Trane Voyager Commercial 27 5 To 50 Tons Installation And Maintenance Manual Installation, Operation,
2015-04-02
: Trane Trane-Voyager-Commercial-27-5-To-50-Tons-Installation-And-Maintenance-Manual-684193 trane-voyager-commercial-27-5-to-50-tons-installation-and-maintenance-manual-684193 trane pdf
Open the PDF directly: View PDF
Page Count: 138 [warning: Documents this large are best viewed by clicking the View PDF Link!]
- Warnings, Cautions and Notices
- Table of Contents
- Model Number Description
- General Information
- Unit Dimensions and Weights
- Installation General Requirements
- Installation Electrical
- Installation Piping
- Startup
- Unit Control Modules
- RTRM - ReliaTel™ Refrigeration Module
- ECA/RTEM - Economizer Actuator/ReliaTel Economizer Module (Optional)
- EBA - Exhaust Blade Actuator (Optional)
- RTAM - ReliaTel Air Handler Module (Standard with Traditional VAV)
- ReliaTel Ventilation Module (RTVM)
- ReliaTel Dehumidification Module (RTDM)
- Conventional Thermostat Connections (Available Only with CV)
- TCI - Trane Communication Interface (Optional)
- LCI - LonTalk® Communication Interface (Optional)
- BCI - BACnet® Communication Interface (Optional)
- Trane Wireless Comm Interface (WCI)
- TD5 Display - 5" Touchscreen Display
- System Operation
- Economizer Operation with a Conventional Thermostat (CV Only)
- Microelectronic Control Features
- Economizer Operation with CV Controls
- Modulating Power Exhaust
- Mechanical Cooling without an Economizer (CV and SZ VAV)
- Zone Temperature - Occupied Cooling (CV and SZ VAV)
- Zone Temperature - Occupied Heating (CV and SZ VAV)
- Supply Fan (CV and SZ VAV)
- Supply Air Tempering (CV and SZ VAV)
- Variable Air Volume Applications (Single Zone VAV)
- Variable Air Volume Applications (Traditional VAV)
- Supply Air Temperature Control - Occupied Cooling and Heating
- Supply Air Temperature Control with an Economizer
- VHR Relay Output
- Zone Temperature Control without a Night Setback Panel or ICS - Unoccupied Cooling
- Zone Temperature Control without a Night Setback Panel or ICS - Unoccupied Heating
- Morning Warm-up (MWU) Control
- Daytime Warm-up (DWU) Control
- Supply Duct Static Pressure Control
- Supply Air Temperature Reset
- VAV Supply Air Tempering (Only Available with Modulating Gas Heat)
- Constant Volume or Variable Air Volume Applications (Single Zone or Traditional)
- Off Mode
- Zone Temperature - Unoccupied Cooling (CV or SZ VAV Only)
- Zone Temperature - Unoccupied Heating
- Mechanical Cooling with an Economizer
- Gas Heat Control
- Electric Heat Control
- Clogged Filter Option
- Ventilation Override
- Emergency Stop
- Phase Monitor
- Low Pressure Control
- Dehumidification Low Pressure Control
- High Pressure Cutout and Temperature Discharge Limit
- Power Exhaust Control (Standard)
- Space Pressure Control - Statitrac
- Power Exhaust Control (Tracking)
- Lead/Lag Control
- Coil Frost Protection
- Dehumidification Frost Protection
- Drain Pan Condensate Overflow Switch (Optional)
- VFD Programming Parameters
- Condenser Fan Sequencing Control
- Preparing the Unit for Operation
- Starting the Unit
- Economizer Damper Adjustment
- Starting the Compressor
- Gas Heat Units
- Electric Heat Units
- Final Unit Checkout
- Unit Control Modules
- Pre-Installation
- Sequence of Operation
- Mechanical Cooling Sequence Of Operation
- Dehumidification (Modulating Hot Gas Reheat) Sequence of Operation
- Gas Heat Sequence Of Operation
- Electric Heat Sequence Of Operation
- Variable Air Volume Applications (Single Zone VAV) Sequence of Operation
- Low Pressure Control (LPC) Sequence of Operation (ReliaTel Control)
- High Pressure Control and Temperature Discharge Limit (ReliaTel Control)
- Maintenance
- Diagnostics
- System Status/Diagnostics
- Terminal locations
- System Status / Diagnostics checkout procedure (DC volt meter required)
- Diagnostics (CV and SZ VAV Units Only)
- Diagnostics (VAV only)
- Resetting Cooling and Ignition Lockouts
- Zone Temperature Sensor (ZSM) Service Indicator
- RTRM Zone Sensor Module (ZSM) Tests
- Programmable & Digital Zone Sensor Test
- ReliaTel Refrigeration Module (RTRM)
- Economizer Actuator (ECA/RTEM) Test Procedures
- ReliaTel Air Module (RTAM) Tests
- ReliaTel Air Module (RTOM) Tests
- Compressor—Blink Codes
- Troubleshooting
- TR-200 VFD Programming Parameters
- System Status/Diagnostics
- Unit Wiring Diagram Numbers
- Warranty and Liability Clause