Fatbob Owners Manual

User Manual:

Open the PDF directly: View PDF .
Page Count: 193 [warning: Documents this large are best viewed by clicking the View PDF Link!]

SafetyFirst

SafeOperatingRules

Motorcyclesaredifferentfromothervehicles.They

operate,steer,handleandbrakedifferently.Unskilledor

improperusecouldresultinlossofcontrol,deathor

seriousinjury.(00556c)

Takearidertrainingcourse.

Readowner'smanualbeforeriding,addingaccessoriesorservicing.

Wearahelmet,eyeprotectionandprotectiveclothing.

Nevertowatrailer.

Beforeoperatingyourmotorcycle,readandfollowtheoperatingandmaintenanceinstructionsin

thismanual.Followthesebasicrulesforyourpersonalsafety.

Knowandrespecttherulesoftheroad.Carefullyreadandfamiliarizeyourselfwiththe

motorcyclesafetyinformationprovidedbyyourcountryorstate.ReadtheRIDINGTIPS

bookletinyourowner'skit(intheU.S.)andtheMOTORCYCLEHANDBOOKfromyour

stateorregionaltrafficauthority.TheRIDINGTIPSbookletisalsoavailableonwww.msf

usa.org.SeeRulesoftheRoad.

Beforestartingengine,checkforproperoperationofbrake,clutch,shifter,throttlecontrols,

correctfuelandoilsupply.

HarleyDavidsonpartsandaccessoriesaredesignedfor

HarleyDavidsonmotorcycles.UsingnonHarleyDavidson

partsoraccessoriescanadverselyaffectperformance,

stabilityorhandling,whichcouldresultindeathorserious

injury.(00001b)

UseonlyHarleyDavidsonapprovedpartsandaccessories.Useofcertainother

manufacturer'sperformancepartsmayvoidyournewmotorcyclewarranty,exceptwhere

prohibitedbylaw.SeeyourHarleyDavidsondealerfordetails.

Stoptheenginewhenrefuelingorservicingthefuel

system.Donotsmokeorallowopenflameorsparksnear

gasoline.Gasolineisextremelyflammableandhighly

explosive,whichcouldresultindeathorseriousinjury.

(00002a)

Whenrefuelingyourmotorcycle,observethefollowingrules.

2016FatBobOwner'sManual

Refuelinaventilatedareawiththeengineturnedoff.

Removefuelfillercapslowly.

Donotsmokeorallowopenflamesorsparkswhenrefuelingorservicingthefuelsystem.

Donotfillfueltankabovethebottomofthefillerneckinsert.

Leaveairspacetoallowforfuelexpansion.

Donotstoremotorcyclewithgasolineintankwithinthe

homeorgaragewhereopenflames,pilotlights,sparksor

electricmotorsarepresent.Gasolineisextremely

flammableandhighlyexplosive,whichcouldresultin

deathorseriousinjury.(00003a)

Engineexhaustfromthisproductcontainschemicals

knowntotheStateofCaliforniatocausecancer,andbirth

defectsorotherreproductiveharm.(00004f)

Donotrunmotorcycleinaclosedgarageorconfinedarea.

Inhalingmotorcycleexhaust,whichcontainspoisonous

carbonmonoxidegas,couldresultindeathorserious

injury.(00005a)

Thejiffystandlockswhenplacedinthefullforward(down)

positionwithvehicleweightonit.Ifthejiffystandisnotin

thefullforward(down)positionwithvehicleweightonit,

thevehiclecanfalloverwhichcouldresultindeathor

seriousinjury.(00006a)

Besurejiffystandisfullyretractedbeforeriding.Ifjiffy

standisnotfullyretracted,itcancontacttheroadsurface

causingalossofvehiclecontrol,whichcouldresultin

deathorseriousinjury.(00007a)

Anewmotorcyclemustbeoperatedaccordingtothespecialbreakinprocedure.See

BreakInRidingRules.

Operatemotorcycleatmoderatespeedandoutoftrafficuntilyoubecomethoroughly

familiarwithitsoperationandhandlingcharacteristicsunderallconditions.

NOTE:

HarleyDavidsonrecommendsthatyouobtaininformationandformaltraininginthecorrect

motorcycleridingtechnique.IntheUnitedStates,boththeHarleyDavidsonRidingAcademy(1

4143434056)andtheMotorcycleSafetyFoundation(18004469227)offerbeginningand

advancedridersafetycourses.

Travelatspeedsappropriateforroadandconditionsand

nevertravelfasterthanpostedspeedlimit.Excessive

speedcancauselossofvehiclecontrol,whichcould

resultindeathorseriousinjury.(00008a)

Donotexceedthelegalspeedlimitordrivetoofastforexistingconditions.Alwaysreduce

speedwhenpoordrivingconditionsexist.Highspeedincreasestheinfluenceofanyother

conditionaffectingstabilityandincreasesthepossibilityoflossofcontrol.

Paystrictattentiontoroadsurfacesandwindconditions.Keepbothhandsonthehandlebar

gripswhenridingthemotorcycle.Anytwowheeledvehiclemaybesubjecttoupsetting

forcessuchaswindblastsfrompassingtrucks,holesinthepavement,roughroadsurfaces

andridercontrolerror.Theseforcesmayinfluencethehandlingcharacteristicsofyour

motorcycle.Ifyouexperiencetheseconditions,reducespeedandguidethemotorcyclewith

arelaxedgriptoacontrolledcondition.Donotbrakeabruptlyorforcethehandlebar.This

mayaggravateanunstablecondition.

Keepcargoweightconcentratedclosetothemotorcycleandaslowaspossibletominimize

thechangeinthemotorcycle'scenterofgravity.Distributeweightevenlyonbothsidesof

thevehicle.Donotloadbulkyitemstoofarbehindtherideroraddweighttothehandlebars

orfrontforks.Donotexceedmaximumspecifiedloadineachsaddlebag.

NOTE:

Newridersshouldgainexperienceundervariousconditionswhileridingatmoderatespeeds.

Operateyourmotorcycledefensively.Remember,amotorcycledoesnotaffordthesame

protectionasanautomobileinanaccident.Onecommonriskforanaccidentoccurswhen

anothervehicleturnsleftinfrontofanoncomingmotorcyclist.Operateonlywithheadlamp

on.

Wearanapprovedhelmet,clothingandfootgearsuitedformotorcycleriding.Brightorlight

colorsarebestforgreatervisibilityintraffic,especiallyatnight.Avoidloose,flowing

garmentsandscarves.

Avoidcontactwithexhaustsystemandwearprotective

clothingthatcompletelycoverslegswhileriding.Exhaust

pipesandmufflersgetveryhotwhenengineisrunning

andremaintoohottotouch,evenafterengineisturned

off.Failuretowearprotectiveclothingcouldresultin

burnsorotherseriousinjury.(00009a)

Whencarryingpassengers,itisyourresponsibilitytoinstructthemonproperriding

procedures.SeetheRIDINGTIPSbookletincludedinyourowner'skit(intheU.S.)or

availableonwww.msfusa.org.

Donotallowotherindividuals,underanycircumstances,tooperateyourmotorcycleunless

youknowthattheyareexperiencedandlicensedriders.Makesuretheyarethoroughly

familiarwiththeoperationofyourparticularmotorcycle.

Protectyourmotorcycleagainsttheft.Usingtheforklockimmediatelyafterparkingyour

motorcyclewilldiscourageunauthorizeduseortheft.

Safemotorcycleoperationrequiresalertmentaljudgmentcombinedwithadefensivedriving

attitude.Donotallowfatigue,alcoholordrugstoendangeryoursafetyorthatofothers.

Forvehicleswithasoundsystem,adjustthevolumetoanondistractinglevelbefore

operatingvehicle.

Propercareandmaintenanceareimportanttostabilityandsafeoperation.Checkthetire

pressure,tirecondition,treaddepthandproperadjustmenttosteeringheadbearings.

Maintainyourmotorcycleinproperoperatingcondition.RefertoRegularService

Intervals:2016HarleyDavidsonDynaModels.

Donotoperatevehiclewithforkslocked.Lockingtheforks

restrictsthevehicle'sturningability,whichcouldresultin

deathorseriousinjury.(00035a)

Performtheserviceandmaintenanceoperationsas

indicatedintheregularserviceintervaltable.Lackof

regularmaintenanceattherecommendedintervalscan

affectthesafeoperationofyourmotorcycle,whichcould

resultindeathorseriousinjury.(00010a)

Donotoperatemotorcyclewithloose,wornordamaged

steeringorsuspensionsystems.ContactaHarley

Davidsondealerforrepairs.Loose,wornordamaged

steeringorsuspensioncomponentscanadverselyaffect

stabilityandhandling,whichcouldresultindeathor

seriousinjury.(00011a)

Regularlyinspectshockabsorbersandfrontforks.

Replaceleaking,damagedorwornpartsthatcan

adverselyaffectstabilityandhandling,whichcouldresult

indeathorseriousinjury.(00012a)

UseHarleyDavidsonreplacementfasteners.Aftermarket

fastenerscanadverselyaffectperformance,whichcould

resultindeathorseriousinjury.(00013a)

SeeyourHarleyDavidsonservicemanualforpropertorquevalues.

Aftermarketfastenersmaynothavethespecificpropertyrequirementstoperformproperly.

Besuretiresareproperlyinflated,balanced,undamaged,

andhaveadequatetread.Inspectyourtiresregularlyand

seeaHarleyDavidsondealerforreplacements.Riding

withexcessivelyworn,unbalanced,improperlyinflated,

overloadedordamagedtirescanleadtotirefailureand

adverselyaffectstabilityandhandling,whichcouldresult

indeathorseriousinjury.(00014b)

Replacepuncturedordamagedtires.Insomecases,small

puncturesinthetreadareamayberepairedfromwithin

theremovedtirebyaHarleyDavidsondealer.Speed

shouldNOTexceed50mph(80km/h)forthefirst24hours

afterrepair,andtherepairedtireshouldNEVERbeused

over80mph(130km/h).Failuretofollowthiswarning

couldleadtotirefailureandresultindeathorserious

injury.(00015b)

Onlyinstalloriginalequipmenttirevalvesandvalvecaps.

Avalve,orvalveandcapcombination,thatistoolongor

tooheavycanstrikeadjacentcomponentsanddamagethe

valve,causingrapidtiredeflation.Rapidtiredeflationcan

causelossofvehiclecontrol,whichcouldresultindeath

orseriousinjury.(00281a)

Donotexceedthemotorcycle'sGrossVehicleWeight

Rating(GVWR)orGrossAxleWeightRating(GAWR).

Exceedingtheseweightratingscanleadtocomponent

failureandadverselyaffectstability,handlingand

performance,whichcouldresultindeathorseriousinjury.

(00016f)

Whenliftingamotorcycleusingajack,besurejack

contactsbothlowerframetubeswheredowntubesand

lowerframetubesconverge.Neverliftbyjackingoncross

members,oilpan,mountingbrackets,componentsor

housings.Failuretocomplycancauseseriousdamage

resultingintheneedtoperformmajorrepairwork.

(00586d)

GVWRisthesumoftheweightofthemotorcycle,accessoriesandthemaximumweightof

therider,passengerandcargothatcanbesafelycarried.

GAWRisthemaximumamountofweightthatcanbesafelycarriedoneachaxle.

SeeinformationlabelonframesteeringheadorframedowntubeforGVWRandGAWR.

SeeSpecifications.

Donottowadisabledmotorcycle.Towingcanadversely

affectstabilityandhandling,whichcouldresultindeathor

seriousinjury.(00017a)

Donotpullatrailerwithamotorcycle.Pullingatrailercan

causetireoverload,damageandfailure,reducedbraking

performance,andadverselyaffectstabilityandhandling,

whichcouldresultindeathorseriousinjury.(00018c)

Batteries,batteryposts,terminalsandrelatedaccessories

containleadandleadcompounds,andotherchemicals

knowntotheStateofCaliforniatocausecancer,andbirth

defectsorotherreproductiveharm.Washhandsafter

handling.(00019e)

Donotopenstoragecompartmentswhileriding.

Distractionswhileridingcanleadtolossofcontrol,which

couldresultindeathorseriousinjury.(00082a)

ConsultaHarleyDavidsondealerregardinganyquestions

orproblemsthatoccurintheoperationofyour

motorcycle.Failuretodosocanaggravateaninitial

problem,causecostlyrepairs,causeanaccidentand

couldresultindeathorseriousinjury.(00020a)

DirectcontactofD.O.T.4brakefluidwitheyescancause

irritation.Avoideyecontact.Incaseofeyecontactflush

withlargeamountsofwaterandgetmedicalattention.

SwallowinglargeamountsofD.O.T.4brakefluidcan

causedigestivediscomfort.Ifswallowed,obtainmedical

attention.Useinwellventilatedarea.KEEPOUTOF

REACHOFCHILDREN.(00240a)

Makesureallequipmentrequiredbyfederal,stateandlocallawisinstalledandingood

operatingcondition.

AntilockBrakeSystem(ABS)

IfABSlampcontinuesflashingatspeedsgreaterthan3

mph(5km/h)orremainsoncontinuously,theABSisnot

operating.Thestandardbrakesystemisoperational,but

wheellockupcanoccur.ContactaHarleyDavidson

DealertohaveABSrepaired.Alockedwheelwillskidand

cancauselossofvehiclecontrol,whichcouldresultin

deathorseriousinjury.(00361b)

ABScannotpreventlockupofrearwheelduetoengine

braking.ABSwillnotaidincorneringoronloose/uneven

surfaces.Alockedwheelwillskidandcancauselossof

vehiclecontrol,whichcouldresultindeathorserious

injury.(00362a)

Tooperatemotorcyclesequippedwithanantilockbrakesystem,seeBrakeSystem.

RulesoftheRoad

Alwayssoundyourhorn,useyourturnsignalsandexercisecautionwhenpassingother

vehiclesgoinginthesamedirection.Neverpassgoinginthesamedirectionatstreet

intersections,oncurvesorwhengoingupordownahill.

Atstreetintersections,givetherightofway.Donotpresumeyouhavetherightofway,as

theotherdrivermaynotknowthatitisyourturn.

Alwayssignalwhenpreparingtostop,turnorpass.

Promptlyobeyalltrafficsigns,includingthosesignsusedforthecontroloftrafficat

intersections.Alwaysobeytrafficsignsnearschoolsandatrailroadcrossings.

Whenintendingtoturn,signalatleast100ft30.5mbeforereachingtheturningpoint.If

turningacrossanintersection,moveovertothecenterlineofthestreet(unlesslocalrules

requireotherwise).Slowdownwhenenteringtheintersectionandturncarefully.

Neveranticipateatrafficlight.WhenachangeisindicatedfromGOtoSTOP(orSTOPto

GO),slowdownandwaitforthelighttochange.Neverrunthroughayelloworredtraffic

light.

Whileturning,watchforpedestrians,animals,aswellasvehicles.

Donotleavethecurborparkingareawithoutsignaling.Makesurethatyourwayisclearto

entermovingtraffic.Amovinglineoftrafficalwayshastherightofway.

Makesurethatyourlicenseplateisinstalledinthepositionspecifiedbylaw.Makesurethat

yourlicenseplateisalwaysclearlyvisible.Keepthelicenseplateclean.

Rideatasafespeedthatisconsistentwiththetypeofhighwayyouareon.Paystrict

attentiontowhethertheroadisdry,oily,icyorwet.

Watchfordebrissuchasleavesorloosegravel.

Weatherandtrafficconditionsonthehighwaydictateadjustingyourspeedanddriving

habitsaccordingly.

AccessoriesandCargo

HarleyDavidsonMotorCompanycannottestandmakespecificrecommendationsconcerning

everyaccessoryorcombinationofaccessoriessold.Therefore,theridermustberesponsiblefor

safeoperationwheninstallingaccessoriesorcarryingextraweight.

SeetheAccessoriesandCargosectioninyourowner's

manual.Impropercargoloadingoraccessoryinstallation

cancausecomponentfailureandadverselyaffectstability,

handlingandperformance,whichcouldresultindeathor

seriousinjury.(00021b)

Donotexceedthemotorcycle'sGrossVehicleWeight

Rating(GVWR)orGrossAxleWeightRating(GAWR).

Exceedingtheseweightratingscanleadtocomponent

failureandadverselyaffectstability,handlingand

performance,whichcouldresultindeathorseriousinjury.

(00016f)

GVWRisthesumoftheweightofthemotorcycle,accessoriesandthemaximumweightof

therider,passengerandcargothatcanbesafelycarried.

GAWRisthemaximumamountofweightthatcanbesafelycarriedoneachaxle.

SeeinformationlabelonframesteeringheadorframedowntubeforGVWRandGAWR.

Refertoweighttables.SeeSpecifications.

Donotpullatrailerwithamotorcycle.Pullingatrailercan

causetireoverload,damageandfailure,reducedbraking

performance,andadverselyaffectstabilityandhandling,

whichcouldresultindeathorseriousinjury.(00018c)

AccessoriesandCargoGuidelines

Followthefollowingguidelineswhenequippingamotorcycle,carryingpassengersand/orcargo.

Travelatspeedsappropriateforroadandconditionsand

nevertravelfasterthanpostedspeedlimit.Excessive

speedcancauselossofvehiclecontrol,whichcould

resultindeathorseriousinjury.(00008a)

Donotexceedthelegalspeedlimitordrivetoofastforexistingconditions.Alwaysreduce

speedwhenpoordrivingconditionsexist.Highspeedincreasestheinfluenceofanyother

conditionaffectingstabilityandincreasesthepossibilityoflossofcontrol.

Paystrictattentiontoroadsurfacesandwindconditions,andalwayskeepbothhandson

thehandlebargripswhenriding.Twowheeledvehiclesaresubjecttoupsettingforcessuch

aswindblastsfrompassingtrucks,holesinthepavement,roughroadsurfaces,ridercontrol

error.Theseforcescaninfluencethehandlingcharacteristicsofyourmotorcycle.Ifyou

experiencetheseconditions,reducespeedandguidethemotorcyclewitharelaxedgriptoa

controlledcondition.Donotbrakeabruptlyorforcethehandlebar.Thisactioncanaggravate

anunstablecondition.

Keepcargoweightconcentratedclosetothemotorcycleandaslowaspossible.This

positionminimizesthechangeinthemotorcycle'scenterofgravity.

Distributeweightevenlyonbothsidesofthevehicle.

Donotloadbulkyitemstoofarbehindtherideroraddweighttothehandlebarsorfront

forks.

Ifequippedwithsaddlebags,donotexceedmaximumspecifiedloadineachsaddlebag.

Ifequippedwithluggageracks,donotoverloadluggageracks.Luggageracksaredesigned

forlightweightitems.

Makesurethatcargoissecureandcannotshiftwhileridingandrecheckthecargo

periodically.Accessoriesthatchangetheoperator'sridingpositioncanincreasereaction

timeandaffecthandling.

Extraelectricalequipmentcanoverloadthemotorcycle'selectricalsystem.Thisoverload

cancauseelectricalsystemand/orcomponentfailure.

Frontand/orrearguard(s)canprovidelimitedlegand

cosmeticvehicleprotectionunderuniquecircumstances.

(Falloverwhilestopped,veryslowspeedslide.)Itisnot

madeorintendedtoprovideprotectionfrombodilyinjury

inacollisionwithanothervehicleoranyotherobject.

(00022b)

Largesurfacessuchasfairings,windshields,backrestsandluggagerackscanhavean

adverseeffectonstabilityandhandling.

OnlyinstallGenuineHarleyDavidsonaccessoriesdesignedspecificallyforyourmotorcycle.

Payparticularattentiontotheweightsofaccessories,cargo,ridinggear,passengerand

rider.Theseweightsaffecttheloadingrequirementsofyourmotorcycle.

HarleyDavidsonpartsandaccessoriesaredesignedfor

HarleyDavidsonmotorcycles.UsingnonHarleyDavidson

partsoraccessoriescanadverselyaffectperformance,

stabilityorhandling,whichcouldresultindeathorserious

injury.(00001b)

Donotaddsidecartothismotorcycle.Operating

motorcyclewithsidecarcancauselossofvehiclecontrol,

whichcouldresultindeathorseriousinjury.(00590d)

NoiseControlSystem

Tampering

Removalorreplacementofanynoisecontrolsystemcomponentmaybeprohibitedbylaw.This

prohibitionincludesmodificationsmadepriortovehiclesaleordeliverytotheultimatepurchaser.

Useofavehicleonwhichnoisecontrolsystemcomponentshavebeenremovedorrendered

inoperativemayalsobeprohibitedbylaw.

Labels

SeeLabels.Thesafetyandmaintenancelabelsonyourmotorcycleindicatecomplianceto

marketregulations.RefertoLabels.

NOTE:

SomelabelsareavailableindifferentlanguagesfordestinationsoutsidetheUnitedStates.

Ifremovedordamaged,replacementlabelscanbepurchased.SeeaHarleyDavidsondealerfor

allavailablelabels.

Labels

LABEL PART

NO.

DESCRIPTION LOCATION TEXT

1 2910808 General

warnings

Allmodels

exceptFXDLS

Topofair

cleaner

cover

WARNING:Motorcyclesaredifferentfromother

vehicles.Theyoperate,steer,handleandbrake

differently.Unskilledorimproperusecould

resultinlossofcontrol,deathorseriousinjury.

Takearidertrainingcourse.

ReadOwner'sManualbeforeriding,

addingaccessoriesorservicing.

Wearahelmet,eyeprotectionand

protectiveclothing.

Nevertowatrailer.

Foramanual,findnearestdealerat1

4143434056orwww.harley

davidson.com

14000377 General

warnings

FXDLS

Topofair

cleaner

cover

2 15368

01A

Battery

warning

Topof

batterytray

cover

WARNING:Aconnectedbatterycancausea

sparkormotorcyclestartupwhileservicing.

Deathorseriousinjurycouldoccur.

Disconnectnegativecablebefore

servicing.

Keepcableawayfromterminalwhile

servicing.

3 14000069 Saddlebag

loadlimits

Inside

saddlebag

(equipped

models)

WARNING:Toomuchweightinsaddlebags

cancauselossofcontrol.Deathorserious

injurycouldoccur.

Donotputmorethan15pounds(6.8kg)

ineachsaddlebag.

Putequalweightineachsaddlebag.

SeeAccessoriesandCargosectionof

Owner'sManualformoreinformation.

Identification

VehicleIdentificationNumber(VIN)

General

SeeTypicalHarleyDavidsonVIN:2016DynaModels.Aunique17digitserialorVehicle

IdentificationNumber(VIN)isassignedtoeachmotorcycle.RefertoHarleyDavidsonVIN

Breakdown:2016DynaModels.

Location

SeeVINLocations.Thefull17digitVINisstampedontherightsideoftheframenearthe

steeringhead.Insomedestinations,aprintedVINlabelisalsoattachedonthefrontdowntube.

AbbreviatedVIN

AnabbreviatedVINshowingthevehiclemodel,enginetype,modelyear,andsequentialnumber

isstampedontheleftsideofthecrankcasebetweentheenginecylinders.

NOTE:

Alwaysgivethefull17digitVehicleIdentificationNumberwhenorderingpartsormakingany

inquiryaboutyourmotorcycle.

1.StampedVIN

2.VINlabel

VINLocations

TypicalHarleyDavidsonVIN:2016DynaModels

HarleyDavidsonVINBreakdown:2016DynaModels

POSITION DESCRIPTION POSSIBLEVALUES

1 Worldmanufacturer

identifier

1HD=OriginallymanufacturedintheUnitedStates

5HD=OriginallymanufacturedintheUnitedStatesforsale

outsideoftheUnitedStates

932=OriginallymanufacturedinBrazil

MEG=OriginallymanufacturedinIndia

2 Motorcycletype 1=Heavyweightmotorcycle(901cm3orlarger)

3 Model SeeVINmodeltable

4 Enginetype 4=TwinCam96™,1585cm3aircooled,fuelinjected

M=TwinCam103™,1690cm3aircooled,fuelinjected

8=TwinCam110™,1802cm3aircooled,fuelinjected

5 Calibration/configuration,

introduction

NormalIntroduction

1=Domestic(DOM)

3=California(CAL)

A=Canada(CAN)

C=HDI

E=Japan(JPN)

G=Australia(AUS)

J=Brazil(BRZ)

L=AsiaPacific(APC)

N=India(IND)

MidyearorSpecialIntroduction

2,4=Domestic(DOM)

5,6=California(CAL)

B=Canada(CAN)

D=HDI

F=Japan(JPN)

H=Australia(AUS)

K=Brazil(BRZ)

M=AsiaPacific(APC)

P=India(IND)

6 VINcheckdigit Canbe09orX

7 Modelyear G=2016

8 Assemblyplant C=KansasCity,MOU.S.A.

D=HDBrazilManaus,Brazil(CKD)

N=HaryanaIndia(BawalDistrictRewari)

9 Sequentialnumber Varies

VINModelCodes:2016DynaModels

CODE MODEL CODE MODEL

GN FXDLDyna®LowRider®GY FXDFDyna®FatBob®

GP FXDWGDyna®WideGlide®GZ FLDDyna®Switchback®

GS FXDLSDyna®LowRider®S VA FXDBPDyna®StreetBob®

GX FXDBDyna®StreetBob®VD FXDBCDyna®StreetBob®Limited

Specifications

Engine:TwinCam96

ITEM SPECIFICATION

Numberofcylinders 2

Type 4cycle,45degree

VType,aircooled

Compressionratio 9.2:1

Bore 3.75in 95.3mm

Stroke 4.38in 111.1mm

Displacement 96.7in31585cm3

Lubricationsystem Pressurized,drysump

Engine:TwinCam103

ITEM SPECIFICATION

Numberofcylinders 2

Type 4cycle,45degree

VType,aircooled

Compressionratio 9.6:1

Bore 3.875in 98.4mm

Stroke 4.38in 111.1mm

Displacement 103.1in31690cm3

Lubricationsystem Pressurized,drysump

Engine:AirCooledTwinCam110

ITEM SPECIFICATION

Numberofcylinders 2

Type 4cycle,45degree

VType,aircooled

Compressionratio 9.2:1

Bore 4.00in 101.6mm

Stroke 4.38in 111.1mm

Displacement 110.0in31802cm3

Lubricationsystem Pressurized,drysump

NOTE:

Specificationsinthispublicationmaynotmatchthoseofofficialcertificationinsomemarketsdue

totimingofpublicationprinting,varianceintestingmethods,and/ormotorcycledifferences.

Customersseekingofficiallyrecognizedregulatoryspecificationsfortheirvehicleshouldreferto

certificationdocumentsand/orcontacttheirrespectivedealerordistributor.

Electrical

COMPONENT SPECIFICATION

Ignitiontiming Notadjustable

Battery 12V,315CCA,19Ah,

sealedandmaintenancefree

Chargingsystem Threephase,40A

(493W@13.5V,2000rpm,

540Wmaxpower@13.5V)

Sparkplugsize 12mm

Sparkpluggap 0.0380.043in 0.971.09mm

Sparkplugtorque 1218ftlb 16.324.4Nm

Transmission

TRANSMISSION SPECIFICATION

Type Constantmesh,footshift

Speeds 6forward

SprocketTeeth

DRIVE ITEM NUMBEROFTEETH

Primary Engine 34

Clutch 46

Final Transmission 32

Rearwheel 66*

*64teethonJapanesemodels

OverallDriveRatios

GEAR DOMESTICAND

INTERNATIONAL

JAPANESE

MODELS

Firstgear 9.311 9.029

Second

gear

6.454 6.259

Thirdgear 4.793 4.648

Fourth

gear

3.882 3.764

Fifthgear 3.307 3.207

Sixthgear 2.790 2.706

Donotexceedthemotorcycle'sGrossVehicleWeight

Rating(GVWR)orGrossAxleWeightRating(GAWR).

Exceedingtheseweightratingscanleadtocomponent

failureandadverselyaffectstability,handlingand

performance,whichcouldresultindeathorseriousinjury.

(00016f)

GVWRisthesumoftheweightofthemotorcycle,accessories,andthemaximumweightof

therider,passengerandcargothatcanbesafelycarried.

GAWRisthemaximumamountofweightthatcanbesafelycarriedoneachaxle.

SeeinformationlabelonframedowntubeforGVWRandGAWR.

NOTE:

ThemaximumadditionalweightallowedonthemotorcycleequalstheGrossVehicleWeight

Rating(GVWR)minustherunningweight.Forexample,amotorcyclewithGVWRof1200lb544

kghavingarunningweightof800lb363kg,wouldallowamaximumofanextra400lb181kg

combinedweightoftherider,passenger,ridinggear,cargoandinstalledaccessories.

Weight

ITEM FXDB,

FXDBC*,

FXDBP*

FXDF FXDWG FLD FXDL FXDLS

lb kg lb kg lb kg lb kg lb kg lb kg

Runningweight** 670 304 706 320 683 310 718 326 666 302 674 306

Maximumaddedweight

allowed***

415 188 379 172 402 182 452 205 419 190 411 186

GVWR 1085 492 1085 492 1085 492 1170 530 1085 492 1085 492

GAWRfront 390 177 390 177 390 177 455 206 390 177 390 177

GAWRrear 695 315 695 315 695 315 794 360 695 315 695 315

*Specificationsmayvaryforfactorycustomizedvehicles.

**Thetotalweightasdeliveredwithalloil/fluidsandapproximately90%offuel.

***Thetotalweightofaccessories,cargo,ridinggear,passengerandridermustnotexceedthis

weight.

Dimensions

ITEM FXDB,FXDBC*,

FXDBP*

FXDF FXDWG FLD FXDL FXDLS

in mm in mm in mm in mm in mm in mm

Length 94.3 2395 94.5 2400 96.3 2445 92.9 2360 92.3 2345 89.9 2283

Overallwidth 36 915 35.0 890 35.2 895 36.6 930 35.6 905 35.5 902

Overallheight 48.8 1240 44.7 1135 44.7 1135 54.5 1385 46.6 1185 50.0 1270

Wheelbase 64.2 1630 63.8 1620 67.5 1715 62.8 1595 64.2 1630 64.2 1630

Roadclearance 4.7 120 4.9 125 3.9 100 4.3 110 4.1 105 4.1 105

Seatheight** 25.5 648 26.1 663 25.5 648 26.1 663 25.4 660 26.6 676

*Specificationsmayvaryforfactorycustomizedvehicles.

**With180lb81.6kgrideronseat.

Capacities

ITEM FXDB,FXDBC,FXDBP,FLD,FXDWG,FXDL,

FXDLS

FXDF

U.S. METRIC U.S. METRIC

Fueltank(total) 4.7gal 17.8L 5.0

gal

18.9L

Oiltankwithfilter 3.0qt 2.8L 3.0qt 2.8L

Transmission(approximate) 1.0qt 0.95L 1.0qt 0.95L

Primarychaincase

(approximate)

1.0qt 0.95L 1.0qt 0.95L

Lowfuelwarninglighton 0.9gal 3.4L 0.9

gal

3.4L

SpecifiedTires

MODEL MOUNT SIZE SPECIFIEDTIRE PRESSURE(COLD68°

F20°C)*

in psi kPa

FXDB,FXDBC,FXDBP,

FXDL,FXDLS

Front 19 MichelinScorcher"31"

100/90B19

30 206

Rear 17 MichelinScorcher"31"

160/70B17

40 276

FXDF Front 16 DunlopD427F

130/90B16

36 248

Rear 16 DunlopD427

180/70B16

40 276

FXDWG Front 21 MichelinScorcher"31"

80/9021

38 262

Rear 17 MichelinScorcher"31"

180/60B17

40 276

FLD Front 18 DunlopD402F

130/70B18

36 248

Rear 17 DunlopD401

160/70B17

40 276

*Tirepressurewillvarywithchangesinambientandtiretemperature.Checkpressurewithtires

cold(68°F20°C).Increasetirepressureby1psi6.9kPaforevery10°F5°Cinambientair

temperatureabovethispoint.

TireData

Matchtires,tubes,rimstripsorseals,airvalvesandcaps

tothecorrectwheel.ContactaHarleyDavidsondealer.

Mismatchingcanleadtotiredamage,allowtireslippage

onthewheelorcausetirefailure,whichcouldresultin

deathorseriousinjury.(00023c)

Onlyinstalloriginalequipmenttirevalvesandvalvecaps.

Avalve,orvalveandcapcombination,thatistoolongor

tooheavycanstrikeadjacentcomponentsanddamagethe

valve,causingrapidtiredeflation.Rapidtiredeflationcan

causelossofvehiclecontrol,whichcouldresultindeath

orseriousinjury.(00281a)

UseonlyHarleyDavidsonspecifiedtires.SeeaHarley

Davidsondealer.Usingnonspecifiedtirescanadversely

affectstability,handlingorbraking,whichcouldresultin

deathorseriousinjury.(00024b)

RefertoSpecifiedTiresforspecifiedtiresandrecommendedpressures.

TubelesstiresfittedwiththecorrectsizeinnertubesmaybeusedonHarleyDavidsonlaced(wire

spoked)wheels.Installanewrimstripandcorrectsizeinnertubeeachtimeanewtireisinstalled

onalacedwheel.

HarleyDavidsonfrontandreartiresarenotthesame.

Interchangingfrontandreartirescancausetirefailure,

whichcouldresultindeathorseriousinjury.(00026a)

Besuretiresareproperlyinflated,balanced,undamaged,

andhaveadequatetread.Inspectyourtiresregularlyand

seeaHarleyDavidsondealerforreplacements.Riding

withexcessivelyworn,unbalanced,improperlyinflated,

overloadedordamagedtirescanleadtotirefailureand

adverselyaffectstabilityandhandling,whichcouldresult

indeathorseriousinjury.(00014b)

AlwaysmaintainpropertirepressureasspecifiedinSpecifiedTires.Donotloadtiresbeyond

GAWRspecifiedinWeight.Underinflated,overinflatedoroverloadedtirescanfail.

ReplacetireimmediatelywithaHarleyDavidsonspecified

tirewhenwearbarsbecomevisibleoronly1/32in(0.8

mm)treaddepthremains.Ridingwithaworntirecould

resultindeathorseriousinjury.(00090c)

Donotuseliquidtirebalancersorsealantsinaluminum

wheels.Usingliquidtirebalancersorsealantscancause

rapidcorrosionoftherimsurface,whichcouldcausetire

deflation.Tiredeflationcancauselossofvehiclecontrol,

whichcouldresultindeathorseriousinjury.(00631b)

HarleyDavidsontireshavewearbarsthatrunhorizontallyacrossthetread.Whenatireiswornto

thepointthatthewearbarsarevisible,or1/32in0.8mmtreaddepthremains,thetirecan:

Bemoreeasilydamagedleadingtotirefailure.

Providereducedtraction.

Adverselyaffectstabilityandhandling.

HarleyDavidsondoesnotperformanytestingwithonlynitrogenintires.HarleyDavidsonneither

recommendsnordiscouragestheuseofpurenitrogentoinflatetires.

IndiaTireComplianceStatement:HarleyDavidsonMotorCompanydeclaresthatthetireslisted

inthespecificationssection(IndiaOnly)meettheIndianStandard15627requirementofthe

BureauofIndianStandards(asamendedfromtimetotime)requiredforregistrationofvehicles

assembled/manufacturedinIndia.ThesetiresalsocomplywiththeCentralMotorVehicleRules

requirements,1989.

Fuel

Alwaysuseagoodqualityunleadedgasoline.Octaneratingsareusuallyfoundonthepump.

RefertoOctaneRating.

Avoidspills.Slowlyremovefillercap.Donotfillabove

bottomoffillerneckinsert,leavingairspaceforfuel

expansion.Securefillercapafterrefueling.Gasolineis

extremelyflammableandhighlyexplosive,whichcould

resultindeathorseriousinjury.(00028a)

Usecarewhenrefueling.Pressurizedairinfueltankcan

forcegasolinetoescapethroughfillertube.Gasolineis

extremelyflammableandhighlyexplosive,whichcould

resultindeathorseriousinjury.(00029a)

Modernservicestationpumpsdispenseahighflowofgasolineintoamotorcyclefueltank.This

cancauseairentrapmentandpressurization.

OctaneRating

SPECIFICATION RATING

PumpOctane(R+M)/2 91(95RON)

GasolineBlends

Yourmotorcyclewasdesignedtogetthebestperformanceandefficiencyusingunleaded

gasoline.Mostgasolineisblendedwithalcoholand/orethertocreateoxygenatedblends.The

typeandamountofalcoholoretheraddedtothefuelisimportant.

Donotusegasolinethatcontainsmethanol.Doingsocan

resultinfuelsystemcomponentfailure,enginedamage

and/orequipmentmalfunction.(00148a)

Gasoline/METHYLTERTIARYBUTYLETHER(MTBE)blendsareamixtureofgasolineand

asmuchas15percentMTBE.Gasoline/MTBEblendsuseinyourmotorcycleisapproved.

ETHANOLfuelisamixtureofethanol(grainalcohol)andunleadedgasolineandcanhave

animpactonfuelmileage.Fuelswithanethanolcontentofupto10percentmaybeusedin

yourmotorcyclewithoutaffectingvehicleperformance.U.S.EPAregulationscurrently

indicatethatfuelswith15percentethanol(E15)arerestrictedfromuseinmotorcyclesatthe

timeofthispublication.Somemotorcyclesarecalibratedtooperatewithhigherethanol

concentrationstomeetthefuelstandardsincertaincountries.

REFORMULATEDOROXYGENATEDGASOLINES(RFG)describesgasolineblendsthat

arespecificallydesignedtoburncleanerthanothertypesofgasoline.Thisresultsinfewer

tailpipeemissions.Theyarealsoformulatedtoevaporatelesswhenfillingthetank.

Reformulatedgasolinesuseadditivestooxygenatethegas.Yourmotorcyclewillrun

normallyusingthistypeoffuel.HarleyDavidsonrecommendsusingitwheneverpossibleas

anaidtocleanerairinourenvironment.

Donotuseracingfuelorfuelcontainingmethanol.Useofthesefuelswilldamagethefuel

system.

UsingfueladditivesotherthanthoseapprovedforusebyHarleyDavidsonmaydamagethe

engine,fuelsystemandothercomponents.

Somegasolineblendsmightadverselyaffectstarting,driveabilityorfuelefficiency.Ifanyofthese

problemsareexperienced,tryadifferentbrandofgasolineorgasolinewithahigheroctaneblend.

CatalyticConverter

Donotoperatecatalyticconverterequippedvehiclewith

enginemisfire.Ifyouoperatethevehicleunderthis

condition,theexhaustwillbecomeabnormallyhot,which

cancausevehicledamage,includingemissioncontrol

loss.(00149c)

Useonlyunleadedfuelincatalyticconverterequipped

motorcycles.Usingleadedfuelwilldamagetheemission

controlsystem.(00150b)

YourmotorcyclehascatalyticconvertersexceptinAustralia.

ControlsandIndicators

General:ControlsandIndicators

ReadtheCONTROLSANDINDICATORSsectionbefore

ridingyourmotorcycle.Failuretounderstandthe

operationofthemotorcyclecouldresultindeathor

seriousinjury.(00043a)

Somefeaturesexplainedareuniquetocertainmodels.Thesefeaturesmaybeavailableas

accessoriesforyourHarleyDavidsonmotorcycle.SeeaHarleyDavidsondealerforacomplete

listofaccessoriesthatwillfityourspecificmotorcycle.

PrimaryControls

Familiarizeyourselfwiththelocationoftheallthecontrolsandservicecomponentsonyour

motorcycle.

ClutchLever

Donotpositionfingersbetweenhandcontrolleverand

handlebargrip.Improperhandpositioningcanimpair

controlleveroperationandcauselossofvehiclecontrol,

whichcouldresultindeathorseriousinjury.(00032a)

SeeControlsandServiceComponents:FXDB.Theclutchleverisonthelefthandlebar.The

clutchleverisoperatedwiththefingersofthelefthand.

Aclutchswitchisincorporatedintothelefthandlebarswitchassembly.Itenablestheridertostart

thevehicleinanygear(orinneutral)aslongastheclutchleverispulledin.Iftheclutchisnot

disengagedandthevehicleisingear,thevehiclecannotstart.

GearShiftLever

SeeControlsandServiceComponents:FXDB.Thegearshiftleverislocatedinfrontofthe

leftriderfootboardorfootrest.Thegearshiftisoperatedwiththeleftfoot.

Neutralisfoundbetweenfirstandsecondgearinasixspeedshiftpattern.SeeShiftingGears.

FrontBrakeLever

SeeControlsandServiceComponents:FXDB.Thefrontbrakeleveroperatesthefront

brake.Operatethehandleverwiththefingersoftherighthand.SeeBrakeSystem.

ThrottleControlGrip

SeeControlsandServiceComponents:FXDB.Thethrottlecontrolgripisontheright

handlebarcontrol.Thethrottleisoperatedwiththerighthand.

RearBrakePedal

SeeControlsandServiceComponents:FXDB.Therearbrakepedaloperatesthebrakeon

therearwheel.Operatetherearbrakepedalwiththerightfoot.SeeBrakeSystem.

1.Clutchhandlever

2.Lefthandcontrolmodule

3.Speedometer/odometer

4.Frontbrakefluidreservoir

5.Frontbrakelever

6.Throttletwistgrip

7.Righthandcontrolmodule

8.Indicatorlampbar

9.Ignitionswitch

10.Fuelfillercap

11.Fuelgauge

ControlsandServiceComponents:FXDB

1.Frontbrakecaliper

2.Clutchcover

3.Sidecover(fuseblock)

4.Preloadadjuster

5.Beltdeflectionwindow

6.Jiffystand

7.Gearshiftlever

8.Airvalve

ControlsandServiceComponents:FXDB

1.Rearbrakecaliper

2.Transmissionfillerplug

3.Oilfillercap/dipstick

4.Aircleaner

5.Rearbrakepedal

6.Rearbrakefluidreservoir

ControlsandServiceComponents:FXDB

LeftHandControlSwitches

Trip

Thetripswitchactivatesthetripodometersandisusedtoactivatetheodometerdisplaytoscroll

throughtheoptionalscreens.Withtheignitionoff,thetripswitchcanactivatetimeorodometer

displays.RefertoLeftHandControlSwitches.

Horn

SeeLeftHandSwitchModule.Thehornisoperatedbypressingonthehornswitch.Thehorn
canbeactivatedforupto10secondsatatime.Ifthehornswitchisheldforalongerperiod,the
hornwillautomaticallydeactivate.RefertoLeftHandControlSwitches.
HighBeam
SeeLeftHandSwitchModule.Pressthehighbeamswitchtoactivatethehighbeam.The
(blue)highbeamindicatorlampislitwhenthehighbeamison.RefertoLeftHandControl
Switches.
LowBeam/FlashtoPass
Lowbeam:SeeLeftHandSwitchModule.Pressthebottomoftheswitchtoactivatethelow
beam.
Flashtopass:Whenthelowbeamswitchison,pressandreleasetheflashtopassswitchto
flashthehighbeambeforepassinganothervehicle.Thehighbeamindicatorlampinthe
speedometerfaceisilluminatedaslongastheflashtopassswitchispressed.
Wheninaccessory,presstheflashtopassswitchtoactivatetheheadlamp.RefertoLeftHand
ControlSwitches.
LeftTurnSignal
Activate:SeeLeftHandSwitchModule.Presstheleftturnsignalswitchtoactivatetheleft
turnsignal.RefertoLeftHandControlSwitches.
Cancel:Presstheleftturnsignalswitchtocanceltheleftturnsignal.Fordetailedoperation,see
TurnSignalSwitchOperation.
NOTE:
Frontturnsignallampsalsofunctionasrunninglamps.Thisfeaturemaynotbeavailableinall
markets.

1.Trip

2.Horn

3.Highbeam

4.Lowbeam/flashtopass

5.Leftturnsignal

LeftHandSwitchModule

LeftHandControlSwitches

SWITCH NAME FUNCTION

Trip Presstoalternateodometer

displays.

Horn Presstosoundthehorn.

High

beam

Presstoswitchtheheadlampto

highbeam.

Low

beam/

flashto

pass

Presstoswitchtheheadlamptolow

beam.

Pressandreleasetoflashthehigh

beam.

InACC,presstoactivatethe

headlamp.

Leftturn Presstoactivatetheleftturnsignal.

CruiseControlSwitch:FXDLS

SeeCruiseControl:FXDLS.Thecruisecontrolswitchisusedtosetandreleasethecruise

speed.RefertoCruiseControlSwitch:FXDLS.SeeCruiseControlOperation:FXDLS.

Cruise:Pressthecruiseswitchstraightintoenablecruisecontrol.Thecruisecontrolindicatorin

thespeedometerfacelightsamber.Pressingtheswitchagainturnsoffcruisecontrol.

SET/:Withcruisecontrolenabled,pressSET/tosetthecruisingspeed.Thecruisecontrol

indicatorlightsgreen.Whileatcruisingspeed,pressSET/todecreasetheregulatedspeed.

RES/+:Ifcruisecontrolisdisengaged(afterbrakingorrollingthethrottlethroughtherolloff

switch),pressRES/+toresumethepreviouscruisingspeed.Whileatcruisingspeed,press

RES/+toincreasespeed.

CruiseControl:FXDLS

CruiseControlSwitch:FXDLS

SWITCH NAME FUNCTION

Cruise Presstoturnoncruise.

Set Presstosetthecruisespeed.

Tapdowntodecreasespeedin

increments.

Resume Presstoresumecruise.

Tapuptoincreasesetspeedin

increments.

RightHandControlSwitches

HazardWarning4WayFlasher

SeeRightHandControlModule.Thehazardswitch(1)isusedtoleaveastrandedmotorcycle

inthe4wayflashingmode.Withtheflashers,themotorcyclecanbeleftwiththeignitionlocked
untilassistanceisfound.RefertoRightHandControlSwitches.
1.WiththeignitionswitchintheIGNITIONorACCposition,pressonthehazardwarning
triangletoactivatethe4wayflashers.
NOTE:
Securitymodels:Thefobmustbepresentwhenturningonthe4wayflashersandwhen
cancelingtheflashers.
2.Turnignitionoff.The4wayflasherscontinuefor2hoursoruntilcancelledbytherider.
3.Tocancel,turntheignitiontoACCorIGNITION.Pressthewarningtriangleabovethestart
switch.
Start
SeeRightHandControlModule.Thestartswitch(5)isontherighthandlebarcontrolmodule.
RefertoRightHandControlSwitches.
1.SwitchtheOFF/RUNswitchtotherunposition(3).Shiftthetransmissiontoneutral.The
neutral(green)indicatorilluminates.SeeStartingtheEngine.
2.Turnignitionon.Pressthestartswitch(5)tooperatethestartermotor.
NOTES:
Whenthestarterisactivated,theheadlampismomentarilyturnedofftoreducebattery
load.
Iftheenginedoesnotstart,thestartermotorrunsforfivesecondsandstops.Release
thestartswitch.Pressthestartswitchtotryagain.Afterseveralunsuccessfulattempts
tostarttheengine,seeaHarleyDavidsondealer.
OFF
SeeRightHandControlModule.PresstheengineOFF/RUNswitchtoOFF(2)toshutoffthe
engine.RefertoRightHandControlSwitches.
Afterturningofftheengine.TurntheignitionswitchtoOFFtodisconnecttheelectricpower.
RUN
SeeRightHandControlModule.PushtheengineOFF/RUNswitchtoRUN(3)toenable
enginestartandrun.TheengineOFF/RUNswitchmustbeintheRUNpositiontostartoroperate
theengine.RefertoRightHandControlSwitches.
RightTurnSignal
Activate:SeeRightHandControlModule.Presstherightturnsignalswitch(4)toactivatethe
rightturnsignal.RefertoRightHandControlSwitches.
Cancel:Presstherightturnsignalswitchtocanceltherightturnsignal.Fordetailedoperation,

seeTurnSignalSwitchOperation.

NOTE:

Frontturnsignallampsalsofunctionasrunninglamps.Thisfeaturemaynotbeavailableinall

markets.

1.Hazard

2.Off

3.Run

4.Leftturnsignal

5.Start

RightHandControlModule

RightHandControlSwitches

SWITCH NAME FUNCTION

Hazard Presstoactivatethe4wayflashers.

Start Presstostarttheengine.

Off Presstostoptheengineortoprevent

theenginefromstarting.

Run Presstoallowtheenginetostart.

Right

turn

Presstosignalarightturn.

TurnSignalSwitchOperation

Operating

Pressandreleasetheleftorrightturnsignalswitchtoactivatetheturnsignallamps.Thelamps

flashuntiltheyareautomaticallycanceledormanuallycanceledbytherider.

NOTE:

Ifaturnsignalindicatorflashesrapidly,aturnsignalisnotoperating.Exercisecaution.Usehand

signals.Immediatelyreplacedefectivecomponents.

AutomaticCanceling

Theturnsignallampsautomaticallycancelwhenafullturnhasbeendetectedbasedonspeed,

accelerationandturncompletion.

Thelampsalsocanceliftheturnsignalhasbeenactivatedforaprolongedperiod(20flashes)

whilethemotorcyclespeedisgreaterthan7mph11km/h.Ifthemotorcycleisstoppedormoving

slowerthanthisspeed,theturnsignalcontinuesflashing.

ManualCanceling

Tocanceltheturnsignal,pressandreleasetheturnsignalswitchasecondtime.

Toactivatetheoppositeturnsignal,pressandreleasetheturnsignalswitchforthenewdirection.

Thefirstturnsignalcancelsandtheoppositeturnsignallampsbeginflashing.

CruiseControlOperation:FXDLS

Donotusethecruisecontrolsysteminheavytraffic,on

roadswithsharporblindcurvesoronslipperyroadsof

anykind.Usingthecruisecontrolinthesecircumstances

cancauselossofcontrol,whichcouldresultindeathor

seriousinjury.(00083a)

Travelatspeedsappropriateforroadandconditionsand

nevertravelfasterthanpostedspeedlimit.Excessive

speedcancauselossofvehiclecontrol,whichcould

resultindeathorseriousinjury.(00008a)

TurnCruiseOn

NOTE:

Cruisecontrolonlyworksatspeedsbetween3090mph48144km/hinthirdgearorhigher.

SeeCruiseControl:FXDLS.Pressthecruiseswitchintoturnoncruise(1).Whenon,the

cruiseiconinthespeedometerfaceglowsamber.

SetCruiseSpeed

SeeCruiseControl:FXDLS.Whenthemotorcyclereachesyourintendedspeed,pressthe

SET/switchdowntosetthecruisespeed(2).Theambercruiseiconchangestogreen.

Ifnecessary,adjustthecruisespeedtomatchthespeedlimitortrafficconditions:

Increase/DecreaseCruise

TappingtheRES/+switchupincreasesspeedby1mph1.6km/h.HoldinguptheRES/+switch

graduallyincreasescruisespeed.

TappingtheSET/+switchdowndecreasesspeedby1mph1.6km/h.Holdingtheswitchdown

graduallydecreasescruisespeed.

DisengageCruise

SeeCruiseControl:FXDLS.Todropoutofcruisespeed,rollthethrottleclosedthroughtheroll

offswitch(3).

Cruisealsodisengages,iftherider:

Squeezesthefrontbrakeleverorpressestherearbrakepedal.

Squeezestheclutchlever.

Rollsthethrottleopenmorethan10mph16km/habovethesetspeed.

ResumeCruise

NOTE:

Ifthecurrentspeedismorethan15mph24km/hbelowthecruisespeed,cruisewillnotresume.

SeeCruiseControl:FXDLS.Ifcruisehasbeendisengagedyetthecruiseindicatorisamber,

pressingtheRES/+switchupresumescruise(4).Theiconglowsgreen.Themotorcycle

automaticallyresumescruiseatthesetspeed.

TurnCruiseOff

Pressthecruiseswitchintoturnoffcruisecontrol.Thecruiseicongoesblank.

1.Cruiseon/off

2.Setspeed(SET/)

3.Disengagecruise

4.Resumespeed(RES/+)

CruiseControl:FXDLS

IgnitionSwitch

Ignition/ForkLockKey

Theignitionkeylockstheignitionswitchtopreventunauthorizeduseoftheftofyourmotorcycle.

Thesamekeyalsoworksintheforklocktopreventunauthorizedmovementofyourmotorcycle.

SeeIgnition/ForkLockKey.Iflost,aHarleyDavidsondealercanreplacethekeybasedonthe

uniquekeynumber.Thekeynumber(2)isstampedonthetopofthekeyundertheplasticcover

(1).RecordyourkeynumberonthelineprovidedonthePersonalInformationandDealer

InformationpageinthefrontofthisOwner'sManual.

1.Cover

2.Keynumber

Ignition/ForkLockKey

IgnitionSwitch

Theautomaticonheadlampfeatureprovidesincreased

visibilityoftheridertoothermotorists.Besureheadlamp

isonatalltimes.Poorvisibilityofridertoothermotorists

canresultindeathorseriousinjury.(00030b)

Theignitionswitchcontrolstheelectricalfunctions.RefertoIgnitionSwitchPositions.

Protectyourvehicleagainsttheft.Failuretolockthe

motorcycleafterparkingcouldresultintheftand/or

equipmentdamage.(00151b)

Donotoperatevehiclewithforkslocked.Lockingtheforks

restrictsthevehicle'sturningability,whichcouldresultin

deathorseriousinjury.(00035a)

Donotlubricatebarrellockswithpetroleumbased

lubricantsorgraphite.Inoperativelocksmayresult.

(00152a)

NOTES:

TheinstrumentlampsandheadlampsareilluminatedwhentheswitchisintheIGNposition

asrequiredbylawinsomelocalities.RefertoIgnitionSwitchPositions.

Removetheignitionkeyfromtheignitionlockwhileoperatingthemotorcycle.Ifyoudonot

removethekey,itcanfallout.

LeavingthemotorcycleinACCforanextendedamountoftimecandischargethebattery.If

inACC,themotorcyclewillbeautomaticallyturnedOFFaftertwohourstopreventbattery

fromcompletedischarge.ToresumenormaloperationturntheignitionswitchbacktoOFF

andthentothedesiredposition.

IgnitionSwitchPositions

SWITCH

POSITION

FUNCTION

OFF Ignition,lampsandaccessoriesareoff.

ACCESSORY

(ACC)*

Accessoriesareon.Hazardwarning

flasherscanbeoperated.Instrument

lampsareon.Theheadlampswitchcan

beswitchedbetweenhighandlowbeam.

Brakelampandhorncanbeactivated.

IGNITION

(IGN)*

Ignition,lampsandaccessoriesareon.

*Internationalmodelshaveanadditionalfunction

positionlampandtaillamparealsoon.

AllModelsExceptFXDL,FXDLS

SeeIgnitionSwitch:AllModelsExceptFXDL,FXDLS.Theignitionswitchisonthe

instrumentpanelontopofthetank.

Unlock:Tounlocktheswitch,insertkeyandturnclockwisetounlockposition.

Operate:RotateswitchtoselecttheACCorIGNposition.RefertoIgnitionSwitchPositions.

Lock:TheswitchcanbelockedintheOFForACCposition.Tolocktheswitch,raisetheswitch

cover,insertkey,andturncounterclockwisetothelockposition.

TurntheignitionswitchtotheOFFpositionbeforelocking

themotorcycle.LeavingtheswitchintheACCpositionwill

keeptheinstrumentlightsonandresultinadischarged

battery.(00492b)

1.Lock

2.Unlock

3.Openswitchcover

4.ACC(Accessory)

5.OFF

6.IGN(Ignition)

IgnitionSwitch:AllModelsExceptFXDL,

FXDLS

FXDL,FXDLS

SeeIgnitionSwitch:FXDL,FXDLS.Theignitionswitchisontheleftsideofthevehicle

betweentheenginecylinders.

Unlock:Insertkeyandturnclockwisetounlockthethumblever.Removethekeyfromignition

switchbeforeoperatingmotorcycle.

Operate:UsethethumblevertoselecttheACCorIGNpositions.Forignitionswitchfunctions,

refertoIgnitionSwitchPositions.

Lock:TurnthethumblevertoOFF.Insertthekeyandturncounterclockwisetolockthethumb

lever.Removethekey.

1.Lock

2.Unlock

3.IGN(Ignition)

4.ACC(Accessory)

5.OFF

6.Thumblever

IgnitionSwitch:FXDL,FXDLS

ForkLock

Protectyourvehicleagainsttheft.Failuretolockthe

motorcycleafterparkingcouldresultintheftand/or

equipmentdamage.(00151b)

SeeForkLock.Theforklockisfoundintherightsidesteeringhead.

Donotoperatevehiclewithforkslocked.Lockingtheforks

restrictsthevehicle'sturningability,whichcouldresultin

deathorseriousinjury.(00035a)

Usingtheforklockimmediatelyafterparkingyourmotorcyclewilldiscourageunauthorizeduseor

theft.

LockFork

1.Turnforktofullleftposition.

2.Insertignitionkeyintoforklock.

3.Turnkeyleft(counterclockwise)tolockposition.

4.Removeignitionkey.

UnlockFork

1.Insertignitionkeyintoforklock.

2.Turnkeyright(clockwise)tounlockposition.

3.Removeignitionkey.

1.Locked

2.Unlocked

ForkLock

Instruments

Speedometer

Travelatspeedsappropriateforroadandconditionsand

nevertravelfasterthanpostedspeedlimit.Excessive

speedcancauselossofvehiclecontrol,whichcould

resultindeathorseriousinjury.(00008a)

SeeInstruments.Thespeedometer(1)registersmilesperhour(U.S.modelsonly)orkilometers

perhour(internationalmodelsonly).Somemarketshaveadualcalibratedspeedometer.

Instrumentbacklightingactivatesafteraslightdelay.Changestoambientlighting,suchasgoing

throughatunnel,maybrieflychangebacklighting.

Tachometer

Thetachometerregisterstheenginespeedinrevolutionsperminute(rpm).

AllmodelsexceptFXDL,FXDLS:SeeInstruments.Therpmappearsintheodometer

window(3).

FXDL,FXDLS:SeeInstruments.Aseparatesweepneedletachometer(2)indicatesthe

enginerpm.

OdometerWindow

SeeInstruments.PressingtheTRIPswitchwiththeignitionswitchinanypositionactivatesthe

odometerreading.

Theodometerwindowinthespeedometerfacealsoprovidesthefollowingselectabledisplays:

Odometertotal

TripodometerA

TripodometerB

Fuelrange

Time

Gearnumber

Tachometer(allbutFXDL,FXDLS)

PressandreleasetheTRIPswitchtocyclethroughthedisplays.SeeOdometerWindow

Displays.

1.Speedometer(mph)

2.Speedometer(km/h)

3.Speedometer(dual)

4.Odometerwindow

5.Tachometer:FXDL,FXDLS

Instruments

OdometerWindowDisplays

TripOdometersAandB

SeeOdometerDisplays.Tocheckmileageortoresettripodometers,theignitionswitchmust

beintheACCorIGNposition.PressandreleasetheTRIPswitchuntilthedesiredtripodometer

odometer.

Toresetorzerotripodometers,havedesired(AorB)odometerindisplaywindow.Pressthe

TRIPswitchandholdforapproximatelythreeseconds.Thetripodometerresetstozero.

GearSelection/Tachometer

PressandreleasetheTRIPswitchtocyclethroughtheodometerdisplaystoselectthegear

numberandthetachometerdisplay.Theodometershowsthecurrentgear(16)andtheengine

speedinrevolutionsperminute(rpm).

Whenthetransmissionisinneutralortheclutchleverispulledin,thegearnumberisblank.

FuelRange

Thefuelrangedisplayshowstheapproximatemileageavailablewiththeamountoffuelleftinthe

fueltank.

WithignitionswitchintheACCorIGNposition,presstheTRIPswitchuntilfuelrangeis

displayed.Theletter"R"intheleftsideofthedisplay,indicatesthefuelrange.Thecalculated

remainingdistance(milesorkilometers)toemptyisdisplayed,basedontheamountoffuelin

tank.RangecanbeaccessedatanytimeusingtheTRIPswitch.

Time

PressandreleasetheTRIPswitchtocyclethroughtheodometerwindowdisplaystothetime

display.SeeSettingTime.

1.TRIPswitch

2.TripodometerA

3.TripodometerB

4.Gearselection/rpm

5.Fuelrange

OdometerDisplays

WarningMessages

LowFuelWarningFuelRange

SeeWarningMessages.Whenthelowfuelwarninglampilluminates,thefuelrangefeature

automaticallydisplaysintheodometerwindow.TheridercanpresstheTRIPswitchtoreturnto

thecycleofodometerdisplays.Thefuelrangewarningisnotrepeateduntiltheignitionswitchis

cycledoffandbackon.

Afterthefuelrangedropsto10mi10km,thefuelrangedisplaywillscroll"LORNG"toindicate

thatthemotorcyclewillshortlyrunoutoffuel.

Resettingthelowfuelwarninglampandrangerequiresanignitioncyclechange.Alwaysturnthe

ignitionswitchtoOFFwhenfueling.

Disable:Todisablethisfunctionwhileriding,pressandholdtheTRIPswitchwhileinthefuel

rangedisplaymode.Theautomaticrangepopupfeatureindicatesthatitisdisabledwhenit

blinkstwice.

Enable:Toenabletheautomaticlowfuelwarningrangedisplay,pressandholdtheTRIPswitch.

Thelowfuelrangeblinksoncewhentheautomaticfeatureisenabled.

NOTES:

Whenthelowfuelwarninglampturnson,thefuellevelislow.Refuelassoonaspossible.

Therangedisplayisonlyupdatedwhenthevehicleismoving.

TheautomaticfuelrangedisplayisenabledaftertheignitionisturnedOFFIGN.

TipIndicator

Iftipoccurs,checkallcontrolsforproperoperation.

Restrictedcontrolmovementcanadverselyaffectthe

performanceofthebrakes,clutchorabilitytoshift,which

couldresultinlossofvehiclecontrolanddeathorserious

injury.(00350a)

SeeWarningMessages.Ifthemotorcycletipsover,theword"tiP"appearsintheodometer

window.Theenginecannotstartuntilreset.

Reset:Toreset,setthemotorcycleuprightandturntheignitionswitchOFFIGN.

NoFobMessage

SeeWarningMessages.Ifamotorcyclewithasecuritysystem,isdrivenoffleavingthefob

behind,'NOFOB'temporarilydisplaysintheodometerwindow.

Withoutthefob,themotorcyclecanonlybestartedwithamanualPINentrytodisarmthesecurity

system.SeeArmingandDisarming.

SidestandMessage

SeeWarningMessages.Oninternational(HDI)models,a'SidEStAnd'messageisdisplayedif

themotorcycleisplacedintogearwhilethejiffystandisdown.SeeJiffyStandInterlock:

InternationalModels.

WarningMessages

SettingTime

1.TurnignitionswitchtoONorACC.

2.SeeSettingTime.PressandreleasetheTRIPswitchuntiltime(hourandminutes)is

displayed.PressandholdtheTRIPswitchuntil12HR(1)beginstoblinkinthespeedometer

displaywindow.Releasetheswitch.

3.PressandreleasetheTRIPswitchoncetoadvancetoablinking24HRormilitarystyletime

display.Eachtimeyoupressandreleasetheswitch,thedisplayswitchesbetween12HR

and24HR.

4.Whenthedesiredtimeformat(12HRor24HR)isdisplayed,pressandholdtheTRIPswitch

untilthehoursdisplay(2)isblinking.

5.PressandreleasetheTRIPswitchrepeatedlytoadvancethehours.

6.Whenthecorrecthourisdisplayed,pressandholdtheTRIPswitchuntiltheminutesdisplay

(3)startsblinking.

7.PressandreleasetheTRIPswitchrepeatedlytoadvancetheminutesdisplay.

8.Whenthecorrectminutesaredisplayed,pressandholdtheTRIPswitchuntilthedisplay

advancestotheselectionofAMorPM.

NOTE:

AMorPMdoesnotappearintheregulartimedisplay.Themotorcycleusestheselectionfor

diagnosticpurposes.

9.Inthe12HRdisplay,AMorPMflashes.SelectAMorPMwiththeTRIPswitch.Pressand

holdtheswitchforfiveseconds.

10.TurnignitionswitchOFF.

SettingTime

InstrumentLamps

LowFuelLamp

Solid:SeeInstrumentLamps.Thelowfuelwarninglamp(1)illuminateswhenthegasolinein

thetankreachesthelowfuellevel(approximate).RefertoSpeedometerInstumentLamps.

Flashing:Ifthelowfuellampflashescontinuously,itindicatesthepresenceofafaultinthefuel

levelcircuitry.SeeaHarleyDavidsondealer.

SecurityLamp

SeeInstrumentLamps.Onmotorcyclesequippedwithasecuritysystem,thesecuritylamp(2)

illuminateswhenthesecuritysystemisarmed.SeeSecuritySystem.

Ifthesecuritylampremainslitafterthesecuritysystemisdisarmed,seeaHarleyDavidson

dealer.

BatteryDischargeLamp

SeeInstrumentLamps.Thebatterylampindicateseitheroverchargingorunderchargingofthe

battery.SeeBatteryMaintenance.

CruiseControl:FXDLS

SeeInstrumentLamps.Thecruisecontrollamp(3)illuminateswhencruisecontrolison.Refer

toSpeedometerInstumentLamps.

AntilockBrakeSystem(ABS)Lamp(ifequipped)

IfABSlampcontinuesflashingatspeedsgreaterthan3

mph(5km/h)orremainsoncontinuously,theABSisnot

operating.Thestandardbrakesystemisoperational,but

wheellockupcanoccur.ContactaHarleyDavidson

DealertohaveABSrepaired.Alockedwheelwillskidand

cancauselossofvehiclecontrol,whichcouldresultin

deathorseriousinjury.(00361b)

Flashing:SeeInstrumentLamps.OnvehicleswithABS,theABSlamp(5)beginsflashing

whenthevehicleisturnedon.Theflashinglampindicatesthatthesystemisinselfdiagnosis

mode.Itcontinuestoflashuntilmotorcyclespeedexceeds3mph5km/h.ABSisnotoperational

untilthelampturnsoff.RefertoSpeedometerInstumentLamps.

Solid:ContinuousilluminationofthelampindicatesanABSmalfunction.TheABSisdisabled

andthebrakesareoperatingasiftheywerenonABSbrakes.SeeaHarleyDavidsondealerfor

service.

CheckEngineLamp

SeeInstrumentLamps.Thecheckenginelampindicateswhentheengine/engine

managementsystemisnotoperatingnormally.

Thecheckenginelampcomesonwhentheignitionisturnedonandremainsonforapproximately

4seconds.Itremainslitwhiletheenginemanagementsystemrunsaseriesofselfdiagnostics.

RefertoSpeedometerInstumentLamps.

Ifthelampcomesonatanyothertime,seeaHarleyDavidsondealer.

1.Lowfuel

2.Security

3.Batterydischarge

4.Cruisecontrol:FXDLS

5.ABS(km/hABSiconalsoshown)

6.Checkengine

InstrumentLamps

SpeedometerInstumentLamps

ICON NAME FUNCTION

Lowfuel Illuminateswhenfuellevelisat

approximately0.8gal3.1Lorless.Fill

withrecommendedfuelassoonas

possible.

Security

system

Aflashinglampindicatesthatthe

securitysystemisarmed.

Battery

discharge

Indicateseitheroverchargingor

underchargingofthebattery.

Cruise

control

Amber:Ambercolorwhencruise

controlison.

Green:Greenwhencruisespeedisset

andmotorcycleisatcruisespeed.

ABS Flashesuntil3mph5km/handABS

becomesoperational.

Check

engine

Illuminateswhenenginediagnostics

hasdetectedanelectricalfault.

IndicatorLamps
Fiveindicatorlampsareprovided:
AllmodelsexceptFXDL,FXDLS:Intheinstrumentpanel.
FXDL,FXDLS:Intachometerface.
TurnSignals
SeeIndicatorLamps.Theturnsignalindicators(1,5)flashwhenaturnsignalisactivated.
Whenthe4wayhazardflashersareoperating,bothturnindicatorsflashsimultaneously.Referto
IndicatorBarIndicatorLamps.
HeadlampHighBeam
SeeIndicatorLamps.Theheadlamphighbeamindicatorlamp(2)islitwhenthehighbeamor
flashtopassswitchisactivated.RefertoIndicatorBarIndicatorLamps.
NeutralIndicatorLamp
SeeIndicatorLamps.Theneutralindicatorlamp(3)islitwhenthetransmissionisinneutral.
RefertoIndicatorBarIndicatorLamps.
OilPressureIndicatorLamp
SeeIndicatorLamps.Theoilpressureindicatorlamp(4)islitwhensufficientoilisnot
circulatingthroughtheengine.RefertoIndicatorBarIndicatorLamps.
Thelampislitwhentheignitionisturnedonbeforestartingengine.Withenginerunning,thelamp
isoffwhenenginespeedisaboveidle.
Circumstancesthatcouldcausetheoilindicatorlamptoilluminate:
Lowoillevel.Stopengineimmediately.Addoil.
Dilutedoil.Changeoilassoonaspossible.
Incorrectoilfortheoperatingtemperature.Changeoilassoonaspossible.
Forinformation,seeTroubleshooting.
Iftheoilpressureindicatorlampremainslit,alwayscheck
theoilsupplyfirst.Iftheoilsupplyisnormalandthelamp
isstilllit,stoptheengineatonceanddonotridefurther
untilthetroubleislocatedandthenecessaryrepairsare
made.Failuretodosomayresultinenginedamage.
(00157a)

1.Leftturn

2.Highbeam

3.Neutral

4.Oilpressure

5.Rightturn

IndicatorLamps

IndicatorBarIndicatorLamps

ICON NAME FUNCTION

Left

turn

Flasheswhenturnsignalswitchis

activatedforaleftturn.Pushleftturn

signalswitchtocancel.

High

beam

Illuminateswhenhighbeamsareon.

Pressthelowbeamswitchtoswitchto

lowbeam.

Neutral Illuminateswhentransmissionisin

neutral.

Oil

pressure

Ifindicatorremainslit,stopengineand

checkoillevel.

Right

turn

Flasheswhenturnsignalswitchis

activatedforarightturn.Pushrightturn

signalswitchtocancel.

ConfiguringSpeedometerUnits

1.Withtheignitiononorthekeyfobpresent,pushtheOFF/RUNswitchtoRUN.

2.SeeChangingSpeedometerUnits.Pressandholdthetripswitchuntilthespeedometer

unitschange(mphorkm/h).

ChangingSpeedometerUnits

ElectronicThrottleControl(ETC):FXDLS

YourmotorcyclehasElectronicThrottleControl(ETC).Insteadofamechanicalcable,theETC

usesgripsensorstocommunicatethrottlepositiontotheElectronicControlModule(ECM).The

ECMthenregulatesproperfuel/airintakeandignitiontimingbasedonthethrottleposition.

TheElectronicControlModule(ECM)monitorsthestatusofthegripsensors,throttleplate

actuationandairflow.IfTroubleCodesaredetected,theECMdisablescruisecontrol,illuminates

thecheckenginelampandtransitionstooneofthefollowingmodes.

ETCLimitedPerformanceMode

Theriderexperiencesnearnormaloperation.Themotorcycleoperateswithprovisionstoguard

againstunintendedacceleration.

ETCPowerManagementMode

Thethrottleplateactuatorreturnstoan"idledetent."Theidledetentor"limphome"position

providesenoughtorquetoachievespeedofabout25mph40km/h.Themotorcycle'sresponse

togripsensorinputisreduced.

ETCForcedIdleMode

Thethrottleplateactuatorisforcedtoa"fastidle"position.Fastidleprovidesenoughtorqueto

crawl,butnotenoughtorquetooperateattrafficspeeds.

ETCForcedShutDownMode

Theengineisforcedtoshutdown.

GearShiftLever

Location

SeeGearShiftLeverandShiftPattern.Thegearshiftleverisontheleftside.Thegearshift

leverisoperatedwiththeleftfoot.Theshiftleverchangesgearsinasequentialsixspeed

transmission.

ShiftPattern

Theclutchmustbefullydisengagedbeforeattemptinga

gearshift.Failuretofullydisengagetheclutchcanresult

inequipmentdamage.(00182a)

SeeGearShiftLeverandShiftPattern.Eachgearmustbeengagedinsequence.Liftthe

gearshiftleveruptoupshift.Presstheleverdowntodownshift.Aftereachgearchange,release

thegearshiftlevertoallowittoreturntoitsrestingposition.SeeGearShiftLever.

Neutral

Neutralislocatedbetweenfirstandsecondgear.Thetransmissioncanbeshiftedtoneutralfrom

eitherfirstorsecondgear.Liftorpressthegearshiftleveronehalfofitsstroke.Inneutral,the

indicatorlampilluminates.

GearShiftLeverandShiftPattern

BrakeSystem

FrontBrakeLever

Donotpositionfingersbetweenhandcontrolleverand

handlebargrip.Improperhandpositioningcanimpair

controlleveroperationandcauselossofvehiclecontrol,

whichcouldresultindeathorseriousinjury.(00032a)

SeeFrontBrakeLever.Thefrontbrakehandlevercontrolsthefrontwheelbrake.Thebrake

leverisontherighthandlebar.Operatethehandleverwiththefingersoftherighthand.

FrontBrakeLever

RearBrakePedal

SeeRearBrakePedal.Therearbrakepedalcontrolstherearwheelbrake.Thebrakepedalis

ontherightside.Operatetherearbrakepedalwiththerightfoot.

RearBrakePedal

NonABSBrakeSystem

Applybrakesuniformlyandevenlytopreventwheelsfromlocking.Usefrontandrearbrakes

equallyforbestresults.

Donotapplybrakestronglyenoughtolockthewheel.A

lockedwheelwillskidandcancauselossofvehicle

control,whichcouldresultindeathorseriousinjury.

(00053a)

AntilockBrakeSystem(ABS)

Identification

TheoptionalHarleyDavidsonantilockbrakesystemassiststheriderinmaintainingcontrolwhen

brakinginastraightlineemergencysituation.ABSoperatesindependentlyonfrontandrear

brakestokeepthewheelsrollingandpreventuncontrolledwheellockupseitherondrypavement

oronslicksurfacessuchasgravel,leavesorwhenridinginwetconditions.

SeeABSModule(EHCU)(behindcover).ModelswithABShaveanABSmodule(EHCU).

ABSModule(EHCU)(behindcover)

HowABSWorks

TheABSmonitorssensorsatthefrontandrearwheelstodeterminewheelspeed.Ifthesystem

detectsoneorbothwheelsareslowingdowntooquickly,whichindicatestheyarecloseto

locking,theABSreacts.Ifthedecelerationratedoesnotmatchacriteriastoredinmemory,the

ABSalsoreacts.Thesystemrapidlyopensandclosesvalvestomodulatethebrakecaliper

pressureutilizingonlythebrakelever/pedalpressurebeingappliedbytherider.DuringABS

activation,thesystemprovidestheelectronicequivalentofmanuallypumpingthebrakes.ABSis

capableofcyclinguptoseventimespersecond.

TheriderrecognizesABSactivationbytheslightpulsingsensationinthehandleverortherear

brakepedal.ThepulsingsensationcanalsobeaccompaniedbyaclickingsoundfromtheABS

module.Botharetheresultofnormaloperation.RefertoABSSymptomsandConditions.

HowToUseABS

Whileanadvantageinemergencybraking,ABSisnotasubstituteforsaferiding.Thesafestway

tostopamotorcycleisuprightwithbothwheelsstraight.

HarleyDavidsonABSisamanualassistsystem.Whenstoppinginanemergencystopping

situation,maintainpressureonthebrakesthroughallABSevents.Donotmodulateor"pump"the

brakecontrols.Thewheelscannotlockuntiltheendofthestopwhenmotorcyclespeedreaches

approximately4mph6km/handABSisnolongerneeded.

ABScannotpreventlockupofrearwheelduetoengine

braking.ABSwillnotaidincorneringoronloose/uneven

surfaces.Alockedwheelwillskidandcancauselossof

vehiclecontrol,whichcouldresultindeathorserious

injury.(00362a)

ABS:TiresandWheels

MotorcyclesequippedwithABSmustalwaysuseHarleyDavidsontiresandwheels.TheABS

monitorstherotationalspeedofthewheelsthroughindividualwheelspeedsensors.Changingto

differentdiameterwheelsordifferentsizedtirescanaltertherotationalspeed.Thiscanupsetthe

calibrationoftheABSandhaveanadverseeffectonitsabilitytodetectandpreventuncontrolled

wheellockups.OperatingattirepressuresotherthanthosespecifiedinSpecifiedTirescan

reduceABSbrakingperformance.

ABSSymptomsandConditions

SYMPTOM CONDITION

ABSlamp

continuously

lit

ABSmalfunctiondetected.SeeaHarleyDavidsondealerforservice.

ABSlamp

flashing

Thisindicatesanormalselfdiagnosticsprocesswhenthemotorcycleisfirstturned

onandthespeedisunder3mph5km/h.ABSisnotoperationaluntilthelamp

turnsoff.Ifthelampcontinuesflashingatspeedsgreaterthan3mph5km/h,see

aHarleyDavidsondealerforservice.

Pulsing

brakelever

Normalcondition.

orpedal

duringan

ABSevent

Clicking

sound

duringan

ABSevent

Normalcondition.

"Surge"

sensation

while

braking

Normalcondition.Thisismostnoticeablewhenbrakingwithonebrake(frontonly

orrearonly).Resultofareductionindecelerationwhichcanbecausedbycracks

orbumpsinroad,enginebraking(highengineRPMscausingtherearwheelto

slowdown),hardbrakingatslowspeeds,andotherconditions.ThisisduetoABS

modulatingcaliperbrakepressuretopreventuncontrolledwheellock.

Temporarily

stiffrear

brakepedal

Normalcondition.Enginebraking(highengineRPMscausingtherearwheelto

slowdown)ordownshiftingcanactivateABS.Ifapplyingtherearbrakeatthe

sametimeorimmediatelyafter,theABSmaybeclosingavalvetoprevent

pressuretotherearbrake.ThisisduetoABSmodulatingcaliperbrakepressureto

preventuncontrolledwheellock.

Tirechirp Normalcondition.Dependingonsurface,tirecanchirpwithoutlockingthewheel.

Blackmark

pavement

Normalcondition.Dependingonsurface,tirecanleaveablackmarkwithout

lockingthewheel.

Wheellock

atlow

speed

Normalcondition.ABSdoesnotactivateonfrontwheelbelow3mph5km/horon

rearwheelbelow5mph8km/h.

JiffyStand

Alwaysparkmotorcycleonalevel,firmsurface.An

unbalancedmotorcyclecanfallover,whichcouldresultin

deathorseriousinjury.(00039a)

Thejiffystandislocatedontheleftsideofthemotorcycle.Thestandswingsoutwardtosupport

themotorcycleforparking.

Thejiffystandlockswhenplacedinthefullforward(down)

positionwithvehicleweightonit.Ifthejiffystandisnotin

thefullforward(down)positionwithvehicleweightonit,

thevehiclecanfalloverwhichcouldresultindeathor

seriousinjury.(00006a)

Besurejiffystandisfullyretractedbeforeriding.Ifjiffy

standisnotfullyretracted,itcancontacttheroadsurface

causingalossofvehiclecontrol,whichcouldresultin

deathorseriousinjury.(00007a)

JiffyStandInterlock:InternationalModels

Someinternationalmodelshaveajiffystandinterlock.

Ifthetransmissionisinneutral,themotorcyclewillstartandrun.Ifthejiffystandisdownandthe

transmissioningear,engagingtheclutchstallsthemotorcycle.Themessage"SidEStAnd"scrolls

acrosstheodometer.Raisingthejiffystandorputtingthetransmissioninneutralwillpermitthe

enginetorun.Theodometerwillclearthemessage.

Ifthestandlowersataspeedgreaterthan10mph15km/h,theenginewillcontinuetorun.The

indicatorswillflashtwice.Themessage"SidEStAnd"willscrollacrosstheodometer.The

messageremainsuntilthesystemdetectsthejiffystandinthefullyretractedpositionagain.The

ridercancontinuetoridewhileinthismode.

Theridercanclearthetextmessagesatanytimebypressingthetrip/triggerswitchoncewhile

thevehicleispoweredup.

RearViewMirrors

Objectsinmirrorsarecloserthantheyappear.Usecaution

whenjudgingdistanceofobjectsinmirrors.Failureto

judgecorrectdistancescouldresultindeathorserious

injury.(00033a)

Yourmotorcyclehastwoconvexrearviewmirrors.

Thistypeofmirrorisdesignedtogiveamuchwiderviewtotherearthanaflatmirror.However,

carsandotherobjectsseeninthistypeofmirrorlooksmallerandfartherawaythantheyactually

are.

Usecautionwhenjudgingthesizeorrelativedistanceofobjectsseeninrearviewmirrors.

Alwaysadjusttherearviewmirrorstoreflecttheareabehindthemotorcyclebeforeriding.

NOTE:

Adjustmirrorssoyoucanseeasmallportionofyourshouldersineachmirror.Thiswillhelpyou

establishtherelativedistanceofvehiclestotherearofyourmotorcycle.

FuelFillerCap

RemovingtheFuelFillerCap

Donotuseaftermarketfuelcaps.Aftermarketfuelcaps

mayfitimproperlyandleak,whichcouldleadtodeathor

seriousinjury.SeeaHarleyDavidsondealerforapproved

fuelcaps.(00034a)

SeeFuelFillerCapandFuelGauge(typical).Thefuelfillercap(1)isontherightsideofthe

fueltank.Thefuelgauge(2)isNOTremovable.

ToRemove:Turnthecapcounterclockwisethree/quarterofaturntoengagethethreads.

Continuetounscrewthecapwhilelifting.

ToInstall:Turnthecapclockwiseuntilitclicks.Theclickisaratchetthatpreventsover

tightening.

1.Fuelfillercap

2.Fuelgauge

FuelFillerCapandFuelGauge(typical)

FillingtheTank

Avoidspills.Slowlyremovefillercap.Donotfillabove

bottomoffillerneckinsert,leavingairspaceforfuel

expansion.Securefillercapafterrefueling.Gasolineis

extremelyflammableandhighlyexplosive,whichcould

resultindeathorseriousinjury.(00028a)

Donotstoremotorcyclewithgasolineintankwithinthe

homeorgaragewhereopenflames,pilotlights,sparksor

electricmotorsarepresent.Gasolineisextremely

flammableandhighlyexplosive,whichcouldresultin

deathorseriousinjury.(00003a)

Donotspillfuelontothemotorcyclewhilerefueling.

Immediatelywipeupfuelspillsonyourmotorcycle.Fuel

cancausedamagetocosmeticsurfaces.(00147b)

Useonlyunleadedfuelincatalyticconverterequipped

motorcycles.Usingleadedfuelwilldamagetheemission

controlsystem.(00150b)

SeeFuelLevelbelowFillerNeck.Donotoverfillthefueltank.Insertthepumpnozzleintothe

fillerhole.Donotfillthetankbeyondthebottomofthefillerneck.Awarmengine,thesunor

extremetemperaturescancausethefueltoexpand.Fuelcanspilloutofthetankanddamagethe

finish.SeeSafeOperatingRules.

FuelLevelbelowFillerNeck

LockingFuelFillerCap(AsiaPacific)

ReplacementKeys

FindthefourdigitkeynumberstampedonthebackofthekeyoppositetheHDlogo.Writethe

ignitionkeynumberinthespaceprovidedatthefrontofthismanual.Withthatnumber,your

HarleyDavidsondealercanorderareplacement.

Removal

1.SeeLockingFuelFillerCap.Rotatethelockcovertoaccessthekeylock.

2.Insertthekey.

3.Holdthefuelfillercapinplace.Turnthekeycounterclockwiseuntilitstops.

4.Turnkeybacktoitsoriginalposition.Removethekey.

5.Turncapcounterclockwiseuntilresistanceisfelt.Continuetoturncapcounterclockwiseto

removecap.

Installation

1.SeeLockingFuelFillerCap.Insertthekeyintothelock.

2.Tomakesurethatthecapisunlocked,firmly,holdthecap.Turnthekeycounterclockwise

untilitstops.

3.Allowthekeytoreturntoaneutralposition.Removethekey.

NOTE:

Wheninstallingthefuelcap,rotatethecaponefullturnpasttheaudibleclick.

4.Turnthecapclockwisetoinstallthefuelcap.

5.Closethelockcover.

LockingFuelFillerCap

ShockAbsorberPreload:FXDLS

CalculatetheLoad

NOTE:

Thetotalofriderweightandpassengerpluscargoandaccessoriescannotexceedthemaximum

addedweightallowed.RefertoMaximumAddedWeightAllowed:FXDLS.

1.Addtheweightoftheriderandridinggeartogetthetotalriderweight.

2.Separately,addtheweightofthepassenger,theirridinggear,intendedcargoandany

accessories.

MaximumAddedWeightAllowed:FXDLS

MODEL SPECIFICATIONS

lb kg

FXDLS 411 186

IdentifythePreloadMeasurement.

1.UnderRIDERWEIGHT,identifytherowthatincludesthetotalweightoftheriderandriding

gear.RefertoShockPreloadMeasurement:FXDLS.

2.IntherowofPASSENGER,CARGOANDACCESSORIES,identifythetotalweightcolumn

foranypassenger,cargoandaccessories.

3.ThenumberattheintersectionoftheRIDERWEIGHTrowandthePASSENGER,CARGO

ANDACCESSORIEScolumnisthepreloadlocationmeasurement.

ShockPreloadMeasurement:FXDLS

RIDER

WEIGHT PASSENGER,CARGO,ANDADDEDACCESSORIES

lb 0 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150

kg 0 5 9 14 18 23 27 32 36 41 45 50 54 59 64 68

lb kg MEASUREMENTBETWEENTOPOFADJUSTERNUTANDBOTTOMOF

CONE(mm)

100 45 16 17 19 20 21 23 24 25 27 28 29 31 32

110 50 16 17 18 20 21 22 24 25 26 28 29 30 32 33

120 54 16 18 19 20 22 23 25 26 27 29 30 31 33 34

130 59 16 17 19 20 21 23 24 25 27 28 29 31 32 34 35

140 64 16 17 18 20 21 22 24 25 26 28 29 30 32 33 34 36

150 68 17 18 19 21 22 23 25 26 27 29 30 31 33 34 35 37

160 73 17 19 20 21 23 24 25 27 28 30 31 32 34 35 36 38

170 77 18 20 21 22 24 25 26 28 29 30 32 33 34 36 37 38

180 82 19 21 22 23 25 26 27 29 30 31 33 34 35 37 38 39

190 86 20 22 23 24 26 27 28 30 31 32 34 35 36 38 39 40

200 91 21 22 24 25 26 28 29 30 32 33 35 36 37 39 40 41

210 95 22 23 25 26 27 29 30 31 33 34 35 37 38 39 41 42

220 100 23 24 26 27 28 30 31 32 34 35 36 38 39 40 41 42

230 104 24 25 27 28 29 31 32 33 35 36 37 39 40 41 42 43

240 109 25 26 27 29 30 31 33 34 35 37 38 40 41 42 43 44

250 113 26 27 28 30 31 32 34 35 36 38 39 40 41 42 43 44

260 118 27 28 29 31 32 33 35 36 37 39 40 41 42 43 44 45

ShockAdjustment

Adjustbothshockabsorbersequally.Improperadjustment

canadverselyaffectstabilityandhandling,whichcould

resultindeathorseriousinjury.(00036b)

Avoidshockdamage.Makesureshockthreadsareclean

andfreeofdebrisbeforelooseningortighteningshock

adjustingnuts.00646b

NOTE:

Topreventdamagetotheadjustmentandlocknuts,donotuseanyotherwrenchthanSpanner

Tool14900080providedwiththemotorcycle.

1.Ifnecessary,cleanthethreadsontheshockabsorber.

2.SeeAdjustingShocktoPreloadMeasurement.Usethespannertool(5)toturnthe

upperlocknut(2)counterclockwisetounlockthering.

NOTE:

SeeAdjustingShocktoPreloadMeasurement.Rotatetheloweradjustmentnut(1)

clockwisetoincreasepreload.Rotatetheloweradjustmentnutcounterclockwiseto

decreasepreload.

3.Measuretothepreloadmeasurementlocation.RefertoShockPreloadMeasurement:

FXDLS.

a.Placethebottomofthespannertoolonthebottomoftheshockcone(shockcap)(3).

b.Onthespannerscale,findthemeasurementfromthepreloadtable.

c.Rotatetheloweradjustmentnut(1)toalignthetopofthenutwiththemeasurement

(4)onthescale.

4.Usethetooltotightentheupperlocknutagainsttheloweradjustmentnut.

5.Adjusttheoppositeshockabsorbertothesamepreloadmeasurement.

1.Loweradjustmentnut

2.Upperlocknut

3.Shockcap

4.Measurement(frompreloadtable)

5.Spannertool

AdjustingShocktoPreloadMeasurement

ShockAbsorberPreload:AllexceptFXDLS

Adjusttheshockabsorberspringpreloadforthetotalload.Increasepreloadforheavyloads.

Reducepreloadforlighterloads.

Adjustbothshockabsorbersequally.Improperadjustment

canadverselyaffectstabilityandhandling,whichcould

resultindeathorseriousinjury.(00036b)

Donotturntheshockabsorberadjustmentcollar

clockwisebeyondadjustmentsetting5.Doingsomay

resultinequipmentdamage.(00166b)

NOTE:

Somemodelshaveacoveroverthepreloadcam.Inserttheteethontheshockadjustment

spannerintotheholesinthecover.

SeeShockAbsorberPreloadAdjustment.UsingSHOCKADJUSTMENTSPANNER94448

82BorSHOCKADJUSTMENTSPANNERHD9470052C,turnthepreloadcam

counterclockwiseuntilitstops.Countingoneatthestopposition,turnthespannerclockwiseand

counteachpositiontospecification.RefertoRecommendedShockPreload:FLD(FLD)or

RecommendedShockPreload:DynaModelsExceptFLD(othermodels).

1.Preloadcamcover

2.Spanner

ShockAbsorberPreloadAdjustment

RecommendedShockPreload:FLD

LOAD1POSITION2

Lessthan190lb86kg 1

190240lb86109kg 2

240290lb109132kg 3

290340lb132154kg 4

340lb154kgtomaximumaddedweight

allowed.RefertoWeight.

1.Passenger/Cargo:Forevery35lb16kgofcargoor

passengerweight,increasepreloadoneposition.Donot

exceedthemaximumaddedweightallowed.

2.SeeShockPreloadCamPositions.

RecommendedShockPreload:DynaModelsExceptFLD

LOAD1POSITION2

FXDF,

FXDL

FXDWG,

FXDB,FXDBC,

FXDBP

Lessthan135lb60kg 1 1

135165lb6075kg 1 2

165195lb7589kg 2 3

195225lb89102kg 3 4

225255lb102116kg 4 5

255lb116kgtomaximum

addedweightallowed.Referto

Weight.

5 5

1.Addtheweightoftherider,passenger,ridinggear,

accessoriesandcargo.

2.SeeShockPreloadCamPositions.

ShockPreloadCamPositions

Luggage

SeetheAccessoriesandCargosectioninyourowner's

manual.Impropercargoloadingoraccessoryinstallation

cancausecomponentfailureandadverselyaffectstability,

handlingandperformance,whichcouldresultindeathor

seriousinjury.(00021b)

Donotexceedthemotorcycle'sGrossVehicleWeight

Rating(GVWR)orGrossAxleWeightRating(GAWR).

Exceedingtheseweightratingscanleadtocomponent

failureandadverselyaffectstability,handlingand

performance,whichcouldresultindeathorseriousinjury.

(00016f)

GVWRisthetotalweightofthemotorcycle,accessories,rider,passengerandcargothat

canbesafelycarried.

GAWRisthemaximumamountofweightthatcanbesafelycarriedoneachaxle.

SeeinformationlabelonframesteeringheadorframedowntubeforGVWRandGAWR.

Improperloadingofcargoorinstallationofaccessories

canaffectmotorcyclestabilityandhandling,whichcould

resultindeathorseriousinjury.(00095a)

Keepcargoweightconcentratedclosetothemotorcycleandaslowaspossibletominimize

thechangeinthemotorcycle'scenterofgravity.Distributeweightevenlyonbothsidesof

thevehicle.Donotloadbulkyitemstoofarbehindtherideroraddweighttothehandlebars

orfrontforks.Donotexceedmaximumloadonthelabelwithintheluggage.

Checkthatcargoissecure.Thecargocannotshiftwhileriding.Periodicallyrecheckload.

Closeandlockluggagebeforeridingorleavingthevehicleunattended.

Saddlebags:FLD

Opening

1.SeeSaddlebag:FLD.Unlockthesaddlebaglatchusingtheignitionkey.

2.Placefingersunderthelatch(1)andlift.

3.Lifttheoutsideedgeofthecoverandgentlypushthecoverintowardthemotorcycleto

disengagethecoverfromthecatchontheinnersideofthesaddlebag.

4.Lifttheinsideedgeofthecoverandswingitoverthesaddlebagtoopen.

5.Asyouswingthecoveroutward,letitflipoversotheinsidefacesup.Letthecoverrest

againstrubbarsandnyloncheckstrap.

NOTE:

Thesaddlebaglidsaredesignedtostayattachedtothebagsatalltimes.

Closing

1.SeeSaddlebag:FLD.Raisetheoutsideedgeofthecoverandswingitoverthe

saddlebag.

2.Pushthelatch(1)tosecurethesaddlebag.Thecoverwillengagethecatchontheinner

sideofthesaddlebag.

NOTE:

Closeandlockthesaddlebaglatchwheneverthemotorcycleisinoperation.

Removing

1.SeeSaddlebagLockKnob:FLD.Insidethesaddlebag,pulltheknoboutwardandrotate

totheUNLOCKposition.

2.SeeSaddlebagInstallation:FLD.Holdthesaddlebagandslideittowardtherearofthe

motorcycletoremoveitfromthethreedockingposts.

NOTE:

Saddlebagsmaybeeasilytippedifnotsecuredintheuprightposition.Therightsaddlebaghasa

largercavityalongthebottomtoaccommodatethebracketsfortheexhaustsystem.Place

saddlebagsonalevelsurface,preferablysupportedagainstawallorothersurface.Avoid

draggingthesaddlebagsonthegroundtopreventscratches.

Installing

NOTE:

Ifthedockingbushingsonthesaddlebagaredamagedormissing,installnewbushingsbefore

mountingthesaddlebagsonthemotorcycle.

1.SeeSaddlebagInstallation:FLD.WiththeknobintheUNLOCKposition,slidethe

saddlebagontothemotorcycle,engagingthesaddlebagbracketstothethreedocking

postsonthesideofthemotorcycle.

2.SeeSaddlebagLockKnob:FLD.PulltheknoboutwardandrotatetotheLOCKposition

untiltheknobsnapsintoplace.

3.Checkthatthesaddlebagissecureonallthreedockingpostsandthelockinglatchis

secure.Gentlypullthesaddlebagtothereartocheckthatitissecureonthemotorcycle.

1.Latch

2.Lockknob

Saddlebag:FLD

1.Dockingposts

2.Saddlebagbrackets(withdockingbushings)

SaddlebagInstallation:FLD

1.Lock

2.Unlock

SaddlebagLockKnob:FLD

Windshield:FLD

Removal

1.SeeWindshield:FLD.Liftthewireformlatchsprings(1)atbothsidesofthewindshield.

MovetheTOPofthewindshieldassemblyforward,untiltheTOPbracketnotchesslide

awayfromthegrommets(2).

2.CarefullyliftthewindshieldbracketBOTTOMnotchesoffthebottomgrommets.

3.Removewindshield.

NOTE:

Forproperwindshieldmaintenance,seeWindshieldCare.

Installation

1.SeeWindshield:FLD.Liftthewireformlatchsprings(1)atbothsidesofthewindshield.

slidetheBOTTOMwindshieldbracketnotchesontothebottomgrommets(2).

2.SlidetheTOPbracketnotchesontothetopgrommets(2).

1.Wireformlatch

2.Grommets

Windshield:FLD

SideMountedLicensePlate

SeeSideMountedLicensePlateAssembly.Somemodelshaveasidemountedlicenseplate

assembly.Thelicenseplatemustbeintheextendedpositionduringoperation.Thisfeaturemay

notbeavailableinallmarkets.

ThesidemountedlicenseplateassemblyincludesanLEDlampmodule.IftheLEDlampfails,

seeaHarleyDavidsondealerforassemblyreplacement.

SideMountedLicensePlateAssembly

AdjustableHandlebarRiser:FXDL

Therider'ssafetydependsuponthecorrectadjustmentof

theriser,handlebarandhandlebarattachments.Usethe

appropriateservicemanualprocedure.Iftheprocedureis

notwithinyourcapabilitiesoryoudonothavethecorrect

tools,haveaHarleyDavidsondealerperformthe

adjustment.Improperadjustmentcouldresultindeathor

seriousinjury.(00640d)

Seeadealerorservicemanualforhandlebarandriseradjustment.

NOTE:

Iftraileringmotorcycle,donotusetiedownstrapsonhandlebarsorrisers.Usestrapsonfork

clamps.

SecuritySystem

Components

Thesecuritysystemconsistsofacontrolmodule,ahandsfreeantennaandahandsfreefob

carriedbytherider/passenger.

Afterparkingthemotorcycle,turntheignitiontoOFForACCESSORYandthesecuritysystem

willautomaticallyarmwithinfiveseconds.Whilearmed,thestarterandignitionaredisabledand

theridercanleavethemotorcycleknowingthatthemoduledisablestheignitionifsomeone

tamperswiththeignitionswitchoractivatesanalarmifsomeoneattemptstomovethe

motorcycle.

Ifthefobispresent,themoduleautomaticallydisarmswhentheignitionisturnedtoIGNITIONor

ACCESSORY.

NOTES:

Ifdisconnectingthebattery,seeDisconnectingPowertopreventtheoptionalsecurity

systemsirenfromsounding.

Donotrelocatethemoduleortheantenna.

Options

SeeaHarleyDavidsondealerorwww.harleydavidson.comforsecuritysystemoptions.

SmartSirenII.

SecurityPagerandSecurityPagerReceiverII.

Replacementfobs.

FCCRegulations

FCCID:L2C0027TRICID:3432A0027TR

FCCID:L2C0028TRICID:3432A0028TR

ThisdevicecomplieswithPart15oftheFCCRulesandwithRSS210ofIndustryCanadarules.

Operationissubjecttothefollowingtwoconditions:

(1)Thisdevicemaynotcauseharmfulinterference,and(2)Thisdevicemustacceptany

interferencereceived,includinginterferencethatmaycauseundesiredoperation.

NOTE:

Changesormodificationsnotexpresslyapprovedbythepartyresponsibleforcompliancecould

voidtheuser'sauthoritytooperatetheequipment.

Theterm"IC:"beforetheradiocertificationnumberonlysignifiesthatIndustryCanadatechnical

specificationsweremet.

SecuritySystemFob

FobAssignment

SeeFob:SecuritySystem.FobsareelectronicallyassignedtothesecuritysystembyaHarley

Davidsondealer.Uptotwofobscanbeassignedatanyonetime.

NOTES:

Thereusablelabelfoundonthefobpackagingliststheserialnumberofthefob.For

reference,affixthelabeltoablank"NOTES"pageinthisOwner'sManual.

Theserialnumberofthefobisalsofoundontheinsideofthefob.SeeFobBattery.

ThemodulewillarmonlyifthefobhasbeenassignedbyaHarleyDavidsondealeranda

personalidentificationnumber(PIN)hasbeenenteredinthesystem.WritethePINonthe

personalinformationpageinthefrontofthisowner'smanualandontheremovablewallet

card.

Ifthefobismisplacedorthefobfails,refertothewalletcardandusethePINtomanually

disarmthesystem.SeeArmingandDisarmingandTroubleshooting.

TheridercanchangethePINatanytime.SeePersonalIdentificationNumber(PIN).

RidingwithaFob

Alwayscarrythefobwhenriding,loading,fueling,moving,parkingorservicingthe

motorcycle.Carrythefobinaconvenientpocket.

Donotleavethefobattachedtothehandlebarsorstorethefobinaluggagecompartment.

Unintentionallyleavingthefobwiththemotorcyclewhenitisparkedpreventsthesystem

fromactivatingthealarm.

Donotridewiththefobstoredinametalcaseorwiththefobcloserthan3.0in76mmtoa

mobilephone,displayorotherelectronicdevice.Anyelectromagneticinterferencemay

preventthefobfromdisarmingthesystem.

Foraddedsecurity,alwayslocktheforkandremovethekeywhenparked.Ifthefobis

withinrangeandthemotorcycleisunlocked,tamperingwiththemotorcyclewillnotactivate

thealarm.

RidingwithoutaFob

Ifthemotorcycleisriddenoffwithoutthefob,theodometerwindowtemporarilydisplays"NO

FOB."Torestartamotorcyclewithoutafob,disarmthesecuritysystemwiththePIN.

Fob:SecuritySystem

PersonalIdentificationNumber(PIN)

Thepersonalidentificationnumber(PIN)isanumberthatcanbeusedtodisarmthesecurity

system.UsethePINincasetheassignedfobismisplaced,failsorifthefobcannotcommunicate

withthemotorcyclebecauseofelectromagneticinterference.

APINisafivedigitnumber(19,nozeros).

ChangingthePIN

TheridercanchangethePINatanytime.RefertoChangingthePIN.

ChangingthePIN

STEP

NO.

ACTION WAITFORCONFIRMATION NOTES

1 Selecta5digit(1thru9)PINand

recordonthewalletcardfrom

owner'smanual.

2 Withanassignedfobpresent,turn

theenginestopswitchtoOFF.

3 TurntheignitionswitchtoIGN.

4 CycletheOFF/RUNswitchtwice:

RUNOFFRUNOFFRUN.

5 Pressleftturnsignalswitchtwo ENTERPINwillscrollthrough

5 Pressleftturnsignalswitchtwo

times.

ENTERPINwillscrollthrough

theodometerwindow.

6 Pressrightturnsignalswitchone

timeandrelease.

Turnsignalswillflashthree

times.CurrentPINwillappear

inodometer.Thefirstdigitwill

beflashing.

7 EnterfirstdigitofnewPINby

pressingandreleasingtheleftturn

signalswitchuntiltheselecteddigit

appears.

8 Pressrightturnsignalswitchone

timeandrelease.

Thenewdigitwillreplacethe

currentinodometerwindow.

9 EnterseconddigitofselectedPIN

bypressingandreleasingtheleft

turnsignalswitchuntiltheselected

digitispresent.

10 Pressrightturnsignalswitchone

timeandrelease.

Thenewdigitwillreplacethe

currentinodometerwindow.

11 EnterthirddigitoftheselectedPIN

bypressingandreleasingtheleft

turnsignalswitchuntiltheselected

digitispresent.

12 Pressrightturnswitchonetime

andrelease.

Thenewdigitwillreplacethe

currentinodometerwindow.

13 EnterfourthdigitofnewPINby

pressingandreleasingtheleftturn

signalswitchuntiltheselecteddigit

ispresent.

14 Pressrightturnswitchonetime

andrelease.

Thenewdigitwillreplacethe

currentinodometerwindow.

15 EnterfifthdigitofthenewPINby

pressingandreleasingtheleftturn

signalswitchuntiltheselecteddigit

ispresent.

16 Pressrightturnswitchonetime

andrelease.

Thenewdigitwillreplacethe

currentinodometerwindow.

17 TurntheenginestopswitchOFF,

thenturntheignitionswitchtoOFF.

Pushingtheengine

stopswitchtoOFF

storesthenewPINin

themodule.

SecurityStatusIndicator

SeeInstruments.Thesecuritylampinthespeedometerfaceindicatesthestatusofthesecurity

system.

Armed:Alampthatblinksapproximatelyeverythreesecondsindicatesthatthesystemis

armed.

Disarmed:Afterthesystemdisarmsandtheignitionison,thelampwillremainilluminated

forapproximatelyfoursecondsandthenturnoff.

Service:Alampthatremainsilluminatedlongerthanfoursecondswhenthesystemis

disarmedindicatesthatserviceofthemoduleisrequired.

ArmingandDisarming

Arming

WhenthemotorcycleisparkedandtheignitionisturnedtoOFForACCESSORY,thesecurity

systemarmsautomaticallywithinfivesecondsifnomotionisdetected.Evenwhenthefobis

present,thesystemarms.

Onarming,theturnsignalsflashtwiceandtheoptionalsirenchirpstwiceifthesirenisinthechirp

mode.Whilearmed,theindicatorlampinthespeedometerfaceflasheseverythreeseconds.

NOTE:

Internationalmodels:Thesystemmustbeinthechirpmodeforthesirentochirponarmingor

disarming.SeeSirenChirpMode(Confirmation).

Disarming

Withthefobpresent,theridermayrideormovethemotorcycleforparking,storageorservice

withoutsettingoffthealarm.Disarmingisautomaticaslongasthefobiswithinrange.

Fob:Anarmedsecuritysystemisautomaticallydisarmedwhenthefobispresentandthe

motorcycleismovedortheignitionswitchisturnedtoIGNITIONorACCESSORY.Therangeof

thefobis5ft1.5m.

Whenthesystemdisarms,theoptionalsirenchirpsonceandthesecurityindicatorlamp

illuminatesforasolidfoursecondsandthenturnsoff.

NOTE:

Onanymotion,likeliftingthemotorcycleupoffitsjiffystandorturningtheignitiontoON,the

systemwillelectronically"poll"forthepresenceofthefob.Ifthefobispresent,thesystem

disarms.

Personalidentificationnumber(PIN):Ifthefobismisplacedorifthepresentfobfailsto

communicate,thesystemcanbedisarmedwiththepersonalidentificationnumber(PIN).Referto

EnteringaPINtoDisarmSecuritySystem.

DisarmingwithaPIN

DisarmthesecuritysystemmanuallyusingthePINifthefobislost,thefobbatteryisdischarged

orifwhereyouparkedthereisastrongelectromagneticinterference.

Donotturnhandlebars,straddleseatorliftmotorcycleoffthejiffystand.DuringaPINdisarm,if

thesecuritysystemdetectsmotorcyclemotionthesystemwillactivatethealarm.

NOTES:

IfamistakeismadewhileenteringPIN,turntheignitionswitchtoOFFbeforeenteringthe

lastdigitandthenstarttheprocedurefromthebeginning.

Iftheprocedurefailstodisarmthesecuritysystem,waittwominutesbeforeattempting

anotherPINdisarm.

ThesecuritysystemremainsdisarmeduntiltheignitionisturnedtoOFF.

AtanytimeduringaPINdisarmifthefobisbroughtwithinrange,thesecuritysystem

disarmsasthemodulereceivesthecodedsignalfromthefob.

EnteringaPINtoDisarmSecuritySystem

STEP

NO.

ACTION WAITFORCONFIRMATION NOTES

1 Ifnecessary,verifythecurrent5

digitPIN.

Shouldbe

recorded

onwallet

card.

2 TurnignitiontoIGN. Ifarmed,theodometerwindowdisplaywill

read:ENTERPINandthesecuritylampwill

beflashingatafastrate.Theheadlightwill

notbeon.

3 Pressandreleasetheleftturn

signalswitch.

Intheodometerwindow,aflashing1will

appear.

4 Advancethedigitbytappingthe

leftturnsignaluntiltheodometer

windowdisplaysthefirstdigitof

thePIN.

Thefirstdigitintheodometerwillbethe

firstdigitinthePIN.

5 Pressrightturnswitch1time. Thefirstdigitisstoredandthenextdigitwill

flash.

Servesas

enterkey.

6 Advancetheseconddigitusing

theleftturnswitchuntilthedigit

reachestheseconddigitofthe

PIN.

Theseconddigitintheodometerwillbethe

seconddigitinthePIN.

7 Pressrightturnswitch1time. Theseconddigitisstoredandthenext

dashwillflash.

Servesas

enterkey.

8 Advancethethirddigitusingthe

leftturnswitchuntilitreaches

thethirddigitofthePIN.

Thethirddigitintheodometerwillbethe

thirddigitinthePIN.

9 Pressrightturnswitch1time. Thethirddigitisstoredandthenextdash

willflash.

Servesas

enterkey.

10 Advancethefourthdigitusing

theleftturnswitchuntilit

reachesthefourthdigitofthe

PIN.

Thefourthdigitintheodometerwillbethe

fourthdigitinthePIN.

11 Pressrightturnswitch1time. Thefourthdigitisstoredandthenextdash

willflash.

Servesas

enterkey.

12 Advancethefifthdigitusingthe

leftturnswitchuntilitreaches

thefifthdigitofthePIN.

Thefifthdigitintheodometerwillbethe

fifthdigitinthePIN.

13 Pressrightturnswitch1time. Thefifthdigitisstored.Thesecuritysystem

indicatorlampstopsblinking.

Security

Systemis

disarmed.

Alarm

IgnitionDisabled

Whenthefobisnotpresentandthesystemisarmed,iftheignitionswitchisturnedtoIGNITION

orACCESSORY,thesecuritylampwillflashatafastrateandtheodometerwindowdisplaywill

scroll"ENtERPIN".Theheadlampwillnotturnon.

Afterapproximately10seconds,ifthesystemdoesnotreceivealeftturnsignalswitchinput,the

displaywillgoblank.Theignitionsystemwillremaindisableduntilthefobispresentorthecurrent

PINisentered.

Warnings

Oncearmed,ifthemotorcycleismovedorliftedupoffofitsjiffystandandthefobisnotpresent,

thealarmwillwarntheoperatorwiththreealternateflashesoftheturnsignalsandachirpofthe

optionalsiren.

Withinfourseconds,ifthemotorcycleisbackonitsjiffystandandnofurthermotionisdetected

and/ortheignitionisturnedtoOFF,thesystemwillremainarmedwithoutactivatingthealarm.

Ifthemotorcyclemotioncontinues,thesystemwillissueasecondwarningfoursecondsafterthe

first.

NOTE:

Duringwarningsandalarms,thestartermotorandtheignitioncircuitsaredisabled.

AlarmActivation

Ifthesecuritysystemisstilldetectingmotionand/oriftheignitionhasnotbeenturnedbackto

OFFafterasecondwarning,thesystemwillactivatethealarm.

Whenactivated,thesecuritysystemwill:

Alternatelyflashthefourturnsignals.

Soundtheoptionalsiren.

Duration:Thealarmwillstopwithin30secondsandifnomotionisdetected,thealarmwillnot

restart.

However,ifmotorcyclemotioncontinues,thesystemwillrepeatthe30secondalarmandrecheck

formotion.Thealarmwillrepeatthis30secondalarmcycleforfiveminutes(10cycles)oruntil

thealarmisdeactivated.

NOTE:

ThealarmwillalsoactivatetheLED,vibrationoraudiblemodesofaHarleyDavidsonsecurity

pager.Apagercanoperateeitherinsilentorincombinationwithanoptionalsiren.Therangeofa

pagercanbeupto0.5mi0.8km.SeeaHarleyDavidsondealerfordetails.

DeactivateAlarm

Keyfob:Bringthefobtowithin5ft1.5mofthemotorcycle.Afterthemoduleidentifiesthat

thefobispresent,thesystemwillterminatethealarm.

PINentry:EnterthePINtodeactivatethealarm.IfanerrorismadewhileenteringthePIN,

waituntilthealarmisbetweencyclestoenterthePIN.

SirenChirpMode(Confirmation)

ChirpMode

Inchirpmode,thesirensoundstwochirpswhenarming,andasinglechirpwhendisarming.

ChirplessMode

Inchirplessmode,thesirendoesnotchirponarmingordisarming.

Thesirenstillprovideswarningchirpsandsoundsthealarmifmotorcycleismovedorignition

switchisturnedonwithoutthefobpresent.

SwitchingModes

QuicklycyclingignitionswitchONOFFONOFFONswitchesthesystemfromonemodetothe

other.

1.Withthefobpresent,turntheignitionswitchtoIGNITION.

2.Whenthesecuritylampturnsoff,turntheignitionswitchtoOFF.

3.Whenthesecuritylampturnsoff(butbeforetheturnsignalsflashtwice),immediatelyturn

theignitionswitchtoIGNITION.

4.Whenthesecuritylampturnsoff,immediatelyturntheignitionswitchtoOFF.

5.Whenthesecuritylampturnsoff(butbeforetheturnsignalsflashtwice),immediatelyturn

theignitionswitchtoIGNITION.

TransportMode

Whentransportingthemotorcycle,placethesysteminthetransportmode.Otherwise,thealarm

activatedbymotiondetectioncandischargethebattery.

Inthetransportmode,thesecuritysystemisarmedwithoutenablingthemotiondetectorforone

ignitioncycle.Thisallowsthevehicletobepickedupandmovedinanarmedstate.However,any

attempttostarttheenginewhenthefobisnotwithinrangewilltriggerthealarm.

ToEnterTransportMode

1.Withanassignedfobwithinrange,turntheignitionswitchtoIGNITION.

2.Beforethesecuritylampgoesout,turntheignitionswitchtoOFF.

3.Withinthreeseconds,simultaneouslypressboththeleftandtherightturnsignalswitches.

4.Aftertheturnsignalsflashonce,thesystementersthetransportmode.Withthefob

removed,themotorcyclecanbemovedwithoutsettingoffthealarm.

ToExitTransportMode

Withthefobpresent,turntheignitionswitchtoIGNITIONtodisarmthesystem.

StorageandServiceDepartments

LongTermParking

Tomaintainarming,storethefobbeyondtherangeoftheantenna.Theantennarangeis

approximately5ft1.5m.Havethefobpresentbeforemovingparkedmotorcycle.

Ifthemotorcyclewillnotbeoperatedforseveralmonths,suchasduringthewinterseason,see

MotorcycleStorage.

ServiceDepartments

WhenthemotorcycleisleftataHarleyDavidsondealer,therearetwooptions:

1.Leaveanassignedfobwiththedealer.

2.Tomaintainpossessionofthefob,askthedealertodisablethesystemforservice(service

mode)beforeleavingthedealership.

FobBattery

ReplacingtheBattery

Replacethefobbatteryeveryyear.

1.SeeFobBattery.Slowlyturnathinbladeinthethumbnailslot(1)onthesideofthefobto

separatethetwohalves.

2.Removethebattery(2)anddiscard.

3.Installanewbattery(Panasonic2032orequivalent)withthepositivesidedown.

4.Alignthetwohalvesofthefob.Snapthehalvestogether.

1.Thumbnailslot

2.Battery

3.Fobserialnumber

FobBattery

DisconnectingPower

SirenEquippedModels

Whendisconnectingthebatteryorremovingthemainfuse,performthefollowingstepstoprevent

theoptionalsirenfromsounding.

1.Verifythatthefobispresent.

2.TurntheignitionswitchtoIGNITION.

3.Pullthemainfusefromitsholderordisconnectthebattery.

NOTE:

PlacetheignitionswitchintheOFFpositionbeforeinstallingthemainfuse.

Troubleshooting

SecuritySystemIndicator

Ifthesystemindicatorlampstaysilluminatedwhileriding,seeaHarleyDavidsondealer.

Fob

Ifthesecuritysystemcontinuestoactuatewarningsandalarmswiththefobpresent,checkfor:

1.Electromagneticinterference:Otherelectronicdevices,powerlinesorother

electromagneticsourcescancausethesecuritysystemtooperateinconsistently.

a.Verifythatthefobisnotinametalenclosureorwithin3.0in76mmofanyother

electronicdevices.

b.PlacethefobontheseatandturntheignitiontoIGN.Afterthesystemdisarms,return

thefobtoaconvenientlocation.

c.Movemotorcycleatleast15ft5mfromthespotofinterference.

d.UsethePINtodisarmthesystem.

NOTE:

Leavingafobnexttoacomputermonitorcanrundownthebattery.

2.Dischargedfobbattery:UsethePINtodisarmthesystem.Replacethebattery.SeeFob

Battery.

3.Adamagedfob:UsethePINtodisarmthemotorcycle.Replacementfobsareavailablefor

purchasefromaHarleyDavidsondealer.

Siren

Ifthesirendoesnotchirptwoorthreetimesonavalidarmingcommandfromthesecurity

module,thesireniseitherinthechirplessmode,notconnected,notworking,orthesiren

wiringwasopenedorshortedwhilethesirenwasdisarmed.

Ifthesirenisarmedandtheinternalsirenbatteryisdead,shorted,disconnected,orhas

beenchargingforaperiodlongerthan24hours,thesirenwillrespondwiththreechirpson

arminginsteadoftwo.

Theinternalsirenbatterymaynotchargeifthevehicle'sbatteryislessthan12.5volts.

Ifthesirenenterstheselfdrivenmodewhereitispoweredfromthesiren'sinternal9volt

battery,theturnsignallampsmayormaynotalternatelyflash.Ifthesecuritymodule

activatesthesiren,theturnsignallampswillalternatelyflash.Ifthesirenhasbeenarmed

andasecurityeventoccurs,andthesirenisinselfdrivenmode,thesirenwillalarmfor20

30secondsandthenturnofffor510seconds.Thisalarmcyclewillberepeatedtentimesif

thesirenisintheselfdrivenmode.

Operation

OperatingRecommendations

Motorcyclesaredifferentfromothervehicles.They

operate,steer,handleandbrakedifferently.Unskilledor

improperusecouldresultinlossofcontrol,deathor

seriousinjury.(00556c)

Takearidertrainingcourse.

Readowner'smanualbeforeriding,addingaccessoriesorservicing.

Wearahelmet,eyeprotectionandprotectiveclothing.

Nevertowatrailer.

Travelatspeedsappropriateforroadandconditionsand

nevertravelfasterthanpostedspeedlimit.Excessive

speedcancauselossofvehiclecontrol,whichcould

resultindeathorseriousinjury.(00008a)

DonotruntheengineatextremelyhighRPMwithclutch

disengagedortransmissioninneutral.Runninganengine

athighRPMcanresultinenginedamage.(00177a)

DonotexceedthemaximumsafeRPMspecifiedbelow

underanyconditions.Exceedingthemaximumsafe

engineRPMcanresultinequipmentdamage.(00248a)

Themaximumrecommendedsafeenginespeedis5500rpm.

Donotidleengineunnecessarilyformorethanafewminuteswithmotorcyclestandingstill.

Aircooledenginesrequireairmovementoverthe

cylindersandheadstomaintainproperoperating

temperature.Extendedperiodsofidlingorparadedutycan

overheattheengine,resultinginseriousenginedamage.

(00178a)

Anenginerunninglongdistanceathighspeedmustbegivencloserthanordinaryattentionto

avoidoverheatingandpossibleenginedamage.

Thisconditionappliesparticularlytoamotorcycleequippedwithwindshieldandfairing.

Whenridingonwetroads,brakeefficiencyandtractionare

greatlyreduced.Failuretousecarewhenbraking,

acceleratingorturningonwetroadscancauselossof

control,whichcouldresultindeathorseriousinjury.

(00041a)

Continuoususeofbrakecausesoverheatingandreduced

efficiency,whichcouldresultindeathorseriousinjury.

(00042a)

Donottowadisabledmotorcycle.Towingcanadversely

affectstabilityandhandling,whichcouldresultindeathor

seriousinjury.(00017a)

NOTES:

Havetheenginecheckedregularlyandkeepittuned.

Whendescendingalong,steepgrade,downshiftThenuseenginecompressiontogether

withintermittentapplicationofbothbrakestoslowthemotorcycle.

BreakInRidingRules

TheFirst500Miles(800Kilometers)

Thesounddesign,qualitymaterialsandworkmanshipthatarebuiltintoyournewHarley

Davidsongivesyouoptimumperformancerightfromthestart.

Toallowyourenginetowearinitscriticalparts,werecommendthatyouobservetheridingrules

forthefirst500mi800km.

1.Duringthefirst50mi80kmofriding,keeptheenginespeedbelow3000rpminanygear.

Donotlugtheenginebyrunningoracceleratingatlowrpm,orbyrunningathighrpm

longerthanneededforshiftingorpassing.

2.Upto500mi800km,varytheenginespeedandavoidoperatingatanysteadyengine

speedforlongperiods.Enginespeedupto3500rpminanygearispermissible.

3.Driveslowlyandavoidfaststartsatwideopenthrottleuntiltheenginehaswarmedup.

4.Avoidluggingtheenginebynotrunningtheengineatlowspeedsinhighergears.

5.Avoidhardbraking.Breakinnewbrakeswithmoderateuseforthefirst200mi300km.

PreRidingChecklist

ReadtheCONTROLSANDINDICATORSsectionbefore

ridingyourmotorcycle.Failuretounderstandthe

operationofthemotorcyclecouldresultindeathor

seriousinjury.(00043a)

Alwaysinspectmotorcycleconditionbeforeriding.

Stoptheenginewhenrefuelingorservicingthefuel

system.Donotsmokeorallowopenflameorsparksnear

gasoline.Gasolineisextremelyflammableandhighly

explosive,whichcouldresultindeathorseriousinjury.

(00002a)

Avoidspills.Slowlyremovefillercap.Donotfillabove

bottomoffillerneckinsert,leavingairspaceforfuel

expansion.Securefillercapafterrefueling.Gasolineis

extremelyflammableandhighlyexplosive,whichcould

resultindeathorseriousinjury.(00028a)

Usecarewhenrefueling.Pressurizedairinfueltankcan

forcegasolinetoescapethroughfillertube.Gasolineis

extremelyflammableandhighlyexplosive,whichcould

resultindeathorseriousinjury.(00029a)

1.Checkfuellevel.Addfuelifnecessary.

2.Adjustmirrorstoproperridingpositions.

3.Checkengineoillevel.Addoilifnecessary.

4.Checkcontrolstomakesurethattheyoperateproperly.Operatethefrontandrearbrakes,

throttle,clutchandshifter.Allcontrolsshouldoperatefreelywithoutbinding.

5.Checksteeringforproperoperationbyturningthehandlebarsthroughthefulloperating

range.Handlebarsshouldturnsmoothlywithoutbinding.

Besuretiresareproperlyinflated,balanced,undamaged,

andhaveadequatetread.Inspectyourtiresregularlyand

seeaHarleyDavidsondealerforreplacements.Riding

withexcessivelyworn,unbalanced,improperlyinflated,

overloadedordamagedtirescanleadtotirefailureand

adverselyaffectstabilityandhandling,whichcouldresult

indeathorseriousinjury.(00014b)

6.Checktirecondition,pressureandmotorcycleloading.Incorrectpressureandexcessive

loadingcanleadtotireorwheelfailure,andcanaffecthandlingandstability.Forcorrecttire

pressures,refertoSpecifiedTires.

Besureheadlamp,tailandstoplampandturnsignalsare

operatingproperlybeforeriding.Poorvisibilityofriderto

othermotoristscanresultindeathorseriousinjury.

(00478b)

7.Testallswitchesandlightsforproperoperation.

8.Checkforanyfuel,oilorhydraulicfluidleaks.Checkforcoolantleaksonapplicable

vehicles.

9.Checkdrivebeltforwearordamage.

10.Serviceyourmotorcycleasnecessary.

EngineIdleTemperatureManagementSystem(EITMS)

TheEngineIdleTemperatureManagementSystem(EITMS)canprovidelimitedcoolingofthe

rearcylinderforriderswhofrequentlyfindthemselvesinprolongedidleconditionsortraffic

congestion.

Operation

Whenenginetemperaturereachesapredeterminedpoint,theEITMSturnsofftherearcylinder

fuelinjector.Idlespeedismaintained,howevertherearcylinderbecomesan"airpump"which

workstocooltheengine.

EITMSactivates(rearcylinderturnsoff)whenallofthefollowingconditionsaremet:

Enginetemperatureisgreaterthan287°F165°C

Twistgripopeningisatidle

Vehiclespeedunder1mph2km/h

Enginespeedunder1200rpm

Ifanyoneofthefollowingoccurs,theEITMSdisables(rearcylinderfiresagain).

Enginetemperaturefallsbelow275°F135°C

Twistgripopeningisgreaterthanidle

Vehiclespeedexceeds2mph3km/h

Enginespeedexceeds1350rpm

Clutchisreleasedwithvehicleingear

WhentheengineisinEITMSoperation,youcannoticeadifferenceinidlecadence.Additionally,

therecanalsobeauniqueexhaustodor.Botharenormalconditions.

Enabling/DisablingEITMS:AllexceptFXDLS

MotorcyclesaredeliveredfromthefactorywiththeEITMSdisabled.Seeyourdealertoenableor

disableEITMS.

Enabling/DisablingEITMS:FXDLS

Enabled:Duringelevatedtemperatureconditions,EITMSautomaticallyactivateswheneverthe

motorcyclecomestoacompletestopwhileidling.Evenwiththefeatureenabled,itdoesnot

activateundercoolridingconditions.

Disabled:TheEITMSfeatureisnotactiveunderanyconditions.

SeeEnabling/DisablingEITMS:FXDLS.EnableordisableEITMSbyperformingthefollowing

procedure.

1.PushtheengineOFF/RUNswitchontherighthandlebartotheRUNposition(1)(theengine

canberunningornotrunning).

2.Rollthethrottletwistgriptotherolloffpositionandhold(2).

NOTE:

AflashinglampindicatestheEITMSsetting.Asolid(nonflashing)lampindicatesthecruise

controlsetting.

3.Afterapproximatelythreeseconds,thecruiseindicatorlampwilleitherflashgreen(3)

(EITMSenabled)oramber(4)(EITMSdisabled).

NOTE:

TheEITMSsettingremainsineffectuntilchangedbytheriderordealer.

4.RepeattoenableordisableEITMS.

1.Enginerun

2.Holdrolloff

3.Greenenabled

4.Reddisabled

Enabling/DisablingEITMS:FXDLS

StartingtheEngine

Shifttransmissiontoneutralbeforestartingengineto

preventaccidentalmovement,whichcouldresultindeath

orseriousinjury.(00044a)

Theengineshouldbeallowedtorunslowlyfor1530

seconds.Thiswillallowtheenginetowarmupandletoil

reachallsurfacesneedinglubrication.Failuretocomply

canresultinenginedamage.(00563b)

1.Turnignitionon.Donotrollthethrottle.

2.SeeRightHandlebarControlSwitches.Turntheoff/runswitchtotherun(1)position.

NOTE:

Theenginelamplightsforapproximately4seconds.Thefuelpumprunsforapproximately2

secondsasitfillsthefuellineswithgasoline.

3.Squeezeintheclutchlever.

NOTE:

Toactivatethestartingsystem,squeezeintheclutchleverand/orshiftthetransmissionto

neutral.

4.Raisethejiffystand(HDI).

NOTE:

Donotrollthethrottlebeforestarting.Rollingthethrottlebeforestartingthemotorcycleis

unnecessary.

5.Pressstart(2).

6.Whentheenginehasstarted,youcanoperateyourmotorcycleasyounormallywouldafter

raisingthejiffystand.

1.Run

2.Start

RightHandlebarControlSwitches

StartingafterTipover

Iftipoccurs,checkallcontrolsforproperoperation.

Restrictedcontrolmovementcanadverselyaffectthe

performanceofthebrakes,clutchorabilitytoshift,which

couldresultinlossofvehiclecontrolanddeathorserious

injury.(00350a)

Afteratipover,resettheignitionbeforestartingtheengine.

NOTE:

Theword"tIP"appearsintheodometerwindow.

1.Standmotorcycleupright(notleaningonjiffystand)onalevelsurface.

2.ResettheignitionbyturningtheignitionswitchOFFIGNITION.

StoppingtheEngine

1.Stoptheenginebyturningtheengineoff/runswitchtooff.

NOTE:

Iftheenginestallsorstopsforanyreason,turntheignitionswitchtoOFFatoncetoprevent

batterydischarge.

2.Turntheignition/headlampkeyswitchtoOFF.

ShiftingGears

Theclutchmustbefullydisengagedbeforeattemptinga

gearshift.Failuretofullydisengagetheclutchcanresult

inequipmentdamage.(00182a)

Stopped,EngineOff

Slowlypullclutchhandleverinagainsthandlebargriptofullydisengageclutch.Gearsdonot

engagebecausethetransmissionshaftsarenotturningandshiftercomponentsarenotlinedup.

Rockthemotorcyclebackwardandforwardwhilelightlypressingtheshiftlever.

StartingfromaStop

NOTE:

Alwaysstarttheenginewiththetransmissioninneutral.Alwaysstartforwardmotioninfirstgear.

1.Withtheenginerunningandthejiffystandretracted,pulltheclutchhandleveragainstthe

handlebargriptodisengagetheclutch.

2.Pressthegearshiftleverdowntotheendofitstravelandrelease.Thetransmissionisnow

infirstgear.

3.Easeouttheclutchleverandatthesametime,graduallyopenthethrottle.

Upshift(Acceleration)

SeeShiftingSequence:Upshift.Engagethenexthighergearwhenthemotorcyclereaches

theshiftingspeed.RefertoRecommendedUpshiftSpeeds.

RecommendedUpshiftSpeeds

GEARCHANGE mph km/h

Firsttosecond 15 25

Secondtothird 25 40

Thirdtofourth 35 55

Fourthtofifth 45 70

Fifthtosixth 55 85

1.Closethethrottle.

2.Slowlypullclutchhandleverinagainsthandlebargriptofullydisengageclutch.

3.Liftthegearshiftleveruptotheendofitstravelandrelease.

4.Easeouttheclutchleverandgraduallyopenthethrottle.

5.Repeatthepreviousstepstoengageremaininggears.

NOTES:

Disengagetheclutchcompletelybeforeeachgearchange.

Partiallyopenthethrottlesotheenginedoesnotdragwhentheclutchleverisreleased.

ShiftingSequence:Upshift

Downshift(Deceleration)

Donotdownshiftatspeedshigherthanthoselisted.

Shiftingtolowergearswhenspeedistoohighcancause

therearwheeltolosetractionandleadtolossofvehicle

control,whichcouldresultindeathorseriousinjury.

(00045b)

SeeShiftingSequence:Downshift.Whenspeeddecreases,aswhenclimbingahillorslowing

foraturn,shifttothenextlowergear.RefertoRecommendedDownshiftSpeeds.

RecommendedDownshiftSpeeds

GEARCHANGE mph km/h

Sixthtofifth 50 80

Fifthtofourth 40 65

Fourthtothird 30 50

Thirdtosecond 20 30

Secondtofirst 10 15

NOTE:

Theshiftingpointsshowninthetablearerecommendations.Individualshiftingpointscandiffer

fromthetable.

1.Closethethrottle.

2.Slowlypullclutchhandleverinagainsthandlebargriptofullydisengageclutch.

3.Pressthegearshiftleverdowntotheendofitstravelandrelease.

4.Easeouttheclutchleverandgraduallyopenthethrottle.

5.Repeatthepreviousstepstoengageremaininggears.

NOTES:

Disengagetheclutchcompletelybeforeeachgearchange.

Partiallyopenthethrottlesotheenginedoesnotdragwhenclutchleverisreleased.

Shifttoneutralbeforestoppingengine.Shifting

mechanismcanbedamagedbyshiftinggearswhile

engineisstopped.(00183a)

Thegearshiftermechanismpermitsshiftingthetransmissiontoneutralfromeitherfirstorsecond

gear.

ShiftingSequence:Downshift

MaintenanceandLubrication

SafeOperatingMaintenance

Performtheserviceandmaintenanceoperationsas

indicatedintheregularserviceintervaltable.Lackof

regularmaintenanceattherecommendedintervalscan

affectthesafeoperationofyourmotorcycle,whichcould

resultindeathorseriousinjury.(00010a)

Ifyouoperateyourmotorcycleunderadverseconditions

(severecold,extremeheat,verydustyenvironment,very

badroads,throughstandingwater,etc.),youshould

performtheregularmaintenanceintervalsmorefrequently

toensurethesafeoperationofyourmotorcycle.Failureto

maintainyourmotorcyclecouldresultindeathorserious

injury.(00094a)

Goodmaintenanceleadstosafemotorcycling.Acarefulcheckofcertainequipmentmustbe

madeafterperiodsofstorage.Also,frequentlyinspectthemotorcyclebetweentheregularservice

intervalstodetermineifadditionalmaintenanceisnecessary.

Checkthefollowingitems:

1.Tiresforcorrectpressure,excessivewearoranysignsoftiredamage.

2.Drivebeltforpropertension,wearordamage.

3.Brakes,steeringandthrottleforresponsivenessandfreedomfrombinding.

4.Brakefluidlevelandcondition.Hydrauliclinesandfittingsforleaks.Also,checkbrakepads

anddiscsforwear.

5.Cablesforfrayingorcrimpingandfreeoperation.

6.Engineoilandprimarychaincase/transmissionfluidlevels.

7.Headlamp,taillamp,brakelampandturnsignalsforproperoperation.

BreakInMaintenance

NOTE:

Theperformanceofnewmotorcycleinitialserviceisrequiredtokeepyournewmotorcycle

warrantyinforceandforproperemissionssystemoperation.

Afteranewmotorcyclehasbeenridden1000mi1600km,visitanauthorizedHarleyDavidson

dealerforinitialservice.RefertoRegularServiceIntervals:2016HarleyDavidsonDyna

Models.

DisposalandRecycling

Helpprotectourenvironment!Manycommunitiesmaintainfacilitiesforrecyclingusedfluids,

plasticsandmetals.Disposeoforrecycleusedoil,lubricants,fuel,coolant,brakefluidand

batteriesinaccordancewithlocalregulations.ManyHarleyDavidsonpartsandaccessoriesare

madeofplasticsandmetalswhichcanalsoberecycled.

EngineLubrication

Prolongedorrepeatedcontactwithusedmotoroilmaybe

harmfultoskinandcouldcauseskincancer.Promptly

washaffectedareaswithsoapandwater.(00358b)

Ifengineoilisswallowed,donotinducevomiting.Contact

aphysicianimmediately.Incaseofcontactwitheyes,

immediatelyflushwithwater.Contactaphysicianif

irritationpersists.(00357d)

Donotswitchlubricantbrandsindiscriminatelybecause

somelubricantsinteractchemicallywhenmixed.Useof

inferiorlubricantscandamagetheengine.(00184a)

Engineoilisamajorfactorintheperformanceandservicelifeoftheengine.Usetheproper

gradeofoilforthelowesttemperatureexpectedbeforethenextoilchange.Referto

RecommendedEngineOils.

AllexceptFXDLS:ThismodelwasoriginallyfilledwithGENUINEHARLEYDAVIDSONHD360

MOTORCYCLEOIL20W50.

FXDLS:ThismodelcomesfilledwithSCREAMIN'EAGLESYN3FULLSYNTHETIC

MOTORCYCLELUBRICANT.

Theseoilsarethepreferredoilundernormaloperatingconditions.Ifoperationunderextremecold

orheatareexpected,refertoRecommendedEngineOilsforalternativechoices.

IfSYN3orHD360isnotavailable,addoilcertifiedfordieselengines.Acceptabledesignations

include:CH4,CI4andCJ4.Thepreferredviscosities,indescendingorderare:20W50,15W40

and10W40.

Atthefirstopportunity,seeanauthorizeddealertochangebackto100percentHarleyDavidson

oil.

RecommendedEngineOils

TYPE VISCOSITY RATING LOWEST

AMBIENT

TEMPERATURE

COLD

WEATHER

STARTS

BELOW

50°F(10°C)

Screamin'EagleSYN3FullSynthetic SAE HD360 Above30°F1 Excellent

MotorcycleLubricant 20W50 °C

GenuineHarleyDavidsonHD360

MotorcycleOil

SAE

20W50

HD360 Above40°F4

°C

Good

GenuineHarleyDavidsonHD360

MotorcycleOil

SAE50 HD360 Above60°F16

°C

Poor

GenuineHarleyDavidsonHD360

MotorcycleOil

SAE60 HD360 Above80°F27

°C

Poor

GenuineHarleyDavidsonHD360

MotorcycleOil

SAE

10W40

HD360 Below40°F4

°C

Excellent

CheckEngineOilLevel

Prolongedorrepeatedcontactwithusedmotoroilmaybe

harmfultoskinandcouldcauseskincancer.Promptly

washaffectedareaswithsoapandwater.(00358b)

Donotoverfilloil.Doingsocanresultinoilcarryoverto

theaircleanerleadingtoequipmentdamageand/or

equipmentmalfunction.(00190b)

NOTES:

Oillevelcanbecheckedwithmotorcycleuprightoronjiffystand.Bothmarksareonthe

samesideofthedipstick.Carefullyreaddipstickwhencheckingoillevel.

Checkengineoillevelateachcompletefuelrefill.

OilLevelColdCheck

1.Placevehicleonlevelgroundrestingonthejiffystand.

2.SeeFillerPlug/Dipstick.Removefillerplug/dipstick.Wipeoffthedipstick.Insertthe

dipstickandtightenintothefillspout.

NOTE:

Oillevelonacoldengineshouldneverbeabovethemidwaypoint.

3.SeeEngineOilDipstick.Removefillerplug/dipstickandcheckoillevel.Thecorrectoil

levelismidway(2)betweentheADDQT(1)andFULLHOT(3)marksonthedipstick.

NOTE:

IfoillevelisatorbelowtheADDQTmark,addonlyenoughoiltobringthelevelmidway(2)

betweentheADDQTandFULLHOTmarks.NeverbringtheleveltotheFULLHOTmarkona

coldengine.

OilLevelHotCheck

DonotallowhotoilleveltofallbelowAdd/Fillmarkon

dipstick.Doingsocanresultinequipmentdamageand/or

equipmentmalfunction.(00189a)

NOTE:

Performengineoillevelhotcheckonlywithengineoilatnormaloperatingtemperature.

1.Ridemotorcycleuntilengineoilreachesatleast200°F93°Corhigher.

2.Allowenginetoidlefor12minutes.Turnoffengine.

3.SeeFillerPlug/Dipstick.Removefillerplug/dipstick.Wipeoffthedipstick.Insertthe

dipstickandtightenintothefillspout.

4.SeeEngineOilDipstick.Removefillerplug/dipstickandcheckoillevel.Oillevelmust

ADDQTmark,addonlyenoughoiltobringtheleveltotheFULLHOTmark.Donotoverfill.

FillerPlug/Dipstick

1.Lowerarrow(addoil)

2.Coldchecklevel

3.Upperarrow(hotchecklevel)

EngineOilDipstick

ChangeOilandOilFilter

Besurethatnolubricantsorfluidsgetontires,wheelsor

brakeswhenchangingfluid.Tractioncanbeadversely

affected,whichcouldresultinlossofcontrolofthe

motorcycleanddeathorseriousinjury.(00047d)

Donotswitchlubricantbrandsindiscriminatelybecause

somelubricantsinteractchemicallywhenmixed.Useof

inferiorlubricantscandamagetheengine.(00184a)

Changeengineoilatthefirst1000mi1600kmforanewengine.Aftertheinitialservice,

changeoilatregularintervalsinnormalserviceatwarmormoderatetemperatures.Referto

RegularServiceIntervals:2016HarleyDavidsonDynaModels.

Changeoilatmorefrequentintervalsincoldweatherorsevereoperatingconditions.See

LowTemperatureLubrication.

1.Runmotorcycleuntilengineisatnormaloperatingtemperature.Turnoffengine.

2.Removefillerplug/dipstick.

NOTE:

ReplacedrainplugOringifdamaged.

3.SeeEngineOilDrainPlug(leftsideundertransmission).Removetheoildrainplug

(2)andOring.Allowoiltodraincompletely.

UseHarleyDavidsonoilfilterwrenchforfilterremoval.

Thistoolcanpreventdamagetocrankshaftposition

sensorand/orsensorcable.(00192b)

4.RemovetheoilfilterusingOILFILTERWRENCHHD42311orOILFILTERWRENCHHD

44067Aandhandtools.Donotusewithairtools.

5.Cleantheoilfiltermountflange.

6.SeeApplyingThinOilFilm.Installnewoilfilter.

a.Lubricategasketwithathinfilmofcleanengineoil.

b.Installnewoilfilter.

c.Handtightenoilfilteronehalftothreequartersofaturnaftergasketfirstcontactsfilter

mountingsurface.DoNOTuseoilfilterwrenchforinstallation.

7.InstallengineoildrainplugandOring.Tightento1421ftlbs(19.028.5Nm).

NOTE:

Usethepropergradeofoilforthelowesttemperatureexpectedbeforethenextoilchange.

RefertoRecommendedEngineOilsforrecommendedoil.

8.Addaninitialvolumeofengineoil.RefertoCapacities.

InitialOilFill

ITEM QUANTITY

Engineoilinitialfill 3.0qt2.8L

9.Verifyproperoillevel.SeeCheckEngineOilLevel.

a.Performengineoillevelcoldcheck.

b.Startengineandcarefullycheckforoilleaksarounddrainplugandoilfilter.

c.Performengineoillevelhotcheck.

EngineOilDrainPlug(leftsideundertransmission)

1.Mountingplate

2.ThinfilmofoilONLY

3.Oilfilter

ApplyingThinOilFilm

LowTemperatureLubrication

Changeengineoiloftenincolderclimates.Ifmotorcycleisfrequentlyriddenlessthan15mi24

km,inambienttemperaturesbelow60°F16°C,reduceoilchangeintervalsto1500mi2400km

NOTE:

Lowerambienttemperaturesrequiremorefrequentoilchanges.

Watervaporisanormalbyproductofcombustion.Duringcoldweatheroperation,somewater

vaporcondensestoliquidformonthecoolsurfacesinsidetheengine.Infreezingweather,this

waterbecomesslushorice.Iftheengineisnotwarmedtooperatingtemperature,accumulated

slushoriceblockstheoillinesandcausesenginedamage.Overtime,waterwillaccumulate,mix

withtheengineoilandformasludgethatisharmfultotheengine.

Iftheengineisallowedtowarmtonormaloperatingtemperature,mostofthewaterevaporates

andexitsthroughthecrankcasebreather.

TransmissionLubrication

Drainthetransmissionandrefillwithfreshlubricantatproperintervals.

Checkthetransmissionlubricantlevelcheckedmonthly.RefertoRegularServiceIntervals:

2016HarleyDavidsonDynaModels.

CheckTransmissionLubricant

NOTE:

Checktransmissionfluidwiththemotorcycleatambienttemperature.

1.Parkmotorcycleonalevelsurfaceonjiffystand.

2.SeeTransmissionDipstickLocation.Removetransmissionfillerplug/dipstick.Wipe

dipstickclean.

3.Installfillerplug/dipstickuntilOringcontactsthecase.Donottighten.

4.SeeTransmissionLubricantLevel.Removefillerplug/dipstick.Checklubricantlevelon

dipstick.

MixingmineralbasedlubricantswithSYN3inthe

transmissioncandamagethetransmission.(00452b)

5.ProperoillevelisbetweentheAdd(A)(1)andFull(F)(2)marks.Addonlyenoughlubricant

tobringleveltobetweentheAmarkandtheFmarks.RefertoTransmissionLubricant.

6.Installfillerplug/dipstick.Tightento2575inlbs(2.88.5Nm).

TransmissionDipstickLocation

1.Add(A)

2.Full(F)

TransmissionLubricantLevel

TransmissionLubricant

MODEL LUBRICANT

FXDLS SCREAMIN'EAGLESYN3FULL

SYNTHETICMOTORCYCLELUBRICANT.

Allexcept

FXDLS

FORMULA+TRANSMISSIONAND

PRIMARYCHAINLUBRICANT

ChangeTransmissionLubricant

1.SeeTransmissionDipstickLocation.Removetransmissionfillerplug/dipstick.

Besurethatnolubricantsorfluidsgetontires,wheelsor

brakeswhenchangingfluid.Tractioncanbeadversely

affected,whichcouldresultinlossofcontrolofthe

motorcycleanddeathorseriousinjury.(00047d)

2.SeeTransmissionDrainPlug(rightside).Removetransmissiondrainplug.Drain

transmission.

3.CleanandinspectdrainplugandOring.

Donotovertightenfillerordrainplug.Doingsocould

resultinalubricantleak.(00200b)

4.InstalldrainplugwithOring.Tightento1421ftlbs(19.028.5Nm).Donotovertighten.

5.Fillthetransmissionwith28oz0.83LofrecommendedHarleyDavidsonlubricant.Referto

TransmissionLubricant.

6.Checklubricantlevel.Addenoughlubricanttobringthelevelbetweentheadd(A)andfull

(F)marks.SeeCheckTransmissionLubricant.

7.Installfillerplug/dipstick.Tightento2575inlbs(2.88.5Nm).

TransmissionDrainPlug(rightside)

PrimaryChaincaseLubrication

Lubricationisamajorfactorintheperformanceandservicelifeoftheclutchcomponents.

Drainandrefilltheprimarychaincasewithfreshlubricantatproperintervals.RefertoRegular

ServiceIntervals:2016HarleyDavidsonDynaModels.

NOTE:

UseonlyFORMULA+TRANSMISSIONANDPRIMARYCHAINCASELUBRICANT(PartNo.

9985105qt)whenchangingprimarychaincaselubricant.

ChangingPrimaryChaincaseLubricant

1.Runmotorcycleuntilengineisatnormaloperatingtemperature.

2.TurntheOFF/RUNswitchtooff.Turnignitionoff.

Besurethatnolubricantsorfluidsgetontires,wheelsor

brakeswhenchangingfluid.Tractioncanbeadversely

affected,whichcouldresultinlossofcontrolofthe

motorcycleanddeathorseriousinjury.(00047d)

Whendrainingoraddinglubricant,donotallowdirt,debris

orothercontaminantstoentertheengine.(00198a)

3.SeeRemovingChaincaseDrainPlug.Removemagneticdrainplugatbottomofprimary

chaincase.Drainprimarychaincase.

NOTE:

Disposeoflubricantinaccordancewithlocalregulations.

4.Cleandrainplug.Ifplughasaccumulatedmuchdebris,inspecttheconditionofchaincase

components.

5.InstallnewOringondrainplug.

6.Installdrainplugbackintoprimarychaincasecover.Tightenplugto1421ftlbs(19.028.5

Nm).

7.SeeClutchCover.RemovefiveTORXscrewswithcaptivewashers(3)todetachclutch

inspectioncover(2)fromprimarychaincasecover.

8.Removetheseal(1).Wipeoilfromgrooveinchaincasecoverandmountingsurface.

Donotoverfilltheprimarychaincasewithlubricant.

Overfillingcancauseroughclutchengagement,

incompletedisengagement,clutchdragand/ordifficultyin

findingneutralatengineidle.(00199b)

9.Pourspecifiedamountoflubricantthroughclutchinspectioncoveropening.Referto

PrimaryChaincaseLubricantRefillCapacity.

a.AllexceptFXDLS:FORMULA+TRANSMISSIONANDPRIMARYCHAINCASE

LUBRICANT

b.FXDLS:SCREAMIN'EAGLESYN3FULLSYNTHETICMOTORCYCLELUBRICANT

10.Installclutchinspectioncoverandnewseal:

a.Thoroughlywipealllubricantfromcovermountingsurfaceandgrooveinchaincase.

b.SeeClutchCover.Positionnewseal(1)ingrooveinclutchinspectioncover(2).

Presseachofthenubsonsealintothegroove.Thenubsretainsealinposition.

c.Insertscrewwithcaptivewasher(3)throughclutchinspectioncover.Carefullythreadit

intothetopcoverscrewhole.

d.Starttheremainingfourscrewswithcaptivewashers.

e.SeeClutchCoverTighteningSequence.Alternatelytightenscrewsto84108in

lbs(9.512.2Nm).

PrimaryChaincaseLubricantRefillCapacity

CONDITION CAPACITY

floz L

Wet 34 1.0

Dry* 38 1.1

*Quantityaftercompletedisassembly.

RemovingChaincaseDrainPlug

1.Seal

2.Clutchinspectioncover

3.Screwandcaptivewasher(5)

ClutchCover

ClutchCoverTighteningSequence

CheckDriveBeltDeflection

NOTE:

AlwaysuseBELTTENSIONGAUGEHD35381Atomeasurebeltdeflection.Failuretouse

tensiongaugemaycauseundertensionedbelts.Loosebeltscanfaildueto"ratcheting"(jumping

atooth)whichcausestensilecordcrimpingandbreakage.

Checkdeflection:

Aspartofprerideinspection.

Ateveryscheduledserviceinterval.

Withtransmissioninneutral.

Withmotorcycleatambienttemperature.

Withmotorcycleuprightoronjiffystandwithrearwheelontheground.

Withthevehicleunladen:norider,noluggageandemptysaddlebags.

Topreventaccidentalvehiclestartup,whichcouldcause

deathorseriousinjury,removemainfusebefore

proceeding.(00251b)

NOTE:

Ifequippedwiththeoptionalsiren,preventthesirenfromsoundingbyfollowingthedisconnecting

powerprocedurebeforeremovingthemainfuse.SeeDisconnectingPower.

1.Disarmsecuritysystem.Removemainfuse.SeeFuses.

2.Shifttransmissiontoneutral.

3.SeeBeltTensionGauge.MeasurebeltdeflectionusingHDBELTTENSIONGAUGE

HD35381A:

a.SlideOring(4)to0lb0kgmark(3).

b.Modelsequippedwithbeltdeflectionwindow:Fitbeltcradle(2)againstbottomof

drivebeltinlinewithbeltdeflectionwindow.

c.Allothermodels:Fitbeltcradle(2)againstbottomofdrivebelthalfwaybetween

drivepulleys.

d.Pressupwardonknob(6)untilOringslidesdownto10lb4.5kgmark(5)andhold

steady.

4.Measurebeltdeflection:

a.Modelsequippedwithbeltdeflectionwindow:SeeBeltDeflectionWindow.

Measurebeltdeflectionasviewedthroughbeltdeflectionviewingwindowwhile

holdinggaugesteady.Eachdeflectiongraduationisapproximately1/16in1.59mm.

b.Allothermodels:SeeCheckingBeltDeflection.Measureamountofdeflection(4)

whileholdinggaugesteady.

5.Comparewithspecifications.Adjustasnecessary.RefertoBeltDeflection.

6.Installmainfuse.

1.Belttensiongauge

2.Beltcradle

3.0lb(0kg)mark

4.Oring

5.10lb(4.5kg)mark

6.Knob

BeltTensionGauge

1.Transmissionsprocket

2.Rearwheelsprocket

3.10lb(4.5kg)offorce

4.Amountofdeflection

CheckingBeltDeflection

1.Drivebelt

2.Deflectiongraduation

BeltDeflectionWindow

BeltDeflection

MODELS in mm

Allmodels 1/43/8 6.49.5

ChassisLubrication

RefertoRegularServiceIntervals:2016HarleyDavidsonDynaModelsforall

maintenanceschedules.

NOTE:

UserecommendedSPECIALPURPOSEGREASEforsteeringheadbearings.Usea

multipurposechassisgreaseforotherapplications.

1.Removeandlubricatehandlebarthrottlecontrolgripsleevewithfreshgraphite.

2.LubricatethrottlecontrolcablesandclutchcontrolcablewithHARLEYLUBE.

3.Lubricatefrontbrakehandleverandclutchcontrolhandleveronlyifnecessary.

4.Inspectrearforkpivotshaftbearings.

5.PackthesteeringheadbearingswithSPECIALPURPOSEGREASEatrecommended

serviceintervals.

6.LubricatethejiffystandmechanismwithSILVERGRADEANTISEIZE.

NOTE:

Formodelspecificinformationregardingthechassislubrication,seetheservicemanualora

HarleyDavidsondealer.

OilApplications

Lubricatemotorcycleatregularintervals,particularlyafterwashingmotorcycleordrivinginwet

weather.RefertoRegularServiceIntervals:2016HarleyDavidsonDynaModels.

MechanicalClutch

Theclutchcontrolcablemustbeoiledandadjusted

periodicallytocompensateforliningwear.See

MAINTENANCESCHEDULINGinthismanual.Failuretooil

andadjusttheclutchcontrolcablecanresultinequipment

damage.(00203b)

Adjusttheclutchcontrolcableatspecifiedintervals.RefertoRegularServiceIntervals:2016

HarleyDavidsonDynaModels.

Iftheclutchslipsunderloadordragswhenreleased,thecontrolcablemayneedtobeadjusted

orclutchservicemayneedtobeperformed.SeeaHarleyDavidsondealerforservice.

HydraulicLifters

Thehydraulicliftersareselfadjusting.Theyautomaticallyadjustlengthtocompensateforengine

expansionandvalvemechanismwear.Thiskeepsthevalvemechanismfreeoflashwhenthe

engineisrunning.

Whenstartinganenginewhichhasbeenturnedoffevenforafewminutes,thevalvemechanism

maybeslightlynoisyuntilthehydraulicunitscompletelyrefillwithoil.Ifatanytimethevalve

mechanismbecomesabnormallynoisy,otherthanforashortperiodimmediatelyafterengineis

started,itisanindicationthatoneormoreofthehydraulicunitsmaynotbefunctioningproperly.

Alwayschecktheengineoillevelfirstsincenormalcirculationofoilthroughtheengineis

necessaryforproperoperationofthehydrauliclifters.

Ifengineoilisattheproperlevel,theliftersmaynotbefunctioningproperlybecauseofdirtinthe

oilsupplypassagesleadingtothelifterunits.SeeaHarleyDavidsondealerforservice.

SteeringHeadBearings

Adjustmentstosteeringheadbearingsshouldbe

performedbyaHarleyDavidsondealer.Improperly

adjustedbearingscanadverselyaffecthandlingand

stability,whichcouldresultindeathorseriousinjury.

(00051b)

CheckforpropersteeringheadbearingadjustmentandlubricatebearingsusingSPECIAL

PURPOSEGREASEatproperintervals.RefertoRegularServiceIntervals:2016Harley

DavidsonDynaModels.

Withmotorcyclefrontendraisedoffthefloor,besurefrontforkturnsfreelywithoutanybindingor

interferenceandthatthereisnoappreciablefronttorearforkmovementindicatingexcessive

bearinglooseness.Steeringheadbearingsshouldbeadjustedaccordingtoservicemanual

procedure,ifnecessary.

Brakes

Inspectbrakefluidlevelandcheckbrakepadsanddiscsforwearatproperintervals.Referto

RegularServiceIntervals:2016HarleyDavidsonDynaModels.

BrakeFluid

Cleanreservoirfillercaporcoverbeforeremoving.Use

onlyDOT4brakefluidfromasealedcontainer.

Contaminatedfluidcanadverselyaffectbrakingorclutch

disengagement,whichcouldresultindeathorserious

injury.(00504d)

DirectcontactofD.O.T.4brakefluidwitheyescancause

irritation.Avoideyecontact.Incaseofeyecontactflush

withlargeamountsofwaterandgetmedicalattention.

SwallowinglargeamountsofD.O.T.4brakefluidcan

causedigestivediscomfort.Ifswallowed,obtainmedical

attention.Useinwellventilatedarea.KEEPOUTOF

REACHOFCHILDREN.(00240a)

D.O.T.4brakefluidwilldamagepaintedandbodypanel

surfacesitcomesincontactwith.Alwaysusecautionand

protectsurfacesfromspillswheneverbrakeworkis

performed.Failuretocomplycanresultincosmetic

damage.(00239b)

Donotallowdirtordebristoenterthemastercylinder

reservoir.Dirtordebrisinthereservoircancause

improperoperationandequipmentdamage.(00205c)

NOTES:

Ifthebrakesystemisnotleaking,thereshouldneverbeaneedtoaddfluid.Ifthefluidlevel

islow,thepadsareprobablyworn.Byreplacingthepads,thefluidlevelreturnstoitsnormal

level.

UseonlyDOT4brakefluidandreplacethebrakefluideverytwoyears.SeeaHarley

Davidsondealer.

1.Standmotorcycleupright(notleaningonjiffystand)onalevelsurface.

a.Frontbrake:Levelthemastercylinderbyturningthehandlebarand/orstandingthe

motorcycleupright(notleaningonjiffystand).

b.Rearbrake:Positionthemotorcyclesothemastercylinderreservoirislevel.

2.SeeBrakeFluidSightGlass/Window.Viewreservoirsightglass.

a.ReservoirwithMINMAXlines:ThefluidlevelmustbebetweentheMINandMAX

lines.Ifthebrakefluidlevel(3)isnotbetweentheMINandMAXlines,seeaHarley

Davidsondealer.

b.Other:Verifyfluidpresence.Iffluidispresent,sightglass(1,2)appearsdark.Ifthe

sightglassremainsclear,seeaHarleyDavidsondealer.

3.Verifyfrontbrakehandleverandrearbrakefootpedalhaveafirmfeelwhenapplied.If

brakesarenotfirm,thebrakesystemmustbebled.SeeaHarleyDavidsondealer.

1.Front

2.Rear:nonABSmodelsandallFLD

3.Rear:ABSmodelsexceptFLD

BrakeFluidSightGlass/Window

BrakePads

Inspectbrakepadsforwearatservicemaintenance

intervals.Ifyourideunderadverseconditions(steephills,

heavytraffic,etc.),inspectmorefrequently.Excessively

wornbrakepadscanleadtobrakefailure,whichcould

resultindeathorseriousinjury.(00052a)

Alwaysreplacebrakepadsincompletesetsforcorrect

andsafebrakeoperation.Improperbrakeoperationcould

resultindeathorseriousinjury.(00111a)

Brakesareacriticalsafetycomponent.ContactaHarley

Davidsondealerforbrakerepairorreplacement.

Improperlyservicedbrakescanadverselyaffectbrake

performance,whichcouldresultindeathorseriousinjury.

(00054a)

Performroutinescheduledbrakemaintenance.Lackof

maintenanceatrecommendedintervalscanadversely

affectbrakeperformance,whichcouldresultindeathor

seriousinjury.(00055a)

Besurewheelandbrakecaliperarealigned.Ridingwitha

misalignedwheelorbrakecalipercancausethebrakedisc

tobindandleadtolossofcontrol,whichcouldresultin

deathorseriousinjury.(00050a)

HarleyDavidsonhasprovidedyournewmotorcyclewiththeoptimumbrakepadfrictionmaterial

available.Itisselectedtogivethebestperformancepossibleunderdry,wetandhighoperating

temperatureconditions.Itexceedsallregulatoryrequirementscurrentlyineffect.However,during

somebrakingconditionsyoucanhearabrakenoise.Thisnoiseisnormalforthisfrictionmaterial.

MinimumBrakePadFrictionMaterialThickness

in mm

0.040 1.020

1.SeeBrakeFrictionMaterial.Checkthebrakediscasitspins.Thediscshouldruntruein

thebrakecaliper.

2.Measurethethicknessofthebrakepadfrictionmaterial.Thepadsdonotnecessarilywear

evenly.Checkeachpad.Thegroovesonthebrakepadsarenolongervisiblewhenthe

padsareneartheendofservicelife.

3.Replacebrakepadsbeforefrictionmaterialreachesmininumthickness.Alwaysreplace

brakepadsinpairs.SeeaHarleyDavidsondealer.RefertoMinimumBrakePadFriction

MaterialThickness.

1.Front,frombelow

2.Rear,fromabove

BrakeFrictionMaterial

Tires

RefertoSpecifiedTiresfortiresandpressures.

Keeptiresproperlyinflated.

Followtiredataforcorrectcoldtireinflationpressure.

Checktirepressureswhentiresarecold.

Besuretiresareproperlyinflated,balanced,undamaged,

andhaveadequatetread.Inspectyourtiresregularlyand

seeaHarleyDavidsondealerforreplacements.Riding

withexcessivelyworn,unbalanced,improperlyinflated,

overloadedordamagedtirescanleadtotirefailureand

adverselyaffectstabilityandhandling,whichcouldresult

indeathorseriousinjury.(00014b)

Matchtires,tubes,rimstripsorseals,airvalvesandcaps

tothecorrectwheel.ContactaHarleyDavidsondealer.

Mismatchingcanleadtotiredamage,allowtireslippage

onthewheelorcausetirefailure,whichcouldresultin

deathorseriousinjury.(00023c)

Onlyinstalloriginalequipmenttirevalvesandvalvecaps.

Avalve,orvalveandcapcombination,thatistoolongor

tooheavycanstrikeadjacentcomponentsanddamagethe

valve,causingrapidtiredeflation.Rapidtiredeflationcan

causelossofvehiclecontrol,whichcouldresultindeath

orseriousinjury.(00281a)

Checktiresforcorrectpressure,excessivewearoranysignsoftiredamageatleastweeklyifin

dailyuse.Checkbeforeeachrideifonlyriddenoccasionally.

UseonlyHarleyDavidsonspecifiedtires.Othertiresmaynotfitcorrectlyandcouldadversely

affectstability,handlingandperformance.RefertoSpecifiedTires.

Tiresareacriticalsafetycomponent.ContactaHarley

Davidsondealerfortirerepairorreplacement.Improper

tireservicecanadverselyaffectstabilityandhandling,

whichcouldresultindeathorseriousinjury.(00057a)

Replacepuncturedordamagedtires.Insomecases,small

puncturesinthetreadareamayberepairedfromwithin

theremovedtirebyaHarleyDavidsondealer.Speed

shouldNOTexceed50mph(80km/h)forthefirst24hours

afterrepair,andtherepairedtireshouldNEVERbeused

over80mph(130km/h).Failuretofollowthiswarning

couldleadtotirefailureandresultindeathorserious

injury.(00015b)

Strikinganobject,suchasacurborpotholecancause

internaltiredamage.Ifanobjectisstruck,havethetire

inspectedimmediatelyinsideandoutbyaHarley

Davidsondealer.Adamagedtirecanfailwhileridingand

adverselyaffectstabilityandhandling,whichcouldresult

indeathorseriousinjury.(00058b)

TireReplacement

Inspection

ReplacetireimmediatelywithaHarleyDavidsonspecified

tirewhenwearbarsbecomevisibleoronly1/32in(0.8

mm)treaddepthremains.Ridingwithaworntirecould

resultindeathorseriousinjury.(00090c)

SeeTreadWearIndicator:MichelinTiresorDunlopSidewallTreadWearIndicatorBar

Locator.Indicatorsonthetiresidewallidentifythelocationoftreadwearbars.

SeeMichelinTireWearBarAppearanceorDunlopTireWearBarAppearance.Always

replacetiresbeforethetreadwearbarsappear.

Treadwearbarswillappearontiretreadsurfaceswhen1/32in0.8mmorlessoftiretread

remains.

WhenToReplaceTires

Newtiresareneededifanyofthefollowingconditionsexist:

1.Treadwearbarsbecomevisibleonthetreadsurfaces.

2.Tirecordsorfabricbecomevisiblethroughcrackedsidewalls,snagsordeepcuts.

3.Abump,bulgeorsplitinthetire.

4.Puncture,cutorotherdamagetothetirethatcannotberepaired.

Wheninstallingtiresonrims,donotrelyontreaddesigntodeterminedirectionofrotation.Always

besuretherotationalarrowsmoldedintothesidewallspointinthedirectionofrotationwhenthe

vehicleismovingforward.

UseonlyHarleyDavidsonspecifiedtires.SeeaHarley

Davidsondealer.Usingnonspecifiedtirescanadversely

affectstability,handlingorbraking,whichcouldresultin

deathorseriousinjury.(00024b)

TreadWearIndicator:MichelinTires

MichelinTireWearBarAppearance

DunlopSidewallTreadWearIndicatorBarLocator

DunlopTireWearBarAppearance

SparkPlugs

Disconnectingsparkplugcablewithenginerunningcan

resultinelectricshockanddeathorseriousinjury.

(00464b)

DoNOTpullonanyelectricalwires.Pullingonelectrical

wiresmaydamagetheinternalconductorcausinghigh

resistance,whichmayresultinminorormoderateinjury.

(00168a)

Checkthesparkplugsatproperintervals.RefertoRegularServiceIntervals:2016Harley

DavidsonDynaModels.

1.Disconnectsparkplugcablesfromplugsbypullinguponthemoldedconnectorcaps.

2.Checksparkplugtype.Onlyusesparkplugsspecifiedforyourmodelmotorcycle.

3.Checksparkpluggapagainstspecifications.RefertoElectrical.

NOTE:

Ifatorquewrenchisnotavailable,tightennewsparkplugsfingertight.Tightenanextra

onequarterturnwithasparkplugwrench.

4.Alwaystightentothepropertorque.Sparkplugsmustbetightenedtothetorquespecified

forproperheattransfer.RefertoElectrical.

5.Connecteachmoldedconnectorcapuntilthecapsnapsfirmlyintoplaceoverthespark

plug.

AirFilter:Allexcept103HighOutput,FXDLS

Removal

Inspectfilterelementatscheduledintervals.Whenoperatedunderdustyconditions,inspectmore

often.RefertoRegularServiceIntervals:2016HarleyDavidsonDynaModels.

1.SeeAirCleanerAssembly:Allexcept103HighOutputandFXDLS.Removethe

coverscrew(1)andthecover(2)withseal(3).

2.Removethebreathertubes(6)fromthefilterelement(5).

3.Removethefilter/bracketscrews(9)andthebracket(8).

4.Removethefilter(5)andgasket(7).

5.Inspectandcleanfilterelementasnecessary.SeeFilterCleaning:96,103andHigh

Output103.

Installation

Installairfilterbeforerunningengine.Failuretodosocan

drawdebrisintotheengineandcouldresultinengine

damage.(00207a)

1.SeeAirCleanerAssembly:Allexcept103HighOutputandFXDLS.Installthefilter

element(5)andgasket(7)tothebackplate.

2.Checkthatthespeednut(4)isclippedintoplaceonthebracket(8).

3.Installthebracketandfilter/bracketscrews(3).Tightento4060inlbs(4.506.8Nm).

4.Checkthattheseal(3)isfittedtothecover(2).Installthecover.

5.ApplyadropofLOCTITETHREADLOCKER243(blue)tothethreadsofthecoverscrew

(1).Installanydecorateinsertsandthecoverscrew.Tightento3660inlbs(4.16.8Nm).

1.Coverscrew

2.Aircleanercover

3.Coverseal

4.Speednut

5.Filterelement

6.Breathertube(2)

7.Gasket

8.Bracket

9.Filter/bracketscrews(3)

AirCleanerAssembly:Allexcept103HighOutputandFXDLS

AirFilter:103HighOutput

RainSock

SeeAirCleanerAssembly:103HighOutput.Inwetorrainyconditions,becausethefilter

elementisexposed,watercanentertheengine.Whenparked,watercancauseinternalengine

corrosionordamage.Whenrunning,watercancausetheenginetomisfire.

Inwetorrainyconditions,installtherainsock(8)overtheaircleanerassemblytopreventwater

intrusion.

Removal

1.SeeAirCleanerAssembly:103HighOutput.Removetwoscrews(1).Removetrim

insert(2).

2.Removescrew(3)toreleasecover(4).Removecover.

3.Removethreescrews(5)toreleasefilterelement(6).Removefilterelement.

4.Inspectandcleanfilterelementasnecessary.SeeFilterCleaning:96,103andHigh

Output103.

Installation

1.SeeAirCleanerAssembly:103HighOutput.Placefilterelement(6)ontobackplate

(7).

2.Installthefilterelementscrews(5).Tightento5560inlbs(6.26.8Nm).

3.Placeaircleanercover(4)ontobackplate.ApplyLOCTITE243(blue)tothethreadsof

screw.Tightento3660inlbs(4.06.8Nm).

4.Installtriminsert(2).Installtriminsertscrews(1).Tightento2732inlbs(3.13.6Nm).

1.Trimscrew(2)

2.Triminsert

3.Coverscrew

4.Cover

5.Filterelementscrew(3)

6.Filterelement

7.Backplate

8.Rainsock

AirCleanerAssembly:103HighOutput

FilterCleaning:96,103andHighOutput103

Donotusegasolineorsolventstocleanfilterelement.

Flammablecleaningagentscancauseanintakesystem

fire,whichcouldresultindeathorseriousinjury.(00101a)

Compressedaircanpiercetheskinandflyingdebrisfrom

compressedaircouldcauseseriouseyeinjury.Wear

safetyglasseswhenworkingwithcompressedair.Never

useyourhandtocheckforairleaksortodetermineair

flowrates.(00061a)

NOTE:

Donotstrikefilteronahardsurfacetodislodgedirt.

1.Washthepaper/wiremeshairfilterelementandbreatherhosesinlukewarmwaterwitha

milddetergent.

NOTE:

DoNOTuseaircleanerfilteroilontheHarleyDavidsonpaper/wiremeshairfilterelement.

2.Allowfiltertoairdryoruseblowlowpressurecompressedairfromtheinsideofthefilter.

NOTE:

Theelementissufficientlycleanwhenlightisuniformlyvisiblethroughthemedia.

3.Holdthefilteruptoastronglighttocheckprogress.

4.Replacethefilterifthefiltercannotbeadequatelycleanedorisdamaged.

AirFilter:FXDLS

Removal

NOTES:

Inspectfilteratproperintervals.Whenoperatedunderdustyconditions,inspectmoreoften.

RefertoRegularServiceIntervals:2016HarleyDavidsonDynaModels.

Aslotinthebacksideoftheclampcoverallowsscrewdriveraccess.

1.SeeAirFilterBandClamp:FXDLS.Loosenthehoseclampinsidetheclampcover.

2.Separatethefilterfromtheairtube.

AirFilterBandClamp:FXDLS

Installation

Installairfilterbeforerunningengine.Failuretodosocan

drawdebrisintotheengineandcouldresultinengine

damage.(00207a)

1.SeeAirFilter:FXDLS.Ifremoved,installtheclamp(2)aroundthefilter(3)neck.

2.Installthefilterontotheintaketube(1)untilitisseatedoverthegroove.

NOTE:

Topreventdamagetothefilterbackplate,holdthewormdriveintheapproximatecenterof

thenotchwhentighteningtheclamp.

3.Tightentheclamparoundthefilterflangeto3040inlbs(3.44.5Nm).

1.Intaketube

2.Hoseclamp

3.Filterelement

AirFilter:FXDLS

FilterCleaning:FXDLS

Donotusegasolineorsolventstocleanfilterelement.

Flammablecleaningagentscancauseanintakesystem

fire,whichcouldresultindeathorseriousinjury.(00101a)

NOTES:

Neverstrikethefilteronahardsurfacetodislodgedirt.

1.Tapthefiltertodislodgeanyloosedirt.Gentlybrushwithasoftbristlebrush.

NOTE:

K&NPOWERKEENAIRFILTERCLEANERisavailablefromaHarleyDavidsondealer.

2.Cleanthefilter:

a.Sprayairfiltercleanerliberallyorrollthecottonfiltermediainashallowpanof

cleaner.

b.Soakfortenminutes.

NOTE:

Donotusecompressedairoraheatguntospeeddrying.

3.Rinseanddrythefilter.

a.Rinseoffthefilterfromthecleansidetothedirtysidewithlowpressuretapwater.

b.Shakeofftheexcesswater.

c.Letthefilterairdry.

NOTE:

Iftheairfilterrequiresreplacement,installtoanewfilterwiththecorrectadhesive.Seeyour

HarleyDavidsondealer.

4.Inspectthefilter.Holdthefilteruptoastronglightsource.

a.Thefilteriscleaniflightisuniformlyvisiblethroughthefilter.

b.Replacethefilterifdamagedorifitcannotbeadequatelycleaned.

NOTES:

K&NAIRFILTEROILisavailableatyourHarleyDavidsondealer.

Donotoveroilthefilter.Ifoilisstilldrippingfromthefilter20minutesafteroiling,clean

andoilthefilteragain.

5.Oilthefilter.

a.Sprayoruseasqueezebottletoapplyairfilteroilalongeachpleat.

b.Allowthefiltertoabsorbtheoilfor20minutes.

c.After20minutes,inspectthefilter.Applyfilteroiltoanyremainingwhitespots.Allow

thefiltertoabsorbtheoil.

HeadlampBulbReplacement:FXDF

Handlebulbcarefullyandweareyeprotection.Bulb

containsgasunderpressure,which,ifnothandled

carefully,couldcauseseriouseyeinjury.(00062b)

Whenreplacementisrequired,useonlythespecified

sealedbeamunitorbulb,availablefromaHarleyDavidson

dealer.Animproperwattagesealedbeamorbulb,can

causechargingsystemproblems.(00209a)

Replacefailedbulbs.

BulbRemoval

NOTE:

Markthelocationandorientationofpartsuponremoval.

1.SeeHeadlampBulbs:DualHeadlight.Removemountingscrews(7).Removetrimring

(4).

2.Removebulb(2)andheadlampconnectorfrombackofheadlamplens(3).

3.Disconnectheadlampconnectorfrombulb.

4.InternationalModels:Rotateconnector(6)onequarterturn.Removebulbassemblyfrom

housing.Pullpositionbulb(5)toremove.

BulbInstallation

Nevertouchthequartzbulb.Fingerprintswilletchthe

glassanddecreasebulblife.Handlethebulbwithpaperor

aclean,drycloth.Failuretodosocouldresultinbulb

damage.(00210b)

NOTE:

Wheninstallinganewbulb,verifythatconnectorcontactsarecleanforgoodelectricalcontact.

1.SeeHeadlampBulbs:DualHeadlight.Installnewbulb(2)andassembletheheadlamp

components.

2.ForInternationalModels:Installnewbulb(5)inconnector(6).Installconnectorin

housing.

3.Installtrimring(4)andscrews(7).

4.Alignheadlamp.SeeHeadlampAlignment.

1.Dualbulbhousing

2.Headlampbulb(s)

3.Headlamplens

4.Trimring

5.Bulb,positionHDImodelsonly

6.ConnectorHDImodelsonly

7.Mountingscrew(s)

HeadlampBulbs:DualHeadlight

HeadlampBulbReplacement:FLD

1.SeeHeadlamp:FLD,FLD103.Removescrew(3)atbottomofheadlampdoor(chrome

ring).Removeheadlampdoor.

2.SeeHeadlampRetainingScrews:FLD.Removescrewssecuringheadlampassembly.

3.Removeheadlampconnectorfromheadlampbulb.

Whenreplacementisrequired,useonlythespecified

sealedbeamunitorbulb,availablefromaHarleyDavidson

dealer.Animproperwattagesealedbeamorbulb,can

causechargingsystemproblems.(00209a)

4.Removeheadlampassembly.

5.Removerubberbootatbackofhousing.

6.SeeWireRetainingClip.Releasewireretainingclip(1)fromretainer(2).Swingwire

retainingclipoutoftheway.

NOTE:

Ifnecessary,loosenretainerscrewonehalftooneturntoreleasewireretainingclip.

Handlebulbcarefullyandweareyeprotection.Bulb

containsgasunderpressure,which,ifnothandled

carefully,couldcauseseriouseyeinjury.(00062b)

7.Replacefailedbulbs.

Nevertouchthequartzbulb.Fingerprintswilletchthe

glassanddecreasebulblife.Handlethebulbwithpaperor

aclean,drycloth.Failuretodosocouldresultinbulb

damage.(00210b)

8.Installnewbulb.Alignthetabonthebulbwiththenotchintheheadlamphousing.

9.SeeWireRetainingClip.Rotatewireretainingclip(1)intoplaceandlatchunderlipof

retainer(2).

NOTE:

Ifretainerscrewwasloosenedtoreleasewireretainingclip,holdretainerinplaceand

tightenscrewuntilsnug.Verifythatreflectorconeisstillcenteredunderdecorativelogo.Ifit

isnot,loosenretainerscrewandrepeatstepuntiltheproperresultsareachieved.

10.Installrubberbootatbackofhousing.

11.HDImodels:Rotatepositionlampbulbretaineronequarterturncounterclockwiseto

remove.Replacebulb.Installbulbretainerinlamphousing.

12.Installheadlampconnectoronheadlampbulb.

13.Installheadlampassembly.Tightenscrewsto918inlbs(1.02.0Nm).

14.Fittheheadlampdoorspringintoslotattopofheadlamphousing.Securetheheadlamp

door(chromering)withscrew.Tightento918inlbs(1.02.0Nm).

1.Horizontaladjuster

2.Verticaladjuster

3.Headlampdoorscrew

Headlamp:FLD,FLD103

HeadlampRetainingScrews:FLD

1.Wireretainingclip

2.Retainer

WireRetainingClip

HeadlampBulbReplacement:AllExceptFXDFandFLD

Handlebulbcarefullyandweareyeprotection.Bulb

containsgasunderpressure,which,ifnothandled

carefully,couldcauseseriouseyeinjury.(00062b)

Whenreplacementisrequired,useonlythespecified

sealedbeamunitorbulb,availablefromaHarleyDavidson

dealer.Animproperwattagesealedbeamorbulb,can

causechargingsystemproblems.(00209a)

Replacefailedbulbs.

BulbRemoval

Topreventaccidentalvehiclestartup,whichcouldcause

deathorseriousinjury,removemainfusebefore

proceeding.(00251b)

NOTE:

Markpartsforlocationandorientationuponremoval.

1.Removemainfuse.SeeFuses.

2.FXDLS:Ifnecessaryremovethespeedscreen.SeeSpeedScreen:FXDLS.

3.SeeHeadlampBulbs:SingleHeadlight.Removetrimringhardware(1).Removetrim

ring(2).

4.Removemountingring(3)andbumper,ifequipped.

5.Disconnectheadlampconnector(8)frombulb(5).

6.Removerubberboot(6),ifequipped,frombackofheadlamplens(4).

7.Removewireretainingclip(7)fromheadlampbase.

8.Removebulbfromheadlampassembly.

9.HDImodels:Rotateboot(10)onequarterturn.Removebulbassemblyfromhousing.Pull

positionbulb(9)toremovefromboot.

BulbInstallation

Nevertouchthequartzbulb.Fingerprintswilletchthe

glassanddecreasebulblife.Handlethebulbwithpaperor

aclean,drycloth.Failuretodosocouldresultinbulb

damage.(00210b)

NOTE:

Wheninstallinganewbulb,makesurethatconnectorcontactsarecleanforgoodelectrical

contact.

1.SeeHeadlampBulbs:SingleHeadlight.Installnewbulb(5)andassemblethe

headlampcomponents.

2.HDImodels:Installnewbulb(9)inboot(10).Installbootinhousing.Rotateonequarter

turn.

3.Verifyslotsandtabsinheadlamp(4)andtrimring(2)arealigned.

4.Installrubberboot(6)withwordTOPatthetopoftheheadlamplensassembly.

5.Connecttheheadlampconnector(8).

6.Ifequipped,installbumper.

7.Installtrimring(2)andhardware(1).

8.FXDLS:Ifremoved,installthespeedscreen.SeeSpeedScreen:FXDLS.

9.Installmainfuse.

Besurethatalllightsandswitchesoperateproperly

beforeoperatingmotorcycle.Lowvisibilityofridercan

resultindeathorseriousinjury.(00316a)

10.Checkoperationofalllamps.

11.Alignheadlamp.SeeHeadlampAlignment.

1.Trimringhardware

2.Trimring

3.Mountingring

4.Headlamplens

5.Bulb

6.Boot

7.Wireretainingclip

8.Headlampconnector

9.Bulb,positionHDImodelsonly

10.BootHDImodelsonly

HeadlampBulbs:SingleHeadlight

SpeedScreen:FXDLS

Removal

1.SeeSpeedScreen:FXDLS.Removethescrewsandwashers(1).

2.Pullthespeedscreenposts(3)awayfromtherubbergrommets(4)inthelowerbracket.

Installation

1.SeeSpeedScreen:FXDLS.Alignthespeedscreenposts(3)withtherubbergrommets

(4)inthelowerbracket.

2.Pressthepostsintotherubbergrommets.

3.Aligntheclips(2)inthespeedscreenwiththethreadedholesintheupperbracket.

4.Installthescrewsandwashers(1).Tightento2129inlbs(2.33.3Nm).

1.Screwandwasher(2)

2.Clip(2)

3.Post(2)

4.Rubbergrommet(2)

SpeedScreen:FXDLS

HeadlampAlignment

1.Checktirepressure.

2.Fillfueltankoraddanequalamountofballast.

3.Adjustrearshocksfortheriderandintendedload.

NOTE:

Chooseawallinminimumlight.

4.SeeCheckingHeadlampAlignment.Parkthemotorcycleonaperpendicularline(1)with

thefrontaxle25ft7.6m(3)fromawall.

5.Drawaverticalline(2)onthewall.

NOTE:

Adjusttheheadlampsofmotorcycleswithmultiplebeamheadlampstoconvergeintoone

pattern.

6.Withthemotorcycleloaded,pointthefrontwheelstraightforwardatwall.Measurethe

distance(4)fromthefloortothecenterofthehighbeambulb.

7.Drawahorizontalline(5)throughtheverticallineonthewall.Placeline2.1in53.3mm

lowerthanthemeasuredbulbcenterline.

NOTE:

Theheadlampisalignedwhenthelightbeamhotspotislocatedovertheintersectionofthe

lines.

8.Withthehighbeamactivated,verifyheadlampalignment.Adjustasnecessary.

1.Perpendicularline

2.Verticalline

3.25ft(7.6meters)

4.Highbeambulbcenterline

5.Horizontalline2.1in(53.3mm)lowerthanbulbcenterline

CheckingHeadlampAlignment

HeadlampAdjustment:ExceptFLD,FLD103,FXDL,FXDL103

1.FXDLS:Ifnecessary,removethespeedscreen.SeeSpeedScreen:FXDLS.

2.SeeHeadlampAdjustment:ExceptFLD,FLD103,FXDL,FXDL103.Loosen

horizontaladjustingbolt(2)toadjustheadlampbeamsidetoside.Tightenboltto2530ft

lbs(33.940.7Nm).

NOTE:

FXDLS:Turnthehandlebarsfulllocklefttoaccesstheverticaladjustmentboltfromtherear

ofthetripleclamp.

3.Loosennutonverticaladjustingbolt(1)toadjustheadlampbeamupordown.Tightenbolt

to2530ftlbs(33.940.7Nm).

4.FXDLS:Ifremoved,installthespeedscreen.SeeSpeedScreen:FXDLS.

1.Verticaladjustingbolt

2.Horizontaladjustingbolt

HeadlampAdjustment:ExceptFLD,

FLD103,FXDL,FXDL103

HeadlampAdjustment:FLD

NOTE:

Headlampadjustmentcanbeperformedwithoutremovingtheheadlamptrimring.

1.SeeHeadlamp:FLD,FLD103.Usingadjusterslotsintrimring,insertPhillipsscrewdriver

betweenheadlamptrimringandrubbergasket.

a.Horizontal:Turnthehorizontaladjustertoadjustlightbeamleftandright.

b.Vertical:Turntheverticaladjustertoadjustlightbeamupanddown.

2.SeeCheckingHeadlampAlignment.Adjustthelightbeamuntilitiscentered.

HeadlampAdjustment:FXDL

1.SeeHeadlamp:FXDLModels.Removesnapplug(1)ontopofvisor(2).

a.SeeHeadlampVisor:FXDLModels.Insertasmallscrewdriverthroughhole(1)on

leftsideundervisor(2)

b.Pushuponplugtoremove.

2.SeeHeadlamp:FXDLModels.Loosenheadlampclampnut(3).

3.Adjustheadlampverticallytoaimitathorizontalline.Atsametime,adjustheadlamp

horizontallytoaimbeamstraightahead.

4.Tightenheadlampclampnutto120240inlbs(1427Nm)afterlampisproperlypositioned.

5.Installsnapplug(1)inheadlampvisor(2).

1.Hole

2.Visor

3.Headlamp

HeadlampVisor:FXDLModels

1.Snapplug

2.Headlampvisor

3.Clampnut

Headlamp:FXDLModels

TurnSignalBulbReplacement:BulletStyle

NOTE:

ModelswithLEDlampsdonotcontainreplacementbulbs.ReplacetheLEDassembly.

1.SeeRemoveLens.Insertacoinorthebladeofasmallscrewdriverintothenotchatthe

bottomofthelenscap.Carefullytwistuntilthelenscappopsoutofthelamphousing.

2.Pushbulbinandrotatecounterclockwise.Pullbulbfromsocket.

3.Inspectconditionofelectricalcontactsinsocket.Ifnecessary,cleanwithasmallwirebrush

andelectricalcontactcleaner.

4.ApplyELECTRICALCONTACTLUBRICANTtocontactsinsocketandatbottomofnew

bulb.

5.Alignpinsonnewbulbwithpinguidesinbulbsocket.Pushbulbinandturnclockwiseto

lockinplace.

6.Snaplenscapontothelamphousingwithnotchatbottom.

Besurethatalllightsandswitchesoperateproperly

beforeoperatingmotorcycle.Lowvisibilityofridercan

resultindeathorseriousinjury.(00316a)

7.Checkoperationofalllamps.

RemoveLens

LEDTailLamp:CanadaFXDB,FXDBC,FXDBP,FXDLSandInternational

FXDWG

CanadaFXDB,FXDBC,FXDBP,FXDLSandFXDWGmodelsoutsidetheU.S.haveacenter

mountedLEDtaillampwithnoreplaceablebulbs.Thecoveronthetaillampisnotremovable.

Seeadealerorservicemanualforassemblyreplacement.

LEDRearTurnSignal/TailLamps:InternationalFXDB,FXDBC,FXDBP,FXDLS

InternationalFXDB,FXDBC,FXDBP(outsidetheU.S.)andFXDLShaveLEDturnsignalsandtail

lampswithnoreplaceablebulbs.Capsonrearturnsignalsarenotremovable.Seeadealeror

servicemanualforassemblyreplacement.

TailLampBulbReplacement:FLDandFXDL

1.TurnignitionswitchOFF.

2.SeeTailLampAssembly.Removetwoscrewsandlens(1)frombase(2).

NOTE:

Disconnect4pinmultilockconnectorfromcircuitboardtosimplifybulbremoval.

3.Removebulbassemblyfromlens(1).Removebulb.

4.CoatbaseofnewbulbwithELECTRICALCONTACTLUBRICANT.Installnewbulb.

5.Installbulbassemblytolens.

6.Ifremoved,connect4pinmultilockconnector(3)tocircuitboard.

7.Installlens(1)tobase(2)withtwoscrews.Tightento2024inlbs(2.32.7Nm).

Besurethatalllightsandswitchesoperateproperly

beforeoperatingmotorcycle.Lowvisibilityofridercan

resultindeathorseriousinjury.(00316a)

8.Turnignitionon.Checkoperationofalllamps.

1.Lens

2.Base

3.4pinmultilockconnector

4.Bulbassembly

TailLampAssembly

BatteryTenderConnector:FXDLS

SeeBatteryTender:FXDLS.Maintainingthebatterybetweenridesandwhilestoredcan

maintainbatterychargeandextendthelifeofthebattery.Connectthebatterytenderconnectorto

abatterytenderduringstorageortoabatterychargerifthebatteryvoltagedropbelow

specification.SeeBatteryMaintenance

Removetheleftsidecovertoaccesstheconnector.Removetheconnectorcap.Connectthe

batterythroughtheconnectortoanautomatic,constantmonitoringbatterycharger/tender.The

connectoriscompatiblewithallHarleyDavidsonbatterytender/chargers.

Whenremovingthetender/charger,replacetheconnectorcaptopreventmoisturedamagewhen

notinuse.

BatteryTender:FXDLS

BatteryMaintenance

Type

YourmotorcycleusesanAbsorbedGlassMat(AGM)battery.TheAGMbatteryispermanently

sealed,valveregulated,maintenancefree,lead/calciumandsulfuricacidbattery.Allbatteriesare

shippedprechargedandreadyforservice.Donotattempttoopenthebatteryforanyreason.

AntidotesforBatteryAcid

CONTACT TREATMENT

External Flushwithwater.

Internal Drinklargequantitiesofmilkorwater,

followedbymilkofmagnesia,vegetableoil

orbeateneggs.Getimmediatemedical

attention.

Eyes Flushwithwater.Getimmediatemedical

attention.

Batteriescontainsulfuricacid,whichcouldcausesevere

burnstoeyesandskin.Wearaprotectivefaceshield,

rubberizedglovesandprotectiveclothingwhenworking

withbatteries.KEEPBATTERIESAWAYFROMCHILDREN.

(00063a)

Explosivehydrogengas,whichescapesduringcharging,

couldcausedeathorseriousinjury.Chargebatteryina

wellventilatedarea.Keepopenflames,electricalsparks

andsmokingmaterialsawayfrombatteryatalltimes.

KEEPBATTERIESAWAYFROMCHILDREN.(00065a)

Batteries,batteryposts,terminalsandrelatedaccessories

containleadandleadcompounds,andotherchemicals

knowntotheStateofCaliforniatocausecancer,andbirth

defectsorotherreproductiveharm.Washhandsafter

handling.(00019e)

Neverremovewarninglabelattachedtotopofbattery.

Failuretoreadandunderstandallprecautionscontained

inwarning,couldresultindeathorseriousinjury.(00064a)

BatteryWarningLabel

1.Contentsarecorrosive

2.Wearsafetyglasses

3.Contentsareexplosive

4.Keepflamesaway

5.Readinstructions

6.Keepawayfromchildren

BatteryWarningLabel

VoltmeterTest

Thevoltmetertestprovidesageneralindicatorofbatterycondition.Checkthevoltageofthe

batterytoverifythatitisina100percentfullychargedcondition.Iftheopencircuit(disconnected)

voltagereadingisbelow12.7V,chargethebattery.Recheckthevoltageafterthebatteryhasset

foronetotwohours.RefertoVoltmeterTest.

VoltmeterTest

READINGINVOLTS PERCENTOFCHARGE

12.7 100

12.6 75

12.3 50

12.0 25

11.8 0

CleaningandInspection

Batterytopmustbecleananddry.Dirtandelectrolyteontopofthebatterycancausebatteryto

selfdischarge.

1.Cleanbatterytop.

2.Cleancableconnectorsandbatteryterminalsusingawirebrushorfinegritsandpaperto

removeanyoxidation.

3.Inspectandcleanthebatteryscrews,clampsandcables.Checkforbreakage,loose

connectionsandcorrosion.

4.Checkthebatterypostsformeltingordamagecausedbyovertightening.

5.Inspectthebatteryfordiscoloration,araisedtoporawarpedordistortedcase.These

conditionsmightindicatethatthebatteryhasbeenfrozen,overheatedorovercharged.

6.Inspectthebatterycaseforcracksorleaks.

Charging

Anautomatic,constantmonitoringbatterycharger/tenderwithachargingrateof5ampsorlessat

lessthan14.6voltsisrecommended.Theuseofconstantcurrentchargers(includingtrickle

chargers)tochargesealedAGMbatteriesisnotrecommended.Anyoverchargewillcausedry

outandprematurebatteryfailure.Neverchargeabatterywithoutfirstreviewingtheinstructions

forthechargerbeingused.Inadditiontothemanufacturer'sinstructions,followthesegeneral

safetyprecautions.

Chargethebatteryifanyofthefollowingconditionsexist:

Vehiclelampsappeardim.

Electricstartersoundsweak.

Batteryhasnotbeenusedforanextendedtime.

Explosivehydrogengas,whichescapesduringcharging,

couldcausedeathorseriousinjury.Chargebatteryina

wellventilatedarea.Keepopenflames,electricalsparks

andsmokingmaterialsawayfrombatteryatalltimes.

KEEPBATTERIESAWAYFROMCHILDREN.(00065a)

Batteriescontainsulfuricacid,whichcouldcausesevere

burnstoeyesandskin.Wearaprotectivefaceshield,

rubberizedglovesandprotectiveclothingwhenworking

withbatteries.KEEPBATTERIESAWAYFROMCHILDREN.

(00063a)

1.Performavoltmetertesttodeterminethestateofcharge.Ifbatteryneedstobecharged,

proceedtothenextstep.

2.Placethebatteryonalevelsurface.

UnplugorturnOFFbatterychargerbeforeconnecting

chargercablestobattery.Connectingcableswithcharger

ONcancauseasparkandbatteryexplosion,whichcould

resultindeathorseriousinjury.(00066a)

Connectpositive(+)batterycablefirst.Ifpositive(+)cable

shouldcontactgroundwithnegative()cableconnected,

theresultingsparkscancauseabatteryexplosion,which

couldresultindeathorseriousinjury.(00068a)

Disconnectnegative()batterycablefirst.Ifpositive(+)

cableshouldcontactgroundwithnegative()cable

connected,theresultingsparkscancauseabattery

explosion,whichcouldresultindeathorseriousinjury.

(00049a)

Donotreversethechargerconnectionsdescribedinthe

followingstepsorthechargingsystemofthemotorcycle

couldbedamaged.(00214a)

NOTES:

Donotusechargerswithexcessivelyhighvoltagedesignedforfloodedbatteriesor

excessivelyhighcurrentdesignedformuchlargerbatteries.Donotchargeatmore

than5ampsormorethan14.6volts.

Mostautomatic,constantmonitoringbatterychargersarecompletelyautomaticand

canbeleftconnectedtobothACpowerandtothebatterythatisbeingcharged.When

leavingthistypeofchargerconnectedforextendedperiodsoftime,periodicallycheck

thebatterytoseeifitisunusuallywarm.Thisisanindicationthatthebatterymay

haveaweakcellorinternalshort.Readthemanufacturer'sinstructionsforthecharger

beingused.

3.Connecttheredbatterychargerleadtopositiveterminalofthebattery.

4.Connecttheblackbatterychargerleadtonegativeterminalofthebattery.

NOTE:

Ifthebatteryisstillinthevehicle,connectthenegativeleadtothechassisground.Make

surethattheignitionandallelectricalaccessoriesareturnedoff.

5.Stepawayfromthebatteryandturnonthecharger.

UnplugorturnOFFbatterychargerbeforedisconnecting

chargercablesfrombattery.Disconnectingclampswith

chargerONcancauseasparkandbatteryexplosion,

whichcouldresultindeathorseriousinjury.(00067a)

6.Afterthebatteryisfullycharged,turnOFFthecharger.Disconnecttheblackbatterycharger

leadfromthenegativeterminalofthebattery.

7.Disconnecttheredbatterychargerleadfromthepositiveterminalofthebattery.

8.Markthechargingdateonthebattery.

Storage

Ifthemotorcyclewillnotbeoperatedforseveralweeks,suchasduringthewinterseason,

removethebatteryfromthemotorcycleandfullycharge.

Ifthemotorcyclewillbestoredwiththebatteryinstalled,connectanautomatic,constant

monitoringcharger/tendertomaintaincharge.SeeanauthorizedHarleyDavidsondealerformore

information.

Abatterythatisremovedfromthevehicleisaffectedbyselfdischarge.Abatterythatisstoredin

thevehicleisaffectedbybothselfdischargeand,moresignificantly,parasiticloads.

Batteriesselfdischargeatafasterrateathigherambienttemperatures.

Toreducetheselfdischargerate,storebatteryinacool,dryplace.

Chargethebatteryeverytwoweeksifstoredinthevehicle.

Chargethebatteryoncepermonthifstoredoutofthevehicle.

1.Capacity

2.Monthsofnonuse

3.Measuredat105°F(40°C)

4.Measuredat77°F(25°C)

EffectiveRateofTemperatureonBattery

SelfdischargingRate

Battery

DisconnectionandRemoval

Beforeyoucaninspectordisconnectyourbatteryyoumustreadthesectioncontaining

informationaboutseatremoval.

Disconnectnegative()batterycablefirst.Ifpositive(+)

cableshouldcontactgroundwithnegative()cable

connected,theresultingsparkscancauseabattery

explosion,whichcouldresultindeathorseriousinjury.

(00049a)

1.Removeseat.SeeSeat.

NOTE:

Thebatteryislocatedbelowtheseatontherightside.

2.SeeBattery.Removethescrew(3)belowthebatterycover.

3.Removebatterycover.

4.Modelswithsirens:TurntheignitionswitchONwiththehandsfreefobpresenttodisarm

thesecuritysystem.

5.Removethenegativecable(black)frombatterynegativeterminal(1).

6.Removebatterypositivecable(red)frombatterypositiveterminal(2).

7.Removetherubberholddownstrap(4)andslidethebatteryoutofthebattery

compartment.

InstallationandConnection

Connectthecablestothecorrectbatteryterminals.Failure

todosocouldresultindamagetothemotorcycle

electricalsystem.(00215a)

Connectpositive(+)batterycablefirst.Ifpositive(+)cable

shouldcontactgroundwithnegative()cableconnected,

theresultingsparkscancauseabatteryexplosion,which

couldresultindeathorseriousinjury.(00068a)

Donotallowpositive(+)batterycabletocontactground

withnegative()cableconnected.Resultingsparkscan

causeabatteryexplosion,whichcouldresultindeathor

seriousinjury.(00069a)

1.Placethefullychargedbatteryintothebatterycompartment.

2.Modelswithsirens:TurntheignitionswitchOFFbeforeconnectingthebattery.

Donotovertightenboltsonbatteryterminals.Use

recommendedtorquevalues.Overtighteningbattery

terminalboltscouldresultindamagetobatteryterminals.

(00216a)

3.Insertboltthroughbatterypositivecable(red)intothreadedholeofbatterypositiveterminal

(2).

4.Tightenboltto6070inlb(6.87.9Nm).

5.Insertboltthroughbatterynegativecable(black)intothreadedholeofbatterynegative

terminal(1).

6.Tightenboltto6070inlb(6.87.9Nm).

Keepbatterycleanandlightlycoatterminalswith

petroleumjellytopreventcorrosion.Failuretodosocould

resultindamagetobatteryterminals.(00217a)

7.Applyalightcoatofpetroleumjellyorcorrosionretardantmaterialtobatteryterminals.

8.Installbatterysidecover.

9.SeeBattery.Installsidecoverscrew(3).Tightento2040inlbs(2.264.52Nm).

Afterinstallingseat,pullupwardonseattobesureitis

lockedinposition.Whileriding,alooseseatcanshift

causinglossofcontrol,whichcouldresultindeathor

seriousinjury.(00070b)

10.Installseat.SeeSeat.

1.Negative()batteryterminal

2.Positive(+)batteryterminal

3.Sidecoverscrew

4.Batterystrap

Battery

JumpStarting

Jumpstartingamotorcycleisnotrecommended.However,incircumstanceswhenajumpstartis

necessary,usethefollowingprocedure.

Besurejumpercablestouchonlyappropriatebattery

terminalsorground.Allowingjumpercablestotoucheach

othercanresultinsparksandabatteryexplosion,which

couldresultindeathorseriousinjury.(00072a)

Explosivehydrogengas,whichescapesduringcharging,

couldcausedeathorseriousinjury.Chargebatteryina

wellventilatedarea.Keepopenflames,electricalsparks

andsmokingmaterialsawayfrombatteryatalltimes.

KEEPBATTERIESAWAYFROMCHILDREN.(00065a)

Besurebothvehicleshavethesamebatteryvoltagewhen

jumpstarting.Connectingvehicleswithdifferentsystem

voltagescanresultinvehicledamage.(00220c)

NOTES:

DONOTjumpstartfromarunningBOOSTERvehicle.Thehighoutputchargingsystemson

somevehiclescandamagethemotorcycle'selectricalcomponents.

MakesurethemotorcycleandtheBOOSTERvehiclearenottouchingoneanother.

Connection

1.Turnoffallunnecessarylampsandaccessories.

2.SeeJumpStartCableConnections.Connectoneendofajumpercabletothe

motorcycleDISCHARGEDbatterypositiveterminal(1).

3.ConnecttheotherendofthesamecabletotheBOOSTERvehiclebatterypositiveterminal

(2).

Donotconnectnegative()cabletoornearthedischarged

batterynegative()terminal.Doingsocouldcauseaspark

andexplosion,whichcouldresultindeathorserious

injury.(00073a)

4.ConnectoneendofajumpercabletotheBOOSTERvehiclebatterynegativeterminal(3).

Donotconnectthenegative()cabletopaintedorchrome

parts.Doingsocouldresultindiscolorationatthe

attachmentpoint.(00221a)

5.Connectotherendofthesamecable(4)toasafemotorcyclegroundawayfromthe

DISCHARGEDbattery.

6.Startthemotorcycle.

Disconnection

1.SeeJumpStartCableConnections.Withthemotorcyclecontinuingtorun,removethe

negativejumpercablemotorcycleground(4).

2.RemovethenegativejumpercablefromtheBOOSTERvehiclebatterynegativeterminal

(3).

3.RemovethepositivejumpercablefromtheBOOSTERvehiclebatterypositiveterminal(2).

4.RemovethepositivejumpercablefromtheDISCHARGEDmotorcyclebatterypositive

terminal(1).

1.Dischargedbatterypositiveterminal

2.Boosterbatterypositiveterminal

3.Boosterbatterynegativeterminal

4.Ground

JumpStartCableConnections

Fuses

SeeFuseBlock.Themotorcyclehasthefollowingthreefusestoprotectelectricalsystems.

Mainfuse(1):A40Afusethatprotectsallthecircuitsincludingthoseprotectedbythe15A

Batteryfuse.Failureofthisfusecausesthemotorcycletostoprunning.SeeaHarleyDavidson

dealer.

P&Afuse(2):A15Afusethatprotectsthecircuitsofanyinstalledaccessories.

Batteryfuse(3):A15Afusethatprotectsallthecircuits.Ifthebatteryfusefailswhiletheengine

isrunning,theenginecontinuestorunandcriticalcircuitsliketheABSbrakescontinueto

function.Thefailureofthisfusetriggersadiagnosticcode.SeeaHarleyDavidsondealer.

Allotherelectricalprotectionforthemotorcycleisaccomplishedbythebodycontrolmodule

(BCM).TheBCMsensesconditionsforindividualcircuits,interruptspowerasneeded,andresets

circuits.Ifreplacingafuseorcyclingpowertothemotorcycledoesnotresolvetheproblem,seea

HarleyDavidsondealer.

FuseReplacement

1.SeeFuseBlockLocation.Pullthetabonthebottomoftheleftsidecover.Removethe

cover.

2.SeeFuseBlock.Replacesuspectfusewithanewfuse.

3.Installleftsidecover.Pushthecoveruntilitsnapstothetopandbottomtabs.

1.Main

2.P&A

3.Battery

FuseBlock

1.Fuseblock

2.Leftsidecovertab

FuseBlockLocation

Seat

Removal:FXDWG

1.SeeSeat.Removescrew(1)fromthepassengerpillion(2).

2.Slidethepillionforwardtoreleasefromtheshoulderbolt(7).

3.Removetheshoulderbolt(7),seatstrap(3),andshoulderwasher(8).

4.Slideseat(4)towardtherearofthemotorcycleandremove.

Installation:FXDWG

1.Putseatonframebackbone.

2.SeeSeat.Slideseat(4)towardfrontofmotorcycle,engagingfronttabofseatunderthefuel

tankmount.

3.Aligntabonrearofseat,holesinseatstrap(3),andwasher(8)withtheholeinthefender.

4.Installshoulderbolt(7)andtightensecurely.

5.Slidepillion(2)throughseatstrapandaligntheslotunderthepillionwiththeheadofthe

shoulderbolt(7).

6.Slidepillionbackwarduntilfirmlysecuredontheshoulderbolt.

7.Installscrew(1)andtightensecurely.

Afterinstallingseat,pullupwardonseattobesureitis

lockedinposition.Whileriding,alooseseatcanshift

causinglossofcontrol,whichcouldresultindeathor

seriousinjury.(00070b)

8.Pulluponseat,pillionandseatstraptoverifythateverythingisproperlysecured.

Removal:AllOtherModels

1.SeeSeat.Removescrew(1).

2.Fortwoupseats,raiseseatslightlyandremovenut(9)andwasher(10)frommountingstud

underseat.Removeseatstrap(3).

3.Slideseattotherearofthemotorcycleandremove.

Installation:AllOtherModels

1.SeeSeat.Putseat(5,6,11)onframebackbone.

2.Slideseattowardfrontofmotorcycle,engagingfronttabofseatunderthefueltankmount.

3.Installwasher(10)andnut(9)tosecureseatstrap(3)tomountingstudunderseat.Tighten

to6090inlb(6.710.2Nm).

4.Installscrew(1)andtightensecurely.

Afterinstallingseat,pullupwardonseattobesureitis

lockedinposition.Whileriding,alooseseatcanshift

causinglossofcontrol,whichcouldresultindeathor

seriousinjury.(00070b)

5.Pulluponseat(5,6,11)andstrap(3)toverifythateverythingisproperlysecured.

1.Screw

2.Passengerpillion:FXDWG

3.Seatstrap

4.Soloseat:FXDWG

5.Soloseat:FXDB,FXDBP

6.Twoupseat(typical)

7.Shoulderbolt

8.Shoulderwasher

9.Nut

10.Washer

11.Seat:FXDL

12.Seat:FXDLS

Seat

LumbarPad:FXDL

Removal

NOTES:

Determineiflumbarpadisdesiredbeforeadjustinghandlebarsandrisers.

Toallowforreuse,installlumbarpadscrewsintobackoflumbarpadafterremoval.

1.SeeLumbarPad.Removeseat.

2.Removescrews(1)andwashers(2)fromthelumbarpad(4).

3.Removescrews(3)fromthenameplate(5).

4.Removenameplatefromlumbarpad.

5.Placenameplateonseat.

6.Installscrewsintonameplate.Tightenscrews.

Installation

1.SeeLumbarPad.Removescrews(3)fromnameplate(5).

2.Placenameplateonlumbarpad(4).

3.Installscrewsinnameplate.Tightenscrews.

4.Insertlumbarpadonseat.

5.Installscrews(1)andwashers(2)tolumbarpad.Tightenscrews.

6.Installseat.

1.Screw(2)

2.Washer(2)

3.Screw(2)

4.Lumbarpad

5.Nameplate

LumbarPad

MotorcycleStorage

PlacingMotorcycleinStorage

Properstorageisimportantforthetroublefreeoperation

ofyourmotorcycle.SeeyourOwner'sManualforstorage

recommendationsorseeaHarleyDavidsondealer.

Improperstorageprocedurescanleadtoequipment

damage.(00046a)

Ifthemotorcycleisnottoberiddenforseveralmonths,suchasduringthewinterseason,there

areseveraltaskswhichmustbeperformed.Thesestepsprotectpartsagainstcorrosion,preserve

thebatteryandpreventthebuildupofgumandvarnishinthefuelsystem.

Ifpossible,storethemotorcycleinadryareawithastabletemperature.Keepthemotorcycle

awayfromharshchemicalsorothersubstancessuchasfertilizersorsalt.

Donotstoremotorcyclewithgasolineintankwithinthe

homeorgaragewhereopenflames,pilotlights,sparksor

electricmotorsarepresent.Gasolineisextremely

flammableandhighlyexplosive,whichcouldresultin

deathorseriousinjury.(00003a)

NOTE:

Makealistofeverythingyoudoandfastenittoahandgrip.Whenyoutakethemotorcycleoutof

storage,thislistisyourreference/checklisttogetyourmotorcycleinoperatingcondition.

1.Fillfueltank.Addfuelstabilizerfollowingmanufacturer'sinstructions.

2.Warmmotorcycletooperatingtemperature.Changeoilandturnengineovertocirculatethe

newoil.

3.Checkandadjustbeltifnecessary.

4.Checktirepressure.RefertoSpecifiedTiresforspecifiedpressure.

5.Protectthebodypanels,engine,chassisandwheelsfromcorrosion.Followthecosmetic

careproceduresdescribedintheCareandCleaningsectionbeforestorage.

6.Preparebatteryforstorage.SeeBatteryMaintenance.

Explosivehydrogengas,whichescapesduringcharging,

couldcausedeathorseriousinjury.Chargebatteryina

wellventilatedarea.Keepopenflames,electricalsparks

andsmokingmaterialsawayfrombatteryatalltimes.

KEEPBATTERIESAWAYFROMCHILDREN.(00065a)

NOTES:

Ifthemotorcycleisbeingstoredwiththesecuritysystemarmed,connecta750mA

SUPERSMARTBATTERYTENDER66000038tomaintainbatterycharge.

Ifthemotorcycleisbeingstoredwiththesecuritysystemdisarmed,turnonthe

motorcyclewhilethehandsfreefobispresent.Thisoperationpreventstheoptional

sirenfromsounding.Disconnectthenegativebatterycableandpreparebatteryfor

storage.SeeBatteryMaintenance.

7.Useamaterialsuchaslightcanvasthatcanbreathetocoverthemotorcycle.Plastic

materialsthatdonotbreathepromotetheformationofcondensation.

8.Removetheantennasorallowthemtoprotrudethroughthecover,ifequipped.Donotbend

ortuckantennasunderthecover.

RemovingMotorcyclefromStorage

Theclutchfailingtodisengagecancauselossofcontrol,

whichcouldresultindeathorseriousinjury.Priorto

startingafterextendedperiodsofstorage,place

transmissioningearandpushvehiclebackandforth

severaltimestoassureproperclutchdisengagement.

(00075a)

NOTE:

Lubricantscontaminatedwithwaterhaveamilkywhiteappearance.Replacecontaminated

lubricantswiththeappropriatenewHarleyDavidsonlubricant.

1.Chargethebattery.

2.Installbattery.SeeBatteryMaintenance.

3.Runmotorcycleuntilengineisatnormaloperatingtemperature.Turnoffengine.

4.Checkengineoillevel.

5.Checklubricantlevel.

6.Checkcontrolstomakesurethattheyareoperatingproperly.Operatethefrontandrear

brakes,throttle,clutchandshifter.

7.Checksteeringforsmoothnessbyturningthehandlebarsthroughthefulloperatingrange.

Besuretiresareproperlyinflated,balanced,undamaged,

andhaveadequatetread.Inspectyourtiresregularlyand

seeaHarleyDavidsondealerforreplacements.Riding

withexcessivelyworn,unbalanced,improperlyinflated,

overloadedordamagedtirescanleadtotirefailureand

adverselyaffectstabilityandhandling,whichcouldresult

indeathorseriousinjury.(00014b)

8.Checktirepressure.RefertoSpecifiedTiresforspecifiedpressure.

9.Checkoveralltirecondition.SeeTireReplacement.

10.Testallswitchesandlightsforproperoperation.

11.Checkforanyfluidleaks.

Turnengineoverafewtimestobesurethereisnooilin

thecrankcaseandthatalloilhasbeenpumpedbackinto

theoiltank.Stopengineandrecheckoillevel.Failureto

dosocanresultinenginedamage.(00071a)

CareandCleaning

CleaningandGeneralCare

Cleanandprotectthecosmeticsurfacesonyourmotorcycleasoftenaspossibletoinhibitrust

andcorrosion.Afterthemotorcycleiscleaned,polishandsealthemotorcycletocreateabarrier

ofprotectionagainsttheweatherandharshsubstances.

HarleyDavidsoncleaningproductsaretestedextensivelyforuseonvehiclesurfaces.These

productsareformulatedtobecompatiblewithoneanother.SeeaHarleyDavidsondealerto

purchaserecommendedcleaningproducts.RefertoRecommendedCleaningandCare

ProductsandRecommendedSurfaceCareProducts.

NOTES:

Userecommendedsurfacecareproducts.Donotusepapertowels,terrycloths,cloth

diapersorothermaterialswithnylonfiberswhichcancreatefinescratchestosurfaces.

Dirtycleaningmaterialscanscratchfinishedsurfaces.Useonlycleanspongesanddetailing

clothstopreventdamagetothemotorcycle.

Forrepairofscratchedsurfaces,seeaHarleyDavidsondealer.

Observewarningsonlabelsofcleaningcompounds.

Failuretofollowwarningscouldresultindeathorserious

injury.(00076a)

Donotwashbrakediscswithcleanerscontainingchlorine

orsilicone.Cleanerscontainingchlorineandsiliconecan

impairbrakefunction,whichcouldresultindeathor

seriousinjury.(00077a)

Donotuseapressurewashertocleanmotorcycle.Usinga

pressurewashercanresultinequipmentdamage.(00489c)

Useofabrasiveproductsorpoweredbuffingequipment

willcausepermanentcosmeticdamagetobodypanels.

Useonlyrecommendedproductsandtechniquesoutlined

inthismanualtoavoiddamagingbodypanels.(00245b)

RecommendedCleaningandCareProducts

PRODUCT

PARTNO.

PURPOSE FRAME BODY

PANELS

WHEELS DENIM

FINISH

OTHER

BARE

ALUMINUM

WHEEL

PROTECTANT

INDIVIDUAL

WIPES

Corrosioncontrolforbare

aluminumsurfaces.

No No Yes No "Burst"

collection

93600063

BAREMETAL

POLISH

93600028(U.S.)

93600083(Non

U.S.)

Polishesnonclearcoated

polishedaluminumor

polishedstainlesssteel

surfaces.

Asapplicable

BLACK

LEATHER

REJUVENATOR

93600033(U.S.)

93600081(Non

U.S.)

Rejuvenatesblackleather

productssotheylook

brandnew.

No No No No Black

leather

goods

BOOTMARK

REMOVER

93600001(U.S.)

93600069(Non

U.S.)

Removesbootmarksfrom

chromeexhaust

components.

No No No No Exhaust

system

BUGREMOVER

93600022(U.S.)

93600075(Non

U.S.)

Removesbugsfrom

metal,plasticorpainted

surfaces.Alsoavailable

asindividualwipes

(93600065).

Yes Yes Yes Yes

CHROMECLEAN

&SHINE

93600031(U.S.)

93600082(Non

U.S.)

Shineschromeplated

surfacesandcleans

brushedaluminumor

stainlesssteelsurfaces.

Asapplicable

DENIMPAINT

CLEANER

93600064(U.S.)

93600078(Non

U.S.)

Waterlessquickcleaner

anddetailer.

Yes Yes Yes Yes

ENGINE

BRIGHTENER

93600002(U.S.)

93600068(Non

U.S.)

Rejuvenateswrinkleblack

enginefinish.

No No No No Wrinkle

black

engines

GLAZEPOLY

SEALANT

Providesaprotective

barrierforglossypaint

surfacesandchrome.

Yes Yes As

applicable

93600026(U.S.)

93600079(Non

U.S.)

GLOSS

DETAILER

93600062(U.S.)

93600073(Non

U.S.)

Produceshighglosswith

UVprotection.Allows

chrometobreathe,unlike

wax.Goodfor

windshields.Also

availableasindividual

wipes(9740110).

Yes Yes Yes No

HARLEY

TRAVELCARE

KIT

93600007

Travelsizecleaningand

careproducts.

Yes Yes Yes Yes

LEATHER

PROTECTANT

93600034(U.S.)

93600080(Non

U.S.)

Weatherproofsand

preservesleather

products.

No No No No Leather

goods

QUICKWASH

93600012(U.S.)

93600071(Non

U.S.)

Aquickwashforalightly

soiledmotorcycle.Cleans

allsurfaces,sheeting

actionpreventsspots.

Yes Yes Yes Yes

SCRATCH&

SWIRLREPAIR

93600025(U.S.)

93600074(Non

U.S.)

Removesfinescratches

andswirls.

Yes Yes No No

SEAT,

SADDLEBAG&

TRIMCLEANER

93600010

Cleansandconditions

vinyl,leatherandplastic.

Useonseats,

saddlebags,innerfairings

andanyothertrim.

No No No No Seats,

saddlebags

andtrim

SPRAY

CLEANER&

POLISH

93600029(U.S.)

93600084(Non

U.S.)

Aerosolquickcleanerand

detailer.Reducesstatic

attractiontodust.Works

greatforremovingbugs.

Yes Yes Yes No

SUNWASHBIKE

SOAP

93600023(U.S.)

Thoroughwashingofall

surfaceswithawashmitt.

Reduceshardwaterspots

whenwashinga

motorcycleinthesun.

Yes Yes Yes Yes

93600077(Non

U.S.)

WHEEL&TIRE

CLEANER

93600024(U.S.)

93600076(Non

U.S.)

Removesbrakedustand

roadgrimefromwheels,

tiresandwhitewalls.Do

notuseonframesor

anodizedparts.

No No Yes No Black

coated

exhaust

pipesand

mufflers

WINDSHIELD

CLEANER

93600067

Quickwindshieldcleaner

inconvenientsingleuse

wipe.

Yes Yes No No Windshield

WINDSHIELD

WATER

REPELLENT

93600032

(Global)

Allowswatertobeadand

dissipatefromthe

windshield.

No No No No Windshield

RecommendedSurfaceCareProducts

PRODUCT

PARTNO.

PURPOSE

BUGEATER

SPONGE

93600110

WhenpairedwithwaterandBUGREMOVER,theBUGEATER

SPONGEbreaksdownanddissolvesbakedonbugsandroadgrime.

CLEANINGBRUSH

KIT

9484410

Brushkitfordetailingyourmotorcycle.

DETAILINGSWABS

93600107

Largecottonswabsforcleaningcrevicesanddetailedsurfaces.

DISPOSABLE

DETAILINGSOFT

CLOTH

93600114

NonabsorbentclothforapplyingandbuffingSWIRL&SCRATCH

REPAIRandGLAZEPOLYSEALANTtopaintedsurfacesorchrome.

HARLEYWASH

BUCKET

9481110

Washbucketwithaprontoholdyoursupplies.IncludesGRITGUARD

insert.

HOGBLASTER

MOTORCYCLE

DRYER

9465109(120V)

Blowsastreamofwarmdryfilteredair.Reducesstreaksandwater

spots.

9486509(220V)

MICROFIBER

DETAILINGCLOTH

9466302

Highlyabsorbentdetailingclothforpolishingandsealing.Containsno

nylonfibers.

SYNTHETICDRYING

CHAMOIS

9479101

Extraabsorbent,nonstreakingsynthetictowelfordrying.Dampentowel

andwringoutbeforeusingforgreatestabsorbency.

WASHMITT

9476099

Absorbentwoolblendedwashingmitten.

WHEEL&SPOKE

BRUSH

4307899

Coneshapedscrubbrushforwheels.

WashingtheMotorcycle

Useonlyrecommendedcleaningandcareproducts.RefertoRecommendedCleaningand

CareProductsandRecommendedSurfaceCareProducts.

NOTE:

Duringrinsingandwashing,avoiddirectsprayonelectricalcomponentsandanyluggageor

saddlebagsealingareas(ifequipped).Avoidsprayingwaterunderleathersaddlebagcovers(if

equipped).

Preparation

1.Allowmotorcycletocoolbeforerinsingorwashing.Sprayingwateronhotsurfacescan

leavewaterspotsandmineraldeposits.

2.Rinsethemotorcyclefromthebottomup.

3.Toloosendriedbugsorhardeneddirt,allowsurfacestosoakunderadamptowel.

CleaningWheelsandTires

1.Rinsewheelandtiresurfaces.Avoidsplashingbrakedustonchromeorpaintedparts.

2.ApplyWHEEL&TIRECLEANER.Allowcleanertosetforoneminute.

3.CleanthewheelwithaBUGEATERSPONGEorWHEEL&SPOKEBRUSH.Thoroughly

scruballbrakedustandothersedimentsoffthewheel.Accumulatedbrakedustcantrap

moistureanddirt,whichleadstowheelcorrosion.

4.Rinsewell.

WashingtheMotorcycle

NOTE:

Seetheappropriateinstructionsinthissectionforcleaningleather,denim(flat)finishes,

windshieldsorotherspecialsurfaces.

1.Ifnecessary,useBUGREMOVERtoremovebugsplatters.

a.Rinsetheaffectedsurfacesduringpreparation.

b.SpraytheareawithBUGREMOVER.

c.WaitoneminutewhiletheBUGREMOVERpenetratesthebugsplatters.

d.UsetheBUGEATERSPONGEwhilewashingtoeasilyremovebugs.

2.Preparethewash.

a.FillaHARLEYWASHBUCKETwithcleanwater.

b.AddSUNWASHBIKESOAP,followingthedirectionsonthepackage.

c.SoaktheWASHMITTand/oraBUGEATERSPONGEintheSUNWASHsolution.

3.Washallsurfacesstartingatthetopworkingdowntowardtheground.

4.Rinsethemotorcycletwiceinbothdirections:

a.Rinsefromthebottomup.

b.Rinsefromthetopdown.

DryingtheMotorcycle

1.DrythesurfacesfromthetopdownusingaSYNTHETICDRYINGCHAMOISoraHOG

BLASTERMOTORCYCLEDRYER.Avoidusinganytypeofforcedaironspeakersorother

sensitivecomponents.

2.Dampenchamoisincleanwaterandwringouttheexcess.Thechamoisismoreabsorbent

whenwet.

3.Wipeacrossthevehiclesurface.

4.Repeatasnecessaryuntilsurfaceisdry.

PolishingandSealing

NOTE:

Ifmotorcyclehasdenimfinish,skipthePolishingandSealingprocedure.

1.ApplyGLAZEPOLYSEALANTwithaDISPOSABLEDETAILINGSOFTCLOTHor

MICROFIBERDETAILINGCLOTH,followingtheinstructionsonthepackage.

2.BuffwithaDISPOSABLEDETAILINGSOFTCLOTH.

3.Polishandsealthewheelstopreventcorrosion.

DenimFinishCare

Somemotorcycleshaveadenim(flatormatte)finish.Thedenimfinishhasqualitieswhichdiffer

fromhighglossfinishesonallotherHarleyDavidsonmotorcycles.Likedenimfabric,denimpaint

burnishesormarswithageandusethataddscharacterandpersonalitytothefinish.Referto

RecommendedCleaningandCareProductsforrecommendedproducts.

Ifscratched,thecolorcoatofpaintdoesnick/scuffandthesemarkscannotberubbedout.

Ifpolished,thefinishwillbecomelessmatteandmoreglossyovertime.

HowtoClean

Forlightdeposits:UseDENIMPAINTCLEANERandaMICROFIBERDETAILINGCLOTH.

Thistreatmenthelpsremovefingerprintsandlightsoil.

Forheavierdeposits:UseeitherSUNWASHBIKESOAPandacleanWASHMITTorQUICK

WASH.Rinsethoroughlywithcleanwater.

LeatherandVinylCare

Donotusebleachordetergentscontainingbleachon

saddlebags,seats,tankpanelsorpaintedsurfaces.Doing

socanresultinequipmentdamage.(00229a)

Donotuseordinarysoaptocleanleatherorfur.Itcoulddryorremovetheoilsfromtheleather.

Leather,vinylandothersyntheticsurfacesmustbeperiodicallycleanedandtreatedtomaintain

itsappearanceandextenditslife.Cleanandtreatthesesurfacesonceaseasonormore

frequentlyunderadverseconditions.

Thesesurfacesarenotdesignedforlongtermexposuretoinclementweather.Protectthese

surfaceswithanHARLEYDAVIDSONSEATRAINCOVERorMOTORCYCLESTORAGE

COVER(soldseparately).

1.Vacuumorblowdustoffsurface.

2.ThoroughlycleansurfaceswithSEAT,SADDLEBAG&TRIMCLEANER,following

directionsonthebottle.

3.Allowthematerialtodrynaturallyandcompletelyatroomtemperaturebeforeapplyingother

productstothematerial.Donotuseartificialmeanstodrythematerialquickly.

4.Forleatheronly,rejuvenatefadedblacksurfaceswithBLACKLEATHERREJUVENATOR.

ApplyLEATHERPROTECTANTtoweatherproofandpreservetheleather.

NOTE:

ManyHarleyDavidsonaccessoriesandseatsaremadeofeithertreatedoruntreatedleatheror

haveleatherinserts.Naturalmaterialsagedifferentlyandrequiredifferentcarethanmanmade

materials.Seatcoversandpanelsmadeofleathergain"character",suchaswrinkles,withage.

Leatherisporousandorganicandeachleatherproductsettlesintoitsowndistinctformwithuse.

Yourleatherproductmaturesintoitsowncustomshapeandstylefromthesun,rainandtime.

ThismaturingisnaturalandenhancesthecustomqualityofyourHarleyDavidsonmotorcycle.

WheelCare

Wheelscancorrodeorbecosmeticallydamagediftheyarenotproperlycleaned,polishedand

preserved.Cleaningandsealingwheelswiththepropertreatmentguardsagainstpitting,

corrosion,spotsandstains.HarleyDavidsonrecommendsthatwheelsbecaredforweekly.

Corrosiontowheelsisnotconsideredadefectinmaterialsorworkmanship.

NOTE:

Barealuminumwheelsdonothaveaprotectivecoatingandcorrodeunlessproperlytreated.

ApplyBAREALUMINUMWHEELPROTECTANTwhenpurchasingthemotorcycleandatleast

twiceperyeartopreventcosmeticdamage.

Keepwheelscleanfromharshchemicals,acidbasedwheelcleaners,saltandaccumulatedbrake

dust.AfterwashingwheelswithWHEEL&TIRECLEANER,usethepolishandsealingproducts

accordingtothetypeofwheels.RefertoWheelPolishandSealingProducts.

WheelPolishandSealingProducts

WHEELS PRODUCT DESCRIPTION

Anodized GLAZEPOLY

SEALANT

Cleanssurface,removesfinescratches.Providesa

breathablesealantagainstacid,chemicals,saltand

brakedust.

GLOSSDETAILER Sealsandprotectsagainstharshchemicals,saltand

othersedimentstopreventcorrosion.

Barealuminum BAREALUMINUM

WHEEL

PROTECTANT

Createsaprotectivecoatingforbarealuminumwheels

topreventoxidation.Individualwipe.

Chrome CHROMECLEAN&

SHINE

Nonabrasivecleanertobrightenchromewheels.

GLOSSDETAILER Sealsandprotectsagainstharshchemicals,saltand

othersedimentstopreventoxidation.

Polished

aluminumor

stainlesssteel

BAREMETAL

POLISH

Microabrasivepolishtorefurbishpolishedwheels.Do

notuseonchrome.

WindshieldCare

Polycarbonatewindscreens/windshieldsrequireproper

attentionandcaretomaintain.Failuretomaintain

polycarbonateproperlycanresultindamagetothe

windscreen/windshield.(00483d)

UseonlyHarleyDavidsonrecommendedproductson

HarleyDavidsonwindshields.Donotuseharshchemicals

orrainsheetingproducts,whichcancausewindshield

surfacedamage,suchasdullingorhazing.(00231c)

Powdered,abrasiveoralkalinecleansercandamagewindscreen/windshields.Ammonia

basedwindowcleanerscausepermanentyelloweffectstowindshields.

Donotusegasstationwindshieldcleanerasfinishcanbedamaged.

Donotuseabrushorsqueegeeasfinishcanbedamaged.

Donotcleaninhotsunorhightemperature.

Windshieldsrequirespecialcare.However,windshieldscanbewashedwithWINDSHIELD

CLEANERINDIVIDUALWIPES,SUNWASHBIKESOAPorQUICKWASHwhenwashingthe

entiremotorcycle.RefertoRecommendedCleaningandCareProducts.

NOTES:

TotreatwindshieldswithwaterrepellentuseWINDSHIELDWATERREPELLENT.

UseBUGREMOVERtosoftbugsplatters.WipecleanwithaBUGEATERSPONGE.

Coveringwindshieldswithaclean,wetclothforapproximately1520minutesbefore

washingmakesdriedbugremovaleasier.

1.UseWINDSHIELDCLEANERtodetailwindshields.

2.WipedrywithacleanMICROFIBERDETAILINGCLOTH.

NOTE:

Tominimizeswirlmarks,cleanwindshieldwhenthemotorcycleiscoolandparkedintheshade.

Faintswirlmarksarenormal.Swirlmarksaremorevisibleontintedwindshields.

HardCandyCustomPaint

HardCandyCustompaintfeaturesauniquecoatingwhichmayincludeflakesofvariedcolorand

size.Thesurfacemayhaveanuneventexture,resultingfrommultiplelayersofclearcoatbeing

appliedoverheavyconcentrationsofmetallicflake.Eachparthasitsowndistinctandcustom

appearance.Thesearenormalcharacteristicsofthecustompaintprocess,anddonotreflect

warrantableconditions.

Troubleshooting

Troubleshooting:General

ThetroubleshootingsectionoftheOwner'sManualisa

guidetodiagnoseproblems.Readtheservicemanual

beforeperforminganywork.Improperrepairand/or

maintenancecouldresultindeathorseriousinjury.

(00080a)

Usethefollowingchecklistsfortroubleshooting.Carefullycheckeachcausebecausemorethan

oneconditioncancausetrouble.

Engine

StarterDoesNotOperateorDoesNotTurnEngineOver

1.EngineOFF/RUNswitchoff.

2.Ignitionswitchoff.

3.Dischargedbatteryorlooseorcorrodedconnections(solenoidchatters).

4.Clutchlevernotsqueezedagainsthandlebarortransmissionnotinneutral.

5.Jiffystandnotinretractedposition(formodelsequippedwithjiffystandinterlock).

6.Blownfuse.

EngineTurnsOverButDoesNotStart

1.Fueltankempty.

2.Fuelfilterclogged.

3.Dischargedbatteryorlooseordamagedbatteryterminalconnections.

4.Fouledsparkplugs.

5.Sparkplugcableconnectionslooseorinbadconditionandshorting.

6.Looseorcorrodedwireorcableconnectionatcoilorbattery.

7.Fuelpumpinoperative.

8.Blownfuse.

StartsHard

1.AutomaticCompressionRelease(ACR)notfunctioningproperly.

2.Sparkplugsinbadcondition,haveimpropergaporarepartiallyfouled.

3.Sparkplugcablesinbadconditionandleaking.

4.Batterynearlydischarged.

5.Loosewireorcableconnectionatoneofthebatteryterminalsoratcoil.

6.Engineoiltooheavy(coldweather).

7.Fueltankventpluggedorfuellineclosedoff,restrictingfuelflow.

8.Waterordirtinfuelsystemorfilter.

9.Fuelpumpinoperative.

StartsButRunsIrregularlyorMisses

1.Sparkplugsinbadconditionorpartiallyfouled.

2.Sparkplugcablesinbadconditionandleaking.

3.Sparkpluggaptoocloseortoowide.

4.Batterynearlydischarged.

5.Damagedwireorlooseconnectionatbatteryterminalsorcoils.

6.Intermittentshortcircuitduetodamagedwireinsulation.

7.Waterordirtinfuelsystemorfilter.

8.Fuelventsystemplugged.Seedealer.

9.Oneormoreinjectorsfouled.

ASparkPlugFoulsRepeatedly

1.Fuelmixturetoorich.

2.Incorrectsparkplugforservice

PreignitionorDetonation(KnocksorPings)

1.Incorrectfuel.

2.Incorrectsparkplugforservice

Overheats

1.Insufficientoilsupplyoroilnotcirculating.

2.Heavycarbondepositfromluggingengine.Seedealer.

3.Insufficientairflowovercylinderheadsduringextendedperiodsofidlingorparadeduty.

ExcessiveVibration

1.Rearforkpivotshaftloose.Seedealer.

2.Frontenginemountingboltsloose.Seedealer.

3.Frontchainorlinkstightasaresultofinsufficientlubricationorbeltbadlyworn.

4.Enginetotransmissionmountingboltsloose(applicablemodels).Seedealer.

5.Damagedframe.Seedealer.

6.Wheelsand/ortiresdamaged.Seedealer.

7.Vehiclenotproperlyaligned.Seedealer.

EngineOilNotCirculating(OilPressureLampLit)

1.Insufficientordilutedoilsupply.

2.Oilfeedcloggedwithiceandsludgeinfreezingweather.

3.Groundedoilsignalswitchwireorfaultysignalswitch.Seedealer.

4.Damagedorimproperlyinstalledcheckvalve.Seedealer.

5.Oilpumpproblem.Seedealer.

ElectricalSystem

AlternatorDoesNotCharge

1.Regulatornotgrounded.Seedealer.

2.Enginegroundwirelooseordamaged.Seedealer.

3.Looseordamagedwiresinchargingcircuit.Seedealer.

AlternatorChargeRateisBelowNormal

1.Weakbattery.

2.Excessiveuseofaddonaccessories.

3.Looseorcorrodedconnections.

4.Extensiveperiodsofidlingorlowspeedriding.

Transmission

TransmissionShiftsHard

1.Bentshifterrod.Seedealer.

TransmissionJumpsOutofGear

1.Wornshifterdogsintransmission.Seedealer.

ClutchSlips

1.Clutchcontrolsimproperlyadjusted.Seedealer.

2.Wornfrictiondiscs.Seedealer.

3.Insufficientclutchspringtension.Seedealer.

ClutchDragsorDoesNotRelease

1.Clutchcontrolsimproperlyadjusted.Seedealer.

2.Primarychaincaseoverfilled.

3.Clutchdiscswarped.Seedealer.

ClutchChatters

1.Frictiondiscsorsteeldiscswornorwarped.Seedealer.

Brakes

BrakesDoNotHoldNormally

1.Mastercylinderlowonfluid.Seedealer.

2.Brakelinecontainsairbubbles.Seedealer.

3.Mastercylinderpistonworn.Seedealer.

4.Brakepadscontaminatedwithgreaseoroil.Seedealer.

5.Brakepadsbadlyworn.Seedealer.

6.Brakediscbadlywornorwarped.Seedealer.

7.Brakefadesbecauseofheatbuildup.Excessivebrakingorbrakepadsdragging.See

dealer.

8.Brakedrags.Insufficienthandleverfreeplay.Seedealer.

Accessories

GenuineMotorPartsandAccessories

StopatyourHarleyDavidsondealertopickupacopyoftheGenuineMotorPartsand

Accessoriescatalogorgotowww.harleydavidson.comtoviewthousandsofGenuineMotor

AccessoriesthatareavailableforHarleyDavidsonmotorcycles.

Thewebsiteincludesthefollowingtoolsandresourcesforaccessorizingandpersonalizingyour

motorcycle.

OnlineCatalog

ThefullGenuineMotorPartsandAccessoriescatalogisavailableonlineinPDFformat.The

catalogincludeshundredsofpagesofHarleyDavidsonaccessoriesandmaintenanceproducts.

Forperformanceparts,checkouttheScreamin'EagleProRacingPartscatalog.

NOTE:

Performancepartsmaynotbeavailableinsomecountriesduetolocalrestrictions.Seeyour

HarleyDavidsondealerformoreinformation.

ShopforYourBike

Browsethroughcategoriesofaccessoriesandoptionsavailablespecificallyforyourmotorcycle.

Viewproductdescriptions,pricing,fitmentandonlineinstructionsheetsformanyoftheavailable

products.

Customizer

VirtuallyredesignyourmotorcyclewithpartsandaccessoriesusingtheCustomizer.Thistool

allowsyoutoexperimentwithdifferentaccessoryandcolorcombinationsandshowshowyour

motorcyclewouldlookwiththeaccessoriesinstalled.Youcaneasilycreateacustomlistof

accessoriestoprintoutforyourdealer.

FitShop

Learnhowtocustomizeyourmotorcycletofityoupersonally.Seehowmakingchangestothe

suspension,seat,handlebarsorfootcontrolscanenhancetheergonomicsandcomfortofyour

motorcycle.

CustomSeats

Createacustomseatusingselecteddesigns,colorsandtexturedmaterials.Customseat

specificationscanbeeasilyprintedoutforyourdealer.

CustomCoverage

AddAccessoriestoYourNewMotorcycle

NOTE:

CustomCoverageisnotofferedinsomeregions.SeeanauthorizedHarleyDavidsondealerto

determinethepartsandaccessorieswarrantypolicies,termsandconditionsinyourarea.

HarleyDavidsonofferstheCustomCoverageextendedlimitedwarrantyforpartsandaccessories

thatarepurchasedandinstalledatanauthorizedHarleyDavidsondealerwithin60daysafter

retailpurchaseofthemotorcycle.

ThislimitedwarrantyprovidescoverageforeligiblestreetlegalGenuineHarleyDavidsonMotor

PartsandGenuineHarleyDavidsonMotorAccessories.Thisextendedcoverageonpartsand

accessoriesremainsineffectfortheremainderoftheHarleyDavidsonMotorcycleLimited

Warrantyforthevehicle.SeeLimitedMotorcycleWarranty.

PurchasesqualifyingforCustomCoveragemustbemadeatanauthorizedHarleyDavidson

dealershipwithin60daysafterretailpurchase.Additionalpartsandaccessoriesmaybe

purchasedandinstalledasoftenasdesiredwithin60daysafterretailpurchaseofthemotorcycle.

PartsandaccessoriesmustbepurchasedandinstalledatanauthorizedHarleyDavidson

dealershiptoqualifyforCustomCoverage.Partsandaccessoriespurchasedviatheinternetare

noteligible.

WarrantiesandResponsibilities

WarrantyandMaintenance

Thisowner'smanualcontainsyournewmotorcyclelimitedwarrantyandyourowner's

maintenancerecord.

Itisyourresponsibilityastheownertofollowthemaintenancescheduleatthemileageintervals

asspecifiedintheowner'smanual.Allofthespecifiedmaintenanceservicesmustbeperformed

onscheduletokeepyourlimitedwarrantyvalid.

Somecountries,statesorotherlocationsmayrequireallregularmaintenanceandserviceworkto

bedonebyanauthorizedHarleyDavidsondealerforyourlimitedwarrantytoremainineffect.

CheckwithyourauthorizedHarleyDavidsondealerforlocalrequirements.

1.MakeanappointmentwithaHarleyDavidsondealerforinspectionandservicepriortothe

first1000mi1600km,andassoonaspossibleafteranyissuearises.

2.Bringthisowner'smanualwithyouwhenyouvisityourauthorizedHarleyDavidsondealer

tohaveyourmotorcycleinspectedandserviced.

3.Havethedealertechniciansignthemaintenancerecordintheowner'smanualattheproper

mileageinterval.Theserecordsshouldberetainedbytheownerasproofofproper

maintenance.

4.Keepreceiptscoveringanyparts,serviceormaintenanceperformed.

Theserecordsshouldbetransferredtoeachsubsequentowner.

UseonlyHarleyDavidsonapprovedpartsandaccessoriesthathavebeendesigned,testedand

approvedforyourmodelandmodelyearmotorcycle.

Useofaftermarketperformancepartsmayvoidallorpartsofyourlimitedwarranty.Seean

authorizedHarleyDavidsondealerfordetails.

HarleyDavidsonauthorizeddealershipsareindependentlyownedandoperatedandmayselland

installpartsandaccessoriesthatarenotmanufacturedorapprovedbyHarleyDavidsonforuse

onyourmotorcycle.Therefore,youshouldunderstandthatHarleyDavidsonisnotandcannotbe

responsibleforthequality,suitability,orsafetyofanynonHarleyDavidsonpart,accessoryor

designmodification,includinglabor,whichmaybesoldand/orinstalledbyauthorizedHarley

Davidsondealerships.

KeepingItAllHarleyDavidson

GenuineHarleyDavidsonpartsareengineeredandtestedspecificallyforuseonyourmotorcycle.

InsistthatyourauthorizedHarleyDavidsondealerusesonlygenuineHarleyDavidson

replacementpartsandaccessoriestokeepyourHarleyDavidsonmotorcycleanditslimited

warrantyintact.NotallHarleyDavidsonpartsandaccessoriesareappropriateforyourmodelor

modelyearmotorcycle.

Itispossibletooverloadyourvehicle'schargingsystem

byaddingtoomanyelectricalaccessories.Ifthecombined

electricalaccessoriesoperatingatanyonetimeconsume

moreelectricalcurrentthanthevehicle'schargingsystem

canproduce,theelectricalconsumptioncandischargethe

batteryandcausedamagetothevehicle'selectrical

system.SeeanauthorizedHarleyDavidsondealerfor

adviceabouttheamountofcurrentconsumedby

additionalelectricalaccessoriesorfornecessarywiring

changes.(00211c)

NOTE:

Installingoffroadorcompetitionpartstoenhanceperformancemayvoidallorpartsofyour

limitedwarranty.SeetheHarleyDavidsonMotorcycleLimitedWarrantyinthisowner'smanualor

anauthorizedHarleyDavidsondealerfordetails.

CaliforniaandSelectInternationalMarketsEvaporativeEmissionControls:

2016Models

Allnew2016HarleyDavidsonmotorcyclessoldintheStateofCaliforniaandselectinternational

marketshaveanevaporativeemissioncontrolsystem.ThissystemisdesignedtomeetCARB

andlocalregulationsineffectatthetimeofmanufacture.

Thesystemrequiresasmallamountofmaintenance.Periodicallyinspectsystemtoverifythat

hosesareproperlyrouted,notkinkedorblockedandthatallfittingsaresecure.Periodicallycheck

mountinghardwarefortightness.

EPANoiseRegulationsintheUnitedStates

EPAnoiseregulationsrequirethatthefollowingstatementsbeincludedintheOwner'sManual.

EPARegulations

TAMPERINGWITHNOISECONTROLSYSTEMPROHIBITED:Federallawprohibitsthe

followingactsorthecausingthereof:(1)Theremovalorrenderinginoperativebyanyperson

otherthanforpurposesofmaintenance,repair,orreplacementofanydeviceorelementofdesign

incorporatedintoanynewvehicleforthepurposeofnoisecontrolpriortoitssaleordeliverytothe

ultimatepurchaserorwhileitisinuse,or(2)theuseofthevehicleaftersuchdeviceorelementof

designhasbeenremovedorrenderedinoperativebyanyperson.

AMONGTHOSEACTSPRESUMEDTOCONSTITUTETAMPERINGARETHEFOLLOWING:

1.Replacingthemuffler(s)and/ortheentireexhaustsystemwithpartsnotcertifiedtobenoise

legalforstreetuse.

2.Removingormodifyingthemufflerinternalbafflesinanyway.

3.Replacingtheairintake/cleanerassemblywithonenotcertifiedtobenoiselegalforstreet

use.

4.Modifyingtheairintake/cleanerassemblyinsuchawayastomakethevehiclenolonger

noiselegalforstreetuse.

HarleyDavidsonrecommendsthatanyandallnoiserelatedmaintenancebedonebyan

authorizedHarleyDavidsondealerusingGenuineHarleyDavidsonparts.

Warranty/ServiceInformation

AnyauthorizedHarleyDavidsondealermayprovidewarrantyrepairworkonyourmotorcycle.

ThefactthatanauthorizedHarleyDavidsondealershipperformswarrantyrepairsdoesnotcreate

anagencyrelationshipbetweenHarleyDavidsonandtheauthorizeddealership.Ifyouhaveany

questionsregardingwarrantyobligationscontactyourauthorizedHarleyDavidsondealer.

Fornormalserviceworkorwarrantyworkundertheaboveconditions,youmayobtainthename

andlocationofyournearestU.S.authorizedHarleyDavidsondealerbycalling18002582464

(U.S.only).Tofinddealersworldwide,seewww.harleydavidson.com.

ReportingSafetyDefectsintheUnitedStates

SafetydefectsmustbereportedtotheNationalHighwayTrafficSafetyAdministration(NHTSA)

andHarleyDavidson.

NHTSAStatement

Ifyoubelievethatyourmotorcyclehasadefectwhichcouldcauseacrashorcouldcauseinjury

ordeath,youshouldimmediatelyinformtheNationalHighwayTrafficSafetyAdministration

(NHTSA)inadditiontonotifyingHarleyDavidson.

IfNHTSAreceivessimilarcomplaints,itmayopenaninvestigation,andifitfindsthatasafety

defectexistsinagroupofmotorcycles,itmayorderarecallandremedycampaign.However,

NHTSAcannotbecomeinvolvedinindividualproblemsbetweenyou,yourauthorizedHarley

Davidsondealer,orHarleyDavidson.

YoucancontactNHTSAthroughthefollowingmeans.Additionalinformationaboutmotorvehicle

safetyisavailablethroughthewebsite.

Telephone:VehicleSafetyHotline(tollfree)at18883274236(TTY:18004249153).

Website:www.safercar.gov

Address:Administrator,NHTSA,400SeventhStreetSW,Washington,DC20590

RequiredDocumentationforImportedMotorcycles

IfaHarleyDavidsonmotorcycleisimportedintotheUnitedStates,additionaldocumentationis

requiredforthatmotorcycletobeeligiblefortheUnitedStatesHarleyDavidsonMotorcycle

LimitedWarranty.AnauthorizedHarleyDavidsondealercanprovideaformexplainingthe

requirements.

OwnerContactInformation

Ifyoumovefromyourpresentaddress,sellyourmotorcycle,orpurchaseapreownedHarley

Davidsonmotorcycle,seeanauthorizedHarleyDavidsondealertoupdateyourownercontact

information.

ThiswillprovideHarleyDavidsonwithanaccurateregistration(asrequiredbylawinsome

countries),andwillallowHarleyDavidsontonotifyyouintheeventofarecallorproductprogram.

TherightsandbenefitsconferreduponyouandtheobligationsofHarleyDavidsonassetforth

hereinareseparateanddistinctfromanyrightsanddutiessetforthinanyservicecontractyou

mayhavepurchasedfromadealershipand/orthirdpartyinsurancecompany.HarleyDavidson

doesnotauthorizeanyentitytoexpandHarleyDavidson'swarrantyobligationsinconnectionwith

yourmotorcycleorthislimitedwarranty.

Whenupdatingyourcontactinformation,yourauthorizedHarleyDavidsondealerwillneedyour

VehicleIdentificationNumber(VIN),odometermileage,anddateofvehicletransfer(ifapplicable).

QuestionsandConcerns

Ifyouhavequestionsorconcernsregardingtheperformanceofyourmotorcycleortheapplication

ofthelimitedwarrantydescribedhere,orarenotsatisfiedwiththeserviceyouarereceivingfrom

anauthorizedHarleyDavidsondealership,dothefollowing:

1.Contactthesellingand/orservicingdealershipandspeaktothesalesand/orservice

manager.

2.Ifyourconcerncannotbeaddressedtoyoursatisfactionbythedealership,contactthe

HarleyDavidsonCustomerSupportCenterbymailingyourconcerntothefollowingaddress

orcallingthephonenumberbelow.

IntheU.S.,statewarrantylaws,oftenreferredtoaslemonlaws,mayprovideyouwithcertain

rightsnotspecificallymentionedhere.Totheextentallowedbyyourstate,HarleyDavidson

requeststhatyoufirstsendwrittennotificationofanydefectorwarrantynonconformitythatyou

haveexperiencedwithyourmotorcycletoHarleyDavidson.HarleyDavidsonappreciatesthe

opportunitytoinvestigateyourconcernsandrestoreyoursatisfactioninyourmotorcycleby

makingthenecessaryrepairsconsistentwiththetermsofHarleyDavidson'slimitedwarranty.

HarleyDavidsonrequeststhatyousendyourcomplainttotheHarleyDavidsonCustomer

SupportCenter.

HarleyDavidsonMotorCompany

Attention:HarleyDavidsonCustomerSupportCenter

P.O.Box653

Milwaukee,Wisconsin53201

18002582464(U.S.only)

14143434056

ThiswarrantydoesnotmeanthateachHarleyDavidsonmotorcycleisfreefromdefects.Defects

maybeunintentionallyintroducedintomotorcyclesduringthedesignandmanufacturing

processesandsuchdefectscouldresultintheneedforrepairs.Forthisreason,HarleyDavidson

providestheLimitedWarrantyinordertoremedyanysuchdefectsthatresultinacomponent

malfunctionorfailureduringthewarrantyperiod.Theremedyunderthiswrittenwarranty,andany

impliedwarranty,islimitedtorepair,replacementoradjustmentofthedefectivepart.This

exclusiveremedyshallnotbedeemedtohavefaileditsessentialpurposesolongasHarley

Davidson,throughitsauthorizeddealers,iswillingandabletorepair,replaceoradjustdefective

partsintheprescribedmanner.HarleyDavidson'sliability,ifany,shallinnoeventexceedthe

costofcorrectinganydefectashereinprovidedanduponexpirationofthiswarranty,anysuch

liabilityshallterminate.

LimitedMotorcycleWarranty

2016HarleyDavidsonMotorcycleLimitedWarranty

24Months/UnlimitedMiles

HarleyDavidsonwarrantsforanynew2016HarleyDavidsonmotorcyclethatanauthorized

HarleyDavidsondealerwillrepairorreplacewithoutchargeanypartsfoundundernormaluseto

bedefectiveinfactorymaterialsorworkmanship.Suchrepairorreplacementofdefectiveparts

willbeHarleyDavidson'ssoleobligationandyoursoleandexclusiveremedyunderthislimited

warranty.Thislimitedwarrantyappliesonlyforthedurationidentifiedbelow.

Noperson,includingHarleyDavidsondealers,maymodify,extendorwaiveanypartofthis

warranty.

Asaconditionofthiswarranty,youareresponsibleforproperlyusing,maintaining,andcaringfor

yourmotorcycleasoutlinedinyourOwnerManual.HarleyDavidsonrecommendsthatyou

maintaincopiesofallmaintenancerecordsandreceipts.

THEREISNOOTHEREXPRESSWARRANTY(OTHERTHANTHESEPARATEEMISSIONS,

NOISE,ANDRADIOLIMITEDWARRANTIES)ONTHEMOTORCYCLE.Anyimpliedwarrantyof

merchantabilityorfitnessforparticularpurposeislimitedtothedurationoftheexpresswarranty,

ortothedurationsetforthinyourstate'swarrantystatutes,whicheverisshorter.Anyimplied

warrantyisnottransferredtosubsequentpurchasers/buyersofthemotorcycle.

Theimpliedwarrantyoffitnessforaparticularpurposedoesnotapplyifyourmotorcycleisused

forracing,evenifthemotorcycleisequippedforracing.

Somestatesdonotallowlimitationsonhowlonganimpliedwarrantylasts,sotheabovelimitation

maynotapplytoyou.

TOTHEFULLESTEXTENTALLOWEDBYLAW,NEITHERHARLEYDAVIDSONNORITS

AUTHORIZEDDEALERSSHALLBELIABLEFORLOSSOFTIME,INCONVENIENCE,LOSS

OFMOTORCYCLEUSE,COMMERCIALLOSSORANYOTHERINCIDENTALOR

CONSEQUENTIALDAMAGES.

HarleyDavidsonandyourdealerarenotresponsibleforanytimeorincomethatyoulose,any

inconvenience,thelossofyourtransportationoruseofyourmotorcycle,thecostofarental

motorcycle,fuel,travel,meals,orlodging,orforanyotherincidentalorconsequentialdamages

youmayhave.

Punitive,exemplary,ormultipledamagesmaynotberecoveredunlessapplicablelawprohibits

theirdisclaimer.Youmaynotbringanywarrantyrelatedclaimasaclassrepresentative,aprivate

attorneygeneral,amemberofaclassofclaimantsorinanyotherrepresentativecapacity.

HarleyDavidsonshallnotbeliableforanydamagescausedbydelayindeliveryorfurnishingof

anyproductsand/orservices.

Somestatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,so

theabovelimitationorexclusionmaynotapplytoyou.

Thiswarrantygivesyouspecificlegalrights,andyoumayalsohaveotherrightswhichvaryfrom

statetostate.

Thefollowingtermsandconditionsapplytothislimitedwarranty:

Duration

1.Thedurationofthislimitedwarrantyistwentyfourmonths,startingfromtheearlierof(a)the

dateofinitialretailpurchaseanddeliveryofthemotorcyclefromanauthorizedHarley

Davidsondealer,or(b)thethirdanniversaryofthelastdayofthemodelyearofthe

motorcycle.YourauthorizedHarleyDavidsondealerwillsubmitanelectronicSalesand

WarrantyRegistrationformtoinitiateyourlimitedwarranty.

2.Anyunexpiredportionofthislimitedwarrantywillbetransferredtosubsequentowners,

upontheresaleofthemotorcycleduringthelimitedwarrantyperiod.

Owner'sObligations

Toobtainwarrantyservice,returnyourmotorcycleatyourexpensewithinthelimitedwarranty

periodtoanauthorizedHarleyDavidsondealer.TheauthorizedHarleyDavidsondealershould

beabletoprovidewarrantyserviceduringnormalbusinesshours,dependingupontheworkload

oftheauthorizeddealer'sservicedepartmentandtheavailabilityofnecessaryparts.

Exclusions

Thislimitedwarrantywillnotapplytoanymotorcycle.

1.Whichhasnotbeenoperatedormaintainedasspecifiedintheowner'smanual.

2.Whichhasbeenabused,neglected,misused,improperlystored,used"offthehighway,"or

usedforracingorcompetitionofanykind.

3.Whichisnotmanufacturedtocomplywiththelawsofthemarketinwhichitisregistered.

4.Whichhasoffroadorcompetitionpartsinstalledtoenhanceperformance,atrailerhitch,or

hasotherunapprovedmodifications(evenifthesemodificationsincludegenuineHarley

Davidsonpartsandaccessoriesthatarenotapprovedforuseonyourmotorcycle).These

modificationsmayvoidallorpartsofyournewmotorcyclelimitedwarranty.Seean

authorizedHarleyDavidsondealerfordetails.

5.WhichhasbeensubjectedtoanactofGod,war,riot,insurrection,nuclearcontamination,

naturaldisasters,including,butnotlimitedto,lightning,forestfires,duststorms,hailstorms,

icestorms,earthquakes,orfloods,orothercircumstancesoutofHarleyDavidson'scontrol.

6.Whichhasbeeninanaccidentorcollisionorhasbeendroppedorstruck.

OtherLimitations

Thislimitedwarrantydoesnotcover:

1.Partsandlaborfornormalmaintenanceasrecommendedintheowner'smanual,orthe

replacementofpartsduetonormalwearandtearincluding,butnotlimitedto,thefollowing:

tires,lubrication,oilandfilterchange,fuelsystemcleaning,batterymaintenance,engine

tuneup,sparkplugs,brake,clutch,chain/beltadjustmentandchainreplacement.

2.Cosmeticconcernsthatariseasaresultofownerabuse,lackofpropermaintenanceor

environmentalconditions(exceptconcernsthatresultfromdefectsinfactorymaterialsor

workmanship,whicharecoveredbythislimitedwarrantyforthedurationofthelimited

warrantyperiod).

3.Anycosmeticconditionexistingatthetimeofretaildeliverythathasnotbeendocumented

bytheauthorizedHarleyDavidsonsellingdealerpriortoretaildelivery.

4.DefectsordamagetothemotorcyclecausedbyalterationsoutsideofHarleyDavidson's

factoryspecificationsorcausedbyalterationsoruseofpartsoraccessoriesnotapproved

forthemakeandmodelyearofyourmotorcycle.

5.DamagecausedbyinstallationoruseofnonHarleyDavidsoncomponents,eventhose

installedbyanauthorizedHarleyDavidsondealership,thatcauseaHarleyDavidsonpartto

fail.Examplesinclude,butarenotlimitedtoperformanceenhancingpowertraincomponents

orsoftware,exhaustsystems,trailerhitches,nonapprovedtires,loweringkits,handlebars,

andaddonsconnectedtothefactoryelectricalsystem.

Important:ReadCarefully

1.AuthorizedHarleyDavidsondealersareindependentlyownedandoperatedandmaysell

nonHarleyDavidsonproducts.Becauseofthis,HARLEYDAVIDSONISNOT

RESPONSIBLEFORTHESAFETY,QUALITY,ORSUITABILITYOFANYNONHARLEY

DAVIDSONPART,ACCESSORYORDESIGNMODIFICATIONINCLUDING,BUTNOT

LIMITEDTO,LABORWHICHMAYBESOLDAND/ORINSTALLEDBYAUTHORIZED

HARLEYDAVIDSONDEALERS.

2.ThislimitedwarrantyisacontractbetweenyouandHarleyDavidson.Itisseparateand

apartfromanywarrantyyoumayreceiveorpurchasefromanauthorizedHarleyDavidson

dealer.AnauthorizedHarleyDavidsondealerisnotauthorizedtoalter,modify,expand,or

inanywaychangethetermsandconditionsofthislimitedwarranty.

3.AnywarrantyworkorpartsreplacementauthorizedbyHarleyDavidsonwillnotpreclude

HarleyDavidsonfromlaterrelyingonanyexclusionwhereapplicable.

4.HarleyDavidsonanditsauthorizeddealersreservetherighttomodifyorservice

motorcyclesdesignedandmanufacturedbyHarleyDavidsonatanytimewithoutincurring

anyadditionalobligationtomakethesamealterationorchangetoamotorcyclepreviously

builtandsold.HarleyDavidsonreservestherighttoprovidepostwarrantyrepairs,conduct

repaircampaigns,offergoodwillorcustomersatisfactionrepairsorextendthewarranty

coverageforcertainmotorcyclesatitssolediscretion.Saidrepairsorextensionsofwarranty

coverageinnowayobligatesHarleyDavidsontoprovidesimilaraccommodationstoother

ownersofsimilarmotorcycles.SometimesHarleyDavidsonmayofferaspecialadjustment

programtopayallorpartofthecostofcertainrepairsbeyondthetermsofyourlimited

warranty.CheckwithyourauthorizedHarleyDavidsondealertolearnwhethersuch

programsareavailabletoyou.Yourstatemayprohibitthesetypesofoffers,inwhichcase,

theymaynotbeavailabletoyou.

5.ThefactthatapartislabeledorbrandedHarleyDavidsondoesnotnecessarilymakeit

appropriateorwarrantedforthemakeandmodelofyourmotorcycle.Theuseofpartsnot

designedandtestedforyourmotorcyclemayhavenegativeconsequencesonthe

performanceofyourmotorcycleandmaycreateconditionsnotcoveredbythislimited

warranty.

LimitedMotorcycleWarranty(Australia)

2016Australia/NewZealandHarleyDavidsonMotorcycleManufacturer's

LimitedWarranty

24Months/UnlimitedMiles

Thismotorcyclelimitedwarranty,referredtobelowasthe"HDMotorcycleWarranty"

appliestoallpersonswhopurchaseanew2016orpriormodelHarleyDavidson

motorcycleinAustraliaandNewZealandonlyafter1stJanuary2016.

YourConsumerRights

ThebenefitsgiventoyouunderthisHDMotorcycleWarrantyareadditionalto,anddonotdetract

from,otherrightsandremediesthatyoumayhaveinrespectofthemotorcycleunderAustralian

andNewZealandlaws,includingconsumerprotectionlaws.

InAustralia,ourgoodscomewithguaranteesthatcannotbeexcludedundertheAustralian

ConsumerLaw.Youareentitledtoareplacementorrefundforamajorfailureandcompensation

foranyotherreasonablyforeseeablelossordamage.Youarealsoentitledtohavethegoods

repairedorreplacedifthegoodsfailtobeofacceptablequalityandthefailuredoesnotamountto

amajorfailure.

InNewZealand,ourgoodsalsocomewithguaranteesthatcannotbeexcludedundertheNew

ZealandConsumerGuaranteesAct.

Warranty

ThisHDMotorcycleWarranty,isprovidedbyHarleyDavidson,MotorCompany,P.O.Box653,

Milwaukee,Wisconsin53201,U.S.A,phone:+1(414)3434056,("HarleyDavidson").

HarleyDavidsonwarrantsforanynew2016HarleyDavidsonmotorcyclethatanauthorised

HarleyDavidsondealerwillrepairorreplacewithoutchargeanypartsfoundtobedefectivein

factorymaterialsorworkmanshipundernormaluseduringthewarrantyperiodsetoutbelow.

SuchrepairorreplacementofpartswillbeHarleyDavidson'ssoleobligationandyoursole

remedyunderthisHDMotorcycleWarranty,howeveryoumayhaveotherrightsunderAustralian

andNewZealandlaws,asdescribedabove.

Note:Goodspresentedforrepairmaybereplacedbyrefurbishedgoodsofthesametyperather

thanbeingrepaired.Refurbishedpartsmaybeusedtorepairgoods.

ThefollowingtermsandconditionsapplytothisHDMotorcycleWarranty:

WarrantyPeriod

ThedurationofthisHDMotorcycleWarrantyistwentyfourmonths,startingfromtheearlierof:

(a)thedateofdeliverybyanauthorisedHarleyDavidsondealertothefirstretailpurchaser;or

(b)thethirdanniversaryofthelastdayofthemodelyearofthemotorcycle(ifnotsoldtoaretail

purchaserbeforethatdate).

YourauthorisedHarleyDavidsondealerwillsubmitanelectronicSalesandWarrantyRegistration

formtoinitiateyourHDMotorcycleWarranty.

Note:Ifthemotorcyclewasusedasademonstratororcompanymotorcycle,thenthewarranty

periodmayhavestartedand/orexpiredpriortotheinitialretailsale.SeeanauthorisedHarley

Davidsondealerfordetails.

AnyunexpiredportionofthisHDMotorcycleWarrantywillbetransferredtosubsequentowners,

upontheresaleofthemotorcycleduringthewarrantyperiod.SeetheOWNERCONTACT

INFORMATIONsectionoftheOwner'sManualforinformationregardingnotificationofownership

changes.

ObtainingWarrantyService

Toobtainwarrantyservice,returnyourmotorcycleatyourexpensewithinthewarrantyperiodto

anauthoriseddealer.HarleyDavidson'snetworkofauthoriseddealersislarge,andcontinuesto

expand.Tofindcurrentcontactinformationforyournearestauthoriseddealer,visitourwebsiteat

www.hd.com.au.

TheauthorisedHarleyDavidsondealershouldbeabletoprovidewarrantyserviceduringnormal

businesshoursandassoonaspossible,dependingupontheworkloadoftheauthoriseddealer's

servicedepartmentandtheavailabilityofnecessaryparts

Youareresponsibleforcollectingthemotorcyclefromtheauthorizeddealeroncethewarranty

servicehasbeencompleted,atyourexpense.

Exclusions

ThisHDMotorcycleWarrantywillnotapplytoanymotorcycle(orpartoraccessory):

1.WhichhasnotbeenoperatedormaintainedasspecifiedintheOwner'sManual.

2.Whichhasbeenabused,neglected,misused,improperlystored,used"offthehighway,"or

usedforracingorcompetitionofanykind.

3.WhichwasnotoriginallymanufacturedforuseorsoldinAustraliaandNewZealandand/or

doesnotcomplywithAustralianandNewZealandhomologationrequirements.

4.Whichhasoffroadorcompetitionpartsinstalledtoenhanceperformance,orhas

unapprovedmodifications.ThesemodificationsmayvoidallorpartofyournewHD

MotorcycleWarranty.SeeanauthorisedHarleyDavidsondealerfordetails.

5.Wheredamageiscausedby,orHarleyDavidsonisunabletohonourthisHDMotorcycle

Warrantydueto,actsofGod,war,riot,insurrection,naturaldisasters,including,butnot

limitedto,nuclearcontamination,lightning,forestfires,duststorms,hailstorms,icestorms,

earthquakes,floods,orothercircumstancesoutofHarleyDavidson'scontrol.

6.Whichhasbeeninanaccident,collision,droppedorstruck.

Note:EventhoughthisHDMotorcycleWarrantydoesnotapplyinthecircumstancessetout

above,youmaystillhaverightsunderAustralianandNewZealandlaws,includingtheAustralian

ConsumerLawinsuchcircumstances.

OtherLimitations

ThisHDMotorcycleWarrantydoesnotcover:

1.PartsandaccessoriesnotmanufacturedbyHarleyDavidson,oranydamagecausedtothe

motorcyclebytheinstallationofsuchpartsandaccessories,evenifsuchpartsand

accessoriesareinstalledonthemotorcycleatthedateofinitialretailpurchase.Aseparate

thirdpartywarrantymayapplytosuchpartsandaccessories.SeeanauthorisedHarley

Davidsondealerfordetails.

2.PartsandlabourfornormalmaintenanceasrecommendedintheOwner'sManual,orthe

replacementofpartsduetonormalwearandtearincluding,butnotlimitedto,thefollowing:

tyres,lubrication,oilandfilterchange,fuelsystemcleaning,batterymaintenance,engine

tuneup,sparkplugs,brake,clutch,chain/beltadjustmentandchainreplacement.

3.Cosmeticorotherconcernsthatariseasaresultofownerabuse,lackofproper

maintenanceorenvironmentalconditions(exceptconcernsthatresultfromdefectsin

factorymaterialsorworkmanship,whicharecoveredbythisHDMotorcycleWarrantyfor

thedurationofthewarrantyperiod).

4.Anycosmeticconditionexistingatthetimeofretaildeliverythathasnotbeendocumented

bytheauthorisedHarleyDavidsonsellingdealerpriortoretaildelivery.

5.DefectsordamagetothemotorcyclecausedbyalterationsoutsideofHarleyDavidson's

factoryspecifications,includingtheinstallationofcompetitionorclosedcoursepartsand

accessoriesandtheadditionofloadsandstressestothemotorcycleabovethose

recommendedbyHarleyDavidson.

6.DamagecausedbyinstallationoruseofnonHarleyDavidsoncomponents,eventhose

installedbyanauthoriseddealership,thatcauseaHarleyDavidsonparttofail.Examples

include,butarenotlimitedtoperformanceenhancingpowertraincomponentsorsoftware,

exhaustsystems,nonapprovedtyres,loweringkits,handlebars,addonsconnectedtothe

factoryelectricalsystem,towbars,etc.

Note:EventhoughthisHDMotorcycleWarrantydoesnotcoverthecircumstancessetout

above,youmaystillhaverightsunderAustralianandNewZealandlaws,includingtheAustralian

ConsumerLaw.

Important:ReadCarefully

1.AuthorisedHarleyDavidsondealersareindependentlyownedandoperatedandmaysell

nonHarleyDavidsonproducts.Becauseofthis,HARLEYDAVIDSONISNOT

RESPONSIBLEFORTHESAFETY,QUALITY,ORSUITABILITYOFANYNONHARLEY

DAVIDSONPART,ACCESSORYORDESIGNMODIFICATIONWHICHMAYBESOLD

AND/ORINSTALLEDBYAUTHORISEDHARLEYDAVIDSONDEALERSORLABOUR

CARRIEDOUTBYDEALERS.

2.ThisHDMotorcycleWarrantyisacontractbetweenyouandHarleyDavidson.Itis

separateandapartfromanywarrantyyoumayreceiveorpurchasefromanauthorised

HarleyDavidsondealer.AnauthorisedHarleyDavidsondealerisnotauthorisedtoalter,

modify,orinanywaychangethetermsandconditionsofthisHDMotorcycleWarranty.

AnywarrantyworkorpartsreplacementauthorisedbyHarleyDavidsonwillnotprecludeHarley

DavidsonfromlaterrelyingonanyexclusionwhereHarleyDavidsonlaterbecomesawarethatan

exclusionappliedorthewarrantyclaimdidnototherwisecomplywiththetermsofthisHD

MotorcycleWarranty.

LimitedNoiseWarranty

2016HarleyDavidsonMotorcycleNoiseControlSystemLimitedWarranty

Thefollowinglimitedwarrantyappliestothenoisecontrolsystem,isinadditiontothe

MOTORCYCLELIMITEDWARRANTYandEMISSIONCONTROLSYSTEMLIMITED

WARRANTY,andappliesonlytoHarleyDavidsonmotorcyclessoldintheU.S.

HarleyDavidsonwarrantstothefirstownerandeachsubsequentownerthatthismotorcycleis

designedandbuiltsoastoconformatthetimeofsalewithapplicableregulationsoftheU.S.

EnvironmentalProtectionAgency(astestedfollowingF76DriveBytestprocedure)andthatitis

freefromdefectsinfactorymaterialsandworkmanshipwhichcancausethismotorcyclenotto

meetU.S.EnvironmentalProtectionAgencyStandardswithinone(1)yearfrominitialretail

purchaseanddeliveryfromanauthorizedHarleyDavidsondealerorone(1)yearfromthe

[second]anniversaryofthelastdayofthemodelyearofthemotorcycle,or3,730miles6,000

kilometerswhicheveroccursfirst.Anyunexpiredportionofthislimitedwarrantywillbetransferred

tosubsequentowners,upontheresaleofthemotorcycleduringthelimitedwarrantyperiod.Ifthe

motorcyclewasusedasademonstratororcompanymotorcycle,thenthelimitedwarrantyperiod

mayhavestartedand/orexpiredpriortotheinitialretailsale.SeeanauthorizedHarleyDavidson

dealerfordetails.

THEREISNOOTHEREXPRESSWARRANTY(OTHERTHANTHESEPARATE

MOTORCYCLEANDEMISSIONSLIMITEDWARRANTIES)ONTHEMOTORCYCLE.ANY

IMPLIEDWARRANTYOFMERCHANTABILITYORFITNESSFORPARTICULARPURPOSEIS

LIMITEDTOTHEDURATIONOFTHISLIMITEDWARRANTY.

Somestatesdonotallowlimitationsonhowlonganimpliedwarrantylasts,sotheabovelimitation

maynotapplytoyou.

Thelimitedwarrantyperiodshallbeginonthedatethemotorcycleisdeliveredtothefirstretail

purchaseror,ifthemotorcycleisplacedinserviceasademonstratororcompanymotorcycle

priortosaleatretail,onthedateitisfirstplacedinservice.

THEFOLLOWINGITEMSARENOTCOVEREDBYTHENOISECONTROLSYSTEMLIMITED

WARRANTY

1.Failureswhichariseasaresultofmisuse,alteration,ornonperformanceofmaintenanceas

specifiedintheOwner'sManual.

2.Replacing,removing,ormodifyinganyportionoftheNOISECONTROLSYSTEM

(consistingoftheexhaustsystemandairintake/cleanerassembly)withpartsnotcertifiedto

benoiselegalforstreetuse.

3.Anymotorcycleonwhichtheodometermileagehasbeenchangedsothatthemileage

cannotbedetermined.

4.TOTHEFULLESTEXTENTALLOWEDBYLAW,NEITHERHARLEYDAVIDSONNOR

ITSAUTHORIZEDDEALERSSHALLBELIABLEFORLOSSOFTIME,INCONVENIENCE,

LOSSOFMOTORCYCLEUSE,COMMERCIALLOSSOROTHERINCIDENTALOR

CONSEQUENTIALDAMAGES.

Somestatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,so

theabovelimitationorexclusionmaynotapplytoyou.

OtherRights

Thislimitedwarrantygivesyouspecificlegalrights,andyoumayhaveotherrightswhichvary

fromstatetostate.

RecommendationsforRequiredMaintenance

ItisrecommendedthatanynoisesystemmaintenancebeperformedbyanauthorizedHarley

DavidsondealerusinggenuineHarleyDavidsonreplacementparts.Themaintenance,

replacementorrepairofthenoisecontrolsystemmaybeperformedbyanyotherqualifiedservice

outletorindividual.NongenuineHarleyDavidsonpartsmaybeusedonlyifsuchpartsare

certifiedtocomplywithU.S.EnvironmentalProtectionAgencyStandards.

LimitedEmissionWarranty

2016HarleyDavidsonEmissionControlSystemLimitedWarranty

Thefollowinglimitedwarrantyappliestotheemissioncontrolsystem,isinadditiontothe

MOTORCYCLELIMITEDWARRANTYandNOISECONTROLSYSTEMLIMITEDWARRANTY,

andappliesonlytoHarleyDavidsonmotorcyclescertifiedforsale,registered,andnormally

operatedintheU.S.RefertotheCALIFORNIAEMISSIONSCONTROLWARRANTY

STATEMENTforadditionalwarrantyprovisionsapplicabletoCaliforniamotorcycles.

HarleyDavidsonMotorCompanywarrantstothefirstownerandeachsubsequentownerthatthis

vehicleisdesigned,built,andequippedsoastoconformatthetimeofsalewithapplicable

regulationsundersection7521ofTitle42oftheUnitedStatesCode,andthatitisfreefrom

defectsinmaterialsandworkmanshipwhichwouldcausethismotorcycletofailtoconformwith

applicableregulationsforfive(5)yearsfromtheinitialretailpurchaseanddeliveryfroman

authorizedHarleyDavidsondealer(orfive(5)yearsfromthedatethemotorcycleisfirstplacedin

service,ifitisfirstplacedinserviceasa"demonstrator"or"company"motorcyclepriorto

delivery),or18,641miles30,000kilometers,whicheveroccursfirst.Anyunexpiredportionofthis

limitedwarrantywillbetransferredtosubsequentowners,upontheresaleofthemotorcycle

duringthewarrantyperiod.

THEREISNOOTHEREXPRESSWARRANTY(OTHERTHANTHESEPARATE

MOTORCYCLEANDNOISELIMITEDWARRANTIES)ONTHEMOTORCYCLE.ANYIMPLIED

WARRANTYOFMERCHANTABILITYORFITNESSFORPARTICULARPURPOSEISLIMITED

TOTHEDURATIONOFTHISWARRANTY.

Somestatesdonotallowlimitationsonhowlonganimpliedwarrantylasts,sotheabovelimitation

maynotapplytoyou.

Thelimitedwarrantyperiodshallbeginonthedatethemotorcycleisdeliveredtothefirstretail

purchaseror,ifthemotorcycleisplacedinserviceasademonstratororcompanymotorcycle

priortosaleatretail,onthedateitisfirstplacedinservice.

THEFOLLOWINGITEMSARENOTCOVEREDBYTHEEMISSIONCONTROLSYSTEM

LIMITEDWARRANTY

1.Failureswhichariseasaresultofmisuse,tampering,alterations,accident,actsofnature,or

improperorinadequatemaintenanceasspecifiedintheOwner'sManual.

2.Requiredmaintenanceservices(asspecifiedintheOwner'sManual)andthereplacement

ofparts(suchassparkplugs,fuelandoilfilters,etc.)usedinrequiredmaintenance.

3.Anymotorcycleonwhichtheodometermileagehasbeenchangedsothatthemileage

cannotbedetermined.

4.TOTHEFULLESTEXTENTALLOWEDBYLAW,NEITHERHARLEYDAVIDSONNOR

ITSAUTHORIZEDDEALERSSHALLBELIABLEFORLOSSOFTIME,INCONVENIENCE,

TOWINGOFTHEVEHICLE,LOSSOFMOTORCYCLEUSE,COMMERCIALLOSSOR

OTHERINCIDENTALORCONSEQUENTIALDAMAGES.

Somestatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,so

theabovelimitationorexclusionmaynotapplytoyou.

ItemsCoveredbythisEmissionWarranty

Theemissioncontrolsystemwarrantymaycoverthefollowingpartsifthedefectisdeemedtobe

emissionsrelated:

Aircleanerassembly

Camshaft

Sparkplug

Ignitioncoil

Ignitionwires

Vaporvalve

Catalyticconverter

Crankcasebreather

MAPsensor

TMAPsensor

Intakeairtemperaturesensor

Throttlepositionsensor

Fuelinjectors

Inductionmoduleorthrottlebody

Enginetemperaturesensor

Electroniccontrolunit

Regulator/fuelpump(forleaksand/orhighandlowpressurefailures)

Fuelfilter

Oxygensensors

FuelTank(noncosmeticfailuresonly)

Leaks

Fuelvaporseparator

Fuelcap

Ifusedontheabove:hoses,clamps,fittings,tubing,sealinggasketsandmountinghardware.

Detailedinstructionsforpropermaintenanceanduseofthismotorcycle,includingthetimeand/or

mileageintervalsatwhichsuchmaintenanceistobeperformed,maybefoundinthisOwner's

ManualunderServiceRecords.

OtherRights

Thislimitedwarrantygivesyouspecificlegalrights,andyoumayhaveotherrightswhichvary

fromstatetostate.

RecommendationsforRequiredMaintenance

ItisrecommendedthatanyemissionsystemmaintenancebeperformedbyanauthorizedHarley

DavidsondealerusinggenuineHarleyDavidsonreplacementparts.Howeverthemaintenance,

replacementorrepairoftheemissionscontrolsystemmaybeperformedbyanyotherqualified

serviceoutletorindividual.NongenuineHarleyDavidsonpartsmaybeusedonlyifsuchparts

arecertifiedtocomplywithU.S.EnvironmentalProtectionAgencyStandards.

CaliforniaEmissionsControlWarranty

CaliforniaEmissionsControlWarrantyStatement

YourWarrantyRightsandObligations

TheCaliforniaAirResourcesBoardandHarleyDavidsonMotorCompanyarepleasedtoexplain

theemissioncontrolsystemwarrantyonyour2016modelyearmotorcycle.InCalifornia,new

motorvehiclesmustbedesigned,builtandequippedtomeettheState'sstringentantismog

standards.HarleyDavidsonMotorCompanymustwarranttheemissioncontrolsystemonyour

motorcyclefortheperiodsoftimelistedbelowprovidedtherehasbeennoabuse,unapproved

modification,neglectorimpropermaintenanceofyourmotorcycle.

Youremissioncontrolsystemmayincludepartssuchasthecarburetororfuelinjectionsystem,

theignitionsystem,catalyticconverter,andenginecomputer.Alsoincludedmaybehoses,

connectorsandotheremissionrelatedassemblies.

Whereawarrantableconditionexists,withinthewarrantyperiodnotedbelow,yourauthorized

HarleyDavidsondealerwillrepairyourmotorcycleatnocosttoyouincludingdiagnosis,partsand

labor.

Manufacturer'sWarrantyCoverage

Foraperiodofuseoffiveyearsor18,641miles30,000kilometers,whicheverfirstoccurs,

beginningonthedatethemotorcycleisdeliveredtotheultimatepurchaseror,ifthemotorcycleis

placedinserviceasademonstratororcompanymotorcyclepriortosaleatretail,thedateitisfirst

placedinservice.

Ifanyemissionrelatedpartonyourmotorcycleisdefective,thepartwillberepairedorreplaced

byHarleyDavidsonMotorCompany.ThisisyouremissioncontrolsystemDEFECTS

WARRANTY.

Owner'sWarrantyResponsibilities

Asthemotorcycleowner,youareresponsiblefortheperformanceoftherequiredmaintenance

listedinyourOwner'sManual.HarleyDavidsonrecommendsthatyouretainallreceiptscovering

maintenanceonyourmotorcycle,butHarleyDavidsoncannotdenyemissionswarrantycoverage

solelyforthelackofreceiptsorforyourfailuretoensuretheperformanceofallscheduled

maintenance.

YouareresponsibleforpresentingyourmotorcycletoanauthorizedHarleyDavidsondealeras

soonasaproblemexists.Thewarrantyrepairsshouldbecompletedinareasonableamountof

time,nottoexceed30days.

Asthemotorcycleowner,youshouldalsobeawarethatHarleyDavidsonmaydenyyouwarranty

coverageifyourmotorcycleoraparthasfailedduetoabuse,neglect,impropermaintenanceor

unapprovedmodifications.

Ifyouhaveanyquestionsregardingyourwarrantyrightsandresponsibilities,youshouldcontact

HarleyDavidsonCustomerServiceDepartmentat18002582464(U.S.only)or1414343

4056,ortheCaliforniaAirResourcesBoardat9528TelstarAve.,ElMonte,California91731.

AdditionalWarrantyTerms

Thewarrantyperiodstartsthedatethemotorcycleisdeliveredtotheultimatepurchaseror,ifthe

motorcycleisplacedinserviceasademonstratororcompanymotorcyclepriortosaleatretail,

thedateitisfirstplacedinservice.

TheemissioncontrolsystemofeachnewHarleyDavidsonmotorcyclewasdesigned,builtand

testedusingonlyGenuineHarleyDavidsonpartsandwiththesepartsthemotorcycleiscertified

asbeinginconformitywithCaliforniaemissioncontrolregulations.

WerecommendthatyoutakeyourmotorcycletoanauthorizedHarleyDavidsondealerforrepairs

underthiswarranty.ThedealerhasfactorytrainedmechanicsandgenuineHarleyDavidson

parts.However,inthecaseofan"emergency"(asdefinedbelow),youcouldhaverepairs

performedatanyavailableserviceestablishmentorbytheowner,usinganyreplacementpart.An

authorizedHarleyDavidsondealernotbeingreasonablyavailable,orapartnotbeingavailable

withinareasonabletimeperiod(nottoexceed30daysfromthetimethemotorcycleisinitially

presentedtoaHarleyDavidsondealerforrepair)constitutesanemergency.HarleyDavidsonwill

reimbursetheownerforsuchrepairs,includingdiagnosis,onlyifitisestablishedthattherepairs

arecoveredunderthisemissionwarranty.HarleyDavidson'spartsreimbursement,however,will

notexceedoursuggestedretailpriceforallwarrantedpartsreplacedandourlabor

reimbursementwillbelimitedtoourrecommendedtimeallowancesforemissionsystemrepairsat

thegeographicallyappropriatehourlylaborrate.

ToobtainreimbursementfromHarleyDavidsonforsuchemergencyrepairs,youmustkeepall

failedpartsandoriginalreceipts,soyoucanpresentthemtoanauthorizedHarleyDavidson

dealerforinspection.HarleyDavidsonrecommendsthatyoubringyourmotorcycletoan

authorizeddealerforinspectiontoensurethattheemergencyrepairsweredoneproperly.

Remember:UseofnonHarleyDavidsonreplacementpartsmayimpairtheeffectivenessofthe

emissioncontrolsystemorotherwisedamageyourmotorcycle.IfotherthangenuineHarley

Davidsonpartsareusedformaintenance,replacementorrepairofcomponentsaffecting

emissioncontrol,youshouldobtainwrittenassurancesthatsuchnonHarleyDavidsonpartsare

warrantedbytheirmanufacturertobeequalinqualitytoGenuineHarleyDavidsonpartsinboth

performanceanddurability.TheuseofnonHarleyDavidsonreplacementpartsdoesnot

invalidatetheexistingwarranty,ifany,onotherHarleyDavidsoncomponentsunlessthenon

HarleyDavidsonpartscausedamagetowarrantedpartsorresultinthecreationofanemissions

noncompliantmotorcycle.However,HARLEYDAVIDSONASSUMESNOLIABILITYUNDER

THISWARRANTYWITHRESPECTTOANYPARTSWHICHARENOTGENUINEHARLEY

DAVIDSONPARTS,unlessHarleyDavidsonpartscausedamagetonongenuineHarley

Davidsonparts.

WhatIsCoveredbythisEmissionWarranty

Theemissioncontrolsystemwarrantycoversthefollowing"warrantedparts"only:

Aircleanerassembly

Camshaft

Sparkplug

Ignitioncoil

Ignitionwires

Vaporvalve

Catalyticconverter

Crankcasebreather

MAPsensor

TMAPsensor

Intakeairtemperaturesensor

Throttlepositionsensor

Fuelinjectors

Inductionmoduleorthrottlebody

Enginetemperaturesensor

Electroniccontrolunit

Regulator/fuelpump(forleaksand/orhighandlowpressurefailures)

Fuelfilter

Oxygensensors

Carboncanister

Purgecontrolvalve

FuelTank(noncosmeticfailuresonly)

Leaks

Fuelvaporseparator

Fuelcap

Ifusedontheabove:hoses,clamps,fittings,tubing,sealinggasketsandmountinghardware.

WhatIsNotCoveredbythisEmissionWarranty

Theemissioncontrolsystemwarrantydoesnotcover:

Malfunctionsinany"warrantedparts"causedbyanyofthefollowing:abuse,misuse,unapproved

modificationoralteration,tampering,disconnection,orimproperorinadequatemaintenance.The

warrantyalsodoesnotcoverreplacementoflistedpartsintheeventthatthevehiclehasbeen

renderedemissionsnoncompliantinthestateofCaliforniathroughactionsnotedabove.

Damageresultingfromaccident,actsofnatureorothereventsbeyondthecontrolofHarley

Davidson.

Therepairorreplacementof"warrantedparts"whicharescheduledforreplacementpriorto

18,641mi30,000km,oncethesepartshavebeenreplacedatthefirstreplacementintervalas

partofrequiredmaintenanceservices.

RepairsandservicesperformedbyanyoneotherthananauthorizedHarleyDavidsonDealer

(exceptincaseofemergencyasdefinedabove).

Lossoftime,inconvenience,lossofuseofthemotorcycle,towingofthevehicle,orcommercial

lossand/orconsequentialdamages.

Repairsonanymotorcycleofwhichodometermileagehasbeenchangedsothatmileagecannot

bereadilydetermined.

MaintenanceScheduling

ServiceRecords

RegularServiceIntervals

Performtheserviceandmaintenanceoperationsas

indicatedintheregularserviceintervaltable.Lackof

regularmaintenanceattherecommendedintervalscan

affectthesafeoperationofyourmotorcycle,whichcould

resultindeathorseriousinjury.(00010a)

Ifyouoperateyourmotorcycleunderadverseconditions

(severecold,extremeheat,verydustyenvironment,very

badroads,throughstandingwater,etc.),youshould

performtheregularmaintenanceintervalsmorefrequently

toensurethesafeoperationofyourmotorcycle.Failureto

maintainyourmotorcyclecouldresultindeathorserious

injury.(00094a)

RegularmaintenancemustbeperformedatspecifiedintervalstohelpkeepyournewHarley

Davidsonmotorcycleoperatingatpeakperformanceandkeepyournewmotorcyclelimited

warrantyinforce.YourauthorizedHarleyDavidsondealerknowsbesthowtoserviceyour

motorcyclewithfactoryapprovedmethodsandequipmentassuringyouofthoroughandcompetent

workmanship.

Somemaintenanceitemsarescheduledatleastonceperyear,evenifthenextmileageinterval

hasnotbeenreached.Insevereridingconditions,somemaintenanceitemsneedtobeperformed

morefrequently.RefertoRegularServiceIntervals:2016HarleyDavidsonDynaModels.

NOTES:

TheuseofpartsandserviceproceduresotherthanHarleyDavidsonapprovedpartsand

serviceproceduresmayvoidthelimitedwarranty.Anyalterationstotheemissionsystem

components,suchastheintakeandexhaustsystem,maybeinviolationofmotorvehicle

laws.

Somecountries,suchasBrazil,mayrequireallregularmaintenancetobeperformedbyan

authorizedHarleyDavidsondealerforyourlimitedwarrantytoremainineffect.Checkwith

yourauthorizedHarleyDavidsondealer.

Somecountries,suchasBrazil,requireadditionalannual(orsemiannual)regular

maintenancestepstokeepyourlimitedwarrantyineffectand/orcomplywithvehicle

regulations.CheckwithyourauthorizedHarleyDavidsondealerandthemotorcycle

regulationsinyourcountryforlocalrequirements.

Aftercompletingthefinalserviceinterval,repeattheserviceschedulestartingatthe5000mi

8000kminterval.RefertoRegularServiceIntervals:2016HarleyDavidsonDyna

Models.

Wheneveravehicleisinformaintenance,alwayscheckforandcompleteopenrecallsand

productprograms.

Wheneveravehicleisinformaintenance,alwaysverifythatthelatestcalibrationisinstalled.

RegularServiceIntervals:2016HarleyDavidsonDynaModels

ITEM

SERVICED

1000

1600

5000

8000

10000

16000

15000

24000

20000

32000

25000

40000

30000

48000

35000

56000

40000

64000

45000

72000

50000

80000

NOTES

Check

operationof

electrical

equipment

and

switches

XXXXXXXXXXX

Checkfront

tire

pressure,

inspect

tread

XXXXXXXXXXX1

Check

torqueof

frontwheel

spokes(if

equipped)

X X X X X 2,3,4

Inspectfront

brakefluid

sightglass

XXXXXXXXXXX5

Check

torqueon

frontbrake

reservoir

coverscrew

X X X X X X 1,2,6

Adjust

steering

head

bearings

XXXXXX2

Lubricate

steering

head

bearings

X 2,7

Check

torqueon

frontfork

lower

bracket

pinchbolts

X X X X X X 1,2,6

Check X X X X X X 1,2,6

torqueon

frontfork:

upper

bracket

pinchbolts

Inspect

windshield

bushings(if

applicable)

XXXXX

Check,

adjustand

lubricate

throttle

controls

except

FXDLS

XXXXXXXXXXX2

Check

upperand

lowerswitch

housing

screw

torque

X X X X X X 1,2,6

Check

clutchlever

handlebar

clampscrew

torque

X X X X X X 1,2,6

Check

master

cylinder

handlebar

clampscrew

torque

X X X X X X 1,2,6

Inspectair

cleaner,

serviceas

required

XXXXXXXXXX4,5

Replace

engineoil

andfilter

XXXXXXXXXXX1,4

Replace

primary

chaincase

lubricant

XXXXXX4

Replace

transmission

lubricant

X X X 4

Inspect

brake

systemfor

leaks,

XXXXXXXXXXX2,5

contactor

abrasion

Inspectfuel

linesand

fittingsfor

leaks,

contactor

abrasion

XXXXXXXXXXX1,2

Inspect

engine

mountsand

stabilizer

links

XXXXXX2

Inspectrear

brakefluid

sightglass

XXXXXXXXXXX5

Checkrear

brake

reservoir

coverscrew

torque

X X X X X X 1,2,6

Inspect

brakepads

anddiscs

forwear

XXXXXXXXXXX

Checkfront

axlepinch

bolttorque:

FLD(right

side)

X X X X X X 1,2,6

CheckFront

axlecap

fastener

torque:all

butFLD

X X X X X X 1,2,6

Checkfront

axlenut

torque

X X X X X X 1,2,6

Checkbrake

master

cylinderand

caliper

banjobolt

torque

X X X X X X 1,2,6

CheckABS

module

(EHCU)

banjobolt

torque

X X X X X X 1,2,6

Check

torqueof

X X X X X X 1,2,6

ABSbrake

lineflare

nutsunder

lowerfork

bracket

Inspectand

lubricatejiffy

stand

XXXXXXXXXXX2,4

Check

clutch

adjustment

XXXXXXXXXXX2,4

Check,

adjustand

lubricate

brakeand

clutch

controls

XXXXXXXXXXX

Checkrear

wheel

spokes

torque(if

equipped)

X X X X X 2,3,4

Checkrear

tire

pressure,

inspect

tread

XXXXXXXXXXX1

Inspectand

lubricate

rearfork

bearings

X 2,7

Inspect

drivebelt

and

sprockets,

adjustbelt

XXXXXXXXXXX2

Checkrear

axlenut

torque

X X X X X X 1,2,6

Inspect

exhaust

systemfor

leaks,

cracks,and

looseor

missing

fastenersor

exhaust

shields

XXXXXXXXXXX1,4

Checkrear

exhaust

X X X X X X 1,2,6

bracketbolt

torqueat

transmission

Checkrear

exhaust

bracket

locknut

torqueat

transmission

X X X X X X 1,2,6

Check

battery,

terminal

torque,and

clean

connections

annually

Replace

sparkplugs

Rebuild

frontfork

X 2,8

Replacefuel

filter

element

2,4,10

Roadtestto

verify

component

andsystem

functions

XXXXXXXXXXX

NOTES: 1.Performannuallyoratspecifiedintervals,whichevercomesfirst.

2.ShouldbeperformedbyanauthorizedHarleyDavidsondealer,unlessyouhave

thepropertools,servicedataandaremechanicallyqualified.

3.Performspoketensioncheckatthe1000mi1600km,5000mi8000km,20,000

mi32,000kmservicesandevery15,000mi24,000kmintervalthereafter.Notall

vehiclesareequippedwithspokewheels.Consultappropriatetopicinservice

manual.

4.Performmaintenancemorefrequentlyinsevereridingconditions(suchas

extremetemperatures,dustyenvironments,mountainousorroughroads,long

storageconditions,shortruns,heavystop/gotrafficorpoorfuelquality).

5.ReplaceDOT4brakefluidandflushsystemeverytwoyears.

6.Fortorqueinstructions,seeShopPracticesintheservicemanual.

7.Disassemble,lubricateandinspectevery30,000mi48,000km.

8.Disassemble,inspect,rebuildforksandreplaceforkoilevery50,000mi80,000

km.

9.Replacesparkplugseverytwoyearsorevery30,000mi48,000km,whichever

comesfirst.

10.Replacefuelfilterelementevery100,000mi160,000km.

MaintenanceRecords

Maintainarecordofallservice.RefertoOwner'sMaintenanceRecords.

Owner'sMaintenanceRecords

SERVICEMILEINTERVAL DATE DEALER

NUMBER

TECHNICIAN

NAME

TECHNICIAN

SIGNATURE

1,000mi1,600km

5,000mi8,000km

10,000mi16,000km

15,000mi24,000km

20,000mi32,000km

25,000mi40,000km

30,000mi48,000km

35,000mi56,000km

40,000mi64,000km

45,000mi72,000km

50,000mi80,000km

ServiceLiterature

VisitanyHarleyDavidsondealertopurchaseaserviceorpartsmanualforyourmotorcycle.

Factoryauthorizedmanualsarethemostcompleteanddetailedsourceofinformationoutsideof

yourHarleyDavidsondealer.RefertoServiceLiterature:2016DynaModels.

ServiceLiterature:2016DynaModels

DOCUMENT PART

NUMBER

DynaModelsServiceManual 9948116A

DynaModelsElectricalDiagnostic

Manual

9949616A

DynaModelsPartsCatalog 9943916A

PublicationnumberslistedareEnglishlanguagemanuals.

OtherlanguagesareavailablefromaHarleyDavidson

dealer.

Glossary

AcronymsandMeasurementSymbols

AcronymsandMeasurementSymbols(AC)

ITEM DEFINITION

A Amperes

ABS Antilockbrakingsystem

AC Alternatingcurrent

AGM Absorbedglassmat(battery)

Ah Amperehour

BAS Bankanglesensor

BCM Bodycontrolmodule

°C Celsius(Centigrade)

CCA Coldcrankingamps

cm Centimeters

cm3Cubiccentimeters(cc)

CVO Customvehicleoperations

AcronymsandMeasurementSymbols(DF)

ITEM DEFINITION

DC Directcurrent

DLC Datalinkconnector

DOM Domestic

DTC Diagnostictroublecode

ECM Electroniccontrolmodule

EHCU Electrohydrauliccontrolunit

EITMS EngineIdleTemperatureManagementSystem

EHCU Electrohydrauliccontrolunit

ETC Electronicthrottlecontrol

EVAP Evaporativeemissionscontrolsystem

°F Fahrenheit

floz Fluidounce

ft Feet

ftlbs Footpounds

FTP Flashtopass

AcronymsandMeasurementSymbol(GZ)

ITEM DEFINITION

g Gram

gal Gallon

GAWR Grossaxleweightrating

GND Ground(electrical)

GPS Globalpositioningsystem

GVWR Grossvehicleweightrating

HDSSS HarleyDavidsonSmartSecuritySystem

HCU Hydrauliccontrolunit

HDI HarleyDavidsonInternational

IGN Ignitionlight/keyswitchposition

in inch

in3Cubicinch

inlbs Inchpounds

kg Kilogram

km Kilometer

km/h Kilometersperhour

kPa Kilopascal

kW Kilowatt

L Liter

lb Pounds

LED Lightemittingdiode

mA Milliampere

mi Mile

mL Milliliter

mm Millimeter

mph Milesperhour

ms Millisecond

Nm Newtonmeter

oz Ounce

P&A PartsandAccessories

PA Publicaddress

PartNo. Partnumber

PIN Personalidentificationnumber

psi Poundspersquareinch

qt Quart

rpm Revolutionsperminute

TPMS Tirepressuremonitoringsystem

USB Universalserialbus

V Volt

VAC Voltsofalternatingcurrent

VDC Voltsofdirectcurrent

VIN Vehicleidentificationnumber

VR Voicerecognition

W Watt

HDU.S.A.,LLCTrademarkInformation

Bar&Shield,Boom!,CrossBones,CruiseDrive,CVO,DigitalTech,DigitalTechnician,Digital

TechnicianII,Dyna,ElectraGlide,Evolution,FatBob,FatBoy,FortyEight,Glaze,Gloss,HD,H

Dnet.com,Harley,HarleyDavidson,HD,HeritageSoftail,Iron883,LowRider,NightRod,

Nightster,NightTrain,Profile,Reflex,Revolution,RoadGlide,RoadKing,RoadTech,Rocker,

Screamin'Eagle,SeventyTwo,Softail,Sportster,StreetGlide,StreetRod,SunRay,Sunwash,

SuperGlide,SuperLow,Supersmart,Switchback,SYN3,TechLink,TechLinkII,TourPak,Tri

Glide,TwinCam88,TwinCam88B,TwinCam96,TwinCam96B,TwinCam103,TwinCam

103B,TwinCam110,TwinCam110B,TwinCooled,UltraClassic,VRod,VRSCandHarley

DavidsonGenuineMotorPartsandGenuineMotorAccessoriesareamongthetrademarksofHD

U.S.A.,LLC.

ProductRegisteredMarks

Apple,AlcantaraS.p.A.,Allen,AmpMultilock,Bluetooth,Brembo,CityNavigator,Delphi,

Deutsch,Dunlop,Dynojet,Fluke,G.E.Versilube,Garmin,Gunk,Hydroseal,Hylomar,iPhone,

iPod,Kevlar,Lexan,Loctite,Lubriplate,Keps,K&N,Magnaflux,MarsonThreadSetterToolKit,

MAXIfuse,Molex,Michelin,MPZ,Mulitilock,nano,NGK,Novus,Packard,Pirelli,Permatex,

Philips,PJ1,Pozidriv,RoadTech,Robinair,S100,Sems,SiriusXM,Snapon,Teflon,

Threadlocker,Torca,Torco,TORX,Tufoil,Tyco,Ultratorch,Velcro,XActoandXMSatellite

Radioareamongthetrademarksoftheirrespectiveowners.

Fatbob Owners Manual

Navigation menu

Versions of this User Manual:

Views

Navigation