Dimension One Spas Home Hot Tubs Users Manual D1 & @Home Export Planning Guide Install
Home Hot Tubs to the manual 47e3f2d2-d885-4f1d-ba90-7b1dbebdc8fe
2015-02-02
: Dimension-One-Spas Dimension-One-Spas-Home-Hot-Tubs-Users-Manual-425816 dimension-one-spas-home-hot-tubs-users-manual-425816 dimension-one-spas pdf
Open the PDF directly: View PDF 
.
Page Count: 36
| Download | |
| Open PDF In Browser | View PDF |
IV Table of Contents PRE-PURCHASE DECISIONS............................................................................................................... 1 BEFORE DELIVERY ........................................................................................................................... 1 Typical Installation Site.........................................................................................................................................................................1 SITE ACCESS...................................................................................................................................... 2 COVER ................................................................................................................................................. 2 INSTALLATION ..................................................................................................................................... 3 ELECTRICAL HOOK UP INSTRUCTIONS ................................................................................... 3 Electrical Requirements Chart for D 1 Hot Tubs .........................................................................................................................4 Electrical Requirements Chart for @ Home Hot Tubs...............................................................................................................5 INSTALLATION CHECK LIST ........................................................................................................ 5 ABOUT SMART HEAT (AVAILABLE ONLY ON DIMENSION ONE HOT TUBS)................. 5 MAINTENANCE ..................................................................................................................................... 6 DRAINING YOUR HOT TUB........................................................................................................... 6 CLEANING YOUR FILTER ............................................................................................................... 6 LIGHT BULB REPLACEMENT......................................................................................................... 6 CARING FOR YOUR HOT TUB COVER........................................................................................ 6 HOT TUB SPECIFICATIONS ............................................................................................................... 6 SPECIFICATIONS FOR DIMENSION ONE SPAS ........................................................................ 6 Arena.........................................................................................................................................................................................................7 Aurora II ...................................................................................................................................................................................................8 Aurora HP ................................................................................................................................................................................................9 Aurora XLT...........................................................................................................................................................................................10 Caliente..................................................................................................................................................................................................11 Caliente HP...........................................................................................................................................................................................12 Californian.............................................................................................................................................................................................13 Chairman...............................................................................................................................................................................................14 Chairman II...........................................................................................................................................................................................15 Diplomat................................................................................................................................................................................................16 Nautilus .................................................................................................................................................................................................17 Triad .......................................................................................................................................................................................................18 Triad II ...................................................................................................................................................................................................19 SPECIFICATIONS FOR @HOME HOT TUBS............................................................................. 20 Companion HP ....................................................................................................................................................................................20 Cove........................................................................................................................................................................................................21 Cove HP.................................................................................................................................................................................................22 Dream....................................................................................................................................................................................................23 Dream HP.............................................................................................................................................................................................24 Sojourn HP............................................................................................................................................................................................25 WIRING DIAGRAMS............................................................................................................................ 26 DIMENSION ONE SPAS ................................................................................................................. 26 @ HOME HOT TUBS ...................................................................................................................... 27 SPA INFORMATION ....................................................................................................................... 29 My Spa ..................................................................................................................................................................................................29 Dealer Information: ............................................................................................................................................................................29 Dimension One Spas Inc. Information ..........................................................................................................................................29 iii iv Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Pre-Purchase Decisions Before Delivery Before attempting to install or use your hot tub, please read these instructions thoroughly, and carefully view the video owner’s manual for your Dimension One hot tub! Because your hot tub is completely self-contained, you can install it just about anywhere you wish . . . on a deck, patio or even indoors. Just be sure to position it above ground, in an area with good drainage and on a level surface that fully contacts the bottom of the hot tub. Typical Installation Site A concrete slab is best but not required. You may choose to install it on a wood deck or bricks. If you choose to install your hot tub on a raised deck or indoors, we suggest you contact a structural engineer to confirm the surface will hold a hot tub filled with water. Settlement of your deck or slab may result in damage to the hot tub, which is not covered by warranty. (See specifications in this booklet.) Wherever you plan to install your hot tub, be sure the surface is flat and solid. Locate your hot tub so that the equipment is above grade and not subject to flooding. Water should always drain away from the hot tub. If you are placing your hot tub next to an obstacle, such as a fence or wall, be sure that you place the hot tub with the topside primary control panel facing forward for easy equipment access. Locate the vents on the drawing of your particular Dimension One hot tub. This is where cool air will enter and warm air will escape during hot tub operation. Please ensure that these areas are always free of obstructions. Also, allow additional space around the hot tub for any accessories you may have purchased - for example an E-Z Lifter® spa cover lift, steps, or a gazebo. Check with your dealer on these additional space requirements. In most cities and counties, permits are required for the installation of electrical circuits or the construction of exterior structures such as decks and gazebos. Some communities have also adopted residential barrier codes that may require fencing and/or self-closing gates on the property to prevent unsupervised access to a hot tub by young children. Note If you install the spa or hot tub indoors, the surrounding area should be waterproof or water resistant. Water may be splashed out during normal usage and when entering or exiting the spa. Dimension One Spas is not responsible for any water damage to any indoor location for any reason. Note Dimension One and @Home hot tubs are equipped with a locking cover that meets or exceeds the “Standard for Safety Covers,” but is not an adequate safety measure to prevent unsupervised entry. Please check with your local Building Permit Office that can inform you on any special requirements needed for installation of your electrical, decking or required barriers. Your local dealer may also provide you with information on local building and electrical codes. 1 Site Access Please refer to the drawings on pages 7 - 26 for the specifications and appropriate measurements for your hot tub model. You will need the measurements of your hot tub in order to determine the clearance needed for delivery. CAUTION: DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. Your hot tub will probably be delivered on a dolly or cart. The additional distance from the ground to the dolly or cart must also be included in your measurements for vertical clearance. Also, take into consideration that if your hot tub must be transported up-hill or taken upstairs, you may need additional clearance or assistance. Be sure to remove obstacles such as gates, planters, or items attached to the house. The point of entry must be clear of air conditioning units, heating units, meters, electrical boxes, etc. It is best that your dealer pre-inspect the installation site and determine the best way to deliver your hot tub. In rare cases, a crane must be brought in to assist in an installation. Your Dimension One dealer will supervise this for you. Here is a list of some of the most common installation hazards in planning your route: ! ! ! ! ! ! Gates Fences Eaves Gutters Air Conditioners Heaters ! ! ! ! ! Hose Bibs Bushes Overhanging Branches Steps 90° Turns Cover The cover supplied with your hot tub is constructed of the highest quality materials and is equipped with quick-release keyed buckle locks that meet standards set by American Standards for Testing and Measurement (ASTM). When the hot tub is not in use, it is recommended that the cover locks always be utilized to discourage unsupervised use and to minimize heat loss. When installing the cover on your hot tub, be sure it is facing the correct direction. When standing in front of the topside primary control panel, the center seam or hinge should run horizontally. You should be able to lift the handle of the cover and see the hot tub control panel. Allow 18 inches of extra space on the backside of the hot tub where the optional EZ Lifter will rest in its upright, open position. 2 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Installation Electrical Hook Up Instructions Do not turn on electrical power to your hot tub until told to do so later in this manual. Warning Have a licensed electrician run the required 240-volt power line to the hot tub installation site. The power inlet connection is located in the pedestal on the left side of the hot tub, approximately 25” from the front. This connection is designed to mate with a Carlon 1” conduit body Type LB, Access Fitting E986F or any 1” female PVC conduit fitting. The manufacturer’s label lists the power requirements for your hot tub. We recommend that only a licensed and bonded electrician do the initial hot tub hook-up. Note This unit requires a GFCI (Ground Fault Circuit Interrupter). We have provided an enclosed instructional flyer for a licensed electrician. A “line of sight” service disconnect must be located where visible from the hot tub, not less than 5 feet from the hot tub and not to exceed 50 feet from the hot tub. This requirement may be filled with the GFCI sub-panel. All supply wire to be rated minimum 90°C. To hook-up your hot tub, follow these instructions: 1. Remove the screws holding the equipment access panel to the front of the hot tub cabinet and set the panel aside. 2. Loosen the four screws located on the front of the black equipment control can and remove the door from the control can to allow access to the four wire connection terminal block. 3. Attach 1” rigid non-metallic conduit to the conduit nipple located in the pedestal base on the side of the hot tub and run required conductors through the conduit to the equipment can. 4. Connect the four wires to the equipment system terminal block (TB1) as indicated on the wiring diagram in the back of this manual. 5. Configure jumpers 1 and 2 on the upper right corner of the PC Board to match the circuit size being used for the hot tub (see Electrical Requirements Chart on the following page for proper wire size). See the chart below for the correct settings. 3 Electrical Requirements Chart for D 1 Hot Tubs Model Power Branch Circuit Circuit Protection Wire Gauge Arena 240V, 30A 240V, 24A 240V, 38A 240V, 32A 240V, 24A 240V, 38A 240V, 30A 240V, 24A 240V, 38A 240V, 32A 240V, 24A 240V, 40A 240V, 30A 240V, 50A 240V, 40A 240V, 30A 240V, 38A 240V, 32A 240V, 24A 240V, 38A 240V, 32A 240V, 24A 240V, 38A 240V, 32A 240V, 24A 240V, 38A 240V, 32A 240V, 24A 240V, 38A 240V, 32A 240V, 24A 240V, 30A 240V, 24A 240V, 30A 240V, 24A 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 40A 30A 50A 40A 30A 50A 40A 30A 50A 40A 30A 40A 30A 50A 40A 30A 50A 40A 30A 50A 40A 30A 50A 40A 30A 50A 40A 30A 50A 40A 30A 40A 30A 40A 30A #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #6 AWG #8 AWG #6 AWG #8 AWG #6 AWG #8 AWG Aurora II Aurora HP Aurora XLT Caliente Caliente HP Californian Chairman Chairman II Diplomat Nautilus Triad Triad II 4 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Electrical Requirements Chart for @ Home Hot Tubs Model Companion HP Cove Cove HP Dream Dream HP Sojourn HP Power 240V, 24A 240V, 29A 240V, 24A 120V, 12A 240V, 32A 240V, 24A 240V, 24A 240V, 32A 240V, 24A 240V, 32A 240V, 24A Branch Circuit 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground* 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground 3 wire + ground Circuit Protection 30A 40A 30A 15A 40A 30A 30A 40A 30A 40A 30A Wire Gauge #8 AWG #6 AWG #8 AWG #12AWG #6 AWG #8 AWG #8 AWG #6 AWG #8 AWG #6 AWG #8 AWG *A GFCI protected cord is required (P/N 1560-09) The power inlet connection is located in the pedestal on the left side of the hot tub, approximately 25" from the front. The front of the hot tub is the section that includes the topside, primary control panel. Installation Check List ! ! ! ! ! ! ! ! ! ! Owner’s Manual Hot Tub Cover Locks on Hot Tub and Cover Cabinet Care Filter Use, Removal and Cleaning GFCI Location Electrical Disconnect Location How to Fill and Drain Hot tub How to Use the Topside Primary Control Instructions for your Ultra Pure Water Management System, CrystalZone, or CD ClearZone Ozone Generators & Water Management Systems ! ! ! ! ! ! ! ! Drain Valve and Hose Bib Changing Light Lens Cap Selector Valve Control Adjusting/Interchanging Jets Adjusting the NeckFlex Jet Pillow and Interchangeable Jets Water Care Guide Automatic Bromine Feeder (Optional) The Use of the Optional PureVision Cartridges Please check these items before you fill your hot tub with water: About Smart Heat (Available Only on Dimension One Hot Tubs) Smart Heat provides maximum heat recovery using the amperage that you have available. Through computerized load sharing, the system automatically recognizes the temperature differential and the number of jet pumps in use, compares it with the available power and adjusts the heater to maximize heater output. 5 Maintenance Draining Your Hot Tub Locate the hose bib at the bottom of the hot tub, on the pedestal, to the left of the equipment compartment on Dimension One hot tubs, and to the right on @Home hot tubs. This is where you can hook-up your hose for hot tub draining. Cleaning Your Filter Your hot tub is equipped with one or two top access filter cartridges. For optimum performance and water quality, we recommend that you clean the filters every month. Before you fill your hot tub, practice removing and reinstalling a filter cartridge. The EZ Lock Filter does not require excessive force to remove or install. “Finger-tip” pressure is all that is needed. Note Light Bulb Replacement Notice the location of the light. To change the bulb, drain hot tub below the level of the light and unscrew the light cover using the special tool provided in the owner’s manual packet. Never try to remove the light housing cover without the special tool. Note Caring For Your Hot Tub Cover The thermal cover for your hot tub is an extremely durable foam insulated product. See the manufacturer’s literature for proper cleaning instructions. When the hot tub is not in use, it is recommended that the cover locks always be utilized to discourage unsupervised use and to minimize heat loss. Hot Tub Specifications The following section of this manual gives you detailed information on the sizes of both Dimension One and @Home hot tubs. Dimension One hot tubs are listed first, alphabetically by model, followed by @Home hot tubs in the same order. Specifications for Dimension One Spas These specifications include: • spa shape, • dimensions, • electrical requirements, • water capacity, • type and number of Hydrotherapy Jets, • weight, • type of Water Management System, • number and type of pumps, • type of skirt, • type and number of controls 6 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Arena DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 7 Aurora II DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 8 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Aurora HP DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 9 Aurora XLT DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 10 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Caliente DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 11 Caliente HP DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 12 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Californian DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 13 Chairman DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 14 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Chairman II DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 15 Diplomat DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 16 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Nautilus DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 17 Triad DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 18 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Triad II DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 19 Specifications for @Home Hot Tubs Companion HP DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 20 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Cove DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 21 Cove HP DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 22 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Dream DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 23 Dream HP DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 24 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Sojourn HP DUE TO MANUFACTURING TOLERANCES THERE COULD BE SOME MINOR DIFFERENCES BETWEEN THE ACTUAL MEASUREMENTS OF YOUR SPA AND THE DRAWING BELOW. IF SITE PLANNING IS CRITICAL TO SUCH TOLERANCES, BE SURE TO MEASURE YOUR ACTUAL SPA. 25 Wiring Diagrams Dimension One Spas 26 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual @ Home Hot Tubs 27 28 Dimension One Spas and @ Home Hot Tubs Export Planning Guide and Installation Manual Spa Information It is very important that you gather the following information on your spa and enter it in the blanks provided below. The Warranty Card should also be completed at the same time, and submitted to the address below. This information will be required if you ever want to purchase additional items for your spa, or if service is ever required. Be sure to consult with your Dealer to ensure the accuracy of this important information. My Spa Model Name: Serial Number: Date Purchased: Date Installed: Notes: Dealer Information: Dimension One Spas Inc. Information 2611 Business Park Drive Vista, California 92083 800.345.7727 760.727.7727 fax 760.734.4425 www.D1Spas.com www.AtHomeHotTubs.com 29 30
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.2 Linearized : Yes Modify Date : 2002:08:22 10:07:40-06:00 Create Date : 2002:08:22 10:03:51-07:00 Page Count : 36 Creation Date : 2002:08:22 17:03:51Z Mod Date : 2002:08:22 17:03:51Z Producer : Acrobat Distiller 5.0 (Windows) Author : jdorman Metadata Date : 2002:08:22 17:03:51Z Creator : jdorman Title : D1 & @Home Export Planning Guide & Install Manual Page Mode : UseOutlines Tagged PDF : YesEXIF Metadata provided by EXIF.tools