IEI Integration 210UPC-V312 PANEL PC User Manual UPC V312 D525 Panel PC

IEI Integration Corp. PANEL PC UPC V312 D525 Panel PC

UPC-V312-D525_User Manual_Rev1_part1

UPC-V312-D525 Panel PC Page i IEI Technology Corp. User Manual UPC-V312-D525 Panel PC MODEL: UPC-V312-D525 Panel PC with Touch Screen and Intel®Atom™ CPU, GbE, Wireless, GPS, RFID, USB, Audio, RS-232/422/485, RoHS Compliant, IP 65 Protection Rev. 1.02 – 23 August, 2012 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage ii Revision Date Version Changes 23 August, 2012 1.02 Replaced IEI MiniDOM support with mSATA support 8 December, 2011 1.01 Updated Table 1-4: System Specifications Updated Section 2.2: Packing List Updated Section 3.5: Mounting the System 23 September, 2011 1.00 Initial release Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page iii Copyright COPYRIGHT NOTICE The information in this document is subject to change without prior notice in order to improve reliability, design and function and does not represent a commitment on the part of the manufacturer. In no event will the manufacturer be liable for direct, indirect, special, incidental, or consequential damages arising out of the use or inability to use the product or documentation, even if advised of the possibility of such damages. This document contains proprietary information protected by copyright. All rights are reserved. No part of this manual may be reproduced by any mechanical, electronic, or other means in any form without prior written permission of the manufacturer. TRADEMARKS All registered trademarks and product names mentioned herein are used for identification purposes only and may be trademarks and/or registered trademarks of their respective owners. Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage iv WARNING This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and(2) this device must accept any interference received, including interference that may cause undesired operation. NOTE: This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures: —Reorient or relocate the receiving antenna. —Increase the separation between the equipment and receiver. —Connect the equipment into an outlet on a circuit different from that to which the receiver is connected. —Consult the dealer or an experienced radio/ TV technician for help. You are cautioned that any change or modifications to the equipment not expressly approve by the party responsible for compliance could void your authority to operate such equipment. IMPORTANT NOTE: FCC Radiation Exposure Statement: This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment. This equipment should be installed and operated with minimum distance 20cm between the radiator & your body. Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page v Table of Contents 1 INTRODUCTION.......................................................................................................... 1 1.1 OVERVIEW.................................................................................................................. 2 1.2 SYSTEM VARIATIONS.................................................................................................. 3 1.3 FEATURES................................................................................................................... 3 1.4 EXTERNAL OVERVIEW................................................................................................ 4 1.4.1 Front Panel ........................................................................................................ 4 1.4.1.1 LED Indicators............................................................................................ 5 1.4.2 Bottom Panel...................................................................................................... 7 1.4.3 Left Side Panel................................................................................................... 8 1.4.4 Right Side Panel................................................................................................. 9 1.4.5 Rear Panel ......................................................................................................... 9 1.4.6 Frame (Function Keys).................................................................................... 10 1.5 DIMENSIONS..............................................................................................................11 1.6 SPECIFICATIONS ....................................................................................................... 12 2 UNPACKING ............................................................................................................... 15 2.1 UNPACKING.............................................................................................................. 16 2.2 PACKING LIST........................................................................................................... 17 3 INSTALLATION ......................................................................................................... 19 3.1 ANTI-STATIC PRECAUTIONS...................................................................................... 20 3.2 INSTALLATION PRECAUTIONS ................................................................................... 20 3.3 PREINSTALLED COMPONENTS................................................................................... 21 3.4 CF CARD INSTALLATION .......................................................................................... 22 3.5 MOUNTING THE SYSTEM .......................................................................................... 23 3.5.1 Arm Mounting .................................................................................................. 25 3.5.2 Stand Mounting................................................................................................ 26 3.5.3 Wall Mounting.................................................................................................. 26 3.6 BOTTOM PANEL CONNECTORS ................................................................................. 29 3.6.1 External Peripheral Device Connection.......................................................... 29 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage vi 3.6.2 ACC Mode Selection........................................................................................ 32 3.6.3 AT/ATX Power Mode Selection........................................................................ 32 3.6.4 Audio Connectors............................................................................................. 33 3.6.5 CAN-bus Terminal Block.................................................................................. 33 3.6.6 LAN Connector ................................................................................................ 33 3.6.7 Power Input 1, 3-pin Terminal Block............................................................... 35 3.6.8 Power Input 2, DIN Connector........................................................................ 35 3.6.9 RJ-45 RS-232 Serial Port................................................................................. 35 3.6.10 RS-422/485 Serial Port.................................................................................. 37 3.6.11 USB Connectors............................................................................................. 38 3.6.12 VGA Connector.............................................................................................. 40 3.7 REDUNDANT POWER ................................................................................................ 42 3.7.1 ACC ON ........................................................................................................... 43 3.7.1.1 Boot-up ..................................................................................................... 43 3.7.1.2 Switch to Backup Power........................................................................... 44 3.7.1.3 Shutdown .................................................................................................. 44 3.7.2 ACC OFF......................................................................................................... 45 3.7.2.1 Boot-up ..................................................................................................... 45 3.7.2.2 Switch to Backup Power........................................................................... 46 3.7.2.3 Shutdown .................................................................................................. 47 3.8 REMOTE CONTROL................................................................................................... 48 4 AMI BIOS SETUP....................................................................................................... 49 4.1 INTRODUCTION......................................................................................................... 50 4.1.1 Starting Setup................................................................................................... 50 4.1.2 Using Setup...................................................................................................... 50 4.1.3 Getting Help..................................................................................................... 51 4.1.4 BIOS Menu Bar................................................................................................ 51 4.2 MAIN........................................................................................................................ 52 4.3 ADVANCED............................................................................................................... 53 4.3.1 ACPI Settings................................................................................................... 53 4.3.2 CPU Configuration.......................................................................................... 55 4.3.3 IDE Configuration ........................................................................................... 56 4.3.4 USB Configuration........................................................................................... 57 4.3.5 Super IO Configuration ................................................................................... 58 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page vii 4.3.5.1 Serial Port n Configuration....................................................................... 59 4.3.6 H/W Monitor.................................................................................................... 64 4.3.7 Serial Port Console Redirection ...................................................................... 65 4.3.7.1 Console Redirection Settings.................................................................... 66 4.3.8 IEI Feature....................................................................................................... 68 4.4 CHIPSET ................................................................................................................... 68 4.4.1 Host Bridge Configuration .............................................................................. 69 4.4.2 South Bridge Configuration............................................................................. 70 4.4.3 Intel IGD SWSCI OpRegion............................................................................. 72 4.5 BOOT........................................................................................................................ 74 4.6 SAV E & EXIT ............................................................................................................ 75 5 SOFTWARE DRIVERS .............................................................................................. 78 5.1 AVAILABLE SOFTWARE DRIVERS .............................................................................. 79 5.2 STARTING THE DRIVER PROGRAM ............................................................................ 79 5.3 CHIPSET DRIVER INSTALLATION............................................................................... 80 5.4 GRAPHICS DRIVER INSTALLATION............................................................................ 83 5.5 LAN DRIVER INSTALLATION.................................................................................... 87 5.6 AUDIO DRIVER INSTALLATION ................................................................................. 90 5.7 TOUCH SCREEN DRIVER INSTALLATION ................................................................... 92 5.7.1 Calibrating the Touch Screen........................................................................... 95 5.8 GPS DRIVER INSTALLATION..................................................................................... 97 5.9 CAN-BUS DRIVER INSTALLATION .......................................................................... 100 A BIOS CONFIGURATION OPTIONS..................................................................... 105 A.1 BIOS CONFIGURATION OPTIONS........................................................................... 106 B ONE KEY RECOVERY........................................................................................... 108 B.1 ONE KEY RECOVERY INTRODUCTION .................................................................... 109 B.1.1 System Requirement........................................................................................110 B.1.2 Supported Operating System..........................................................................111 B.2 SETUP PROCEDURE FOR WINDOWS.........................................................................112 B.2.1 Hardware and BIOS Setup .............................................................................113 B.2.2 Create Partitions ............................................................................................113 B.2.3 Install Operating System, Drivers and Applications......................................117 B.2.4 Building the Recovery Partition.....................................................................118 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage viii B.2.5 Create Factory Default Image....................................................................... 120 B.3 AUTO RECOVERY SETUP PROCEDURE.................................................................... 125 B.4 SETUP PROCEDURE FOR LINUX.............................................................................. 129 B.5 RECOVERY TOOL FUNCTIONS ................................................................................ 133 B.5.1 Factory Restore ............................................................................................. 134 B.5.2 Backup System............................................................................................... 135 B.5.3 Restore Your Last Backup.............................................................................. 136 B.5.4 Manual........................................................................................................... 137 B.6 RESTORE SYSTEMS FROM A LINUX SERVER THROUGH LAN.................................. 138 B.6.1 Configure DHCP Server Settings.................................................................. 139 B.6.2 Configure TFTP Settings............................................................................... 140 B.6.3 Configure One Key Recovery Server Settings ............................................... 141 B.6.4 Start the DHCP, TFTP and HTTP ................................................................. 142 B.6.5 Create Shared Directory................................................................................ 142 B.6.6 Setup a Client System for Auto Recovery ...................................................... 143 B.7 OTHER INFORMATION ............................................................................................ 146 B.7.1 Using AHCI Mode or ALi M5283 / VIA VT6421A Controller....................... 146 B.7.2 System Memory Requirement ........................................................................ 148 C SAFETY PRECAUTIONS....................................................................................... 149 C.1 SAFETY PRECAUTIONS........................................................................................... 150 C.1.1 General Safety Precautions........................................................................... 150 C.1.2 Anti-static Precautions.................................................................................. 151 C.1.3 Product Disposal........................................................................................... 151 C.2 MAINTENANCE AND CLEANING PRECAUTIONS ...................................................... 152 C.2.1 Maintenance and Cleaning ........................................................................... 152 C.2.2 Cleaning Tools............................................................................................... 153 D WATCHDOG TIMER .............................................................................................. 154 E HAZARDOUS MATERIALS DISCLOSURE ....................................................... 157 E.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ..................................... 158 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page ix List of Figures Figure 1-1: UPC-V312-D525 Panel PC...........................................................................................2 Figure 1-2: Front View....................................................................................................................5 Figure 1-3: LED Indicators.............................................................................................................5 Figure 1-4: Bottom View ................................................................................................................8 Figure 1-5: Left Side View..............................................................................................................8 Figure 1-6: Left Side View..............................................................................................................9 Figure 1-7: Rear View.....................................................................................................................9 Figure 1-8: Function Key Locations ...........................................................................................10 Figure 1-9: UPC-V312-D525 Dimensions (mm)..........................................................................11 Figure 3-1: Remove the CF Card Slot Panel ..............................................................................22 Figure 3-2: CF Card Installation ..................................................................................................23 Figure 3-7: VESA Mount Retention Screw Holes ......................................................................24 Figure 3-8: Mounting Brackets (Side Panels)............................................................................24 Figure 3-9: VESA Compliant Arm................................................................................................25 Figure 3-10: VESA Compliant Stand...........................................................................................26 Figure 3-11: Wall-mounting Bracket...........................................................................................27 Figure 3-12: Chassis Support Screws........................................................................................28 Figure 3-13: Secure the Panel PC ...............................................................................................29 Figure 3-14: I/O Cover Retention Screws...................................................................................30 Figure 3-15: External Peripheral Device Connection................................................................30 Figure 3-16: Rubber Gasket Removal.........................................................................................30 Figure 3-17: Rubber Gasket and Cable ......................................................................................31 Figure 3-18: Reinstall the I/O Cover............................................................................................31 Figure 3-19: External Peripheral Device Connection Complete ..............................................32 Figure 3-20: ACC Mode Switch ...................................................................................................32 Figure 3-21: AT/ATX Power Mode Switch ..................................................................................32 Figure 3-22: CAN-bus Terminal Block Pinouts..........................................................................33 Figure 3-23: RJ-45 Ethernet Connector......................................................................................33 Figure 3-24: LAN Connection......................................................................................................34 Figure 3-25: 3-pin Terminal Block Pinouts ................................................................................35 Figure 3-26: RJ-45 RS-232 Serial Port........................................................................................36 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage x Figure 3-27: RJ-45 RS-232 Serial Device Connection...............................................................36 Figure 3-28: RS-422/485 Serial Port............................................................................................37 Figure 3-29: RS-422/485 Cable ....................................................................................................37 Figure 3-30: RS-422/485 Serial Port (DB-9)................................................................................38 Figure 3-31: USB Device Connection .........................................................................................39 Figure 3-32: VGA Connector .......................................................................................................40 Figure 3-33: VGA Connector .......................................................................................................41 Figure 3-34: Power Connectors ..................................................................................................42 Figure 3-35: ACC On: AT Mode...................................................................................................43 Figure 3-36: ACC On: ATX Mode.................................................................................................43 Figure 3-37: ACC On: Switch Between PWR1 and PWR2 ........................................................44 Figure 3-38: ACC On: Shutdown.................................................................................................45 Figure 3-39: ACC Off: AT Mode...................................................................................................46 Figure 3-40: ACC Off: ATX Mode ................................................................................................46 Figure 3-41: ACC Off: Switch Between PWR1 and PWR2........................................................46 Figure 3-42: ACC Off: Shutdown.................................................................................................47 Figure 3-43: Remote Control .......................................................................................................48 Figure 5-1: Chipset Driver Screen...............................................................................................80 Figure 5-2: Chipset Driver Welcome Screen..............................................................................81 Figure 5-3: Chipset Driver License Agreement .........................................................................81 Figure 5-4: Chipset Driver Read Me File ....................................................................................82 Figure 5-5: Chipset Driver Setup Operations ............................................................................82 Figure 5-6: Chipset Driver Installation Finish Screen...............................................................83 Figure 5-7: Graphics Driver Read Me File..................................................................................84 Figure 5-8: Graphics Driver Setup Files Extracted ...................................................................84 Figure 5-9: Graphics Driver Welcome Screen ...........................................................................85 Figure 5-10: Graphics Driver License Agreement.....................................................................85 Figure 5-11: Graphics Driver Read Me File................................................................................86 Figure 5-12: Graphics Driver Setup Operations........................................................................86 Figure 5-13: Graphics Driver Installation Finish Screen ..........................................................87 Figure 5-14: LAN Driver Welcome Screen .................................................................................88 Figure 5-15: LAN Driver Welcome Screen .................................................................................88 Figure 5-16: LAN Driver Installation ...........................................................................................89 Figure 5-17: LAN Driver Installation Complete..........................................................................89 Figure 5-18: Audio Driver Welcome Screen...............................................................................90 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page xi Figure 5-19: Audio Driver Installation.........................................................................................91 Figure 5-20: AC’97 Driver Installation Complete.......................................................................91 Figure 5-21: Touch Screen Driver Welcome Screen.................................................................92 Figure 5-22: Touch Screen Driver License Agreement.............................................................93 Figure 5-23: Touch Screen Driver Choose Install Location.....................................................93 Figure 5-24: Touch Screen Driver Installation Screen..............................................................94 Figure 5-25: Touch Screen Driver Update Complete................................................................94 Figure 5-26: PenMount Monitor Icon..........................................................................................95 Figure 5-27: PenMount Monitor Popup Menu............................................................................95 Figure 5-28: Configuration Screen..............................................................................................96 Figure 5-29: Calibration Initiation Screen ..................................................................................96 Figure 5-30: Calibration Screen ..................................................................................................97 Figure 5-31: GPS Driver Welcome Screen .................................................................................98 Figure 5-32: GPS Driver Choose Install Location .....................................................................98 Figure 5-33: Installing GPS Driver ..............................................................................................99 Figure 5-34: GPS Driver Installation Complete..........................................................................99 Figure 5-35: Windows Control Panel....................................................................................... 100 Figure 5-36: System Icon.......................................................................................................... 101 Figure 5-37: Device Manager Tab ............................................................................................ 102 Figure 5-38: Search for Suitable Driver................................................................................... 103 Figure 5-39: Locate Driver Files............................................................................................... 103 Figure B-1: IEI One Key Recovery Tool Menu ........................................................................ 109 Figure B-2: Launching the Recovery Tool.............................................................................. 114 Figure B-3: Recovery Tool Setup Menu .................................................................................. 114 Figure B-4: Command Prompt ................................................................................................. 115 Figure B-5: Partition Creation Commands.............................................................................. 116 Figure B-6: Launching the Recovery Tool.............................................................................. 118 Figure B-7: Manual Recovery Environment for Windows ..................................................... 118 Figure B-8: Building the Recovery Partition........................................................................... 119 Figure B-9: Press Any Key to Continue .................................................................................. 119 Figure B-10: Press F3 to Boot into Recovery Mode............................................................... 120 Figure B-11: Recovery Tool Menu ........................................................................................... 120 Figure B-12: About Symantec Ghost Window........................................................................ 121 Figure B-13: Symantec Ghost Path ......................................................................................... 121 Figure B-14: Select a Local Source Drive ............................................................................... 122 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage xii Figure B-15: Select a Source Partition from Basic Drive ...................................................... 122 Figure B-16: File Name to Copy Image to ............................................................................... 123 Figure B-17: Compress Image.................................................................................................. 123 Figure B-18: Image Creation Confirmation............................................................................. 124 Figure B-19: Image Creation Complete................................................................................... 124 Figure B-20: Image Creation Complete................................................................................... 124 Figure B-21: Press Any Key to Continue ................................................................................ 125 Figure B-22: Auto Recovery Utility .......................................................................................... 126 Figure B-23: Launching the Recovery Tool............................................................................ 126 Figure B-24: Auto Recovery Environment for Windows ....................................................... 126 Figure B-25: Building the Auto Recovery Partition................................................................ 127 Figure B-26: Factory Default Image Confirmation ................................................................. 127 Figure B-27: Image Creation Complete................................................................................... 128 Figure B-28: Press any key to continue .................................................................................. 128 Figure B-29: Partitions for Linux.............................................................................................. 130 Figure B-30: Manual Recovery Environment for Linux ......................................................... 131 Figure B-31: Access menu.lst in Linux (Text Mode).............................................................. 132 Figure B-32: Recovery Tool Menu ........................................................................................... 132 Figure B-33: Recovery Tool Main Menu.................................................................................. 133 Figure B-34: Restore Factory Default...................................................................................... 134 Figure B-35: Recovery Complete Window .............................................................................. 135 Figure B-36: Backup System.................................................................................................... 135 Figure B-37: System Backup Complete Window ................................................................... 136 Figure B-38: Restore Backup ................................................................................................... 136 Figure B-39: Restore System Backup Complete Window..................................................... 137 Figure B-40: Symantec Ghost Window ................................................................................... 137 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page xiii List of Tables Table 1-1: System Variations.........................................................................................................3 Table 1-2: LED Indicators ..............................................................................................................6 Table 1-3: Function Keys.............................................................................................................10 Table 1-4: System Specifications................................................................................................14 Table 3-1: LAN Pinouts ................................................................................................................33 Table 3-2: RJ-45 Ethernet Connector LEDs...............................................................................34 Table 3-3: RJ-45 RS-232 Serial Port Pinouts .............................................................................36 Table 3-4: RS-422/485 Serial Port Pinouts .................................................................................37 Table 3-5: RS-422/485 Serial Port Pinouts .................................................................................38 Table 3-6: USB Port Pinouts........................................................................................................39 Table 3-7: VGA Connector Pinouts.............................................................................................40 Table 4-1: BIOS Navigation Keys................................................................................................51 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page 1 1 Introduction Chapter 1 Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage 2 1.1 Overview Figure 1-1: UPC-V312-D525 Panel PC The fanless UPC-V312-D525 is Intel® Atom D525 powered panel PC with a rich variety of functions and peripherals. The UPC-V312-D525 panel PC is designed for easy and simplified integration into various vehicle applications. An Intel® ICH8M chipset ensures optimal memory, graphics, and peripheral I/O support. The system comes with 1GB of preinstalled DDR3 SDRAM ensuring smooth data throughputs with reduced bottlenecks and fast system access. The redundant dual DC power input of the UPC-V312-D525 increases the reliability of the system and prevents data loss and system corruption from sudden power failure. The CAN-bus interface allows the UPC-V312-D525 to communication with vehicles. Two serial ports and five external USB 2.0 ports ensure simplified connectivity to a variety of external peripheral devices. A VGA connector enables connectivity to other monitors for dual display. Wi-Fi capabilities and the RJ-45 GbE connector ensure smooth connection of the system to an external LAN. Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page 31.2 System Variations The part numbers and system variations are listed below. Part Numbers CPU RFID Reader UPC-V312-D525/R/1G-R10 Intel® Atom D525 N/A UPC-V312-D525/R-EM/1G-R10 Intel® Atom D525 EM card reader UPC-V312-D525/R-MF/1G-R10 Intel® Atom D525 Mifare card reader Table 1-1: System Variations 1.3 Features The UPC-V312-D525 series features the following:  12.1'' 600nits 1024 x 768 LCD with LED backlight  Fanless system with 1.8GHz Intel® Atom™ D525 dual-core processor  Redundant dual DC input power  Dual-band 2.4/5GHz Wi-Fi 802.11 a/b/g/n  Reserved space for 3.75G / HSUPA USB module  Built-in 1.3 megapixel webcam with AF, AE and AWB capabilities  CAN-bus interface  Optional RFID reader for EM or Mifare cards  Optional GPS receiver  Provide two PCIe Mini card slots  F1 ~ F10 function keys and friendly indicators  IP 65 compliant system  AT or ATX power mode  Touch screen  RoHS comlpliance Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage 4 1.4 External Overview The panel PC is a rectangular cubic structure that comprises of a screen, rear panel, top panel, bottom panel and two side panels (left and right). An aluminum frame surrounds the front screen. The rear panel provides screw holes for a wall-mounting bracket, and an arm mounting interface. The bottom panel provides access to external interface connectors. 1.4.1 Front Panel The front side of the UPC-V312-D525 is a flat panel TFT LCD screen surrounded by an aluminum frame. At the top of the front panel features one 1.3 megapixel webcam that supports auto-focus (AF), auto-exposure (AE) and auto white balance (AWB). The front panel also has following buttons, LED indicators and sensors:  Buttons: F1~F10 (same as the function key on the keyboard)  LEDs o Power 1 LED o Power 2 LED o AT/ATX power mode LED o CPU temperature alert LED o Wi-Fi connection LED o RFID LED o GPS LED o Auto dimming LED o Microphone on/off LED o Audio mute LED  Sensors o Ambient light sensor o Infrared remote control sensor Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page 5Figure 1-2: Front View 1.4.1.1 LED Indicators The LED indicators on the front panel of the UPC-V312-D525 are shown below. Figure 1-3: LED Indicators The descriptions of each LED indicator are listed below. LED Indicator Description Power 1 Pulsing Orange: Power 1 is the main power and is in standby mode Solid Orange: Power 1 is the second power and is in standby mode Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage 6 Solid Blue: Power 1 is providing power to the system Power 2 Pulsing Orange: Power 2 is the main power and is in standby mode Solid Orange: Power 2 is the second power and is in standby mode Solid Blue: Power 2 is providing power to the system AT/ATX Power Mode Shows the power mode status. Controlled by the AT/ATX power mode switch. CPU Temperature Alert Blue: the CPU temperature is normal. Red: the CPU temperature is too high. Wi-Fi The Wi-Fi module is enabled or disabled. Controlled by the BIOS (see Section 4.4.2). RFID Reader The optional RFID reader is enabled or disabled. Controlled by the hot keys (see Section 1.4.6). GPS The GPS receiver is enabled or disabled. Controlled by the BIOS (see Section 4.4.2). Auto Dimming The auto dimming function is enabled or disabled. Controlled by the remote control (see Section 3.8). Microphone The microphone is enabled or disabled. Controlled by the BIOS (Section 4.4.2). Audio Mute Light on when the audio is turned off. Controlled by the hot keys (see Section 1.4.6). Function LCD on/off Volume Down Volume Up Brightness Down Brightness Up Shows the status of the function key below the LED indicator. Blinks when the corresponding button is pushed. Table 1-2: LED Indicators Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PC Page 7 CAUTION: If the CPU temperature alert LED shows in red, the user must lower the environment temperature or close some running applications to cool down the CPU. 1.4.2 Bottom Panel The following is a list of the bottom panel peripheral device connectors on the UPC-V312-D525.  1 x 9 V ~ 36 V DC power input terminal block (Power 1)  1 x 10.5 V ~ 36 V DC power input connector (Power 2)  2 x Audio jacks  1 x CAN but connector  1 x RJ-45 GbE connector  1 x RS-232 COM port by RJ-45 connector  1 x RS-422/485 serial port (COM2) connector  4 x USB 2.0 connectors  1 x VGA connector The bottom panel also includes the following switches and buttons:  1 x ACC on/off switch  1 x AT/ATX power mode switch  1 x Reset button Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com
UPC-V312-D525 Panel PCPage 8 Figure 1-4: Bottom View 1.4.3 Left Side Panel The left side panel of the panel PC provides access to the CF card slot. (55Figure 1-5). Figure 1-5: Left Side View Click to buy NOW!PDF-XChange Viewerwww.docu-track.comClick to buy NOW!PDF-XChange Viewerwww.docu-track.com

Navigation menu