2014 Wildcat Trail Service
User Manual: Manual
Open the PDF directly: View PDF
Page Count: 168 [warning: Documents this large are best viewed by clicking the View PDF Link!]
- FRONT COVER
- FOREWORD
- TABLE OF CONTENTS
- General Information
- Periodic Maintenance/ Tune-Up
- Steering/Frame/Controls
- Engine
- SPECIAL TOOLS
- Troubleshooting
- Removing Engine
- Top-Side Components
- Removing Top-Side Components
- Servicing Top-Side Components
- MEASURING VALVE/TAPPET CLEARENCE
- Cleaning/Inspecting Valve Cover
- VALVE ASSEMBLY
- Removing Valves
- Measuring Valve Guide (Bore)
- Installing Valves
- PISTON ASSEMBLY
- Removing Piston Rings
- Inspecting Piston
- Measuring Piston-Ring End Gap (Installed)
- Measuring Piston Pin (Outside Diameter) and Piston Pin Bore
- Measuring Connecting Rod (Small End Bore)
- Measuring Piston/Cylinder Clearance
- Installing Piston Rings
- CYLINDER/CYLINDER HEAD ASSEMBLY
- Cleaning/Inspecting Cylinder Head
- Measuring Cylinder Head Distortion
- Cleaning/Inspecting Cylinder
- Inspecting Cam Chain Guide
- Measuring Camshaft Runout
- Measuring Camshaft Lobe Height
- Inspecting Camshaft Bearing Journal
- Installing Top-Side Components
- Bottom-Side Components
- Removing Bottom-Side Components
- Servicing Bottom-Side Components
- Installing Bottom-Side Components
- Servicing Left-Side Components
- Installing Engine
- Fuel/Lubrication/Cooling
- Electrical System
- SPECIAL TOOLS
- TESTING ELECTRICAL COMPONENTS
- Battery
- Accessory Receptacle/ Connector
- Brakelight Switch
- Engine Coolant Temperature (ECT) Sensor
- Fan Motor
- Power Distribution Module (PDM)
- Ignition Coils
- EFI Sensors/Components
- Speed Sensor
- Ignition Switch
- Headlight Switch
- Drive Select Switch
- Reverse Override Switch
- Front Drive Actuator
- Stator Coil
- Starter Motor
- Starter Relay
- Engine Control Module (ECM)
- Regulator/Rectifier
- Headlights
- Taillight-Brakelight
- Tilt Sensor
- Throttle Position Sensor (TPS)
- EFI Diagnostic System
- RPM Limiter
- Drive and Brake Systems
- C. Carrier bearing smooth rotation and bearing support tight.
- GENERAL INFORMATION
- SPECIAL TOOLS
- Front Drive Actuator
- Front Differential
- Drive Axles
- Transaxle
- REPLACING SEALS
- Output (Axle) Seals
- Input (Driven Clutch) Seal
- Front Output Seal
- Pinion Plug
- REMOVING
- SEPARATING HALVES
- DISASSEMBLING HALVES
- SERVICING COMPONENTS
- A. Output Gear
- B. Intermediate Shaft
- C. Shift Shaft Rail
- D. Shift Shaft
- E. Idler Shaft
- F. Shift Drum
- G. Reverse Shaft
- H. Input Shaft
- K. Pinion Assembly
- BACKLASH
- ASSEMBLING HALVES
- INSTALLING
- Driveshaft/Carrier Bearing
- Hub
- Hydraulic Brake Caliper
- Master Cylinder Assembly
- Troubleshooting
- Suspension
- BACK COVER