York Tg9S Technical Guide 400991 YTG H 0615
2015-09-09
: York Tg9S-Technical-Guide york-tg9s-technical-guide-811954 york pdf
Open the PDF directly: View PDF
Page Count: 6
![TECHNICAL GUIDE95.5% AFUE SINGLE STAGERESIDENTIAL GAS FURNACESMULTI-POSITION MODELS: TG9SNATURAL GAS40 - 130 MBH INPUTDue to continuous product improvement, specifications are subject to change without notice.Visit us on the web at www.york.comAdditional rating information can be found at www.ahridirectory.orgWARRANTY SUMMARYA 20-year limited warranty on heat exchangers in residen-tial applications.A 10-year warranty on the heat exchanger in commercialapplications.Standard 5-year limited Parts warranty.Extended lifetime heat exchanger and 10-year limitedparts warranty when product is registered onlinewithin 90 days of purchase for replacement or closingfor new home construction.See Limited Warranty certificate in Users Information Manual for details.400991-YTG-H-0615FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALEDESCRIPTIONThese compact units employ induced combustion, reliable hot sur-face ignition and high heat transfer aluminized tubular heatexchangers. The units are factory shipped for installation in upflowor horizontal applications and may be converted for downflow appli-cations.These furnaces are designed for residential installation in a base-ment, closet, alcove, attic, recreation room or garage and are alsoideal for commercial applications. All units are factory assembled,wired and tested to assure safe dependable and economical instal-lation and operation.These units are Category IV, National Fuel Gas Code and may bevented either through side wall or roof applications using approvedplastic combustion air and vent piping. Approved plastic combus-tion air and vent piping include Polyflue (a polypropylene ventingsystems).FEATURES• Easily applied in upflow, horizontal left or right, or downflow installation with minimal conversion necessary.• Compact, easy to install, ideal height 33" tall cabinet.• Blower-off delay for cooling SEER improvement.• Easy access to controls to connect power/control wiring.• Built-in, high level self diagnostics with fault code displays standard on integrated control module for reliable operation.• Low unit amp requirement for easy replacement application.• Single wire twinning or staging feature available.• All models are convertible to use propane (LP) gas.• Electronic Hot Surface Ignition saves fuel cost with increased dependability and reliability.• 100% shut off main gas valve for extra safety.• 4 speed, direct drive PSC motor.• 24V, 40 VA control transformer and blower relay supplied for add-on cooling.• Hi-tech tubular aluminized steel primary heat exchanger.• Secondary heat exchanger made of corrosion resistant stain-less steel materials.• Timed on, adjustable off blower capability for maximum com-fort.• Blower door safety switch.• Solid removable bottom panel allows easy conversion.• Airflow leakage less than 1% of nominal airflow at ductblaster conditions.• No knockouts to deal with, making installation easier.• Movable duct connector flanges for application flexibility.• Quiet inducer operation.• Inducer rotates for easy conversion of venting options.• Fully supported blower assembly for easy access and removal of blower.• External air filters used for maximum flexibility in meeting cus-tomers IAQ needs.• Protection included from air intake, exhaust vent, or conden-sate blockage.• No special vent termination required.• 1/4 turn knobs provided for easy door removal.• Internal condensate trap design (patent pending) provides condensate management options and is self-priming to pre-vent nuisance problems.• Venting applications - may be installed as either 2-pipe (sealed combustion) or single-pipe vent (using indoor combustion air).](https://usermanual.wiki/York/Tg9STechnicalGuide.779456254-User-Guide-Page-1.png)
![400991-YTG-H-06152Johnson Controls Unitary ProductsAnnual Fuel Utilization Efficiency (AFUE) numbers are determined in accordance with DOE Test procedures.Wire size and over current protection must comply with the National Electrical Code (NFPA-70-latest edition) and all local codes.The furnace shall be installed so that the electrical components are protected from water.FRONT33ALEFT SIDECombustion Air InletCondensate Drain(Downflow)Vent OutletThermostatWiring28.5”Gas PipeEntryElectricalEntryCondensateDrainThermostatWiringRIGHT SIDEVent OutletCondensate Drain(Downflow)14”1”1.5”23”Combustion Air InletGas PipeEntryElectricalEntryCondensateDrainOptional Return AirCutout (Either side)29.5”CSUPPLY END.56”.56”20”B3”23.8”.56”CombustionAir InletVentOutletRETURN ENDB24.25”Cabinet & Duct DimensionsModels NominalCFM (m3/min)CabinetSizeCabinet Dimensions (Inches) ApproximateOperating WeightsABC LbsTG9S040A08MP11 800 A 14 1/2 13 3/8 11 3/4 113TG9S060A10MP11 1000 A 14 1/2 13 3/8 11 3/4 118TG9S060B12MP11 1200 B 17 1/2 16 3/8 13 1/4 122TG9S080B12MP11 1200 B 17 1/2 16 3/8 14 3/4 126TG9S080C16MP11 1600 C 21 19 7/8 16 1/2 136TG9S080C22MP11 2200 C 21 19 7/8 16 1/2 139TG9S100C16MP11 1600 C 21 19 7/8 18 1/4 142TG9S100C20MP11 2000 C 21 19 7/8 18 1/4 145TG9S120D16MP11 1600 D 24 1/2 23 3/8 21 3/4 153TG9S120D20MP11 2000 D 24 1/2 23 3/8 21 3/4 156TG9S130D20MP11 2000 D 24 1/2 23 3/8 No Hole 160Ratings & Physical / Electrical DataModels Input Output AFUE%Air Temp. Rise Max. OutletAir Temp Blower Blower SizeMax Over-Current ProtectTotal UnitAmpsMin. wire Size (awg) @ 75 ft one wayMBH MBH °F °F HP AmpsTG9S040A08MP11 40 38 95.5 30-60 160 1/3 4.8 11x8 15 8.0 14TG9S060A10MP11 60 57 95.5 30-60 160 1/2 7.1 11x8 15 10.0 14TG9S060B12MP11 60 57 95.5 30-60 160 1/2 7.1 11x8 15 10.0 14TG9S080B12MP11 80 76 95.5 35-65 165 1/2 7.1 11x8 15 10.0 14TG9S080C16MP11 80 76 95.5 35-65 165 3/4 8.8 11x10 15 11.5 14TG9S080C22MP11 80 76 95.5 35-65 165 1 14.5 11x11 20 17.0 12TG9S100C16MP11 100 95 95.5 35-65 165 3/4 8.8 11x10 15 11.5 14TG9S100C20MP11 100 95 95.5 35-65 165 1 14.5 11x11 20 17.0 12TG9S120D16MP11 120 114 95.5 40-70 170 3/4 8.8 11x10 15 11.5 14TG9S120D20MP11 120 114 95.5 35-65 165 1 14.5 11x11 20 17.0 12TG9S130D20MP11 130 123.5 95.5 45-75 175 1 14.5 11x11 20 17.0 12](https://usermanual.wiki/York/Tg9STechnicalGuide.779456254-User-Guide-Page-2.png)
: York Tg9S-Technical-Guide york-tg9s-technical-guide-811954 york pdf
Open the PDF directly: View PDF
Page Count: 6