RRV3568 XVDV363
User Manual: XVDV363
Open the PDF directly: View PDF 
.
Page Count: 103
| Download | |
| Open PDF In Browser | View PDF |
ORDER NO. RRV3568 XV-DV363 DVD/CD RECEIVER XV-DV363 XV-DV365K THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S). Model Type Power Requirement Regional restriction codes (Region No.) XV-DV363 WYXJ5 AC 220 V to 240 V 2 XV-DV365K WXJ/RE5 AC 220 V to 240 V 5 Remarks For details, refer to "Important Check Points for good servicing". PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2007 T-IZK APR. 2007 printed in Japan 1 2 3 4 SAFETY INFORMATION A This service manual is intended for qualified service technicians ; it is not meant for the casual doit-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING! B The laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. LASER DIODE CHARACTERISTICS FOR DVD : MAXIMUM OUTPUT POWER : 5 mW WAVELENGTH : 650 nm FOR CD : MAXIMUM OUTPUT POWER : 7 mW WAVELENGTH : 780 nm C LABEL CHECK D VRW2257 Additional Laser Caution 1. Laser Interlock Mechanism • Loading switch (S101 on the LOAB Assy) is used for interlock mechanism of the laser. When this switch turned ON in SW2 (CLOSE) side (OPEN signal is 0 V and CLOSE signal is 3.5 V), a laser becomes the status which can completely oscillation. Furthermore, the laser completely oscillates in the disc judgment and disc playback. When player is power ON state and laser diode is not completely oscillating, 780 nm laser diode is always oscillating by half power. • Laser diode is driving with Q307 (650 nm LD) and Q308 (780 nm LD) on the DVD MAIN Assy. Therefore, when short-circuit between the emitter and collector of these transistors or the base voltage is supplied for transistors turn on, the laser oscillates. (failure mode) • In the test mode ∗ , there is the mode that the laser oscillates except for the disc judgment and playback. LD ON mode in the test mode oscillates with the laser forcibly. The interlock mechanism mentioned above becomes invalid in this mode. E Name Label 2. When the cover is open, close viewing through the objective lens with the naked eye will cause exposure to the laser beam. F ∗ : Refer to page 25. 2 XV-DV363 1 2 3 4 5 6 7 8 A B C D E F 3 XV-DV363 5 6 7 8 1 2 3 4 CONTENTS SAFETY INFORMATION..................................................................................................................................... 2 1. SERVICE PRECAUTIONS ............................................................................................................................... 5 1.1 NOTES ON SOLDERING .......................................................................................................................... 5 1.2 CAUTION ................................................................................................................................................... 5 2. SPECIFICATIONS ............................................................................................................................................ 6 2.1 SPECIFICATIONS and ACCESORRIES ................................................................................................... 6 2.2 PANEL FACILITIES.................................................................................................................................... 7 3. BASIC ITEMS FOR SERVICE........................................................................................................................ 10 3.1 CHECK POINTS AFTER SERVICING..................................................................................................... 10 3.2 PCB LOCATIONS .....................................................................................................................................11 3.3 JIGS LIST ................................................................................................................................................ 12 3.4 CLEANING............................................................................................................................................... 12 4. BLOCK DIAGRAM.......................................................................................................................................... 14 4.1 OVERALL WIRING CONNECTION DIAGRAM and LOAB ASSY ........................................................... 14 4.2 OVERALL BLOCK DIAGRAM.................................................................................................................. 16 5. DIAGNOSIS.................................................................................................................................................... 18 5.1 METHOD FOR DIAGNOSING DEGRADATION OF THE LDS ON THE PICKUP................................... 18 5.2 DVD TROUBLE SHOOTING ................................................................................................................... 19 5.3 CIRCUIT DESCRIPTION OF DIGITAL AMP. SECTION .......................................................................... 22 5.4 SPECIFICATIONS FOR THE PROTECTION CIRCUITS FOR THE DIGITAL AMPLIFIER..................... 23 5.5 PASS/FAIL TEST PROCEDURE OF HDMI TRANSMITTER IC.............................................................. 24 6. SERVICE MODE ............................................................................................................................................ 25 6.1 TEST MODE ............................................................................................................................................ 25 6.2 DISPLAY SPECIFICATION OF THE TEST MODE.................................................................................. 26 6.3 FUNCTIONAL SPECIFICATION OF THE SHORTCUT KEY .................................................................. 27 6.4 SPECIFICATION OF MODEL INFORMATION DISPLAY ........................................................................ 28 6.5 FUNCTIONAL SPECIFICATION OF THE SERVICE MODE ................................................................... 29 6.6 SERVICE TEST MODE ........................................................................................................................... 30 7. DISASSEMBLY .............................................................................................................................................. 33 8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 40 8.1 ADJUSTMENT ......................................................................................................................................... 40 8.2 ID NUMBER AND ID DATA SETTING ..................................................................................................... 45 9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 48 9.1 PACKING SECTION ................................................................................................................................ 48 9.2 EXTERIOR SECTION.............................................................................................................................. 50 9.3 06 LOADER ASSY................................................................................................................................... 52 9.4 TRAVERSE MECHANISM ASSY-S ......................................................................................................... 54 10. SCHEMATIC DIAGRAM ............................................................................................................................... 56 10.1 DVD MAIN ASSY (1/5) .......................................................................................................................... 56 10.2 DVD MAIN ASSY (2/5) .......................................................................................................................... 58 10.3 DVD MAIN ASSY (3/5) .......................................................................................................................... 60 10.4 DVD MAIN ASSY (4/5) .......................................................................................................................... 62 10.5 DVD MAIN ASSY (5/5) .......................................................................................................................... 64 10.6 DAMP ASSY (1/2).................................................................................................................................. 66 10.7 DAMP ASSY (2/2).................................................................................................................................. 68 10.8 DISPLAY, USB, LED and KEY ASSYS .................................................................................................. 70 10.9 MIC ASSY (XV-DV365K ONLY)............................................................................................................. 72 10.10 EUROSCART ASSY ............................................................................................................................ 74 10.11 POWER SUPPLY UNIT ....................................................................................................................... 76 10.12 WAVEFORMS ...................................................................................................................................... 78 11. PCB CONNECTION DIAGRAM.................................................................................................................... 80 11.1 LOAB ASSY ........................................................................................................................................... 80 11.2 MIC ASSY (XV-DV365K ONLY) ............................................................................................................. 81 11.3 DVD MAIN ASSY ................................................................................................................................... 82 11.4 DAMP ASSY .......................................................................................................................................... 86 11.5 DISPLAY, USB, LED and KEY ASSYS .................................................................................................. 88 11.6 POWER SUPPLY UNIT ......................................................................................................................... 90 11.7 EUROSCART ASSY .............................................................................................................................. 92 12. PCB PARTS LIST ......................................................................................................................................... 93 A B C D E F 4 XV-DV363 1 2 3 4 5 6 7 8 1. SERVICE PRECAUTIONS 1.1 NOTES ON SOLDERING • For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. A • Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 °C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 °C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Do NOT use a soldering iron whose tip temperature cannot be controlled. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). B The following lead-free solders are available as service parts: • Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. C 1.2 CAUTION NOTES ON BTL DRIVE As a signal to drive the BTL is output from the negative speaker terminal, DO NOT short-circuit between the negative speaker terminal and ground, such as the chassis. Do not short-circuit between the plus speaker terminal and ground, such as the chassis, too. D Negative Speaker Terminal Do not short-circuit Ground (Chassis) E F 5 XV-DV363 5 6 7 8 1 2 3 4 2. SPECIFICATIONS 2.1 SPECIFICATIONS and ACCESORRIES A B C (XV-DV363) (XV-DV365K) D Accessories • Power Cord (ADG1127) E • FM Antenna (ADH7030) • Video Cable (L = 1.5 m) (XDE3046) • AM Loop Antenna (ATB7013) • Dry Cell Battery (AA/R6) • Remote Control (XV-DV363 : XXD3121) (XV-DV365K : XXD3124) F 6 XV-DV363 1 2 3 4 5 6 7 8 2.2 PANEL FACILITIES A Front panel B C XV-DV363 D XV-DV365K USB PHONES SUB MIC MAIN MIC MIN VOL MAX E F 7 XV-DV363 5 6 7 8 A 1 2 1 2 3 4 3 4 Display B C D E F 8 XV-DV363 5 6 7 8 A Remote control B ECHO (XV-DV356K) SHIFT+KARAOKE SHIFT+ECHO SHIFT+ SHIFT+ KARAOKE C D E F 9 XV-DV363 5 6 7 8 1 2 3 4 3. BASIC ITEMS FOR SERVICE 3.1 CHECK POINTS AFTER SERVICING A Check points after servicing (HTZ and system audio) To keep the product quality after servicing, confirm recommended check points shown below. No. B Procedures Check points 1 Confirm the firmware version on Service Mode. The version of the firmware must be latest. Update firmware to the latest one, if it is not the latest. 2 Confirm whether the customer complain has been solved. If the customer complain occurs with the specific disc, use it for the operation check. The customer complain must not be reappeared. Video, audio and operations must be normal. 3 Confirm playback error rates at the innermost and outermost tracks by using the following disc. DVD test disc (GGV1025) 4 Play back a CD. (track search) Audio and operations must be normal. 5 Play back a DVD. (Menu operation, Title/chapter search) Video, audio and operations must be normal. 6 Check the tuner (AM and FM) operations. Audio and operations must be normal. 7 Check the sound from headphone output. Sound must be normal, without noise. 8 Check the appearance of the product. No scratches or dirt on its appearance after receiving it for service. The error rates must be less than 5.0e-4. C See the table below for the items to be checked regarding video and audio: Item to be checked regarding video D Item to be checked regarding audio Block noise Distortion Horizontal noise Noise Dot noise Volume too low Disturbed image (video jumpiness) Volume too high Too dark Volume fluctuating Too bright Sound interrupted Mottled color E F 10 XV-DV363 1 2 3 4 5 6 7 8 3.2 PCB LOCATIONS J C POWER SUPPLY Unit I DAMP Assy EUROSCART Assy A FM/AM TUNER Unit B DVD MAIN Assy 06 LOADER Assy B E H D USB Assy MIC Assy (XV-DV365K only) DISPLAY Assy A LOAB Assy C Bottom view Front panel section D Rear view G F KEY Assy Mark No. Description LED Assy Part No. Mark No. LIST OF ASSEMBLIES NSP NSP NSP 1..06 LOADER ASSY 2..LOAB ASSY VWT1226 VWG2346 1..DAMP ASSY 1..DVD MAIN ASSY (XV-DV363) 1..DVD MAIN ASSY (XV-DV365K) XWK3318 XWM3341 XWM3342 1..COMPLEX ASSY 2..DISPLAY ASSY 2..USB ASSY 2..KEY ASSY 2..LED ASSY XWM3372 XWZ4256 XWZ4259 XWZ4261 XWZ4263 1..JACK ASSY 2..EUROSCART ASSY AWM8034 AWU8291 > Description Part No. 1..MIC ASSY (XV-DV365K ONLY) XWM3375 1..POWER SUPPLY UNIT 1..FM/AM TUNER UNIT XWR3012 AXX7248 F 11 XV-DV363 5 6 E 7 8 1 2 3 4 3.3 JIGS LIST Jigs list A Name Service Remote Control Unit DVD Test Disc (DVD-Video) CD Test Disc DVD Data Disc Speaker Cable with terminal Jig No. GGF1381 GGV1025 STD-905 GGV1269 SDS1174 (FL/WHITE) Remarks adjustment, diagnosis Check of DVD-Video Check of CD ID data setting For checking audio at the SP terminal SDS1175 (FR/RED), SDS1176 (SL/BLUE) SDS1177 (SR/GRAY), SDS1178 (C/GREEN) B Lubricants and Glues list Name Lubricating Oil Daifree Silicone Adhesive Screw tight Lubricants and Glues No. GYA1001 GEM1036 GEM1037 GYL1001 Remarks refer to "9.3 06 LOADER ASSY" refer to "9.3 06 LOADER ASSY" refer to "9.4 TRAVERSE MECHANISM ASSY-S" refer to "8.1.5 MECHANISM ADJUSTMENT" C 3.4 CLEANING D CLEANING Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Pickup leneses E Cleaning tools Cleaning liquid : GEM1004 Cleaning paper : GED-008 F 12 XV-DV363 1 2 3 4 5 6 7 8 A B C D E F 13 XV-DV363 5 6 7 8 1 2 3 4 4. BLOCK DIAGRAM 4.1 OVERALL WIRING CONNECTION DIAGRAM and LOAB ASSY A FM/AM TUNER UNIT (AXX7248) K No schematic Diagram CN5701 CN1 FM AM 1 2 3 4 11P FFC (ADD7543) 5 6 +9V TXR VSM RDS B B ( B 1/5- B 5/5) DVD MAIN ASSY CKS3376- CE DI CLK DO GND TXL 7 8 9 10 GND 11 CE DI CLK DO GND TXL (XWM3341:XV-DV363/WYXJ5) (XWM3342:XV-DV365K/WXJ/RE5) +9V TXR VSM RDS GND C D DVD LOADER VWT1226- CN102 CN1 J E 4 5 CN3 POWER SUPPLY UNIT (XWR3012) CN1 1 3 4 5 CN1001 B13B-PH-K-S AC_DET 2 MIC SW ECHOCONT V+10V MIC GND B13B-PH-K-S PG13KK-F22 1 AC_DET 1 F 2 F VS(VREF) 3 VS(VREF) VCC 4 VCC E 5 E D 6 D C 7 C SW(DVD/CD) 8 SW(DVD/CD) RF 9 B 10 A 11 VR650 12 VRCOM 13 TRAVERSE MECHA ASSY DXB1860- RF B A 2 2 SW10.5V 3 3 EV5.0V VR780 14 VR780 SW5.0V 4 4 SW5.0V GNDD 15 GNDD SW6.8V 5 5 SW6.8V LD(780) 16 6 6 7 7 SW3.3V(B) LD(650) 18 8 8 SW3.3V(A) GNDD 19 GNDD LIVE NEUTRAL SW3.3V(A) Pwr-ctr 9 9 Pwr-ctr GND 10 10 GND FL DC- 11 11 FL DC- AC POWER CORD PD GND 1 FL DC+ 12 12 FL DC+ -25.5V 13 13 -25.5V W V 10 V U 9 U HB 8 HB 7 W- 6 W+ V- 5 V- V+ 4 V+ U- 3 U- U+ 2 U+ V+5S 1 V+5S WW+ CN103 LD(780) GND 2 INSIDE 11 VRCOM EV5.0V SW3.3V(B) 12 W VR650 SW10.5V PD 17 INSIDE LD(650) VSHF 20 VSHF TRKG DRV 21 TRKG DRV TRKG RTN 22 TRKG RTN FOCS DRV 23 FOCS DRV FOCS RTN 24 FOCS RTN CN602 VKN1235 ST2+(B) ST1+(A) ST1-(~A~) CN601 S5B-PH-K-S LOAD1 2 1 LOAD+ GND +B B2P-VH 1 2 CN2 PICK UP ASSY OWY8087- 1 ST2-(~B~) SW2 F 12P FFC 3 1 SPINDLE MOTOR (XWM3375: XV-DV365K/WXJ/RE5) 2 CKS3370 STEPPING MOTOR 1 1 2 JA3922 3 RKN1004 1 VKN1243 GNDD GNDD (ADD7545-) MIC SW ECHOCONT V+10V MIC GND CN5702 OKN8001 24P FFC JA3921 AKN7003 MIC ASSY 5P FFC 3 4 5 CN3921 (XDD3232-) H 7 6 2 VKN2045 4P FFC CN101 GNDD A SW1 3 4 ST1-(~A~) CN104 B5B-PH-K-S LOAD- 2 LOAD+ 3 3 SW2 4 4 GNDD 5 5 SW1 PF05PP-B40 ADX7480- 2 ST1+(A) 1 XV-DV363 1 ST2+(B) 3 2 LOAB ASSY (VWG2346) 14 ST2-(~B~) 2 4 5 6 7 8 8 12 10 9 11 14 13 16 15 A 18 17 DATA2+ DATA2 SHIELD DATA2DATA1+ DATA1 SHIELD DATA1DATA0+ DATA0 SHIELD DATA0CLOCK+ CLOCK SHIELD CLOCKCEC NC HDMISCL HDMISDA 7 VSEL1 SQEEZE V+10 TVOUT_R GND TVOUT_L TVMUTE SCART_R GND SCART_L V+5 VSEL2 B GND G GND R DVDPOWER S_C GND V GND S_Y 19 1 1 2 2 3 3 5 5 4 4 6 6 7 8 9 10 11 12 13 14 15 16 7 (ADD7544) 6 5 23P FFC 4 3 DDC/CEC GND +5V HOT PLUG DETECT AKP7210(AKP7211) CN931 HDMI OUTPUT 2 1 8 9 10 11 12 13 14 15 16 17 17 19 19 18 18 20 20 21 21 22 22 23 23 CN451 CKS3388- VSEL1 SQEEZE V+10 TVOUT_R GND TVOUT_L TVMUTE SCART_R GND SCART_L V+5 VSEL2 B GND G GND R DVDPOWER S_C GND V GND S_Y JA451 XKB3054EURO CONNECTOR 2 3 4 5 I 6 7 8 9 EURO SCART ASSY (AWU8291) 10 11 12 13 14 15 16 17 18 19 20 21 CN461 CKS3388- JA403 XKB3060(VKB1122) 10 2 4 7 5 6 8 3 4 1 7 12 10 9 D IC5902 Vcc GND 15p:CKS3380 HPMUTE HP_L GNDD HP_R HP_DET GNDUSB V5USB V5USB USB_DP2 USB_DM2 GNDUSB KEY2 KEY1 V+10 LED CN5906 5 1 11 13 G 15p:CKS3380 CKS3378- CN5901 3 8 FLDATA FLCK FLCS REMOCON VE+5 VFDP FLDCFLDC+ GNDD GNDD KEY1 KEY2 KEY2A 1 6 DISPLAY ASSY KEY ASSY (XWZ4261) (XWZ4256) COMPOSITE VIDEO OUTPUT C 2 13P FFC(ADD7541) B 3 5 7 9 2 4 6 8 2 4 6 8 11 10 15 13 14 12 15P FFC (XDD3234) 1 3 5 7 12 10 9 11 14 13 15 HPMUTE HP_L GNDD HP_R HP_DET GNDUSB V5USB V5USB USB_DP2 USB_DM2 GNDUSB KEY2 KEY1 LED V+10 9 11 12 CN5601 REMOCON VE+5 VFDP FLDCFLDC+ GNDD GNDD KEY1 KEY2 KEY2A FLDATA FLCK FLCS CKS3378- CN5602 V 13 R OUT R IN L OUT GND GND L IN B SQUEEZE GND NC G NC GND GND R/C BLANK GND GND V/Y NC GND 1 FL AAV7104(AAV7107) Vout GP1UM27XKOVF D CN5908 CN5907 16 14 14 13 13 11 11 9 9 7 7 5 5 12 12 10 10 8 8 6 6 4 4 3 3 1 1 2 2 3 2 1 3P FFC (XDD3229-) 1 F 2 3 LED ASSY (XWZ4263) 1 KEY2A 2 GND 3 KEY1 4 LED 5 V+10 E USB ASSY (XWZ4259) 16 16 15 15 14 14 13 13 11 11 12 12 10 10 9 9 7 7 8 8 6 6 5 5 3 3 1 1 4 4 2 2 SDATA1 SDATA2 SDATA3 GND MCLK GND SCLK LRCLK GND LIN1_L GND LIN1_R GND S_TVOUT_L GND S_TVOUT_R RECMUTE GND SDATA4 TVIN_L TVIN_R GA UPPER EU,RUSSIA,KUC & J LINEOUT_L AUDIO IN/OUT E CN3111 AKB7114 CN3211 AKE7121 C ( C 1/2- C 2/2) DAMP ASSY (XWK3318) 1 FR+ 2 FR- 3 RR+ 4 RR- 5 FL+ 6 FL- 7 RL+ 8 RL- 6ch SP OUT +B 18 GND 17 1 2 B2P-VH 19 17 JA602 XKP3086 LINEOUT_R CN3201 GND SDATA4 19 18 HP OUT HEAD PHONE USB CN3002 CN3102 AKP7199AKM7077SDATA1 SDATA2 SDATA3 GND MCLK GND SCLK LRCLK GND LIN1_L GND LIN1_R GND S_TVOUT_L GND S_TVOUT_R RECMUTE JA5902 AKN7003- SLR-343BBT 15 16 5 LED 15 18 4 GND 17 LED V+10 LED 17 18 PCON XHPSEL HPL GND HPR GND 3.3V XRST XPDN XMUTE GND SDA SCL GND XOTW XSD SROUT POWER PLCCONT 3 GND 19 2 V+10V AKM7077- 19 V+10V AKP7199- PCON XHPSEL HPL GND HPR GND 3.3V XRST XPDN XMUTE GND SDA SCL GND XOTW XSD SROUT POWER PLCCONT 1 GND KEY1 CN5603 CN5909 CKS3368 CKS3368 CN3001 CN3101 KEY2A CKS3370 5P FFC (XDD3231) CKS3370 RKN1004 9 C+ 10 C- 11 SW+ 12 SW- F SR OUT 15 XV-DV363 5 6 7 8 1 2 3 4 4.2 OVERALL BLOCK DIAGRAM A B D DISPLAY ASSY DVD MAIN ASSY PCON (from SMPS or D-AM Display Driver FL DC DET VE+5 SYSTEM UCOM FL DC+/- KEY SCL SDA MUTE RESET VFDP PDN HP B SD OTW E USB ASSY USB USB POWER 27M V+5USB 5V V+6R8 ACLK USB DP USB DM BCKO BE ALRCK LRCKO MCLK MT1389 MCKO ASDAT0 DATAO A MOTOR DRIVER ASDAT1 ASDAT2 LOAB ASSY 64M SDRAM LOADER MECHA C • AUDIO PROCESSING • Audio Decode • Bass Management • Virtual Surround • Preset EQ 16M FLASH 64k EEPROM MCDATA etc. G,B,R V K Y,C FM/AM TUNER UNIT +9V TUNER ADBCK SCART LINE/TV A/D ADLRCK AK5358AET ADDATA MCACC 12.288M ADMCK0 D ADMCK1 74HCU04 MCACC LINE SCART XV-DV365K/WXJ/RE55 ONLY MCLK H MIC ASSY ACLK A/D ALRCK +9V AK5358AET 9V SW+10.5V MCDATA DVD POWER E V+5V SW SW5.0V V+3 SW SW3.3V(A) V+1R8 1.8V PWRCONT V+10 VE+5 F V+5 16 SW VE+5 V+6R8 V+3R3 XV-DV363 1 2 3 4 5 6 7 8 A C FRONT L DAMP ASSY PCON (from SMPS or D-AMP) FRONT R HP AMP DC DET MODULATER TAS5508BPAG SCL SDA MUTE RESET HP SEL PDN PWMA P SD OTW PWMA M CENTER DRIVER TAS5122DCA SUB WOOFER REAR L RESET B SD REAR R PWMB P PWMB M LINE OUT ch7 ch8 PWM LINE IN LPF SR OUT +3.3V C LINE SCART MCACC MIC MCACC SCART (EU) G, B, R Y, C Scart Circuit V I D EUROSCART ASSY G, B, R Video AMP V Y, C V Composite Y, C HDMI Transmitter TX HDMI OUT E V+3 V+1R8 FLDC +/- +B VFDP SW10.5V FV5.0V SW 5.0V J SW 6.8V SW F AC IN POWER SUPPLY UNIT SW 17 XV-DV363 5 6 7 8 1 2 3 4 5. DIAGNOSIS 5.1 METHOD FOR DIAGNOSING DEGRADATION OF THE LDS ON THE PICKUP A Case when this diagnosis is required : When playback of any disc, including a test disc (DVD: GGV1025, CD: STD-905), won't play or doesn't play How to diagnose In the case mentioned above, degradation of the laser diodes (LDs) mounted on the 06SD Pickup Assy-S is suspected. Measure the voltage between the two ends of one of the resistors mentioned below. No playback of a DVD : B Measure the voltage between the both ends of R322 or R325 on the DVD MAIN Assy. If the voltage is 0.4 V or higher, the 650-nm LD is degraded. No playback of a CD : Measure the voltage between the both ends of R321 or R326 on the DVD MAIN Assy. If the voltage is 0.4 V or higher, the 780-nm LD is degraded. If the measurements show degradation of an LD, replace the 06SD Pickup Assy-S. C PICKUP ASSY D B CN101 R1001 C374 R375 R372 Q307 C310 Front side 1 2 CONTACT SIDE 1 4 CN5601 C771 24 23 1 5 3 23 C320 R310 SIDE A [CN5603] 15 C372 R371 R374 R373 C161 C133 R136 4 C146 Q308 R321 R772 C773 C131 B1 CN101 CONTACT SIDE R135 R134 L309 C144 C145 R322 C309 R326 C373 C371 5 4 1 3 L308 Q305 R313 E R325 R318 R314 Q304 ICT FC1 R315 XWM 000 0 111 1 12 DVD MAIN ASSY IC771 C132 R771 L772 F 1 C772 C781 18 XV-DV363 1 2 3 4 5 6 7 8 5.2 DVD TROUBLE SHOOTING A No. 1 Symptoms Diagnosis Contents Possible Defective Points The power is not turned on. Are wires of output connector (POWER SUPPLY Unit) and CN1001 (DVD MAIN Assy) disconnected or damaged ? Check that the following voltage is output : Q1202-source on the DVD MAIN Assy: 3.3V 2 Connector / cable POWER SUPPLY Unit An opening screen is not Are the signals output from IC201-pin 97 (MDATA) and pin 98 (SCLK) displayed on the monitor on the DVD MAIN Assy ? (in the range of 0-3V) (The FL display lights. The mechanism does not work.) Are the signals input into IC5501-pin 50 (MDATA) and pin 51 (SCLK) on the DVD MAIN Assy ? (in the range of 0-3V) DVD MAIN Assy DVD IC (IC201) DVD MAIN Assy UCOM (IC5501) B Check that the following voltage are output : Q1302-collector on the DVD MAIN Assy: 5V DVD MAIN Assy 5V Regulator IC (IC751) Is a resonator (X201: 27MHz) on the DVD MAIN Assy oscillating ? DVD MAIN Assy Crystal resonator (X201) DVD IC (IC201) • Is a signal input into IC203-pin26 (PCE#) on the DVD MAIN Assy ? (Is a signal "H" for 80 mS and then "L" after the power is turned on ?) -> Communication with flash ROM. • Are the signals input into IC202-pin 16 (DWE#), pin 19 (DCS#) and pin 38 (SDCLK) on the DVD MAIN Assy ? (Is a signal fluctuating ?) -> Communication with SDRAM DVD MAIN Assy DVD IC (IC201) Flash ROM (IC203) SDRAM (IC202) C Is a signal output from IC203-pin 28 (PRD#) on the DVD MAIN Assy? DVD MAIN Assy (Is a signal fluctuating for several hundred mS after the power is turned Flash ROM (IC203) on ?) Is a signal input into IC5501-pin 67 (DVD ACK) on the DVD MAIN Assy ? (Is a signal fluctuating ?) -> Communication with FL Control IC DVD MAIN Assy DVD IC (IC201) UCOM (IC5501) Is a signal output from IC5501-pin 78 (XREADY) on the DVD MAIN Assy ? (Is a signal fluctuating in the range of 0-5V ?) DVD MAIN Assy UCOM (IC5501) Are the signals output from IC5501-pin 49 (SDATA) on the DVD MAIN Assy ? (in the range of 0-5V) DVD MAIN Assy DVD IC (IC201) UCOM (IC5501) D Are the signals of IC204-pin 5 (SDA) and pin 6 (SCL) on the DVD MAIN DVD MAIN Assy Assy fluctuating for one or two seconds after the power is turned? EEPROM (IC204) 3 An opening screen is not displayed on the monitor (The FL display lights. The mechanism works.) DVD MAIN Assy Check the video signal path between DVD IC (DVD MAIN Assy IC201) Video circuitafter DVD IC and video-out terminal (see the block diagram) (IC201) E F 19 XV-DV363 5 6 7 8 1 2 3 4 A No. 4 Symptoms A tray cannot be opened. (An opening screen is displayed on the monitor) Diagnosis Contents Possible Defective Points Does the voltage of CN104-pin 3 and pin 5 on the DVD MAIN Assy change normally ? Pin 3 (SW2(TRIN)): Tray is fully closed: "L" Pin 5 (SW1(TROUT)): Tray is fully opened: "L" Is the signal input into IC101-pin 11 (TROPEN) on the DVD MAIN Assy? At open: 3.3V, At close: 0V Are the signals output from IC101-pin 1 and pin 2 (CN103-pin 1 and pin 2) on the DVD MAIN Assy ? Pin 2: Approx. 6V during opening tray approx. 0V during closing tray. Pin 1: Approx. 0V during opening tray approx. 6V during closing tray. Are wires of CN104 and CN103 on the DVD MAIN Assy disconnected or damaged ? B 5 Playback impossible (no focusing) C 6 Playback impossible (Spindle does not turn) D 7 Playback impossible (Playback stops) Does the voltage of CN102-pin 1 on the DVD MAIN Assy change to 0V by pressing the Inside switch. Are the signals output from IC101-pin 3 (FOCS_DRV) and pin 4 (FOCS_RTN) on the DVD MAIN Assy ? Does 650-nm LD emit light ? Does a pickup lens move up / down ? Does an actuator spring bend ? Are plastic parts damaged ? Or is a shaft detached ? Is the turntable detached or tilted ? Is flexible cable of CN101 on the DVD MAIN Assy disconnected or damaged ? Is signal output from IC201-pin 42 (FOSO) on the DVD MAIN Assy ? (Device control of about 1.4 V is output usually. It is fluctuated by about 250 mV with focus up / down.) Are the signals output from IC101-pin 30 (W), pin 33 (V) and pin 35 (U) on the DVD MAIN Assy ? Is pin 26 (STBY) fixed LOW ? (pin 26 is High at playback: 3V) Is there any part detached from the spindle motor ? Or Is there any foreign object lodged in it ? Are wires of CN102 on the DVD MAIN Assy disconnected or damaged ? 8 E 9 No sound (Picture is normal) DVD MAIN Assy DVD IC (IC201) DVD MAIN Assy FTS Driver IC (IC101) Connector / cable Inside switch DVD MAIN Assy FTS Driver IC (IC101) Pickup Mechanism section (motor) Flexible cable / connector DVD MAIN Assy DVD IC (IC201) DVD MAIN Assy FTS Driver IC (IC101) Mechanism section (Spindle motor) Flexible cable / connector Is signal output from IC201-pin 37 (DMSO) on the DVD MAIN Assy ? DVD MAIN Assy DVD IC (IC201) Does 650-nm LD deteriorate ? If the voltage at each both ends of R322 and R325 on the DVD MAIN Assy is 0.4 V or more, the 650-nm LD is definitely deteriorated. Does 780-nm LD deteriorate ? If the voltage at each both ends of R321 and R326 on the DVD MAIN Assy is 0.4 V or more, the 780-nm LD is definitely deteriorated. 650-nm LD deteriorated. (When playback of a DVD is impossible) 780-nm LD deteriorated. (When playback of a CD is impossible) DVD MAIN Assy FG output : FTS Driver IC (IC101) Is there abnormality in FG waveform ? (IC201-pin 50) Picture disturbance during playback (block noise, freeze, other) LOAB Assy Tray SW (S101) Are there scratches or dirt on the disc ? Disc Are there scratches or dirt on the disc ? Is there a problem with the format of the disc ? Disc Check the video signals. Composite video signal (IC401-pin 25) S video signal (IC401-pin 21, pin 26) RGB video signal (IC401-pin 16, pin 18, pin 20) DVD MAIN Assy DVD IC (IC201) Video IC (IC401, IC451) Check the waveform (ALCK : IC201-pin 212), (ALRCK : IC201-pin 209), DVD MAIN Assy (ABCK : IC201-pin 210), (ASDATA0 : IC201-pin 197). DVD IC (IC201) F 20 XV-DV363 1 2 3 4 5 6 7 8 A Symptoms that may occur when any of the following ICs is in failure IC Symptoms EEP ROM (DVD MAIN Assy : IC204) User's data cannot be stored in memory. The ID number is lost. Flash ROM (DVD MAIN Assy : IC203) The power cannot be turned on. Downloading of the firmware cannot be performed. DVD IC (DVD MAIN Assy : IC201) Any kind of symptoms (no power, a failure in any of the servo, video and audio systems, etc.) may be generated, because the DVD processing is performed by a single chip. 64M SDRAM (DVD MAIN Assy : IC202) No power. Block noise is generated during playback. B C D E F 21 XV-DV363 5 6 7 8 1 2 3 4 5.3 CIRCUIT DESCRIPTION OF DIGITAL AMP. SECTION A To UCOM XSD 3.3V 20V 0V 0V 0V *1 *2 XOTW TAS5122DCA B TAS5508BPAG PCM Signal From DVD or ADC Filter and Volume Gate Drive Timing Control PCM -> PWM Protection IC3101 Gate Drive IC3201, IC3301, IC3401 *1 XSD : SD_AB (23pin), SD_CD (24pin) *2 XOTW : OTW (25pin) 0V C PWM Processor section Power Stage section Output LPF section PWM Processor section The PCM signals output from the DVD decoder or AD converter are input to this section, and their volume and sound quality are digitally adjusted. At the output stage, after conversion from PCM to PWM, the signals are output to the Power stage. Power Stage section In this section, timing is controlled so that the MOSFETs on the high and low sides will not be turned on simultaneously. The voltage of the PWM signals are raised to drive the gates of the MOSFET, and the PWM signals to drive the speakers are output from the MOSFET at the output stage. Detection and protection functions against short-circuiting of the output signals and temperature exceeding the standard value are also provided. D If the detection and protection work, the ports of the power stage ICs become the following state. Power Stage ICs No. IC3201 IC3301 IC3401 Protection Enable State SD_AB (23pin) => L SD_CD (24pin) => L OTW (25pin) => L Output LPF section The carrier elements, high-frequency signals that are unnecessary for these speakers, are eliminated. The signals passed through the LPF will become sine-wave signals, as shown in the figure above. E F 22 XV-DV363 1 2 3 4 5 6 7 8 5.4 SPECIFICATIONS FOR THE PROTECTION CIRCUITS FOR THE DIGITAL AMPLIFIER A The protection circuits for the Digital Amplifier are activated, following the specifications shown below. The error indication on the FL display shows the reason a protection circuit was activated. Upon diagnosis of the Digital Amplifier, refer to the specifications for the protection circuits here and the overview of the Digital Amplifier circuitry. 1. Overview The system microcomputer monitors the ports for shutdown requests (Pin 23:SD_AB and Pin 24: SD_CD) and the ports for abnormal-temperature detection (Pin 25: /OTW) of the Power Stage ICs (IC3201, IC3301, and IC3401). As soon as any abnormality is detected, it shuts the unit down. To notify the user of the possibility of a too high a volume, when the unit is turned on the next time, the volume level will be set to 0, and an error message will be displayed on the FL display. B 2. Ports on the system microcomputer to be used for detection Pin 77: SHUTDOWN Low voltage at this pin means overcurrent or voltage too low (= V+B27) at a Power Stage IC. Pin 79: XOTW Low voltage at this pin means the temperature at the Power Stage ICs exceeded 125°C. Note: As one Power Stage IC is provided with two channels, three Power Stage ICs (in total 6 channels) are mounted in this unit. For abnormality detection, the unit implements a logical OR operation regarding these three ICs. Therefore, which IC is abnormal cannot be known directly. To find which IC is abnormal, it is required to check the PWM outputs (35, 38, 47, 50 pin) of the each power stage ICs (IC3201, IC3301, IC3401). C 3. Detection timing Start : Detection starts 500 ms after the PWRCONT port (Pin 84) of the system microcomputer becomes active by your pressing the STANDBY/ON key. Finish : When the STANDBY/ON key is pressed again (when the power-off process starts). D 4. Operation of the protection circuits The following three protection circuits are activated when the conditions shown below are met: Overcurrent detection: Indication on the FL display: OC ERROR Conditions: If the SHUTDOWN ports, which are monitored every 10 ms, become low 7 times in succession Abnormal temperature detection 1: Indication on the FL display: OVERTEMP Conditions: If the XOTW ports, which are monitored every 10 ms, become low in succession for one minute. Abnormal temperature detection 2: Indication on the FL display: OVERTEMP (Prerequisite: The XOTW ports, which are monitored every 10 ms, become low three times in succession.) Conditions: The above prerequisite is upheld, and the conditions for an overcurrent detection are met. E Abnormal temperature detection 3: Indication on the FL display: OVERTEMP Conditions: The PCONFIG ports (21-pin), which are monitored every 30 ms, become more than 2Vrms more than 45% in one minute. 5. Process when the protection circuits are activated The unit is shut down within 30 ms after abnormality detection then the volume level is set to 0. The unit can be turned on immediately after the shutdown. F 23 XV-DV363 5 6 7 8 1 2 3 4 5.5 PASS/FAIL TEST PROCEDURE OF HDMI TRANSMITTER IC A 1 In a case where the HDMI video signal is not output No Is the analog video signal output? Malfunctions are caused around IC201 BE IC. Yes B Check if the HOME MENU or VCD playback picture is displayed when this unit is connected to a PC monitor equipped with a Yes DVI input. Purpose: To check if the HDMI output line, including the terminal, is in failure. (An HDMI <-> DVI conversion cable is required for checking.) No Check if the initialization process for HDCP, etc. is OK by connecting this unit with a Pioneer Plasma Display equipped with an HDMI input. NG OK The customer's monitor may not be compatible with this unit. Confirm the name of manufacturer and model of the monitor, and get a specific description of the failure. Then look for an identical case in a collection of past cases, or consult the design section. In some cases, upgrading the software or firmware for both the DVD player and the monitor will solve the problem. The HDMI transmitter IC (HDCP process block) may be in failure. Change IC201 or IC931. C Pass/fail test of BE IC (IC201: DVD MAIN Assy) Conduct proving of R264, R265, R267 and R271 (33 ohms x 44 set), and R266 (27 MHz clock) with an oscilloscope to check whether each signal varies in amplitude between H (3.3 V) and L at reproducing VCD, and whether 27 MHz clock is correctly output. OK Malfunctions are caused in HDMI IC (IC931 : DVD MAIN Assy) or in the output line between IC931 and CN931. In this regard, the frequency is around 1 GHz at the CLK and DATA line between IC931 and CN931, which makes it difficult to observe the waveform by a general oscilloscope. Check the connection with the HDMI connector and the HDMI cable, as well. NG Malfunctions are caused around IC201 BE IC or in IC201. D 2 In a case where the HDMI audio signal is not output The initial setting provides no sound. Has HDMI sound been changed in STAND-BY MENU? No Change mode. Yes Is a correct signal found by proving the output of 216 pin and 211 pin of IC201, R248 (HSPDIF) and R240 (HCLK : 22/24MHz clock) with an oscilloscope? No Malfunctions in IC201. Yes E No Is the signal as described above sent to the input of IC931? Malfunctions around IC931. Yes Yes Is the HDMI image output? Malfunctions in IC931. No Malfunctions are caused in the output line between IC931 and CN931. Check the HDMI connector, as well. F 24 XV-DV363 1 2 3 4 5 6 7 8 6. SERVICE MODE 6.1 TEST MODE A Test Mode Functional Specification 1 Test mode entry In the power ON state, press the [ESC] (A8-5F) key and [TEST] (A8-5E) key in order of the Test mode remote control unit. • OSD displays test mode. 2 LD ON Enter the test mode. DVD : Press the [TEST] (A8-5E) and [1] (A8-01) keys in order, and turn on the laser diode (650 nm). CD : Press the [TEST] (A8-5E) and [4] (A8-04) keys in order, and turn on the laser diode (780 nm). B 3 Release the Test mode • Turn off the power. • Press the [ESC] (A8-5F) key of the remote control unit and reset it. C D E F 25 XV-DV363 5 6 7 8 1 2 3 4 6.2 DISPLAY SPECIFICATION OF THE TEST MODE A 2 Character in bold : Item name : Information display 3 7 8 9 1 5 6 12 13 14 B 15 10 11 C 1 Address indication The address being traced is displayed in number. (as for the DVD, indication of decimal number is possible.) DVD : ID indication (hexadecimal number, 8 digits) [* * * * * * * *] CD : ID indication [* * * * * * * *] 2 Code indication of remote control unit [R – * * * *] In case of double code, display a 2nd code. a Disc sensing [DSC – * * *] The type of discs loaded is displayed. [DVD], [CD ] b Jitter value [J – * * * *] Note: Don't use it. c Version of the FL controller [FL: * * * *] Note: Don't use it. 3 Main unit keycode indication [K – * *] D d Region setting of the player [REG: *] Setting value : [1] to [6] 5 Tracking status [TRKG – * * *] Tracking on : [ON] Tracking off : [OFF] e Destination setting of the FL controller [MDL: * * * * / * * *] Four characters in the front represent code 01. Three characters in the back represent the destination code. J: /J, K: /KU, /KC, /KU/KC, R: /RL/RD, RAM : /RAM, LB: /LB, WY: /WY 6 Spindle status [SPDL – * * *] CLV : [CLV] Off : [OFF] 7 Mechanism (loading) position value [M – * *] Unknown : [01] or [41] Open state : [04] Close state : [08] During opening : [12] During closing : [22] f Version of the flash ROM [V: * *. * *] Flash ROM size [FLASH = * *] E 8 Slider position [S – * * * *] In Side Switch ON : [01] In Side Switch OFF : [00] F 9 Output video system [V – * * * *] NTSC system : [NTSC] PAL system : [PAL] Automatic setting : [AUTO] Scart terminal output [SK – * *] (Display only the WY model which can do the output setting of scart terminal.) VIDEO : [00] S-VIDEO : [01] RGB : [02] 26 XV-DV363 1 2 3 4 5 6 7 8 6.3 FUNCTIONAL SPECIFICATION OF THE SHORTCUT KEY A Only during normal playback, the following shortcut keys can be assigned by pressing a required key after pressing the ESC key of the remote control unit. To quit, press the ESC key Command Contents Conditions Remote Control Key Name Remote Control Code CLEAR (*1) A8-45 Memory clear and region / revision indication Average value measurement of DVD error rate 5 (*1) A8-05 CD error rate measurement 5 (*1) A8-05 AUDIO A3-BE Scart terminal output : VIDEO Scart terminal output : S-VIDEO WY, models equipped with Scart terminal Scart terminal output : RGB Progressive OFF Only for progressive models Progressive ON HDMI Resolution : 1920 x 1080i Only for HDMI models FL indication of ID number ZOOM ON (x4) Service mode indication (error rate indication, etc.) SUBTITLE A3-36 ANGLE A3-B5 R_SKIP A3-9D F_SKIP A3-9C PROGRAM A3-EC STEREO (*1) A8-4A ZOOM A3-37 CHP/TIM (*1) A8-13 CHAP (*1) A8-40 Title search Input mode IN Title No. input Search execution SIDE A (*1) Numbers (*1) PLAY (*1) A8-4D A8-00 to A8-09 A8-17 Region confimation mode A.MON (*1) Numbers (*1) A8-1E A8-01 to A8-08 Model information indication B C *1 : Test mode remote control unit Service mode indication (ESC + CHP/TIM keys) ID Address The error rate is always displayed in exponential notation, e.g., *.* * e - *, for both DVDs and CDs. EDC/ID/AV 1 error history (ID Address, EDC/ID Error, last eight errors) Calculation of the average error rate (ESC + "5" [Test mode remote control unit] keys) The average of the last eight error rates is calculated and indicated in exponential notation. After the calculation is completed, "OK" or "NG" is displayed. If "NG" is displayed, the disc tray will open (for both DVDs and CDs) For DVDs: OK with 5.0e-4 or less, for CDs: OK with 7.6e-3 or less D Indication of model information (ESC + CHAP keys) The items from 12 to 15 of the TEST MODE Indications are displayed. However, in the indications, S in the standard test mode is changed to CHIP VERSION, and M is changed to RF VERSION. For details, see 6.4. Region confirmation mode (ESC + A.MON [Test mode remote control unit] + "1"-"8" [Test mode remote control unit] keys) After you press the AUDIO key while holding the ESC key pressed and then input the region number, if the number is different from that set in the unit, an error message is displayed, and the tray opens. E F 27 XV-DV363 5 6 7 8 1 2 3 4 6.4 SPECIFICATION OF MODEL INFORMATION DISPLAY A To display model information : Press the ESC key then the CHAP key. To close the model information display : Press the ESC key. • Display contents 1 10 B 9 2 Don't care. 3 4 5 6 7 Character in bold : Item name : Information display C 1 Destination indication Display it according to model information set from the FL controller. 2 Region No. 3 Part number 4 ROM version 5 Flash size D 6 FL controller version 7 CHIP VERSION 9 Remote control code 0 Key code of Main unit E F 28 XV-DV363 1 2 3 4 5 6 7 8 6.5 FUNCTIONAL SPECIFICATION OF THE SERVICE MODE A • Display during Service Mode To enter Service Mode, press the CHP/TIM key while holding the ESC key pressed. To quit, press the ESC key. Service mode display 1 ID Address 2 Error rate (always displayed), in exponential notation ERROR RATE : ∗ ∗ ∗ ∗ ∗ ∗ ∗ (∗∗∗∗) Number of error B • Calculation of the average error rate For DVDs: OK with 5.0e-4 or less, for CDs: OK with 7.6e-3 or less ex) For DVDs • Step 1 • Step 2 ""e ""e -6 ""e -5 ""e -4 ""e -3 ""e -2 ""e -4 : OK : OK : Refer to Step 2 : NG : NG 3.0e -4 4.0e -4 5.0e -4 6.0e -4 7.0e -4 : OK : OK : OK : NG : NG C 3 EDC/ID error history (ID Address, EDC/ID errors, last eight errors) Note: ∗ Error of AV1 is not supported in this player. Indication plan contents D 3 1 2 E Character in bold : Item name : Information display F 29 XV-DV363 5 6 7 8 1 2 3 4 6.6 SERVICE TEST MODE A 1. Conditions During Service Test Mode • During Service Test mode, the unit will not be shut down for an emergency even if one of the failures mentioned below occurs. • After the unit has been shut down in Normal mode for an emergency upon detection of one of the failures mentioned below, you can turn it on immediately, without waiting for one minute, in Service Test mode. • The accumulated power-on time can be checked during Service Test mode. 2. How to enter Service Test mode B • Connect AC power cord with the STEST port (microcomputer terminal IC5501: 43-pin) at High (5 V). (See "Service Test mode connecting point".) Note: Initial function setting is DVD/CD. • Connect AC power cord while holding both the PLAY LIST 3 and POWER keys on the main unit pressed. The unit will be turned on, and the following indication will be displayed: Service Test mode starts, as follows: Note: If the power cord was disconnected immediately before, be sure to wait at least one minute before turning on the power in the manner mentioned above. Otherwise, the unit may not operate properly. Service Test Mode connecting point R5548 C5555 D1417 D1416 R1415 C1415 D1415 Q1413 DVD MAIN ASSY SIDE A R5557 V+3R3 D1403 Q1402 C5558 1 4 R5 IC5502 5 [[ G ]] A30C5/C7 R1404 R5559 KN5601 D R1403 R1401 8 1 R5545 B 51 50 Q5531 C1413 R5528 Q5532 NP R5542 STEST Q5535 Q5534 Q5533 R5543 R5530 R5541 UTEST R5546 R5547 FLDCFLDC+ 1/2 Connecting point C V+10 C5557 R1402 3. Indications on the FL display when Service Test mode is entered • Indications on the FL display when Service Test mode is entered differ depending on whether the unit was turned off normally or shut down for emergency protection, immediately before Service Test mode starts, as follows: D [After a normal power-off] FL display WE L COME FL display V O L FL display D V D 0 S E R V [After a shutdown caused by an AMP-system failure] E [After a shutdown caused by an EEPROM (IC5502) failure] FL display FL display P R T C T E FL display FL display V O L 0 FL display FL display D V D S E R V FL display D V D P R T C T V O L D V D S E R V [After a shutdown 1 caused by over current detection] FL display FL display FL display O V E R T EMP V O L D V D 0 FL display S E R V FL display OC FL display E E P E R R V O L D V D 0 S E R V [After a shutdown 2 caused by over current detection] E R R V O L D V D FL display 0 [After a shutdown caused by high-temperature detection] FL display F [After a shutdown caused by a DVD-system failure] FL display 1 0 FL display S E R V FL display OC E R R V O L D V D 2 0 S E R V 4. How to quit Service Test mode, and conditions for quitting • To quit Service Test mode, turn the power off or disconnect the AC power cord to turn the power off. • When Service Test mode is quit, only data on protection in RAM will be initialized, and data on user settings in RAM will not be initialized. 30 XV-DV363 1 2 3 4 5 6 7 8 A 5. Operations during Service Test Mode • Basically, operations in Service Test mode are the same as in Normal mode. However, to indicate that the unit is in Service Test mode, the following are displayed when the functions are changed: [Functions] [FL display] DVD/CD D V D S E R V USB U S B S E R V T X S E R V LINE1 L N 1 S E R V LINE2 L N 2 S E R V TUNER • When the function is set to LINE2, the Surround setting is fixed to X-STEREO (5 CH STEREO), which is only for Service Test mode. (In Normal mode, it is fixed to 2 CH STEREO.) In such a case, do not check the sound through the headphones, because headphone operation with X-STEREO (5 CH STEREO) is not guaranteed. If you wish to check the sound through the headphones, use a function other than LINE2. B 6. Failures • Depending on the types of errors, one of the following error messages will be displayed when the unit is turned on: P R T C T E A protection circuit was activated: 1. The V+10, V+5 or V+6R8 was short-circuited (See the protection circuit on "10.2 DVD MAIN ASSY (2/5)"), or the value at V+10, V+5, or V+6R8 exceeded the standard value because of an abnormality in its power section. 2. The XPROTECT port (22-pin) line up to the system-control computer (IC5501) was short-circuited by grounding or was broken. C D V D P R T C T Abnormality in the DVD section 1. The V+5V, or V+3 was short-circuited, or the value at V+5V, or V+3 exceeded the standard value because of an abnormality in its power section. 2. The VDET port (17-pin) line up to the system-control computer (IC5501) was short-circuited by grounding or was broken. (See VDET circuit on "10.2 DVD MAIN ASSY (2/5)") E E P E R R 1. Breakage or short-circuiting of the communication line between the microcomputer (IC5501) and the EEPROM (IC5502) can be suspected. 2. A failure in the EEPROM (IC5502) can be suspected. OC OC E R R E R R 1 2 D • If "OC ERR 1, 2" is not displayed when the unit is turned on in Normal mode, short-circuiting of the speaker terminals can be suspected. (It causes speaker cable "+", "-" short.) • If "OC ERR 1, 2" is displayed again when the unit is turned on in Normal mode, the following causes can be suspected: 1. One or more of the ICs among the three digital amplifier ICs (IC3201, IC3301, and IC3401: TAS5122DCA) on the DAMP Assy is in failure. 2. The line between one of the above digital amplifier ICs and the speaker terminals is short-circuited. 3. The SHUTDOWN port (77-pin) line from one of the above digital amplifier ICs to the system-control computer (IC5501) is short-circuited by grounding or is broken. O V E R T EMP • If "OVERTEMP" is not displayed when the unit is turned on in Normal mode, the unit is normal. The protection circuit was activated because the temperature at the three digital amplifier ICs (IC3201, IC3301, and IC3401: TAS5122DCA) had become too high. Because it is likely that this was a temporary temperature rise, lower the volume of the speakers. • If "OVERTEMP" is displayed again when the unit is turned on in Normal mode, the following causes can be suspected: 1. One or more of the ICs among the three digital amplifier ICs (IC3201, IC3301, and IC3401: TAS5122DCA) on the DAMP Assy is in failure. 2. The XOTW port (79-pin) line from one of the above digital amplifier ICs to the system-control computer (IC5501) is short-circuited by grounding or is broken. E F 31 XV-DV363 5 6 7 8 1 2 3 4 A 7. Accumulated power-on time display • Hold the STOP key on the unit pressed for 8 seconds during Service Test mode. After the version for the system-control computer is displayed, the accumulated power-on time is displayed. Version of the system-controller P D C 1 5 3 A About 3 seconds after Accumulated power-on time 1 0 H 3 0 M • Power-on time is always counted while the power is on, regardless of unit's functions and operations. However, it is not counted during Standby mode. • The maximum countable power-on time is 255H59M (255 hours 59 minutes.) The indication will not advance beyond that. • The accumulated power-on time basically cannot be cleared. B C D E F 32 XV-DV363 1 2 3 4 5 6 7 8 7. DISASSEMBLY Note 1: Do NOT look directly into the pickup lens. The laser beam may cause eye injury. Note 2: Even if the unit shown in the photos and illustrations in this manual may differ from your product, the procedures described here are common. A Diagnosis of PCB's 1 Bonnet, Tray Panel 1 2 Remove the bonnet by removing the nine screws. 3 4 5 6 Press the OPEN/CLOSE button to open the tray. Press the STANDBY/ON button to turn on the power. 2 7 B Remove the tray panel. Set the test disc. Press the OPEN/CLOSE button to close the tray. (Test disc is clamped.) 7 Press the STANDBY/ON button to turn off the power. 8 Pull out the Power cord. 5 Test disc 4 3 Tray 6 3 6 C Tray panel D How to open the tray when the power cannot be on Insert a screwdriver (small) into the slit located at the bottom of the unit, and slide the projection of the drive cam in the 06 LOADER Assy in the direction of the arrow, as indicated in the photo. If the tray pops out a little, fully pull it out by hand. Projection Screwdriver (small) E Slit Tray open Drive cam 06 LOADER Assy F Bottom view Screwdriver (small) 33 XV-DV363 5 6 7 8 1 A 2 3 4 2 Front panel section 1 2 Disconnect the one flexible cable. Remove the MIC knob. (XV-DV365K only) 1 USB Assy B MIC knob 2 3 Unhook the eight hooks. XV-DV365K only 3 3 C 3 3 3 3 3 3 D Note A: Do not use an electric screwdriver. If the screws are over-tightened, the screw threads may be damaged. E 4 A Remove the front panel section. F 4 34 Front panel section XV-DV363 1 2 3 4 5 6 7 8 A Removing the Traverse Mechanism Assy-S and 06SD Pickup Assy-S 1 06 LOADER Assy 1 Short-circuit point by soldering. Note: After replacement, connect the flexible cable, then remove the soldered joint (open). 2 3 4 3 4 3 Disconnect the four connectors. Remove the two screws. B Remove the 06 LOADER Assy. 06 LOADER Assy Rear view 06SD Pickup Assy-S 2 2 2 C 2 Note: Do not touch the bottom side of the 06SD Pickup Assy-S. If touched, the optical axis may be shifted. 1 DVD MAIN Assy 2 Bridge 04, Tray 1 2 3 Remove the one screw. D Remove the bridge 04. 1 Pull out the tray, then remove it by pressing the hook. 3 2 -2 Hook Tray E Bridge 04 3 Note when reinserting the tray -1 Drive cam Pin When reinserting the tray, first align the triangle printed on the loading base and the pin of the drive cam, then insert the tray. F Front side Loading base Triangle 35 XV-DV363 5 6 7 8 1 A 2 3 4 3 Traverse Mechanism Assy-S 1 Flexible cable for the spindle motor Dislodge the two flexible cables from their factory placement. Front Side B Note: Do not touch the IC for the optical axis. If touched, the optical axis may be shifted. 1 1 C Flexible cable for the pickup Bottom view D 2 3 Unhook the four hooks. Traverse Mechanism Assy-S 2 Remove the Traverse Mechanism Assy-S. 3 E 2 ×2 F 36 XV-DV363 1 2 3 4 ×2 5 6 7 8 A 4 06SD Pickup Assy-S Note: The 06SD Pickup Assy-S can be removed without removing the Traverse Mechanism Assy-S. (shown as Step 3.) 1 06SD Pickup Assy-S Front Side Disconnect the flexible cable for the pickup. B Note: Do not touch the IC for the optical axis. If touched, the optical axis may be shifted. 1 C Flexible cable for the pickup Bottom view D 2 3 2 Adjustment screw (skew screw VK1) Remove the two adjustment screws. Remove the 06SD Pickup Assy-S. 2 Adjustment screw (skew screw VK1) 06SD Pickup Assy-S E 3 Note: Be careful not to lose the adjustment spring (skew spring VK1). Adjustment screw (skew screw VK1) Adjustment spring (skew spring VK1) F 37 XV-DV363 5 6 7 8 1 A 4 2 3 4 Remove the one screw. 06SD Pickup Assy-S Note: The screw is secured with the silicone adhesive. Make sure to apply the silicone adhesive after reattaching the screw. Joint VK1B B Joint spring VK1 Hold spring 4 Silicone Adhesive GEM1037 C Arrangement of the flexible cable for the spindle motor : Conductive surface Hook Front Side D [Caution] DO NOT touch the OE IC. It occurs out of the optical axis due to the shock. E Hook F Bottom view 38 XV-DV363 1 2 3 4 5 6 7 8 A Arrangement of the flexible cable for the pickup : Conductive surface Note: Be sure to move the 06SD Pickup Assy-S to the innermost perimeter. 1 Fold the flexible cable for the pickup with the backing outward in the illustration below. 3 Pass the flexible cable through the hook. 88 mm Reference line 17 mm Hook Hook B 3 Make sure that the cable is loose C 2 Attach the flexible cable for the pickup to the connector. 4 5 Hook the part folded in Step 1 to the hook. Pass the flexible cable through the hook. Reference line Hook 2 5 4 D Hook Front Side Bottom View 6 7 Fold the flexible cable along the hook. Pass the flexible cable through the hook. E Hook 7 Hold Spring 6 Backing F Hook 39 XV-DV363 5 6 7 8 1 2 3 4 8. EACH SETTING AND ADJUSTMENT 8.1 ADJUSTMENT A 8.1.1 ADJUSTMENT ITEMS AND LOCATION Adjustment Items [Mechanism Part] Adjustment Points (Mechanism Part) Cautions: After adjustment, adjustment screw locks with the Screw tight. 1 Tangential and Radial Height Coarse Adjustment 2 DVD Error Rate Adjustment 1 2 Tangential adjustment screw [Electrical Part] 1 2 Radial adjustment screw Electrical adjustments are not required. B C D 8.1.2 JIGS AND MEASURING INSTRUMENTS E Screwdriver (large) Screwdriver (medium) TV monitor Test mode remote control unit (GGF1381) Screw tight (GYL1001) F Precise screwdriver DVD test disc (GGV1025) 40 Soldering iron XV-DV363 1 2 3 4 5 6 7 8 8.1.3 NECESSARY ADJUSTMENT POINTS When A Adjustment Points Exchange Parts of Mechanism Mechanical 1,2 point Exchange the 06SD Pickup Assy-S * After adjustment, screw locks with the Screw tight. Electric point Mechanical point Exchange the Traverse Mechanism Assy-S B Electric point Mechanical 2 point Exchange the Spindle Motor * After adjustment, screw locks with the Screw tight. Electric point C Exchange PCB Assy Mechanical point Exchange PC Board LOAB and DVD MAIN ASSYS Electric point D E F 41 XV-DV363 5 6 7 8 1 2 3 4 8.1.4 TEST MODE A POWER ON POWER B ON DISC SETOPEN/CLOSE (Player) C OPEN/CLOSE DVD disc (Player) TEST MODE: PLAY CHECK D DVD, CD ESC Press the play key ( ) of the normal remote control unit. GGF1381 Test mode remote control unit E An address is displayed TEST DSC - Notes: After going into test mode, if you play back the disc, "DISC-NON" is displayed. The video signal and the audio signal are outputted duvring the test mode. The SKIP key and the SCAN key are effective during the test mode. TEST MODE: OFF ESC POWER OR F GGF1381 Test mode remote control unit OFF 42 XV-DV363 1 2 3 4 5 6 7 8 8.1.5 MECHANISM ADJUSTMENT A 1 Tangential and Radial Height Coarse Adjustment START 06SD Pickup Assy-S Remove the 06SD Pickup Assy-S from the Traverse Mechanism Assy-S. Remove the joint and the joint spring of the 06SD Pickup Assy-S. Joint VK1B Note: Before removing the flexible cable for the pickup, soldering of the pickup circuit is necessary. For details, see “7. DISASSEMBLY”. B Joint spring VK1 Hold spring Pass through the guide shaft to a new 06SD Pickup Assy-S. Attach it to the Traverse Mechanism Assy-S. C 06SD Pickup Assy-S Guide Shaft D Put the joint between the Tangential (or Radial) adjustment scrw and the mechanism base and turn each screw to adjust the height. (Refer to "8.1.1 ADJUSTMENT ITEMS AND LOCATION".) Joint 7.5mm E Mechanism base Attach the Traverse Mechanism Assy-S to the 06 LOADER Assy. Turn it over and attach the joint and the joint spring. Arrange the flexible cables. (Refer to "7. DISASSEMBLY".) F 43 XV-DV363 5 6 7 8 1 2 3 4 A 2 DVD Error Rate Adjustment · Play the DVD test disc at inner track (around #30000) Notes: · Use disc: GGV1025 START Traverse Mechanism Assy-S Adjust the radial adjustment screw so that ERROR RATE becomes around "5E-4". A · Play the DVD test disc at inner track · Display ERROR RATE on the monitor B ESC CHP/TIM Traverse Mechanism Assy-S Fasten the radial adjustment screw so that ERROR RATE becomes around "1E-3". B ERROR RATE : "5E-4" ERROR RATE : "1E-3" 1E-3 C ERROR RATE B A 5E-4 · Unfasten the radial adjustment screw by 90 degrees step till ERROR RATE C becomes around "1E-3" again . · Record the number of rotation (N1). A Best point C (memorizing how much the screw was rotated.) Anticlock wise Clock wise Rotation of Radial screw and Tangential screw · Fasten the radial adjustment screw till the number of rotation becomes harf of N1. Best Radial point ESC ERROR RATE: - - - - Player Service mode end · Play the DVD test disc at outer track (around #200000) Monitor D Turn the POWER OFF in case of NG once, and perform the adjustment once again. G E ESC CHP/TIM N If error rate is OK, locks a root of tangential and radial adjustment screws with the Screw tight. Screw tight: GYL1001 Service mode Traverse Mechanism Assy-S Fasten the tangential adjustment screw so that ERROR RATE becomes around "1E-3". B CHECK OK In this check, the error rate that is less than "5E-5"is better. ERROR RATE : "1E-3" Disc playback normally. · The measurement of block error rate ESC CHP/TIM · Unfasten the tangential screw by 90 degrees step till ERROR RATE becomes around "1E-3" again . C · Record the number of rotation (N1). ESC F · Fasten the tangential adjustment screw till the number of rotation becomes harf of N1. Best tangential point Service mode end 44 XV-DV363 1 2 3 4 5 6 7 8 8.2 ID NUMBER AND ID DATA SETTING A Caution: For the DVD players compatible with DVD-RW, for playback of a DVD-RW disc (CPRM) and for the DVD players possessing HDMI output, for HDCP process, it is necessary that an individual ID number and ID data are set for each player. If the ID number and ID data be not properly set in the manner described below, future operations cannot be guaranteed. The ID number is written on the yellow label at the rear panel of the player. If there is no yellow label, before downloading FLASH ROM, take note of the ID number set following the procedures outlined in "ID Number Confirmation Mode" on the next page. Note: Enter ID numbers while the unit is in Stop mode so that the values set will be immediately written to the flash ROM. Setting an ID number or ID data is required in the following case: If "No NUM" or "NO DATA" is displayed on the FL display for a few seconds immediately after the power to the player is turned on or during Stop mode. 5 After entering all 9 digits, if you press the SEARCH key, the unit unconditionally sets the input number as the ID number. Then the unit automatically enters Player's Data Input Mode. (The SEARCH key is not accepted after all 9 digits have been entered.) B [Player's ID Number Setting] ID Number ? 000000001 JIGS AND MEASURING INSTRUMENTS 4 5 Compare Mode Enter Input ID Number ! Service Remote Control Unit [GGF1381] DVD Data Disc [GGV1269] C 6 This display appears when the PLAY key is pressed in Step 4. Enter a 9-digit number to compare. The number is also displayed on the FL display. ID Number Input Mode 1 To enter ID Number Input Mode, with no ID number set, such as in a case of immediately after upgrading the firmware, press the ESC key then the STEREO key. 7 By pressing the CLEAR key without having input a number, the unit returns to Step 2 without doing anything else. Each press of this key after a number has been input deletes one digit. Note: If a previous ID number and ID data, such as a factorypreset ID number and ID data, are maintained, the unit enters ID Number Confirmation Mode when the above keys are pressed. However, if only an ID number is maintained, the unit enters ID Data Input Mode. 6 2 Enter a 9-digit ID number. The ID number is also displayed on the FL display. 3 By pressing the CLEAR key without having input a number, you can exit this mode. Each press of this key after a number has been input deletes one digit. 2 3 [Player's ID Number Setting] ID Number ? --------- [Player's ID Number Setting] ID Number ? 000000001 Compare ∗∗∗∗∗∗∗∗∗ D Input ID Number ! 8 After entering all 9 digits, if you press the PLAY key, the unit compares the numbers input in Steps 2 and 6, and only if the numbers match, that number is set as the ID. Then the unit automatically enters ID DATA Input Mode. If the numbers do not match, the disc tray is opened, and the unit exits ID Number Input Mode. Exit Note: If you press the PLAY button before inputting a 9-digit ID number, the unit returns to Step 6 without doing anything else. Input ID Number ! [Player's ID Number Setting] ID Number ? 000000001 Compare 000000001 4 After entering all 9 digits, if you press the PLAY key, the unit enters Compare mode. Enter the same ID number again. Only if your two input numbers match, the ID number is set. Compare mode helps eliminate mistyping of the ID number. Note: If you press the PLAY button before inputting a 9-digit ID number, the unit returns to Step 2 without doing anything else. 8 F Enter Input ID Number ! 45 XV-DV363 5 E 6 7 8 1 A 2 3 ID Number Confirmation Mode 1 To enter ID Number Confirmation Mode after the ID number and the ID data are set, press the ESC key then the STEREO key. 2 The ID number already set is displayed. (It is also displayed on the FL display.) 3 Enter a 9-digit number for comparison. This is not required when you only wish to check the ID number visually. (The number is also displayed on the FL display.) B 4 4 By pressing the CLEAR key without having input a number, you can exit this mode. Each press of this key after a number has been input deletes one digit. 2 3 • Indication of an ID number already set An ID number already set is displayed in the following cases: 1) When the ESC key then the CLEAR key are pressed, user settings are cleared, then the ID number set is displayed on the screen. In this case, the ID number is not displayed on the FL display. 2) When the unit enters ID Number Confirmation Mode by your pressing the ESC key then the CLEAR key, the ID number set is displayed. In this case, the ID number is also displayed on the FL display. If you only need to confirm the ID number, you can exit this mode by pressing the CLEAR key or turning off the power. • Indication when no ID number is set [Player's ID Number Setting] ID Number ? 000000001 Compare ∗∗∗∗∗∗∗∗∗ If no ID number is set, the message "No NUM" flashes on the screen and FL display for a few seconds after the power is turned on or during Stop mode. Exit 4 Input ID Number ! C 5 After entering all 9 digits, if you press the PLAY key, the unit compares the number entered in Step 2 with the ID number set, and only if the numbers match, the unit automatically exits ID Number Confirmation Mode. If an ID data has not been entered, the unit enters ID DATA Input Mode. If the numbers do not match, the disc tray is opened, and the unit exits ID Number Confirmation Mode. D Note: If you press the PLAY button before inputting a 9-digit ID number, the unit returns to Step 4 without doing anything else. 6 After entering all 9 digits, if you press the STOP key, the unit compares the number entered in Step 3 with the ID number set, and only if the numbers match, the unit automatically deletes the ID number and exits this mode. If the numbers do not match, the disc tray is opened, and the unit exits this mode. (The STOP key is not accepted after all 9 digits have been entered.) [Player's ID Number Setting] ID Number ? 000000001 Compare 000000001 E Enter Memory Clear 5 6 Input ID Number ! F 46 XV-DV363 1 2 3 4 5 6 7 8 A ID DATA Input Mode NOTE: Be sure to use a specified DVD (ID) DATA DISC. 1 To enter ID DATA Input Mode, with the ID number set, press the ESC key then the STEREO key. 2 When the STEREO key is pressed, the unit enters ID DATA Input Mode. 5 When writing of the data read from the disc to flash ROM is completed, "Rom Write OK!" is displayed. After seeing this message, you can exit this mode by pressing the CLEAR key. Note: Whether or not the data have been written to flash ROM can be confirmed by watching for the message "Rom Write OK!" being displayed after the disc is read. [Player's ID Number Setting] ID Number ? [000000001] Compare >∗∗∗∗∗∗∗∗∗ 2 [Player's Data Input Mode] 5 Exit ID Data Setting Mode B Rom Write OK! Exit Input ID Number ! 3 If the DVD DATA DISC is loaded in this mode, the unit automatically starts reading the data. (If the DVD DATA DISC has already been loaded, the unit does not start reading the data. In this case, open then close the tray.) 4 To exit this mode, press the CLEAR key. While data are being read from the DVD DATA DISC, you cannot exit this mode. C 6 If the data cannot be read from the disc, the unit will be exited ID Data Input Mode and proceed to the display of “Pioneer” logo. • Indication when the data have not been set If no ID data are set after the ID number is changed, the message "NO DATA" flashes on the screen and FL display for a few seconds after the power is turned on or during Stop mode. [Player's Data Input Mode] D 4 Exit Insert The ID Data Disc ! E F 47 XV-DV363 5 6 7 8 1 2 3 4 9. EXPLODED VIEWS AND PARTS LIST NOTES: A Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION B C D Front side E Joint of Packing F 48 XV-DV363 1 2 3 4 5 6 7 8 (1) PACKING SECTION PARTS LIST Mark No. > Description 1 Power Cord ADG1127 2 FM Antenna ADH7030 3 AM Loop Antenna ATB7013 4 Video Cable XDE3046 5 Remote Control Mark No. Part No. Description 14 Setup Guide 15 Setup Guide 16 Setup Guide Part No. See Contrast table (2) (English / French) See Contrast table (2) A (German / Italian) See Contrast table (2) See Contrast table (2) (Dutch / Spanish) 6 NSP 7 Battery Cover AZN8018 Dry Cell Battery (AA/R6) XEX3002 17 See Contrast table (2) (Russian) NSP 8 Warranty Card ARY7065 9 Label (WEEE) ARW7322 10 Setup Guide Polyethylene Bag AHG7117 19 Packing Sheet AHG7053 (English / French) 20 Pad L AHA7454 Operating Instructions 21 Pad R AHA7455 22 Packing Case See Contrast table (2) Operating Instructions NSP 18 See Contrast table (2) B 11 See Contrast table (2) (German / Italian) 12 Operating Instructions See Contrast table (2) (Dutch / Spanish) 13 Operating Instructions See Contrast table (2) (Russian) C (2) CONTRAST TABLE XV-DV363/WYXJ5 and XV-DV365K/WXJ/RE5 are constructed the same except for the following : Mark No. Symbol and Description XV-DV363 /WYXJ5 XV-DV365K /WXJ/RE5 5 10 11 12 13 Remote Control Operating Instructions (English / French) Operating Instructions (German / Italian) Operating Instructions (Dutch / Spanish) Operating Instructions (Russian) XXD3121 XRC3292 XRC3293 XRC3315 Not used XXD3124 Not used Not used Not used XRC3294 14 15 16 17 22 Setup Guide (English / French) Setup Guide (German / Italian) Setup Guide (Dutch / Spanish) Setup Guide (Russian) Packing Case XRC3281 XRC3282 XRC3283 Not used XHD3704 Not used Not used Not used XRC3284 XHD3705 D E F 49 XV-DV363 5 6 7 8 1 2 3 4 9.2 EXTERIOR SECTION A B F XV-DV365K Only H C H I J C H E F A D A Refer to "9.3 06 LOADER ASSY". B B C B E C G G I D E G E I F (2/2) (1/2) D F D 50 XV-DV363 1 2 3 4 CONTACT SIDE NON-CONTACT SIDE XV-DV365K Only 5 6 7 8 (1) EXTERIOR SECTION PARTS LIST Mark No. Mark No. Part No. Description Diffusion Sheet Part No. 1 DAMP Assy XWK3318 26 2 DVD MAIN Assy See Contrast table (2) 27 XAK3577 Front Panel Assy See Contrast table (2) Rubber Foot VEB1325 3 DISPLAY Assy XWZ4256 28 4 USB Assy XWZ4259 NSP 29 Button XAD3254 Display Window See Contrast table (2) 5 KEY Assy XWZ4261 NSP 30 6 LED Assy XWZ4263 NSP 31 Front Panel See Contrast table (2) EUROSCART Assy AWU8291 32 Pioneer Name Plate AAM1107 MIC Assy See Contrast table (2) 33 Standby Button XAD3253 Tray Panel XAK3573 7 NSP 8 > Description 9 POWER SUPPLY Unit XWR3012 34 10 FM/AM TUNER Unit AXX7248 35 Bonnet (for service) XZN3192 06 LOADER Assy VWT1226 36 MIC Knob See Contrast table (2) 12 13P Flexible Cable/60V (J1903) ADD7541 37 Laser Caution VRW2257 13 11P Flexible Cable/60V (J1908) ADD7543 NSP 38 Name Label See Contrast table (2) 23P Flexible Cable/60V (J1909) ADD7544 NSP 39 Getter See Contrast table (2) 15 2P Housing Wire Assy (J1901) ADX7480 40 • • • • • 16 Connector Assy (J1901) PF05PP-B40 41 Screw PG13KK-F22 42 Screw BBZ30P080FTB Screw BSZ30P060FTC Screw VPZ30P080FNI NSP 11 14 17 Connector Assy (J1902) 18 3P Flexible Cable/60V (J1906) XDD3229 43 19 5P Flexible Cable/60V (J1905) XDD3231 44 20 15P Flexible Cable/60V (J1904) XDD3234 A B BBZ30P080FNI C 21 5P Flexible Cable/60V 22 Earth Spring W5.1 ABH7240 23 GND Plate W5.1 ABH7241 Chassis ANA7187 Rear Panel See Contrast table (2) NSP 24 25 See Contrast table (2) D (2) CONTRAST TABLE XV-DV363/WYXJ5 and XV-DV365K/WXJ/RE5 are constructed the same except for the following : Mark NSP NSP NSP NSP NSP No. Symbol and Description XV-DV363 /WYXJ5 XV-DV365K /WXJ/RE5 2 8 21 25 27 DVD MAIN Assy MIC Assy 5P Flexible Cable/60V Rear Panel Front Panel Assy XWM3341 Not used Not used XNC3498 XXG3302 XWM3342 XWM3375 XDD3232 XNC3503 XXG3304 30 31 36 38 39 Display Window Front Panel MIC Knob Name Label Getter XAK3572 XMB3271 Not used XAL3260 XAX3610 XAK3575 XMB3275 AAK8309 XAL3279 XAX3611 E F 51 XV-DV363 5 6 7 8 1 2 3 4 9.3 06 LOADER ASSY Refer to " Application of Lubricant". A Refer to "9.4 TRAVERSE MECHANISM ASSY-S". Pickup leneses Cleaning liquid GEM1004 Cleaning paper GED-008 Note : To DVD MAIN CN101 (Pickup) To DVD MAIN CN103 (Stepping Motor) Daifree GEM1036 To DVD MAIN CN102 (Spindle Motor) B Lubricating Oil GYA1001 A C To DVD MAIN CN104 A Lubricating Oil GYA1001 D A 06 LOADER ASSY PARTS LIST Mark No. NSP 1 2 E Mark No. Part No. Description Drive Gear Part No. LOAB Assy VWG2346 16 VNL1923 Traverse Mechanism Assy-S DXX2575 17 SW Lever VNL1925 VXX2912 18 Clamper Plate 04 VNE2342 3 Loading Motor Assy 4 • • • • • 19 Bridge 04 VNE2343 5 • • • • • 20 Clamper 04 VNL1969 6 Flexible Cable (24P) ADD7545 21 Screw JGZ17P028FTC VKP2253 22 Screw VBA1094 Tray VNL1920 Clamp Magnet VMG1029 7 F Description Connector Assy 2P 8 Floating Rubber VEB1351 23 9 Belt VEB1358 24 10 Stabilizer VNE2253 VNL1917 11 Loading Base 12 Float Base 04 VNL1968 13 Drive Cam VNL1919 14 Gear Pulley VNL1921 15 Loading Gear VNL1922 52 XV-DV363 1 2 3 4 5 6 7 8 A Application of Lubricant Lubricating Oil GYA1001 Around the shaft No. 11 Loading Base B Lubricating Oil GYA1001 C Lubricating Oil GYA1001 Lubricating Oil GYA1001 Lubricating Oil GYA1001 Inner side of a ditch No. 13 Drive Cam Lubricating Oil GYA1001 Inner side of a ditch No. 13 Drive Cam Lubricating Oil GYA1001 D Front View Rear View Daifree GEM1036 Concave of unevenness No. 23 Tray Daifree GEM1036 Concave of unevenness No. 23 Tray E Inner side of a ditch Daifree GEM1036 Top View Bottom View Concave of unevenness Daifree GEM1036 Daifree GEM1036 53 XV-DV363 5 6 F Side of the rib 7 8 1 2 3 4 9.4 TRAVERSE MECHANISM ASSY-S A Note : Refer to " Application of Lubricant". Note : When Spindle motor (No. 2) is replaced, Spindle screw (No.13) also need to be replaced at the same time. B C To DVD MAIN CN102 (Spindle Motor) Silicone Adhesive GEM1037 To DVD MAIN CN101 (Pickup Assy) D NON-CONTACT SIDE E CONTACT SIDE To DVD MAIN CN103 (Stepping Motor) Note : Spindle screw (DBA1252)(No.13) is the screw which applied special bond. Therefore the adhesion becomes inteffective when takes it off once. Spindle screw is the part which cannot recycle. When Spindle motor (No. 2) is replaced, Spindle screw (No.13) also need to be replaced at the same time. F 54 XV-DV363 1 2 3 4 5 6 7 8 TRAVERSE MECHANISM ASSY-S PARTS LIST Mark No. > Description Part No. 1 06SD Pickup Assy-S OXX8020 2 Spindle Motor N200 DXM1197 Guide Shaft VK1 DLA1940 NSP 3 NSP 4 Sub Guide Shaft VK1 DLA1941 NSP 5 Joint VK1B DNK4272 Joint Spring VK1 DBK1235 Stepping Motor VK1 DXM1201 NSP 6 7 NSP 8 Mechanism Frame VK1 DNK4160 9 Precision Screw VK1 DBA1209 10 Skew Screw VK1 DBA1211 11 Skew Spring VK1 DBH1516 Stepping Screw DBA1205 NSP 12 13 NSP 14 A B Spindle Screw VK1(for Service) DBA1252 Hold Spring DBK1297 C D E F 55 XV-DV363 5 6 7 8 1 2 3 4 10. SCHEMATIC DIAGRAM 10.1 DVD MAIN ASSY (1/5) A DVD MAIN ASSY B 1/5 (XWM3341:WYXJ5) (XWM3342:WXJ/RE5) IOA IOA V+5S to PICK UP CN101 *** R372 *** R371 *** LD(650) 18 GNDD 19 VSHF 20 L309 *** 22 FOCS DRV 23 FOCS RTN 24 (T) T+ (T) T(F)F+ (F) F- Q307 HN1A01F(YGR) (1/2) 1 1 4 2 C343 C346 C345 C344 C347 D A B C RF 1 1 1 1 1 2 3 4 5 6 (RF) 5 7 8 9 LDO2 10 6 11 3 12 Q307 HN1A01F(YGR) (2/2) 13 14 15 16 17 FTS Driver to SPINDLE MOTOR CN102 21 U+ 2 HU+ V+5S 1 C102 1 V+5S V+6R8 1 IC101 V+6R8 C101 W V U R151 1 C219 5600p 41 42 44 45 C216 15k 47 15k 48 0.1 49 50 10K 10K STBY STBY C217 2 51 52 53 54 55 0.1 A2 A3 A4 A5 A6 A7 A8 56 57 58 59 60 61 62 A18 A19 TROPEN 63 64 C271 0.1 C269 0.033 249 73 72 71 70 FOSO TRSO V+3 C220 0.1 V+3D ST1+ ST1ST2+ ST2- T+ T- 40 46 R767 R768 R213 R212 R211 R210 *** TRIN LOADLOAD+ F+ F- 38 69 CN601 37 68 A FG TROUT TRIN STBY ENDM TROUT 5 22k 51k 51k 67 3 SW1 R204 R205 R206 66 2 SW2 36 R769 33 R214 (F) (T) GNDD 4 35 1.5K 22K R770 33 C121 1 LOAD+ 34 R201 R202 39 V+5M LOAD- 33 3 AGND DVDA DVDB DVDC DVDD DVDRFIP DVDRFIN MA MB MC MD SA SB SC SD CDFON CDFOP TNI TPI MIDI1 MIDI2 LDO2 LDO1 SVDD3 CSO/RFOP RFLV/RFON SGND V2REFO V2O VREFO FEO TEO TEZISILV OP_OUT OP_INN OP_INP DMO FMO TROPENPWM PWMOUT1/V_ADIN9 TRO FOO VPLLVSS CAPPAD VPLLVDD3 USB_VSS USBP USBM USB_VDD3 FG/V_ADIN8 (PU) TDI/V_ADIN4 (JTAG) TMS/V_ADIN5 (JTAG) TCK/V_ADIN6 (JTAG) TDO/V_ADIN7 (JTAG) DVDD18 IOA2 (PU) IOA3 (PU) IOA4 (PU) IOA5 (PU) IOA6 (PU) IOA7 (PU) HIGHA0(PU) IOA18 (PU) IOA19 (PU) 65 LOAD+ 31 FMSO B5B-PH-K-S 1 30 C200 0.1 (T) (F) V+5M CN104 29 43 PWMOUT1 ST1- to LOAB ASSY LOAD- DMSO FMSO TROPEN PWMOUT1 TRSO FOSO R154 1.8 4 ST1+ R152 1.8 ST1-(~A~) 3 GNDM C153 0.01 YB C152 ST1+(A) ST2+ C133 *** ST2+(B) 2 ST2- 4.7 4.7 4.7 4.7 4.7 4.7 1 (S) (S) (S) (S) R131 R132 R133 R134 R135 R136 CN103 V1P4 SERVO DRIVER BD7995EFS 0.01 YB C151 0.01 YB STEPPING MOTOR to STEPPING MOTOR 100/10 GNDD VKN1235 27 1.8v HU- 0.1 0.1 3 C205 C218 HV+ 26 C213 0.1 3.3v 4 C208 2200p C210 2200p C211 100p V+ 0.1 32 C209 0.1 HV- C204 C206 47/35 C132 *** 5 C161 1000p V- DMSO C131 0.1 HW+ 1 6 C104 W+ R153 1 HW- V1P4 C146 2200p 7 V20 STBY C145 2200p W- 25 28 C143 *** 4 2200p 8 C144 HB 24 ENDM 1 U C103 9 HU+ HUHV+ HVHW+ HW- U 23 C215 47/35 C203 47/35 FG C142 *** V C141 *** V 10 22 1 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 W VCC HU+ HUHV+ HVHW+ HWHB SPGND1 U SPVM1 V SPGND2 SPVM1 W SPRNF FG CTL1 CTL2 SPIN DGND VC W 11 LDOP LDON FCO+ FCOTKO+ TKOAVM AGND TKIN FCIN LDIN DVCC SLVDD SLO1P SLO1N SLGND SLO2P SLO2N SLIN2 SLIN1 SLRNF2 SLRNF1 INSIDE 12 ST2-(~B~) 20 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 SPINDLE MOTOR LIMIT C140 R208 STBY V+5USB C773 0.1/16 D781 STBY STBY PWR# A16 A15 A14 A13 A12 A11 A10 A1 PCE# AD1 AD2 AD3 AD4 AD5 AD6 AD0 PRD# B 2/5 A0 AD7 A17 V+3D 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 D782 2.2 IC771 AAT4618IGV-0.5-1-TLB C782 4 5 C771 1/16 C783 STBY 3 2 1 C781 10/50 L772 ATL7002-A-T XFLAG R771 220 CTL R772 100k S-24CS64A 2 V+6R8 IC781 NJM2845DL1-05 OUT IN 3 1 2 1 NC 2 NC 3 NC 4 GND IC204 EEPROM R282 *** USBPOWER 0.1 GNDD FLASH V+3D STBY C772 R284 10k A16 ~BYTE~ VSS D15 D7 D14 D6 D13 D5 D12 D4 VCC D11 D3 D10 D2 D9 D1 D8 D0 ~OE~ VSS ~CE~ A0 XFLAG USB POWER CONTROL V+5USB VCC WP SCL SDA AYW7154 A15 A14 A13 A12 A11 A10 A9 A8 A19 NC ~WE~ ~RESET~ NC NC RY/~BY~ A18 A17 A7 A6 A5 A4 A3 A2 A1 3 8 7 6 5 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 USBN VTH1047 L761 1 1 C296 4 SDA 1000p B 2/5 USBP R219 10K SCL R218 10K C290 KN103 STBY IC203 GNDD FLASH S29AL016D70TFI010 E C289 D 19 C207 0.1 LDO2 LDO1 VKN1243 U- 18 C212 100p C E F MDI1 GNDD 251 LDO1 250 R256 15k C272 0.1 GNDD 5 3 252 4 2 6 L308 *** 21 TRKG RTN 1 OSP RFGND CRTPLP HRFZC 17 Q308 HN1A01F(YGR) (1/2) 100K AVDD3:256 IREF:255 RFGC:254 OSN:253 PD 5 GNDD 65:DVDD3 66:IOWR# 67:A16 68:HIGHA7(PU) 16 R318 HIGHA6(PU) HIGHA5(PU) HIGHA4(PU) HIGHA3(PU) HIGHA2(PU) 15 3 2 1 253 14 GNDD R315 10K 4 254 VR780 LD(780) Q305 UM5K1N MDI1 0.1 13 Q308 HN1A01F(YGR) (2/2) C273 12 3.3v 1.8v V+1R8 255 11 R313 100K A R207 STBY V+3 Q304 2SC4154(EFG) (2SC4081(QR)) 256 B V+3 V+3 C201 220/6.3 RF V+1R8 C202 220/6.3 A VR650 LD CURRENT CONTROL V+5S V+5S 3.3v (RF) 10 VRCOM TRKG DRV R373 D STBY B IOA R310 *** 9 C *** C320 8 RF *** R374 C310 47/35 SW R375 E C309 47/35 7 0.1 R321 C C371 4.7 6 4.7 5 R326 4 E D F 0.1 4.7 VCC STBY C372 R322 3 R325 VREF C374 100/6.3 4.7 2 R314 10K 1 F C373 TRAVERSE MECHA ASSY CN1 B GNDD V20 GNDD VKN2045- A19 B 1/5 56 XV-DV363 1 2 3 4 A18 A8 A7 A6 A5 A4 A3 A2 A16 A15 A14 A13 A12 A11 A10 A9 A20 GNDD PWR# F PCE# R285 *** PWR# GNDD 5 6 7 8 A (AD) 33 ASDAT0 33 ASDAT2 33 ASDAT1 R246 R245 (AD) SQUEEZE LETTER to VIDEO PART 10/50 *1 0.1 : 1608 Size (B/Cb) 182 (R/Cr) 181 VSYNC VSEL2 180 HSYNC 179 178 VSEL1 177 176 175 C236 0.1 C0 C1 C2 C3 R264 RAB4C330J-T 174 173 172 (MDMI) 171 170 C235 0.1 R265 RAB4C330J-T 169 168 167 R266 0 166 165 R267 RAB4C330J-T 164 163 C234 0.1 162 161 (MDMI) R271 RAB4C330J-T 159 158 157 C233 0.1 156 151 150 149 148 C281 220/6.3 R229 33 SDCKE R228 33 SDCLK C232 0.1 C283 0.1 145 144 143 C231 0.1 MA3 MA2 C230 0.1 MA1 MA0 MA10 DBA1 DBA0 DCS# DRAS# R225 DCAS# 33*4 DWE# RAB4C330J DQM1 142 141 140 139 R227 R226 138 137 136 135 134 133 132 33 0 131 MA4 MA5 MA6 MA7 MA8 MA9 MA11 SDCKE SDCLK DQM1 C284 DQ8 0.1 130 DQ8 129 DQ9 DQ10 DQ13 DQ14 C285 DQ15 0.1 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 VSS A4 A5 A6 A7 A8 A9 A11 NC CKE CLK UDQM NC VSS DQ8 VCCQ DQ9 DQ10 VSSQ DQ11 DQ12 VCCQ DQ13 DQ14 VSSQ DQ15 VSS IC202 146 VCC A3 A2 A1 A0 A10/AP BA1 BA0 CS RAS CAS WE LDQM VCC DQ7 VSSQ DQ6 DQ5 VCCQ DQ4 DQ3 VSSQ DQ2 DQ1 VCCQ DQ0 VCC 64M SD-RAM K4S641632K-UC75-K 147 V+3DR 0 152 V+3D 1 153 R281 154 C282 MA4 MA5 MA6 MA7 MA8 MA9 MA11 155 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 6.8k R294 R293 3.3k XDVDRST LIMIT D MA3 MA2 MA1 MA0 MA10 DBA1 DBA0 DCS# DRAS# DCAS# DWE# DQM0 DQ0 C288 0.1 DQ1 DQ2 DQ3 DQ4 C287 0.1 DQ5 DQ6 DQ7 C286 E (F) (T) (S) (C/V) GNDD B 2/5,3/5 KN202 STBY HDMI (RF) 80 DOWNLOAD Y4 Y5 Y6 Y7 0.1 XDVDRST INT0# CN204 B4B-PH-K-S C C4 C5 C6 C7 VCK Y0 Y1 Y2 Y3 160 HDMI 4 3 2 1 4.7k 50 MDATA 51 SCLK 67 ACK 49 SDATA R215 3.3k R216 CH : CCSRCH~ OTHERS : CKSRYB~ B_CB R_CR 183 3.3v 1.8v 1 C250 R279 2.2k C245 C237 220/6.3 0.1 184 : 2125 Size CKSQ**~ G_CY 185 33k R223 R222 DQM0 R261 DQ7 DQ6 DQ5 DQ4 DQ3 R272 DQ2 DQ1 DQ0 DQ15 DQ14 *1 SCL SDA HDMISCL HDMISDA A17 A0 78 C244 186 CAPACITOR S_C CVBS GNDD 6.8k AD7 R292 3.3k R291 XREADY 33 33 33 33 33 33 33 33 R221 R237 R234 R258 R259 R260 R262 R263 RXD TXD R224 AD2 AD3 AD4 AD5 AD6 187 C229 0.1 C227 220p R220 STBY STBY R236 C226 0.01 R235 4.7k C225 0.1 C224 0.1 33 0 R233 0.1 188 DQ9 DQ10 DQ11 DQ12 DQ13 A9 A20 PCE# A1 PRD# AD0 AD1 189 128 127 126 125 124 123 122 121 120 119 118 117 116 115 114 113 112 111 110 109 108 107 106 105 104 103 102 99 98 101 97 100 96 95 94 93 92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76 75 74 33 33 - (S_C) (C/V) (G/Y) C243 190 : 1608 Size (F) : RS1/16S****F OTHERS : RS1/16S***J S_Y 191 GNDD UCOM 0 0 0 10 33 33 33 33 - (S_Y) 192 3.3v 1.8v V+3DR 0 0 0 10 33 - : 2125 Size RS1/10S***J DQ11 DQ12 3.3v 1.8v R257 R240 R247 R243 R248 R249 R262 R263 R222 RESISTOR 193 195 196 194 C246 0.1 197 198 199 200 201 202 203 204 C248 0.1 C247 0.1 10k R230 206 207 208 209 205 C239 0.1 210 211 212 213 214 215 216 217 218 219 220 221 C222 C228 C223 C241 10/50 222 223 224 225 227 228 229 230 231 232 233 234 235 236 237 238 239 240 241 242 243 226 C240 STBY STBY 10/50 C242 0.1 C238 0.1 C260 0.1 C258 0.047 C259 0.047 C266 244 245 246 0.1 C268 0.1 247 248 HIGHA1(PU) IOA20 XIOCS IOA1 XIOCE AD0 AD1 DVSS AD2 AD3 AD4 AD5 AD6 IOA21 ALE AD7 DVSS A17 IOA0 DVDD18 UWR# URD# DVDD3 UP1_2 (PU) UP1_3 (PU) UP1_4 (PU) UP1_5 (PU) UP1_6 (PU) UP1_7 (PU) UP3_0 (PU) UP3_1 (PU) UP3_4 (PU) UP3_5 (PU) ICE (PD) XPRST IR XINT0 DQM0 IO_19 RD7 RD6 RD5 RD4 RD3 DVDD3 RD2 RD1 RD0 RD15 126:RD11 RD14 127:RD10 RD13 128:RD9 RD12 DVD BE WXJ/RE5 B STBY I/XP RFRPAC RFRPDC RFVDD3 ADCVSS ADCVDD3 LPFOP LPFIN LPFIP LPFON PLLVDD3 IDACEXLP PLLVSS JITFN JITFO XTALI XTALO RFVDD18 RFGND18 ADACVDD2 ADACVDD1 ALF/(CTR) ALS/SDATA0 AL/SDATA2 AVCM AR/SDATA1 ARS/SDATA3 ARF(SW) ADACVSS1 ADACVSS2 APLLCSS APLLCAP APLLVDD3 SPDIF MC_DATA ASDATA4 DVDD18 ASDATA3 ACLK ABCK ALRCK DVDD3 SPBCLK SPLRCK SPDATA SPMCLK ASDATA2/GPO_0 ASDATA1/GPO_1 GPIO_3 GPIO_4 RCLKB/GPIO_5 RVREF/GPIO_6 ASDATA0/GPO_2 DACVDDC VREF FS YUV0/CIN MT1389FE/H-L WYXJ5 B 4/5 R209 Chip Size DACVSSB YUV3/CVBS DACVDDA DACVSSC:192 YUV4/G YUV1/Y:191 DACVSSA DACVDDB:190 YUV5/B YUV2/C:189 YUV6/R VSYNC/V_ADIN1 YUV7 HSYNC/VADIN2 DVSS IO_17 C0/IO_0 C1/IO_1 DVDD18 C2/IO_2 C3/IO_3 C4/IO_4 DVDD3 C5/IO_5 C6/IO_6 C7/IO_7 YUVCLK/IO_8 Y1/IO9 Y2/IO10 Y2/IO11 Y3/IO12 Y4/IO_13 DVDD18 Y5/IO_14 Y6/IO_16 Y7/IO_16 DVDD3 RA4 RA5 RA6 RA7 RA8 RA9 RA11 DVSS CKE RCLK DVDD3 RA3 RA2 DVDD18 RA1 RA0 RA10 BA1 BA0 XRCS XRAS XCAS XRWE DQM1 DVDD3 IO_18 RD8 GNDD VIDEO (Page 2/2) V+3 3.3v 1.8v 3.3v IC201 *1 (Page 2/2) PRDN 1.8v GNDD B 2/5,3/5,5/5 AUDIO R244 STBYADDATA R250 ACLK GNDD ABCK ALRCK STBY 33 33 R268 R243 R269 10 0 R248 C262 10/50 C261 0.1 R254 750K XO PUSEL *1 C270 3 C254 1000p C255 0.47 C256 10/50 4 1 14 R242 R241 R252 0 C264 0.1 IC205 STBY 5 2 100K C267 1000p C265 22p R255 100K R251 STBY 27MHz 12 to AUDIO PART ASPDIF V+3D R253 680 VSS1168 13 R249 GNDD X201 V1P4 R247 HSPDIF MCDATA R240 HCLK C252 12p C251 9p XAMUTE 11 *1 R257 (S_Y) (S_C) (R/Cr) (G/Y) (B/Cb) (AD) (HDMI) B 5/5 : RF SIGNAL ROUTE : FOCUS SERVO LOOP LINE : TRACKING SERVO LOOP LINE : STEPPING SERVO LOOP LINE : VIDEO SIGNAL ROUTE(C/V) : VIDEO SIGNAL ROUTE (S_Y) : VIDEO SIGNAL ROUTE (S_C) : VIDEO SIGNAL ROUTE (R/Cr) : VIDEO SIGNAL ROUTE (G/Y) : VIDEO SIGNAL ROUTE (B/Cb) : AUDIO DATA SIGNAL ROUTE : VIDEO/AUDIO SIGNAL ROUTE (HDMI) 6 B 1/5 57 XV-DV363 5 F 7 8 1 2 3 4 10.2 DVD MAIN ASSY (2/5) VE+5 XWM R5513 R5514 R5515 R5516 CN5501 52045-0745 2 XV-DV365K /WXJ/RE5 3342 15K 68K 82K 15K 7 STBY C5597 3 4 VSS NC 5 RST VCC 6 B 4/5,5/5 R3951 47k R3952 47k V+10 GNDD VE+5 CKS3378 HP_L 100/16 C3952 15 HP_R B 3/5 C5604 1 STBY 2 3 19 69 C5605 4 STBY 5 6 MIC_DET USBPOWER XDAMUTE μ-COM XT2 VSS1 XDAPDN XDARST KEY1 CF1 EEP_DI CF2 IC5501 VDD1 DVDACK TXIDATA PDC153A/A8 SIMUKE MODEL RDSDATA VDET KEY1 RDSPOW KEY2 DIRERR TXODATA NC TXCLK EEP_SK PCONFIG NC EEP_DO DSPMODE DATASEL SDATA MDATA EEP_CS VSS2 VDD2 XDSPRST UTEST STEST XFLAG BUSY NC TXCE SCLK R5502 STBY STBY *2 XFLAG 0.01 R5565 R5564 EU 220 220 62 220 R5562 C5555 0.1/16 STBY STBY 0 R5598 R5543 STBY 0 R5546 10k R5548 RAB4C221J 220 72 R5545 STBY C5603 1000p REMOUT 10 2 3 1 11 12 13 C5601 1000p F GNDD VFDP FLDC- FLDC+ KN5601 STBY CHASSIS GND B 2/5 58 XV-DV363 1 2 3 STEST GNDD C5602 1000p 9 VE+5 UTEST *1 R5538 R5542 R5544 61 60 58 57 R5557 RAB4C221J 220 SHORT for TEST POINT 48 49 50 51 52 R5542 RAB4C221J 220 R5541 RAB4C221J 220 *1 C5539 0.1/16 WYXJ5, WXJ/RE5 R5522 STBY R5531 0 R5537 STBY 71 70 69 68 67 66 65 64 R5563 R5566 10k RAB4C221J 220 C5569 GNDD GNDD 74 R5570 RAB4C221J 220 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 INPUTSELB VDD4 INPUTSELA VSS4 NC DASCK DSPHREQ DASDA R5576 R5575 R5571 0.01 R5547 10k XTVMUTE XADPDN DSPDO DSPCK ADMD XPROTECT DSPDI 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 XADPDN(MIC) VSS3 BEATCUT1 VDD3 PWRCONT HPDET HPSEL DVDPOWER BEATCUT2 FLASHDO FLASHE/D FLASHCLK PLC_CONT UTESTMODE XDIRRST ECHO_CONT2 ECHO_CONT1 (DMUTECHECK) DIRDO XDIRCS SR+TX C5577 7 8 *2 100 99 98 XREADY SHUTDWN SR+RX 80 79 78 77 220 4 PWRCONT 84 69 36 22 XPROTECT RAB4C221J R5577 *1 C3951 100/16 13 14 B 1/5 B 1/5 STBY DSPMUTE 72 ACDET 4 USBN STBY 1K R5543 11 12 XOTW 45 46 47 USBP XT1 41 10 XRESET XDVDRST *1 STBY STBY STBY STBY *2 *1 *1 83 V+5USB CN5602 KEY2A KEY2 KEY1 GNDD GNDD FLDC+ FLDCVFDP VE+5 REMOCON FLCS FLCK FLDATA R5536 220 9 REMOCON 31 R5531 32 R5532 R5533 34 R5534 R5535 36 R5536 R5537 R5538 7 8 RDSCLK R5544 0.01 C5519 STBY 5 6 C5606 STBY to DISPLAY CN5901 D 1.8k R3955 TO USB ASSY CN5906 4 *2 R3954 STBY L3952 CTF1346V+5USB 100K R5571 KN5501 STBY CHASSIS GND 0.01 *1 E C3954 3 27 28 29 R5527 30 220 RAB4C221J P_ON XHPMUTE XRECMUTE R5514** R5516 ** R5513 ** MODEL R5515 ** 10k 1 31 B Q3951 RT1N241M (DTC124EUA) GNDD C3953 R3953 STBY STBY CTF1346L3951 CKS3380 E R5525 STBY E 2 220 *1 XTVMUTE C HPMUTE HP_L GNDD HP_R HP_DET GNDUSB V5USB V5USB USB_DP2 USB_DM2 GNDUSB KEY2A KEY1 LED V+10 R5512 STBY 17 R5517 220 19 RAB4C221J 21 22 R5521 R5522 220 RAB4C221J 1M 20 C5521 0.1 C5522 0.01 23 24 25 VE+5 CN5601 X5501 ASS7034 10MHz R5569 220 69 C5517 0.01 R5518 GNDD D 220 0.1/16 C5509 VU+5 C5518 0.1 R5519 DESTINATION C 220 R5507 0.01 VE+5 EU R5506 FLCLK ACDET LED XDEC MUTE C5508 REMOCON 220 DSPMUTE 6 7 GNDD R5505 XFLCS 37 38 0.01 FLDAT 35 C5504 R5502 C5578 1 2 3 4 33 STBY Q5525 E RT1N431M (DTC143EUA) WXJ/RE5 WYXJ5 *2 100 99 98 R5595 97 STBY 97 96 R5596 R5590 STBY RAB4C221J 95 220 94 93 93 92 R5597 91 90 15K 89 C5589 0.1 88 87 STBY R5587 87 86 STBY R5586 86 85 STBY R5585 85 84 220 R5584 84 83 10k R5583 83 C5579 R5574 82 100k 1000p 82 81 R5582 220 R5581 220 C5502 100/10 C5501 STBY R5600 *1 R5598 STBY RAB4C221J 220 4 5 47k R5501 RAB4C221J 220 R5508 2.2K STBY C B C5525 R5503 STBY C5503 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 C5524 10/50 R5500 STBY R5510 RESET 1 2 3 VU+5 VE+5 VE+5 IC5503 STBY R5509 0 B 1/5,3/5 B UCOM GNDD UCOM VE+5 DVDPOWER DSP XDSPSS STBY 1 WEN/DI WDD WCLK XV-DV363 /WYXJ 3341 68k 47k 15k ** DOWNLOAD μ-COM A 57 60 58 68 17 5 6 7 8 DVD MAIN ASSY B 2/5 (XWM3341:WYXJ5) A (XWM3342:WXJ/RE5) D1416 *3 D1417 *3 V+10 *3 D1415 C1413 D1416 D1417 WYXJ5 WXJ/RE5 UDZS 4.7B STBY STBY R5943 0 REMOUT V+3R3 B D1403 MC2846-11 2 1 R1402 3.3k E 3 REMOCON VE+5 39k Q5941 RT1N241M (DTC124EUA) GNDD SROUT D5941 R5947 B D5942 1k R801 4.7k NC 7 EEPROM 6 TEST GND 5 DO C5558 47p V+5V V+3R3 V+5 TX D μcom FL DRIVER VE+5 HDMI AC_DET 2 SW10.5V 3 EV5.0V 4 SW5.0V 5 SW6.8V USB BUS R1307 4.7k 1 C1301 1 V+6R8 FTS DRIVER Q1304 2SC4154(EFG) E (2SC4081(QR)) 10k 0.1 C1501 C1505 100/10 0.01 L1501 22 LAU-TA B13B-PH-K-S MIC C B CN1001 V+10 *5 AUDIO BUFFER R1304 560(1/10W) R1306 B B R1302 3.9k MODULATOR C Q1303 2SC4154(BFG) (2SC4081(QR)) E V+3R3 DSP A/D 6 GND 7 SW3.3V(B) DATA SELECTOR R1101 220 8 SW3.3V(A) 9 Pwr-ctr 10 GND 11 FL DC- 12 FL DC+ 13 -25.5V D 1 GNDD C1101 STBY Q1302 2SA1577(QR) Q1301 2SA1602A(EF) (2SA1576A(QR)) R1303 47k R1201 10k 0.056 C1204 S G STBY IC1101 NJM2846DL3-18 5 1 2 4 3 B 4/5,5/5 POWER SUPPLY INPUT SELECTOR V+5V L1305 VTL1095 μcom GNDD HDMI V+1R8 VIDEO DRIVER V+5S R1305 STBY E BACK END IC PU SCART D1201 R1202 470k 1 R1204 C1201 V+5M VU+5 Q1201 RT1N141-11 C (DTC114EUA) C1102 V+5M V+10 C : 1SS352 (1SS355) (MA111) SCART BACK END IC GNDD : 1608 Size CCSR**~ CKSR**~ V+5M GNDD FTS DRIVER Q1202 RSR015P03 C1103 47/35 V+5S V+10 FLASH ROM V+3 V+1R8 VE+5 V+6R8 : 2125 Size CKSQ**~ V+5S VE+5 V+6R8 D1501 STBY SDRAM V+5 V+3R3 C1502 V+3 V+5 R1301 47k DI GNDD V+5V CN3 VCC 8 : 1608 Size RS1/16S~ : R5513, R5514 * R5515, R5516 RD1/4PU~ CAPACITOR R5945 3.9k R5949 10k E : 2125 Size RS1/10S~ J CS SK GNDD HDMI V+3 C801 STBY 1 2 3 4 V+5V S-93C46BD01-J8T1 C5557 0.1/16 47k R5559 CH 47k R5558 B 1/5 IC5502 VE+5 D802 C USBPOWER Chip Size RESISTOR Q5942 2SA1602A(EF) (2SA1576A(QR)) E R5944 100k B C R5946 4.7k GNDD from POWER SUPPLY C B V+6R8 V+5 SR OUT R1404 *3 C1413 D1415 C1415 *3 STBY Q1402 2SA1602A(EF) 47K R1403 1.8k V+10 Q1413 RT1N241M (DTC124EUA) 3.9k R1401 R1415 PROTECT GNDD DVDPOWER FLDC- FLDC+ VFDP R1001 CHASSIS GND KN1001 STBY STBY FL GNDM E GNDD PCB BINDER: VEF1040- F B 2/5 59 XV-DV363 5 6 7 8 1 2 3 4 10.3 DVD MAIN ASSY (3/5) A V+3R3 from Ucom PART CN3001 AKP7199-A HP_L 15 HP_R V+10 DATA0 ASDAT1 ASDAT2 Q3005 (2/2) HN1A01FU(YGR) (RT3AMMM) R3010 B2 1k MCKO 10/50 22k VREF 10/50 22k TVOUT_R ASDAT3 R3003 STBY VREF C3016 R3016 GNDD 22k 10/50 VREF Q3006 RT1N241M GNDD SCART_L B 4/5 SCART_R R3915 30 29 VE+5 R3039 15k 22k C3015 R3015 MICOUT R3020 R3019 2.7k 2.7k R5703 STBY V+5 RDS 0 47/35 C5713 4700p IC5701 LC72725KM QUAL RDSCLK 16 RDSDATA VREF MPXIN VDDA VSSA FLOUT CIN RST 15 14 13 VDDD 12 VSSD 11 MODE 10 9 T1 XO C5712 27p X5701 ASS7004 C5714 27p 4.322MHz XI CH C5716 560p CH GNDD GNDD F B 3/5 60 XV-DV363 1 C5720 47/35 C5719 10/50 1 2 3 4 5 6 7 8 C5715 0.01 STBY STBY Q5701 STBY R5706 STBY B2 Q5703 (2/2) HN1C01FU (RT3CLLM(EF)) R5710 STBY R5704 C5706 E C2 1000p R5719 STBY B Q5703 (1/2) HN1C01FU (RT3CLLM(EF)) R5708 R5705 STBY C5707 9 C E2 100p CH STBY STBY 100p CH 11 52 62 61 66 C5701 C5709 C5702 C5703 6 GND R5715 STBY STBY R5717 STBY R5718 STBY 5 7 STBY STBY R5716 3 4 V+5 V+10 R5707 STBY 2 +9V TXR 8 VSM RDS 10 C3020 10/50 C5708 1 C5704 STBY C5705 STBY K CN1 to TUNER MODULE CE DI CLK DO GND TXL GNDD R5714 STBY CKS3376 E C3019 10/50 2.7k R5713 CN5701 R5712 2.7k R5702 R5701 VREF STBY 2 3 4 47k 10/50 1k INPUTSELB INPUTSELA B 4/5 R3018 R3017 22k 22k TVOUT_L R3014 22k VREF C3012 R3012 R3024 E2 C2 STBY BCKO LRCKO R3022 220k (AD) R3011 R3013 22k C3011 32 RECMUTE D V+10 C3004 CHASSIS GND 47k 1 2 3 4 5 6 7 8 CN3002 C3002 1 R3027 R3026 R3025 1k 1k SCART V+5 VREF C C3024 220/6.3 LINE H 1k 0.1 H H C3003 L R3007 STBY MCACC PWRCONT 84 R3082 1M PLC_CONT 93 KN3001 R3002 STBY STBY 2 AKP7199-A SDATA1 19 SDATA2 18 SDATA3 17 GND 16 MCLK 15 GND 14 SCLK 13 LRCLK 12 GND 11 LIN1_L 10 GND 9 LIN1_R 8 GND 7 S_TVOUT_L 6 GND 5 S_TVOUT_R 4 RECMUTE 3 GND 2 SDATA4 1 TUNER L R3023 E C3022 3 L H X1 X(Lch) X0 X3 A B 5 4 L VDD X2 R3081 1M FUNCTION Y0 Y2 Y(Rch) Y3 Y1 INH VEE VSS 7 6 B 16 15 14 13 12 11 10 9 8 A IC3001 Sub:HEF4052BT Main:TC4052BFN 9 Q3005 (1/2) HN1A01FU(YGR) (RT3AMMM) R3009 B 1k V+5 R3040 15k 70 71 27 28 R3001 STBY 79 77 V+5 STBY DSPMUTE 11 10 C3021 0.1 AUDIO INPUT SELECTOR STBY 13 R3021 220k SROUT 12 C3023 47/35 V+10 0.01 14 B 2/5 C3001 16 R3006 C 1/2 C 21 82 17 RDS DATA 65 CN3102 TO DAMP/HAMP B 19 18 B 2/5 10k C 1/2 CN3101 PCON XHPSEL HPL GND HPR GND 3.3V XRST XPDN XMUTE GND SDA SCL GND XOTW XSD SROUT POWER PLCCONT UCOM V+3R3 5 6 7 8 A DVD MAIN ASSY B 3/5 (XWM3341:WYXJ5) (XWM3342:WXJ/RE5) from DVD,DSP PART (AD) AUDIO B 1/5,2/5,5/5 A/D V+5 GNDD IC3004 TC7WU04FU 1 2 3 4 GND C3026 10/50 (AD) R3048 1.8k ADBCK ADMCK0 ADLRCK ADDATA 3.3k B R3049 100 RAB4C101J-T R3052 0 0 16 15 14 13 12 11 10 9 0.01 0.1 C3045 R3046 STBY R3057 10/50 C3046 R3045 STBY CKS0 CKS2 DIF PDN SCLK MCLK LRCK SDTO AINL CKS1 VCOM AGND VA VD DGND R3073 V+3R3 AINR C3048 0 R3060 1 2 3 4 5 6 7 8 0.1 0.1 10/50 C3042 C3041 10/50 2.2/50 C3044 C3025 C3043 R3041 STBY IC3003 AK5358AET C3052 0.1 VCC 8 7 6 5 ADMCK0 R3053 100 ADMCK1 R3054 100 R3055 C XADPDN CH C3056 27p CH 12.288M C3057 27p R3056 100 1M X3004 VSS1140 220 R3062 220 R3063 (AD) 220 1 2 3 4 5 6 7 8 VCC ST GND 34 STBY IC3005 TC74VHC157FTS1 R3061 ADLRCK ALRCK LRCKO ADDATA ASDAT0 DATA0 85 XADPDN(MIC) V+3R3 DATA SELECTOR R3064 DATASEL 48 6 RDSCLK RDSPOW 64 MIC_DET 74 ECHO_CONT 97 GNDD 16 15 14 13 12 R3065 11 220 10 9 R3066 100 C3064 0.1 (AD) ADBCK ABCK BCKO ADMCK1 ACLK MCKO D (AD) GNDD UDZS3R9 V+5 MIC A/D IC3961 AK5358AET Chip Size RESISTOR 16 15 14 13 12 11 10 9 0.1 1 C3966 C3965 V+3R3 AINL CKS1 VCOM AGND VA VD DGND CKS0 CKS2 DIF PDN SCLK MCLK LRCK SDTO V+10 : 2125 Size RS1/10S~ R3968 1.8k ABCK ACLK ALRCK MCDATA 3.3k STBY 2.2 C3963 C3964 1 0.1 C3962 C3961 GNDD AINR 0.01 1 2 3 4 5 6 7 8 R3967 V+5 XV-DV365K/WXJ/RE5 C3968 UDZS3R9 D3962 D3961 C3967 22/25 R3966 1K R3969 100 RAB4C101J E : 1608 Size RS1/16S~ CAPACITOR : 2125 Size CKSQ**~ : 1608 Size CCSR**~ CKSR**~ GNDD 1 CKS3370 3 2 5 4 MIC SW ECHOCNT V+10V MIC GND CN3961 (AD) F : AUDIO DATA SIGNAL ROUTE TO MIC ASSY B 3/5 H CN3921 61 XV-DV363 5 6 7 8 1 2 3 4 10.4 DVD MAIN ASSY (4/5) A (Page 1/4) from DVD PART VIDEO B 1/5 C411 150(F) R411 S_C (S_C) 0.1 C447 R431 STBY V+5V STBY (C/V) V+5V 1 C449 R432 STBY R405 STBY R412 B 150(F) C412 CVBS VIDEO AMP C451 R433 STBY STBY R414 150(F) C414 G_CY (G) 1 C453 R434 STBY STBY C415 150(F) R415 B_CB (B) 0.1 C455 R435 STBY STBY C416 R416 150(F) R_CR C (R) 1 2 3 4 C403 5 STBY 6 C404 7 100/16 8 C405 0.1 9 10 R401 11 10k 12 13 14 VCC228 DC out 27 C out 26 S1 25 S2 24 V out 23 GND222 21 Y out G/CY out 20 GND219 B/Cb out 18 GND217 R/Cr out 16 GND215 VCC1 C in MUTE1 V in YC MIX Y in GND1 BIAS I/P CY/G in CLP Cb/B in MUTE2 Cr/R in 0.1 IC401 (MM1623BF) MM1758XF (S_Y) 1 C402 R413 150(F) C413 C401 100/16 STBY S_Y 10 8 9 0.1 C457 R436 STBY STBY GNDD GNDD SQUEEZE LETTER I/XP Chip Size RESISTOR : 2125 Size RS1/10S~ : 1608 Size RS1/16S~ D CAPACITOR : 2125 Size CKSQ**~ : 1608 Size CCSR**~ CKSR**~ E (C/V) (S_Y) (S_C) (R) (G) (B) (AD) : VIDEO SIGNAL ROUTE(C/V) : VIDEO SIGNAL ROUTE (S_Y) : VIDEO SIGNAL ROUTE (S_C) : VIDEO SIGNAL ROUTE (R) : VIDEO SIGNAL ROUTE (G) : VIDEO SIGNAL ROUTE (B) : AUDIO DATA SIGNAL ROUTE VSEL1 SQUEEZE VSEL2 F B 4/5 62 XV-DV363 1 2 3 4 5 6 7 8 A DVD MAIN ASSY B 4/5 (XWM3341:WYXJ5) (XWM3342:WXJ/RE5) (C/V) R9401 B R424 75 (F) C429 1000/6.3 C424 STBY C JA403 VKB1122 1 V 2 D COMPOSITE VIDEO OUTPUT GNDD CN451 CKS338823 16 VSEL1 SQEEZE V+10 TVOUT_R GND TVOUT_L TVMUTE SCART_R 14 GND SCART_L 21 10k R491 22 TVOUT_R B 5/5 18 TVOUT_L XTVMUTE Q491 RT1N241M (DTC124EUA) 20 19 17 SCART_R SCART_L 15 13 12 (B) 11 10 (G) 9 B 1/5,2/5 (R) 8 7 from u-com 81p (S_C) DVDPOWER 6 5 4 (C/V) 3 2 (S_C) 1 V+5 VSEL2 B GND G GND R DVDPOWER S_C GND V GND S_Y TO EURO SCART ASSY V+5 CN461 V+10 VE+5 E I VE+5 GNDD F B 4/5 63 XV-DV363 5 6 7 8 1 2 3 4 10.5 DVD MAIN ASSY (5/5) GNDD GNDD C944 0.1 V+3R3HD R933 560 10 R906 HSPDIF HCLK 10 C931 0.1 R911 B 1/5 B ATL7010 C987 HDMI 1000p C985 0.1 B 1/5,2/5,3/5 L937 AUDIO 80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 GNDD STBY STBY STBY STBY STBY E R915 1k R914 10k XDVDRST GNDD 1 2 3 4 F GNDD HDMISDA PUSEL STBY 8 7 6 5 IC932 STBY GNDD B 5/5 XV-DV363 1 2 510 (F) HDMISCL C940 64 R934 R943 R901 R902 R903 R904 R905 VSYNC HSYNC SCL SDA PRDN XO INT0# R937 R938 R939 R940 D R936 C942 0.1 MT1392E/C-L 0.1 VCK R931 0 Y0 Y1 Y2 Y3 Y4 Y5 Y6 Y7 C936 C IC931 21 C943 22 23 0.1 24 25 STBY R945 26 27 28 29 STBY 30 STBY 31 STBY 32 STBY 33 STBY 34 35 R935 36 STBY 37 STBY 38 39 40 R944 STBY C0 C1 C2 C3 C4 C5 C6 C7 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 C945 C946 5600p 0.1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 3 4 C956 1000p ATL7010 C954 0.1 L936 C953 47/35 C933 0.1 ATL7010 C932 47/35 C935 0.1 V+3 V+1R8 V+3R3TX V+3R3HD L931 C955 0.1 V+3 C934 1000p A 5 6 7 8 A DVD MAIN ASSY B 5/5 (XWM3341:WYXJ5) (XWM3342:WXJ/RE5) V+6R8 IC981 NJM2872BF05 5 1 2 4 3 1 C983 V+6R8 0.1 2.2 C984 C982 V+5HD B 2/5,4/5 B DVDPOWER GNDD V+3R3TX C947 3 L932 2 1 R954 8 9 4 1 3 L935 2 STBY STBY R957 C950 7 ATH7022 R956 10 ATH7022 R958 12 1 V+5HD STBY VA931 R974 STBY C952 18 19 10/50 VA932 VA933 VA934 VA935 VA936 VA937 VA938 0 HDMI Terminal Q934 RT3P22M (UMB1N) D Q933 RT1N144M STBY R965 R963 STBY R966 R969 STBY Q935 STBY STBY STBY STBY Q935 STBY R968 R971 R967 2.7k STBY STBY R942 STBY VA901 V+3 VA902 R962 2.7k R960 4.7k 4.7k STBY R964 GNDD 47k VA903 Q934 RT3P22M (UMB1N) Q936 STBY R961 17 R973 V+5HD V+5HD R959 14 15 16 R975 STBY GNDD R941 STBY 13 R972 STBY 4 STBY STBY C HDMI Output 11 C951 0.1 R950 6 4 1 3 L934 2 R955 C949 4 5 ATH7022 STBY STBY R949 3 4 1 3 L933 2 R953 R948 C948 2 ATH7022 R952 STBY STBY STBY R947 JA931(PCB:CN931) AKP7210 STBY R951 E R970 D933 UDZS5R1(B) 1k GNDD F B 5/5 65 XV-DV363 5 6 7 8 1 2 3 4 10.6 DAMP ASSY (1/2) A HP AMP V+3R3 9 STBY STBY R3154 R3155 8 7 SDA SCL C3906 180p/50 IC3901 (2/2) 6 5 NJM4565MD (NJM4565M) R3906 5.6k 4 3 SROUT 1 PLCCONT - 6 4 + 5 C3912 STBY XOTW 8 7 XSD C3908 2 (AD) (AD) (AD) 19 18 17 R3912 SDATA1 SDATA2 SDATA3 PCB Binder : VEF1040 R3901 4.7k R3907 5.6k 18k 18k 680p/50 C3907 C3923 0.1/25 10/25 R3911 R3910 18k 680p/50 10 560p/50 XRST XPDN XMUTE 10k STBY C3922 10/16 R3153 11 R3924 13 C3924 0.1/16 14 12 680p/50 C3911 STBY + 3 R3915 4.7k R3913 680p/50 8.2 10k C3921 15 C3901 4 1 17 16 AKM7077- 4.7k R3916 R3908 5.6k 4.7k R3914 16 4.7k 15 14 (AD) (AD) 13 12 SCLK LRCLK 11 LINE_IN_L 10 9 LINE_IN_R 7 LINE_OUT_L 6 MCLK 5 LINE_OUT_R 4 C3119 0.1/16 3 2 SDATA4 1 C3120 10/10 8 PWM_HPPL PWM_HPML PWM_HPPR PWM_HPMR PWM_P_6 PWM_M_6 PWM_P_5 PWM_M_5 SDATA1 SDATA2 SDATA3 GND MCLK GND SCLK LRCLK GND LIN1_L GND LIN1_R GND S_TVOUT_L GND S_TVOUT_R RECMUTE GND SDATA4 NJM4565MD (NJM4565M) R3905 5.6k C3903 8 - 2 C3902 18 IC3901 (1/2) PCON XHPSEL C3904 19 R3921 R3923 R3152 2.2k R3151 10k 0.1/16 STBY AKM7077- PCON XHPSEL HPL GND HPR GND 3.3V XRST XPDN XMUTE GND SDA SCL GND XOTW XSD SROUT POWER PLC_CONT C3151 C3152 CN3101 C3905 180p/50 CN3102 B 3/5 CN 3002 C 18k R3909 560p/50 TO DVD MAIN ASSY (3/5) B B 3/5 CN 3001 TO DVD MAIN ASSY (3/5) V+BSW PWM MODULATOR C3101 0.22/16 STBY GNDD PWM_M_5 DVSS_PWM DVDD_PWM PWM_P_6 PWM_M_6 PWM_P_8 PWM_M_8 PWM_P_7 PWM_M_7 PWM_M_2 /HP_SEL PWM_M_1 VALID DVSS SIND2 SDIN1 NC /RESET /BKND_ERR SDIN3 DVSS SDIN4 DVSS DVDD SCLK /MUTE LCRCK DVDD SCL /PDN DVSS VR_DIG RESET CONTROL CIRCUIT C 1/2 66 XV-DV363 2 3 4 (AD) (AD) (AD) SDATA3 SDATA2 SDATA1 1M SDA SCL LRCLK SCLK SDATA4 0.1/16 C3182 R3108 47 R3107 47 C3113 18p/50 0 R3182 13.5MHZ R3106 C3114 15p/50 0.1/16 C3181 PWM_P_2 PWM_P_1 TAS5508 1 PWM_P_3 PWM_M_3 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 GNDD XRST IC3182 T-TPS3825-33DBVR 1 5 R3181 2 4.7K 3 4 PWM_M_4 ASS7062 X3101 IC3181 SN74AHC1G04DBV 1 5 2 AND 3 4 PWM_HPML VBGAP V+3R3 STBY RESERVED MCLK PWM_HPPR PWM_HPMR PWM_HPPL AVDD_PLL R3105 GNDD VR_PWM PWM_P_4 IC3101 TAS5508BPAG SDA E F C3106 0.1/16 R3104 220 V+3R3 AVSS_PLL RESERVED XRST VRD_PLL (AD) (AD) (AD) (AD) 5 AVSS VR_DPLL OSC_CAP 4 AVSS RESERVED RST GNDD XHPSEL XPDN XMUTE PLL_FLTP RESERVED 3 GNDA 0.1/16 5V GNDD SDA PLL_FLTM C3112 0.1/16 2 10/10 SDA SCL C3110 1 C3109 1000p/50 C3111 SCL C3107 0.1/16 V+5V B5B-PH-K-S CN3171 10/10 4.7 R3113 3.3 C3108 R3103 STBY PLL_FLT_RET XTL_IN GNDD VRA_PLL PWM_P_5 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 XTL_OUT V+3R3 C3102 0.01/50 C3103 R3101 0.1/16 220 STBY R3102 220 PLCCONT SROUT STBY C5984 R5982 C5983 STBY STBY C5982 PLC_CONT C5981 SR OUT D 0 3 2 1 C3104 0.1/16 R5981 STBY RKN1004 C3105 0.01/50 JA5981 R3112 47 GNDD 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 5 6 7 8 A DAMP ASSY C 1/2 (XWK3318) R3141 V+BSW LINE_IN_L R3631 R3614 47k Q3601 (2/2) R3624 STBY D3603 UDZS12(B) C3622 10/16 C3624 0.1/16 R3618 10/16 Q3603 (1/2) 4.7k E2 C2 IMX9 220p/50 220p/50 2 LINEOUT_R AKB7114 R3620 820 220 GNDD LINE_OUT_R resistor 2125 size RS1/10S*** 3216 size RS1/8S*** C E C 1608 size RS1/16S*** capacitor R3612 10K B 2125 size CKSQ** 1608 size CCSR** CKSR** C E LINEOUT_L 4 R3630 1k 5 CN3111 4.7k R3632 D3602 4.7k B2 STBY R3616 220 IMX9 C3611 820p/50 E Q3603 (1/2) IMX9 (2/2) R3613 47k 820 Q3601 C 1k R3617B D3601 4.7k STBY C3610 330p/50 C3614 STBY 820p/50 820p/50 C3604 C3608 C3602 STBY Q3901 (AD) PWM B V+BSW V+B E 2.2k R3134 IC3191 BA10358F 8 R3193 10K C3192 0.1/25 4 + 5 VALID CN3201 B2P-VH IC3191 BA10358F 8 - 2 XSD GNDD 1 R3109 C3117 10/10 4 C3116 0.1/16 STBY R3198 R3192 10K - 6 7 STBY D3191 10K C3191 R3196 (DTC143EUA) 2.2k PCON 8.2 R3199 UDZS18(B) 47k D3131 R3131 12k STBY R3195 100k STBY C3131 STBY D R3194 100k FROM POWER SUPPLY UNIT D3101 MC2846-11 (DAP202U) V+3R3 STBY E R3137 D3132 PWM_P_4 PWM_M_4 PWM_P_3 PWM_M_3 PWM_P_2 PWM_M_2 PWM_P_1 PWM_M_1 R3191 0.1(2W) ACN7112 C RT1N431M Q3132 B UDZS4.7(B) R3197 (AD) (AD) (AD) (AD) (AD) (AD) (AD) (AD) R3133 1k STBY R3136 10k R3114 PWM_P_8 PWM_M_8 PWM_P_7 PWM_M_7 R3132 B B C E 0.1/16 (AD) (AD) (AD) (AD) R3110 V+25 Q3131 2SA1036K(QR) C Q3604 RT1P241M (DTA124EUA) R3111 22 C3118 2 +B 1 GND J CN2 Power Supply + 3 E STBY V+5V IC3171 NJM78L05UA GNDD STBY (AD) R3171 IN 1 3 330 C3171 0.1/16 C3172 2 COM 10/25 OUT GNDD XPDN STBY R3626 STBY R3628 V+3R3 C3115 0.47/10 STBY R3627 10/16 Q3602 RT1P241M (DTA124EUA) R3608 4.7k TVIN_R B STBY R3625 IC3601 (2/2) NJM4565MD (NJM4565M) 6 8 7 5 + 4 3 R3619 R3629 IMX9 10/25 C3621 330p/50 C3623 10K C3606 330p/50 R3606 4.7k R3615 R3611 10K R3610 R3607 4.7k TVIN_L 1 330 C3609 4 6 LINE_IN_R LINE_OUT_L 1 3 + C3142 8.2 8 AUDIO IN/OUT C3612 820p/50 2 - 0.1/25 C3607 R3601 4.7k R3142 C3613 STBY 820p/50 820p/50 C3603 C3601 4.7k R3623 2.2k R3621 10K C3605 330p/50 IC3601 (1/2) NJM4565MD (NJM4565M) R3605 C3141 330 R3609 KN3101 VNF1084GND_CHASSIS : AUDIO DATA SIGNAL ROUTE F C 1/2 67 XV-DV363 5 6 7 8 1 2 3 4 10.7 DAMP ASSY (2/2) A C3301 XOTW /RESET_AB GND OUT_B BM OUT_B BP PVDD_B DREG PVDD_B M1 BST_B M2 BST_C M3 PVDD_C DREG_RTN PVDD_C CP OUT_C CM OUT_C /RESET_CD GND DM GND DP OUT_D /SD_AB OUT_D /SD_CD PVDD_D /OTW PVDD_D GREG BST_D GND GVDD GND GND C3248 STBY C3246 STBY 4.7K C3240 R3238 YB 0.01/50 1 4.7K R3236 C3238 YB 1 0.01/50 0.47/50 C3234 C3232 YB 0.1/25 YB 0.033/50 C3228 C3247 STBY C3245 STBY 4.7K C3239 R3237 YB 0.01/50 1 0.47/50 C3231 4.7K R3235 C3237 YB 1 0.01/50 C3218 CFTLA474J50 C3236 YB YB 0.1/25 0.1/25 R3232 R3234 C3226 YB 1000p/50 C3224 YB 0.01/50 3.3 R3228 820 L3252 R3342 18 C3343 330p/50 YB YB 18 R3341 18 4 (RL) 1.5 R3317 C3313 R3313 YB 2.7 0.1/50 R3343 L3302 10 L3301 10 4 (FL) YB 2.7 0.1/50 1.5 R3315 C3348 STBY 2 3 ATH7019 1 C3341 330p/50 C3311 R3311 4.7K C3340 R3338 YB 0.01/50 1 0.47/50 C3326 YB 1000p/50 C3324 YB 0.01/50 3.3 R3328 1 YB 2.7 0.1/50 1.5 R3316 820 R3325 R3323 GNDD 2 18 C3342 330p/50 C3312 R3312 V+BSW FL/RL Amplifier R3344 YB YB C3346 STBY AM GND YB 2.7 0.1/50 2 2 3 ATH7019 V+B C3347 STBY AP C3344 330p/50 4.7K R3336 C3338 YB 1 0.01/50 OUT_A YB 0.033/50 C3328 OUT_A GND YB 0.033/50 PVDD_A DGND 1.5 R3318 C3314 R3314 YB 0.033/50 GND L3354 YB R3324 PVDD_A C3345 STBY E STBY STBY STBY YB 1/16 R3303 R3302 R3301 BST_A DVDD C3331 1 XSD GREG 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 YB 0.033/50 C3327 R3304 220 VALID GVDD YB 1000p/50 STBY 10K R3309 R3305 (FL) GND GND C3325 PWM_M_2 PWM_P_2 YB C3303 0.1/16 1 GND C3318 100 YB 0.1/16 C3304 R3306 C3302 1/16 47K R3307 4.7K R3308 PWM_M_4 PWM_P_4 (RL) V+B V+BSW IC3301 TAS5122DCA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 V+B 4.7K C3339 R3337 YB 0.01/50 1 GNDD DIGTAL AMPLIFIER D 820 R3226 V+BSW 4.7K R3335 C3337 YB 1 0.01/50 GND CFTLA474J50 C3235 YB YB 0.1/25 0.1/25 R3231 R3233 GVDD C3233 BST_D C3316 GND C3317 GND C3315 GREG R3211 YB 2.7 0.1/50 1.5 R3215 2 3 ATH7019 C3332 PVDD_D 2 CFTLA474J50 C3336 YB YB 0.1/25 0.1/25 R3334 R3332 PVDD_D /OTW 4 C3334 OUT_D /SD_CD C3241 330p/50 C3211 R3327 YB 3.3 0.01/50 /SD_AB GND OUT_D L3201 10 (FR) C3323 DP C3321 DM GND 1000/25 /RESET_CD 1 0.47/50 OUT_C CFTLA474J50 C3335 YB YB 0.1/25 0.1/25 R3333 R3331 OUT_C CM C3333 CP 1.5 R3217 C3213 R3213 YB 2.7 C3243 0.1/50 330p/50 18 R3243 YB YB 18 R3241 YB 0.1/25 PVDD_C YB 0.1/25 DREG_RTN YB 0.1/25 PVDD_C YB 0.033/50 BST_C M3 YB 0.033/50 BST_B M2 4 2 3 ATH7019 YB 0.033/50 C3227 PVDD_B M1 YB 2.7 0.1/50 1.5 R3216 YB 1000p/50 DREG C3242 330p/50 C3212 R3212 C3225 PVDD_B C3216 OUT_B BP L3202 10 (RR) C3217 OUT_B BM 18 R3242 L3352 /RESET_AB 1 C3215 GND 2 18 R3227 YB 3.3 0.01/50 AM YB YB C3223 GND YB 2.7 0.1/50 R3244 C3221 AP C3244 330p/50 1000/25 OUT_A L3253 OUT_A GND L3254 YB R3224 PVDD_A DGND 1.5 C3214 R3214 L3351 FR/RR Amplifier GND R3218 820 R3225 C YB 1/16 XSD XOTW STBY STBY STBY C3201 R3203 R3202 R3201 PVDD_A L3353 1 BST_A DVDD L3251 R3204 220 VALID GREG 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 820 STBY 10K R3209 (FR) GVDD R3223 PWM_M_1 PWM_P_1 R3205 C3203 0.1/16 YB 1 GND GND 820 B GND V+B 820 (RR) IC3201 TAS5122DCA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 820 R3326 PWM_M_3 PWM_P_3 100 R3206 YB 0.1/16 C3204 4.7K R3208 C3202 1/16 47K R3207 PWM V+BSW NOTICE R3211 - R3214,R3311 - R3314,R3411 - R3414 : ACN7148-(2.7 Ω)(SUB:ACN7141-(2.7 Ω)) (2W) F C 2/2 68 XV-DV363 1 2 3 4 5 6 7 8 A DAMP ASSY C 2/2 (XWK3318) CN3211 11 SW+ 10 C- 9 C+ 8 RL- 7 RL+ 6 FL- 5 FL+ 4 RR- 3 RR+ 2 FR- 1 FR+ (RL) (FL) (RR) (FR) (RL) : AUDIO DATA SIGNAL ROUTE (Sub woofer ch) : AUDIO DATA SIGNAL ROUTE (Center ch) M3 PVDD_C DREG_RTN PVDD_C CP OUT_C CM OUT_C /RESET_CD GND DM GND DP OUT_D /SD_AB OUT_D /SD_CD PVDD_D /OTW PVDD_D GREG BST_D GND GVDD GND GND R3443 18 R3441 18 1 L3401 10 YB 2.7 0.1/50 1.5 R3415 2 C3448 STBY C3446 STBY 4.7K C3440 R3438 YB 0.01/50 1 4 (C) C3441 330p/50 C3411 R3411 4.7K R3436 C3438 YB 1 0.01/50 0.47/50 C3434 C3432 YB 0.1/25 YB 0.033/50 C3428 C3418 YB 2.7 0.1/50 CFTLA474J50 C3436 YB YB 0.1/25 0.1/25 R3432 R3434 C3426 YB 0.01/50 YB 1000p/50 R3428 3.3 C3424 YB YB 820 R3425 R3423 GNDD 820 C3443 330p/50 V+BSW C/SW Amplifier L3352 820 R3426 R3417 1.5 C3413 R3413 D 2 3 ATH7019 2 3 ATH7019 V+B 4.7K C3439 R3437 YB 0.01/50 1 BST_C (SW) 4.7K R3435 C3437 YB 1 0.01/50 BST_B M2 YB 2.7 0.1/50 R3416 1.5 0.47/50 PVDD_B M1 C3442 330p/50 C3412 R3412 4 CFTLA474J50 C3435 YB YB 0.1/25 0.1/25 R3433 R3431 DREG 1 C3431 PVDD_B 18 L3402 10 C3433 OUT_B BP 18 R3442 YB 0.033/50 OUT_B BM R3444 YB 0.033/50 /RESET_AB YB YB YB 0.033/50 C3427 GND 2 YB 1000p/50 GND AM YB 2.7 0.1/50 C3425 OUT_A AP C3444 330p/50 C3416 GND OUT_A 1.5 C3417 PVDD_A DGND R3418 C3414 R3414 C3415 GND L3354 YB R3424 PVDD_A R3427 YB 3.3 0.01/50 YB 1/16 STBY STBY STBY C3401 XSD XOTW R3403 R3402 R3401 BST_A DVDD C3423 1 GREG 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 C3421 R3404 220 VALID GVDD 1000/25 (C) GND GND L3353 STBY 10K R3409 R3405 YB C3403 0.1/16 1 GND L3351 (SW) IC3401 TAS5122DCA 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 V+B 820 YB 0.1/16 100 R3406 C3402 1/16 47K C3404 4.7K R3408 R3407 V+BSW (C) (SW) C YB 0.1/25 (C) C3447 STBY (SW) E C3445 STBY (FL) (FR) PWM_M_7 PWM_P_7 B : AUDIO DATA SIGNAL ROUTE (Rear Lch) : AUDIO DATA SIGNAL ROUTE (Rear Rch) : AUDIO DATA SIGNAL ROUTE (Front Lch) : AUDIO DATA SIGNAL ROUTE (Front Rch) (RR) PWM_M_8 PWM_P_8 6ch SP OUT AKE712112 SW- F C 2/2 69 XV-DV363 5 6 7 8 1 2 3 4 10.8 DISPLAY, USB, LED and KEY ASSYS DISPLAY ASSY (XWZ4256) V5901 AAV7104(AAV7107-) F+ P2 P1 45 SG1 SG2 SG3 SG4 37 38 39 40 SG5 SG6 35 P3 P4 P5 P6 P7 P8 SG7 SG9 32 33 SG8 29 30 SG10 SG11 26 27 P9 P10 P11 P12 P13 P14 P16 P15 SG14 22 23 24 SG15 FL F+ R5909 STBY C5907 R5901 5 R5902 R5903 6 7 220 220 220 8 9 Q5902 STBY R5910 STBY VDD FL DRIVER 10 33 32 31 30 29 28 27 26 25 24 23 R5908 STBY GR9 GR8 GR7 GR6 GR5 GR4 GR3 GR2 GR1 STBY GR9 GR10 SG18 SG17 VEE C5919 STBY SG16 C5918 AL 47/35 SG15 SG14 SG13 D5902 SG12 STBY SG11 SG10 C5917 0.022/50 13 GNDD R5951 47 STBY SG9 SG8 SG7 SG6 SG5 SG4 SG3 C5916 0.022/50 SR IC5902 STBY R5952 0.022 R5953 47/6.3 C5951 C5952 AL C SG2 C5915 0.01/50 12 SG1 12 13 14 15 16 17 18 19 20 21 22 11 LAU100J 3 4 VEE IC5901 PT6315 VDD 2 C5920 220p C5921 220p C5922 220p B 2/5 CN5602 From DVD MAIN ASSY (2/5) 1 VSS 1 2 3 R5904 4 82k 5 6 7 8 9 10 11 CK3378 REMOCON VE+5 VFDP FLDCFLDC+ GNDD GNDD KEY1 KEY2 KEY2A R5906 44 43 42 41 40 39 38 37 36 35 34 CN5901 FLDATA FLCK FLCS C5914 STBY D5901 STBY 47/6.3 STBY C5913 AL STBY Q5901 STBY C5912 0.022 STBY C5903 C5911 0.022 STBY C5904 R5907 STBY R5905 STBY L5901 LAU220J 22 VE+5 VSS B C5906 47/35 JQ C5905 L5902 10 P18 8G P17 SG16 19 20 SG17 GR5 1G GR4 SG18 GR3 2G GR2 11 12 13 14 15 16 17 GR10 GR1 9G 9 GR9 8 3G 4G 7 GR8 5G 6 GR7 6G 5 GR6 10G 7G 1 FL SPACER AEB7367 FL F- F- FL SPACER AEB7367 SG12 D SG13 A VFDP Vcc GND Vout R5954 100 GPIUM27XKOVF R5966 1k VOL UP FM/AM S5967 VSG1024 S5965 VSG1024 S5964 VSG1024 VOL DOWN R5965 1.8k S5966 VSG1024 R5964 1.5k R5963 1.2k S5963 VSG1024 S5962 VSG1024 R5962 1k PLAY /PAUSE STOP KEY KN5903 STBY OPEN/CLOSE D R5971 68 R5973 68 Q5971 RT1P241M R5979 68 R5983 68 R5981 68 R5985 68 C5971 1000p R5975 2.2k E2 C Q5973 B (2/2) IMX9 B2 C2 E Q5973 R5976 2.2k (1/2) IMX9 D5972 R5978 STBY 2.2k CN5906 E2 B2 C2 E Q5974 Q5974 (1/2) (2/2) IMX9 IMX9 L5973 STBY C JA5901 AKN70037 6 2 3 4 5 B 1 C5972 1000p R5972 68 R5980 68 R5984 68 L5972 CTF1306 R5974 68 R5982 68 R5986 68 R5988 R5990 68 C5977 0.01/50 C5978 STBY C5974 0.047/25 C5979 STBY STBY GNDD JA602 XKP3086 2 V5USB 3 USB 4 CN5907 C605 CKS3370 6 GNDD F D E 70 XV-DV363 1 2 3 4 1 KEY2A 2 GND 3 KEY1 4 LED 5 V+10 CN5908 GNDUSB +5V DD+ GND 5 SHLD C604 3 STBY C603 STBY R602 STBY R603 STBY 14 15 4 L602 1 2 3 4 0.1 13 UMZU6.2N 0.1 D601 220/6.3 STBY R605 STBY 11 12 C602 9 10 STBY 2 STBY 0.1 7 8 L601 1 L603 TO KEY ASSY 7 5 6 G LED V+10 HP C5973 0.047/25 R5989 STBY 1 R604 B 2/5 CN5601 From DVD MAIN ASSY (2/5) CK3380 HPMUTE HP_L GNDD HP_R HP_DET GNDUSB V5USB V5USB USB_DP2 USB_DM2 GNDUSB KEY2A KEY1 L5971 CTF1306 R5977 2.2k D5971 STBY E R5987 STBY KN5902 STBY USB ASSY (XWZ4259) C601 E 5 6 7 8 A B NOTES C ALL CAPACITORS ARE IN μF UNLESS OTHERWISE SPECIFIED CKSRYB**K50 JQ : CEJQ**M** AL : CEAL**M** AT : CEAT**M** ALL RESISTORS ARE IN Ω RS1/16S***J RS1/10S***J D ALL INDUCTORS ARE IN μH LAU***J-TA F CKS3370 CN5908 PLAY LIST1 PLAY LIST2 V+10 1 2 GND 2 1 LED 3 R5613 470 470 NSPB320BS B 4.7k BLUE LED E C Q5611 2SC4081 (QR) E STBY 3 150 R5615 1 R5993 5.6k R5612 R5992 3.3k D5611 R5991 2.7k C5611 R5611 KEY2A 2 CKS3368 D5612 DAN217 R5614 3 CKS3368 C5612 STBY KEY1 CN5909 CN5603 POWER ON S5994 VSG1024 4 0.1 VA+10 S5993 VSG1024 5 LED S5992 VSG1024 V+10 GND E KEY ASSY (XWZ4261) S5991 VSG1024 CN5907 FROM USB ASSY G LED ASSY (XWZ4263) PLAY LIST3 GNDLED F F G 71 XV-DV363 5 6 7 8 1 2 3 4 10.9 MIC ASSY (XV-DV365K ONLY) H A MIC ASSY (XWM3375:WXJ/RE5) JA3921 2 6 7 (MAIN) 5 4 3 B 1 C3928 R3925 C3925 C3930 R3921 1 MIC AMP D RUSSIA E F H 72 XV-DV363 1 2 3 4 R3929 C3933 C3931 R3928 R3927 IC3921 VR3921 C3921 C C3926 C3922 (SUB) R3923 R3922 8 (1/2) 3 + 4 R3926 1 2 3 C3929 C3932 2 - C3927 JA3922 5 6 7 8 A B 4 5 + (2/2) R3930 7 8 R3931 C3938 6 - C3937 C C3936 C3935 NOTES CN3921 MIC SW 5 4 NC 2 V+10V MIC GNDA 3 1 B 3/5 CN3961 C3934 IC3921 ALL CAPACITORS ARE IN μF D UNLESS OTHERWISE SPECIFIED CKSRYB**K50 JQ : CEJQ**M** AL : CEAL**M** AT : CEAT**M** ALL RESISTORS ARE IN Ω E RS1/16S***J RS1/10S***J ALL INDUCTORS ARE IN μH LAU***J-TA F H 73 XV-DV363 5 6 7 8 1 2 3 4 10.10 EUROSCART ASSY A Q492 RT1P241M V+10 V+5 GNDD 3 4 5 6 7 8 9 10 V+5 11 12 D471 20 21 C472 0.1 23 C473 0.1 L H 4 5 6 CN461 GNDD 3 2 1 L D472 D473 V+5 IC472 MM1507XN-TRB 22 CKS3388 3 2 1 C474 0.1 DAP202U H 4 5 6 19 0.1 17 18 V+5 IC471 MM1505XN-TRB C471 10/50 C475 16 0.1 15 DAP202U 13 14 DAN202U C 1 2 C476 B 4/5 CN451 B VSEL1 SQEEZE V+10 TVOUT_R GND TVOUT_L TVMUTE SCART_R GND SCART_L V+5 VSEL2 B GND G GND R DVDPOWER S_C GND V GND S_Y D474 DAN202U GNDD V+10 820 R471 C 22k R472 560 GNDD Q462 (2/2) RT3WLMM C2 B2 C C B E STBY E Q472 RT1N241M E Q463 RT1P441M B E C465 STBY C469 4.7k B E2 4.7k C464 0.1 R463 Q462 (1/2) RT3WLMM R464 B R465 56k R461 22k BLACK Q461(1/2) RT3WLMM E2 R462 C 1.2k B2 C2 Q461 (2/2) RT3WLMM C470 0.1 R470 V+5 D R467 1.2k R468 1.2k R469 1k R466 10k SQUEEZE GNDD E F I 74 XV-DV363 1 2 3 4 5 6 R481 C481 1k 10/50 R485 7 I R487 STBY 8 EURO SCART ASSY (AWU8291) A C2 R484 47k R486 470 R496 330 C485 C486 R495 330 R488 STBY EURO CONNECTOR XKB30541 R474 B SQUEEZE G 75(F) C478 470/6.3 3 4 5 6 C487 47p 7 C488 0.1 9 10 R475 11 C489 47p 12 13 C479 470/6.3 BLANK V/Y 2 8 75(F) R/C STBY C493 STBY C494 C477 470/6.3 JA451 CH CH 100p 100p C495 C496 STBY STBY R482 C482 10/50 1k CH 330p R494 B2 4.7k C484 Q493 (1/2) IMX9 E Q493 IMX9 E2 (2/2) CH 330p R493 4.7k B C483 R483 47k 470 C R476 75(F) R477 75 (F) C490 47p 16 C491 47p C480 1000/6.3 R478 14 15 75 (F) 17 18 19 C492 47p 20 21 R OUT R IN L OUT GND GND L IN B SQUEEZE GND NC G NC GND GND R/C BLANK GND GND V/Y NC GND B C GNDD NOTES ALL CAPACITORS ARE IN μF D UNLESS OTHERWISE SPECIFIED CKSRYB**K50 JQ : CEJQ**M** R473 56k AL : CEAL**M** AT : CEAT**M** ALL RESISTORS ARE IN Ω RS1/16S***J RS1/10S***J E ALL INDUCTORS ARE IN μH LCYA***J2520 F I XV-DV363 5 6 7 8 75 1 2 3 4 10.11 POWER SUPPLY UNIT A AC IN T1 B C D E F J 76 XV-DV363 1 2 3 4 5 6 7 8 A J POWER SUPPLY UNIT (XWR3012) C 1/2 CN3201 B C D B 2/5 CN1001 E F J 77 XV-DV363 5 6 7 8 1 2 3 4 10.12 WAVEFORMS Note : The encircled numbers denote measuring point in the schematic diagram. A B DVD MAIN ASSY Measurement condition ; No. 1 to 10 : reference A1 (DVD), T2-chp 19, Color-bar No. 11 to 14 : reference A1 (DVD), T1 1 IC201-pin50 [FG] V: 1V/div. H: 2msec/div. GND B 2 IC201-pin 39 [TROPENPWM] V: 1V/div. H: 5μsec/div. [Tray stops] [Tray is opening] [Tray is closing] GND GND GND C 3 IC201-pin37 [DMSO] V: 1V/div. H: 10μsec/div. [TRAY OPEN] V: 1V/div. H: 10μsec/div. [DVD PLAY] V: 1V/div. H: 2sec/div. [DMSO] GND GND PLAY D GND Tray : opening Pless OPEN key Pless PLAY key Braking a turn of disc 4 CN102-pin 11, 10, 9 (IC101-pin 30, 33, 36) [SPINDLE (WVU)] V: 2V/div. H: 2msec/div. E GND 8 IC401-pin23 [CompositeVideo Out] V: 1V/div. H: 10μsec/div. 9 IC401-pin21 [S VIDEO OUT - Y] V: 1V/div. H: 10μsec/div. 10 IC401-pin26 [S VIDEO OUT - C] V: 1V/div. H: 10μsec/div. 9 9 GND GND 10 F 10 GND 78 XV-DV363 1 2 3 4 5 11 6 IC201-pin212 [ACLK] V: 1V/div. H: 20nsec/div. 7 12 IC201-pin209 [ALRCK] V: 2V/div. H: 500nsec/div. 13 IC201-pin210 [ABCK] V: 2V/div. H: 500nsec/div. 14 IC201-pin197 [ASDATA0] V: 2V/div. H: 500sec/div. 8 A GND 12 GND 13 GND 14 GND B C DAMP ASSY 1 IC3201, IC3301, IC3401 [PWM_M, PWM_P] V: 1V/div. H: 2μsec/div. 2 IC3201, IC3301, IC3401 [OUT_A, B, C, D] V: 5V/div. H: 2μsec/div. C GND GND D E F 79 XV-DV363 5 6 7 8 1 2 3 4 11. PCB CONNECTION DIAGRAM NOTE FOR PCB DIAGRAMS : A 1. Part numbers in PCB diagrams match those in the schematic diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below. Symbol In PCB Diagrams Symbol In Schematic Diagrams B C E B C E Part Name Connector Capacitor Transistor B C E B C E B C SIDE A E Transistor with resistor B C E G S D D B 3. The parts mounted on this PCB include all necessary parts for several destinations. For further information for respective destinations, be sure to check with the schematic diagram. 4. View point of PCB diagrams. G S Field effect transistor D G S P.C.Board SIDE B Chip Part Resistor array 3-terminal regulator C 11.1 LOAB ASSY D SIDE A SIDE B A LOAB ASSY E A LOAB ASSY VNP1836-C LOAB PNE-1B1 1 CN601 5 5 1 C102 C101 5 (VNP1836-C) (VNP1836-C) LOAD+ LOAD- SW2 CN602 1 2 5 VWG VWG2279VWG2346- V+3D (V+5D) 1 GND S101 5 CN602 1 CN601 CN602 CN601 CN601 CN602 B CN104 M LOADING MOTOR ASSY F A A 80 XV-DV363 1 2 3 4 5 6 7 8 11.2 MIC ASSY (XV-DV365K ONLY) SIDE A SIDE A A H MIC ASSY 10 20 30 40 50 JA3922 Y 0 ICT FC 60 70 80 90 X 10 B [[ G ]] C7 PNE-1B1 CN3921 5.MIC SW 4.ECHOCONT 3.V+10V 2.MIC 1.GNDA W104 5 R 1 W103 GNDA IC3951 8 A GNDA XWM3375MIC ASSY JA3921 50 60 C3935 C3925 W109 40 PRODUCTION CODE 30 1/5 20 V+10V W101 80 CN3921 CONTACT SIDE C3929 W106 GNDA W105 1 C3931 C3937 C3930 VR3921 W107 70 B CN3961 C (XNP3115-A) SIDE B SIDE B H MIC ASSY D 80 70 5 4 IC3921 C3934 R3927 PNE-1B1 C3926 C3921 R3922 R R3930 XWM3375MIC ASSY 40 1.GNDA 2.MIC 3.V+10V 4.ECHOCONT 5.MIC SW 8 1 50 5 CN3921 C3928 R3925 C3927 1 C3938 R3926 R3923 R3921 60 CN3921 R3928 C3936 R3929 R3931 C3932 C3933 E C3922 30 1/5 LF 20 (XNP3115-A) X 10 0 Y 10 30 20 40 50 60 70 80 90 F H H 81 XV-DV363 5 6 7 8 1 1 16 64 8 9 14 48 CN103 1 4 5 IC3961 24 1 128 C229 C227 C236 C235 C233 C234 IC201 C232 C231 C290 IC204 R219 R294 R293 R218 R5603 R5605 R5575 C5597 R266 C285 CONTACT SIDE 80 C250 Q5601 R5606 R5576 1 3 R5563 23 3 4 1 D5601 C5578 CONTACT SIDE R5559 R5565 R5564 R5562 30 51 5 KN5601 C5522 Q5602 D 110 8 4 D1403 Q1402 IC5502 IC5503 1 C5555 C1413 R5528 Q5532 100 5 4 24 Q5535 Q5534 Q5533 R229 R228 R227 R226 OPEN SIDE R208 R5602 R5601 C5569 50 R5542 90 1/2 FLDCFLDC+ STEST R5541 UTEST C5603 NP 2 C5602 R5546 R5547 C5539 IC5501 R5590 25 1 1 CN104 13 31 100 C346 CN5602 C5601 81 C347 C345 13 R3065 C344 65 IC203 R5501 R5505 R5506 R5507 R5598 R5569 C5518 [CN5604] R5521 R5522 R5525 R5527 X5501 R5509 C5504 R5508 C5508 R5510 R801 D802 C5606 80 1 R3083 R3062 R3063 R3085 R3066 C202 C204 C205 V+1R8 R3967 R3968 C3968 C206 D3962 C3966 C3965 C3953 D1501 C5501 C5524 C1505 C3954 D781 C104 C5502 A B C D VFDP C225 CN5602 C1103 C215 C203 C3961 C3951 SW3.3B C153 R5518 C5519 R5519 C801 R233 DVD MAIN ASSY 70 R265 R271 X3004 Q1202 C1204 R1201 D3961 C200 C219 C218 C216 R214 R213 R212 R211 R210 C3952 C121 IC781 D782 R3955 Q3951 1 C772 C781 C213 OPEN SIDE 1 CN104 5 C201 60 C283 R207 E IC1101 R1101 R1204 C1201 Q1201 R767 R769 R768 R770 Q1301 Q1302 R1301 R1303 R1302 C1301 Q1303 R1307 CN5601 C771 C132 C102 C101 50 R225 120 OPEN SIDE SW5.0V 5 VA934 VA937 VA938 VA935 VA936 [CN5603] 15 C161 C133 R136 R371 R374 R373 C372 R135 R134 R133 R132 R131 V+6R8 F R5515 R5513 R5514 R5516 Production code A. B. C. D. 40 C 120 130 B 110 VA933 CN101 CONTACT SIDE -A HEATPROOF PREFLUX 30 F L1305 B 1 CN3961 B1 R314 1 3 5 4 C371 C373 PCB VA931 VA932 BINDER R1001 C374 R375 R372 R315 XWM 000 0 111 1 222 2 333 3 444 4 555 5 666 6 777 7 888 8 999 9 LF 20 129 IC202 C288 C287 C286 100 90 80 70 60 50 40 30 20 10 Y 0 10 C281 4 3 2 1 CN1002 0 X XV-DV363 82 1 0 0 1 2 3 4 5 6 7 8 9 A B C 1 C230 C1101 R1202 R2 R267 0 C5557 0 1 2 3 R1402 27 R1404 KN5501 CN5501 1 7 [[ G ]] A30C5/C7 R281 C282 R5558 R5604 R5571 R5502 C5558 C217 R3969 28 R5557 R5548 1 R1403 R1401 54 CN204 C5577 R5577 V+3R3 D1417 D1416 R1415 C1415 D1415 Q1413 E 4 NP R285 C284 R5586 R5585 R5584 R5583 C5579 R5574 R5582 R5581 Q5531 4 1 1 R5500 R5503 C5503 R5570 R5566 5 8 R5545 R5543 R5530 R292 R235 C226 R236 R223 R222 R220 R261 R272 R234 R215 R221 C224 R5595 R5596 R5600 R259 R260 R262 R263 C289 V+10 R224 R237 R216 R258 C5509 C296 R5597 C5589 R5587 CN5901 C5525 V+5V R5512 R5517 C220 Q5525 C5521 R284 R282 V+3 L1501 VE+5 C1501 C1502 R206 C212 C207 C208 R3952 R3954 L3952 L3951 R3953 R3951 R154 R152 C1102 D1201 R1304 Q1304 L761 C210 R204 C211 R205 C782 C3964 C3962 R771 L772 C3967 C142 R201 C209 R202 C152 R3966 C144 R291 R5531 R5532 R5533 R5534 C5605 R5535 C5604 R5536 R5537 R5544 R5538 D C141 C783 22 C103 C151 1 C5517 D IC771 IC101 R1305 C310 C3963 C131 C146 23 C145 C143 44 R153 R151 CN601 R313 C320 R310 R772 C773 C A KN103 SW10.5V C309 Q305 R1306 R951 R952 R953 R954 R955 R956 R957 R958 CONTACT SIDE 1 R318 CN1001 ICT FC1 FC2 Q307 R322 Q308 R321 R325 L308 R326 L309 CN3961 CN1001 CN5601 CN103 EV5.0V SW6.8V Q304 12 CN102 C140 STEPPING MOTOR SPINDLE MOTOR B CN101 CN102 H CN3921 CN3 CN5906 XV-DV365K ONL J E 06SD PICKUP ASSY 4 3 2 1 11.3 DVD MAIN ASSY A SIDE A B DVD MAIN ASSY C947 R947 61 NP 80 1 Q5703 16 1 5 19 4 1 8 CONTACT SIDE 1 5 4 3 (for FFC) 9 CN3004 1 1 IC3001 3 16 19 NP 1 8 9 C944 R933 R906 R911 C956 C934 C954 C933 1 28 C948 R931 C942 1 C949 B B 19 C951 20 19 9 1 CN3003 1 8 8 R415 C940 15 R5931 R5939 Q5931 14 R416 R209 R401 R406 R5936 C5936 Q5934 C405 IC3004 5 1 8 16 9 13 1 R229 R228 R973 C952 C950 R949 R950 R948 IC931 C946 1 C932 C987 R5719 C5705 R5713 R5718 C5704 R5712 R5701 R5717 R5716 L5932 R5715 R5714 C5703 R5705 C5702 C5709 R405 C401 C402 C404 R240 60 A C984 IC981 C982 IC3901 C3911 CN451 C R3911 CN5701 D5933 C5931 C248 C447 C237 R266 C250 R411 R412 R414 C244 C236 C235 C233 C234 IC201 C232 C231 41 R5933 R5934 C3909 R5704 C5701 C3901 C3906 R5706 R5703 R5708 Q5701 C5706 C5707 C5715 C5712 C5713 R5710 R5702 C5716 C5714 X5701 X201 1 C4615 L4603 A C256 C343 C259 R254 R251 R253 C255 C258 C254 C251 C252 R255 9 1 R3908 R3013 R3027 C346 16 C406 R402 R428 Q428 C427 C428 C3015 C3016 C3001 R3009 R3019 R3017 R3015 R3040 C3022 C3003 R3021 R3064 C273 C271 C347 C345 4 CONTACT SIDE R3007 C3024 C3064 R3061 R3084 R3065 3 L422 C431 Q5942 C3023 R3053 R3090 C3002 R3020 R3014 R3012 R3010 R3016 R3018 A R5948 R5945 R5949 KN3001 C3043 C3045 R3041 C3025 R3049 C3021 R3052 C3052 R3054 R491 C344 1 R425 JA402 C424 Q5941 D5941 R9402 R9401 R424 R3003 C3012 C3011 C3041 R3048 R3001 R3055 C3057 IC3005 C202 C204 C205 5 L421 C429 CONTACT SIDE R3056 C3056 C C426 C1103 JA401 C206 256 C430 Q3006 R3006 R3081 R3082 R3045 C425 (for FFC) R426 X3004 R3083 R3062 R3063 R3085 R3066 C215 193 240 230 220 210 200 190 180 170 160 150 140 130 C3027 R3028 IC3002 C3029 C3028 E IC1101 C423 Q1202 C1204 L932 CN931 R972 R943 R940 R915 R938 R936 R971 R944 R935 R939 R937 R905 R904 R945 C936 C R3913 R3910 C3905 C3910 R413 8 7 6 5 4 R961 NP R975 R974 VA902 Q934 R959 R960 VA901 R970 R964 Q935 R969 R966 R968 R963 R965 C945 D933 R967 Q936 IC932 1 R433 C270 C451 C4614 E VA903 R962 R 40 21 5 8 NP R903 R914 L3901 C453 C414 R941 R942 KN202 L934 L937 JA3901 L931 L935 C943 R901 R902 JA5931 L5934 R5943 C3908 L933 R432 L5931 R3914 R934 L936 4 1 R3907 C3904 CN5701 1 CONTACT SIDE C953 C931 C955 C935 C449 Q933 R264 R267 R242 C985 C412 C455 C415 C457 C416 C283 120 110 OPEN SIDE L1305 C245 R5940 Q5932 D5936 Q5936 R5937 R5938 28 R248 IC401 192 C403 R431 C413 C411 C243 R436 5 R269 R249 R243 C239 R241 C5932 D5931 R434 R435 R265 R271 I JA4602 FM/AM TUNER UNIT 83 XV-DV363 D R5942 CN452 C5708 8 C983 IC5701 C5719 C228 C262 C3907 11 Q5935 R3915 R5935 R5707 L5933 C242 C240 R247 R250 R246 R245 IC205 R230 R268 C247 C246 C223 R4609 CN461 C4613 23 1 R5946 R4610 C4612 CN5532 C265 C267 C241 CONTACT SIDE C3020 C3019 CN5533 CN451 D3902 D3903 R256 C272 C269 C268 C264 C266 C207 R244 R279 27 C213 C5720 R3903 D3901 R3902 C3902 R3905 C3903 R3906 CN5531 C421 R421 C422 R422 Q491 R3026 9 CN401 1 Q3005 R423 R5944 R3057 R3058 C3026 R3060 R3002 C3046 C3042 D5942 C3044 R3011 R3025 C3004 R3022 R3024 R3039 R3023 R207 R3046 R3073 IC3003 R5947 C1101 C3048 (for FJ) CN3002 (for FJ) CN3001 JA403 SW10.5V R3059 C1102 C260 R252 R257 C238 C261 C222 02 KN1001 CN3002 CN3001 CN3961 B C CN3102 C CN3101 H CN3921 8 7 6 5 SIDE A A V-DV365K ONLY (XNP3111-A) F B 1 4 1 2 3 4 SIDE B A 110 120 130 140 150 160 170 180 190 200 210 220 230 240 B DVD MAIN ASSY B CN3001 19 CN3002 C 19 1 1 1 CN3001 CN3002 C CN401 1 1 9 1 CN451 19 D CN5531 1 CN5533 CN5532 13 9 CN451 1 CN5701 23 CN5701 11 1 E F B 84 XV-DV363 1 2 3 4 5 6 7 8 SIDE B 0 Y 10 20 30 40 50 60 70 80 90 100 110 CN1001 B CN103 CN5601 CN101 CN102 0 X CN3961 10 CN1001 1 1 14 12 CN102 5 20 1 CN3961 CN101 1 30 C 50 60 5 CN104 CN104 1 15 40 CN5601 1 CN103 4 CN5602 80 13 70 D CN5602 90 1 1 100 4 CN204 110 E CN5501 1 120 7 (XNP3111-A) 130 120 A F B 85 XV-DV363 5 6 7 8 C3236 C3232 R3216 FR- C3243 C3231 R3215 C3211 R3211 C3215 C3241 29 FR+ 28 C3141 R3141 R3631 NP 1 8 4 5 SIDE A SIDE A C3610 C3609 C3606 Q3602 C3605 R3609 IC3601 R3610 1 64 1 1 8 1 R3625 R3626 R3627 R3628 R3155 R3154 R3153 C3151 5 4 C3922 1.SDATA4 2.GND 3.RECMUTE 4.SOUTR 5.GND 6.SOUTL 7.GND 8.LINR 9.GND 10.LINL 11.GND 12.LRCLK 13.SCLK 14.GND 15.MCLK 16.GND 17.SDA3 18.SDA2 19.SDA1 19.PCON 1.PLC_CONT 2.POWER 3.SROUT 4.XSD 5.XOTW 6.GND 7.SCL 8.SDA 9.GND 10.XMUTE 11.XPDN 12.XRST 13.3.3V 14.GND 15.HPR 16.GND 17.HPL 18.XHPSEL C C 120 110 CN3111 C3142 R3142 R3632 Q3603 NP R3227 4 C3911 1 R3905 R3907 C3921 19 49 C3181 R3181 Q3604 Q3901 5 4 3 IC3182 8 1 C3242 SR+ IC3201 C3203 R3209 C3204 C5981 C5983 C3217 R3213 R3217 R3228 C5982 C5984 L5982 C3212 C3213 R3212 C3216 LOUT C3234 R3218 R3327 R3238 C3240 R3315 C3218 R3214 C3214 C3244 SR- 56 1 R3208 R3206 R3207 D3101 IC3181 ROUT C3334 R3328 C3331 R3317 C3311 R3311 C3315 R3110 X3101 C3117 R3107 R3105 R3103 LIN C3336 C3332 R3316 C3317 C3341 28 FL+ C3343 R3313 FL- IC3301 SL+ C3303 R3309 C3304 C3342 C3312 C3313 R3312 C3316 R3318 C3318 R3314 C3314 C3344 SL- 56 1 R3305 C3118 C3116 R3106 C3111 RIN C3434 R3427 R3415 C3411 R3411 C3415 C3441 29 R3308 R3306 R3307 16 R3104 C3912 C3621 C3622 C3436 C3431 R3428 R3417 C+ 28 C3120 R3112 C3101 1 29 C3339 C3337 R3338 R3331 R3333 R3336 C3338 R3334 R3335 R3337 R3332 C3340 R3416 C3417 R3413 C- C3443 C3412 C3413 R3412 C3416 IC3401 SW+ C3171 R3409 C3404 C3403 C3442 C3435 OUT 48 C3432 R3418 C3418 R3414 C3414 C3444 SW- 56 1 R3408 R3406 R3407 C3191 IN 33 2.+B 1.GND D3131 R3134 R3133 R3132 R3136 R3137 C3131 D3191 C3333 1.SCL 2.SDA 3.+5V 4.RST 5.GND R3237 R3233 R3131 D3132 Production Code B2 R3620 C3221 R3434 KN3101 L5981 100 90 80 70 R3193 4 3 2 1 5 XV-DV363 86 B CN3002 B CN3001 60 50 40 30 20 10 0 X R3908 IC3901 Y 0 (XNP3112-A) CN3102 CN3101 R3601 D3603 R3624 R3623 R3621 1/2 CN3102 CN3101 C3152 [[ G ]] A30C5/C7 R3619 C3906 R3234 C3108 R3906 10 C3225 R3606 C3602 C3608 C3604 C3624 C3614 R3612 R3608 C3623 C3613 R3611 R3607 R3605 C3601 C3607 C3603 5 E DAMP ASSY 20 XWK3318 FC ICT R3152 R3151 XWK**** XWK**** R3921 C3924 R3923 R3924 C3923 C3223 40 C3612 R3630 R3616 R3614 R3910 C3227 C3201 C3611 Q3601 R3629 R3615 R3617 R3618 R3613 D3601 D3602 30 R3241 R3914 L3201 LF C3905 R3909 R3225 R3901 R3203 R3202 R3201 R3223 C3903 C3901 C3907 R3911 C3904 C3902 C3908 R3912 R3913 R3915 R3916 C3321 C3224 R3243 R3114 C3228 C3202 R3224 R3242 4 5 R3204 1 R3205 R3182 C3182 R3226 JA5981 60 C3226 C3239 C3237 R3236 C3238 R3244 C3323 L3301 L3202 R3325 70 R3109 R3341 C3110 C3112 C3113 C3114 R3108 C3327 C3301 C3233 R3343 R3231 R3235 R3232 17 R3323 C3235 C3325 R3304 80 3 50 D C3103 C3104 90 R3303 32 R3302 R3301 C3324 C3328 C3302 C3119 R3342 C3106 C3107 C3109 C R3111 IC3101 R3101 C3102 R3102 C3105 C3115 C3335 C3326 R3344 R3326 R3324 R3113 C3427 C3401 L3401 L3302 R3425 CN3211 IC3171 CN3171 R3191 1 R3192 C3192 R3198 R3197 C3433 R3443 C3423 R3403 R3402 R3401 C3172 R3441 R3423 OPEN SIDE 100 R3404 R3442 R3432 C3426 L3402 C3421 C3425 110 R3444 R3424 B R3405 R3171 C3440 R3438 R3433 R3426 C3424 120 C3438 R3436 Q3132 C3428 C3402 C3439 R3437 R3194 C3437 R3435 R3431 R3199 R3196 130 Q3131 EL FR4 P IC3191 R3195 CN3201 R 140 J CN2 C DAMP ASSY CN3201 150 4 3 2 1 11.4 DAMP ASSY A F 19 5 6 7 8 SIDE B SIDE B A C DAMP ASSY 150 CN3201 1 140 CN3201 B 130 120 C3448 C3447 110 C3445 C3446 1 C3345 5 C3348 100 C3347 C 90 C3346 C3248 C3245 C3247 80 C3246 3 2 1 70 60 D 50 40 LF 30 20 CN3102 E CN3101 10 19 1 19 1 0 Y CN3102 (XNP3112-A) 120 110 100 90 80 70 60 CN3101 50 40 30 20 10 0 X F C C 87 XV-DV363 5 6 7 8 1 2 3 4 11.5 DISPLAY, USB, LED and KEY ASSYS SIDE A SIDE A B CN5602 D DISPLAY ASSY CN5901 DISPLAY ASSY 13 C5907 V+10 W5908 FLDC- VEE 1 FLDC+ W5906 60 W5910 XWZ4256 1 CONTACT SIDE 70 [[ G ]] C7 A CN5901 45 W5900 B IC 59 01 C5952 IC5902 C5913 VE+5 W5907 VEE FL SPACER L5901 W5911 FL SPACER W5912 C5918 GNDD GNDD W5905 V5901 PNE-1B1 S5967 S5965 S5966 KN5903 40 B L5902 50 S5964 A S5962 S5963 30 OPEN/CLOSE PLAY/PAUSE STOP VOL DOWN USB VOL UP 1/4 (XNP3114-B) Y 20 50 60 70 F 80 90 100 110 120 130 140 150 160 170 180 190 200 210 LED ASSY KEY ASSY 70 80 90 100 110 120 FC 130 ICT 60 D 3 1 1 CONTACT SIDE CONTACT SIDE 50 USB ASSY 50 W5904 CN5908 CN5904 C602 PNE-1B1 Production Code 40 XWZ4259 XWZ4260 KN5902 1 E 3 40 W5991 60 5 5 CN5902 CN5906 S5992 13 15 CN5903 CN5907 V+10 E 1 60 CN5906 CN5902 PNE-1B1 70 1/4 CN5907 CN5903 S5993 CN5906 PLAYLIST1 CN5907 70 80 PLAY LIST2 B CN5601 PLAYLIST ASSY PLAYLIST3 1 90 USB ASSY 30 GNDUSB JA602 [[ G ]] C7 POWER ON S5991 CONTACT SIDE W5902 30 W5913 W5901 JA5901 GNDUSB 20 CN5909 1/4 100 50 X CN5908 D5611 Y 0 CN5909 3 CONTACT SIDE LED ASSY XWZ4263 CN5603 110 (XNP3114-B) XWZ4261 XWZ4262 3 10 G 120 S5994 PNE-1B1 [[ G ]] C7 20 1/4 CONTACT SIDE 1 CN5603 30 C 20 [[ G ]] C7 A 10 10 (XNP3114-B) (XNP3114-B) Y 0 Y 0 0 X F 10 20 30 40 50 60 70 190 X DE F G 200 210 220 230 D E F G 88 XV-DV363 1 2 3 4 PNE-1B1 1.KEY2A 2.GND 3.KEY1 4.LED 5.V+10 3 C5611 LED ASSY 5 Q5611 R5615 VOL DOWN 10 1/4 15 13 C5612 R5613 R5612 D5612 23 VFDP USB STOP PLAY LIST2 15.V+10 14.LED 13.KEY1 12.KEY2A 11.GNDUSB 10.USB_DM2 9.USB_DP2 8.V5USB 7.V5USB 6.GNDUSB 5.HP_DET 4.HP_R 3.GNDD 2.HP_L 1.HPMUTE C601 D5972 R5972 R5974 Q5973 Q5971 R5971 R5973 R602 R603 C603 R605 1 PLAY/PAUSE 1 3 1 R5990 R604 R5978 R5984 R5986 Q5974 R5985 R5983 R5976 R5980 R5982 C5972 C5971 5 PNE-1B1 R5979 R5981 D5971 R5975 R5977 B R5991 PLAYLIST1 R5992 L603 C604 L602 D601 L5972 R5988 POWER ON C605 A R5989 L5973 C5978 L601 C5979 C5977 C5974 C5973 L5971 R5987 JA602 XWZ4259 XWZ4260 PNE-1B1 1 VOL UP R5614 R5611 1/4 XWZ4261 XWZ4262 R5993 PLAYLIST ASSY PLAYLIST3 90 1 11 GNDD 22 DISPLAY ASSY 33 FLDC+ 11 R5966 3 R5962 R5963 R5964 C5915 R5965 C5917 C5919 30 1 1 R5904 C5921 C5922 C5914 D5901 C5912 CN5603 GNDD D5902 C5916 01 59 IC 44 C5911 VE+5 1/4 CN5901 34 R5905 R5909 Q5901 12 C5905 C5903 R5907 R5908 B C5920 R5902 R5903 R5901 100 1.LED 2.GND 3.V+10 CN5909 70 13 C5906 R5906 R5910 Q5902 R5951 R5952 3 E 2.GND 3.KEY1 4.LED 5.V+10 CN5908 60 13.GNDD 12.KEY2 11.KEY1 10.GNDD 9.GNDD 8.FLDC+ 7.FLDC6.VFDP 5.VE+5 4.REMOCON 3.FLCS 2.FLCK 1.FLDATA LF C5904 R5953 0 Y C 89 D E F G DE F G GNDUSB SIDE B SIDE B 20 Y (XNP3114-B) 110 10 10 0 Y 0 Y XV-DV363 8 F 0 X 10 20 30 40 50 LF 40 R5954 (XNP3114-B) (XNP3114-B) GNDUSB NP 50 C5951 NP 20 JA5901 20 NP 60 60 40 40 CN5902 30 30 7 6 5 PNE-1B1 50 NP 50 70 USB ASSY 1/4 70 CN5907 CN5906 USB ASSY 50 X 60 70 80 90 100 110 120 130 D E 80 1.V+10 2.GND 3.LED 20 120 60 70 190 X 200 210 220 230 C KEY ASSY G 30 LED ASSY F 50 X 60 70 80 90 100 110 120 130 140 150 160 170 180 190 200 210 CN5901 DISPLAY ASSY 8 7 6 5 A D (XNP3114-B) VFDP FLDC- OPEN/CLOSE 1.KEY2A 1 2 3 4 11.6 POWER SUPPLY UNIT A SIDE A SIDE A J POWER SUPPLY UNIT To AC POWER CORD CN1 CN2 C CN3201 CN3 B CN1001 B C D E F J J 90 XV-DV363 1 2 3 4 5 6 7 8 SIDE B SIDE B J A POWER SUPPLY UNIT CN1 CN2 B C CN3 D E F J J 91 XV-DV363 5 6 7 8 1 2 3 4 XV-DV363 92 I I 90 F (ANP7569-B) R473 R470 R471 C470 R468 V+5 Q463 GNDD V+10 R461 C465 R464 Q472 Q461 R465 C464 R466 R467 R469 R472 23 20 CN461 10 CN461 GNDD VSEL1 3 SQEEZE NP Q493 1 V+10 Q492 D471 D472 1 R476 R475 C474 GNDD R478 C490 GNDD V+5 D473 R474 D474 R484 R486 C484 C489 C487 1 3 IC471 6 4 R482 R487 C493 IC472 6 4 C476 R481 R488 C494 C473 GNDD C472 VSEL2 C475 R483 R485 C483 R493 R494 C496 R496 C486 GNDD 1/4 C B2 E2 E B C2 R462 R463 C469 R LF PNE-1B1 C495 R495 C485 EUROSCART ASSY AWU8291 Q462 23.S_Y 11.V+5 22.GND 10.SCART_L 21.V 9.GND 20.GND 8.SCART_R 7.TVMUTE 19.S_C 6.TVOUT_L 18. DVDPOWER 5.GND 17.R 4.TVOUT_R 16.GND 3.V+10 15.G 2.SQEEZE 14.GND 1.VSEL1 13.B 12.VSEL2 80 70 60 50 40 E 30 R477 C492 C491 C488 21 1 20 20 2 10 Y 0 D X 0 I 10 EUROSCART ASSY 20 30 40 50 60 70 80 90 100 110 SIDE B SIDE B 0 X 10 20 30 40 50 60 70 80 90 100 110 Y 0 (ANP7569-B) 10 C 20 V+10 W112 GNDD 1 CONTACT SIDE W204 GNDD C477 C482 CN461 CN461 VSEL1 SQEEZE W111 W110 CN451 B 23 PRODUCTION CODE 1/4 R PNE-1B1 W201 GNDD W102 V+10 C481 V+5 W106 GNDD C471 W109 EUROSCART ASSY AWU8291 GNDD W104 W108 VSEL2 W103 60 GNDD C478 C479 C480 JA451 30 W202 40 W101 V+5 W107 50 B 70 ICT FC W203 GNDD 80 I 90 EUROSCART ASSY A SIDE A SIDE A 11.7 EUROSCART ASSY 1 2 3 4 5 6 7 8 12. PCB PARTS LIST NOTES: Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%, and K=10%). 560 Ω 561 56 x 10 1 RD1/4PU 5 6 1 J 473 47k Ω 47 x 10 3 RD1/4PU 4 7 3 J 0.5 Ω R50 RN2H R 5 0 K 1R0 1Ω RS1P 1 R 0 K Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k Ω 562 x 10 1 5621 RN1/4PC 5 6 2 1 F Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V A B LIST OF WHOLE PCB ASSEMBLIES XV-DV363 /WYXJ5 XV-DV365K /WXJ/RE5 1..LOAB ASSY 1..DAMP ASSY 1..DVD MAIN ASSY VWG2346 XWK3318 XWM3341 VWG2346 XWK3318 XWM3342 NSP 1..COMPLEX ASSY 2..DISPLAY ASSY 2..USB ASSY 2..KEY ASSY 2..LED ASSY XWM3372 XWZ4256 XWZ4259 XWZ4261 XWZ4263 XWM3372 XWZ4256 XWZ4259 XWZ4261 XWZ4263 NSP 1..JACK ASSY 2..EUROSCART ASSY AWM8034 AWU8291 AWM8034 AWU8291 NSP > 1..MIC ASSY 1..POWER SUPPLY UNIT 1..FM/AM TUNER UNIT Not used XWR3012 AXX7248 XWM3375 XWR3012 AXX7248 Mark Symbol and Description C D CONTRAST OF PCB ASSEMBLIES B DVD MAIN ASSY XWM3341 and XWM3342 are constructed the same except for the following : Mark Symbol and Description XWM3341 XWM3342 IC3961 D3961, D3962 C3961 C3962, C3966 C3963, C3965 Not used Not used Not used Not used Not used AK5358AET UDZS3R9(B) CKSRYB105K16 CKSRYB104K16 CKSQYB225K10 C3967 C3968 R249 R3966 R3967 Not used Not used Not used Not used Not used CEAT220M25 CKSRYB103K50 RS1/16S330J RS1/16S102J RS1/16S332J R3968 R3969 R5502 R5513 R5515 Not used Not used Not used Not used RD1/4PU473J RS1/16S182J RAB4C101J RS1/16S104J RD1/4PU153J RD1/4PU823J Not used Not used RS1/16S102J CKS3370 R5571 CN3961 Connector E F 93 XV-DV363 5 6 7 8 1 2 3 4 PCB PARTS LIST Mark No. A Description Mark No. Part No. A LOAB ASSY MISCELLANEOUS S 101 SWITCH CN 602 CONNECTOR CN 601 CONNECTOR VSK1011 S2B-PH-K S5B-PH-K B DVD MAIN ASSY MISCELLANEOUS IC IC IC IC 101 201 202 203 (A,41,32) 6CH DRIVER IC (A,77,112) DVD IC (A,110,99) IC (A,72,77) FLASH ROM FLASH MEMORY IC IC 204 (A,93,79) EEPROM IC IC > IC IC > IC 401 771 781 931 981 B (A,103,145) DVD VIDEO AMP IC (A,34,50) LOAD SWITCHING (A,51,49) REGULATOR IC (A,102,195) HDMI IC (A,84,160) REGULATOR IC > IC 1101 (A,20,110) REGULATOR IC C D E F BD7995EFS MT1389FE/H-L K4S641632K-UC75 AYW7154 S29AL016D70TFI010 S-24CS64A0I MM1758XF AAT4618IGV-0.5-1 NJM2845DL1-05 MT1392E/C-L NJM2872BF05 IC IC IC IC 3001 (A,41,151) IC 3003 (A,23,145) AD CONVERTER IC 3004 (A,25,132) IC 3005 (A,42,126) IC NJM2846DL3-18 TC4052BFN AK5358AET TC7WU04FU TC74VHC157FTS1 IC IC IC Q Q 5501 (A,83,44) SYSTEM CONTROL UCON 5502 (A,111,37) EEPROM 5701 (A,72,168) RDS DECORDER IC 304 (A,13,35) TRANSISTOR 305 (A,14,41) NMOS FET TRANSISTOR PDC153A S-93C46BD0I-J8T1 LC72725KM 2SC4154 UM5K1N Q Q Q Q Q 307 308 491 933 934 HN1A01F HN1A01F RT1N241M RT1N144M RT3P22M Q Q Q Q Q 1201 (A,24,101) TRANSISTOR 1202 (A,30,106) CHIP TRANSISTOR 1301 (A,13,102) TRANSISTOR(SC-70) 1302 (A,17,102) TRANSISTOR 1303 (A,13,96) TRANSISTOR RT1N141M-11 RSR015P03 2SA1602A 2SA1577 2SC4154 Q Q Q Q Q 1304 (A,18,92) TRANSISTOR 1402 (A,110,25) TRANSISTOR (SC-70) 1413 (A,106,21) TRANSISTOR 3005 (A,42,140) CHIP TRANSISTOR 3006 (A,8,200) TRANSISTOR 2SC4154 2SA1602A RT1N241M HN1A01FU RT1N241M Q Q Q Q Q 3951 (A,46,64) TRANSISTOR 5525 (A,62,59) DIGITAL TR (SC-70) 5703 (A,74,187) CHIP TRANSISTOR 5941 (A,21,192) TRANSISTOR 5942 (A,27,195) TRANSISTOR (SC-70) RT1N241M RT1N431M HN1C01FU RT1N241M 2SA1602A D D D D D 802 (A,61,24) DIODE 933 (A,112,204) DIODE 1201 (A,27,103) DIODE 1403 (A,110,30) DIODE 1415 (A,103,22) DIODE 1SS352 UDZS5R1(B) 1SS352 MC2846-11 UDZS4R7(B) (A,11,61) CHIP TRANSISTOR (A,16,61) CHIP TRANSISTOR (A,46,206) TRANSISTOR (A,114,212) TRANSISTOR (A,115,216) TRANSISTOR 94 Description Part No. D D L L L 5941 (A,21,195) DIODE 5942 (A,25,188) DIODE 761 (A,51,98) COIL 772 (A,39,50) CHIP SOLID INDUCTOR 931 (A,95,171) CHIP BEADS 1SS352 1SS352 VTH1047 ATL7002 ATL7010 L L L L L 932 933 934 935 936 ATH7022 ATH7022 ATH7022 ATH7022 ATL7010 L L L L L 937 (A,100,169) CHIP BEADS 1305 (A,16,105) INDUCTOR 1501 (A,58,42) AXIAL INDUCTOR 3951 (A,40,65) INDUCTOR 3952 (A,38,65) INDUCTOR (A,97,216) COIL (A,100,216) COIL (A,102,216) COIL (A,105,216) COIL (A,93,171) CHIP BEADS JA 403 (A,20,232) JACK JA 931 HDMI CONNECTOR X 201 (A,75,140) CRYSTAL RESONATOR (27 MHz) X 3004 (A,24,123) CRYSTAL RESONATOR (12.288 MHz) X 5501 (A,64,44) CERAMIC RESONATOR (10 MHz) ATL7010 CTF1395 LAU220J CTF1346 CTF1346 VKB1122 AKP7210 VSS1168 VSS1140 ASS7034 X 5701 (A,74,157) CRYSTAL RESONATOR (4.332 MHz) CN 101 (A,21,41) CONNECTOR 24P CN 102 (A,19,18) 12P CONNECTOR CN 103 (A,20,57) 4P CONNECTOR CN 104 (A,46,10) CONNECTOR POST ASS7004 VKN2045 VKN1243 VKN1235 B5B-PH CN CN CN CN CN 204 (A,99,83) CONNECTOR 451 (A,65,182) CONNECTOR 1001 CONNECTOR 3001 (A,8,157) 19P RECEPTACLE 3002 (A,8,193) 19P RECEPTACLE B4B-PH CKS3388 B13B-PH AKP7199 AKP7199 CN CN CN CN 5501 (A,114,53) CONNECTOR 5601 (A,26,56) CONNECTOR 5602 (A,85,12) CONNECTOR 5701 (A,86,179) CONNECTOR 2 PCB BINDER CKS3372 CKS3380 CKS3378 CKS3376 VEF1040 RESISTORS R R R R R 131 132 133 134 135 (A,28,24) (A,28,26) (A,28,28) (A,28,30) (A,28,32) RS1/10S4R7J RS1/10S4R7J RS1/10S4R7J RS1/10S4R7J RS1/10S4R7J R R R R R 136 151 152 153 154 (A,28,34) (A,51,37) (A,51,41) (A,49,37) (A,49,41) RS1/10S4R7J RS1/10S1R0J RS1/10S1R8J RS1/10S1R0J RS1/10S1R8J R R R R R 201 202 204 205 206 (A,50,75) (A,53,75) (A,53,79) (A,56,79) (A,56,75) RS1/16S152J RS1/16S223J RS1/16S223J RS1/16S513J RS1/16S513J R R R R R 212 213 215 216 218 (A,56,101) (A,56,102) (A,80,86) (A,79,89) (A,86,81) RS1/16S103J RS1/16S103J RS1/16S332J RS1/16S472J RS1/16S103J 3 4 XV-DV363 1 2 5 Mark No. 6 Description Part No. 7 Mark No. 8 Description Part No. R R R R R 219 221 223 224 225 (A,86,82) (A,76,89) (A,91,87) (A,73,89) (A,99,99) CHIP RESISTOR ARRAY RS1/16S103J RS1/16S330J RS1/16S330J RS1/16S330J RAB4C330J R R R R R 412 413 414 415 416 (A,100,131) (A,93,130) (A,103,131) (A,107,130) (A,110,130) RS1/16S1500F RS1/16S1500F RS1/16S1500F RS1/16S1500F RS1/16S1500F R R R R R 226 227 228 229 230 (A,99,102) (A,99,103) (A,99,105) (A,99,106) (A,86,134) RS1/16S0R0J RS1/16S330J RS1/16S330J RS1/16S330J RS1/16S103J R R R R R 424 491 767 768 769 (A,19,209) (A,49,206) (A,51,104) (A,52,101) (A,51,103) RS1/10S75R0F RS1/16S103J RS1/16S153J RS1/16S153J RS1/16S330J R R R R R 233 234 235 237 240 (A,68,92) (A,79,86) (A,77,86) (A,77,89) (A,88,147) RS1/16S0R0J RS1/16S330J RS1/16S472J RS1/16S330J RS1/16S0R0J R R R R R 770 771 772 801 906 (A,52,100) (A,37,50) (A,31,48) (A,61,28) (A,91,194) RS1/16S330J RS1/16S221J RS1/16S104J RS1/16S472J RS1/16S100J R R R R R 241 242 243 244 245 (A,83,134) (A,83,138) (A,81,134) (A,88,134) (A,87,137) RS1/16S330J RS1/16S330J RS1/16S100J RS1/16S330J RS1/16S330J R R R R R 911 914 915 931 933 (A,91,191) (A,114,184) (A,116,191) (A,102,184) (A,92,199) RS1/16S100J RS1/16S103J RS1/16S102J RS1/16S0R0J RS1/16S561J R R R R R 246 247 248 251 252 (A,86,138) (A,88,156) (A,81,138) (A,70,134) (A,72,130) RS1/16S330J RS1/16S0R0J RS1/16S330J RS1/16S104J RS1/16S0R0J R R R R R 934 959 960 961 962 (A,92,203) CHIP RESISTOR (A,117,214) (A,117,217) (A,113,219) (A,115,219) RS1/16S5100F RS1/16S472J RS1/16S272J RS1/16S472J RS1/16S272J R R R R R 253 254 255 256 257 (A,73,134) (A,67,133) (A,61,134) (A,57,131) (A,74,130) RS1/16S681J RS1/16S754J RS1/16S104J RS1/16S153J RS1/16S0R0J R R R R R 966 (A,110,206) 970 (A,112,209) 973 (A,109,209) 1101 (A,24,105) 1201 (A,31,102) RS1/16S473J RS1/16S102J RS1/16S0R0J RS1/16S221J RS1/16S103J R R R R R 258 259 260 261 262 (A,80,89) (A,82,87) (A,83,87) (A,95,87) (A,85,86) RS1/16S330J RS1/16S330J RS1/16S330J RS1/16S330J RS1/16S330J R R R R R 1202 (A,29,103) 1301 (A,13,100) 1302 (A,13,98) 1303 (A,17,99) 1304 (A,16,92) RS1/16S474J RS1/16S473J RS1/16S392J RS1/16S473J RS1/10S561J R R R R R 263 264 265 266 267 (A,86,86) (A,110,122) CHIP RESISTOR ARRAY (A,104,118) CHIP RESISTOR ARRAY (A,99,115) (A,110,115) CHIP RESISTOR ARRAY RS1/16S330J RAB4C330J RAB4C330J RS1/16S0R0J RAB4C330J R R R R R 1306 (A,21,95) 1307 (A,13,92) 1401 (A,114,27) 1402 (A,114,30) 1403 (A,112,27) RS1/16S103J RS1/16S472J RS1/16S392J RS1/16S332J RS1/16S473J R R R R R 269 271 272 279 281 (A,82,142) (A,104,113) CHIP RESISTOR ARRAY (A,96,87) (A,89,134) CHIP RESISTOR (A,107,84) RS1/16S0R0J RAB4C330J RS1/16S333J RS1/16S2201F RS1/10S0R0J R R R R R 1404 (A,112,30) 1415 (A,100,22) 3006 (A,8,198) 3009 (A,49,153) 3010 (A,34,153) RS1/16S393J RS1/16S182J RS1/16S103J RS1/16S102J RS1/16S102J R R R R R 284 291 292 293 294 (A,60,80) (A,72,86) (A,73,85) (A,93,84) (A,90,84) RS1/16S103J RS1/16S332J RS1/16S682J RS1/16S332J RS1/16S682J R R R R R 3011 (A,47,159) 3012 (A,34,155) 3013 (A,49,156) 3014 (A,34,156) 3015 (A,48,149) RS1/16S223J RS1/16S223J RS1/16S223J RS1/16S223J RS1/16S223J R R R R R 313 314 315 318 321 (A,16,39) (A,15,37) (A,12,37) (A,12,39) (A,19,61) RS1/16S104J RS1/16S103J RS1/16S103J RS1/16S104J RS1/16S4R7J R R R R R 3016 (A,34,152) 3017 (A,48,150) 3018 (A,34,150) 3019 (A,48,152) 3020 (A,37,157) RS1/16S223J RS1/16S223J RS1/16S223J RS1/16S272J RS1/16S272J R R R R R 322 325 326 401 411 (A,14,61) (A,10,57) (A,15,57) (A,109,138) (A,96,131) RS1/16S4R7J RS1/16S4R7J RS1/16S4R7J RS1/16S103J RS1/16S1500F R R R R R 3021 (A,45,140) 3022 (A,37,143) 3023 (A,37,138) 3024 (A,39,143) 3025 (A,45,136) RS1/16S224J RS1/16S224J RS1/16S102J RS1/16S102J RS1/16S102J A B C 6 E F 95 XV-DV363 5 D 7 8 1 Mark No. A B 2 Description 3 Part No. Mark No. E F Description Part No. R R R R R 3026 (A,44,136) 3027 (A,49,155) 3039 (A,36,138) 3040 (A,42,144) 3048 (A,17,137) RS1/16S102J RS1/16S473J RS1/16S153J RS1/16S153J RS1/16S182J R R R R R 5581 (A,98,64) 5582 (A,96,64) 5583 (A,92,64) 5584 (A,90,64) 5590 (A,80,63) RS1/16S221J RS1/16S221J RS1/16S103J RS1/16S221J RAB4C221J R R R R R 3049 (A,22,139) 3052 (A,22,134) 3053 (A,31,131) 3054 (A,31,128) 3055 (A,27,129) RAB4C101J RS1/16S0R0J RS1/16S101J RS1/16S101J RS1/16S105J R R R R R 5597 (A,82,63) 5708 (A,75,193) 5712 (A,78,184) 5713 (A,78,190) 5943 (A,73,212) RS1/16S153J RS1/16S0R0J RS1/16S272J RS1/16S272J RS1/16S0R0J R R R R R 3056 (A,23,129) 3057 (A,27,150) 3060 (A,29,143) 3061 (A,37,130) 3062 (A,35,127) RS1/16S101J RS1/16S0R0J RS1/16S0R0J RS1/16S221J RS1/16S221J R R R R R 5944 (A,30,195) 5945 (A,29,192) 5946 (A,24,195) 5947 (A,27,188) 5949 (A,25,192) RS1/16S104J RS1/16S392J RS1/16S472J RS1/16S102J RS1/16S103J R R R R R 3063 (A,35,125) 3065 (A,48,127) 3066 (A,35,121) 3073 (A,18,139) 3081 (A,10,164) RS1/16S221J RS1/16S221J RS1/16S101J RS1/16S332J RS1/16S105J R 9401 (A,16,196) RS1/16S0R0J R R R R R 3082 (A,10,163) 3915 (A,70,200) 3951 (A,43,65) 3952 (A,35,65) 3955 (A,50,63) RS1/16S105J RS1/16S473J RS1/16S473J RS1/16S473J RS1/16S182J R R R R R 5501 (A,67,58) 5505 (A,67,55) 5506 (A,67,54) 5507 (A,67,53) 5508 (A,62,55) RAB4C221J RS1/16S221J RS1/16S221J RS1/16S221J RS1/16S222J R R R R R 5509 (A,67,61) 5510 (A,62,53) 5514 (A,57,22) 5515 (A,52,27) 5516 (A,52,20) RS1/16S0R0J RS1/16S473J RD1/4PU683J RD1/4PU473J RD1/4PU153J R R R R R 5517 (A,66,35) 5518 (A,62,35) 5519 (A,62,32) 5521 (A,66,33) 5527 (A,67,25) RAB4C221J RS1/16S105J RS1/16S103J RS1/16S221J RAB4C221J R R R R R 5531 (A,71,25) 5536 (A,79,25) 5541 (A,87,25) 5543 (A,94,10) 5544 (A,81,22) RS1/16S0R0J RS1/16S221J RAB4C221J RS1/16S0R0J RS1/16S0R0J R R R R R 5546 (A,84,22) 5547 (A,84,21) 5548 (A,100,29) 5557 (A,100,36) 5558 (A,106,40) RS1/16S103J RS1/16S103J RAB4C221J RAB4C221J RS1/16S473J R R R R R 5559 (A,112,41) 5562 (A,100,39) 5563 (A,104,46) 5564 (A,100,40) 5565 (A,100,42) RS1/16S473J RS1/16S221J RS1/16S103J RS1/16S221J RS1/16S221J R R R R R 5566 (A,100,45) 5569 (A,66,39) 5570 (A,100,51) 5574 (A,95,64) 5577 (A,100,60) RAB4C221J RS1/16S221J RAB4C221J RS1/16S104J RAB4C221J CAPACITORS C D 4 96 C C C C C 101 102 103 104 121 (A,40,18) (A,40,22) (A,48,29) (A,49,34) (A,48,32) CEAT101M10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K6R3 C C C C C 131 140 144 145 146 (A,33,41) (A,16,15) (A,32,32) (A,34,31) (A,34,34) CKSRYB104K16 CKSRYB105K6R3 CKSRYB222K50 CKSRYB222K50 CKSRYB222K50 C C C C C 151 152 153 161 200 (A,49,26) (A,49,23) (A,46,21) (A,32,38) (A,58,111) CKSRYB103K50 CKSRYB103K50 CKSRYB103K50 CKSRYB102K50 CKSRYB104K16 C C C C C 201 202 203 204 205 (A,59,93) (A,45,112) (A,46,100) ELECT. CAPACITOR (A,54,113) (A,54,111) CEAT221M6R3 CEAT221M6R3 CEAT470M35 CKSRYB104K16 CKSRYB104K16 C C C C C 206 207 208 209 210 (A,52,108) ELECT. CAPACITOR (A,55,116) (A,55,75) (A,52,75) (A,52,79) CEAT470M35 CKSRYB104K16 CKSRYB222K50 CKSRYB104K16 CKSRYB222K50 C C C C C 211 212 213 215 216 (A,55,79) (A,58,75) (A,54,115) (A,46,106) ELECT. CAPACITOR (A,58,105) CCSRCH101J50 CCSRCH101J50 CKSRYB104K16 CEAT470M35 CKSRYB104K16 C C C C C 217 218 219 220 223 (A,59,100) (A,58,108) (A,58,109) (A,63,94) (A,63,146) CKSRYB104K16 CKSRYB104K16 CKSRYB562K50 CKSRYB104K16 CEAT100M50 C C C C C 224 225 226 227 228 (A,75,93) (A,76,93) (A,88,87) (A,96,89) (A,78,134) CKSRYB104K16 CKSRYB104K16 CKSRYB103K50 CCSRCH221J50 CKSRYB104K16 3 4 XV-DV363 1 2 5 Mark No. 6 Description Part No. 7 Mark No. 8 Description Part No. C C C C C 229 230 231 232 233 (A,89,92) (A,94,99) (A,95,104) (A,95,106) (A,96,111) CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 C C C C C 401 402 404 405 411 (A,92,151) (A,91,147) (A,92,144) (A,103,138) (A,97,137) CEAT101M16 CKSRYB104K16 CEAT101M16 CKSRYB104K16 CKSRYB104K16 C C C C C 234 235 236 237 238 (A,95,113) (A,95,116) (A,95,118) (A,103,126) (A,75,130) CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CEAT221M6R3 CKSRYB104K16 C C C C C 412 413 414 415 416 (A,101,136) (A,95,137) (A,104,136) (A,107,135) (A,111,135) CKSRYB105K6R3 CKSRYB105K6R3 CKSRYB105K6R3 CKSRYB104K16 CKSRYB104K16 C C C C C 239 241 242 243 244 (A,81,131) (A,69,147) (A,75,147) (A,94,127) (A,95,123) CKSRYB104K16 CEAT100M50 CEAT100M50 CKSRYB104K16 CKSRYB104K16 C C C C C 429 771 773 781 782 (A,18,203) ELECT. CAPACITOR (A,36,53) (A,31,51) (A,42,45) (A,48,58) CEAT102M6R3 CKSQYB105K16 CKSRYB104K16 CEAT100M50 CKSQYB225K10 C C C C C 245 246 247 248 250 (A,88,131) (A,87,130) (A,84,131) (A,84,134) (A,102,122) CKSRYB105K6R3 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 C C C C C 931 932 933 934 935 (A,96,186) (A,97,180) ELECT. CAPACITOR (A,94,185) (A,94,187) (A,96,166) CKSRYB104K16 CEAT470M35 CKSRYB104K16 CKSRYB102K50 CKSRYB104K16 C C C C C 251 252 254 255 256 (A,70,135) (A,74,135) (A,67,135) (A,60,137) (A,64,140) CCSRCH9R0D50 CCSRCH120J50 CKSRYB102K50 CKSRYB474K10 CEAT100M50 C C C C C 936 942 943 944 945 (A,113,189) (A,102,185) (A,108,185) (A,92,201) (A,110,202) CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB562K50 C C C C C 258 259 260 261 262 (A,64,135) (A,64,133) (A,70,131) (A,76,131) (A,81,148) CKSRYB473K25 CKSRYB473K25 CKSRYB104K16 CKSRYB104K16 CEAT100M50 C C C C C 946 951 952 953 954 (A,108,204) (A,109,210) (A,109,218) (A,91,180) ELECT. CAPACITOR (A,91,185) CKSRYB104K16 CKSRYB104K16 CEAT100M50 CEAT470M35 CKSRYB104K16 C C C C C 264 265 266 267 268 (A,66,131) (A,57,135) (A,68,131) (A,58,135) (A,62,131) CKSRYB104K16 CCSRCH220J50 CKSRYB104K16 CKSRYB102K50 CKSRYB104K16 C C C C C 955 956 982 983 984 (A,94,166) (A,91,187) (A,84,164) (A,80,161) (A,84,157) CKSRYB104K16 CKSRYB102K50 CKSQYB225K10 CKSQYB105K16 CKSRYB104K16 C C C C C 269 271 272 273 281 (A,60,131) (A,64,130) (A,59,131) (A,64,131) (A,113,85) CKSRYB333K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CEAT221M6R3 C C C C C 985 (A,100,165) 987 (A,100,172) 1101 (A,27,108) 1103 (A,31,115) ELECT. CAPACITOR 1201 (A,24,103) CKSRYB104K16 CKSRYB102K50 CKSRYB105K6R3 CEAT470M35 CKSRYB105K6R3 C C C C C 282 283 284 285 286 (A,109,84) (A,117,109) (A,102,98) (A,101,93) (A,117,90) CKSRYB105K6R3 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 C C C C C 1204 (A,31,103) 1301 (A,18,95) 1501 (A,61,48) 1502 (A,61,43) 1505 (A,58,51) CKSRYB563K16 CKSRYB105K6R3 CKSRYB103K50 CKSRYB104K16 CEAT101M10 C C C C C 287 288 289 290 296 (A,117,94) (A,117,99) (A,86,77) (A,93,75) (A,84,77) CKSRYB104K16 CKSRYB104K16 CKSRYB105K6R3 CKSRYB104K16 CKSRYB102K50 C C C C C 3001 (A,44,157) 3011 (A,20,182) 3012 (A,20,188) 3015 (A,39,170) 3016 (A,39,164) CKSRYB103K50 CEAT100M50 CEAT100M50 CEAT100M50 CEAT100M50 C C C C C 309 310 343 344 345 (A,17,66) ELECT. CAPACITOR (A,23,66) ELECT. CAPACITOR (A,58,124) (A,48,117) (A,48,118) CEAT470M35 CEAT470M35 CKSRYB105K6R3 CKSRYB105K6R3 CKSRYB105K6R3 C C C C C 3019 (A,63,165) 3020 (A,62,172) 3021 (A,29,138) 3022 (A,42,143) 3023 (A,31,135) ELECT. CAPACITOR CEAT100M50 CEAT100M50 CKSRYB104K16 CKSRYB104K16 CEAT470M35 C C C C C 346 347 371 372 374 (A,55,122) (A,55,120) (A,15,44) (A,26,46) (A,10,49) ELECTR.CAPACITOR CKSRYB105K6R3 CKSRYB105K6R3 CKSRYB104K16 CKSRYB104K16 CEAT101M6R3 C C C C C 3024 (A,40,136) 3025 (A,33,141) 3026 (A,33,147) 3041 (A,19,161) 3042 (A,22,151) CEAT221M6R3 CEAT100M50 CEAT100M50 CEAT100M50 CKSRYB104K16 A B C 6 E F 97 XV-DV363 5 D 7 8 1 Mark No. A B 2 Description 3 Part No. Mark No. E Part No. 3043 (A,27,158) 3044 (A,24,151) 3045 (A,20,155) 3046 (A,20,151) 3048 (A,17,139) CEAT2R2M50 CKSRYB104K16 CEAT100M50 CKSRYB104K16 CKSRYB103K50 Q Q Q D D 3602 (A,81,21) DIGITAL TR (SC-70) 3603 (A,95,32) TRANSISTOR 3604 (A,29,52) DIGITAL TR (SC-70) 3101 (A,28,57) DIODE 3131 (A,41,137) DIODE RT1P241M IMX9 RT1P241M MC2846-11 UDZS18(B) C C C C C 3052 (A,25,134) 3056 (A,23,127) 3057 (A,27,127) 3064 (A,43,130) 3951 (A,41,73) CKSRYB104K16 CCSRCH270J50 CCSRCH270J50 CKSRYB104K16 CEAT101M16 D D L L L 3191 (A,21,124) DIODE 3603 (A,83,8) DIODE 3201 (A,70,37) INDUCTORS 3202 (A,70,54) INDUCTORS 3301 (A,70,70) INDUCTORS UDZS4R7(B) UDZS12(B) ATH7019 ATH7019 ATH7019 C C C C C 3952 (A,35,73) 5502 (A,56,36) 5504 (A,62,56) 5508 (A,62,54) 5509 (A,68,50) CEAT101M16 CEAT101M10 CKSRYB103K50 CKSRYB103K50 CKSRYB104K16 L L L JA X 3302 (A,70,87) INDUCTORS 3401 (A,70,103) INDUCTORS 3402 (A,70,120) INDUCTORS 5981 (A,113,65) JACK 3101 (A,18,67) CRYSTAL RESONATOR (13.5 MHz) ATH7019 ATH7019 ATH7019 RKN1004 ASS7062 C C C C C 5517 (A,68,41) 5518 (A,66,38) 5519 (A,62,33) 5521 (A,63,28) 5522 (A,64,33) CKSRYB103K50 CKSRYB104K16 CKSRYB103K50 CKSRYB104K16 CKSRYB103K50 CN CN CN CN CN 3101 (A,41,8) 19P PLUG 3102 (A,77,8) 19P PLUG 3111 (A,116,42) PIN JACK(4P) 3201 (A,84,140) 2P CONNECTOR 3211 (A,116,96) 6CH SPEAKER JACK AKM7077 AKM7077 AKB7114 B2P-VH AKE7121 C C C C C 5524 (A,58,62) 5539 (A,84,25) 5555 (A,99,32) 5557 (A,116,38) 5558 (A,106,36) CEAT100M50 CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CCSRCH470J50 4 VEF1040 C C C C C 5569 (A,100,48) 5577 (A,100,57) 5578 (A,101,62) 5579 (A,93,64) 5589 (A,84,63) CKSRYB103K50 CKSRYB103K50 CKSRYB103K50 CKSRYB102K50 CKSRYB104K16 C C C C C 5601 (A,72,6) 5602 (A,77,6) 5603 (A,81,6) 5701 (A,79,172) 5703 (A,78,176) CKSRYB102K50 CKSRYB102K50 CKSRYB102K50 CCSRCH101J50 CCSRCH101J50 C C C C C 5707 (A,75,185) 5708 (A,72,182) ELECT. CAPACITOR 5712 (A,74,161) 5713 (A,74,174) 5714 (A,70,161) CKSRYB102K50 CEAT470M35 CCSRCH270J50 CKSRYB472K50 CCSRCH270J50 C C C C 5715 (A,70,163) 5716 (A,68,174) 5719 (A,81,168) 5720 (A,63,161) ELECT. CAPACITOR CKSRYB103K50 CCSRCH561J50 CEAT100M50 CEAT470M35 MISCELLANEOUS IC IC > IC > IC > IC IC IC Q Q Q PCB BINDER RESISTORS C DAMP ASSY F Description C C C C C C D 4 R R R R R 3101 (A,14,95) 3102 (A,14,92) 3103 (A,12,58) 3104 (A,13,78) 3106 (A,19,73) RS1/16S221J RS1/16S221J RS1/16S4R7J RAB4C221J RS1/16S105J R R R R R 3107 (A,22,72) 3108 (A,26,72) 3111 (A,28,94) 3112 (A,18,97) 3113 (A,15,96) RAB4C470J RAB4C470J RS1/16S220J RS1/16S470J RS1/16S3R3J R R R R R 3114 (A,28,54) 3131 (A,41,140) 3132 (A,39,136) 3133 (A,39,133) 3134 (A,41,133) RS1/16S103J RS1/16S473J RS1/10S123J RS1/16S102J RS1/16S222J R R R R R 3141 (A,100,36) 3142 (A,101,30) 3151 (A,28,17) 3152 (A,36,17) 3182 (A,16,57) RS1/16S331J RS1/16S331J RAB4C103J RAB4C222J RS1/16S0R0J R R R R R 3191 (A,108,137) RESISTOR (0.1 ohm, 2 W) 3192 (A,101,135) 3193 (A,92,140) 3194 (A,97,133) 3195 (A,92,141) ACN7112 RS1/16S103J RS1/16S103J RS1/16S104J RS1/16S104J 3101 (A,22,84) 8CH PWM PROCESSOR IC 3191 (A,99,139) OP-AMP IC 3201 (A,46,54) DIGITAL AMP IC 3301 (A,46,84) DIGITAL AMP IC 3401 (A,46,114) DIGITAL AMP IC TAS5508BPAG BA10358F TAS5122DCA TAS5122DCA TAS5122DCA R R >R R R 3196 (A,93,133) 3197 (A,90,132) 3199 (A,94,135) 3204 (A,33,51) 3205 (A,34,56) RS1/16S222J RS1/16S103J RS1/16S8R2J RS1/16S221J RS1/16S103J 3601 (A,97,15) DUAL OP-AMP 3901 (A,11,27) DUAL OP-AMP 3131 (A,37,140) TRANSISTOR 3132 (A,36,132) DIGITAL TR (SC-70) 3601 (A,97,25) TRANSISTOR NJM4565MD NJM4565MD 2SA1036K RT1N431M IMX9 R R R >R >R 3206 (A,36,60) 3207 (A,35,60) 3208 (A,38,60) 3211 (A,60,46) RESISTOR (2.7 ohm) 3212 (A,60,60) RESISTOR (2.7 ohm) RS1/16S101J RS1/16S473J RS1/16S472J ACN7148 ACN7148 98 XV-DV363 1 2 3 4 5 Mark No. 6 Description > R 3213 (A,60,48) RESISTOR (2.7 ohm) > R 3214 (A,60,62) RESISTOR (2.7 ohm) Part No. 7 Mark No. 8 Description R 3215 (A,64,43) CHIP RESISTOR R 3216 (A,64,57) CHIP RESISTOR R 3217 (A,64,52) CHIP RESISTOR R R R R R RS1/8S1R5J RS1/10S821J RS1/10S821J RS1/10S821J RS1/10S821J R R R R R R 3231 (A,100,71) R 3232 (A,103,71) R 3233 (A,96,70) RS1/10S3R3J RS1/10S3R3J RS1/10S472J RS1/10S472J RS1/10S472J R R >R >R R 3425 (A,39,101) 3426 (A,39,128) 3427 (A,86,101) 3428 (A,86,117) 3431 (A,100,122) RS1/10S821J RS1/10S821J RS1/10S3R3J RS1/10S3R3J RS1/10S472J R 3234 (A,111,71) 3235 (A,99,69) 3236 (A,99,64) 3237 (A,96,69) 3238 (A,108,70) RS1/10S472J RS1/16S1R0J RS1/16S1R0J RS1/16S1R0J RS1/16S1R0J R R R >R >R 3432 (A,107,122) 3433 (A,104,122) 3434 (A,110,122) 3435 (A,101,124) 3436 (A,107,124) RS1/10S472J RS1/10S472J RS1/10S472J RS1/16S1R0J RS1/16S1R0J RS1/10S180J RS1/10S180J RS1/10S180J RS1/10S180J RS1/16S221J >R >R >R >R >R 3437 (A,104,124) 3438 (A,110,124) 3441 (A,58,105) 3442 (A,58,119) 3443 (A,58,109) RS1/16S1R0J RS1/16S1R0J RS1/10S180J RS1/10S180J RS1/10S180J RS1/16S103J RS1/16S101J RS1/16S473J RS1/16S472J ACN7148 > R 3444 (A,58,123) 3218 (A,64,66) CHIP RESISTOR 3223 (A,39,43) 3224 (A,39,66) 3225 (A,39,41) 3226 (A,39,68) > R 3227 (A,86,35) > R 3228 (A,86,51) >R >R >R >R >R >R >R >R 3241 (A,58,45) 3242 (A,58,59) 3243 (A,58,49) 3244 (A,58,63) R 3304 (A,33,80) >R >R >R >R Part No. ACN7148 ACN7148 RS1/8S1R5J RS1/8S1R5J RS1/8S1R5J 3411 (A,60,106) RESISTOR (2.7 ohm) 3412 (A,60,120) RESISTOR (2.7 ohm) 3413 (A,60,108) RESISTOR (2.7 ohm) 3414 (A,60,122) RESISTOR (2.7 ohm) R 3415 (A,64,103) CHIP RESISTOR ACN7148 ACN7148 ACN7148 ACN7148 RS1/8S1R5J 3416 (A,64,117) CHIP RESISTOR 3417 (A,64,112) CHIP RESISTOR 3418 (A,64,126) CHIP RESISTOR 3423 (A,39,103) 3424 (A,39,126) RS1/8S1R5J RS1/8S1R5J RS1/8S1R5J RS1/10S821J RS1/10S821J A B C R R R R 3601 (A,87,9) 3605 (A,87,17) 3606 (A,107,17) 3607 (A,90,13) RS1/10S180J RAB4C472J RS1/16S472J RS1/16S472J RS1/16S472J R 3315 (A,64,73) CHIP RESISTOR R 3316 (A,64,87) CHIP RESISTOR ACN7148 ACN7148 ACN7148 RS1/8S1R5J RS1/8S1R5J R R R R R 3608 (A,104,13) 3609 (A,91,18) 3610 (A,103,18) 3611 (A,90,14) 3612 (A,104,14) RS1/16S472J RS1/16S103J RS1/16S103J RS1/16S103J RS1/16S103J R R R R R RS1/8S1R5J RS1/8S1R5J RS1/10S821J RS1/10S821J RS1/10S821J R R R R R 3613 (A,92,21) 3614 (A,102,21) 3615 (A,92,22) 3616 (A,102,22) 3617 (A,95,22) RS1/16S473J RS1/16S473J RS1/16S102J RS1/16S102J RS1/16S472J RS1/10S821J RS1/10S3R3J RS1/10S3R3J RS1/10S472J RS1/10S472J R R R >R R 3618 (A,99,22) 3619 (A,94,35) 3620 (A,97,35) 3621 (A,92,6) 3623 (A,92,8) RS1/16S472J RS1/16S221J RS1/16S221J RS1/16S8R2J RS1/16S222J R R R R >R 3305 (A,34,86) 3306 (A,36,90) 3307 (A,35,90) 3308 (A,38,90) 3311 (A,60,76) RESISTOR (2.7 ohm) > R 3312 (A,60,90) RESISTOR (2.7 ohm) > R 3313 (A,60,78) RESISTOR (2.7 ohm) > R 3314 (A,60,92) RESISTOR (2.7 ohm) 3317 (A,64,82) CHIP RESISTOR 3318 (A,64,96) CHIP RESISTOR 3323 (A,39,73) 3324 (A,39,96) 3325 (A,39,71) R 3326 (A,39,98) > R 3327 (A,86,68) > R 3328 (A,86,84) R 3331 (A,94,98) R 3332 (A,94,84) R R >R >R >R 3333 (A,94,94) 3334 (A,94,108) 3335 (A,94,101) 3336 (A,94,81) 3337 (A,94,91) RS1/10S472J RS1/10S472J RS1/16S1R0J RS1/16S1R0J RS1/16S1R0J R R R R R 3629 (A,92,24) 3630 (A,102,24) 3631 (A,94,29) 3632 (A,97,29) 3901 (A,11,39) RS1/16S821J RS1/16S821J RS1/16S472J RS1/16S472J RAB4C472J >R >R >R >R >R 3338 (A,94,111) 3341 (A,58,75) 3342 (A,58,89) 3343 (A,58,79) 3344 (A,58,93) RS1/16S1R0J RS1/10S180J RS1/10S180J RS1/10S180J RS1/10S180J R R R R R 3905 (A,17,35) 3906 (A,6,35) 3907 (A,15,35) 3908 (A,7,35) 3909 (A,16,32) RS1/16S562J RS1/16S562J RS1/16S562J RS1/16S562J RS1/16S183J R R R R R 3404 (A,33,110) 3405 (A,34,116) 3406 (A,36,120) 3407 (A,35,120) 3408 (A,38,120) RS1/16S221J RS1/16S103J RS1/16S101J RS1/16S473J RS1/16S472J R R R R R 3910 (A,6,32) 3911 (A,13,32) 3912 (A,9,32) 3913 (A,11,43) 3914 (A,7,42) RS1/16S183J RS1/16S183J RS1/16S183J RS1/16S472J RS1/16S472J 6 E F 99 XV-DV363 5 D 7 8 1 Mark No. A R R >R R R 2 Description 3915 (A,12,41) 3916 (A,8,43) 3921 (A,12,24) 3923 (A,12,22) 3924 (A,15,22) R 5982 3 Part No. Mark No. C D E F Description Part No. RS1/16S472J RS1/16S472J RS1/16S8R2J RS1/16S103J RS1/16S103J C C C C C 3238 (A,99,63) 3239 (A,96,66) 3240 (A,106,70) 3241 (A,56,44) 3242 (A,56,58) CKSRYB103K50 CKSRYB103K50 CKSRYB103K50 CKSRYB331K50 CKSRYB331K50 RS1/16S0R0J C C C C C 3243 (A,56,50) 3244 (A,56,64) 3301 (A,40,75) 3302 (A,40,93) 3303 (A,35,84) CKSRYB331K50 CKSRYB331K50 CKSQYB105K16 CKSQYB105K16 CKSRYB104K16 C C C C C 3304 (A,39,90) 3311 (A,59,72) 3312 (A,59,86) 3313 (A,59,82) 3314 (A,59,96) CKSRYB104K16 CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 C C C C C 3315 (A,65,76) 3316 (A,65,90) 3317 (A,65,78) 3318 (A,65,92) 3321 (A,91,59) ELECT. CAPACITOR CKSRYB333K50 CKSRYB333K50 CKSRYB333K50 CKSRYB333K50 CEAT102M25 C C C C C 3323 (A,86,70) 3324 (A,86,87) 3325 (A,86,81) 3326 (A,86,98) 3327 (A,49,75) CKSRYB103K50 CKSRYB103K50 CKSRYB102K50 CKSRYB102K50 CKSRYB104K25 C C C C C 3328 (A,49,94) 3331 (A,85,78) 3332 (A,85,95) 3333 (A,102,99) 3334 (A,107,92) CKSRYB104K25 CFTLA474J50 CFTLA474J50 CKSRYB104K25 CKSRYB104K25 C C C C C 3335 (A,102,96) 3336 (A,107,95) 3337 (A,94,104) 3338 (A,94,78) 3339 (A,94,88) CKSRYB104K25 CKSRYB104K25 CKSRYB103K50 CKSRYB103K50 CKSRYB103K50 C C C C C 3340 (A,94,114) 3341 (A,56,74) 3342 (A,56,88) 3343 (A,56,80) 3344 (A,56,94) CKSRYB103K50 CKSRYB331K50 CKSRYB331K50 CKSRYB331K50 CKSRYB331K50 C C C C C 3401 (A,40,105) 3402 (A,40,123) 3403 (A,35,114) 3404 (A,39,120) 3411 (A,59,102) CKSQYB105K16 CKSQYB105K16 CKSRYB104K16 CKSRYB104K16 CKSQYB104K50 C C C C C 3412 (A,59,116) 3413 (A,59,112) 3414 (A,59,126) 3415 (A,65,106) 3416 (A,65,120) CKSQYB104K50 CKSQYB104K50 CKSQYB104K50 CKSRYB333K50 CKSRYB333K50 C C C C C 3417 (A,65,108) 3418 (A,65,122) 3421 (A,91,125) ELECT. CAPACITOR 3423 (A,86,103) 3424 (A,86,120) CKSRYB333K50 CKSRYB333K50 CEAT102M25 CKSRYB103K50 CKSRYB103K50 C C C C C 3425 (A,86,114) 3426 (A,86,131) 3427 (A,49,105) 3428 (A,49,124) 3431 (A,85,111) CKSRYB102K50 CKSRYB102K50 CKSRYB104K25 CKSRYB104K25 CFTLA474J50 CAPACITORS B 4 C C C C C 3101 (A,16,92) 3102 (A,14,93) 3103 (A,11,94) 3104 (A,11,91) 3105 (A,14,90) CKSRYB224K16 CKSRYB103K50 CKSRYB104K16 CKSRYB104K16 CKSRYB103K50 C C C C C 3106 (A,12,87) 3107 (A,12,86) 3108 (A,12,72) 3109 (A,12,84) 3110 (A,16,77) CKSRYB104K16 CKSRYB104K16 CEVW100M10 CKSRYB102K50 CKSRYB104K16 C C C C C 3111 (A,12,64) 3112 (A,17,76) 3113 (A,17,74) 3114 (A,17,73) 3115 (A,28,76) CEVW100M10 CKSRYB104K16 CCSRCH180J50 CCSRCH150J50 CKSRYB474K10 C C C C C 3116 (A,28,75) 3117 (A,26,66) 3118 (A,30,90) 3119 (A,25,94) 3120 (A,26,97) CKSRYB104K16 CEVW100M10 CKSRYB104K16 CKSRYB104K16 CEVW100M10 C C C C C 3141 (A,101,36) 3142 (A,101,33) 3151 (A,18,20) 3192 (A,98,135) 3201 (A,40,45) CCSRCH221J50 CCSRCH221J50 CKSRYB104K16 CKSRYB104K25 CKSQYB105K16 C C C C C 3202 (A,40,63) 3203 (A,35,54) 3204 (A,39,60) 3211 (A,59,42) 3212 (A,59,56) CKSQYB105K16 CKSRYB104K16 CKSRYB104K16 CKSQYB104K50 CKSQYB104K50 C C C C C 3213 (A,59,52) 3214 (A,59,66) 3215 (A,65,46) 3216 (A,65,60) 3217 (A,65,48) CKSQYB104K50 CKSQYB104K50 CKSRYB333K50 CKSRYB333K50 CKSRYB333K50 C C C C C 3218 (A,65,62) 3221 (A,91,43) ELECT. CAPACITOR 3223 (A,86,37) 3224 (A,86,54) 3225 (A,86,48) CKSRYB333K50 CEAT102M25 CKSRYB103K50 CKSRYB103K50 CKSRYB102K50 C C C C C 3226 (A,86,65) 3227 (A,49,45) 3228 (A,49,64) 3231 (A,85,45) 3232 (A,85,62) CKSRYB102K50 CKSRYB104K25 CKSRYB104K25 CFTLA474J50 CFTLA474J50 C C C C C 3233 (A,102,83) 3234 (A,108,81) 3235 (A,102,81) 3236 (A,108,78) 3237 (A,99,66) CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB103K50 100 XV-DV363 1 2 3 4 5 Mark No. Description 6 7 Part No. Mark No. RESISTORS C C C C C 3432 (A,85,128) 3433 (A,102,113) 3434 (A,107,107) 3435 (A,102,111) 3436 (A,107,110) CFTLA474J50 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 CKSRYB104K25 C C C C C 3437 (A,101,126) 3438 (A,107,126) 3439 (A,104,126) 3440 (A,110,126) 3441 (A,56,104) CKSRYB103K50 CKSRYB103K50 CKSRYB103K50 CKSRYB103K50 CKSRYB331K50 C C C C C 3442 (A,56,118) 3443 (A,56,110) 3444 (A,56,124) 3601 (A,87,16) 3602 (A,107,16) CKSRYB331K50 CKSRYB331K50 CKSRYB331K50 CCSRCH821J50 CCSRCH821J50 C C C C C 3603 (A,87,13) 3604 (A,107,13) 3605 (A,89,18) 3606 (A,105,18) 3607 (A,87,14) CCSRCH821J50 CCSRCH821J50 CCSRCH331J50 CCSRCH331J50 CCSRCH331J50 C C C C C 3608 (A,107,14) 3609 (A,87,22) 3610 (A,108,22) 3611 (A,92,25) 3612 (A,102,25) CCSRCH331J50 CEVW100M16 CEVW100M16 CCSRCH821J50 CCSRCH821J50 C C C C C 3621 (A,105,9) 3622 (A,97,8) 3623 (A,99,11) 3624 (A,96,11) 3901 (A,13,35) CEVW100M25 CEVW100M16 CKSRYB104K25 CKSRYB104K16 CCSRCH681J50 C C C C C 3902 (A,9,35) 3903 (A,13,36) 3904 (A,9,36) 3905 (A,16,33) 3906 (A,6,33) CCSRCH681J50 CCSRCH681J50 CCSRCH681J50 CCSRCH181J50 CCSRCH181J50 C C C C C 3907 (A,13,33) 3908 (A,9,33) 3921 (A,8,18) 3922 (A,14,18) 3923 (A,9,24) CCSRCH561J50 CCSRCH561J50 CEVW100M25 CEVW100M16 CKSRYB104K25 C 3924 (A,15,24) CKSRYB104K16 8 Description Part No. R R R R R 5901 (B,161,35) 5902 (B,157,35) 5903 (B,159,35) 5904 (B,152,36) 5951 (B,173,47) RS1/16S221J RS1/16S221J RS1/16S221J RS1/16S823J RS1/16S470J R R R R R 5954 (B,183,42) 5962 (B,80,32) 5963 (B,82,32) 5964 (B,118,30) 5965 (B,120,30) RS1/16S101J RS1/16S102J RS1/16S122J RS1/16S152J RS1/16S182J R 5966 (B,170,28) RS1/16S102J A CAPACITORS C C C C C 5907 (A,67,59) ELECT. CAPACITOR 5911 (B,165,40) 5912 (B,159,41) 5913 (A,162,42) 5915 (B,135,32) CEJQ470M35 CKSRYB223K50 CKSRYB223K50 CEAL470M6R3 CKSRYB103K50 C C C C C 5916 (B,114,47) 5917 (B,127,44) 5918 (A,123,42) ELECTR. CAPACITOR 5920 (B,155,35) 5921 (B,153,31) CKSRYB223K50 CKSRYB223K50 CEAL470M35 CCSRCH221J50 CCSRCH221J50 C 5922 (B,155,31) C 5951 (B,183,49) C 5952 (A,172,50) B CCSRCH221J50 CKSRYB223K50 CEAL470M6R3 C E USB ASSY MISCELLANEOUS Q Q Q D L 5971 (B,48,53) 5973 (B,44,45) 5974 (B,45,36) 601 (B,28,27) 5971 (B,50,32) DIGITAL TR (SC-70) TRANSISTOR TRANSISTOR ZENER DIODE INDUCTOR L JA JA CN CN 5972 (B,41,32) INDUCTOR 602 (A,19,7) USB CONNECTOR 5901 (A,49,9) JACK 5906 (A,46,60) CONNECTOR 5907 (A,23,60) CONNECTOR RT1P241M IMX9 IMX9 UMZU6.2N CTF1306 D CTF1306 XKP3086 AKN7003 CKS3380 CKS3370 RESISTORS D DISPLAY ASSY MISCELLANEOUS IC IC >L L V 5901 (B,141,42) FL DRIVER IC 5902 (A,179,44) REMOTE RECEIVER UNIT 5901 (A,168,42) AXIAL INDUCTOR 5902 (A,117,50) AXIAL INDUCTOR 5901 (A,168,55) FL TUBE PT6315 GP1UM27XK0VF LAU220J LAU100J AAV7104 5962 (A,75,30) SWITCH 5963 (A,93,30) SWITCH 5964 (A,106,30) SWITCH 5965 (A,124,30) SWITCH 5966 (A,147,30) SWITCH VSG1024 VSG1024 VSG1024 VSG1024 VSG1024 S 5967 (A,165,30) SWITCH CN 5901 (A,112,65) CONNECTOR 5971 FL SPACER VSG1024 CKS3378 AEB7367 S S S S S R R R R R 5971 (B,49,45) 5972 (B,39,45) 5973 (B,52,45) 5974 (B,41,45) 5975 (B,54,44) RS1/10S680J RS1/10S680J RS1/10S680J RS1/10S680J RS1/16S222J R R R R R 5976 (B,37,41) 5977 (B,54,40) 5978 (B,37,37) 5979 (B,49,40) 5980 (B,39,40) RS1/16S222J RS1/16S222J RS1/16S222J RS1/10S680J RS1/10S680J R R R R R 5981 (B,52,40) 5982 (B,41,40) 5983 (B,52,36) 5984 (B,39,36) 5985 (B,50,36) RS1/10S680J RS1/10S680J RS1/16S680J RS1/16S680J RS1/16S680J R 5986 (B,41,36) R 5990 (B,39,32) RS1/16S680J RS1/16S680J 6 F 101 XV-DV363 5 E 7 8 1 2 Mark No. Description CAPACITORS A B 3 Part No. C C C C C 601 (B,31,50) 602 (A,30,46) 604 (B,29,23) 605 (B,29,19) 5971 (B,47,40) CKSRYB104K50 CEAT221M6R3 CKSRYB104K50 CKSRYB104K50 CKSRYB102K50 C C C C 5972 (B,43,40) 5973 (B,48,30) 5974 (B,43,30) 5977 (B,54,24) CKSRYB102K50 CKSRYB473K25 CKSRYB473K25 CKSRYB103K50 Mark No. R R R R MISCELLANEOUS 5611 (B,100,19) TRANSISTOR 5611 (A,98,15) LED (BLUE) 5612 (B,95,20) DIODE 5603 (A,121,20) CONNECTOR 2SC4081 NSPB320BS-6734 DAN217 CKS3368 C 5611 (B,112,20) 5612 (B,110,20) 5613 (B,106,15) 5614 (B,105,20) CAPACITORS CKSRYB104K50 G KEY ASSY MISCELLANEOUS S S S S CN D 5991 (A,205,29) 5992 (A,204,55) 5993 (A,204,68) 5994 (A,204,91) 5908 (A,213,36) SWITCH SWITCH SWITCH SWITCH CONNECTOR VSG1024 VSG1024 VSG1024 VSG1024 CKS3370 CN 5909 (A,213,92) CONNECTOR CKS3368 RS1/16S272J RS1/16S332J RS1/16S562J H MIC ASSY E MISCELLANEOUS IC JA JA VR CN 3921 (B,54,40) 3921 (A,48,15) 3922 (A,29,16) 3921 (A,68,27) 3921 (A,67,68) DUAL OP-AMP JACK JACK VARIABLE (10K-X1) CONNECTOR NJM4565MD AKN7003 RKN1004 ACS7042 CKS3370 RESISTORS R R R R R 3921 (B,45,35) 3922 (B,45,31) 3925 (B,56,32) 3926 (B,50,35) 3927 (B,50,48) C C C C C 3921 (B,47,31) 3922 (B,34,23) 3925 (A,43,45) 3928 (B,58,32) 3929 (A,71,36) CCSRCH101J50 CCSRCH101J50 CEJQ2R2M50 CCSRCH681J50 CEAT2R2M50 C C C C C 3930 (A,64,39) 3931 (A,63,52) 3932 (B,56,52) 3933 (B,54,52) 3935 (A,42,50) CEAT2R2M50 CEAT470M16 CKSRYB104K16 CCSRCH101J50 CEJQ2R2M50 C 3936 (B,56,48) C 3938 (B,67,46) CKSRYB122K50 CKSRYB104K16 IC IC Q Q Q 471 472 461 462 463 (B,38,46) (B,29,48) (B,68,68) (B,47,65) (B,52,70) VIDEO SW IC VIDEO SW IC CHIP TRANSISTOR CHIP TRANSISTOR DIGITAL TR (SC-70) MM1505XN MM1507XN RT3WLMM RT3WLMM RT1P441M Q Q Q D D 472 492 493 471 472 (B,25,67) (B,80,40) (B,74,45) (B,49,41) (B,43,41) TRANSISTOR DIGITAL TR (SC-70) TRANSISTOR DIODE DIODE RT1N241M RT1P241M IMX9 MC2846-11 MC2848-11 D D JA CN 473 474 451 461 (B,32,41) DIODE (B,38,41) DIODE (A,62,8) CONNECTOR (A,89,31) CONNECTOR MC2846-11 MC2848-11 XKB3054 CKS3388 RESISTORS RESISTORS R 5991 (B,202,60) R 5992 (B,202,64) R 5993 (B,202,79) RS1/16S332J RS1/16S332J RS1/16S152J RS1/16S123J MISCELLANEOUS RS1/16S471J RS1/16S471J RS1/16S472J RS1/16S151J C 5611 (B,92,15) Part No. I EUROSCART ASSY RESISTORS R R R R Description 3928 (B,59,48) 3929 (B,58,52) 3930 (B,47,48) 3931 (B,54,48) CAPACITORS F LED ASSY Q D D CN 4 RS1/16S332J RS1/16S332J RS1/16S473J RS1/16S103J RS1/16S473J R R R R R 461 462 463 464 465 (B,62,69) (B,62,67) (B,73,65) (B,52,65) (B,73,67) RS1/16S223J RS1/16S122J RS1/16S472J RS1/16S472J RS1/16S563J R R R R R 466 467 468 469 470 (B,30,66) (B,41,69) (B,41,71) (B,41,67) (B,46,72) RS1/16S103J RS1/16S122J RS1/16S122J RS1/16S102J RS1/16S821J R R R R R 471 472 473 474 475 (B,46,70) (B,30,64) (B,52,73) (B,58,28) CHIP RESISTOR (B,53,28) CHIP RESISTOR RS1/16S561J RS1/16S223J RS1/16S563J RS1/16S75R0F RS1/16S75R0F R R R R R 476 477 478 481 482 (B,47,28) CHIP RESISTOR (B,27,27) CHIP RESISTOR (B,40,28) CHIP RESISTOR (B,71,37) (B,71,35) RS1/16S75R0F RS1/16S75R0F RS1/16S75R0F RS1/16S102J RS1/16S102J 3 4 F 102 XV-DV363 1 2 5 Mark No. R R R R R 483 484 485 486 493 6 Description 7 8 Part No. (B,59,38) (B,63,38) (B,59,36) (B,63,36) (B,76,42) RS1/16S473J RS1/16S473J RS1/16S471J RS1/16S471J RS1/16S472J R 494 (B,76,40) R 495 (B,89,23) R 496 (B,85,23) RS1/16S472J RS1/16S331J RS1/16S331J A CAPACITORS C C C C C 464 470 471 472 473 (B,66,65) (B,41,73) (A,35,57) (B,39,52) (B,24,57) CKSRYB104K50 CKSRYB104K50 CEAT100M50 CKSRYB104K50 CKSRYB104K50 C C C C C 474 475 476 477 478 (B,24,61) (B,43,44) (B,29,45) (A,52,37) ELECT. CAPACITOR (A,45,37) ELECT. CAPACITOR CKSRYB104K50 CKSRYB104K50 CKSRYB104K50 CEAT471M6R3 CEAT471M6R3 C C C C C 479 480 481 482 483 (A,38,37) ELECT. CAPACITOR (A,30,37) ELECT. CAPACITOR (A,65,49) (A,65,42) (B,59,34) CEAT471M6R3 CEAT102M6R3 CEAT100M50 CEAT100M50 CCSRCH331J50 C C C C C 484 485 486 487 488 (B,63,34) (B,89,21) (B,85,21) (B,58,26) (B,23,25) CCSRCH331J50 CCSRCH101J50 CCSRCH101J50 CCSRCH470J50 CKSRYB104K50 C C C C 489 490 491 492 (B,53,26) (B,47,26) (B,27,25) (B,40,26) CCSRCH470J50 CCSRCH470J50 CCSRCH470J50 CCSRCH470J50 B C J POWER SUPPLY UNIT D POWER SUPPLY UNIT has no service parts. K FM/AM TUNER UNIT FM/AM TUNER UNIT has no service parts. E F 103 XV-DV363 5 6 7 8
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.5 Linearized : Yes Page Count : 103 Page Mode : UseOutlines Page Layout : TwoColumnRight Has XFA : No XMP Toolkit : XMP toolkit 2.9.1-14, framework 1.6 About : uuid:012f95b8-4f2e-4641-8834-abfc88c7616d Producer : Acrobat Distiller 7.0 (Windows) Create Date : 2006:03:14 17:03:33Z Creator Tool : FrameMaker 7.2 Modify Date : 2007:04:10 10:13:53+09:00 Metadata Date : 2007:04:10 10:13:53+09:00 Document ID : uuid:d6bf1ff4-bcd0-4746-bb65-37fbbed3d692 Instance ID : uuid:02f9b8b4-ac0a-4cfb-8a3e-e48d23123cc8 Format : application/pdf Creator : PMC Title : RRV3568 Description : Linked Author : PMC Subject : LinkedEXIF Metadata provided by EXIF.tools