Lumex Syatems Zhejiang Co Ltd Range 566Dg Users Manual

566DG to the manual 55791fc1-ea74-4311-9c10-916878256d11

: Lumex-Syatems Lumex-Syatems-Zhejiang-Lumex-Syatems-Co-Ltd-Range-566Dg-Users-Manual-576485 lumex-syatems-zhejiang-lumex-syatems-co-ltd-range-566dg-users-manual-576485 lumex-syatems pdf

Open the PDF directly: View PDF .
Page Count: 8

566DG-INS-LAB

©Graham-Field Health Products 2005

566DG Ortho-Biotic Clinical Care

Drop Arm Recliner

Operating Instructions

IMPORTANT: READ THIS MANUAL BEFORE OPERATING

YOUR ORTHO-BIOTIC CLINICAL CARE DROP ARM RECLINER

2 566DG Ortho Biotic Clinical Care®Recliner Operating Instructions

Warning: Read entire sheet before assembly

or operation.

Warning: Periodically inspect all parts and

replace as needed.

Warning: Do not use near open flame, as the

chair may be a “combustion source”.

Warning: Occupant weight should not

exceed 350 lbs.

Warning: Casters must be locked at all times,

except during transit.

WARNINGS

Every three months:

•Check and clean casters • tighten nuts • check brakes on casters •

•check and clean lock recline mechanism •

Check recliner mechanism for operation in all positions with assistant seated in recliner.

OrdinaryDirt: Wash with warmwater and a mild

soap or detergent.

Stubborn Dirt: Using a soft bristle brush, follow

directions above.

Ground-in Dirt: Scrub with powdered cleanser or

similar detergent.

Chewing Gum: Scrape carefully; remove with

kerosene or naphtha.

Nail Polish and Remover: Blot immediately to

prevent damage.

Ball Point Pen: Blot immediately with a white

cloth dampened in water or mineral oil.

Paint, Shoe Polish, Heel Marks: Remove

immediately! Use a white cloth dampened in

kerosene, naphtha or turpentine. Do not use

paint remover or liquid brush cleaners.

Tars, Asphalt, Creosote: Remove to prevent

staining. Clean area with kerosene or naphtha.

Caution: When using kerosene or naphtha, do so

in a well ventilated area and keep away

from fire and flame.

Waxing and Refinishing: Improves wearability.

Use any quality paste wax.

Adiluted solution of 10% (or less) of bleach or

Clorox may be used when cleaning this chair.

For upholstery maintenance and stain removal, the following hints will be helpful:

CARE & MAINTENANCE

3566DG Ortho Biotic Clinical Care®Recliner Operating Instructions

Upholstered Armrest

Upholstered Footrest

Upholstered Seat

Upholstered Legrest

Front Casters

with Tread

Lock

Frame

Fold Down Side Tables

Trendelenburg Release Bar

Rear Swivel Locking

Casters with Tread lock

Padded Push Handle

Upholstered Back

Drop Arm

Telescoping Tubes

Drop Arm Pull Button

(Behind Table)

ToOperate Drop Arm

ToDrop Arm:

1. Lift fold down Side table away from frame to

expose button.

2. Pull button out while gently pushing down on

center of armrest until arm is in the full down

position.

ToRaise Arm:

1. Grasp armrest with one hand and pull upwards

while pulling pull button out. Pull up on arm

evenly until pull button locks into place.

2. Ensure arm is secure by pushing down on

center of armrest.

4 566DG Ortho Biotic Clinical Care®Recliner Operating Instructions

1. Lift the skirt on the rear of the upholstered

back, fasten skirt up with a small piece of

tape to fully expose the "KD Bracket" that are

to be mated to the recliner mechanism.

2. Carefully guide upholstered back onto the

mechanism inserting both "bayonet links" at

the same time thru cutouts in vinyl.

3. Push down on the back until the mechanism

"bayonet links" are properly engaged into the

upholstered back "KD Brackets". The top of

bayonet link should be even with top of KD

Bracket. (See fig. 1)

4. Once back is properly seated onto

mechanism insert the threaded knob thru

"bayonet link", 'ED Bracket" and steel tube.

Secure hand tight.

5. Remove tape lower upholstery skirt and

secure to Velcro.

UPHOLSTERED BACK ASSEMBLY

Threaded Knobs

Upholstered Back

Upholstered Back’s

KD Brackets

Bracket and Link to be even

Upholstered Skirt

Steel Tube

Mechanism’s

Bayonet Links

Threaded Knob thru large

hole in Bayonet Link

KD Bracket

Bayonet Link

To lock swivel

5566DG Ortho Biotic Clinical Care®Recliner Operating Instructions

Figure 4

Figure 5

To lock wheel

To unlock wheel

Tread Lock Pedal

CASTER OPERATION (FRONT)

NOTE: This chair is equipped with four casters for

improved maneuverability. The front

casters are equipped with tread locks.

To Lock: Step on the back edge of the black

pedal until it latches and stays down.

To Unlock: Step on the top edge of the pedal.

Side Panel

CASTER OPERATION (REAR)

NOTE: The chair is equipped with four casters for

improved maneuverability. Right rear

caster is also equipped with locking

features. Swivel lock will aid the chair in

rolling straight.

Lock: To prevent the rear casters from swiveling

and wheel turning, step on the rear pedal of the

caster until it latches.

Unlock: Step on middle button to unlatch.

TABLE OPERATION

To Raise: Raise table all the way up and slide in

toward the armrest until tabs engage slots in

mount bracket. Press down lightly on table to

ensurelock tabs areengaged.

To Lower: Lift table up until tabs disengage slots

and pull table away from armrest. Lower table to

self-storing position.

SIDE PANEL REMOVAL

ToRemove: Grasp upholstered side panel at

back of panel and pull sharply out from chair

until locking clips release side panel.

To Install: Insert side panel into chair frame by

lining up side panel clips with tubes on frame

and pushing firmly.

Table

(Stored Position)

Table

(Engaged

Position)

Tabs engage into

slots on table

mount bracket

Table Mount

Bracket

3/8 Clevis Pin

Attachment

Armrest

Table

(Disengaged Position)

Drop Arm Pull Button

(Behind Table)

6 566DG Ortho Biotic Clinical Care®Recliner Operating Instructions

SEAT POSITIONING

Reclining by Patient: Place hands on armrest

and push body against chair's back to recline

yourself to desired position. To bring yourself

up, place hands on armrest and pull yourself up

while leaning your body forward away from the

chairs back.

Reclining by Attendant: Standing on either side

of the chair, grasp the armrest with one hand

and push handle with the other hand. Push back

on push handle to recline and pull forward to

raise the chair.

Upright Position

TV Position

TrendelenburgPosition

Infinite Position Between TV and Full Recline

TRENDELENBURG POSITION:

Standing on either side of the chair, grasp the

armrest with one hand while holding the recliner

back with the other. With your foot, push down

on the release bar while gently pushing down

with your hand on the recliners back until it

comes to a stop. To bring chair out of

Trendelenburg, stand on either side of the chair,

grasp the armrest with one hand and push

handle with the other hand and pull forward on

the push handle.

NOTES

U.S.A., Corporate Headquarters:

Graham-Field Health Products

2935 Northeast Parkway

Atlanta, Georgia 30360

telephone: 800-347-5678, 770-447-1609

fax: 800-726-0601, 678-291-3232

http://www.grahamfield.com