965 0231(10/1/08)_BGE 0231 BGE BGEL Parts
User Manual: 965-0231-BGE-BGEL-parts
Open the PDF directly: View PDF .
Page Count: 60
Download | |
Open PDF In Browser | View PDF |
Parts Manual RV Generator Set BGE BGEL English 10−2008 965−0231 (Issue 1) To avoid errors or delay in filling your parts order, always give the MODEL, SPEC NO. and SERIAL NO. from the Onan nameplate. For handy reference, insert your nameplate information in the spaces below. MODEL AND SPEC NO. SERIAL NO. DIGITAL CONTROL SOFTWARE VERSION AND DATE (IF APPLICABLE) The following symbols are used in Onan manuals to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe. This symbol warns of immediate hazards which will result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or death. This symbol refers to a hazard or unsafe practice which can result in severe personal injury or product or property damage. Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on. Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil. Contact with ASBESTOS has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing! Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing! PSP-1 Introduction This parts catalog applies to the standard generator sets listed below. Parts are arranged in groups of related items and each illustrated part is defined by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and specification number from your generator set nameplate, select parts that apply to your set. Right and left sides are detemined by facing the engine end (front ) of the set. Generator Set Data Table Model Identification 3.5BGEL 53CR 31813 3.5BGEL 53CR 31814E 3.5BGE 53CR 29236F 3.5BGE 53CR 29237F 3.5BGE FN 31813 3.5BGE FN 31814 3.5BGE FR 31813P 3.5BGE FR 31814P 4.0BGEL 1R 26110E 4.0BGEL 1R 26111E 4.0BGE 1R 26100 4.0BGE 1R 26101 4.0BGE 1R 26109 4.0BGE FN 29236 4.0BGE FN 29237 4.0BGE FN 37593 4.0BGE FA 11500P 4.0BGE FA 26100P 4.0BGE FA 26101P 4.0BGE FA 26109P 4.0BGE FA 26110A−P 4.0BGE FA 26111A−P 4.0BGE FA 55215A−P 4.0BGE FR 26103A−P 4.0BGE FR 26104A−P 4.0BGE FR 29236P 4.0BGE FR 29237P 5.0BGE FA 730P 5.0BGE FA 11579P 5.0BGE FA 26100A−P 5.0BGE FA 26101A−P Rating Fuel Voltage 3,500 Watts 3,500 Watts 3,500 Watts 3,500 Watts 3,500 Watts 3,500 Watts 3,500 Watts 3,500 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 4,000 Watts 5,000 Watts 5,000 Watts 5,000 Watts 5,000 Watts LP Liquid LP Liquid Gasoline Gasoline LP Liquid LP Liquid LP Liquid LP Liquid LP Liquid LP Liquid Gasoline Gasoline Gasoline Gasoline Gasoline Gasoline LP Vapor Gasoline Gasoline Gasoline LP Liquid LP Liquid Gasoline Gasoline Gasoline Gasoline Gasoline Gasoline Gasoline Gasoline Gasoline 120/240 120/240 120/240 120/240 115/230 115/230 115/230 115/230 120 120 120 120 120 115/230 115/230 115/230 120 120 120 120 120 120 120 100 100 115/230 115/230 120 120 120 120 Hertz Phase 50 50 50 50 50 50 50 50 60 60 60 50 50 50 50 50 60 60 60 60 60 60 60 60 60 50 50 60 60 60 60 * − The specification number denotes customer requested options or deviations from a standard (1A, 1B, etc.) model. The specification letter advances (A, to B, to C, etc.) with major manufacturing changes. 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 Index Adapter, Carburetor, 30 Adapter, Cleaner − Air, 17, 21 Adapter, Exhaust, 35 Adapter, Filter − Oil, 14 Adapter, Generator, 45 Adapter, Hose − Fuel, 17 Adapter, Preheater, 17 Adapter, Reducer, 21 Arm, Governor, 15 Assy, Choke Shaft, 23 Connector, Conduit, 45 Connector, Hose, 30 Connector, Housing (8 Pin), 42 Connector, Receptacle, 45 Connector, Tab, 45 Control, 47 Control, Ignition, 25 Control, Start − Remote, 42, 43 Cover, Block − Brush, 45 Cover, Box − Breaker, 27 Cover, Choke, 17 Cover, Control, 47 Cover, Housing − Choke, 17 Cover, Inlet − Air, 17 Cover, Switch − Rocker, 47 Cover, Valve − RH, 7 Crankshaft, 11 Cup, Governor, 10 Cup, Intake − Oil Pump, 13 Backplate, Scroll, 33 Baffle, Valve − Breather, 7 Ball, Bearing, 15 Ball, Governor, 10 Base, Box − Breaker, 27 Base, Oil, 13 Bearing, Camshaft, 7 Bearing, Crankshaft, 7 Bearing, Needle, 15 Bearing, Ring − Collector, 45 Bimetal, Choke, 17 Block, Brush, 45 Block, Cylinder, 7 Board, Circuit − Printed, 47 Bowl, Fuel, 24 Box Assy, Breaker, 27 Brace, Rear, 38, 39, 40, 41 Brace, Side, 38, 39, 40 Bracket, 40 Bracket, Cable − Governor Adjust, 22 Bracket, Coil − Ignition, 25 Bracket, Control − Ignition, 25 Bracket, Exhaust, 35 Bracket, Gas Regulator, 31 Bracket, Governor, 22 Bracket, Holder − Fuse, 47 Bracket, Housing, 38, 39, 41 Bracket, Lifting, 33 Bracket, Line − Fuel, 21 Bracket, Manifold − Exhaust, 35, 37 Bracket, Mounting − Diaphragm, 17 Bracket, Mounting − Filter, 21 Bracket, Mounting − Housing, 17, 21 Bracket, Regulator − Gas, 30 Breaker, Circuit, 47 Bridge, Rectifier, 45 Brush, Block, 45 Bushing, Governor, 10 Bushing, Reducer, 21 Drain, Filter − Oil, 14 Elbow, 21, 48 Elbow, Inlet, 17 Elbow, Inverted, 19 Elbow, Male, 21 Elbow, Male − Inverted, 17 Elbow, Reducing, 21 Elbow, Street, 21, 30 Element, Choke, 17 Element, Cleaner − Air, 17, 21 Element, Filter − Fuel, 21 Exhaust System, 35, 37 Fan, Armature, 45 Filter, Fuel, 17 Filter, Oil, 14 Filter, Tube − Breather, 9 Fitting, Vacuum − Intake, 17 Flange, Exhaust Manifold, 35 Flywheel, 11 Fuel System (Gasoline), 17, 19 Fuel System (LP Liquid), 21 Fuel System (LPG) Field Conversion, 30, 31 Fuse, 47, 51 Gasket Kits, 52 Gasket, Adapter − Air Intake, 30 Gasket, Adapter − Oil Filter, 14 Gasket, Airhorn, 31 Gasket, Base − Oil, 13 Gasket, Bowl, 24 Gasket, Box − Breaker, 27 Gasket, Carburetor, 31 Gasket, Exhaust, 35, 37 Gasket, Filter − Oil, 13, 14 Gasket, Head − Cylinder, 7 Gasket, Horn − Air, 17, 21 Gasket, Manifold − Exhaust, 35, 37 Gasket, Manifold − Intake, 17, 21 Gasket, Mounting − Carburetor, 17, 21 Gasket, Mounting − Gearcase, 15 Gasket, Plate, 25 Gear, Armature, 45 Gear, Camshaft, 10 Gear, Crankshaft, 11 Gearcase, 15 Generator, 45 Cable, Adjust − Governor, 22 Cable, Plug − Spark, 25, 26 Camshaft, 10 Cap, Drive, 29 Cap, End, 29 Cap, End − Drive, 29 Cap, Fill − Oil, 13 Cap, Valve, 7 Cap, Vinyl, 17 Carburetor, 17, 21 Carburetor (Gasoline), 23 Carburetor (LP), 24 Carburetor Kits, 52 Carburetor, LPG (Emissions), 31 Coil, Ignition, 25, 26 Condenser, Ignition, 26, 27 Connector, 25 2 Index Governor, 22 Grommet, Rubber, 38, 39, 40, 41 Guard, Breaker − Circuit, 47 Guard, Scroll, 33 Guide, Valve, 7 Hanger, Exhaust, 35 Hanger, Pipe − Exhaust, 37 Harness, Charger − Battery, 45 Harness, Wiring, 14, 42, 49, 51 Harness, Wiring − AC Outlet, 47 Harness, Wiring − Fuel Pump, 17 Harness, Wiring − Ignition Relay, 21 Harness, Wiring − PCB #1, 47 Harness, Wiring − PCB #3, 49 Harness, Wiring − Remote, 50 Harness, Wiring − Voltage Regulator, 47 Head, Cylinder, 7 Holder, Fuse, 47, 51 Hose, Fuel, 17, 21, 30, 31 Hose, Oil (Vent), 30, 31 Hose, Preheater, 17 Hourmeter, 43 Housing − Below Floor, (Specs 26109, 37593), 40 Housing − Below Floor Models (1985−1992), (Specs 26101, 26104, 26111, 29237, 31814), 38 (Begin 1992), (Specs 26101, 26104, 26111, 29237, 31814), 39 (Commercial Applications), 41 Housing, Air, 33 Housing, Breather, 7 Housing, Choke, 17 Housing, Cleaner − Air, 17, 21 Housing, Cylinder − Air, 33 Housing, Cylinder − Air, 33 Housing, Stator, 45 Hub, Cup − Governor, 10 Kit, Repair − Carburetor, 23 Kit, Ring − Piston, 9 Kit, Vacuum Sustain Valve, 23 Kit, Vacuum Valve Hose, 23 Label, Kit Number, 31 Label, Caution, 40 Label, LP Kit, 31 Label, Preheat, 17 Label, Warning, 38, 39, 40, 41 Labels, 52 Lead, Box − Breaker, 27 Lead, Bracket − Filter Mounting, 21 Lead, Resistor, 45 Lead, Starter, 28 Lever, Shaft − Throttle, 24 Line, Fuel, 17, 21 Link, Spring − Governor, 15 Linkage, Choke, 17 Linkage, Choke − Pull−off, 17 Lock, Spring − Valve, 7 Manifold, Exhaust, 21, 35, 37 Manifold, Intake, 17, 21 Muffler, Arrester − Spark, 35 Muffler, Arrestor − Spark, 37 Needle, Adjust − Idle, 24 Nipple, Close, 21 Nipple, Pipe, 30 O’Ring, Cap − Oil Fill, 13 O’Ring, Housing − Stator, 45 Paint, 52 Pan, Drip, 13, 38, 39, 40, 41 Panel Rear, 40 Panel, Control, 42, 43 Panel, Housing, 38, 39, 41 Panel, Left Hand, 40 Panel, Right Hand, 40 Pin, Alignment − Gear Cover, 7 Pin, Center − Camshaft, 10 Pin, Dowel − Governor Cup Stop, 15 Pin, Drive − Bearing Stop, 7 Pin, Hinge, 38, 39, 40, 41 Pin, Piston, 7 Piston, 7 Plate, Bearing − Rear, 7 Plate, Cover − Ignition Plunger, 25 Plate, Hinge, 38, 39, 40 Plate, Throttle, 24 Plug, Bowl, 24 Plug, Button − Dot, 33 Plug, Cap, 48 Plug, Drain − Oil, 13 Plug, Head − Square, 30 Plug, Hole, 47 Plug, Hole − Core, 7 Plug, Pipe − Hex, 19, 21 Plug, Spark, 25, 26 Plug, Welch − Camshaft, 7 Plunger, Point − Breaker, 27 Plunger, Valve − Bypass, 7 Points, Breaker, 27 Potentiometer, 47 Pull−off, Choke, 17 Pump, Fuel − Electric, 17 Ignition System, 26 Ignition, Electronic, 25 Insert, Seat − Valve, 7 Insert, Valve Seat, 7 Insulator, Board − PC, 47 Insulator, Fuse, 47 Insulator, Terminal − Start, 47 Isolator, Vibration − Engine End, 13 Isolator, Vibration − Generator End, 13 Jet, Idle, 23 Jet, Power, 23 Joint, Ball, 22 Key, Gear − Crankshaft, 11 Key, Woodruff, 10 Kit Assembly, Drive, 29 Kit, Choke Bimetal, 23 Kit, Choke Pulloff Breaker, 23 Kit, Conversion, 31 Kit, Conversion − LP, 30 Kit, Damper − Governor, 22 Kit, Drive − Starter, 29 Kit, Float − Carburetor, 23 Kit, Gasket − Engine, 7 Kit, Gasket − Oil Pump, 7 Kit, Key − Blower Wheel, 11 Kit, LP Accessory, 31 Kit, Remote Control, 42, 43 3 Index Pump, Oil, 7 Spring, By−pass, 17 Spring, Compression, 22 Spring, Governor, 22 Spring, Needle − Idle, 15, 24 Spring, Screw − Main Jet, 24 Spring, Stop − Throttle, 24 Spring, Valve, 7 Spring, Valve − Breather, 7 Spring, Valve − Bypass, 7 Starter, 28 Starter Components, 29 Stator, Generator, 45 Strap, Ground, 13 Strap, Muffler, 35 Stud, Adjustment − Speed, 22 Stud, Grounding, 45 Stud, Long Extended Shaft, 45 Support, 40 Support, Hinge, 38, 39, 40, 41 Support, Housing, 38, 39, 41 Switch, Pressure − Low Oil, 14 Switch, Rocker, 42, 43, 47 Rectifier, 21, 49 Reed, Valve − Breather, 7 Regulator, Gas, 30, 31 Regulator, LP, 21 Regulator, Voltage, 47 Relay (K4), 51 Relay, Ignition, 21 Resistor, Charger − Battery, 45 Resistor, Pump − Fuel, 45 Resonator, Exhaust, 35 Retainer − Push−on, 22 Ring, Collector − Armature, 45 Ring, Retainer − Choke Housing, 17 Ring, Retaining − Camshaft, 10 Ring, Retaining − Crankshaft, 11 Ring, Retaining − Piston, 7 Ring, Tolerance, 45 Rod, Arm − Governor, 22 Rod, Connecting, 9 Rod, Inlet − Air, 17 Rod, Throttle, 22 Rotor Assembly, Ignition, 25 Rotor, Generator, 45 Tappet, Valve, 7 Thread Sealant, 52 Tie, Cable, 28, 45, 47 Tube, Breather, 17, 21, 48 Tube, Bypass − Breather, 48 Tube, Exhaust, 35, 37 Tube, Housing − Choke, 17 Tube, Idle, 24 Tube, Oil − Cylinder Block, 7 Scroll, 33 Seal, Dust, 24 Seal, Dust − Rubber, 24 Seal, Oil − Crankshaft Front, 15 Seal, Oil − Crankshaft Rear, 7 Seal, Oil − Governor Shaft, 15 Seal, Valve − Intake, 7 Shaft, Governor, 15 Shield, Noise, 33 Snubber, Isolator, 13 Solenoid, Liquid − LP, 21 Solenoid, Start, 47 Solenoid, Vapor − LP, 30 Spacer, Brace, 41 Spacer, Mounting − Pump, 17 Spacer, Muffler, 35 Spring, Brush − Generator, 45 Valve, Exhaust, 7 Valve, Fuel Shutoff, 31 Valve, Intake, 7 Valve, Shut−off − Fuel, 21 Valve, Shut−off − Oil Base, 13 Wheel, Blower, 11 Yoke, Governor, 15 4 5 Cylinder Block 30 41 25 58 26 30 23 41 24 38 27 21 32 26 43 22 32 26 31 43 37 1 8 33 7 49 50 51 52 2 16 11 10 5 6 4 3 19 34 9 14 42 28 35 20 13 11 48 47 45 36 57 15 12 18 44 29 17 40 56 55 54 53 46 6 39 Cylinder Block REF NO. PART NO. QTY USED 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 517−0048−01 1 800−0575 5 800−0051 5 104−0776 1 101−0804 101−0804−02 101−0804−10 101−0804−20 101−0804−30 104−0575 101−0809 101−0439−01 101−0405 509−0041 516−0072 120−1320 1 1 1 1 1 2 1 1 2 1 4 1 110−1824 110−1824−02 110−1824−05 110−1824−10 110−1824−25 2 2 2 2 2 110−0197 110−0197−10 2 2 101−0805 101−0805−02 101−0805−10 101−0805−20 101−0805−30 1 1 1 1 1 110−3527 110−3526 114−0392 870−0533 2 2 4 4 850−0050 526−0402 516−0141 123−1175 123−1173 123−1174 110−1879−01 123−1649 5 5 2 1 1 1 1 1 PART DESCRIPTION Block, Cylinder (See Short Block Catalog #932−0109) Plug, Welch − Camshaft Screw, Cap Spec F−H, Flanged Head (3/8−16 x 1−1/8”) Begin Spec J, Hex Head (3/8−16 x 1−1/4”) Shim, End Play − Crankshaft Bearing, Crankshaft − Rear (Includes Thrust Washer) Standard .002” Undersize .010” Undersize .020” Undersize .030” Undersize Washer, Thrust Gasket, Plate − Bearing Plate, Bearing − Rear Bearing, Camshaft Seal, Oil − Crankshaft Rear Pin, Drive − Bearing Stop Tube, Oil − Cylinder Block Insert, Valve Seat − Exhaust Standard .002” Oversize .005” Oversize .010” Oversize .025” Oversize Insert, Valve Seat − Intake Standard .010” Oversize Bearing, Crankshaft − Front Standard .002” Undersize .010” Undersize .020” Undersize .030” Undersize Guide, Valve Exhaust Intake Bolt, Rod − Connecting Nut, Self−Locking (5/16−24) Washer Spec F−H, Lock (3/8”) Begin Spec J, Flat (3/8”) Pin, Alignment − Gear Cover Reed, Valve − Breather Baffle, Valve − Breather Spring, Valve − Breather Cover, Valve − Right Hand Housing, Breather REF NO. PART NO. QTY USED PART DESCRIPTION 26 27 110−3709 3 115−0006 115−0006−02 115−0006−05 110−3479 4 4 4 2 30 110−3480 110−3515 800−0010 2 2 2 31 32 33 34 110−3485 110−3511 509−0289 803−0071 4 8 2 2 35 36 110−3181 2 37 110−3509 110−3508 110−3487 1 1 4 38 39 40 526−0018 526−0122 800−0571 1 18 18 41 42 43 44 526−0063 517−0067 110−3510 2 1 4 45 46 47 48 168−0189 168−0192 120−0491 120−0161 740−1004 800−0007 1 1 1 1 2 2 49 801−0049 1 50 51 52 53 526−0066 120−0140 120−0398 1 1 1 112−0264 112−0264−05 112−0264−01 112−0264−02 112−0264−03 112−0229 518−0311 2 2 2 2 2 2 4 Gasket, Cover − Valve Tappet, Valve Standard .002” Oversize .005” Oversize Valve, Intake Valve, Exhaust Stellite Standard Screw, Cap − Hex Head (1/4−20 x 1−3/4”) Spring, Valve Lock, Spring − Valve Seal, Valve − Intake Screw, Set − Socket (3/8−16 x 5/8”) Gasket, Head − Cylinder Head, Cylinder Right Side Left Side Washer, Retaining − Valve Spring Washer, Flat (1/4”) Washer, Flat (5/16”) Screw, Cap − Hex Head (5/16−18 x 2−1/4”) Washer, Flat − Copper (1/4”) Plug, Hole − Core Cap, Valve Kit, Gasket Carbon Removal/Valve Grind Engine, Complete Pump, Oil Kit, Gasket − Oil Pump Washer, Flat (M6) Screw, Cap − Hex Head (1/4−20 x 1”) Screw, Cap − Hex Head (3/8−24 x 7/8”) Washer, Flat − Copper (3/8”) Spring, Valve − Bypass Plunger, Valve − Bypass Piston (Includes Pin and Retaining Rings) Standard .005” Oversize .010” Oversize .020” Oversize .030” Oversize Pin, Piston Ring, Retaining 28 29 54 55 7 Cylinder Block 30 41 25 58 26 30 23 41 24 38 27 21 32 26 43 22 32 26 31 43 37 1 8 33 7 49 50 51 52 2 16 11 10 5 6 4 3 19 34 9 14 42 28 35 20 13 11 48 47 45 36 57 15 12 18 44 29 17 40 56 55 54 53 46 8 39 Cylinder Block REF NO. PART NO. QTY USED 56 113−0314 113−0314−05 113−0314−10 113−0314−20 113−0314−30 2 2 2 2 2 113−0310 113−0310−05 113−0310−01 113−0310−02 113−0310−03 2 2 2 2 2 PART DESCRIPTION REF NO. Kit, Ring − Piston Specs E−H Standard .005” Oversize .010” Oversize .020” Oversize .030” Oversize Begin Spec J Standard .005” Oversize .010” Oversize .020” Oversize .030” Oversize PART NO. 57 58 9 114−0397 114−0397−10 114−0397−20 114−0397−30 123−1871 QTY USED PART DESCRIPTION Rod, Connecting (Includes Bolt and Nut) 2 Standard 2 .010” Undersize 2 .020” Undersize 2 .030” Undersize 1 Filter, Tube − Breather Camshaft 5 7 8 3 4 6 1 REF NO. 1 2 3 4 5 PART NO. 150−0078 150−1519 150−1520 510−0015 515−0001 9 2 QTY USED 1 1 1 10 1 PART DESCRIPTION Ring, Retaining Hub, Cup − Governor Cup and Bushing, Governor Ball, Governor Key, Woodruff 10 REF NO. PART NO. QTY USED PART DESCRIPTION 6 7 105−0637 105−0700 1 1 8 9 105−0541 150−0075 1 1 Camshaft (Includes Center Pin) Gear, Camshaft (Includes Gear, Spacer and Plate) Washer, Thrust Pin, Center − Camshaft Crankshaft and Flywheel 4 7 2 1 REF NO. 1 2 3 4 5 PART NO. 104−0170 526−0356 526−0017 134−4342 518−0014 5 3 QTY USED 1 1 1 1 1 8 6 9 10 PART DESCRIPTION Screw, Cap − Hex Head Washer, Flat (7/16”) Washer, Flat (7/16”) Wheel, Blower Ring, Retaining 11 REF NO. PART NO. QTY USED 6 7 8 9 10 104−0043 104−0032 515−0263 515−0001 104−1735 1 1 1 1 1 PART DESCRIPTION Washer, Gear Gear, Crankshaft Kit, Key − Blower Wheel Key, Gear − Crankshaft Crankshaft (Includes Keys) Oil Base and Mounting Hardware 2 16 20 1 21 19 7 18 22 6 5 15 23 14 3 13 10 4 24 11 12 8 10 9 12 17 Oil Base and Mounting Hardware REF NO. 1 PART NO. QTY USED 102−1493 102−1458 102−1387 1 1 1 403−2557−02 − 1 1 4 403−2218−01 402−0597 1 2 5 821−0010 4 6 7 526−0325 815−0657 2 2 8 402−0549 1 9 821−0016 2 2 3 PART DESCRIPTION REF NO. PART NO. QTY USED PART DESCRIPTION Base, Oil Spec F−P Begin Spec N Gasket, Base − Oil Pan, Drip Above Floor Models Below Floor Models (See Below Floor Housing Pages) Begin Spec J Isolator, Vibration − Generator End Screw, Hex Washer Head − Self−Locking (1/4−20 x 1/2”) Washer, Flat (3/8”) Screw, Hex Head − Thread Form (3/8−16 x 2−3/4”) Isolator, Vibration − Engine End Screw, Hex Washer Head − Self Locking (5/16−18 x 3/4”) 10 821−0031 2 11 12 13 14 526−0324 526−0240 337−2311 821−0014 1 1 1 1 15 16 856−0008 123−1616 2 1 17 18 504−0150 800−0058 1 4 19 20 21 22 23 24 526−0251 123−1961 509−0096 505−0266 102−0743 402−0547 4 1 1 1 1 2 Screw, Hex Washer Head − Self Locking (3/8−16 x 3/4”) Washer, Flat (5/16”) Washer, Flat (3/8”) Strap, Ground Screw, Hex Washer Head − Self Locking (5/16−18 x 1/2”) Washer, Lock − EIT (5/16”) Cup, Intake − Oil Pump (Includes Pipe And Cup) Valve, Drain − Oil Screw, Cap − Hex Head (3/8−16 x 3”) Washer, Flat (3/8”) Cap, Fill − Oil O’Ring, Cap − Oil Fill Plug, Drain − Oil (3/8”) Gasket, Drain − Oil Snubber, Isolator 13 Oil Filter 6 2 3 8 10 1 9 5 7 4 REF NO. PART NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED PART DESCRIPTION Adapter, Filter − Oil (Includes Screws) Washer, Flat − Copper (5/16”) Screw, Cap − Hex Head (5/16−18 x 1”) Drain, Filter − Oil Screw, Cap − Hex Washer Head − Thread Forming (#10−32 x 3/8”) Gasket, Adapter − Oil Filter 7 8 9 10 122−0645 309−0322 122−0502 1 1 1 338−2041 338−2634 1 1 338−2086 338−2635 1 1 Filter, Oil Switch, Pressure − Low Oil Gasket, Filter − Oil Harness, Wiring (See Separate Page for Components) Gasoline Spec F−G Begin Spec H LP Spec F−G Begin Spec H 1 122−0814 1 2 526−0065 2 3 800−0028 2 4 5 122−0360−50 815−0340 1 2 6 122−0771 1 14 Gearcase 15 17 18 14 16 2 13 3 4 12 8 7 11 6 5 9 10 1 REF NO. PART NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED Gearcase Assy (Includes Parts Marked*) *Arm and Shaft, Governor *Seal, Oil − Governor Shaft *Bearing, Needle *Ball, Bearing *Pin, Stop − Governor Cup *Yoke, Governor *Screw, Machine − Pan Head (#8−32 x 3/8”) *Seal, Oil − Crankshaft Front Gasket, Gearcase Washer, Flat − Copper (5/16”) Screw, Cap − Hex Head 1−3/4” Long 2−3/4” Long 13 14 15 16 150−1998 870−0328 141−0710 820−1077 1 1 1 1 17 851−0031 1 18 870−0257 1 1 103−0772 1 2 3 4 5 6 7 8 150−2002−04 509−0008 510−0013 510−0014 516−0130 150−1187 815−0046 1 1 1 1 1 1 2 509−0040 103−0810 526−0065 1 1 5 114−0022 800−0545 4 1 9 10 11 12 PART DESCRIPTION *Link, Spring − Governor *Nut, Self−Lock (#10−32) *Spring, Needle − Idle *Screw, Pan Head (#10−32 x 2−1/2”) *Washer, Spring − Conical Disc (#10) Nut, Hex − Self−Locking (5/16−18) * − Parts Included In Gearcase Assy. 15 Fuel System (Gasoline) 49 53 37 38 18 19 48 41 47 40 13 9 23 24 46 45 44 20 21 25 8 36 26 36 5 27 31 12 6 3 67 66 17 4 56 7 11 22 64 1 16 10 43 15 32 50 34 30 35 54 39 55 51 33 52 54 6 14 42 28 2 61 14 60 57 32 65 62 29 58 54 59 61 54 55 14 55 16 28 63 Fuel System (Gasoline) REF NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED PART DESCRIPTION 154−2447 815−0587 1 2 29 815−0664 1 141−0950 141−0958 862−0015 1 1 1 146−0455 146−0577 146−0630 1 149−2080 149−2293 149−2319 149−2334 149−2335 98−6105−01 1 1 1 1 1 1 1 815−0692−01 1 1 1 1 815−0692−02 1 7 502−0002 502−1108 153−0555 8 9 140−2308 815−0590 1 3 33 34 154−2495 800−0033 2 4 10 153−0556 1 518−0387 1 11 815−0592 2 12 153−0561 1 35 36 37 38 39 40 41 42 740−1006 503−0813 140−1919−50 123−1615 149−2226 503−1133 503−0183 338−2285 4 2 1 1 2 1 1 1 13 14 518−0450 1 43 153−0578 1 1 1 1 1 1 1 44 45 46 517−0223 526−0002 120−0140 1 1 1 15 16 149−2140 149−2269 149−2331 149−2331−02 153−0554 153−0557 47 17 815−0591 2 48 49 50 145−0667 145−0704 145−0561 503−1351 153−0579 1 1 1 1 1 18 800−0017 1 19 20 21 526−0021 140−2379 1 1 51 52 870−0421 518−0466 1 1 53 518−0459 1 140−1894 140−2962 153−0558 1 1 1 54 815−0290 2 24 1 1 1 55 56 853−0013 140−2782 140−3093 153−0577 25 26 153−0576 503−1252 1 1 57 58 149−2279 149−2333 149−1353 370−4052 1 1 1 1 1 2 27 28 502−1105 502−0313 1 1 Manifold, Intake Screw, Hex Washer Head Gasket, Mounting − Carburetor Spec F−J Begin Spec K Nut, Hex (5/16−18) Carburetor (Includes Mounting Gasket) (See Separate Page for Components) Spec F−J Begin Spec K Begin Spec L & Up Elbow, Male − Inverted 90° Spec F Begin Spec G Element and Cover, Choke (Spec F−J) Gasket, Horn − Air Screw, Cap − Hex Head (#10−32 x 1/2”) Housing, Choke (Includes Choke Shaft) (Spec F−J) Ring, Retainer− Choke Housing (Not Shown) Screw, Head − Hex Washer (#8−32 x 1−3/8”) (Spec F−J) Bracket, Mounting − Diaphragm (Spec F−J) Clip, U (Spec F−J) Pump, Fuel − Electric (Includes Mounting Bracket) Spec F,G Spec H Begin Spec J Begin Spec K Bimetal, Choke (Spec F−J) Bracket, Mounting − Housing (Spec F−J) Screw, Head − Hex Washer (1/4−10 x 3/4”) (Spec F−J) Screw, Cap − Hex Head (1/4−20 x 3−1/2”) Washer, Flat (1/4”) Element, Cleaner − Air Housing, Cleaner − Air Spec F−K Spec L Linkage, Choke (Spec F−J) Adapter, Cleaner − Air Spec F−K Spec L Linkage, Pull−off − Choke (Spec F−J) Pull−off, Choke (Spec F−J) Hose, Vacuum (Spec F−J) (3/16” ID x 3” Long) Fitting, Vacuum − Intake 90° Elbow, 90° 59 60 503−1313 502−1164 1 1 Screw, Thread Form Torx (1/4−20 x 3/8”) Line, Fuel (Includes 2 Inverted Nuts) Spec F Spec G Spec H Begin Spec J (Four Bends) Begin Spec J (Three Bends) Label, Preheat Screw Hex, Machine − 60 Hz (1/4−20 x 1/2”) Pan Head − 50 Hz (1/4−20 x 1”) Gasket, Manifold − Intake Spec F−H Screw, Cap − Hex Head (5/16−18 x 2”) Washer, Flat (M8) Clamp, Hose Adapter, Preheater Tube, Breather Washer, Pump − Fuel Clamp, Hose − Breather Tube Clamp, Hose − Breather Tube Harness, Wiring − Fuel Pump (Includes Rectifier) Tube, Housing − Choke (Spec F−J) Cap, Vinyl Washer, Flat (#6 Screw) Spring, By−pass Rod, Inlet − Air Spec F−J Used on Spec K Cover, Inlet − Air Hose, Preheater Cover, Housing − Choke (Spec F−J) Nut, Cap (#6−32) (Spec F−J) Clip, Housing − Choke (Spec F−J) Clip, Hose − Preheater (Spec F−J) Screw, Torx − Thread Form (1/4−20 x .62”) Washer, ET (1/4”) 50 Hz Filter, Fuel Spec F−G Begin Spec J Filter, Fuel (Spec H) Spacer, Mounting − Pump (Begin Spec H) Hose, Fuel (Begin Spec H) Adapter, Hose − Fuel (Begin Spec H) 1 2 3 4 5 6 22 23 PART NO. 30 31 32 17 Fuel System (Gasoline) 49 53 37 38 18 19 48 41 47 40 13 9 23 24 46 45 44 20 21 25 8 36 26 36 5 27 31 12 6 3 67 66 17 4 56 7 11 22 64 1 16 10 43 15 32 50 34 30 35 54 39 55 51 33 52 54 6 14 42 28 2 61 14 60 57 32 65 62 29 58 54 59 61 54 55 14 55 18 28 63 Fuel System (Gasoline) REF NO. PART NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED Clip, Wire (Begin Spec H) Clamp, Hose (Begin Spec H) Screw, Pan Head − Torx (Begin Spec J) Plug, Pipe − Hex Head (Begin Spec K) 65 502−0065 1 66 67 740−1006 800−0033 4 4 61 62 63 518−0515 503−0170 815−0782 2 2 1 64 502−0028 1 19 PART DESCRIPTION Elbow, Inverted − 45° (Begin Spec J) Washer, Flat (M8) Screw, Hex Head Cap Fuel System (LP Liquid) 39 43 46 45 44 53 36 35 33 30 41 25 24 38 10 37 28 27 52 14 29 32 15 41 12 22 42 31 13 40 26 18 21 19 49 20 51 3 9 23 5 58 50 8 56 48 55 16 4 11 47 34 17 7 57 6 54 1 2 20 Fuel System (LP Liquid) REF NO. 1 PART NO. QTY USED 154−2447 154−3026 815−0587 1 1 2 141−0281 862−0015 1 2 6 7 8 9 141−0932 146−0723 505−1426 307−1886 140−2308 815−0590 1 1 1 1 1 3 10 815−0261 2 11 821−0005 1 12 503−0183 2 503−1365 503−0633 1 1 15 16 17 148−0893 148−1020 541−0532 502−0927−01 307−2559−01 815−0591 1 1 1 1 1 2 18 800−0017 1 19 20 21 22 23 24 526−0021 140−2379 140−1894 502−0838 140−2782 815−0647 1 1 1 1 1 2 25 26 27 850−0040 502−0935 2 1 28 148−0896 148−0903 148−0890 1 1 1 29 30 148−0898 815−0692−01 1 1 31 502−0932−01 1 502−0933−01 1 502−0054 1 2 3 4 5 13 14 32 PART DESCRIPTION REF NO. PART NO. QTY USED Manifold, Intake Spec F−K Begin Spec L Screw, Head − Hex Washer (5/16−18 x 1”) Gasket, Mounting − Carburetor Nut, Hex (5/16−18) Carburetor (See Separate Page For Components) Spec F−K Begin Spec L (LPG Liquid) Plug, Pipe (1/8”) (Spec F−K) Relay, Ignition Gasket, Horn − Air Screw, Cap − Hex Head (#10−32 x 1/2”) Screw, Head −Hex Washer (1/4−20 x 1/2”) Screw, Cap − Hex Washer (#10−32 x 1/2”) Clamp, Hose (9/16 to1−1/16”) Hose, Fuel Spec F−K (8” Long) Spec L & Up (7−1/4” Long) Regulator Spec F−K Begin Spec L (LPG Vapor) Begin Spec L (LPG Liquid) Bushing, Reducer (3/8 x 1/4”) Bracket, Mounting − Zinc Plated Screw, Head − Hex Washer (1/4−10 x 3/4”) Screw, Cap − Hex Head (1/4−20 x 3−1/2”) Washer, Flat (1/4”) Element, Cleaner − Air Housing, Cleaner − Air Elbow, Reducing − 90° Adapter, Cleaner − Air Screw, Hex Washer Head (1/4−20 x 5/8”) Washer, Lock (1/4”) Elbow, 90‘ Bracket, Mounting − Filter Bottom Outlet Exhaust Front Outlet Exhaust Filter, LPG (Includes Element and O−Rings) Element, Filter − Fuel Screw, Head − Pan (1/4−20 x 1/2”)) Elbow, Street − 45° (Front Outlet, Exhaust Manifold) Elbow, Male − 90° Front Outlet, Exhaust Manifold − LP Liquid Bottom Outlet, Exhaust Manifold 33 307−2478 1 34 35 154−2495 502−0928−01 2 1 36 37 38 501−0525 336−9679 815−0664 1 1 1 39 1 40 502−0965−01 1 41 502−0929−01 1 42 307−2501 1 43 815−0176 1 44 45 46 47 870−0221 503−1190 526−0003 800−0033 1 1 1 4 48 49 50 740−1006 123−1615 503−0183 4 1 1 51 503−1133 1 52 53 54 148−0897 149−2032−01 1 1 338−2317 1 338−2644 1 338−2317 1 357−0067 1 323−1440 323−1486 1 1 332−0147 332−0806 1 1 332−1992 332−1993 2 2 55 56 57 58 PART DESCRIPTION Solenoid, Lock − Fuel (Front Outlet − Exhaust Manifold) − LP Liquid Gasket, Manifold − Intake Adapter, Reducer (Front Outlet − Exhaust Manifold) Line, Fuel Lead Screw, Torx − Thread Form (1/4−20 x 3/8”) Manifold, Exhaust (See Exhaust System Pages) Elbow, Reducing − 45° (Bottom Outlet, Exhaust Manifold) − LP Gas Nipple, Close (Bottom Outlet, Exhaust Manifold) Valve, Fuel Shut−off − LP Gas (Bottom Outlet, Exhaust Manifold) Screw, Machine − Hex Head (#8−32 x 1/2”) Nut, Hex (#8−32) Clamp, Hose Washer, Flat (#8) Screw, Cap − Hex Head (5/16−18 x 2”) Washer, Flat (M8) Tube, Breather Clamp, Hose − Breather Tube (9/16 to 1−1/16”) Clamp, Hose − Breather Tube (Fits Hose O.D. .875”) Washer, Mounting − Regulator Bracket, Fuel Line − Zinc Plated Harness, Wiring − Ignition Relay BGE Spec F−G (Includes Parts Marked *) Begin Spec H (Includes Parts Marked +) BGEL (Includes Parts Marked *) *+Rectifier, Silicon Pin, Contact * Brass, Gold Plated + 13 Ampere Terminal, Ring * #10 − Red + #8 − Blue Terminal, Receptacle * Red + Blue * − Parts Included in Wiring Harness. + − Parts Included in Wiring Harness. 21 Governor 9 10 8 15 2 1 5 3 4 14 13 6 1 11 7 REF NO. PART NO. QTY USED PART DESCRIPTION REF NO. Nut, Hex − Self−Locking (#10−32) Stud, Adjustment − Speed Spring, Governor Bracket, Governor − Zinc Plated Gasoline LP Liquid Clip, Retaining − BGE (Spec H) Rod, Governor BGE Gasoline LP BGEL Joint, Ball Cable, Adjust − Governor (Begin Spec H) Bracket, Cable − Governor Adjust 10 11 1 870−0131 2 2 3 4 150−0096 150−1612 1 1 150−1958−02 150−2298−01 518−0006 1 1 1 7 8 150−1957 150−2079 150−2493 150−0939 150−2294 1 1 1 1 1 9 150−2295 1 5 6 12 13 14 15 12 PART NO. QTY USED PART DESCRIPTION 518−0582 150−2421 1 1 150−2428 150−2468 150−2589 1 1 3 518−0606 1 150−2454 1 150−2493 1 Retainer − Push On °*Spring, Compression (Begin Spec H) Rod, Throttle * Gasoline ° LP Liquid/Vapor °*Washer, Friction (Begin Spec H) °*Clip, Linkage (Begin Spec H) Kit, Damper Gasoline (Includes Parts Marked *) LP (Includes Parts Marked °) * − Included in Gasoline Damper Kit. ° − Included in LP Damper Kit. 22 Carburetor Components (Gasoline) 9 8 7 10 4 5 3 1 2 REF NO. PART NO. QTY USED 146−0455 1 146−0577 146−0630 1 1 1 2 3 146−0449 146−0450 146−0453 1 1 1 4 146−0457 1 5 146−0588 1 PART DESCRIPTION REF NO. PART NO. QTY USED PART DESCRIPTION Carburetor, Complete (Includes Mounting Gaskets) Spec F−J (Includes Carb 146−0443) Begin Spec K Begin Spec L (Emission Carb) Jet, Idle (Not EMSN Part) Jet, Power (Not EMSN Part) Kit, Float (Includes Float, Pin and Valve and Set Screw) Kit, Repair (Includes Repair Package and Gaskets Used on Pre Spec L only) Kit, Choke Bimetal (Includes Holder, Thermostat Cover, Set Plate and Case Set Screw) 6 146−0663 1 7 146−0589 1 8 146−0590 1 9 146−0591 1 10 146−0592 1 Kit, Auto Choke (Includes Carb and Gaskets after Spec L) Kit, Choke Breaker (Includes Piston Rod, Link Washer, Snap Pin and Breaker) Kit, Vacuum Sustain Valve (Includes Body, Jet and Filter) Kit, Vacuum Valve Hose (Includes Valve and Hoses) Assy, Choke Shaft (Includes Choke Shaft, Collar, Arm Return Spring, Valve, Set Screw and Lever) * − Carburetors beginning with Spec L are emission Carbureators and can’t be rebuilt. 23 Carburetor Components (LP) 15 8 12 6 14 5 3 9 2 16 4 13 7 1 11 10 REF NO. 1 2 3 4 5 6 PART NO. QTY USED 141−0932 146−0723 146−0727 141−0708 141−0906 141−0919 141−0940 141−0935 1 1 1 1 2 1 1 1 141−0938 141−0978 1 1 PART DESCRIPTION REF NO. PART NO. QTY USED Carburetor, Complete Spec F−K Spec L & Up (LPG Liquid) Spec L & Up (LPG Vapor) Bowl, Fuel Screw, Head − Round Washer Plate, Throttle Seal, Dust Spring, Needle − Idle Tube, Idle − Rubber Spec F−K Begin Spec L 7 8 9 10 11 12 13 14 15 16 141−0701 141−0700 141−0711 141−0736 141−0077 141−0934 141−0936 141−0939 141−0937 141−0924 1 1 1 1 1 1 1 1 1 1 24 PART DESCRIPTION Gasket, Bowl Screw, Stop − Throttle Spring, Stop − Throttle Plug, Bowl Washer, Plug − Bowl Screw, Adjust − Main Jet Lever, Shaft − Throttle Spring, Screw − Main Jet Needle, Adjust − Idle Seal, Rubber − Dust Electronic Ignition Begin Spec G 12 11 7 2 9 8 1 14 5 3 18 15 4 17 10 16 13 6 REF NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED 160−1368 160−1345−01 1 1 11 800−0004 2 12 166−0771 1 166−0761 1 166−0820 1 4 815−0290 2 166−0821 166−0821−01 815−0650 1 1 2 5 166−0842 1 870−0328 2 6 7 167−0263−01 2 166−0789−01 1 167−1615−01 167−1602 740−1004 166−0770 1 1 2 1 166−0747 1 17 815−0770 2 18 332−3198 1 166−0793 1 Gasket, Plate Plate, Cover − Ignition Plunger − Zinc Plated Coil, Ignition (Includes Nuts) Through S/N G923938483 During Spec J Begin S/N G923938484 During Spec J Screw, Head − Hex Washer Thread Form (1/4−20 x 5/8”) Rotor Assembly, Ignition (Includes Rotor and Magnet) Plug, Spark Cable, Plug − Spark 9” Long 23” Long Washer, Flat (M6) Nut, Flange − Hex (M4) (Positive Terminal) Bracket, Control − Ignition 1 2 3 8 9 10 PART NO. 13 14 15 16 25 PART DESCRIPTION Screw, Cap − Hex Head (1/4−20 x 5/8”) Nut, Flange − Hex (M5) (Negative Terminal) Control, Ignition 15.0” Lead 28.5” Lead Screw, Head − Hex Washer (1/4−20 x 1”) Nut, Self−Lock (10−32) Bracket, Coil − Ignition Through S/N G923938483 During Spec J Begin S/N G923938484 During Spec J Screw, Head − Hex Washer Thread Form Connector Ignition System Spec E, F 3 3 9 1 12 2 6 10 5 11 7 4 REF NO. 8 PART NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED Coil, Ignition (Includes Nuts and Washers) Clamp, Coil Cable, Plug − Spark 9” Long 26” Long Screw, Head − Hex Washer Thread Cutting (1/4−20 x 1/2”) Condenser, Ignition Washer, Lock (M8) 7 160−1325 1 8 160−1368 1 9 10 167−0272 802−0034 2 2 11 12 850−0038 166−0554 2 2 1 166−0772 1 2 3 166−0747 4 167−1602 167−1602 815−0261 1 1 1 1 1 5 6 312−0249 850−2005 1 2 26 PART DESCRIPTION Box, Breaker (See Separate Page For Components) (Includes Mounting Gasket) Gasket, Mounting − Breaker Box Plug, Spark Screw, Cap − Socket Head (1/4−20 x 3/4”) Washer, Lock − Spring (1/4”) Nut, Hex (8 MM) Breaker Box Spec E, F 2 7 1 11 5 3 6 8 9 10 4 REF NO. 1 2 3 4 5 PART NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED 160−1325 1 160−1317 160−1316 1 1 312−0246 1 6 7 8 9 10 11 850−0038 160−1183 160−1314 160−1368 336−2378 2 1 1 1 1 312−0256 1 815−0358 815−0340 1 1 160−1151 802−0034 1 2 Box Assy, Breaker (Includes Parts Marked *) *Clip, Cover − Breaker Box *Cover, Box − Breaker Condenser, Ignition Units Built Prior to 9/87 − Mounts Inside Breaker Box Units Built Beginning 9/87 − Mounts Remote Attached to Generator Adapter Plunger, Points − Breaker *Screw, Cap − Socket Head (1/4−20 x 3/4”) PART DESCRIPTION *Washer, Lock − Spring (1/4”) *Points, Breaker *Base, Box − Breaker *Gasket, Box − Breaker Lead, Box − Breaker *Screw, Hex Head − Slotted Thread Form (#8−32 x 5/16”) Use Prior to 9/87 Begin 9/87 * − Parts Included In Breaker Box. 27 Starter 3 4 1 7 6 5 2 8 REF NO. PART NO. QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED Starter, 12 Volt (See Separate Page For Components) Lead, Starter (Includes Tube) Screw, Hex Head − Cap (3/8−16 x 1−1/2”) 4 5 6 7 8 850−0050 332−0942 850−0040 862−0001 862−0003 2 1 1 2 2 1 191−1667 1 2 3 226−3457 800−0052 1 2 28 PART DESCRIPTION Washer, Lock (3/8”) Tie, Cable Washer, Lock (1/4”) Nut, Hex (1/4−20) Nut, Hex (3/8−16) 7 Starter Components 2, 4 3,5 REF NO. 1 PART NO. QTY USED 191−1667 1 191−2158 1 1 2 3 191−1781 191−1776 191−2187 1 1 1 4 5 191−2186 191−2187 1 1 PART DESCRIPTION Starter, 12 Volt (Spec F−K Thru S/N 1933079632 During Spec K) (Includes Parts Marked*) Starter, 12 Volt (Begin S/N 1933079633 During Spec K) (Includes Parts Marked #) *Cap, End (Includes Brushes) *Cap, End − Drive *Kit, Drive − Starter (Includes Spring Cover, Clutch Retainer, Clutch, Spline, Gear, Roll Pin and Hardware) #Cap, Drive #Kit Assembly, Drive (Includes Washers, Retainers, Spring, Cover, Roll Pin, Pinion Gear, and Drive Clutch) * − Parts Included in Starter Units Thru S/N 1933079632 During Spec K. # − Parts Included in Starter Units That Begin S/N 1933079633 During Spec K. 29 LP Vapor Fuel System Field Conversion Kit 148−0913 (Spec F−L) 6 7 19 4 1 23 8 20 14 13 17 15 11 19 16 3 7 12 10 6 18 9 5 REF NO. PART NO. 21 22 2 11 QTY USED PART DESCRIPTION REF NO. PART NO. QTY USED PART DESCRIPTION Kit, LP Conversion (Spec F−L) (Includes all Parts on this Page) Bracket, Regulator − Gas Regulator, Gas Clamp, Insulated (1/4” OD) Hose, Oil (Vent ) − 12” Long Hose, Fuel − 30” Long Clamp, Hose (#4) Connector, Hose Nut, Hex (1/4−20) Connector, Hose Elbow, Street − 90° Nipple, Pipe (3/4 x 3.00 Lg) Solenoid and Terminal 14 15 16 505−0057 854−0010 813−0117 1 3 3 17 18 19 20 140−2308 850−0040 526−0018 114−0023 2 2 2 2 21 800−0028 2 22 870−0257 2 23 148−0912 1 Plug, Head − Square Washer, Lock − IT (#10) Screw, Machine − Round Head (#10−32 x 1−5/8”) Gasket, Adapter − Air Intake Washer, Lock (1/4”) Washer, Flat (1/4”) Screw, Cap − Hex Head (1/4−20 x 1−1/4”) Screw, Cap − Hex Head (5/16−18 x 1”) Nut, Hex − Self Locking (5/16−18) Adapter, Carburetor 1 148−0913 1 2 3 4 5 6 7 8 9 10 11 12 13 148−0843 148−0311 518−0350 503−1016 503−1048 503−0183 502−0238 862−0001 502−0395 505−0051 505−0332 307−1881 1 1 1 1 1 2 1 2 1 2 1 1 30 LP Vapor Fuel System Field Conversion Kit 148−1057−01 & 148−1108−01 (Begin Spec M) 23 22 27 15 23 24 28 21 4 23 27 24 23 17 22 26 16 30 11 12 29 25 21 17 29 7 16 19 18 1 20 REF NO. 1 PART NO. QTY USED 148−1057−01 1 148−1108−01 1 2 3 4 5 G−267 98−7315−08 140−2308 141−0958 1 1 2 1 6 146−0727 1 7 148−1107 1 8 9 10 11 G−328 98−6455 505−0120 800−0028 1 1 1 2 12 870−0257 2 13 853−0013 1 PART DESCRIPTION Kit, Conversion LPG Vapor (Begin Spec M) (Includes Parts Marked #) LPG Vapor (Begin Spec M) (Includes Parts Marked <) #
Source Exif Data:File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.4 Linearized : Yes Encryption : Standard V2.3 (128-bit) User Access : Print, Extract, Print high-res Page Mode : UseOutlines XMP Toolkit : 3.1-702 Producer : Acrobat Distiller 7.0.5 (Windows) Creator Tool : BroadVision, Inc. Modify Date : 2008:10:10 14:59:15-05:00 Create Date : 2008:10:02 13:47:02-05:00 Metadata Date : 2008:10:10 14:59:15-05:00 Format : application/pdf Title : 965-0231(10/1/08)_BGE Creator : ci419 Document ID : uuid:58186ec8-ab87-4afd-b479-e014f303fcf8 Instance ID : uuid:adbbef0c-3645-4bc4-9122-2f87c5782c67 Page Count : 60 Page Layout : OneColumn Author : ci419EXIF Metadata provided by EXIF.tools