N91 Schematics Nokia E61 Rm 89 Service
User Manual: Smartphone Nokia E61 RM-89 - Service manuals and Schematics, Disassembly / Assembly. Free.
Open the PDF directly: View PDF 
.
Page Count: 4
| Download | |
| Open PDF In Browser | View PDF |
Service Schematics Introduction Exploded view and component disposal RM-89 IMPORTANT: This document is intended for use by authorized NOKIA service centers only. “Service Schematics” was created with focus on customer care. The purpose of this document is to provide further technical repair information for NOKIA mobile phones on Level 3/4 service activities. The “Signal overview” page gives a good and fast overview about the most important signals and voltages on board. Saving process time and improving the repair quality is the aim of this document. It is to be used additionally to the service manual and other training or service information such as Service Bulletins. All measurements were made using following equipment: Nokia repair SW Oscilloscope Spectrum Analyzer RF-Generator / GSM Tester Multimeter : : : : : Phoenix version 2006.04.6.130 Fluke PM 3380A/B Advantest R3162 with an analog probe Rhode & Schwarz CMU 200 Fluke 73 Series II While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If the reader finds any errors, NOKIA shall be notified in writing. Please send E-Mail to: training.sace@nokia.com Copyright © NOKIA This material, including documentation and any related computer programs is protected by copyright, controlled by NOKIA. All rights are reserved. Copying, including reproducing, modifying, storing, adapting or translating any or all of this material requires the prior written consent of NOKIA. This material also contains companyconfidential information, which may not be disclosed to others without the prior written consent of NOKIA. Customer Care / Training & Vendor Development / Content Creation Team Confidential - Copyright © 2006 NOKIA Only for training and service purposes Table of Content Page Front page Schematics Signal overview Component finder 1 2 3 4 Version: 1.0 10.04.2006 E61 / RM-89 Board version: 1NF_11 Front page Page 1 (4) GND GND GND 8 4 3 7 2 27p GND GND L4400 600R/100MHz VDDL C4402 C4400 C4420 27p 1u0 27p GND GND GND LEDOUT R4407 18R 4 1k0 - 33R 2= GND 5= VAUX MIC2P MIC2N XEARL XEARLC XEARR XEARRC A1 A2 A3 A4 A5 B1 B2 B3 B4 B5 C1 C2 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 IN10 A1 GND GND 5 3 1 19 18 7 21 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 IN10 E1 E2 E3 E4 E5 D1 D2 D3 D4 D5 C3 C4 C5 2 4 6 16 20 0 17 C1 C2 GND GND 3.7V VBAT R4411 3 GND GND 5 2 6 C4404 68p GND GND Indicator LED GND V+ L+ VOUT LNC C4414 0.47MH L4402 J4420 8 200Vpp 1u0 kbc_2 kbc_0 kbr_0 9 kbc_1 Xear_l_n EMIF10 R4508 0R R4509 Customer Care / Training & Vendor Development / Content Creation Team Confidential - Copyright © 2006 NOKIA Only for training and service purposes R4506 0R 0R R4507 0R Voice Vol Down Vol Up AGND L2003 EXC24CB102U 4 1 Xear_r_p 3 2 Xear_r_n Z2003 600R/100MHz GND R2007 IP4065CX11_LF 17k J2002 SLAVEPU DPRXD DMTXD MASTPD2 MASTPD1 ACI Power switch 1k3 D+ 33R D- 33R J2003 R4406 15k GND GND GND 3 MIC1P V4402 GND RD100S RD100S 2.5V Microphone Z2100 0 VANA B2100 OUT GND 0 HFSPP 1 HFSPN 6 5 4 3 2 1 5 6 Earpiece L= W=0.10 1 EARP 1 EARN 2 L2100 EXC24CB102U GND C2104 1n0 IHF C2071 150u_10V Battery connector C R4403 47k GND GND GND E L2103 56nH C2105 1n0 C2106 C2107 C2101 C2102 1n0 1n0 68p 68p GND ALS V4400 PT202MR0MP SIM connector X2700 SM SIM CONN 2X3POL P2.54 H4.6 1 2 3 1 X2101 GND GND 1 0 2 1 J2070 VBATT BSI J2071 GND J2072 GND BGND GND GND X2100 L2102 56nH GND GND C2700 C1 C2 C3 C5 C6 C7 5 6 7 100n GND E61 / RM-89 -t GND B2101 4 2 47k R2071 3 GND 10.04.2006 S4401 GND L2205 GND Version: 1.0 600R/100MHz L5200 GND SIMIF(6:0) 4 X4501 10 8 0 2 VSIM1 GND Side key connector C4415 3 GND 220R/100MHz C2103 1n0 7 Xear_l_p SLOWAD(6:0) VBAT R4404 0R 10 9 8 7 6 C4406 1u0 V4401 GND 1k0 C1 C2 CHF CLF E NC GND J4421 R4413 V4406 2SC5658QRS GND 1 J2001 GND Z2000 Z2001 10R R2001 L2002 EXC24CB102U 4 A2 C2 D2 600R/100MHz X2070 3.7V GND EL Lamp 1n0 GND C4405 15n 1 GND 1 2 3 4 5 V4405 CL-191WB-D-T IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 IN10 4 0 3 2 1 7 6 5 600R/100MHz D3 R 4 1 0 6 5 7 R2000 10R 1 2 3 4 5 6 7 8 9 10 11 12 13 14 Charge Charge gnd ACI VOUT Vbus D+ DData gnd Xmicn Xmicp Xear_l_n Xear_l_p Xear_r_n Xear_r_p VBAT N4402 1DDD381BB-NL4 82k R4412 680R Z4502 EMIF10-COM01F2 Pop port PWRONX EL lamp & driver N4404 PEMD9 4 GND 1 2 VBATH VBAT OUT1 OUT2 OUT3 OUT4 OUT5 OUT6 OUT7 OUT8 OUT9 OUT10 GND GND GND C3 R USB_ACI(7:0) QWERTY- KEYBOARD 3.7V Right Up Common Left Down Enter 2 Xmicn GND OUT1 OUT2 OUT3 OUT4 OUT5 OUT6 OUT7 OUT8 OUT9 OUT10 GND GND GND GND A1 A2 A3 A4 A5 B1 B2 B3 B4 B5 1 Xmicp 3 B3 R Z4403 EMIF10-COM01F2 A1 A2 A3 A4 A5 B1 B2 B3 B4 B5 F2000 GND GND GND 220R/100MHz C2006 10n C G2200 2A VOUT VBUS C VBACK X2000 L2000 X2001 L2001 EXC24CB102U 4 C B1 LED DRIVER Charger plug GND R D1 E1 E2 E3 E4 E5 D1 D2 D3 D4 D5 C3 C4 C5 GND R2015 ESDA18-1F2 C2001 470n A3 MESSI_VIDEO(25:0) OUT1 OUT2 OUT3 OUT4 OUT5 OUT6 OUT7 OUT8 OUT9 OUT10 GND GND GND GND 1 2 3 4 5 6 7 8 1k2 C2005 10n C1 Z4402 EMIF10-COM01F2 GND RDX D/CX D1 D3 GND D5 D7 TE RESX CSX D6 D4 D2 GND D0 WRX GND 3 X4500 C2000 27p M2100 KHN4NX1RA J2060 1 KEYB(19:0) GND E1 E2 E3 E4 E5 D1 D2 D3 D4 D5 C3 C4 C5 1n0 Flash interface 1 3 0 JOYSTICK(7:0) 1 Joystick connector VBUS J2063 GND R2006 IP5040CX11_LF AUDIO(8:0) + R4410 C2110 1n0 C GND GND GND GND N4403 LMV321M7X_NOPB C2109 - M 470k 1u0 6 IR(7:0) SETCURR1 + C2108 1n0 R2010 C4421 VIBRAN FLASHM J2062 J2061 VILMA OMAP1710 GND 3M3 C4401 1.8V R4409 2 3 4 5 6 7 XAUDIO(7:0) 100n VLEDOUT1 VLEDOUT2 3 GND GND R4408 L4401 600R/100MHz GND V4403 2SC5658QRS SDRAM FLASH R4414 100k 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 VIBRAP 220R/100MHz BETTY BT C4412 1n0 2 220R/100MHz GND 2 3 GND Vibra L2106 VPP NAND/DDR X4400 LEDIN VDD VIO A3 GND NOR C5200 1u0 GND L2105 C4410 Display connector VAUX 27p RAP3GS V_SD GND 11 2.8V level COMBO 2.8V C4403 DATA1 DATA2 DATA3 GND 2.8V 14V/50V 4u7 27p VBAT VCCA VCCB C1 D1 D2 3 4 5 R2070 C4416 A1 B4 B1 B1 B2 B3 J5210 J5204 J5211 14V/50V C4409 C5203 EN2 LatchClk DATA1 DATA2 DATA3 BTEMP NTC 1 0 2 VBAT A2 C2 C4 D4 D3 470k LEDA TXD RXD SD VCC GND GND GND S4402 VIO GND 1.8V level A1 A2 A3 R4429 VAUX 100k VBAT R4423 4R7 2 2.8V 4 3 1 3.7V Battery cover detection 1.8V 3.7V Dir1 Dir2 Dir3 EN1 GND WLAN VIO B3 B2 C3 A4 1u0 GND GND 1.8V LS_ENABLE GND L6301 1n2H X7500 J5207 2 EN D2 GND C6328 1p5 WCDMA antenna clips V4404 CIM-138M7-T In C In R RF DATA_DIR1 1 2 W6300 20 X7505 IrDA 7 X6300 X7501 GSM antenna clips GND SYNC/MODE D1 PGND J5205 15 SD_LS_ENABLE X7504 4 PUSL(7:0) 19 SW D3 22u GND C7597 1p2 C3 GND 100R R2004 BT/WLAN antenna 8p2 L7591 6n8H C4200 PVIN ISEL C1 100k 12p L4200 10uH VSEL B1 R4401 GND C7595 C7593 22u GND VDD CLK CMD DATA0 DATA1 DATA2 DATA3 A2 A1 B2 B1 C1 D1 GND R4400 10n A3 B3 VIO R2002 6 C4201 N5201 LP3928TLX-1828_NOPB K Vcont1 C4202 0R R7591 1.8V GND GND GND A3 clk cmd dat0 dat1 dat2 dat3 R2 R3 R4 R5 R6 R7 1 2 3 4 5 6 7 8 9 10 11 12 13 A 5 GND GND 220k OUT1 4 IN 1u0 2.8V level Vdd/ Vmmc MMCclk MMCcmd MMCdat0 MMCdat1 MMCdat2 MMCdat3 GND GND GND R2105 14V/50V 1 100p X7507 Vcont2 SGND C5202 10n A3 A4 B4 C4 C3 D4 D3 B3 C2 D2 R2107 14V/50V GND FB A2 C5201 1u0 V_SD R2106 14V/50V OUT2 2 L4201 220R/100MHz R7590 0R A1 C5204 GND X5200 R10 R11 R12 R13 R14 2.8V R2104 14V/50V C7591 3 U//U VBAT VCCA VCCB CLK CMD DATA0 0 1 2 RXD CLK TXD 0R 12p N4200 LM3661TLX-1.40_NOPB VCOREA A1 B4 B1 C1 D1 D2 RXD2 R7593 1.05/1.35V VBAT EN2 LatchClk B1 B2 B3 J5208 J5200 J5209 R4402 3.7V C7594 N7590 UPG2155TB-E4 V_SD VIO A2 C2 CLK CMD DATA0 5.6V/15V/0.05J VBAT APE Vcore SMPS GND C4 D4 D3 R2003 3.7V 1.8V 2.8V A4 1.8V level A1 A2 A3 5.6V/15V/0.05J J5201 J5202 J5203 Dir1 Dir2 Dir3 EN1 R5202 CMD_DIR DATA_DIR0 LS_ENABLE 6 7 B3 B2 C3 Z5200 EMIF06-HMC01F2 680R 100k VIO R5201 10 N5200 LP3928TLX-1828_NOPB miniSD reader R5200 CLK_FB 1.8V Board version: 1NF_11 GND Schematics GND Page 2 (4) 1) Sleepclock at J2310 2) RFCLK at J2800/J2801 3) SYSCLK at J4819 19 20 VANA 2.5V 4) CBUSENA at J2209 5) CBUSCLK at J2206 6) CBUSDATA at J2207 VBAT 3.7V VAUX 2.8V VSIM 1.8/3V 7) CLK600 at J2305 8) VEL at C4406 9) WRX at TPs of service jig VIO 1.8V 15 10) Data0 at TPs of service jig 11) TXCCTRL at J2211 12) TXCCLK at J2210 13 6 4 5 V_SD 2.8V 1 11 12 2 21 21 17 18 3 16 14 7 13) TXCDATA at J2212 14) RFBUSENA at J7521 15) RFBUSCLK at J7520 16) RFBUSDATA at J7519 17) TXIQ at J7522/J7525 18) TXC at J7526 19) GSM TX at X7504 20) WCDMA TX at X7501 21) RXIQ at J7515/J7517 VCOREA 1.05/1.35V 8 200Vpp Customer Care / Training & Vendor Development / Content Creation Team Confidential - Copyright © 2006 NOKIA Only for training and service purposes Version: 1.0 10.04.2006 E61 / RM-89 Board version: 1NF_11 Signal overview Page 3 (4) C C2000 C2001 C2005 C2006 C2071 C2103 C2104 C2105 C2106 C2107 C2108 C2109 C2110 C2700 C4200 C4201 C4202 C4400 C4401 C4402 C4403 C4404 C4405 C4409 C4410 C4412 C4414 C4415 C4420 C4421 C5200 C5201 C5202 C5203 C5204 C7591 C7593 C7594 C7595 F F2000 G G2200 J J2001 J2002 J2003 J2060 J2061 J2062 J2063 J2070 J2071 J2072 J2206 J2207 J2209 J2210 J2211 J2212 J2305 J2310 J2800 J2801 D4 D4 F3 G3 K18 F23 F22 C17 B9 B8 B9 B9 B9 C17 C10 C10 B9 G18 F18 G17 F17 A5 A5 K1 I2 G3 A3 C23 C23 C22 I15 I16 H16 H15 H16 K22 J22 J23 J22 C3 E10 F3 F3 F3 F5 F5 F5 F5 I19 I19 H19 C12 C12 C12 C13 C13 C13 D10 D13 D13 D13 J4819 J5200 J5201 J5202 J5203 J5204 J5205 J5207 J5208 J5209 J5210 J5211 J7515 J7517 J7519 J7520 J7521 J7522 J7525 J7526 L L2000 L2001 L2002 L2003 L2100 L2101 L2102 L2103 L2104 L2105 L2106 L4200 L4201 L4400 L4401 L5200 L7541 L7591 M M2100 N N4200 N4402 N4403 N4404 N5200 N5201 N7590 R R2000 R2001 R2002 R2003 R2004 R2006 R2007 R2010 R2015 R2070 R2104 R2105 R2106 R2107 R4400 H12 J12 K12 J12 L12 K12 L12 L12 J12 J12 J12 J12 D13 D13 D12 C14 D12 D13 C13 G14 C4 G3 G2 G3 F22 C9 I21 I21 C8 B9 B9 B10 B9 G18 F18 I15 E17 J22 B7 C10 A4 I14 B3 I16 I15 J22 G3 F3 G2 F2 E4 G3 F2 F2 D4 J18 F22 F23 C17 C17 C22 R4401 R4402 R4403 R4404 R4406 R4407 R4409 R4410 R4411 R4412 R4413 R4414 R4423 R4429 R4506 R4507 R4508 R4509 R5200 R5201 R5202 R7590 R7591 R7593 S S4401 S4402 V V4400 V4401 V4402 V4403 V4404 V4405 V4406 W W6300 X X2001 X2070 X2100 X2101 X2700 X4400 X4500 X4501 X5200 X6300 X7500 X7501 X7504 X7505 X7507 Z Z2000 Z2001 Z2003 Z4402 Z4403 Z5200 B22 C22 C22 A3 L22 H13 H14 H15 B5 B22 C22 B2 K1 G3 B17 B17 B17 B16 H16 H17 I15 J23 J22 K23 Top Bottom Display connector WCDMA antenna pads GSM antenna pads Power switch IHF pads Battery connector Please note: Due to soldered shielding cans rework is not possible within red shaded areas. Also the component list on the left is reduced to reworkable parts only! Side keys connector SIM connector L22 H3 miniSD connector B22 C3 C4 I14 J2 B22 C22 J1 F1 I18 H21 H21 C15 E22 F8 B17 K15 K2 B23 C23 M23 L23 J23 Vibra F3 F3 F3 F18 G18 I17 Customer Care / Training & Vendor Development / Content Creation Team Confidential - Copyright © 2006 NOKIA Only for training and service purposes 200Vpp System connector Version: 1.0 10.04.2006 E61 / RM-89 Board version: 1NF_11 Component finder Page 4 (4)
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.6 Linearized : Yes Encryption : Standard V4.4 (128-bit) User Access : Print, Print high-res XMP Toolkit : 3.1-701 Format : application/pdf Title : N91 schematics Creator : thombeck Creator Tool : Adobe Illustrator CS2 Create Date : 2005:11:11 08:36:01+02:00 Modify Date : 2006:04:18 12:36:06+03:00 Metadata Date : 2006:04:18 12:36:06+03:00 Thumbnail Width : 256 Thumbnail Height : 200 Thumbnail Format : JPEG Thumbnail Image : (Binary data 25155 bytes, use -b option to extract) Document ID : uuid:4A3D4D228452DA118CD6890B09310E2E Instance ID : uuid:ad860025-b4ec-4014-836c-305fa3605b85 Derived From Instance ID : uuid:c74e2ed2-7011-4414-be8d-559ad060d52b Derived From Document ID : uuid:8bee11f0-9bee-4797-aa06-762fd3b6d23b Producer : Adobe PDF library 7.77 Has XFA : No Page Count : 4 Author : thombeckEXIF Metadata provided by EXIF.tools