TM2349 John Deere Lawn Tractor Select X700 X720 X724 X728 04780
2019-04-21
: John-Deere John-Deere-Lawn-Tractor-Select-X700-X720-X724-X728-Tm2349-04780 John-Deere-Lawn-Tractor-Select-X700-X720-X724-X728-TM2349-04780
Open the PDF directly: View PDF
Page Count: 478 [warning: Documents this large are best viewed by clicking the View PDF Link!]
- TM2349 X700, X720, X724 and X728 John Deere Select Series Tractors
- Introduction
- Safety
- Recognize Safety Information
- Understand Signal Words
- Replace Safety Signs
- Handle Fluids Safely - Avoid Fires
- Use Care In Handling And Servicing Batteries
- Prevent Battery Explosions
- Prevent Acid Burns
- Wear Protective Clothing
- Use Care Around High-pressure Fluid Lines
- Service Machines Safely
- Use Proper Tools
- Park Machine Safely
- Support Machine Properly and Use Proper Lifting Equipment
- Work In Clean Area
- Using High Pressure Washers
- Illuminate Work Area Safely
- Work In Ventilated Area
- Warning: California Proposition 65 Warning
- Remove Paint Before Welding or Heating
- Avoid Harmful Asbestos Dust
- Service Tires Safely
- Avoid Injury From Rotating Blades, Augers And PTO Shafts
- Service Cooling System Safely
- Handle Chemical Products Safely
- Dispose of Waste Properly
- Live With Safety
- Specifications & Information
- Table of Contents
- Fastener Torques
- O-Ring Seal Service Recommendations
- General Information
- Gasoline
- Gasoline Storage
- 4 - Cycle Gasoline Engine Oil
- Break-In Engine Oil - 4-Cycle Gasoline
- Hydrostatic Transmission and Hydraulic Oil
- Gear Case Oil
- Gear Transmission Grease
- Alternative Lubricants
- Synthetic Lubricants
- Anti-Corrosion Grease
- Mower Spindle Grease
- Lubricant Storage
- Mixing of Lubricants
- Oil Filters
- Coolant Specifications
- Serial Number Locations
- Engine - Gas (Liquid-Cooled)
- Table of Contents
- Specifications
- Component Location
- Theory of Operation
- Diagnostics
- Tests and Adjustments
- Throttle Lever Adjustment
- Throttle Cable Adjustment
- Choke Adjustment (FD671D)
- Governor Adjustment
- Low Idle Speed Adjustment
- High Idle Speed Adjustment
- Compression Test
- Valve Clearance Adjustment
- Crankcase Vacuum Test
- Engine Oil Pressure Test
- Fuel Pump Flow Test for Carburetor (FD671D)
- Fuel Pump Pressure Test for Carburetor (FD671D)
- Fuel Pump Pressure Test For Fuel Injection (FD750D)
- Bleed Fuel System (FD750D)
- Fan Belt Tension Adjustment
- Thermostat Test
- Cooling System Test
- Radiator Bubble Test
- Radiator Cap Pressure Test
- Water Pump/Alternator Drive Belt Adjustment
- Repair
- Thermostat Removal and Installation
- Fan Belt Removal and Installation
- Cooling Fan and Bracket Removal and Installation
- Coolant Pump Removal and Installation
- Radiator Removal and Installation
- Muffler Removal and Installation
- Air Cleaner Removal and Installation
- Carburetor Removal and Installation (FD671D)
- Throttle Body Removal and Installation (FD750D)
- Fuel Injector Removal and Installation (FD750D)
- Fuel Pressure Regulator Removal and Installation (FD750D)
- Cylinder Head Removal and Installation
- Intake Manifold Removal and Installation (FD671D)
- Intake Manifold Removal and Installation (FD750D)
- Starting Motor Removal and Installation
- Starter Motor Disassembly and Assembly
- Starting Motor Inspection
- Engine Removal and Installation
- Flywheel Removal and Installation
- Push Rod/Rocker Arm Removal and Installation
- Valve Train Removal and Installation
- Crankcase Cover Removal and Installation
- Crankcase Cover Inspection
- Governor Assembly Removal and Installation
- Piston Removal and Installation
- Inspect Piston and Cylinder
- Cylinder Bore Honing
- Camshaft/Tappet Removal and Installation
- Camshaft Disassembly and Inspection
- Crankshaft Removal and Replacement
- Crankshaft Inspection
- Connecting Rod Inspection
- Breather Valve Removal and Installation
- Oil Pump Removal and Installation
- Oil Pump Inspection
- Oil Screen Removal and Installation
- Electrical
- Table of Contents
- General Information
- Specifications
- Component Location
- Schematics and Harnesses
- Schematic and Wiring Harness Legend - X700
- Schematic And Wiring Harness Legend - X720/X724/X728
- Electrical Schematic - X700 Carbureted (1 of 2)
- Electrical Schematic - X700 Carbureted (2 of 2)
- W1 Main Wiring Schematic - 720/X724/X728 EFI (1 of 2)
- W1 Main Wiring Schematic - 720/X724/X728 EFI (2 of 2)
- Liquid Cooled EFI Schematic (1 of 2)
- Liquid Cooled EFI Schematic (2 of 2)
- W1 Main Wiring Harness - X700 Carbureted (1 of 2)
- W1 Main Wiring Harness - X700 Carbureted (2 of 2)
- W1 Main Wiring Harness - X720/X724/X728 EFI (1 of 2)
- W1 Main Wiring Harness - X720/X724/X728 EFI (2 of 2)
- W2 Engine Wiring Harness - X700
- W2 Engine Wiring Harness - X720/X724/X728
- W2 Engine Wiring Harness Circuit Schematic - X720/X724/X728
- W3 Headlight Wiring Harness
- W4 Rear Wiring Harness
- W5 PTO Option Wiring Harness
- W6 Auxiliary Alternator Wiring Harness
- W6 Auxiliary Alternator Wiring Harness Circuit Schematic
- A2 EFI Module Pin and Signal Location
- W1 Main Wiring Harness Color Codes - X700
- W1 Main Wiring Harness Color Codes - X720/ X724/X728
- W2 Engine Wiring Harness Color Codes - X700
- W2 Engine Wiring Harness Color Codes - X720/X724/X728
- W3 Headlight Wiring Harness Color Codes
- W4 Rear Lights Wiring Harness Color Codes
- W5 PTO Option Wiring Harness Color Codes
- W6 Auxiliary Alternator Wiring Harness Color Codes
- Operation and Diagnostics
- Power Circuit Operation - X700
- Power Circuit Electrical Schematic - X700
- Power Circuit Diagnosis - X700
- Power Circuit Operation - X720/X724/X728
- Power Circuit Electrical Schematic - X720/X724/X728
- Power Circuit Diagnosis - X720/X724/X728
- Cranking Circuit Operation - All Models
- Cranking Circuit Electrical Schematic - All Models
- Cranking Circuit Diagnosis - All Models
- Charging Circuit Operation - All Models (Standard Configuration)
- Charging Circuit Operation - All Models (With Auxiliary Alternator)
- Charging Circuit Electrical Schematic - All Models
- Charging Circuit Diagnosis
- Charging Circuit Diagnosis - All Models (With Optional Alternator)
- Ignition Circuit Operation - X700
- Ignition Circuit Electrical Schematic - X700
- Ignition Circuit Diagnosis - X700
- Ignition Circuit Operation - X720/X724/X728
- Ignition Circuit Electrical Schematic - X720/X724/X728
- Ignition Circuit Diagnosis - X720/X724/X728 EFI
- PTO/RIP Circuit Operation - All Models
- PTO/RIP Circuit Electrical Schematic - All Models
- PTO/RIP Circuit Diagnosis - All Models
- Display Panel Circuit Operation - All Models
- A1 Display Panel Pin and Signal Location
- Lights Circuit Operation - All Models
- Lights Circuit Electrical Schematic - All Models
- Lights Circuit Diagnosis - All Models
- Power Port Circuit Operation - All Models
- Power Port Circuit Electrical Schematic - All Models
- Power Port Circuit Diagnosis - All Models
- Fuel Pump and Fuel Shutoff Circuit Operation - X700
- Fuel Pump and Fuel Shutoff Circuit Electrical Schematic - X700
- Fuel Pump and Fuel Shutoff Circuit Diagnosis - X700
- Fuel Pump and Fuel Injector Circuit Operation - X720/X724/X728
- Fuel Pump and Fuel Injector Circuit Electrical Schematic - X720/X724/X728
- Fuel Pump and Fuel Injector Circuit Diagnosis - X720/X724/X728
- Fuel Injection Sensor and Diagnostic Circuit Operation - X720/X724/X728
- Fuel Injection Sensor and Diagnostic Circuit Electrical Schematic - X720/X724/X728
- Tests and Adjustments
- Common Circuit Tests
- Ground Circuit Tests
- Battery Voltage and Specific Gravity Test
- Battery - Charge
- Battery - Load Test
- Regulated Amperage and Voltage Test
- Regulated Voltage Test
- Unregulated Voltage Test (Standard Configuration)
- Unregulated Voltage Test (Optional Auxiliary Alternator)
- Stator Resistance Test (Standard Configuration)
- Alternator Resistance Test (Optional Auxiliary Alternator)
- Starting Motor Condition
- Starter Solenoid Test
- Starting Motor Amp Draw Test
- Starting Motor No-load Amperage and RPM Test
- Starting Motor Field Windings Test
- Starter Armature Test
- Engine Coolant Temperature Sensor Test
- Engine Oil Pressure Switch Test
- Lights Switch Test
- PTO/RIP Switch Test
- Relay Test
- Power Port Switch Test
- Key Switch Test
- Seat Switch Test
- Brake Switch Test and Adjustment
- RIO Switch Test
- RIO Switch Adjustment
- Fuse Test
- PTO Solenoid Test (Standard Front PTO)
- PTO Switch Test (Optional Rear PTO Installed)
- Fuel Shutoff Solenoid Test - X700
- Diode Test
- Fuel Tank Sensor Test
- Fuel Injector Test - X720/X724/X728
- Fuel Injection Module Test - X720/X724/X728
- Vacuum Pressure Sensor Test - X720/X724/ X728
- Air Temperature Sensor Test - X720/X724/ X728
- Coolant Temperature Sensor Test - X720/ X724/X728
- Spark Plug Gap Test
- Spark Plug Gap Adjustment
- Ignition Coil Test
- Spark Test
- Repair
- Power Train - Hydrostatic
- Table of Contents
- Specifications
- Component Location
- Theory of Operation
- Diagnostics
- Tests and Adjustments
- Repair
- Foot Control Linkage Removal and Installation
- Shift Lever Linkage (MFWD) Removal and Installation
- Oil Cooler Removal and Installation
- Control Arm and Damper Removal and Installation
- Differential Lock Linkage Inspection
- Charge Pump Removal and Installation
- Charge Pump Disassembly and Assembly
- Directional Control Valves
- Hydrostatic Pressure Relief Valve (45 Loader) Installation
- Drive Shaft Removal and Installation
- PTO Solenoid Valve
- PTO Relief Valve Removal and Installation
- PTO Relief Valve Disassembly, Inspection and Assembly
- PTO Brake Removal and Installation
- PTO Brake Disassembly, Inspection and Assembly
- PTO Drive Train (Mid-PTO) Removal and Installation
- PTO Drive Train (Mid and Rear PTO) Removal and Installation
- Rear PTO Removal and Installation
- Transaxle Removal and Installation
- Differential Lock Shaft Disassembly and Assembly
- Differential (2-Wheel Drive) Disassembly and Assembly
- Differential (MFWD) Disassembly and Assembly
- PTO Clutch Disassembly, Inspection and Assembly
- MFWD Output Shaft Removal and Installation
- Hydrostatic Transmission 2-WD and MFWD
- Hydrostatic Pump Inspection
- Transaxle Disassembly
- Transaxle (Right Cover) Disassembly and Assembly
- Transaxle Case Inspection
- Transaxle Assembly
- Rear Axle Assembly (Two Wheel Steer Models) Removal and Installation
- Rear Axle Assembly (Two Wheel Steer Models) Disassembly and Assembly
- Rear Axle Assembly (All Wheel Steer) Removal and Installation
- Rear Axle Assembly (All Wheel Steer) Disassembly and Assembly
- Knuckle Assembly (All Wheel Steer) Removal and Installation
- Knuckle Housing Disassembly and Assembly
- Final Drive Cover Removal and Installation - (MFWD)
- Final Drive Housing Removal and Installation - (MFWD)
- Spindle Housing - (MFWD)
- Drive Shaft Removal and Installation - (MFWD)
- Mechanical Front Wheel Drive Removal and Installation - (MFWD)
- Differential Input Housing - (MFWD)
- Front Axle Housing Disassembly and Assembly
- Hydraulics
- Table of Contents
- Specifications
- Schematics
- Component Location
- Operation and Diagnostics
- Hydraulic System
- Hydraulic Control Valve Operation - Neutral
- Hydraulic Control Valve Operation - Raise
- Hydraulic Control Valve Operation - Float
- Hydraulic Control Valve Operation - Regen
- Lift Cylinder Shut-off Valve - Optional
- Hydraulic Diagnostics
- Preliminary Hydraulic System Inspection
- Hydraulic System Tests
- Tests and Adjustments
- Repair
- Steering
- Table of Contents
- Specifications
- Component Location
- Theory of Operation
- Diagnostics
- Tests and Adjustments
- Repair
- Steering Column Removal and Installation
- Steering Valve Removal and Installation
- Steering Valve Disassembly and Assembly
- Steering Cylinder Removal and Installation
- Front Axle Removal and Installation
- Front Axle Disassembly and Assembly
- Rear Steering Linkage - All Wheel Steering
- Steering Intermediate Linkage - AWS
- Front and Rear Pivots
- Brakes
- Attachments
- Table of Contents
- Specifications
- Diagnostics
- Tests and Adjustments
- Repair
- Cleaning Grass and Debris From Machine
- Mower Deck Belt and Shield Removal and Installation
- Mower Deck Blade Removal and Installation
- Mower Deck Blade - Sharpen
- Mower Deck Blade - Balance
- 48C Mower Deck Spindle Removal and Installation
- Idlers
- Jacksheave
- 54C Mower Deck Spindle Removal and Installation
- Jacksheave
- Idlers
- 62C Mower Deck Spindle Removal and Installation
- Mower Deck Drive Shaft Removal and Installation
- Mower Deck Drive Shaft Repair
- Mower Deck Gearbox Removal and Installation
- Mower Deck Gearbox Repair
- General Information
- Identification Numbers
- Component Location
- Schematics and Harnesses
- Operation and Diagnostics
- Tests and Adjustments
- Repair
- Miscellaneous
- Table of Contents
- Specifications
- Repair
- Headlights Adjustment
- Hood Removal and Installation
- Fender Deck Removal and Installation
- Foot Deck Removal and Installation
- Fuel Tank Removal and Installation
- Fuel Pump/Fuel Gauge Sensor Removal and Installation
- Rear Wheel Removal and Installation
- Front Wheel Removal and Installation
- Instrument Panel Removal and Installation
- Lift Linkage Removal and Installation
- Lift Linkage Adjustment:
- Deck Height Stop Removal and Installation
- Index