DATASHEET SURGELOGIC SPD (ANSI/IEEE PERFORMANCE ING) 565797 Catalog 1
114401-Catalog 114401-Catalog 114401-Catalog 785901 Batch7 unilog cesco-content
658815-Catalog 658815-Catalog 658815-Catalog 785901 Batch5 unilog cesco-content
2014-07-05
: Pdf 565797-Catalog 1 565797-Catalog_1 785901 Batch5 unilog
Open the PDF directly: View PDF 
.
Page Count: 14
| Download | |
| Open PDF In Browser | View PDF |
ANSI/IEEE Performance Testing Surgelogic® Surge Protective Devices (SPDs) ANSI/IEEE C62.41.1, C62.41.2 & C62.45 Surge Performance Testing Test performance values contained within this document are representative of Square D® brand Surgelogic Surge Protective Devices (SPDs) when tested in accordance with the waveforms as defined in the ANSI/IEEE C62.41.2 – 1991 and 2002 standards. The testing was conducted inside the Schneider Electric industry certified surge laboratory. Standard testing processes and procedures were followed. The representative unit from each group (listed in italics) was tested in all of its modes of operation (L-N, L-G, N-G, L-L) and the let-through voltage recorded for each of the modes. The tables in this document provide these measured let-through values. The actual plots can be provided upon request. 1 ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices TEST SETUP AND INFORMATION Connection • All integral and external panel type products (IMA, EMA, EBA) were connected using #6 AWG wire. • Hard-Wired Assembly (HWA) products were connected using #10 AWG wire. Surge Injection Phase Angle The transient was injected at the 90° point of the sine wave unless otherwise noted. Dynamic Testing All testing was dynamic, applying the respective nominal system voltages. Measurements Measurements were taken with: • 6” of lead outside the panels for external type products (EMA, EBA) • 6” of lead from the nipple for the hard wired type products (HWA) • Backplane connection points for the Internal/ Integral (IMA) products Table 1: Standard 0.5 micro second – 100 kHz Ring Wave 2 Let-Through Values • Recorded let-through values are the averaged value across the similar modes of a 3-phase system +/-10%. ( L-N = Ave(L1L2L3–N), L-G = Ave(L1L2L3-G), L-L = Ave(L1L2, L2L3, L1L3) • All let-through values are peak values referenced from the zero reference point or zero crossing (See Fig. 1). Note The voltage peak to which an SPD limits an incoming surge has been given or has taken on many different names, including: clamping voltage, surge residual, surge remnant, protection level, let through voltage and Voltage Protection Level (VPR). Even though all these terms are technically correct it is important when making any product comparison to understand how a manufacturer may be representing their performance numbers. Table 2: Standard 1.2/50 micro second – 8/20 micro second Combination Wave Category Peak Voltage (kV) Peak Current (kA) Effective A1* 2 0.067 30 Ohms A 6 0.2 30 Ohms B 6 0.5 12 Ohms Category C Voltage Peak (kV) Peak Current (kA) C (low) 6 (Minimum) 3 (Actual) C (high)* 10 (Minimum) 10 (Actual) *C (high) impulse testing was conducted at 20 kV, 10 kA *A1-Ringwave used on sine wave tracking systems only Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Figure 2 © 20010 Schneider Electric. All rights reserved. Figure 1 Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices Let-Through Definition For the purpose of this document we have also introduced the term “True Let-Through” (see Figure 3). True Let-Through we have defined as the amount of surge voltage above the nominal system voltage. If this value is needed for specification purposes it can be easily obtained by a simple calculation: 3 Figure 3 TLTV=LTV-Vnom LTV – Let-Through Voltage TLTV – True Let-Through Voltage Vnom – Peak value of the nominal AC voltage Example An SPD used in a 120 Vac system with a Let-Through voltage of 370 Vac will have a “True Let-Through” voltage of: 370(LTV) – 170(Vnom) = 200 V. CONTACT INFORMATION For additional information or supporting documentation regarding these tests please contact the Surgelogic Technical Assistance Group. Telephone: (800) 577-7353 Email: tvsstag@us.schneider-electric.com Manufacturer Description Model Serial # Last Cal. Cal. Due Tektronix Oscilloscope TDS3054B B010034 3-24-2010 3-24-2011 Tektronix High Voltage Probe P0615A B050063 3-24-2010 3-24-2011 Tektronix High Voltage Probe P0615A B050064 3-23-2010 3-23-2011 Pearson Current Transformer 101 108855 6-22-2010 6-22-2011 Pearson Current Transformer 101 108856 7-19-2010 7-19-2011 Fluke Digital Multi-meter 175 78590012 4-25-2010 4-25-2011 Haefley Surge Generator 20430 Calibrated before each use Haefley Surge Generator P-8000 Calibrated before each use Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Telephone: (801) 976-9009 © 20010 Schneider Electric. All rights reserved. Table 3: Test Equipment Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 4 Internal/integral Models (ima Series) Voltages measured at the backplane Table 4: 120/240V and 208Y/120V 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz L-N L-G N-G 369 375 399 Category B Ringwave (6 kV, 500 A) 100 kHz L-L Internal L-N L-G N-G 420 428 455 L-L Category C (low) Impulse (6 kV, 3 kA) L-N L-G N-G 429 428 468 L-L Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G 607 627 650 (panelboards/switchboards/ switchgear) I-Line Plug-on QMB Plug-on MCC Busway TVS1IMA12 TVS1IMA16 TVS1IMA24 TVS2IMA12 TVS2IMA16 TVS2IMA24 HL1IMA12 HL1IMA16 HL1IMA24 HL2IMA12 HL2IMA16 HL2IMA24 FI1IMA12 FI1IMA16 FI1IMA24 FI2IMA12 FI2IMA16 FI2IMA24 QMB2IMA12 QMB2IMA16 QMB2IMA24 MCC2IMA12 MCC2IMA16 MCC2IMA24 PIU2IMA12 PIU2IMA16 PIU2IMA24 L-L Table 5: 120/240V and 208Y/120V 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 384 387 355 670 408 392 391 723 427 416 407 743 583 520 523 863 Internal (panelboards/switchboards/ switchgear) TVS1IMA32 TVS1IMA48 TVS2IMA36 TVS2IMA48 Table 6: 240/120V High-leg Delta 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages L-N L-G N-G 369 375 668 655 Category B Ringwave (6 kV, 500 A) 100 kHz L-L L-N L-G N-G 355 420 428 355 783 703 L-L Category C (low) Impulse (6 kV, 3 kA) L-N L-G N-G 391 429 428 391 767 763 L-L Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G 407 607 627 523 407 990 990 523 L-L © 20010 Schneider Electric. All rights reserved. Category A Ringwave (6 kV, 200 A) 100 kHz Row 1 = 120 V leg, Row 2 = 240 V leg Internal (panelboards/switchboards/ switchgear) I-Line Plug-on QMB Plug-on MCC Busway TVS3IMA12 TVS3IMA16 TVS3IMA24 HL3IMA12 HL3IMA16 HL3IMA24 FI3IMA12 FI3IMA16 FI3IMA24 QMB3IMA12 QMB3IMA16 QMB3IMA24 MCC3IMA12 MCC3IMA16 MCC3IMA24 PIU3IMA12 PIU3IMA16 PIU3IMA24 Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 5 Internal/integral Models (ima Series) Table 7: 240/120V High-leg Delta 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 384 387 356 670 408 392 400 723 427 416 423 743 583 520 523 863 635 628 356 903 683 680 400 945 727 707 423 1008 873 890 523 1070 Row 1 = 120 V leg, Row 2 = 240 V leg Internal (panelboards/switchboards/ switchgear) TVS3IMA32 TVS3IMA48 Table 8: 480Y/277V 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz L-N L-G N-G 780 773 793 Category B Ringwave (6 kV, 500 A) 100 kHz L-L Internal L-N L-G N-G 823 827 780 L-L Category C (low) Impulse (6 kV, 3 kA) L-N L-G N-G 913 880 930 L-L Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G 1057 1070 1160 (panelboards/switchboards/ switchgear) I-Line Plug-on QMB Plug-on MCC Busway TVS4IMA12 TVS4IMA16 TVS4IMA24 HL4IMA12 HL4IMA16 HL4IMA24 FI4IMA12 FI4IMA16 FI4IMA24 QMB4IMA12 QMB4IMA16 QMB4IMA24 MCC4IMA12 MCC4IMA16 MCC4IMA24 PIU4IMA12 PIU4IMA16 PIU4IMA24 L-L Table 9: 480Y/277V 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 750 757 793 1390 823 807 893 1450 853 853 887 1523 997 963 937 1693 Internal © 20010 Schneider Electric. All rights reserved. (panelboards/switchboards/ switchgear) TVS4IMA32 TVS4IMA48 Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 6 Internal/integral Models (ima Series) Table 10: 600Y/347 V 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz L-N L-G N-G 983 970 1043 Category B Ringwave (6 kV, 500 A) 100 kHz L-L Internal L-N L-G N-G 1053 1080 1107 L-L Category C (low) Impulse (6 kV, 3 kA) L-N L-G N-G L-L 1093 1113 1173 Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G 1327 1327 1437 (panelboards/switchboards/ switchgear) I-Line Plug-on QMB Plug-on MCC Busway TVS8IMA12 TVS8IMA16 TVS8IMA24 FI8IMA12 FI8IMA16 FI8IMA24 QMB8IMA12 QMB8IMA16 QMB8IMA24 MCC8IMA12 MCC8IMA16 MCC8IMA24 PIU8IMA12 PIU8IMA16 PIU8IMA24 L-L Table 11: 600Y/347V 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 960 973 887 1793 977 1003 920 1813 1040 1083 1050 1930 1210 1197 1070 2167 Internal (panelboards/switchboards/ switchgear) Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A © 20010 Schneider Electric. All rights reserved. TVS8IMA32 TVS8IMA48 Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 7 External panel mount Models (ema, eba Series) Voltages measured with 6 inches of lead outside housing Table 12: 120/240V and 208Y/120V 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 489 496 457 833 640 679 633 993 605 621 600 943 1090 1057 1023 1640 TVS1EMA12A TVS1EMA16A TVS1EMA24A TVS1EBA12A TVS1EBA16A TVS1EBA24A TVS2EMA12A TVS2EMA16A TVS2EMA24A TVS2EBA12A TVS2EBA16A TVS2EBA24A Table 13: 120/240 V and 208Y/120V 120 kA - 240 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 523 543 505 873 740 783 740 1067 673 678 667 997 1527 1497 1467 1993 TVS1EMA12AI TVS1EMA16AI TVS1EMA24AI TVS1EBA12AI TVS1EBA16AI TVS1EBA24AI TVS2EMA12AI TVS2EMA16AI TVS2EMA24AI TVS2EBA12AI TVS2EBA16AI TVS2EBA24AI Table 14: 120/240 V and 208Y/120V 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 513 533 425 817 720 760 700 1007 663 639 619 950 1417 1257 1283 1743 TVS1EMA32A TVS1EMA48A TVS2EMA32A TVS2EMA48A Table 15: 120/240 V and 208Y/120V 320 kA - 480 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 556 556 465 867 850 840 747 1107 737 743 677 1043 1680 1713 1543 2037 TVS1EMA32AI TVS1EMA48AI TVS2EMA32AI TVS2EMA48AI Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A © 20010 Schneider Electric. All rights reserved. Category A Ringwave (6 kV, 200 A) 100 kHz Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 8 External panel mount Models (ema, eba Series) Table 16: 240/120V High-leg Delta 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 489 496 457 833 640 679 633 993 605 621 600 943 1090 1057 1023 1640 757 773 485 1083 960 1027 677 1290 927 937 623 1250 1577 1610 1270 1905 Row 1 = 120 V leg, Row 2 = 240 V leg TVS3EMA12A TVS3EMA16A TVS3EMA24A TVS3EBA12A TVS3EBA16A TVS3EBA24A Table 17: 240/120V High-leg Delta 120 kA - 240 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 523 543 505 873 740 783 740 1067 673 678 667 997 1527 1497 1467 1993 867 870 573 965 1147 1167 843 1402 1057 1070 757 1315 2030 2000 1693 2220 Row 1 = 120 V leg, Row 2 = 240 V leg TVS3EMA12AI TVS3EMA16AI TVS3EMA24AI TVS3EBA12AI TVS3EBA16AI TVS3EBA24AI Table 18: 240/120V High-leg Delta 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 513 533 425 817 720 760 700 1007 663 639 619 950 1417 1257 1283 1743 800 817 493 1075 1050 1080 813 1325 987 993 700 1258 1987 1920 1530 1987 Row 1 = 120 V leg, Row 2 = 240 V leg TVS3EMA32A TVS3EMA48A Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) © 20010 Schneider Electric. All rights reserved. Table 19: 240/120V High-leg Delta 320 kA - 480 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 556 556 465 867 850 840 747 1107 737 743 677 1043 1680 1713 1543 2037 860 853 507 1093 1173 1160 840 1405 1063 1053 737 1300 2230 2280 1797 2287 Row 1 = 120 V leg, Row 2 = 240 V leg TVS3EMA32AI TVS3EMA48AI Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 9 External panel mount Models (ema, eba Series) Table 20: 480Y/277V 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 840 857 860 1550 997 1013 1043 1727 997 1007 973 1723 1673 1660 1623 2513 TVS4EMA12A TVS4EMA16A TVS4EMA24A TVS4EBA12A TVS4EBA16A TVS4EBA24A Table 21: 480Y/277V 120 kA - 240 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 900 897 807 1603 1117 1040 970 1823 1060 1057 1030 1797 1990 1997 1950 2833 TVS4EMA12AI TVS4EMA16AI TVS4EMA24AI TVS4EBA12AI TVS4EBA16AI TVS4EBA24AI Table 22: 480Y/277V 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 840 850 807 1550 1093 1063 1030 1793 1023 1017 917 1707 1917 1777 1640 2613 TVS4EMA32A TVS4EMA48A Table 23: 480Y/277V 320 kA - 480 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 937 973 883 1590 1193 1233 1147 1817 1093 1130 1050 1777 2230 2317 2133 2813 © 20010 Schneider Electric. All rights reserved. Category A Ringwave (6 kV, 200 A) 100 kHz TVS4EMA32AI TVS4EMA48AI Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 10 External panel mount Models (ema, eba Series) Table 24: 600Y/347V 120 kA - 240 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 1100 1107 1090 1967 1323 1327 1267 2180 1233 1260 1197 2167 1947 1953 1870 2967 TVS8EMA12A TVS8EMA16A TVS8EMA24A TVS8EBA12A TVS8EBA16A TVS8EBA24A Table 25: 600Y/347V 120 kA - 240 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 1167 1160 1130 2000 1397 1400 1353 2233 1350 1327 1287 2203 2373 2307 2147 3313 TVS8EMA12AI TVS8EMA16AI TVS8EMA24AI TVS8EBA12AI TVS8EBA16AI TVS8EBA24AI Table 26: 600Y/347V 320 kA - 480 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 1123 1130 1013 1937 1323 1343 1263 2127 884 1267 1247 2107 2227 2073 1913 3027 TVS8EMA32A TVS8EMA48A Table 27: 600Y/347V 320 kA - 480 kA with Integral Switch IEEE C62.41.2-2002 Waveform Let-Through Voltages Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 1137 1160 1050 1960 1433 1460 1343 2200 1340 1347 2187 1303 2387 2407 2207 3267 © 20010 Schneider Electric. All rights reserved. Category A Ringwave (6 kV, 200 A) 100 kHz TVS8EMA32AI TVS8EMA48AI Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 11 External panel mount 10-mode Models (Mema Series) Voltages measured with 6 inches of lead outside housing Table 28: 208Y/120V 120 kA - 360 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 591 597 520 850 833 860 707 1057 730 733 617 953 1757 1647 1380 1750 TVS2MEMA12A TVS2MEMA18A TVS2MEMA27A TVS2MEMA36A Table 29: 208Y/120V 120 kA - 360 kA with Sine Wave Tracking IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 427 520 520 547 677 733 707 807 707 733 617 980 1717 1647 1380 1750 TVS2MEMA12ASWT TVS2MEMA18ASWT TVS2MEMA27ASWT TVS2MEMA36ASWT Table 30: 208Y/120V 120 kA - 360 kA with Sine Wave Tracking IEEE C62.41.2 A1 Ringwave (100 kHz) 2 kV, 67A @ 90° 2 kV, 67A @ 180° 2 kV, 67A @ 270° L-N L-G N-G L-L L-N L-G 88 85 88 81 88 85 Values shown in Table 30 reference true let-through Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A © 20010 Schneider Electric. All rights reserved. TVS2MEMA12ASWT TVS2MEMA18ASWT TVS2MEMA27ASWT TVS2MEMA36ASWT Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 12 External panel mount 10-mode Models (Mema Series) Voltages measured with 6 inches of lead outside housing Table 31: 480Y/277V 120 kA - 360 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 923 947 880 1390 1157 1140 1060 1647 1130 1093 1000 1643 2173 2107 1840 2560 TVS4MEMA12A TVS4MEMA18A TVS4MEMA27A TVS4MEMA36A Table 32: 480Y/277V 120 kA - 360 kA with Sine Wave Tracking IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 690 947 880 917 997 810 1060 1177 1070 1093 1000 1693 2160 2107 1840 2587 TVS4MEMA12ASWT TVS4MEMA18ASWT TVS4MEMA27ASWT TVS4MEMA36ASWT Table 33: 480Y/277V 120 kA - 360 kA with Sine Wave Tracking IEEE C62.41.2 A1 Ringwave (100 kHz) 2 kV, 67A @ 90° 2 kV, 67A @ 180° 2 kV, 67A @ 270° L-N L-G N-G L-L L-N L-G 88 80 85 80 87 81 Values shown in Table 30 reference true let-through Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A © 20010 Schneider Electric. All rights reserved. TVS4MEMA12ASWT TVS4MEMA18ASWT TVS4MEMA27ASWT TVS4MEMA36ASWT Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 13 hardwire nipple models (hwa Series) Voltages measured with 6 inches of lead Table 34: 120/240V and 208Y/120V 50 kA - 100 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 423 547 512 797 680 843 743 1070 923 1143 673 1317 1813 2093 1370 2193 TVS1HWA50X TVS1HWA80X TVS1HWA10X TVS2HWA50X TVS2HWA80X TVS2HWA10X Table 35: 240/120V High-leg Delta 50 kA - 100 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 423 547 512 797 680 843 743 1070 923 1143 673 1317 1813 2093 1370 2193 577 635 515 877 870 980 720 1250 1183 1490 1603 673 2127 2393 1347 2467 Row 1 = 120 V leg, Row 2 = 240 V leg TVS3HWA50X TVS3HWA80X TVS3HWA10X Table 36: 480Y/277V 50 kA - 100 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 663 960 887 1163 890 1327 1073 1660 1217 2020 1037 2100 2207 3007 1827 3173 TVS4HWA50X TVS4HWA80X TVS4HWA10X Category A Ringwave (6 kV, 200 A) 100 kHz L-N L-G N-G L-L 1313 Category B Ringwave (6 kV, 500 A) 100 kHz L-N L-G N-G L-L Category C (low) Impulse (6 kV, 3 kA) L-N 2080 L-G N-G L-L © 20010 Schneider Electric. All rights reserved. Table 37: 480V Delta 50 kA - 100 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G 2613 L-L 3760 TVS5HWA50X TVS5HWA80X TVS5HWA10X Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt ANSI/IEEE Performance Testing Surgelogic Surge Protective Devices 14 hardwire nipple models (hwa Series) Table 38: 240V Delta 50 kA - 100 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz L-N L-G N-G L-L Category B Ringwave (6 kV, 500 A) 100 kHz L-N L-G N-G 883 L-L Category C (low) Impulse (6 kV, 3 kA) L-N L-G N-G 1110 L-L Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G 1387 L-L 2160 TVS6HWA50X TVS6HWA80X TVS6HWA10X Table 39: 600Y/347V 50 kA - 100 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz Category B Ringwave (6 kV, 500 A) 100 kHz Category C (low) Impulse (6 kV, 3 kA) Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L L-N L-G N-G L-L 723 1157 1107 1313 1083 1497 1277 2080 1570 2527 1303 2613 2507 3547 2093 3760 TVS8HWA50X TVS8HWA80X TVS8HWA10X Table 40: 600V Delta 50 kA - 100 kA IEEE C62.41.2-2002 Waveform Let-Through Voltages Category A Ringwave (6 kV, 200 A) 100 kHz L-N L-G N-G L-L 1313 Category B Ringwave (6 kV, 500 A) 100 kHz L-N L-G N-G L-L Category C (low) Impulse (6 kV, 3 kA) L-N 2080 L-G N-G L-L Category C (high) Impulse (20 kV, 10 kA) L-N L-G N-G 2613 L-L 3760 Schneider Electric USA, Inc. 1751 S. 4800 W., Salt Lake City, UT, 84104 Document Number 9990-0200A © 20010 Schneider Electric. All rights reserved. TVS9HWA50X TVS9HWA80X TVS9HWA10X Telephone: (801) 976-9009 Fax: (801) 976-0200 www.schneider-electric.com September 2010 bt
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.5 Linearized : Yes Create Date : 2010:09:30 11:32:46-06:00 Creator : Adobe InDesign CS5 (7.0) Modify Date : 2010:10:01 08:25:51-06:00 XMP Toolkit : Adobe XMP Core 4.2.1-c043 52.372728, 2009/01/18-15:08:04 Instance ID : uuid:8f0fe603-6b2b-401c-96a9-196916cae44a Document ID : xmp.did:05801174072068118C14F674805D84EA Original Document ID : adobe:docid:indd:0f547964-6264-11de-b65f-f7973ddeff07 Rendition Class : proof:pdf Derived From Instance ID : xmp.iid:03801174072068118C14F674805D84EA Derived From Document ID : xmp.did:00801174072068118A6D953D39D0590F Derived From Original Document ID: adobe:docid:indd:0f547964-6264-11de-b65f-f7973ddeff07 Derived From Rendition Class : default History Action : saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved, saved History Instance ID : xmp.iid:F87F11740720681188C6CC55E9C5FA28, xmp.iid:F97F11740720681188C6CC55E9C5FA28, xmp.iid:FB7F11740720681188C6CC55E9C5FA28, xmp.iid:FD7F11740720681188C6CC55E9C5FA28, xmp.iid:FF7F11740720681188C6CC55E9C5FA28, xmp.iid:08E709EC2720681188C6CC55E9C5FA28, xmp.iid:0AE709EC2720681188C6CC55E9C5FA28, xmp.iid:0CE709EC2720681188C6CC55E9C5FA28, xmp.iid:0EE709EC2720681188C6CC55E9C5FA28, xmp.iid:10E709EC2720681188C6CC55E9C5FA28, xmp.iid:F97F1174072068118A6DE9B26151CD2F, xmp.iid:FB7F1174072068118A6DE9B26151CD2F, xmp.iid:FD7F1174072068118A6DE9B26151CD2F, xmp.iid:FF7F1174072068118A6DE9B26151CD2F, xmp.iid:8C09CB6B1D2068118A6DE9B26151CD2F, xmp.iid:8E09CB6B1D2068118A6DE9B26151CD2F, xmp.iid:F87F1174072068118A6D953D39D0590F, xmp.iid:FA7F1174072068118A6D953D39D0590F, xmp.iid:FB7F1174072068118A6D953D39D0590F, xmp.iid:FD7F1174072068118A6D953D39D0590F, xmp.iid:FE7F1174072068118A6D953D39D0590F, xmp.iid:00801174072068118A6D953D39D0590F, xmp.iid:02801174072068118C14F674805D84EA, xmp.iid:03801174072068118C14F674805D84EA, xmp.iid:05801174072068118C14F674805D84EA, xmp.iid:06801174072068118C14F674805D84EA, xmp.iid:F97F1174072068118C14A795843472D5, xmp.iid:FC7F1174072068118C14A795843472D5, xmp.iid:FD7F1174072068118C14A795843472D5, xmp.iid:F97F11740720681188C6E03428693D5A, xmp.iid:FC7F11740720681188C6E03428693D5A, xmp.iid:084967890920681188C6E03428693D5A, xmp.iid:F97F1174072068118A6D9922B8B13E70, xmp.iid:F97F11740720681188C6E92A6CC03DF9 History When : 2010:09:14 11:05:25-06:00, 2010:09:14 11:05:25-06:00, 2010:09:14 11:13:59-06:00, 2010:09:14 11:30:20-06:00, 2010:09:14 14:13:22-06:00, 2010:09:14 14:57:50-06:00, 2010:09:14 16:24:08-06:00, 2010:09:14 16:33:03-06:00, 2010:09:14 16:39:53-06:00, 2010:09:14 16:42:52-06:00, 2010:09:14 21:37:39-06:00, 2010:09:14 22:34:28-06:00, 2010:09:14 23:11-06:00, 2010:09:14 23:39:13-06:00, 2010:09:15 00:06:15-06:00, 2010:09:15 00:07:30-06:00, 2010:09:15 10:48:43-06:00, 2010:09:15 10:49:59-06:00, 2010:09:15 11:00:57-06:00, 2010:09:15 11:04:52-06:00, 2010:09:15 11:06:43-06:00, 2010:09:15 11:06:43-06:00, 2010:09:27 11:23:19-06:00, 2010:09:27 11:23:49-06:00, 2010:09:27 11:23:49-06:00, 2010:09:27 11:29:30-06:00, 2010:09:27 12:14:32-06:00, 2010:09:27 12:26:57-06:00, 2010:09:27 12:33-06:00, 2010:09:28 07:34:03-06:00, 2010:09:28 07:37:42-06:00, 2010:09:28 07:48:58-06:00, 2010:09:29 16:40:25-06:00, 2010:09:30 11:30:47-06:00 History Software Agent : Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0, Adobe InDesign 7.0 History Changed : /;/metadata, /metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /metadata, /;/metadata, /;/metadata, /metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata, /;/metadata Metadata Date : 2010:10:01 08:25:51-06:00 Creator Tool : Adobe InDesign CS5 (7.0) Page Image Page Number : 1, 2 Page Image Format : JPEG, JPEG Page Image Width : 256, 256 Page Image Height : 256, 256 Page Image : (Binary data 8657 bytes, use -b option to extract), (Binary data 10132 bytes, use -b option to extract) Doc Change Count : 7493 Format : application/pdf Title : DATASHEET SURGELOGIC SPD (ANSI/IEEE PERFORMANCE TESTING) Producer : Adobe PDF Library 9.9 Trapped : False Page Mode : UseNone Page Count : 14EXIF Metadata provided by EXIF.tools