548049 3 Zoeller Aquanot 508 Pump Instruction
: Pump 548049 3 Zoeller Aquanot 508 Pump Instruction 548049_3_Zoeller Aquanot 508 Pump Instruction pdf
Open the PDF directly: View PDF 
.
Page Count: 2
| Download | |
| Open PDF In Browser | View PDF |
SECTION: 2.60.055 Your Peace of Mind is Our Top Priority ® FM2826 0114 Supersedes New ® Product information presented of publication. Consult factory regarding discrepancies or inconsistencies. MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347 SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961 (502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624 visit our web site: www.zoeller.com Model 508 12 Volt Backup Sump Pump System “The submersible sump pump worthy of the Aquanot® Name” APPLICATION: For clear water, emergency backup usage during interruption of AC power or because of primary pump(s) failure or insufficient capacity. FEATURES: Designed using Zoeller's time-tested components giving you the needed performance and reliability. BILGE PUMP PUMP: • 12 volt highly efficient noncorrosive pump construction. Supplied with 6' leads. • NOT a Bilge pump. Designed, Engineered and Assembled by Zoeller as a sump pump • Integrated check valve • Legs allow free standing installation • Quick disconnect discharge • Aluminum seal pocket & cooling plate • Hand built & 100% tested in USA • Efficient design means more water pumped during emergencies. PRIMARY SUMP PUMP NOT INCLUDED WITH MODEL 508 CONTROL BOX: Includes battery burn-out and overcharge protection. The self contained 10 amp battery recharger system is a solid state automatic controller with alarms, light indicators and warning systems. LCD SCREEN: Always displays battery voltage along with other helpful information about the system. LED LIGHT INDICATORS: • AC Power - blinks red when power is out • Charged - green indicates battery is fully charged • Charging - yellow indicates power is going to battery • Low Battery - red light blinks when below 10.8 volts and rapidly blinks when below 8.4 volts • High Water - yellow light will blink when the float is activated, and becomes solid after 3 seconds • Alarm Off - yellow light indicates the buzzer is currently silenced ALARMS: • High Water • Reverse Polarity • Low Battery BUTTONS: • Scroll - display information on the system such as DC pump cycles and power outages • Alarm Reset - press to reset alarms. Press and hold for three seconds for 24-hour buzzer silence AUXILIARY ALARM CONTACT: A set of dry contacts allows system to connect to home security alarm, auto dialers, etc. SWITCH: Reliable, low voltage vertical float switch BATTERY CASE: The included battery case will accommodate maximum battery dimensions of 13" L x 7-1/2" W x 9-1/2" H and fits all group size 27, 29 and 31 batteries. Made from noncorrodible polyethylene. To use multiple batteries, order extra battery case with hookup wire (P/N 007861). Product may not be exactly as shown. For preassembled systems, order a Pro Pak. FITTINGS: An integrated DC pump discharge check valve, additional AC pump check valve, tee, and adapter are included. TECHNOLOGY: This charger uses the latest switch mode technology available. This allows for an extremely efficient charger in a compact design. It satisfies the rigid California Battery Council standards. BC Charger is also C US approved. © Copyright 2014 Zoeller Co. All rights reserved. Model 508 Aquanot® Deep-cycle Battery (purchase separately) P/N 10-1450 - AGM (shown) P/N 10-0761 - Wet WARRANTY - 12-months from date of installation or 18-months from date of manufacture. However the 12-month warranty is extended to 36-months with the purchase of an Aquanot ® Battery by Zoeller. NOTE: Three-year limited warranty is valid only when a complete system is purchased and used as a backup to a primary dewatering system. A complete system includes a Model 508 and an Aquanot ® Battery. BATTERY LIFE - The estimated life of a fully charged (175 minute reserve capacity) battery when the pump is operating continuously is approximately 5½ hours. Example: the pump's capacity at 10 ft. head is 1800 GPH (30 GPM). Most backup systems require intermittent pump operation.The system will provide protection for extended periods of time dependent upon stop-start requirements. PERFORMANCE DATA - Pump performance is based on the use of a fully charged 12 volt, (200-minute reserve capacity) deep-cycle battery with no deficiency and less than two years old. AQUANOT ® BATTERY • • Size 31 “Wet” P/N 10-0761 (69 lbs.) (shipped via truckline only) 200 minute reserve capacity Minimum battery requirements: Size 27 “AGM” P/N 10-1450 (66 lbs.) deep-cycle, size 27, 175 minute 175-minute reserve capacity METERS TOTAL DYNAMIC HEAD 8 6 4 FEET reserve capacity. PUMP PERFORMANCE CURVE MODELS 508 TOTAL DYNAMIC HEAD/FLOW PER MINUTE EFFLUENT AND DEWATERING 25 20 15 10 2 MODEL 508 Feet Meters 5 1.5 10 3.0 15 4.6 20 6.1 Shut-off Head: Gal. Liters 39 148 30 114 20 76 6 23 22ft. (6.7m) 5 based upon actual performance achieved with a 12 volt deep-cycle battery. Some manufacturers publish performance data based upon D.C. Pump testing according to Marine Industry standards which can reflect a performance of 40% - 80% higher than actual battery powered performance. 152944 Minimum pit size requirements: 18" diameter X 24" deep. For 18" x 22" applications, consult factory. 0 10 GALLONS LITERS NOTE: Performance chart 0 20 30 80 FLOW PER MINUTE 40 50 160 Shipping weight: 17 lbs. NOTE: Not recommended for installation with over 20 ft. Total Dynamic Head. CAUTIONS: See FM2769 (Model 508) Installation Instructions. ® MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347 SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961 (502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624 Your Peace of Mind is Our Top Priority ® © Copyright 2014 Zoeller Co. All rights reserved. visit our web site: www.zoeller.com
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.4 Linearized : Yes Tagged PDF : Yes XMP Toolkit : Adobe XMP Core 5.6-c015 84.159810, 2016/09/10-02:41:30 Create Date : 2014:01:08 08:42:47-05:00 Modify Date : 2017:01:23 11:16:12-05:00 Metadata Date : 2017:01:23 11:16:12-05:00 Creator Tool : Adobe InDesign CS6 (Windows) Version ID : 1 Instance ID : uuid:e543efab-deba-425c-ab7f-91e74ea98ed6 Original Document ID : adobe:docid:indd:a1c60291-7040-11dc-add0-ed2c4ae1c339 Document ID : xmp.id:A04E4A556978E3119CA1AC1BB46F2532 Rendition Class : proof:pdf Derived From Instance ID : xmp.iid:9F4E4A556978E3119CA1AC1BB46F2532 Derived From Document ID : xmp.did:0EB420823B63E3119CF288F41A17B0F8 Derived From Original Document ID: adobe:docid:indd:a1c60291-7040-11dc-add0-ed2c4ae1c339 Derived From Version ID : 1 Derived From Rendition Class : default History Action : converted History Parameters : from application/x-indesign to application/pdf History Software Agent : Adobe InDesign CS6 (Windows) History Changed : / History When : 2014:01:08 08:42:47-05:00 Format : application/pdf Producer : Adobe PDF Library 10.0.1 Trapped : False Page Count : 2 Creator : Adobe InDesign CS6 (Windows)EXIF Metadata provided by EXIF.tools