Harman Hf60 Owner S Manual
2014-07-05
: Harman Harman-Hf60-Owner-S-Manual harman-hf60-owner-s-manual harman pdf
Open the PDF directly: View PDF 
.
Page Count: 5
| Download | |
| Open PDF In Browser | View PDF |
HF60 Service Parts Beginning Manufacturing Date: July 2009 Ending Manufacturing Date: Active Hydroflex 60 Central Heat 1-90-232000 1 2 6 5 3 60 4 59 8 58 7 57 56 55 9 19 54 10 13 11 53 12 50 52 14 49 48 51 15 47 16 20 17 46 18 19 21 22 45 31 29 30 23 44 32 33 24 34 37 25 36 35 43 28 26 41 27 Part number list on following page. 42 38 39 40 11/13 HF60 Service Parts Beginning Manufacturing Date: July 2009 Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor. ITEM Description COMMENTS Stocked at Depot PART NUMBER 1 Plumbing Support Kit - Qty. 2 req. 1-10-232044 2 Firetube Cleanout Door Assembly 1-10-232060A Firetube Lift & Clean Kit 1-00-232120 3 Draft Section Refractory Side Qty 2 req 3-40-232054 4 1/4-20 x 1-1/2" Wingscrew with Collar Pkg of 10 3-31-782124-10 5 Draft Section Weldment 1-10-232011W 6 1/2" Foam Insulation Wrap Around 3-44-232089 7 1/2" Foam Insulation 3-44-232088 8 Hopper Assembly Gasket, Hopper Lid 10 Ft Gasket, Hopper Throat Gasket, Hopper Top 20 Ft Hopper Lid Assembly Y 1-10-232034A Y 1-00-00248 Y 3-44-677185 Y 1-00-375501 Y 1-00-232038 9 Feeder Shield Rear 2-00-232039B 10 1" Foil Faced Fiberglass Insulation 3-44-232085 Y 11 UL Feeder Assembly 12 Differential Switch 3-20-6866 Y 13 Tempco 450W Igniter 1-00-10450 Y 14 1" Foil Faced Fiberglass Insulation 3-44-232086 15 Tube Cleanout Plate 16 2-00-232008B 2-00-232031-1B Hopper Stiffener Bracket Right 2-00-232031-2B Firebox Refractory Side 18 Burn Pot Scraper 20 Qty 2 req Hopper Stiffener Bracket Left 17 19 Refer to feeder assembly page Water Jacket Gasket Qty 2 req 3-40-232010 Combustion 3-44-232094-1 Long Bottom 3-44-232094-2 Short Bottom 3-44-232094-3 1-00-232208 Air Pump Fitting & Filter Pre 008490076 3-20-02679 Y 1-00-02679 Y 21 1/4" Ceramic Paper Feeder Insulation 22 3/4" NPT Square Plug 23 Feeder Cover Left 2-00-232096B 24 3/4" NPT Boiler Drain 3-10-07560 25 Outer Skin Left 2-00-232026B 26 Combustion Section Weldment 1-10-232005W 27 Steel Sleeve Bushing 3/8 OD x 1/2 OAL 3-50-05229 28 Elevator Bolt 3/8-16 x 1-1/2" Qty 4 req 3-30-937161501 29 Firebox Cleanout Cover Retainer Qty 2 req 2-00-232056B Additional service part numbers on the following page. 3-44-232078 Qty 4 req 3-10-00600 HF60 Service Parts Beginning Manufacturing Date: July 2009 Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor. ITEM Description COMMENTS Stocked at Depot PART NUMBER 30 Tube Cleanout Cover Plate Qty 2 req 2-00-232052B 31 Tube Cleanout Latch Qty 2 req 2-00-232009L 32 Ceramic Insert Pkg of 10 3-20-05238-10 Y 33 Flame Guide 3-00-03000 Y 34 Burnpot Assembly 1-10-232079A Y Y Clean Out Cover 2 Sets 1-00-06623 Y Thumb Screw Pkg of 10 3-31-782108-10 Y 35 Ceramic Insert Gasket 3-44-724114 Y 36 Ceramic Insert Plate 2-00-724104 Y 37 Burn Pot Gasket 3-44-724115 Y 38 Firebox Refractory Rear 3-40-232015 Y 39 Firebrick 3-40-232093 Y 40 Firebox Refractory Bottom 3-40-232006 Y 41 Ash Pan Assembly 1-10-232049A Y 42 Ash Door Assembly 1-10-232019A Ash Door Spacer Set w/Gasket 1-00-232074 Glass 5.25 x 5.25 3-40-5555 Refractory Tadpole Gasket, Glass 43 3-40-232023 10 Ft Control Board Plate Assembly 1-00-00539 Y 1-10-232055A Circuit Board w/Knobs & Shafts 1-00-06143 Y Knob & Shaft Set of 25 1-00-015605 Y Fuse, 6 AMP Pkg of 5 3-20-49447-5 Y 3-10-78427 Y 44 Pressure / Temperature Gauge 45 Plumbing Assembly 1-10-232080A Pre SN 004490643 2-00-232028A Post SN 004490643 2-00-232028B 46 Combustion Motor Cover 47 Outer Skin Front 2-00-232027B 48 Combustion Blower 3-21-08639 Y Blade 5" Single 3-20-502221 Y Combustion Blower Mount 1-10-73416 Combustion Motor Mounting Screws Pkg of 100 1-00-53483208 49 External Retaining Ring 3-31-004357 50 Flex Conduit Support Bracket 2-00-232071B 51 3/8" Flex Conduit 1-00-25043 3/8" Flex Connector Qty 2 req 3-20-1000 52 Ash Door Hinge 2-00-232020L 53 Water Jacket Weldment 1-10-232001W Additional service part numbers on the following page. Y HF60 Service Parts Beginning Manufacturing Date: July 2009 Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor. ITEM Description COMMENTS Pkg of 8 Stocked at Depot PART NUMBER 54 Spiral Fire Tube Baffle 55 ESP Probe 56 1/2" Foam Insulation 57 2" Fiberglass Insulation 58 Feeder Cover Right 2-00-232097B 59 Outer Skin Right 2-00-232025B 60 Spring Latch Qty 4 req 3-31-00927 Y 3/8"-16 x 1/4" Alloy Steel Black Oxide Cup Point SSS Pkg of 25 3-30-2014-25 Y 3-20-03018 Y Aqua Temp Sensor Cable 2-00-232053-8 Y 3-20-00844 Y 3-20-72180 Y 3-44-232087 Qty 2 req 3 Position Terminal Block 3-44-232090 Y Amtrol Air Vent 3-10-70130 Circuit breaker 10 Amp (orange - on/off switch) 3-20-334110 Y Diagnostic Dsplay Module 3-20-05401 Y DDM Replacement Cable 1-00-05402 Differential Switch Disconnect, Female Pkg of 25 Draft Meter Assembly Draft Meter Bolt & Tube 3-20-6866 Y 1-00-00959 Y 1-00-00637 Y 1-00-04004 High Altitude Intake Reduction 1-00-232059 Label, Caution 3-90-00247 Labels, Caution & Danger Pkg of 10 1-00-200408541 Power Cord 3-20-39685 Y Relay, 8 Pin 3-20-29202 Y 1-00-00888 Y 3-10-77382 Y Rope Gasket, 3/8" 4 Strand 30 Ft Safety Relief Valve Silicone Tubing, 1/4" 5 Ft 1-00-5113521 Y Silicone Tubing, 1/8" 5 Ft 1-00-5113574 Y Swell latch & Spacer 1-00-199110 Y Touch Up Paint, Prepaint Aerosol 3-42-7737 Wiring Harness 3-20-232076 Additional service part numbers on the following page. Y HF60 Service Parts Beginning Manufacturing Date: July 2009 Ending Manufacturing Date: Active #11 Feeder Asembly 11.1 11.12 11.16 11.15 11.14 11.2 11.13 11.11 11.3 11.10 11.9 11.4 11.5 11.7 11.6 11.8 IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor. ITEM 11 11.1 Description COMMENTS UL Feeder Assembly PART NUMBER 1-10-232108A Pellet Feeder Gear Motor, 6RPM Feed Motor Fan Blade Stocked at Depot Pkg of 3 3-20-09302 Y 3-20-09302-3 Y 11.2 UL Feeder Cam 3-31-3014 Y 11.3 Feeder Air Crossover Kit 1-00-67900 Y 1-00-511427 Y 9MM Silicone Tube 5 Ft 11.4 Pellet Air Intake Assembly 1-10-06810A 11.5 Gasket Feeder Air Intake 11.6 UL Feeder Air Intake 11.7 Gasket Ultra Air Intake 3-44-677160-10 Y 11.8 Ultra Feeder Weldment 1-10-72226S Y 11.9 UL Feeder Pusher Arm 1-10-677187W Y 11.10 Fines Deflector 11.11 Gasket, UL Feeder Cover 11.12 Pkg of 6 3-44-72224-6 Y 1-10-232114 Pkg of 10 No longer available Set of 2 2-00-677138-10 1-00-677122 Y Slide Plate Assembly 1-10-677121A Y 11.13 UL Feeder Auger Assembly 3-50-00565 Y 11.14 Bearing Flange w/Hardware 1-00-04035 Y 11.15 UL Feeder Gear Motor Bracket w/Grommet 1-00-247406 Y 11.16 UL Feeder Cam Block 3-00-677154 Y Grommet, Motor Bracket Pkg of 12 3-31-2761-12 Hopper Switch Feeder Fitting Set of 2 1-00-142818 Y Pillow Block Pkg of 4 3-31-3614087-4 Y
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.3 Linearized : Yes XMP Toolkit : Adobe XMP Core 5.2-c001 63.139439, 2010/09/27-13:37:26 Create Date : 2013:11:21 15:37:46-06:00 Modify Date : 2013:11:21 15:37:46-06:00 Producer : Acrobat Distiller 10.0.0 (Windows) Format : application/pdf Title : untitled Document ID : uuid:57849ff9-591a-478e-adb0-c8d86a22c133 Instance ID : uuid:fae4108c-20d6-42cc-9c7b-831014433c7d Page Count : 5EXIF Metadata provided by EXIF.tools