CRT4275 AVHP4100DVD
User Manual: AVHP4100DVD
Open the PDF directly: View PDF .
Page Count: 204
Download | ![]() |
Open PDF In Browser | View PDF |
ORDER NO. CRT4275 AVH-P4100DVD/XN/UC DVD AV RECEIVER AVH-P4100DVD /XN/UC DVD RDS AV RECEIVER AVH-P4100DVD/XNEW5 AVH-P4100DVD/XNUW5 This service manual should be used together with the following manual(s): Model No. CX-3250 Order No. CRT4300 Mech.Module LS1 Remarks DVD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly DTS and DTS Digital Out are registered trademartks and the DTS logos and Symbol are trademarks of DTS, Inc. Manufactured under license from Dolby Laboratories. Dolby, Pro Logic, and the double-D symbol are trademarks of Dolby Laboratories. For details, refer to "Important Check Points for Good Servicing". PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2009 K-ZZZ. JAN. 2009 Printed in Japan 1 2 3 4 SAFETY INFORMATION CAUTION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safety repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safety, you should not risk trying to do so and refer the repair to a qualified service technician. A WARNING This product contains certain electrical parts contain chemicals which are known to the State of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65 B Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used: This product contains mercury. Disposal of this material may be regulated due to environmental considerations. For disposal or recycling information, please contact your local authorities or the Electronics Industries Alliance: www.eiae.org. C The backlighting lamp of LCD in this equipment contains mercury. Disposal of this material may be regulated due to environmental considerations according to Local, State or Federal Laws. For disposal or recycling information, please contact your local authorities or the Electronics Industries Alliance: www.eiae.org - Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results. Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer. D CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. CAUTION CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN. DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS E F 2 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 WARNING! A The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. Laser diode characteristics Wave length: DVD:660 nm to 670 nm CD:780 nm to 800 nm Focus lens on Maximum output: CD:6.26 mW(Emitting period :9 sec.) DVD:1.27 mW (Emitting period : unlimited) B Additional Laser Caution Transistors Q1103 and Q1104 in PCB drive the laser diodes for DVD and CD respectively. When Q1103 or Q1104 is shorted between their terminals, the laser diodes for DVD or CD will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam. C D E F AVH-P4100DVD/XN/UC 5 6 7 8 3 1 2 3 4 [Important Check Points for Good Servicing] In this manual, procedures that must be performed during repairs are marked with the below symbol. Please be sure to confirm and follow these procedures. A 1. Product safety Please conform to product regulations (such as safety and radiation regulations), and maintain a safe servicing environment by following the safety instructions described in this manual. 1 Use specified parts for repair. Use genuine parts. Be sure to use important parts for safety. 2 Do not perform modifications without proper instructions. Please follow the specified safety methods when modification(addition/change of parts) is required due to interferences such as radio/TV interference and foreign noise. 3 Make sure the soldering of repaired locations is properly performed. B When you solder while repairing, please be sure that there are no cold solder and other debris. Soldering should be finished with the proper quantity. (Refer to the example) 4 Make sure the screws are tightly fastened. Please be sure that all screws are fastened, and that there are no loose screws. 5 Make sure each connectors are correctly inserted. Please be sure that all connectors are inserted, and that there are no imperfect insertion. 6 Make sure the wiring cables are set to their original state. Please replace the wiring and cables to the original state after repairs. In addition, be sure that there are no pinched wires, etc. C 7 Make sure screws and soldering scraps do not remain inside the product. Please check that neither solder debris nor screws remain inside the product. 8 There should be no semi-broken wires, scratches, melting, etc. on the coating of the power cord. Damaged power cords may lead to fire accidents, so please be sure that there are no damages. If you find a damaged power cord, please exchange it with a suitable one. 9 There should be no spark traces or similar marks on the power plug. When spark traces or similar marks are found on the power supply plug, please check the connection and advise on secure connections and suitable usage. Please exchange the power cord if necessary. a Safe environment should be secured during servicing. D When you perform repairs, please pay attention to static electricity, furniture, household articles, etc. in order to prevent injuries. Please pay attention to your surroundings and repair safely. 2. Adjustments To keep the original performance of the products, optimum adjustments and confirmation of characteristics within specification. Adjustments should be performed in accordance with the procedures/instructions described in this manual. 3. Lubricants, Glues, and Replacement parts Use grease and adhesives that are equal to the specified substance. Make sure the proper amount is applied. E 4. Cleaning For parts that require cleaning, such as optical pickups, tape deck heads, lenses and mirrors used in projection monitors, proper cleaning should be performed to restore their performances. 5. Shipping mode and Shipping screws To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. F 4 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 CONTENTS SAFETY INFORMATION .....................................................................................................................................2 1. SERVICE PRECAUTIONS................................................................................................................................6 1.1 SERVICE PRECAUTIONS .........................................................................................................................6 1.2 NOTES ON SOLDERING...........................................................................................................................7 2. SPECIFICATIONS.............................................................................................................................................8 2.1 SPECIFICATIONS ......................................................................................................................................8 2.2 DISC/CONTENT FORMAT....................................................................................................................... 11 2.3 PANEL FACILITIES ..................................................................................................................................13 2.4 CONNECTION DIAGRAM........................................................................................................................15 3. BASIC ITEMS FOR SERVICE ........................................................................................................................21 3.1 CHECK POINTS AFTER SERVICING .....................................................................................................21 3.2 PCB LOCATIONS.....................................................................................................................................22 3.3 JIGS LIST .................................................................................................................................................23 3.4 CLEANING ...............................................................................................................................................24 4. BLOCK DIAGRAM ..........................................................................................................................................26 4.1 OVERALL CONNECTION DIAGRAM ......................................................................................................26 4.2 BLOCK DIAGRAM....................................................................................................................................28 5. DIAGNOSIS ....................................................................................................................................................36 5.1 OPERATIONAL FLOWCHART.................................................................................................................36 5.2 INSPECTION METHOD OF PICKUP UNIT .............................................................................................37 5.3 DIAGNOSIS FLOWCHART ......................................................................................................................40 5.4 ERROR CODE LIST.................................................................................................................................67 5.5 CONNECTOR FUNCTION DESCRIPTION .............................................................................................70 6. SERVICE MODE.............................................................................................................................................71 6.1 MONITOR TEST MODE...........................................................................................................................71 6.2 DVD TEST MODE ....................................................................................................................................91 6.3 DVD TOUCH PANEL TEST MODE ..........................................................................................................95 7. DISASSEMBLY ...............................................................................................................................................96 8. EACH SETTING AND ADJUSTMENT..........................................................................................................105 8.1 DVD ADJUSTMENT ...............................................................................................................................105 8.2 MONITOR UNIT ADJUSTMENT ............................................................................................................ 113 8.3 PCL OUTPUT CONFIRMATION ............................................................................................................ 116 9. EXPLODED VIEWS AND PARTS LIST ........................................................................................................ 117 9.1 PACKING(AVH-P4100DVD/XN/UC) ....................................................................................................... 118 9.2 PACKING(AVH-P4100DVD/XNEW5, XNUW5) ......................................................................................120 9.3 EXTERIOR(1) .........................................................................................................................................122 9.4 EXTERIOR(2) .........................................................................................................................................124 9.5 EXTERIOR(3) .........................................................................................................................................126 9.6 DVD MECHANISM MODULE.................................................................................................................128 10. SCHEMATIC DIAGRAM..............................................................................................................................132 10.1 MOTHER PCB(ANALOG) ....................................................................................................................132 10.2 MOTHER PCB(TUNER) .......................................................................................................................134 10.3 MOTHER PCB(SYSTEM)(GUIDE PAGE) ............................................................................................136 10.4 MOTHER PCB(POWER SUPPLY).......................................................................................................142 10.5 IF PCB ..................................................................................................................................................144 10.6 DVD CORE UNIT(GUIDE PAGE).........................................................................................................146 10.7 CONNECT PCB....................................................................................................................................152 10.8 KEYBOARD UNIT ................................................................................................................................154 10.9 MONITOR UNIT(uCOM)(GUIDE PAGE) ..............................................................................................156 10.10 MONITOR UNIT(MONITOR)(GUIDE PAGE)......................................................................................162 10.11 SERVICE PCB ASSY .........................................................................................................................168 10.12 WAVEFORMS.....................................................................................................................................170 11. PCB CONNECTION DIAGRAM ..................................................................................................................172 11.1 MOTHER PCB ......................................................................................................................................172 11.2 DVD CORE UNIT..................................................................................................................................176 11.3 CONNECT PCB....................................................................................................................................178 11.4 KEYBOARD UNIT.................................................................................................................................180 11.5 MONITOR UNIT....................................................................................................................................182 11.6 SERVICE PCB ASSY ...........................................................................................................................186 11.7 IF PCB ..................................................................................................................................................188 12. ELECTRICAL PARTS LIST.........................................................................................................................189 A B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 5 1 2 3 4 1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS A 1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. 3. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 4. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY" . 5. After replacing the pickup unit, be sure to skew adjustment. 6. During disassembly, be sure to turn the power off since an internal IC might be destroyed when a connector is plugged or unplugged. 7. After the replacement of LS1 mecha, connect ACC and BUP, and then press RESET button. ->Some functions such as BOOK mark may not work normally. 8. Connector CN5001 in the monitor unit : When you remove the flexible from the CKS5951, hold up the end of the flexible holddown part to remove it. ->There is a possibility of breakage of connector pin. 9. Connector CN5001 in the monitor unit : CKS5951 is a connector of both contact points. If you insert the flexible inversely, there is a possibility of IC damaged because of unintended connection. So please take care not to insert it inversely. If perchance you insert it inversely, you need to replace the unit. 10. The FFC styling between mother unit and DVD mecha (LS1) requires careful attention. Fold FFC to the mecha side and style it. 11. Eject lock How to enter:Reset with [VOL-] key and [SOURCE] key pressed. Summary:DISC EJECT behavior of built-in DVD mecha is prohibited It is for DISC antitheft from the storefront display. With or without DISC, the behavior of pressing EJECT key during the EJECT lock is as follows. During grille closed Press EJECT key -> Grille is opened. *The key is valid at the point of being pressed (BEEP). To Leave the key makes grille opened. During grille opened Press EJECT key -> Grille is closed. *The key is valid at the point of being pressed (BEEP). To Leave the key makes grille opened Remarks: [Notes] EJECT lock is not unlocked by turning ACC ON or product reset. To unlock it, you need to operate keys as above. For existing model (AVH-P9DVA), it is unlocked by turning ACC ON or reset. 12. Background display data is stored in IC5201. So, if you replace the IC, user photo data will be lost. 13. If the gasket (CNN2782) on the FM/AM tuner unit was damaged or lost, then the reception sensitivity would be poor. So, replace it with the new one. B C D NOTE: When you remove the top case OK NG E Don't put tweezers or something into these holes to remove the top case Use these holes to remove the top case. F 6 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 1.2 NOTES ON SOLDERING A For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). B The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. C D E F AVH-P4100DVD/XN/UC 5 6 7 8 7 1 2 3 4 2. SPECIFICATIONS 2.1 SPECIFICATIONS A AVH-P4100DVD/XN/UC General Power source .........................14.4 V DC (10.8 V to 15.1 V allowable) Grounding system................. Negative type Max. current consumption ...............................................10.0 A Backup current ....................... 2.2 mA or less B Dimensions (W × H × D): DIN Chassis ................. 178 mm × 100 mm × 165 mm (7 in. × 3-7/8 in. × 6-1/2 in.) Nose ....................... 171 mm × 97 mm × 9 mm (6-3/4 in.× 3-7/8 in.× 3/8 in.) Weight ..................................... 1.7 kg(3.7 lbs) Display Screen size/aspect ratio.......6.95 inch wide/16:9 (effective display area: 155.2 × 81.3 mm) Pixels ........................................ 336 960 (1 440 × 234) Display method ..................... TFT active matrix Color system........................... NTSC Durable temperature range (power off) ............................................... -20 °C to +80 °C C Audio Maximum power output ...... 50 W × 4 50 W × 2/4 + 70 W × 1/2 (for subwoofer) Continuous power output .. 22 W × 4 (1 kHz, 5% THD, 4 load, both channels driven) Load impedance ................... 4 to 8 × 4 4 to 8 × 2 + 2 × 1 Preout max output level ..... 4.0 V Equalizer (3-Band Parametric Equalizer): Low Frequency ............. 40/80/100/160 Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ......................... ±12 dB Mid Frequency ............. 200/500/1k/2k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ......................... ±12 dB High Frequency ............. 3.15k/8k/10k/12.5k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ........................ ±12 dB D E F 8 HPF: Frequency ..................... 50/63/80/100/125 Hz Slope ............................... –12 dB/oct Subwoofer (mono): Frequency ......................50/63/80/100/125 Hz Slope ............................... –18 dB/oct Gain ................................. +6 dB to –24 dB Phase .............................. Normal/Reverse Bass boost: Gain ................................. +12 dB to 0 dB DVD Player System ..................................... DVD video, Video CD, CD, WMA, MP3, AAC, DivX, JPEG system Usable discs .......................... DVD video, Video CD, CD, CD-R/RW, DVD-R/RW/RDL Region number .................... 1 Frequency response ........... 5 Hz to 44 000 Hz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio............ 96 dB (1 kHz) (IHF-A network) (RCA level) Output level: Video ............................... 1.0 Vp -p/75 (±0.2 V) Number of channels ............. 2 (stereo) MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ........ Ver. 7,7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver. 8.0 and earlier) DivX decoding format...........Home Theater Ver. 3, 4, 5.2, 6 (.avi, .divx) USB USB standard specification .............................................. USB 1.1, USB 2.0 full speed Maximum current supply ... 500 mA USB Class ............................. MSC (Mass Storage Class) File system............................. FAT16, FAT32 MP3 decoding format ......... MPEG-1 & 2 Audio Layer 3 WMA decoding format ........ Ver. 7,7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format.......... MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver. 8.0 and earlier) FM tuner Frequency range .................. 87.9 MHz to 107.9 MHz Usable sensitivity.................. 9 dBf (0.8 μV/75 , mono, S/N: 30 dB) AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A Signal-to-noise ratio............. 72 dB (IHF-A network) AM tuner Frequency range .................. 530 kHz to 1 710 kHz (10 kHz) Usable sensitivity.................. 25 μV (S/N: 20 dB) Signal-to-noise ratio............. 62 dB (IHF-A network) CEA2006 Specifications B Power output ......................... 14 W RMS × 4 Channels (4 and 1 % THD+N) S/N ratio .................................. 91 dBA (reference: 1 W into 4 ) Note C Specifications and the design are subject to modifications without notice due to improvements. D E F AVH-P4100DVD/XN/UC 5 6 7 8 9 1 2 3 4 AVH-P4100DVD/XNEW5, AVH-P4100DVD/XNUW5 A General DVD Player Power source .........................14.4 V DC (10.8 V to 15.1 V allowable) Grounding system................ Negative type Max. current consumption ...............................................10.0 A Backup current ....................... 2.2 mA or less System ..................................... DVD video, DVD-VR, Video CD, CD, WMA, MP3, AAC, DivX, JPEG system Usable discs ......................... DVD video, Video CD, CD, CD-R/RW, DVD-R/RW/RDL Region number ..................... 2 (EW5) 5 (UW5) Frequency response............. 5 Hz to 44 000 Hz (withDVD, at sampling frequency 96 kHz) Signal-to-noise ratio ........... 96 dB (1 kHz) (IEC-A network) (RCA level) Output level: Video .............................. 1.0 Vp-p/75 (±0.2 V) Number of channels ............ 2 (stereo) MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ........ Ver. 7,7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver. 8.0 and earlier) DivX decoding format.......... Home Theater Ver. 3, 4,5.2, 6 (.avi, .divx) Dimensions (W × H × D): DIN Chassis .................. 178 mm × 100 mm × 165 mm Nose ....................... 171 mm × 97 mm × 9 mm Weight ..................................... 1.7 kg B Display Screen size/aspect ratio.......6.95 inch wide/16:9 (effective display area: 155.2 × 81.3 mm) Pixels ....................................... 336 960 (1 440 × 234) Display method .................... TFT active matrix Color system.......................... PAL/SECAM compatible Durable temperature range (power off) .............................................. -20 °C to +80 °C C Audio Maximum power output ...... 50 W × 4 50 W × 2/4 + 70 W × 1/2 (for subwoofer) Continuous power output .. 22 W × 4 (1 kHz, 5% THD, 4 load, both channels driven) Load impedance ................... 4 to 8 × 4 4 to 8 × 2 + 2 × 1 Preout max output level ..... 4.0 V Equalizer (3-Band Parametric Equalizer): Low Frequency ............. 40/80/100/160 Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ........................ ±12 dB Mid Frequency ............. 200/500/1k/2k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ........................ ±12 dB High Frequency ............. 3.15k/8k/10k/12.5k Hz Q Factor .................0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ......................... ±12 dB HPF: Frequency ......................50/63/80/100/125 Hz Slope ................................–12 dB/oct Subwoofer (mono): Frequency ..................... 50/63/80/100/125 Hz Slope ............................... –18 dB/oct Gain ................................. +6 dB to –24 dB Phase .............................. Normal/Reverse Bass boost: Gain ................................. +12 dB to 0 dB D E F 10 USB USB standard specification .............................................. USB 1.1, USB 2.0 full speed Maximum current supply ... 500 mA USB Class ............................. MSC (Mass Storage Class) File system.............................. FAT16, FAT32 MP3 decoding format ..........MPEG-1 & 2 Audio Layer 3 WMA decoding format ....... Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) AAC decoding format...........MPEG-4 AAC (iTunes encoded only) (.m4a) (Ver. 8.0 and earlier) FM tuner Frequency range .................. 87.5 MHz to 108.0 MHz Usable sensitivity.................. 9 dBf (0.8 μV/75 , mono, S/N: 30 dB) Signal-to-noise ratio ............ 72 dB (IEC-A network) MW tuner Frequency range .................. 531 kHz to 1 602 kHz (9 kHz) Usable sensitivity.................. 25 μV (S/N: 20 dB) Signal-to-noise ratio ............ 62 dB (IEC-A network) LW tuner Frequency range .................. 153 kHz to 281 kHz Usable sensitivity................... 28 μV (S/N: 20 dB) Signal-to-noise ratio ............ 62 dB (IEC-A network) Note Specifications and the design are subject to modifications without notice due to improvements. AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 2.2 DISC/CONTENT FORMAT Handling guideline of discs and player • Use only discs featuring any of following logos. DVD video A • Use only normal, round discs. If you insert irregular, non-round, shaped discs they may jam in the DVD player or not play properly. • Check all discs for cracks, scratches or warping before playing. Discs that have cracks, scratches or are warped may not play properly. Do not use such discs. • Avoid touching the recorded (non-printed) surface when handling the disc. • Store discs in their cases when not in use. • Keep discs out of direct sunlight and do not expose the discs to high temperatures. • Do not attach labels, write on or apply chemicals to the surface of the discs. • To clean a disc, wipe the disc with a soft cloth outward from the center. Video CD B C CD • If the heater is used in cold weather, condensation may form on components inside the DVD player. Condensation may cause the DVD player to not operate properly. If you think that condensation is a problem turn off the DVD player for an hour or so to allow it to dry out and wipe any damp discs with a soft cloth to remove the moisture. • Road shocks may interrupt disc playback. D E F AVH-P4100DVD/XN/UC 5 6 7 8 11 1 2 3 4 A is a trademark of DVD Format/Logo Licensing Corporation. B C AVH-P4100DVD/XN/UC D E F 12 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 2.3 PANEL FACILITIES A AVH-P4100DVD/XN/UC, AVH-P4100DVD/XNEW5 B Head unit RESET button Press to return to the factory settings (initial settings). For details concerning operations, see the remote control manual. C DISP OFF button Press to turn the information display on or off. / (TRACK) buttons Press to do manual seek tuning, fast forward, reverse and track search controls. D SRC/OFF button Press to cycle through all the available sources. Press and hold to turn the source off. +/ – (VOLUME) buttons Press to increase or decrease the volume. MUTE button Press to turn off the sound. To turn on the sound, press again. E (eject) button Press to eject a disc from this unit. Optional remote control The remote control CD-R55 is sold separately. F AVH-P4100DVD/XN/UC 5 6 7 8 13 1 2 3 4 AVH-P4100DVD/XNUW5 A B Head unit Optional remote control RESET button Press to return to the factory settings (initial settings). C The remote control CD-R55 is sold separately. For details concerning operations, see the remote control manual. DISP OFFAV/NAVI button Press to turn the information display on or off. If separately sold navigation unit is connected to this unit via RGB cable, pressing and holding this button switches between navigation display and audio display. D / (TRACK) buttons Press to do manual seek tuning, fast forward, reverse and track search controls. SRC/OFF button Press to cycle through all the available sources. Press and hold to turn the source off. +/ – (VOLUME) buttons Press to increase or decrease the volume. E MUTE button Press to turn off the sound. To turn on the sound, press again. (eject) button Press to eject a disc from this unit. F 14 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 Green/black Green Violet/black Violet Gray/black Rear speaker or Subwoofer (4 ) Right Front speaker Not used. Green/black Green Violet/black Violet Subwoofer (4 ×2 ) When using a subwoofer of 70 W (2 ), be sure to connect with Violet and Violet/black leads of this unit. Do not connect anything to Green and Green/black leads. Rear speaker or Subwoofer (4 ) White/black Gray Ground side Power supply side When you connect the separately sold multi-channel processor (e.g., DEQ-P8000) to this unit, do not connect anything to the speaker leads and systemremote control (blue/white). Parking brake switch Note: · Change the initial setting of this unit (refer to the Operation Manual). The subwoofer output of this unit is monaural. With a 2 speaker system, do not connect anything to the speaker leads that are not connected to speakers. Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal (max. 300 mA 12 V DC). Light green Used to detect the ON/OFF status of the parking brake. This lead must be connected to the power supply side of the parking brake switch. Note: · The position of the parking brake switch depends on the vehicle model. For details, consult the vehicle Owner’s Manual or dealer. 2. Clamp firmly with needle-nosed pliers. Yellow/black If you use equipment with Mute function, wire this lead to the Audio Mute lead on that piece of equipment. If not, keep the Audio Mute lead free of any connections. Violet/white Of the two lead wires connected to the back lamp, connect the one in which the voltage changes when the gear shift is in the REVERSE (R) position. This connection enables the unit to sense whether the car is moving forwards or backwards. 1. Clamp the lead. Connection method Fuse resistor 6 Left Front speaker White Black (chassis ground) Connect to a clean, paint-free metal location. Fuse resistor Red Connect to terminal controlled by ignition switch (12 V DC). Fuse (10 A) Fuse resistor Antenna input This product Use a mini plug cable to connect with auxiliary device. AUX jack (3.5 ø) Orange/white Connect to lighting switch terminal. Yellow Connect to the constant 12 V supply terminal. Connecting the power cord AVH-P4100DVD/XN/UC 5 7 8 2.4 CONNECTION DIAGRAM A B C D E F AVH-P4100DVD/XN/UC 8 15 D E F 16 1 4* 5* 2 Yellow (2*) Connect to the constant 12 V supply terminal. Red (4*) Connect to terminal controlled by ignition switch (12 V DC). Red (5*) Accessory (or back-up) 3 Speaker leads White: Front left White/black: Front left Gray: Front right Gray/black: Front right Green: Rear left or subwoofer Green/black: Rear left or subwoofer Violet: Rear right or subwoofer Violet/black: Rear right or subwoofer Parking brake switch Notes: · Change the initial setting of this unit (refer to the Operation Manual). The subwoofer output of this unit is monaural. · When using a subwoofer of 70 W (2 ) , be sure to connect with Violet and Violet/black leads of this unit. Do not connect anything to Green and Green/black leads. Blue/white (7*) Connect to auto-antenna relay control terminal (max. 300 mA 12 V DC). The pin position of the ISO connector will differ depending on the type of vehicle. Connect 6* and 7* when Pin 5 is an antenna control type. In other types of vehicles, never connect 6* and 7*. Blue/white (6*) Ground side Power supply side 3 When you connect the separately sold multi-channel processor (e.g., DEQ-P6600) to this unit, do not connect anything to the speaker leads and systemremote control (blue/white). ISO connector Note: In some vehicles, the ISO connector may be divided into two. In this case, be sure to connect to both connectors. Blue/white Connect to system control terminal of the power amp (max. 300 mA 12 V DC). Light green Used to detect the ON/OFF status of the parking brake. This lead must be connected to the power supply side of the parking brake switch. A Black (chassis ground) Connect to a clean, paint-free metal location. Fuse resistor Fuse resistor 2. Clamp firmly with needle-nosed pliers. Note: · The position of the parking brake switch depends on the vehicle model. For details, consult the vehicle Owner’s Manual or dealer. 1. Clamp the lead. Connection method Yellow/black If you use equipment with Mute function, wire this lead to the Audio Mute lead on that piece of equipment. If not, keep the Audio Mute lead free of any connections. Violet/white Of the two lead wires connected to the back lamp, connect the one in which the voltage changes when the gear shift is in the REVERSE (R) position. This connection enables the unit to sense whether the car is moving forwards or backwards. 2 Orange/white Connect to lighting switch terminal. Fuse (10 A) Connect leads of the same color to each other. Antenna input Yellow (3*) Back-up (or accessory) Cap (1*) Do not remove cap if this terminal is not in use. 2* Fuse resistor C 3* This product Use a mini plug cable to connect with auxiliary device. AUX jack (3.5 ø) B 1* Note: Depending on the kind of vehicle, the function of 3* and 5* may be different. In this case, be sure to connect 2* to 5* and 4* to 3*. Connecting the power cord AVH-P4100DVD/XNEW5, AVH-P4100DVD/XNUW5 1 4 AVH-P4100DVD/XN/UC 4 5 This product To subwoofer output To front output To rear output 6 7 Perform these connections when using the optional amplifier. When you connect the multi-channel processor to this unit, refer to multi-channel processor’s installation manual for the connection method. Front speaker Rear speaker Rear speaker Subwoofer R i ght Front speaker Subwoofer L ef t System remote control Connect with RCA cables (sold separately) Power amp (sold separately) Power amp (sold separately) Power amp (sold separately) This product Perform these connections when using the optional amplifier. When you connect the multi-channel processor to this unit, refer to multi-channel processor’s installation manual for the connection method. When you connect the separately sold multi-channel processor (e.g., DEQ-P6600) to this unit, do not connect anything to the speaker leads and system remote control (blue/white). The pin position of the ISO connector will differ depending on the type of vehicle. Connect 6* and 7* when Pin 5 is an antenna control type. In other types of vehicles, never connect 6* and 7*. Blue/white (6*) Power amp (sold separately) Front speaker Rear speaker Rear speaker Subwoofer R i ght System remote control Front speaker Subwoofer L ef t Power amp (sold separately) Power amp (sold separately) Connect with RCA cables (sold separately) Blue/white (7*) Connect to auto-antenna relay control terminal (max. 300 mA 12 V DC). To subwoofer output To front output To rear output Blue/white Connect to system control terminal of the power amp (max. 300 mA 12 V DC). Subwoofer output Front output Rear output When connecting to separately sold power amp AVH-P4100DVD/XNEW5, AVH-P4100DVD/XNUW5 6 When you connect the separately sold multi-channel processor (e.g., DEQ-P8000) to this unit, do not connect anything to the speaker leads and system remote control (blue/white). Blue/white Connect to system control terminal of the power amp or auto-antenna relay control terminal. (max. 300 mA 12 V DC). Subwoofer output Front output Rear output When connecting to separately sold power amp AVH-P4100DVD/XN/UC 5 7 8 A B C D E F AVH-P4100DVD/XN/UC 8 17 E F 18 1 2 USB cable Connect to sparately sold USB device. 3 1.5 m IP-BUS input USB cable USB input Black Bluetooth adapter (e.g. CD-BTB200) (sold separately) IP-BUS cable (Supplied with Bluetooth adapter) Interface cable (CD-IU200V) (sold separately) Dock connector 1.5 m Microphone for hands-free phoning (supplied with Bluetooth adapter) iPod with video capabilities (sold separately) AUX input (AUX IN) WARNING Fuse resistor Violet/white Of the two lead wires connected to the back lamp, connect the one in which the voltage changes when the gear shift is in the REVERSE (R) position. This connection enables the unit to sense whether the car is moving forwards or backwards. Rear view camera You must use a camera which outputs mirror reversed images. To video output RCA cable (sold separately) Rear view camera input (REAR CAMERA IN ) • It is necessary to set Camera Polarity properly in System Menu when connecting the rear view camera. This product CAUTION • The screen image may appear reversed. • The rear view camera function is to be used as an aid for backing into a tight parking spot. Do not use this function for entertainment purposes. • Objects in the rear view may appear closer or more distant than they actually are. CAUTION USE INPUT ONLY FOR REVERSE OR MIRROR IMAGE REAR VIEW CAMERA. OTHER USE MAY RESULT IN INJURY OR DAMAGE. 2 This product Wired remote input Hard-wired remote control adaptor can be connected (sold separately). Black IP-BUS cable (Supplied with Bluetooth adapter) 1.5 m (4 ft. 11 in.) When connecting with optional CD-IU200V cable 1.5 m (4 ft. 11 in.) This product Bluetooth adapter (e.g. CD-BTB200) (sold separately) When this product is used with a rear view camera, it is possible to automatically switch from the video to rear view image when the gear shift is moved to REVERSE (R). A IP-BUS input Blue D Microphone for hands-free phoning (supplied with Bluetooth adapter) C When connecting with a rear view camera B Wired remote input Hard-wired remote control adaptor can be connected (sold separately). When connecting with supplied USB cable 1 3 4 AVH-P4100DVD/XN/UC 4 5 ToRR ToRL Wired remote input Hard-wired remote control adaptor can be connected (sold separately). (UW5) 6 IP-BUS input Blue 7 IP-BUS cable (supplied with multi-channel processor) Multi-channel processor (e.g., DEQ-P8000 (UC) / DEQ-P6600 (EW5,UW5)) (sold separately) Blue Optical cable (supplied with multi-channel processor) Optical cable 2. Connect the optical cable to the optical cable connection box. Screw Connect the optical cable so that it does not protrude from the main unit, as shown in the illustration. Fasten the ground lead to the protrusion on the back of the main unit. 1. Connect the optical cable and ground lead to the main unit. Connecting the optical cable • Install this unit using only the parts supplied with this unit. If other parts are used, this unit may be damaged or could dismount itself, which leads to an accident or other problems. • Do not install this unit near the doors where rainwater is likely to be spilled on the unit. Incursion of water into the unit may cause smoke or fire. CAUTION • Avoid installing the optical cable connection box in locations where the operation of safety devices such as airbags is prevented by this unit. Otherwise, there is a danger of a fatal accident. • Avoid installing the optical cable connection box in locations where the operation of the brake may be prevented. Otherwise, it may result in a traffic accident. • Fix the optical cable connection box securely with the hook and loop fastener or lock tie. If the unit is loose, it disturbs driving stability, which may result in a traffic accident. WARNING Fasten with the lock tie Wrap with the protection tape Wrap the optical cable and connection box with the protection tape and fasten with the power code using the lock tie. • When installing the optical cable connection box with the lock tie. Loop fastener Hook fastener Install the optical cable connection box using the hook and loop fastener in the ample space of the console box. • When installing the optical cable connection box with the hook and loop fastener. Installing the optical cable connection box Connecting and installing the optical cable connection box 6 Black Black IP-BUS cable (Supplied with Bluetooth adapter) Blue Bluetooth adapter (e.g. CD-BTB200) (sold separately) Microphone for hands-free phoning (supplied with Bluetooth adapter) Optical cable connection box (supplied with multi-channel processor) RCA cable (supplied with multi-channel processor) Black This product RGB input Optical output (Black) Please contact your dealer to inquire about the connectable navigation unit. Navigation Unit (sold separately) When connecting with a multi-channel processor 5 7 8 A B C D E F AVH-P4100DVD/XN/UC 8 19 D E F 20 1 2 Audio input (L IN , R IN ) Rear monitor output (V OUT ) To audio outputs External video component (sold separately) To video output To video input 3 Never install the display in a location where it is visible to the driver while driving. WARNING This product’s rear video output is for connection of a display to enable passengers in the rear seats to watch video. When using a display connected to rear video output 2 • It is necessary to change AV Input in System Menu when connecting the external video component. This product Video input (V IN ) RCA cables (sold separately) Display with RCA input jacks (sold separately) When connecting the external video component and the display 1 3 4 A B C AVH-P4100DVD/XN/UC 4 5 6 7 8 3. BASIC ITEMS FOR SERVICE 3.1 CHECK POINTS AFTER SERVICING A To keep the product quality after servicing, please confirm following check points. No. 1 Procedures Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check. 2 Flap-mecha 3 DVD Check points The customer complain must not be reappeared. Display, video, audio and operations must be normal. Check the operation of the flap mechanism. The flap mechanism operation must be smooth without making the noise and scratches. Measure playback error rates at the Deterioration of mecha-drive can be checked. innermost and outermost tracks by using the The error rate must be less than the test mode with the following disc. threshold value. DVD test disc (TDV-582) (Refer to the chapter of DIAGNOSIS for the threshold value.) 4 DVD Play back a DVD. (Menu operation; Title/chapter search) Display, video, audio and operations must be normal. 5 CD Play back a CD. (Track search) Display, audio and operations must be normal. 6 FM/AM tuner Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM. Display, audio and operations must be normal. * If the reception sensitivity is poorer than normal, the gasket on the FM/AM tuner unit may be damaged or lost. 7 Check whether no disc is inside the product. The media used for the operating check must be ejected. 8 Appearance check No scratches or dirt on its appearance after receiving it for service. B C See the table below for the items to be checked regarding video and audio: Item to be checked regarding video Block-noise Horizontal noise Dot noise Disturbed image (video jumpiness) Too dark Too bright Mottled color D Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted E F AVH-P4100DVD/XN/UC 5 6 7 8 21 1 2 3 4 3.2 PCB LOCATIONS A B IF PCB B E Keyboard Unit G Service PCB Assy A Mother PCB F Monitor Unit C C DVD Core Unit D D Connect PCB E F 22 Mother Unit Unit Number : CWN3797(UC,EW5) Consists of Unit Number : CWN3796(UW5) Mother PCB Unit Name : Monitor Unit IF PCB Unit Number : YWX5007 DVD Core Unit Unit Number : CWN3794(UC) Unit Name : Unit Number : CWN3790(EW5) Unit Number : Unit Number : CWN3795(UW5) Unit Name : Connect PCB Unit Name : Mother Unit Unit Number : EXX1058 Unit Number : (UC,EW5) Unit Name : Service PCB Assy Unit Number : (UW5) Unit Name : Keyboard Unit AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 3.3 JIGS LIST A DVD Module GGD1524 B Mother PCB Drive Unit GGD1170 C GGF1461 GGF1495 GGD1380 LCD Monitor Unit D - Jigs List Name 60-Pin Relay PCB 60-Pin FFC 40-Pin + 20-Pin Relay PCB 40-Pin FFC 11-Pin FFC Disc Jig No. GGF1495 GGD1380 GGF1461 GGD1170 GGD1524 TDV-582 Disc TCD-782 Remarks LCD <--> 60-Pin FFC (GGD1380) 60-Pin Relay PCB (GGF1495) <--> Monitor PCB (CN6001) Monitor Unit (CN5001) <--> FFC (CDE8744) 40-Pin + 20-Pin Relay PCB (GGF1461) <--> Mother PCB (CN501) Mother PCB (CN801) <--> Drive Unit Skew adjustment, Check points after servicing, Inspection method of Pickup Unit Inspection method of Pickup Unit E - Grease List Name Grease Grease Grease Locking agents Bond Bond Jig No. GEM1024 GEM1038 GEM1045 1401M GEM1033 1530 Remarks DVD Mechanism Module DVD Mechanism Module DVD Mechanism Module Skew adjustment (1401M:produced by THREE BOND) Skew adjustment Skew adjustment (1530:produced by THREE BOND) F AVH-P4100DVD/XN/UC 5 6 7 8 23 1 2 3 4 3.4 CLEANING A Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned DVD pickup lenses Cleaning tools Cleaning liquid : GEM1004 Cleaning paper : GED-008 B C D E F 24 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 25 26 1 JA2002 F MINI JACK 2 B.CAM INPUT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 A JA2003 B JA2001 WIRED REMOTE 3 GND BUSL+ BUSLAUXL AUAGND AUXR MAINTEST AUVGND AUXV BCAM_IN BCAM_VGGND GNDV GNDD WIREDAD WIRED NC ANR GNDSIG ANG GNDSIG ANB GNDSIG CSYNC GNDSIG CCAUL CCAUR GNDAU ONSEI+ ONSEI- BUSBUS+ ASENSB0 BUSR+ BUSR- 1 2 3 4 5 6 7 8 9 10 11 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 MOTV HALFSW HOMESW OPENSW MOT5V PULSE1 PULSE0 MOT1 MOT0 GND GND 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 GNDILM GNDFL GNDFL GNDFL NC PWRFL PWRFL PWRFL NC GNDD GNDD GNDD GNDV MONVBS GNDV GNDRGB CSYNC NAVI_R NAVI_G NAVI_B GNDRGB GNDP GNDP GNDP NC PWRVI C 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 F CCR CCG CCB CCSYNC GNDSIG DVDVBS GNDDVD YS NC CCAUL CCAUR GNDAU ONSEI+ ONSEIREAUR REAUL GNDRAU CCREM DSEN TVON GION MONON VSW5 SYS_TO_NAVI NAVI_TO_SYS GNDD 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 B CN5003 VCOM VCOM NC VEE NC SPS U/L CLS MODE CS GND NC VDD NC SPR VCC VSHD NC GND CLD GND GND NC VSHA VSHA NC 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 2 1 3 2 KEYBOARD UNIT 14 REM 13 GNDKEY 12 HDRST 11 LEDB1 10 LEDG1 9 LEDR1 8 LEDB2 7 LEDG2 6 LEDR2 5 KDT0 4 KDT1 3 ILMB 2 SWVDD33 1 GNDKEY 2 B.CAM_IN CN901 DVD MECHANISM MODULE (LS1) VD 30 VD 29 VD 28 PGND 27 PGND 26 DGND 25 VDD5 24 AMUTE 23 XRES 22 IRQPWR 21 S LS1TX 20 LS1 SRX 19 STANBY 18 AGND 17 ROUT 16 AGND 15 LOUT 14 AGND 13 COMPOSIT 12 VGND 11 DGND 10 D9 D+ 8 DGND 7 IECOUT 6 DGND 5 SCK 4 SDA 3 CPRST 2 DGND 1 CN801 CXE1173 D C D E 1 BCV_GND 1 VIDEO 2 GND 3 AUXR 4 AUXL G E DRIVE UNIT 1 3 4 4. BLOCK DIAGRAM 4.1 OVERALL CONNECTION DIAGRAM A MONITOR UNIT F 1/2 MONITOR UNIT(uCOM) F 2/2 MONITOR UNIT(MONITOR) CN5001 CN501 MOTHER PCB A 1/4 MOTHER PCB(ANALOG) A 2/4 MOTHER PCB(TUNER) A 3/4 MOTHER PCB(SYSTEM) A 4/4 MOTHER PCB(POWER SUPPLY) 40FY-BMGB(LF)(SN) CN121 CN2002 IF PCB CN2001 NAVI INTERFACE AVH-P4100DVD/XN/UC 4 19 20 21 22 23 24 25 26 1 2 3 4 5 6 7 8 9 10 11 DSEN TVON GION MONON VSW5 SYS_TO_NAVI NAVI_TO_SYS GNDD BUS+ BUSG BUSLG MAINTEST BUSBUSRG BUSL+ ASENBO BUSR+ BUSRBUSL- GNDSIG ANG GNDSIG ANB GNDSIG CSYNC GNDSIG CCAUL CCAUR GNDAU ONSEI+ ONSEINC TVON GUIDEON SYS_TO_NAVI NAVI_TO_SYS GNDD USB5V DD+ USBGND Shield1 Shield2 VCR_VIN VCR_VG VCR_LIN VCR_LG VOUT VOUT_G VCR_RIN VCR_RG REAR_R REAR_L SW_R SW_L FRONT_R FRONT_L GND GND GND GND 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 6 8 7 6 5 4 3 2 1 1 2 3 4 5 6 7 8 9 10 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 IP BUS 5 USB VCR IN RCA OUT CN522 6 JA102 7 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 CN6101 TH_G TH NC A2NC A1NC A1+ NC A2+ 10 9 8 7 6 5 4 3 2 1 CN501 BACKLIGHT CN5401 TOUCH PANEL CSX1142 NC 10 ADVY 9 ADVY 8 ADVX 7 ADVX 6 PLXV 5 PLXV 4 PLYV 3 PLYV 2 NC 1 JA402 JA141 1 FR- RR- FR+ RR+ FL- JA951 5 RL6 FL+ 7 P.B. RL+ 8 MUTE 10 9 B.REM ILM BGSENS ACC B.UP JA101 1 2 3 POWER SUPPLY GNDV GNDRGB CSYNC NAVI_R NAVI_G NAVI_B GNDRGB GNDP GNDP GNDP NC PWRVI PWRVI PWRVI SWVDD33 SWVDD33 ILMB MONRST S_MTX M_SRX MFLPWR HDRST GNDOSD GNDOSD GNDILM GNDILM SPR VCC VSHD NC GND CLD GND GND NC VSHA VSHA NC GND LBR LS R5 R4 R3 R2 R1 R0 G5 G4 G3 G2 G1 G0 B5 B4 B3 B2 B1 B0 V10 V9 NC V7 NC V5 NC V3 NC NC V0 SPL GND 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 6 S/PDIF OUT 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 5 7 8 LCD MODULE A CWX3691 CN6001 B CN5001 C 2 FM/AM ANT 1 2 3 4 D 11 12 13 14 15 16 E JA2004 F CE AVH-P4100DVD/XN/UC 8 27 1 2 3 4 4.2 BLOCK DIAGRAM A A MOTHER PCB (1/2) CN901 24 28 I 30 6 VDD5 SPDIFSENS VD5 VD VD8 5 1 IECOUT Q951 4 2 SPDIFOUT IC951 TC7SET08FUS1 14 LOUT IPOD CP IC IC561 341S2162 C B SCK 4 CN1901 18 19 20 21 22 23 12 Q901 nRESET 13 I2C_SDA/ SPI_SOMI 12 I2C_SCL/ SPI_SIMO SDA 3 Q902 SYS+B 4 CPRST 2 STANBY STNDBY LS1 SRX MS_SRX S LS1TX S_MSTX IRQPWR E 9 COMPOSIT D+ 3 D- 2 VDCNT5 1 13 A2 B1 A1 B2 12 11 1OE USB 5V IC521 R5523N001B D- DD5 1 5 USB5V 1 VIN EN VOUT OC 3 USBCNT 4 USBFLG 37 8 4 VCR_LIN VCR_L 8 VCR_VIN VCR_V 39 VOUT R_VOUT 32 AUX_L 15 AUX_V 41 BCAM_IN 47 B LOUT1 IN2_L IN5+_L STNDBY 27 MS-SRX 29 S-MSTX 31 IRQPW 18 XRES 17 AMUTE 13 USBCNT 10 USBFLG 11 S R T I X A U U CN2002 AUXL 3 AUXR 2 GND 1 VIDEO AUXV JA2003 2 B.CAM_IN BCAM_IN 28 VOUT2 L3-1 SCL V3-1 SDA V6-1 FB1 4 AUXL B.CAMERA INPUT IN4-_L V2-1 IF PCB JA2002 MINI JACK 2 L2-1 VOUT1 D TUN_L IN4+_L V1-1 JA102 VCR IN 6 AV SELECTOR IC301 AN15887A LS-V 6 4 LOUT 2OE D+ 2 BUSL- IN1_L AMUTE CN522 USB 3 XRES AMUTE TO 2/2 3 BUSL+ IRQPW XRES F C 7 TO 2/2 IC522 TC7MBL6126SFK 8 LS_L 36 144 35 1 A A 34 33 CN121 9 32 14 27 15 26 AUXL AUX_L AUXV AUX_V BCAM_IN Q121 125 JA2004 7 11 8 4 123 BUP_1 1 BCV_GND ASENBO BUSL+ BUSL+ BUSL- BUSLASENBO ASENBO MAINTEST MAINTEST 7 34 8 33 3 38 12 29 2 39 1 40 73 BUSL+ 75 BUSL- 138 ASENBO NC 139 MAINTEST A M T R W W IP BUS E 1 5 BUS+ BUS+ BUS- BUS- 6 BUS+ 5 BUS- IP-BUS DRIVER BUS+ DIN1 BUS- ROUT IC751 HA12241FP 1 TXIE 2 RXIE JA2001 2 WIREDAD WIREDAD 3 WIRED WIRED REMOTE WIRED 19 22 20 21 WIREDAD WIRED 1 GNDD 52 55 53 CN2001 20 24 NAVI I/F 25 F 1 2 3 4 28 Q601 TVON TVON SYS_TO_NAVI SYS_TO_NAVI NAVI_TO_SYS NAVI_TO_SYS CCR ANR CCG ANG CCB ANB CCSYNC CSYNC 36 5 38 3 39 2 22 19 24 17 26 15 28 13 TVON RGBON SYS_TO_NAVI TXNADI NAVI_TO_SYS RXNAVI Q771 SYS+B ANR ANG ANB CSYNC AVH-P4100DVD/XN/UC 1 2 3 4 R T R 5 6 7 8 A JA951 7 + 3 - 4 T 6 L 2 IN1_L Front_L IN4+_L IN4-_L IN2_L IN5+_L E.VOL CAPTAIN6 IC201 PML018A Rear_L CLK STB 27 S-SRX 29 MSTX 31 ES 18 17 MUTE 13 SBCNT 10 SBFLG 11 1 S/PDIF OUT FRONT_L 6 STANDBY EVSDA RXLS1 EVSCK TXLS1 EVSEL 11 RCA_RL REAR_L RCA_SWL 12 19 EVSDT 20 EVSCK 21 EVSTB SW_L Q103 Q105 AMP IC181 PA2030A 109 EVSDT 110 EVSCK PA_FL 11 111 EVSTB PA_RL 15 Q183 4 FLIN FL+ RLIN FL- STBY XRESET RL+ 129 RL- USBCNT AMPMUTE USBFLG SYSMUTE B 4 BUP_1 SYS+B AMPPW RCA OUT Q101(2/2) IRQPW AMUTE 2 Q105 DATA NDBY 2 GND JA101 RCA MUTE RCA_FL 3 SPDIFOUT Q101(1/2) Pre/SW_L QPW 10 SPDIFSENS Q182 (1/2) 131 22 B.REMOTE JA141 9 FL+ 7 7 FL- 5 17 RL+ 8 19 RL- 6 25 B.REM 11 MUTE C SYSTEM uCON IC601(1/2) PEG535A8(UC) PEG534A8 (EW5,UW5) OFFMUTE Q181 BUP_1 Q182 (2/2) B.UP 16 BUP_1 ASENS Q162(1/2) ASENS ACC 14 9 BSENS Q162(2/2) BSENS 8 POWER CONNECTOR BUP_1 Q165 PBSENS Q163(1/2) 144 1 AVSCK PBSENS 135 P.B. 9 TELMUTE AVSDATA Q163(2/2) TELMUTE 134 MUTE 10 D ISENS Q161 ISENS 137 ILM 12 BGSENS Q164 BGSENS 136 BGSENS 13 INSERTION LED DD5 123 125 73 75 138 139 ASENBO MAINTEST FLPILM D801 Q801 TXIE RXIE 67 RESET 1 19 RESET IC602 S-80827CNNB-B8M 2 VDD33 CN501 WIREDAD HDRST TO 2/2 RXMON TXMON MONIRST D MFLPW 45 55 53 MFLPWR M_SRX 44 S_MTX 47 MONRST DD8 52 5 WIRED :AVH-P4100DVD/XN/UC :AVH-P4100DVD/XNEW5 C :AVH-P4100DVD/XNUW5 RGBON A D B E ACC33 TO 2/2 PWVI F TXNAVI RXNAVI PWFL ILMB SWVDD33 6 E 7 8 9 10 11 . 12 PWRVI 13 I E CN5001 15 PWRFL 33 I 35 MONVBS 27 RGB VIDEO ISOLATOR IC771 NJM2138V 10 5 3 12 C_+IN C_OUT B_+IN B_OUT A_+IN A_OUT D_+IN D_OUT 8 NAVI_R 7 NAVI_G 1 NAVI_B 14 CSYNC F 23 22 21 24 C AVH-P4100DVD/XN/UC 5 6 7 8 29 1 A 2 3 4 MOTHER PCB(2/2) A SYS+B IC1061 NJM2388F84 1 BUP_1 VIN VOUT 2 SYS+B CONTROL 4 SYSPW 128 SYSPW TUN3.3V IC1081 NJM2886DL3-33 JA402 SYSTEM uCON IC601(2/2) PEG535A8(UC) PEG534A8 (EW5,UW5) 1 ANTENNA 2 2 DD5 VIN VOUT 4 1 SYSPW HIOUT12V Q1141 DD8 1 B 3 23 5 6 FM/AM TUNER UNIT U401 8 9 10 14 11 AM_ANT Lch HIOUTCLK TUN_L E 3 Vcc 7 OSC 92 TO 1/2 SL 119 CE2 114 CE1 113 CK 117 DI 118 DO 116 LDET 103 IC1141 TK11840L Out 5 PWVI P1021 PWVI TUNSL TUNPCE2 BUP_1 TUNPCE Q1002 Q1001 TUNPCK VDD33V VDD33 TUNPDO TUNPDI 2 LDET IC1001 S-812C33AUA-C2N 3 Q404 18 19 RDS_CK 104 RDS_DATA 105 D/D CONVERTER IC1201 BD9013KV RCK RDT Q403 20 C EV12 Q1142 Q1143 FM_ANT TUN33V CONT 21 SW1 107 RDS_LOCK 106 RDS_HSLK RDSLK RDS57K B 4 13 17 VCC ROM_VDD VDD_3.3 SYS+B C VDCNT5 VDCONT5 VDCONT8 DDCCLK TO 1/2 P1202 13 VD5 Q1201 F 25 26 26 27 80 34 1 EN1 OUTH1 EN2 3 SYNC OUTL1 VDD33 FB1 TUN33V COMP1 P1201 7 BUP_1 8 5 10 3 41 12 VCC VCCCL1 SW2 VIN IC1401 S-1112B33MC-L6S VOUT CL1 OUTH2 5 ACC33 ON/OFF 15 21 22 P1203 48 VD8 Q1202 VCCCL2 CL2 DD5 ACC33V DD8 1 EXTVCC OUTL2 FB2 D COMP2 46 39 38 MOTV Q1341 P1341 DD8 BEEP XOUT XIN 85 MOTV BZ601 BUZZER 20 22 PWFL X601 15MHz P1022 Q1022 PWFL TO 1/2 D MFLPW Q1021 CN801 E NC(OPENSW) MOT0 MOT1 PULSE0 PULSE1 HALFSW HOMESW 30 OPENSW 32 MOT0 33 MOT1 34 PULSE0 35 PULSE1 36 HALFSW 37 HOMESW :AVH-P4100DVD/XN/UC B :AVH-P4100DVD/XNEW5 C :AVH-P4100DVD/XNUW5 VD5 D E TO 1/2 F F 30 AVH-P4100DVD/XN/UC 1 2 3 4 9 8 7 6 2 3 1 MOTV A 4 MOT5V 5 DRIVE UNIT INTERFACE 5 6 7 8 A B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 31 1 2 3 C 4 DVD CORE UNIT A NRES VIDEO+AUD IC1501 MN2DS0018M 70 NRES S S FLASH 16M D0-15 IC1401 CWW1753 B A0-19 CE 26 XCFS1 59 26 XCFS2 213 11 XWR1 31 28 XRD 214 XCSSR USB_ IC1402 CWW1754 CE WE NRES 12 RESET OE NEXCE NEXWE NEXOE MA0-11 MDQ0-15 LDQM UDQM BA0 BA1 WE CAS RAS CS CLK 15 39 20 21 16 17 18 19 38 DQM0 DQM1 XWE XCAS XRAS XCSM MCK I COM ST ST CMD IR E SDRAM IC1480 K4S641632N-LC75 C I2 I2 CP 179 180 193 197 181 188 189 190 183 185 DQM0 DQM1 BA0 BA1 NWE NCAS NRAS NCSM MCK MCKI TRC TRC TRC TRC T E S F+ E+ D D CONNECT PCB LS1 MECHA UNIT LOADING/CARRIAGE MOTOR SPINDLE MOTOR V U W E CN701 CRG1 CRG+ 2 BR GY M MOTOR DRIVER IC1201 BD8231EFV CN1201 32 31 CRG/LE18 CRG/LE+ 17 CN101 1 2 3 V 1 2 U W 3 COIL V 10 COIL U 11 COIL W 12 9 8 7 27 26 28 COIL_V COIL_U COIL_W H1 HUP(HU+),HUM(HU-) HUP(HU+),HUM(HU-) H2 HVP(HV+),HVM(HV-) HVP(HV+),HVM(HV-) H- 4 H+ 10 H4 H+ 10 V U W FCO+ 33 34 FCO36 TKO35 TKO+ HWP(HW+),HWM(HW-) HWP(HW+),HWM(HW-) H3 HALL BIASHALL BIAS+ HOME S101 HOME 8cm S102 8SNS 12cm S103 DSCSNS 3 13 HALL_BIAS16 HALL_BIAS+ 6 16 3 15 14 4 5 1 VC 2 TKIN 3 FCIN 4 SLIN 5 SLOPOUT 6 LDIN 7 SPIN 8 CTL1 9 CTL2 12 FG SL/LDOSL/LDO+ 14 VHALF TD FD CRGDRV 110 126 127 67 MD CONT1 CONT2 62 66 63 64 71 2 D HB VCC5 HOME 65 8cm 49 12cm(DSCSNS) 55 AVH-P4100DVD/XN/UC 1 LDIN MD CONT1 CONT2 FG FOP FOM TOP TOM F 32 VHALF TD FD CRGDRV 3 4 HOME 08EJ V 12EJ 5 6 7 8 A CN1901 VIDEO+AUDIO IC1501 MN2DS0018MAUB 70 NRES SRCK ADOUT LRCK SDODAC SCKDAC LTDAC DACCK XCSSR USB_CLOCK 149 151 150 57 58 56 148 1 2 3 13 14 15 16 SRCK ADOUT LRCK SDODAC SCKDAC LTDAC DACCK BCK DATA LRCK MD MC ML SCK VOUTL 7 31 214 179 180 193 197 181 188 189 190 183 185 110 126 127 67 62 66 63 64 71 NEXCE NEXWE NEXOE DQM0 DQM1 BA0 BA1 NWE NCAS NRAS NCSM MCK MCKI VHALF TD FD CRGDRV LDIN MD CONT1 CONT2 FG I2C_SCL I2C_SDA CP_Reset IECOUT ROUT LOUT COMPOSITE STANDBY STSCOMN CMDCOMN IRQPWR EXTRG1 TRCST TRCDATA3 TRCDATA2 TRCDATA1 TRCDATA0 TRCCLK EXTRG0 SDATA SCLOCK F+H_G+H E+G_E+F LPCO2 LPCO1 VIN3RF VIN4RF VIN2RF VIN1RF VIN7 VIN8 CDMPD DVDMPD TEMP RFINP VREFH VIN1 VIN2 VIN4 VIN3 VIN6 VIN5 OSCO 65 55 ANALOG LOUT 50 2 4 VCC5 D+ D- 5 VOUT VIN ON/OFF 9 17 27 28 29 25 23 22 19 13 12 A CN901 B 11 10 8 7 1. 2 VD8 4 3 VD8 3 AVCC5 REG. IC1003 S-1200B50-M5 AVCC5 5 VOUT VIN ON/OFF 1 3 C AMUTE 81 80 79 78 77 76 74 73 72 CN1951 112 111 106 104 100 99 98 97 115 116 105 103 122 96 TRCST TRCDATA3 TRCDATA2 TRCDATA1 TRCDATA0 TRCCLK EXTRG0 SDATA SCLOCK 3.3V REG. IC1004 NJM2885DL1-33 B A C D FE1 FE2 3 VCC33 OUT IN 1 VDD5 1.2V REG. IC1005 R1232D121B 8 VCC12 LX 5 VOUT VIN VDD CE 2 3 4 VDD5 DEBUG D 9 CN1101 VREF VCC5 F+H_G+H E+G_E+F RF 109 120 119 118 117 114 113 1 2 3 4 5 6 7 8 12 13 VCC33 VREF Q1102 Q1104 Q1101 Q1103 78LD LPCO1 156 155 CDMPD DVDMPD 121 12EJ FOP FOM TOP TOM Vref VCC F+H/G+H E+G/E+F LPCO2 08EJ VDSENS VD5 VDD5 VCC5 REG. IC1002 S-1133850-U5 47 46 61 152 146 144 138 191 54 53 48 75 SCL SDA RESET IFCOUT D+ DCOMPOSIT STANBY SLVSTS HSTCMD IRQPWR AMUTE COMPOSITE STANDBY STSCOMN CMDCOMN X1501 HOME OSCI 49 LOUT ISC_SCL I2C_SDA CP_Reset X1950 213 XRESET AUDIO 2CH ANALOG OUT IC1801 PCM1753DBQ IC1951 TC7SZU04FU 59 NRES 65LD B A C D FE1 FE2 78MD 65MD TEMP RF 2 3 4 5 7 8 10 11 12 13 E PU (DP10) 14 15 17 18 20 22 F+ 25 F24 T+ 23 T26 F AVH-P4100DVD/XN/UC 5 6 7 8 33 1 2 F 3 4 MONITOR UNIT A GERDA IC5702 MN103SE60PUB C.VIDEO CN5001 14 17 18 19 20 Q5451 MONVBS 4 CSYNC 34 A CN501 B 35 LCD_G_[0-5] NAVI_G VIDEO_AD IC5601 AK5406XQ MONITOR uCON IC5101 PE5669A8 NAVI_B S_MTX 53 M_SRX 52 MFLPWR 28 CSYNC 49 NAVI_R 54 NAVI_G 48 43 SCL RXD0/TSI TXD0/TSO SDA VADRES MFLPW 21 56 22 57 23 61 LCD_B_[0-5] GPIO_05 SOGIN DVR[0-5] PWRFL I 8 RXD1 26 PWRVI I 28 29 . 30 36 TXD1 LCDHSY DVB[0-5] BIN SCL VSYNCO SDA HSYNCO RESETN DTCLK LCDVSY 62 162 64 161 65 160 50 128 51 127 ILMB LCDCLK 189 192 193 194 195 196 DVVSY COMDC DVHSY DVCLK COMAC HDRST EPRCE 10 MONRST RESET EPRDI EPRCK 3 1 4 3 5 4 6 2 DI CKE DO CLK SK CAS WE 9 1 2 10 TOOL1 8 FLMDO 13 SWVDD 37 16 38 17 18 RAS TOOL0 191 SDM[0,1] RSTIN 4 LCDCE SDD[0-15] CN5101 RSTOUT Q6151 SDBA[0,1] CS CS 3 TXD0 RXD0 SDA[0-11] RAM IC5301 K4S281632K-UC75 EEPROM IC5102 S-93C56BD0I-J6 EPRDO 32 8. 9 LCDDEN DVG[0-5] GIN SWVDD33 31 uCON REWRITE LCDCSY RIN AVH-P4100DVD/XNUW5 Only 6 C LCD_R_[0-5] 168 AINP0 NAVI_R NAVI_B 33 Q5452 1 IC5451 NJM2505AF 19 40 18 41 17 42 16 43 SDCKE MEMCLK MIMCLK SDCS SDRAS SDCAS SDWE IC5701 TC7SHU04FUS1 TOOL0 FLMDO 200 4 2 TOOL1 X5701 9.597MHz SWVDD33 180 X5702 33MHz Q61 LCDICLK BLSYNC OSCXO Q61 DIMMER 179 OSCXI TEMPSEN BLERR1 FAD[0-21] X1 X2 ROM IC5201 PEH208A8 15 X5101 20MHz 14 FDATA[0-15] WE OE CE RESET 11 84 28 86 26 85 12 135 FRWE GPIO_04 FROE GPIO_03 FRCS GPIO_02 XRST SDATA SCLOCK XRST D COMDC COMAC BLSYNC DIMMER TEMPSEN BLERR1 ADVX 75 64 63 D/D CONVERTER IC5501 BD6171KV 41 62 Q5401 (1/2) E TOUCH PANEL 2. 3 46 45 PLYV Q5403 (1/2) SWVDD33 65 42 PNLADY PNLADX PNLVD Q5401 (2/2) FSEL MVIPW PWCTL1 PNLYV PWCTL2 PWCTL3 4. 5 PLXV Q5402 (1/2) ILMLD SWVDD33 ILMCK 44 Q5402 (2/2) 39 43 27 32 34 34 35 35 36 36 TOUCHAD Q5403 (2/2) PNLXV ILMDT REMIN KDT0 KDT1 PVCC1 PVCC2 OUT2 VS2 PVCC PVCC3 VCC PVCC5 FIN 8V REGULATOR Q5502 4 7 3 S G D Q5505 1,2,5,6 4 23 37 10 OUT1 13 VS1 3.3V REGULATOR Q5501 4 S 1,2,5,6 D G 3 EN1 EN3 EN4 EN5 PVCC4 OUT3 OUT4 48 22 47 78 77 Q5561 Q5504 76 74 OUT5 38 Q5503 68 CHARGE PUMP REGULATOR PWCTL2 67 F 34 AVH-P4100DVD/XN/UC 1 2 122 25 CN5401 6. 7 123 57 6 61 130 58 11 ADVY 131 GRST 29 PWRVI 8. 9 190 3 4 5 6 7 8 LCD PANEL A CN6001 5] LR[0-5] 5] LG[0-5] LB[0-5] 5] 05 SY EN SY SY LK 30 | 35 36 | 41 42 | 47 189 MODE 192 LS 193 CLS 194 SPL 195 SPS 196 CLD COMDC LCD 9 29 8 59 6 20 VCOM AMP IC6151 NJM082BV 3 + 2 - COMAC 1 VCOM DRIVE 5 + 6 - 7 VCOM Q6001 Q6002 VCOM 1 2 B Q6151 8 9 CE 191 LADDER NETWORK 10,12 11,13 IC6005 TC74VHCT04AFTS1 5 1,3 6 48 . 49 . 51 . 53 . 55 . 58 V[0,3,5,7,9,10] 2,4 VEE VCCM16V CS VDD VCC15V VCC VCC3.3V VSHD LBR 7 OSC OUT 3 5 G D1-4 S 4 BR/CTL EaIn C CN6101 Q6102 Q6101 DIMMER 16 17 28 VSHA 24 . 25 VCC53V BLSYNC 13 PWRFL IC6101 TK11840L Q6103 4 10 A2+ 1,2,5,6 A2- 4 A1+ A1- 1 TEMPSEN TH 1 7 3 LCD BACKLIGHT 5 9 BLERR1 CN5701 TRCD[0-3] 04 03 02 TA CK EXTRG0 190 131 TRCST 130 TRCCLK 123 SDATA 122 SCLOCK GRST GD33V 3 5 6 8 GERDA REWRITE 9 4 1. 2 D VCC8V E KEYBOARD UNIT RGB LED DRIVER Q5001 ILMLD 3.3V 10 CSB AO1 ILMB IC5001 BH2227AFV VCC3.3V GD33V ILMCK 11 ILMDT 12 CLK AO2 LEDR1 2 V33A LEDG1 VCC53V CN3003 CN5003 1 3 3 9 9 10 10 ILMB D3005 LEDR1 E LEDG1 Q5002 DI AO3 5 LEDB1 11 11 LEDR2 6 6 7 7 8 8 2 2 LEDB1 VCC15V D3002 Q5003 Q5561 LEDG2 LEDR2 LEDG2 Q5004 LEDB2 VCCM16V SWVDD33 REM KDT0 Q5562 KDT1 14 14 5 5 4 4 LEDB2 REMOTE CONTROL SENSOR 4 U3001 2 RS-470 SWVDD33 REM 12 12 S3006 EJECT S3001 SOURCE S3007 MUTE S3002 FORWARD S3009 VOL+ S3003 REVERSE S3004 VOL- KDT1 S3005 RESET HDRST OPT IN KDT0 F S3008 DISP,OFF HDRST AVH-P4100DVD/XN/UC 5 6 7 8 35 1 2 3 4 5. DIAGNOSIS 5.1 OPERATIONAL FLOWCHART A RESET Vdd : pin 23 Vdd = 3.3 V? Y BSENS : pin8 B BSENS = L? Y ASENS : pin9 ASENS = L? Y STANDBY : pin27 STANDBY = H? Y ASENBO : pin123 C VDCNT5 : pin25 ASENBO <- H Standby VDCNT5,8 <- H VDCNT8 : pin26 Starts Communication with Display microcomputer Source keys operartive Source ON D SYSPW : pin128 SYSPW <- H E F 36 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 5.2 INSPECTION METHOD OF PICKUP UNIT Disc to be used A CD-DA: TCD-782 DVD-Video: TDV-582 Execution method Replace the PICK UP START LD turned on? SKEW ADJ. Check parts B No Yes Check point: AS MAX check Check point: LD current check LD current check Is it OK? RF level check Is it OK? Replace the PICK UP No No Check point: Error rate check Yes Yes Error rate check C Is it OK? No Check point: AS MAX check RF level check Is it OK? No Yes PICK UP cleaned? Yes No Perform lens cleaning Yes Replace the PICK UP Check point: Error rate check Error rate check Is it OK? No Yes PICK UP cleaned? No D Perform lens cleaning Yes Replace the PICK UP E Ckeck parts other than PICK UP Finished F AVH-P4100DVD/XN/UC 5 6 7 8 37 1 2 3 4 LD current check Check Status: [Foucs closed] of TEST MODE A NO. 1 Disc GGV1025 Check Point DVDLD1-VCC5_3 Threshold 60 - 390 (mV) Remarks: LD current 10 - 65 (mA) Expansion B C NO. Disc 2 TCD-782 Check Point Remarks: LD current Threshold CDLD1-VCC5_3 60 - 360 (mV) 10 - 60 (mA) Expansion D Notes: Please pay attention to the laser diode damage by static electricity. E F 38 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 ASMAX check ASMAX value shows the value of RF level. Status: [Foucs closed] of TEST MODE No. A Disc Check Point 8 digits value of ASMAX GGV1025 on display 8 digits value of TCD-782 ASMAX on display 1 2 Threshold more than 0000 0B00 more than 0000 0C00 Remarks: Only four last digits are displayed according to the product. Only four last digits is displayed according to the product. Test mode display will not appear on the display of this product. Connect the rear monitor output to a monitor. In this case, the value is displayed for a split second. When you tried to perform [FOCS CLOSE], the display will charge automatically in the following order. [1FFF0000]->[FEMAX]->[FE MIN]->[AS MAX]-> [ENV MAX]->[FE normal]->[Spindle gain]-> [TEMAX]->[TEMIN] ->[20000000] Watch carefully the value of ASMAX. B C Error rate check Status: [Tracking Closed] of TEST MODE No. 1 2 3 Disc Check Point Threshold less than GGV1025 ID: 40000 1.000E-03 less than GGV1025 ID: 200000 1.000E-03 less than TCD-782 ID: HOME Position 2.500E-03 Remarks: D Test mode display will not appear on the display of this product. Connect the rear monitor output to a monitor. E F AVH-P4100DVD/XN/UC 5 6 7 8 39 E 40 1 2 Go to FE section check. YES Is the life of flash memory OK? Conduct check item 12. YES 3 F AVH-P4100DVD/XN/UC 4 END YES NO Product repair Replace the unit. YES The product is normal?(iPod attestation IC) Go to the product check. YES Is the iPod circuit OK? Execute check 14. Go to FE related repair process. NO NO YES Is the iPod play in error? NO NO Replace the unit. YES Is the USB circuit OK? Execute check 14. YES Is 48 MHz OK? Execute check 13. YES Is the USB play in error? NO NO NO NO END YES Normal? Repair the defective part. Go to FE section check. YES Is the audio circuit OK? Execute check 10. YES Is DACCLK normal? Execute check 9. YES Is AVCC5 voltage OK? Execute check 8. YES Is the sound in error? NO NO Go to FE section check. YES Is VD8, VCC5 power supply voltage OK? Execute check 7. YES Is SDRAM IF OK? Execute check 6. YES Standby OK? Execute check 1. NO NO NO Replace the unit. YES Is 27 MHz OK? Execute check 5. YES Is VSENS OK? Execute check 4. YES Reset OK? Execute check 3. YES 3 Normal? YES Replace the unit. YES Is FE section normal? NO YES Is the video circuit OK? Execute check 11. YES Is AVCC5 voltage OK? Execute check 8. NO NO Is VDD5(VCC33, VCC12) power supply voltage OK? Execute check 2. 2 Go to FE section check. NO NO YES Is the image in error? NO C NO NO NO YES Can the playback start? START B Does the operation take time? BACK END section flow 1 4 5.3 DIAGNOSIS FLOWCHART A D 5 6 7 8 Check 1: Standby OK? ACheck the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference. NO. Check point 1 STANBY-DGND1 Specification value VCC33 V0.6 V or more Module No. ALL Unit V Side A B C STANBY Fig 1.1: STANBY check point D E F AVH-P4100DVD/XN/UC 5 6 7 8 41 1 2 3 4 Check 2: Is VDD5 (VCC33, VCC12) power supply voltage OK? A VDD5 IC1004 3.3 V output regulator IC1005 DC/DC converter 1.2 V output IC1401 FLASH power supply (Data) IC1402 FLASH power supply (Program) IC1481 SDRAM power supply IC1501 DV5U power supply VCC33 (= 3.3 V) VCC12 (= 1.2 V) IC1501 DV5U power supply Fig 2.1: Power supply configuration Check the voltage at the “VDD5_1, VCC33_1 and VCC12_1” test point while the power is on. Use the “DGND1” test point at the reference. B NO. Check point 1 VDD5_1 - DGND1 2 VCC33_1 - DGND1 3 VCC12_1 - DGND1 Module No. ALL ALL ALL Specification value 5.0 ± 0.4 3.3 ± 0.15 1.2 ± 0.12 Unit V V V Side A C VCC33_1 VCC12_1 D DGND1 VDD5_1 Fig 2.2: VDD5, VCC33, VCC12 voltage check points E F 42 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Check 3: Reset OK? A Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference. NO. 1 Check point XRES-DGND1 Module No. ALL Specification value VCC33 × 0.7 or more Unit V Side A B C DGND1 NRES Fig 3.1: RESET check point D E F AVH-P4100DVD/XN/UC 5 6 7 8 43 1 2 3 4 Check 4: Is VSENS OK? A CN1901 HOST I/F R1004, R1007 VD8 VDD5 STANBY XRES B VSENS IC1004 Regulator VCC33 IC1005 DC/DC converter VCC12 IC1501 DV5U Fig 4.1: Power supply configuration and VSENS Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference. NO. C Check point 1 VSENS - DGND1 Module No. ALL Specification value 0.95 - 1.07 VD8 = 8.0 ± 0.4 V Unit V Side A VSENS D DGND1 E Fig 4.2: VSENS check point F 44 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Check 5: 27 MHz Normal? Each clock is created inside the IC1501 using the 27 MHz master crystal oscillator (X1501). A IC1501 DVD-LSI OSCO X1501 27 MHz crystal OSCI VCC33 B VCC12 Fig 5.1: Clock configuration Turn the power on, and check with DGND being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components. NO. 2 Check point Module No. IC1501 169pin ALL Specification value 27 MHz ± 50 ppm Unit ppm C Specification value GND Fig 5.2: Clock specification value Side A D E IC1501 158pin DGND1 Fig 5.3: 27 MHz check point F AVH-P4100DVD/XN/UC 5 6 7 8 45 1 2 3 4 Check 6: Is SDRAM I/F OK? In order to secure the MPEG stream data as the buffer, the capacity of communication I/F SDRAM between the LSI and the memory is 64Mbit. Be careful as XCSM, XWE, XCAS and XRAS of IC1480 are called differently in IC1501, namely NCSM, NWE, NCAS, NRAS. IC IC1501 MA0 - 11 1480 DV5U MDQ0 - 15 SDRAM MCK A XWE(NWE) XCAS(NCAS) XRAS(NRAS) XCSM(NCSM) DQM0 DQM1 BA0 BA1 B Fig 6.1: SDRAM I/F C D E F 46 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Check the conductivity at “check point 1” and “check point 2” without power. In case of NG, check the soldering and defective components throughout the “output t input” of the applicable section. A NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 Signal name MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 MDQ0 MDQ1 MDQ2 MDQ3 MDQ4 MDQ5 MDQ6 MDQ7 MDQ8 MDQ9 MDQ10 MDQ11 MDQ12 MDQ13 MDQ14 MDQ15 MCK XWE XCAS XRAS XCSM DQM0 DQM1 BA0 BA1 Check point 1 IC1480 23pin IC1480 24pin IC1480 25pin IC1480 29pin IC1480 30pin IC1480 31pin IC1480 32pin IC1480 33pin IC1480 34pin IC1480 33pin IC1480 22pin IC1480 35pin IC1480 2pin IC1480 4pin IC1480 5pin IC1480 7pin IC1480 8pin IC1480 10pin IC1480 11pin IC1480 13pin IC1480 42pin IC1480 44pin IC1480 45pin IC1480 47pin IC1480 48pin IC1480 50pin IC1480 51pin IC1480 53pin IC1480 38pin IC1480 16pin IC1480 17pin IC1480 18pin IC1480 19pin IC1480 15pin IC1480 39pin IC1480 20pin IC1480 21pin Check point 2 IC1501 201pin IC1501 203pin IC1501 207pin IC1501 209pin IC1501 208pin IC1501 206pin IC1501 202pin IC1501 200pin IC1501 198pin IC1501 194pin IC1501 199pin IC1501 192pin IC1501 160pin IC1501 162pin IC1501 164pin IC1501 168pin IC1501 170pin IC1501 172pin IC1501 176pin IC1501 178pin IC1501 177pin IC1501 175pin IC1501 171pin IC1501 169pin IC1501 167pin IC1501 163pin IC1501 161pin IC1501 159pin IC1501 183pin IC1501 181pin IC1501 188pin IC1501 189pin IC1501 190pin IC1501 179pin IC1501 180pin IC1501 193pin IC1501 197pin Specification value 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 0.17 ohm or lower 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % 56 ohm ± 5 % B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 47 1 2 3 4 Side B A B Check point 1 (IC1480) Side A C D Check point 2 (IC1501) Fig 6.2: SDRAM I/F check point E F 48 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Check 7: Is VD8, VCC5 power supply voltage OK? A VD8_1 F.E. driver system VD8_2 IC1002 REG IC for VCC 5 V. VCC5 (= 5.0 V) Power supply for PU Fig 7.1: Power supply configuration Check the voltage at the “VD8_1, VD and VCC5_1” test point while the power is on. Use the “PGND3 and AGND1” test point at the reference. NO. 1 2 3 Check point VD8_1 - PGND3 VD - PGND3 VCC5_1- AGND1 Module No. ALL ALL ALL Specification value 8.0 ± 0.4 8.0 ± 0.4 5.0 ± 0.1 B Unit V V V Side A AGND3 C VCC5_1 PGND1 D VD8_1 VD PGND3 Fig 7.2: VD8, VCC5 voltage check points E F AVH-P4100DVD/XN/UC 5 6 7 8 49 1 2 3 4 Check 8: Is AVCC5 voltage OK? A IC1003 REG IC for AVCC 5 V. VD AVCC5 (= 5.0 V) IC1801 Audio-DAC Fig 8.1: Power supply configuration Playback DVD-REF-A1 TITLE 1 and check the voltage at the stylus. Check with PGND and GNDAU being the reference. NO. B Check point VD - PGND_3 AVCC5 - GNDAU1 1 2 Module No. ALL ALL Specification value 8.0 ± 0.4 5.0 ± 0.1 Unit V V Side A C AVCC5 D PGND3 VD GNDAU1 Fig 8.2: VD8, AVCC5 voltage check points E F 50 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Check 9: Is DACCLK normal? DACCLK for Audio-DAC is created by IC1501 using the 27 MHz master crystal oscillator (X1501). A IC1501 X1501 27 MHz crystal DVD-LSI DACCLK VCC33 IC1801 Audio-DAC VCC12 Fig 9.1: Clock configuration B DVD: DVD-REF-A1 TITLE 1 CD: Playback a normal CDDA. Common to all DVD-V compatible modules. Check with DGND being the reference. In case of NG, check the applicable line, the periphery of IC1501, soldering of the peripheral components and defective components. Check point 1 (stylus) DACCK DACCK NO. 1 2 Media DVD CD Specification value 1 Specification value 2 2.0 V~VCC33 V DGND~0.8 V 2.0 V~VCC33 V DGND~0.8 V Specification value 3 36.864 0 MHz ± 300 ppm 33.868 8 MHz ± 300 ppm Specification value 1 C Specification value 2 Specification value 3 GND Fig 9.2: Clock specification value D E F AVH-P4100DVD/XN/UC 5 6 7 8 51 1 2 3 4 Side B A B Check point 1 (DACCK stylus) Side A C D Check point 2 (IC1501 148 pin) DGND2 E Fig 9.3: 27 MHz, DACCLK check point F 52 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Check 10: Is the audio circuit OK? The serial 3 lines digital output + DACCLK, output from DVD-LSI (IC1501), are converted to analog audio signal at Audio-DAC (IC1801) and are output from the HOST I/F (CN1901). Simultaneously, the analog MUTE signal is also output from DVD-LSI (IC1501) via the HOST I/F. The digital audio signal (IECOUT), output from DVD-LSI (IC1501). A CN1901 HOST I/F IC1501 DVD-LSI IECOUT IC1801 Audio-DAC LRCK ADOUT SRCK LO RO GNDAU B Fig 10.1: Audio circuit Playback DVD-REF-A1 TITLE 2 CHAPTER 1 (48 k/16 bit 1 kHz 0 dB), and check with DGND being the reference. In case of NG, check the applicable line, periphery of major components as described in the above drawing, soldering of the peripheral components and defective components. NO. 1 2 3 Check point 1 (stylus) ADOUT3 SRCK LRCK Specification value 1 VCC33 V-0.6 V or higher VCC33 V-0.6 V or higher VCC33 V-0.6 V or higher Specification value 2 0.4 V or lower 0.4 V or lower 0.4 V or lower Reference waveform Waveform 1 Waveform 2 Waveform 3 C Specification Specification value 2 value 1 GND Fig 10.2: Serial 3 lines specification value D E F AVH-P4100DVD/XN/UC 5 6 7 8 53 1 2 3 4 3 4 Side A A B DGND2 ADOUT LRCK Side B C D SRCK E Fig 10.3: Serial 3 lines check points F 54 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 The following checks shall be conducted using the following measurement circuits with GNDAU1 being the reference. 47 kohm 47 kohm A LO GNDAU1 NO. 4 5 RO Check point 1 (stylus) LO RO Specification value (rms) 1 400 ± 150 mV 1 400 ± 150 mV Reference waveform Waveform 4 Waveform 4 B Specification value is the root-mean-square value (rms). Fig 10.4: Analog audio out (LO, RO) specification value. Side A C D RO LO GNDAU1 Fig 10.5: Analog audio out check point Check with DGND being the reference. NO. Check point 1 (stylus) 6 IEC E Specification value 1 VCC33 V-0.6 V or higher Specification value 2 0.4 V or lower Reference waveform Waveform 5 F AVH-P4100DVD/XN/UC 5 6 7 8 55 1 2 3 4 3 4 Side A A B IEC DGND2 Fig 10.6: Digital audio signal (IECOUT) check point C D E F 56 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 Check 11: Is the video circuit OK? Composite signal and component signal are output from DVD-LSI (IC1501), and are output from the HOST I/F (CN1901) via a buffer circuit. A CN1901 HOST I/F IC1501 DVD_LSI Composite Video DAC section COMPOSITE B Fig 11.1: Video circuit Playback DVD-REF-A1 TITLE2 CHAPTER5 (WHITE 100%), and monitor COMPOSITE signal with an oscilloscope with GNDV1 (stylus) being the reference. Set the trigger mode to “TV trigger” and the trigger line to “150 line”. Check point 1 (stylus) NO. 1 Specification value 1 000 mVpp ± 5 % COMPOSITE Reference waveform Waveform 6 C In case of NG, check the applicable line, the periphery of the major components in the drawing above, soldering of the peripheral components and defective components. PEAK Reference value COMPOSITE signal Color burst Pedestal level BOTTOM Horizontal sync signal Fig 11.2: Waveform for the case of composite white 100% output D E F AVH-P4100DVD/XN/UC 5 6 7 8 57 1 2 3 4 3 4 Side A A B COMPOSITE GNDV Fig 11.3: VIDEO signal check point C D E F 58 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 Check 12:How to judge whether the flash memory has reached its life or not. If the reaction to user operation is slow or operation is slow in general, there is a possibility that the flash memory has reached its life. Make judgment regarding the flash memory life by looking at the display of the LD energizing time. A 1.Let the LD energizing time displayed. (Refer to the FE test mode for the method of displaying the LD energizing time.) 2.If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life. Example: B 0E000BB8 C D E F AVH-P4100DVD/XN/UC 5 6 7 8 59 1 2 3 4 Check 13: 48 MHz Normal? Each clock is created inside the IC1501 using the 48 MHz master crystal oscillator (X1501). A IC1501 DVD-LSI X1950 48 MHz crystal USB_CLOCK B VCC33 VCC12 Fig 13.1: Clock configuration Turn the power on, and check with DGND1 being the reference. In case of NG, check the applicable line, periphery of IC1501, soldering of the peripheral components and defective components. NO. 2 Check point Module No. IC1501 50pin-DGND1 ALL Specification value 48 MHz ± 50 ppm Unit ppm C Specification value GND Fig 13.2: Clock specification value D E F 60 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Side A A IC1501 50pin B DGND1 Fig 13.3: 48 MHz check point C D E F AVH-P4100DVD/XN/UC 5 6 7 8 61 1 2 3 4 Check 14: Is USB Circuit OK? The data is transmitted through D+, D- and SDA of HOST I/F while playing USB/IPOD. USB memory uses only D+ and D-, but IPOD uses SDA (DATA) and SCL (CLOCK) in addition to D+ and D-. CN1901 HOST I/F IC1501 CP_RESE DVD-LSI A I2C_SDA I2C_SCL D+ DB DGND Fig. 14-1: USB Circuit 1.USB Memory: Play a song from USB memory and check D+ and D- with the DGND standards. 2.iPod: Connect iPod and check CP_RESET, SDA and SCL with the DGND standards until the pioneer log appears. Play a song from iPod and check D+/D- with the DGND standards. When it does not conform to the standards, check appropriate line, main parts shown in the above figure, soldering of peripheral parts and malfunctions in parts. C No. Checking spot (stylus) 1 CP_RESET 2 SDATA 3 SCLOCK 4 D+ 5 D- Standard value 2 Standard value 1 VCC33*0.7or more VCC33*0.7or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod VCC33*0.7or more VCC33*0.2 or less *Until the pioneer log appears after connecting the iPod VCC33*0.7or more VCC33*0.3 or less VCC33*0.7or more VCC33*0.3 or less D Standard value 2 Standard value 1 Fig. 14.2: USB Circuit Communication Wave E F 62 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Side A A SDATA CP_RESET SCLOCK B D- D+ DGND2 C D E F AVH-P4100DVD/XN/UC 5 6 7 8 63 1 2 3 4 AUDIO CH1:LO CH2:RO A CH1:ADOUT3 Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: GNDAU2 1 V/div. 500 usec/div G-> G-> B G-> Waveform 1 Waveform 4 CH1:SRCK CH1:IECOUT Reference voltage: DGND2 1 V/div. 5 usec/div Reference voltage: DGND2 1 V/div. 500 nsec/div C G-> G-> Waveform 2 D Waveform 5 CH1:LRCK Reference voltage: DGND2 1 V/div. 5 usec/div G-> E Waveform 3 F 64 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 VIDEO A [WHITE 100IRE] CH1:COMPO Reference voltage: GNDV1 200 mV/div. 10 usec/div B Waveform 6 USB memory USB memory USB memory Reference voltage:DGND 1 ms/div 2 V/div C Reference voltage:DGND 200 ns/div 2 V/div D- D- DGND D+ DGND D+ D Waveform 7 Waveform 8 E F AVH-P4100DVD/XN/UC 5 6 7 8 65 1 2 3 4 iPod iPod iPod A Reference voltage:DGND 1 ms/div 2 V/div Reference voltage:DGND 200 ns/div 2 V/div D- D- DGND D+ DGND D+ B Waveform 9 Waveform 10 iPod iPod Reference voltage:DGND 2 ms/div 1 V/div Reference voltage:DGND 20 ms/div 1 V/div CP_RESET C DGND SDA NRES Waveform 11 Waveform 12 D iPod Reference voltage:DGND 500 us/div 1 V/div E SCL Waveform 13 F 66 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 5.4 ERROR CODE LIST Error status OSD *1 M e d ia E r r o r Open Read Error Focus Error(Focus Error in mechanism set u p) UART *2 NON-PLAYABLE DISC 00h INCOMPATIBLE DEVICE 00h UNPLAYABLE FILE 00h (No display) E R R O R -0 2 -9 9 E R R O R -0 2 -9 0 Surface Error E R R O R -0 2 -9 E Address no t found(Invalid Track) ERROR-02-80 Meaning A disc containing the unplayable Format only USB device that doesn't correspond Disc Generation source USB USB (MSC) (iPod) ACC Off/On Method of reset Source Eject Off/On A Play Key X - - X X X - - X X X X - - - X - X X - - 10h 20h USB device of format alone that cannot be reproduced Door open error Transfer start error X X - - * X * X * X * X 21h Focus error X - - X X X X 22h Focus error during set up (A focus has never been achieved with that disc.) X - - X X X X Address not found. X - - X X X X X - - X X X X X - - X X X X X - - X X X X X 23h Spindle lock NG (the disc cannot rotate) Carriage home NG (The pick up tries to return to carriage home, but it cannot go back and stopped.) ID/SUBCODE Read Error (ID/SUBCODE cannot be read due to scratch or stain.) AV CHIP decode NG (AV chip cannot be decoded.) Spindle Lock ERROR-02-91 24h Carriage HOME ERROR-02-92 25h ID/SUBCODE Read Error ERROR-02-94 26h AV CHIP decode Error ERROR-02-9A 2Ah X X - X X X AV CHIP Recovery NG ERROR-02-9B 2Bh AV CHIP recovery NG X X X X X X X Error of PLAY BAC K Mode Status ERROR-02-9C 2Ch Playback state error (An error due to software bug.) X X - X X X X ERROR-02-9D 2Dh Disc Data NG X - - X X X X X - X - - - X - - * * * * X X - X - - - X X X - Disc Data Error Temp Error (In Case of High Tem perature ) No Disc ( including Disc loading and e jectin g) Loading_Mecha Error THERMAL PROTECTION IN MOTION 30h (No display) 40h (No display) 50h Communication fault attesting iPod E R R O R -02-60 iPod authentication data is abnormal E R R O R -02-61 iPod attestation retrying failure E R R O R -02-62 60h 61h 62h High temperature (Playback is stopped because the pick up temperature is 89 C or higher.) Disc has not been inserted. (Including Load in process or Eject in process.) Loading mechanism error (The disc cannot be clamped.) Communication fault attesting iPod iPod authentication data is abnormal iPod attestation retrying failure X X X X X - - C X X X iPod attestation time out E R R O R -0 2 -6 3 63h iPod attestation time out X - X - - X - Error when iPod is connected/ It is generated STALL by the USB communication E R R O R -0 2 -6 4 64h Error when iPod is connected/ It is generated STALL by the USB communication - - X - - X - E R R O R -0 2 -6 5 65h - - - X - 66h - - X - - X - E R R O R -0 2 -6 7 67h - - X - - X - E R R O R -0 2 -6 8 68h Error setting iPod Demand timeout when initial is communicated Protocol version non-correspondence Timeout when protocol version is judged - E R R O R -0 2 -6 6 - - X - - X - No songs error - - X - - X - - - X - - X - - - X - - X - Error setting iPod Demand timeout when initial is communicated Protocol version non-correspondence Timeout when protocol version is judged (No display) No songs error iPod control forwarding/ Intarapta forwarding error Demand timeout iPod's reproducing Remote switch error Remote switch demand timeout D R M E rro r 69h E R R O R -0 2 -6 A 6Ah E R R O R -0 2 -6 B 6Bh ERROR-02-6C 6Ch ERROR-02-6D 6Dh PROTECTED DISC 70h iPod control forwarding/ Intarapta forwarding error Demand timeout iPod's reproducing Remote switch error Remote switch demand timeout DRM error (All music cannot be played back due to DRM.) DRM error (All music cannot be played back due to DRM.) Region code NG (Unable to be played back due to incorrect mechanism region.) B X - - - - X - - - X - - X - X - - - - - X - - - X - - - - X - X - X X D - NO ACCESSIBLE DATA AVAILABL 70h Region code Error NG DIFFERENT REGION DISC 90h C P R M *7 K e y E rro r *8 NON-PLAYABLE DISC 93h Key Error for playback X - - - - REQUEST error Failure in issuing read command (chip dependent) Adjustment of L0 is NG. Adjustment of L1 is NG. LD system NG Gain adjustment system NG. Gain determining system NG. Servo initial setting related items NG. Disc is not clamped yet. Tracking system NG. Media setting system NG. Focus Error Error of PLAY BAC K Mode Status Error of PLAY BAC K Mode Status Audio Propert y Timeou t Error *9 ERROR-02-A0 A0h X - - X X X X E R R O R -0 2 -A 1 A1h REQUEST error Failure in issuing the read command X - - X X X X ERROR-02-A2 ERROR-02-A3 ERROR-02-A4 ERROR-02-A5 ERROR-02-A6 ERROR-02-A7 ERROR-02-A8 ERROR-02-A9 ERROR-02-AA ERROR-02-AB A2h A3h A4h A5h A6h A7h A8h A9h AAh ABh L0 adjustment is NG. L1 adjustment is NG LD system NG Gain adjustment system NG. Gain determining system NG. Servo initial setting related items NG. Disc is not clamped yet. Tracking system NG Media setting system NG JUMP over layers NG X X X X X X X X X X - - X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X X E R R O R -0 2 -B 0 B0h Navigation command error X - - X X X X E R R O R -0 2 -B 1 B1h Retry over X - - X X X X X X X - X ERROR-02-C0 C0h Audio property timeout error X - - Error when MCS is connected/ It is generated STALL by the USB communication ERROR-02-D0 D0h Error when MCS is connected/ It is generated STALL by the USB communication - X - - - CBW and CSW forwarding error Audio class band securing failure Audio class FS setting failure Undefined Error ERROR-02-D1 ERROR-02-D8 ERROR-02-D9 ERROR-FF-FF D1h D8h D9h FFh CBW and CSW forwarding error Audio class band securing failure Audio class FS setting failure Undefined error X X - X X - X X - X X X X - X AVH-P4100DVD/XN/UC 5 6 7 E 8 F 67 1 2 3 4 X: Cancel the error by operation. -: Error is not cancelled by operation. *: No setting *1 A content displayed on OSD. As for the items having multiple display patterns, the upper row is for the Japanese version Full GUI, and the lower row is for the Touch Panel model and Full GUI (English version). *2 A parameter of UART command, such as “receipt error notice”, that the DVD mechanism transmits. *3 CPPM(Content Protection for Prerecorded Media) : A copyright protection technique used in DVD-A. The protection is realized by using the keys recorded on the media and the device key held by the player. *4 DVD-A compatible model only. When an error has occurred, only the audio output will be muted but playback operation will continue. Furthermore, acceptance of the user operation will be the same as usual. *5 AWM (Audio WaterMark): Electronic watermark. Information on the copyright owner or CCI (copy control information) are recorded so that illegally copied discs can be identified. *6 Notice as an error status will not be given *7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card. (DVD-VR model only) A B C D E F 68 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 69 1 2 3 4 5.5 CONNECTOR FUNCTION DESCRIPTION VIDEO INPUT/OUTPUT WIRED REMOTE REAR CONTROL OUTPUT A REAR CAMERA IN AUX IN B C ANTENNA OPTICAL OUTPUT AUDIO INPUT SUBWOOFER OUTPUT IP-BUS INPUT FRONT OUTPUT 1 3 5 7 9 11 13 15 2 4 6 8 10 12 14 16 11 7 10 9 6 8 5 RGB INPUT(UW5) D 25 26 1. CCR 2. CCG 3. CCB 4. CCSYNC 5. GNDSIG 6. DVDVBS 7. GNDDVD 8. YS 9. NC 10. CCAUL 11. CCAUR 12. GNDAU 13. ONSEI+ E 1 2 14. ONSEI15. REAUR 16. REAUL 17. GNDRAU 18. CCREM 19. DSEN 20. TVON 21. GION 22. MONON 23. VSW5 24. SYS_TO_NAVI 25. NAVI_TO_SYS 26. GNDD 1. FR2. RR3. FR+ 4. RR+ 5. FL6. RL7. FL+ 8. RL+ 9. PARKING BRAKE 10. MUTE 11. B.REM 12. ILM 13. BGSENS 14. ACC 15. GND 16. B.UP 1. BUS+ 2. BUSG 3. BUSLG 4. MAINTEST 5. BUS6. BUSRG 7. BUSL+ 8. ASENBO 9. BUSR+ 10. BUSR11. BUSLUSB 1 3 2 1. USB5V 2. D3. D+ 4. USBGND F 70 AVH-P4100DVD/XN/UC 1 2 4 3 2 1 3 4 4 5 6 7 8 6. SERVICE MODE 6.1 MONITOR TEST MODE A [Method for Mode IN] When the reset start is done while pushing MUTE and TRACK DOWN, it shifts to the monitor test mode. [Display specifications] B [Operation specification] Operational description Selection cursor up movement Selection cursor down movement Menu enter C Remote controller key 2 8 5 1. Version Check [Method for Mode IN] Choose "Version Check" among the monitor test mode menu screen. D [Display specifications] When 4 digits of read number is strange, "---" is displayed. ex) ---1x34 E "CONNECT" is indicated at the time of the Navigation connection. [Operation specification] Operational description Return to test mode mene Remote controller key 1 F AVH-P4100DVD/XN/UC 5 6 7 8 71 1 2 3 4 2. Touch Panel Calibration [How to activate the touch panel test mode] A Choose "Touch Panel Calibration" among the monitor test mode menu screen. [Menu types in the mode] The calibration test mode consists of the following menus. Top menu Outermost circumference inspection 16 points adjustment Coordinate inspection Calibration verification B Data initialization [Operation specification] Operational description Selection cursor up movement Selection cursor down movement Return to test mode mene Menu enter Remote controller key 2 8 1 5 [Description of the top menu] [Display specification] C Flicker initialized state D Conditions for lighting of the adjustment complete mark “ * ”. Outermost circumference inspection : In case the outermost circumference inspection has been completed normally. 16 points adjustment : In case the calibration has been completed normally. Conditions for the adjustment complete mark “ * ” to go out. E Outermost circumference inspection : In case the outermost circumference inspection has never been performed. In case the EEPROM initialization has been performed. In case the adjustment value has been initialized. 16 points adjustment : In case the 16 points adjustment has never been performed. In case the EEPROM initialization has been performed. In case the adjustment value has been initialized. F 72 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 [Outermost circumference inspection] [Outline] Outermost circumference value of X and Y is obtained by tracing the outermost circumference of the touch panel screen. When exiting the menu screen by pressing 5 key, the captured value is stored in the EEPROM. Furthermore, when storing the value, checking is made as to whether the value is within the range or not. A When the value is within the range. Write the following value and adjustment information to the EEPROM, then “OK” is displayed. 1. The outermost value of X and Y(min/max) : 4 byte 2. The reference value for A/D correction of X,Y : 2 byte 3. Adjustment information(Adjustment OK) : 1 byte When the value is within the range. Write the following adjustment information to the EEPROM, then “NG” is displayed. 1. Adjustment information(Adjustment NG) : 1 byte B The initial value and the setting value allowable range are as follows. Outermost value Xmin : 35h Ymin : 3Fh Xmax : F3h Ymax : EAh A/D correction value X : 33h Y : 38h Outermost value Xmin : 78h Ymin : 78h Xmax : B4h Ymax : B4h A/D correction value X : 00h Y : 00h Setting value allowable range X direction Minimum value Maximum value Maximum value - Minimum value Y direction Minimum value Maximum value Maximum value - Minimum value : : : : : : C 00h to 80h 9Eh to FFh more then 73h 00h to 83h 9Ah to FFh more then 6Bh [Display specifications] D Outermost circumference inspection in process E X/Y information of [MIN] and [MAX] of the outermost circumference are displayed. [BEFOR] indicates the value stored in the EEPROM. [AFTER] indicates MIN/MAX of the A/D value currently captured. [Operation specification] Operational description Return to top mene F Remote controller key 5 AVH-P4100DVD/XN/UC 5 6 7 8 73 1 2 3 4 [16 points adjustment] [Outline] When correctly touched, the cursor will disappear, and the next cursor will appear. Calibration is conducted by repeating this process 16 times. When the 17th point has been finally touched, setting information for the 16 points and the normal ending information, total of 17 byte data, are written into the EEPROM, and the screen returns to the TOP menu. A [Display specifications] 16 points adjustment in process B C Order of display of the locations to be pressed. D This point is intended to end the calibration inspection, and therefore, the corrected value of this point is not obtained. E [Operation specification] Operational description Return to top mene Remote controller key 5 F 74 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 [Coordinate inspection] [Outline] The coordinate before correction and after correction at the time of pressing the touch panel are displayed for coordinate verification. Furthermore, the red "+" cursor can be moved by the key operaiont mentioned bellow, and the coordinate of the cursor center is displayed. [Display specifications] A Fixed display B C Each displayed coordinate is as follows. The values under [Factory] are the corrected values in the Factory region and the values under [User] are the corrected values in the User region. • Sampling : A/D value (X direction, Y direction) of the pressed point is displayed. • AD Value : The coordinate (X direction, Y direction) of the A/D value of the pressed point corrected by the reference value for A/D correction is displayed. • Normalization : The coordinate (X direction, Y direction) after normalizing the A/D corrected coordinate within the effective range is displayed. (0~255) • Calibration : The coordinate (X direction, Y direction) which is the result of adding the correction by calibration to the normalized coordinate is displayed. Movable "+" cursor is displayed in red. 16 calibration points are displayed in white. [Operation specification] Operational description Return to top mene D Remote controller key 1 E F AVH-P4100DVD/XN/UC 5 6 7 8 75 1 2 3 4 [Calibration verification] [Outline] Touch the cursor “+” displayed on the screen. The correct touch will delete the cursor and another cursor will be displayed. The incorrect touch will make the characters of cursor turn red. Repeat this for 4 points, and “OK” is displayed upon the last press of 4th point. A [Display specifications] confirming B C The pushing order D [Operation specification] Operational description Return to top mene E Remote controller key 1 F 76 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 [Data initialization] [Outline] Result of outermost circumference inspection and of calibration inspection (corrected value) are returned to their initial values. As for the initialized items, the initial values are written into the EEPROM and the adjustment information is cleared. A [Display specifications] B Conditions for the adjustment completion mark (*) to be lighted up. (The mark will be lighted up if one of the multiple conditions is met.) C Outermost circumference inspection When the outermost circumference inspection of the calibration for line has been completed normally. 16 point adjustment When the 16 point adjustment of the calibration for line has been completed normally. User outermost circumference inspection When the user outermost circumference inspection of the calibration for line has been completed normally. User 16 point adjustment When the user 16 point adjustment of the calibration for line has been completed normally. D Conditions for the adjustment completion mark (*) to go out. Outermost circumference inspection When the above mentioned lighting conditions are not applicable. When the adjusted value has been initialized (Data initialize). When the EEPROM has been initialized. 16 point adjustment When the above mentioned lighting conditions are not applicable. When the adjusted value has been initialized (Data initialize). When the EEPROM has been initialized. User outermost circumference inspection When the above mentioned lighting conditions are not applicable. In case the outermost circumference inspection of the calibration for line or the 16-point adjustment is normally terminated after normal termination of the outermost circumference inspection for user calibration. When the adjusted value has been initialized (Data initialize). When the EEPROM has been initialized. E User 16 point adjustment When the above mentioned lighting conditions are not applicable. In case the outermost circumference inspection of the calibration for line or the 16-point adjustment is normally terminated after normal termination of the outermost circumference inspection for user calibration. When the adjusted value has been initialized (Data initialize). When the EEPROM has been initialized. F [Operation specification] Refer to [Menu types in the mode]. AVH-P4100DVD/XN/UC 5 6 7 8 77 1 2 3 4 3. EEPROM Adjust [Method for Mode IN] A Choose "EEPROM Adjust" among the monitor test mode menu screen. [Display specifications] Flicker Adjust B C D Backlight output max value : 196 Backlight output min value : 83 Dimmer threshold value (high) : 192 Dimmer threshold value (low) : 96 E Dimmer external light point (high) : 255 Dimmer external light point (medium) : 135 Dimmer external light point (low) : 0 Dimmer backlight point (high) : 196 Dimmer backlight point (medium) : 196 Dimmer backlight point (low) : 87 F 78 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B LCD protection value at High temperature (1) LCD protection value at High temperature (1) LCD protection value at High temperature (1) Temperature value : 0 Dimmer output : 0 Target arrival time : 6 LCD protection value at High temperature (2) LCD protection value at High temperature (2) LCD protection value at High temperature (2) Temperature value : 0 Dimmer output : 4 Target arrival time : 6 LCD protection value at High temperature (3) LCD protection value at High temperature (3) LCD protection value at High temperature (3) Temperature value : 0 Dimmer output : 14 Target arrival time : 4 LCD protection value at High temperature (4) LCD protection value at High temperature (4) LCD protection value at High temperature (4) Temperature value : 0 Dimmer output : 30 Target arrival time : 3 C D LCD protection value at High temperature (5) LCD protection value at High temperature (5) LCD protection value at High temperature (5) Temperature value : 0 Dimmer output : 50 Target arrival time : 1 LCD protection value at High temperature (6) LCD protection value at High temperature (6) LCD protection value at High temperature (6) Temperature value : 0 Dimmer output : 62 Target arrival time : 1 LCD protection value at High temperature (7) LCD protection value at High temperature (7) LCD protection value at High temperature (7) Temperature value : 0 Dimmer output : 63 Target arrival time : 1 LCD protection value at High temperature (8) LCD protection value at High temperature (8) LCD protection value at High temperature (8) Temperature value : 0 Dimmer output : 63 Target arrival time : 1 E F AVH-P4100DVD/XN/UC 5 6 7 8 79 1 2 3 4 A B Common inverted output amplitude adjusted value : 173 Brightness adjustment : 32 Noise shaping setting : 1 C D RGB gamma correction : 0 E RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting R polygonal line position setting arrangement [3] : 31 R polygonal line position setting arrangement [4] : 39 R polygonal line position setting arrangement [5] : 47 RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting G polygonal line position setting arrangement [3] : 31 G polygonal line position setting arrangement [4] : 39 G polygonal line position setting arrangement [5] : 47 RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting B polygonal line position setting arrangement [3] : 31 B polygonal line position setting arrangement [4] : 39 B polygonal line position setting arrangement [5] : 47 F 80 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting R gain arrangement [3] : 32 R gain arrangement [4] : 32 R gain arrangement [5] : 32 R gain arrangement [6] : 32 RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting G gain arrangement [3] : 32 G gain arrangement [4] : 32 G gain arrangement [5] : 32 G gain arrangement [6] : 32 RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting RGB gamma correction setting B gain arrangement [3] : 32 B gain arrangement [4] : 32 B gain arrangement [5] : 32 B gain arrangement [6] : 32 C D R drive adjustment +3 : 22 G drive adjustment +3 : 24 E R drive adjustment +2 : 25 G drive adjustment +2 : 26 R drive adjustment +1 : 28 G drive adjustment +1 : 28 B drive adjustment +1 : 28 G drive adjustment +1 : 31 B drive adjustment +2 : 25 G drive adjustment +2 : 29 F B drive adjustment +3 : 20 G drive adjustment +3 : 28 AVH-P4100DVD/XN/UC 5 6 7 8 81 1 2 3 4 A B R cutoff adjustment +3 : 64 G cutoff adjustment +3 : 64 R cutoff adjustment +2 : 64 G cutoff adjustment +2 : 64 R cutoff adjustment +1 : 64 G cutoff adjustment +1 : 64 B cutoff adjustment -1 : 64 G cutoff adjustment -1 : 64 C B cutoff adjustment -2 : 64 G cutoff adjustment -2 : 64 B cutoff adjustment -3 : 64 G cutoff adjustment -3 : 64 D E Horizontal enhancer adjustment Horizontal enhancer adjustment Horizontal enhancer adjustment Correction effect adjustment : 98 Limiter for both shots of the positive/negative side : 10 Horizontal enhancer adjustment : 0 YUV DC transmission quantity correction setting YUV DC transmission quantity correction setting Brightness outline correction adjustment Brightness outline correction adjustment Brightness outline correction adjustment F 82 Correction gain : 16 DC transmission quantity correction polarity : 0 Correction tap select : 0 Correction gain : 2 Coring quantity : 10 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Strong electric field, TV) Dcs1_ilgain1 : 3 Top curl adjustment (Strong electric field, TV) Dmv1_ilgain1 : 3 Top curl adjustment (Strong electric field, TV) Dcs1_ilgain23 : 56 Top curl adjustment (Strong electric field, TV) Dmv1_ilgain23 : 56 Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Strong electric field, Besides TV) Dcs1_ilgain1 : 3 Top curl adjustment (Strong electric field, Besides TV) Dmv1_ilgain1 : 3 Top curl adjustment (Strong electric field, Besides TV) Dcs1_ilgain23 : 56 Top curl adjustment (Strong electric field, Besides TV) Dmv1_ilgain23 : 56 C D Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Weak electric field, TV) Dcs2_ilgain1 : 39 Top curl adjustment (Weak electric field, TV) Dmv2_ilgain1 : 3 Top curl adjustment (Weak electric field, TV) Dcs2_ilgain23 : 21 Top curl adjustment (Weak electric field, TV) Dmv2_ilgain23 : 21 Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Weak electric field, Besides TV) Dcs2_ilgain1 : 39 Top curl adjustment (Weak electric field, Besides TV) Dmv2_ilgain1 : 3 Top curl adjustment (Weak electric field, Besides TV) Dcs2_ilgain23 : 39 Top curl adjustment (Weak electric field, Besides TV) Dmv2_ilgain23 : 39 E F AVH-P4100DVD/XN/UC 5 6 7 8 83 1 2 3 4 A B Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Super-weak electric field, TV) Dcs25_ilgain1 : 39 Top curl adjustment (Super-weak electric field, TV) Dmv25_ilgain1 : 3 Top curl adjustment (Super-weak electric field, TV) Dcs25_ilgain23 : 39 Top curl adjustment (Super-weak electric field, TV) Dmv25_ilgain23 : 39 Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Super-weak electric field, Besides TV) Dcs25_ilgain1 : 39 Top curl adjustment (Super-weak electric field, Besides TV) Dmv25_ilgain1 : 3 Top curl adjustment (Super-weak electric field, Besides TV) Dcs25_ilgain23 : 39 Top curl adjustment (Super-weak electric field, Besides TV) Dmv25_ilgain23 : 39 Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Super-weak electric field, TV) Dcs3_ilgain1 : 71 Top curl adjustment (Super-weak electric field, TV) Dmv3_ilgain1 : 7 Top curl adjustment (Super-weak electric field, TV) Dcs3_ilgain23 : 71 Top curl adjustment (Super-weak electric field, TV) Dmv3_ilgain23 : 7 Synchronous separation Synchronous separation Synchronous separation Synchronous separation Top curl adjustment (Super-weak electric field, Besides TV) Dcs3_ilgain1 : 71 Top curl adjustment (Super-weak electric field, Besides TV) Dmv3_ilgain1 : 7 Top curl adjustment (Super-weak electric field, Besides TV) Dcs3_ilgain23 : 71 Top curl adjustment (Super-weak electric field, Besides TV) Dmv3_ilgain23 : 7 C D E F 84 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B Synchronous separation Synchronous separation Top curl adjustment (Non signal, TV) Dycomp5_ilgain1 : 2 Top curl adjustment (Non signal, TV) Dycomp5_ilgain23 : 39 Synchronous separation Synchronous separation Top curl adjustment (Non signal, Besides TV) Dycomp5_ilgain1 : 2 Top curl adjustment (Non signal, Besides TV) Dycomp5_ilg : 39 Electric field strength judgment value for TV Dwec_th_cs225 : 150 Electric field strength judgment value for Dwec_th_cs12 : 16 C D ACCGAIN setting (ulNT358_SYNC1_08) : 8500 ACCGAIN setting (ulPALBG_SYNC1_08) : 8500 ACCGAIN setting (ulPALM_SYNC1_08) : 8500 ACCGAIN setting (ulPALN_SYNC1_08) : 8500 ACCGAIN setting (ulSECAM_SYNC1_08) : 8500 E IVMODE setting : 10 Com part Com part Com part Com part Com part Brightness gain (ulNT358_CMB1_20) : 221 Brightness gain (ulPALBG_CMB1_20) : 218 Brightness gain (ulPALBG_CMB1_21) : 216 Brightness gain (ulPALBG_CMB1_22) : 208 Brightness gain (ulPALBG_CMB1_23) : 211 F AVH-P4100DVD/XN/UC 5 6 7 8 85 1 2 3 4 A B C Color demodulate part Color demodulate part Color demodulate part Color demodulate part Color demodulate part UV delay adjustment (ulNT358_AVICOL3_03) : 27 UV delay adjustment (ulPALBG_AVICOL3_03) : 27 UV delay adjustment (ulPALM_AVICOL3_03) : 26 UV delay adjustment (ulPALN_AVICOL3_03) : 26 UV delay adjustment (ulSECAM_AVICOL3_03) : 26 Color demodulate part Color demodulate part Color demodulate part Color demodulate part Color demodulate part Phase killer value (ulNT358_AVICOL1_09) : 2 Phase killer value (ulPALBG_AVICOL1_09) : 2 Phase killer value (ulPALM_AVICOL1_09) : 2 Phase killer value (ulPALN_AVICOL1_09) : 2 Phase killer value (ulSECAM_AVICOL1_09) : 96 AV input picture indication movement : 0 [Operation specification] Operational description Selection cursor up movement Selection cursor down movement Item content value up Item content value down Next menu page Former menu page Return to test mode mene D Remote controller key 2 8 6 4 9 7 1 E F 86 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 4. EEPROM Initialize A [Method for Mode IN] Choose "EEPROM Initialize" among the monitor test mode menu screen. [Display specifications] B C Default of a cursor is the location of "No". Choose "YES" and decide, initialize a setting value. *) Don't turn off power while initializing. When normally ends, "success" is displayed. When will not end in four seconds, judged to be abnormal, "failure" is displayed. [Operation specification] Operational description Selection cursor left movement Selection cursor right movement Return to test mode mene Menu enter Remote controller key 4 6 1 5 D E F AVH-P4100DVD/XN/UC 5 6 7 8 87 1 2 3 4 5. Display Test (Test Pattern) [Method for Mode IN] A Choose "Display Test (Test Pattern)" among the monitor test mode menu screen. [Display specifications] B [Operation specification] Operational description Selection cursor up movement Selection cursor down movement Selection cursor left movement Selection cursor right movement Return to test mode mene Menu enter C Remote controller key 2 8 4 6 1 5 [RGB] RGB is plotted in the following pattern: R100% -> R50% -> G100% -> G50% -> B100% -> B50% -> BLACK -> GRAY -> WHITE -> C.Video 60Hz -> C.Video 50Hz (The display of the screen will be changed in 1 second.) D [Operation specification] Operational description Return to test mode mene Stop/Restart Remote controller key 1 5 [MONOCHROME STRIPE] Display of monochrome stripe signal (1dot Width) E [Operation specification] Operational description Return to test mode mene Remote controller key 1 [COLOR BAR] Display of color bar signal [Operation specification] Operational description Return to test mode mene F 88 Remote controller key 1 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 [FLICKER ADJUSTER] Display of monochrome stripe signal of the flicker adjustment [Operation specification] Operational description Return to test mode mene A Remote controller key 1 [RAMP & 10STEP] Display of step signal and signal for alpha blend check [Operation specification] Operational description alpha blend rate up alpha blend rate down Return to test mode mene Next signal B Remote controller key 2 8 1 5 [WINDOW & 1LINE STRIPE] Display of signal for video signal reply check [Operation specification] Operational description Return to test mode mene Next signal C Remote controller key 1 5 [MOVING BAR] A white vertical line indicates the signal which moves from the right to the left. D Drift to the left E Cycle1 : 1 seconds Cycle2 : 2 seconds Cycle3 : 3 seconds [Operation specification] Operational description Return to test mode mene Cycle1 -> 2 -> 3 -> stop -> 1 Remote controller key 1 5 F AVH-P4100DVD/XN/UC 5 6 7 8 89 1 2 3 4 3 4 [RASTER SIGNAL] Display of signal for step confirmation A [Operation specification] Operational description Return to test mode mene Next signal Remote controller key 1 5 [CONTRAST] Display of Black/White signal B [Operation specification] Operational description Return to test mode mene Next signal Remote controller key 1 5 [CENTER MARKER] Display of signal for screen central location setting. C D [Operation specification] Operational description Return to test mode mene Remote controller key 1 E F 90 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 6.2 DVD TEST MODE Test mode display will not appear on the display of this product. Connect the rear monitor output to a monitor. A Image of the test mode. [VOL-] + [TRACK UP] + Reset start Switch position of the remote control unit. [AVH mode] (1)-(8) and EJECT is the key of remote control unit. Legend: … Key operation … Operation state … The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication. Start of the test mode. TEST B [Note] Higher level 4 characters only. Lower level 4 characters are spaces. (1) (3) (2) FE test selection Hereafter, to FE test mode image. (4) (5) EDC1 test selection EDC2 test selection LD power on time mode selection Hereafter, to EDC1 test mode image. Hereafter, to EDC2 test mode image. Hereafter, to LD power on time mode image. Simple FE test mode Hereafter, to simple FE test mode. [Note] In order to move on to another test after selecting a test (FE/EDC1/EDC2), it is necessary to restart the DVD mechanism in the test mode. C Image of the front end test mode. Legend: … Key operation … Operation state … The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication. FE test mode 0 x 00 0000 (1) (3) (2) FE offset coefficient TE offset coefficient AS offset coefficient ENV offset coefficient TG offset coefficient DBAL coefficient VIN1 offset cancel value VIN2 offset cancel value VIN3 offset cancel value VIN4 offset cancel value VIN5 offset cancel value Power on 0FFF 0000 (4) (5) Disc type DVD1 layer Disc type DVD2 layer Disc type CD Disc type CD-RW 0000 0000 0100 0000 0200 0000 0300 0000 EJECT D EJECT 1 x 00 0000 (1) (3),(4) (2) F close F search (5) (6) (8) (7) CRG+/- LD-ON/OFF CRG_HOME CRG_OUTSIDER Activates while the key is being pressed. 1B00 0000 : CRG+ 1C00 0000 : CRG- When LO-ON: 1100 0000 When LD-OFF: 1000 000 1D00 0000 1E00 0000 E Power_OFF S curve measurement 1FFF 0000 1A00 0000 (2) F search 1100 0000 [Note] If no action is taken for approximately 10 seconds after LD-ON, it will become LO-OFF automatically. If F close is selected during LD-OFF, it will become an error. During focus search (S character measurement mode), too, safety regulation applies if LD_OFF is not selected within 10 seconds. Therefore, even if focus search is selected after LD-ON, it will become LD-OFF after 9 seconds. In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again before F close. Focus close state FEMAX level FEMIN level ASMAX level ENVMAX level FE normalization coefficient Spindle gain coefficient TEMAX level indication TEMIN level indication (2) F a b AVH-P4100DVD/XN/UC 5 6 7 8 91 1 2 3 4 a b (2) 2 x 00 0000 A (1) (2) (3),(4) When L0 layer: 2000 0000 When L1 layer: 2100 0000 2FFF 0000 (8) CRG +/- Focus Jump Tracking balance TBAL coefficient (layer 0) TBAL coefficient (layer 1) TE normalization coefficient (layer 0) TE normalization coefficient (layer 1) Off track adjustment result Power_OFF It operates while the key is being pressed. 2B00 0000 : CRG+ 2C00 0000 : CRG- 3000 0000 (1) (5) (3),(4) Tracking close CRG +/- 3FFF 0000 RF level value Power_OFF 3FFF 0000 It operates while the key is being pressed. 3B00 0000 : CRG+ 3C00 0000 : CRG- B (8) Performed including the tracking close processing. Tracking close state FBAL coefficient (layer 0) FBAL coefficient (layer 1) Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0) 5000 0000 (1) (2) RF level value indication start RF level is informed every 500msec. C (1) (7) Error rate measurement (8) Power_OFF T.OPEN Error rate Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0) To (2) RF level value indication end Tracking close state FBAL coefficient (layer 0) FBAL coefficient (layer 1) Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) 4000 0000 D 4 x 00 0000 (1) Error rate measurement (2) Playback speed switching Error rate Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0) DVDX1.3~ 1.6CAV CDX4CLV: 4x00 0000 (5) (6) (3),(4) (7) Focus Jump ID Search T.Jump+/- T.OPEN When L0 layer: 4x00 0000 When L1 layer: 4x00 0000 4A00 0000 Jump+ : 4B00 0000 Jump- : 4C00 0000 To (2) (1)-(4) ID designation ID display (5) Search start (8) Power_OFF (3) Track number designation Track number indication (5) The higher 2 digits of the designated ID are the value showing the test state. The lower 6 digits show the ID. Example) If 300000 is desired to be designated as the ID, designated ID: 4A03 0000. Jump start Error occurrence E Error display L0 layer L1 layer (8) DVD X 1.3~1.6CAV, CD X 4CLV :4000 0000 DVD X 1.3~1.6CAV :4100 0000 The number for designation of the track number shall be selected from the track numbers previously prepared. Switch to cyclic by (3). Fix by (4). For CD: Tracks 1, 4, 10, 11 and 32 For DVD: Tracks 1, 4, 10, 11, 32, 64 and 100 Change the method for ID address designation. Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Power_OFF Error occurrence at Power_OFF [Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again. Error display F 92 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 Legend: 8 … Key operation EDC. Image of the test mode A … Operational state … The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication. EDC1/2 test mode [Note] Image is the same for both EDC1 and EDC2. 0000 0000 EJECT operation [Note] Eject can be effected any time during the EDC test mode. (1) (2) Layer 0 selection Layer 1 selection 0000 0000 0100 0000 1003 0000 1103 0000 Eject B Test mode Eject After completion of EJECT operation (1)-(4) ID designation Layer 0: 10** **** Layer 1: 11** **** [Note] ** **** is the ID designation value (5) C EDC1/2 start Layer 0: 20** **** Layer 1: 21** **** [Note] ** **** is the present ID designation value **** **** [Note] The display is updated at 0.5 seconds interval until 0/1 layer is selected or Eject is effected. [Note] **** **** is the present ID designation value Image of the LD power on time mode. Legend: … Key operation … Operational state … The content displayed on the DVD mechanism (video only) 8 characters data is sent to the product side (HOST) by UART communication. LD power on time mode D 0000 0000 Not for service use (1) CD LD power on time indication (2) DVD LD power on time indication (6) DVD LD power on time setting (5) CD LD power on time setting 20** **** 10** **** [Note] ** **** is the CD LD [Note] ** **** is the DVD LD power on time. power on time. 30** **** [Note] ** **** is the setting time. 40** **** [Note] ** **** is the setting time. (1)-(4) (1)-(4) Setting time designation (5) (8) Setting time designation (8) E (5) Setting time registration Setting time registration 10** **** [Note] ** **** is the CD LD power on time. 20** **** [Note] ** **** is the DVD LD power on time. [Method of setting time designation] Designate the digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Cancel by command (8). F [Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours. [Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory. AVH-P4100DVD/XN/UC 5 6 7 8 93 1 2 3 4 Simple test mode The selection of the figure of each screen can be selected by "Key command for the test". A TEST MODE 1: LD ON 2: ASMAX 3: Skew Adjustment 4: Error Rate 5: CRG Move Outer 6: Eject Please Input Number LD ON 1 select B 1: DVD Single Layer 2: DVD Dual Layer 3: CD 4: CD-RW 5: Return 5 Return select LD ON Please Input Number Now Running ASMAX 2 select 1: DVD Single Layer 2: DVD Dual Layer 3: CD 4: CD-RW 5: Return 5 Return select 1: DVD Single Layer 5 Return select Now Running 1: Power OFF select RF Level : 000000 Now Running Error Rat e Error Rat e 5: Ret urn ASMAX Level display Skew Adjust ment RF Level value set 1: Inner Measurement 2: Outer Measurement 3: Middle Measurement DVD select 3: CD 5 Return select select Please Input Number Skew Adjust ment select Please Input Number 1: DVD Single Layer 1: Power OFF ASMAX Level : 000000 5: Return 4 select select ASMAX ASMAX value set Skew Adjust ment 3 select 1: Power OFF Please Input Number ASMAX select Please Input Number C LD ON LD ON Completion select Search ID 0x00100000 RF Level display Update 500 msec. Please Input Number Error Rat e - Inner *1 Error Rat e - Inner Error Rate set select 5: Ret urn 5 Return select Please Input Number Please Input Number Search ID inner : 0x00040000 outer : 0 00200000 Please Input Number Now Running Error Rate -CD *1 : The position in which select was done is displayed. *1 DVD Inner DVD Outer DVD Middle CD CD CD select Now Running CRG Move Out er 1: DVD Single Layer 2: DVD Dual Layer 3: CD 4: CD-RW 5: Return 5 Return select CRG Move Out er 1: Power OFF select CRG moves to the most outer Please Input Number E Search CRG home position CRG Move Out er CRG Move Completion select Now Running Please Input Number ERROR 1: Power OFF select Code : 00000000 Please Input Number ERROR Code : 00000000 F Please Reset 94 AVH-P4100DVD/XN/UC 1 2 select Error Rate : 000000 D 5 select *1 1: Power OFF 3 4 Error Rate display 5 6 7 8 6.3 DVD TOUCH PANEL TEST MODE How to enter: Reset with [VOL-] key and [TrackDOWN] key pressed. A How to unlock: Product reset Turning ACC ON Summary: It is for temporary analysis in services. (For temporary analysis of user claim and etc. against DVD touch direct.) (1)Display a frame border in the valid area as a button in the contents by OSD of DVD mecha on DVD-Video menu time. (2)Display a cross-shape on the place user touched on touch direct display time by OSD of DVD mecha. (3)Every time pressing "C (clear)" key on the remote controller, the color of the frame border and the cross-shape above (1)(2) is changed (white -> red -> black -> clear -> white -> ... ). B Remarks: The aim is as follows. 1.Display the available area of the disc button by OSD of MS5AVcode2. ->To clarify the true button position enables to judge the disc cause. 2.Display a cross-shape on the position that MS5AVcode2 thinks was pressed actually. ->To detect a gap in perception between HOST and mecha enables to judge the HOST cause. C D E F AVH-P4100DVD/XN/UC 5 6 7 8 95 1 2 3 4 7. DISASSEMBLY - Removing the Panel and Holder (not shown) (EW5, UW5) A 1. Remove the Panel. 2. Remove the eight screws and then remove the Holder. 3. Remove the four screws and then remove the Left and Right Holder. - Removing the Monitor Assy (Fig.1, 2, 3) 1 B Remove the two screws.(Fig.1) 1 1 Fig.1 Monitor Assy 2 Remove the screw and then remove the Cover.(Fig.2) 3 C 3 2 Disconnect the cable and then remove the Monitor Assy.(Fig.3) Cover Fig.2 - Removing the Monitor Unit (Fig.5) Fig.3 Cover Case Unit 3 1 Remove the screw and then remove the Cover.(Fig.4) 2 Remove the two screws.(Fig.4) D 3 1 2 2 Fig.4 3 3 Remove the four screws.(Fig.4) 4 Remove the four hooks and then remove the Case Unit.(Fig.4, 5) 3 4 4 4 Please insert the driver from the hole when it is difficult to remove the hook. Fig.5 E 4 Monitor Unit 5 Disconnect the two cables and then remove the LCD Assy.(Fig.6) 7 6 7 7 6 LCD Assy Disconnect the two cables.(Fig.6) 6 5 7 F 96 Remove the five screws and then remove the Monitor Unit. 5 7 7 Fig.6 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 - Removing the Keybord Unit (Fig.7, 8) A 1 Remove the three hooks and then remove the Keybord Unit.(Fig.7) Fig.7 1 Attention when the Keyboard Unit are exchanged.(Fig.8) 1 1 Keybord Unit _ Refer to figure for how to bend the Cable. _ Notes after exchanges. Fig.8 B The following items after the Keyboard Unit are exchanged are checked. • Bend the cable of a broken line part. • Don’t bend it while rubbing right and left. • Lighting confirmation of all LED • All switch operation confirmations • Confirming the operation of the Remote Control Unit - Removing the Case (Fig.9, 10, 11) The hook is removed with Tweezers as shown in figure. (Fig.9) Fig.10 Don’t remove from the hook of sign.(Fig.11) Because the Holder may be deformed.(Fig.10) Fig.9 Case 1 C Remove the four hooks with Tweezers and then remove the Case.(Fig.11) Holder 1 1 1 1 D Fig.11 - Removing the Panel Unit (Fig.12) Panel Unit 1 Remove the six screws. 2 Remove the two hooks and then remove the Panel Unit. 1 1 2 2 1 1 1 E 1 Fig.12 F AVH-P4100DVD/XN/UC 5 6 7 8 97 1 2 3 4 - Removing the DVD Mechanism Module (Fig.13) A 1 1 1 Remove the four screws. 2 Disconnect the cable and then remove the DVD Mechanism Module. 2 1 1 B Fig.13 DVD Mechanism Module - Removing the Chassis(Upper) (Fig.14, 15) Holder 2 C 1 Remove the two screws. (Fig.14) 2 Remove the five screws and then remove the Heat Sink. (Fig.14) 2 2 1 1 Heat Sink Remove the Holder. (Fig.14) 3 2 2 Remove the four screws and then remove Chassis(Upper) while holding both edges of the gasket. (Fig.15) Fig.14 3 3 3 3 D *If the gasket was damaged or lost, replace it with the new one. Chassis(Upper) Fig.15 E F 98 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 - Removing the Mother Unit (Fig.16) Mother Unit 1 Disconnect the cable. 2 Remove the screw. 1 A 3 3 3 3 Remove the four screws and then remove the Mother Unit. 3 2 B Fig.16 C NOTE: When you remove the top case OK NG Don't put tweezers or something into these holes to remove the top case Use these holes to remove the top case. D REASON: The rear panel may be deformed. E F AVH-P4100DVD/XN/UC 5 6 7 8 99 1 2 3 4 3 4 How to have it 1.Have a specified part. A Handling OK B Handling NG C D E F 100 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 Mecha Module_Bringing into the Clamp State with No Disc Loaded 1. Remove the relay FFC from the connector on the module PCB side (Fig. 1). (Precaution) When it is difficult to apply 4V to the motor in procedure 2 below, remove the connector on the relay PCB side, then remove the FFC, and remove the solder of the CRG motor lead and apply voltage to the lead. 2. Push the Disc detection arm while applying 4V to the CRG motor (Fig. 2) By this action, the mecha moves to the clamp state and the PU moves to the outer periphery. 3. Stop the motor when the PU comes to the vicinity of the intermediate periphery. (Precaution) If the PU goes to the outer most periphery, it idles. It is not a problem, but please try not to let it idle as much as possible. A GND the brown line 4V to the gray line Fig. 1 B Fig. 2 C Relay FFC Connector (relay FFC) D E F AVH-P4100DVD/XN/UC 5 6 7 8 101 1 2 3 4 CRG Mecha_Bringing into the Clamp State with No Disc Loaded 1.Remove the T-case washer and then remove the drive gear. (Fig. 1) 2.Lift the clamp arm assy until it is in the state shown in Fig. 2_b (open-lock state). 3.Put your finger on the area A of Fig. 2_c and then slide it to the direction of the arrow (the direction of the playing state). 4.Push down the clamp arm. (Precaution) When bringing the CRG mecha into the ejecting state again, install the drive gear after sliding the drive lever and bringing it to the ejecting state, in order to prevent the cog of the pinion in the drive gear from chipping at the time of its installation. A Fig. 1 B T-case washer Drive gear C Fig. 2 a.Ejecting state b.Open-lock state c.Clamp state with no disc loaded D A There is a space There is no space E F 102 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Removing the Module PCB 1.Short-circuit two spots on the land of the pick up FPC. (Fig. 1) 2.Remove the pick up FPC and the relay FFC from the connector. (Fig. 2) 3.Temporarily attach the pick up FPC to the pick up rack. (Fig. 3) (in order to prevent the damage to the pick up FPC) 4.Remove the two PCB clinch screws and then remove the module PCB. (Fig. 2) Connector (pick up FPC) Pick up FPC Fig. 2 A Short-circuit Fig.1 Fig.3 B Relay FFC Connector PCB clinch screw (Relay FFC) Removing/Installing the Relay PCB Removing) 1.Remove the relay FFC from the connector Fig. 4 (remove both sides so that the entire FFC will be removed). (Fig. 2) 2.Remove the solder on the lead for the CRG motor. (Fig. 4) 3.Remove the one relay PCB clinch screw. (Fig. 4) 4.Slide the relay PCB to the direction of the arrow and then remove the relay PCB from the hook A and the hook B. (Fig. 4) 5.Turn the relay PCB over and then remove the SPDL motor FFC from the connector. Installing) 1.Check the mecha is in the ejecting state (disc-load suspended state). When it is not in the ejecting state, apply 4V to the lead (motor) and then bring it to the ejecting state (4V to the brown line and GND the gray line). 2.Fit the SPDL motor FFC to the connector (back of the relay PCB). Fig. 5 3.Hold the relay PCB so that it does not touch the SW knob as in Fig. 5. 4.Insert it into the hook B as it is a little off to the clockwise direction. (Precaution) This is to prevent the SW knob from getting into the NG position as in Fig. 6. 5.Push down the relay PCB lightly and then rotate it to the counterclockwise direction. It sets the relay PCB in the hook A and the positioning dowel. (Precaution) Pay attention so the SW knob will not get onto the PU rack. (Fig. 6) 6.As in the Figures, while supporting the location A with your fingers, Fig. 6 screw the relay PCB. (Fig. 7 / Fig. 8) 7.Solder the lead for the CRG motor. 8.Fit the relay FFC to the connector. Fig. 7 Hook A Hook B Solder on the lead C Relay PCB clinch screw D Hook B E OK NG Fig. 8 A F AVH-P4100DVD/XN/UC 5 6 7 8 103 1 2 3 4 Removing the PU Unit A 1.Hook the feed screw biasing spring on the temporary hook (Fig. 2b). Be careful not to get injured by the tip of the spring. 2.Hold the PU at the location A in Fig. 1 and slide and scoot it to the direction of the inner periphery. 3.As in Fig. 3, shift the back end of the feed screw to the side and then to above and remove it from the outside holder. 4.Remove the tucking joint for the chassis at the location B and the PU unit by lifting them up without changing their position and then remove the PU unit. (Precaution) When installing the PU again, make sure to tuck the chassis in B and the PU unit (Fig. 4) first. Moreover, do not forget to permanently hook the feed screw biasing spring (Fig. 2a). Adjustments to the PU after its installation should be made according to the service manual. Fig. 1 Slide to the direction of inner periphery Permanently hooked position Temporary hooked position Fig. 2a Fig. 2b B The spring is installed under the resin flange and inside the bended metal plate. B A C Fig. 3 Fig.4 D Outside holder Back end of the feed screw Regularly installed position Install avoiding the area with blue broken line (the connected metal plate part) [Installation NG] The chassis is not tucked between the PU case and the PU rack. Sending the PU to the outer periphery E 1.Bring to the clamp state with no disc loaded according to the “Mecha Module_Bringing into the Clamp State with No Disc Loaded” manual. (Precaution) The relay FFC must be removed for certainty in order to prevent the IC damage. 2.Apply 1.5V to the CRG motor and then transfer the PU to the outer periphery. (Precaution) Do not forget to reinstall the relay FFC after sending the PU to the outer periphery and take the necessary measures. F 104 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 8. EACH SETTING AND ADJUSTMENT 8.1 DVD ADJUSTMENT A 1) Precautions This product uses 5 V and 3.3 V as standard voltages. The electrical potential that is the reference for signals, is not GND, but VREF (approximately 2.2 V) and VHALF (approximately 1.65 V) . During product adjustments, if the reference voltage is mistakenly taken as GND, and a grounding contact is made, not only would it be impossible to measure the accurate electrical potential, but also the servo motor would malfunction, resulting in the application of a strong impact on the pick up. The following precautionary measures should be strictly adhered to, in order to avoid such problems. The reference voltage and GND should not be confused when using the minus probe of a measurement device. When an oscilloscope is being used special care should be taken to make sure that the reference voltage is not connected to the probe of ch1 (on the minus side), while the probe of ch2 (on the minus side), is connected to GND. Further, since the body frame of most measurement devices have the same electrical potential as the minus side of the probe, the body frame of the measurement device should be set to floating ground. If the reference voltage is connected to GND by mistake, turn the regulator OFF immediately, or turn the power OFF. Remove the filters and wires used for measurements only after the regulator has been turned OFF. After the power supply is turned on, regulator ON the following adjustment and measurement are promptly done. Whenever the product is in the test mode, the software will not take any protective action. For this reason, special care should be taken to make sure that no mechanical or electrical shock could be applied to the product when taking measurements in the test mode. Whenever the EJECT key is pressed to eject the disk, no other keys, other than the EJECT key, should be pressed until the disk eject action has been completed. Press the EJECT key only after the disk has stopped completely. If the product hangs up turn the power OFF immediately. Laser didoes may be damaged, if the volume switch for the laser power adjustment of the pick up unit, is turned. B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 105 1 2 3 4 - SKEW adjustment A When one of the following replacements has taken place, SKEW adjustment for the pick up will be required. (1) Replacement of the pick up unit (2) Replacement of the spindle motor (3) Replacement of the carriage chassis (4) Replacement of the main shaft of the pick up unit Measurement equipment and tools/jigs: Oscilloscope Driver for SKEW adjustment -> Driver Bond for fixing the SKEW -> GEM1033 Bond for resonance -> 1530 (1530 : produced by THREE BOND) Bond for locking the screw -> 1401M (1401M : produced by THREE BOND) Disc used:TDV-582 B Measurement reference: AGND3 Measurement point: RF Connection drawing DVD core unit AGND3 AGND3 C RF RF D Expansion Oscilloscope E Symptom in case the adjustment is not adequate: Worsening of the error rate 10 -4 (Normally 10 or less.) Large RF jitter RF waveform distortion Tracking drawing/Unstable servo * Caution: Do not look into the laser light during adjustment. -3 F 106 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 There are two methods of making adjustment: a method of making adjustment through monitoring RF waves by the oscilloscope (method 1) and a method of making adjustment through checking the numerical value of the RF level by OSD (method 2). Adjusting procedure is shown below, but regarding how to start the test mode and the operating procedure, please refer to the clause on the service test mode. A Adjusting Procedure: 1. Install the pickup (Refer to the removal of the pickup from the mecha unit.) When handling the pickup, refer to the precautions on how to handle the PU listed below. 2. Method 1: Connect the oscilloscope according to the AGND3 standards with reference to the connection diagram so that the RF signals can be monitored. Method 2: The device does not need to be set. Proceed to the procedure 3. 3. Turn ON the power of the product. 4. Start the simplified FE test mode. (Regarding how to start the test mode and the operating procedure, refer to the clause on the service test mode.) 5. Load the disc for adjustment (TDV582). 6. TEST MODE Select “3: Skew Adjustment.” B TEST MODE 1: LD ON 2: ASMAX 3: Skew Adjustment 4: Error Rate 5: CRG Move Outer 6: Eject C Please Input Number Skew Adjustment Select “1: DVD Single Layer.” Skew Adjustment 1: DVD Single Layer D 5: Return Please Input Number Adjust the Skew using a driver while checking the RF value. Refer to the following pages concerning the locations to make SKEW adjustment. Method 1: Slightly turn the skew adjusting screw A while checking the RF wave level by the oscilloscope and make adjustment so the wave level would reach its maximum. Next, slightly turn the skew adjusting screw B so the wave level would reach its maximum. Slightly turn the skew adjusting screw A again so the wave level would reach its maximum. (Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw in the clockwise direction.) E Method 2: Slightly turn the skew adjusting screw A while checking the value of the RF level through the OSD display so the wave level would reach its maximum. Next, slightly turn the skew adjusting screw B so the level would reach its maximum. Slightly turn the skew adjusting screw A again so the level would reach its maximum. (Make adjustment in the order of A->B->A and in the end complete adjustment by turning each screw in the clockwise direction.) F AVH-P4100DVD/XN/UC 5 6 7 8 107 1 2 3 4 Skew Adjustment 1: Power OFF A RF Level : 000000 Please Input Number 9. Skew Adjustment Select “1: Power OFF.” Skew Adjustment 1: Power OFF B RF Level : 000000 Please Input Number 10. TEST MODE Select “6: Eject.” TEST MODE 1: LD ON 2: ASMAX 3: Skew Adjustment 4: Error Rate 5: CRG Move Outer 6: Eject C Please Input Number 11. TEST MODE Select “5: CRG Move Outer.” TEST MODE 1: LD ON 2: ASMAX 3: Skew Adjustment 4: Error Rate 5: CRG Move Outer 6: Eject D Please Input Number 12. In order to produce the clamping state with no disc loaded, slightly move the disc detection arm in the counterclockwise direction while moving the switch arms outward. E Switch arms F 108 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B Disc Detection Arm 13. CRG Move Outer Select “1: DVD Single Layer.” CRG Move Outer 1: DVD Single Layer 2: DVD Dual Layer 3: CD 4: CD-RW 5: Return C Please Input Number The pickup moves to the outer periphery. Apply the adhesive to fix the skew, the resonance adhesive and the screw lock. Refer to the next page regarding the locations of adhesive joining. 14. CRG Move Outer 1: Power OFF CRG Move Outer D 1: Power OFF Please Input Number 15. TEST MODE Select “6: Eject.” E TEST MODE 1: LD ON 2: ASMAX 3: Skew Adjustment 4: Error Rate 5: CRG Move Outer 6: Eject Please Input Number F AVH-P4100DVD/XN/UC 5 6 7 8 109 1 2 3 4 Locations to make SKEW adjustment A A B A B B Locations to adhere the SKEW 1,2,3: BOND QUICK MENDER C 2 3 1 D 1 2 3 E F 110 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 Bond for resonance 4:Three Bond 1530 A 5 4 6 B 4 C adhesive Bond for locking the screw 5,6 : Three Bond 1401M 5 D 6 E Bond for locking the screw F AVH-P4100DVD/XN/UC 5 6 7 8 111 1 2 3 4 Precautions on handling the PU *Precaution: Do not touch those shaded areas in the following figures. . Do not touch the optical part A Hologram (Beware of the static) B RF level adjusting part Do not touch the spring C D E F 112 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 8.2 MONITOR UNIT ADJUSTMENT MONITOR UNIT(SIDE B) A - Adjustment Point VCC33 15V PWRVI 8V 53V B -16V COM C MONVBS COMDC D E F AVH-P4100DVD/XN/UC 5 6 7 8 113 E F C D 114 1 2 Tone voltage amplitude check V0 Tone voltage amplitude check V3 Tone voltage amplitude adjustment V5 8 9 3 No definition 53pin of CN6001 55pin of CN6001 58pin of CN6001 0.121 ± 0.10 V 1.68 ± 0.20 V - - 4.50 ± 0.30 V - Connect LCD panel for measurement Connect LCD panel for measurement Connect LCD panel for measurement Connect LCD panel for measurement 2 No definition No definition B Note A 7 NOTE:When shutting off the power supply of TC90A96BFGSING, be careful not to energize each IC terminal. However , IIC lines(SDA and SCL) is not included in this case and it is possible to energize them with up 5 V. Input signal Measurement point Adustment point No. Adustment item Adustment 1 Check 3.3 V power TP:PWRVI TP:VCC33 VCC33 = 3.3 ± 0.3 V supply voltage to 14.4 V 2 Check 5.3 V power TP:PWRVI TP:53V 53V = 5.3 ± 0.3 V supply voltage to 14.4 V 3 Check 8 V power TP:PWRVI TP:8V 8V = 8.0 ± 0.5 V supply voltage to 14.4 V 4 Check 15 V power TP:PWRVI TP:15V 15V = 15.0 ± 0.2 V supply voltage to 14.4 V 5 Check -16 V power TP:PWRVI TP:-16V -16V = 16.35 ± 0.35 V supply voltage to 14.4 V 6 Vcom amplifier No definition TP:COM 5.80 ± 0.10 V output amplitude check MONITOR UNIT ADJUSTMENT 1 3 4 AVH-P4100DVD/XN/UC 4 5 51pin of CN6001 49pin of CN6001 48pin of CN6001 Screen DAC output Screen No definition 6 7 16 15 14 13 12 11 No definition No definition Input Color-bar signal from IC5702 Input composite image 10-step signal to TP MONVBS (2.0 Vpp ± 1%) Input composite image lamp signal (monochrome) to TP MONVBS Tone voltage amplitude adjustment V9 Tone voltage amplitude adjustment V10 Image check of RGB signal Composite level check Image check Flicker adjustment Output black-white 50% reverse signal per 1 line from IC5702 Connect LCD panel for measurement 3.15 ± 0.20 V 3.43 ± 0.20 V - - - - TP COMDC DC output - Adjust the flicker level to minimum from all directions. Adjustment point can be COM DC off flicker adjustment mode. Make sure that tone changes Execute to verify that IC5702 digital-out smoothly, and there is no is not bridged or "OPEN"ed. colored area in the entire display. 1.77 V ± 0.05 V The amplitude of the 9-step and the 0-step is 1.77 ± 0.05 V. Connect LCD panel for measurement 1.262 ± 0.20 V - Note Connect LCD panel for measurement Adustment - Adustment point 6 Screen Measurement point Input signal No. Adustment item 10 Tone voltage amplitude adjustment V7 5 7 8 A B C D AVH-P4100DVD/XN/UC 8 E F 115 1 2 3 4 8.3 PCL OUTPUT CONFIRMATION A - PCL output In the normal operation mode (with the detachable panel installed, the ACC switched ON, the standby mode cancelled), shift the TESTIN IC601(Pin 87) terminal to H. The clock signal is output from the CLKOUT terminal IC601(Pin 62). The frequency of the clock signal is 625 000 Hz that is one 32th of the fundamental frequency. The clock signal should be 625 000 Hz (- 10 Hz, + 15 Hz). If the clock signal out of the range, the X’tal (X601) should be replaced with new one. B C D E F 116 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 9. EXPLODED VIEWS AND PARTS LIST NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) A " B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 117 1 2 3 4 3 4 9.1 PACKING(AVH-P4100DVD/XN/UC) AVH-P4100DVD/XN/UC A B C D E F 118 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 PACKING(AVH-P4100DVD/XN/UC) SECTION PARTS LIST Mark No. * Description Mark No. Part No. Description Part No. 1 Cord Assy CDP1219 12-1 Owner's Manual CRB2897 2 Cord Assy CDP1166 12-2 Owner's Manual CRB2898 CRB2983 3 Screw Assy CEA2788 12-3 Owner's Manual 4 Polyethylene Bag CEG-127 12-4 Installation Manual CRD4377 5 Screw BMZ50P080FTC 12-5 Caution Card CRP1387 6 Screw CMZ50P080FTC * 16-6 Warranty Card 7 Poly Bag CEG1402 13 8 Unit Box CHG6730 14 Polyethylene Bag 15 ••••• 16 Sheet 9 Contain Box CHL6730 10 Protector CHP3709 11 Pen A CRY1276 Panel CNS9475 CEG1426 CNN3089 B CNV8969 Owner's Manual,Installation Manual Part No. Language CRB2897 English CRB2898 French CRB2983 Spanish(Espanol) CRD4377 English, French, Spanish(Espanol) C D E F AVH-P4100DVD/XN/UC 5 6 7 8 119 1 2 3 4 3 4 9.2 PACKING(AVH-P4100DVD/XNEW5, XNUW5) AVH-P4100DVD/XNEW5 AVH-P4100DVD/XNUW5 A B C D E F 120 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 (1) PACKING(AVH-P4100DVD/XNEW5, XNUW5) SECTION PARTS LIST Mark No. * Description Mark No. Part No. Description Part No. 1 Cord Assy CDP1040 2 Cord Assy CDP1167 16-1 Installation Manual See Contrast table(2) See Contrast table(2) 3 Attachment Assy CEC1766 16-2 Quick Start Guide 4 Screw Assy CEA9898 16-3 Quick Start Guide See Contrast table(2) CMZ50P080FTC 16-4 Owner's Manual See Contrast table(2) 16-5 Owner's Manual See Contrast table(2) 5 Screw 6 Screw 7 ••••• * 16-6 Caution Card See Contrast table(2) ••••• * 16-7 Caution Card See Contrast table(2) Screw * 16-8 Passport See Contrast table(2) 16-9 Warranty Card CRY1279 8 9 10 BMZ50P080FTC CBA1650 Bush 11 A CNV3930 Poly Bag 17 Panel CNS9366 IM CD-ROM See Contrast table(2) B CEG1401 12 Unit Box See Contrast table(2) 18 13 Contain Box See Contrast table(2) 19 Polyethylene Bag CEG1426 20 Sheet CNN3089 14 Protector CHP3708 15 Pen CNV8969 (2) CONTRAST TABLE AVH-P4100DVD/XNEW5 and AVH-P4100DVD/XNUW5 are constructed the same except for the following: Mark * * * No. Description AVH-P4100DVD/XNEW5 AVH-P4100DVD/XNUW5 12 13 16-1 16-2 16-3 Unit Box Contain Box Installation Manual Quick Start Guide Quick Start Guide CHG6728 CHL6728 CRD4376 CRD4393 CRD4394 CHG6729 CHL6729 CRD4378 Not used Not used 16-4 16-5 16-6 16-7 16-8 Owner's Manual Owner's Manual Caution Card Caution Card Passport Not used Not used CRP1389 CRP1394 CRY1268 CRB2899 CRB2900 Not used Not used Not used 18 IM CD-ROM CPJ1271 Not used C Owner's Manual,Installation Manual,Quick Start Guide Part No. D Language CRD4393 CRD4394 CRD4376 CRB2899 CRB2900 CRD4378 English, Spanish(Espanol), German, French Italian, Dutch English, Spanish(Espanol), German, French, Italian, Dutch English Russian English, Russian (3) CONTENTS OF CD-ROM (Operation Manual), CPJ1271 Part No. Language * CRB2878 * CRB2879 * CRB2880 * CRB2881 * CRB2882 * CRB2883 * CRB2884 * CRB2885 * CRB2886 * CRB2887 * CRB2888 * CRB2889 * CRB2890 English Spanish(Espanol) German French Italian Dutch Swedish Norwegian Finnish Danish Portuguese Greek Turkish E F All operation manuals are supplied in PDF files by the CD-ROM. No printed papers are available. AVH-P4100DVD/XN/UC 5 6 7 8 121 1 2 3 4 3 4 9.3 EXTERIOR(1) A A B B A C A D E F 122 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 (1) EXTERIOR(1) SECTION PARTS LIST Mark No. Description Mark No. Part No. Description Part No. 1 Screw ASZ26P050FTC 29 2 Screw See Contrast table(2) 30 Jack(JA2002) 3 Screw BMZ25P040FTB 4 Screw BSZ26P060FTC 31 Connector(JA2004) CKS3410 BSZ26P100FTC 32 Connector(CN901) CKS3871 33 Connector(JA2001) CKS4124 Connector(CN801) CKS4178 5 Screw Jack(JA951) CKN1042 CKN1077 6 Screw BSZ26P160FTC 34 7 Screw CBA1735 35 Connector(CN522) CKS5669 8 Screw(M2 x 3) CBA1877 9 FFC CDE8603 36 Connector(CN121) CKS6051 CDE8746 37 Connector(CN501) CKS6062 38 Connector(CN2002) CKS6062 See Contrast table(2) 39 Antenna Jack(JA402) CKX1060 40 Holder CND4811 10 FFC 11 Screw A B 12 Chassis CNA3100 13 Case CNB3543 14 Holder See Contrast table(2) 41 Holder See Contrast table(2) See Contrast table(2) 42 Insulator CNN2307 43 Gasket CNN2782 FM/AM Tuner Unit(U401) See Contrast table(2) Holder CND4324 15 Holder 16 Holder CND4809 44 17 Holder CND4810 45 18 Insulator CNN2764 19 Heat Sink CNR1981 20 Panel 21 46 Pin Jack(JA101) XKB7001 47 Fuse(10 A) YEK5001 48 Panel Unit See Contrast table(2) CNW1450 49 DVD Mechanism Module(LS1) CXK6800 50 IC(IC181) See Contrast table(2) Cover > PA2030A 22 Mother Unit See Contrast table(2) 23 Screw BPZ26P080FTC 24 Screw BSZ26P060FTC 51 IC(IC1061) NJM2388F84 CDE8747 52 Holder See Contrast table(2) 53 Connector(CN2001) See Contrast table(2) CKB1065 54 Screw See Contrast table(2) 55 Sheet See Contrast table(2) 25 FFC 26 Pin Jack(JA2003) 27 Pin Jack(JA102) CKB1085 28 Plug(JA141) CKM1376 (2) CONTRAST TABLE AVH-P4100DVD/XN/UC, AVH-P4100DVD/XNEW5 and AVH-P4100DVD/XNUW5 are constructed the same except for the following: Mark No. Description AVH-P4100DVD/XN/UC AVH-P4100DVD/XNEW5 AVH-P4100DVD/XNUW5 BMZ30P060FTC 2 Screw Not used BMZ30P060FTC 11 Screw Not used CMZ50P080FTC CMZ50P080FTC 14 Holder Not used CND4337 CND4337 15 Holder Not used CND4338 CND4338 20 Panel Not used CNS9952 CNS9952 22 Mother Unit CWN3794 CWN3790 CWN3795 41 Holder CND4864 CND4864 CND4808 44 FM/AM Tuner Unit(U401) CWE2098 CWE2097 CWE2097 48 Panel Unit CXE1738 CXE1736 CXE1736 52 Holder Not used Not used CND4814 53 Connector(CN2001) Not used Not used CKS4497 54 Screw Not used Not used BSZ26P060FTC 55 Sheet Not used CNN2947 CNN2947 F AVH-P4100DVD/XN/UC 6 7 D E *If the gasket (No.43: CNN2782) was damaged or lost, replace it with the new one. 5 C 8 123 1 2 3 4 9.4 EXTERIOR(2) A B A E A C D F E F UC EW5, UW5 124 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 (1) EXTERIOR(2) SECTION PARTS LIST Mark No. Description * 20 Monitor Unit See Contrast table(2) Description Part No. Screw(M2 x 3) CBA1877 2 Cover CNN2600 3 Cover CNN2601 21 Connector(CN5401) CKS5561 4 Flexible PCB CNQ2709 22 Connector(CN6101) CKS5561 CNW1449 23 Connector(CN5003) CKS5629 24 Connector(CN6001) CKS5773 25 Connector(CN5001) CKS5957 Cover A 6 Touch Panel 7 Button(RESET) CAI2199 8 Plate CNN2856 26 LCD CWX3691 See Contrast table(2) 27 Case Unit CXE1249 CNW1445 28 Cushion CNN1325 29 Screw IMS20P030FTC 30 Cord Assy CDP1167 CNS1472 9 Grille 10 * Mark No. 1 5 * Part No. Lighting Conductor CSX1142 11 Spacer 12 Lighting Conductor CNW1458 13 Holder Unit CXE1268 31 Cap AMZ20P030FTC 32 Resistor RS1/2PMF102J 33 Button Unit CXE1271 14 CNW1446 Screw 15 Screw(M2 x 2) * CBA1771 16 Holder CND4805 17 Holder CND4807 18 Insulator CNN2596 19 Insulator CNN2778 B 34 Spacer CNN3066 35 Spacer See Contrast table(2) 36 Keyboard Unit See Contrast table(2) (2) CONTRAST TABLE AVH-P4100DVD/XN/UC, AVH-P4100DVD/XNEW5 and AVH-P4100DVD/XNUW5 are constructed the same except for the following: Mark * No. Description AVH-P4100DVD/XN/UC AVH-P4100DVD/XNEW5 C AVH-P4100DVD/XNUW5 9 Grille CNS9812 CNS9812 CNS9665 20 Monitor Unit CWN3797 CWN3797 CWN3796 35 Spacer Not used Not used CNN2602 36 Keyboard Unit CWN3798 CWN3798 CWN3800 D E F AVH-P4100DVD/XN/UC 5 6 7 8 125 1 2 3 4 9.5 EXTERIOR(3) A G (A) (A) B (A) Spreads it on the entire gear (A) (B) (C) C (A) (A) D (A) (A) (A) E (A) : GEM1024 (B) : GEM1043 (C) : GEM1048 (A) F 126 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 EXTERIOR(3) SECTION PARTS LIST Mark No. Description Part No. 1 Drive Unit CXE1173 2 Screw AMZ26P030FTC 3 Screw BMZ26P030FTC 4 Screw(M2 x 2) CBA2129 5 Washer CBF1039 6 Screw EBA1049 7 Spring EBH1684 8 Spring EBL1031 9 Spring EBL1032 10 Slit board ENC1582 11 Bracket ENC1586 12 Insulator ENM1048 13 Spacer ENM1049 14 Insulator ENM1051 15 Arm(White) ENV1615 16 Gear ENV1616 17 Gear ENV1617 18 Gear ENV1618 19 Roller ENV1619 20 Rack ENV1620 A B C * 21 Arm(Black) ENV1623 22 Frame Unit EXA1669 23 Motor Unit EXA1674 24 Chassis Unit EXA1687 25 Service PCB Assy EXX1058 26 Cord(White) EDC1024 27 Cord(Orange) EDC1025 D E F AVH-P4100DVD/XN/UC 5 6 7 8 127 1 2 3 4 9.6 DVD MECHANISM MODULE A A (C) (C) B B (A) (C) (B) G B C D C (A) D C (A) (C) (A) (A) (C) F D (A) (C) (C) A E G (C) E D (C) C E (A) : GEM1045 F F (B) : GEM1038 (C) : GEM1024 128 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 DVD MECHANISM MODULE SECTION PARTS LIST Mark No. Description Mark No. Part No. 1 Screw BMZ20P020FTC 2 Screw BSZ20P040FTC 3 Screw(M2 x 4) CBA1835 4 Washer CBF1038 5 Spring CBH2860 Description Part No. 50 Holder CNW1195 51 Damper CNW1197 52 Damper CNW1198 53 Connect PCB Unit CWX3618 54 Connector(CN701) CKS6003 55 Connector(CN101) CKS6063 CXC4026 A * 6 Spring CBH3010 7 Spring CBH3011 8 Spring CBH3012 56 Motor Unit CBH3013 57 Screw Unit CXC8894 CBH3014 58 Chassis Unit CXC8895 59 Arm Assy CXC8896 60 Washer CBF1037 CBF1038 9 10 Spring Spring 11 Spring CBH3015 12 Spring CBH3016 13 Spring CBH3017 61 Washer CBH3018 62 Arm CND4554 CBH3019 63 Collar CNV6906 64 Roller CNW1196 65 Gear Unit CXC8893 14 15 Spring Spring 16 Spring CBH3020 17 Spring CBH3030 18 Plate Spring CBL1797 66 Screw(M2 x 5) EBA1028 Motor EXM1050 19 Cable CDE8631 67 20 Service PU Unit CXX2398 68 Screw JFZ20P025FTC 69 Screw JGZ17P022FTC 70 Washer YE15FTC 21 Bracket CND4553 22 Arm CND4555 23 Lever CND4556 71 Screw IMS20P030FTC DVD Core Unit YWX5007 24 Frame CND4557 72 25 Frame CND4558 73 Connector(CN1101) CKS5775 74 Connector(CN1201) CKS6003 75 Connector(CN1901) CKS6025 26 Sheet CNN2280 27 Rack CNW1170 28 Guide CNW1171 29 Roller CNW1172 30 Arm CNW1173 31 Arm CNW1174 32 Roller CNW1175 33 Lever CNW1176 34 Arm CNW1177 35 Arm CNW1178 36 Gear CNW1180 37 Gear CNW1181 38 Gear CNW1182 39 Gear CNW1183 40 Rack CNW1184 41 Gear CNW1185 42 Gear CNW1186 43 Gear CNW1187 44 Gear CNW1188 45 Clamper CNW1190 46 Arm CNW1191 47 Arm CNW1192 48 Holder CNW1193 49 Holder CNW1194 6 C D E F AVH-P4100DVD/XN/UC 5 B 7 8 129 1 2 3 4 A (A) (A) (C) (C) B (C) (C) (C) (C) (C) (A) C (A) (A) D E (A) : GEM1045 (B) : GEM1038 F (C) : GEM1024 130 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 131 1 2 3 4 10. SCHEMATIC DIAGRAM 10.1 MOTHER PCB(ANALOG) Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". VOUT VOUT_G VCR_RIN VCR_RG 2 1 VCR_LG 3 5 4 VCR_VG VCR_LIN 6 VCR_VIN 7 TP105 TP106 TP108 TP109 TP103 TP107 TP104 GNDA GNDA MALS068X D105 R112 R113 MALS068X D103 22k 22k C2 4 3E C108 2 C109 B1 5 C110 E1 6 2 VCR_R R111 GND A 3/4 20 C202 22 1u/10 C227 23 NM C203 24 BUSR- 1u/10 C204 25 BUSR+ 1u/10 C205 26 0.1u/10 C206 27 NM 1u/10 0 28 ONSEI- ONSEI+ L201 10 NM 47u/16 0.1u/10 2.2u C207 10u/10 9 NM NM R215 R203 NM R201 AVSDA TXNAVI RXNAVI GUIDEON TVON PA_FL 8.3V 11 0.1u/10 C222 C225 7 C209 1u/10 NM 6 C228 1u/10 5 C210 4 C211 NM 1u/10 R213 NM 3 C212 2 C213 1u/10 0.1u/10 1 C214 0.22u/6.3 NAVI GUIDE 4 IP_BUS 5 TUNER R222 1 3 GNDA 4 OUT1 VCC IN-1 OUT2 IN+1 IN-2 VEE IN+2 LS_V LS_L TUN_L GNDBE2 TUN_R GNDA AUX_V R323 BC_VGND NM R324 VCR_VGND BCAM_IN VCR_V MONITOR R319 NM R320 NM R321 NM GNDA R312 9 100 10 R330 R322 C315 C316 C340 C341 43 42 41 40 39 - 4 L2-2 6 - - 5 VCC2 11 BIAS2 GND2 12 - B.CAM x VCR_R 22k R318 68 4.7 NM NM C307 0.1u/10 C308 0.1u/10 1 1 1 1 1 2 3 3 GNDA 3 NM GNDV ANALOGBUS 2 0 R_VOUT NM 100u/6.3 Q 0 R317 AVH-P4100DVD/XN/UC 1 R371 R378 37 C343 C342 38 1u/10 C333 C332 220u/4 NM mini C346 R373 VCR mini NM C345 R372 VCR 3 R327 C344 NM 2 V2-1 V1-2 V1-1 NM V4-1 V2-2 R306 C304 44 V3-1 R305 C303 45 V4-2 V5-1 V3-2 C302 46 L2-1 R314 GNDA NM NM C301 47 V6-2 V6-1 V5-2 R1-2 - R326 220 C314 NM C323 R1-1 AUDIO LS1 35 SCL SDA 34 VOUT1 33 FB1 32 VOUT2 31 FB2 30 LOUT2 29 ROUT2 28 LOUT1 27 ROUT1 R5-2 26 R5-1 25 GNDV R325 220 C371 NM 7 100 8 VIDEO 1 SYS+B 8.3V 36 0.1u NM C320 R310 L1-2 AUAGND NM AUX_R 22u/16 0.1u/10 NM 6 1u/10 C347 0.1u/10 C326 C331 C325 47u/16 RB551V-30 RB551V-30 D302 D301 22k NM 5 C318 MONVBS R2-1 C309 R301 15 R2-2 L3-1 C312 R302 16 L3-2 C310 R303 17 R3-1 C313 R304 18 R3-2 C327 19 L4-1 C329 20 L4-2 C328 21 R4-1 C330 22 R4-2 23 L5-1 C305 L5-2 C306 24 1u/10 VCR_LGND C319 IC301 AN15887A L1-1 VCR_RGND GNDV GNDA C321 R307 VCC1 3 BIAS1 GND1 NM 4 AUX_L C311 0.1u/10 C337 22u/16 0.1u/10 2 C317 100 1u C322 R311 13 C324 R313 14 VCR_L C336 C334 E C335 47u/16 1 NM R316 C339 100 R329 1u/10 48 C338 NM NM R315 R308 0 R328 8.3V R309 0 SYS+B 132 6 5 GN NM A 1/4 7 NM AV SELECTOR A 2/4 A 3/4 8 BUSL- AUVGND F SY IC202 NM 2 BUSL+ AV SEL NM C226 C223 8 LS1 3 NM 1k C224 R223 R207 SYS+B 2 NM EVSTB 12 E.VOL INPUT 1 R224 19 C216 0.1u/16 C208 10u/10 13 C220 R218 NM 1k 47u/16 14 C218 NM 1k R206 Vp Pre/SW_R Pre/SW_L Rear_R Rear_L Front_R Front_L DATA Vcc CLK Vref STB IN1_L GND IN2_L IN1_R IN3_L IN2_R IN4-_L IN3_R IN4+_L IN4-_R IN5+_L IN4+_R IN5-_L IN5+_R PA_RL RCA_FL 2.7k Pref PGND C219 R217 NM R205 EVSCK C201 2.7k R220 1.6k NM 17 EVSDT R214 1.6k R219 C215 NM R225 NM R216 NM C221 16 18 LS_R D 12.2V 1C uCOM BUS AVSCL IC201 PML018A 21 E.VOL INPUT FM(UC):-14.0 dBs AM(UC):-24.0 dBs FM(EW5):-10.0 dBs AM(EW5):-20.0 dBs IP-BUS: +2.2 dBs AUX: +2.2 dBs USB(AUX): +0.9 dBs USB(LS1): +5.1 dBs VCR: +2.2 dBs DVD/CD: +5.1 dBs RCA_RL RCA_SWL WIRED 1.6k 15 E.VOL CAPTAIN6 R211 EV12 R221 0 1.6k R209 0 R204 2.7k WIREDAD RCA_RR RCA_FR 2.7k R202 RCA_SWR PA_RR R210 R208 C PA_FR MAINTEST BUS+ ASENBO BUS- AUX_EXT R212 2B Q105 IMH23 0.1u/50 VCR_RGND P102 1 GNDV R_VOUT VCR_LGND VCR_L VCR_V ONSEI- ONSEI+ BC_VGND BCAM_IN AUX_V AUVGND AUX_R AUAGND AUX_L BUSL- BUSL+ VCR_VGND CSYNC GNDSIG GNDSIG ANB GNDSIG ANG GNDSIG ANR 1k R129 22k R115 75 2 miniSMDC075F/24 NM 82 P132 2 C106 1 P131 4.7u/10 1 RCA_RR 180 GNDD 22k R126 R127 GNDRF FOR SERVICE 1 1k R128 GNDV JA 0.1u/50 MALS068X D104 NAVI_EXT BUSR+ BUSR- VCR IN P130 R123 180 R125 2.2k R124 GNDD GNDD A 3/4 TP102 1 Q121 R121 E2 C2 4 3 5.6k B2 B1 5 2 E1 C1 1 6 UMF23N 3.3k B miniSMDC075F/24 2 P121 R122 8 GNDD NAVI_TO_SYS SYS_TO_NAVI GUIDEON TVON NC ONSEI- ONSEI+ GNDAU CCAUR CCAUL GNDSIG BUP_1 14.4V VCR:+8.2 dBs C111 1 2 3 4 5 6 7 8 9 10 11 GNDSIG CSYNC 12 13 14 ANG ANB 15 GNDSIG ANR NC WIRED WIREDAD GNDSIG 16 17 18 19 20 GNDD JA102 CN2002 21 22 23 BCAM_IN GNDV AUXV AUVGND MAINTEST AUXR AUXL B BCAM_VGGND 25 26 27 28 29 30 BUSL- BUSL+ GND BUSR- BUSR+ ASENSB0 BUS- AUAGND 31 32 33 34 35 36 37 38 39 40 CN121 BUS+ IP-BUS&NAVI&WIRED 24 A 4 5 6 dBs GND 10 GND GND FRONT_L GND FRONT_R 6 A 1/4 MOTHER PCB(ANALOG) B1 5 2 B2 E1 6 1 C1 E1 6 1 C1 E1 6 1 C1 R104 C182 0.47u/16 C188 0.47u/16 C183 C187 0.47u/16 RCA_FL 0.47u/16 C185 0.47u/16 PA_RR PA_RL C184 0.47u/16 R185 B1 2 5 B2 1.5k C2 3 4 E2 SYSMUTE 0.47u/16 C190 0.47u/16 15 C181 TP181 OFFMUTE1 R182 100k SYS+B 8.3V 17 RL+ 18 GNDA 19 RLR188 20 100 21 RR+ 22 23 RR- GND D182 1.TAB PW-GND2 2.PW.GND2 OUT2(-) 3.RR- STBY 4.STBY OUT2(+) 5.RR+ VCC2 6.VCC1/2 OUT1(-) 7.RL- PW-GND1 8.PW.GND1 OUT1(+) 9.RL+ RIPPLE 10.SVR IN1 11.FLIN IN2 12.FRIN PRE-GND 13.S-GND IN4 14.RRIN IN3 15.RLIN AC-GND 16.ACGND OUT3(+) 17.FL+ PW-GND3 18.PW.GND3 OUT3(-) 19.FL- VCC1 20.VCC3/4 OUT4(+) 21.FR+ MUTE 22.MUTE OUT4(-) 23.FR- PW-GND4 24.PW.GND4 H-SW/VOS-DET 25.B.REMOTE B C D184 S1G-6904G2P C195 0.1u/50 47k R168 PBSENS GND L162 2.2u D164 6 C1 5 B2 4 E2 UMT1N 10k DAN202U 1 E1 2 B1 3 C2 Q163 R162 GNDD PBSENS 25 ACC33 R174 5 R170 47k PW CONNECTOR GNDD GNDA TP160 4.7k D165 2 TP159 FR+ 3 TP172 RR+ 4 D FR+ R176 L161 2.2u DAN202U RR+ 15k TP158 0.1u/50 R171 47k 1 TP173 RR- RR- TELMUTE R165 FR- FR- GND C166 NM 2.2u/16 C192 0.1u/50 TAB UDZS8R2(B) TELMUTE 47k NM 6 C217 NM IN+2 16 3.3V NM IN-2 VEE R223 IN+1 7 2.2u/16 C194 AMPMUTE GNDA 8 R224 OUT2 FL- 5 FLTP171 RL- GNDD TP165 TP163 R163 R177 RL7 TP170 RL+ 8 6 C1 5 B2 4 E2 UMX1 N C163 TP169 0.1u/50 1 E1 2 B1 3 C2 4.7k R166 R173 RL+ Q1 6 2 MONVBS FL+ FL+ 10k 0 6 TP157 ASENS D162 HZU7L(A1) 47k BSENS MONITOR VBS ADJUST 9 P.B. TP168 10 TP175 RCAOUT MUTE&VCRIN IP-BUS&NAVI&WIRED PW CONNECTOR SENS AMP E.VOL CAPTAIN6 AV SELECTER MONITOR VBS ADJUST R167 47k TP177 SIDE_A TP156 BGSENS 100k 14.4V L163 10k CTF1295-A 14 ACC GND1 GND2 15 GND TP178 TP155 16 B.UP JA141 0.1u/50 R175 C167 0.1u/50 C164 Q164 DTC114EUA NM TP176 TP162 600uH L141 CTH1221-A D141 S1G-6904G2P D142 S1G-6904G2P 3.3V C141 ACC33 3300u/16 CEAT332M16-P35 BUP_1 TP166 GNDD FM(UC):+29.1 dBs AM(UC):+19.1 dBs FM(EW5):+33.1 dBs AM(EW5):+23.1 dBs IP-BUS:+35.3 dBs AUX:+35.3 dBs USB(AUX):+34.0 dBs USB(LS1):+35.2 dBs VCR:+35.3 dBs DVD/CD:+35.2 dBs CHIP SIZE LEGEND 1608 F MOTHER UNIT Consists of MOTHER PCB IF PCB 2125 3216 A 1/4 AVH-P4100DVD/XN/UC 5 E BGSENS GNDD D166 UDZS5R6(B) A 3/4 ILM TP174 GND R169 101 121 141 161 181 201 301 371 B.REM 12 13 GNDD uCOMBUS 11 HZU7L(C3) 10k R172 MA111 GNDV BGSENS D167 UDZ20(B) R179 0.1u/50 10k TP154 GNDD D163 GNDD D161 R161 1u/10 C161 TP164 Q161 DTC114EUA 100k TP179 R180 10k ISENS ISENS MUTE TP167 C162 NM TP161 R164 Q165 2SC4081(QRS) Q372 NM(D) NM (D) R376 NM R373 NM BSENS 0 NM R377 NM Q371 NM R374 R372 R178 ASENS R375 NM R371 0 SYS+B 8.3V R378 4 VCC IN-1 NM 3 OUT1 C371 2 C191 GNDA SYS+B IC202 1 10k 13 0.01u/50 TUNER R181 C165 IP_BUS 5 D181 MA111 12 24 47k 4 8.3V 11 14 OFFMUTE R183 NAVI GUIDE 10 (CCG1236-A) 68k Q182 9 FL+ C189 R186 6 C1 E1 1 Q181 2SC4081(QRS) AV SEL 3 10k R187 82 PA_FR AMPPW SYS+B 7 FL- 8 PA_FL DCH1201-A 10u LS1 2 Q183 5 FR+ 6 UMH1N 1 1 E1 4 GNDA 68k E.VOL INPUT C1 6 GNDA R184 COM BUS 2 B1 3 FR- C193 10u/35 4.7u/10 C102 82 82 R101 C101 4.7u/10 RCA_FR RCA_SWL 4.7u/10 R110 82 C105 C104 RCA_SWR 4.7u/10 82 R107 R114 C107 RCA_RL EXT 4.7u/10 82 R111 C106 4.7u/10 RCA_RR 3/4 GNDA Q101 IMH23 B2 5 C168 Q104 IMH23 1k 3 C2 D183 S1G-6904G2P 2 B2 E2 4 47k B1 5 2 UMD3N R120 R189 2 B2 UMD2N AMP 1 C142 B1 5 4 1E IC181 PA2030A 8.3V 0.1u/50 3 E2 1C 3 SYS+B 14.4V NM C2 4 5 1B C186 4.7u/10 3 E2 BUP_1 6 2C C103 100u/16 C2 4 D101 3 E2 Q103 2B 2 D102 NM Q102 DTA124EUA C2 4 GNDA MA111 2E 1 R105 DAN202U 22k 22k SYSMUTE P101 R103 GNDA GND NM : No Mount Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors. OFFMUTE 22k 22k R118 0 2 R109 GNDA R102 1 R108 Q105 IMH23 A NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. FM(UC): +7.1 dBs AM(UC): -2.9 dBs FM(EW5):+11.1 dBs AM(EW5): +1.1 dBs IP-BUS:+13.3 dBs AUX:+13.3 dBs USB(AUX):+12.0 dBs USB(LS1):+13.2 dBs VCR:+13.3 dBs DVD/CD:+13.2 dBs miniSMDC075F/24 22k 22k 9 SW_L RCA_FL 5 GNDA R113 X 8 SW_R RCA_FR4 REAR_R GNDA X R112 8 RCAGND R117 0 X RCA_RL1 RCA_RR GNDA 3 RCA_SWL JA101 1u/50 2 REAR_L RCA_SWR C111 7 RCAOUT R IN 7 6 7 8 133 1 2 3 4 10.2 MOTHER PCB(TUNER) A A 2/4 MOTHER PCB(TUNER) CHIP SIZE LEGEND FM/AM TUNER UNIT 1608 2125 SYS+B 3216 NM NM C404 C402 R403 NM 8.4V A 1/4 TUN_R Q402 NM NM R404 NM NM R424 Q403 GNDBE RDSLK R406 680 R426 0 R407 680 R427 0 20 R408 680 R428 0 19 R409 R429 D TUNDGND 15 DO 14 ROMVDD 13 OSCGND 12 LDET 11 TUNDI 10 TUNCK ROM_VDD OSCGND LDET DI CK 9 CE1 7 TUNCE2 6 TUNSL CE2 SL 5 VCC 0 GNDRF 1k R411 R432 680 R413 680 R414 680 R415 680 R416 680 TUN8V 0 R433 GNDRF LDET S_TTUN TUNCK 0 TUNCE2 0 TUNSL L402 0 SYS+B MAX.140mA 100u/10 8.4V C408 ANT 1 EW5,UW5 R435 0.01u/16 22u 3.3V T_STUN TUNCE R434 C405 L401 IMSA-6801-01Y901-T 1 P401 2 AM_ANT VDD33 EW5,UW5 1u 3 MAX.8mA 0 4 RF_GND L405 R431 FM_ANT E L404 CTF1379-A NM 680 R412 8 GNDD GNDRF R430 R410 TUNCE1 WC C407 NM DGND L403 TUN33V 3.3V LCTAW1R0J3225 MAX.200mA 22k COMP 16 0 0.01u/16 C403 17 RCK GNDD 22k 680 TUN33 C401 EW5,UW5:CWE2097 UC:CWE2098 18 4 E2 UMH1N R422 RDS_CK VDD_3.3 C2 3 22k RDS_DATA 5 B2 R421 RDS_LOCK C406 GNDBE 10u/6.3 21 RDT 6 C1 22k 68k BEGND RDS_HSLK Q404 B1 2 R420 22 E1 1 EW5,UW5 C409 R425 NM U401 TUNL 23 0.01u/16 24 4 E2 NM NM C2 3 Rch Lch 5 B2 UMH1N C411 TUNR C410 GNDBE FM(100%)(UC):-14.0 dBs AM(30%)(UC):-24.0 dBs FM(100%)(EW5):-10.0 dBs AM(30%)(EW5):-20.0 dBs HSLK 6 C1 R419 R405 NM R423 E1 1 B1 2 C A 3/4 EW5,UW5 NM R402 Q401 NM NM R401 TUN_L GNDBE2 TUNERBUS B ANALOGBUS GNDBE 2 JA402 GNDRF MOTHER UNIT Consists of MOTHER PCB IF PCB F A 2/4 134 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 7 8 A B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 135 136 F 1 2 VDD33 GNDD A 3/4 3 R753 100 100 R755 8 1k 7 6 R754 5 5.1V BUS- STBY DIN1 VCC ROUT BUS+ DIN2 GND IP-BUS DRIVER DD5 IC751 1 2 3 HA12241FP 4 GNDD AVH-P4100DVD/XN/UC 4 66 NC B,D G NC TUNPDI TUNPCK 13 IC601 XRESET 22 XIN RXLS1 113 UC:PEG535A8 EW5,UW5:PEG534A8 24 NMI 109 R623 1k 1k 680 114 R612 115 116 R609 112 NC EVSEL 111 EVSCK EVSDA 110 TUNPCE TUNPCE2 C615 100p/50 (RB551V-30) NM D604 EVSDT EVSCK EVSTB TUNSL MFLPW TUNCE TUNCE2 T_STUN TUNCK S_TTUN RESET M_SRX S_MTX MONIRST ACC33 72 NC 69 NC NC 70 NC 71 NC FLPILM 680 0 680 117 R610 R663 1.5k 118 R608 119 R664 ASENBO DD8 68 NC FLCE TUNSL TUNPDO 120 1k R652 8.1V 67 65 R607 100k NC CLKOUT 122 121 MAINTEST N_B N_G N_R CSYNC1 0 R501 GNDMP 63 62 NC NC 124 123 NM SYSPW AMPPW MONVBS GNDP N_B N_G N_R CSYNC MONVBS GNDD PWRFL MFLPW M_SRX S_MTX MONIRST ILMB ACC33 PWRVI 13.5V 64 NC NC ASENBO 10k R640 SYSMUTE TELMUTE PBSENS BGSENS ISENS PWFL NC NC VCC NC VSS R658 100 R645 R622 WIREDAD WIRED PWVI CLKOUT 60 125 126 127 128 129 130 0 R665 100k R662 R621 0 10k 100k RB501V-40 D603 GND 61 59 58 57 MODEL3 0 MAINTET NC NC SYSPW AMPPW R602 132 131 C607 0.01u/16 133 0 134 135 136 137 138 139 RB751V-40 D602 GNDV R604 17 0.01u/16 CNVSS NC NSD TXNAVI FLEPM RXNAVI RGBON 16 C610 55 MODEL2 56 54 53 VSS SYSMUTE VCC NC TELMUTE PBSENS BGSENS ISENS WIREDAD WIRED 140 TP502 HOMESW PULSE0 GND GNDD GNDV 28 GNDP GNDP NC 18 17 16 GNDD RDSLK NC RDT RCK LDET DELIVERY TO NC L L L L UC NC L L L L EW5 NC H L L L UW5 MODEL0 USBFLG MODEL1 VDC0 MODEL2 AMUTE MODEL3 VDC1 NC HIOUTCLK TSO 23 VCC TESTIN TCK TSI NC BEEP R5F64167DFD-K NC STANDBY MOTPWR VDCONT8 NC NC NC 30 NC(OPENSW) NC 32 TXLS1 NC RXIE TXIE SWVDD33 ILMB MONRST S_MTX M_SRX MFLPWR HDRST GNDSD GNDSD GNDILM 12 11 10 9 8 7 6 5 4 3 2 GNDILM SWVDD33 13 1 PWRVI PWRVI 14 PWRVI GNDP 19 15 NAVI_G GNDRGB 20 NAVI_R NAVI_B 23 21 CCYNC 22 GNDRGB 25 GNDV 24 26 MONVBS GNDD 29 27 30 PWRFL 32 GNDD 33 31 PWRFL NC 34 PWRFL GNDFL 37 NC GNDFL 38 35 GNDFL 39 36 GNDILM 40 GND MOT0 11 10 MOT1 PULSE1 9 8 7 MOT5V 6 5 OPENSW HALFSW 3 3 FLPILM E 52 VDCONT5 100k NC AVSS 141 MOT0 MOT1 PULSE0 PULSE1 MOT5V OPENSW MOTV 2 4 1 CN101 R619 36 RXNAVI 680 VREF MOTV HALFSW HOMESW G TXNAVI 680 NC 680 MOT0 33 MOT1 PULSE0 34 PULSE1 HALFSW 35 NC 680 MODEL1 51 31 100k 100k R625 MS_SRX NC 29 NC VSS RXMON XOUT MONIRST 28 MODEL0 50 R656 27 1u/10 7.8V 49 PULSE1 21 NC(SWVDD) 1k 142 AVSCL MOT0 GNDFL 48 R657 RESET 47 PULSE0 20 46 R670 19 100k R649 D605 NM R661 1k R669 R648 220 GNDD SWVDD GNDD IRQPW MONIRST VDCNT8 TXMON 26 45 STNDBY 25 R650 100k FLBUSY S_MSTX R618 44 MOT1 1000p/50 R647 220 MOT0 R671 0 M_SRX S_MTX 15MHz CSS1776 C612 43 C601 R601 R651 1.8k SYSTEM MICOM FLBUSY 18 FLCLK TP602 42 XRES FLCLK R606 AVSDATA 3 NC GUIDEON 4 NC 5 NC 6 NC 7 NC 8 BSENS 9 ASENS 10 USBCNT C753 0.1u/10 R617 4.7k VSS 4.7k FLRXD 7p/50 14 41 TP603 15 0.01u/16 NM FLRXD 7p/50 4.7u/10 0 100k 12 R756 R654 C613 AVcc C606 4 VSS C752 GNDD MOT1 PULSE0 PULSE1 VD5 1000p/50 USBFLG 11 VCC L601 R667 1k 143 144 R626 40 3.3V 100k FLTXD VDD33 1k 2 39 C602 GND 0 C611 1 AVSCK 2 VDD R605 TP601 100k HOMESW R646 1.8k 38 37 GNDD 33k AVSDA 33k C618 1u/10 R655 R677 C751 1000p/50 FLTXD 100k R668 HOMESW HOMESW HALFSW OPENSW Detailed page 15 AMUTE R751 ASENS NM USBCNT R627 R660 1000p/50 3 NC IC602 S-80827CNNB-B8M HALFSW OPENSW 100k R653 BSENS X601 R659 C605 D 3 2 1 GUIDEON BUS+ BUS- RESET CN801 47 T_RESET 100k R620 MA111 D601 2 R752 VDD33 GNDD1 NM CNVSS C603 10u/6.3 C619 100p/50 CN602 GND 1 R616 NM FLRXD FLCLK FLTXD RESET MOTV 3.3V 2 T_RESET 3 R611 S_J J_S SCLK CNVSS RESET CNVSS 4 NM R615 NM NM R613 R629 2.2u 7 CNVSS S_J 5 1 OUT R614 NM CN601 NM NM Guide page J_S 6 FLBUSY UW5 T_SCLK BUSY VDCNT5 NM IRQPW R628 R674 47k 9 TVON 100k B 10 C604 R641 C Q601 2SC4081(QRS) A-b R675 47k A-a A-b Large size SCH diagram T_BUSY 8 JTAG BUS A-a A-b uCOM BUS A-a POWER BUS TUNER BUS 1 4 10.3 MOTHER PCB(SYSTEM)(GUIDE PAGE) A A-a 3/4 MONITOR UNIT F 1/2 CN5001 CN501 GNDD 3.3V GND RDS57K 108 107 106 105 104 103 102 101 100 99 98 97 FLAPLESS 96 VSS 95 94 VCC 93 92 91 75 0.0 90 89 TP C 88 TP 87 TP 86 85 84 83 TP DDCCLK 82 81 80 NC 79 VSS 78 77 VCC 76 74 73 0 GND 5 6 7 8 A NM NM SYS+B 0 C781 B ANR CSYNC GNDSIG ANG UW5 ANB 8.2k 0.1u/16 5.1k C782 R784 1000p/50 R785 680 C780 0.1u/16 R786 RGB VIDEO ISOLATOR GNDV R798 22k 22k Q771 2SC4081(QRS) R792 1A_OUT R791 2A_-IN D_OUT 14 6p/50 3A_+IN D_-IN 13 NJM2138V MONITOR BUS NM 10u/6.3 R797 10u/6.3 C778 R796 10u/6.3 C777 NM 10u/6.3 10u/6.3 C776 R794 C786 C787 A 3/4 MOTHER PCB(SYSTEM) R795 10u/6.3 22k 22k R789 10u/6.3 C775 R788 R790 22k 22k 10u/6.3 C779 4V+ D_+IN 12 22k 6p/50 22k C772 R778 22k 22k R772 R776 R781 100 100 100 CSYNC1 R780 100 R782 N_R N_G N_B R793 C785 22k 5B_+IN 6p/50 C773 C_+IN 10 R787 6B_-IN R773 9 C774 22k R777 C771 6p/50 R783 22k 22k 22k 22k R779 R771 R775 7B_OUT C_-IN R774 GNDILM GNDSD GNDSD HDRST MFLPWR M_SRX S_MTX MONRST GNDILM 1 2 3 4 5 RESET M_SRX S_MTX C_OUT 8 V- 11 GND GNDD MONIRST IC771 MFLPW 6 ILMB 7 M_SRX SWVDD33 8 9 10 ILMB ACC33 MONIRST S_MTX 11 A-b 3/4 NAVI BUS NAVI_EXT A 1/4 ANALOG BUS LDET LS_R DD5 Q951 2SA1576A(RS) C615 10k 2 5 Vcc INA 3 47k R952 NM 3.3k C802 INB GND 4 R953 OUTY 120 C CN901 8.3V TSI NC BEEP NC NC NC R633 NM R630 NM R631 0 97 96 0 6 E1 5 B1 4 C2 R678 R603 90 1k R907 0 R908 0 GNDA 89 TP604 88 TP605 87 TP606 R639 86 TP607 100k 85 R638 1 84 1k 2 IEC 0 0 SCK PDT R906 0 SDA CPRST C902 VD 28 VD PGND 26 PGND 25 DGND 24 VDD5 23 AMUTE 22 XRES 21 IRQPWR 20 S 19 LS1 18 STANBY 17 AGND 16 ROUT 15 AGND 14 LS1TX SRX LOUT DVD/CD:+5.1 dBs AGND 12 COMPOSIT 11 VGND DGND 9 D- 8 D+ 7 DGND 6 C CN1901 13 D IECOUT 5 DGND 4 SCK 3 SDA 2 CPRST 1 2 DGND 100p/25 82 GND GNDD 80 R642 79 1k BZ601 CPV1062-A R521 1 VDD33 73 100k 72 R676 NM 1 1OE 2 A1 3 A2 A3 A4 6 4OE 0USBD+ 2 B1 B2 B3 B4 GND 0 GND 12 11 10 2 L521 CTF1713-A 5.2V 1u/6.3 C521 GNDD 1 2 EN FLG 4 VIN R5523N001B ACC33 E 1k 100k R563 IPOD CP IC VCC GND PCK 6 9 10 NC3 NC4 NC5 NC6 NC7 VSS 7 8 4 2 0.1u/10 5 Q561 C561 0.1u/10 C563 1 1 E1 IC561 341S2162 NC1 2 B1 C1 6 20 NC13 NC12 NC11 NC10 NC9 19 18 17 NC8 3 C2 B2 5 3 E2 4 10k R570 NM R562 TP561 R561 UMD22N NC2 MODE0/SPI_CLK MODE1/SPI_nSS 3.3V I2C_SCL/SPI_SIMO nRESET DDCCLK GND GNDD I2C_SDA/SPI_SOMI FLPILM USB 5 VOUT GND PRST MONITOR BUS Shield2 4 JTAG BUS PDT Shield1 6 1 3 3 USBFLG DVD&USB BUS D+ USBGND 5 IC521 USBCNT VDCNT5 D- 4 DD5 8 3OE TUNER BUS USB5V 3 9 TC7MBL6126SFK POWER BUS USBGR GNDD 2 13 GNDD uCOM BUS R522 1 0 3 R530 R529 0 2OE 5 7 14 VCC 4 0 USBD- NM 0 VCC R525 R526 D521 EMZC6.8N CN522 USB5V1 0 R532 R624 74 IC522 R524 0.01u/16 C522 75 0.1u/10 4.7k R644 0.1u/10 C564 C609 1u/6.3 NM R523 76 0 C523 VSS NC 69 NC NC 70 NC 71 NC D+ GND R916 83 NC VD 29 10 DGNDV R905 77 68 CTF1387-A PCK PRST 1 L903 L901 NM 78 FLPILM LOUT COMPOSIT CTF1387-A C1 1 C608 91 NC 67 ROUT L902 IMH23 Q901 92 100k E2 3 0.01u/16 R637 93 R643 100k TP608 NC TXIE XRES 0 95 DDCCLK RXIE C901 0.1u/10 C903 C904 NM 220 R910 R913 LS1-SRX R914 STANBY R903 81 NC 220 AMUTE R911 IRQPWR R912 S-LS1TX 98 VCC TCK MS_SRX STNDBY R909 R902 VSS TESTIN 470 99 FLAPLESS TSO 100k UW5 100 NM 101 R632 102 94 HIOUTCLK UMD3N 220 R634 NC 4 E2 220 S_MSTX 100k MODEL3 C2 3 1k IRQPW 103 R635 MODEL2 5 B2 6 C1 XRES 104 100k MODEL1 VD5 105 R636 MODEL0 GNDDDC AMUTE 100k NC GNDDDC 30 27 106 RDS57K NC E1 1 107 RDSLK B1 2 108 B2 2 NC Q902 109 112 NC EVSEL 111 EVSCK EVSDA 110 113 TUNPCE TUNPCE2 5.1V 0.1u/10 1k R623 1k 680 VD5 SYS+B 1k LS1 VD8 8.0V R915 NC 16 11 12 13 14 15 100k NM R568 2125 R567 NM R569 1608 R564 NM MONITOR UNIT USB I/F ipod CP SYSTEM MICOM IP-BUS DRIVER RGB VIDEO ISOLATOR DRIVE UNIT LS1 S/PDIF OUT R566 100 CHIP SIZE LEGEND 501 521 561 601 751 771 801 901 951 R565 100 NC S/PDIF OUT CTF1389-A GNDD INSERTION LED RDT 66 JA951 1 2 3 L951 C952 0.1u/10 1 D951 MALS068X C951 R803 SPDIF IC951 IECOUT R951 TP951 B3 C 2 0 R804 D801 180 C801 NM SMLE12BC7T (RB551V-30) 100p/50 114 R612 115 116 R609 180 R801 R955 10k E 1 TC7SET08FUS1 RCK NC A 1/4 R954 100k DD5_1 GNDD LDET FLCE A 4/4 uCOMBUS VD8 NC TUNPDI TUNPCK NM D604 R802 6 Q801 1 C1 E1 2 5 B1 B2 4 3 E2 C2 UMF5N L952 CTF1379-A NM 10/6R3 FLPILM 5.2V DD5 LED 65 A 2/4 DD5 HIOUTCLK EVSDT EVSCK EVSTB uCOM BUS R607 TUNERBUS POWERBUS POWER BUS VDCNT5 RCK RDT HSLK RDSLK MFLPW TUNCE T_STUN TUNCE2 TUNER BUS LS_L LS_V ANALOGBUS 3216 F GND MOTHER UNIT Consists of MOTHER PCB IF PCB AVH-P4100DVD/XN/UC 5 6 7 8 A 3/4 137 M_SRX 7 MFLPWR 6 MFLPW GNDSD HDRST 5 VSS FLAPLESS NC MODEL3 MODEL2 MODEL1 MODEL0 NC NC NC LDET RCK RDT RDS57K RDSLK NC GNDSD 4 RESET GNDILM 3 NJM2138V LED 180 180 6 Q801 1 E1 C1 2 5 B1 B2 4 3 E2 C2 UMF5N 10u/6.3 10u/6.3 C777 C778 DD5 DD5 92 93 94 95 96 97 98 99 100 101 102 103 104 C608 0.01u/16 100k R643 R678 C780 UW5 STNDBY MS_SRX S_MSTX IRQPW XRES INSERTION LED GNDD R801 R802 uCOM BUS POWER BUS TUNER BUS ANALOG BUS RGB VIDEO ISOLATOR 1A_OUT 10u/6.3 C776 105 UW5 GNDV D_OUT 14 2A_-IN D_-IN 13 10u/6.3 10u/6.3 C786 C787 10u/6.3 AMUTE TP608 100 R793 3A_+IN D_+IN 12 4V+ C_+IN 10 V- 11 5B_+IN 22k R788 10u/6.3 10u/6.3 C775 106 107 108 CSYNC1 MONITOR BUS R780 100 N_B 6B_-IN C773 9 6p/50 22k R774 C_-IN R787 C774 S_MTX 8 S_MTX p 1k R781 100 N_G S_MTX M_SRX TUNCE 1k M_SRX MFLPW D604 R789 R792 GNDILM EVSTB 22k 6p/50 2 NM 22k 22k 1 GND 100k 100k EVSCK 22k R632 R636 (RB551V-30) 22k R775 R779 NM EVSDT 22k 22k 22k R771 22k NM 100k GNDD RCK R631 R635 109 R783 22k 22k RDT 100 R782 N_R R777 R776 HSLK R790 R791 C779 Q771 2SC4081(QRS) 0.1u/16 7B_OUT HIOUTCLK R772 RDSLK IC771 D801 R794 R784 C_OUT 8 SMLE12BC7T A-a A-b 8.2k R786 0 R798 SYS+B NM 0 IECOUT R951 NM C781 22k R773 FLPILM 22k 100k R623 R803 R804 R796 LS_R C785 C802 R778 LDET R630 TUNPCE2 113 TUNPCE 112 NC EVSEL 111 EVSCK EVSDA 110 10k 3.3k R785 680 NM R795 1000p/50 LS_V NM LS_L NM 5.1k C782 VDCNT5 R797 0.1u/16 A-b 3/4 R952 C771 6p/50 R634 GNDSIG 3 2 1 CSYNC OUTY Vcc 1k R915 8.3V 120 4 R953 5 L952 CTF1379-A Q951 2SA1576A(RS) 5.2V DD5 GNDD 0 R903 0 R902 0 1 2 3 XRES AMUTE GNDDDC LOUT ROUT D CTF1387-A L903 COMPOSIT R913 LS1-SRX R914 STANBY VD5 VD8 VD PGND 28 27 DGND XRES AMUTE VDD5 AGND 10 11 DGND VGND C CN1901 DVD/CD:+5.1 dBs 12 COMPOSIT 13 LOUT AGND 15 14 ROUT AGND 16 17 LS1 S/PDIF OUT SRX LS1TX 18 STANBY 19 LS1 20 S 21 IRQPWR 22 23 24 25 PGND VD 26 VD 29 JA951 A 1/4 A 4/4 A 2/4 A 1/4 30 CN901 TP951 R911 IRQPWR R912 S-LS1TX R910 8.0V VD8 R909 CTF1387-A R907 R955 10k uCOMBUS SPDIF CTF1389-A L951 B3 L902 220 220 220 220 1k 470 C2 E 1 R954 100k POWERBUS TUNERBUS ANALOGBUS NAVI_EXT A 3/4 MOTHER PCB(SYSTEM) GNDDDC 5.1V VD5 DD5_1 NAVI BUS SYS+B TC7SET08FUS1 GND INA INB IC951 6 C1 Q902 6p/50 NM 100k ANB E1 1 4 C2 C801 NM ANG 5 B2 B1 2 5 B1 4 E2 22k C772 R633 4 R637 3 47k IMH23 Q901 ANR UMD3N 3 C2 3 AVH-P4100DVD/XN/UC 6 E1 2 NM 10/6R3 1 C904 NM 138 C952 0.1u/10 F 0.1u/10 E C903 D C901 C D951 MALS068X C951 B 2 0.1u/10 1 4 A FLPILM FLPILM 68 NC MODEL3 MODEL2 TXIE VCC RXIE VSS NC NC NC DDCCLK NC NC NC NC BEEP NC TESTIN TSI TCK TSO VCC HIOUTCLK VSS 1k 1k 79 73 GNDD 0.01u/16 75 74 C609 76 77 78 R642 80 81 82 83 R638 84 4.7k R644 1k R676 NM 0 R678 R624 100k TP607 85 R639 TP606 0 R603 100k R643 86 TP605 TP604 C608 0.01u/16 TP608 87 88 89 90 91 92 93 94 95 96 97 98 99 A-b 3/4 69 NC FLAPLESS 70 NC NC NC NC NC 71 R630 R634 NM 100k NM 100k R632 R636 2 BZ601 CPV1062-A 2 501 521 561 601 751 771 801 901 951 MONITOR UNIT USB I/F ipod CP SYSTEM MICOM IP-BUS DRIVER RGB VIDEO ISOLATOR DRIVE UNIT LS1 S/PDIF OUT MONITOR BUS DVD&USB BUS TUNER BUS POWER BUS uCOM BUS JTAG BUS R631 R635 GNDD NM 100k 1 R633 R637 1 3216 2125 1608 CHIP SIZE LEGEND VDCNT5 PDT PCK NM R561 GNDD 3 C2 2 B1 1 E1 E2 4 B2 5 C1 6 Q561 UMD22N ACC33 3.3V PRST USBFLG USBCNT PRST PDT PCK IC522 GND 4OE A4 A3 A2 A1 1OE 3OE B4 B3 B2 B1 2OE VCC A-a A-b GND TP561 TC7MBL6126SFK 7 6 5 4 3 2 1 0.1u/10 C523 8 9 10 11 12 13 14 5.2V DD5 VDD33 GNDA 3 2 1 FLG GND EN VIN VOUT IC521 L521 CTF1713-A 10 9 8 7 6 0.1u/10 0.1u/10 C563 C561 NC3 NC4 NC5 NC6 NC7 R5523N001B 3 2 4 C2 E2 3 MODEL1 72 100k 100k DDCCLK 5 B1 B2 2 MODEL0 C521 10k STNDBY R570 6 E1 C1 1 IMH23 Q901 1u/6.3 4 5 4 1 0 R524 C522 UW5 0 NC13 NC12 NC11 NC10 NC9 11 12 13 14 15 R565 100 100 VSS 100k 2 R566 100 2 0 R903 0 R902 0 R908 GND 0 0 0 16 17 18 19 20 IC561 341S2162 GND L903 GNDD GNDD GND USBGR 0 0USBD+ R526 R522 0 USBD- R525 USB5V1 0 GND R521 CPRST SDA IEC GND D+ D- CTF1387-A GNDV SCK D521 EMZC6.8N 100p/25 C902 R906 R905 R916 L901 NM 0 R907 LOUT ROUT COMPOSIT R914 STANBY CTF1387-A L902 220 IPOD CP IC R532 101 R564 NM R563 5 VCC 1k 4 I2C_SCL/SPI_SIMO nRESET 0.1u/10 C564 R562 3 I2C_SDA/SPI_SOMI NC2 MODE0/SPI_CLK MODE1/SPI_nSS R529 0 R530 NM 1u/6.3 NM R523 1 NC1 R567 NM R569 NC NM 7 R568 6 NC8 1 3 5 AGND AGND DGND USBGND Shield1 Shield2 5 6 D+ D- USB5V 4 3 2 CN522 DGND 1 CPRST 1 SDA 2 3 SCK 5 4 6 DGND D+ D- DGND VGND IECOUT 7 8 9 10 11 CN1901 C USB MOTHER UNIT Consists of MOTHER PCB IF PCB DVD/CD:+5.1 dBs 12 COMPOSIT 13 LOUT 15 14 16 AGND ROUT 17 18 STANBY 19 6 100k 5 7 8 AVH-P4100DVD/XN/UC 8 139 A B C D E F 140 1 2 3 4 AVH-P4100DVD/XN/UC A-a 3/4 F XRES AMUTE USBFLG USBCNT TUNER BUS E POWER BUS uCOM BUS ASENS BSENS GUIDEON AVSDA TVON CNVSS R674 47k UW5 R675 47k R641 GNDD Q601 2SC4081(QRS) 100k RESET 4.7k 2 3 MOTV HALFSW HOMESW C618 1u/10 VD5 4 VSS OPENSW PULSE1 6 MOT5V 5 PULSE0 NM 100k 100k R617 4.7k 17 16 14 13 12 11 CNVSS NSD VDC1 AMUTE VDC0 USBFLG AVSDATA 3 NC GUIDEON 4 NC 5 NC 6 NC 7 NC 8 BSENS 9 ASENS 10 USBCNT 2 1 TP603 15 4.7u/10 C613 R667 1k 0 R626 GNDFL GND GNDFL 39 GNDILM 40 D605 NM 7.8V PWFL PWRFL 35 NC 36 H L L MODEL0 GNDD GNDD 31 NC 32 L L L GNDV MODEL1 GNDV L L L MODEL2 24 GNDRGB 25 GNDV 26 NAVI_R NAVI_G UW5 EW5 UC 3.3V DD8 8.1V ACC33 13.5V PWVI DELIVERY TO IC601 L L L MODEL3 GNDMP GNDP 19 GNDRGB 20 NC 16 SWVDD33 ILMB MONRST S_MTX M_SRX VSS FLAPLESS NC MODEL3 MODEL2 MODEL1 MODEL0 NC NC NC LDET RCK NC RDT RDS57K RDSLK GNDD 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 GND A-b 3/4 3 100k R654 100k R668 R660 R659 R646 1.8k GND CN501 SYSTEM MICOM MOT1 GND 10 GNDFL 38 PWRFL 34 GNDD 30 MONVBS CCYNC 23 NAVI_B GNDP 18 PWRVI 15 PWRVI SWVDD33 12 F 1/2 CN5001 CSYNC N_R 22 GNDP 17 PWRVI 14 13 11 7 MONITOR UNIT N_R PWRVI G MOT5V MONVBS N_G N_B N_G MAINTEST GNDP TUNSL S_TTUN S_MTX MOT0 GND 11 GNDFL 37 PWRFL 33 GNDD 29 28 27 0 SYSMUTE 680 R608 TUNCK 10 ILMB 9 MONIRST TUNCE2 8 S_MTX M_SRX 6 RESET MFLPWR GNDILM 1 GNDILM 2 GNDSD 3 GNDSD 4 HDRST 5 2 R677 CN602 1 MOTV HALFSW HOMESW 4 OPENSW TP502 RB501V-40 D603 PWRFL WIREDAD ISENS PBSENS GNDD TELMUTE R501 MONVBS 0 CSYNC1 AMPPW SYSPW 680 R610 ACC33 T_STUN C615 MONIRST 100p/50 TUNCE 1k M_SRX MFLPW MFLPW EVSTB EVSCK CN101 3 NC IC602 S-80827CNNB-B8M 2 VDD 1 OUT MOTV CN801 100k R620 HALFSW MA111 D601 HOMESW OPENSW PULSE1 PULSE1 PULSE0 8 MOT1 MOT0 9 MOT0 AVSCL C606 1u/10 RB751V-40 D602 WIRED 100k R662 R621 0 10k R622 BGSENS R665 100k C607 0.01u/16 R602 R645 10k R658 100 NM 1.5k R664 680 R609 21 N_B R640 ASENBO 1k R652 0 R663 1k R612 R623 D604 NM (RB551V-30) EVSDT A-a A-b 1 2 3 R651 7 PULSE0 MOT1 1.8k 144 AVSCK 143 AVcc 142 VREF 141 NC 140 AVSS 139 WIRED 138 WIREDAD 137 ISENS 136 BGSENS 135 PBSENS 134 TELMUTE 133 NC 132 VCC 131 SYSMUTE 130 VSS 129 AMPPW 128 SYSPW 127 NC 126 NC 125 MAINTET 124 NC 123 ASENBO 122 NC 121 NC 120 NC 119 TUNSL 118 TUNPDO 117 TUNPCK 116 TUNPDI 115 NC 114 TUNPCE2 113 TUNPCE 112 NC EVSEL 111 EVSCK EVSDA 110 109 D C B A 1 4 S_MSTX MS_SRX STNDBY VDCNT8 VDCNT5 PULSE1 PULSE0 MOT1 MOT0 RESET GNDD 2.2u L601 3.3V VDD33 C604 CN601 NM TP602 NM 10 IRQPW FLCLK XRES C603 10u/6.3 SCLK AVH-P4100DVD/XN/UC 8 A-a A-b 7p/50 C601 7p/50 C602 3 VDD33 GNDD TP601 4.7k X601 680 680 680 R670 R657 R656 GNDD 680 R671 15MHz CSS1776 1k R606 0 R601 C605 BUS- NM 36 FLRXD VSS 100 R753 100 R754 1k R755 5.1V DD5 L L L L L L UW5 EW5 UC IC601 L L L GND DIN2 ROUT HA12241FP BUS- BUS+ VCC DIN1 IC751 STBY 4 3 2 1 B,D G R5F64167DFD-K UC:PEG535A8 EW5,UW5:PEG534A8 H GNDD 5 6 7 8 IP-BUS DRIVER R627 R677 HALFSW CN602 VCC L RXMON 100k 33k NC(SWVDD) R654 42 10 USBCNT 11 USBFLG C613 12 VDC0 13 4.7u/10 AMUTE 14 VDC1 TP603 15 NSD 16 R617 4.7k CNVSS 17 XRESET 18 IRQPW 19 C612 RESET 20 XOUT 1000p/50 21 VSS 22 XIN 23 VCC R618 24 NMI 25 100k VDCONT5 26 VDCONT8 27 R669 STANDBY 1k 28 MOTPWR 29 R649 RXLS1 30 NC(OPENSW) 100k 31 GNDD TXLS1 32 MOT0 33 MOT1 PULSE0 34 PULSE1 HALFSW 35 R667 1k FLCLK FLCLK MONIRST L NC ASENS FLBUSY 43 FLBUSY NC 48 R661 1k BSENS NC 100k R668 49 CNVSS FLBUSY BUSY 9 NM T_SCLK 7 NM T_BUSY 8 NC AMUTE FLRXD R628 FLTXD R613 S_J NM CNVSS NM J_S 6 NM S_J 5 R615 J_S C619 100p/50 CNVSS R629 T_RESET NM R611 CNVSS 4 51 USBFLG RESET R616 50 NC RGBON 1 R614 NM T_RESET 3 53 USBCNT 3.3V 2 RXNAVI RXNAVI FLEPM 54 TXNAVI 55 100k R619 9 56 8 R751 VSS 57 C610 2 VDD33 GNDD1 GND 1 HOMESW R752 1000p/50 100k R653 BUS+ FLTXD 15 47 NC 58 0.01u/16 NC 100k VCC 59 R604 NC 61 CLKOUT 62 100k TXIE VCC RXIE VSS NC NC NC DDCCLK NC NC NC NC BEEP NC TESTIN TSI TCK TSO VCC HIOUTCLK VSS FLAPLESS NC MODEL3 MODEL2 MODEL1 MODEL0 NC NC G A-b 3/4 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 7 C751 1000p/50 NM OPENSW 37 R655 HOMESW 39 C611 R605 38 33k FLTXD 40 0 FLRXD 41 0.01u/16 0 R756 C752 7 1000p/50 6 C753 0.1u/10 NC 60 0 TXMON 44 R647 220 S_MTX 45 R650 M_SRX 46 R648 220 SWVDD 47 100k MONIRST 52 100k R625 6 TXNAVI 63 CLKOUT NC 64 FLCE 65 R607 FLPILM 67 R660 68 NC 66 100k JTAG BUS R659 69 ASENS 70 NC NC NC NC NC 71 BSENS 72 5 FLPILM 5 8 A-a 3/4 141 A B C D E F NC 1 2 3 4 10.4 MOTHER PCB(POWER SUPPLY) A CHIP SIZE LEGEND 1001 1021 1061 1081 1121 1201 1608 2125 3216 VDD33V PWVI,PWFL SYS+B TUN3.3V HIOUT12V DDC 1341 1381 1401 1421 1500 MOTV MOT5V ACC33V SWVDD33V VD5 ACC33V B DD5 ACC33 3.3V NM VOUT 2 5.1V D1401 RB551V-30 3 C1403 NC ON/OFF S-1112B33MC-L6S 0.47u/10 NM C1402 C1401 NM R1401 4 4.8V 1 VIN VSS NM R1421 NM C1421 5 1 E1 2 B1 3 C2 R1422 6 Q1422 C1 5 B2 4 E2 NM SWVDD(NC) IC1401 TP1401 1u/10 NM GNDD GNDD C HIOUT12V SYSPW EV12 12.2V R1127 B1 2 5 B2 VD5 5.1V > CTH P1202 1 2 CEK1280-A (1.0A) 6 C1 C1500 GND 1000p/50 Q1121 C1227 0 1u/10 C1226 10u/35 E1 1 D1122 4 NM 3 4 E2 0 R1154 0 R1152 Vcc C1147 SCP BR/CTL C2 3 NM NM Out GNDHI 270p/25 (D) (D) R1144 910 370kHz/416kHz HIOUTCLK GND TK11840L R1147 5.1k DTC143EUA Q1143 OSC 2 C1129 R1148 0 R1145 5.1k 5 R1149 NM CCG1222-A 4.7u CCG1222-A 4.7u 11k C1145 R1150 6 TP1142 S EaIn C1142 0.1u/16 7 0.1u/16 FB NM 1 620 8 R1151 300k R1146 C1146 0.01u/16 R1141 680 NM C1143 C1148 G NM D1141 HZU13(B1) C1149 C1141 D R1128 NM IC1141 Q1142 RSF014N03 NM Q1122 R1153 47uH NM L1141 ATH7061-A NM C1128 D1142 RB551V-30 0.1u/16 D 14.1V GNDDD C1144 TP1141 2SC4081(QRS) Q1141 GNDHI VDCNT5 E VDCNT8 P1203 > AVH-P4100DVD/XN/UC 2 C1228 0.1u/10 C1229 10u/35 1000p/50 220 1 2 CEK1285-A (2.5A) GND 1 CTH1358-A-T L1209 NM TP1207 C1343 0.1u/16 D1341 HZU6R8(B2) DD8 8.1V GNDDDC A 4/4 142 VD8 C1344 C1341 100uF/16V CCH1477-A NM R1381 NM NM D1381 C1383 NM NM C1382 C1381 F 1u/10 C1342 Q1381 NM NM R1343 Q1341 2SD2153(VW) MOT5V L1381 > NM MOTV P1341 1 2 CEK1282-A (1.5A) R1382 MOT5V & MOTV 3 4 5 6 7 8 A 4/4 MOTHER PCB(POWER SUPPLY) A A 3/4 SYSPW DDCCLK MFLPW POWERBUS BUP_1 SIDE_A TP1003 Q1021 2SC4081(QRS) R1027 10k R1023 10k 270 R1001 2.2 0.1u/50 C1007 UDZS18(B) D1001 2.2 R1004 2.2 R1006 2.2 R1007 390 R1003 C1006 0.01u/16 0.01u/50 0 R1024 NM PWVI PWVI UW5 13.5V L1021 DTL1100-A > P1021 1 2 CEK1280-A (1.0A) D1021 S1G-6904G2P (22uH) 100u/16 10k R1026 R1022 330 > C1021 R1021 330 1 2 CEK1283-A (1.75A) C1025 22u/16 0.1u/50 C1024 1000u/16 C1022 100uH B 8.1V TP1021 P1022 S1G-6904G2P 2SD1664(PQR) D1002 Q1001 C1005 1000u/16 CEAT102M16-P30 R1025 Q1022 2SB1132(QRS) TP1002 DD8 GNDD L1022 CTH1262-A 3 Vout 1 GND 2 Vin NM C1002 C1003 47u/6.3 C1001 PWFL 7.8V C1023 4.7u/16 PWFL VDD33V S-812C33AUA-C2N Q1002 2SB1132(RS) IC1001 TP1001 R1005 VDD33 3.3V GNDFL IC1081 C GNDMP 0 R1081 CONTROL R1201 4700u/16 R1218 150p/50 82k (D) C1222 8.10V E 33 R1214 100p/50 1k (D) R1217 1k C1218 R1215 0 R1224 9.1k (D) R1216 C1221 150p/50 R1213 0.01u/16 C1219 30k 0.068u/50 GNDDDC C1217 36 35 R1212 2.2 C1220 3.3u/10 SYNC N.C.14 N.C.15 RT (15uH) TP1206 L1207 CTH1253-A C1201 NM NM C1224 C1225 NM C1203 330u/16 (ZL) NM 1.0u/35 C1230 C1213 CCG1223-A 8 D1-1 7 D1-2 6 D2-1 5 D2-2 D1204 C1214 CCG1223-A Q1202 HAT2210RJ-TBB CTF1661-A L1206 1 S1 2 G1 R1211 10(D) 3 S2 4 G2 C1223 3 4 47k 1 2 3 4 CL2 BOOT2 OUTH2 N.C.1 5 32 33 1k N.C.13 N.C.12 31 GND 82k NM C1235 R1202 26 0 N.C.9 EN1 EN2 25 0 R1220 D (15uH) GNDDDC 370kHz/416kHz C1228 0.1u/10 NM 30 COMP1 SS1 N.C.8 N.C.11 FB1 34 6 N.C.2 VCCCL2 7 N.C.7 TP1202 C1234 VCC VCCCL1 8 10 9 N.C.3 N.C.6 R1219 C1231 IC1201 BD9013KV N.C.5 0.01u/16 0.068u/50 11 VREG5A 24 CTH1253-A 48 47 SW2 DGND2 46 OUTL2 45 N.C.19 44 VREG5 43 N.C.18 42 N.C.17 41 EXTVCC 40 N.C.16 39 FB2 COMP2 38 SS2 37 N.C.4 29 30k 23 SW1 DGND1 OUTL1 C1215 0.033u/25 R1226 TP1205 L1204 L1205 CTF1661-A 10k N.C.10 47k (D) 6.8k (D) C1208 22 D1206 RB551V-30 28 18 21 8V C1229 10u/35 17 19 150p/50 C1209 R1209 CTH1358-A-T L1209 NM 16 20 10k (D) C1207 R1208 DD8 7 15 2.2 3.3u/10 R1205 0 150 330p/50 R1207 R1206 5.10V R1203 C1210 12 C1211 0.033u/25 13 D1205 RB551V-30 OUTH1 BOOT1 CL1 L1203 CTF1661-A 10(D) 14 R1204 NM R1225 10k R1210 TP1203 (106/50) C1232 NM (106/50) C1212 1.0u/35 C1233 D1203 C1216 CCG1223-A D2-2 5 D2-1 6 D1-2 7 D1-1 8 2 G2 4 S2 3 G1 2 S1 1 Q1201 HAT2210RJ-TBB 330u/16 C1202 (ZL) NM NM C1205 C1206 NM C1204 C1227 0.1u/10 C1226 10u/35 GNDDDC > P1201 CEK1344-A 1 2 LAYCHEM 4.0A 3 DDC L1202 CTF1661-A (15uH) NM 1 27 L1201 CTH1253-A 5.1V NM NM CTH1358-A-T L1208 P1202 1 2 CEK1280-A (1.0A) 1 GNDRF GNDBE GNDD TP1201 RSX201L-30 D1202 F1201 GNDD > VOUT VIN NM NM R1061 NM C1088 C1061 C1087 RSX201L-30 D1201 8.3V 100u/10 C1085 C1081 4.7u/10 C1084 0.01u/16 22u/16 C1083 C1082 SYS+B NM C1086 TUN3.3V 1V SYS+B NM GND R1082 2 D1081 S1G-6904G2P 1.0u/35 NC VOUT GND SYS+B IC1061 NJM2388F84 5 4 2 1 3.3V 3 TUN33V VIN CONT NJM2886DL3-33 GNDDDC F The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. MOTHER UNIT Consists of MOTHER PCB IF PCB A 4/4 AVH-P4100DVD/XN/UC 5 6 7 8 143 1 2 3 4 10.5 IF PCB A CHIP SIZE LEGEND 1608 2125 3216 CN2002 BUSBUS+ B ASENBO BUSR+ BUSRGND BUSL+ BUSLAUXL 1 2 3 4 5 6 7 8 9 AUAGND 10 AUXR 11 MAINTEST 12 AUVGND 13 AUXV 14 BCAM_IN 15 C BCAM_VGGND 16 GNDV 17 GNDD 18 A 1/4 WIREDAD 19 WIRED 20 CN121 NC 21 ANR 22 GNDSIG 23 GNDD ANG 24 GNDV CN2001 GND R2004 TP2015 GNDSIG 25 R2006 ANB 26 TP2017 75 R2001 CSYNC 28 D 75 R2007 GNDSIG 27 TP2016 R2003 75 TP2018 0 GNDSIG 29 TP2019 CCR 1 CCG 2 CCB 3 CCSYNC 4 5 75 CCAUL 30 6 CCAUR 31 7 GNDAU 32 8 R2008 ONSEI+ 33 ONSEI- 34 TP2030 10 NM NC 35 11 TP2020 TVON 36 TP2022 SYS_TO_NAVI 38 NAVI_TO_SYS 39 E 40 R2002 TP2023 NM D2004 D2005 GNDD B 144 GND 1k R2005 470 R2009 470 TP2024 TP2025 TP2026 MALS068X F D2006 D2001 R2010 GNDD AVH-P4100DVD/XN/UC 1 2 3 4 DVDVBS GNDDVD YS NC CCAUL CCAUR 12 GNDAU 13 ONSEI+ 14 ONSEI- 15 REAUR 16 REAUL 17 GNDRAU 18 CCREM 19 DSEN 20 TVON 21 GION 22 MONON 23 VSW5 24 SYS_TO_NAVI 25 NAVI_TO_SYS 26 GNDD TP2021 GUIDEON 37 GNDD 9 GNDSIG 5 6 7 8 A LEGEND B IF PCB IP BUS JA2004 BUS+ A D2002 C2002 C MALS068X 0.1u/50 TP2029 R2019 A D2007 C BUS- 1k BUSG MALS068X BUSL+ ASENB BUSR+ BUSR- GND 1 BUS+ 2 BUSG 3 BUSLG 4 MAINTEST 5 BUS- 6 BUSRG 7 BUSL+ 8 ASENBO 9 BUSR+ 10 BUSR- 11 BUSL- B IP-BUS:+2.2 dBs C BUSL- R2013 R2014 22k R2021 R2017 R2015 75 0 0 AUR 4 3 2 AUG 1 0 0 R2016 CCR AUX:+2.2 dBs AUL R2020 22k JA2002 4 3 2 1 AUXL AUXR GND VIDEO MINI JACK R2022 AUV C2004 D2011 GNDSIG D2003 CCSYNC C2003 D2012 CCB MALS068X 0.1u/50 MALS068X MALS068X 0.1u/50 CCG D DVDVBS B.CAMERA INPUT GNDDVD GND YS BCAM 2 R2018 NC B.CAM_IN BCVG JA2003 CCAUL 1 75 GNDAU ONSEIREAUR NAVI I/F WIRED REMOTE GND TP2002 UW5 R2012 REAUL R2011 TP2001 1k 2 3 1 1k MALS068X D2010 GNDRAU CCREM DSEN BCV_GND C2005 WIREDAD WIRED GNDD JA2001 E D2009 ONSEI+ 0.1u/50 C2001 CCAUR TVON 0.1u/50 GION GNDD GND GNDD GND MONON VSW5 SYS_TO_NAVI NAVI_TO_SYS GNDD F MOTHER UNIT Consists of MOTHER PCB IF PCB B AVH-P4100DVD/XN/UC 5 6 7 8 145 1 2 3 4 10.6 DVD CORE UNIT(GUIDE PAGE) 12P 10P TD FD COMPOSITE 68P 100P C1604 200 R1672 12K C1606 44 11 C1602 DACCK SRCK LRCK IEC ADOUT T R1602 R1670 12K 68P C1605 NM 100P NM R1675 NM R1679 33 2 2 C1603 R1956 0R0 L1901 NM R1673 R1671 10K C1674 R1 24K R1603 C1601 10K R01 FE1 TEMP FE2 TEMP 1 C1676 R1 C1672 R1 C1671 240 240 R1951 R1950 30K 100 R1507 R1674 100 R1506 R1 GNDD5 C1515 R1 R1 C1511 AD2 C1514 MDQ0 MDQ15 MDQ1 MDQ14 GNDD (1608) 100 GNDA 1M (2125) C1502 10 15K GNDD 0R0 1R2K GNDD GNDD R1503 VCC12 B 2 R1508 220 C1512 R1601 GNDV C1673 GND R1501 R1 C1809 NM C1807 R1 C1805 GNDAU D- R1957 0R0 IECOUT GND1 X1 C1510 (IEC/IPFLG) 1 AUDIO 2CH ANALOG OUT F R1954 R1 R1504 12 8 820 27.000MHz CSS1768 X1501 4 X2 3 GND2 R1505 R1804 4 R7 (2125) D1901 NM NM D1902 15K R1955 R1511 IC1801 PCM1753DBQ C1804 1800P 100K R1802 C1 8 0 2 LTDAC C1808 NM LOUT AGND 9 VOUTR 10 7 VOUTL VCOM 6 ZEROR/ZEROA 11 VCC 5 ZEROL/NA 12 NC 13 SDODAC 4 DGND MD 14 SCKDAC 3 LRCK MC 2 15 LTDAC DATA ML 16 1 BCK SCK 10 C1806 SCKDAC ADAC GNDAU1 GNDAU SDODAC AVCC5 820 C1803 R1803 4R7 1800P (2125) C1801 R1801 100K ROUT D+ C-a A GNDD GNDA 162 163 164 MDQ2 165 C1504 166 R1 167 MDQ12 STANDBY VCC33 L1904 MDQ3 168 MDQ11 169 MDQ4 170 MDQ10 171 172 173 10 (2125) C1489 R001 C1490 MDQ5 C1505 174 R1 175 MDQ9 IC1480 MDQ0 R1490 C1480 R1 56 R1480 56 C1481 R1 C1494 NM MDQ1 MDQ2 5 4 MDQ3 6 3 7 2 MDQ4 1 8 C R1481 56 C1482 MDQ5 5 4 MDQ6 6 3 MDQ7 7 R1 C1493 NM 2 1 8 C1483 NM C1484 R1 DQM0 XWE 5 4 XCAS 6 3 XRAS 7 2 XCSM 8 1 BA0 5 4 BA1 6 3 MA10 7 2 MA0 8 1 MA1 5 4 MA2 6 MA3 7 2 8 1 R1482 56 R1483 56 R1484 56 3 C1485 1 54 VDD1 VSS3 2 DQ0 DQ15 3 VDDQ1 VSSQ4 4 DQ1 DQ14 5 DQ2 DQ13 6 VSSQ1 VDDQ4 7 DQ3 DQ12 8 DQ4 DQ11 9 VDDQ2 VSSQ3 10 DQ5 DQ10 11 DQ6 DQ9 12 VSSQ2 VDDQ3 13 DQ7 DQ8 14 VDD2 VSS2 15 LDQM N.C/RFU 16 WE UDQM 17 CLK CAS 18 CKE RAS 19 N.C CS 20 A11 BA0 21 A9 BA1 22 A8 A10/AP 23 A7 A0 24 A6 A1 25 A5 A2 26 A4 A3 27 VDD3 VSS1 R1 C1486 GNDD R1485 56 53 MDQ15 52 51 50 R1 49 C1488 48 C1491 NM 5 4 6 3 7 2 8 1 R1486 56 46 45 44 R1 C1487 42 MDQ8 177 MDQ7 178 DQM0 179 DQM1 180 XWE 181 182 C1506 MDQ12 5 4 6 3 7 2 8 1 NM C1492 MDQ13 176 R1512 47 43 MDQ14 MDQ6 184 185 C1503 R1 MDQ9 187 188 XCAS 189 XRAS R1489 56 190 R1538 XCSM 40 191 39 100K MA11 38 MCK 37 36 192 BA0 193 MA9 194 DQM1 56 R1487 35 34 33 32 56 R1488 31 5 4 6 3 7 2 8 1 5 4 3 30 6 29 7 2 28 8 1 195 MA11 MA9 C1507 196 R1 197 BA1 MA8 MA8 198 MA7 MA10 199 MA6 MA7 200 MA5 MA0 201 MA6 202 MA1 203 MA4 204 K4S641632N-LC75 C1508 205 R1 206 DGND3 SDRAM NM 100 186 MDQ10 MDQ8 41 183 R1 MCK MDQ11 L1512 MA5 GNDD MA2 207 MA4 208 MA3 209 D 210 C1509 211 R1 212 213 214 215 MDQ12 MDQ3 MDQ11 MDQ4 MDQ10 MDQ5 VSS_12 VDD33_8 MDQ9 MDQ6 MDQ8 MDQ7 DQM0 DQM1 NWE VSS_13 MCK VDD33_9 MCKI VSS_14 VDD12_5 IC1501 MN2DS0018MAUB NCAS NRAS NCSM STANDBY DQM3 BA0 MA9 VSS_15 VDD33_10 BA1 MA8 MA10 MA7 MA0 MA6 MA1 VSS_16 VDD33_11 MA5 MA2 MA4 MA3 VSS_17 VDD12_6 EXADT0 NEXCE NEXOE EXDT0 EXDT8 1 2 D1 D9 216 DEBUG T MDQ13 MDQ2 VSS_11 VDD33_7 EXDT1 3 EXDT9 EXDT2 4 EXDT10 5 VSS_1 6 VDD33_1 7 EXDT3 8 EXDT11 9 EXDT4 10 EXDT12 11 EXDT5 12 EXDT13 13 EXDT6 14 EXDT14 15 VSS_2 16 VDD33_2 17 EXDT7 18 EXDT15 19 VSS_3 20 VDD12_1 21 EXADR16 22 EXADT15 23 EXADT14 24 EXADT13 25 EXADT12 26 EXADT11 27 EXADT10 28 EXADT9 29 EXADT8 30 EXADR19 31 NEXWE 32 VSS_4 33 VDD33_3 34 EXADR18 35 EXADR17 36 EXADT7 37 EXADT6 38 EXADT5 39 EXADT4 40 EXADT3 41 EXADT2 42 EXADT1 43 VSS_5 44 VDD12_2 45 CP_READY 46 I2C_SDA 47 I2C_SCL 48 IRQPWR 49 08EJ 50 USB CLOCK (2125) C1501 10 MDQ13 GNDD 161 MDQ1 MDQ14 160 MDQ0 159 MDQ15 158 VDD12_4 157 VSS_10 156 OSCO 155 OSCI 154 VDD33_6 153 VSS_9 152 IECOUT 151 ADOUT 150 LRCK 149 SRCK 148 DACCK 147 AVDDI 146 ROUT 145 AVSSI 144 LOUT 143 AVSSG 142 AVDDG 141 AVDDE 140 AVSSE 139 DAC5OUT 138 COMPOSITE 137 AVSSF 136 COMP2 135 IREF1 134 VREF 133 COMP1 132 AVDDF 131 DAC1OUT 130 DAC2OUT 129 DAC3OUT 128 AVDDH 127 FD 126 TD 125 AVSSH 124 AD4 123 AD2 122 TEMP 121 VDSENS 120 VIN1 119 VIN2 118 VIN4 117 VIN3 116 VIN8 115 VIN7 114 VIN6 113 VIN5 F VCC33 10K R1542 R1527 6R8K R1546 6R8K R1539 100K R1531 10K R1518 10K R1517 10K R1528 10K R1529 10K R1530 10K DGND2 C1519 R1 C1518 R1 R1 C1517 C1513 9 12 8 13 1011 7 14 6 15 5 16 4 17 3 18 2 19 1 20 CN1951 C1516 R1 R1 VCC33 GNDD NM C1525 NM A20 R1547 A1 A2 A3 A4 A5 A6 A18 A7 A17 XWR1 A19 A8 A9 A10 A11 A13 A14 A15 A12 A16 D15 D7 D14 D6 D13 D5 D12 D4 D11 D3 D10 D2 D8 D0 XRD XCSF2 A0 SCLOCK SDATA EXTRG0 TRCCLK TRCDATA0 TRCDATA1 TRCDATA2 TRCDATA3 TRCST GNDD VD8 C1201 100/16 E VCC33 FLASH 16M FLASH 16M XWR1 XWR1 GNDD A18 F R01 220 C1401 NRES R1401 A17 17 A7 18 A6 19 A5 20 A4 21 A3 22 A2 23 A1 24 A18 DQ2 A17 DQ9 A7 DQ1 A6 A5 DQ8 DQ0 A4 /OE A3 Vss1 A2 /CE A1 A0 A0 3 D15 A12 44 D7 A11 D14 A10 42 D6 41 A9 A8 D13 40 A19 D5 39 C1403 R1 38 37 A20 D12 XWR1 D4 NRES R1403 C1402 36 NM NM D11 14 34 D10 33 D2 A18 32 D9 A17 17 31 D1 A7 18 30 D8 A6 19 15 16 29 D0 A5 20 28 XRD A4 21 A3 22 A2 23 A1 24 27 26 25 GNDD A14 NC2 D3 GNDD A15 HOM A16 /BYTE A13 Vss2 4 A12 DQ15_A-1 5 A11 DQ7 6 A10 DQ14 7 A9 DQ6 8 A8 DQ13 9 A19 DQ5 10 NC1 DQ12 11 DQ4 /WE 12 /RESET Vcc 13 35 DQ11 48 46 20 HUM 19 D15 HVP 18 D7 HVM 17 43 D14 HWP 16 42 D6 41 15 HWM D13 40 R1212 HBM D5 39 37 14 270 C1208 D12 C1408 R1 38 R01 FG FG D4 C1407 36 13 D11 CONT2 CONT2 R1201 220 9 D3 CONT1 CONT1 R1202 220 8 D10 MD1 MD D2 LDIN D9 S CRGDRV C R1203 CRGDRV D8 FD FD1 F TD TD1 T 10K D0 XRD 42 VM_S HU- BH HV+ SPRNF HV- SPVM HW+ SPGND HW- U HB V SPCNF W R1204 15K VHALF VHALF PGND2 PGND1 21 CTL2 SL/LDO- CTL1 FCO+ SPIN FCO- NM 22 C1204 23 2200P R1213 C1209 R1214 25 R1 R1215 S S S 26 27 28 C1205 R1 2 FOP2 FOP 34 FOM2 FOM 35 T TOM2 TOM T TOP2 TOP LDIN TKO+ 5 36 SLOPOUT TKO- 37 AVM SLIN 38 3 FCIN PREVcc 39 2 TKIN PREGND 40 1 VC SUBGND COIL HWP 1 HWM R1216 R1217 HVP 1 R1218 HVM HUP HUM F F 4 C1207 R1 IC1201 BD8231EFV PGND GNDD 3 COILW C AVH-P4100DVD/XN/UC 1 COILV COIL 1 C XCSF2 R1409 NM COILU 1 1 32 33 COILW 1 24 GND141 31 SL/LDO+ 6 D1 R1406 100K 7 MD2 LDIN HU+ 12 FG 29 SLVM 11 TEST PGND 30 GND2 10 NM 08E C1203 HUP 44 45 35 DQ3 NC3 34 RY_/BY DQ10 33 DQ2 A18 32 A17 DQ9 31 A7 DQ1 30 A6 DQ8 29 DQ0 A5 28 /OE A4 27 Vss1 A3 26 /CE A2 25 A0 A1 CWW1754 C A16 C1409 4R7 (2125) 47 A0 XCSF1 CWW1753 146 2 A13 4 C1210 R1 A19 A14 43 45 1 A15 A16 C1404 4R7 (2125) 46 (3216) A8 A13 Vss2 4 A12 DQ15_A-1 5 A11 DQ7 6 A10 DQ14 7 A9 DQ6 8 A8 DQ13 9 A19 DQ5 10 NC1 DQ12 11 /WE DQ4 12 /RESET Vcc 13 NC2 DQ11 14 NC3 DQ3 15 RY_/BY DQ10 16 48 47 C1211 4R7 A9 VC PGND 100K A10 A16 /BYTE R1405 A12 A14 NM A13 A11 A15 C1405 2 3 100K A14 R1402 1 A15 VCC33 IC1402 IC1401 PGND HBM 6 7 8 C-b C DVD CORE UNIT TD 100 IC1001 1 OUT R1008 VDSENS NM VREF VD8 VREF R1004 47K 6R8K C1018 5 10 3 4 B C1011 1 C1010 2R2 R1 VCC33 GND_DD LPCO1 EF1001 DVDMPD VD8 C1612 R1 C1613 R1 C1614 R1 C1615 R1 D C1616 R1 RF C1617 R1 B GNDA 2 A C VCC5_1 PGND VCC5 IC1002 S-1133B50-U5 R1 R1 GNDA NM AVCC5 GNDA C1953 DEBUG TRCST (1005) NM C1954 TRCST 47P C1934 TRCDATA2 1K 1K GNDD GNDD AMUTE R1514 R1526 AMUTE MD NM AMUTE 9 XRESET 10 IRQPWR 11 SLVSTS STANBY 14 AGND 15 ANALOG ROUT 16 AGND 17 ANALOG LOUT 18 AGND 19 COMPOSIT 20 VIDEO GND 21 WAKEUP 22 D- 23 D+ STSCOMN STANBY R1025 100 RO LO LOUT WAKEUP R1026 COMPOSITE COMPOSITE R1027 100 NM D- D- D+ 24 10K IECOUT R1540 220 100K R1534 R1536 220 100K STSCOMN CMDCOMN IRQPWR C1528 470P I2C_SCL SCL I2C_SDA SDA CP_Reset RESET R1543 180 I2C_SCL 180 I2C_SDA IECOUT 26 DGND 28 GNDV CN901 D DGND 25 27 GNDAU2 R1544 A 3/4 HSTCMD 13 D+ R1 8 CMDCOMN ROUT LTDAC 220 DGND VD5 12 CP_Reset SDODAC PGND 7 GNDD GNDD PGND 6 CMDCOMN STANDBY 1K R1537 2 NRES SCKDAC R1519 3 IRQPWR CONT1 R1532 100 XCSF1 VD8 VD8 5 VDD5_1 VD8 2 IRQPWR LDIN CP_RESET 3 AMUTE STSCOMN CONT2 R1535 100K C1004 1 R1019 100 NRES CRGDRV HOME C1527 CN1901 1 PGND 4 VDD5_2 NRES C1523 R1 C1524 R047 VD8 GNDD GNDAU DGND4 (3216) R1015 NM NRES 18K 10K R1525 AGND4 VDD5 220 10K GNDD EF1002 R1522 100K R1 GNDV L1903 FG C1526 R01 R1513 AGND1 GNDA SDATA 10K R1523 680P C1022 680P NM GNDAU SCLOCK SCLOCK R1516 C1021 NM C1007 GNDA EXTRG0 SDATA HOST I/F C1006 SCL SDA 29 RESET 30 DGND 0R0 4R7K 3 NC ON/OFF DGND1 TRCCLK R1524 2 VSS 4 S-1200B50-M5 68P TRCDATA0 R1510 VD 1 VIN (1608) TRCDATA1 R1509 IC1003 VOUT (1608) TRCDATA3 C1522 5 R1021 R1 AVCC5 (1608) 1 C1521 C1627 GNDA C1622 R033 C GNDD R1 R001 PGND C1624 R22 R001 C1620 R22 VOUT 5 C1019 C1016 C1625 GNDD C1001 5600P NM 100P C1619 C1626 C1618 USBGNDD C1005 (1608) GNDA VIN 4 ON/OFF 3 VSS 2 NC 1 ANAMONI1 4R7 (2125) ANAMONI2 C1621 VD8_1 PGND3 PGND4 PGND5 C1003 R1 R1 VD8_2 L1902 3 1 C1611 1 NM R1 C1017 C1610 54 53 C1013 2 GNDD C1529 USB_CLOCK 08EJ 10K C1520 CE VOUT 1 GND_DCON GND_DD CDMPD VSS_6 VDD33_4 CMDCOMN STSCOMN 52 51 50 49 VDD LPCO2 R1527 6R8K R1546 6R8K R1542 C1519 R1 R1539 100K R1 VIN TEST NM GNDD 1M NM VIN6 113 VIN5 112 F+H_G+H E+G_E+F 111 VHALF VREFH 110 109 114 IRQPWR VIN7 115 116 117 VIN3 VIN4 VIN8 I2C_SDA CP_READY I2C_SCL 48 46 47 118 119 VIN1 VIN2 VDD12_2 VSS_5 44 45 120 122 121 43 123 AD2 AD4 VDSENS TEMP EXADT2 EXADT3 EXADT4 EXADT1 42 41 40 C1609 107 AVSSB AVDDB 106 LPCO2 105 CDMPD 104 LPCO1 103 DVDMPD 102 VREFL5 101 VREFH5 100 VIN3RF 99 VIN4RF 98 VIN2RF 97 VIN1RF 96 RFINP 95 RFINN 94 ANAMONI2 93 ANAMONI1 92 AVDDC 91 CDATA 90 CCAPA 89 AVSSC 88 VREFL7 87 AVSSD 86 VREFH7 85 PLFIL1 84 AVDDD 83 VDD12_3 82 VSS_8 81 TRCST 80 TRCDATA3 79 TRCDATA2 78 TRCDATA1 77 TRCDATA0 76 TRCCLK 75 EXTRG1 74 EXTRG0 73 SDATA 72 SCLOCK 71 FG 70 NRES 69 VDD33_5 68 VSS_7 67 C CRGDRV 66 S MD 65 HOME 64 CONT2 63 CONT1 62 LDIN 61 CP_Reset 60 P13 59 XCSSR 58 SCKDAC SDODAC 57 LTDAC 12EJ 56 55 R1541 1M AGND GND_DCON VCC33-1 R1604 R1605 108 PGND LX R1232D121B GND_DD (2125) R1017 NM R1007 6 NM 4 VSS 3 NC 2 VDD 7 IC1004 1 NM R1001 E+G_E+F F+H_G+H FE1 FE2 TEMP TEMP 1 C1623 (1608) VHALF AD2 8 FB12A FB12B (1608) R1011 VDD5 10 IC1005 VCC33 VSENS C1608 (1608) L1004 C1014 DDF L1003 NM VDSENS VCC12-1 VCC12 VOLTAGE DETECT GNDA C1015 R01 1 IN 0K 5.0-3.3&1.2 V DC/DC NJM2885DL1-33 C1601 3 OUT 2 GND 603 S 10 C1008 R1 68P C1605 100P C1603 12K C 10 C1009 T R1602 AGND2 GNDA C1606 68P 100P 12K C1604 C1602 R1601 10 (2125) C1607 F :POWER SUPPLY :PU :ACT+SPDL :FLASH :SDRAM :DVN(SYS) :DVN(FE) :DVN(BE) :VIDEO :AUDIO (ANALOG) :AUDIO (DIGITAL) :OUTSIDE I/F :USB A FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE RF SIGNAL T 1000->1049 1100->1199 1200->1299 1400->1449 1480->1499 1500->1599 1600->1669 1670->1699 1700->1749 1800->1849 1850->1899 1900->1950 1950->1999 R1002 FD F VCC33 C1012 5 GNDAU3 CP_READY GNDAU R1533 GNDD GNDV R01 C1108 VCC5 C1101 10 (1608*4) R1113 R1118 HUM UHB- HBM C COM C COP R1300 18 CRG/LE+ 3 R1 C1105 C1107 R01 R1110 3R3 22 560 R1106 1M VCC33 IC1006 0R0 1 2 15 HALL_U16 HALL_BIAS17 CRG/LE- D FE1 FE1 FE2 FE2 3 VCC G 5 IN GND OUT NM G OUT IN X Z L L H L H 4 H H X:Don’t Care Z:High Impedance LPCO1 DVD 1R5 VCC 4 F+H/G+H 5 E+G/E+F 6 SW 7 78LD 8 65LD 9 LD GND 10 B 11 A 12 C 13 D 14 FE1 15 FE2 CDMPD 1R5 1R5 1R5 Q1103 2SB1132 Q1101 2SC4081 DVDMPD DVDMPD TEMP 1 RF RF DVDLD1 R1111 R1116 GNDA GNDD Vref 3 GNDD 17 78MD 18 65MD 19 65MDG 20 TEMP 21 TEMP GND T TOP FOM F FOP F 22 RF 23 T+ 24 FFOP1 T TOM GNDA TOP1 E 25 F+ 26 T- R22 (1608) U+ C D C1111 HUP 13 HALL_V14 HALL_U+ NM R01 V- R1301 R1 HVM A C (1608) C1109 R22 PGND V+ A GND 2 16 78MDG C1106 C1210 R1 1 HVP CN701 B B R1112 R1115 C1104 1 11 HALL_W12 HALL_V+ 1R5 1R5 Q1104 2SB1132 (1608*4) 22 W- DVDLD0 CDMPD C1113 R1109 3R3 HWM 1R5 GNDD D CDLD0 GNDA 390 1 GND1 X1 CSS1760 CD 2 Q1102 2SC4081 LPCO2 1R5 E+G_E+F E+G_E+F CDLD1 R1114 R1117 510 W+ 9 COIL_V 10 HALL_W+ IC1951 TC7SZU04FU 1 X2 3 R1103 COILV GND GND2 R1102 100K S OUT_Y 3 X1950 4 C1952 10P COILV IN_A 10P R1953 COILU HWP R1217 (3216) S 1 R1216 R1218 COILU 7 COIL_W 8 COIL_U 2 R1104 1 R1215 270 COILW 1 NC R1101 100K R1214 S 48.000MHz VCC 4 5 12cm(DSCSNS) 6 HALL_BIAS+ HB+ COILW 5 8cm C1951 680 R1952 1 C1950 R1 HOME 4 48MHz R1222 GNDD 3 NM 12EJ GNDD 2 NM 08EJ C1301 HOME C1302 1 HOME 08EJ 390 R1105 GNDA F+H_G+H 1 PICKUP UNIT (SERVICE) CN1201 C1112 AGND3 VREF R01 F+H_G+H VCC5 R1213 CN1101 VCC5_3 NM C1525 NM A20 R1547 A1 A2 A3 08EJ C1110 C1211 4R7 A4 NM PU(DP10) F MOTOR DRIVER C AVH-P4100DVD/XN/UC 5 6 7 8 147 100P 100P C1604 R01 C1601 C1605 FD T 68P 68P C1602 C1603 TEMP C1606 GNDA R1 F+H_G+H 12K 107 AVSSB AVDDB 106 LPCO2 105 CDMPD 104 LPCO1 103 DVDMPD 102 VREFL5 101 VREFH5 100 VIN3RF 99 VIN4RF 98 VIN2RF 97 VIN1RF 96 RFINP 95 RFINN 94 ANAMONI2 93 ANAMONI1 92 AVDDC 91 CDATA 90 CCAPA 89 AVSSC 88 VREFL7 87 AVSSD 86 VREFH7 85 PLFIL1 84 AVDDD 83 VDD12_3 82 VSS_8 81 TRCST 80 TRCDATA3 79 TRCDATA2 78 TRCDATA1 77 TRCDATA0 76 TRCCLK 75 EXTRG1 74 EXTRG0 73 SDATA 72 SCLOCK 71 FG 70 NRES 69 VDD33_5 68 VSS_7 67 108 VHALF C (2125) C1607 R1 R1 R1 R1 R1 R1 R1 C1611 C1612 C1613 C1614 C1615 C1616 C1617 FE1 FE2 TD AVH-P4100DVD/XN/UC 4 1K 1K R1513 C1522 10K R1 C1526 R01 R1516 R1510 1M 1M SDATA EXTRG0 TRCCLK TRCDATA0 TRCDATA1 TRCDATA2 TRCDATA3 TRCST NRES C1523 R1 R1522 100K R1523 220 SCLOCK SCLOCK 10K CRGDRV FG VREF DEBUG GNDA SDATA TRCST GNDA R1 4R7K R1 R1 R1605 R1604 VREF RF D C A B DVDMPD LPCO1 CDMPD LPCO2 NRES AMUTE NRES AMUTE GNDD 68P 47P C1934 NM C1954 C1953 R1 C1019 GNDD VCC5 NM R1008 (1608) (1608) GNDA R1019 100 VD8 (1005) AVCC5 GNDD VD8 USBGNDD VSENS PGND VDSENS 1 VDD5 GNDA GNDD PGND 2 EF1001 GNDD NRES AMUTE AGND1 DGND1 3 IC1003 VSS VIN AGND4 NM (3216) R1015 3 2 1 1 VOUT 5 NM L1902 GNDD VIN 4 NC ON/OFF VOUT S-1200B50-M5 4 5 NM (1608) R1011 GND_DD (2125) R1017 VCC33 IC1002 S-1133B50-U5 ON/OFF 3 VSS 2 NC 1 GNDA 3 NC 2 VDD NM 4 VSS IC1001 1 OUT AVCC5 VCC33 VCC12 VCC5_1 GND_DD GND_DCON 2 NM L1903 GNDV NM C1007 C1006 GNDD 3 GNDAU EF1002 FB12B FB12A VCC12-1 5.0-3.3&1.2 V DC/DC VDD5_2 VDD5_1 C1022 680P 680P C1021 GNDD 5 6 7 8 CE VDD VIN PGND R1232D121B VOUT TEST DVD CORE UNIT VD8_1 GND_DD GNDD VD 4 3 2 1 10 C1013 10 C1014 GND_DCON PGND VDD5 VD8 11 10 9 8 7 6 5 4 HSTCMD IRQPWR XRESET AMUTE VD5 DGND PGND PGND VD8 VD8 2 3 VD8 1 A 3/4 CN1901 HOST I/F L1004 FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE RF SIGNAL IC1005 AGND LX PGND3 VD8_2 PGND4 GNDAU DGND4 GNDD PGND5 VCC33-1 L1003 DDF S C T F C A R1509 R1524 C1521 GNDA GNDA C1624 R22 C1622 R033 C1621 10 C1625 C1619 C1620 R22 100P 5600P C1618 ANAMONI1 ANAMONI2 R1 C1610 R1 1 C1623 (1608) C1609 1 C1608 (1608) VDSENS VOLTAGE DETECT NM R1602 E+G_E+F 122 TEMP 121 VDSENS 120 VIN1 119 VIN2 118 VIN4 117 VIN3 116 VIN8 115 VIN7 114 VIN6 113 VIN5 112 F+H_G+H E+G_E+F 111 VHALF VREFH 110 109 R1001 47K R1004 R1007 GNDA NM NM R1 NM 6R8K C1018 C1017 12K (1608) 1 AGND2 100 R1601 C1626 C1627 :POWER SUPPLY :PU :ACT+SPDL :FLASH :SDRAM :DVN(SYS) :DVN(FE) :DVN(BE) :VIDEO :AUDIO (ANALOG) :AUDIO (DIGITAL) :OUTSIDE I/F :USB C1001 1000->1049 1100->1199 1200->1299 1400->1449 1480->1499 1500->1599 1600->1669 1670->1699 1700->1749 1800->1849 1850->1899 1900->1950 1950->1999 C1004 10 C1008 R1002 VCC33 C1003 R1 IC1004 10 C1009 C1010 2R2 C-a C-b 4R7 (2125) 3 1 C C1005 (1608) B 3 OUT C-b 3 C1016 2 R001 2 GND 1 IN 2 NJM2885DL1-33 1 C1011 1 148 NM F C1012 E R001 D C1015 1 4 EXADT2 41 A2 EXADT1 42 VSS_5 R1218 R1217 R1216 R1215 R1214 R1213 A1 VDD12_2 44 C1519 R1 CP_READY 45 I2C_SCL PGND MD HOME 60 61 62 63 64 65 67 R1222 08EJ HOME HB+ 12EJ 10K R1525 180 180 R1543 8cm HOME GNDD GNDD V- U+ U- HVM HUP HUM C COP COM HB- 13 HALL_V14 HALL_U+ V+ HVP CN701 D MOTOR DRIVER GNDD 18 CRG/LE+ 17 CRG/LE- 15 HALL_U16 HALL_BIAS- 11 HALL_W12 HALL_V+ W- 9 COIL_V 10 HALL_W+ 7 COIL_W 8 COIL_U HWM C R1540 220 R1535 100K 100K W+ HBM NM C1527 220 R1544 220 NRES R1532 100 XCSF1 C1523 R1 C1524 R047 R1522 100K R1523 10K R1536 C1528 470P SDATA EXTRG0 SCLOCK SCLOCK SDATA 100K R1534 R1537 1K R1519 5 12cm(DSCSNS) 6 HALL_BIAS+ 4 3 2 1 18K 10K 10K R1 CP_RESET R1526 R1514 R1513 C1522 HWP 3 220 1K 1K C1526 R01 R1516 R1510 R1509 CN1201 R1541 P13 59 XCSSR 58 SCKDAC SDODAC 57 LTDAC 12EJ 56 55 CP_Reset LDIN CONT1 CONT2 S 270 COILW COILU COILU S COILV COILV S COILW 08EJ HOME VCC5 NM R1533 68 69 70 71 C CRGDRV 66 S VSS_7 VDD33_5 NRES FG SCLOCK 72 73 74 0R0 R1300 08EJ LDIN CONT1 CONT2 HOME MD CRGDRV FG 3 2 1 NM GNDD GND IN G OUT_Y VCC NC GND IN_A OUT VCC 4 5 NM 3 2 1 VCC33 R1301 IC1951 TC7SZU04FU IC1006 4 5 C1950 R1 I2C_SDA I2C_SCL IRQPWR STSCOMN CMDCOMN LTDAC SDODAC SCKDAC CP_Reset NRES AMUTE GNDD H H X:Don’t Care Z:High Impedance H GNDA 2 X2 3 R1027 100 R1025 100 R1019 100 GND1 X1 CSS1760 GND2 IN G OUT X L Z L H L 1 4 X1950 48.000MHz CP_READY CP_Reset I2C_SDA I2C_SCL IECOUT D+ D- COMPOSITE LOUT ROUT STANDBY STSCOMN CMDCOMN IRQPWR NRES AMUTE GNDD C-a C-b LPCO1 AGND4 RESET SDA SCL D+ D- COMPOSITE LO RO STANBY STSCOMN CMDCOMN IRQPWR NRES AMUTE AGND1 DVD CD GNDA AGND3 LPCO2 VCC5 VDD5 GNDA GNDD GNDA Q1101 2SC4081 GNDA 1 GNDD 3 GNDAU3 GNDAU2 2 EF1002 VCC5_3 Q1102 2SC4081 NM (3216) R1015 GNDV 1R5 1R5 1R5 Q1104 2SB1132 CDLD1 R1114 R1117 1R5 1R5 1R5 1R5 Q1103 2SB1132 DVDLD1 R1111 R1116 1R5 R1112 R1115 (1608*4) VDD5_1 GNDD GNDV VDD5_2 (1608*4) R1113 R1118 GNDAU L1903 DGND4 RF TEMP TOM FOP FOM TOP RF 1 DVDMPD CDMPD FE2 FE1 D C A B E+G_E+F F+H_G+H R01 C1110 GNDA F F T T R1021 0R0 DGND IECOUT DGND 23 24 25 26 SDA RESET DGND 28 29 30 Vref VCC 2 3 LD GND 26 T- 25 F+ 24 F- 23 T+ RF 21 TEMP GND 20 TEMP 19 65MDG 18 65MD 17 78MD 16 78MDG 15 FE2 14 FE1 13 D 12 C 11 A 10 B 65LD 78LD 7 9 SW 6 8 E+G/E+F 5 22 SCL D+ 22 27 WAKEUP D- 21 VIDEO GND COMPOSIT 19 20 AGND ANALOG LOUT AGND 18 17 16 A 3/4 CN901 ANALOG ROUT AGND 15 STANBY SLVSTS HSTCMD IRQPWR XRESET AMUTE VD5 DGND PGND 14 F+H/G+H GND 1 4 VD8 VD8 PGND 13 12 11 10 9 8 7 6 5 4 3 2 CN1101 WAKEUP PU(DP10) FOP1 TOP1 DVDMPD CDMPD FE2 FE1 D C A B DVDLD0 CDLD0 E+G_E+F F+H_G+H VREF GNDD NM R1026 PGND 7 C-b 1 1 1 1 1 1 46 NM IRQPWR 48 R1542 I2C_SDA 47 R1527 6R8K R1546 6R8K C1210 R1 51 USB_CLOCK 50 10K NM 52 C1520 08EJ 49 C1525 SDATA NM EXTRG0 54 VSS_6 VDD33_4 CMDCOMN STSCOMN 53 R1 TRCCLK C1529 4R7K 48MHz R1524 C1952 10P 75 NM R1539 100K A20 R1547 (3216) 1M 10P R1953 C1101 10 76 C1104 R001 EXTRG1 C1302 R1952 C1951 680 43 C1211 4R7 R1102 100K R1101 100K R1105 R1106 R1110 3R3 C1112 C1113 R1109 3R3 R1 C1105 R1 C1016 TRCCLK C1301 22 22 R01 TRCDATA0 NM C1107 390 560 390 510 R1103 R1104 R01 R01 7 C1106 6 (1608) C1109 R22 6 R22 (1608) 5 C1108 5 8 PICKUP UNIT (SERVICE) A B C D E AVH-P4100DVD/XN/UC 8 149 F C1111 STANDBY LOUT 1800P R1801 R1802 100K 100K 820 3 C-a AVH-P4100DVD/XN/UC 4 MA3 MA2 MA1 MA0 MA10 BA1 BA0 XCSM XRAS XCAS 1 4 3 2 1 4 3 2 1 8 6 7 8 5 6 7 8 2 5 3 7 1 8 6 2 7 4 3 5 4 1 8 6 2 7 5 3 6 R1481 56 4 5 7 6 5 4 3 2 1 DQ3 VSSQ1 DQ2 DQ1 VDDQ1 VDD1 DQ0 VSS3 DQ15 DQ12 VDDQ4 DQ13 DQ14 VSSQ4 IC1480 8 DQ11 DQ4 9 R1 VSSQ3 C1493 NM 10 VDDQ2 DQ10 DQ5 11 DQ9 DQ6 12 VSSQ2 VDDQ3 13 DQ8 DQ7 C1483 NM 14 VSS2 C1484 R1 15 VDD2 LDQM N.C/RFU 16 UDQM WE R1482 17 56 CAS CLK 18 RAS CKE 19 CS N.C 20 BA0 A11 R1483 21 56 A9 BA1 22 A8 A10/AP 23 A7 A0 24 A6 A1 R1484 25 56 A5 A2 26 A4 A3 C1485 27 VDD3 VSS1 R1 C1482 C1481 R1 C1494 NM C1480 R1 GNDD 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 C1492 C1487 C1491 C1488 56 R1488 8 7 6 5 8 7 6 5 R1489 56 8 7 6 5 8 7 6 R1486 56 R1485 56 5 GNDD 56 R1487 NM R1 NM R1 L1904 1 2 3 4 1 2 3 4 1 2 3 4 1 2 3 4 VCC33 MA4 MA5 MA6 MA7 MA8 MA9 MA11 DQM1 MCK MDQ8 MDQ9 MDQ10 MDQ11 MDQ12 MDQ13 MDQ14 MDQ15 SCK MA1 MA6 MA0 MA7 MA10 MA8 BA1 MA9 BA0 MA11 XCSM XRAS XCAS MCK XWE DQM1 DQM0 MDQ7 MDQ8 MDQ6 MDQ9 L1512 R1 C1507 100K R1538 C1503 R1 R1 C1506 100 175 R1 204 203 202 201 200 199 198 197 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 174 C1505 173 172 171 MDQ10 MDQ5 170 MDQ4 169 R1 168 167 MDQ11 166 C1504 R1512 164 163 165 MDQ3 MDQ12 MDQ2 MDQ13 GNDD 1 10P 12P MA1 MA6 MA0 MA7 MA10 MA8 BA1 VDD33_10 VSS_15 MA9 BA0 DQM3 STANDBY NCSM NRAS NCAS VDD12_5 VSS_14 MCKI VDD33_9 MCK VSS_13 NWE DQM1 DQM0 MDQ7 MDQ8 MDQ6 MDQ9 VDD33_8 VSS_12 MDQ5 MDQ10 MDQ4 MDQ11 MDQ3 MDQ12 MDQ13 MDQ2 VSS_11 VDD33_7 1M GNDD R1503 C1512 GND1 C1510 X1 2 CSS1768 X1501 4 X2 3 GND2 27.000MHz 15K R1954 15K R1955 NM D1902 GNDD GNDD D1901 NM 200 R1672 GNDA GNDA 10K C1674 R1 R1670 IC1501 MN2DS0018MAUB 24K R1671 NM NM R1675 NM R1679 R1673 R1 GNDV C1673 10K R1603 F AD2 R01 C1601 12K R1602 12K R1601 FD T 3 XWE DQM0 MDQ7 MDQ6 MDQ5 MDQ4 MDQ3 MDQ2 MDQ1 R1480 56 GNDD VCC33 GNDAU LTDAC LTDAC C-b 2 56 MDQ0 R1490 VCC12 AUDIO 2CH ANALOG OUT 4 R7 (2125) 8 R1804 7 C1 8 0 2 6 C1808 5 NM SDODAC R1 GNDAU AVCC5 R001 10 C1806 IC1801 PCM1753DBQ SCKDAC AGND 9 VOUTR 10 VOUTL VCOM ZEROR/ZEROA 11 VCC ZEROL/NA 12 NC 13 SDODAC DGND MD 14 SCKDAC MC 4 IECOUT IEC GNDAU1 R1 C1805 C1490 11 15 16 ML 3 LRCK C1809 DATA 2 BCK 1 C1803 C1502 10 D44 ADAC MDQ1 820 MDQ14 162 R1956 0R0 R1803 R1501 MDQ0 4R7 C-a C-b R1 1800P C1501 10 1R2K MDQ15 (IEC/IPFLG) R1504 12 C1804 (2125) (2125) R1 157 COMPOSITE R1 (2125) C1801 C1807 C1489 C1672 100P 100P ROUT NM 10 (2125) 156 VSS_10 C1511 161 MDQ1 MDQ14 160 MDQ0 159 MDQ15 158 VDD12_4 C1514 OSCI 155 OSCO 154 0R0 R1511 152 VSS_9 153 VDD33_6 ADOUT 100 R1505 ADOUT 151 LRCK 100 R1506 150 SRCK 100 R1507 IECOUT R1674 DACCK 148 SRCK 149 LRCK R1508 220 C1515 147 DACCK 1 C1602 C1603 TEMP D+ R1957 0R0 L1901 NM R1950 146 AVDDI 30K 134 C1676 2 2 240 R1951 R1 GNDD5 ROUT 145 AVSSI 120 C1604 C1605 119 68P 68P 118 33 144 LOUT 123 240 R1 C1671 143 AVSSG 142 AVDDG 141 AVDDE 140 AVSSE 139 DAC5OUT 138 COMPOSITE 137 AVSSF 136 COMP2 135 IREF1 T F (1608) VREF 133 COMP1 132 AVDDF 131 DAC1OUT 130 DAC2OUT 129 DAC3OUT 128 AVDDH 127 FD 126 TD 124 AD4 125 AVSSH TEMP AD2 122 TEMP 121 VDSENS 2 VIN1 TD 117 1 VIN2 FE1 FE2 150 VIN4 F 116 E 115 D VIN3 C VIN8 B 114 VIN6 A VIN7 1 4 AVH-P4100DVD/XN/UC 8 A0 R01 GNDD 1 2 3 4 1 2 SDRAM GNDD 2 A14 A15 A16 /BYTE 46 47 48 CWW1753 Vss2 A13 4 A12 45 DQ15_A-1 5 44 A11 DQ7 6 43 A10 DQ14 7 42 A9 DQ6 41 8 DQ13 A8 40 9 DQ5 A19 39 10 DQ12 NC1 38 11 DQ4 /WE 37 12 /RESET Vcc 36 13 DQ11 NC2 35 14 DQ3 NC3 34 15 RY_/BY DQ10 33 16 DQ2 A18 17 32 A17 DQ9 18 31 A7 DQ1 19 30 A6 DQ8 20 29 A5 DQ0 21 28 /OE A4 22 27 Vss1 A3 23 26 /CE A2 24 25 A0 A1 3 IC1401 FLASH 16M 1 VSS1 A4 A5 A6 A7 A8 A9 K4S641632N-LC75 VDD3 A3 A2 A1 DEBUG 27 26 25 24 A0 A10/AP CN1951 NM R1 C1486 C1485 R1484 56 23 22 BA1 28 29 30 31 32 33 34 GNDD DGND3 A7 D1 XCSF1 A0 A1 A2 A3 A5 A4 D0 XRD D8 A17 D2 D9 A6 A18 D10 D3 D11 NM NRES R1403 XWR1 A20 D5 D4 A8 A19 D13 A9 D6 D12 A10 D14 A13 A14 A15 A11 MA4 MA5 MA6 MA7 MA8 MA9 MA11 DQM1 A12 1 2 3 4 1 2 3 4 D7 1011 D15 A16 VCC33 C1404 4R7 (2125) GNDD NM C1402 C1403 R1 8 7 6 5 8 7 6 5 VCC33 56 R1488 56 R1487 GNDD R1 XCSF2 A0 A15 48 3 2 XRD C-a C-b CWW1754 A14 A16 47 /BYTE 46 Vss2 A13 45 4 A12 DQ15_A-1 44 5 DQ7 A11 6 43 A10 DQ14 7 42 A9 DQ6 8 41 A8 DQ13 9 40 A19 DQ5 10 39 NC1 DQ12 11 38 /WE DQ4 12 /RESET 37 Vcc 13 36 NC2 DQ11 14 35 NC3 DQ3 15 RY_/BY 34 DQ10 16 33 A18 DQ2 17 32 A17 DQ9 18 31 A7 DQ1 19 30 A6 DQ8 20 29 A5 DQ0 21 28 /OE A4 27 22 Vss1 A3 26 23 /CE A2 25 24 A0 A1 1 IC1402 FLASH 16M R1 C1509 R1 C1508 GNDD DGND2 MA3 MA4 MA2 MA5 MA1 MA6 MA0 MA7 MA10 MA8 BA1 C1507 R1409 NM NEXCE NEXOE EXDT0 EXDT8 EXADT0 VDD12_6 VSS_17 MA3 MA4 MA2 MA5 VDD33_11 VSS_16 MA1 MA6 MA0 MA7 MA10 MA8 BA1 VDD33_10 VSS_15 MA9 XRD D0 D8 D1 D9 D2 D10 D3 D11 D4 D12 D5 D13 D6 D14 D7 D15 A16 VCC33 XCSF2 R1406 100K C1409 4R7 (2125) GNDD NM C1407 C1408 R1 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 LDIN MD1 CONT1 CONT2 S 10K C 220 220 VHALF 15K R1204 MD2 R1202 R1201 PGND2 PGND1 T F R1203 FG HW- HW+ HV- HV+ HU- BH VM_S U SPGND SPVM SPRNF PGND HU+ EXADT11 26 25 24 23 22 21 13 PGND IC1201 BD8231EFV 27 HB V 28 SPCNF W 12 FG 29 SLVM 11 TEST PGND 30 GND2 10 GND141 31 SL/LDO+ 9 CTL2 SL/LDO- 32 8 33 CTL1 FCO+ 7 34 FCOSPIN 6 35 LDIN TKO+ 5 36 SLOPOUT TKO- 37 4 AVM SLIN 38 3 FCIN PREVcc 39 2 TKIN PREGND 40 1 VC SUBGND 14 15 HWM 270 16 HWP R01 17 HVM C1208 18 HVP HBM 19 HUM VHALF TD1 FD1 CRGDRV 42 TD FD CRGDRV LDIN MD CONT1 CONT2 FG 20 HUP R1212 VD8 TOM2 TOP2 T C1207 R1 FOM FOM2 TOP TOM FOP FOP2 S S S R1 C1209 T C C VDD33_3 F F C1205 R1 2200P C1204 NM C1203 COILW COILV COILU R1218 R1217 R1216 R1215 R1214 R1213 45 I2C_SCL PGND C-b 1 1 1 1 1 1 C C C 7 A1 A2 A3 A4 A5 A6 A7 A17 A18 220 XWR1 8 7 6 5 8 7 NRES R1401 XWR1 A19 A8 A9 A10 A11 A12 A13 A14 A15 MA3 MA2 MA1 MA0 MA10 21 3 18 TRCDATA2 BA1 1 20 TRCST 36 4 17 TRCDATA1 35 5 16 TRCDATA0 A11 6 15 TRCCLK N.C 7 14 EXTRG0 CS 8 13 SDATA BA0 9 12 SCLOCK 19 C1405 20 1 D1 R1483 56 D9 1 2 EXDT1 3 EXDT9 EXDT2 EXDT10 D2 3 4 D10 VSS_1 5 VDD33_1 6 R1 C1513 EXDT3 7 D3 EXDT11 8 D11 EXDT4 9 D4 EXDT12 10 D12 EXDT5 11 D5 EXDT13 12 D13 EXDT6 13 D6 EXDT14 14 D14 VSS_2 15 VDD33_2 16 C1516 R1 EXDT7 17 D7 EXDT15 18 D15 VSS_3 19 VDD12_1 20 4 A15 8 A14 6 NM 2 19 TRCDATA3 R1402 A13 5 D8 R1405 A12 R1 C1517 EXADR16 21 A16 EXADT15 22 EXADT14 23 EXADT13 24 EXADT12 25 R1517 10K R1528 10K R1529 10K R1530 10K C1201 100/16 26 A11 EXADT10 27 A10 EXADT9 28 A9 EXADT8 29 A8 EXADR19 30 A19 NEXWE 31 XWR1 VSS_4 32 BA0 A17 33 C1518 R1 EXADR18 34 A18 EXADR17 35 EXADT7 36 R1531 10K R1518 10K A7 EXADT6 37 A6 EXADT5 38 A5 EXADT4 39 A4 EXADT3 40 A3 EXADT2 41 A2 EXADT1 42 A1 VSS_5 43 VDD12_2 44 XCSM C1401 7 100K NM C1519 R1 R1539 100K A20 R1547 (3216) 6 100K 6 C1211 4R7 CP_READY 46 I2C_SDA 47 R1527 6R8K R1546 6R8K 08EJ 49 IRQPWR 48 R1542 C1525 5 C1210 R1 5 8 C-a 151 A B C D E F D0 1 2 3 4 10.7 CONNECT PCB A D CONNECT PCB CN701 B GND_B GND3 GND2 GND1 HOME HOME1 HOME HOME1_B HOME_B R101 2 4 3 1 S101 100 CSN1068-A 8SNS 8SNS1 8SNS0 8SNS1_B 8SNS0_B R102 2 4 3 1 S103 H+ 100 CSN1068-A DSCSNS W W U U V DSCSNS1 DSCSNS0 DSCSNS1_B DSCSNS0_B R103 13 4 2 CSN1068-A 100 S102 C HP V HW+ HWP HW- HWM HV+ HVP HV- HVM HU+ HUP HU- HUM H- HM CRGP M1 LOAD/CRG MOTOR CXC4026 C CRGM C C GND 17 GND 16 HOME 15 8SNS 14 DSCSNS 13 HALL BIAS+ 12 COIL W 11 COIL U 10 COIL V 9 HALL W+ 8 HALL W- 7 HALL V+ 6 HALL V- 5 HALL U+ 4 HALL U- 3 HALL BIAS- 2 CRG+ 1 CRG- BR C 1 1 GY 0.1u/50 C101 1 1 2 1 S S S 18 D H+,H-,HU+,HU-,HV+,HV-,HW+,HW-,U,V,W M2 SPINDLE MOTOR EXM1050 CN101 V 1 1 U 2 2 W 3 3 H- 4 4 HW+ H3 5 5 HW- 6 6 HU+ H1 7 7 HU- 8 8 HV+ 9 H2 9 H+ 10 10 HV- 11 11 S S S V U W HHW+ HWHU+ HUHV+ H+ HV- E F D 152 AVH-P4100DVD/XN/UC 1 2 3 4 C CN1201 5 6 7 8 A B C D E F AVH-P4100DVD/XN/UC 5 6 7 8 153 1 2 3 4 10.8 KEYBOARD UNIT A S SWVDD33 B ILMB 14 F 1/2 CN5003 C R3005 REM 13 GNDKEY 12 HDRST 11 LEDB1 10 GND2 1 0 LEDB1 LEDG1 LEDG1 9 LEDR1 LEDR1 8 LEDB2 LEDB2 7 LEDG2 6 LEDR2 5 KDT0 4 KDT1 3 ILMB 2 SWVDD33 1 LEDG2 LEDR2 ILMB 8.0V GNDKEY 3 4 5 6 D3005 D 1 2 GNDKEY NSSM038A-6430 C3012 0.1u/16 C3013 0.1u/16 C3014 0.1u/16 6 D3002 1 2 3 4 5 E NSSM038A-6430 C3006 0.1u/16 C3007 0.1u/16 C3008 0.1u/16 F E 154 AVH-P4100DVD/XN/UC 1 2 3 4 U3001 OUT 2 RS-470 5 6 7 8 A E GND2 1 U3001 KEYBOARD UNIT 47 R3001 SWVDD33 B C3005 4 VCC 0.1u/50 3 GND1 0.0~0.5V 0.5~1.4V KDT0 EJECT MUTE VOL+ KDT1 SOURCE FORWARD REVERSE RS-470 1.4~2.2V 2.2~3.0V 3.0~3.3V GNDKEY x VOLDISP.OFF x R3008 R3009 1.8k 3.9k 10k EJECT MUTE VOL+ VOL- RESET 1 CSG1155-A 2 3 S3005 4 3 4 S3004 VSG1020-A 2 1 3 4 S3009 VSG1020-A 2 1 3 4 S3007 VSG1020-A 2 1 4 3 DISP.OFF S3006 VSG1020-A 2 1 3 S3008 VSG1020-A 2 1 4 REVERSE 3 FORWARD R3010 4 SOURCE S3003 VSG1020-A 2 1 10k 3 R3011 3.9k S3002 VSG1020-A 2 1 R3007 1.8k 3 R3006 4 S3001 VSG1020-A 2 1 C 4 OUT 2 D GNDKEY CHIP SIZE LEGEND 1608 2125 E 3216 F E AVH-P4100DVD/XN/UC 5 6 7 8 155 1 2 3 4 10.9 MONITOR UNIT(uCOM)(GUIDE PAGE) H NC SWVDD FLMDO 7 8 9 10 GND GND SWVDD 6 RSTIN 5 TOOL1 4 TOOL0 RSTOUT 3 ILMLD NC NC 0.47u/10 R5140 8 1 NC 2 R5148 EPRCK 3 4 FLMD0 NM IC5102 1 2 3 GNDOSD NC TEST DO 47k R5144 NM R5143 470 100 470 470 R5131 R5129 R5128 VCC SK GND 8 R5150 7 0 6 5 S-93C56BD0I-J8 47k ILMLD C5105 C5111 0.1u/10 0.1u/10 GNDOSD ILMCK R5124 R5126 470 470 470 R5116 R5115 R5152 47k R5108 ILMDT 4.7k F% R5153 CS DI 4 TH5101 NM GNDOSD R5149 EPRDI 7 EPRDO 6 EPRCE 5 2 NC 1 1k TEMPSEN 100k C5107 5 80 ILMCK 79 DIMMER ILMDT 78 77 REMIN 76 NC 73 74 75 NC NC 72 NC 71 70 KDT0 NC 68 69 NC KDT1 67 65 64 66 EPRDI 470 R5111 MONRST GNDOSD TOUCHAD R5113 R5114 D 4.7k 4.7k CN5001 GNDOSD 1 AO1 2 AO2 SWVDD33 4 BLUE SWVDD33 29 NAVI_G NAVIR NAVI_R CSYNC GNDRGB GNDRGB 16 9 8 PWRFL 7 PWRFL 6 NC 5 GNDFL 4 GNDFL 3 GNDFL 2 GNDILM 1 NM C5005 LEDB2 GNDV LEDG2 LEDR2 GNDD Q5001 UMX1N GNDD PWRFL 1 E1 2 B1 3 C2 R5004 PWRFL 10k (RED) GNDFL GNDFL GNDILM Q5003 UMX1N Q5002 2SC4081(QR) 6 C1 5 B2 4 E2 R5014 R5024 R5009 10k 10k 10k (GREEN) (BLUE) (RED) 1 E1 2 B1 3 C2 6 C1 5 B2 4 E2 Q5004 2SC4081(QR) R5029 R5019 10k 10k (GREEN) R5017 R5016 270 270 NC PWRFL MONVBS R5018 0 10 (BLUE) GNDOSD F 1/2 156 AVH-P4100DVD/XN/UC 1 KDT1 LEDB1 GNDV R5006 200 11 GNDD GNDV C5002 NM GNDD MONVBS R5007 150 12 R5008 0 13 NM 14 GNDV GNDD REM KDT0 CSYNC R5010 MONVBS 0 GNDRGB R5021 220 15 R5022 220 GNDV R5023 0 17 NAVI_B NM 18 CSYNC 8 LEDR1 NAVIB NAVIG C5009 NM NAVI_R R5031 9 HDRST R5025 19 10 LEDG1 C5003 NM 20 NAVI_G 11 BH2227AFV F 2/2 R5015 NM NAVI_B 12 GNDP GNDRGB 21 F C5004 22 7 SWVDD33 13 GNDOSD R5011 270 GNDP 23 R5012 270 GNDP 24 R5013 0 GNDP GNDP R5001 200 25 R5002 150 NC R5003 0 26 NM PWRVI 5 6 PWRVI PWRVI R5005 CN501 27 C5001 NM A 3/4 28 PWRVI ANALOG E PWRVI 14 VSS VFS TESTMONI1 DI TESTMONI2 CLK AO3 CSB AO4 VDD NC1 NC2 C5007 ILMB 3 2.2u/10 SWVDD33 RED GREEN 2 3 4 R5028 R5027 R5026 220 220 0 SWVDD33 30 IC5001 SMTX MONRST NM 31 MONRST C5010 NM ILMB SMTX ILMB RGB_LED DRIVER PART MSRX NM 33 MFLPW MSRX NM S_MTX MONRST 32 HDRST MFLPW R5020 34 R5030 36 M_SRX GNDOSD NM C5006 HDRST MFLPWR 35 HDRST C5008 NM GNDOSD 37 REM GNDILM GNDOSD 38 KDT0 GNDILM1 GNDILM 39 KDT1 GNDILM 40 DIMMER TEMPSEN BLERR1 R5141 EPRCK 6 EPRCE 3 PNLADY PNLADX BLERR1 TEMPSEN TOUCHAD C5106 NC 7 EPRDO 4 C5104 1k TOOL1 8 58 COMDC F 2/2 R5145 9 57 COMAC 60 AVss 0.1u/10 SCL 21 SDA 22 25 NC 24 NC 26 TOOL0 56 AVREF1 59 AVREF0 GNDOSD RST GNDOSD 0.1u/10 H H 47k R5137 47k C5110 L UW5 R5136 11 10k GNDOSD VSS1186-A RESET 10 MODEL2 UC,EW5 13 10k R5147 C5108 55 NC R5146 0.01u/16 R5107 MODEL1 54 TSCK 2 XT1 12 470 GNDOSD NM 47 47 R5133 R5132 470 470 R5127 470 BLSYNC VADRES 23 MFLPW 28 XRST 29 EPRST 30 EPRTEST 31 34 NC 33 35 STEST 32 36 PWCTL1 MVIPW 27 FLMD0 MODEL1 H:VAD(IC5601) L:NO VAD(IC5601) MODEL2 H:6.95inch L:5.8inch 53 RXD0/TSI 0 M_VAD MFLPW MVIPW 47k 470 R5121 R5122 R5120 R5123 470 E P R S T R5119 47k PWCTL2 PWCTL1 470 470 470 R5138 R5135 TP5102 0 X2 14 XT2 52 TXD0/TSO 17 X1 15 UPD78F1155AGC(A) TSI R5110 470 R5106 470 TSCK 0 GNDOSD 20MHz X5101 1 3 C5109 MODEL2 18 1u/10 MODEL1 49 19 100k 48 R5151 20 REGC 16 IC5101 PE5669A8 63 R5103 PNLVD 62 47k R5102 COMDC PNLYV 46 Vss0 51 TXD1 0.1u/10 VCOM R5101 COMAC R5408 1M C5404 SMTX PNLADX 1000p/50 GNDOSD 6 C1 5 B2 4 E2 45 Vdd1 Vdd0 Vss1 50 RXD1 TSO 0 PNLXV 0.1u/10 0.047u/10 1 Q5403 E1 2 B1 R5413 3 C2 10k UMF5N 10k R5411 C5401 0.1u/10 C5405 1M C5403 C5402 0.047u/10 1000p/50 R5407 1k 1k MSRX R5406 VADSDA VADSCL R5142 47k 47k G_to_M GtoM R5104 GNDOSD 0 M_to_G MtoG R5105 44 47 NC 47k R5155 C5103 10k R5410 D5401 MA111 R5409 NM FMG12 2 2 1 R5125 R5139 47k R5154 NC 61 UW5 3 3 4 4 5 5 Q5401 6 C1 5 PNLXV B2 4 E2 NC 42 43 (TBD) PNLYV 1 Q5402 E1 2 B1 R5412 3 C2 10k UMF5N 41 PWCTL2 R5156 PWCTL3 NC 40 LEN2 VADRES VADSCL GNDOSD FSEL 39 NC 38 TESTIN 37 F 2/2 PNLVD NM 1 GRST VADSDA 470 GNDOSD 1000p/50 L5401 CTF1473-A R5401 UW5 VADRES GNDOSD 0 PNLADY DDCON 47k 1000p/50 D5405 UDZS5R6(B) C5406 0 ADVY R5404 C TESTIN R5112 F 2/2 F 2/2 TP5101 GRST C5409 PLYV R5403 F 2/2 S T E S T R5117 47k E P R T E S TR5118 UDZS5R6(B) 0 DDS E L F 2/2 1000p/50 D5404 R5109 470 0 PLXV R5402 R5134 GER_M 1000p/50 D5403 PWCTL3 F 2/2 C5407 ADVY ADVX PLYV PLXV D5402 UDZS5R6(B) UDZS5R6(B) C5408 2 BLSYNC C5102 0.1u/10 PWCTL R5130 C5101 10u/6.3 7 NC ADVX 6 ADVY ADVX 5 10 PLXV 4 ADVY PLXV 3 9 PLYV 2 8 NC PLYV 1 GNDOSD ADVX R5405 GNDOSD F L MD 0 CTF1635-A CN5401 B T OOL 1 TOOL1 T OOL 0 TOOL0 L5101 MONRST R S T OU T RSTOUT CN5101 NM SWVDD33 TO TOUCH PANEL 1 F-a 1/2 A F 5 6 7 8 F-b 1/2 CHIP SIZE LEGEND 1608 2125 F 1/2 MONITOR UNIT(uCOM) 3216 3225 A LCD PANELPART BACKLIGHT PART R5201 FAD_14 R5202 FAD_13 R5203 FAD_12 R5204 FAD_11 R5205 FAD_10 R5206 1 0 0 0 FAD_8 R5208 FAD_19 R5209 FAD_20 R5210 FRWE R5211 GRST R5212 FAD_21 R5213 6 0 7 0 8 0 9 0 11 0 12 22 FAD_18 R5215 FAD_17 R5216 R5217 FAD_7 FAD_6 R5218 FAD_5 R5219 FAD_4 R5220 FAD_2 R5222 FAD_1 R5223 18 19 0 20 0 21 0 R5221 FAD_3 17 0 22 0 23 0 24 0 DQ6 A8 DQ13 DQ5 A20 DQ12 WE DQ4 A18 DQ2 A17 DQ9 A7 DQ1 A6 DQ8 A5 DQ0 OE A4 A2 CE A1 A0 44 R5226 43 R5227 42 R5228 41 R5229 40 R5230 39 R5231 38 R5232 CTF1473-A FDATA_15 0 FDATA_7 0 FDATA_14 0 FDATA_6 0 FDATA_13 0 FDATA_5 0 FDATA_12 0 FDATA_4 0 36 R5233 35 R5234 C5203 B 0.1u/10 FDATA_11 0 FDATA_3 0 34 R5235 33 R5236 32 R5237 0 31 R5238 0 FDATA_10 0 FDATA_2 FDATA_9 FDATA_1 0 30 R5239 29 R5240 0 28 R5241 0 FDATA_8 FDATA_0 FROE 0 27 VSS1 A3 45 R5225 37 VCC DQ11 RY/BY DQ10 16 0 A9 WP/ACC DQ3 15 0 DQ14 A21 14 1k DQ7 A10 RESET 13 0 A11 A19 10 0 R5214 DQ15/A-1 A12 5 0 R5207 FAD_9 4 0 FAD_16 46 VSS2 A13 1k 0 47 BYTE A14 3 R5224 48 A16 A15 2 0 FAD_15 4.7u/10 C5201 NM L5201 TEMPSEN DIMMER F 2/2 R5244 IC5201 PEH208A8 MONRST BLERR1 INV_CONT FLASH ROM 5001 5101 5201 5301 5401 5451 5501 5601 5701 6001 6151 6101 R5245 F L MD 0 FLMD0 CONNECTOR PART CON PART FLASH ROM PART SD RAM PART TOUCH PANEL PART C.VIDEO PART DD-CON PART VIDEOA/D IC PART GERDA IC PART C5202 F 2/2 GNDOSD G_FROM FLMDO 10 NC SWVDD SWVDD 7 8 6 9 GND GND 5 GD33V 26 R5242 25 FRCS 0 R5243 FAD_0 0 GNDD L5301 C5303 10u/6.3 G_SDRAM F 2/2 CTF1473-A GD33V C5304 SD RAM 0.1u/10 IC5301 K4S281632K-UC75 SDA_4 OSD 28 R5301 SDA_5 R5302 SDA_6 R5303 SDA_7 R5304 SDA_8 R5305 SDA_9 R5306 SDA_11 R5307 SDCKE R5308 MEMCLK R5309 0 29 0 30 0 31 0 32 0 33 0 34 0 35 R5150 SDM_1 R5310 SDD_8 R5311 SDD_9 R5312 SDD_10 R5313 36 0.1u/10 0 0 37 0 38 0 39 40 41 82 SD R5319 42 0 43 C5301 0.1u/10 82 44 82 SDD_11 R5314 SDD_12 R5315 45 46 82 47 R5320 C5302 82 SDD_13 SDD_14 R5317 A1 A6 A0 A7 A10/AP A8 BA1 A9 BA0 A11 CS N.C CKE RAS CLK CAS N.C/RFU LDQM VSS2 VDD2 VDDQ3 DQ5 DQ10 VSSQ3 VDDQ4 50 51 R5318 82 53 R5334 18 R5335 0 17 R5336 0 SDBA_0 0 SDCS 0 SDRAS SDCAS SDWE SDM_0 0 R5322 0 R5338 SDD_7 82 C5306 0.1u/10 12 R5339 11 R5340 SDD_6 82 SDD_5 82 R5323 0 R5341 C5307 0.1u/10 R5342 SDD_4 82 SDD_3 82 R5343 SDD_2 82 R5344 SDD_1 82 R5324 0 C5308 0.1u/10 3 54 SDBA_1 0 R5337 0 16 4 DQ0 VDD1 DQ15 VSS3 R5333 19 5 VDDQ1 52 20 6 DQ1 DQ14 82 R5332 7 DQ2 SDA_0 SDA_10 0 R5331 21 8 DQ3 VSSQ1 SDA_1 0 22 9 DQ4 DQ12 R5330 10 VDDQ2 DQ11 R5329 0 23 13 DQ6 SDA_2 0 R5328 24 14 VSSQ2 DQ9 SDA_3 0 R5327 25 15 DQ7 DQ8 VSSQ4 SDD_15 WE UDQM C5305 0.1u/10 26 A2 A5 C R5326 27 A3 DQ13 0.1u/10 82 L5302 CTF1382-A VDD3 49 0 R5316 48 VSS1 A4 2 R5325 1 0 D SDD_0 R5345 82 C5309 0.1u/10 GNDD 2 R6101 NM 1 CN5003 P6101 C5017 NM D5001 NM 7.8V 14 REM 13 GNDKEY GNDILM L6101 miniSMDC075F/24 CTH1419-A 3.3uH PWRFL TO KEYBOARD BACKLIGHT PART L6102 4 KDT1 3 ILMB 2 SWVDD33 1 GNDKEY DIMMER 3 4 0.1u/10 OSC Vcc GND BR/CTL Out 7 0.47u/10 1 D1 6 2 D2 TP6101 5 D4 D3 3 G S R6113 0 TK11840L 6 UDZS36(B) C6108 10u/50 120k FB SCP R6107 EaIn 10u/50 C6109 C6111 0.1u/50 R6102 10u/35 NM C6103 C6104 0 2 D% GNDFL 5 4 CPH6424 R6106 GNDOSD2 GNDOSD A2+ 2 NC 3 A1+ 4 NC 5 A1- 6 NC 7 A2- 8 9 10 NC TH TH_G E 1k Q6101 DTC143EUA NM 5.6 R6111 10k GNDFL R6110 R6108 GNDILM2 NM C5011 ILMB F 2/2 GNDFL GNDILM LEDR1 C6102 C6101 R6114 2k C6105 Q6102 60mA setting LEDG1 KDT0 NM C6110 8 A1- 2.7 LEDB1 LEDR2 5 C6107 IC6101 1 A1+ R6109 HDRST 6 E 5.1k SWVDD33 KDT1 LEDG2 R6105 KDT0 LEDB2 7 620 REM 8 R6103 LEDR2 10u/35 LEDG2 LEDR1 INV_CONT LEDB2 9 10u/35 10 LEDG1 D6102 RB050L-60 TO BACKLIGHT 1 CTH1419-A 3.3uH 11 LEDB1 WVDD33 CN6101 A2+ D6101 12 HDRST D% GNDFL 0 R6104 R6112 C6106 330p/50 Basic oscillation frequency 360kHz DTC143EUA Q6103 GNDFL D 3.9k GNDILM GNDFL PWM (CONVERSION 478/528kHz) BLSYNC BLERR1 TEMPSEN F F 1/2 AVH-P4100DVD/XN/UC 5 6 7 8 157 F FLMDO 10 FLMD0 SWVDD SWVDD 8 F L MD 0 9 MONRST F 2/2 INV_CONT BACKLIGHT PART LCD PANELPART CONNECTOR PART CON PART FLASH ROM PART SD RAM PART TOUCH PANEL PART C.VIDEO PART DD-CON PART VIDEOA/D IC PART GERDA IC PART 3216 3225 2125 1608 CHIP SIZE LEGEND 5001 5101 5201 5301 5401 5451 5501 5601 5701 6001 6151 6101 G_FROM F 2/2 F 2/2 R5203 FAD_13 R5207 FAD_9 2 R5213 FAD_21 3 R5304 R5305 R5306 R5307 R5308 R5309 R5310 R5311 R5312 R5313 R5314 R5315 SDA_8 SDA_9 SDA_11 SDCKE MEMCLK SDM_1 SDD_8 SDD_9 SDD_10 SDD_11 SDD 12 R5223 FAD_1 SDA_7 R5222 FAD_2 R5303 R5221 FAD_3 SDA_6 R5220 FAD_4 R5302 R5219 FAD_5 R5301 R5218 FAD_6 SDA_5 R5217 FAD_7 SDA_4 R5216 FAD_17 0 0 0 0 0 0 0 0 0 1k 0 22 0 0 0 0 0 0 0 0 0 0 0 AVH-P4100DVD/XN/UC 4 82 82 82 82 0 0 0 C5301 0.1u/10 R5319 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 VSS2 DQ11 VCC DQ4 DQ12 DQ5 DQ13 DQ6 DQ14 DQ7 0.1u/10 A0 CE VSS1 OE DQ0 DQ8 DQ1 DQ9 DQ2 C5303 10u/6.3 C5304 A1 A2 A3 A4 A5 A6 A7 A17 A18 RY/BY DQ10 WP/ACC DQ3 A21 RESET WE A20 A19 A8 A9 A10 A11 DQ11 VSSQ3 DQ10 DQ9 VDDQ3 DQ4 VDDQ2 DQ5 DQ6 VSSQ2 DQ7 VDD2 VSS2 DQ8 LDQM WE CAS N.C/RFU UDQM CLK RAS CS N.C CKE BA0 BA1 A10/AP A0 A1 A2 A3 VDD3 A11 A9 A8 A7 A6 A5 A4 VSS1 25 26 27 28 29 30 31 GD33V R5243 R5242 R5241 R5240 R5239 R5238 R5237 R5236 33 32 R5235 R5234 R5233 R5232 R5231 R5230 R5229 R5228 R5227 R5226 R5225 R5224 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 0 0 C5307 R5323 0 C5306 0.1u/10 R5322 C5305 0.1u/10 C5202 GNDD 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 L5302 CTF1382-A 0 0 C5201 NM 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 4.7u/10 R5327 0 0 0 0 R5338 R5342 R5341 R5340 R5339 0 82 82 82 82 0 R5337 0 R5336 0 R5335 0 R5334 R5333 R5332 R5331 R5330 0 R5329 0 R5328 0 0.1u/10 R5326 C5203 1k R5244 GD33V SDD 3 SDD_4 SDD_5 SDD_6 SDD_7 SDM_0 SDWE SDCAS SDRAS SDCS SDBA_0 SDBA_1 SDA_10 SDA_0 SDA_1 SDA_2 SDA_3 FAD_0 FRCS FROE FDATA_0 FDATA_8 FDATA_1 FDATA_9 FDATA_2 FDATA_10 FDATA_3 FDATA_11 FDATA_4 FDATA_12 FDATA_5 FDATA_13 FDATA_6 FDATA_14 FDATA_7 FDATA_15 FAD_16 F 1/2 MONITOR UNIT(uCOM) 3 0 0 0 0 0 0 0 0 28 A16 BYTE DQ15/A-1 A12 A13 A14 A15 IC5201 PEH208A8 IC5301 K4S281632K-UC75 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 FLASH ROM SD RAM R5215 FAD_18 R5214 R5211 R5212 GRST R5210 FAD_20 FRWE R5209 FAD_19 R5208 R5206 FAD_10 FAD_8 R5205 FAD_11 R5204 R5202 FAD_12 R5201 FAD_14 F-a F-b FAD_15 D G_SDRAM C L5301 1 L5201 158 CTF1473-A F-b 1/2 0 E R5245 B 2 CTF1473-A 1 4 A TEMPSEN DIMMER BLERR1 7 3 LEDR1 LEDG1 LEDB1 HDRST KDT1 KDT0 ILMB GNDILM2 GNDILM NM C5017 GNDILM SWVDD33 LEDR2 LEDG2 LEDB2 GNDILM TO KEYBOARD NM D5001 NM KDT0 KDT1 5 4 SWVDD33 GNDKEY 2 1 3 ILMB LEDR2 LEDG2 LEDB2 LEDR1 6 7 8 9 10 LEDG1 11 LEDB1 12 HDRST 13 GNDKEY E CN5003 14 REM R5315 R5316 R5317 R5318 SDD_12 SDD_13 SDD_14 SDD_15 TEMPSEN BLERR1 BLSYNC DIMMER F 2/2 R5314 SDD_11 INV_CONT R5313 C6101 SDD_10 82 82 82 82 82 82 82 C6102 R5312 R6101 NM 10u/35 C5301 0.1u/10 7.8V DQ0 VDD1 VDDQ1 DQ1 DQ2 VSSQ1 DQ3 DQ4 VDDQ2 DQ5 DQ6 VSSQ2 DQ7 VDD2 R6114 2k 4 3 2 1 Basic oscillation frequency 360kHz GNDFL WE LDQM 0 0 C5309 0.1u/10 R5325 1 R5324 C5307 0.1u/10 0 R5323 0 C5306 0.1u/10 R5322 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 R5345 82 C5308 0.1u/10 R5344 R5343 R5342 R5341 R5340 R5339 R5338 GND Out Vcc BR/CTL 6 R6113 0 GNDFL TP6101 GNDFL 5 NM C6110 7 0.47u/10 8 C6107 D6101 3 G Q6102 SDWE S D3 D4 4 5 6 SDD_0 SDD_1 SDD_2 SDD_3 SDD_4 SDD_5 SDD_6 SDD_7 SDM_0 DTC143EUA Q6103 CPH6424 2 D2 1 D1 RB050L-60 PWM (CONVERSION 478/528kHz) OSC SCP TK11840L FB EaIn IC6101 L6102 CTH1419-A 3.3uH 82 82 82 82 82 82 82 0 R5337 0 R5336 0 BACKLIGHT PART DQ15 VSS3 VSSQ4 DQ14 DQ13 VDDQ4 DQ12 DQ11 VSSQ3 DQ10 DQ9 VDDQ3 DQ8 VSS2 Q6101 DTC143EUA 0.1u/10 F-a F-b GNDFL 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 C6105 0.1u/10 PWRFL GNDD 0 R5320 C5302 0 R5319 P6101 SDD_9 10u/35 82 NM 2 1 C6103 miniSMDC075F/24 L6101 CTH1419-A 3.3uH C6104 R5311 10u/35 N.C/RFU 0 SDD_8 R6102 UDQM 620 39 R6103 38 C6106 C6111 0 0.1u/50 0 330p/50 10u/50 C6109 1k R6106 GNDFL D% 120k GNDFL D% 10k R5310 5.1k REM C5011 R6105 0 R6107 R6108 SDM_1 R6104 R6112 GNDOSD GNDOSD2 A1- A1+ A2+ NC A2NC TH TH_G 7 8 9 10 NC A16 5 3 4 NC A1+ 2 A2+ CN6101 1 6 D 3.9k 60mA setting 2.7 R6109 6 R6110 5 5.6 5 7 8 TO BACKLIGHT A C6108 UDZS36(B) B C D E F F-b 1/2 AVH-P4100DVD/XN/UC 8 159 R6111 NM 10u/50 D6102 PLXV 5 PLXV 4 PLYV 3 PLYV 2 NC 1 PLYV ADVX 6 PLXV ADVX 7 Q5401 NC CN5401 2 1k 3 4 4 5 5 1 1 R5401 1k 0.047u/10 C5401 C5402 0.047u/10 C5403 C5404 FMG12 1000p/50 R5407 1000p/50 0 GNDOSD PNLVD GNDOSD PNLYV 6 C1 5 PNLXV B2 4 E2 GNDOSD 1 Q5403 6 E1 C1 2 5 B1 B2 R5413 3 4 C2 E2 10k UMF5N L5401 CTF1473-A 1 Q5402 E1 2 B1 R5412 3 C2 10k UMF5N 1000p/50 10k 3 2 R5406 PNLADX 1M R5408 1M R5410 R5411 0.1u/10 R5125 F 2/2 R5139 47k R5154 LEN2 R5156 47k R5155 NM SMTX MSRX COMDC F 2/2 R5102 R5103 COMAC 47k R5101 470 470 0 4.7k F% R5111 TEMPSEN R5107 F 2/2 C5405 NC NC PNLYV PNLVD 45 46 MODEL2 49 TH5101 NM GNDOSD 60 AVss 59 AVREF0 58 COMDC 57 COMAC 56 AVREF1 55 NC 54 TSCK 53 RXD0/TSI 52 TXD0/TSO 51 TXD1 50 RXD1 MODEL1 48 47 NC PNLXV 44 43 (TBD) 42 41 GNDOSD C5105 C5111 0.1u/10 0.1u/10 GNDOSD TSI R5110 470 R5106 470 TSCK 47k 47k G_to_M GtoM R5104 GNDOSD 0 MtoG M_to_G TSO R5105 0 UW5 VCOM R5409 UDZS5R6(B) C5406 D5401 MA111 0 ADVY R5404 C5103 10k 47k GER_M 1000p/50 D5405 C5101 PLYV R5403 GRST GNDOSD F 2/2 10u/6.3 R5112 UDZS5R6(B) 1000p/50 D5404 UDZS5R6(B) C5408 1000p/50 D5403 C5407 D5402 UDZS5R6(B) L5101 0.1u/10 C5409 0 PLXV R5402 0 ADVX R5405 10 C5102 0.1u/10 CTF1635-A 0.1u/10 ADVX ADVY ADVY ADVY 8 TO TOUCH PANEL NM 9 PNLADY R5109 470 DDS E L TESTIN TP5101 F 2/2 PWCTL GRST PWCTL1 UW5 UC,EW5 H L MODEL1 H H MODEL2 MODEL1 H:VAD(IC5601) L:NO VAD(IC5601) MODEL2 H:6.95inch L:5.8inch UPD78F1155AGC(A) IC5101 PE5669A8 17 Vss0 13 9 5 R5153 47k NC 1 NC 2 EPRCE 3 EPRDO 4 EPRDI EPRCK 6 NC 7 TOOL1 8 TOOL0 RESET 10 XT2 11 XT1 12 FLMD0 X2 14 X1 15 REGC 16 18 Vdd1 Vdd0 Vss1 19 20 VADSCL VADSDA VADRES F 2/2 UW5 GNDOSD C5107 0.1u/10 47k R5136 R5137 47k 4 3 2 1k EPRCK EPRDI 7 EPRDO 6 EPRCE 5 R5140 8 1 GNDOSD RST GNDOSD GNDOSD 2 VSS1186-A GNDOSD 20MHz X5101 1 3 0 R5151 M_VAD 4 3 2 1 TOOL1 2 GND TEST NC VCC NM RSTIN 3 5 6 7 8 S-93C56BD0I-J8 DO DI SK TOOL0 R5149 IC5102 CS 1k R5145 10k R5147 10k R5146 VADSCL VADSDA VADRES F 2/2 CN5101 NM C5109 SWVDD33 64 KDT1 T OOL 0 TOOL0 100k 1 T OOL 1 TOOL1 0.01u/16 RSTOUT 4 NC GND 5 GNDOSD GND 6 GNDOSD 0 R5150 GNDOSD MONRST R S T OU T RSTOUT SWVDD SWVDD 8 F-a F-b C5104 PWCTL2 470 65 R5152 KDT0 68 NC 40 61 PWCTL3 R5134 37 TESTIN TP5102 NC 69 DDCON 62 R5108 S T E S T R5117 47k E P R T E S TR5118 STEST 32 NC 70 FSEL 39 NC 38 63 EPRST 30 NC 470 NC 66 47k R5115 67 470 R5116 PNLADY PNLADX BLERR1 TEMPSEN TOUCHAD 470 E P R S T R5119 47k EPRTEST 31 NC 33 470 R5121 R5120 71 R5141 470 36 PWCTL3 470 PWCTL2 R5135 35 R5138 34 PWCTL1 MFLPW R5122 0 XRST 29 NC 72 47 47k MFLPW 28 NC 73 R5130 NC 24 47 R5133 SDA 22 MVIPW R5123 470 R5124 NC 26 DIMMER NM C5106 BLSYNC 470 R5127 470 MVIPW 27 REMIN 74 470 R5126 25 BLSYNC ILMDT 76 ILMCK 77 470 R5131 75 100 R5128 ILMDT 470 R5129 ILMCK 0.47u/10 R5142 R5132 470 VADRES 23 78 100k NM SCL 21 ILMLD NC NC 470 4 ILMLD 1u/10 3 79 AVH-P4100DVD/XN/UC 80 F-a 1/2 R5143 F 3 47k 2 R5144 E R5148 C C5108 B C5110 FLMDO 10 1 FLMD0 160 F L MD 0 F MONRST D 9 F-b 1/2 7 A 2 0.1u/10 1 4 TEMPSEN BLERR1 DIMMER CN501 A 3/4 36 33 S_MTX 31 27 26 25 24 23 22 PWRVI PWRVI NC GNDP GNDP GNDP 19 18 17 NAVI_G NAVI_R CSYNC 9 8 7 6 NC PWRFL PWRFL PWRFL 2 1 GNDFL GNDILM 3 10 GNDD 4 11 GNDD GNDFL 12 GNDD 5 13 GNDV NC 14 GNDFL 15 GNDV MONVBS GNDRGB 16 20 NAVI_B GNDRGB 21 28 PWRVI SWVDD33 29 SWVDD33 30 ILMB MONRST 32 34 M_SRX MFLPWR 35 HDRST GNDOSD 37 GNDOSD 38 PNLAD GNDILM PNLA GNDFL PWRFL GNDD GNDV MONVBS GNDILM GNDFL PWRFL GNDD GNDV GNDRGB NAVI_R GNDV MONVBS CSYNC NAVI_G NAVIR CSYNC GNDRGB NAVI_B NAVIG GNDP PWRVI SWVDD33 ILMB GNDOSD ANALOG NAVIB GNDP PWRVI SWVDD33 ILMB MONRST SMTX MSRX MFLPW HDRST GNDOSD GNDILM1 CN5001 F 2/2 MONRST SMTX MSRX MFLPW R5005 (RED) 10k R5004 HDRST 1 E1 2 B1 3 C2 Q5001 UMX1N (GREEN) 10k R5014 470 470 (BLUE) 10k R5024 Q5002 2SC4081(QR) (RED) 10k R5009 GNDOSD 1 E1 2 B1 3 C2 RGB_LED DRIVER PART 4.7k 4.7k 47k R5153 Q5003 UMX1N 6 C1 5 B2 4 E2 BLUE GREEN RED NM C5005 (GREEN) 10k R5019 GNDOSD 7 6 5 4 3 2 1 GND DO 10k (BLUE) 5 6 8 9 10 11 12 13 14 S-93C56BD0I-J8 TEST DI Q5004 2SC4081(QR) R5029 BH2227AFV VFS TESTMONI1 DI TESTMONI2 CLK AO3 CSB AO4 VDD NC1 NC2 AO2 47k VSS R5144 IC5001 NM AO1 4 0.1u/10 C5110 LEDR2 LEDG2 LEDB2 0 R5031 SWVDD33 GNDOSD LEDR1 LEDG1 LEDB1 HDRST KDT1 KDT0 REM 7 F-a F-b 6 C1 5 B2 4 E2 R5114 R5113 C5105 C5111 0.1u/10 0.1u/10 GNDOSD R5152 R5025 GNDILM 39 NM 4.7k F% NM GNDILM 40 C5001 NM REM C5009 NM TOUCHAD R5001 200 R5002 150 R5003 0 R5011 270 R5012 270 R5013 0 R5021 220 R5022 220 R5023 0 R5111 C5003 NM R5124 R5010 TH5101 NM NM R5108 R5015 NM 47k R5115 KDT1 470 R5126 470 R5116 KDT0 100 R5128 ILMDT 470 R5131 470 ILMCK TEMPSEN R5020 R5129 C5002 NM NM R5143 NM 470 R5007 150 R5008 0 C5007 3 2.2u/10 GNDOSD R5030 ILMLD R5006 200 R5017 R5016 270 270 R5018 0 NM C5006 C5008 NM 7 NM 6 C5010 NM 5 6 R5028 R5027 R5026 220 0 220 5 8 F-b 1/2 AVH-P4100DVD/XN/UC F-a 1/2 8 161 A B C D E F C5004 1 2 3 4 10.10 MONITOR UNIT(MONITOR)(GUIDE PAGE) F-a 2/2 A VCC3.3V R5736 LVSY R5737 270 0 R5704 NM R5715 LB1 R5716 LB2 R5717 C5707 LB3 0.1u/10 3.3k C5706 R5703 LB0 LB4 180 180 LB5 R5720 LG0 R5721 LG1 R5722 LG2 R5723 LG3 R5724 180 180 180 180 180 180 C5724 1u/6.3 R5748 0 C5731 0.1u/10 VCC3.3V 216 1 80 C5619 0.1u/10 4 VCC15V R5794 R5796 R5798 SDD_12 SDD_11 SDD_10 SDD_9 68 R5792 SDD_13 LR2 VAD_GERDA F 1/2 3 DVG_4 VDD3_15 215 DVG_4 DVG_3 LCD_G_3 VSS_17 LCD_G_4 LCD_G_5 LCD_R_0 LCD_R_1 CTF1748-A DVG_3 DVG_5 C5736 LCD_G_2 214 DVG_2 150 LCD_G_1 213 DVG_1 DVG_2 LCD_G_0 210 DVG_0 150 LCD_B_5 209 DVB_5 DVG_1 LCD_B_4 208 C5620 0.1u/10 150 LCD_B_3 207 DVB_4 DVG_0 LCD_B_2 206 DVB_3 150 LCD_B_1 205 0 DVR_5 LCD_B_0 204 DVB_2 150 DVR_4 LCDICLK 203 DVB_1 150 DVR_3 VDD_7 L5725 2 1 L5726 2 1 L5727 2 1 L5728 2 1 L5603 C5621 10u/6.3 DVDD4 DVSS4 GOUT7 150 VSS_16 212 GNDD 150 VDD3_14 200 CTF1748-A L5711 2 201 1 L5712 2 202 1 DVG_5 R5619 0 DVR_0 DVR_1 DVR_2 DVR_3 150 LCDCLK 199 AVH-P4100DVD/XN/UC 2 150 LCDVSY 198 DVB_0 R5620 DVR_1 C5732 1u/6.3 R5784 0 C5733 0.1u/10 DVR_2 LCDHSY 197 L5721 2 1 L5722 2 1 L5723 2 1 L5724 2 1 150 150 R5772 DVVSY 150 R5775 DVHSY 150 R5778 DVCLK 220 DVR_0 162 LCDDEN 196 211 R5725 180 R5726 180 R5727 180 R5728 180 161 DVVSY 160 DVHSY DVCLK 159 R5781 DVR_0 158 R5783 DVR_1 157 VDD3_12 156 VSS_14 155 R5787 DVR_2 154 R5789 DVR_3 153 R5791 DVR_4 152 R5793 DVR_5 151 R5795 DVG_0 150 R5797 DVG_1 149 R5799 DVG_2 148 R5801 DVG_3 147 R5803 DVG_4 146 R5805 DVG_5 145 LCDCSY 195 1 79 77 78 NC5 NC6 76 ROUT1 ROUT0 75 74 ROUT2 R5612 0 DVR_4 DVCLK DVHSY DVVSY M_VAD GNDD DVR_5 C5616 R5623 VADRES NAVI_G 0.1u/10 CSYNC 1 LCDCE 194 2.2k F 1/2 GPIO_04 193 L5713 2 1 L5714 2 1 L5715 2 1 L5716 2 1 L5717 2 1 L5718 2 1 L5719 2 1 L5720 2 1 R5718 180 R5719 180 GPIO_05 192 21 AVSS5 AVDD1 39 R5608 0 TEST R5609 38 BIAS 37 6.8k (F) AVSS4 36C5615 0.1u/10 PVDD3 R5611 35 PVDD2 34 0 FLT 33 AVSS3 32 R5613 VSYNC 31 R5614 0 HSYNC 0 30 R5615 COAST 29 0 AVSS2 28 PVDD1 R5616 27 C5617 0 0.1u/10 TEST2 26 AVSS1 R5617 25 CLAMP 0 24 R5618 DVDD2 0 DVSS2 23 NC4 22 C5618 0.1u/10 73 60 72 C5610 0.1u/10 GNDRGB ROUT3 47k R5602 59 ROUT4 58 BYPASS AVDD7 AVSS11 ROUT5 0 SDA 71 R5607 MONVBS 57 SCL 70 R5622 2.2k VIDEO_AD A0 69 C5606 0.1u/10 ROUT7 VADSDA RIN ROUT6 56 AVSS10 DVDD3 55 2.2k AVDD6 DVSS3 54 AVDD5 68 53 IC5601 AK5406XQ 67 52 0.1u/10 AVSS9 66 C5609 51 SOGIN DTCLK 0 GIN 65 R5606 AVSS8 HSYNCO 50 AVDD4 RESETN VSYNCO SONGOUT 49 AVDD3 64 48 AVSS7 63 47 1000p/50 C5623 100p/50 45 46 C5601 ANALOG 44 20 NC3 BOUT0 19 BOUT1 18 BOUT2 17 BOUT3 16 BOUT4 15 BOUT5 14 BOUT6 13 BOUT7 12 DVDD1 11 DVSS1 10 NC2 9 NC1 8 GOUT0 7 GOUT1 6 GOUT2 5 GOUT3 4 GOUT4 GOUT5 3 GOUT6 2 AVSS6 AVDD2 BIN 62 0 C5603 0.1u/10 R5621 (3528) C5612 0.1u/10 42 61 R5605 VADSCL 40 47u/10_Ta (3528) 41 0 2.7k 0.082u/10 C5607 0.1u/10 R5604 C56080.1u/10 C5604 0.1u/10 8200p/16 C5613 R5610 GNDRGB 43 162 270 LCDMUTE 191 0 L5706 2 1 L5707 2 1 L5708 2 1 L5709 2 1 L5710 2 1 CTF1635-A C5614 C5611 47u/10_Ta NM C5622 C5602 0.1u/10 F 2/2 270 R5738 180 C5722 1u/6.3 R5746 0 C5729 0.1u/10 C5723 1u/6.3 R5747 0 C5730 0.1u/10 LR0 V33A L5601 CTF1473-A C5605 E NAVI_R 150 MCKSL 190 GD33V L5602 CTF1473-A NAVI_B 22 R5751 0 NM R5808 LHSY NM R5750 68 R5735 22 VDD3_13 150 LDEN 189 VSS_15 188 R5806 R5734 R5749 VDD_6 187 150 LCSY LR1 F R5732 R5733 LG5 GNDV 0 R5731 TSTC0 186 R5804 GNDD CSS1778-A 9.597MHz C5703 C5701 C5460 33u/10_Ta C5459 0.1u/10 2.7k 12p/50 0 2SA1576A(QRS) 47p/50 R5466 68p/50 R5469 12p/50 TC7SHU04FUS1 R5701 390 R5467 L5453 27u (2520) 4 R5702 22 AVAGND F 1/2 0 LCE LG4 UW5 10k TSTC1 185 SDCKE GND0 OUTY TSTCK 184 68 INA 5 OSCXO R5800 Vcc X5701 Q5452 C5458 47p/50 0 C5455 680 33k R5462 6.8k D% L5452 22u (2520) 470 R5460 R5458 R5463 R5455 C5457 5p/50 Q5451 2SC4081(QRS) C5456 D% NC 1M 15k R5459 C.VIDEO 0.1m (2520) D L5454 3 10u/6.3 10k 10k 183 R5802 2 VCC3.3V 4.7k 0 C5720 R5744 1u/6.3 0 C5727 0.1u/10 C5721 1u/6.3 R5745 0 C5728 0.1u/10 LCLK 1 C5453 0 SDM_1 NJM2505AF R5457 R5714 EXTRG0 GD33V OSCXI 182 SDD_8 AVAGND IC5701 PMODE0 68 R5710 R5713 AVAGND AVCLK 180 R5788 68 68 1 TSTIO SDD_14 VGND Vout 5 2 AVDD_2 178 68 3 DAOUT 177 R5786 V+ GND 10u/6.3 100 Vin 4 0 R5785 10u/6.3 C5452 AVSS_2 176 SDD_15 100 R5454 R5730 1M R5709 R5712 0.1u/10 C5451 NM R5708 GNDD LEN CTF1379-A 0 R5461 R5453 C5454 0 NM R5452 R5451 L5703 AVBGND R5711 VCC53V L5451 IC5451 CLL 175 181 R5468 NM R5740 470 68 R5705 6p/50 100 CSS1634-A 33MHz GNDD UW5 CLH 174 68 GND AVSS_1 180 GNDP 6p/50 C5705 GNDD GNDFL 173 6.2k 179 R5706 NM 2.7k 172 180 GNDILM 47u/10_Ta C5702 NM 171 C5704 X5702 GNDRGB GNDD C5014 C5717 0.01u/16 NM 1000p/50 C5013 R5464 C5012 C5016 0.047u/25 7.5k R5742 R5743 R5790 C5735 0.1u/10 0 470 V33A AINP1 170 R5741 R5707 AINP0 169 C5734 1u/6.3 47u/10_Ta C5713 1u/16 C5529 NM C5523 L5701 CTF1635-A AVAGND AVAGND GNDV 1u/6.3 AVDD_1 168 R5729 0 1u/6.3 C5711 F 1/2 167 R5780 GNDRGB GNDP 10u/6.3 C5710 0.8Vp-p(max1.0V) 166 R5771 R5774 180 R5777 180 AVAGND NM 10u/6.3 C5709 IREF VCMO VREFH VREFL 165 L5704 0.1u/10 NM C5708 PWCTL1 164 LR4 GNDD 0.1u/50 NM GNDP L5702 CTF1635-A CTF1748-A V33A 163 0.1u/10 LR3 AVBGND NM F 1/2 R5038 C5015 R5533 15k C5718 C5715 0.1u/10 C5716 68p/50 C 0 R5035 R5739 (D) 12k GNDP LCD_R_2 4 LCD_R_3 LCD_R_4 5 LCD_R_5 SDDATA_15 6 SDDATA_14 7 SDDATA_13 8 VSS_1 9 VDD3_1 10 SDDATA_12 11 SDDATA_11 12 SDDATA_10 13 SDDATA_9 14 SDDATA_8 15 SDM_1 16 SDCKE 17 MEMCLK 18 0 R5920 10k 10k R5921 10k GNDD C5714 NM R5034 DCG 3 C5551 NM 4.7u / 25V C5712 R5033 PWCTL VCC15V CCG1222-A 33p/50 R5032 5 UW5 2 R5526 2 RB548W R5527 R5529 R5919 -16.3V (2016) C5550 UC,EW5 -16V L5509 CTF1635-A 1u/16 1 3 0.1u/50 C5549 C5719 C5542 1u/16 2 0.1u/10 D5507 CVIDEO DCG3 E1 1 R5568 B1 2 4.7k C2 3 6 4 VAD_GERDA C5726 0.1u/10 1 47k 7.5k D% D% PWCTL NM E2 22k 0.1u/10 0.1u/50 C5548 2 VCCM16V D5506 3 PWCTL3 1000p/50 C5531 R5039 B2 R5567 22k F 1/2 C5725 1 3 0.1u/50 AVAGND C5559 NM C5018 NM 0 10k R5538 C5560 0.1u/16 1u/16 H:500kHz L:454.5kHz DDCON D5508 NM Q5562 C1 R5566 UMZ1N D5505 RB548W C5540 10k D% 47k GNDP C5541 2SC4097(R) Q5504 0 R5522 R5524 NM D5510 GNDP R5040 B2 GNDP R5528 C5554 R5534 6.8k R5565 B1 4 4.7k C2 GNDP GNDP 2SA1577(QR) Q5503 0.1u/50 C5534 C5538 4.7u/16 R5564 5 R5563 3 22k DCG2 C1 6 2 E2 22k CTF1748-A R5525 62k D% 3.3k D% 12k D% C5537 GNDP 0.01u/50 47 D5511 NM 0 UW5 PWCTL2 1u/25 R5523 15.0V (2012) max100mA 1u/25 C5545 NM R5535 MVIPW R5036 0 R5561 F 1/2 15V C5555 1u/25 2 D5504 RB548W 47 D5509 NM R5532 0 R5530 220k D% 1 3 C5553 1u/16 NC1 2 1 4700p/50 L5510 DTL1096-A C5547 C5536 48 0.1u/50 C5544 2 36 34 3 DCG1 Q5561 1 E1 R5562 PWCT2 PWCTL3 PWCTL2 R5037 3 PWCTL3 1 GNDP CTF1635-A (2016) C5507 0.1u/10 0.1u/50 4700p/50 5.3V GNDP 2 4 GNDP 1u/16 0.01u/50 EN4 EN3 OUT3 23 PVCC3 25 C5535 EN5 VREF 22 24 FB3 1 5 R5515 10k D5503 RB548W C5533 35 SS2 21 0.039u/50 IC5501 BD6171KV INV2 6 R5536 1k UMX2N C5543 CCH1586-A_Po 33u 10V D5502 C5539 RB160M-30 RSQ035P03 S 4 D3 5 D4 6 C5528 0.01u/50 G 3 D2 2 D1 1 Q5502 CL1 12 PVCC1 11 R5519 15 OVT1 10 C5525 VREGB 9 C55261u/16 LGND 1000p/50 8 OUT2 7 15 PVCC2 6 CL2 5 VS2 4 VREGA OCPC2 3 FB2 20 C5513 DCH1201-A 10u 10V R5512 R5509 2.2k 510 (D) (D) GNDP R5514 0 L5504 53V SS1 EN2 R5507 0.1u/16 INV1 17 EN1 27p/50 200 VCC53V 16 C5517 C5512 C5532 1u/16 PVCC4 47 OUT4 46 FB4 45 PGND4 44 RT 43 FIN 42 VCC 41 PVCC 40 PGND5 39 FB5 OUT5 38 PVCC5 37 FB1 0.039u/5018 GNDP 19 0.033u/16 C5558 15 33 6.8k (D) 0 5.1k VS1 OCPC1 14 32 R5508 C5508 200 4700p/25 R5502 R5505 R5501 56k V03DET 26 V01DET 27 V02DET 28 V04DET V05DET 29 SVBGND 30 31 GND 6800p/25 1k (D) C5503 33u/10_Ta (3528) B 13 V32 C5518 3.3k 0.01u/50 C5515 68p/50 0.015u/16 R5516 C5557 3k C5516 R5517 C5514 1k / C5502 0.1u/10 200 10k C5511 0.1u/50 R5521 1000p/50 GNDP D% D% R5510 R5513 D% R5506 R5537 10k +15V -16V Discharge Part Q5505 IMZ4 C5530 R5520 C5556 22k R5511 C5527 10u 50V CCG1223-A (10u) TP5501 C5520 0.1u/50 R5518 0 CCG1223-A C5521 10u CCG1223-A C5522 D5501 68uH L5507 CTH1318-A L5501 18uH CTH1250-A R5504 L5508 CTF1635-A (2016) C5546 1 Q5501 6 D1 D4 2 5 D2 D3 3 4 G S RSQ035P03 0.01u/50 C5519 0.1u/50 C5510 RSX201L-30 L5505 DTL1136 68u C5509 6.3V CCH1440-A_Po GNDP 3.3V GNDP NM C5506 1u/6.3 0 R5503 C5504 1u/6.3 V33A 8.0V GNDP GNDP V33A 8V VCC8V C5552 3.3V RB548W L5502 CTH1249-A 10uH CTF1488-A (3216) C5524 GD33V L5503 CTH1249-A 10uH/0.61A C5505 DCH1201-A 10u / 10V 3.3V C5501 DCH1201-A 10u / 10V GD33V POWER SUPPLY MAX2.0A 501 L5506 PWRVI LR5 3.3V VCC33 BACKLIGHT PART 5 6 68 67 66 65 64 63 62 0 61 60 R5915 59 R5916 58 R5917 57 R5918 56 CHIP SIZE LEGEND 1608 2125 3216 3225 COMDC F 1/2 0 0 0 0 COMAC LCE R6157 LR3 FAD_5 LR4 LR5 LCSY FAD_6 FAD_7 VCC53V FAD_8 L6005 FAD_10 FAD_11 FAD_9 CTF1635-A FAD_12 FAD_13 LCLK FAD_15 FAD_16 L6006 FAD_17 DTL1096-A C5764 1u/6.3 R5877 0 C5770 0.1u/10 FAD_18 FAD_20 VCC15V FAD_21 L6007 55 F 1/2 VCC8V R6161 15k Q6151 RUE003N02 1k D% R6155 R6154 1k COMDC VCCM16V 1 2 10k 3 4 GNDD R6158 7 A:OUT A:-IN VCTF1635-A DTL1096-A L6008 0 COMAC 4.7u/6.3 IC6151 C6158 B:OUT V+ A:+IN B:-IN B:+IN GNDD NJM082BV 8 7 6 5 1k GNDD LDEN R6038 LVSY G_SDRAM R6025 100 NM GNDD LVSY GNDD GNDD 10u D% Q6002 2SC4097(R) 1 R6160 E 2 3 C R6152 3.9k D% R6153 TP6003 0 69 FAD_4 1u/16 70 LR2 1u/25 71 FAD_3 C6027 72 LR1 R6029 73 LR0 FAD_2 C6026 74 FAD_1 0 75 0 C5762 1u/6.3 R5872 0 C5768 0.1u/10 C5763 1u/6.3 R5876 0 C5769 0.1u/10 R5903 0 R5904 0 R5905 0 R5906 0 R5907 0 R5908 0 R5909 0 R5910 0 R5911 0 R5912 0 R5913 R5914 0 LG5 20 76 FAD_0 R6041 77 0 LHSY 82 0 R6032 R6022 15 0 R6021 R6020 D% 0 R5902 LG4 C1 78 0 FRWE Q6003 2SA1577(Q) R5901 0 LG3 Q6001 UMZ1N 79 0 FRCS 0 R5900 0 LG2 33k 80 0 LHSY R6042 R5899 0 LG1 1k 81 FROE R6026 R5898 0 0.1u/10 82 FDATA_15 R6040 FAD_20 FAD_21 FAD_22 VSS_5 R5897 LG0 0 FAD_19 83 LB5 B2 FAD_18 R5896 LB4 5 VSS_6 84 LB3 6 VDD3_5 R5895 LB2 FDATA_14 R6049 FAD_17 85 0 LB1 FDATA_13 R6027 FAD_16 R5894 LEN2 FAD_15 86 FDATA_12 R6030 FAD_14 87 C5760 R5874 C5766 C5761 R5875 C5767 R5893 0 1u/6.3 0 0.1u/10 1u/6.3 0 0.1u/10 E2 FAD_13 88 0 4 FAD_12 89 0 3 C2 2 B1 1 E1 FAD_11 90 0 10k FAD_9 R5892 0 FAD_8 R5891 91 LB0 0.1u/10 FAD_10 R5890 92 FDATA_11 0.1u/50 FAD_7 93 0 20k FAD_6 R5889 4.7k VDD3_6 94 0 R6047 VSS_7 R5888 0 4.7k VDD_3 95 0 FDATA_7 1.8k FAD_5 R5887 0 FDATA_6 5.6k 5.1k R6048 R6046 FAD_4 96 FDATA_5 R6050 R6028 FAD_3 R5886 1u/6.3 0 0.1u/10 R6045 R6044 FAD_2 97 FDATA_3 C6022 FAD_1 R5885 FDATA_2 (3528) FAD_0 98 FDATA_1 DCH1201-A C6023 FRWE GRST 0.33u/50 C6024 FRCS R5884 FDATA_0 NM R6043 D6001 FROE F 1/2 0.1u/50 FDATA_15 99 0 C6017 22u/16_Ta VDD3_7 100 C5759 R5873 C5765 R5883 C6018 10u 10V VSS_8 101 C6019 VDD_4 39 R6018 CTF1473-A L6004 56 R6019 C6010 0.1u/10 47 12 R6017 R6016 CTF1306-A 680 R6001 LCE2 C6156 22u/16_Ta (3528) FDATA_14 GNDD C6020 25V FDATA_13 C5758 47u/10_Ta TC74VHCT04AFTS1 C6025 FDATA_12 0 TRCD0 82 15 R6015 R6014 160 R6013 C6012 DCH1201-A 10u / 10V R6010 0 10 R6011 VCC53V 18 0 R6008 L6001 CTF1306-A R6012 8 4Y 4.7u FDATA_11 102 0 GND7 CCG1222-A FDATA_10 R5882 9 4A C6155 FDATA_9 103 0 105Y 3Y6 0.1u/10 FDATA_8 R5881 3A5 3k D% FDATA_7 R5880 104 0 115A R6151 FDATA_6 105 0 126Y 2Y4 NM VDD3_8 R5879 136A 2A3 C6152 FDATA_5 G_FROM 0 L5705 C5754 10u/6.3 R5865 C5755 10u/6.3 TRCD1 TRCD2 TRCD3 IC6005 0.1u/10 VSS_9 R5878 106 14Vcc 1Y2 0.1u/50 FDATA_4 107 C6014 FDATA_3 C6015 108 1A1 0.1u/50 1k NM C5756 10u/6.3 R5869 0 C5757 0.1u/10 109 110 111 112 113 114 115 R5862 NM NM NM GNDD 0.1u/10 VSS_10 FDATA_0 FDATA_1 FDATA_2 C6013 VDDP_0 VOUT_2 VOUT_1 VOUT_0 VDDP_1 VDDP_2 RON GPIO_08 117 R5858 118 R5856 119 R5854 116 R5860 VCCM16V GRST TRCD0 SCLOCK SDATA TRCCLK TRCST TRCD1 TRCD2 TRCD3 EXTRG0 VCC15V 14 13 12 11 10 9 8 7 6 5 4 3 2 1 NM C6154 CCG1222-A 4.7u C6016 SDDATA_4 SDDATA_3 SDDATA_2 SDDATA_1 SDDATA_0 VSS_4 VDD3_4 SDDATA_5 GPIO_09 C5750 1u/6.3 R5851 0 C5751 0.1u/10 GD33V NM 54 53 52 51 50 49 48 SDDATA_6 120 NM F 1/2 10k 46 47 VSS_11 VDD3_9 GPIO_10 GPIO_11 121 NM 10k DCG4 R5569 D% R6156 C5753 0.1u/10 C5752 1u/6.3 R5863 0 SDDATA_7 SDM_0 SDWE SDCAS SCLOCK 124 122 R5848 123 R5846 M_to_G 47k TRCCLK TRCST DCG3 C6153 68 68 68 68 68 LCE 68 68 68 43 45 44 GERDA R5871 R5870 R5868 R5867 82 150 150 IC5702 MN103SE60PUB SDD_0 SDD_1 SDD_2 R5866 R5861 R5859 R5857 SDRAS SDATA DPSEL GPIO_01 10k 1k 1k G_to_M R5752 10k SDD_3 R5853 R5855 42 SDAD_10 SDBA_0 SDCS 125 R5843 126 R5841 127 R5839 128 R5837 NM 10k R5850 SDD_4 SDD_5 SDD_6 SDD_7 SDM_0 39 41 40 GPIO_00 RXD0 TXD0 129 R5835 NM NM SDWE C5748 1u/6.3 C5749 0.1u/10 VDD_2 VSS_3 VDD3_3 GPIO_02 GPIO_06 130 R5833 0 R5840 150 R5842 0 38 37 36 35 SDBA_1 SDAD_0 GPIO_03 131 R5831 C5744 1u/6.3 R5829 C5745 0.1u/10 R5824 1k GER_M SDCAS R5852 150 150 150 150 34 SDAD_1 VDD_5 132 133 134 DVB_5 DVB_4 6.8k R5570 NM R5847 SDRAS R5849 SDCS SDA_10 R5845 SDBA_0 R5844 SDBA_1 33 XRST VSS_12 VDD3_10 10k 1000p/50 C5742 1u/6.3 R5826 0 C5743 0.1u/10 GRST 47k SDA_0 R5838 C5746 1u/6.3 0 C5747 0.1u/10 SDAD_2 SDAD_3 SDAD_4 SDAD_5 135 150 10k 150 UMZ1N 32 31 30 29 INTR 137 R5820 138 R5818 139 R5816 136 R5822 DVB_3 DVB_2 DVB_1 NDP SDA_1 150 R5830 150 R5832 150 R5834 150 R5836 150 150 DVB_4 DVB_5 GPIO_07 150 C5771 SDA_2 R5828 SDAD_6 SDAD_7 SDAD_8 SDAD_9 150 150 150 DVG_4 DVG_3 DVG_5 C5736 1u/6.3 0 R5807 C5737 0.1u/10 DVB_0 47k R5827 28 27 26 25 24 140 R5814 141 R5813 142 R5811 143 R5809 144 150 DVG_2 UMX2N R6159 SDA_5 C5740 1u/6.3 R5815 C5741 0 0.1u/10 DVB_3 DVB_2 DVB_1 DVB_0 VSS_13 145 150 R5564 SDA_3 150 150 150 150 VDD3_2 VSS_2 VDD_1 SDAD_11 SDAD_12 VDD3_11 DVG_5 146 R5805 DVG_1 6.8k R5565 SDA_4 R5825 R5823 R5821 R5819 R5817 23 22 21 20 19 MIMCLK MEMCLK DVG_4 150 DCG1 C6151 5001 5101 5201 5301 5401 5451 5501 5601 5701 6001 6151 6101 SDA_6 SDA_7 150 C5738 1u/6.3 R5812 C5739 0 0.1u/10 18 SDCKE 147 R5803 148 R5801 CN5701 0.1u/50 CONNECTOR PART CON PART FLASH ROM PART SD RAM PART TOUCH PANELPART C.VIDEO PART DD-CON PART VIDEOA/D IC PART GERDA IC PART SDA_8 R5810 0 68 17 DVG_3 UW5 VCOM LCD PANELPART SDA_9 SDA_11 MEMCLK R5808 150 SDM_1 DVG_0 E1 1 R5568 B1 2 4.7k C2 3 R5806 16 15 150 DVR_5 DVR_4 DCG2 150 149 R5799 150 150 DVR_3 B1 4 4.7k C2 R5804 R5802 DVG_2 150 150 5 R5563 SDCKE SDM_1 SDDATA_8 150 R5797 151 R5795 152 R5793 153 R5791 4 14 DVG_1 DVG_0 DVR_5 DVR_4 Q5562 68 SDDATA_9 SDDATA_10 SDDATA_11 SDDATA_12 5 R5800 13 12 11 10 6 68 68 R5790 C5735 0.1u/10 0 R5784 0 C5733 0.1u/10 DVR_2 C1 SDD_8 R5798 68 68 150 150 C1 6 SDD_9 R5796 R5794 154 R5789 155 R5787 156 B2 R5792 DVR_3 DVR_2 VSS_14 VDD3_12 E2 VDD3_1 VSS_1 SDDATA_13 SDDATA_14 B2 9 8 7 Q5561 SDD_10 C5734 1u/6.3 E2 SDD_11 68 R5788 68 68 R5786 E1 SDD_12 SDD_13 6V ge Part 6 7 GNDD D% FDATA_4 LCE EXTRG0 FDATA_8 FDATA_9 FDATA_10 LB0 48 V10 LB1 47 B0 LB2 46 B1 LB3 45 B2 LB4 44 B3 LB5 43 B4 LG0 42 B5 LG1 41 G0 LG2 40 G1 LG3 39 G2 LG4 38 G3 LG5 37 G4 LR0 36 G5 LR1 35 R0 LR2 34 R1 LR3 33 R2 LR4 LR5 LCSY 32 R3 R6037 31 R4 0 30 R5 GNDLCD 29 LS 28 27 GND 26 NC LCLK FAD_14 VCC3.3V F 1/2 FAD_19 LEN LDEN R6039 0 5 3 1 AVH-P4100DVD/XN/UC 8 LBR 25 VSHA 9 MODE 8 CLS 7 U/L TO LCD MODULE SDD_14 5 8 F-b 2/2 F 2/2 MONITOR UNIT(MONITOR) A GD33V D% F% D% F% D% F% B D% D% D% CN6001 60 GND 59 SPL 58 V0 57 NC 56 NC 55 V3 54 NC 53 V5 52 NC 51 V7 50 NC 49 V9 C 24 VSHA 23 NC 22 GND 21 GND 20 CLD D 19 GND 18 NC 17 VSHD 16 VCC 15 SPR 14 NC 13 VDD 12 NC 11 GND 10 CS 6 SPS 4 VEE NC NC COM 2 VCOM VCOM VCCM16V E B R6031 10 0 VCOM PART F F 2/2 163 4 5 6 UMZ1N Q5562 DVR_4 DVR_3 UW5 2 2 1 MX2N B1 4 4.7k C2 5 R5563 C1 6 DCG1 DVG_0 47k E1 1 R5568 B1 2 4.7k C2 3 47k 6.8k R5570 DCG4 R5569 6.8k R5565 R5564 DCG3 DCG2 DVG_1 Part DVR_5 VCCM16V DVB_1 5561 DVG_2 150 DVR_2 155 R5787 150 154 R5789 DVR_2 150 153 R5791 DVR_3 150 152 R5793 DVR_4 150 151 R5795 DVR_5 150 DVG_0 150 R5797 150 149 R5799 DVG_1 148 R5801 DVG_2 DVG_4 150 GER_M F 1/2 GD33V DVB_5 VCC15V 150 DVG_3 150 147 R5803 DVG_3 146 R5805 DVG_4 145 DVG_5 144 VDD3_11 143 R5809 DVB_4 150 DVG_5 C5736 1u/6.3 0 R5807 C5737 0.1u/10 DVB_0 VSS_13 142 R5811 150 DVB_0 DVB_2 141 R5813 150 DVB_1 DVB_3 140 R5814 150 DVB_2 137 R5820 150 2 4 C5771 1000p/50 135 150 DVB_3 139 R5816 DVB_4 138 R5818 DVB_5 1 C5742 1u/6.3 R5826 0 C5743 0.1u/10 GRST 10k 12 NM R5840 10k R5850 3 FDATA_9 FDATA_8 FDATA_7 FDATA_6 FDATA_5 VDD3_8 VSS_9 FDATA_4 FDATA_3 VSS_10 FDATA_0 FDATA_1 FDATA_2 109 AVH-P4100DVD/XN/UC 4 VDD3 6 VSS_7 VDD_3 FAD_5 FAD_4 FAD_3 FAD_2 FAD_1 FAD_0 FRWE FRCS FROE FDATA_15 VDD3_7 VSS_8 VDD_4 FDATA_14 FDATA_13 FDATA_12 FDATA_11 FDATA_10 GD33V R5881 104 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 1u/6.3 0 0.1u/10 0 0 0 0 0 0 0 0 0 0 1u/6.3 0 0.1u/10 1u/6.3 0 0.1u/10 0 0 0 0 0 0 0 0 0 0 0 0 0 0 0 C5762 1u/6.3 R5872 0 C5768 0.1u/10 C5763 1u/6.3 R5876 0 C5769 0.1u/10 R5902 R5901 R5900 R5899 R5898 R5897 R5896 R5895 R5894 R5893 C5760 R5874 C5766 C5761 R5875 C5767 R5892 R5891 R5890 R5889 R5888 R5887 R5886 R5885 R5884 C5759 R5873 C5765 R5883 R5882 R5880 103 R5879 R5878 105 C5758 47u/10_Ta 106 107 108 L6001 CTF1306-A 8 4Y FAD_5 FAD_4 FAD_3 FAD_2 FAD_1 FAD_0 FRWE FRCS FROE FDATA_15 FDATA_14 FDATA_13 FDATA_12 FDATA_11 FDATA_10 FDATA_9 FDATA_8 FDATA_7 FDATA_6 FDATA_5 FDATA_4 FDATA_3 FDATA_2 FDATA_1 FDATA_0 GRST LCE2 TC74VHCT04AFTS1 9 4A 105Y 3Y6 3A5 GND7 F 1/2 GNDD 126Y 2A3 115A 136A 2Y4 14Vcc 1Y2 IC6005 1A1 EXTRG0 LCE D% F% D% F% D% F% D% D% D% D% D% LCSY LR5 LR4 LR3 LR2 LR1 LR0 LG5 LG4 LG3 LG2 LG1 LG0 LB5 LB4 LB3 LB2 LB1 LB0 LHSY LCSY LR5 LR4 LR3 LR2 LR1 LR0 LG5 LG4 LG3 LG2 LG1 LG0 LB5 LB4 LB3 LB2 LB1 LB0 GNDD R6037 28 LBR 29 LS 30 R5 31 R4 32 R3 33 R2 34 R1 35 R0 36 G5 37 G4 38 G3 39 G2 40 G1 41 G0 42 B5 43 B4 44 B3 45 B2 46 B1 47 B0 48 V10 49 V9 50 NC 51 V7 52 NC 53 V5 54 NC 55 V3 56 NC 57 NC 58 V0 59 SPL 60 GND CN6001 3 GERDA 11 10 GNDD F 2/2 MONITOR UNIT(MONITOR) A 8 IC5702 MN103SE60PUB INTR 136 R5822 10k GPIO_07 EXTRG0 134 5 TRCST 132 R5824 1k XRST 6 131 R5831 GRST 133 VSS_12 NM 3 VDD3_10 TRCD1 NM TRCCLK TRCST 0 VDD_5 TRCD0 NM 7 TRCCLK C5744 1u/6.3 R5829 C5745 0.1u/10 130 R5833 NM GPIO_03 SDATA R5752 NM GPIO_02 NM 47k 129 R5835 TRCD3 NM 9 SCLOCK G_to_M 128 R5837 10k GPIO_06 M_to_G 127 R5839 1k TXD0 113 TRCD3 126 R5841 1k RXD0 111 TRCD2 125 R5843 L5705 14 NM TRCD0 NM 680 CN5701 F-a F-b R6001 VCC53V R6008 CTF1306-A 13 124 DPSEL 10k GPIO_00 TRCD1 10k GPIO_01 123 R5846 SDATA 122 R5848 SCLOCK CTF1473-A C5756 10u/6.3 R5869 0 C5757 0.1u/10 0 112 C5750 1u/6.3 R5851 0 C5751 0.1u/10 121 VDD3_9 120 VSS_11 119 R5854 GPIO_11 TRCD2 118 R5856 GPIO_10 117 R5858 GPIO_09 115 R5862 1k RON 116 R5860 GPIO_08 114 VDDP_2 C5754 10u/6.3 R5865 C5755 10u/6.3 VDDP_1 110 VDDP_0 VOUT_2 VOUT_1 VOUT_0 G_FROM C6010 L6004 0 C6012 DCH1201-A 10u / 10V 10 0 R6011 R6010 R6012 R6013 18 160 15 82 12 R6015 R6014 R6017 R6016 R6019 47 56 39 2 R6018 1 0 164 15 F R6021 R6020 D 0 F-b 2/2 LHSY E 2 82 C 0.1u/10 B R6032 R6022 1 4 TO LCD MO SDA_9 SDA_5 SDA_6 SDA_8 R5792 VSS_1 8 VDD3_1 9 SDDATA_10 SDD_12 1u/6.3 68 SDD_13 SDDATA_12 10 SDDATA_11 11 R5790 C5735 0.1u/10 0 R5794 SDD_11 68 12 R5796 SDD_10 68 SDDATA_9 13 R5798 SDD_9 68 SDDATA_8 14 R5800 SDD_8 68 SDM_1 15 R5802 SDM_1 68 SDCKE 16 150 R5804 SDCKE MEMCLK 17 SDAD_12 R5808 150 R5806 18 MIMCLK 0 MEMCLK 68 19 SDAD_11 20 VDD_1 BACKLIGHT PART SDA_4 C5738 1u/6.3 R5812 C5739 0 0.1u/10 R5810 SDA_11 LCD PANELPART SDA_7 5001 5101 5201 5301 5401 5451 5501 5601 5701 6001 6151 6101 SDAD_0 3225 3216 2125 1608 CHIP SIZE LEGEND SDA_1 21 150 CONNECTOR PART CON PART FLASH ROM PART SD RAM PART TOUCH PANELPART C.VIDEO PART DD-CON PART VIDEOA/D IC PART GERDA IC PART SDA_3 VSS_2 22 GERDA SDA_2 VDD3_2 23 SDAD_9 24 SDAD_8 25 SDAD_7 26 C5740 1u/6.3 R5815 C5741 0 0.1u/10 SDAD_6 27 SDAD_5 28 SDAD_4 29 SDAD_3 30 SDAD_1 32 SDAD_2 31 SDBA_1 34 VDD3_3 35 150 VSS_3 36 VDD_2 37 SDCS 40 SDBA_0 38 SDBA_0 R5844 33 SDA_0 41 150 SDAD_10 39 150 C5748 1u/6.3 C5749 0.1u/10 R5842 0 SDA_10 R5845 FAD_20 FAD_21 FAD_22 VSS_5 FAD_19 FAD_18 VSS_6 VDD3_5 FAD_17 FAD_16 FAD_15 FAD_14 FAD_13 FAD_12 FAD_11 FAD_10 FAD_9 FAD_8 FAD_7 FAD_6 VDD3_6 VSS_7 VDD_3 FAD_5 FAD_4 FAD_3 FAD_2 FAD_1 68 SDCAS R5901 R5902 79 78 R5918 57 55 F 1/2 COMDC COMAC LCE R5917 58 0 0 0 0 GNDD F-a F-b COMDC 1k R6157 COMAC R5916 59 G_SDRAM R5915 56 0 0 0 0 0 15k R6161 0 C5764 1u/6.3 R5877 0 C5770 0.1u/10 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 F 1/2 R5900 80 77 R5899 81 0 C5762 1u/6.3 R5872 0 C5768 0.1u/10 C5763 1u/6.3 R5876 0 C5769 0.1u/10 R5903 0 R5904 0 R5905 0 R5906 0 R5907 0 R5908 0 R5909 0 R5910 0 R5911 0 R5912 0 R5913 R5914 0 R5898 82 0 0 NM IC5702 MN103SE60PUB R5853 SDWE 42 SDWE 43 R5855 150 SDM_0 44 SDDATA_6 SDM_0 82 SDDATA_7 45 R5857 SDD_7 68 R5859 SDD_6 150 46 SDDATA_5 47 C5752 1u/6.3 R5863 0 R5861 68 VDD3_4 48 68 50 C5753 0.1u/10 SDD_5 R5838 C5746 1u/6.3 0 C5747 0.1u/10 R5817 150 R5819 150 R5821 150 R5823 150 R5825 150 R5827 150 R5828 150 R5830 150 R5832 150 R5834 150 R5836 SDBA_1 68 VSS_4 49 LCE R5866 SDD_4 150 R5847 SDCS 51 R5867 SDD_3 SDRAS SDRAS R5849 52 68 R5868 SDD_2 150 SDCAS R5852 54 68 R5870 SDD_1 R5897 VCOM SDDATA_4 SDDATA_3 SDDATA_2 SDDATA_1 SDDATA_0 53 68 R5871 SDD_0 R5896 R6159 FRWE 0 R6158 4 3 2 1 V+ B:+IN NJM082BV V- A:+IN B:-IN B:OUT 0 5 6 7 8 R6160 C6158 4.7u/6.3 IC6151 A:-IN 10u DTL1096-A VCCM16V A:OUT L6007 CTF1635-A VCC15V L6008 L6006 DTL1096-A VCC3.3V GNDD VCC8V L6005 CTF1635-A VCC53V LCSY LR5 LR4 LR3 LR2 LR1 LR0 LG5 LG4 GNDD 1k 3.9k D% R6153 R6152 GNDD VCOM PART R6154 1k 10k D% R6155 D% R6156 VCCM16V Q6151 RUE003N02 GNDD FAD_21 FAD_20 FAD_19 FAD_18 FAD_17 FAD_16 FAD_15 FAD_14 FAD_13 FAD_12 FAD_11 FAD_10 FAD_9 FAD_8 FAD_7 FAD_6 FAD_5 FAD_4 FAD_3 FAD_2 FAD_1 FAD_0 0.1u/10 C6016 C6014 C6015 83 CCG1222-A 0.1u/10 0.1u/10 84 10k C6153 C6019 0.1u/10 0.1u/10 0.1u/50 C6022 (3528) C6017 22u/16_Ta R6045 R6044 0.1u/50 4.7k C6018 10u 10V NM R6043 0.33u/50 C6024 D6001 0.1u/50 C6025 R6047 100 LCSY LR5 LR4 LR3 LR2 LR1 LR0 LG5 LG4 LVSY LDEN LEN F 1/2 LCLK TP6003 R6025 D% 5.6k 5.1k R6048 R6046 1k FRWE NM C6020 25V 4.7u 20k 4.7k 1.8k R6050 R6028 R6026 3 2 Q6002 2SC4097(R) 1 B C E COM LVSY LDEN LCLK GNDLCD GNDD NM R6038 LEN2 DCH1201-A C6023 3k D% 10k 0 FAD_0 C6151 0 B2 C6013 0.1u/50 R6030 4 0.1u/50 C6154 CCG1222-A 4.7u C6155 R6151 C6152 E2 5 C6156 22u/16_Ta (3528) NM C1 C6026 10 R6031 0 0 R6039 R6037 1u/16 R6041 Q6003 2SA1577(Q) R6040 6 3 C2 2 B1 1 E1 R6049 R6027 0 0 33k 7 Q6001 UMZ1N G3 CLS U/L 8 7 NC NC 1 VCOM 2 VCOM 3 4 VEE 5 6 SPS MODE 9 10 CS 11 GND 12 NC 13 VDD 14 NC 15 SPR 16 VCC 17 VSHD 18 NC 19 GND 20 CLD 21 GND 22 GND 23 NC 24 VSHA 25 VSHA 26 NC 27 GND 28 LBR 29 LS 30 R5 31 R4 32 R3 33 R2 34 R1 35 R0 36 G5 37 G4 6 R6042 C6027 20 6 R6029 5 0 5 7 8 TO LCD MODULE A B C D E F F-b 2/2 AVH-P4100DVD/XN/UC 8 165 0 1u/25 4 V33A V33A GNDP UW5 GNDRGB GNDD GNDILM NM 1000p/50 NM R5035 NM GNDP C5014 NM 5.3V 0 1u/6.3 R5503 C5506 C5016 0.047u/25 AVAGND 0 L5505 DTL1136 GNDP D% D% R5510 R5513 C5510 0 NM GND 100 100 R5454 R5453 CTF1635-A (2016) AVAGND NM R5039 R5040 GNDP 0.1u/50 R5451 D% R5506 10k R5511 C5511 R5038 GNDD GNDFL 3.3V RSX201L-30 C5518 0.01u/50 GNDP C5520 V32 13 22k 0.1u/50 R5518 CTF1488-A (3216) 4 5 10u/6.3 C5452 10u/6.3 C5451 V+ GND NJM2505AF VGND Vout Vin IC5451 F 1/2 1 2 3 POWER SUPPLY NM CCG1223-A MAX2.0A 501 L5506 1k 3.3k 14 VS1 0 OCPC1 C5515 68p/50 15 200 6800p/25 0.015u/16 FB1 R5516 16 C5557 3k INV1 C5516 17 C5514 C5508 R5508 R5517 SS1 4700p/25 200 0.039u/5018 0.033u/16 5.1k FB2 GNDP R5502 R5505 19 C5558 27p/50 INV2 C5517 20 6.8k 200 SS2 (D) 21 C5512 0.1u/16 0.039u/50 VREF 22 C5513 OUT3 DCH1201-A 10u 10V 23 PVCC3 R5512 R5509 24 FB3 2.2k 510 (D) (D) GNDP R5514 53V 0 L5504 R5504 L5503 CTH1249-A 10uH/0.61A C5015 UW5 GNDRGB GNDV R5034 L5501 18uH CTH1250-A 3.3V R5501 L5502 AVAGND C5013 GNDD 0 C5012 AVBGND 0 R5032 NM R5033 0 R5037 GNDP GNDP 3.3V CTH1249-A 10uH GD33V C5018 NM R5036 GD33V C5504 1u/6.3 PWRVI D5501 C5501 DCH1201-A 10u / 10V C5502 0.1u/10 0.1u/50 C5505 DCH1201-A 10u / 10V C5503 33u/10_Ta (3528) VCC53V C5530 IC5501 BD6171KV 1000p/50 56k 0.1u/50 R5521 C5556 R5520 GNDP NM D5508 GNDP GNDP 10k D% C5538 4.7u/16 R5468 F 1/2 PWCTL1 PWCTL2 PWCTL3 NM R5523 4700p/50 C5536 4700p/50 C5535 2 1 2 1 D5503 RB548W R5525 AVAGND CVIDEO 47 R5535 47 R5534 3 D5507 3 1 2 1 2 1 0.8Vp-p(max1.0V) 0 C5552 V33A C5550 1u/16 C5549 1u/16 C5548 1u/16 L5701 CTF1635-A C5551 NM CCG1222-A 1u/25 C5547 C5545 NM D5506 47k 7.5k D% D% R5526 0.1u/50 C5544 GNDP D5505 RB548W 3 8.0V 2 RB548W R5527 R5529 0.1u/50 C5542 0.1u/50 C5541 0.1u/50 C5540 GNDP 8V R5532 0 R5530 220k D% R5528 VCC8V D5504 RB548W 3 3 0.1u/50 62k D% 3.3k D% 12k D% C5537 GNDP 0.01u/50 R5524 PVCC4 47 OUT4 46 FB4 45 PGND4 44 RT 43 FIN 42 VCC 41 PVCC 40 PGND5 39 FB5 OUT5 38 PVCC5 37 48 GNDP 0.01u/50 C5533 C5532 1u/16 TP5501 68uH L5507 CTH1318-A D5502 3.3V R5507 L5508 CTF1635-A (2016) C5546 VCC3.3V 1k (D) 0.1u/16 C5560 4.7u / 25V R5705 GD33V H:500kHz L:454.5kHz 0 0 10k 10k 10k 0 R5732 R5733 R5734 R5735 R5736 R5737 R5738 LCE LCSY LDEN LHSY LVSY LCLK 0 R5731 R5714 R5713 R5712 R5711 R5710 R5709 R5708 F 1/2 L5704 0 R5730 180 270 270 270 150 22 NM 22 NM 0 0 L5706 2 1 L5707 2 1 L5708 2 1 L5709 2 1 L5710 2 1 R5751 R5750 R5749 C5720 R5744 1u/6.3 0 C5727 0.1u/10 C5721 1u/6.3 R5745 0 C5728 0.1u/10 AVBGND NM 6.2k L5703 R5740 470 2.7k 7.5k R5742 R5743 R5741 0.1u/10 NM 0.1u/10 C5716 0.1u/10 R5729 0 C5718 C5715 GNDD R5919 196 195 194 193 192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 R5920 10k 10k R5921 10k 22k R5566 22k R5561 VAD_GERDA UC,EW5 DDCON C5717 0.01u/16 470 R5707 EXTRG0 GNDD LEN 6p/50 100 CSS1634-A 33MHz GNDD 6p/50 C5705 C5704 AVAGND -16.3V L5702 CTF1635-A 1u/6.3 1u/6.3 C5711 10u/6.3 C5710 -16V PWCTL3 PWCTL3 PWCTL2 PWCT2 F 1/2 R5515 10k R5536 1k R5739 (D) 12k 3 4 15.0V 2 15V 1 5 Q5505 IMZ4 6 GNDP GNDP V33A (2016) L5509 CTF1635-A (2012) max100mA L5510 DTL1096-A 10u/6.3 C5709 C5708 R5538 R5537 10k 10k VCC15V VCC33 28 V04DET V05DET 0 C5507 0.1u/10 SVBGND 30 68u C5509 6.3V CCH1440-A_Po NM 25 D5510 0 26 NM C5559 NM GND 31 1 Q5501 6 D4 D1 5 2 D2 D3 3 4 G S RSQ035P03 0.01u/50 C5519 MVIPW C5528 EN1 32 C5521 10u CCG1223-A D5509 NM R5461 0.01u/50 EN2 33 C5529 C5539 C5524 (10u) C5522 S 4 D3 5 D4 6 1000p/50 C5531 C5543 CCH1586-A_Po 33u 10V 2SA1577(QR) Q5503 2SC4097(R) Q5504 22k R5567 22k R5562 LCDCLK LCDVSY LCDHSY LCDDEN LCDCSY LCDCE GPIO_04 GPIO_05 LCDMUTE MCKSL VDD3_13 VSS_15 VDD_6 TSTC0 TSTC1 TSTCK OSCXO OSCXI PMODE0 AVCLK TSTIO AVDD_2 DAOUT AVSS_2 CLL CLH AVSS_1 AINP1 AINP0 AVDD_1 IREF VCMO VREFH VREFL B2 4 5 6 DCG1 UMZ1N Q5562 B1 4 4.7k C2 5 R5563 C1 6 UW5 E2 B2 C1 UMX2N Q5561 GNDP GNDP 3 2 E2 1 E1 +15V -16V Discharge Part VCC3.3V 1u/16 RB548W NC1 2 1 EN4 35 EN5 36 V03DET V01DET V02DET 27 D5511 NM C5523 162 C5527 10u 50V CCG1223-A 29 NM 161 G 3 D2 2 D1 1 Q5502 EN3 34 1u/16 DVR_3 RSQ035P03 R5464 R556 47k 6.8k R556 E1 1 R5568 B1 2 4.7k C2 3 DCG3 DCG2 DVG_3 RB160M-30 C5534 R5522 PWCTL NM 160 0.1u/50 0 DVR_4 C5555 1u/25 VCCM16V C5554 X5702 DVG_4 F-a F-b 47u/10_Ta C5702 C5553 1u/16 R5533 15k 47u/10_Ta VCC53V R5452 C5714 1u/25 C5712 R5706 C5713 33p/50 1M DVG_2 PWCTL C5719 R5772 DVVSY 150 R5775 DVHSY 150 R5778 DVCLK 220 DVR_0 159 R5781 DVVSY DVHSY DVCLK DVR_0 150 157 DVR_1 DVR_5 CL1 12 PVCC1 11 R5519 15 OVT1 10 C5525 VREGB 9 C55261u/16 LGND 1000p/50 8 OUT2 7 15 PVCC2 6 CL2 5 VS2 4 VREGA OCPC2 3 L5451 AVH-P4100DVD/XN/UC C5454 F-a 2/2 CTF1379-A F 0.1u/10 3 4 68p/50 0.1u/10 C5726 0.1u/10 0.1u/10 3 C5725 2 CTF1748-A 156 VDD3_12 150 158 R5783 DVR_1 C5732 1u/6.3 R5784 0 C5733 0.1u/10 DVR_2 155 R5787 VSS_14 150 154 R5789 DVR_2 150 153 R5791 DVR_3 DVG_0 150 150 R5797 DVG_0 150 152 R5793 DVR_4 150 151 R5795 DVR_5 DVG_1 150 149 R5799 DVG_1 2 150 1 / 166 150 E 150 D 148 R5801 C 147 R5803 B DVG_2 F-b 2/2 DVG_3 A DVG 4 1 4 NAVI_R NAVI_G NAVI_B CSYNC GNDV MONVBS F 1/2 ANALOG VADRES VADSDA VADSCL F 1/2 0 C5603 0.1u/10 C5602 0.1u/10 GNDD 2.2k R5623 2.2k R5622 2.2k R5621 C5604 0.1u/10 1000p/50 C5601 47k UW5 M_VAD C5623 100p/50 R5602 R5452 V33A L5601 NM CTF1473-A C5622 0 C5607 0.1u/10 0 0 0 C5610 0.1u/10 GNDRGB R5607 C5606 0.1u/10 0.1u/10 C5609 R5606 R5605 C56080.1u/10 R5604 C5611 47u/10_Ta 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 GNDRGB L5602 CTF1473-A 4.7k R5457 10u/6.3 10u/6.3 C5452 100 R5454 100 C5451 R5453 D% 5 4 AVSS8 AVDD4 AVDD3 AVSS7 AVSS6 AVDD2 BIN BYPASS AVDD7 AVSS11 SDA SCL A0 RIN AVSS10 AVDD6 AVDD5 AVSS9 SOGIN GIN IC5451 GND V+ NJM2505AF VGND Vout Vin 10u/6.3 C5453 C5614 1 2 3 R5461 CTF1379-A L5451 470 R5463 L5452 22u (2520) Q5451 2SC4081(QRS) C5457 5p/50 L5453 27u (2520) C.VIDEO AVAGND AVAGND IC5601 AK5406XQ VIDEO_AD 2.7k 8200p/16 C5613 R5610 0.082u/10 62 NM R5458 R5455 6.8k D% 0 R5451 61 DVVSY C5605 (3528) C5456 R5459 R5460 DTCLK 65 0.1u/10 RESETN VSYNCO SONGOUT 63 DVHSY HSYNCO 64 C5616 DVCLK 47u/10_Ta (3528) C5458 R5467 Q5452 390 2SA1576A(QRS) 47p/50 R5466 F-a F-b 1 20 NC3 BOUT0 19 BOUT1 18 BOUT2 17 BOUT3 16 BOUT4 15 BOUT5 14 BOUT6 13 BOUT7 12 DVDD1 11 DVSS1 10 NC2 9 NC1 8 GOUT0 7 GOUT1 6 GOUT2 5 GOUT3 4 GOUT4 GOUT5 3 GOUT6 2 0 R5469 VCC3.3V AVAGND R546 L5454 0.1u/10 21 0 680 ROUT7 C5612 0.1u/10 68p/50 NM 0.1m (2520) R5620 C5620 0.1u/10 C5460 33u/10_Ta VCC53V 0 GD33V L5603 15k 33k R5462 DVSS3 66 DVDD3 67 R5612 0 C5701 F 1/2 GNDD DVG_4 DVG_3 DVG_2 DVG_1 DVG_0 DVB_5 DVB_4 DVB_3 DVB_2 DVB_1 DVB_0 Vcc GND0 OUTY INA NC IC5701 CSS1778-A 9.597MHz X5701 1M TC7SHU04FUS1 R5701 3 2 1 12p/50 22 4 R5702 5 GD33V R5733 R5734 R5735 R5736 R5737 LCE LCSY LDEN LHSY LVSY 22 270 270 150 22 NM R5717 LB2 R5723 LG2 LR1 LR0 LG5 LG4 180 180 180 180 180 R5725 180 R5726 180 R5727 180 R5728 180 180 C5724 1u/6.3 R5748 0 C5731 0.1u/10 R5724 R5722 LG1 LG3 R5721 R5720 LG0 LB5 LB4 180 180 R5718 180 R5719 180 R5716 LB1 LB3 R5715 LB0 LCLK GNDD 270 R5738 180 C5722 1u/6.3 R5746 0 C5729 0.1u/10 C5723 1u/6.3 R5747 0 C5730 0.1u/10 R5732 EXTRG0 0 R5731 0 10k 0 NM 0 L5706 2 1 L5707 2 1 L5708 2 1 L5709 2 1 L5710 2 1 R5751 R5750 R5749 0 C5728 0.1u/10 199 198 197 196 195 194 193 192 191 190 189 188 187 CTF1748-A L5721 2 1 L5722 2 1 L5723 2 1 L5724 2 1 L5713 2 1 L5714 2 1 L5715 2 1 L5716 2 1 L5717 2 1 L5718 2 1 L5719 2 1 L5720 2 1 216 215 214 213 212 211 210 209 208 207 206 205 204 203 200 CTF1748-A L5711 2 201 1 L5712 2 202 1 CTF1748-A R5714 _ VSS_17 LCD_G_4 LCD_G_5 LCD_R_0 LCD_R_1 VDD3_15 LCD_G_3 LCD_G_2 LCD_G_1 LCD_G_0 LCD_B_5 LCD_B_4 LCD_B_3 LCD_B_2 LCD_B_1 LCD_B_0 LCDICLK VDD_7 VSS_16 VDD3_14 LCDCLK LCDVSY LCDHSY LCDDEN LCDCSY LCDCE GPIO_04 GPIO_05 LCDMUTE MCKSL 7 DVR_5 C5621 10u/6.3 R5703 C5703 R5704 NM C5707 0.1u/10 C5455 ROUT5 70 CTF1635-A 3.3k C5706 12p/50 0 0.1u/10 C5454 68 DVR_4 ROUT6 69 DVR_3 NC6 2 R5713 CTF1748-A GNDD LEN LR2 47p/50 71 DVR_1 ROUT3 72 DVR_0 ROUT4 DVR_2 ROUT2 73 ROUT1 74 ROUT0 75 NC5 76 VAD_GERDA 1 LR3 R5771 R5774 180 R5777 180 LR4 2.7k 77 R5619 0 R5785 SDD_15 C5459 40 AVSS5 AVDD1 39 R5608 0 TEST R5609 38 BIAS 37 6.8k (F) AVSS4 36C5615 0.1u/10 PVDD3 R5611 35 PVDD2 34 0 FLT 33 AVSS3 32 R5613 VSYNC 31 R5614 0 HSYNC 0 30 R5615 COAST 29 0 AVSS2 28 PVDD1 R5616 27 C5617 0 0.1u/10 TEST2 26 AVSS1 R5617 25 CLAMP 24 R5618 0 DVDD2 0 DVSS2 23 NC4 22 C5618 0.1u/10 78 DVDD4 DVSS4 GOUT7 79 C5619 0.1u/10 7 DVG_5 6 80 R5786 L5725 2 1 L5726 2 1 L5727 2 1 L5728 2 1 180 VDD3_1 SDD_14 180 R5780 SDDATA_14 6 SDDATA_13 7 68 VSS_1 8 R5788 68 68 SDD_13 9 R5792 C5734 1u/6.3 SDDATA_12 SDD_12 10 SDDATA_11 11 R5790 C5735 0.1u/10 0 R5794 SDD_11 68 SDDATA_10 12 R5796 SDD_10 68 SDDATA_9 13 R5798 68 SDDATA_8 14 SDD_9 68 R5800 SDD_8 3 LCD_R_2 4 LCD_R_3 LCD_R_4 5 LCD_R_5 SDDATA_15 LR5 16 SDCKE 150 SDM_1 15 68 R5802 150 R5804 6 SDM_1 5 SDCKE 5 8 F-b 2/2 AVH-P4100DVD/XN/UC F-a 2/2 8 167 A B C D E F 1 2 3 4 3 4 10.11 SERVICE PCB ASSY A B C D E F G 168 AVH-P4100DVD/XN/UC 1 2 5 6 7 8 A G SERVICE PCB ASSY B C D A 3/4 CN801 E F G AVH-P4100DVD/XN/UC 5 6 7 8 169 1 2 3 4 10.12 WAVEFORMS - DVD CORE UNIT A Note:1. The encircled number denote measuring points in the circuit diagram. 2. Reference voltage: 1.65 V(TD1,FD1)(=VHALF) 2.2 V(RF)(=VREF) In the waveform, it is seeing on the GND standard. Offset of 1.65 V or 2.2 V is put in. RF 0.2 V/div(AC) 100 ns/div CDRF(x4CLV) RF 0.2 V/div(AC) 50 ns/div DVDRF(x1.3ZCAV) RF 0.5 V/div 100 us/div DVDRF(BD1mm) TD1 0.2 V/div 100 us/div Interval FWD(DVD) B TD1 0.2 V/div 100 us/div Interval REV(DVD) 2.2 V-> VHALF VHALF C TD1 0.2 V/div 500 us/div Multi 32FWD(DVD) TD1 0.2 V/div 500 us/div Multi 32REV(DVD) CH1:TD1 0.5 V/div 10 ms/div CH2:COP-COM 2.0 V/div 10 ms/div Traverse 1001FWD(short)(DVD) VHALF VHALF VHALF 0-> D E F 170 AVH-P4100DVD/XN/UC 1 2 3 4 5 CH1:TD1 0.5 V/div 10 ms/div CH2:COP-COM 2.0 V/div 10 ms/div 6 7 CH1:TD1 0.5 V/div 20 ms/div CH2:COP-COM 2.0 V/div 20 ms/div 8 CH1:TD1 0.5 V/div 20 ms/div CH2:COP-COM 2.0 V/div 20 ms/div Traverse 1001REV(short)(DVD) Traverse 5001FWD(long)(DVD) Traverse 5001REV(long)(DVD) VHALF VHALF VHALF A 0-> 0-> 0-> CH2:COP-COM 2.0 V/div 100 ms/div ID search Inside -> Outside(DVD) TD1 0.5 V/div 100 ms/div FD1 0.5 V/div 1 ms/div Play TD (DVD) Focus Close (DVD) B 0-> VHALF VHALF FD1 0.5 V/div 20 ms/div Play FD(DVD) FD1 0.5 V/div 500 us/div FD1 0.5 V/div 500 us/div Focus Jump L0 -> L1 Focus Jump L1 -> L0 C VHALF VHALF VHALF D E F AVH-P4100DVD/XN/UC 5 6 7 8 171 1 2 3 4 11. PCB CONNECTION DIAGRAM 11.1 MOTHER PCB A NOTE FOR PCB DIAGRAMS 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams 140 130 Capacitor Connector S/PDIF OUT SIDE A JA951 1 120 SIDE B CORD ASSY CN522 JA141 10 C192 10 Chip Part P.C.Board USB 5 B 1 5 1 110 C951 R521 R522 R525 E R526 L951 R953 D951 IC951 Q951 15 D521 C952 5 5 R954 MOTHER PCB 1 L141 1 R952 L952 100 R951 C1081 IC1061 CEK1280 CEK1285 5 10 C1061 C1141 C1149 R1141 C771 R783 C772 R779 R772 R780 R781 R165 R778 R776 R774 D1141 E Q1141 R775 R782 R793 R792 R791 R170 R168 R162 Q163 R771 R777 R789 R787 C773 C168 D164 R171 Q161 E C778 R788 C165 D165 R161 C1001 R174 C142 R790 C161 D161 C1002 80 L161 C162 L162 R176 C166 R173 C163 1 90 R773 C787 1 C C774 > P 1202 (A,61,57) Fuse 1 A > P 1203 (A,66,24) Fuse 2.5 A 1 C141 R1061 1 A R955 C1143 70 C1401 C1129 C1005 C1421 L1141 D1201 D1202 D 60 P1202 CN901 1 L1207 C1226 L1202 1 5 C1233 L1201 D1203 C1227 C1216 5 Q1201 L1208 L1203 R904 C1201 C1223 C903 C1214 L1206 C904 1 C901 P1203 1 5 D1204 L1205 R569 R566 R567 R564 R565 C1229 L1204 C1228 C1500 L1209 CN101 30 Q1202 R524 R568 15 C1232 R5 C1203 25 30 C1224 R1211 20 C1225 40 E G C1202 15 CN1901 L902 C1206 R1210 C 10 1 C1204 C1205 50 10 10 R1382 C1344 IC561 D1341 1 1 C1341 C1343 L1381 5 CN801 C1342 0 A 172 1 X 10 FRONT 5 20 30 40 50 60 AVH-P4100DVD/XN/UC 1 2 3 4 C563 C561 1 Q1341 E Y F 5 R562 10 1 R1343 C1381 10 R57 P1341 R563 C1383 R528 R535 R534 CN521 E R527 C564 C1382 20 R1381 Q1381 R530 20 D1381 R529 70 5 6 7 8 A SIDE A VCR IN RCA OUT JA102 JA101 IC181 1 5 10 10 20 B 5 R118 R108 R112 R101 R102 R107 R111 E Q102 R113 1 1 R105 R117 R116 Q101 R104 R110 D105 R189 D182 R119 R109 R103 D103 1 R185 R186 R115 D104 C108 Q182 R114 C109 C186 C110 R187 R188 25 15 P130 1 1 5 R184 Q183 1 1 2 Q104 D102 P101 ANTENNA 1 R120 JA402 R121 10 15 20 25 30 35 C208 R207 R206 R205 P121 C222 C334 L402 L201 D301 C224 R751 R753 C751 C753 D302 R328 C347 C336 P131 C405 5 R780 R781 C785 C772 R779 R772 R778 R774 C CN2002 U401 C215 R776 R782 R793 R791 B C408 1 C786 R129 R127 R123 R128 R126 R124 C771 R783 R775 R788 R792 C106 C207 C778 R771 R777 R789 R773 C787 C101 40 1 5 C104 C103 CN121 1 C107 Q103 C105 1 R125 C102 Q121 R122 R752 R754 C752 1 5 R756 IC751 10 R662 C325 1 R621 C346 C345 5 140 R652 R663 R608 R610 R609 R612 R623 C606 R651 1 R327 R602 R645 R317 R626 R646 R318 CN901 CN602 135 130 125 120 115 1 C344 C1086 C404 110 1 15 1 10 10 15 20 25 30 65 15 C1082 L1022 C1021 Q801 CN5001 10 C1024 CN501 CN601 C802 1 C801 ONT 70 F BZ601 R614 R616 R611 R629 R615 R613 R628 1 20 R633 R630 R631 R632 R637 R634 R635 R636 R624 C609 R607 C610 R604 R650 R648 R661 R619 R647 R655 R605 C611 D601 R378 70 E R620 E 5 60 R421 R676 C1025 Q372 R501 40 35 55 R644 C602 1 E R569 R566 R567 R564 R565 15 C563 C561 50 R420 R419 R422 IC602 R373 R376 5 R563 75 R570 1 80 1 20 R374 1 C618 R377 R375 L403 85 30 R371 Q371 R562 45 R372 IC561 10 40 R627 R668 D 90 R671 R670 R657 R656 C371 Q561 35 25 C904 30 R618 R669 25 20 C601 R561 C903 IC601 20 C603 R601 15 X601 1 95 R606 L601 R568 100 10 R904 03 105 5 10 R667 C604 L902 FM/AM TUNER UNIT P132 R622 1 D602 D603 R755 F D801 80 90 100 110 120 130 140 150 160 A 170 AVH-P4100DVD/XN/UC 5 6 7 8 173 1 2 3 4 A A MOTHER PCB > P 1021 (B,137,20) Fuse 1 A > P 1022 (B,136,17) Fuse 1.75 A > P 1201 (B,19,46) Fuse 4 A CEK1280 CEK1283 CEK1344 1 B 1 D101 P102 1 Q105 C111 E R212 R182 R183 C181 C221 C201 25 Q181 R214 R202 R204 R210 C227 C202 R216 C203 C204 C206 C205 D181 R181 20 15 1 R225 C218 5 R223 P401 IC201 C C219 R2 R220 R319 C331 C306 C305 C615 R640 R665 R410 R430 R424 E R405 C411 C1087 R407 R427 45 R649 R91 C605 R617 R638 C619 R642 1 Q403 R653 R625 1 C1084 R406 R426 C612 R639 Q404 D1081 D1021 P1021 C1085 L1021 R1024 P1022 C1083 R1025 15 E Q1022 C1023 IC1081 Q1021 E R803 C1022 R801 R804 R1027 R1026 R802 F A 174 170 160 150 140 130 120 110 AVH-P4100DVD/XN/UC 1 2 R315 C320 C318 C319 C317 C333 C332 C308 C307 C613 R408 R428 C410 R402 R654 R678 R643 R603 C608 R409 R429 E C3 C3 R325 R1082 R1081 R404 E C409 R658 C3 C34 R660 R677 C406 Q402 R401 35 R1023 R1022 R1021 R403 R423 Q401 D604 R659 C403 30 R326 R664 C407 C402 25 C607 L404 C31 C34 D605 L405 C401 IC301 20 R311 R313 R301 R302 R303 R304 C327 C329 C328 C330 C309 C311 C312 C310 C314 C313 R320 1 R C324 40 R314 R433 R432 R431 R312 R310 R307 D R435 R434 C335 C337 15 R416 R415 R414 R413 R412 R411 C1088 R222 C226 C220 R218 C216 R209 C223 R219 C225 C209 R213 C211 C228 R321 C322 C321 C323 C326 10 C210 R211 R221 5 C213 C212 R208 1 C214 R425 10 5 1 L401 R224 C217 1 IC202 3 4 100 5 6 7 8 A SIDE B 140 130 1 120 1 C188 C187 C190 C194 R181 C189 D101 D181 B 110 1 D141 C182 C183 C185 C184 C191 C193 Q181 R182 R183 C181 E D142 C195 D183 100 C777 E R1001 D162 C167 C1007 L163 Q164 D1001 E C164 R175 R1007 R179 D163 R1003 R177 R166 R163 Q162 R785 C782 R784 C780 C781 1 R786 R1004 D1002 Q1001 IC771 D166 80 C1006 C1403 R324 1 C1402 C1142 R1149 C1147 R1153 R1152 1 R1148 D 60 R1151 C902 R1202 R1212 R903 IC1201 35 R906 1 40 R915 45 R1218 R907 40 C1220 E D1206 IC521 1 R908 C1221 R1213 C1222 R1217 R1215 R1216 C1218 C1219 R1214 R905 1 P1201 C1212 R909 C1217 50 C1230 C521 R902 Q901 30 C1234 R1219 R1220 C1235 R913 R911 C1208 25 R914 R901 R1226 R912 10 L903 C1215 R910 1 C1213 R1225 R1204 L901 R641 R325 F1201 C1207 R1205 R1203 R1207 R1208 D1205 R1209 C1210 C1211 R916 5 Q601 C1231 C1209 10 40 C1145 R675 R674 C343 Q902 Q1142 1 R308 Q1122 D1142 R1206 R1224 R322 C342 R1128 C1128 5 45 C341 R1127 R1147 E 1 C332 1 D1122 R306 R330 C1144 R1144 R1154 R1146 C1148 C1146 IC1141 R1150 5 C333 Q1121 E R326 C316 C340 IC1401 1 C315 70 Q1143 E IC301 35 C1003 R316 C338 C339 C301 C302 C303 C304 R309 R305 IC1001 E R1401 R1422 30 R172 R1145 1 C320 C318 C319 C317 R323 R329 C337 Q1002 D1401 Q1422 R1421 20 R312 R310 C335 15 R315 R169 321 R1201 IC522 C523 30 C522 1 R523 1 C307 R1006 E D167 5 10 Q165 R1005 R167 R164 E R222 C226 C220 R218 R215 R178 C 90 R180 R798 Q771 1 C217 C776 R201 R203 1 IC202 C775 R797 R796 R794 R795 5 C219 R217 1 R225 C218 223 C779 D184 5 10 L521 R532 20 D522 10 D523 C524 Y 100 90 80 70 60 50 40 20 30 10 F 0 A X AVH-P4100DVD/XN/UC 5 6 7 8 175 3 X 20 A CN901 1 R1008 30 25 30 40 R1955 R1505 C1511 C1514 155 10 20 150 15 175 180 C1506 C1505 170 R1512 185 190 200 C1508 205 215 70 C1509 210 CN1951 R1536 R1539 R1547 R1542 C1516 R1517 R1529 C1518 R1518 C1519 R1533 C1520 R1534 R1540 C1529 R1537 C1110 C1108 A 80 3 DVD CORE UNIT C1503 R1538 AVH-P4100DVD/XN/UC 4 60 C1507 195 R1526 R1514 C1524 50 C1504 165 C1619 0 10 R1508 R1507 C1515 C1671 145 5 R1201 R1506 R1672 C1672 IC1501 R1510 R1522 R1516 R1513 Y 10 1 R1204 1 R1957 R1950 R1951 140 D1901 L1901 R1956 C1111 C1521 C1627 C1626 CN1101 R1530 CN1901 R1021 R1675 R1954 R1104 R1671 135 D1902 R1674 130 R1026 R1679 R1673 R1670 C1674 C1673 R1602 125 C1019 R1027 C1606 C1602 R1604 C1613 C1617 C1109 C1622 20 C1018 120 C1022 C1676 C1604 R1601 C1601 C1603 R1007 C1623 C1205 C1207 115 C1204 25 20 2 C1605 C1609 E 110 30 15 C1203 R1202 35 C1208 R1603 C1607 R1004 R1001 C1608 IC1001 R1115 R1112 R1106 R1118 R1113 C1612 IC1201 R1101 C1502 E R1116 R1111 R1605 30 R1203 Q1101 E R1117 R1114 C1610 10 R1212 5 15 40 R1103 C1104 C1105 R1105 Q1102 E C1620 40 1 CN1201 R1109 Q1103 50 C1106 C1611 105 Q1104 C1614 100 C1107 C1616 C1618 C1615 95 10 50 C1625 90 CN701 C1624 40 R1509 35 C1522 30 R1524 R1531 25 R1523 45 R1525 85 R1102 80 C1621 R1541 R1528 20 R1519 C1528 15 15 10 C1523 C1526 75 5 D C1953 70 R1110 10 65 C 5 60 1 1 1 55 25 176 20 C 15 D 10 E 5 PICKUP UNIT (SERVICE) 1 B 20 5 C 2 1 1 4 11.2 DVD CORE UNIT SIDE A C1517 L1512 160 F C1405 15 IC1402 15 35 40 1 5 45 25 20 30 35 10 5 45 C1954 C1934 C1112 C1302 IC1006 R1300 C1113 C1101 C1005 R1222 R1011 1 C1009 C1003 E R1002 R1025 C1011 IC1005 C1012 C1008 IC1002 L1003 C1004 C1010 IC1004 R1017 20 25 30 25 20 C1201 C1209 C1211 10 R1015 C1016 EF1002 C1013 C1014 L1004 L1903 R1019 1 R1802 30 C1006 C1804 C1007 C1805 C1807 R1804 IC1003 C1001 D 1 C1801 C1802 C1021 R1801 C1803 R1803 IC1801 R1301 C1806 C1808 5 X1501 C1512 R1504 C1809 C1489 1 R1501 R1503 R1511 L1904 1 C1409 40 15 30 10 20 35 5 5 10 1 C1481 R1490 R1485 1 R1403 R1406 R1405 R1409 C1482 R1480 C1494 C1491 C1510 40 1 C1401 R1401 IC1401 40 C1527 R1535 C1404 R1482 C1483 R1481 45 X1950 C1951 R1953 R1402 R1532 C1525 B R1483 C1484 IC1480 R1486 C1488 C1490 C1301 R1213 R1215 R1214 R1217 R1218 R1216 L1902 C1017 C1210 EF1001 C1015 1 X Y 10 20 30 40 50 C 0 AVH-P4100DVD/XN/UC 177 8 7 C1952 R1952 R1546 IC1951 R1527 R1543 C1402 R1484 R1487 C1492 C1487 50 5 1 10 15 C1403 R1488 60 1 C1408 C1480 C C1407 C1493 1 R1544 C1513 C1485 C1950 C1501 C1486 70 50 80 R1489 6 5 SIDE B DVD CORE UNIT C 8 7 6 5 A F 1 1 2 3 4 11.3 CONNECT PCB D CONNECT PCB SIDE A A C B CN1201 40 CN701 M1 LOAD/CRG MOTOR 15 30 C 10 M 1 5 20 D 10 Y 0 X 10 20 30 40 50 E F D 178 AVH-P4100DVD/XN/UC 1 2 3 4 5 7 8 CONNECT PCB SIDE B A B M2 SPINDLE MOTOR 40 1 S101 HOME CN101 1 R102 DSCSNS 30 S102 C R101 5 1 D 6 C101 10 20 8SNS R103 S103 D 10 1 Y 50 40 30 20 10 0 X E F D AVH-P4100DVD/XN/UC 5 6 7 8 179 F R3011 C3013 E 180 1 2 S3008 DISP OFF S3003 R3007 REVERSE S3002 FORWARD D R3005 U3001 D3005 S3001 SRC/OFF R3006 S3004 VOL- C S3005 RESET R3009 R3010 S3009 VOL+ S3007 MUTE B 6 S3006 EJECT D3002 C3007 C3008 E 1 1 2 3 1 3 4 11.4 KEYBOARD UNIT KEYBOARD UNIT SIDE A A 6 C3006 R3008 C3014 R3001 C3015 C3012 E AVH-P4100DVD/XN/UC 4 5 E 6 7 8 KEYBOARD UNIT SIDE B A B C D F CN5003 E F E AVH-P4100DVD/XN/UC 5 6 7 8 181 1 2 3 4 11.5 MONITOR UNIT F A MONITOR UNIT BACKLIGHT C5016 R5204 R5205 R5206 R5207 R5344 R5341 R5339 R5323 R5342 C5307 1 5 R5209 R5210 R5213 10 R5215 R5324 R5216 IC5201 R5217 R5345 R5340 R5338 R5343 R5322 R5208 C5306 R5335 R5337 R5334 R5331 R5326 L5302 R5333 R5330 R5328 R5329 R5327 R5336 R5332 10 70 B R5239 R5203 R5229 R5211 R5201 R5202 R5237 1 R5235 C5013 R5231 CN6101 R5233 80 15 R5218 C5308 R5219 20 R5220 R5221 C5309 C5305 R5222 R5223 R5212 R5214 5 1 15 10 20 25 60 R5325 R5897 R5240 R5895 C5201 L5301 R5894 L5201 R5840 C5202 CN5701 R5850 C5304 IC5301 R5822 R5835 L5705 R5820 C5303 C5758 5 10 C6109 50 45 40 30 35 R5301 R6046 R5317 R5320 R5921 R5920 R5708 C5725 R5709 R5712 R5710 R5714 C56 C5018 R5730 R5716 L5703 R5715 R5618 C5611 R5034 R5711 R5616 R5717 L5602 L5715 R5721 R5713 L5712 L5713 L5711 R5718 L5716 L5714 R5720 L5718 L5603 R6043 R6045 1 R5316 C5302 R6044 L5710 R5615 R5037 R5719 E Q6101 C5622 R5036 R5613 C5614 C5605 C6024 C6022 C6023 C6104 R6158 R5315 L5719 R5723 5 C6026 R6102 30 R5314 R5319 R5311 C6015 L6007 C6027 R6048 D L6005 C6018 C6019 R6113 1 R6103 C6105 C6013 R5724 D6001 C6107 IC6101 R6114 R6047 1 L6006 R5318 C5713 L5720 5 C6110 40 C6017 C6014 D6101 L6102 R5309 R5307 R6105 L5701 R5032 C5702 R5312 R5722 L5717 C6111 R5310 R5303 R6111 R6110 Q6102 D6102 R5313 C5301 R6109 R6106 R5302 R6108 R5308 C6108 R5306 R6107 R5305 L5702 R5304 50 C L5601 CN6001 C6153 R6021 C5613 R5611 R56 R6155 C6154 R6156 C6151 1 5 10 15 20 25 30 35 40 45 50 55 R6020 60 L5454 1 R6013 C6156 R6017 C6106 C5460 Q6103 IC6151 R6016 R6012 5 R6112 R6160 R6014 R6010 R6011 E R6032 R6152 R6019 R6151 R6022 R6015 C6155 R6018 R6104 E 20 R5033 L6004 1 L6001 10 C6103 C6102 R6101 L6101 C6101 P6101 Y 0 X 10 20 30 40 50 60 F LCD MODULE F 182 AVH-P4100DVD/XN/UC 1 2 3 4 70 5 6 7 8 SIDE A A C5502 R5227 C5501 R5229 R5225 R5231 R5233 R5237 R5239 C5505 C5506 C5503 L5502 L5503 L5501 R5224 C5014 R5244 R5226 45 R5228 L5507 R5230 R5232 R5503 Q5505 C5203 R5536 1 IC5201 R5245 R5515 R5238 25 R5240 C5509 C5543 1 C5560 C5528 R5520 R5241 Q5501 C5527 C5522 R5523 C5553 R5242 C5521 1 R5243 R5514 Q5504 R5522 Q5561 C5559 C5529 C5523 D5501 D5511 TP5102 1 R5564 R5563 E CN5701 L5505 C5519 R5501 R5565 R5535 R5562 10 D5508 E Q5503 R5127 R5141 R5534 R5561 R5123 R5120 R5135 R5122 20 1 R5568 R5570 R5569 R5801 R5797 R5799 C5106 R5805 R5921 40 35 R5803 CN5101 R5151 30 C5620 C R5142 X5101 45 C5621 R5133 25 R5620 L5603 R5130 5 R5795 Q5562 10 R5567 R5109 R5138 R5132 R5566 R5156 15 R5920 B D5502 R5236 30 R5519 Q5502 C5539 R5537 R5234 5 35 C5510 5 R5538 1 40 1 R5235 C5504 C5618 10 15 20 80 5 C5617 5 R5612 IC5601 65 C5104 R5103 R5609 R5124 C5606 TH5101 5 C5105 1 1 5 R5409 R5406 R5408 C5602 C5404 10 IC5001 5 C5604 C5601 C5603 D5403 Q5401 R5606 R6022 R5113 R5401 D5401 R5607 D5405 R5405 R5403 C5402 1 C5408 C5006 D5001 C5017 10 C5406 CN5001 C5403 5 10 15 20 25 30 35 40 R5407 5 10 R5402 E C5409 1 L6001 1 CN5401 D5404 C5011 CN5003 C5407 D5402 R5033 10 C5004 C5610 C5401 R5605 R5604 R5153 R5131 1 C5460 C5609 C5608 D R5111 L5101 C5607 R5129 R5115 R5128 C5101 60 R5116 55 R5114 C5111 50 L5401 L5454 80 CN5004 R5108 C5612 45 R6032 75 70 C5102 40 R5608 C5615 R5140 65 C5613 R5611 35 C5605 C5103 R5102 1 C5616 60 R5610 C5614 5601 R5147 70 R5613 R5146 R5106 R5107 R5614 30 C5622 75 R5617 R5615 IC5101 R5105 R5110 55 5602 25 R5616 R5104 R5101 C5619 10 1 C5611 34 R5154 R5619 50 R5618 1 R5125 018 R5404 R6101 P6101 70 80 90 100 110 120 130 F A E TOUCH PANEL CN501 F AVH-P4100DVD/XN/UC 5 6 7 8 183 1 3 4 L5506 C5555 L5510 R5533 B R5521 D5504 R5530 C5518 C5515 40 R5833 D5505 R5841 C5540 C5534 R5512 C5541 30 35 R5843 R5837 R5839 R5831 C5542 R5829 C5554 D5507 R5529 R5527 R5524 C5531 D5509 L5509 C5745 C5742 C5743 R5826 D5510 C5507 C5744 C5771 C5549 R5509 C5750 C5751 R5848 R5846 D5506 C5548 25 R5856 R5851 C5537 C5513 C5512 C5755 R5860 R5854 IC5501 53V C5754 C5546 20 R5507 45 C5558 R5508 R5517 L5504 R5858 8V C5538 R5526 C5557 R5516 R5502 10 L5508 C5552 15 C5508 C5535 D5503 R5505 C5514 C5517 5 C5516 C5544 C5536 1 C5511 C5532 C5757 R5862 R5510 R5511 C5756 R5869 C5547 R5532 R5878 C5530 C5525 C5526 C5520 R5518 C5556 R5513 R5506 R5528 C5545 C5533 R5879 R5525 C5524 R5504 R5873 15V PWRVI R5882 VCC33 R5881 MONITOR UNIT R5865 F A 2 R5824 C5736 C5737 R5807 C5550 C R5813 R5811 R5112 C5109 R5118 R5121 -16V R5117 C5108 R5148 R5816 R5119 R5814 R5752 R5145 R5818 C5551 R5134 C5732 C5733 R5784 R5809 C5107 R5139 R5919 R5155 R5793 R5152 C5709 C5711 1 R5016 E C5002 C5623 R5467 R5019 R5623 1 R5010 R5007 L5452 R5035 R5412 Q5403 R5004 C5001 C5454 R5029 Q5004 R5028 120 R5023 R5022 E C5010 E R5027 110 R5025 R5024 C5009 MONVBS R5462 R5461 R5460 R5455 IC6 R5458 R5453 Q5002 R5454 1 R5452 100 90 80 70 F F AVH-P4100DVD/XN/UC 2 C5455 C6010 R5463 E R5413 R5457 R5021 R5411 R5001 R5002 R5003 R5030 IC5451 C5452 1 1 R5410 R5026 C5456 Q5451 1 R5005 E R5459 R5451 Q5001 C5459 L5451 Q5402 C5451 R5012 R5011 R5014 C5003 C5015 1 R5015 R5621 C5405 R5013 R5031 C5458 L5453 R5468 R5006 R5008 C5005 C5007 R546 R5466 C5457 R5009 5 R5020 R5622 C5453 R5017 Q5003 1 R5729 R5464 C5008 184 C5708 Q5452 R5144 130 R5739 R5039 D R5018 C5718 R5772 C5012 R5602 C5710 R5126 R5149 C R5038 R5778 R5143 IC5102 R5040 R5783 R5775 R5791 R5137 5 R5789 R5787 C5110 R5150 C5715 R5781 R5136 3 4 5 6 7 8 SIDE B A R5871 205 210 R5845 R5800 C5738 C 5457 R6008 R5727 C5749 C5740 C5741 C5734 R5728 L5721 R6037 L6008 C6020 C6016 R5751 COM R6028 L5709 R5734 R5733 R6030 R6038 Q6002 D R6050 R6031 30 C5703 C5701 L5706 R6039 R6041 R6040 R5738 R5745 R5746 X5701 R5726 R5749 C5707 R5725 1 R5704 R5748 C5724 40 C6025 Q6003 E L5708 E R5469 C5705 R5736 C5704 R5785 L5726 L5723 L5722 R6026 X5702 IC5701 R5747 C5723 R5744 R5743 C5712 R5702 C5706 C5729 R5701 C5728 R5705 R5706 C5731 C5730 5 R5707 C5726 C5721 R5703 R5750 C5720 C5722 R5732 C5717 R5740 C5714 R5741 C5718 R5739 C5715 C5727 R5742 R5468 C5746 C5747 C5735 R5788 215 L5728 200 R5780 195 L5724 1 C5716 L5704 C5458 50 R5790 R5737 190 R5731 185 R5735 180 Q5452 L5453 R5819 R5786 R5771 L5727 R5774 R5777 175 L5707 170 R5729 R5466 C5748 45 40 35 30 25 10 5 1 160 C5719 8 5467 R5834 105 155 165 64 R5796 R5794 L5725 C5708 R5849 100 150 15 R5806 R5815 R5812 R5792 R5919 C5709 C5711 R5810 R5798 4 R5040 R5836 95 20 C5739 R5808 R5827 R5821 R5817 R5802 90 145 C5733 60 R5844 R5825 R5823 140 C5732 R5847 R5842 R5832 R5830 R5828 IC5702 C5736 737 R5852 R5804 85 C5743 C5742 R5863 80 135 26 R5853 R5838 130 C5745 C5752 R5866 75 125 C5744 R5857 R5868 70 5843 29 R5859 R5855 120 48 C5753 R5867 65 50 R5861 115 C5750 C5751 R5870 R5915 R5917 C5770 R5918 R5916 R5913 R5914 R5877 C5764 R5876 R5909 R5911 R5912 R5908 R5910 R5907 R5906 R5905 C5763 C5769 C5768 C5762 R5901 R5900 C5767 C5761 R5893 R5892 C5760 C5766 R5904 R5899 R5902 R5872 R5874 R5875 R5890 R5888 R5889 R5891 R5884 R5886 R5887 R5885 R5903 60 110 856 70 B C5755 55 R5865 C5754 C5759 R5880 C5757 R5896 C5765 R5882 R5883 R5873 R5878 R5879 C5756 R5869 R5898 E R5881 80 R6049 R6042 R6027 Q6001 R6029 1 R6025 C6012 C6158 L5452 1 9 Q6151 R6154 C5456 20 R6157 5451 C5455 C6010 R6161 R6159 C6152 R5463 E R6153 R5462 R5460 R5455 E IC6005 R5458 COMDC R6001 1 10 5 Y 0 70 60 50 40 30 20 10 X F F AVH-P4100DVD/XN/UC 5 6 7 8 185 1 2 3 4 11.6 SERVICE PCB ASSY G SERVICE PCB ASSY A SIDE A B C D E F G 186 A CN801 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 G 7 SERVICE PCB ASSY 8 SIDE B A B C D E F G AVH-P4100DVD/XN/UC 5 6 7 8 187 X X 10 20 C2005 10 Y 30 40 50 R2009 30 20 10 0 0 D2009 20 Y D2004 D2001 D2006 CN2001 60 30 35 40 1 JA2003 120 25 110 20 100 15 90 10 80 5 70 1 B.CAM INPUT 130 R2014 D2010 R2011 30 10 40 R2012 CN2002 1 D2011 R2001 R2007 D2005 R2004 R2006 R2003 R2008 50 20 C2001 60 JA2001 JA2002 R2019 160 5 7 150 8 11 1 4 JA2004 IP-BUS 140 C2002 R2022 R2017 R2016 70 WIRED REMOTE D2002 R2013 D2007 C2003 80 3 R2018 90 F 170 B R2015 MINIJACK SIDE A D2012 100 25 2 110 C 120 20 30 IF PCB 130 15 1 10 B 5 188 1 E 140 B 150 CN121 A 160 A B 2 170 D NAVI INTERFACE 1 3 4 11.7 IF PCB IF PCB SIDE B 1 R2021 R2020 1 C2004 D2003 1 R2002 R2010 R2005 AVH-P4100DVD/XN/UC 4 5 6 7 8 12. ELECTRICAL PARTS LIST NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V Circuit Symbol and No. Unit Number : Unit Number : Unit Number : Unit Name : Unit Number : Unit Name : Unit Number : Unit Number : Unit Name : Unit Number : Unit Name : Unit Number : Unit Name : Unit Number : Unit Name : CWN3794(UC) CWN3790(EW5) CWN3795(UW5) Mother Unit (B,23,23) IC TC7MBL6126SFK IC 561 IC 601 IC 602 IC 751 IC 771 (A,74,20) IC (A,125,41) IC(UC) (A,125,41) IC(EW5,UW5) (A,107,20) IC (A,140,68) IC (B,71,85) IC(UW5) 341S2162 PEG535A8 PEG534A8 S-80827CNNB-B8M HA12241FP NJM2138V Keyboard Unit CWN3797(UC,EW5) CWN3796(UW5) Monitor Unit YWX5007 DVD Core Unit IC 951 IC 1001 IC 1061 IC 1081 IC 1141 (A,23,105) L-MOS And Gate TC7SET08FUS1 (B,20,74) IC S-812C33AUA-C2N (A,7,88) IC NJM2388F84 (B,150,10) IC NJM2886DL3-33 (B,38,62) IC TK11840L IC 1201 IC 1401 Q 101 Q 102 Q 103 (B,43,41) IC BD9013KV (B,49,69) Regulator IC S-1112B33MC-L6S (A,134,110) Transistor IMH23 (A,101,109) Chip Digital Transistor DTA124EUA (A,101,105) Transistor UMD2N Q Q Q Q Q 104 105 121 161 162 (A,144,110) Transistor (B,145,110) Transistor (A,90,104) Transistor (A,33,80) Chip Transistor (B,48,84) Transistor IMH23 IMH23 UMF23N DTC114EUA UMX1N Q Q Q Q Q 163 164 165 181 182 (A,41,80) Transistor (B,38,76) Chip Transistor (B,42,86) Transistor (B,95,106) Transistor (A,103,112) Transistor UMT1N DTC114EUA 2SC4081 2SC4081 UMH1N Q Q Q Q Q 183 403 404 561 601 (A,96,114) Transistor UMD3N (B,149,30) Transistor(EW5,UW5) UMH1N (B,148,36) Transistor(EW5,UW5) UMH1N (A,81,26) Transistor UMD22N (B,78,54) Transistor(UW5) 2SC4081 Q Q Q Q Q 771 801 901 902 951 (B,61,87) Transistor(UW5) (A,168,10) Transistor (B,84,37) Transistor (B,87,37) Transistor (A,20,105) Transistor 2SC4081 UMF5N IMH23 UMD3N 2SA1576A Q Q Q Q 1001 1002 1021 1022 (B,30,83) Transistor (B,25,74) Chip Transistor (B,129,10) Transistor (B,133,13) Chip Transistor 2SD1664 2SB1132 2SC4081 2SB1132 Connect PCB EXX1058 Service PCB Assy B Part No. IC 522 Mother Unit Consists of Mother PCB IF PCB C D E AB Unit Number : CWN3794(UC) Unit Number : CWN3790(EW5) Unit Number : CWN3795(UW5) Unit Name : Mother Unit MISCELLANEOUS IC 181 IC 201 IC 301 IC 521 Circuit Symbol and No. Part No. A (A,80,120) IC (B,134,92) IC (B,100,62) IC (B,19,28) IC PA2030A PML018A AN15887A R5523N001B F AVH-P4100DVD/XN/UC 5 6 7 8 189 1 2 Circuit Symbol and No. A B Transistor FET Digital Transistor FET 3 Part No. Q Q Q Q 1141 1142 1143 1201 (A,34,76) (B,34,64) (B,41,68) (A,36,51) Q Q D D D 1202 1341 101 102 103 (A,36,28) FET (A,38,12) Transistor (B,99,111) Diode (A,107,105) Diode (A,118,113) Diode HAT2210RJ 2SD2153 DAN202U MA111 MALS068X D D D D D 104 105 141 142 161 (A,110,114) Diode (A,122,114) Diode (B,29,104) Diode (B,29,107) Diode (A,31,83) Diode MALS068X MALS068X S1G-6904G2P S1G-6904G2P MA111 D D D D D 162 163 164 165 166 (B,37,82) (B,37,84) (A,40,83) (A,36,80) (B,45,75) HZU7L(A1) HZU7L(C3) DAN202U DAN202U UDZS5R6(B) D D D D D 167 181 182 183 184 (B,37,86) Diode (B,101,108) Diode (A,91,107) Diode (B,78,100) Diode (B,70,96) Diode UDZS20(B) MA111 UDZS8R2(B) S1G-6904G2P S1G-6904G2P D D D D D 301 302 521 601 602 (A,101,76) (A,103,76) (A,15,107) (A,106,16) (A,121,65) RB551V-30 RB551V-30 EMZC6.8N MA111 RB751V-40 D D D D D 603 801 951 1001 1002 (A,123,65) Diode (A,167,4) LED (A,28,105) Diode (B,26,80) Diode (B,22,85) Diode RB501V-40 SMLE12BC7T MALS068X UDZS18(B) S1G-6904G2P D D D D 1021 1081 1141 1142 (B,142,21) Diode (B,147,20) Diode (A,39,76) Diode (B,31,65) Diode S1G-6904G2P S1G-6904G2P HZU13(B1) RB551V-30 D D D D D 1201 1202 1205 1206 1341 (A,29,61) (A,26,61) (B,40,50) (B,40,31) (A,35,16) RSX201L-30 RSX201L-30 RB551V-30 RB551V-30 HZU6R8(B2) D D D D D 1401 2002 2003 2004 2005 (B,52,73) Diode (B,144,13) Diode (B,128,13) Diode (A,44,16) Diode(UW5) (A,44,18) Diode(UW5) RB551V-30 MALS068X MALS068X MALS068X MALS068X D D D D D 2006 2007 2009 2010 2011 (A,44,13) Diode(UW5) (B,145,16) Diode (B,27,17) Diode (B,27,15) Diode (B,136,12) Diode MALS068X MALS068X MALS068X MALS068X MALS068X D L L L L 2012 141 161 162 163 (B,139,8) (A,37,97) (A,36,84) (A,39,87) (B,49,76) Diode Diode Diode Diode Diode 2SC4081 RSF014N03 DTC143EUA HAT2210RJ C Diode Diode Diode Diode Diode 4 Circuit Symbol and No. Inductor Chip Coil Inductor Inductor Part No. L L L L 401 402 403 404 (B,152,84) (A,148,79) (A,150,40) (B,149,50) L L L L L 521 601 902 903 951 (B,18,23) Inductor (A,99,41) Inductor (A,73,44) Inductor (B,70,48) Inductor (A,28,107) Inductor CTF1713 LCTAW2R2J2520 CTF1387 CTF1381 CTF1389 L L L L L 952 1021 1022 1141 1201 (A,20,103) Inductor (B,142,15) Inductor (A,136,10) Inductor (A,39,63) Inductor (A,48,53) Inductor CTF1379 DTL1100 CTH1262 ATH7061 CTH1253 L L L L L 1202 1203 1204 1205 1206 (A,38,56) (A,33,46) (A,46,24) (A,34,22) (A,41,31) CTF1661 CTF1661 CTH1253 CTF1661 CTF1661 L X P P P 1207 601 101 102 121 (A,19,53) Inductor CTH1253 (A,107,40) Oscillator 15 MHz CSS1776 (A,152,111) Poly Switch MINISMDC075F/24 (B,109,109) Poly Switch MINISMDC075F/24 (A,86,85) Poly Switch MINISMDC075F/24 Inductor Inductor Inductor Inductor Inductor LCTAW220J2520 LCTAW1R0J2520 LCTAW1R0J3225 CTF1379 P 401 >P1021 >P1022 >P1201 >P1202 (B,151,90) Surge Protector (B,137,20) Fuse 1 A (B,136,17) Fuse 1.75 A (B,19,46) Fuse 4 A (A,61,57) Fuse 1 A IMSA-6801-01Y901 CEK1280 CEK1283 CEK1344 CEK1280 >P1203 >P1341 BZ601 U 401 (A,66,24) Fuse 2.5 A CEK1285 (A,40,16) Fuse 1.5 A CEK1282 (A,159,12) Buzzer CPV1062 (A,158,86) FM/AM Tuner Unit(UC) CWE2098 (A,158,86) FM/AM Tuner Unit(EW5,UW5) CWE2097 RESISTORS D E F L 201 190 Diode Diode Diode Diode Diode Diode MALS068X Choke Coil 600 uH CTH1221 Inductor LCTAW2R2J2520 Inductor LCTAW2R2J2520 Inductor CTF1295 (A,144,79) Inductor R R R R R 101 102 103 104 107 (A,140,111) (A,143,113) (A,132,114) (A,131,112) (A,147,111) RS1/16SS820J RS1/16SS223J RS1/16SS223J RS1/16SS820J RS1/16SS820J R R R R R 108 109 110 111 112 (A,147,114) (A,134,114) (A,137,109) (A,148,111) (A,149,114) RS1/16SS223J RS1/16SS223J RS1/16SS820J RS1/16SS820J RS1/16SS223J R R R R R 113 114 115 117 118 (A,141,113) (A,138,109) (A,120,115) (A,136,114) (A,145,113) RS1/16SS223J RS1/16SS820J RS1/16SS750J RS1/16SS0R0J RS1/16SS0R0J R R R R R 120 121 122 123 124 (A,105,105) (A,88,103) (A,88,104) (A,95,87) (A,98,87) RS1/16SS102J RS1/16SS562J RS1/16SS332J RS1/16SS181J RS1/16SS181J R R R R 125 126 127 128 (A,93,104) (A,97,87) (A,94,87) (A,96,87) RS1/16SS222J RS1/16SS223J RS1/16SS223J RS1/16SS102J LCTAW2R2J2520 AVH-P4100DVD/XN/UC 1 2 3 4 5 Circuit Symbol and No. 6 7 Part No. 8 Circuit Symbol and No. Part No. R 129 (A,93,87) RS1/16SS102J R 325 (B,97,51) RS1/16SS221J R R R R R 161 162 163 164 165 (A,31,80) (A,39,79) (B,43,82) (B,45,87) (A,44,79) RS1/16SS103J RS1/16SS473J RS1/16SS103J RS1/16SS104J RS1/16SS473J R R R R R 326 327 328 329 330 (B,97,52) (A,96,55) (A,99,75) (B,90,70) (B,87,58) RS1/16SS221J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS101J RS1/16SS101J R R R R R 166 167 168 170 171 (B,42,82) (B,46,86) (A,39,80) (A,42,83) (A,44,81) RS1/16SS473J RS1/16SS473J RS1/16SS473J RS1/16SS473J RS1/16SS472J R R R R R 378 406 407 408 409 (A,100,13) (B,152,29) (B,152,33) (B,152,35) (B,152,39) (EW5,UW5) (EW5,UW5) (EW5,UW5) (EW5,UW5) RS1/16SS0R0J RS1/16SS681J RS1/16SS681J RS1/16SS681J RS1/16SS681J R R R R R 172 173 174 175 176 (B,39,72) (A,33,89) (A,39,84) (B,47,77) (A,35,88) RS1/16SS104J RS1/16SS472J RS1/16SS103J RS1/16SS103J RS1/16SS153J R R R R R 410 411 412 413 414 (B,150,48) (B,152,63) (EW5,UW5) (B,152,64) (B,152,65) (B,152,66) RS1/16SS102J RS1/16SS681J RS1/16SS681J RS1/16SS681J RS1/16SS681J R R R R R 177 178 179 180 181 (B,48,82) (B,50,87) (B,40,86) (B,44,89) (B,96,108) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS103J RS1/16SS103J RS1/16SS103J R R R R R 415 416 419 420 421 (B,152,67) (B,152,68) (A,148,35) (EW5,UW5) (A,148,36) (EW5,UW5) (A,150,34) (EW5,UW5) RS1/16SS681J RS1/16SS681J RS1/16SS223J RS1/16SS223J RS1/16SS223J R R R R R 182 183 184 185 186 (B,93,106) (B,92,106) (A,101,112) (A,100,113) (A,100,112) RS1/16SS104J RS1/16SS473J RS1/16SS683J RS1/16SS152J RS1/16SS683J R R R R R 422 425 426 427 428 (A,148,34) (B,143,82) (B,151,29) (B,151,33) (B,151,35) (EW5,UW5) (EW5,UW5) (EW5,UW5) RS1/16SS223J RS1/16SS683J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 187 188 189 202 204 (A,98,113) (A,99,114) (A,95,111) (B,130,100) (B,129,100) RS1/16SS103J RS1/16SS101J RS1/16SS473J RS1/16SS272J RS1/16SS162J R R R R R 429 430 431 432 433 (B,150,39) (EW5,UW5) (B,149,48) (B,150,63) (EW5,UW5) (B,150,64) (B,150,65) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 205 206 207 208 209 (A,132,93) (A,131,93) (A,130,93) (B,125,84) (B,129,83) RS1/16SS102J RS1/16SS102J RS1/16SS102J RS1/16S0R0J RS1/16SS162J R R R R R 434 435 501 521 522 (B,150,67) (B,150,68) (A,98,13) (A,18,108) (A,11,108) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16S0R0J RS1/16S0R0J R R R R R 210 211 212 214 219 (B,128,100) (B,128,82) (B,126,100) (B,130,102) (B,131,83) RS1/16SS162J RS1/16SS272J RS1/16SS272J RS1/16SS0R0J RS1/16SS162J R R R R R 524 525 526 529 530 (A,15,24) (A,17,108) (A,13,108) (A,14,21) (A,14,20) RS1/16SS0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 220 221 301 302 303 (B,130,82) (B,131,79) (B,111,65) (B,111,64) (B,111,63) RS1/16SS272J RS1/16SS0R0J RS1/16SS101J RS1/16SS101J RS1/16SS101J R R R R R 562 563 565 566 568 (A,73,16) (A,74,16) (A,78,24) (A,75,24) (A,70,22) RS1/16SS104J RS1/16SS102J RS1/16SS101J RS1/16SS101J RS1/16SS1003F (EW5,UW5) A B C D E R R R R R 304 305 306 307 308 (B,111,62) (B,87,61) (B,87,60) (B,110,72) (B,87,55) RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/16SS223J RS1/16SS0R0J R R R R R 570 601 602 603 604 (A,77,17) (A,111,40) (A,123,55) (B,135,41) (A,127,26) RS1/16SS103J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 310 311 312 313 314 (B,102,72) (B,111,67) (B,103,72) (B,111,66) (B,115,68) RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/16SS101J RS1/16SS223J R R R R R 605 606 607 608 609 (A,116,26) (A,110,43) (A,130,26) (A,128,55) (A,130,55) RS1/16SS0R0J RS1/16SS102J RS1/16SS104J RS1/16SS681J RS1/16SS472J R R R R 316 317 318 322 (B,89,70) (A,108,59) (A,108,61) (B,87,57) RS1/16SS101J RS1/16SS680J RS1/16SS4R7J RS1/16SS101J R R R R 610 612 617 618 (A,129,55) (A,131,55) (B,123,36) (A,110,36) RS1/16SS681J RS1/16SS102J RS1/16SS472J RS1/16SS104J AVH-P4100DVD/XN/UC 5 6 7 8 F 191 1 2 Circuit Symbol and No. A B C D 3 Part No. 4 Circuit Symbol and No. Part No. R 619 (A,124,26) RS1/16SS104J R 776 (A,72,83) (UW5) RS1/16SS472J R R R R R 620 621 622 623 624 (A,107,18) (A,119,64) (A,124,66) (A,132,55) (A,139,29) RS1/16SS104J RS1/16SS103J RS1/16SS104J RS1/16SS102J RS1/16SS0R0J R R R R R 777 778 779 780 781 (A,75,87) (A,75,84) (A,79,84) (A,66,82) (A,67,82) (UW5) (UW5) (UW5) (UW5) (UW5) RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS101J RS1/16SS101J R R R R R 625 626 627 632 634 (B,124,30) (UW5) (A,117,57) (A,111,27) (A,142,36) (UW5) (A,140,33) RS1/16SS104J RS1/16SS0R0J RS1/16SS333J RS1/16SS104J RS1/16SS104J R R R R R 782 783 784 785 786 (A,74,82) (A,79,87) (B,57,85) (B,55,85) (B,61,85) (UW5) (UW5) (UW5) (UW5) (UW5) RS1/16SS101J RS1/16SS472J RS1/16SS512J RS1/16SS681J RS1/16SS822J R R R R R 635 636 637 638 639 (A,141,33) (A,142,33) (A,139,33) (B,138,34) (B,127,40) RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS102J RS1/16SS104J R R R R R 787 788 789 790 791 (A,63,86) (A,70,87) (A,68,87) (A,63,84) (A,67,84) (UW5) (UW5) (UW5) (UW5) (UW5) RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS472J R R R R R 641 642 643 644 645 (B,81,52) (UW5) (B,134,34) (B,135,42) (A,140,30) (A,124,55) RS1/16SS104J RS1/16SS102J RS1/16SS104J RS1/16SS472J RS1/16SS103J R R R R R 792 793 798 801 802 (A,68,84) (UW5) (A,75,82) (UW5) (B,64,88) (UW5) (B,166,10) (B,166,7) RS1/16SS472J RS1/16SS101J RS1/16S0R0J RS1/16S181J RS1/16S181J R R R R R 646 647 648 649 650 (A,116,57) (A,120,26) (A,122,26) (B,122,40) (A,121,26) RS1/16SS182J RS1/16SS221J RS1/16SS221J RS1/16SS104J RS1/16SS104J R R R R R 803 804 902 903 905 (B,167,11) (B,168,9) (B,77,41) (B,75,39) (B,76,36) RS1/16SS103J RS1/16SS332J RS1/16SS0R0J RS1/16SS0R0J RS1/16S0R0J R R R R R 651 652 654 655 656 (A,116,55) (A,126,55) (B,122,43) (A,115,26) (A,109,28) RS1/16SS182J RS1/16SS102J RS1/16SS104J RS1/16SS333J RS1/16SS681J R R R R R 906 907 908 909 910 (B,80,38) (B,61,29) (B,63,29) (B,69,36) (B,77,50) RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS471J RS1/16SS102J R R R R R 657 658 659 660 661 (A,109,29) (B,123,48) (B,126,47) (B,126,46) (A,123,26) RS1/16SS681J RS1/16SS101J RS1/16SS104J RS1/16SS104J RS1/16SS102J R R R R R 911 912 913 914 915 (B,70,42) (B,76,47) (B,70,44) (B,76,44) (B,91,37) RS1/16SS221J RS1/16SS221J RS1/16SS221J RS1/16SS221J RS1/16SS102J R R R R R 662 663 664 665 667 (A,119,66) (A,127,55) (B,130,49) (B,121,54) (A,110,46) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS1501D RS1/16SS104J RS1/16SS102J R R R R R 916 951 952 953 954 (B,71,53) (A,24,101) (A,24,103) (A,28,106) (A,20,108) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS473J RS1/16SS121J RS1/16SS104J R R R R R 668 669 670 671 674 (A,105,26) (A,109,33) (A,109,30) (A,109,31) (B,81,53) (UW5) RS1/16SS104J RS1/16SS102J RS1/16SS681J RS1/16SS681J RS1/16SS473J R R R R R 955 1001 1003 1004 1005 (A,20,109) (B,26,83) (B,19,80) (B,16,84) (B,16,82) RS1/16SS103J RS1/16SS271J RS1/16SS391J RS1/16S2R2J RS1/16S2R2J R R R R R 675 677 678 751 752 (B,78,56) (UW5) (B,135,44) (B,131,43) (A,138,76) (A,142,75) RS1/16SS473J RS1/16SS472J RS1/16SS102J RS1/16SS150J RS1/16SS470J R R R R R 1006 1007 1021 1022 1023 (B,18,84) (B,18,82) (B,131,17) (B,132,17) (B,133,17) RS1/16S2R2J RS1/16S2R2J RS1/16SS331J RS1/16SS331J RS1/16SS103J R R R R R 753 754 755 756 771 (A,138,75) (A,142,74) (A,136,70) (A,144,67) (A,73,87) (UW5) RS1/16SS101J RS1/16SS101J RS1/16SS102J RS1/16S0R0J RS1/16SS472J R R R R R 1025 1026 1027 1061 1081 (B,131,20) (B,128,8) (B,126,11) (A,11,95) (B,146,24) RS1/16SS0R0J RS1/16SS103J RS1/16SS103J RS1/16SS473J RS1/16SS0R0J R R R R 772 773 774 775 (A,73,84) (A,67,87) (A,70,83) (A,72,87) RS1/16SS472J RS1/16SS472J RS1/16SS472J RS1/16SS472J R R R R 1141 1144 1145 1146 (A,36,76) (B,38,67) (B,33,61) (B,40,65) RS1/16SS681J RS1/16SS9100D RS1/16SS512J RS1/16SS3003D E F 192 (UW5) (UW5) (UW5) (UW5) AVH-P4100DVD/XN/UC 1 2 3 4 5 6 Circuit Symbol and No. 7 Part No. Circuit Symbol and No. 8 Part No. C 108 C 109 C 110 (A,109,114) (A,114,114) (A,123,114) CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 C C C C C 111 141 142 161 162 (B,154,109) (A,57,96) (A,43,89) (A,33,83) (A,33,85) CKSRYB104K50 CEAT332M16 CKSRYB104K50 CKSRYB105K10 CKSRYB104K50 C C C C C 163 164 165 166 167 (A,33,87) (B,41,76) (A,41,86) (A,37,88) (B,46,78) CKSRYB104K50 CKSRYB104K50 CKSRYB103K50 CKSRYB104K50 CKSRYB104K50 C C C C C 181 182 183 184 185 (B,98,106) 10 uF (B,78,104) (B,80,104) (B,85,104) (B,83,104) DCH1201 CKSRYB474K16 CKSRYB474K16 CKSRYB474K16 CKSRYB474K16 C C C C C 186 187 188 189 190 (A,101,114) (B,80,108) (B,78,108) (B,83,108) (B,85,108) CKSQYB475K10 CKSQYB474K16 CKSQYB474K16 CKSQYB474K16 CKSQYB474K16 C C C C C 191 192 193 194 195 (B,88,103) (A,66,114) (B,90,104) 10 uF (B,88,107) (B,49,102) CKSQYB225K16 CKSRYB104K50 CCG1236 CKSQYB225K16 CKSQYB104K50 C C C C C 202 204 205 206 207 (B,135,100) (B,140,100) (B,141,100) (B,143,99) (A,140,94) CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSSYB104K10 CEVW100M10 RS1/16SS471J RS1/16SS750J RS1/16SS750J RS1/16SS471J RS1/16SS102J C C C C C 208 209 211 212 213 (A,127,94) (B,134,83) (B,138,83) (B,140,83) (B,141,83) CEVW100M10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSSYB104K10 (B,27,12) (A,33,16) (B,131,10) (B,129,10) (B,138,9) RS1/16SS102J RS1/16SS102J RS1/16SS223J RS1/16SS223J RS1/16SS750J C C C C C 214 215 216 222 223 (B,143,83) (A,132,82) (B,127,83) (A,140,86) (B,133,83) CKSSYB224K6R3 CEVW470M16 CKSSYB104K16 CEVW470M16 CKSSYB104K10 2016 2017 2018 2019 2020 (B,126,8) (B,126,10) (B,111,9) (A,144,15) (B,131,13) RS1/16S0R0J RS1/16S0R0J RS1/16SS750J RS1/16SS102J RS1/16SS0R0J C C C C C 224 227 228 307 308 (A,146,79) (B,137,100) (B,135,83) (B,104,52) (B,105,52) CKSSYB104K10 CKSRYB105K10 CKSRYB105K10 CKSSYB104K10 CKSSYB104K10 R 2021 R 2022 (B,133,13) (B,138,14) RS1/16SS0R0J RS1/16SS0R0J C C C C C 309 310 312 313 315 (B,113,66) (B,113,63) (B,113,65) (B,113,62) (B,90,61) CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 C C C C C 316 321 322 323 324 (B,90,60) (B,103,74) (B,113,69) (B,108,73) (B,113,68) CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 C 325 C 326 (A,104,61) (B,105,72) CEVW470M16 CKSSYB104K10 R R R R R 1147 1148 1150 1151 1152 (B,35,66) (B,35,61) (B,42,63) (B,38,59) (B,46,58) RS1/16S5101D RS1/16SS0R0J RS1/16SS1102D RS1/16SS621J RS1/16SS0R0J R R R R R 1154 1201 1202 1203 1204 (B,38,66) (B,38,29) (B,50,40) (B,40,51) (B,46,52) RS1/16SS0R0J RS1/16SS2R2J RS1/16SS823J RS1/16SS2R2J RS1/16SS0R0J R R R R R 1205 1206 1207 1208 1209 (B,44,51) (B,43,52) (B,43,50) (B,44,50) (B,44,49) RS1/16SS151J RS1/16SS4702D RS1/16SS6801D RS1/16SS1002D RS1/16SS303J R R R R R 1210 1211 1212 1213 1214 (A,35,46) (A,38,33) (B,50,39) (B,46,34) (B,46,32) RS1/16SS10R0D RS1/16SS10R0D RS1/16SS102J RS1/16SS303J RS1/16SS8202D R R R R R 1215 1216 1217 1218 1219 (B,45,32) (B,44,30) (B,45,30) (B,48,32) (B,50,44) RS1/16SS102J RS1/16SS9101F RS1/16SS330J RS1/16SS0R0J RS1/16SS0R0J R R R R R R R R 1220 1224 1225 1226 1343 2001 2003 2004 (B,50,43) (B,42,52) (B,37,48) (B,37,35) (A,38,16) (B,70,27) (UW5) (B,65,17) (UW5) (B,72,27) (UW5) RS1/16SS0R0J RS1/16SS102J RS1/10SR103J RS1/10SR103J RS1/16SS221J RS1/16SS750J RS1/16SS0R0J RS1/16SS750J R R R R R 2005 2006 2007 2009 2010 (B,57,20) (B,72,26) (B,70,26) (B,56,16) (B,59,20) R R R R R 2011 2012 2013 2014 2015 R R R R R (UW5) (UW5) (UW5) (UW5) (UW5) CAPACITORS C C C C C 101 102 103 104 105 (A,140,106) (A,134,106) (A,106,98) (A,142,106) (A,136,106) CKSQYB475K10 CKSQYB475K10 CEVW101M16 CKSQYB475K10 CKSQYB475K10 C 106 C 107 (A,144,106) (A,138,106) CKSQYB475K10 CKSQYB475K10 AVH-P4100DVD/XN/UC 5 6 7 8 A B C D E F 193 1 2 Circuit Symbol and No. A B C D E F 3 Part No. 4 Circuit Symbol and No. Part No. C 331 C 334 C 335 (B,105,71) (A,97,80) (B,97,73) CKSSYB104K10 CEVW470M16 CKSSYB104K10 C 903 C 952 C 1002 (A,75,33) (A,23,107) (A,19,79) CKSSYB104K10 CKSSYB104K10 CEVW470M6R3 C C C C C 336 337 338 339 340 (A,96,70) (B,97,72) (B,90,68) (B,90,67) (B,90,58) CEVW220M16 CKSSYB104K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 C C C C C 1003 1005 1006 1007 1021 (B,19,70) (A,16,65) (B,19,78) (B,30,80) (A,147,10) CKSSYB103K16 CEAT102M16(P30) CKSRYB103K50 CKSRYB104K50 CEVW101M16 C C C C C 341 342 343 345 346 (B,90,57) (B,90,55) (B,90,53) (A,98,50) (A,106,50) CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CEVW221M4 CEVW101M6R3 C C C C C 1022 1023 1024 1025 1061 (B,134,9) (B,137,13) (A,118,8) (A,138,20) (UW5) (A,11,91) CKSRYB104K50 CKSYB475K16 CEAT102M10(P30) CEVW220M16 CKSYB105K35 C C C C C 347 403 405 406 408 (A,103,70) (B,164,46) (A,150,81) (B,152,44) (A,148,86) CEVW220M16 CKSSYB103K16 CKSSYB103K16 CKSQYB106K6R3 CEVW101M10 C C C C 1081 1082 1083 1084 (A,20,95) (A,148,20) (B,151,17) (B,150,23) CEVW101M10 CEVW220M16 CKSSYB103K16 CKSQYB475K10 C C C C C 409 521 522 523 561 (B,164,40) (B,16,27) (B,15,28) (B,19,25) (A,76,15) CKSSYB103K16 CKSSYB105K6R3 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C 1141 1142 1144 1145 (A,32,77) (B,42,62) (B,38,68) (B,29,65) 4.7 uF CKSSYB104K16 CKSSYB104K16 CCSSCH271J25 CCG1222 C C C C C 563 564 601 602 603 (A,76,16) (A,17,18) (A,110,38) (A,110,40) (A,101,38) CKSSYB104K10 CKSRYB105K6R3 CCSSCH7R0D50 CCSSCH7R0D50 CKSQYB106K6R3 C C C C C 1146 1147 1148 1201 1202 (B,41,65) (B,44,60) 4.7 uF (B,38,65) (A,19,37) (A,55,42) CKSSYB103K16 CCG1222 CKSRYB104K16 CEAT472M16(P30) CEHAZL331M16(P30) C C C C C 605 606 607 608 609 (B,114,37) (A,117,55) (B,122,51) (B,135,40) (A,139,28) CKSSYB102K50 CKSRYB105K10 CKSSYB103K16 CKSSYB103K16 CKSSYB103K16 C C C C C 1203 1207 1208 1209 1210 (A,55,33) (B,44,52) (B,44,48) (B,46,49) (B,41,48) CEHAZL331M16(P30) CCSSCH331J50 CCSSCH151J50 CKSRYB683K50 CKSQYB335K10 C C C C C 610 611 612 613 615 (A,126,26) (A,117,26) (B,122,42) (B,126,42) (B,128,58) CKSSYB103K16 CKSSYB103K16 CKSSYB102K50 CKSQYB475K10 CCSSCH101J50 C C C C C 1211 1212 1213 1214 1215 (B,39,48) (B,35,40) (B,22,51) 10 uF (A,31,27) 10 uF (B,38,34) CKSRYB333K25 CKSYB105K35 CCG1223 CCG1223 CKSRYB333K25 C C C C C 618 619 751 752 753 (A,105,23) (B,121,35) (A,138,74) (A,142,73) (A,138,73) CKSRYB105K10 CCSSCH101J50 CKSSYB102K50 CKSSYB102K50 CKSSYB104K10 C C C C C 1216 1217 1218 1219 1220 (A,30,51) 10 uF (B,50,35) (B,43,33) (B,47,34) (B,41,33) CCG1223 CKSSYB103K16 CCSRCH101J50 CKSRYB683K50 CKSQYB335K10 C C C C C 771 772 773 774 775 (A,77,87) (A,77,84) (A,65,86) (A,64,83) (B,74,91) (UW5) (UW5) (UW5) (UW5) (UW5) CCSRCH6R0D50 CCSRCH6R0D50 CCSRCH6R0D50 CCSRCH6R0D50 CKSQYB106K6R3 C C C C C 1221 1222 1226 1227 1228 (B,46,35) (B,46,30) (A,57,56) 10 uF (A,57,54) (A,61,23) CCSSCH151J50 CCSSCH151J50 CCG1236 CKSSYB104K10 CKSSYB104K10 C C C C C 776 777 778 779 780 (B,70,91) (B,68,91) (A,74,91) (B,72,91) (B,56,85) (UW5) (UW5) (UW5) (UW5) (UW5) CKSQYB106K6R3 CKSQYB106K6R3 CKSQYB106K6R3 CKSQYB106K6R3 CKSRYB104K16 C C C C C 1229 1230 1231 1341 1342 (A,60,24) 10 uF (B,22,48) (B,47,49) (A,45,10) 100 uF/16 V (A,39,8) CCG1236 CKSYB105K35 CKSSYB103K16 CCH1477 CKSRYB105K10 C C C C C 781 782 785 786 787 (B,63,85) (B,59,85) (A,81,84) (A,81,87) (A,69,91) (UW5) (UW5) (UW5) (UW5) (UW5) CKSRYB104K16 CKSSYB102K50 CKSQYB106K6R3 CKSQYB106K6R3 CKSQYB106K6R3 C C C C C 1343 1344 1402 1403 1500 (A,34,14) (A,32,17) (B,54,69) (B,48,72) (A,63,23) CKSRYB104K16 CKSSYB102K50 CKSRYB474K10 CKSRYB105K10 CKSSYB102K50 C 901 C 902 (A,66,28) (B,68,51) C C C C 2001 2002 2003 2004 (B,110,11) (B,154,27) (B,134,9) (B,127,13) CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 194 CKSSYB104K10 CCSSCH101J50 AVH-P4100DVD/XN/UC 1 2 3 4 5 Circuit Symbol and No. C 2005 (B,22,22) 6 7 Part No. 8 Circuit Symbol and No. CKSRYB104K50 E Unit Number : (UC,EW5) Unit Number : (UW5) Unit Name : Keyboard Unit MISCELLANEOUS Part No. IC 6101 IC 6151 Q 5001 Q 5002 (A,16,38) IC (A,18,22) IC (B,116,19) Transistor (B,106,12) Transistor TK11840L NJM082BV UMX1N 2SC4081 Q Q Q Q Q 5003 5004 5401 5402 5403 (B,116,27) (B,113,12) (A,104,20) (B,104,20) (B,101,20) UMX1N 2SC4081 FMG12 UMF5N UMF5N Transistor Transistor Transistor Transistor Transistor D D S S S 3002 3005 3001 3002 3003 Chip LED Chip LED Switch(SOURCE) Switch(FORWARD) Switch(REVERSE) NSSM038A-6430 NSSM038A-6430 VSG1020 VSG1020 VSG1020 Q Q Q Q Q 5451 5452 5501 5502 5503 (B,71,20) Transistor (B,68,30) Transistor (A,119,65) FET (A,110,68) FET (A,98,53) Transistor 2SC4081 2SA1576A RSQ035P03 RSQ035P03 2SA1577 S S S S S 3004 3005 3006 3007 3008 Switch(VOL-) Push Switch(RESET) Switch(EJECT) Switch(MUTE) Switch(DISP.OFF) VSG1020 CSG1155 VSG1020 VSG1020 VSG1020 Q Q Q Q Q 5504 5505 5561 5562 6001 (A,98,56) (A,96,67) (A,93,56) (A,97,50) (B,18,28) 2SC4097 IMZ4 UMX2N UMZ1N UMZ1N S 3009 U 3001 Switch(VOL+) Remote Receiver Unit VSG1020 RS-470 Q Q Q Q Q 6002 6003 6101 6102 6103 (B,24,31) Transistor (B,25,28) Transistor (A,17,34) Digital Transistor (A,16,43) FET (A,7,21) Digital Transistor 2SC4097 2SA1577 DTC143EUA CPH6424 DTC143EUA Q D D D D 6151 5401 5402 5403 5404 (B,21,22) FET (A,98,21) Diode (A,113,15) Diode (A,110,21) Diode (A,98,12) Diode RUE003N02 MA111 UDZS5R6(B) UDZS5R6(B) UDZS5R6(B) D D D D D 5405 5501 5502 5503 5504 (A,97,16) Diode (A,121,55) Diode (A,107,64) Diode (B,98,65) Diode (B,98,67) Diode UDZS5R6(B) RSX201L-30 RB160M-30 RB548W RB548W A B RESISTORS R R R R R 3001 3005 3006 3007 3008 RS1/16S470J RS1/16S0R0J RS1/16S182J RS1/16S392J RS1/16S392J R 3009 R 3010 R 3011 RS1/16S103J RS1/16S182J RS1/16S103J CAPACITORS C C C C C Transistor Transistor Transistor Transistor Transistor 3005 3006 3007 3008 3012 CKSRYB104K50 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 D D D D D 5505 5506 5507 6101 6102 (B,96,59) Diode (B,96,57) Diode (B,96,54) Diode (A,8,41) Diode (A,8,44) Diode RB548W RB548W RB548W RB050L-60 UDZS36(B) C 3013 C 3014 CKSRYB104K16 CKSRYB104K16 L L L L L 5101 5201 5301 5302 5401 (A,102,26) Inductor (A,52,57) Inductor (A,48,57) Inductor (A,21,64) Inductor (A,98,27) Inductor CTF1635 CTF1473 CTF1473 CTF1382 CTF1473 L L L L L 5451 5452 5453 5454 5501 (B,76,21) Inductor CTF1379 (B,68,23) Inductor LCTAW220J2520 (B,68,25) Chip Coil LCTAW270J2520 (A,68,25) Inductor LCTAW101J2520 (A,117,73) Choke Coil 18 uH CTH1250 F Unit Number : CWN3797(UC,EW5) Unit Number : CWN3796(UW5) Unit Name : Monitor Unit MISCELLANEOUS IC 5001 IC 5101 IC 5102 IC 5201 IC 5301 (A,118,22) IC (A,111,39) BLANK IC (B,119,34) IC (A,65,68) IC (A,33,57) SDRAM(128 M) BH2227AFV PE5669A8 S-93C56BD0I-J8 PEH208A8 K4S281632K-UC75 L L L L L 5502 5503 5504 5505 5506 (A,110,73) (A,123,73) (B,121,57) (A,125,61) (B,103,73) IC 5451 IC 5501 IC 5601 IC 5701 IC 5702 (B,75,18) IC (B,109,61) IC (A,83,34) IC(UW5) (B,44,36) Logic IC (B,50,54) IC NJM2505AF BD6171KV AK5406XQ TC7SHU04FUS1 MN103SE60PUB L L L L L 5507 5508 5509 5510 5601 (A,102,71) Choke Coil 68 uH CTH1318 (B,94,63) Inductor CTF1635 (B,100,50) Inductor CTF1635 (B,96,72) Inductor DTL1096 (A,65,30) Inductor(UW5) CTF1473 IC 6005 (B,63,13) Logic IC TC74VHCT04AFTS1 L 5602 6 (A,64,35) Inductor(UW5) 7 D E Choke Coil 10 uH CTH1249 Choke Coil 10 uH CTH1249 Inductor CTF1635 Inductor DTL1136 Inductor CTF1488 F CTF1473 AVH-P4100DVD/XN/UC 5 C 8 195 1 2 Circuit Symbol and No. A 3 Part No. L L L L 5603 5701 5702 5705 (A,68,43) (A,53,49) (A,59,50) (A,52,54) Inductor(UW5) Inductor Inductor Inductor CTF1635 CTF1635 CTF1635 CTF1473 L L L L L 5706 5707 5708 5709 5710 (B,39,29) (B,34,29) (B,57,27) (B,28,31) (A,48,44) Inductor Inductor Inductor Inductor Inductor CTF1748 CTF1748 CTF1748 CTF1748 CTF1748 L L L L L 5711 5712 5713 5714 5715 (A,48,42) (A,46,42) (A,46,40) (A,45,42) (A,45,37) Inductor Inductor Inductor Inductor Inductor CTF1748 CTF1748 CTF1748 CTF1748 CTF1748 L L L L L 5716 5717 5718 5719 5720 (A,44,41) (A,43,38) (A,43,42) (A,42,37) (A,42,42) Inductor Inductor Inductor Inductor Inductor CTF1748 CTF1748 CTF1748 CTF1748 CTF1748 L L L L L 5721 5722 5723 5724 5725 (B,38,37) (B,37,38) (B,34,39) (B,34,40) (B,34,41) Inductor Inductor Inductor Inductor Inductor CTF1748 CTF1748 CTF1748 CTF1748 CTF1748 L L L L L 5726 5727 5728 6001 6004 (B,32,41) (B,32,39) (B,31,39) (A,64,12) (A,63,14) Inductor Inductor Inductor Inductor Inductor CTF1748 CTF1748 CTF1748 CTF1306 CTF1306 L L L L L 6005 6006 6007 6008 6101 (A,37,41) Inductor (A,30,41) Inductor (A,25,38) Inductor (B,23,38) Inductor (A,56,9) Choke Coil 3.3 uH L X X X P 6102 5101 5701 5702 6101 (A,8,35) Choke Coil 3.3 uH CTH1419 (A,123,42) Ceramic Resonator 20.000 MHz VSS1186 (B,44,30) Oscillator 9.597 MHz CSS1778 (B,55,32) Radiator 33.000 MHz CSS1634 (A,65,8) Poly Switch MINISMDC075F/24 B C D CTF1635 DTL1096 CTF1635 DTL1096 CTH1419 RESISTORS E F R R R R R 5001 5002 5003 5004 5006 (B,113,17) (B,114,17) (B,115,17) (B,111,21) (B,114,24) RS1/16SS201J RS1/16SS151J RS1/16SS0R0J RS1/16SS103J RS1/16SS201J R R R R R 5007 5008 5009 5011 5012 (B,115,24) (B,116,24) (B,109,25) (B,116,21) (B,115,21) RS1/16SS151J RS1/16SS0R0J RS1/16SS103J RS1/16SS271J RS1/16SS271J R R R R R 5013 5014 5016 5017 5018 (B,115,23) (B,118,20) (B,118,29) (B,120,29) (B,122,29) RS1/16SS0R0J RS1/16SS103J RS1/16SS271J RS1/16SS271J RS1/16SS0R0J R R R R 5019 5021 5022 5023 (B,119,27) (B,108,15) (B,108,13) (B,108,11) RS1/16SS103J RS1/16SS221J RS1/16SS221J RS1/16SS0R0J 196 4 Circuit Symbol and No. Part No. R 5024 (B,106,15) RS1/16SS103J R R R R R 5026 5027 5028 5029 5031 (B,115,13) (B,115,12) (B,114,11) (B,112,14) (B,121,21) RS1/16SS221J RS1/16SS221J RS1/16SS0R0J RS1/16SS103J RS1/16S0R0J R R R R R 5033 5036 5037 5040 5101 (A,67,15) (A,59,34) (A,61,34) (B,68,37) (A,97,37) RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS473J R R R R R 5102 5103 5104 5105 5106 (A,98,34) (A,98,33) (A,99,40) (A,99,39) (A,99,37) RS1/16SS471J RS1/16SS471J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS471J R R R R R 5107 5108 5109 5110 5111 (A,97,36) (A,106,28) (A,105,51) (A,99,38) (A,107,27) RS1/16S0R0J RS1/16SS471J RS1/16SS471J RS1/16SS471J RS1/16SS4701D R R R R R 5112 5113 5114 5115 5116 (B,107,44) (A,110,25) (A,110,27) (A,108,28) (A,111,27) RS1/16SS473J RS1/16SS472J RS1/16SS472J RS1/16SS471J RS1/16SS471J R R R R R 5117 5118 5119 5120 5121 (B,109,45) (B,110,45) (B,116,46) (A,111,51) (B,112,45) RS1/16SS473J RS1/16SS473J RS1/16SS471J RS1/16SS0R0J RS1/16SS473J R R R R R 5122 5123 5124 5125 5126 (A,112,51) (A,113,51) (A,113,28) (A,99,42) (UW5) (B,112,33) RS1/16SS471J RS1/16SS471J RS1/16SS471J RS1/16SS473J RS1/16SS101J R R R R R 5127 5128 5129 5130 5131 (A,114,53) (A,115,28) (A,116,28) (A,115,51) (UW5) (A,118,28) RS1/16SS471J RS1/16SS471J RS1/16SS471J RS1/16SS471J RS1/16SS471J R R R R R 5132 5133 5134 5135 5136 (A,117,51) (UW5) (A,118,51) (UW5) (B,108,48) (A,108,52) (B,114,39) RS1/16SS470J RS1/16SS470J RS1/16SS471J RS1/16SS471J RS1/16SS473J R R R R R 5137 5138 5139 5140 5142 (B,115,38) (A,109,52) (B,107,42) (UC,EW5) (A,123,35) (A,120,51) RS1/16SS473J RS1/16SS471J RS1/16SS473J RAB4CQ102J RS1/16SS104J R R R R R 5144 5145 5146 5147 5148 (B,122,31) (B,121,46) (A,122,38) (A,122,37) (B,122,45) RS1/16SS473J RS1/16SS102J RS1/16SS103J RS1/16SS103J RS1/16SS104J R R R R 5150 5151 5152 5153 (B,122,38) (A,122,47) (B,109,32) (A,123,28) RS1/16S0R0J RS1/16S0R0J RS1/16SS473J RS1/16SS473J AVH-P4100DVD/XN/UC 1 2 3 4 5 Circuit Symbol and No. 6 7 Part No. Circuit Symbol and No. 8 Part No. R 5154 (A,99,41) RS1/16SS473J R 5315 (A,41,48) RS1/16SS820J R R R R R 5201 5202 5203 5204 5205 (A,52,76) (A,49,75) (A,52,74) (A,50,74) (A,52,73) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5316 5317 5318 5319 5320 (A,43,48) (A,44,48) (A,45,48) (A,35,47) (A,43,45) RS1/16SS820J RS1/16SS820J RS1/16SS820J RS1/16S0R0J RS1/16S0R0J R R R R R 5206 5207 5208 5209 5210 (A,50,72) (A,52,72) (A,50,71) (A,52,70) (A,50,70) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5322 5323 5324 5325 5326 (A,33,68) (A,36,68) (A,42,68) (A,46,59) (A,21,66) RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS0R0J R R R R R 5211 5212 5213 5214 5215 (A,54,76) (A,53,60) (A,52,69) (A,50,60) (A,52,68) RS1/16SS0R0J RS1/16SS220J RS1/16SS0R0J RS1/16SS102J RS1/16SS0R0J R R R R R 5327 5328 5329 5330 5331 (A,21,67) (A,23,67) (A,24,66) (A,25,66) (A,26,66) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5216 5217 5218 5219 5220 (A,50,67) (A,48,67) (A,50,66) (A,52,65) (A,52,64) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5332 5333 5334 5335 5336 (A,26,68) (A,27,66) (A,28,66) (A,29,66) (A,30,68) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5221 5222 5223 5224 5225 (A,52,63) (A,52,62) (A,50,61) (A,78,75) (A,72,76) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5337 5338 5339 5340 5341 (A,31,66) (A,34,66) (A,35,68) (A,35,66) (A,38,68) RS1/16SS0R0J RS1/16SS820J RS1/16SS820J RS1/16SS820J RS1/16SS820J R R R R R 5226 5227 5228 5229 5230 (A,78,73) (A,72,78) (A,78,72) (A,71,76) (A,78,71) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5342 5343 5344 5345 5401 (A,38,66) (A,39,68) (A,40,68) (A,42,66) (A,106,23) RS1/16SS820J RS1/16SS820J RS1/16SS820J RS1/16SS820J RS1/16SS102J R R R R R 5231 5232 5233 5234 5235 (A,70,78) (A,78,70) (A,70,76) (A,78,66) (A,69,78) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5402 5403 5404 5405 5406 (A,100,13) (A,99,16) (A,112,13) (A,109,19) (A,107,20) RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS102J R R R R R 5236 5237 5238 5239 5240 (A,78,65) (A,68,76) (A,78,64) (A,66,76) (A,70,61) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5407 5408 5410 5411 5412 (A,95,13) (A,97,19) (B,104,17) (B,102,18) (B,104,22) RS1/16SS105J RS1/16SS105J RS1/16SS103J RS1/16SS103J RS1/16SS103J R R R R R 5241 5242 5243 5244 5245 (A,77,63) (A,74,60) (A,75,59) (A,78,74) (A,79,68) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS102J RS1/16S0R0J R R R R R 5413 5451 5453 5454 5455 (B,100,17) (B,78,11) (B,76,12) (B,75,11) (B,69,15) RS1/16SS103J RS1/16SS0R0J RS1/16SS101J RS1/16SS101J RS1/16SS0R0J A B C D E R R R R R 5301 5302 5303 5304 5305 (A,21,51) (A,23,48) (A,24,48) (A,26,48) (A,27,48) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5457 5458 5459 5460 5461 (B,72,16) (B,70,14) (B,72,20) (B,69,16) (B,73,18) RS1/16S4701D RS1/16SS6801D RS1/16SS153J RS1/16SS333J RS1/16SS0R0J R R R R R 5306 5307 5308 5309 5310 (A,28,48) (A,29,48) (A,30,46) (A,30,48) (A,32,48) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5462 5463 5466 5467 5469 (B,69,17) (B,68,18) (B,66,28) (B,69,28) (B,65,28) RS1/16SS681J RS1/16SS471J RS1/16SS272J RS1/16SS391J RS1/16SS0R0J R R R R 5311 5312 5313 5314 (A,33,48) (A,38,46) (A,38,48) (A,40,48) RS1/16SS820J RS1/16SS820J RS1/16SS820J RS1/16SS820J R R R R 5501 5502 5503 5504 (A,104,59) (B,122,62) (A,121,69) (B,121,70) RS1/16S0R0J RS1/16S6801D RS1/16S0R0J RS1/16S0R0J AVH-P4100DVD/XN/UC 5 6 7 8 F 197 1 2 Circuit Symbol and No. A B C D E F 3 Part No. R 5505 (B,119,62) RS1/16SS201J R R R R R 5506 5507 5508 5509 5510 (B,120,68) (B,117,60) (B,119,61) (B,117,55) (B,118,67) RS1/16S1002D RS1/16S1001D RS1/16SS201J RS1/16S5100D RS1/16S1001D R R R R R 5511 5512 5513 5514 5515 (B,122,66) (B,116,57) (B,118,68) (A,100,59) (A,99,65) RS1/16SS201J RS1/16S2201D RS1/16S3301D RS1/16S0R0J RS1/16SS103J R R R R R 5516 5517 5518 5519 5520 (B,120,65) (B,117,61) (B,113,68) (A,117,67) (A,109,65) RS1/16SS302J RS1/16SS512J RS1/16SS223J RS1/16SS150J RS1/16SS150J R R R R R 5521 5522 5523 5524 5525 (B,106,70) (A,102,58) (A,105,61) (B,104,53) (B,98,72) RS1/16SS563J RS1/16S0R0J RS1/16S6202D RS1/16S1002D RS1/16S3301D R R R R R 5526 5527 5528 5529 5530 (B,102,53) (B,101,53) (B,98,71) (B,99,53) (B,101,68) RS1/16S4702D RS1/16S7501D RS1/16S1202D RS1/16S0R0J RS1/16S2203D R R R R R R R 5532 5533 5534 5535 5536 5537 5538 (B,98,69) (B,94,72) (A,101,53) (A,103,54) (A,99,67) (A,93,67) (A,94,69) RS1/16S0R0J RS1/16SS153J RS1/16SS470J RS1/16SS470J RS1/16SS102J RS1/16SS103J RS1/16SS103J R R R R R 5561 5562 5563 5564 5565 (A,95,53) (A,94,54) (A,91,56) (A,90,56) (A,91,59) R R R R R 5566 5567 5568 5569 5570 (A,102,51) (A,95,51) (A,100,50) (A,99,48) (A,100,48) R R R R R 5602 5604 5605 5606 5607 (B,84,35) (A,77,23) (A,79,23) (A,84,23) (A,88,23) R R R R R 5608 5609 5610 5611 5612 R R R R R 5613 5614 5615 5616 5617 R 5618 R 5619 198 4 Circuit Symbol and No. Part No. R 5620 R 5621 R 5622 (A,83,45) (UW5) (B,90,25) (UW5) (B,92,25) (UW5) RS1/16S0R0J RS1/16SS222J RS1/16SS222J R R R R R 5623 5701 5702 5703 5704 (B,93,25) (UW5) (B,42,32) (B,45,37) (B,44,32) (B,46,34) RS1/16SS222J RS1/16SS105J RS1/16SS220J RS1/16SS332J RS1/16S0R0J R R R R R 5705 5706 5707 5708 5709 (B,54,34) (B,56,34) (B,57,36) (A,54,41) (A,53,41) RS1/16SS101J RS1/16SS105J RS1/16SS471J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5710 5711 5712 5713 5714 (A,52,41) (A,52,39) (A,51,41) (A,49,41) (A,50,41) RS1/16SS103J RS1/16SS103J RS1/16SS103J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5715 5716 5717 5718 5719 (A,48,41) (A,47,40) (A,47,37) (A,46,38) (A,46,36) RS1/16SS181J RS1/16SS181J RS1/16SS181J RS1/16SS181J RS1/16SS181J R R R R R 5720 5721 5722 5723 5724 (A,44,40) (A,44,37) (A,42,40) (A,42,35) (A,41,40) RS1/16SS181J RS1/16SS181J RS1/16SS181J RS1/16SS181J RS1/16SS181J R R R R R 5725 5726 5727 5728 5729 (B,38,36) (B,36,37) (B,34,37) (B,33,37) (B,62,35) RS1/16SS181J RS1/16SS181J RS1/16SS181J RS1/16SS181J RS1/16SS0R0J RS1/16SS223J RS1/16SS223J RS1/16SS472J RS1/16SS682J RS1/16SS473J R R R R R 5730 5731 5733 5734 5735 (A,58,40) (B,33,31) (B,16,35) (B,39,30) (B,33,29) RS1/16SS0R0J RS1/16SS220J RS1/16SS220J RS1/16SS151J RS1/16SS271J RS1/16SS223J RS1/16SS223J RS1/16SS472J RS1/16SS682J RS1/16SS473J R R R R R 5736 5737 5738 5739 5740 (B,56,27) (B,29,29) (B,36,29) (B,64,38) (B,57,37) RS1/16SS271J RS1/16SS271J RS1/16SS181J RS1/16SS1202D RS1/16SS471J (UW5) (UW5) (UW5) (UW5) (UW5) RS1/16SS473J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J R R R R R 5741 5742 5743 5744 5745 (B,60,36) (B,60,32) (B,60,33) (B,51,32) (B,50,30) RS1/16SS752J RS1/16SS272J RS1/16SS622J RS1/16S0R0J RS1/16S0R0J (A,72,29) (A,73,31) (A,73,33) (A,71,31) (A,94,34) (UW5) (UW5) (UW5) (UW5) (UW5) RS1/16S0R0J RS1/16SS6801F RS1/16SS272J RS1/16S0R0J RS1/16S0R0J R R R R R R 5746 5747 5748 5749 5751 5752 (B,49,30) (B,48,32) (B,40,35) (B,34,31) (B,19,35) (B,85,47) RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS473J (A,71,34) (A,73,35) (A,71,35) (A,71,37) (A,73,38) (UW5) (UW5) (UW5) (UW5) (UW5) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16S0R0J RS1/16SS0R0J R R R R R 5771 5772 5774 5775 5777 (B,33,39) (B,85,37) (UW5) (B,32,37) (B,86,35) (UW5) (B,31,37) RS1/16SS181J RS1/16SS151J RS1/16SS181J RS1/16SS151J RS1/16SS181J R 5778 (B,86,34) (UW5) RS1/16SS221J (A,71,40) (UW5) (A,94,39) (UW5) RS1/16S0R0J RS1/16S0R0J AVH-P4100DVD/XN/UC 1 2 3 4 5 Circuit Symbol and No. 6 7 Part No. Circuit Symbol and No. 8 Part No. R R R R 5780 5781 5783 5784 (B,30,37) (B,82,40) (UW5) (B,87,38) (UW5) (B,71,44) RS1/16SS181J RS1/16SS151J RS1/16SS151J RS1/16S0R0J R R R R 5844 5845 5847 5849 (B,26,60) (B,27,62) (B,28,60) (B,28,62) RS1/16SS151J RS1/16SS151J RS1/16SS151J RS1/16SS151J R R R R R 5785 5786 5787 5788 5789 (B,34,42) (B,31,43) (B,88,37) (UW5) (B,34,44) (B,89,35) (UW5) RS1/16SS680J RS1/16SS680J RS1/16SS151J RS1/16SS680J RS1/16SS151J R R R R R 5850 5851 5852 5853 5855 (A,59,57) (B,73,61) (B,30,61) (B,32,61) (B,34,61) RS1/16SS103J RS1/16S0R0J RS1/16SS151J RS1/16SS820J RS1/16SS151J R R R R R 5790 5791 5792 5793 5794 (B,31,44) (B,90,35) (UW5) (B,30,46) (B,90,33) (UW5) (B,34,47) RS1/16S0R0J RS1/16SS151J RS1/16SS680J RS1/16SS151J RS1/16SS680J R R R R R 5857 5859 5861 5862 5863 (B,30,63) (B,32,62) (B,34,63) (B,71,66) (B,32,66) RS1/16SS680J RS1/16SS680J RS1/16SS680J RS1/16SS102J RS1/16S0R0J R R R R R 5795 5796 5797 5798 5799 (A,85,44) (UW5) (B,30,47) (A,86,45) (UW5) (B,32,47) (A,87,44) (UW5) RS1/16SS151J RS1/16SS680J RS1/16SS151J RS1/16SS680J RS1/16SS151J R R R R R 5865 5866 5867 5868 5869 (B,70,66) (B,33,66) (B,34,66) (B,35,67) (B,69,69) RS1/16S0R0J RS1/16SS680J RS1/16SS680J RS1/16SS680J RS1/16S0R0J R R R R R 5800 5801 5802 5803 5804 (B,28,47) (A,88,45) (UW5) (B,27,47) (A,90,44) (UW5) (B,26,46) RS1/16SS680J RS1/16SS151J RS1/16SS151J RS1/16SS151J RS1/16SS151J R R R R R 5870 5871 5872 5873 5874 (B,34,68) (B,35,69) (B,49,75) (B,63,75) (B,56,75) RS1/16SS680J RS1/16SS680J RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J R R R R R 5805 5806 5807 5808 5809 (A,91,44) (UW5) (B,34,49) (B,73,51) (B,34,50) (B,78,44) (UW5) RS1/16SS151J RS1/16SS680J RS1/16S0R0J RS1/16SS0R0J RS1/16SS151J R R R R R 5875 5876 5877 5878 5879 (B,54,75) (B,47,75) (B,39,72) (B,64,72) (B,63,71) RS1/16S0R0J RS1/16S0R0J RS1/16S0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5810 5811 5812 5813 5814 (B,29,49) (B,80,45) (UW5) (B,26,50) (B,80,47) (UW5) (B,81,46) (UW5) RS1/16SS151J RS1/16SS151J RS1/16S0R0J RS1/16SS151J RS1/16SS151J R R R R R 5880 5881 5882 5883 5884 (B,62,70) (B,65,75) (B,64,75) (B,61,73) (B,61,75) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5815 5816 5817 5818 5819 (B,26,51) (B,82,46) (UW5) (B,29,52) (B,83,46) (UW5) (B,24,50) RS1/16S0R0J RS1/16SS151J RS1/16SS151J RS1/16SS151J RS1/16SS151J R R R R R 5885 5886 5887 5888 5889 (B,60,73) (B,60,75) (B,59,73) (B,59,75) (B,58,73) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5820 5821 5822 5823 5824 (A,59,55) (B,27,53) (A,62,55) (B,34,53) (B,77,54) RS1/16SS103J RS1/16SS151J RS1/16SS103J RS1/16SS151J RS1/16SS102J R R R R R 5890 5891 5892 5893 5894 (B,57,75) (B,56,72) (B,55,70) (B,52,70) (A,59,58) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5825 5826 5827 5828 5829 (B,26,54) (B,71,54) (B,24,54) (B,34,55) (B,71,56) RS1/16SS151J RS1/16S0R0J RS1/16SS151J RS1/16SS151J RS1/16S0R0J R R R R R 5895 5896 5897 5898 5899 (A,55,60) (B,53,73) (A,52,59) (B,52,75) (B,51,75) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5830 5832 5834 5835 5836 (B,31,55) (B,29,55) (B,25,57) (A,59,56) (B,26,57) RS1/16SS151J RS1/16SS151J RS1/16SS151J RS1/16SS103J RS1/16SS151J R R R R R 5900 5901 5902 5903 5904 (B,51,72) (B,50,72) (B,50,74) (B,46,75) (B,46,70) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R R 5837 5838 5839 5841 5842 (B,75,58) (B,29,57) (B,73,58) (B,75,59) (B,29,59) RS1/16SS102J RS1/16S0R0J RS1/16SS102J RS1/16SS103J RS1/16S0R0J R R R R R 5905 5906 5907 5908 5909 (B,46,73) (B,45,71) (B,45,73) (B,44,71) (B,43,73) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R 5843 (B,71,58) RS1/16SS103J R 5910 (B,42,71) RS1/16SS0R0J A B AVH-P4100DVD/XN/UC 5 6 7 8 C D E F 199 1 Circuit Symbol and No. A 2 3 Part No. D E F Part No. R R R R 5911 5912 5913 5914 (B,42,73) (B,41,71) (B,41,73) (B,40,75) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J R R R R 6152 6153 6154 6155 (A,17,17) (B,17,18) (B,17,21) (A,20,29) RS1/16S3901D RS1/16SS102J RS1/16SS102J RS1/16S1002D R R R R R 5915 5916 5917 5918 5919 (B,38,73) (B,37,71) (B,37,73) (B,36,71) (B,67,41) (UC,EW5) RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS103J R R R R R 6156 6157 6158 6160 6161 (A,20,27) (B,21,20) (A,15,29) (A,21,17) (B,18,20) RS1/16S1002D RS1/16SS102J RS1/10S0R0J RS1/10S0R0J RS1/16SS153J R R R R R 5920 5921 6001 6008 6010 (A,65,41) (UC,EW5) (A,66,41) (UC,EW5) (B,59,10) (B,61,26) (A,61,15) RS1/16SS103J RS1/16SS103J RS1/16SS681J RS1/10S0R0J RS1/16SS0R0J R R R R R 6011 6012 6013 6014 6015 (A,61,13) (A,61,21) (A,61,24) (A,61,17) (A,61,19) RS1/16S10R0D RS1/16SS18R0F RS1/16S1600D RS1/16SS15R0F RS1/16SS82R0D R R R R R 6016 6017 6018 6019 6020 (A,62,21) (A,63,23) (A,63,19) (A,63,16) (A,62,27) RS1/16SS12R0F RS1/16S47R0D RS1/16SS39R0D RS1/16S56R0D RS1/16SS0R0J R R R R R 6021 6022 6025 6026 6027 (A,62,29) (A,64,21) (B,21,24) (B,37,29) (B,20,27) RS1/16SS15R0D RS1/16SS0R0J RS1/16SS101J RS1/16SS102J RS1/16SS333J R R R R R 6028 6029 6030 6031 6032 (B,19,32) (B,23,27) (B,21,32) (B,26,31) (A,64,16) RS1/16SS103J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS100J RS1/16SS82R0D R R R R R 6037 6039 6040 6041 6042 (B,37,31) (B,34,26) (B,20,29) (B,28,29) (B,20,28) RS1/16SS0R0J RS1/16S0R0J RS1/16SS0R0J RS1/16SS200J RS1/16SS0R0J R R R R R 6043 6044 6045 6046 6047 (A,30,32) (A,28,33) (A,25,32) (A,22,33) (A,23,38) RS1/16S4701D RS1/16S5101D RS1/16S5601D RS1/16S4701D RS1/16S2002D R R R R R 6048 6049 6050 6102 6103 (A,22,32) (B,22,28) (B,18,30) (A,12,33) (A,15,35) RS1/16S1801D RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS621J R R R R R 6104 6105 6106 6107 6108 (A,10,20) (A,19,45) (A,14,46) (A,15,49) (A,16,48) RS1/16SS0R0J RS1/16SS512J RS1/16SS102J RS1/16SS1203D RS1/16SS1002D R R R R R 6109 6110 6112 6113 6114 (A,15,46) (A,16,46) (A,7,19) (A,19,37) (A,12,38) RS1/16SS2R7J RS1/16SS5R6J RS1/16S3901D RS1/16SS0R0J RS1/16SS202J R 6151 (A,15,18) RS1/16S3001D B C 4 Circuit Symbol and No. 200 CAPACITORS C C C C C 5007 5012 5015 5016 5101 (B,122,23) (B,82,35) (UW5) (B,73,24) (UW5) (A,12,62) (A,102,28) CKSQYB225K10 CKSSYB102K50 CKSRYB104K50 CKSRYB473K25 CKSQYB106K6R3 C C C C C 5102 5103 5104 5105 5106 (A,100,30) (A,99,35) (A,100,32) (A,105,25) (A,122,45) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 5107 5108 5109 5110 5111 (B,115,42) (B,119,46) (B,119,44) (B,120,39) (A,105,28) CKSRYB474K10 CKSSYB103K16 CKSRYB105K10 CKSSYB104K10 CKSSYB104K10 C C C C C 5202 5203 5301 5302 5303 (A,56,56) (A,78,69) (A,36,48) (A,42,48) (A,48,53) CKSQYB475K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSQYB106K6R3 C C C C C 5304 5305 5306 5307 5308 (A,47,56) (A,21,61) (A,32,66) (A,37,65) (A,41,66) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 5309 5401 5402 5403 5404 (A,46,62) (A,97,24) (A,102,17) (A,95,14) (A,96,19) CKSSYB104K10 CKSSYB473K10 CKSSYB473K10 CKSSYB102K50 CKSSYB102K50 C C C C C 5405 5406 5407 5408 5409 (B,102,24) (A,96,16) (A,111,16) (A,112,19) (A,96,13) CKSSYB104K10 CKSSYB102K50 CKSSYB102K50 CKSSYB102K50 CKSSYB102K50 C C C C C 5451 5452 5453 5454 5455 (B,76,14) (B,74,14) (B,70,16) (B,77,19) (B,68,19) CKSQYB106K6R3 CKSQYB106K6R3 CKSQYB106K6R3 CKSSYB104K10 CCSSCH470J50 C C C C C 5456 5457 5458 5459 5460 (B,67,20) (B,69,27) (B,66,27) (B,71,22) (A,68,21) CCSSCH680J50 CCSSCH5R0C50 CCSSCH470J50 CKSSYB104K10 CSZSR330M10 C C C C 5501 5502 5503 5504 (A,110,78) 10 uF (A,114,79) (A,117,78) (A,111,78) DCH1201 CKSSYB104K10 CSZSR330M10 CKSRYB105K6R3 AVH-P4100DVD/XN/UC 1 2 3 4 5 6 Circuit Symbol and No. 7 Part No. 8 Circuit Symbol and No. Part No. C 5505 (A,125,78) 10 uF DCH1201 C 5610 (A,88,25) (UW5) CKSSYB104K10 C C C C C 5506 5507 5508 5509 5510 (A,124,78) (B,120,55) (B,121,61) (A,126,67) 68 uF/6.3 V (A,125,69) CKSRYB105K6R3 CKSSYB104K10 CKSSYB472K25 CCH1440 CKSRYB104K50 C C C C C 5611 5612 5613 5614 5615 (A,67,37) (A,74,29) (A,71,32) (A,71,33) (A,73,32) (UW5) (UW5) (UW5) (UW5) (UW5) CSZSR470M10 CKSSYB104K10 CKSSYB823K10 CKSSYB822K16 CKSSYB104K10 C C C C C 5511 5512 5513 5514 5515 (B,122,65) (B,117,58) (B,119,57) 10 uF (B,117,62) (B,117,64) CKSSYB682K25 CKSSYB104K16 DCH1201 CKSSYB333K16 CCSSCH680J50 C C C C C 5616 5617 5618 5619 5620 (A,92,32) (A,74,37) (A,74,40) (A,92,38) (A,84,44) (UW5) (UW5) (UW5) (UW5) (UW5) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 5516 5517 5518 5519 5520 (B,122,64) (B,122,59) (B,116,65) (A,114,59) (B,115,68) CKSRYB393K50 CKSRYB393K50 CKSRYB103K50 CKSRYB103K50 CKSRYB104K50 C C C C C C 5621 5623 5701 5702 5703 5704 (A,72,43) (UW5) (B,84,23) (UW5) (B,42,27) (A,53,47) (B,45,27) (B,56,29) CKSQYB106K6R3 CCSSCH101J50 CCSSCH120J50 CSZSR470M10 CCSSCH120J50 CCSSCH6R0D50 C C C C C 5521 5522 5525 5526 5527 (A,119,60) 10 uF (A,116,60) 10 uF (B,111,69) (B,109,68) (A,112,62) 10 uF CCG1223 CCG1223 CKSRYB105K16 CKSSYB102K50 CCG1223 C C C C C 5705 5707 5708 5709 5710 (B,54,29) (B,43,34) (B,66,33) (B,68,33) (B,71,33) CCSSCH6R0D50 CKSSYB104K10 CKSQYB106K6R3 CKSQYB106K6R3 CKSRYB105K6R3 C C C C C 5528 5529 5530 5531 5532 (A,112,64) (A,108,57) (B,108,69) (B,105,52) (B,105,69) CKSRYB103K50 CKSSYB102K50 CKSRYB104K50 CKSRYB105K16 CKSRYB105K16 C C C C C 5711 5712 5713 5714 5715 (B,70,33) (B,58,35) (A,60,47) (B,58,37) (B,63,36) CKSRYB105K6R3 CCSSCH330J50 CSZSR470M10 CCSSCH680J50 CKSSYB104K10 C C C C C 5533 5534 5535 5536 5537 (B,104,69) (B,101,58) (B,101,65) (B,101,66) (B,99,60) CKSRYB103K50 CKSRYB104K50 CKSRYB472K50 CKSRYB472K50 CKSRYB103K50 C C C C C 5716 5717 5718 5719 5720 (B,62,36) (B,56,37) (B,63,38) (B,62,38) (B,53,37) CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CKSSYB104K10 CKSSYB105K6R3 C C C C C 5538 5539 5540 5541 5542 (B,99,61) (A,101,67) (B,99,58) (B,99,57) (B,99,55) CKSYB475K16 CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 C C C C C 5721 5722 5723 5724 5725 (B,52,36) (B,48,38) (B,48,35) (B,40,37) (A,56,41) CKSSYB105K6R3 CKSSYB105K6R3 CKSSYB105K6R3 CKSSYB105K6R3 CKSSYB104K10 C C C C C 5543 5544 5546 5547 5548 (A,103,64) 33 uF/10 V (B,95,67) (B,94,60) (B,94,69) (B,94,57) CCH1586 CKSRYB104K50 CKSRYB105K16 CKSQYB105K25 CKSRYB105K16 C C C C C 5726 5727 5728 5729 5730 (B,61,35) (B,53,38) (B,51,35) (B,48,37) (B,48,36) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 5549 5550 5552 5553 5554 (B,94,55) (B,96,52) 4.7 uF (B,96,63) (A,100,61) (B,104,50) CKSRYB105K16 CCG1222 CKSRYB105K16 CKSRYB105K16 CKSQYB105K25 C C C C C 5731 5732 5733 5734 5735 (B,40,38) (B,69,45) (B,67,45) (B,33,45) (B,34,45) CKSSYB104K10 CKSSYB105K6R3 CKSSYB104K10 CKSSYB105K6R3 CKSSYB104K10 C C C C C 5736 5737 5738 5739 5740 (B,69,51) (B,71,51) (B,28,51) (B,29,51) (B,31,51) CKSSYB105K6R3 CKSSYB104K10 CKSSYB105K6R3 CKSSYB104K10 CKSSYB105K6R3 C C C C C 5741 5742 5743 5744 5745 (B,32,51) (B,68,54) (B,66,54) (B,69,56) (B,67,56) CKSSYB104K10 CKSSYB105K6R3 CKSSYB104K10 CKSSYB105K6R3 CKSSYB104K10 C 5746 C 5747 C 5748 (B,33,57) (B,34,57) (B,32,58) CKSSYB105K6R3 CKSSYB104K10 CKSSYB105K6R3 C C C C C 5555 5556 5557 5558 5560 (B,93,72) (B,116,69) (B,119,65) (B,116,61) (A,95,65) CKSQYB105K25 CKSSYB102K50 CKSSYB153K16 CCSSCH270J50 CKSSYB104K16 C C C C C 5601 5602 5603 5604 5605 (A,83,25) (A,79,25) (A,82,25) (A,86,24) (A,67,30) (UW5) (UW5) (UW5) (UW5) (UW5) CKSSYB102K50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CSZSR470M10 C C C C 5606 5607 5608 5609 (A,87,25) (A,77,25) (A,80,25) (A,84,25) (UW5) (UW5) (UW5) (UW5) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 AVH-P4100DVD/XN/UC 5 6 7 8 A B C D E F 201 1 2 Circuit Symbol and No. A B C D E 4 Circuit Symbol and No. Part No. C 5749 C 5750 (B,31,58) (B,68,61) CKSSYB104K10 CKSSYB105K6R3 C C C C C 5751 5752 5753 5754 5755 (B,70,61) (B,33,64) (B,34,64) (B,68,65) (B,66,65) CKSSYB104K10 CKSSYB105K6R3 CKSSYB104K10 CKSQYB106K6R3 CKSQYB106K6R3 C C C C C 5756 5757 5758 5759 5760 (B,66,69) (B,66,68) (A,56,53) (B,61,70) (B,55,72) CKSQYB106K6R3 CKSSYB104K10 CSZSR470M10 CKSSYB105K6R3 CKSSYB105K6R3 C C C C C 5761 5762 5763 5764 5765 (B,53,70) (B,48,72) (B,47,72) (B,40,70) (B,60,70) CKSSYB105K6R3 CKSSYB105K6R3 CKSSYB105K6R3 CKSSYB105K6R3 CKSSYB104K10 C C C C C 5766 5767 5768 5769 5770 (B,54,70) (B,54,72) (B,49,70) (B,48,70) (B,39,70) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 5771 6010 6012 6013 6014 (B,77,55) (B,64,19) (B,61,24) 10 uF (A,37,43) (A,31,43) CKSSYB102K50 CKSSYB104K10 DCH1201 CKSSYB104K10 CKSSYB104K10 C C C C C 6015 6016 6017 6018 6019 (A,26,40) (B,23,36) (A,34,42) (A,32,41) 10 uF (A,29,38) CKSRYB104K50 CKSRYB104K50 CSZSR220M16 DCH1201 CKSQYB334K50 R R R R R 1002 1004 1007 1019 1021 (B,18,27) (A,29,27) (A,29,26) (B,15,9) (A,27,15) RS1/16SS101J RS1/16SS4702D RS1/16SS6801D RS1/16SS101J RS1/16SS0R0J C C C C C 6020 6022 6023 6024 6025 (B,27,36) 4.7 uF (A,38,31) (A,35,31) (A,33,31) (B,27,38) CCG1222 CKSSYB104K10 CKSSYB104K10 CKSRYB104K50 CKSRYB104K50 R R R R R 1025 1027 1101 1102 1103 (B,19,11) (A,27,19) (A,35,36) (A,43,42) (A,34,41) RS1/16SS101J RS1/16SS101J RS1/16SS104J RS1/16SS104J RS1/16SS391J C C C C C 6026 6027 6101 6102 6104 (A,28,35) (A,24,36) (A,61,7) 10 uF (A,52,8) 10 uF (A,9,30) 10 uF CKSRYB105K16 CKSQYB105K25 CCG1236 CCG1236 CCG1236 R R R R R 1104 1105 1106 1109 1110 (A,36,36) (A,42,44) (A,45,39) (A,34,43) (A,41,43) RS1/16SS511J RS1/16SS391J RS1/16SS561J RS1/16SS3R3J RS1/16SS3R3J C C C C C 6105 6106 6108 6109 6110 (A,13,34) (A,9,24) (A,9,48) 10 uF/50 V (A,13,56) 10 uF/50 V (A,16,41) CKSSYB104K10 CCSSCH331J50 CCH1922 CCH1922 CKSRYB474K10 R R R R R 1111 1112 1113 1114 1115 (A,38,39) (A,38,38) (A,49,46) (A,48,46) (A,41,38) RS1/10SR1R5J RS1/10SR1R5J RS1/10SR1R5J RS1/10SR1R5J RS1/10SR1R5J C C C C C 6111 6151 6154 6155 6156 (A,12,44) (A,15,26) (A,13,27) 4.7 uF (A,23,19) (A,22,23) CKSRYB104K50 CKSRYB104K50 CCG1222 CKSSYB104K10 CSZSR220M16 R R R R R 1116 1117 1118 1201 1202 (A,41,39) (A,48,43) (A,49,43) (A,16,36) (A,17,35) RS1/10SR1R5J RS1/10SR1R5J RS1/10SR1R5J RS1/16SS221J RS1/16SS221J (B,17,24) CKSQYB475K6R3 R R R R R 1203 1204 1212 1213 1214 (A,22,35) (A,19,35) (A,7,36) (B,8,29) (B,8,27) RS1/16SS103J RS1/16SS153J RS1/16SS271J RS1/16SS1R0J RS1/16SS1R0J (B,8,28) (B,8,24) RS1/16SS1R0J RS1/16SS1R0J C 6158 F 3 Part No. C Unit Number : YWX5007 Unit Name : DVD Core Unit (B,21,41) (B,35,23) (B,25,11) (B,19,21) (A,15,29) Regulator IC IC IC IC IC S-1133B50-U5 S-1200B50-M5 NJM2885DL1-33 R1232D121B BD8231EFV *IC1401 *IC1402 IC 1480 IC 1501 IC 1801 (B,63,36) (B,50,36) (B,59,13) (A,60,20) (B,37,16) Flash ROM Unit Flash ROM Unit SDRAM(64M) IC D/A Converter CWW1753 CWW1754 K4S641632N-LC75 MN2DS0018MAUB PCM1753DBQ IC 1951 Q 1101 Q 1102 Q 1103 Q 1104 (B,76,32) (A,35,39) (A,46,42) (A,38,45) (A,45,49) Logic IC Transistor Transistor Transistor Transistor TC7SZU04FU 2SC4081 2SC4081 2SB1132 2SB1132 L L L L L (B,22,26) Inductor (B,14,17) Inductor (A,57,5) Inductor (B,5,8) Inductor (B,12,11) Inductor 1003 1004 1512 1902 1903 L 1904 X 1501 X 1950 EF1001 EF1002 CTF1677 CTF1678 CTF1743 CTF1487 CTF1558 (B,46,19) Inductor CTF1473 (B,43,7) Oscillator 27.000 MHz CSS1768 (B,76,35) Oscillator 48.000 MHz CSS1760 (B,5,12) Chip EMI Filter DTF1106 (B,11,13) Chip EMI Filter DTL1106 RESISTORS R 1215 R 1216 MISCELLANEOUS 202 IC 1002 IC 1003 IC 1004 IC 1005 IC 1201 AVH-P4100DVD/XN/UC 1 2 3 4 5 Circuit Symbol and No. 6 7 Part No. Circuit Symbol and No. 8 Part No. R 1217 R 1218 R 1222 (B,8,25) (B,8,26) (B,26,39) RS1/16SS1R0J RS1/16SS1R0J RS1/16SS271J R 1602 R 1603 R 1604 (A,44,25) (A,43,30) (A,50,35) RS1/16SS123J RN1/16SE1002D RS1/16SS105J R R R R R 1300 1401 1402 1405 1406 (B,39,24) (B,63,49) (B,70,27) (B,56,24) (B,54,25) RS1/16SS0R0J RS1/16SS221J RS1/16SS104J RS1/16SS104J RS1/16SS104J R R R R R 1605 1670 1671 1672 1674 (A,49,37) (A,34,21) (A,36,21) (A,45,19) (A,45,20) RS1/16SS105J RS1/16SS1002D RS1/16SS2402D RS1/16SS2000D RS1/16SS3002D R R R R R 1480 1481 1482 1483 1484 (B,52,21) (B,56,21) (B,61,21) (B,64,21) (B,67,21) RAB4CQ560J RAB4CQ560J RAB4CQ560J RAB4CQ560J RAB4CQ560J R R R R R 1801 1802 1803 1804 1950 (B,35,6) (B,33,6) (B,35,11) (B,34,11) (A,42,16) RS1/16SS104J RS1/16SS104J RS1/16SS821J RS1/16SS821J RS1/16S24R0F R R R R R 1485 1486 1487 1488 1489 (B,50,5) (B,55,5) (B,64,5) (B,68,5) (B,59,5) RAB4CQ560J RAB4CQ560J RAB4CQ560J RAB4CQ560J RS1/16SS560J R R R R R 1951 1952 1953 1954 1955 (A,42,18) (B,78,34) (B,74,34) (A,35,17) (A,40,14) RS1/16S24R0F RS1/16SS105J RS1/16SS681J RS1/16SS153J RS1/16SS153J R R R R R 1490 1501 1503 1504 1505 (B,50,21) (B,46,7) (B,45,8) (B,45,13) (A,43,13) RS1/16SS560J RS1/16SS122J RS1/16SS105J RS1/16SS120J RS1/16SS101J R 1956 R 1957 (A,40,18) (A,40,15) RS1/16SS0R0J RS1/16SS0R0J R R R R R 1506 1507 1508 1509 1510 (A,37,14) (A,44,14) (A,43,15) (A,63,35) (A,64,35) RS1/16SS101J RS1/16SS101J RS1/16SS221J RS1/16SS102J RS1/16SS102J R R R R R 1511 1512 1513 1514 1516 (B,46,13) (A,58,5) (A,66,35) (A,68,35) (A,65,36) RS1/16S0R0J RS1/16SS101J RS1/16SS103J RS1/16SS183J RS1/16SS103J R R R R R 1517 1518 1519 1522 1523 (A,76,16) (A,74,24) (A,70,34) (A,65,38) (A,66,37) RS1/16SS103J RS1/16SS103J RS1/16SS102J RS1/16SS104J RS1/16SS221J R R R R R 1524 1525 1526 1527 1528 (A,64,37) (A,71,34) (A,67,34) (B,77,29) (A,78,20) RS1/16SS472J RS1/16SS103J RS1/16SS103J RS1/16SS682J RS1/16SS103J R R R R R 1529 1530 1531 1532 1534 (A,76,18) (A,77,20) (A,75,24) (B,70,33) (A,78,30) RS1/16SS103J RS1/16SS103J RS1/16SS103J RS1/16SS101J RS1/16SS221J R R R R R 1535 1536 1537 1538 1539 (B,70,34) (A,78,31) (A,73,35) (A,61,4) (A,77,23) RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J RS1/16SS104J R R R R R 1540 1541 1542 1543 1544 (A,73,32) (A,75,32) (A,77,29) (B,75,28) (B,77,28) RS1/16SS221J RS1/16SS221J RS1/16SS103J RS1/16SS181J RS1/16SS181J R 1546 R 1601 (B,75,29) (A,42,25) RS1/16SS682J RS1/16SS123J 6 B CAPACITORS C C C C C 1001 1003 1004 1005 1008 (B,36,21) (B,18,44) (B,24,40) (B,32,23) (B,20,31) 10 uF CKSRYB105K10 CKSSYB104K16 CKSQYB475K10 CKSRYB105K16 DCH1201 C C C C C 1009 1010 1011 1013 1014 (B,18,31) 10 uF (B,26,18) (B,22,18) (B,15,25) 10 uF (B,13,25) 10 uF DCH1201 CKSQYB225K10 CKSRYB105K10 DCH1201 DCH1201 C C C C C 1015 1016 1018 1019 1021 (B,7,8) (B,12,10) (A,28,28) (A,10,17) (B,34,4) CKSSYB102K50 CKSSYB102K50 CKSSYB104K10 CKSSYB104K10 CCSRCH681J50 C C C C C 1022 1101 1104 1105 1106 (A,23,21) (B,31,40) 10 uF (A,34,42) (A,42,45) (A,37,48) CCSRCH681J50 DCH1201 CKSSYB104K10 CKSSYB104K10 CKSSYB103K16 C C C C C 1107 1108 1109 1110 1111 (A,41,49) (A,74,42) (A,56,41) (A,71,42) (A,61,39) CKSSYB103K16 CKSSYB103K16 CKSRYB224K10 CKSSYB103K16 CKSRYB224K10 C C C C C 1112 1113 1201 1204 1205 (B,40,39) 22 uF (B,36,38) 22 uF (B,12,34) (A,8,24) (A,13,23) CCG1178 CCG1178 CEVW101M16 CKSSYB222K50 CKSSYB104K16 C C C C C 1207 1208 1209 1210 1211 (A,22,25) (A,15,36) (B,10,25) (B,6,23) (B,9,22) CKSSYB104K16 CKSSYB103K16 CKSSYB104K16 CKSSYB104K16 CKSYB475K16 C 1401 C 1403 (B,63,48) (B,69,23) CKSSYB103K16 CKSSYB104K10 AVH-P4100DVD/XN/UC 5 A 7 8 C D E F 203 1 Circuit Symbol and No. A B C D E F 2 3 Part No. 4 Circuit Symbol and No. Part No. C 1404 C 1408 C 1409 (B,58,25) (B,47,25) (B,47,23) CKSQYB475K6R3 CKSSYB104K10 CKSQYB475K6R3 C 1623 C 1624 C 1625 (A,45,35) (A,58,37) (A,56,37) CKSRYB105K10 CKSSYB104K10 CKSSYB104K10 C C C C C 1480 1481 1482 1484 1485 (B,47,21) (B,49,23) (B,54,21) (B,59,20) (B,69,21) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 1671 1672 1673 1674 1676 (A,44,17) (A,45,18) (A,45,22) (A,43,21) (A,38,22) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSRYB105K10 C C C C C 1487 1488 1489 1490 1501 (B,58,4) (B,52,5) (B,45,20) (B,45,23) (B,72,9) CKSSYB104K10 CKSSYB104K10 CKSQYB106K6R3 CKSSYB102K50 CKSQYB106K6R3 C C C C C 1801 1802 1803 1804 1805 (B,34,8) (B,32,8) (B,36,8) (B,31,7) (B,32,19) CKSQYB475K6R3 CKSQYB475K6R3 CCSRCH182J50 CCSRCH182J50 CKSSYB104K10 C C C C C 1502 1503 1504 1505 1506 (A,35,32) (A,60,4) (A,51,5) (A,53,5) (A,55,5) CKSQYB106K6R3 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 1806 1809 1934 1950 1951 (B,39,9) 10 uF (B,43,16) (B,42,29) (B,73,33) (B,74,36) DCH1201 CKSSYB104K10 CCSRCH680J50 CKSSYB104K10 CCSSCH100D50 C C C C C 1507 1508 1509 1510 1511 (A,62,5) (A,66,5) (A,69,5) (B,46,5) (A,46,9) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CCSSCH120J50 CKSSYB104K10 C 1952 C 1954 (B,78,36) (B,43,49) CCSSCH100D50 CCSRCH470J50 C C C C C 1512 1513 1514 1515 1516 (B,43,10) (B,74,12) (A,46,13) (A,45,15) (A,75,15) CCSSCH100D50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 1517 1518 1519 1520 1521 (A,74,16) (A,75,22) (A,74,26) (A,75,30) (A,60,37) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 1522 1523 1524 1526 1528 (A,65,34) (A,68,37) (A,69,37) (A,68,37) (A,78,29) CKSSYB104K10 CKSSYB104K10 CKSSYB473K10 CKSSYB103K16 CCSSCH471J16 C C C C C 1601 1602 1603 1604 1605 (A,44,29) (A,42,24) (A,44,27) (A,41,27) (A,43,27) CKSSYB103K16 CCSSCH101J50 CCSSCH101J50 CCSSCH680J50 CCSSCH680J50 C C C C C 1606 1607 1608 1609 1610 (A,41,23) (A,41,35) (A,43,36) (A,48,35) (A,50,37) CKSSYB104K10 CKSQYB106K6R3 CKSRYB105K10 CKSSYB104K10 CKSSYB104K10 C C C C C 1611 1612 1613 1614 1615 (A,51,37) (A,52,34) (A,52,37) (A,53,34) (A,54,34) CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 C C C C C 1616 1617 1618 1619 1620 (A,54,37) (A,54,38) (A,56,34) (A,57,34) (A,58,34) CKSSYB104K10 CKSSYB104K10 CCSSCH101J50 CKSSYB562K25 CKSSYB224K6R3 C 1621 C 1622 (A,57,37) (A,59,35) CKSSYB224K6R3 CKSSYB333K16 204 D Unit Number : Unit Name : Connect PCB MISCELLANEOUS S S S R R 101 102 103 101 102 R 103 C 101 (B,51,37) Switch(HOME) (B,12,23) Switch(DSCSNS) (B,22,10) Switch(8SNS) (B,52,27) (B,15,29) CSN1068 CSN1068 CSN1068 RS1/16S101J RS1/16S101J (B,16,11) (B,51,23) RS1/16S101J CKSRYB104K50 G Unit Number : EXX1058 Unit Name : Service PCB Assy IC 101 IC 102 IC 103 IC 104 S 101 IC IC Photo Interruptor Photo Interruptor Switch BA6288FS TC7W14FU GP1S94J GP1S94J CSN1067 S S R R Switch Switch CSN1068 CSN1067 RS1/16S181J RS1/16S181J 102 103 101 102 R 103 R 104 R 113 RS1/16S183J RS1/16S183J RS1/16S221J R C C C RS1/10S0R0J CEVW220M16 CKSRYB104K16 CKSRYB104K16 118 101 102 111 Miscellaneous Parts List Pickup Unit(Service) Motor Unit(LOAD/CRG) Motor(SPINDLE) M 1 M 2 CXX2398 CXC4026 EXM1050 AVH-P4100DVD/XN/UC 1 2 3 4
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.5 Linearized : No Page Mode : UseOutlines XMP Toolkit : 3.1-702 Creator Tool : FrameMaker 7.2 Modify Date : 2009:01:31 20:16:50-05:00 Create Date : 2008:11:26 11:32:47Z Metadata Date : 2009:01:31 20:16:50-05:00 Format : application/pdf Title : CRT4275 Creator : PMC Producer : Acrobat Distiller 8.1.0 (Windows) Document ID : uuid:7b8c7ca7-b6d4-4240-9eda-0c1b3fdd56ae Instance ID : uuid:bbe023aa-d2df-4cc1-adb8-34912e94cba1 Page Count : 204 Page Layout : SinglePage Author : PMCEXIF Metadata provided by EXIF.tools