MSA Innovation FPAW44 M2M Gateway User Manual

Sierra Monitor Corporation M2M Gateway

User Manual

FPA-W44 1/ 15 FPA-W44User’sManualM 2M G a t ew a y
FPA-W44 2/ 15 SierraMonitorCorporationRevisionHistory:No.VersionDescriptionDate1V1.0Initial Version2017.08.282V1.1Modify 2017.09.073V2.0Update productpictures2018.02.124V2.1AppendFCC,ISEDwarning 2018.03.29
FPA-W44 3/ 15 TableofContents1.Foreword................................................................................................................................41.1CopyrightNotice........................................................................................................................41.2Notes..........................................................................................................................................41.3Statement..................................................................................................................................41.4Disclaimer..................................................................................................................................41.5LimitationofLiability/Non‐warranty.........................................................................................51.6SafetyInstructions.....................................................................................................................51.7Precautions................................................................................................................................51.8SafetyInstructionsforPowerCablesandAccessories...............................................................52.Overview................................................................................................................................72.1Introduction...............................................................................................................................73.FPA‐W44,FPC‐N54HardwareInstructions..............................................................................83.1ProductAppearance..................................................................................................................83.2InterfaceDescription.................................................................................................................93.2.1PowerInterface..........................................................................................................93.2.2EthernetInterface......................................................................................................93.2.3RS232orRS485Connector.......................................................................................103.2.4RS485Connector......................................................................................................103.2.5BootConfiguration...................................................................................................113.2.6LED............................................................................................................................113.2.7DEBUG......................................................................................................................123.2.8Renewbutton...........................................................................................................123.2.9SD/MMCsocket........................................................................................................124.Tips......................................................................................................................................13
FPA-W44 4/ 15 1. Foreword1.1CopyrightNoticeWhileallinformationcontainedhereinhavebeencarefullycheckedtoassureitsaccuracyintechnicaldetailsandprinting,SierraMonitorCorporationassumesnoresponsibilityresultingfromanyerrororfeaturesofthismanual,orfromimproperusesofthismanualorthesoftware.Pleasecontactourtechnicaldepartmentforrelevantoperationsolutionsifthereisanyproblemthatcannotbesolvedaccordingtothismanual.SierraMonitorCorporationreservesallrightsofthismanual,includingtherighttochangethecontent,form,productfeatures,andspecificationscontainedhereinatanytimewithoutpriornotice.PleasecontactSierraMonitorCorporationforfurtherinformation:US Office: Sierra Monitor Corporation Address: 1991 Tarob Court, Milpitas CA 95035-6840, UNITED STATES Tel: +1 408 964-4447 Fax: +1 408 262-9042Thetrademarksandregisteredtrademarksinthismanualarepropertiesoftheirrespectiveowners.Nopartofthismanualmaybecopied,reproduced,translatedorsold.NochangesorotherpurposesarepermittedwithoutthepriorwrittenconsentofSierraMonitorCorporation.SierraMonitorCorporationreservestherightofallpublicly‐releasedcopiesofthismanual.1.2NotesApplicablenotesarelistedinthefollowingtable:SignNoticeTypeDescriptionNoticeImportantinformationandregulationsCautionCautionforlatentdamagetosystemorharmtopersonnel1.3StatementItisrecommendedtoreadandcomplywiththismanualbeforeoperatingFPA‐W44andFPC‐N54whichprovidesimportantguidanceandhelpsdecreasingthedangerofinjury,electricshock,fire,oranydamagetothedevice.1.4DisclaimerSierraMonitorCorporationassumesnolegalliabilityofaccidentsresultingfromfailureofconformingto
FPA-W44 5/ 15 thesafetyinstructions.1.5LimitationofLiability/Non‐warrantyFordirectorindirectdamagetothisdeviceorotherdevicesofSierraMonitorCorporationcausedbyfailureofconformingtothismanualorthesafetyinstructionsondevicelabel,SierraMonitorCorporationassumesneitherwarrantynorlegalliabilityevenifthedeviceisstillunderwarranty.TheFPA‐W44andFPC‐N54shouldbeinstalled,debuggedandmaintainedbyprofessionalpeople.Theoutsideantennasarenotpermittedtobeinstalledortobechangedbynon‐professionalpeople.Torunthedevicenormally,onlyspecifyantennasareapprovedtobeassembledtogetherbyprofessionalpeople.Unitshallbeusedwithindoor‐useantennaonly.Noantennaforthisunitcanbeinstalledoutdoor.1.6SafetyInstructions Keepandcomplywithalloperationinstructions,warnings,andinformation. Payattentiontowarningsonthisdevice. Readthefollowingprecautionssoastodecreasethedangerofinjury,electricshock,fire,oranydamagetothedevice. 1.7Precautions Payattentiontotheproductlabels/safetyinstructionsprintedonsilkscreens. Donottryrepairingthisproductunlessdeclaredinthismanual. Keepawayfromheatsource,suchasheater,heatdissipater,orenginecasing. Donotinsertotheritemsintotheslot(ifany)ofthisdevice.•Keeptheventilationslotventilatedforcooling.•Systemfaultmayariseifotheritemsareinsertedintothisdevice. Installation:ensurecorrectinstallationaccordingtoinstructionsfromthemanufacturerwithrecommendedinstallationtools. Ensureventilationandsmoothnessaccordingtorelevantventilationstandard.1.8SafetyInstructionsforPowerCablesandAccessoriesProperpowersourceonlyStartonlywithpowersourcethatsatisfiesvoltagelabelandthevoltagenecessaryaccordingtothismanual.PleasecontacttechnicalsupportpersonnelofSierraMonitorCorporationforanyuncertaintyabouttherequirementsofnecessarypowersource.UsetestedpowersourceThisproductstillcontainsabuttonlithiumbatteryasareal‐timeclockafteritsexternalpowersourceis
FPA-W44 6/ 15 removedandthereforeshouldnotbeshort‐circuitedduringtransportationorplacedunderhightemperature.Placecablesproperly:Donotplacecablesatanyplacewithextrusiondanger.CleaningInstructions Pleasepoweroffbeforecleaningthedevice. Donotusespraydetergent. Cleanwithadampcloth. Donottrycleaningexposedelectroniccomponentsunlesswithadustcollector. Supportforspecialfault:PoweroffandcontacttechnicalsupportpersonnelofSierraMonitorCorporationincaseofthefollowingfaults: Thedeviceisdamaged. Thetemperatureisexcessivelyhigh. Faultisstillnotsolvedaftertheoperationaccordingtothemanual.
FPA-W44 7/ 15 2. Overview2.1IntroductionThankyouforchoosingSierraMonitorCorporation.Itisourcommitmenttoprovideourvaluedcustomerswiththeembeddeddevicesequippedwiththestate‐of‐the‐arttechnologyandthebestproductservices.SierraMonitorCorporation’sM2MproductsarebasedonthemostadvancedARMandIntelAtomprocessorsandhavelow‐powerconsumptionandhighintegration.TheproductsaredesignedforapplicationsofM2Minindustrials,financial,retail,vehicle,andtransportationsetc.
FPA-W44 8/ 15 3. FPA‐W44,HardwareInstructions3.1ProductAppearanceFrontSideViewRightSideView LeftSideView
FPA-W44 9/ 15 3.2InterfaceDescription3.2.1PowerInterface PowerconnectoroutlookPinDescription1PowerinputrangeDC9‐36VorAC24VL2DCGroundorAC24VN3Shellground 3.2.2EthernetInterfaceStandardRJ45interface,supporting10M/100MFull/HalfDuplex,thisisastandardRJ45Ethernetport PinDescriptionRemarks1ETH_TX+O2ETH_TX‐ O3ETH_RX+I4ETH_RX‐ I5ETH_CT6ETH_CT7NC8DGNDP9LEDG+IO10LEDG‐ IO11LEDG+12LEDG‐  PIN1
FPA-W44 10/ 15 3.2.3RS232orRS485ConnectorStandardvertical1x3x3.81mmmaleTerminalBlock. PinDescriptionRemarks1TXD1orRS485_AIO2RXD1orRS485_BIO3GND DIP Switch for select BitDescriptionSingle1ON:havematchedresistanceof120ohmOFF:havenoTerm2ON:havepullupresisterof510ohmOFF:havenoBias‐3ON:havepulldownresisterof510ohmOFF:havenoBias+4ON:selectRS232OFF:selectRS485SelectRS232orRS485 3.2.4RS485ConnectorStandardvertical1x3x3.81mmmaleTerminalBlock. PinDescriptionRemarks1RS485_AIO2RS485_BIO3GND
FPA-W44 11/ 15 DIP Switch for select BitDescriptionSingle1ON:havematchedresistanceof120ohmOFF:havenoTerm2ON:havepullupresisterof510ohmOFF:havenoBias‐3ON:havepulldownresisterof510ohmOFF:havenoBias+ 3.2.5BootConfiguration SHORT: BootfromNANDOPEN:BootfromSD/MMC 3.2.6LEDPWR LED: lighting indicate system power Okay(main power up); OFF indicate system power turn offErrLED: User can define it. SS LED: User can define it. TX LED: when UART2 send data, TX1 can blink; when UART4 send data, TX2 can blink. RX LED: when UART2 receive data, RX1 can blink; when UART4 receive data, RX2 can blink. Boot Configuration
FPA-W44 12/ 15 3.2.7DEBUGCONN,Pinheader,1x4x2.0,TH,Usercanshowthedebugmessageandusekeyboardinputdebugcommand.It’sTTLlevel,weneedaUart‐debugboardwhenweuseit. PinDescription13.3V2TTL_TXD3TTL_RXD4DGND3.2.8RenewbuttonRenew button: long press this button will restore the factory setting, the long press time can be setting by user 3.2.9SD/MMCsocketThis is standard SD card socket, user can save data on this storage. PIN1
FPA-W44 13/ 15 4. TipsWasteDisposalItisrecommendedtodisassemblethedevicebeforeabandoningitinconformitywithlocalregulations.Pleaseensurethattheabandonedbatteriesaredisposedaccordingtolocalregulationsonwastedisposal.Donotthrowbatteriesintofire(explosive)orputincommonwastecanister.Productsorproductpackageswiththesignof“explosive”shouldnotbedisposedlikehouseholdwastebutdeliveredtospecializedelectrical＆electronicwasterecycling/disposalcenter.Properdisposalofthissortofwastehelpsavoidingharmandadverseeffectuponsurroundingsandpeople’shealth.Pleasecontactlocalorganizationsorrecycling/disposalcenterformorerecycling/disposalmethodsofrelatedproducts.Complywiththefollowingsafetytips:DonotuseincombustibleandexplosiveenvironmentKeepawayfromcombustibleandexplosiveenvironmentforfearofdanger.Keepawayfromallenergizedcircuits.Operatorsshouldnotremoveenclosurefromthedevice.Onlythegrouporpersonwithfactorycertificationispermittedtoopentheenclosuretoadjustandreplacethestructureandcomponentsofthedevice.Donotchangecomponentsunlessthepowercordisremoved.Insomecases,thedevicemaystillhaveresidualvoltageevenifthepowercordisremoved.Therefore,itisamusttoremoveandfullydischargethedevicebeforecontactsoastoavoidinjury.Unauthorizedchangestothisproductoritscomponentsareprohibited.Intheaimofavoidingaccidentsasfaraspossible,itisnotallowedtoreplacethesystemorchangecomponentsunlesswithpermissionandcertification.PleasecontactthetechnicaldepartmentofSierraMonitorCorporationorlocalbranchesforhelp.Payattentiontocautionsigns.Cautionsignsinthismanualremindofpossibledanger.Pleasecomplywithrelevantsafetytipsbeloweachsign.Meanwhile,youshouldstrictlyconformtoallsafetytipsforoperationenvironment.NoticeConsideringthatreasonableeffortshavebeenmadetoassureaccuracyofthismanual,SierraMonitorCorporationassumesnoresponsibilityofpossiblemissingcontentsandinformation,errorsincontents,citations,examples,andsourceprograms.SierraMonitorCorporationreservestherighttomakenecessarychangestothismanualwithoutpriornotice.NopartofthismanualmaybereprintedorpubliclyreleasedinforFCCWarningThis device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions:
FPA-W44 14/ 15  Thisdevicemaynotcauseharmfulinterference.Thisdevicemustacceptanyinterferencereceived,includinginterferencethatmaycauseundesiredoperation.Note:ThisequipmenthasbeentestedandfoundtocomplywiththelimitsforaClassBdigitaldevice,pursuanttopart15oftheFCCRules.Theselimitsaredesignedtoprovidereasonableprotectionagainstharmfulinterferenceinaresidentialinstallation.Thisequipmentgenerates,usesandcanradiateradiofrequencyenergyand,ifnotinstalledandusedinaccordancewiththeinstructions,maycauseharmfulinterferencetoradiocommunications.However,thereisnoguaranteethatinterferencewillnotoccurinaparticularinstallation.Ifthisequipmentdoescauseharmfulinterferencetoradioortelevisionreception,whichcanbedeterminedbyturningtheequipmentoffandon,theuserisencouragedtotrytocorrecttheinterferencebyoneormoreofthefollowingmeasures:—Reorientorrelocatethereceivingantenna.—Connecttheequipmentintoanoutletonacircuitdifferentfromthattowhichthereceiverisconnected.—Consultthedealeroranexperiencedradio/TVtechnicianforhelp.ICstatementDisclaimer:        (1)Thisdevicemaynotcauseinterference,and(2)Thisdevicemustacceptanyinterference,includinginterferencethatmaycauseundesiredoperationofthedevice.Warning！ThisclassBdigitalapparatuscomplieswithCanadianICES‐003.IndustryCanadaICES‐003ComplianceLabel: CANICES‐3(B)/NMB‐3(B)Le présent appareil est conforme aux CNR d'Industrie Canada applicables aux appareils radio exempts. L'exploitation est autorisée aux deux conditions suivantes : (1) l'appareil ne doit pas produire de brouillage, et (2) l'utilisateur de l'appareil doit accepter tout brouillage radioélectrique subi, même si le brouillage est susceptible d'en compromettre le fonctionnement. Any changes or modifications to this unit not expressly approved by the party responsible for compliancecould void the user's authority to operate the equipment.This device complies with Industry Canada’s licence-exempt RSSs. Operation is subject to the followingtwo conditions:This radio transmitter [IC: 21758-FPAW44] has been approved by Innovation, Science and EconomicDevelopment Canada to operate with the antenna types listed below, with the maximum permissiblegain indicated. Antenna types not included in this list that have a gain greater than the maximumgain indicated for any type listed are strictly prohibited for use with this device.No. Antenna Type Gain Impedance1 External uniqueness Antenna 3dBi 50ohm
FPA-W44 15/ 15 RFexposurewarningThisequipmentmustbeinstalledandoperatedinaccordancewithprovideinstructionsandtheantennausedforthistransmittermustbeinstalledtoprovideaseparationdistanceofatleast20cmfromallpersonsandmustnotbeco‐locatedoroperationinconjunctionwithanyotherantennaortransmitter.End‐usersandinstallersmustbeprovidewithantennainstallationinstructionsandtransmitteroperatingconditionsforsatisfyingRFexposurecompliance.Sierra Monitor Corporation, Model: FPA-W44, Product name: M2M Gateway, uses installable external antennas for WLAN wireless communication. The interface type of the antenna is male and on the devices the interface type to the corresponding SMA sockets is female. The manufacturer of the models is Sierra Monitor Corporation. The device must be professionally installed. Antennas to the devices can be swapped but the antenna must be provided by the manufacturer Sierra Monitor Corporation, for ensuring that the proper antennas are employed.ForproductcompliancetestFCCandIC,allthetechnicaldocumentationissubmittedbythefactoryChengduVantronTechnology,Ltd.,andSierraMonitorCorporationisthecustomerorimporteroftheproductFPA‐W44andFPC‐N54.Product Name: M2M Gateway, Model: FPA-W44 FCC ID: 2AIVJ-FPAW44 US Office: Sierra Monitor Corporation Address: 1991 Tarob Court, Milpitas CA 95035-6840, UNITED STATES Tel: +1 408 964-4447 Fax: +1 408 262-9042 

Navigation menu