Blue Nile OEM Suite 1400 Standards: FCC 15.247 & RSS-210 FCC ID/IC: ACQBLUENILE/3231A-BLUENILEHerndon, VA 20170 http://www.rheintech.com Report #: 2007108 Page 43 of 49 Appendix K: User Manual Please refer to the following pages for the OEM Application Guide and Warranty, Safety and Regulatory information.
Blue Nile OEM Application Guide Document Nbr Version 0.1 Date 11/29/2006 Motorola Internal Use Only
TBlue Nile OEM Application Guide Revision History: Date Version Author Description 11/29/06 0.1 hblarson Initial draft 11/29/2006T Motorola Internal Use Only Page 2 of 9
TBlue Nile OEM Application Guide 11/29/2006T Motorola Internal Use Only Page 3 of 9 Table of Contents Revision History: .........................................................................................................................2 Table of Contents.........................................................................................................................3 Introduction................................................................................................................................4 Abbreviations and Acronyms.......................................................................................................4 Test Procedures...........................................................................................................................4 DC Power Requirements.............................................................................................................4 Test Set Up and Sample Preparation............................................................................................5 Downloading the BlueCore™3 firmware .....................................................................................5 Trimming the BlueCore™3 carrier frequency...............................................................................5 Operating the Blue Nile OEM module.........................................................................................6 Test Equipment ...........................................................................................................................6 Test Equipment List...................................................................................................................6 General Test Equipment ..........................................................................................................6 BlueCore™3 Firmware Download ..............................................................................................6 Test Equipment Setup................................................................................................................7 BlueCore™3 Flash Download and Carrier Frequency Trim Setup ....................................................7 Blue Nile Operational Setup .....................................................................................................7 DUT I/O Signal List.................................................................................................................8 DB25 Adapter Pin Assignments.................................................................................................9
TBlue Nile OEM Application Guide 11/29/2006T Motorola Internal Use Only Page 4 of 9 Introduction This document describes how to set up the Blue Nile OEM board for bench testing. Abbreviations and Acronyms Acronym Description BC03 BlueCore™3 BGA Ball Grid Array CAT5 Category 5 CODEC Coder/Decoder CSR Cambridge Silicon Radio DAC Digital to Analog Converter DC Direct Current DUT Device Under Test GPIB General Purpose Interface Bus HLD High Level Design I2S Inter-IC Sound IC Integrated Circuit MIC Microphone PS Key Persistent Store Key RF Radio Frequency SPI Serial Peripheral Interface WACA Wireless Audio Car Adapter Table 1. Abbreviations and Acronyms Figure 1. Blue Nile Block Diagram Test Procedures DC Power Requirements Specifications Units of Specification Nominal Lower Limit Upper LimitOperating Voltage VDC 13.5 10 16 Table 2. Power Supply Specifications
TBlue Nile OEM Application Guide 11/29/2006T Motorola Internal Use Only Page 5 of 9 Test Set Up and Sample Preparation Downloading the BlueCore™3 firmware Firmware is downloaded to the BC03 using a SPI connection from the computer parallel port through the Blue Nile test fixture to SPI pins on the DUT interface connector. 1. 2. 3. 4. 1. 2. 3. 4. 5. 6. 7. Make the connections as described in Figure 1. Start CSR BlueFlash application a. Choose LPT1 as output port. b. Depress Choose File and navigate to the location of the firmware download file. c. Depress Stop Processor. Download should become active. d. Depress Download The firmware download will run automatically. When download is done Depress Start Processor. Trimming the BlueCore™3 carrier frequency The carrier frequency will be trimmed at center band for minimum error. The maximum error must be less than ± 10 KHz. Make the connections as described in Figure 1. Start the BlueTest3 application. a. Choose SPI Transport b. Choose LPT1 Port c. Depress Ok LPT1 should open successfully. Select TXSTART in the RF Test Mode window a. Set LO Frequency to 2441 MHz. b. Depress Execute. c. Select CFG XTAL FTRIM in the RF Test Mode window. d. Depress Execute. Measure the RF carrier frequency using the RF Counter mode of a spectrum analyzer. Note whether the frequency is out of tolerance high or low. If the carrier frequency is within tolerance, proceed to Step 7. Otherwise, proceed to Step 6. If the measured carrier frequency is out of tolerance a. If the measured frequency is low, decrease the value in the Crystal Trim (hex) window. b. If the measured frequency is high, increase the value in the Crystal Trim (hex) window. c. Depress Execute. d. Return to Step 5. Open the PSTool application. Store the crystal trim value determined in Step 5 in PS Key 502 (PSKEY_ANA_FTRIM).
TBlue Nile OEM Application Guide 11/29/2006T Motorola Internal Use Only Page 6 of 9 Operating the Blue Nile OEM module 1. 2. 3. 4. 5. 6. 7. 8. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 1. 2. 3. 4. Connect the equipment as shown in Figure 2. Open the PSTool application. In the Filter window, type the string: User Configuration Data Scroll down and select User Configuration Data 7 The value of the PSKEY for User Configuration Data 7 will be displayed in the box on the upper right part of the display. If the value displayed for the PSKEY is 0000 0000, change the display to 1 and depress the SET button. Depress BC Reset button. The DUT will now be in Test Mode. Test Equipment Test Equipment List General Test Equipment Spectrum analyzer (frequency trim only) Desktop computer with Windows installed Bluetooth RF test system MMCX-SMA adapter 12V DC power supply Blue Nile test fixture CAT5 cable DB25-RJ45 adapter Windows Media Player application software or equivalent PSTools application program from CSR BlueSuite BlueTest application program from CSR BlueSuite (frequency trim only) BlueCore™3 Firmware Download DB25-RJ45 adapter CAT5 cable Blue Nile test fixture CSR BlueFlash application software from CSR BlueSuite
TBlue Nile OEM Application Guide 11/29/2006T Motorola Internal Use Only Page 7 of 9 Test Equipment Setup BlueCore™3 Flash Download and Carrier Frequency Trim Setup Connect the equipment as shown in Figure 1. 1. 2. For carrier frequency trim, connect spectrum analyzer as shown. Figure 1. BlueCore™3 Flash Download and Carrier Frequency Trim Setup Blue Nile Operational Setup Connect the Blue Nile as shown in Figure 2 for operational testing.
TBlue Nile OEM Application Guide 11/29/2006T Motorola Internal Use Only Page 8 of 9 Figure 2. Blue Nile operational test setup. DUT I/O Signal List Pin Signal Name Pin Signal Name 1 MIC IN I 2 VBAT I 3 DGND I 4 DGND I 5 iCRISP TX O 6 POWER ENABLE I 7 iCRISP RX I 8 EVENT OUT O 9 DGND I 10 DGND I 11 SPI CSB I 12 SPI MISO O 13 SPI CLK I 14 SPI MOSI I 15 AGND I 16 AGND I 17 RIGHT AUDIO OUT O 18 LEFT LINE INPUT I 19 LEFT AUDIO OUT O 20 RIGHT LINE INPUT I Table 3. DUT I/O Signal List
TBlue Nile OEM Application Guide 11/29/2006T Motorola Internal Use Only Page 9 of 9 DB25 Adapter Pin Assignments DB25 RJ45 Signal Name 2 1 Chip Select 5 2 10 3 MISO 4 4 8 5 MOSI 3 6 9 7 CLK 25 8 GND Table 4. DB25 Pin Assignments
Warranty, Safety and Regulatory Information iRadio® Blue Nile Wireless Audio Car Adapter Limited Warranty Wireless Audio Car Adapter (“Product”) Motorola warrants to you, the original end user customer, that the Product will be materially free from defects in materials and workmanship under normal use for a period of one (1) year from the date of purchase from Motorola or from an authorized reseller. To take advantage of this Limited Warranty please call Motorola at 1-866-289-6686 within the warranty period. Motorola's sole and exclusive obligation under this Limited Warranty shall be to repair or replace any Product that does not meet this Limited Warranty. All warranty claims must be made within the applicable Warranty Period. The Limited Warranty shall not apply: (i) to any Product subjected to accident, misuse, neglect, alteration, Acts of God, improper handling, improper transport, improper storage, improper use or application, improper installation, improper testing or unauthorized repair; or (ii) to cosmetic problems or defects which result from normal wear and tear under ordinary use, and do not affect the performance or use of the Product. Motorola's warranties apply only to a Product that is manufactured by Motorola and identified by Motorola owned trademark, trade name or product identification logos affixed to the Product. THERE ARE NO WARRANTIES OF ANY KIND RELATING TO THE PRODUCT, EXPRESS, IMPLIED OR STATUTORY, INCLUDING BUT NOT LIMITED TO IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE OR THE WARRANTY AGAINST INFRINGEMENT PROVIDED IN THE UNIFORM COMMERCIAL CODE. Some states do not allow for the exclusion of implied warranties, so the above exclusion may not apply to you. If you are purchasing the Product as a consumer then nothing in this limited warranty affects or limits any of your statutory rights as a consumer. While every reasonable effort has been made to ensure that you will receive a Product that you can use and enjoy, Motorola does not warrant that the functions of the Product will meet your requirements or that the operation of the Product will be uninterrupted or error-free. MOTOROLA IS NOT RESPONSIBLE FOR PROBLEMS OR DAMAGE CAUSED BY THE INTERACTION OF THE PRODUCT WITH ANY OTHER SOFTWARE OR HARDWARE. ALL WARRANTIES ARE VOID IF THE PRODUCT IS OPENED, ALTERED, AND/OR DAMAGED. THESE ARE YOUR SOLE AND EXCLUSIVE REMEDIES for any and all claims that you may have arising out of or in connection with this Product, whether made or suffered by you or another person and whether based in contract or tort. IN NO EVENT SHALL MOTOROLA BE LIABLE TO YOU OR ANY OTHER PARTY FOR ANY DIRECT, INDIRECT, GENERAL, SPECIAL, INCIDENTAL, CONSEQUENTIAL, EXEMPLARY OR OTHER DAMAGES ARISING OUT OF THE USE OR INABILITY TO USE THE PRODUCT (INCLUDING, WITHOUT LIMITATION, DAMAGES FOR INJURY, LOSS OF PROPERTY, BUSINESS PROFITS, BUSINESS INTERRUPTION, LOSS OF INFORMATION OR ANY OTHER PECUNIARY LOSS), OR FROM ANY BREACH OF WARRANTY, EVEN IF MOTOROLA HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. IN NO CASE SHALL MOTOROLA'S LIABILITY EXCEED THE AMOUNT YOU PAID FOR THE PRODUCT These matters are governed by the laws of the Commonwealth of Pennsylvania, without regard to conflict of laws principles and excluding the provisions of the United Nations Convention on Contracts for the International Sale of Goods.
FCC ID: ACQBLUENILE IC: 3231A-BLUENILE FCC Compliance Part 15 Note: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: --Reorient or relocate the receiving antenna. --Increase the separation between the equipment and receiver. --Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. --Consult the dealer or an experienced radio/TV technician for help. Caution: Changes or modifications not expressly approved by the responsible party for compliance could void the user’s authority to operate the equipment. This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation. FCC Declaration of Conformity Motorola Inc., Connected Home Solutions, 101 Tournament Drive, Horsham,PA 19044, 1-215-323-1000, declares that the Blue Nile OEM Wireless Audio Car Adapter and its associated models complies with 47 CFR Parts 2 and 15 of the FCC rules as a Class B digital device. FCC Certification This Product contains a radio transmitter and accordingly has been certified as compliant with 47 CFR Part 15 of the FCC Rules for intentional radiators. Products that contain a radio transmitter are labeled with FCC ID and the FCC logo.
MOTOROLA, Intelligence Everywhere, iRadio and the Stylized M Logo are registered in the US Patent & Trademark Office. All other product or service names are the property of their respective owners. All rights reserved. No part of the contents of this document may be reproduced or transmitted in any form or by any means without the written permission of the publisher. © Motorola, Inc. 2006. 530552-001 Rev A 03/06 MGBI

Navigation menu