548049 3 Zoeller Aquanot 508 Pump Instruction
: Pump 548049 3 Zoeller Aquanot 508 Pump Instruction 548049_3_Zoeller Aquanot 508 Pump Instruction pdf
Open the PDF directly: View PDF 
.
Page Count: 2
Model 508
12 Volt Backup Sump Pump System
“The submersible sump pump worthy of
the Aquanot® Name”
APPLICATION:
For clear water, emergency backup usage during interruption of AC power or
because of primary pump(s) failure or insufficient capacity.
FEATURES:
Designed using Zoeller's time-tested components giving you the needed
performance and reliability.
PUMP:
• 12 volt highly efficient noncorrosive pump construction. Supplied with 6' leads.
• NOT a Bilge pump. Designed, Engineered and Assembled by Zoeller as a
sump pump
• Integrated check valve
• Legs allow free standing installation
• Quick disconnect discharge
• Aluminum seal pocket & cooling plate
• Hand built & 100% tested in USA
• Efficient design means more water pumped during emergencies.
CONTROL BOX: Includes battery burn-out and overcharge protection. The self contained
10 amp battery recharger system is a solid state automatic controller with alarms, light
indicators and warning systems.
LCD SCREEN: Always displays battery voltage along with other helpful information
about the system.
LED LIGHT INDICATORS:
• AC Power - blinks red when power is out
• Charged - green indicates battery is fully charged
• Charging - yellow indicates power is going to battery
• Low Battery - red light blinks when below 10.8 volts and rapidly blinks when
below 8.4 volts
• High Water - yellow light will blink when the oat is activated, and becomes
solid after 3 seconds
• Alarm Off - yellow light indicates the buzzer is currently silenced
ALARMS:
• High Water • Reverse Polarity • Low Battery
BUTTONS:
• Scroll - display information on the system such as DC pump cycles and power
outages
• Alarm Reset - press to reset alarms. Press and hold for three seconds for
24-hour buzzer silence
AUXILIARY ALARM CONTACT: A set of dry contacts allows system to connect to
home security alarm, auto dialers, etc.
SWITCH: Reliable, low voltage vertical oat switch
BATTERY CASE: The included battery case will accommodate maximum battery
dimensions of 13" L x 7-1/2" W x 9-1/2" H and ts all group size 27, 29 and 31 batteries.
Made from noncorrodible polyethylene. To use multiple batteries, order extra battery
case with hookup wire (P/N 007861).
SECTION: 2.60.055
FM2826
0114
Supersedes
New
© Copyright 2014 Zoeller Co. All rights reserved.
Product may not be exactly as shown. For preassembled systems,
order a Pro Pak.
PRIMARY SUMP PUMP
NOT INCLUDED WITH MODEL 508
®
Product information presented
of publication. Consult factory
regarding discrepancies or
inconsistencies.
MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624
visit our web site:
www.zoeller.com
Your Peace of Mind is Our Top Priority
®
FITTINGS: An integrated DC pump discharge check valve, additional AC
pump check valve, tee, and adapter are included.
TECHNOLOGY: This charger uses the latest switch mode technology
available. This allows for an extremely efficient charger in a compact
design. It satisfies the rigid California Battery Council standards.
Charger is also approved.
BC
C US
BILGE
PUMP
Model 508
Shipping weight: 17 lbs.
NOTE: Not recommended for installation with over 20 ft. Total Dynamic Head.
CAUTIONS: See FM2769 (Model 508) Installation Instructions.
NOTE: Performance chart
based upon actual performance
achieved with a 12 volt deep-cycle
battery. Some manufacturers
publish performance data based
upon D.C. Pump testing according
to Marine Industry standards
which can reect a performance
of 40% - 80% higher than actual
battery powered performance.
152944
Aquanot® Deep-cycle
Battery (purchase separately)
© Copyright 2014 Zoeller Co. All rights reserved.
P/N 10-1450 - AGM (shown)
P/N 10-0761 - Wet
WARRANTY - 12-months from date of installation or 18-months from date of manufacture. However the 12-month warranty is
extended to 36-months with the purchase of an Aquanot® Battery by Zoeller. NOTE: Three-year limited warranty is valid only when a
complete system is purchased and used as a backup to a primary dewatering system. A complete system includes a Model 508 and
an Aquanot® Battery.
BATTERY LIFE - The estimated life of a fully charged (175 minute reserve capacity) battery when the pump is operating continuously
is approximately 5½ hours. Example: the pump's capacity at 10 ft. head is 1800 GPH (30 GPM). Most backup systems require intermittent
pump operation.The system will provide protection for extended periods of time dependent upon stop-start requirements.
PERFORMANCE DATA - Pump performance is based on the use of a fully charged 12 volt, (200-minute reserve capacity)
deep-cycle battery with no deciency and less than two years old.
AQUANOT® BATTERY • Size 31 “Wet” P/N 10-0761 (69 lbs.) (shipped via truckline only)
200 minute reserve capacity
• Size 27 “AGM” P/N 10-1450 (66 lbs.)
175-minute reserve capacity
Minimum pit size requirements: 18" diameter X 24" deep.
For 18" x 22" applications, consult factory.
MAIL TO: P.O. BOX 16347 • Louisville, KY 40256-0347
SHIP TO: 3649 Cane Run Road • Louisville, KY 40211-1961
(502) 778-2731 • 1 (800) 928-PUMP • FAX (502) 774-3624
Your Peace of Mind is Our Top Priority
®
®visit our web site:
www.zoeller.com
Minimum battery requirements:
deep-cycle, size 27, 175 minute
reserve capacity.
PUMP PERFORMANCE CURVE
MODELS 508 TOTAL DYNAMIC HEAD/FLOW
PER MINUTE
EFFLUENT AND DEWATERING
22ft. (6.7m)
508
Shut-off Head:
MODEL
15
10
Feet
5
4.6
3.0 30
20
1.5
Meters
39
Gal.
76
114
148
Liters
20 6.1 6 23
FLOW PER MINUTE
LITERS 0 80
5
25
15
10
GALLONS
TOTAL DYNAMIC HEAD
0
2
4
6
10 20 30
160
40 50
FEET
METERS
20
8
