965 0267 Onan BGM (spec A H) RV Genset Parts Manual (09 1998)
User Manual: 965-0267 Onan BGM (spec A-H) RV Genset Parts manual (09-1998)
Open the PDF directly: View PDF 
.
Page Count: 58
| Download | |
| Open PDF In Browser | View PDF |
RV
GenSet Parts Manual
BGM
To avoid errors or delay in filling your parts order,
always give the MODEL, SPEC NO. and SERIAL
NO. from the Onan nameplate.
For handy reference, insert your nameplate information in the spaces below.
MODEL AND SPEC NO.
SERIAL NO.
DIGITAL CONTROL SOFTWARE VERSION
AND DATE (IF APPLICABLE)
The following symbols are used in Onan manuals
to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe.
This symbol warns of immediate hazards which will result in
severe personal injury or death.
This symbol refers to a hazard
or unsafe practice which can result in severe personal injury or
death.
This symbol refers to a hazard
or unsafe practice which can result in severe personal injury or
product or property damage.
Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this
catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.
Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA
state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine
oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.
Contact with ASBESTOS has been identified by a United States federal agency and some USA state
agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all
necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing!
Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified
by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take
all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing!
PSP-1
Introduction
This manual applies to the standard Recreational Vehicle Generator Set as listed in the Generator Set Data Table.
Parts are arranged in groups of related items and each illustrated part is identified by a reference number corresponding to the same reference number in the parts list. Parts illustrations are typical. Using the model and specification
number from your generator set nameplate, select parts that apply to your set. Right and left sides are determined by
facing the engine end (front) of the set.
Generator Set Data Table
MODEL**
WATTS
5BGM–FA/*
5.5BGM–FA/
5000
5500
ELECTRICAL DATA
VOLTS
HERTZ
WIRE
120
120
60
60
2
2
PHASE
1
1
* – The diagonal line (/) in the model and specification number separates generator set
characteristics from the specification number and letter. The specification number
denotes customer requested options of deviations from a standard (26105A) model.
The specification letter advances (A to B, B to C, etc.) with major manufacturing
changes.
** – See Back of Book for W/D Information.
1
2
Index
Actuator, Governor, 17
Adapter, Air Cleaner, 19
Adapter, Generator, 27
Adapter, Oil Drain, 26
Adapter, Oil Fill Tube, 25
Adapter, Oil Filter, 23
Adapter, Preheater, 19
Coil, Ignition, 27
Components, Carburetor, 20
Connector, Conduit, 37
Connector, Fuel Tank Barbed Hose, 35
Connector, Hose, 19
Control, 39
Control, Ignition, 27
Controller, Governor, 31
Coupling, Fuel Tank Hose, 35
Cover, Air Housing Cylinder, 33
Cover, Air Housing Top, 33
Cover, Air Inlet, 19
Cover, Breaker Box Opening, 7
Cover, Brush Block Access, 37
Cover, Choke, 19
Cover, Choke Housing, 19
Cover, Control, 39
Cover, Governor Access, 33
Cover, Switch, 39
Cover, Tailpipe Access, 29
Cover, Underfloor Housing Rear Panel, 34
Cover, Valve, 7
Crankshaft, 12
Cup, Governor, 10
Cup, Oil Pickup, 24
Backplate, Air Housing, 33
Baffle, Breather Valve, 7
Ball, Gearcase Bearing, 14
Ball, Governor, 10
Base, Oil, 24
Bearing, Camshaft, 9
Bearing, Crankshaft, 7, 9
Bearing, Generator Rotor Ball, 37
Bearing, Governor Shaft Needle, 14
Block, Cylinder, 7, 9
Block, Generator Brush, 37
Block, Terminal, 39
Board, PC, 39
Bracket, Cable Adjust, 16
Bracket, Choke Mounting, 19
Bracket, Diaphragm Mounting, 19
Bracket, Fuel Pump, 31
Bracket, Fuse Holder, 39
Bracket, Governor, 16
Bracket, Ignition Coil, 27
Bracket, Ignition Control, 27
Bracket, Oil Fill Tube Support, 25
Bracket, Relay, 39
Bracket, Resistor Mounting, 22
Bracket, Voltage Regulator, 39
Breaker, Circuit, 39
Brush, Generator, 37
Bushing, Fuel Tank Reducer, 35
Bushing, Isolator, 31
Diaphragm, Pulloff, 19
Diode, 43
Drain, Oil Filter, 23
Elbow, Carburetor, 19
Elbow, Hose, 19
Element, Air Cleaner, 19
Element, Thermostat, 19
Exhaust Options, 29
Extension, Oil Drain, 26
Fan, Generator, 37
Filter, Breather Tube, 7
Filter, Fuel, 19
Filter, Oil, 23
Fitting, Vacuum, 19
Flange, Exhaust Manifold, 29
Float Package, 20
Fuse, Control Panel, 39
Fuse, Engine Harness, 41
Cable, Governor Flexible Adjust, 16
Cable, Spark Plug, 27
Cable, Starter, 21
Camshaft (Begin Spec B), 11
Camshaft (Spec A), 10
Cap, Air Inlet Rod Vinyl, 19
Cap, Intake/Exhaust Valve, 7
Cap, Oil Fill, 24
Cap, Starter Drive, 21
Capacitor, 27
Carburetor, 19
Clip, Air Housing Moulding, 33
Clip, Choke Housing Tube Retaining, 19
Clip, Control Rod Retaining, 16
Clip, Diaphragm Mounting ”U”, 19
Clip, Fuel Line Retainer, 31
Clip, Fuse, 39
Clip, Preheater Hose, 19
Clip, Spark Plug Wire, 33
Clip, Throttle Rod, 17
Gasket, Air Horn, 19
Gasket, Bearing Plate, 7
Gasket, Breaker Box Opening, 7
Gasket, Carburetor Mounting, 19
Gasket, Cylinder Head, 7
Gasket, Exhaust Manifold, 28
Gasket, Gearcase (Begin Spec B), 15
Gasket, Gearcase (Spec A), 14
Gasket, Intake Manifold, 19
Gasket, Oil Base, 24
Gasket, Oil Drain Adapter, 26
3
Index
Key, Crankshaft Gear, 12
Kit, Carburetor Repair, 20
Kit, Choke Bimetal, 20
Kit, Choke Breaker, 20
Kit, Choke Shaft, 20
Kit, Engine Gasket, 50
Kit, Oil Pump Gasket, 50
Kit, Piston Ring, 7
Kit, Remote Panel (Spec A–F), 43
Kit, Remote Panel (Switch Only) (Begin Spec G), 45
Kit, Remote Panel (Switch/Hourmeter) (Begin Spec G), 46
Kit, Remote Panel (Switch/Voltmeter) (Begin Spec G), 47
Kit, Starter Drive, 21
Kit, Valve Grind Gasket, 50
Gasket, Oil Filter Adapter, 23
Gasket, Side/Bottom Exhaust Tube, 28
Gasket, Valve Cover, 7
Gear, Camshaft (Begin Spec B), 11
Gear, Camshaft (Spec A), 10
Gear, Crankshaft, 12
Gearcase (Begin Spec B), 15
Gearcase (Spec A), 14
Generator, 37
Governor (Begin Spec B), 17
Governor (Spec A), 16
Grommet, Fuel Pump, 31
Grommet, Generator Stator Housing, 37
Grommet, Underfloor Housing, 34
Guide, Valve, 7
Labels, 50
Line, Fuel, 19
Link, Governor Spring, 14
Linkage, Choke, 19
Linkage, Diaphragm Pulloff, 19
Lock, Valve Spring, 7
Hanger, Exhaust, 29
Harness, AC Output, 39
Harness, Adapter, 48, 49
Harness, Engine (Begin Spec B), 41
Harness, Engine (Spec A), 40
Harness, Fuel Pump, 39
Harness, Generator, 39
Harness, PC Board, 42
Harness, Remote (Begin Spec G), 48
Harness, Remote (Spec A–F), 44
Harness, Remote Panel (Switch Only) (Begin Spec G), 45
Harness, Remote Panel (Switch/Hourmeter) (Begin Spec
G), 46
Harness, Remote Panel (Switch/Voltmeter) (Begin Spec G),
47
Harness, Voltage Regulator, 39
Head, Cylinder, 7
Holder, Control Panel Fuse, 39
Holder, Engine Harness Fuse, 41
Hose, Fuel, 19, 35
Hose, Oil Drain, 26
Hose, Preheater, 19
Hose, Vacuum, 19
Housing, Air, 33
Housing, Air Cleaner, 19
Housing, Breather, 7
Housing, Choke, 19
Housing, Generator Stator, 37
Housing, Underfloor, 34
Hub, Governor Cup, 10
Manifold, Exhaust, 28
Manifold, Intake, 19
Meter, Battery Condition, 43
Meter, Hour, 46
Meter, Time Totalizing, 43
Meter, Voltage, 47
Muffler, 28
O’Ring, Generator, 37
O’Ring, Oil Drain Valve, 24
O’Ring, Oil Fill Cap, 24
O’Ring, Oil Fill Tube, 25
O’Ring, Oil Fill Tube Adapter, 25
O’Ring, Preheater Hose, 19
Paint, 50
Pan, Drip, 31
Panel, Air Housing Front, 33
Panel, Remote (Begin Spec G), 45, 46, 47
Panel, Remote (Spec A–F), 43
Panel, Underfloor Housing, 34
Pin, Bearing Stop Drive, 7
Pin, Camshaft Center, 10
Pin, Gear Cover Aignment, 9
Pin, Gearcase Alignment (Begin Spec B), 15
Pin, Gearcase Alignment (Spec A), 14
Pin, Piston, 7
Piston, 7
Plate, Bearing, 7
Plug, Air Cleaner Housing, 19
Plug, Camshaft Opening Welch, 7
Plug, Core Hole, 9
Plug, Gearcase, 15
Plug, Governor Adjust Access, 33
Plug, Intake Manifold Hex Head, 19
Plug, Spark, 27
Indicator, Oil Fill Tube, 25
Insulation, Exhaust Tube, 28
Insulator, PC Board, 39
Isolator, Vibration, 31
Jet, Idle, 20
Jet, Power, 20
Joint, Governor Ball, 16
Key, Blower Wheel, 13
Key, Camshaft Woodruff (Begin Spec B), 11
Key, Camshaft Woodruff (Spec A), 10
4
Index
Plunger, Bypass Valve, 7
Plunger, Camshaft, 11
Pump, Fuel, 19
Pump, Oil, 9
Shield, Fuel Pump, 19
Shield, Starter Lead, 21
Shim, Crankshaft, 7
Spring, Air Inlet, 19
Spring, Breather Valve, 7
Spring, Bypass Valve, 7
Spring, Generator Brush, 37
Spring, Governor, 16
Spring, Plunger, 11
Spring, Throttle Rod, 17
Spring, Valve, 7
Starter, 21
Stator, Generator, 37
Strap, Ground, 31
Support, Muffler, 28
Switch, Low Oil Pressure, 23
Switch, On/Off, 39
Switch, On/Off (Remote Panel), 43, 45, 46, 47
System, Exhaust (Side/Bottom), 28
System, Fuel, 19
Rectifier, 39
Reed, Breather Valve, 7
Regulator, Voltage, 39
Relay, Engine Harness, 41
Relay, Start Solenoid, 39
Relay, Stop Latch, 39
Resistor, Battery Charger, 37
Resistor, Fixed, 22
Resistor, Fuel Pump, 37
Resonator, Exhaust, 29
Retainer, Governor Push–On, 16
Ring, Camshaft Retaining, 10
Ring, Choke Housing Retaining, 19
Ring, Collector, 37
Ring, Crankshaft Retaining, 12
Ring, Piston Pin Retaining, 7
Ring, Tolerance, 37
Rod, Air Inlet, 19
Rod, Connecting, 9
Rod, Governor Control (Spec A), 16
Rod, Throttle Control (Begin Spec B), 17
Rotor, Generator, 37
Rotor, Ignition, 27
Tank, Fuel, 35
Tappet, Valve, 7
Tube, Breather, 19
Tube, Choke Housing, 19
Tube, Cylinder Block Oil, 9
Tube, Elbow Exhaust, 28
Tube, Extended Oil Fill, 25
Tube, Oil Fill, 25
Tube, Straight Exhaust, 29
Seal, Crankshaft Oil (Begin Spec B), 15
Seal, Crankshaft Oil (Spec A), 14
Seal, Crankshaft Rear Oil, 7
Seal, Drip Pan Air Outlet, 31
Seal, Governor Shaft Oil, 14
Seal, Muffler Support, 28
Seal, Oil Fill Tube, 25
Seal, Valve, 7
Sealant, Thread, 50
Seat, Valve, 7
Shaft, Governor, 14
Valve, Exhaust, 7
Valve, Fuel Solenoid, 19
Valve, Intake, 7
Valve, Oil Base Drain/Shutoff, 24
Valve, Shutoff, 35
Wheel, Blower, 13
Yoke, Governor Shaft (Spec A), 14
5
Cylinder Block
1
2
3
1
4
2
5
21
6
7
8
22
23
5
10
9
24
11
25
12
18
5
19
27
26
20
11
29
12
13
14
31 28
30
17
16
15
36
32
35
60
33
34
59
37
39
55
41
54
42
38
32
40
58
53
57
56
51
52
49
50
46
43
47
44
48
45
6
BGM/965–0267
Cylinder Block
REF
NO.
PART
NO.
QTY
USED
1
800–0009
1
2
3
4
5
6
7
8
9
10
526–0063
123–1649
123–1871
110–3709
123–1174
526–0018
123–1175
123–1173
2
1
1
3
1
1
1
1
115–0006
115–0006–02
115–0006–05
110–3511
110–3510
110–3487
120–0398
120–0140
526–0066
801–0049
4
4
4
8
4
4
1
1
1
1
110–3485
509–0289
4
2
21
22
110–3527
110–3526
110–1879–01
800–0004
2
2
1
2
23
24
740–1004
160–1345–01
2
1
25
26
27
28
160–1368
509–0041
101–0439–01
1
1
1
11
12
13
14
15
16
17
18
19
20
104–0776
104–0776–01
1
1
101–0804
101–0804–02
101–0804–10
101–0804–20
101–0804–30
104–0575
101–0809
516–0072
517–0048–01
1
1
1
1
1
2
1
2
1
29
30
31
32
33
PART
DESCRIPTION
Screw, Hex Head Cap
(1/4–20 x 1–1/2”)
Washer, Copper Flat (1/4”)
Housing, Left Side Breather
Filter, Breather Tube
Gasket, Valve Cover
Spring, Breather Valve
Washer, Flat (1/4”)
Reed, Breather Valve
Baffle, Breather Valve
Tappet, Valve
Standard
.002” Oversize
.005” Oversize
Lock, Valve Spring
Cap, Valve
Washer, Valve Spring–Retg
Plunger, Bypass Valve
Spring, Bypass Valve
Washer, Copper Flat (3/8”)
Screw, Hex Head Cap
(3/8–24 x 7/8”)
Spring, Valve
Seal, Intake Valve
Guide, Valve
Exhaust
Intake
Cover, Right Side Valve
Screw, Hex Head Cap
(1/4–20 x 5/8”)
Washer, Flat (M6)
Cover, Breaker Box Opening –
Prime Painted
Gasket, Breaker Box Opening
Seal, Crankshaft Rear Oil
Plate, Rear Bearing
Shim, Crankshaft (Use as
Required)
.005”
.003”
Bearing, Rear Crankshaft
(Includes Thrust Washer)
Standard
.002” Undersize
.010” Undersize
.020” Undersize
.030” Undersize
Washer, Thrust (Special)
Gasket, Bearing Plate
Pin, Bearing Stop Drive
Plug, Camshaft Opening Welch
(1–5/8”)
REF
NO.
PART
NO.
QTY
USED
34
803–0071
2
850–0050
526–0402
5
5
800–0575
5
800–0051
5
110–0197
110–0197–10
2
2
110–1824
110–1824–02
110–1824–05
110–1824–10
110–1824–25
110–3479
110–3515
110–3181
2
2
2
2
2
2
2
2
35
36
37
38
39
40
41
42
43
44
110–3509
110–3508
526–0122
800–0571
1
1
18
18
45
113–0314
113–0314–05
113–0314–10
113–0314–20
113–0314–30
2
2
2
2
2
113–0310
113–0310–05
113–0310–01
113–0310–02
113–0310–03
2
2
2
2
2
112–0264
112–0264–05
112–0264–01
112–0264–02
112–0264–03
112–0229
518–0311
2
2
2
2
2
2
4
46
47
48
7
PART
DESCRIPTION
Screw, Set Socket
(3/8–16 x 5/8”)
Washer
Specs A–B – Lock (3/8”)
Begin Spec C – Flat (.385”)
Screw, Cap
Flanged Head (Special)
(Specs A–B)
Hex Head (3/8–16 x 1–1/4”)
(Begin Spec C)
Seat, Intake Valve
Standard
.010” Oversize
Seat, Exhaust Valve
Standard
.002” Oversize
.005” Oversize
.010” Oversize
.025” Oversize
Valve, Intake
Valve, Exhaust
Gasket, Cylinder Head
Head, Cylinder
Right Side
Left Side
Washer, Flat (5/16”)
Screw, Hex Head Cap
(Special) 2” Long
Kit, Piston Ring
Spec A–B
Standard
.005” Oversize
.010” Oversize
.020” Oversize
.030” Oversize
Begin Spec C
Standard
.005” Oversize
.010” Oversize
.020” Oversize
.030” Oversize
Piston (Includes Pin and
Retaining Rings)
Standard
.005” Oversize
.010” Oversize
.020” Oversize
.030” Oversize
Pin, Piston
Ring, Retaining
BGM/965–0267
Cylinder Block
1
2
3
1
2
4
5
21
6
22
23
7
8
5
10
9
24
11
25
12
18
5
19
27
26
20
11
29
12
13
14
17
16
15
31 28
30
36
32
60
35
33
34
59
37
39
55
41
54
42
38
32
40
58
53
57
51
56
52
49
50
43
45
44
48
47
46
8
BGM/965–0267
Cylinder Block
REF
NO.
PART
NO.
QTY
USED
49
50
51
52
53
114–0397
114–0397–10
114–0397–20
114–0397–30
114–0392
2
2
2
2
4
870–0302
870–0533
120–1320
4
4
1
101–0805
101–0805–02
101–0805–10
101–0805–20
101–0805–30
1
1
1
1
1
PART
DESCRIPTION
REF
NO.
PART
NO.
Rod, Connecting (Includes Bolt
and Nut)
Standard
.010” Undersize
.020” Undersize
.030” Undersize
Bolt, Connecting Rod (Special)
Nut
Self–Locking (5/16–24)
Hex Flange
Tube, Cylinder Block Oil
Bearing, Front Crankshaft
(Flanged)
Standard
.002” Undersize
.010” Undersize
.020” Undersize
.030” Undersize
54
55
56
516–0141
517–0067
120–0491
2
1
1
57
58
740–1004
800–0007
2
2
59
60
101–0405
–
2
1
9
QTY
USED
PART
DESCRIPTION
Pin, Gear Cover Alignment
Plug, Core Hole
Pump, Oil (Components Not
Sold Separately)
Washer, Flat (M6)
Screw, Hex Head Cap
(1/4–20 x 1”)
Bearing, Camshaft
Block, Cylinder (See Short
Block Catalog #932–0109)
BGM/965–0267
Camshaft
Spec A
7
5
6
4
3
2
8
1
9
REF
NO.
PART
NO.
QTY
USED
1
2
3
150–0078
150–1519
150–1520
1
1
1
4
5
510–0015
105–0700
10
1
PART
DESCRIPTION
Ring, Retaining
Hub, Governor Cup
Cup, Governor (Includes
Bushing)
Ball, Governor
Gear (Includes Spacer and
Plate)
10
REF
NO.
PART
NO.
6
7
8
9
105–0541
515–0001
105–0637
150–0075
QTY
USED
1
1
1
1
PART
DESCRIPTION
Washer, Thrust
Key, Woodruff
Camshaft (Includes Center Pin)
Pin, Center
BGM/965–0267
Camshaft
Begin Spec B
4
2
3
1
5
6
REF
NO.
PART
NO.
QTY
USED
1
2
105–0677
105–0700
1
1
3
105–0541
1
PART
DESCRIPTION
Camshaft
Gear (Includes Spacer and
Plate)
Washer, Thrust
11
REF
NO.
PART
NO.
4
5
6
515–0001
105–0058
105–0059
QTY
USED
1
1
1
PART
DESCRIPTION
Key, Woodruff
Plunger, Camshaft
Spring, Plunger
BGM/965–0267
Crankshaft
1
5
4
3
2
REF
NO.
1
2
3
PART
NO.
104–1735
515–0001
104–0032
QTY
USED
1
1
1
PART
DESCRIPTION
Crankshaft
Key, Gear
Gear
12
REF
NO.
PART
NO.
4
5
104–0043
518–0014
QTY
USED
1
1
PART
DESCRIPTION
Washer, Gear
Ring, Retaining
BGM/965–0267
Blower Wheel
1
2
3
4
5
REF
NO.
1
2
3
PART
NO.
134–4705
515–0263
526–0017
QTY
USED
1
1
1
PART
DESCRIPTION
REF
NO.
PART
NO.
Wheel, Blower
Key, Blower Wheel
Washer, Flat (7/16” x 1/4”THK)
Special
4
526–0356
1
5
104–0170
1
13
QTY
USED
PART
DESCRIPTION
Washer, Flat (7/16” x 1/8”THK)
Special
Screw (Special)
BGM/965–0267
Gearcase
Spec A
6
4
5
7
3
8
2
9
10
1
11
15
12
16
14
13
REF
NO.
PART
NO.
QTY
USED
1
103–0804
1
2
815–0046
2
3
4
5
6
7
150–1187
870–0328
851–0031
150–2002–04
150–2300
1
1
1
1
1
8
9
150–1998
509–0008
1
1
PART
DESCRIPTION
REF
NO.
PART
NO.
QTY
USED
Gearcase Assy (Includes Parts
Marked *) (Spec A)
*Screw, Pan Head Machine
Cross Recessed
(#8–32 x 3/8”)
*Yoke
*Nut, Self–Locking (#10–32)
*Washer, Conical Disc Spring
*Shaft, Governor
*Screw, Governor Adjust Guide
(Special)
*Link, Governor Spring
*Seal, Oil
10
11
12
13
14
15
16
510–0013
516–0130
510–0014
509–0040
103–0810
526–0065
1
1
1
1
1
5
114–0022
800–0592
4
1
PART
DESCRIPTION
*Bearing, Needle
*Pin, Alignment
*Ball, Bearing
*Seal, Crankshaft Front Oil
Gasket, Gearcase
Washer, Copper Flat (5/16”)
Screw, Hex Head Cap
5/16–18 x 1–3/4”
5/16–18 x 3–1/4”
* – Parts Included in Gearcase Assy.
14
BGM/965–0267
Gearcase
Begin Spec B
4
3
6
7
5
8
1
2
6
9
REF
NO.
PART
NO.
QTY
USED
1
103–0813
1
2
3
4
5
509–0040
516–0051
517–0293
800–0545
1
1
1
1
PART
DESCRIPTION
REF
NO.
Gearcase Assy (Includes Seal
and Plugs)
Seal, Crankshaft Front Oil
Plug
Plug, Expansion
Screw, Hex Head Cap
(5/16–18 x 2–3/4”)
6
7
8
9
15
PART
NO.
QTY
USED
526–0065
516–0141
103–0810
800–0032–01
5
2
1
4
PART
DESCRIPTION
Washer, Flat (5/16”)
Pin, Alignment
Gasket, Gearcase
Screw, Hex Head Cap
(1–3/4” Lg.)
BGM/965–0267
Governor
Spec A
10
9
8
5
4
2
3
6
1
1
7
REF
NO.
1
2
3
4
5
PART
NO.
QTY
USED
870–0131
150–0096
150–1612
150–2298–01
518–0006
2
1
1
1
1
PART
DESCRIPTION
Nut, ET Hex (#10–32)
Stud, Governor Adjusting
Spring, Governor
Bracket, Governor
Clip, Retaining
16
REF
NO.
PART
NO.
6
7
8
9
10
150–1957
150–0939
150–2294
150–2295
518–0582
QTY
USED
1
1
1
1
1
PART
DESCRIPTION
Rod, Governor Control
Joint, Ball
Cable, Flexible Adjust
Bracket, Cable Adjust
Retainer, Push–On
BGM/965–0267
Electronic Governor
Begin Spec B
2
6
3
5
4
REF
NO.
1
2
3
4
PART
NO.
150–2424
150–2425
150–2426
151–0701
QTY
USED
1
1
1
1
1
PART
DESCRIPTION
REF
NO.
Rod, Throttle Control
Clip, Throttle Rod
Spring, Throttle Rod
Actuator, Governor (K2)
17
PART
NO.
QTY
USED
5
815–0783–01
2
6
815–0783–02
2
PART
DESCRIPTION
Screw, Pan Head
(#10–32 x 1–5/8”)
Screw, Pan Head
(#10–32 x 2–1/8”)
BGM/965–0267
Fuel System
2
4
5
7
8
6
9
10
1
3
67
65
66
11
12
64
63
58
56
61
59
62
60
53
13
14
51
55
52
57
15
54
53
50
44
17
16
18
19 20 21
45
22 , 23 , 24
25
47
46
43
26
48
27
49
30
42
37
36
38
29
28
39
41
31
40
35
33
18
34
32
BGM/965–0267
Fuel System
REF
NO.
1
2
3
4
5
6
PART
NO.
QTY
USED
503–1133
123–1852
140–1919–50
503–0183
503–1351
518–0459
1
1
1
1
1
1
145–0707
145–0704
526–0002
120–0140
517–0223
800–0017
1
1
1
1
1
1
526–0021
1
14
15
140–1894
140–2883–01
140–2379
153–0557
1
1
1
1
16
153–0556
1
7
8
9
10
11
12
13
17
18
518–0387
518–0466
1
1
19
153–0578
1
20
153–0554
1
21
153–0555
1
22
23
526–0047
854–0006
2
2
24
871–0006
2
25
153–0579
1
26
870–0421
1
27
815–0592
2
28
29
30
31
32
33
503–2041
503–0731
502–0395
149–2331–03
502–0313
502–0020
1
2
1
1
1
1
34
35
122–0345
870–0131
1
2
PART
DESCRIPTION
Clamp, Hose
Tube, Breather
Adapter, Preheater
Clamp, Hose
Hose, Preheater
Clip, Preheater Hose
(Spec A–B)
Rod, Air Inlet
Spec A–E
Begin Spec F
Washer, Flat (#6)
Spring, Air Inlet
Cap, Vinyl
Screw, Hex Head Cap
(1/4–20 x 3–1/2”)
Washer, Flat (1/4”)
Housing, Air Cleaner
Spec A–C
Begin Spec D
Element, Air Cleaner
Bracket, Choke Mounting
(Spec A–C)
Housing, Choke (Spec A–C)
(Includes Choke Shaft,
Insulating Washer and
Retainer Ring) (H1)
Ring, Retaining (Spec A–C)
Clip, Choke Housing Tube
Retaining (Spec A–C)
Tube, Choke Housing
(Spec A–C)
Element, Thermostat (Spec
A–C)
Cover, Choke (Spec A–C)
(Includes Hex Nuts, Washers,
Heater Coil Spider and Choke
Heater Element)
Washer, Flat (#6) (Spec A–C)
Washer, IT Lock (#6)
(Spec A–C)
Nut, Brass Hex (6–32”)
(Spec A–C)
Cover, Choke Housing
(Spec A–C)
Nut, Nylon Acorn Cap (#6–32)
(Spec A–C)
Screw, Hex Washer Head
Thread Forming (Spec A–C)
(#8–32 x 1–3/8”)
Hose, Fuel
Clamp, Hose
Connector, Hose
Pump, Fuel (E3) (Begin Spec G)
Elbow, 90° Hose
Elbow, 90° Street – Valve
Outlet
Shield, Fuel Pump
Nut, ET Hex (#10–32)
REF
NO.
PART
NO.
36
37
502–1107
1
526–0115
526–0115
149–2267
502–0054
3
3
1
1
307–1279
307–2756
307–2788
501–0550
1
1
1
1
149–2279
149–2341
153–0558
815–0591
1
1
1
2
502–1108
1
146–0455
146–0528
146–0664
1
1
1
141–0281
141–0958
1
1
49
50
51
154–2447
154–3026
154–2495
740–1006
800–0033
1
1
1
4
4
52
502–0028
1
53
54
503–0813
502–1105
2
1
55
815–0587
2
56
503–1252–01
1
57
153–0561
1
58
59
153–0614
518–0450
1
1
60
153–0577
1
61
62
63
64
862–0015
140–2308
140–3093
815–0590
1
1
1
3
65
66
67
145–0561
517–0320
509–0313
1
1
1
38
39
40
41
42
43
44
45
46
QTY
USED
47
48
19
PART
DESCRIPTION
Elbow, 90° Barbed – Inlet
Washer, Flat
Spec A (.344)
Begin Spec B (.3125)
Pump, Fuel (E3) (Spec A–F)
Elbow, 90° Street – Outlet
Valve, Fuel Solenoid (E4)
Spec A
Spec B,C
Spec D
Line, 30” Flexible Fuel
Filter, Fuel
Spec A–F
Begin Spec G
Linkage, Choke (Spec A–C)
Screw, Hex Washer Head Cap
Thread Forming(1/4–10 x 3/4”)
Elbow, 90° Street
Carburetor (See Separate Page
for Components)
Spec A
Spec B–C
Begin Spec D (Includes
Gaskets)
Gasket, Mounting
Spec A
Begin Spec B
Manifold, Intake
Spec A–F
Begin Spec G
Gasket, Intake Manifold
Washer, Flat (M8)
Screw, Hex Head Cap
(5/16–18 x 2”)
Plug, Hex Head Pipe (Begin
Spec D)
Clamp, Hose (Spec A–C)
Fitting, 90° Flow Vacuum
(Spec A–C)
Screw, Hex Flange Head Cap
(5/16–18 x 1”)
Hose, Vacuum (3/16” ID x 6”)
(Spec A–C)
Bracket, Diaphragm Mounting
(Spec A–C)
Diaphragm, Pulloff (Spec A–C)
Clip, Diaphragm Mounting ”U”
(Spec A–C)
Linkage, Diaphragm Pulloff
(Spec A–C)
Nut, Hex (5/16–18)
Gasket, Air Horn
Adapter, Air Cleaner
Screw, Hex Head Machine
(#10–32 x 7/16”)
Cover, Air Inlet
Plug, Button (Begin Spec D)
O’Ring (Begin Spec C)
BGM/965–0267
Carburetor Components
1
1
2
Begin Spec D
3
Spec A–C
REF
NO.
PART
NO.
QTY
USED
146–0455
1
146–0528
146–0664
1
1
1
146–0453
1
2
3
4
146–0449
146–0450
146–0588
1
1
1
4 , 5 , 6, 7
PART
DESCRIPTION
REF
NO.
PART
NO.
Carburetor
Spec A (Includes Mounting
Gaskets)
Spec B,C
Begin Spec D (Includes
Mounting Gaskets)
Float Package (Includes Float,
Pin and Valve)
Jet, Idle (Spec A–C)
Jet, Power (Spec A–C)
Kit, Choke Bimetal (Includes
Compl. Bimetal Holder,
Thermostat Cover Assy,
Bimetal Set Plate, Bimetal
Case Set Screw)
5
146–0589
1
6
146–0592
1
7
146–0457
1
20
QTY
USED
PART
DESCRIPTION
Kit, Choke Breaker (Includes
Choke Piston Rod, Link
Washer, Snap Pin, Choke
Opener Assy
Kit, Choke Shaft (Includes
Choke Shaft Assy, Choke
Collar, Choke Arm Return
Spring, Choke Valve, Valve Set
Screw, Choke Lever Assy)
Kit, Repair (Includes Gasket
Package, Float Valve, Idle
Adjust Needle and Spring,
Mounting Gaskets, Adjust
Limit Caps, Throttle Stop
Screw and Spring) (Spec A–C)
BGM/965–0267
Starter
2
6
5
4
7
8
6
2
3
1
4
9
11
10
REF
NO.
PART
NO.
QTY
USED
1
2
191–2158
800–0052
1
2
3
4
5
6
337–2435
850–0050
850–0040
862–0001
1
2
1
2
PART
DESCRIPTION
REF
NO.
Starter (B1)
Screw, Hex Head Cap
(3/8–16 x 1–1/2”)
Cable (Spec A)
Washer, Spring Lock (3/8”)
Washer, Spring Lock (1/4”)
Nut, Hex (1/4–20)
7
8
9
10
11
21
PART
NO.
QTY
USED
226–3457–01
122–0345
862–0003
191–2186
191–2187
1
1
2
1
1
PART
DESCRIPTION
Lead, Starter (Includes Shield)
Shield
Nut, Hex (3/8–16)
Cap, Drive
Kit, Drive (Includes Retainers,
Washers, Spring, Cover, Roll
Pin, Pinion Gear, Drive Clutch)
BGM/965–0267
Resistor
Spec A–F
5
6
4
3
7
2
9
1
8
REF
NO.
PART
NO.
QTY
USED
1
2
3
870–0196
304–0015
304–0818
1
1
1
4
5
304–0773
815–0583
1
1
PART
DESCRIPTION
Nut, Insulation (#8)
Washer, Centering
Resistor, Fixed – 1.4 Ohms
50 Watts
Bracket, Resistor Mounting
Screw, Hex Head Cap
(#8–32 x 4.75”)
22
REF
NO.
PART
NO.
QTY
USED
6
815–0770
1
7
8
304–0772
815–0261
1
1
9
508–0321
1
PART
DESCRIPTION
Screw, Hex Washer Head
Thread Form (#10–32 x 1/2”)
Bracket, Resistor Mounting
Screw, Hex Washer Head
Thread Cutting
(1/4–20 x 1/2”)
Washer, Flat (.184)
BGM/965–0267
Oil Filter
7
5
6
8
1
4
2
3
REF
NO.
PART
NO.
QTY
USED
1
122–0814
1
2
815–0340
2
3
4
5
122–0360–55
122–0645
526–0065
1
1
2
PART
DESCRIPTION
REF
NO.
Adapter, Oil Filter (Includes
Screws)
Screw, Hex Head Cap
Thread Forming with ET
(#10–32 x 3/8”)
Drain, Oil Filter
Filter, Oil
Washer, Copper Flat (5/16”)
23
PART
NO.
QTY
USED
6
800–0028–01
2
7
8
122–0771
1
309–0322
1
309–0615
1
PART
DESCRIPTION
Screw, Hex Head Cap
(5/16–18 x 1”)
Gasket, Oil Filter Adapter
Switch, Low Oil Pressure (S2)
Spec A – Open – to
Close at 5–9 PSI
Begin Spec B – Close
to Open at 5–9 PSI
BGM/965–0267
Oil Base
1
8
9
3
4
2
6
7
10
REF
NO.
1
2
3
4
5
PART
NO.
QTY
USED
102–1387
1
102–1359
102–1457–01
123–1616
123–2092
1
1
1
1
504–0164
504–0150
1
1
PART
DESCRIPTION
REF
NO.
6
7
8
9
Gasket, Oil Base
Base, Oil
Spec A–F
Begin Spec G
Cup, Oil Pickup
Cap, Oil Fill
Valve, Drain/Shutoff
Spec A–F
Begin Spec G
10
24
PART
NO.
QTY
USED
509–0246
509–0247
526–0251
800–0052–01
1
2
4
4
509–0291
1
5
PART
DESCRIPTION
O’Ring (1–1/4” ID)
O’Ring (3/8” ID) (Spec A–F)
Washer, Flat (3/8”)
Screw, Hex Head Cap
(3/8–16 x 1–1/2”)
O’Ring (1/2”ID)
(Spec A–F)
BGM/965–0267
Extended Oil Fill Tube
10
11
6
2
7
8
9
1
3
5
4
REF
NO.
PART
NO.
QTY
USED
1
2
3
123–2041–50
332–3213
123–2039
1
1
1
4
5
509–0246
509–0269
1
1
PART
DESCRIPTION
REF
NO.
6
7
8
9
10
11
Tube, OIl Fill
Clamp, Coated
Adapter Assy (Includes Adapter
and O’Ring)
O’Ring, Adapter
Seal, Oil FIll Tube
25
PART
NO.
123–2042
509–0142
155–2943–02
821–0010
870–0212
526–0029
QTY
USED
PART
DESCRIPTION
1
1
1
1
1
1
Indicator Assy (Includes O’Ring)
O’Ring, Indicator
Bracket, Tube Support
Screw (1/4–20 x 1/2”)
Nut (1/4 x 20)
Washer, Flat (3/8”)
BGM/965–0267
Oil Drain Extension
4
1
5
3
2
REF
NO.
1
2
3
4
PART
NO.
102–1394
503–1195
503–0183
102–1391
QTY
USED
1
1
1
1
PART
DESCRIPTION
REF
NO.
PART
NO.
Adapter, Oil Drain
Hose, Oil Drain (3/4” ID x 24”)
Clamp, Hose
Gasket, Oil Drain Adapter
5
815–0261
26
QTY
USED
3
PART
DESCRIPTION
Screw, Hex Washer Head Cap
Thread Forming
(1/4–20 x 1/2”)
BGM/965–0267
Generator Adapter
1
12
2
3
13
6
4
14
11
15
5
16
10
6
7
8
9
REF
NO.
PART
NO.
QTY
USED
1
2
166–0770
166–0771
815–0650
1
1
2
166–0761
1
166–0820
1
166–0789–01
1
166–0747
1
815–0290
2
3
4
5
PART
DESCRIPTION
Nut, Hex Flange
M4 x 0.7 – Positive Terminal
M5 x 0.8 – Negative Terminal
Screw, Self–Locking Hex
Washer Head Thread
Forming (1/4–20 x 1”)
Coil, Ignition (T1)
Spec A,B – Spec C
S/N G923938483 & Below
Begin Spec C,
S/N G923938484 & Above
Bracket, Ignition Coil
Spec A,B – Spec C
S/N G923938483 & Below
Begin Spec C
S/N G923938484 & Above
Screw, Self–Locking Hex
Washer Head Thread
Forming (1/4–20 x 5/8”)
27
REF
NO.
PART
NO.
QTY
USED
6
815–0770
3
7
8
9
10
11
12
332–3198
166–0793
166–0821
870–0328
312–0256
1
1
1
2
1
13
14
15
167–1625–01
167–1625–02
167–0272
166–0842
800–0575–01
1
1
2
1
4
16
231–0381–01
1
PART
DESCRIPTION
Screw, Self–Locking Hex
Washer Head Thread
Forming (#10–32 x 1/2”)
Connector
Bracket, Ignition Control
Control, Ignition (S3)
Nut, Self–Locking (#10–32)
Capacitor (C4)
Cable, Spark Plug
9”
23”
Plug, Spark
Rotor, Ignition
Screw, Hex Flange Head Cap
(3/8–16 x 1–1/8”)
Adapter, Generator
BGM/965–0267
Exhaust System
(Side or Bottom)
1
2
3
18
17
6
4
1
5
6
7
8
16
9
15
10
13
14
12
11
REF
NO.
PART
NO.
QTY
USED
1
2
3
4
134–4770
870–0048
526–0122
816–0140
2
2
2
2
5
862–0014
2
6
7
740–1006
800–0730
6
2
8
9
10
155–2428
154–2765
155–2477
1
2
1
PART
DESCRIPTION
Insulation, Exhaust Tube
Nut, Self–Locking (5/16–18)
Washer, Flat (.34)
Bolt, Carriage
(5/16–18 x 1–1/4”)
Nut, Hex (5/16–18)
(Stainless Steel)
Washer, Flat (M8)
Screw, Hex Head Cap
(5/16–18 x 1”)
Tube, Exhaust
Gasket, Exhaust Tube
Muffler, Exhaust
28
REF
NO.
PART
NO.
QTY
USED
11
815–0261
4
12
13
14
15
526–0018
155–2558
155–2415
4
2
2
16
17
821–0029
815–0890–01
154–2746
802–0053
4
4
2
4
18
154–2784
1
PART
DESCRIPTION
Screw, Hex Washer Head Cap
Thread Forming
(1/4–20 x 1/2”)
Washer, Flat (1/4”)
Support, Muffler
Seal, Muffler Support
Screw, Hex Flange Head
Spec A–F (3/8–16 x 3/4”)
Begin Spec G (3/8–16 x 1)
Gasket, Exhaust Manifold
Screw, Socket Head
(5/16–18 x 3/4”)
Manifold, Exhaust
BGM/965–0267
Exhaust Options
9
8
6
7
1
2
5
3
4
REF
NO.
PART
NO.
QTY
USED
1
2
155–2610
155–2424
154–0945
1
1
1
3
800–0730
2
4
5
6
526–0115
155–2402
155–2174
2
2
–
PART
DESCRIPTION
REF
NO.
7
8
9
Tube, Exhaust
3”
7”
Flange, Exhaust Manifold
(1/4”Thk) (Steel Plate)
Screw, Hex Head Cap
(5/16–18 x 1”)
Washer, Flat (5/16”)
Cover, Tailpipe Access
Hanger, Exhaust (1–1/2”)
29
PART
NO.
QTY
USED
155–2401–02
155–2449
2
1
155–1255
155–1256
155–1257
155–1015
155–1239
155–1135
–
–
–
–
–
–
PART
DESCRIPTION
Cover, Tailpipe Access
Resonator, Exhaust
Clamp, Exhaust
1”
1–1/8”
1–1/4”
1–3/8”
1–1/2”
1–5/8”
BGM/965–0267
Drip Pan
18
17
16
15
12
14
19
3
9
20
13
12
8
5
9
11
8
12
21
5
10
5
5
1
7
3
2
6
4
3
30
BGM/965–0267
Drip Pan
REF
NO.
1
2
3
4
5
6
PART
NO.
QTY
USED
403–2893–02
402–0629
821–0010
821–0010
815–0657
402–0624
526–0325
1
1
7
9
4
4
4
7
821–0015
2
8
9
518–0515
870–0212
2
4
10
151–0752
1
11
815–0783–03
1
PART
DESCRIPTION
REF
NO.
PART
NO.
QTY
USED
Pan, Drip
Bushing, Isolator
Screw, Self–Locking Hex
Flange Head (1/4–20 x 1/2”)
Spec A–F
Begin Spec G
Screw, Hex Head Cap
Thread Forming
(3/8–16 x 2–3/4”)
Isolator, Vibration
Washer, Flat
(13/32” ID x 2–29/64” OD x
1/8” Thk)
Screw, Self–Locking Hex
Flange Head (1/4–20 x 3/4”)
Clip, Fuel Line Retainer
Nut, Self–Locking Hex
(1/4–20)
Controller, Governor (Begin
Spec B)
Screw, Pan Head Torx
(#10–32 x 1/2”)
12
13
856–0008
5
821–0016
1
815–0236
1
149–2321–02
149–2569–02
508–0307
1
1
3
526–0012
850–0030
3
3
19
867–0028
870–0131
815–0610
1
1
1
20
21
337–2434
134–4745
1
1
14
15
16
17
18
31
PART
DESCRIPTION
Washer, EIT Lock (5/16”)
Screw
Self–Locking Hex Flange
Head (5/16–18 x 3/4”)
Hex Head Thread Cutting
(5/16–18 x 5/8”)
Bracket, Fuel Pump
Spec A–F
Begin Spec G
Grommet, Fuel Pump
(Neoprene) (Spec A–F)
Washer, Flat (#10)(Spec A–F)
Washer, Lock (#10) (Spec A–F)
Nut, Hex (#10–32)
Spec A–F
Begin Spec G
Screw, Hex Head Cap
Thread Forming (1/4–20 x 1”)
Strap, Ground
Seal, Air Outlet
BGM/965–0267
Air Housing
1
2
3
12
4
2
11
5
10
6
9
7
8
6
2
32
BGM/965–0267
Air Housing
REF
NO.
PART
NO.
QTY
USED
1
2
134–4753–02 1
815–0889
31
3
134–5163
4
134–5146
518–0581
134–4890
1
3
1
134–5061
870–0468
518–0581
1
1
6
134–4771–50
518–0574
815–0815
1
4
4
5
6
134–4837
1
134–4832
1
134–4793–50
518–0618
815–0261
1
1
7
PART
DESCRIPTION
REF
NO.
Cover, Governor Access
Screw, Hex Washer Head
(1/4–20 x 3/4”)
Cover, Top (Includes Insulation
and Indented Nut Listed
Below)
Insulation, Top
Nut, Push On
Cover, Left Side Cylinder
(Includes Indented Parts
Listed Below)
Insulation, Cylinder Head
Nut, Flex Lock
Nut, Push On (Round
Shaped)
Cover, Tailpipe Access
Clip (1/4–20) Access Cover
Screw, Torx Drive
(1/4–20 x 1/2”) Access
Cover
Insulation, Muffler Box
(Lower)
Insulation, Muffler Box
(Upper)
Cover, Cylinder Head Inner
Clip, Spark Plug Wire
Screw, Hex Washer Head Cap
Thread Forming
(1/4–20 x 1/2”)
7
QTY
USED
8
134–4961–50
134–4924–50
821–0014
1
1
2
9
134–4939
1
134–5060
870–0468
518–0581
134–4791–50
134–4831
134–4888
1
1
5
1
1
1
134–4771–50
1
518–0574
815–0815
4
4
518–0581
134–4997
518–0570
517–0278
5
1
9
1
10
11
12
33
PART
NO.
PART
DESCRIPTION
Backplate
Spec A
Begin Spec B
Screw, Self–Locking Hex
Washer Head (5/16–18 x 1/2”)
Cover, Right Side Cylinder
(Includes Indented Parts
Listed Below)
Insulation, Cylinder Head
Nut, Flex Lock
Nut, Push On
Cover, Cylinder Head Inner
Insulation, Muffler Box
Panel, Front (Includes
Insulation and Indented
Parts Listed Below)
Cover, Tailpipe Access
Opening
Clip (1/4–20) Access Cover
Screw, Torx Drive – Access
Cover (1/4–20 x 1/2”)
Nut, Push On
Insulation
Clip, Moulding
Plug, Governor Adjust Access
BGM/965–0267
Underfloor Housing
6
5
5
6
11
10
9
1
4 3
5
8
2
5
6
6
5
7
6
5
REF
NO.
PART
NO.
QTY
USED
1
405–4662
1
2
3
4
405–4668–01
850–0030
813–0098
1
2
2
5
800–0026
16
PART
DESCRIPTION
REF
NO.
PART
NO.
QTY
USED
Panel, Rear (Includes
Insulation)
Cover, Panel Rear
Washer, Spring Lock (#10)
Screw, Round Head Machine
(#10–32 x 3/8”)
Screw, Hex Head Cap
(5/16–18 x 3/4”)
6
7
526–0122
405–4663
22
1
8
9
856–0008
405–4237
2
1
10
11
508–0071
508–0055
3
1
34
PART
DESCRIPTION
Washer, Flat (5/16”)
Panel, Left Side (Includes
Insulation)
Washer, EIT Lock (5/16”)
Panel, Right Side (Includes
Insulation)
Grommet, Rubber (5/8”)
Grommet, Rubber (1–1/2”)
BGM/965–0267
Fuel Tank
2
3
1
4
7
5
8
6
REF
NO.
PART
NO.
QTY
USED
PART
DESCRIPTION
REF
NO.
PART
NO.
QTY
USED
Tank, Fuel (6 Gallon)
Bushing, Reducer (1/4” x 1/8”)
Valve, Shutoff (1/8”)
Connector, Barbed Hose
(1/8”)
Hose, Fuel (1/4” ID x 14”)
6
7
503–0731
502–0397
4
1
8
502–0398
1
1
2
3
4
415–0511
505–0007
504–0169
502–0395
1
1
1
1
5
503–0708
1
35
PART
DESCRIPTION
Clamp, Hose
Coupling, Quick Disconnect
Female
Coupling, Quick Disconnect
Male
BGM/965–0267
Generator
17
20
18
21
24
23
22
18
19
15
14
16
13
26
12
10
25
27
9
11
28
7
8
2
3
29
5
4
1
6
36
BGM/965–0267
Generator
REF
NO.
PART
NO.
QTY
USED
1
2
3
4
5
6
7
201–3388–03
201–3509–01
510–0099
204–0134
518–0460
205–0165
862–0003
802–1038
1
1
1
1
1
1
4
1
8
331–0536
1
9
10
11
508–0272
212–1284
212–1285
2
1
1
12
13
14
212–1286
214–0103
815–0788
1
2
2
15
16
17
212–1276–03
304–0810
2
1
815–0660
2
815–0808–01
1
PART
DESCRIPTION
REF
NO.
PART
NO.
Rotor, Generator (Includes
Parts Marked *)
Spec A,B
Begin Spec C
*Bearing, Ball
*Ring, Collector
*Ring, Tolerance
*Fan, Generator
Nut, Hex (3/8–16)
Screw, Socket Head
(7/16–14 x 10–7/32”)
Connector, Conduit (Begin
Spec D)
Grommet, Nylon
Cover, Brush Block Access
Block, Generator Brush
(Includes Parts Marked #)
#Block, Brush
#Brush, Generator
Screw, Torx – Pan Head
(#10–32 x 7/8”)
#Spring, Generator Brush
Resistor, Fuel Pump (R7)
Screw, Torx Drive Thread
Forming
Hex Head (#10–32 x 2–1/2”)
Specs A,B
Pan Head Shakeproof
(#10–32 x 4–1/2”)
Begin Spec C
18
19
304–0015
4
304–0794
304–0818
821–0030
856–0010
1
1
1
1
23
220–4438–01
220–4532–01
800–0052
1
1
4
24
25
26
850–0050
232–2955–02
815–0290
4
3
3
27
28
29
220–4135–04
509–0196
332–0819
1
1
2
20
21
22
QTY
USED
PART
DESCRIPTION
Washer, Centering (7/32”)
Resistor, Battery Charge (R1)
(Spec A–F)
25 Watts, 5 Ohms
50 Watts, 1.2 Ohms
Screw, Lock Head (3/8–16 x 1”)
Washer, EIT Lock (3/8”)
Housing, Generator Stator
Spec A
Begin Spec B–G
Screw, Hex Head Cap
(3/8–16 x 1–1/2”)
Washer, Spring Lock (3/8”)
Clamp, Stator
Screw, Hex Washer Head
Thread Forming
(1/4–20 x 5/8”)
Stator, Generator
O’Ring
Housing, Push On Connector
* – Parts Included in Generator Rotor.
# – Parts Included in Generator Brush Block
37
BGM/965–0267
Control
5
7
10
6
1
9
2
3
7
5
11
8
4
12
13
14
15
16
31
17
32
33
18
27 28
29
34
19
30 2928
27
20
46
26
25
21
22
23
35
24
36
45
40
41
39
44
42
38
37
43
38
BGM/965–0267
Control
REF
NO.
PART
NO.
QTY
USED
1
815–0550–01
4
2
3
232–3265–02
815–0661
1
2
4
5
321–0323–02
321–0357–02
815–0692–02
1
1
2
6
7
305–0825–02
815–0664
1
2
8
305–0826
1
9
10
11
12
323–1315
1
323–1199
12
815–0777–01 1
338–2476
1
13
14
323–1200
323–1314
7
1
15
815–0791
4
16
17
320–1323
320–1683
320–1323
332–3075
1
1
2
1
18
19
20
300–3950
300–3764
300–4902
321–0271
815–0661
1
1
1
1
2
321–0298
321–0146
321–0295
1
1
2
21
22
PART
DESCRIPTION
REF
NO.
PART
NO.
QTY
USED
Screw, Pan Head
(#6–32 x .312”)
Clamp, Conduit
Screw, Pan Head Thread
Forming (#10–32 x 1/2”)
Bracket, Fuse Holder
Spec A–F
Begin Spec G
Screw, Machine Pan Head
Torx Drive (1/4–20 x 1”)
Bracket, Voltage Regulator
Screw, Torx Drive Thread
Forming (1/4–20 x 3/8”)
Regulator, Voltage (Includes
Cap and Pins) (VR1)
Cap, Connector – 12 Place (P4)
Pin, Contact
Screw, Torx Drive (1/4–20 x 1/2”)
Harness, Voltage Regulator
(Includes Socket and Plug)
Socket, Contact
Plug, Connector – 12 Place
(J4)
Screw, Pan Head
(#6–32 x 3/8”)
Breaker, AC Output Circuit
(CB1,CB2)
Spec 26105
30A
20A
Spec 11578 (30A)
Insulator, PC Board (Begin
Spec B)
Board, Printed Circuit
(Includes Parts Marked °) (A1)
Spec A
Spec B–F
Begin Spec G
°Clip, Fuse
Screw, Pan Head Thread
Forming (#10–32 x 1/2”)
Fuse (F1)
5 Amp – Spec A
10 Amp – Begin Spec B
Holder, Fuse (For Spares)
23
24
308–0949
1
319–0762
1
25
26
27
28
29
30
31
32
319–1238–01
319–1238–02
308–0996
308–0995
332–2112
868–0002
850–0045
307–2570
338–2058
815–0803
1
1
1
1
2
2
2
1
1
1
33
815–0691–01
1
34
35
332–2859–02
813–0096
1
2
36
37
307–2695
338–2465
1
1
38
39
40
323–1440
870–0131
307–1886
2
1
2
41
305–0718
1
42
357–0067
2
43
813–0103
1
44
338–2533
1
332–0819
332–0556
323–1298
1
1
2
45
46
PART
DESCRIPTION
Cover, Rubber Switch
Cover, Control
Spec A
Begin Spec B
Spec 26105
Spec 11578
°Cover, Hard Plastic Switch
°Switch, On/Off (A1S1)
Insulator, Terminal
Nut, Jam Hex (5/16–24)
Washer, Spring Lock (5/16”)
Relay, Start Solenoid (K1)
Harness, AC Output
Screw, Torx Pan Head
(#10–32 x 1”)(Spec A–F)
Screw, Pan Head Torx Drive
Thread Forming
(#10–32 x 3/8”)
Block, Terminal (TB1)
Screw, Round Head Machine
(#10–32 x 1/4”)
Bracket, Relay
Harness, Generator (Includes
Parts Marked +)
+Pin, Contact
Nut, Hex (#10–32)(Spec A–F)
+Relay, Stop Latch – Fuel Pump
(K5, K6)
+Rectifier, Bridge – Fuel Pump
Power (CR10) (Spec A–F)
+Rectifier, Stop Latch – Fuel
Pump (CR8, CR9)
Screw, Round Head Machine
(#10–32 x 3/4”)
Harness, Fuel Pump
(F2–2, TB1–L0 to J5, R6)
Housing, Push On Connector
Spec A–F
Begin Spec G
Connector (B1 to H1–1, J1–1
and B2 to H1–2, J1–7)
+ – Parts Included in 338–2465 Wiring Harness.
° – Parts Included in Printed Circuit Board.
39
BGM/965–0267
Engine Harness
Spec A
3
2
REF
NO.
PART
NO.
1
QTY
USED
1
338–2481
1
2
3
323–1329
323–1440
1
2
PART
DESCRIPTION
Harness, Wiring – Engine to
Control (Includes Housing
and Contact Pins)
Housing (J3)
Pin, Contact
40
BGM/965–0267
Engine Harness
Begin Spec B
7
6
5
1
2
4
3
REF
NO.
1
PART
NO.
QTY
USED
338–2585
338–2585–01
338–2888
1
1
1
323–1505
1
PART
DESCRIPTION
REF
NO.
PART
NO.
Harness, Engine Wiring
(Includes Connector and
Wedge)
Spec B
S pec C
Begin Spec D (Also Includes
Fuse Holder, Fuse and
Relay)
Connector, Receptacle
2
323–1501
1
3
4
5
6
321–0322–01
321–0321–06
307–1886
323–1500
1
1
1
1
7
323–1504
1
41
QTY
USED
PART
DESCRIPTION
Wedge, Receptacle – Use with
323–1505 Connector
Holder, Fuse
Fuse (10A)
Relay (K4)
Wedge, Plug – Use with
323–1505 Connector
Connector, Plug – Use with
323–1505 Connector
BGM/965–0267
PCB Harness
1
2
3
11
12
4
5
6
7
9
8
10
REF
NO.
PART
NO.
QTY
USED
338–2040
1
338–2584
1
338–2584–01
1
338–2887
1
338–3478–01
1
1
323–1487–03
1
2
3
4
323–1494
323–1486
323–1491
1
8
3
PART
DESCRIPTION
REF
NO.
PART
NO.
QTY
USED
Harness, PCB
Spec A (Includes Parts
Marked #)
Spec B (Includes Parts
Marked +)
Spec C (Includes Parts
Marked +)
Spec D–F (Includes Parts
Marked +)
Begin Spec G (Includes Parts
Marked )
+Housing, Connector –
12 Connections
+Connector, Receptacle
+Socket, Contact
+Terminal, Pin
5
323–1502
1
6
7
8
9
10
11
12
323–1200
323–1312
323–1440
323–1743
323–1741
323–1708
323–1712
1
1
5
1
1
–
3
PART
DESCRIPTION
+Wedge, Receptacle – Use with
323–1494 Connector
#+Socket, Contact
#Housing (J1) (8 Pin)
#Pin, Contact
Connector, Plug (8 Pin)
Housing, Lock
Seal, Cable
Plug, Cavity
# – Parts Included in 338–2040 Wiring Harness.
+ – Parts Included in 338–2584, 338–2584–01, and
338–2887 Wiring Harnesses.
– Parts Included in 338–3478–01 Wiring Harness.
42
BGM/965–0267
Remote Panel
Spec A–F
1
2
6
4
8
10
7
3
5
4
9
5
3
REF
NO.
PART
NO.
QTY
USED
1
300–2313
1
2
300–2314
1
3
815–0380
815–0380
2
4
PART
DESCRIPTION
Kit, Standard Remote Starting
Control (Includes Parts
Marked *) (A3)
Kit, Deluxe Remote Starting
Control (Includes Parts
Marked +) (A2)
Screw, Wood Oval Head
Cross Recessed (#5 x 1/2”)
* Standard Control
+ Deluxe Control
43
REF
NO.
PART
NO.
QTY
USED
4
5
308–0341
1
6
7
8
9
301–3566
301–3606
302–0885
302–0888
359–0034
815–0385
1
1
1
1
1
2
10
860–0006
2
PART
DESCRIPTION
+*Switch, Rocker (S1)
Panel, Control
* Standard Control
+ Deluxe Control
+Meter, Time Totalizing (M2)
+Meter, Battery Condition (M1)
+Diode
+Screw, Round Head Machine
(#6–32 x 1/2”)
+Nut, Hex (#6–32)
BGM/965–0267
Remote Harness
Spec A–F
3
6
2
9
4
3
10
1
8
11
6
3
7
12
5
14 13
REF
NO.
PART
NO.
QTY
USED
1
338–1082
1
2
3
4
5
323–0500
332–0941
323–0400
338–2046
5
1
1
1
6
7
8
323–1304
323–1199
338–2137
1
5
1
9
10
323–1199
323–0488
5
5
PART
DESCRIPTION
Harness, Wiring – 6” (Includes
Parts Marked *)
*Pin, Contact
+#*Tie, Cable
*Housing, Connector (6 Place)
Harness, Wiring – 6” (Includes
Parts Marked #)
+#Housing, Connector (6 Place)
#Pin, Contact
Harness, Wiring – 6” (Includes
Parts Marked +)
+Pin, Contact
+Socket, Connector
REF
NO.
PART
NO.
11
12
323–0440
1
338–2260–01
338–2260–02
323–1199
323–1304
1
1
5
1
13
14
QTY
USED
PART
DESCRIPTION
+Housing, Connector (6 Place)
Harness, Wiring (Includes)
Housing and Pins)
Ten Foot
Thirty Foot
Pin, Contact
Housing, Connector (6 Place)
(J2)
* – Parts Included in 338–1082 Wiring Harness
# – Parts Included in 338–2046 Wiring Harness
+ – Parts Included in 338–2137 Wiring Harness
44
BGM/965–0267
Remote Switch Panel
Begin Spec G
2
1
3
4
5
REF
NO.
1
2
3
PART
NO.
300–4936
815–0910
308–1062
338–3510
QTY
USED
1
2
1
1
PART
DESCRIPTION
Kit, Switch Only Remote Panel
Screw, Wood Mounting (#6 x 1)
Switch, Rocker
Harness, Remote Panel
(Includes Pins and Plug)
45
REF
NO.
PART
NO.
QTY
USED
4
5
323–1291
323–1199
1
4
PART
DESCRIPTION
Plug (9 Pin)
Pin, Contact
BGM/965–0267
Remote Switch/Hourmeter Panel
Begin Spec G
2
1
3
4
5
6
REF
NO.
1
2
PART
NO.
QTY
USED
300–4937
1
815–0910
308–1062
2
1
PART
DESCRIPTION
Kit, Switch/Hourmeter Remote
Panel
Screw, Wood Mounting (#6 x 1)
Switch, Rocker
46
REF
NO.
PART
NO.
QTY
USED
3
4
302–2002
338–3466
1
1
5
6
323–1304
323–1199
1
4
PART
DESCRIPTION
Meter, Hour
Harness, Remote Panel
(Includes Pins and Plug)
Plug (6 Pin)
Pin, Contact
BGM/965–0267
Remote Switch/Voltmeter Panel
Begin Spec G
4, 5 , 6 , 7
2
1
3
8
9
10
REF
NO.
1
2
3
4
5
6
PART
NO.
300–4938
815–0910
308–1062
302–1641
526–0409
526–0049
871–0010
QTY
USED
1
2
1
1
2
4
4
PART
DESCRIPTION
Kit, Switch/Voltmeter
Screw, Wood Mounting (#6 x 1)
Switch, Rocker
Meter, Voltage
Washer, Nylon
Washer, Flat
Nut, Hex Brass Machine
(10–32)
47
REF
NO.
PART
NO.
QTY
USED
7
8
850–0030
338–3507
2
1
9
10
323–1304
323–1199
1
4
PART
DESCRIPTION
Washer, Lock
Harness, Remote Panel
(Includes Pins and Plug)
Plug (6 Pin)
Pin, Contact
BGM/965–0267
Remote Harness
Begin Spec G
2
6
5
4
9
10
7
8
3
1
REF
NO.
1
PART
NO.
QTY
USED
300–4946
1
3
338–3489–01
338–3489–02
338–3572
1
1
1
4
5
323–1744
323–1712
1
3
2
PART
DESCRIPTION
Harness, Remote (Includes
Parts Marked *)
Harness, Remote Panel
(Includes Parts Marked +)
10’
30’
Harness, Adapter (Includes
Parts Marked #)
+*Connector, Receptacle (8 Pin)
+*Plug, Cavity
REF
NO.
PART
NO.
QTY
USED
6
7
8
9
10
323–1708
323–1707
323–1741
323–1200
323–1342
5
5
1
1
1
PART
DESCRIPTION
+*Seal, Cable
*Pin, Contact
+*Housing, Lock
+#Socket, Contact
+#Cap, Connector
* – Parts Included in Remote Harness (300–4947).
+ – Parts Included in Remote Panel Harness (338–3490).
# – Parts Included in Adapter Harness (338–3573).
48
BGM/965–0267
Adapter Harness
1
9
5
7
4
8 , 12
3 , 10
6
11
2
13
REF
NO.
PART
NO.
1
338–3513
2
338–3514
3
4
5
6
7
323–1744
323–1708
323–1707
323–1712
323–1741
QTY
USED
1
5
5
3
1
PART
DESCRIPTION
Harness, Adapter Wiring
New Set to Old Panel
(Includes Parts Marked *)
Harness, Adapter Wiring
Old Set to New Panel
(Includes Parts Marked +)
*Connector, Receptacle (8 Pin)
+*Seal, Cable
*Pin, Contact
+*Plug, Cavity
+*Housing, Lock
REF
NO.
PART
NO.
QTY
USED
8
9
10
11
12
13
323–1342
323–1200
323–1743
323–1709
323–1304
323–1199
1
1
1
5
1
5
PART
DESCRIPTION
*Cap, Connector (6 Pl)
*Socket, Contact
+Connector, Plug (8 Pin)
+Socket, Terminal
+Cap, Connector (6 Pl)
+Pin, Contact
* – Parts Included in Remote Harness (338–3513).
+ – Parts Included in Remote Panel Harness (338–3514).
49
BGM/965–0267
Labels, Kits, Paint and Thread Sealant
REF
NO.
PART
NO.
QTY
USED
98–6105–02
98–6105–03
98–5335
1
1
1
98–6586–02
98–6566
1
1
98–7371–01
98–7371–05
98–6618–01
98–6618–02
98–6388–02
98–6402–02
1
1
1
1
PART
DESCRIPTION
REF
NO.
Label, Air Cleaner (Spec A)
Label, Air Cleaner (Spec A)
Label, Air Cleaner – Begin
Spec B
Label, Battery – Negative
Label, Fuse
Label, Model Identification
5.0kW
5.5kW
Label, Oil Fill
White Background
Black Background
Label, Phone Info.
Label, Warning – Service/
Maintenance
50
PART
NO.
QTY
USED
98–6074–02
1
98–6088
98–6041
1
1
168–0189
168–0192
120–0161
518–0347
525–0394
1
1
1
1
1
518–0452
–
PART
DESCRIPTION
Label, Warning – Provide
Support
Label, Warning – Fire or Fumes
Label, Warning – Hazardous
Voltage, Exhaust Gas
Kit, Gasket
Valve Grind
Engine
Kit, Oil Pump Gasket
Loctite, Bottle (250cc)
Paint, Black – Flat Enamel
(16 oz. Pressurized Spray
Can)
Sealant, Thread (50cc Bottle)
BGM/965–0267
Wiring Diagram Information
Spec
Number
A
Wiring Diagram Number
B/C
D/E/F
G
11578 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 611–1240
26105 . . . . . . . . . . . . . . . . . . . . . . . . . . . 611–1196 . . . . . . . 611–1219 . . . . . . . . 611–1240
51
Numerical Index
Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
098–5335, 50
104–0776–01, 7
113–0314–05, 7
134–4793–50, 33
098–6041, 50
104–1735, 12
113–0314–10, 7
134–4831, 33
098–6074–02, 50
105–0058, 11
113–0314–20, 7
134–4832, 33
098–6088, 50
105–0059, 11
113–0314–30, 7
134–4837, 33
098–6105–02, 50
105–0541, 10, 11
114–0022, 14
134–4888, 33
098–6105–03, 50
105–0637, 10
114–0392, 9
134–4890, 33
098–6388–02, 50
105–0677, 11
114–0397, 9
134–4924–50, 33
098–6402–02, 50
105–0700, 10, 11
114–0397–10, 9
134–4939, 33
098–6566, 50
110–0197, 7
114–0397–20, 9
134–4961–50, 33
098–6586–02, 50
110–0197–10, 7
114–0397–30, 9
134–4997, 33
098–6618–01, 50
110–1824, 7
115–0006, 7
134–5060, 33
098–6618–02, 50
110–1824–02, 7
115–0006–02, 7
134–5061, 33
098–7371–01, 50
110–1824–05, 7
115–0006–05, 7
134–5146, 33
098–7371–05, 50
110–1824–10, 7
120–0140, 7, 19
134–5163, 33
101–0405, 9
110–1824–25, 7
120–0161, 50
140–1894, 19
101–0439–01, 7
110–1879–01, 7
120–0398, 7
140–1919–50, 19
101–0804, 7
110–3181, 7
120–0491, 9
140–2308, 19
101–0804–02, 7
110–3479, 7
120–1320, 9
140–2379, 19
101–0804–10, 7
110–3485, 7
122–0345, 19, 21
140–2883–01, 19
101–0804–20, 7
110–3487, 7
122–0360–55, 23
140–3093, 19
101–0804–30, 7
110–3508, 7
122–0645, 23
141–0281, 19
101–0805, 9
110–3509, 7
122–0771, 23
141–0958, 19
101–0805–02, 9
110–3510, 7
122–0814, 23
145–0561, 19
101–0805–10, 9
110–3511, 7
123–1173, 7
145–0704, 19
101–0805–20, 9
110–3515, 7
123–1174, 7
145–0707, 19
101–0805–30, 9
110–3526, 7
123–1175, 7
146–0449, 20
101–0809, 7
110–3527, 7
123–1616, 24
146–0450, 20
102–1359, 24
110–3709, 7
123–1649, 7
146–0453, 20
102–1387, 24
112–0229, 7
123–1852, 19
146–0455, 19, 20
102–1391, 26
112–0264, 7
123–1871, 7
146–0457, 20
102–1394, 26
112–0264–01, 7
123–2039, 25
146–0528, 19, 20
102–1457–01, 24
112–0264–02, 7
123–2041–50, 25
146–0588, 20
103–0804, 14
112–0264–03, 7
123–2042, 25
146–0589, 20
103–0810, 14, 15
112–0264–05, 7
123–2092, 24
146–0592, 20
103–0813, 15
113–0310, 7
134–4705, 13
146–0664, 19, 20
104–0032, 12
113–0310–01, 7
134–4745, 31
149–2267, 19
104–0043, 12
113–0310–02, 7
134–4753–02, 33
149–2279, 19
104–0170, 13
113–0310–03, 7
134–4770, 28
149–2321–02, 31
104–0575, 7
113–0310–05, 7
134–4771–50, 33
149–2331–03, 19
104–0776, 7
113–0314, 7
134–4791–50, 33
149–2341, 19
52
Numerical Index
Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
149–2569–02, 31
155–1239, 29
212–1285, 37
307–2788, 19
150–0075, 10
155–1255, 29
212–1286, 37
308–0341, 43
150–0078, 10
155–1256, 29
214–0103, 37
308–0949, 39
150–0096, 16
155–1257, 29
220–4135–04, 37
308–0995, 39
150–0939, 16
155–2174, 29
220–4438–01, 37
308–0996, 39
150–1187, 14
155–2401–02, 29
220–4532–01, 37
308–1062, 45, 46, 47
150–1519, 10
155–2402, 29
226–3457–01, 21
309–0322, 23
150–1520, 10
155–2415, 28
231–0381–01, 27
309–0615, 23
150–1612, 16
155–2424, 29
232–2955–02, 37
312–0256, 27
150–1957, 16
155–2428, 28
232–3265–02, 39
319–0762, 39
150–1998, 14
155–2449, 29
300–2313, 43
319–1238–01, 39
150–2002–04, 14
155–2477, 28
300–2314, 43
319–1238–02, 39
150–2294, 16
155–2558, 28
300–3764, 39
320–1323, 39
150–2295, 16
155–2610, 29
300–3950, 39
320–1683, 39
150–2298–01, 16
155–2943–02, 25
300–4902, 39
321–0146, 39
150–2300, 14
160–1345–01, 7
300–4936, 45
321–0271, 39
150–2424, 17
160–1368, 7
300–4937, 46
321–0295, 39
150–2425, 17
166–0747, 27
300–4938, 47
321–0298, 39
150–2426, 17
166–0761, 27
300–4946, 48
321–0321–06, 41
151–0701, 17
166–0770, 27
300–4947, 48, 49
321–0322–01, 41
151–0752, 31
166–0771, 27
301–3566, 43
321–0323–02, 39
153–0554, 19
166–0789–01, 27
301–3606, 43
321–0357–02, 39
153–0555, 19
166–0793, 27
302–0885, 43
323–0400, 44
153–0556, 19
166–0820, 27
302–0888, 43
323–0440, 44
153–0557, 19
166–0821, 27
302–1641, 47
323–0488, 44
153–0558, 19
166–0842, 27
302–2002, 46
323–0500, 44
153–0561, 19
167–0272, 27
304–0015, 22, 37
153–0577, 19
167–1625–01, 27
304–0772, 22
323–1199, 39, 44, 45, 46,
47, 49
153–0578, 19
167–1625–02, 27
304–0773, 22
153–0579, 19
168–0189, 50
304–0794, 37
153–0614, 19
168–0192, 50
304–0810, 37
154–0945, 29
191–2158, 21
304–0818, 22, 37
154–2447, 19
191–2186, 21
305–0718, 39
154–2495, 19
191–2187, 21
305–0825–02, 39
154–2746, 28
201–3388–03, 37
305–0826, 39
154–2765, 28
201–3509–01, 37
307–1279, 19
154–2784, 28
204–0134, 37
307–1886, 39, 41
154–3026, 19
205–0165, 37
307–2570, 39
155–1015, 29
212–1276–03, 37
307–2695, 39
155–1135, 29
212–1284, 37
307–2756, 19
53
323–1200, 39, 42, 48, 49
323–1291, 45
323–1298, 39
323–1304, 44, 46, 47, 49
323–1312, 42
323–1314, 39
323–1315, 39
323–1329, 40
323–1342, 48, 49
323–1440, 39, 40, 42
323–1486, 42
323–1487–03, 42
Numerical Index
Part No.
Page
Part No.
Page
Part No.
Page
Part No.
Page
323–1491, 42
338–2887, 42
503–1252–01, 19
518–0014, 12
323–1494, 42
338–2888, 41
503–1351, 19
518–0311, 7
323–1500, 41
338–3466, 46
503–2041, 19
518–0347, 50
323–1501, 41
338–3478–01, 42
504–0150, 24
518–0387, 19
323–1502, 42
338–3489–01, 48
504–0164, 24
518–0450, 19
323–1504, 41
338–3489–02, 48
504–0169, 35
518–0452, 50
323–1505, 41
338–3490, 48, 49
505–0007, 35
518–0459, 19
323–1707, 48, 49
338–3507, 47
508–0055, 34
518–0460, 37
323–1708, 42, 48, 49
338–3510, 45
508–0071, 34
518–0466, 19
323–1709, 49
338–3513, 49
508–0272, 37
518–0515, 31
323–1712, 42, 48, 49
338–3514, 49
508–0307, 31
518–0570, 33
323–1741, 42, 48, 49
338–3572, 48
508–0321, 22
518–0574, 33
323–1743, 42, 49
338–3573, 48
509–0008, 14
518–0581, 33
323–1744, 48, 49
357–0067, 39
509–0040, 14, 15
518–0582, 16
331–0536, 37
359–0034, 43
509–0041, 7
518–0618, 33
332–0556, 39
402–0624, 31
509–0142, 25
525–0394, 50
332–0819, 37, 39
402–0629, 31
509–0196, 37
526–0002, 19
332–0941, 44
403–2893–02, 31
509–0246, 24, 25
526–0012, 31
332–2112, 39
405–4237, 34
509–0247, 24
526–0017, 13
332–2859–02, 39
405–4662, 34
509–0269, 25
526–0018, 7, 28
332–3075, 39
405–4663, 34
509–0289, 7
526–0021, 19
332–3198, 27
405–4668–01, 34
509–0291, 24
526–0029, 25
332–3213, 25
415–0511, 35
509–0313, 19
526–0047, 19
337–2434, 31
501–0550, 19
510–0013, 14
526–0049, 47
337–2435, 21
502–0020, 19
510–0014, 14
526–0063, 7
338–1082, 44
502–0028, 19
510–0015, 10
526–0065, 14, 15, 23
338–2040, 42
502–0054, 19
510–0099, 37
526–0066, 7
338–2046, 44
502–0313, 19
515–0001, 10, 11, 12
526–0115, 19, 29
338–2058, 39
502–0395, 19, 35
515–0263, 13
526–0122, 7, 28, 34
338–2137, 44
502–0397, 35
516–0051, 15
526–0251, 24
338–2260–01, 44
502–0398, 35
516–0072, 7
526–0325, 31
338–2260–02, 44
502–1105, 19
516–0130, 14
526–0356, 13
338–2465, 39
502–1107, 19
516–0141, 9, 15
526–0402, 7
338–2476, 39
502–1108, 19
517–0048–01, 7
526–0409, 47
338–2481, 40
503–0183, 19, 26
517–0067, 9
740–1004, 7, 9
338–2533, 39
503–0708, 35
517–0223, 19
740–1006, 19, 28
338–2584, 42
503–0731, 19, 35
517–0278, 33
800–0004, 7
338–2584–01, 42
503–0813, 19
517–0293, 15
800–0007, 9
338–2585, 41
503–1133, 19
517–0320, 19
800–0009, 7
338–2585–01, 41
503–1195, 26
518–0006, 16
800–0017, 19
54
Numerical Index
Part No.
Page
Part No.
Page
Part No.
Page
800–0026, 34
815–0692–02, 39
870–0302, 9
800–0028–01, 23
815–0770, 22, 27
870–0328, 14, 27
800–0032–01, 15
815–0777–01, 39
870–0421, 19
800–0033, 19
815–0783–01, 17
870–0468, 33
800–0051, 7
815–0783–02, 17
870–0533, 9
800–0052, 21, 37
815–0783–03, 31
871–0006, 19
800–0052–01, 24
815–0788, 37
871–0010, 47
800–0545, 15
815–0791, 39
800–0571, 7
815–0803, 39
800–0575, 7
815–0808–01, 37
800–0575–01, 27
815–0815, 33
800–0592, 14
815–0889, 33
800–0730, 28, 29
815–0890–01, 28
801–0049, 7
815–0910, 45, 46, 47
802–0053, 28
816–0140, 28
802–1038, 37
821–0010, 25, 31
803–0071, 7
821–0014, 33
813–0096, 39
821–0015, 31
813–0098, 34
821–0016, 31
813–0103, 39
821–0029, 28
815–0046, 14
821–0030, 37
815–0236, 31
850–0030, 31, 34, 47
815–0261, 22, 26, 28, 33
850–0040, 21
815–0290, 27, 37
850–0045, 39
815–0340, 23
850–0050, 7, 21, 37
815–0380, 43
851–0031, 14
815–0385, 43
854–0006, 19
815–0550–01, 39
856–0008, 31, 34
815–0583, 22
856–0010, 37
815–0587, 19
860–0006, 43
815–0590, 19
862–0001, 21
815–0591, 19
862–0003, 21, 37
815–0592, 19
862–0014, 28
815–0610, 31
862–0015, 19
815–0650, 27
867–0028, 31
815–0657, 31
868–0002, 39
815–0660, 37
870–0048, 28
815–0661, 39
870–0131, 16, 19, 31, 39
815–0664, 39
870–0196, 22
815–0691–01, 39
870–0212, 25, 31
55
Part No.
Page
Onan Corporation
1400 73rd Avenue N.E.
Minneapolis, MN 55432
1-800-888-ONAN
612-574-5000 International Use
Telex: 275477
Fax: 612-574-8087
Onan is a registered trademark of Onan Corporation
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.3 Linearized : No Create Date : 1998:10:08 15:43:01 Producer : Acrobat Distiller 3.0 for Windows Modify Date : 1999:10:08 09:49:42-05:00 Title : Document Page Count : 58 Page Mode : UseThumbsEXIF Metadata provided by EXIF.tools