Swisher LS728C, LS10528C Microsoft 11815 User Manual To The 78e8e8eb d163 4683 a214 bd659bd23cda

ReadandfollowallSafety

PrecautionsandInstructions

beforeoperatingthis

equipment.

LOG

SPLITTER

OWNER’S

MANUAL

1602CORPORATEDRIVE,WARRENSBURG,MISSOURI64093PHONE660-747-8183

FAX660-747-8650

MODELNO.

LS728C

LS10528C

Manufacturingqualitylawncareequipmentsince1945

Safety

Assembly

Operation

ServiceandAdjustment

RepairParts

MadeInThe

USA

IMPORTANT

swisherinc.com

11815

Rev.

2

Intheeventyouhaveaclaimunderthiswarranty,youmustreturntheproducttoanauthorizedservicedealer.

Alltransportationcharges,damage,orlossincurredduringtransportationofpartssubmittedforreplacementor

repair under this warranty shallbe bornebythe purchaser. Should you haveany questions concerning this

warranty,pleasecontactustoll-freeat1-800-222-8183.Themodelnumber,serialnumber,dateofpurchase,

andthenameoftheauthorizedSwisherdealerfromwhomyoupurchasedthemowerwillbeneededbeforeany

warrantyclaimcanbeprocessed.

THIS WARRANTY DOES NOT APPLY TO ANY INCIDENTAL OR CONSEQUENTIAL

DAMAGESANDANYIMPLIEDWARRANTIESARELIMITEDTOTHESAMETIMEPERIODS

STATEDHEREINFORALLEXPRESSEDWARRANTIES.Somestatesdonotallowthelimitationof

consequentialdamagesorlimitationsonhowlonganimpliedwarrantymaylast,sotheabovelimitationsor

exclusionsmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayhaveotherrights,

whichvaryfromstate-to-state.ThisisalimitedwarrantyasdefinedbytheMagnuson-MossActof1975.

LIMITEDWARRANTY

Themanufacturer’swarrantytotheoriginalconsumerpurchaseris:Thisproductisfreefromdefectsin

materialsandworkmanshipforaperiodoftwo(2)yearfromthe dateofpurchasebytheoriginalconsumer

purchaser.Wewillrepairorreplace,atourdiscretion,partsfoundtobedefectiveduetomaterialsor

workmanship.Thiswarrantyissubjecttothefollowinglimitationsandexclusions:

TABLEOFCONTENTS

WARRANTY………………....….2

SAFETY..……………………….3-4

TOWING..….……..……………..5

OPERATION……………………6-8

MAINTENANCE.…………………….8-9

DECALS…..………….……………….10

PARTSBREAKDOWN…………….11-18

SPECIFICATIONS..…………………23

1) EngineWarranty Allenginesutilizedonourproductshaveaseparatewarrantyextended

tothembytheindividualenginemanufacturer.Anyengineservice

difficultyistheresponsibilityoftheenginemanufacturerandinno

wayisSwisherMowerCo.,Inc.oritsagentsresponsibleforthe engine

warranty.TheBriggs&StrattonEngineServiceHot-Lineis1-800-

233-3723.TheTecumsehEngineServiceHot-Lineis1-800-558-5402.

TheHondaEngineServiceHot-Lineis1-800-426-7701.

1) CommercialUse Thewarrantyperiodforanyproductusedforcommercialorrentalis

limitedtoninety(90)daysfromthedateoforiginalpurchase.

2) Limitation Thiswarrantyappliesonlytoproductswhichhavebeenproperly

assembled,adjusted,andoperatedinaccordancewiththeinstructions

containedwithinthismanual.Thiswarrantydoesnotapplytoany

productofSwisherMowerCo.,Inc.,thathasbeensubjecttoalteration,

misuse,abuse,improperassemblyorinstallation,shippingdamage,or

tonormalwearofproduct.

3) Exclusions Excludedfromthiswarrantyarenormalwear,normaladjustments, and

normalmaintenance.Thepump,valve,andcylindereachcarryseparate

manufacture’swarranties.Thevalveandcylinderbothcarryaone(1)year

limitedwarranty.Thepumpcarriesatwo(2)yearlimitedwarranty.

SAFETYPRECAUTIONS



WARNING:Theengineexhaustfromthisproductcontainschemicalsknowntothestateof

Californiatocausecancer,birthdefectsorotherreproductiveharm.



DANGER:Yourlogsplitterwasbuilttobeoperatedaccordingtotherulesforsafeoperationin

thismanual.Aswithanytypeofpowerequipment,carelessnessorerroronthepartofthe

operatorcanresultinseriousinjury.Ifyouviolateanyoftheserules,youmaycauseserious

injurytoyourselforothers.



• Readthemanual.Learntooperatethisequipmentinasafemanner.



• Donotunderanycircumstancesalterthislogsplitter.Thisequipmentwasdesignedand

engineeredinaccordancewithoperatinginstructions.Alteringthisequipment,orusing

thisequipmentinsuchawayastocircumventitsdesigncapabilitiesandcapacities,could

resultinseriousinjuryorfatalityandWILLVOIDTHEWARRANTY.



• Allowonlyresponsibleadultswhohavereadthismanualtooperatethismachine.Never

allowchildrentooperatethismachine.



• Neverusesplitterforanyotherpurposethansplittingwood.Anyotherusecanresultin

injury.Yoursplitterisaprecisionpieceofpowerequipment,notatoy.Therefore,

exerciseextremecautionatalltimes.



• Onlyasingleoperatoristoloadandoperatethelogsplitter.Keepallothers,including

petsandchildren,aminimumof20feetawayfromyourworkarea.Moreaccidents

occurwhenmorethanonepersonoperatesthelogsplitterthananyothertime.



• Alwaysdisconnectthesparkplugwireandplacethewirewhereitcannotcontactthe

sparkplug,topreventaccidentalstartingtheenginewhensettingup,transporting,

adjustingorrepairing.



• Alwayswearprotectivegearsuchassafetygoggles,protectivehearingdevice,steel-toed

shoes,andtight-fittinggloveswithoutdrawstringsorloosecuffs.



• Neverwearlooseclothingorjewelrythatcanbecaughtbymovingpartsofthesplitter

andpullyouintoit.Keephairawayfrommovingparts.



• Familiarizeyourselfwithallofthecontrolsinasafeenvironmentbeforestartingtowork

withthismachine.



ThisSafetyAlertSymbolindicatesimportantmessagesinthismanual.

Whenyouseethissymbol,carefullyreadthemessagethatfollowsandbe

alerttothepossibilityofpersonalinjury.

Readthismanualcompletely.Thismachinecanamputatehands,feet,andthrowobjects.

Failuretoobservethefollowingsafetyinstructionscouldresultinseriousinjuryordeath.

3

Fluidescapingfromaverysmallholecanbealmostinvisible.Donotcheckforleakswithyour

hand.Escapingfluidunderpressurecanhavesufficientforcetopenetrateskin,causingserious

personalinjury.Leakscanbelocatedbypassingapieceof

cardboardorwoodoverthesuspected

leakandlookingfordiscoloration.IFinjuredbyescapingfluid,seeadoctoratonce.Serious

infectionorreactioncandevelopifpropermedicaltreatmentisnotadministered

immediately.



• Splitonlyonelogatatime.Neverattempttosplittwologsontopofeachother.



• Donotstraddleorreachacrossthesplittingareawhileoperatingthesplitter.



• Donotstepoversplitterwhentheengineisrunning.Youmaytriporaccidentally

activatethesplittingwedge.Walkaroundtogettotheotherside.



•

Neverplacehandsorfeetbetweenlogandsplittingwedgeorbetweenlogandramduring

forwardorreversestroke.



• Neverattempttoloadsplitterwhilesplittingwedgeisinmotion.Whenloadinglog

splitter,placehandsonthesidesofthelog,nottheends.



• Onlyuseyourhandstooperatethecontrollever.Neverusefoot,knee,ropeorany

extensiondevice.



• Alwayskeepfingersclearofsplitsthatopeninlogduringsplitteroperation.



• Whensplitterisinthereturnmode,keephandsoffthemachine.



•

Onlyoperatesplitteronlevelground,notonthesideofahill.Itcouldtiporrollinglogs,

poorfooting,etc.couldcauseanaccident.



• Neveroperateorallowsomeonetooperatethisequipmentwhileundertheinfluenceof

alcoholordrugs.



• Alwaysblockthewheelstopreventmovementwhileusingsplitter.



• Neveroperateyoursplitteronwet,muddy,oricysurfaces.Safefootingisessentialin

preventingaccidents.



• Neveroperateyoursplitterwhileitisattachedtothetowvehicle.



• Nevermakeadjustmentsorrepairswiththeenginerunning.



• Neverattempttosplitwoodsacrossthegrain.Sometypesofwoodmayburstorflyout

ofyoursplitterandresultininjury.



• Bothendsofthelogshouldbecutassquarelyaspossibletopreventthelogfromsliding

outofthesplitterduringoperation.Loglengthshouldbekeptto24”orless.



4



TOWINGSAFETY



• Donotallowpersonstorideonsplitter.Donotcarryanycargoorwoodonyour

splitter.Itmayfalloffandendangervehiclesthatarefollowingyou.



• Besurejackstandisinthetravelpositionandcouplingsecure.Thismustalsobe

retractedsonottointerferewhiletowing.Retractkickstandbyremovingpin,

rotatingup,andreplacingpin.



• Neverexceed45MPHwhiletowingyoursplitter.Beextracautiouswhen

travelingoverroughterrain,especiallyoverrailroadtracks.



• Alwaysbecarefulwhilebackingyoursplitter.Youcouldjackknifeyourlog

splitterifnotcareful.



• Beforeusingsplitter,disconnectitfromtowvehicle.Alogcouldeasilybe

pushedforwardintothevehicle.



• SeetireandwheelspecificationsforPSIwhiletowing.



• Beawareoftheextralengthofsplitterwhileturning,parking,crossing

intersections,andinalldrivingsituations.



• 



OPERATIONINSTRUCTIONS

POSI-LOCKCOUPLER

ADJUSTCOUPLERLOCKINGPRESSUREONBALLBEFOREUSE.PLACEHANDLEINLOCKED

POSITIONWITHBALLINCOUPLER.TIGHTENLOCKNUTAGAINSTTENSIONSPRINGSOTHAT

COUPLERISNOTLOOSEONBALL.CORRECTADJUSTMENTWILLALLOWHANDLETOBE

RELEASEDWITHMODERATEPRESSUREAPPLIEDTOHANDLE.



TOOPEN,PULLUPONCOUPLERHANDLEANDROTATEFORWARD.PLACECOUPLERONBALL

WHENBALLISCOMPLETELYNESTEDINBALLSOCKET,ROTATECOUPLERHANDLE

BACKWARDUNTILHANDLEISINLOCKEDPOSITION.



AFTERTOWINGFOR50MILES,CHECKCOUPLERFORTIGHTNESSONBALL.ALWAYSCHECK

TIGHTNESSBEFORETOWING.BESURECOUPLERHANDLEISINLOCKEDPOSITION.



WARNING:

NEVEREXCEEDWEIGHTCAPACITYANDALWAYSUSESAFETYCHAINS.ALWAYSUSE

CORRECTBALLSIZE,MAKINGSUREBALLISCOMPLETELYINSERTEDINTOCOUPLER.LOCK

COUPLERHANDLESECURELYBEFORETOWING.ALWAYSCHECKFORDAMAGESAND

REPLACEIFDAMAGED.AVOIDSHARPTURNSANDSTEEPVERTICALANGLESWHENTOWING.

5

OPERATION



Intendeduse:Thislogsplitterisintendedanddesignedtoonlysplitwood.NEVERuse

foranyotherpurposes.DoingsocancauseinjuryorVOIDTHEWARRANTY.



ASSEMBLYINSTRUCTIONS

Thislogsplitterhasbeenpartiallyassembledatthefactory.Refertothedrawingsandpart

listsshoulditbecomenecessarytodisassembletheunitforrepairorreplacementofparts.

Inspectallcomponentsfordamage.

WARNING:Exerciseextremecaution,aspartsareveryheavy.Sufficientpersonsor

mechanicalhandlingequipmentshouldbeused.

IMPORTANT:Thisunitisshippedwithoilbutwithoutgasolineintheengine.After

assembly,seeseparateEngineManualforproperfuelandoilrecommendations.

1. GeneralAssembly:Removetop,sidesandendsofcrate.Placecratepanelsaside

toavoidpuncturingtires.Removetongueassemblyfromtop.

2. Carefullysetthebeampre-assemblyaside.

3. Attachtonguetotank/mountplatesusingtwoboltsandnuts.Becertainhardware

issecure.(SeeAssemblyFigure1)

4. Removetank/engineassemblyfrombaseofcrateanddiscardbanding.

5. FenderAssembly:Removefendersfrombox.Mounttofenderbracketswith5/16

hardwareprovided.Makesurefenderclearswheel.

6. Thecylinderistiedtothebase.Removetiesandslidecylinder/wedgeforward

aligningclevisatcylinderendtobeam.Insertpinandretainingclips,check

componenttoassureproperassembly.Standbeampre-assemblyverticaland

secureinposition.Rolltank/engineassemblyintoplace,aligningpivotholes

.Bolt

withprovidedhardware.Note:Donotovertighten;thisisthevertical/horizontal

pivotpoint.



7. Pivotbeamassemblyintothehorizontalpositionandlockwithpinprovided.

8. HoseAssembly:LocatethePressureHose,notedbythepipefittings,andattachit

tothelowerfittingonthevalve.Theremaininghoseattachestothetopfittingof

thevalve.Securewithprovidedhoseclamp.

9.

Checkboththehorizontalandverticalpositionsforany“kinks”inthehoses.Note:

Alwaysmakesurebeamislockedsecurelyintoplace.

SeeOPERATINGPOSITIONSforHorizontaltoVerticalSplitting



AssemblyFigure1

Tank/MountPlates

6

OPERATION



FILLINGTHEHYDRAULICRESERVOIR

FillthehydraulicreservoirwithatleastfivegallonsofGeneralPurposeHydraulicfluidor

AutomaticTransmissionfluid.Afterthehydraulicreservoirandtheenginecrankcasearefilled

correctlywiththeirr

espectiveoils,starttheengine.Remembertosetthethrottleandturnonthe

fuelshut-

offvalve.Thehydraulicpumpshouldprimeitself.Withtheenginerunning,movethe

hydraulicvalvelevertowardthewedge.Thiswillcausethecylindertoextendandexpelair.

Whenthecylinderisfullyextended,retractit.Repeatthisprocedureseveraltimes.(Anerratic

movementofthecylinderindicatesthatthereisairinthesystem).Youmayhavetoaddmore

fluidandrepeatthisprocedure.Oncethecylinderhasasmoothandconstantspeedindicating

thatalltheairhasbeenexpelled,moreoilshouldthenbeaddedtobringthefluidlevelupto

approximately3”belowthefillhole.Standardmodelsrequireapprox.4.5gallonsofhydraulic

fluid.



NOTE:

Ifthetankisoverfilled,itwilltendtoexpeloilfromthebreathercapwhenthecylinder

isretracted.



STARTUP

WARNING:DONOTSTARTORRUNTHELOGSPLITTERWITHOUTOILINTHE

ENGINEANDHYDRAULICRESERVOIR.

SeeseparateEngineManualforfuelandoilrecommendations.Yourlogsplitterhascome

equippedwithafuelshut-offvalvefortowingpurposes.

Beforestartingenginemakesurecrankcaseisfilledcorrectlywithoilandtheproperfuelhas

beenused.Theenginewillonlystartwhenthethrottleleverandfuelshut-offvalveareturned

totheirONpositions.



COLDWEATHERSTARTUP

TheColdWeatherClutchenablestheenginetobestartedwithouthavingtopullthroughcold,

thickenedhydraulicfluid.Simplypullthehandleoutandslideintolockedposition.Start

engine,letitwarmup,andreleaseColdWeatherClutch.Afterstarting,assurethattheleverhas

reengaged.



TOWING

Thisunitshouldnotbetowedonanystreet,highway,orpublicroadwithoutcheckingthe

existingfederal,local,andstatelaws.Anylicensingormodificationssuchastaillights,etc.,

needtocomplywithexistingfederal,local,orstatevehiclerequirementsisthesole

responsibilityofthepurchaser.Obeyallregulationswhentowingonpublicroadsand

highways.SeealsoTOWINGSAFETY.



Besureyouareusingthecorrectballhitchsizeforthehitchcoupleronthelogsplitter(2”ball).

Besuresafetychainsareproperlyconnected.Leaveenoughslackinchainsforturning.See

TOWINGSAFETYtoreadwarningsaboutcoupling.



Makesurebeamattachmentislockedinthehorizontalposition.NEVERtowsplitterinthe

verticalposition.



Turnthefuelshut-offvalveOFFtopreventfloodingoftheenginewhiletraveling.



TOWINGATNIGHT

TherequirementsfortaillightsarebasedonStatesregulations.Somestatesallowtowingat

nightaslongasthetowedequipmentdoesnotvisiblyimpairthetowvehicletaillights.Thisis

basedonastate,tostaterequirements.Thecustomerisresponsibleformeetingthestates

requirements.ATaillightKitAccessory(PartNo.7420)isavailableandrecommendedfornight

driving.



Ifa“StatementofOrigin”isrequiredinyourstate,seeyourlocaldealertoreceiveone.



7



OPERATION

1. Setupthelogsplitterinaclear,levelareaandblockthewheels.Thesuctionportonthetank

shouldalwaysbeonthelowersideofthelogsplitter.

2. Placealogonthebeam,againstthefootplate.Makesurethelogissecurelyonthefootplate

andupagainstthebeam.

3.

Depressthevalveleversothatthecylinderwilldrivethewedgeintothelog.Extendthecylinder

untilthelogsplitsortotheendofitsstroke.Iftheloghasnotcompletelysplitafterthecylinder

hasreachedtheendofitsextension,retractthecylinder.NOTE:

Leavingthevalveinthe“actuate”positionattheendofthestrokemaydamagethepump.



OPERATINGPOSITIONS

WARNING:THELOGSPLITTERBEAMISHEAVYANDCANPINCHHANDS/FINGERSIF

CAREISNOTTAKEN.



STANDARDHORIZONTALTOVERTICAL

TheStandardSplitterhas2operatingpositions:Horizontal,Vertical.

Removepinfrombelowbeam.Donotremoveboltandnut.Rotatebeamintoverticalpositionandpin

sobeamcannotfallintohorizontalposition.

DONOTTOWINVERTICALPOSITION!



IMPORTANT:

Whenoperatingsplitterinwoodedareas,obtainasparkarrestorfortheexhaustsystem.

Seeyourlocalenginedealer.



Whenpreparinglogs,cutendsassquareaspossible.Themaximumlengthofanylogsshouldbeonly

24”.



MAINTENANCE&STORAGE



WARNING:Disconnectsparkplugbeforeperforminganymaintenanceormakingadjustments.



RESERVOIRFLUID 

Checkthehydraulicfluidlevelinthereservoirtankbeforeeachuse.Operatingwithoutanadequateoil

supplywillcauseseveredamagetothepump.Changethehydraulicfluidinthereservoirper

manufacturersrecommendations.



Beawareoftheenvironmentwhendisposingofusedpetroleumproducts.Pleasedisposeofused

hydraulicfluid,engineoilandanybyproductsfromthemaintenanceofyourlogsplitterat

approvedrecyclingcenters.



Shoulditbecomenecessarytoloosenorremoveanyhydraulicfittingorline,besuretoremoveall

pressurebyshuttingofftheengineandmovingthecontrolhandlebackandforthseveraltimes.



NEVERremovethecapfromthehydraulictankorreservoirwhileyourunitisrunning.Hotoil

underpressurewillcauseinjury.



Alwaysstoregasolineinanapproved,tightlysealedcontainer.Storecontainerinadry,coolplac

e.Keep

fuelawayfromgasapplianceswherefumescouldcontactopenflame,pilotlightsorsparks.



8



Donotoperateyoursplitterinpoormechanicalconditionorwhenneedingrepair.Repairand

replacewornorbrokenpartsimmediately.



Periodicallytightennuts,bolts,andhydraulicfittings.



Thehydraulicsystemofyourlogsplitterrequirescarefulinspection,alongwiththemechanical

parts.Besuretoreplacefrayed,kinked,orotherwisedamagedhydrauliccomponents.



Thepressurereliefvalveonthesplitterispresetatthefactory.Donotadjustvalve.Onlya

qualifiedservicetechnicianshouldperformthisadjustment.



Ifthewedgebecomesdullornicked,itcanberemovedandsharpened.Thewedgeisheavyand

maystillhavesharpedges,weargloveswhilehandlingthewedge.



REPAIRPARTS



YourSwisherLogSplitterhasbeenproducedwithcomponentsdesignedspecificallytothis

machine.Althoughstandardsprings,hardware,etc.maylooksimilartopartsusedonother

machinery,theymayinsomecasesbemadeofadifferentconstructionand/ormaterials.



9

OD12– HYDRAULICFILLPLUG

DECAL

OD09– DANGER/POSITIONLOCK

DECAL

OD08– OPERATORINSTRUCTION

DECAL

OD16– FUELSHUTOFFDECAL OD07– COLDWEATHERDECAL

SAFETYDECALS

Replacedecalsimmediatelyifdamaged.

10

ASSEMBLYDETAIL

LS728C,LS10528CMODELS

SEEDETAIL

1

2

3B

4

5

6

7

8

9

10

A

11

16

15

14

13

12

18

17

8

20

25

21 23

24

2627

22

28

29

6

25

39

31

33 3432

35

35 36

30

42

41

40

38

37

43

44

45

46

47

48

49

50

42

16

51 55

18

52

54

53

52

58

57

56

49

6

5

SEEDETAIL

NOTALLPARTSAREONALLMODELS

57

B

FENDERS&FENDER

BRACKETSSOLD

SEPERATELY

11

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

Colorcannotbeguaranteeduponserviceparts.

ITEMNUMBER DESCRIPTION PARTNUMBER

1 RETURNHOSE54" 7290

2 PRESSUREHOSE48" 7289

3 #12HOSECLAMP LS5001

4 HYDRAULICRESERVOIR 7319

5 1/2-13X31/2GR5BOLT NB577

6 1/2-13NYLOCKNUT NB281

7 RESERVOIRVENTPLUG 7379

8 3/8-16X1GR5BOLT NB604

9 1/2X31/2HITCHPINW/HAIRPIN NB648

10 SUCTIONHOSE18" 7346

11 #16HOSECLAMP LS4999

12 RETURNLINEFITTING 7329

13 FILTERHEAD LS1112

14 FILTERELEMENT LS1113

15 1/2-13X11/4GR5BOLT NB647

16 3/8-162-WAYLOCKNUT NB280

17 TANKBRACE 7352

18 3/8-16NYLOCKNUT NB182

20 HYDRAULICPUMP-LS622,LS67525MODEL LS2001H

HYDRAULICPUMP-LS928,LS11534MODELS LS2002B

21 1/8X1/2#3WOODRUFFKEY 024002

22 5/16-182-WAYLOCKNUT NB558

23 PUMPPULLEY 7306

24 SETSCREWW/NYLOCK NB312

25 5/16-18X3/4GR2BOLT NB143

26 FENDERBRACKET-RIGHTSIDE-LS11534ONLY 7417

FENDERBRACKET-LEFTSIDE-LS11534ONLY 7418

27 FENDER-LS11534ONLY 7428

28 KICKSTAND 7398

12

SERVICEPARTS

PleasehaveModelandSerialNumbersreadywhenorderingparts.

ITEMNUMBER DESCRIPTION PARTNUMBER

29 MOTORBASE/AXLE 7297

30 TIRE/WHEEL 7296

31 COTTERPIN NB633

32 WHEELDUSTCOVER 2203DC

33 CASTLENUT 2203CN

34 WASHER NB184

35 TAPEREDBEARING 2203B

36 BEARINGSEAL 2203S

37 BELT 644

38 IDLERARM 6681TK

39 CLUTCHLEVER 7358

40 SPRING 682S

41 3/8-16JAMNUT NB174

42 HARDENEDWASHER NB196

43 3/8-16X21/2GR5BOLT NB619

44 5/16-18FLANGENUT NB170

45 IDLERSPRINGMOUNT 2046

46 WIRELINKFORIDLERSPRING BRS6H

47 SHOULDERBOLT NB220

48 IDLERPULLEY B527

49 WASHER NB272

50 BELTCOVER 7321

51 #14x3/4SELF-TAPPINGSCREW NB161

52 SAFETYCLIPPIN H11

53 TOWINGTONGUE 7343

TOWINGTONGUE-LS11534 7168

54 TRAVELLOCK 7441

55 SAFETYCHAINW/HOOK 7366

56 2"BALLCOUPLER 7365

57 3/8-16X3GR5BOLT NB164

58 3/8-16X31/2GR5BOLT NB649

Colorcannotbeguaranteeduponserviceparts.

13

ITEMNUMBER DESCRIPTION PARTNUMBER

59 CLIPPIN NB642

60 STEELPIN 7293

61 HYDRAULICFITTING 7291

62 STATIONARYLINEASSEMBLY 7288

63 RAMCYLINDER-LS622MODELS 7284

RAMCYLINDER-LS928&LS67525MODEL 7354

RAMCYLINDER-LS11534&LS12534DMODEL 7355

64 1/2-13X3GR5BOLT NB131

65 SPLITTINGWEDGE 7233

66 1/2-13X21/2GR5CARRIAGEBOLT NB643

67 RETURNLINEFITTING 7329

68 1/2-13JAM2-WAYLOCKNUT NB121

69 2-WAYPIPENIPPLE 7292

70 MASTERCHAINLINK 7424

71 COTTERPIN NB597

72 VALVEINLETFITTING 7387

73 VALVECONTROLW/LEVER 7287

74 BEAMWELDMENT 7624

BEAMWELDMENT-LS12534DMODEL 7384

75 1/4X1CLEVISPIN NB522

76 1/2-13NUT NB213Z

77 VALVELEVER&GRIP 7423/7425

78 THINGIBPLATE 7388

79 THICKGIBPLATE 7237

80 BOTTOMGIBPLATE 7333

81 LOCKWASHER NB508

81A FLATWASHER NB555

62

61

64

68

60

70

69

67

66

65

61

74

72

71

73

75

77

79

80

81

78

76

BEAMDETAIL

ALLMODELS

NOTALLPARTSAREONALLMODELS

59

63

81A

14

ENGINEDETAIL

LS728CMODELS

ITEM# DESCRIPTION PART#

89 ENGINE N/A

90 5/16-18X11/4GR5BOLT NB504

91 5/16-182-WAYLOCKNUT NB558

92 UPPERSPACER BB105SL

93 ENGINEPULLEY BB105

94 LOWERSPACER BB105S

95 BELLEVILLEWASHER 699

96 7/16-20X1GR5BOLTW/NYLOCK NB452N

106 KEYSTOCK 9031

182 WASHER TR150W

NOTSHOWN WIRINGHARNESS-LS12534DMODEL 7416

NOTSHOWN OILDRAINVALVE AS122

NOTSHOWN FUELSHUTOFFVALVE(INLINE) 7414

ITEM# DESCRIPTION PART#

97 ENGINE N/A

98 5/16-18X21/2GR5BOLT NB138

99 5/16-182-WAYLOCKNUT NB558

100 5/16-18X11/4GR5BOLT NB504

101 KEYSTOCK 9030

102 SETSCREWW/NYLOCK NB312

103 ENGINEPULLEY-LS622 7323

104 BELLEVILLEWASHER 699

105 3/8-24X1BOLTW/NYLOCK NB238N

89

90

91

94

93

92

182

96

100

98

97

99

101

105

102

104 103

106

15

ENGINEDETAIL

LS10528CMODELS

95

19

NOTES

:

______________________________________________________________________

20

NOTES

:

______________________________________________________________________

22

NOTES

:

______________________________________________________________________

LS728C LS10528C

Splitting

Force

28Tons 28Tons

Engine

7HPBriggs and

StrattonIntek

10.5HPBriggs 

andStrattonI/C

Splitting

Positions

Horizontaland

Vertical

Horizontaland

Vertical

Cylinder

Size

41/2"X24" 41/2"X24"

Pump

2StagewithHeavy

DutyBearings 

2StagewithHeavy

DutyBearings

Pump

Specs

11Gallons Per

Minute

16Gallons Pe r

Minute

Valve

AutoReturn AutoReturn

Oil

Capacity

Approx.4.5Gallon Approx.4.5Gallon

Maximum

Loglength

24" 24"

TireSpecs

4.00X4.80X8

withHighSpeed

Bearings

4.00X4.80X8

withHighSpeed

Bearings

Metal

Fenders

No No

BallHitch

2"Ball 2"Ball

Unit

Weight

535Lbs

550Lbs

Models

23

SPECIFICATIONS

OWNER’S

MANUAL

MODELNO.

LS728C

LS10528C

HOWTOORDER

REPAIRPARTS

:

LOGSPLITTER

EachLogSplitterhasitsownserialnumber.Eachenginehas

itsownserialnumber.TheserialnumberfortheLogSplitter

willbefoundontherighthandsideofthehydraulicoil

reservoir.Theserialnumberfortheenginewillbefoundon

thetopoftheblowerfanhousing.

AllLogSplitterpartslistedhereinmaybeordereddirectly

fromSwisherMower&MachineCo.Inc.,yournearest

Swisherdealer,orfromourwebsite.

Allenginepartsmaybeorderedfromthenearestdealerofthe

enginesuppliedwithyourlogsplitter

.

Partssubjecttochange

withoutnotice.

WHENORDERINGPARTS,PLEASEHAVETHE

FOLLOWINGINFORMATIONAVAILABLE:

*PRODUCT– SWISHERLOGSPLITTER

*SERIALNUMBER- _______________

*MODELNUMBER- _______________

*ENGINEMODELNUMBER- _______________

TYPE- _______________

*PARTNUMBER

*PARTDESCRIPTION

www.swisherinc.com

TELEPHONE- 1-800-222-8183

FAX- 1-660-747-8650

SWISHERMOWER&MACHINECO.INC.

1602CORPORATEDRIVE

WARRENSBURG,MO64093

SWISHERMOWER&MACHINECO.INC.

Swisher LS728C, LS10528C Microsoft 11815 User Manual To The 78e8e8eb D163 4683 A214 Bd659bd23cda

Navigation menu

Versions of this User Manual:

Views

Navigation