User Manual for 3M models including: Respirator
Before use, the wearer must read and understand the User Instruct
1 your local 3M representative or call o ur 3M Technical Service Line at 1-800-243-4630. Respirator Program Management In the United States, where respirators
3M Respirator Selection Guide For more information In U.S. Technical Assistance Customer Care Center 3M.com/PPESafety 1-800-243-4630 1-800-328-1667 In Canada Technical Assistance Customer Care 3M.ca/PPESafety 1-800-267-4414 1-800-364-3577 © 3M 2019. Data for this guide compiled 2019. Table of Contents © 3M 2019 Data for this guide compiled 2019 Respirator Selection Criteria ................................................................................ 1 · Respirator Program Management · Respirator Fit · Assigned Protection Factors (APF) · Effects from Skin or Eye Contact · Human Factors · Location of Hazardous Areas · Respirator Characteristics, Capabilities, and Limitations · General Use Instructions · General Use Limitations Format Explanation............................................................................................... 4 · Chemical Name · CAS # · Synonyms · IDLH Level · OEL · Respirator Recommendations · Comments Particulate Filter Definitions ................................................................................10 · N-Series · R-Series · P-Series · HEPA How to Use This Guide .........................................................................................11 Chemical Compound Guide ...............................................................................15 Respirator Codes and Descriptions.......................................... end of document Selection of appropriate respiratory protective equipment (RPE) will depend on the particular situation and should be made only by a competent person knowledgeable of the actual working conditions and the limitations of RPE. Details regarding performance and limitations are set out on the respirator packaging and User Instructions. 3M respirators help protect against certain airborne contaminants. No respirator is capable of preventing all airborne contaminants from entering the wearer's breathing zone. Before use, the wearer must read and understand the User Instructions provided as a part of the product packaging. This guide summarizes certain U.S. respiratory requirements and considerations. Local requirements may vary. Follow all local regulations. In the U.S., a written respiratory protection program must be implemented meeting all the requirements of OSHA 29 CFR 1910.134 including training, fit testing, and medical evaluation. In Canada, CSA standards Z94.4 requirements must be met and/or requirements of the applicable jurisdiction, as appropriate. Misuse may result in sickness or death. For correct use, consult supervisor and User Instructions, or call 3M Personal Safety Division (PSD) Technical Service in the U.S.A. at 1-800-243-4630. In Canada, call 1-800-267-4414. 1 Respirator Selection Criteria The 3MTM Respirator Selection Guide includes a list of chemicals for which 3M respirators can help provide protection. This information can be used to supplement general industrial hygiene knowledge. Once workplace contaminants and their the guide can be used to help select an appropriate 3MTM Respirator for nearly 700 chemicals with Threshold Limit Values (TLVs®) or other recommended exposure limits. Because actual conditions vary from one worksite to another, this information is intended only as a guide. Selection of the most appropriate respirator will depend on the particular situation and should be made only by a person familiar with the and limitations of respiratory protection products. If you have any questions related to proper selection and use of 3M respirators, or the use of this guide, contact your local 3M representative or call our 3M Technical Service Line at 1-800-243-4630. Respirator Program Management In the United States, where respirators are in use in the workplace, a formal respiratory protection program must be established covering the requirements outlined in the OSHA Respiratory Protection Standard (29 CFR 1910.134). Education and training must be properly emphasized and conducted periodically. Maintenance, cleaning, and storage programs must be established and routinely followed for respirators that are reused. Respirator Fit The OSHA Respiratory Protection (disposable) respirator or a reusable respirator, the wearer must obtain a satisfactory a qualitative or quan test. Worker comfort should also be considered. Removal of the respirator in contaminated environments, even for short periods of time, dramatically reduces the protection afforded by the respirator. Assigned Protection Factors (APF) The respirator selected must have an assigned protection factor (APF) adequate for the particular workplace exposure. Divide the air contaminant concentration by the occupational exposure limit (OEL) to obtain a hazard ratio. Then select a respirator with an assigned protection factor greater than or equal to that hazard ratio. Hazard Ratio Airborne Contaminant Concentration = OEL Assigned protection factors* per OSHA 29 CFR 1910.134 are as follows: Air Purifying Respirators · Half facepiece (filtering facepiece- disposable and reusable) ..................... 10 · Full facepiece........................................ 50 Powered Air Purifying Respirators · Loose-fitting facepiece....................... 25 · Half facepiece....................................... 50 · Full facepiece, helmet, or hood .....1000** Supplied Air Respirators (airline) · Continuous Flow Loose-fitting facepiece................... 25 Half facepiece................................... 50 Full facepiece, helmet, or hood ..... 1000** ·Pressure demand with full facepiece.....1000 Self-Contained Breathing Apparatus (SCBA) Pressure demand airline with escape SCBA ............................................. 10,000 unknown and IDLH atmospheres Pressure demand SCBA............... 10,000 unknown and IDLH atmospheres Effects From Skin or Eye Contact If a chemical can be absorbed through the skin, skin protection may be required in addition to respiratory protection. Eye protection may also be necessary if not provided by the respirator. Failure to provide adequate skin or eye protection can invalidate established exposure limits and make respirator use ineffective for protection against certain workplace contaminants. *Assigned protection factors may vary for specific standards as promulgated by OSHA. Where assigned protection factors in local, state, or federal standards are lower than those listed here, they should be used instead. For additional limitations of 3M respiratory protection products, refer to 3M respirator packaging and User Instructions. ** Respirator manufacturer must provide data demonstrating performance of 1000 or greater, otherwise APF of 25. Respirator Selection Criteria 2 3 Human Factors Consider the entire package of safety equipment required for the job. The respirator selected must be compatible with hard hats, goggles, glasses, welding hoods, faceshields, etc. In addition, the worker must be able to communicate and perform required job duties without removing the respirator. If strenuous work is to be performed, or if the respirator is to be worn for an extended period of time, it may be desirable to select a lightweight respirator with low breathing resistance. If a respirator does not have good worker acceptance and does not stay on the worker's face, it will not provide the protection needed. Location Of Hazardous Area When specifying supplied air respirators, consider the distance the worker must travel to get to an uncontaminated work area, as well as obstacles or equipment present in the area. If ladders or scaffolds must be climbed, a supplied air respirator or a combination air purifying/supplied air respirator may not be appropriate. Respirator Characteristics, Capabilities, and Limitations A respirator may not be able to help protect against all of the contaminants present in a particular work environment. Specific limitations are stated on the approval labels and are included with User Instructions. These must be carefully reviewed for each respirator before use. General precautionary information is given below. Refer to respirator packaging and User Instructions for specific information. General Use Instructions · Failure to follow all instructions and limitations on the use of these respirators and/or failure to wear them properly during all times of exposure can reduce respirator effectiveness and may result in sickness or death. · Many of the contaminants that can be dangerous to a person's health include ones that are so small they cannot be seen or smelled at dangerous levels. · Before use of any respirator, the wearer must first be trained by the employer in proper respirator use in accordance with applicable safety and health standards. · The OSHA Respiratory Protection Standard (29 CFR 1910.134(f)(1)) requires that the wearer of any tight-fitting respirator be fit tested. · Leave the contaminated area immediately if dizziness or other distress occurs, if the respirator becomes damaged or breathing becomes difficult, if contaminants can be smelled or tasted, or if irritation occurs. General Use Limitations · Air purifying respirators do not supply oxygen. · Only use self-contained breathing apparatus (SCBA) or combination supplied air/SCBA when concentrations are unknown, or in atmospheres containing less than 19.5% oxygen. · Do not abuse or misuse any respirator. · Do not use tight-fitting respirators or loose-fitting facepieces with beards or other facial hair or conditions that prevent direct contact between the face and the edge of the respirator. · Do not use when concentrations exceed maximum use concentrations established by regulatory agencies. Format Explanation Chemical Name Chemical names listed in this guide are generally those used in the Threshold Limit Values and Biological Exposure Indices for 2019 published by the American Conference of Governmental Industrial Hygienists (ACGIH). Pesticides and chemicals without established occupational exposure limits are not included. Call 3M Technical Service for assistance in selecting respirators for these chemicals. CAS # Chemical abstract service registry numbers were established by the American Chemical Society to harmonize chemical identification regardless of the synonym used or differences in spelling. Synonyms Several common synonyms are listed in this column. IDLH Level This is the concentration considered Immediately Dangerous to Life or Health (IDLH), as published by the National Institute for Occupational Safety and Health (NIOSH) (DHHS [NIOSH] Publication No. 90-117). It specifically refers to the acute respiratory exposure that poses an immediate threat of loss of life, immediate or delayed irreversible adverse effects on health, or acute eye exposure that would prevent escape from a hazardous atmosphere. Format Explanation 4 5 The reasons NIOSH established an IDLH at a particular level for a specific chemical are described in Documentation for Immediately Dangerous to Life or Health Concentrations (IDLHs), NTIS Publication No. PB-94-195047, May 1994. The 1994 IDLH values established by NIOSH used interim criteria, and OSHA stated in a August 3, 1998 memorandum that OSHA will use the older 1990 IDLH values. The 1990 IDLH values are used in this guide, but OSHA allows employers to use other IDLH values. For those substances with no IDLH listed, the manufacturer or supplier may have additional chemical information. The Chemical Referral Center operated by the Chemical Manufacturers Association can assist in providing telephone numbers for obtaining information from manufacturers. The lower explosive level (LEL) has been listed when an IDLH value was not located. The concentration that would result in an oxygen deficient atmosphere should also be considered to be IDLH. OEL · The occupational exposure limits listed are 2019 ACGIH Threshold Limit Values (TLVs), unless otherwise stated. From ACGIH®, 2019 TLVs® and BEIs® Book. Copyright 2019. Reprinted with permission. The concentrations are expressed in ppm -- parts per million (parts of contaminant per million parts of air) -- unless specifically stated as mg/m3 (milligrams of contaminant per cubic meter of air) or some other unit. · The OSHA Permissible Exposure Limit (PEL) is listed when it is more stringent than the current TLV. · The 2010 Workplace Environmental Exposure Levels (WEEL) from the American Industrial Hygiene Association is listed when it is the most stringent value or there is no TLV or PEL. · Time Weighted Average (TWA) exposure limits are for a normal eight (8) hour workday and a forty (40) hour work-week. · Short-Term Exposure Limit (STEL) is a 15-minute time weighted average exposure which should not be exceeded at any time during a workday. · Ceiling (C) exposure limits refer to concentrations that should not be exceeded during any part of the working exposure. · Exposure limits for particulates are as total dust unless otherwise noted (e.g., inhalable fraction, respirable fraction, respirable fibers, etc.) · Skin notations indicate the substance can be absorbed through the skin. In these cases, appropriate measures must be taken to prevent skin and eye contact to avoid invalidating the OEL. · For a more detailed explanation of TLVs and their proper application, refer to the TLV booklet available for a nominal fee from ACGIH, 1330 Kemper Meadow Drive, Cincinnati, OH 45240 www.acgih.org. Odor Threshold Odor thresholds have been removed from this version of the guide. While contaminant odor or irritation may serve as a secondary indicator of when to change cartridges, it cannot be used as the primary indicator for when to change. For more information on odor thresholds, please see relevant publications such as "Odor Thresholds for Chemicals with Established Health Standards, Second Edition. AIHA (2013)." Respirator Type This column lists the suggested type of particulate, gas/vapor, or supplied air respirator. The abbreviations used are explained at the end of this document. Not all of these respirators have been specifically tested against each compound listed. Either specific testing or a review of chemical and physical properties of the materials, as well as adsorption or filtration characteristics of the respirators, forms the basis for the recommendations. The recommendations are for single substances. When two or more substances are present, a combination respirator may be appropriate. For example, with a spray paint that contains organic solvents and titanium dioxide, a respirator consisting of an organic vapor cartridge and a particle filter may be appropriate. In cases where an air purifying respirator is not available for all of the substances of concern in a mixture, a supplied air respirator may be required. In some cases, the respirator is preceded by an "(F)" designation. These contaminants have been identified as potential eye irritants. Full facepieces, hoods, helmets or loose fitting facepieces, or half facepieces with appropriate eye protection should be considered. Format Explanation 6 7 Do not exceed maximum use concentrations established by regulatory agencies. Follow the protection factor guidelines in specific OSHA standards, and refer to the instructions in the Respirator Selection Criteria and How To Use This Guide sections of this guide. When a chemical cartridge respirator is recommended, it can only be used if a cartridge change schedule is established as described in 29 CFR 1910.134 (d)(3)(iii) (B) (2). If a change schedule is not established, a supplied air respirator must be used instead. Comments Other information may be listed in this column: A. Short service life means predicted cartridge life of less than 30 minutes at concentrations of ten times (10X) the OEL, or the contaminant's boiling point is less than 65C. Actual service life will vary considerably depending on concentration levels, temperature, humidity, work rate, etc. See the following literature references for specific details on the conditions and limitations of these estimates: 1. 3M Company. 3M Service Life Software. 3M.com/sls 2. Nelson, G.O. and C.A. Harder. Respirator Cartridge Efficiency Studies: V. Effect of Solvent Vapor. Am. Ind. Hyg. Assoc. J. 35(7): 391-410 (1974). Sometimes, a supplied air respirator is recommended because the service life may be so short that the frequency required for changing the cartridges may not be practical. References to Ineffective sorbents or Unknown sorbent effectiveness indicate 3M does not make chemical cartridge respirators appropriate for these substances at this time or it is not known how effective the sorbents would be for these materials. B. References to a respirator not being specifically approved refer to approvals for that particular substance only. All respirators listed in this guide are NIOSH approved for specific substances and/or conditions. C. Comments regarding warning properties have been removed as OSHA allows air purifying respirators to be used against gases and vapors with poor or unknown warning properties. Instead cartridge change schedules based on objective information and data must be established. D. These compounds have been identified as possibly existing in both particulate and vapor phase in the workplace. For these compounds, 3M recommends that a gas/vapor cartridge be used in addition to the traditionally accepted particulate filter. It is the user's responsibility to determine whether both forms coexist. Both chemical properties and use conditions/processes can affect the physical form in the workplace. Users should consider specific exposure data and Both chemical properties and use workplace conditions before making conditions/processes can affect the their final selection.* If a chemical physical form in the workplace. Users cartridge is used, a change schedule should consider specific exposure must be established to replace the data and workplace conditions before cartridges before the end of their making their final selection.* service life. E. These compounds have been identified as possibly existing in both vapor and particulate phase in the workplace. Even though these chemicals would be expected to be in the vapor phase, when other aerosols are present or there is high humidity, it is possible that the vapor may be adsorbed onto these coexisting particles or dissolved in available water droplets; therefore, 3M recommends a filter for the F. It is believed that an N-series filter is sufficient since these materials will not coat the filter fibers, but since this material may contain oil aerosols, an R- or P-series filter is recommended until further research or a regulatory agency takes a specific position. G. R- or P-series filters have been recommended pending more research as to how these materials affect the filter fibers. particulate phase be used in addition H. Listing of 3M 3510, 3530, 3550, or to the traditionally accepted chemical 3720 refers to a 3MTM Personal Air cartridge. It is the user's responsibility to Monitor with Pre-Paid Analysis. determine whether both forms coexist. * See Perez, C. and S. C. Soderholm: Some Chemicals Requiring Special Consideration When Deciding Whether to Sample the Particle, Vapor, or Both Phases of an Atmosphere. Appl. Occup. Hyg. 6(10): 859-864 (1991). Format Explanation 8 9 Monitors may be used to measure the amount of specific contaminants in the air. 3MTM Monitors without pre-paid analysis may be used with analysis performed by a private laboratory. You should check with the laboratory to determine what other chemicals can be measured with the monitors. An estimate of the airborne concentration is needed for making appropriate respirator selection and establishing a cartridge change schedule. Contact the toll free 3M Technical Service Line at 1-800-243-4630 if you have questions about the use of this guide or the proper selection and use and limitations of any 3M respirators. Particulate Filter Definitions N-Series Filters: These filters are restricted to use in atmospheres free of oil aerosols. They may be used for any solid or liquid airborne particulate hazard that does not contain oil. Generally these filters should be replaced subject to considerations of hygiene, damage, and increased breathing resistance. R-Series Filters: A filter intended for removal of any particle including oil-based liquid aerosol. They may be used for any solid or liquid airborne particulate hazard. If the atmosphere contains oil, the R-series filter should be used only for a single shift (or for 8 hours of continuous or intermittent use). P-Series Filters: A filter intended for removal of any particle including oil-based liquid aerosols. They may be used for any solid or liquid particulate airborne hazard. NIOSH requires that respirator manufacturers establish time-use limitations for all P-series filters. 3M recommends that in atmospheres containing oil aerosols, P-series filters should be used and reused for no more than 40 hours of use or 30 days, whichever occurs first, unless the filter needs to be changed for hygiene reasons, is damaged, or becomes difficult to breathe through before the time limit is reached. When used in atmospheres containing non-oil aerosol, 3M P-series filters should be replaced subject to conditions of hygiene, damage and increased breathing resistance. Oil: Any of numerous mineral, vegetable and synthetic substances and animal and vegetable fats that are generally slippery, combustible, viscous, liquid or liquefiable at room temperatures soluble in various organic solvents such as ether but not in water. 95 Level Filter At least 95% filtration efficiency per the NIOSH 42 CFR 84 test method. 100 Level Filter At least 99.97% filtration efficiency per the NIOSH 42 CFR 84 test method. HEPA Filter At least 99.97% filtration efficiency per the NIOSH 42 CFR 84 test method. Filter class for powered air purifying respirators (PAPRs) only. Use instead of N, R, P type filters. Particulate Filter Definitions 10 11 How to Use this Guide If a respirator is being selected for a single compound listed in this guide with an air concentration not exceeding either the respirator APF times the OEL, or the IDLH, then the respirator identified in the Respirator column may be appropriate for selection. Descriptions of the respirator codes may be found at the end of this guide. If a particulate filter respirator is recommended (any respirator code with N95, N100, R95, P95 or P100 in it) and a mineral, vegetable or synthetic oil or other oily material is also present in the air, you must select a respirator that provides the same efficiency but is acceptable for oil aerosols (see Oil definition given previously). For example, if a respirator is being selected for beryllium dust at a concentration 2 times the exposure limit, the guide lists N95. If an oil mist is present (air concentration greater than 0.1 mg/m3, but less than the occupational exposure limit) either an Ror P-series filter must be selected, even though respiratory protection is not needed for the oil mist. For PAPRs, use a HEPA filter instead of the N, R or P type particle filters listed in the guide. If respiratory protection is required for an atmosphere with more than one chemical, you must follow the directions below for proper respirator selection. If you need help, call 3M Technical Service at 1-800-243-4630. 1. Identify the air contaminants present in the workplace. Include chemical name and form. Classify particulate contaminants as oil or non-oil material. If the chemical is listed in this guide, it is classified. For help, see definition of oil. The material safety data sheet (MSDS) can be helpful with this step. Consider particulate contaminants as oil if unknown or not sure. List the contaminants on the form contained in this guide or on your own form. Go to Step 2. 2. Determine the air concentration of the contaminant(s). Air sampling is highly recommended. Consideration should be given to TWA, short term and peak (ceiling) exposures, while keeping in mind seasonal and worker variability and the specific process being used. If air sampling data are not available and sampling is not practical, historical information from similar processes or analogous operations may be helpful for calculating maximum exposures and evaluating potential health effects. Record the airborne concentration(s) on the form provided or your own form. Go to Step 3. 3. Is the airborne concentration unknown? a) If yes, go to Step 16. b) If no, go to Step 4. 4. Is the oxygen concentration less than 19.5% or does the potential exist for the oxygen concentration to fall below 19.5%? a) If yes, go to Step 16. b) If no, go to Step 5. 5. Is the chemical listed in the guide? a) If yes, go to Step 6. b) If no, go to Step 15. 6. Record the IDLH value and the value from the OEL column on the form provided or on one you created. Determine the hazard ratio (see page 1) and record. Using this information, determine which condition describes your situation: a) Does the airborne concentration exceed the IDLH value? If yes, go to Step 16. b) Does the hazard ratio exceed (>) 1000? If yes, go to Step 16. c) Does the hazard ratio exceed (>) 50?If yes, go to Step 7. d) Does the hazard ratio exceed (>) 10? If yes, go to Step 8. e) Is the hazard ratio less than or equal to () 10? If yes, go to Step 9. 7. If the hazard ratio exceeds 50, but is less than 1000: Select one of the following respirators: (1) a full facepiece, helmet or hood supplied air respirator or (2) a full facepiece, helmet or hood powered air purifying respirator (PAPR) with the same cartridge type as listed in the guide under the Respirator column. If a PAPR is selected, use a HEPA filter if an N, R, or P-series filter is listed. If the guide lists SA or SA(F), a PAPR cannot be used. If a gas or vapor respirator is selected, cartridge change schedules based on objective data must be established. Otherwise supplied air respirators must be used. The service life of gas or vapor cartridges should be considered to determine if supplied air respirators are a better selection given the high exposure concentrations. Record the respirator you selected in the last column of the form for that chemical. Go to Step 10. 8. If the hazard ratio exceeds 10 but is less than 50, select one of the following respirators: (1) If the guide lists SA or SA(F), a supplied air respirator must be used. Loose fitting facepieces may only be used if the hazard ratio is less than 25. (2) A powered air purifying respirator (PAPR) may be used with the cartridge and/or filter type listed under the Respirator column. Use a HEPA filter if an N, R, P-series filter is listed. Loose fitting facepiece may only be used if the hazard ratio is less than 25. (3) A full facepiece respirator that has been quantitatively fit tested may be used with cartridges and/or filters listed under the Respirator column. If a gas or vapor respirator is selected, cartridge change schedules based on objective data must be established. Otherwise supplied air respirators must be used. Record the respirator you selected in the last column of the form for that chemical. Go to Step 10. 9. If the hazard ratio is less than or equal to 10: Select the respirator type listed in the Respirator column. If a gas or vapor respirator is selected, cartridge change schedules based on objective data must be established. Otherwise supplied air respirators must be used. Record the respirator you selected in the last column of the form for that chemical. Go to Step 10. 10. Are any other air contaminants present at the same time? a) If yes, go to Step 2 and repeat the procedure, recording the appropriate information for the next chemical. When two or more contaminants that act upon How to Use This Guide 12 13 the same organ system are present, consideration should be given to the combined effect rather than individual effects. Consult the current TLVs® and documentation published by the American Conference of Governmental Industrial Hygienists for more information and the appropriate formula. If combined effects are considered, calculate the hazard ratio for the mixture. b) If no, go to Step 11. 11. Are any of the respirators listed in the last column a particulate filter respirator (i.e., does it have an N, R or P filter?)? a) If yes, go to Step 12. b) If no, go to Step 14. 12. Are only N-series particulate filter respirator(s) listed? a) If yes, go to Step 13. b) If no, go to Step 14. 13. Is airborne oil mist present at a concentration greater than 0.1 mg/m³ but less than the value in the OEL column of the guide? (If a respirator is not being selected for oil, the presence of the oil must still be considered when choosing the appropriate filter.) a) If yes, a respirator with either an R- or P-series or HEPA filter must be selected. R-series filters must be changed after 8 hours use or after the respirator is loaded with or exposed to 200 mg of aerosol. The manufacturer's service time recommendation must be followed for P-series filters. Record the respirator with the R- or P-series filter that is being selected. Go to Step 14. b) If no, go to Step 14. 14. Was more than one respirator type required for the specific exposure situation (i.e., is there more than one respirator code included in the list made in the last column of the form?)? a) If yes, note all respirators recommended. If your list contains more than one respirator and all are airpurifying respirators, select the one with the highest assigned protection factor (see page 2) and one that removes all of the contaminants, if available. If SA or SA(F) is one of the respirators listed, this respirator must be selected over all others. If any of the respirator codes contain the (F) designation, respirators with half facepieces cannot be used unless appropriate eye protection is also worn. If no air-purifying respirator will provide the protection required, select SA or SA(F). Go to Step 17. b) If no, record the respirator listed as the final respirator selected (bottom line). Go to Step 17. 15. If the chemical is not listed in the guide, either it is a pesticide or an occupational exposure limit was not located. If an acceptable exposure level is not known, a respirator cannot be recommended. If you have an exposure level for the material and would like help, go to Step 17. If no exposure limit is known, go to Step 16. 16. These conditions (unknown, <19.5% oxygen, airborne concentration >IDLH) are generally considered as IDLH or the hazard ratio exceeds 1000. Select either a positive pressure self-contained breathing apparatus (SCBA) or combination respirator consisting of a positive pressure supplied air respirator with an auxiliary SCBA. The rated duration of the auxiliary SCBA should be sufficient to allow adequate time for escape. Record the respirator selected in the final row of the form. This is the minimum acceptable level of respiratory protection; the selection process is finished. If you need help, go to Step 17. 17. Do you need help? a) If yes, call 3M for assistance at 1-800-243-4630. b) If no, order the selected respirator(s) from your local safety equipment distributor. Chemical Name Respirator Selection Form Air IDLH OEL Concentration Hazard Ratio Respirator Type Respirator Selected: 14 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 15 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Acetaldehyde 75-07-0 Acetamide 60-35-5 Acetic acid 64-19-7 Acetic anhydride 108-24-7 Acetone 67-64-1 Acetone cyanohydrin 75-86-5 Acetonitrile 75-05-8 Acetic aldehyde, Ethanal 10000 Ethanamide Ethanoic acid, Glacial acetic 1000 acid, Methane carboxylic acid, Vinegar acid Acetic acid anhydride, Acetyl 1000 oxide, Ethanoic anhydride 2-Propanone, Dimethyl ketone, 20000 Ketone propane 2-Cyano-2-propanol, 2-Hydroxy-2-methyl propanenitrile, 2-Methyllactonile, 2-Propane cyanohydrin, a-Hydroxy isobutyronitrile 22000 Cyanomethane, Ethane nitrile, Ethyl nitrile, Methanecarbonitrile, Methyl cyanide 4000 TWA=200 (OSHA) (F)OV C=25 (F)MG TWA=1 (inhalable fraction and vapor) TWA=10 STEL=15 OV/N95 (F)OV/AG TWA=1 STEL=3 (F)OV TWA=250 OV STEL=500 TWA=2 (AIHA) OV STEL=5 (AIHA) C=5 mg/m3 (as CN) -skin- TWA=20 OV -skin- Multigas cartridge recommended for longer service life See comment D on page 8 Short service life. 3M 3530 Monitor 3M 3530 Monitor Acetophenone 98-86-2 Acetylsalicylic acid 50-78-2 Acrolein 107-02-8 Acrylamide 79-06-1 1-Phenylethanone, Acetyl benzene, Benzoyl methide, Methyl phenyl ketone Aspirin Acrylaldehyde, 5 Acrylic aldehyde, Allylaldehyde, Propenal Acrylamide monomer, Acrylic amide, Propenamide Acrylic acid 79-10-7 Acrylonitrile 107-13-1 Acroleic acid, Propenoic acid 24000 AN, Propenenitrile, 500 Vinyl cyanide TWA=10 OV TWA=5 mg/m3 N95 TWA=0.1 (OSHA) C=0.1 -skin- (F)OV TWA=0.03 mg/m3 (inhalable fraction and vapor) -skin- OV/N95 TWA=2 -skin- (F)OV TWA=2 OV -skin- Adipic acid 124-04-9 1,4-Butanedicarboxylic acid, 1,6-Hexanedioic acid, Adipinic acid, Hexanedioic acid TWA=5 mg/m3 (F)N95 See comment E on page 8 Short service life See comment D on page 8 SA if cartridge not disposed of after shift, per 29 CFR 1910.1045. 3M 3510 monitor. Chemical Compound Guide 16 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 17 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Adiponitrile 111-69-3 Allyl alcohol 107-18-6 Allyl Bromide 106-95-6 Allyl chloride 107-05-1 Allyl glycidyl ether 106-92-3 Allyl isothiocyanate 57-06-7 1,4-Dicyanobutane, Addipic acid dinitrile, Hexanedinitrile, Tetramethylene cyanide 17000 2-Propen-1-ol, 2-Propenol, 150 Vinyl carbinol 1-Bromo-2-propene; 1-Propene; 44000 3-bromo-; 2-Propenyl bromide; 3-Bromo-1propene; 3-Bromopropene; 3-Bromoproylene 1-Chloro-2-propene, 300 3-Chloropropene 1-Allyloxy-2,3-epoxy-propane, 270 AGE AITC, Allyl isosulfocyanate, Allyl thiocarbanimide, Oil of mustard, 3-Isothiocyanate-1-propene TWA=2 -skin- TWA=0.5 -skin- TWA=0.1 STEL=0.2 -skin- TWA=1 STEL=2 -skin- TWA=1 C=10 (OSHA) STEL=1 (AIHA) -skin- OV (F)OV (F)OV OV (F)OV OV 3M 3510 Monitor Short service life SA if used with acids Allyl Methacrylate, 96-05-9 AMA TWA=1 OV -skin- Allyl propyl disulfide 2-Propenyl propyl disulfide, 2179-59-1 Onion oil, Propyl allyl disulfide TWA=0.5 (F)OV alpha-Alumina 1344-28-1 Aluminum metal and insoluble compounds 7429-90-5 p-Aminobenzoic acid 4-Aminobenzoic acid, 150-13-0 Aminobenzoic acid, PABA 2-Aminopyridine a-Aminopyridine 5 504-29-0 Aminotri (methylenephosphonic acid) 6419-19-8 ATMP, Briquest 301-32S, Briquest 302-500, Dequest 2000, Dequest 2001, Nitrilotrimethanephosphonic acid, NTF, NTMP, NTPA Ammonia 7664-41-7 Anhydrous ammonia 500 Ammonium chloride (liquids) 12125-02-9 Ammonium chloride (solids) 12125-02-9 TWA=15 mg/m3 (OSHA) TWA=15 mg/m3 (OSHA) TWA=1 mg/m3 (respirable fraction) TWA=5 mg/m3 (AIHA) TWA=0.5 N95 N95 (F)N95 OV TWA=10 mg/m3 (AIHA) AG/N95 TWA=25 STEL=35 TWA=10 mg/m3 STEL=20 mg/m3 TWA=10 mg/m3 STEL=20 mg/m3 (F)AM AM/N95 N95 If heated, AG cartridge may be needed Irritation also provides warning 18 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 19 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Ammonium perfluorooctanoate 3825-26-1 n-Amyl alcohol 71-41-0 tert-Amyl methyl ether 994-05-8 Aniline 62-53-3 o-Anisidine 90-04-0 29191-52-4 p-Anisidine 104-94-9 29191-52-4 Antimony and compounds (as Sb) 7440-36-0 1-Pentanol, Amyl alcohol, n-Butyl carbinol, n-Pentanol, Pentanol, Pentyl alcohol TAME TWA=0.01 mg/m3 -skin- OV/N95 TWA=100 (AIHA) (F)OV TWA=20 OV Aminobenzene, Aniline oil, Phenylamine 2-Methoxyaniline, o-Aminoanisole, o-Methoxyaniline (oil) 4-Methoxyaniline, pAminoanisole, p-Methoxyaniline (solid) 100 50 mg/m3 TWA=2 -skin- TWA=0.5 mg/m3 -skin- 50 mg/m3 TWA=0.5 mg/m3 -skin- 80 mg/m3 TWA=0.5 mg/m3 OV OV/P95 OV/N95 N95 See comment D on page 8 3M 3510 Monitor Arsenic, elemental 7440-38-2 Arsenic, inorganic compounds (except arsine) (as As) 100 mg/m3 TWA=0.01 mg/m3 N100 100 mg/m3 TWA=0.01 mg/m3 MG/N100 Arsenic, organic compounds (as As) Arsine 7784-42-1 Asbestos 1332-21-4 Asphalt (petroleum; bitumen) fumes 8052-42-4 Arsenic hydride, Arsenic 6 trihydride, Arseniuretted hydrogen, Arsenous hydride, Hydrogen arsenide Actinolite, Amosite, Anthophyllite, Chrysotile, Crocidolite, Tremolite Asphaltic bitumen, Asphaltum, Bitumen, Hot mix asphalt, Mineral pitch, Petroleum asphalt, Road asphalt, Road tar TWA=0.5 mg/m3 (OSHA) OV/N100 TWA=0.005 (F)SA TWA= 0.1 f/cc (respirable fibers) N100 TWA=0.5 mg/m3 (inhalable fraction as benzene-soluble aerosol) OV/P95 No half mask respirators for arsenic trichloride because of skin adsorption. N100 may be appropriate if vapor concentrations are below exposure limits MG/N100 may be required for certain organic arsenic compounds Unknown sorbent effectiveness Dual cartridge as per 29 CFR 1910.1001, 1915.1001 and 1926.1101 R or P95 alone may be suitable for some applications. See comment F on page 8 20 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 21 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Barium and soluble compounds (as Ba) 7440-39-3 Barium sulfate 7727-43-7 Benzaldehyde 100-52-7 Benzene 71-43-2 1100 mg/m3 TWA=0.5 mg/m3 N95 Benzenecarbonal, Benzoic aldehyde, Oil of bitter almond Benzol, Coal tar naptha 3000 TWA= 5 mg/m3 (inhalable fraction) TWA=2 (AIHA) STEL=4 (AIHA) N95 (F)OV TWA=0.5 OV STEL=2.5 -skin- Benzophenone 119-61-9 Benzotrichloride 98-07-7 Benzoyl benzene, Diphenyl ketone, Diphenyl methanone, Phenyl ketone Benzenyl trichloride, Benzenylchloride, Benzoic trichloride, Benzyl trichloride, Phenyl chloroform, Toluene trichloride, Trichloromethylbenzene TWA=0.5 mg/m3 (AIHA) OV/N95 C=0.1 -skin- (F)OV SA if cartridges are not replaced at the start of each shift, per 20 CFR 1910.1028. 3M 3510 Monitor See comment D on page 8 Benzoyl chloride 98-88-4 a-Chlorobenzaldehyde, Benzene carbonyl chloride, Benzoic acid chloride C=0.5 (F)OV/AG (F)MG Benzoyl peroxide 94-36-0 Dibenzoyl peroxide 7000 mg/m3 TWA=5 mg/m3 OV/N95 See comment D on page 8 Benzyl acetate 140-11-4 Acetic acid benzyl ester, Acetic acid phenylmethyl ester, Phenylmethyl acetate TWA=10 OV/N95 Benzyl alcohol 100-51-6 a-Hydroxytoluene, Phenylcarbinol, Phenylmethanol TWA=10 (AIHA) (F)OV Benzyl chloride 100-44-7 Beryllium and compounds (as Be) 7440-41-7 a-Chlorotoluene 10 TWA=1 (F)OV/AG 10 mg/m3 TWA=0.00005 N95 mg/m3 (inhalable fraction) STEL=0.002 mg/m3 (OSHA) -skin- See comment E on page 8. 3M 3510 Monitor See OSHA standard 1910.1024 regarding PAPRs requested by employee Biphenyl 92-52-4 Diphenyl, Phenylbenzene 300 mg/m3 TWA=0.2 OV/N95 Bismuth telluride (undoped) 1304-82-1 Bismuth sesquitelluride TWA=10 mg/m3 N95 TWA=5 mg/m3 (OSHA, respirable fraction) 22 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 23 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Bismuth telluride (Se-doped) (as Bi2Te3) Boric acid 10043-35-3 Boron oxide 1303-86-2 Boron tribromide 10294-33-4 Boron trichloride 10294-34-5 Boron trifluoride 7637-07-2 Borofax, Boron trihydroxide, Hydrogen orthoborate, Kill-off, Kjel-sorb Orthoboric acid, Three elephant, Trihydroxyborane Anhydrous boric acid, Boric anhydride, Boric oxide Boron bromide Trichloroboron 100 Boron trifluoride diethyl ether 109-63-7 Boron trifluoride dimethyl ether 353-42-4 TWA=5 mg/m3 N95 TWA=2 mg/m3 N95 (inhalable fraction) STEL=6 mg/m3 (inhalable fraction) TWA=10 mg/m3 N95 C=0.7 C=0.7 STEL=0.1 C=0.7 TWA=0.1 (as BF3) C=0.7 (as BF3) TWA=0.1 (as BF3) C=0.7 (as BF3) (F)AG (F)AG (F)AG (F)OV/AG (F)OV/AG Bromine 7726-95-6 Bromine pentafluoride 7789-30-2 Bromoform 75-25-2 1-Bromopropane 106-94-5 1,3-Butadiene 106-99-0 Tribromomethane n-Propylbromide, Propylbromide Biethylene, Divinyl, Erythrene 10 TWA=0.1 STEL=0.2 TWA=0.1 (F)AG AG 20000 TWA=0.5 TWA=0.1 TWA=1 (OSHA) STEL=5 (OSHA) (F)OV OV OV Butane 106-97-8 n-Butane, 16000 STEL=1000 SA Methylethyl methane 1-Butene 106-98-9 1-Butylene, a-Butene, a-Butylene, But-1-ene, Ethylethylene TWA=250 OV 2-Butene (mixture of trans- and cis-) 107-01-7 b-Butene, b-Butylene, Dimethylethylene, Pseudobutylene TWA=250 OV cis-2-Butene 590-18-1 b-cis-Butylene, cis-1,2Dimethylethylene, cis-Butene, cis-Butene-2 TWA=250 OV Irritation also provides warning 3M 3510 Monitor 3M 3510 Monitor Cartridges must be replaced, per 29 CFR 1910.1051. 3M 3530 Monitor Short OV service life Short service life Short service life Short service life 24 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 25 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments trans-2-Butene 624-64-6 2-Butoxyethanol 111-76-2 2-Butoxyethyl acetate 112-07-2 n-Butyl acetate 123-86-4 sec-Butyl acetate 105-46-4 tert-Butyl acetate 540-88-5 Butyl acrylate 141-32-2 2-Butene,(E)-; 2-trans-Butene, b-trans-Butylene, trans-1,2Dimethylethylene, trans-Butene Butyl Cellosolve®, Ethylene 700 glycol monobutylether Acetic acid, 2-butoxyethyl ester; 2-Butoxyethanol acetate; Butyl Cellusolve acetate; Butylglycol acetate; EGBA; Ektasolve EB acetate; Ethylene glycol monobutyl ether acetate; Glycol monobutyl ether acetate 8800 Acetic acid butyl ester, Butyl 10000 acetate, Butyl ethanoate 1-Methylpropylacetate 10000 Acetic acid tert-butyl ester 10000 2-Propenoic acid butyl ester, 15000 Butyl 2-propenoate TWA=250 TWA=20 TWA=20 TWA=50 STEL=150 TWA=50 STEL=150 TWA=50 STEL=150 TWA=2 OV (F)OV OV (F)OV (F)OV (F)OV OV Short service life See comment E on page 8. 3M 3510 Monitor 3M 3510 Monitor See comment E on page 8. 3M 3510 Monitor. See comment E on page 8. 3M 3510 Monitor. 3M 3510 Monitor 3M 3510 Monitor n-Butyl alcohol 71-36-3 1-Butanol, 1-Hydroxybutane, Butyl alcohol, Butyl hydroxide, Butyric alcohol, Methylolpropane, n-Butanol, n-Propyl carbinol, Propyl methanol 8000 TWA=20 (F)OV 3M 3510 Monitor sec-Butyl alcohol 78-92-2 2-Butanol, Methyl ethyl carbinol 10000 TWA=100 (F)OV 3M 3510 Monitor tert-Butyl alcohol 75-65-0 2-Methyl-2-propanol, TBA, Trimethyl carbinol 8000 TWA=100 (F)OV 3M 3510 Monitor Butylamine 109-73-9 Butylated hydroxytoluene 128-37-0 1-Aminobutane, n-Butylamine 2000 2,6-bis(1,1-Dimethylethyl)-4methylphenol; 2,6-Di-tert-butylp-cresol; BHT; DBPD C=5 AM -skin- TWA=2 mg/m3 (inhalable fraction and vapor) (F)OV/N95 AM not specifically approved, but 3M recommended for longer service life See comment D on page 8 4-tert-Butylcatechol 98-29-3 4-(1,1-Dimethylethyl)-1,2benzenediol; 4-tert-Butyl pyrocatechol; 4-tert-Butyl-1-1,2dihydroxy benzene; p-tertButylcatechol C= 2 mg/m3 (AIHA) (F)N95 -skin- tert-Butyl Chromic acid di-tert-butyl ester 30 mg/m3 TWA=0.005 mg/m3 N95 chromate (as CrO3) 1189-85-1 (OSHA) C=0.1 mg/m3 -skin- 26 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 27 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Butylene oxide 106-88-7 n-Butyl glycidyl ether 2426-08-6 1,2-Butene oxide; 1,2-Butylene oxide; 1,2-Epoxybutane; 1-Butene oxide; BO; Epoxybutane 1,2-Epoxy-3-butoxypropane, BGE 3500 TWA=2 (AIHA) OV TWA=3 OV -skin- Short service life 3M 3510 Monitor tert-Butyl hydroperoxide 1,1-Dimethylethyl hydroperoxide 75-91-2 TWA=0.1 -skin- (F)OV Irritation also provides warning n-Butyl lactate 138-22-7 Butyl mercaptan 109-79-5 o-sec-Butylphenol 89-72-5 p-tert-Butyltoluene 98-51-1 Butyraldehyde 123-72-8 Lactic acid butylester 11500 1-Mercaptobutane, n-Butanethiol 2-sec-Butylphenol 2500 1-Methyl-4-tert-butylbenzene 1000 Butal, Butaldehyde, Butalyde, Butanal, Butanaldehyde, Butylaldehyde, Butyral butyric aldehyde 19000 TWA=5 TWA=0.5 TWA=5 -skinTWA=1 TWA=25 (AIHA) OV OV OV/P95 OV (F)Form Irritation also provides warning Formaldehyde cartridge not specifically approved, but 3M recommended for longer service life Cadmium and compounds (as Cd) 7440-43-9 Calcium arsenate (as As) 7778-44-1 Calcium carbonate 1317-65-3 Calcium chromate (as Cr) 13765-19-0 Calcium cyanamide 156-62-7 Calcium fluoride (as F) 7789-75-5 Cadmium oxide fume 9 mg/m3 (fume) 50 mg/m3 TWA=0.002 mg/m3 (respirable fraction) TWA=0.005 mg/ m3 (OSHA) Cucumber dust, Tricalcium 100 mg/m3 TWA=0.01 mg/m3 arsenate, Tricalcium o-arsenate N100 N100 Limestone, Marble Calcium chrome yellow Calcium carbimide, Lime nitrogen Fluorite, Fluorospar 30 mg/m3 TWA=15 mg/m3 N95 (OSHA) TWA= 5 mg/m3 (OSHA, respirable fraction) TWA=0.0002 mg/m3 N95 (as Cr(VI), inhalable fraction) STEL=0.0005 mg/m3 (as Cr(VI), inhalable fraction) -skin- TWA=0.5 mg/m3 N95 TWA= 2.5 mg/m3 N95 28 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 29 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Calcium hydroxide 1305-62-0 Calcium oxide 1305-78-8 Calcium silicate (containing no asbestos and <1% crystaline silica) 1344-95-2 Calcium sulfate 7778-18-9 Camphor 76-22-2 Caprolactam 105-60-2 Captan 133-06-2 Calcium hydrate, Caustic lime, Hydrated lime Pebble lime, Quicklime Calcium hydrosilicate, Wollastonite TWA=5 mg/m3 TWA=2 mg/m3 TWA=1 mg/m3 N95 N95 N95 Gypsum, Plaster of Paris TWA=10 mg/m3 (inhalable fraction) TWA= 5 mg/m3 (OSHA, respirable fraction) 2-Camphonone, Gum camphor, Laurel camphor, Synthetic camphor 200 mg/m3 TWA=2 STEL=3 2-Oxohexamethylenimine, Aminocaproic lactam 14000 TWA=5 mg/m3 (inhalable fraction and vapor) N-(Trichloromethylthio)-4cyclohexene-1,2-dicarboximide TWA=5 mg/m3 (inhalable fraction) N95 (F)OV/N95 OV/N95 N95 3M 3510 Monitor See comment D on page 8 Carbon black 1333-86-4 Carbon dioxide 124-38-9 Carbon disulfide 75-15-0 Carbon monoxide 630-08-0 Carbon tetrabromide 558-13-4 Carbon tetrachloride 56-23-5 Acetylene black, Channel black, Furnace black, Lamp black, Thermal black Carbonic acid gas, Dry ice 50000 Carbon bisulfide, Carbon bisulfur, Carbon bisulphide, Carbon disulphide, Carbon sulfide, Dithiocarbonic anhydride, Sulphocarbonic anhydride, Weevitox Monoxide 500 1500 Tetrabromomethane Tetrachloromethane 300 Carbonyl fluoride 353-50-4 Carbonyl sulfide 463-58-1 Carbon oxyfluoride, Fluoroformyl fluoride Carbon monoxide monosulfide, Carbon oxide sulfide, Carbon oxysulfide, Oxycarbon sulfide TWA=3 mg/m3 N95 (inhalable fraction) TWA=5000 SA STEL=30000 TWA=1 OV C=30 (OSHA) -skin- TWA=25 TWA=0.1 STEL=0.3 TWA=5 STEL=10 C=25 (OSHA) -skin- TWA=2 STEL=5 TWA=5 SA (F)OV (F)OV (F)MG SA Ineffective sorbents Short service life Ineffective sorbents 3M 3510 Monitor 30 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 31 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Catechol 120-80-9 Cellulose 9004-34-6 Pyrocatechol Paper fiber 14000 Cesium fluoride (as F) 13400-13-0 Cesium hydroxide 21351-79-1 Chloramphenicol 56-75-7 Chlorinated diphenyl oxide 31242-93-0 Chlorine 7782-50-5 Cesuim hydrate [R-(R*,R*)]-2,2-dichloro-N[2,hydroxy-1-(hydroxy methyl)-2(4-nitrophenyl)ethyl] acetamide; Chloromycetin; Levomycetin Hexachlorodiphenyl oxide 30 TWA=5 -skin- TWA=10 mg/m3 TWA= 5 mg/m3 (OSHA, respirable fraction) TWA=2.5 mg/m3 OV/N95 N95 N95 TWA=2 mg/m3 N95 TWA=0.5 mg/m3 N95 (AIHA) TWA=0.5 mg/m3 OV/P95 TWA=0.1 STEL=0.4 C=1 (OSHA) (F)AG Irritation also provides warning Chlorine dioxide Chlorine oxide, 10 10049-04-4 Chlorine peroxide Chlorine trifluoride 7790-91-2 Chloroacetaldehyde 107-20-0 Chloroacetone 78-95-5 Chloroacetyl chloride 79-04-9 Chlorobenzene 108-90-7 Chlorobromomethane 74-97-5 1-Chloro-1,1difluoroethane 75-68-3 Chlorine fluoride 20 2-Chloroethanal, 100 Chloroacetaldehyde (40% aqueous) Chloracetone, 1-Chloro-2propanone, Monochloroacetone Chloracetyl chloride Chlorobenzol, MCB, Monochlorobenzene, Phenyl chloride 2400 Bromochloromethane, CBM, HalonTM 1011, Methylene chlorobromide 5000 a-Chloroethylidene fluoride, Chlorodifluoroethane, Dymel® 142b, GenetronTM 142b, HCFC-142b C=0.1 C=0.1 C=1 AG MG (F)OV C=1 -skin- TWA=0.05 STEL=0.15 -skin- TWA=10 (F)OV (F)OV/AG OV TWA=200 OV TWA=1000 (AIHA) SA 3M 3510 Monitor Short OV service life 32 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 33 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Chlorodifluoromethane Freon® 22 75-45-6 Chlorodiphenyl (42% chlorine) 53469-21-9 PCB, Polychlorinated biphenyl 10 mg/m3 Chlorodiphenyl (54% chlorine) 11097-69-1 PCB, Polychlorinated biphenyl 5 mg/m3 Chloroform 67-66-3 Trichloromethane 1000 bis-(2-Chloroisopropyl) BCIPE; bis-(1-methyl-2- ether chloroethyl) ether; bis-2- 39628-32-9 chloro-1-methylethyl ether; Dichloroisopropyl ether bis-Chloromethyl ether 542-88-1 BCME, Chloro (chloromethoxy) methane, Chloromethyl ether, Dichloromethylether TWA=1000 TWA=1 mg/m3 -skin- TWA=0.5 mg/m3 -skin- TWA=10 C=50 (OSHA) TWA=3 (AIHA) TWA=0.001 SA (F)OV/P95 (F)OV/P95 OV (F)OV (F)OV Ineffective sorbents See comment D on page 8 See comment D on page 8 Short service life. 3M 3510 Monitor OSHA requires SA with hood for certain applications; see 29 CFR 1910.1003 Chloropentafluoroethane 76-15-3 Chloropicrin 76-06-2 b-Chloroprene 126-99-8 2-Chloropropane 75-29-6 1-Chloro-2-propanol 127-00-4 2-Chloro-1-propanol 78-89-7 2-Chloropropionic acid 598-78-7 o-Chlorostyrene 2039-87-4 FC-115, Monochloropentafluoroethane Nitrochloroform, 4 Nitrotrichloromethane, Trichloronitromethane 2-Chloro-1,3-butadiene, beta- 400 Chloroprene, Chlorobutadiene 2-CP, 2-Propyl chloride, Isoprid, Isopropyl chloride 1-Chloro-2-hydroxypropane, 1-Chloroisopropyl alcohol, secPropylene chlorohydrin 1-Hydroxy-2-chloropropane, 2-Chloropropanol, 2-Chloropropyl alcohol, Propylene chlorohydrin a-Chloropropionic acid 1-Chloro-2-ethenylbenzene, 2-Chlorostyrene TWA=1000 SA TWA=0.1 (F)SA TWA=1 -skinTWA=50 (AIHA) TWA=1 -skin- TWA=1 -skin- (F)OV OV OV OV TWA=0.1 -skin- TWA=50 STEL=75 OV/AG OV Short OV service life Irritation also provides warning Short service life Short service life 34 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 35 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Chlorosulfonic acid 7790-94-5 Chlorosulfuric acid, CSA 2-Chloro-1,1,1,2- tetrafluoroethane 2837-89-0 Chlorotetrafluoroethane, Fluorocarbon 124, HCFC124, HFA124 o-Chlorotoluene 95-49-8 2-Chloro-1-methylbenzene Chlorotrifluoroethylene CFE, CTFE, 79-38-9 Trifluorochloroethylene, Trifluorovinylchloride Chromium II compounds (as Cr) Chromium metal 7440-47-3 C=0.1 mg/m3 (AIHA) (F)AG/N95 TWA=1000 (AIHA) SA HCl, SO2 hydrolysis products Short OV service life TWA=50 OV TWA=5 (AIHA) SA Short OV service life TWA=0.5 mg/m3 N95 (OSHA) TWA=0.5 mg/m3 N95 (inhalable fraction) Chromium III compounds TWA=0.003 mg/m3 N95 (as Cr(III)) Chromium VI compounds Chromyl chloride 14977-61-8 Citral 5392-40-5 Hexavalent chromium compounds, Chromic acid Chloro-chromic anhydride, Chromium oxychloride 2,6-Octadienal-3,7-dimethyl; 3,7-Dimethyl-2,6-octadienal 30 mg/m3 TWA=0.0002 mg/m3 N95 (as Cr(VI), inhalable fraction) STEL=0.0005 mg/m3 (as Cr(VI), inhalable fraction) -skin- TWA=0.0002 mg/m3 (F)AG/N95 (as Cr(VI), inhalable fraction) STEL=0.0005 mg/m3 (as Cr(VI), inhalable fraction) -skin- TWA=5 (inhalable fraction and vapor) -skin- OV/P95 Skin notation for water soluble compounds See comment E on page 8 See comment D on page 8 Coal dust, Anthracite TWA=0.4 mg/m3 N95 (respirable fraction) May also contain crystaline silica (quartz) Coal dust, Bituminous or Lignite TWA=0.9 mg/m3 N95 (respirable fraction) May also contain crystaline silica (quartz) Coal tar pitch volatiles Particulate polycyclic aromatic 700 mg/m3 TWA=0.2 mg/m3 R95 (as Benzene solubles) hydrocarbons, PPAH P95 65996-93-2 Respirators with nuisance level organic vapor or acid gas relief specifically recommended 36 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 37 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Cobalt, elemental and inorganic compounds (as Co) 7440-48-4 Cobalt carbonyl (as Co) 10210-68-1 Cobalt hydrocarbonyl (as Co) 16842-03-8 Coke oven emissions 65996-93-2 Copper dust and mist (as Cu) 7440-50-8 Copper fume (as Cu) 7440-50-8 20 mg/m3 TWA=0.02 mg/m3 N95 (inhalable fraction) TWA=0.1 mg/m3 SA TWA=0.1 mg/m3 SA TWA=0.15 mg/m3 R95 (OSHA) P95 TWA=1 mg/m3 N95 TWA=0.1 mg/m3 N95 (OSHA) Ineffective sorbents Ineffective sorbents Respirators with nuisance level organic vapor or acid gas relief specifically recommended. Cotton dust, raw TWA=0.1 mg/m3 N95 (thoracic fraction) Cresol (all isomers) 1319-77-3 Crotonaldehyde 4170-30-3 Cryolite (as F) 15096-52-3 Cumene 98-82-8 Cumene hydroperoxide 80-15-9 Cyanamide 420-04-2 Cresylic acid 250 TWA=20 mg/m3 (inhalable fraction and vapor) -skin- b-Methylacrolein, Crotonic 400 aldehyde, Propylene aldehyde TWA=2 (OSHA) C=0.3 Greenland spar, Icetone 500 mg/m3 TWA=2.5 mg/m3 2-Phenyl propane, Cumol, Isopropyl benzene 8000 a,a'-Dimethylbenzyl hydroperoxide, CHP, Cumyl hydroperoxide, Isopropyl benzene hydroperoxide Carbodiimide, Cyanogenamide TWA=50 TWA=1 (AIHA) -skin- TWA=2 mg/m3 OV/P95 (F)OV N95 OV (F)OV N95 5X PEL maximum for disposables, per OSHA cotton dust standard. If oil aerosol present, use R or P95 See comment D on page 8 3M 3510 Monitor 38 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 39 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Cyanides (as CN) Cyanogen 460-19-5 Cyanogen bromide 506-68-3 Cyanogen chloride 506-77-4 Cyclohexane 110-82-7 Cyclohexanol 108-93-0 Cyclohexanone 108-94-1 Dicyan, Oxalonitrile 50 mg/m3 66000 TWA=5 mg/m3 -skin- C=5 Bromine cyanide C=0.3 CNCl C=0.3 Hexahydrobenzene, Hexamethylene 10000 TWA=100 Anol, Cyclohexyl alcohol, 3500 Hexahydrophenol, Hexalin, Hydralin, Hydroxycyclohexane Cyclohexyl ketone, Pimelic ketone 5000 TWA=50 -skin- TWA=20 STEL=50 -skin- SA MG (F)SA (F)SA (F)OV OV OV Short OV service life Irritation also provides warning. 3M 3510 Monitor. See comment E on page 8. 3M 3510 Monitor. 3M 3510 Monitor Cyclohexene 110-83-8 Cyclohexylamine 108-91-8 Cyclonite 121-82-4 Cyclopentadiene 542-92-7 Cyclopentane 287-92-3 Decaborane 17702-41-9 Decabromodiphenyl oxide 1163-19-5 1-Decene 872-05-9 Dehydrolinalool 29171-20-8 Benzene tetrahydride 10000 TWA=300 Aminocyclohexane, Hexahydroaniline 15000 Hexahydro-1,3,5-trinitro-symtriazine, RDX, sym-Trimethylene trinitramine 1,3-Cylclopentadiene 2000 Pentamethylene 11000 TWA=10 TWA=0.5 mg/m3 -skin- TWA=0.5 STEL=1 TWA=600 bis-(Pentabromophenyl) ether, DBDPO, Decabromodiphenyl ether a-Decene, Decylene 100 mg/m3 TWA=0.05 STEL=0.15 -skin- TWA=5 mg/m3 (AIHA) 5000 TWA=100 (AIHA) TWA=2 (AIHA) OV (F)OV N95 OV SA SA N95 OV OV 3M 3510 Monitor Short service life Short OV service life Unknown sorbent effectiveness 40 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 41 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Diacetone alcohol 123-42-2 Diacetyl 431-03-8 Diallylamine 124-02-7 Diazomethane 334-88-3 Diborane 19287-45-7 Dibromochloropropane 96-12-8 Dibromoneopenytl Glycol 3296-90-0 2-Methyl-2-pentanol-4-one, 4-Hydroxy-4-methyl2-pentanone, Diacetone Biacetyl, 2,3-Butanedione, Dimethylglyoxal, Dimethyl diketone, 2,3-Diketobutane Di-2-propenylamine, N-2propenyl-2-propen-1-amine Azimethylene, Diazirine 2100 2 Boroethane 40 1,2-Dibromo-3-chloropropane, 1-Chloro-2,3-dibromopropane, DBCP Dibromopentaerythritol TWA=50 (F)OV 3M 3510 Monitor TWA=0.01 STEL=0.02 OV/P95 TWA=1 (AIHA) OV -skin- TWA=0.2 SA TWA=0.1 SA TWA=0.001 (OSHA) (F)SA TWA=0.2 mg/m3 (AIHA) (F)R95/P95 Unknown sorbent effectiveness Unknown sorbent effectiveness OSHA requires (F)SA; no change schedule allowed R95/P95 acceptable with appropriate eye/ face protection Dibutylamine 111-92-2 2-NDibutylaminoethanol 102-81-8 1-Butanamine, n-butyl; Di-nbutylamine; DNBA Dibutylaminoethanol, N,N-Dibutyl-N-(2-hydroxyethyl) amine C=5 (AIHA) -skin- TWA=0.5 -skin- Dibutyl phenyl phosphate 2528-36-1 Dibutyl phosphate 107-66-4 Dibutyl phthalate 84-74-2 Dichloroacetic acid 79-43-6 Dichloroacetylene 7572-29-4 o-Dichlorobenzene 95-50-1 DBPP TWA=0.3 -skin- Dibutyl acid-o-phosphate, 125 Dibutyl phosphoric acid, Di-n-butyl hydrogen phosphate TWA=5 mg/m3 (inhalable fraction and vapor) -skin- 1,2-Benzene dicarboxylate, DBP, Dibutyl 9300 mg/m3 TWA=5 mg/m3 2-2-Dichloroacetic acid; Acetic acid, dichloro; Dichloroethanoic acid; Urmer's liquid TWA=0.5 -skin- Dichloroethyne C=0.1 1,2-Dichlorobenzene, o-Dichlorobenzol 1000 TWA=25 STEL=50 C=50 (OSHA) (F)OV (F)OV R95 P95 OV/P95 OV/P95 (F)OV/AG (F)SA (F)OV See comment E on page 8 OV/P95 may be preferable if heat involved See comment D on page 8 See comment D on page 8 Short OV service life See comment E on page 8. 3M 3510 Monitor 42 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 43 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments p-Dichlorobenzene 106-46-7 1,4-Dichlorobenzene, Dichloricide, PDCB, 1000 1,4-Dichloro2-butene 764-41-0 Dichlorodifluoromethane 75-71-8 1,3-Dichloro-5,5dimethyl hydantoin 118-52-5 1,1-Dichloroethane 75-34-3 1,2-Dichloroethylene 540-59-0 156-59-2 156-60-5 1,4-DCB, 2-Butylenedichloride, DCB, dichlorobutene Freon® 12, Refrigerant 12 50000 Dactin, Halane Ethylidene chloride 4000 Acetylene dichloride, Dioform 4000 TWA=10 TWA=0.005 -skinTWA=1000 (F)OV/N95 (F)OV SA TWA=0.2 mg/m3 STEL=0.4 mg/m3 TWA=100 TWA=200 OV/N95 OV OV 3M 3510 Monitor Short OV service life Short service life Short service life. 3M 3510 Monitor Dichloroethyl ether 111-44-4 2,2'-Dichlorodiethyl ether; bis- 250 (2-Chloroethyl) ether 1,1-Dichloro-1- fluoroethane 1717-00-6 Fluorocarbon 141b, HCFC 141b, HFA 141b Dichlorofluoromethane Dichloromonofluoromethane, 75-43-4 Freon® 21, Refrigerant 21 1,1-Dichloro-1nitroethane 594-72-9 2,4-Dichlorophenol 120-83-2 2,4-DCP, DCP 50000 150 1,3-Dichloropropene 542-75-6 2,2-Dichloropropionic acid 75-99-0 Dichlorotetrafluoroethane 76-14-2 1,3-Dichloropropylene DalaponTM FC-114, Freon® 114, HalonTM 242, Refrigerant 114 53000 50000 TWA=5 STEL=10 C=15 (OSHA) -skin- TWA=500 (AIHA) STEL=3000 (AIHA, 5 minute) TWA=10 (F)OV SA SA TWA=2 OV C=10 (OSHA) TWA=1 (AIHA) OV -skin- TWA=1 -skin- TWA=5 mg/m3 (inhalable fraction) (F)OV (F)OV/N95 TWA=1000 SA Short OV service life Short OV service life R or P95 may also be needed if material is molten Short OV service life 44 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 45 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Dicyclopentadiene 77-73-6 Dicyclopentadienyl iron (as Fe) 102-54-5 Diesel fuel (as total hydrocarbons) 68334-30-5 68476-30-2 68476-31-3 68476-34-6 77650-28-3 Diethanolamine 111-42-2 8000 bis-Cyclopentadienyl iron (as Fe) Astral oil, Coal oil, Fuel oil, Gas oil, Home heating oil, Marine diesel fuel 2,2'-Dihydroxydiethylamine, 16000 Butadiene Dioxide, DEA, Diolamine, N,N-Diethanolamine, di-(2-Hydroxyethyl)amine, 2,2'-Iminobisethanol TWA=0.5 STEL=1 OV/N95 TWA=10 mg/m3 N95 TWA=5 mg/m3 (OSHA, respirable fraction) TWA=100 (inhalable OV/P95 fraction and vapor) -skin- TWA=1 mg/m3 (inhalable fraction and vapor) -skin- OV/N95 3M 3510 Monitor See comment E on page 8. 3M 3510 Monitor See comment E on page 8 Diethylamine 109-89-7 2000 2-Diethylaminoethanol 2-Diethylaminoethyl alcohol, 500 100-37-8 N,N-Diethylethanolamine TWA=5 STEL=15 -skin- TWA=2 -skin- (F)AM (F)OV OV AM not specifically approved, but 3M recommended for longer service life Diethylbenzenes, mixed 25340-17-4 1,2-Diethylbenzene, 1,3-Diethylbenzene, 1,4-Diethylbenzene, DEB, DowthermTM J TWA=5 (AIHA) OV Diethylene glycol 111-46-6 2,2'-Dihydroxydiethyl ether, DEG, Digycol TWA=10 mg/m3 R95 (AIHA) P95 See comments D and G on page 8 Diethylene glycol monobutyl ether 112-34-5 Diethylene glycol monoethyl ether 111-90-0 Butoxy diethylene glycol, Butoxydiglycol, Butyl Carbitol® 2-(2-Ethoxyethoxy) ethanol, 12000 Carbitol®, DiEGEE, Diethylene glycol ethyl ether, Dioxitol, Ethyl Carbitol®, Glycol ether DE TWA=10 (inhalable (F)OV/P95 fraction and vapor) TWA=25 (AIHA) OV See comment D on page 8. 3M 3510 Monitor 3M 3510 Monitor Diethylene triamine 111-40-0 20000 TWA=1 -skin- (F)OV N,N- DEHA TWA=2 OV Diethylhydroxylamine 3710-84-7 46 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 47 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Diethyl ketone 96-22-0 Diethyl phthalate 84-66-2 Difluorodibromomethane 75-61-6 1,1-Difluoroethane 75-37-6 Difluoromethane 75-10-5 Diglycidyl ether 2238-07-5 Diisobutylene (mixed isomers) 25167-70-8 a-Diisobutylene 107-39-1 3-Pentanone, Ethyl propionyl, Metacetone, Propione DEP, Ethylphthalate 16000 7000 DFBM, Dibromodifluoromethane, Freon® 12B2 2500 Dymel® 152a, Ethylidene fluoride, Freon® 152a, GenetronTM 152a, HFC-152a Hydrofluorocarbon 32, R32, Refrigerant 32 2-Epoxypropyl ether, bis- 25 (2,3-Epoxypropyl)-ether, DGE, Di-(epoxypropyl) ether, Diallyl ether dioxide Diisobutene 2,4,4-Trimethyl-1-pentene, a-Diisobutene TWA=200 OV STEL=300 TWA=5 mg/m3 R95 P95 TWA=100 OV TWA=1000 (AIHA) SA TWA=1000 (AIHA) SA TWA=0.01 C=0.5 (OSHA) (F)OV TWA=75 (AIHA) OV TWA=75 (AIHA) OV Short service life Ineffective sorbents Ineffective sorbents b-Diisobutylene 107-40-4 Diisobutyl ketone 108-83-8 Diisopropylamine 108-18-9 Dimethyl acetamide 127-19-5 Dimethylamine 124-40-3 2,4,4-Trimethyl-2-pentene, b-Diisobutene 2,6-Dimethyl-4-heptanone, Isovalerone, symDiisopropylacetone, Valerone 2000 1000 DMAC, N,N-Dimethyl acetamide Anhydrous dimethylamine 400 2000 bis-(2Dimethylaminoethyl) ether 3033-62-3 DMAEE; Ethylamine, 2,2"-Oxybis (N,N-dimethyl); Niax® Catalyst A-99 Dimethylaniline N,N-Dimethylaniline 100 121-69-7 Dimethyl carbamoyl chloride 79-44-7 Chloroformic acid dimethylamide, Dimethyl carbamic chloride, Dimethylcarbamyl chloride, DMCC TWA=75 (AIHA) TWA=25 OV (F)OV TWA=5 -skin- TWA=10 -skin- TWA=5 STEL=15 (F)OV OV AM TWA=0.05 STEL=0.15 -skin- TWA=5 STEL=10 -skin- TWA=0.005 -skin- (F)OV OV (F)MG See comment E on page 8. 3M 3510 Monitor AM not specifically approved, but 3M recommended for longer service life 48 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 49 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Dimethyldichlorosilane Dichlorodimethylsilane 75-78-5 Dimethyl disulfide 624-92-0 2,3-Dithiabutane, Dimethyldisulfide, Dimethyldisulphide, DMDS Dimethyl ether 115-10-6 Methyl ether, Wood ether 34000 Dimethylethoxysilane Ethoxydimethyl silane 14857-34-2 Dimethyl formamide DMF, N,N-Dimethyl formamide 3500 68-12-2 1,1-Dimethylhydrazine UDMH, 50 57-14-7 unsym-Dimethylhydrazine Dimethylphenol, 562-75-0, 105-67-9, 95-87-4, 576-26-1, 95-65-8, 108-68-9, 1300-71-6 2,3-Dimethylphenol, 2,4Dimethylphenol, 2,5-Dimethylphenol, 2,6Dimethylphenol, 3,4Dimethylphenol, 3,5-Dimethylphenol C=2 (AIHA) OV/AG TWA=0.5 -skin- OV/AG TWA=1000 (AIHA) SA TWA=0.5 STEL=1.5 TWA=5 -skin- TWA=0.01 -skin- TWA=1 (inhalable fraction and vapor) (F)SA (F)OV (F)AM (F)OV/N95 Short OV service life Unknown sorbent effectiveness 3M 3510 Monitor See comment D on page 8 Dimethylphthalate 131-11-3 DMP 9300 mg/m3 TWA=5 mg/m3 Dimethyl sulfide 75-18-3 DMS; Methane, thiobis; Thiobis (methane) TWA=10 Dimethyl sulfoxide 67-68-5 DMSO, Methylsulfoxide TWA=250 (AIHA) Dimethylsulfate 77-78-1 Methyl sulfate 10 TWA=0.1 -skin- Dimethyl terephthalate 1,4-Benzene dicarboxylic acid, 120-61-6 dimethyl ester; Dimethyl para- phthalate; DMT TWA=5 mg/m3 (AIHA) N,N-Dimethyl-paratoluidine 99-97-8 4-Dimethylaminotoluene, DMPT, N,N,4-trimethylaniline, N,N,4-Trimethylbenzenamine TWA=0.5 (AIHA) Dinitrobenzene 528-29-0 99-65-0 100-25-4 25154-54-5 1,2-Dinitrobenzene, 1,3-Dinitrobenzene, 1,4-Dinitrobenzene, m-Dinitrobenzene, o-Dinitrobenzene, p-Dinitrobenzene 200 mg/m3 TWA=0.15 (inhalable fraction and vapor) -skin- 3,5-Dinitro-otoluamide 148-01-6 2-Methyl-3,5-dinitrobenzamide, Coccidin, Dinitolmide, Salcostat, Zoalene TWA=1 mg/m3 OV/P95 OV/AG OV (F)OV OV/N95 OV OV/N95 N95 See comment D on page 8 AG recommended since H2S may also be present 50 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 51 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Dinitrotoluene 25321-14-6 DNT 200 mg/m3 TWA=0.2 mg/m3 -skin- Di-sec-octyl phthalate bis(2-Ethylhexyl) phthalate, 3000 117-81-7 DEHP, Di-2-ethylhexyl phthalate, DOP TWA=5 mg/m3 1,3-Dioxalane 646-06-0 1,3-Dioxacyclopentane; 1,3-Dioxalan; 1,3-Dioxole, dihydroethylene glycol formal; Dioxalane; Formal glycol; Glycol methylene ether; Glycolformal TWA=20 Dioxane 123-91-1 1,4-Dioxane, Diethylene dioxide, Diethylene ether, p-Dioxane 2000 TWA=20 -skin- Diphenylamine 122-39-4 DPA, N-Phenylaniline TWA=10 mg/m3 OV/N95 R95 P95 OV OV N95 Dipropylene glycol bis(2-Methoxypropyl) ether, 11000 TWA=100 OV methyl ether Dipropylene glycol monomethyl STEL=150 34590-94-8 ether, DowanolTM 50B -skin- See comment D on page 8 OV/N95 may be preferable when odor is a problem 3M 3510 Monitor Dipropyl ketone 123-19-3 Divinyl benzene 1321-74-0 Dodecyl mercaptan 112-55-0 DowthermTM Q Emery 1302-74-5 4-Heptanone, Butyrane DVB, Vinylstyrene 11000 1-Dodecanethiol, 1-Mercaptododecane, n-Dodecyl mercaptan, n-Lauryl mercaptan 1,1-Diphenylethane with ethylated benzenes Corundum Enflurane 13838-16-9 Epichlorohydrin 106-89-8 Erythromycin 114-07-8 2-Chloro-1,1,2-trifluoroethyl difluoromethyl ether; Ethrane 1-Chloro,2,3-epoxypropane, 250 2-Chloropropylene oxide, gamma-Chloropropylene oxide Dotycin, E-MycinTM, Ericynum, Erycin, Pentadecanoic acid TWA=50 TWA=10 TWA=0.1 OV (F)OV OV TWA=1 (AIHA) OV/P95 TWA=15 mg/m3 N95 (OSHA) TWA=1 mg/m3 (respirable fraction) TWA=75 SA TWA=0.5 -skin- (F)OV TWA=3 mg/m3 N95 (AIHA) R or P filter may be needed with oily aerosols Short OV service life 3M 3510 Monitor 52 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 53 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Ethane 74-84-0 Ethanolamine 141-43-5 2-Ethoxyethanol 110-80-5 2-Ethoxyethyl acetate 111-15-9 Ethyl acetate 141-78-6 Ethyl acrylate 140-88-5 Ethylhydride, Methyl methane 2-Aminoethanol, 2-Hydroxyethylamine, b-Aminoethyl alcohol, Ethylolamine, Monoethanolamine 1000 Cellosolve® solvent, Ethylene 6000 glycol monoethyl ether, Glycol monoethyl ether Cellosolve® acetate, Ethylene 2500 glycol monoethyl ether acetate Acetic ester, Acetic ether, Ethyl ethanoate Acrylic acid ethyl ester 10000 2000 TWA=3 STEL=6 TWA=5 -skin- TWA=5 -skin- TWA=400 TWA=5 STEL=15 -skin- OV OV OV (F)OV (F)OV Simple asphyxiant, oxygen displacing gas 3M 3510 Monitor 3M 3510 Monitor 3M 3510 Monitor 3M 3510 Monitor Ethyl alcohol 64-17-5 Ethylamine 75-04-7 Ethanol 15000 Aminoethane, Anhydrous 4000 ethylamine, Monoethylamine Ethyl amyl ketone 541-85-5 Ethyl benzene 100-41-4 Ethyl bromide 74-96-4 Ethyl butyl ketone 106-35-4 Ethyl chloride 75-00-3 Ethyl cyanoacrylate 7085-85-0 5-Methyl-3-heptanone, EAK 3000 Ethylbenzol, Phenylethane 2000 Bromoethane 3500 3-Heptanone 3000 Chloroethane, Hydrochloric ether, Monochloroethane 2-Cyano-2-propenoic acid, ethyl ester; 2-Cyanoacrylic acid, ethyl ester; ECA; Ethyl 2-cyano-2-propenoate; Ethyl 2-cyanoacrylate; Ethyl alphacyanoacrylate 20000 STEL=1000 TWA=5 STEL=15 -skin- TWA=10 TWA=20 TWA=5 -skinTWA=50 STEL=75 TWA=100 -skinTWA=0.2 STEL=1 OV (F)AM (F)OV OV SA OV SA (F)OV Short OV service life AM not specifically approved, but 3M recommended for longer service life See comment E on page 8. 3M 3510 Monitor. Short OV service life See comment E on page 8 Short OV service life 54 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 55 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Ethyl tert-butyl ether 637-92-3 Ethylene 74-85-1 Ethylene chlorohydrin 107-07-3 Ethylenediamine 107-15-3 Ethylene dibromide 106-93-4 1,1-Dimethyl ethyl ether; 2-Ethoxy-2-methylpropane; ETBE; Ethyl 1,1-dimethylethyl ether; Ethyl tert-butyl oxide; tert-Butyl ethyl ether Acetene, Bicarburretted hydrogen, Elayl, Ethene, Olefiant gas 2-Chloroethanol, 2-Chloroethyl alcohol 1,2-Diaminoethane, 1,2-Ethanediamine 1,2-Dibromoethane 10 2000 400 Ethylene dichloride 107-06-2 Ethylene glycol 107-21-1 1,2-Dichloroethane, Ethylene chloride 1,2-Ethanediol 1000 32000 TWA=25 OV TWA=200 (F)SA C=1 -skin- TWA=10 OV (F)OV TWA=20 (OSHA) C=30 (OSHA) -skin- (F)OV TWA=10 OV C=100 (OSHA) TWA=25 OV/P95 (vapor fraction) STEL=50 (vapor fraction) STEL=10 mg/m3 (inhalable particulate matter) 3M 3510 Monitor See comments D and G on page 8 Ethylene glycol dinitrate 628-96-6 Ethyleneimine 151-56-4 Glycol dinitrate, Nitroglycol Aminoethylene, Azirane, Aziridine, Dihydroazirine, Dimethylenimine, Ethyleimine 500 mg/m3 TWA=0.05 C=0.2 (OSHA) -skin- 100 TWA=0.05 STEL=0.1 -skin- OV (F)MG Ethylene oxide 75-21-8 1,2-Epoxyethane, Dimethylene 800 oxide, Oxirane TWA=1 STEL=5 (OSHA) (F)SA Ethyl ether 60-29-7 Ethyl formate 109-94-4 2-Ethylhexanoic acid 149-57-5 Ethylidene norbornene 16219-75-3 Diethyl ether, Ether, Ethyl oxide 19000 Ethyl methanoate, Formic acid 8000 ethyl ester 2-Butylbutanoic acid, 2-Ethylcaproic acid, 2-Ethylhexoic acid, Butylethylacetic acid, Ethylhexoic acid ENB TWA=400 STEL=500 STEL=100 OV (F)OV TWA=5 mg/m3 (inhalable fraction and vapor) OV/N95 TWA=2 STEL=4 (F)OV OSHA requires SA with hood for certain applications; see 29 CFR 1910.1003 OSHA requires (F)SA; no change schedule allowed. 3M 3550 Monitor. Short service life. 3M 3530 Monitor Short service life. 3M 3510 Monitor See comment D on page 8 56 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 57 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Ethyl isocyanate 109-90-0 Ethyl mercaptan 75-08-1 N-Ethylmorpholine 100-74-3 Ethyl silicate 78-10-4 Ferrovanadium dust 12604-58-9 Flour dust Fluorides (as F) Fluorine 7782-41-4 Isocyanatoethene; Isocyanic acid, ethyl ester TWA= 0.02 ppm STEL= 0.06 ppm -skin- Ethanethiol, Ethyl sulfhydrate 2500 TWA=0.5 C=10 (OSHA) 4-Ethylmorpholine 2000 TWA=5 -skin- Ethyl orthosilicate, Tetraethoxy- 1000 silane, Tetraethyl silicate TWA=10 TWA=1 mg/m3 STEL=3 mg/m3 TWA=0.5 mg/m3 (inhalable fraction) (Synonyms vary depending upon specific compound.) 500 mg/m3 TWA=2.5 mg/m3 25 TWA=0.1 C=0.5 OV OV (F)OV OV N95 N95 N95 (F)SA Short service life Short service life Unknown reaction products with sorbent Formaldehyde 50-00-0 Formamide 75-12-7 Formic acid 64-18-6 Furfural 98-01-1 Furfuryl alcohol 98-00-0 Gallium arsenide 1303-00-0 Gasoline 86290-81-5 Germanium tetrahydride 7782-65-2 Formalin, Methylene oxide 30 Methanamide Hydrogencarboxylic acid, 30 Methanoic acid 2-Furaldehyde, 250 2-Furancarboxaldehyde, Fural, Furfuraldehyde 2-Hydroxymethylfuran, 250 2-Furylmethanol Gallium monoarsenide Petrol 14000 Germane, Germanium hydride TWA=0.1 STEL=0.3 (F)Form TWA=10 -skin- TWA=5 STEL=10 TWA=0.2 -skin- OV (F)AG (F)Form (F)OV TWA=0.2 -skin- TWA=0.0003 mg/m3 (respirable fraction) TWA=300 STEL=500 TWA=0.2 (F)OV N100 (F)OV (F)SA Irritation also provides warning. 3M 3720 Monitor Low IDLH See comment E on page 8 3M 3510 Monitor Unknown sorbent effectiveness 58 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 59 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Glutaraldehyde 111-30-8 Glycerin mist 56-81-5 Glycidol 556-52-5 Glycidyl methacrylate 106-91-2 Glyoxal 107-22-2 Grain dust (oat, wheat, barley) 1,5-Pentanedial Glycerol 2,3-Epoxy-1-propanol; 500 2-Hydroxymethyloxiran; 3-Hydroxypropylene oxide; Epoxypropyl alcohol; Hydroxymethyl ethylene oxide 1-Propanol, 2-3, epoxy-, ethacrylate; 2,3-Epoxypropyl methacrylate; 2-Methyl-2propenoic acid, oxiranylmethyl ester; GMA; Methacrylic acid, 2,3-Epoxypropyl ester 1,2-Ethanedione, Biformyl, Diformyl, Ethanedial, Glyoxalaldehyde, Oxalaldehyde C=0.05 (F)OV TWA= 5 mg/m3 R95 (OSHA, respirable P95 fraction) TWA=2 OV See comment E on page 8 TWA=0.5 (AIHA) OV -skin- TWA=0.1 mg/m3 (inhalable fraction and vapor) TWA=4 mg/m3 (F)OV/N95 N95 Short OV service life at 10X OEL. See comment E in Help document. Graphite (natural) 7782-42-5 Graphite (synthetic) 7440-44-0 Black lead, Corbo minerals, Plumbago, Potelot, Silver lead Hafnium and compounds (as Hf) 7440-58-6 Halothane 151-67-7 2-Bromo-2-chloro-1,1,1trifluoroethane Hard metals containing cobalt and tungsten Heptane (all isomers) 142-82-5 590-35-2 565-59-3 108-08-7 591-76-4 589-34-4 n-Heptane, normal Heptane Hexachlorobenzene 118-74-1 Perchlorobenzene Hexachlorobutadiene Hexachloro-1,3-butadiene; 87-68-3 Perchlorobutadiene 5000 TWA=2 mg/m3 N95 (respirable fraction) TWA=15 mg/m3 N95 (OSHA) TWA=2 mg/m3 (respirable fraction) TWA=0.5 mg/m3 N95 TWA=50 OV TWA=0.005 mg/m3 N95 (thoracic fraction) TWA=400 OV STEL=500 TWA=0.002 mg/m3 -skin- TWA=0.02 -skin- N95 (F)OV Short service life. 3M 3510 Monitor 60 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 61 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Hexachlorocyclopentadiene 77-47-4 Hexachloroethane 67-72-1 Hexachloronaphthalene 1335-87-1 1,4-Hexadiene 592-45-0 Hexafluoroacetone 684-16-2 1,1,1,3,3,3Hexafluoropropane 690-39-1 TWA=0.01 (F)OV Perchloroethane HalowaxTM 1014 300 2 mg/m3 TWA=1 -skin- TWA=0.2 mg/m3 -skin- OV/N95 OV/N95 1-Allylpropene TWA=10 (AIHA) OV 1,1,1,3,3,3-Hexafluoro-2propanone FC-236fa, FE-13, HFC-236fa, Hydrofluorocarbon 236fa TWA=0.1 SA -skin- TWA=1000 (AIHA) SA See comment D on page 8 Short OV service life Ineffective sorbents Hexafluoropropylene 116-15-4 Hexahydrophthalic anhydride (all isomers) 85-42-7 13149-00-3 14166-21-3 Hexamethylene diisocyanate 822-06-0 Hexane (n-hexane) 110-54-3 1,1,2,3,3,3-Hexafluoro1-propene; 1,1,2,3,3,3-Hexafluoropropylene; Fluorocarbon 1216; Hexafluoropropene; HFP; Perfluoro-1-propene; Perfluoropropene; Perfluoropropylene 1,2-Cyclohexanedicarboxylic acid anhydride; 1,2-Cyclohexanedicarboxylic anhydride; 1,3-Isobenzofurandione, hexahydro; Cyclohexane-1,2dicaboxylic anhydride, cis and trans mixture; Hexahydro1,3-isobenzofurandione; Hexahydrophthalic acid anhydride; HHPA; HHPAA HDI Hexyl hydride, Normal hexane 5000 TWA=0.1 SA C=0.005 mg/m3 (inhalable fraction and vapor) OV/N95 TWA=0.005 TWA=50 -skin- OV/N95 OV Short OV service life See comment D on page 8 3M 3510 Monitor 62 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 63 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Hexane (other isomers) 1,6-Hexanediamine 124-09-4 Hexanediol diacrylate 13048-33-4 1-Hexene 592-41-6 sec-Hexyl acetate 108-84-9 Hexylene glycol 107-41-5 12000 1,6-Diaminohexane, Hexamethylenediamine, HMD, HMDA HDODA; Propenoic acid, 1,6-hexanediol ester Butyl ethylene, Hex-1-ene, Hexene, Hexene-n-1, Hexylene 1,3-Dimethylbutyl acetate, Methylamyl acetate, Methylisoamyl acetate, Methylisobutyl carbinol 4000 2-Methyl-2,4-pentanediol 13000 TWA=500 STEL=1000 TWA=0.5 OV OV/N95 TWA=1 mg/m3 (AIHA) TWA=50 TWA=50 OV/P95 OV (F)OV TWA=25 (vapor fraction) STEL=50 (vapor fraction) STEL=10mg/m3 (inhalable particulate matter) (F)OV/P95 Short service life. 3M 3510 Monitor See comment D on page 8 Short service life See comment E on page 8 Irritation also provides warning HFE-7100 163702-08-7 163702-07-6 Hydrazine 302-01-2 Hydrogenated terphenyls 61788-32-7 Hydrogen bromide 10035-10-6 Hydrogen chloride 7647-01-0 Hydrogen cyanide 74-90-8 Hydrogen fluoride 7664-39-3 60% of mixture is: 1-Methoxy- 2-trifluoromethyl-1,1,2,3,3,3hexafluoropropane; 1-Methoxyperfluoroisobutane 40% of mixture is 1-Methoxy-1,1,2,2,3,3,4,4,4- nonafluorobutane; 1-Methoxyperfluorobutane Anhydrous hydrazine 80 HBr, Hydrobromic acid 50 HCl, Hydrochloric acid, 100 Muriatic acid Hydrocyanic acid, Prussic acid 50 Anydrofluoric acid, Etching 30 acid, Fluoric acid, Fluorohydric acid, HF TWA=750 (AIHA) OV TWA=0.01 -skinTWA=0.5 C=2 C=2 C=4.7 -skinTWA=0.5 C=2 -skin- (F)AM R95 P95 AG AG (F)SA (F)HF Short service life. 3M 3510 Monitor Not specifically approved for HBr Irritation also provides warning Low IDLH 64 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 65 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Hydrogen peroxide 7722-84-1 Hydrogen selenide (as Se) 7783-07-5 Hydrogen sulfide 7783-06-4 Hydroquinone 123-31-9 4-Hydroxybenzoic acid 99-96-7 2-Hydroxypropyl acrylate 999-61-1 Indene 95-13-6 Indium and compounds (as In) 7440-74-6 Hydrogen dioxide, Peroxide 75 Selenium hydride 2 H2S, Hepatic gas, Hydrosulfuric 300 acid, Sulfuretted hydrogen 1,4-Benzenediol, Dihydroxybenzene, Quinol HPA Indonaphthene 18000 TWA=1 TWA=0.05 (F)OV (F)MG TWA=1 STEL=5 TWA=1 mg/m3 TWA=5 mg/m3 (AIHA) TWA=0.5 -skin- TWA=5 TWA=0.1 mg/m3 AG (F)OV/N95 (F)N95 OV OV N95 See Technical Data Bulletin #185 Poor warning (olfactory fatigue) See comment D on page 8 Indium tin oxide 50926-11-9 Iodides Iodine 7553-56-2 TWA=0.0001 mg/m3 N95 (respirable fraction) 90:10 mixture of In2O3 and SnO2 TWA=0.01 (inhalable (F)MG/N95 fraction and vapor) See comment E on page 8 10 TWA=0.01 (inhalable (F)MG/N95 See comment E on fraction and vapor) page 8 STEL=0.1 (vapor) Iodoform 75-47-8 Iron oxide 1309-37-1 Iron oxide fume 1309-37-1 Triiodomethane Burnt sienna, Burnt umber, Ferric oxide, Hematite, Jeweler's rouge, Rouge Ferric oxide fume Iron pentacarbonyl (as Fe) 13463-40-6 Iron salts, soluble (as Fe) Iron carbonyl Ferric chloride; Ferric nitrate; Ferric sulfate; Ferric/Ferrous salts, soluble; Ferrous chloride; Ferrous sulfate TWA=0.6 (F)OV TWA=5 mg/m3 N95 (respirable fraction) TWA=10 mg/m3 N95 (OSHA) TWA= 5 mg/m3 (respirable fraction) TWA=0.1 SA STEL=0.2 TWA=1 mg/m3 N95 Unknown sorbent effectiveness 66 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 67 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Isoamyl alcohol 123-51-3 Isobutane 75-28-5 Isobutene 115-11-7 Isobutyl acetate 110-19-0 Isobutyl alcohol 78-83-1 Isobutyl nitrite 542-56-3 3-Methyl-1-butanol, Fusel oil, Isobutyl carbinol, Isopentyl alcohol 10000 2-Methyl propane, Methylpropane 16000 1,1-Dimethylethene, 1,1-Dimethylethylene, 2-Methylpropene, 2-Methylpropylene, Isobutylene 2-Methylpropyl acetate 7500 2-Methyl-1-propanol, IBA, Isobutanol, Isopropylcarbinol IBN; Nitrous acid, 2-methylpropyl ester; Nitrous acid, isobutyl ester 8000 TWA=100 STEL=125 STEL=1000 TWA=250 TWA=50 STEL=150 TWA=50 C=1 (F)OV SA OV (F)OV (F)OV OV See comment E on page 8 Short OV service life Short service life 3M 3510 Monitor 3M 3510 Monitor Isobutyraldehyde 78-84-2 2-Methyl-1-propanal, 2-Methylpropanal, 2-Methylpropionaldehyde, Isobutanal, Isobutyl aldehyde, Isobutyric aldehyde, Valine aldehyde TWA=25 (AIHA) OV Short service life Isocyanuric acid 108-80-5 Cyanuric acid; s-Triazine2,4,6(1H,3H,5H)-triione; s-Triazinetriol TWA=10 mg/m3 N95 (AIHA) TWA=5 mg/m3 (AIHA, respirable fraction) AM/N95 may be preferable if wet Isooctyl alcohol 26952-21-6 Isooctanol 9000 TWA=50 OV -skin- Isophorone 78-59-1 Isophorone diisocyanate 4098-71-9 3,5,5-Trimethyl-2-cyclohexene- 800 1-one IPDI C=5 TWA=0.005 OV OV/N95 See comment E on page 8. 3M 3510 Monitor Isophthalic acid 121-91-5 1,3-Benzenedicarboxylic acid, IA, IPA, m-Phthalic acid TWA=10 mg/m3 N95 (AIHA) TWA=5 mg/m3 (AIHA, respirable fraction) Isoprene 78-79-5 2-Methyl-1,3-butadiene 15000 TWA=2 (AIHA) OV Short service life 68 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 69 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Isopropoxyethanol 109-59-1 Isopropyl acetate 108-21-4 Isopropylamine 75-31-0 Ethylene glycol monoisopropyl ether, IPE, Isopropyl Cellosolve®, Isopropyl glycol Isopropyl ester of acetic acid, 16000 sec-Propyl acetate 2-Aminopropane, Monoisopropylamine 4000 TWA=25 -skin- TWA=100 STEL=150 TWA=5 STEL=10 N-Isopropylaniline 768-52-5 Isopropyl ether 108-20-3 Isopropyl glycidyl ether 4016-14-2 o-Aminoisopropylbenzene, o-Isopropylaniline Diisopropyl ether 10000 1,2-Epoxy-3-isopropoxypropane, IGE, Isopropoxymethyl-oxiran, Isopropyl epoxypropyl ether 1000 TWA=2 -skin- TWA=250 STEL=310 TWA=50 STEL=75 OV (F)OV (F)AM (F)OV OV OV (F)OV 3M 3510 Monitor AM not specifically approved, but 3M recommended for longer service life Kaolin (particles with no asbestos and <1% crystalline silica) 1332-58-7 Kerosene (applications with negligible aerosol) 8008-20-6 64712-81-0 64742-81-0 Ketene 463-51-4 Lead arsenate (as As) 3687-31-8 Lead chromate (as Cr) 7758-97-6 Lead, elemental and inorganic compounds (as Pb) 7439-92-1 Aluminium silicate, China clay Deobase, Diesel No.1, Fuel oil No.1, JP-4, JP-5, JP-8, Kerosine, Carbomethene, Ethenone Chromates of lead, Chrome orange, Red lead chromate TWA= 2 mg/m3 N95 (respirable fraction) 7000 TWA= 200 mg/m3 (as total hydrocabon vapor) -skin- OV/P95 TWA=0.5 STEL=1.5 100 mg/m3 TWA=0.01 mg/m3 (F)SA N100 30 mg/m3 TWA=0.0002 mg/m3 (as Cr(VI), inhalable fraction) STEL=0.0005 mg/m3 (as Cr(VI), inhalable fraction) 700 mg/m3 TWA=0.05 mg/m3 N100 N100 When aerosols present, add a particulate prefilter Ineffective sorbents 70 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 71 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments d-Limonene 5989-27-5 Lithium fluoride (as F) 7789-24-4 Lithium hydride 7580-67-8 Lithium hydroxide 1310-65-2 Lithium hydroxide monohydrate 1310-66-3 Lithium oxide 12057-24-8 LPG 68476-85-7 1-Methyl-4(1-methylethenyl) cyclohexene, 4-Isopropyl-1methlcyclohexene, Cajeputene, Cinene, p-Mentha-1,8-diene 55 mg/m3 Dilithium oxide, Lithium monoxide Bottled gas, Liquefied petroleum gas 19000 TWA=30 (AIHA) OV TWA=2.5 mg/m3 N95 C=0.05 mg/m3 N95 (inhalable fraction) C=1 mg/m3 (AIHA) N95 C=1.8 mg/m3 (AIHA) N95 C=1 mg/m3 (AIHA) N95 TWA=1000 (OSHA) SA 3M 3510 Monitor Mixture with compounds with short OV service life Magnesite 546-93-0 Magnesium carbonate Magnesium oxide fume 1309-48-4 Magnesia fume Maleic anhydride 108-31-6 2,5-Furandione, cisButenedioic anhydride, Maleic acid anhydride Manganese cyclopentadienyl tricarbonyl 12079-65-1 MCT Manganese, elemental and inorganic compounds (as Mn) 7439-96-5 14000 Melamine 108-78-1 1,3,5-Triazine-2,4,6-triamine; 2,4,6-Triamino-1,3,5-triazine; Cyanuramide TWA=15 mg/m3 (OSHA) TWA= 5 mg/m3 (OSHA, respirable fraction) TWA=10 mg/m3 (inhalable fraction) TWA=0.01 mg/m3 (Inhalable fraction and vapor) TWA=0.1 mg/m3 -skin- N95 N95 (F)OV/N95 SA See comment D on page 8 Properties of vapor unknown TWA=0.1 mg/m3 N95 (inhalable fraction) TWA=0.02 mg/m3 (respirable fraction) C= 5 mg/m3 (OSHA) TWA=3 mg/m3 N95 (AIHA, inhalable fraction and vapor) 72 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 73 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments 2-Mercaptobenzothiazole 149-30-4 Mercaptoethanol 60-24-2 Mercury, alkyl compounds (as Hg) Mercury, aryl compounds (as Hg) Mercury, inorganic compounds (as Hg) 2-Benzothiazolethiol, 2-Benzothiazolylmercaptan, Benzothiazole-2-thione, Mercaptobenzothiazole 1-Hydroxy-2-mercaptoethane, 2-Hydroxy-1-ethanethiol, 2-Hydroxyethylmercaptan, 2ME, 2-Mercaptoethanol, 2-Thioethanol, Thioethyleneglycol, Thioglycol 10 mg/m3 28 mg/m3 28 mg/m3 TWA=5 mg/m3 N95 (AIHA) -skin- TWA=0.2 (AIHA) OV -skin- TWA=0.01 mg/m3 OV -skin- TWA=0.1 mg/m3 N95 -skin- TWA=0.025 mg/m3 N95 -skin- Mercury, metallic mercury vapor 7439-97-6 Hg, Quicksilver 28 mg/m3 TWA=0.025 mg/m3 Hg -skin- Dust with essentially no vapor pressure only Dust with essentially no vapor pressure only. Hg/N95 for volatile liquids Mesityl oxide 141-79-7 Methacrylic acid 79-41-4 Methane 74-82-8 2-Methoxyethanol 109-86-4 2-Methoxyethyl acetate 110-49-6 4-Methoxyphenol 150-76-5 3-Methoxypropyl amine 5332-73-0 Methyl acetate 79-20-9 Isobutenyl methyl ketone, Isopropylidene acetone, Methyl isobutenyl ketone a-Methacrylic acid 5000 Biogas, Fire damp, Marsh gas, Methyl hydride, R 50 (refrigerant) Ethylene glycol monomethyl ether, Methyl Cellosolve® Ethylene glycol methyl ether acetate, Ethylene glycol monomethyl ether acetate, Methyl Cellosolve® acetate Hydroquinone monomethyl ether, p-Methoxyphenol 1-Propanimine, 3-methoxy 2000 4000 Acetic acid methyl ester, Methyl 10000 acetic ester, Methyl ethanoate TWA=15 STEL=25 TWA=20 TWA=0.1 -skinTWA=0.1 -skin- TWA=5 mg/m3 TWA=5 (AIHA) STEL=15 (AIHA) TWA=200 STEL=250 (F)OV (F)OV OV OV N95 (F)OV (F)AM OV Simple asphyxiant, oxygen displacing gas 3M 3510 Monitor 3M 3510 Monitor Irritation also provides warning. AM may be preferred, but not specifically approved Short service life. 3M 3530 Monitor 74 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 75 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Methyl acetylene 74-99-7 Methyl acetylene propadiene mixture 59355-75-8 Methyl acrylate 96-33-3 Methylacrylonitrile 126-98-7 Methylal 109-87-5 Methyl alcohol 67-56-1 Methylamine 74-89-5 Allylene, Propyne 15000 MAPP gas, Methyl acetylene- 15000 allene mixture, Propyne-allene mixture Methyl propenoate 1000 2-Methyl-2-propenenitrile, Isoprene cyanide Dimethoxymethane, Dimethylacetal formaldehyde, Formal, Methyl formal Carbinol, Methanol, Wood alcohol 20000 15000 25000 Monomethylamine 100 TWA=1000 TWA=1000 STEL=1250 TWA=2 -skinTWA=1 -skinTWA=1000 TWA=200 STEL=250 -skinTWA=5 STEL=15 SA SA (F)OV SA SA SA (F)AM Short OV service life Short OV service life 3M 3510 Monitor Short OV service life Methyl amyl alcohol 108-11-2 Methyl isobutyl carbinol 2000 Methyl n-amyl ketone 110-43-0 Methylaniline 100-61-8 Methyl bromide 74-83-9 2-Heptanone, Amyl methyl ketone, Methyl amyl ketone, n-Amyl methyl ketone MA, Monomethyl aniline, N-Methyl aniline Bromomethane 4000 100 2000 TWA=25 STEL=40 -skinTWA=50 TWA=0.5 -skin- TWA=1 C=20 (OSHA) -skin- OV OV OV (F)SA Methyl tert-butyl 2,2-MMOP, 2-Methoxy-2- 25000 TWA=50 OV ether methyl-propane, MTBE, 1634-04-4 tert-Butyl methyl ether Methyl n-butyl ketone 2-Hexanone, MBK 5000 TWA=5 OV 591-78-6 STEL=10 -skin- Methyl chloride 74-87-3 Chloromethane 10000 TWA=50 SA STEL=100 -skin- See comment E on page 8. 3M 3510 Monitor Short OV service life. Use of 60928 cartridge/ filter recommended by 3M, not specifically approved for methyl bromide Short service life. 3M 3510 Monitor 3M 3510 Monitor Short OV service life 76 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 77 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Methyl chloroform 71-55-6 1,1,1-Trichloroethane 1000 TWA=350 STEL=450 Methyl 2-cyanoacrylate 137-05-3 Mecrylate TWA=0.2 STEL=1 Methylcyclohexane 108-87-2 Cyclohexylmethane, Hexahydrotoluene 10000 TWA=400 Methylcyclohexanol 25639-42-3 Hexahydrocresols 10000 TWA=50 o-Methylcyclohexanone 583-60-8 2-Methylcyclohexanone 2500 TWA=50 STEL=75 -skin- 2-Methylcyclopentadienyl manganese tricarbonyl (as Mn) 12108-13-3 TWA=0.2 mg/m3 -skin- Methylene bisphenyl isocyanate 101-68-8 4,4-Diphenylmethane 100 mg/m3 TWA=0.005 diisocyanate, MDI, Methylene- C=0.02 (OSHA) bis-(4-phenyl isocyanate) OV (F)OV OV OV (F)OV OV/N95 OV/N95 3M 3510 Monitor Irritation also provides warning SA preferable if heat involved Methylene chloride 75-09-2 Dichloromethane, Methylene 5000 dichloride 4,4'-Methylene-bis(2-chloroaniline) 101-14-4 4,4'-Methylene-bis(2-chlorobenzamine), DACPM, MOCA Methylene-bis(4cyclohexylisocyanate) 5124-30-1 4,4'-Methylene dianiline 101-77-9 Methyl ethyl ketone 78-93-3 Methyl ethyl ketone peroxide 1338-23-4 Methyl ethyl ketoxime 96-29-7 4,4'-Diaminodiphenylmethane, MDA 2-Butanone, MEK MEKP 2-Butanone oxime, MEKO 3000 TWA=25 (OSHA) STEL=125 (OSHA) (F)SA TWA=0.01 (inhalable fraction and vapor) -skin- TWA=0.005 OV/N95 OV/N95 TWA=0.01 (OSHA) STEL=0.1 (OSHA) -skin- TWA=200 STEL=300 C=0.2 N100 (F)OV (F)OV TWA=10 (AIHA) OV OSHA requires (F)SA; no change schedule allowed. Short OV service life. 3M 3530 Monitor See comment D on page 8 Use OV/N100 if heat is involved. See 29 CFR 1910.1050. 3M 3510 Monitor 78 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 79 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Methyl formate 107-31-3 Methyl hydrazine 60-34-4 Methyl iodide 74-88-4 Formic acid methyl ester, Methyl methanoate Monomethyl hydrazine Iodomethane 5000 50 800 TWA=50 STEL=100 TWA=0.01 C=0.2 (OSHA) -skin- TWA=2 -skin- SA (F)AM (F)SA Methyl isoamyl ketone 2-Methyl-5-hexanone, 110-12-3 5-Methyl-2-hexanone, MIAK Methyl isobutyl ketone Hexone, MIBK 108-10-1 Methyl isocyanate 624-83-9 Isocyanic acid,methyl ester 10000 3000 20 Methyl isopropyl ketone 563-80-4 3-Methyl-2-butanone, MIPK TWA=20 STEL=50 TWA=20 STEL=75 TWA=0.02 STEL=0.06 -skin- TWA=20 (F)OV (F)OV SA (F)OV Short OV service life Short OV service life. Use of 60928 cartridge/filter recommended by 3M, not specifically approved for methyl iodide. 3M 3510 Monitor 3M 3510 Monitor Unknown sorbent effectiveness Methyl mercaptan 74-93-1 Methyl methacrylate 80-62-6 1-Methylnaphthalene 90-12-0 2-Methylnaphthalene 91-57-6 Methyl propyl ketone 107-87-9 n-Methyl-2pyrrolidone 872-50-4 Methyl silicate 681-84-5 a-Methyl styrene 98-83-9 Mercaptomethane, 400 Methanethiol, Methyl sulfhydrate, Thiomethyl alcohol 2-Methyl-2-propenoic acid 4000 methyl ester; Methacrylic acid,methyl ester; Methyl alphamethyl-acrylate; Methyl-2methyl-2-propenoate; Methyl-2methylpropenoate; MMA a-Methyl naphthalene, a-Methylnaphthalene b-Methyl naphthalene, b-Methylnaphthalene 2-Pentanone, Ethyl acetone, 5000 MPK 1-Methyl-2-pyrrolidone, m-Pyrol, n-Methyl Pyrrolidone, NMP Tetramethoxy silane 1-Methyl-1-phenylethylene, AMS 5000 TWA=0.5 OV C=10 (OSHA) TWA=50 OV STEL=100 TWA=0.5 -skinTWA=0.5 -skinSTEL=150 TWA=10 (AIHA) -skin- TWA=1 TWA=10 OV/R95 OV/P95 OV/R95 OV/P95 (F)OV OV (F)OV OV Short service life 3M 3510 Monitor 3M 3510 Monitor 3M 3510 Monitor See comment E on page 8 80 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 81 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Methyltetrahydrophthalic anhydride isomers 3425-89-6, 5333-84-6, 11070-44-3, 19438-63-2, 19438-64-3, 26590-20-5, 42498-58-8 Methyltrichlorosilane Trichloromethylsilane 75-79-6 Methyl vinyl ketone 78-94-4 3-Buten-2-one, 3-Butene-2- 21000 one, Acetyl ethylene, d(3)-2Butenone, g-Oxo-a-Butylene, Methyl vinyl acetone, Methylene acetone Mica (less than 1% quartz) 12001-26-2 Mineral oil (pure, highly and severely refined), excluding metal working fluids 8012-95-1 Liquid petrolatum, Parrafin oil, USP mineral oil, White mineral oil TWA=0.07 ppb OV STEL=0.3 ppb -skin- C=1 (AIHA) C=0.01 (F)AG/N95 OV TWA=3 mg/m3 N95 (respirable fraction) TWA= 5 mg/m3 R95 (inhalable particulate P95 matter) Irritation also provides warning Molybdenum and insoluble compounds (as Mo) 7439-98-7 Molybdenum, soluble compounds (as Mo) 7439-98-7 Monochloroacetic acid 79-11-8 Chloroethanoic acid, MCAA Monomethylformamide n-Methylformamide 123-39-7 Morpholine 110-91-8 Naphtha (coal tar) 8030-30-6 Naphthalene 91-20-3 Diethylenimide oxide, Tetrahyrdo-1,4-oxazine 8000 Crude solvent coal tar naphtha, 10000 High solvent naphtha, Rubber solvent Naphthalin, White tar 500 TWA=10 mg/m3 (inhalable fraction) TWA=3 mg/m3 (respirable fraction) TWA=0.5 mg/m3 (respirable fraction) N95 N95 TWA=0.5 (inhalable fraction and vapor) -skin- TWA=1 -skin- TWA=20 -skin- TWA=100 (OSHA) (F)OV/N95 (F)OV (F)OV (F)OV TWA=10 OV -skin- See comment D on page 8 Odor variable. Irritation also provides warning. 3M 3510 Monitor 3M 3510 Monitor. See comment E on page 8 Natural gas 8006-14-2 Natural rubber latex 9006-04-6 Caoutchouc, India rubber, Natural latex, Natural rubber, NRL, Polyisoprene, Rubber TWA=0.0001 mg/m3 N95 (inhalable fraction) -skin- Simple asphyxiant, oxygen displacing gas. 82 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 83 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Nickel carbonyl (as Ni) Nickel tetracarbonyl 7 13463-39-3 Nickel, elemental/metal compounds (as Ni) 7440-02-0 Nickel, insoluble inorganic compounds (not otherwise specified) (as Ni) Nickel, soluble inorganic compounds (not otherwise specified) (as Ni) Nickel subsulfide (as Ni) 12035-72-2 Nicotine 54-11-5 3-(1-Methyl-2-pyrrolidyl) pyridine 35 mg/m3 Nitric acid 7697-37-2 Aqua fortis, Hydrogen nitrate, 100 Red fuming nitric acid, RFNA, WFNA, White fuming nitric acid TWA=0.001 (OSHA) C=0.05 TWA=1 mg/m3 (OSHA) TWA=1.5 mg/m3 (inhalable fraction) TWA=0.2 mg/m3 (inhalable fraction) TWA=0.1 mg/m3 (inhalable fraction) TWA=0.1 mg/m3 (inhalable fraction) TWA=0.5 mg/m3 -skin- TWA=2 STEL=4 (F)SA N95 N95 N95 N95 OV/P95 (F)SA Unknown sorbent effectiveness See comment D on page 8 Ineffective sorbents Nitric oxide 10102-43-9 p-Nitroaniline 100-01-6 Nitrobenzene 98-95-3 p-Nitrochlorobenzene 100-00-5 Nitroethane 79-24-3 Nitrogen dioxide 10102-44-0 Nitrogen trifluoride 7783-54-2 Nitroglycerin (NG) 55-63-0 Nitromethane 75-52-5 Nitrogen monoxide, NO 1-Amino-4-nitrobenzene, 4-Nitroaniline, Azoic diazo component 37, Fast Red GG base, p-Aminonitro-benzene, PNA Nitrobenzol, Oil of mirbane 1-Chloro-4-nitrobenzene, 4-Chloronitrobenzene, PCNB, PNCB Nitrogen peroxide Nitrogen fluoride Glyceryl trinitrate, Trinitroglycerin Nitrocarbol 100 TWA=25 300 mg/m3 TWA=3 mg/m3 -skin- 200 TWA=1 -skin- 1000 mg/m3 TWA=0.1 -skin- 1000 TWA=100 50 2000 TWA=0.2 C=5 (OSHA) TWA=10 500 mg/m3 TWA=0.05 C=0.2 (OSHA) -skin- 1000 TWA=20 SA OV/N95 OV OV (F)OV SA SA OV OV Ineffective sorbents See comment D on page 8 Ineffective sorbents Unknown sorbent effectiveness 84 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 85 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments 1-Nitropropane 108-03-2 2-Nitropropane 79-46-9 Nitrotoluene 88-72-2 99-08-1 99-99-0 5-Nitro-o-toluidine 99-55-8 Nitrous oxide 10024-97-2 Nonane 111-84-2 Octachloronaphthalene 2234-13-1 sec-Nitropropane Nitrotoluol 2300 2300 200 2-Methyl-5-nitrobenzenamine, 5-Nitro-2-toluidine, Azoic Diazo Compound 12 Dinitrogen monoxide n-Nonane 8000 HalowaxTM 1051 TWA=25 TWA=10 TWA=2 -skin- OV OV OV/N95 TWA=1 mg/m3 OV/R95 (inhalable fraction) OV/P95 TWA=50 SA TWA=200 OV TWA=0.1 mg/m3 STEL=0.3 mg/m3 -skin- OV/N95 See comment D on page 8 Ineffective sorbents See comment D on page 8 Octane, all isomers 111-65-9 540-84-1 1-Octanol 111-87-5 1-Octene 111-66-0 Osmium tetroxide (as Os) 20816-12-0 Oxalic acid 144-62-7 6153-56-6 p,p-Oxybis (benzenesulfonyl hydrazide) 80-51-3 Oxygen difluoride 7783-41-7 n-Octane, Isooctane 5000 TWA=300 OV 1-Hydroxyoctane, Alcohol C-8, Capryl alcohol, Heptyl carbinol, n-Octanol, n-Octyl alcohol a-Octene, a-Octylene 8000 TWA=50 (AIHA) OV TWA=75 (AIHA) OV Osmic acid 1 mg/m3 TWA=0.0002 STEL=0.0006 (F)SA Ethane dioic acid, Oxalic acid dihydrate 500 mg/m3 TWA=1 mg/m3 STEL=2 mg/m3 OV/N95 Benzenesulfonic acid, 4,4-Oxybis-dihydrazide; Celogen®; Diphenyl ether 4,4'-disulfohydrazide; OBSH Difluorine monoxide, 0.5 Fluorine monoxide TWA=0.1 mg/m3 N95 (inhalable fraction) C=0.05 SA 3M 3510 Monitor Unknown sorbent effectiveness See comment D on page 8 Unknown sorbent effectiveness 86 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 87 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Ozone 10 10028-15-6 Paraffin wax fume 8002-74-2 Particulates Not Otherwise Regulated Nuisance particulates Pentaborane 19624-22-7 Pentachloronaphthalene 1321-64-8 Pentaboron nonahydride, 3 Stable pentaborane HalowaxTM 1013 TWA=0.1 OZ (light work) TWA=0.08 (moderate work) TWA=0.05 (heavy work) TWA=2 mg/m3 N95 TWA=15 mg/m3 (total dust, OSHA) TWA=10 mg/m3 (inhalable fraction) TWA=3 mg/m3 (respirable fraction) TWA=0.005 STEL=0.015 TWA=0.5 mg/m3 (inhalable fraction and vapor) -skin- N95 SA OV/N95 Respirators with nuisance level organic vapor relief recommended by 3M up to 10X OEL. Not NIOSH approved for ozone. This category includes many materials. For oils, an R or P95 filter/respirator is recommended Unknown sorbent effectiveness See comment D on page 8 Pentaerythritol 115-77-5 Tetramethylolmethane Pentaerythritol triacrylate 3524-68-3 1,1,1,2,2Pentafluoroethane 354-33-6 1,1,1,3,3Pentafluoropropane 460-73-1 Pentane, all isomers 109-66-0 78-78-4 463-82-1 2,4-Pentanedione 123-54-6 2-Propenoic acid, 2-(hydroxymethyl)-2-[[(1-oxo2-propenyl)oxy]methyl]-1,3propanediyl-ester, PETA Fluorocarbon 125, HFC-125, Pentafluoroethane GenetronTM 245fa, HFC-245fa, R-245fa n-Pentane 15000 Acetylacetone, Diacetylmethane TWA=10 mg/m3 TWA= 5 mg/m3 (OSHA, respirable fraction) TWA=1 mg/m3 (AIHA) N95 OV/P95 TWA=1000 (AIHA) SA TWA=300 (AIHA) SA TWA=1000 OV TWA=25 OV -skin- See comment D on page 8 Ineffective sorbents Short service life. 3M 3530 Monitor 88 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 89 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Pentyl acetate, all isomers 628-63-7 626-38-0 620-11-1 625-16-1 123-92-2 624-41-9 Peracetic acid 79-21-0 Perchloroethylene 127-18-4 Perchloromethyl mercaptan 594-42-3 2-Acetoxypentane, 3-Amyl 3000-9000 TWA=50 acetate, n-Amyl acetate, sec- STEL=100 Amyl acetate, tert-Amyl acetate, Banana oil, 1,1-Dimethylpropyl acetate, Isoamyl acetate, Isopentyl acetate, 3-Methyl-1- butanol acetate, 1-Methylbutyl acetate, 2-Methylbutyl acetate, 3-Methylbutyl acetate, 2-Methylbutyl ethanoate, 1-Pentanol acetate, 2-Pentanol acetate, 1-Pentyl acetate, 2-Pentyl acetate, 3-Pentyl acetate Acetic peroxide, Peroxyacetic acid STEL= 0.4ppm (Inhalable fraction and vapor) Perk, Tetrachloroethylene 500 PMM, Trichloromethyl 10 sulfur chloride TWA=25 STEL=100 TWA=0.1 OV See comment E on page 8. 3M 3510 Monitor (F)OV/AG/N95 (F)OV See Technical Data Bulletin #185. See comment E on page 8 3M 3510 Monitor OV Perchloryl fluoride 7616-94-6 Perfluorobutyl ethylene 19430-93-4 Perfluoroisobutylene 382-21-8 Persulfates, Ammonium 7727-54-0 Persulfates, Potassium 7727-21-1 Persulfates, Sodium 7775-27-1 Petroleum distillates 8002-05-9 Phenol 108-95-2 Chlorine oxyfluoride 385 1H,1H,2H-Perfluorohexene; 1-Hexane,3,3,4,4,5,5,6,6,6nonafluoro; PFBE Octafluoroisobutylene, Octafluoro-sec-butene, PFIB Aliphatic petroleum 10000 naphtha, Petroleum ether (boiling range 95-115 degrees C), Petroleum naphtha Carbolic acid, Monohydroxy 250 benzene TWA=3 SA STEL=6 TWA=100 OV C=0.01 SA TWA=0.1 mg/m3 N95 TWA=0.1 mg/m3 (F)N95 TWA=0.1 mg/m3 (F)N95 TWA=500 (OSHA) OV TWA=5 -skin- OV/N95 Unknown sorbent effectiveness Short service life Short OV service life Odor variable. See also Gasoline, Stoddard solvent 90 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 91 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments m-Phenylenediamine 108-45-2 o-Phenylenediamine 95-54-5 p-Phenylenediamine 106-50-3 1,3-Benzenediamine, m-Diaminobenzene 1,2-Benzenediamine, o-Diaminobenzene, Orthamine 1,4-Diaminobenzene, p-Diaminobenzene Phenyl ether, vapor 101-84-8 Diphenyl ether, Diphenyl oxide 7000 Phenyl ether-biphenyl mixture vapor 8004-13-5 Phenyl glycidyl ether 122-60-1 Phenylhydrazine 100-63-0 Diphenyl oxide-diphenyl mixture, DowthermTM A 1,2-Epoxy-3-phenoxy propane, Glycidyl phenyl ether, Oxirane, PGE, Phenoxymethyl, Phenoxypropenoxide, Phenyl epoxypropyl ether Hydrazinobenzene 295 TWA=0.1 mg/m3 OV/N95 TWA=0.1 mg/m3 OV/N95 TWA=0.1 mg/m3 OV/N95 TWA=1 OV STEL=2 TWA=1 (OSHA) OV TWA=0.1 OV -skin- TWA=0.1 -skin- (F)OV SA preferable if heat involved SA preferable if heat involved SA preferable if heat involved See comment E on page 8. 3M 3510 Monitor. See comment E on page 8 Phenyl isocyanate 103-71-9 Isocyanatobenzene, Carbamil Phenyl carbamide TWA=0.005 OV STEL=0.015 Phenyl mercaptan 108-98-5 Benzenethiol, Thiophenol TWA=0.1 OV Phenylphosphine 638-21-1 C=0.05 OV Phosgene 75-44-5 Carbon oxychloride, Carbonyl 2 TWA=0.1 SA chloride, Chloroformyl chloride Phosphine 7803-51-2 Hydrogen phosphide, 200 TWA=0.05 SA Phosphorus hydride C=0.15 2-Phosphono-1,2,4- PBTC butanetricarboxylic acid 37971-36-1 Phosphoric acid 7664-38-2 m-Phosphoric acid, o-Phosphoric acid, White phosphoric acid Phosphorus (yellow) 12185-10-3 White phosphorus, WP Phosphorus oxychloride Phosphoryl chloride 10025-87-3 TWA=10 (AIHA) N95 10000 mg/m3TWA=1 mg/m3 STEL=3 mg/m3 TWA=0.1 mg/m3 (F)N95 SA TWA=0.1 (F)AG Hg recommended for certain applications. See Technical Data Bulletin #212 N95 acceptable with appropriate eye/face protection If no phosphorus vapor or phosphine gas present, N95 92 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 93 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Phosphorus pentachloride 10026-13-8 Phosphorus pentasulfide 1314-80-3 Phosphorus trichloride 7719-12-2 o-Phthalaldehyde 643-79-8 Phthalic anhydride 85-44-9 m-Phthalodinitrile 626-17-5 Phosphoric chloride Phosphoric sulfide Phosphorus chloride 200 mg/m3 750 mg/m3 50 1,2-Benzenedialdehyde, OPA 1,3-Isobenzofurandione, PAN 10000 mg/m3 IPN, Isophthalodinitrile, m-Dicyanobenzene TWA=0.1 AG TWA=1 mg/m3 N95 STEL=3 mg/m3 TWA=0.2 STEL=0.5 (F)AG C=0.0001 -skin- (F)OV/N95 TWA=0.002 mg/m3 OV/N95 (inhalable fraction and vapor) STEL=0.005 mg/m3 (inhalable fraction and vapor) -skin- TWA=5 mg/m3 (inhalable fraction and vapor) OV/N95 See comment D on page 8 See comment D on page 8 o-Phthalodinitrile 91-15-6 2-Picoline 109-06-8 3-Picoline 108-99-6 4-Picoline 108-89-4 Picric acid 88-89-1 Piperazine and salts 110-85-0 Piperidine 110-89-4 Platinum metal (as Pt) 7440-06-4 1,2-Benzenedicarbonitrile, 1,2-dicyanobenzene, 1,2-Benzodinitrile, o-Benzenedinitrile, Phtalic acid dinitrile 2-Methyl-pyridine, a-Picoline TWA=1 mg/m3 (inhalable fraction and vapor) TWA=2 (AIHA) STEL=5 (AIHA) -skin- 3-Methyl-pyridine, b-Picoline TWA=2 (AIHA) STEL=5 (AIHA) -skin- 4-Methyl-pyridine, g-Picoline TWA=2 (AIHA) STEL=5 (AIHA) -skin- 2,4,6-Trinitrophenol, Lyddite, 100 mg/m3 TWA=0.1 mg/m3 Melinite, Pertite, Shimose 1,4-Piperazine, 1,4-Diazacyclohexane, Diethylenediamine, Hexahydropyrazine, Piperazidine TWA=0.03 (inhalable fraction and vapor, as piperazine) Hexahydropyridine TWA=1 (AIHA) -skin- TWA=1 mg/m3 OV/N95 OV OV OV N95 OV/N95 (F)OV N95 See comment D on page 8 See comment D on page 8 94 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 95 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Platinum soluble salts (as Pt) Polyethylene glycols 25322-68-3 Polypropylene glycols 25322-69-4 Polyvinyl chloride 9002-86-2 Portland cement (containing no asbestos and <1% crystaline silica) 65997-15-1 Potassium bromate 7758-01-2 Potassium hydroxide 1310-58-3 PEG, PGE, Polyoxyethylene PPG Cloroethene polymer, Cloroethylene homopolymer, Cloroethylene polymer, Polychloroethylene, PVC, Vinyl chloride homoploymer, Vinyl chloride polymer Cement, Hyraulic cement, Portland cement silicate Bromic acid potassium salt Caustic potash, Lye, Potassium hydrate TWA=0.002 mg/m3 (F)N95 TWA=10 mg/m3 R95 (AIHA) P95 TWA=10 mg/m3 R95 (AIHA) P95 TWA=1 mg/m3 N95 (respirable fraction) See comment G on page 8 See comment G on page 8 TWA=1 mg/m3 N95 (respirable fraction) TWA=0.1 mg/m3 N95 (AIHA) C=2 mg/m3 N95 Propane 74-98-6 2-Propanol 67-63-0 n-Propanol 71-23-8 Propargyl alcohol 107-19-7 Propargyl bromide 106-96-7 2-Propenoic acid, Isooctyl ester 29590-42-9 b-Propiolactone 57-57-8 Dimethyl methane, n-Propane 20000 IPA, Isopropanol, Isopropyl alcohol, sec-Propyl alcohol 1-Propanol, Ethyl carbinol, n-Propyl alcohol, Propan-1-ol 12000 4000 2-Propyn-1-ol 1-Bromo-2-propyne; 3-Bromopropyne; Bromopropyne; gamaBromoallylene; Propyne, 3-bromo IOA, Isoctyl acrylate 3-Hydroxy beta-lactone; 29000 3-Hydroxypropionic acid; beta- Propiolactone; BPL; Hydroacrylic acid, beta-lactone; Propiolactone TWA=1000 (OSHA) TWA=200 STEL=400 TWA=100 TWA=1 -skinTWA=0.1 (AIHA) -skin- TWA=5 (AIHA) TWA=0.5 SA (F)OV (F)OV OV OV OV (F)OV Ineffective sorbents Irritation also provides warning. 3M 3530 Monitor See comment E on page 8. 3M 3510 Monitor OSHA requires SA with hood for certain applications; see 29 CFR 1910.1003 96 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 97 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Propionaldehyde 123-38-6 Propionic acid 79-09-4 n-Propyl acetate 109-60-4 Propylene 115-07-1 Propylene dichloride 78-87-5 Propylene glycol (aerosol only) 57-55-6 Propylene glycol (vapor and aerosol) 57-55-6 Propylene glycol dinitrate 6423-43-4 1-Propanal, Methylacetalaldhyde, Propylaldehyde Ethylformic acid, Methylacetic acid 29000 Acetic acid n-propyl ester, Propyl acetate 8000 1-Propene, 1-Propylene, Methylethene, Methylethylene, Propene 1,2-Dichloropropane 2000 1,2-Dihydroxy propane, 1,2-Propanediol, Methyl glycol 1,2-Dihydroxy propane, 24000 1,2-Propanediol, Methyl glycol 1,2-Propanediol dinitrate, 1,2-Propylene glycol dinitrate TWA=20 TWA=10 TWA=100 STEL=150 TWA=500 TWA=10 TWA=10 mg/m3 (AIHA) TWA=10 mg/m3 (AIHA) TWA=0.05 -skin- SA (F)OV (F)OV SA OV R95 P95 OV/P95 (F)OV Short OV service life 3M 3510 Monitor See comment G on page 8 See comment G on page 8 Propylene glycol ethyl ether 1569-02-4 Propylene glycol monomethyl ether 107-98-2 Propylene glycol monoethyl ether 1-Methoxy-2-propanol 16000 TWA=50 STEL=200 -skin- TWA=50 STEL=100 (F)OV OV 3M 3510 Monitor Propylene glycol monomethyl ether acetate 108-65-6 Propyleneimine 75-55-8 Propylene oxide 75-56-9 n-Propyl nitrate 627-13-4 Pyridine 110-86-1 Quinoline 91-22-5 1-Methoxy-2-acetoxypropane, 15000 1-Methyoxy-2-propanol acetate, 2-Methoxy-1-methylethyl acetate, Glycol ether PM acetate, PGMEA 2-Methylaziridine 500 1,2-Epoxypropane, 1,2Propylene oxide, 2,3-Epoxypropane, Methyloxirane, Propene oxide Nitric acid n-propylester 2000 2000 Azabenzene, Azine 3600 1-Azana-phthalene, 1-Benzazine, Chinoline, Lencol, Leukoline TWA=50 (AIHA) OV TWA=0.2 STEL=0.4 -skin- TWA=2 (F)OV OV TWA=25 OV STEL=40 TWA=1 OV TWA=0.001 (AIHA) -skin- (F)OV 3M 3510 Monitor Short service life. 3M 3550 Monitor 98 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 99 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Quinone 106-51-4 Resorcinol 108-46-3 Benzoquinone, p-Benzoquinone 1,3-Benzenediol, m-Dihydroxybenzene Rhodium, metal and insoluble compounds 7440-16-6 Rhodium, soluble compounds (as Rh) Selenium & compounds, (as Se) 7782-49-2 Selenium hexafluoride 7783-79-1 Silca, amorphous (diatomaceous earth) 61790-53-2 Diatomite, Silicon dioxide 300 mg/m3 TWA=0.1 (F)OV/N95 14000 TWA=10 N95 STEL=20 TWA=0.1 mg/m3 N95 (OSHA) TWA=0.001 mg/ N95 m3 (OSHA) TWA=0.2 mg/m3 N95 5 TWA=0.05 SA TWA=0.8 mg/m3 N95 (OSHA) OV/N95 may be preferable if heat is involved Unknown sorbent effectiveness Assuming 100% SiO2 (80 mg/m3 divided by %SiO2) Silica, crystalline 14808-60-7 1317-95-9 14464-46-1 Silica, crystallinetridymite 15468-32-3 Crystallized silicon dioxide, Cristobalite, a-Quartz, Silica, Tripoli Silicon 7440-21-3 Silicon carbide (fibrous) 409-21-2 Silicon carbide (nonfibrous particles with no asbestos and <1% crystalline silica) 409-21-2 Silicon tetrahydride 7803-62-5 Silane TWA=0.025 mg/m3 N95 (respirable fraction) TWA=0.05 mg/m3 N95 (OSHA, respirable fraction) TWA=15 mg/m3 N95 (OSHA) TWA=5 mg/m3 (OSHA, respirable fraction) TWA= 0.1 f/cc N95 (respirable fibers) TWA= 10 mg/m3 N95 (inhalable fraction) TWA=3 mg/m3 (respirable fraction) TWA=5 SA 100 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 101 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Silver, metal and soluble compounds (as Ag) 7440-22-4 Soapstone (particles with no asbestos and <1% crystalline silica) Sodium azide as hydrazoic acid vapor 26628-22-8 Sodium azide as sodium azide 26628-22-8 Sodium bisulfite 7631-90-5 Massive talc, Soapstone silicate, Steatite Hydrazoic acid vapor Hydrazoic acid (no vapor) Sodium hydrogen sulfite Sodium borate, anhydrous 1330-43-4 Borates, tetrasodium salts, anhydrous; Borax fused; Boric acid, disodium salt; Disodium tetraborate; Sodium tetraborate, anhydrous TWA=0.01 mg/m3 N95 (OSHA) TWA=2 mg/m3 N95 (respirable fraction) C=0.11 SA C=0.29 mg/m3 N95 TWA=5 mg/m3 AG/N95 TWA=2 mg/m3 N95 (inhalable fraction) STEL=6 mg/m3 (inhalable fraction) Unknown sorbent effectiveness N95 alone may be suitable if irritation eliminated Sodium borate, decahydrate 1303-96-4 Borascu; Borates, tetrasodium salts, decahydrate; Borax; Borocin; Disodium diborate decahydrate; Disodium tetraborate decahydrate; Sodium pyroborate decahydrate; Sodium tetraborate, decahydrate TWA=2 mg/m3 N95 (inhalable fraction) STEL=6 mg/m3 (inhalable fraction) Sodium borate, pentahydrate 12179-04-3 Borates, tetrasodium salts, pentahydrate; Boric acid, pentahydrate; Boron sodium oxide, pentahydrate; Mule team borascu; Sodium tetraborate pentahydrate TWA=2 mg/m3 N95 (inhalable fraction) STEL=6 mg/m3 (inhalable fraction) Sodium chloroacetate Chloroacetic acid, sodium 3926-62-3 salt; Monoxone; Sodium monochloroacetate TWA=2.5 mg/m3 N95 (AIHA) Sodium fluoroacetate 1080, SFA, Sodium 62-74-8 monofluoroacetate 5 mg/m3 TWA=0.05 mg/m3 N95 -skin- Sodium hydroxide Caustic soda, Lye, Soda lye 250 mg/m3 C=2 mg/m3 N95 1310-73-2 Sodium hypochlorite Hypochlorous acid, sodium 7681-52-9 salt; Sodium oxychloride STEL= 2 mg/m3 N95 (AIHA) Chlorine may also be present 102 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. Respirator 103 Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Sodium metabisulfite 7681-57-4 Starch 9005-25-8 Stearates 557-05-1; 557-04-0; 57-11-4; 822-16-2 Stibine 7803-52-3 Stoddard solvent 8052-41-3 Strontium chromate (as Cr) 7789-06-2 Sodium pyrosulfite TWA=5 mg/m3 AG/N95 Corn starch Aluminium stearate, Calcium stearate, Glyceryl stearate, Lithium stearate, magnesium stearate, Potassium stearate, Sodium stearate, Stearic acid, Zinc stearate Antimony trihydride, Hydrogen antimonide Dry cleaning safety solvent, Mineral spirits C.I. pigment yellow 32, Strontium yellow 40 29500 mg/m3 30 mg/m3 TWA=10 mg/m3 N95 TWA= 5 mg/m3 (OSHA, respirable fraction) TWA=10 mg/m3 N95 (inhalable fraction) TWA=3 mg/m3 (respirable fraction) TWA=0.1 SA TWA=100 OV TWA=0.0002 mg/m3 N95 (as Cr(VI), inhalable fraction) STEL=0.0005 mg/m3 (as Cr(VI), inhalable fraction) N95 alone may be suitable if irritation eliminated Unknown sorbent effectiveness 3M 3510 Monitor Strychnine 57-24-9 Styrene 100-42-5 Subtilisins 1395-21-7 9014-01-1 3 mg/m3 TWA=0.15 mg/m3 N95 Cinnamene, Phenylethylene, Styrene, Styrene monomer, Vinyl benzene Proteolytic enzymes as 100% crystalline enzyme 5000 TWA=20 OV STEL=40 C=0.00006 mg/m3 SA Sucrose 57-50-1 Sulfur dioxide 7446-09-5 Sulfur hexafluoride 2551-62-4 Sulfuric acid 7664-93-9 Sulfur monochloride 10025-67-9 Saccharose, Table sugar SO2 100 TWA=10 mg/m3 TWA= 5 mg/m3 (OSHA, respirable fraction) STEL=0.25 SF6 TWA=1000 Hydrogen sulfate, Matting acid, 80 mg/m3 Oil of vitriol, Sulphuric acid, Vitriol brown oil Sulfur chloride, 10 Sulfur subchloride TWA=0.2 mg/m3 (thoracic fraction) C=1 N95 AG SA (F)N95 (F)AG Sulfur pentafluoride Disulfur decafluoride 1 C=0.01 AG 5714-22-7 3M 3510 Monitor Difficult to measure 10X OEL. N95 acceptable with suitable air sampling data Irritation and taste also provides warning Unknown sorbent effectiveness N95 acceptable with appropriate eye/face protection 104 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. Respirator 105 Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Sulfur tetrafluoride 7783-60-0 Sulfuryl fluoride 2699-79-8 Synthetic vitreous fibers - Continuous filament glass fibers Fibrous glass, dust; Glass, fibrous or dust Synthetic vitreous fibers - glass wool fibers Synthetic vitreous fibers - refractory ceramic fibers Synthetic vitreous Mineral (rock), wool fiber fibers - rock wool fibers Synthetic vitreous fibers - slag wool fibers 1000 C=0.1 AG TWA=5 SA STEL=10 TWA=5 mg/m3 N95 (inhalable fraction) TWA=1 f/cc (respirable fibers) TWA=1 f/cc N95 (respirable fibers) TWA=0.2 f/cc N95 (respirable fibers) TWA=1 f/cc N95 (respirable fibers) TWA=1 f/cc N95 (respirable fibers) Unknown sorbent effectiveness Synthetic vitreous fibers - special purpose glass fibers Talc (containing no asbestos and <1% cystalline silica) 14807-96-6 Hydrous magnesium silicate, Non-asbestiform talc, Non- fibrous talc, Steatite talc Tantalum, metal and oxide dusts (as Ta) 7440-25-7 Tellurium and compounds (as Te, excluding hydrogen telluride) 13494-80-9 Tellurium hexafluoride 1 (as Te) 7783-80-4 Terephthalic acid 100-21-0 1,4 Benzenediacarboxylic acids, Benzene-p-dicarboxylic acid, p-Phthalic acid, Tephthol, TPA Terphenyls 26140-60-3 Diphenyl benzenes, Mixed terphenyls, m-Terphenyl, o-Terphenyl, p-Terphenyl TWA=1 f/cc N95 (respirable fibers) TWA=2 mg/m3 N95 (respirable fraction) TWA=5 mg/m3 N95 (OSHA) TWA=0.1 mg/m3 N95 TWA=0.02 SA TWA=10 mg/m3 N95 C=5 mg/m3 N95 Unknown sorbent effectiveness OV/N95 may be preferable if heat is involved 106 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. Respirator 107 Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments 1,1,2,2Tetrabromoethane 79-27-6 1,1,1,2Tetrachloro-2,2difluoroethane 76-11-9 1,1,2,2-Tetrachloro1,2-difluoroethane 76-12-0 1,1,2,2Tetrachloroethane 79-34-5 Tetrachloronaphthalene 1335-88-2 2,3,5,6Tetrachloropyridine 2402-79-1 Acetylene tetrabromide, Muthmann's liquid, Tetrabromoethane, Tetrabromoethylene 2,2-Difluoro-1,1,1,2tetrachloroethane; Freon® 112a; Halocarbon 112a; Refrigerant 112a Freon® 112, Halocarbon 112, Refrigerant 112 Acetylene tetrachloride 10 15000 15000 150 HalowaxTM, Nibren wax, Seekay wax Pyridine 2,3,5,6-tetrachloro- TWA=0.1 OV/N95 TWA=100 OV TWA=50 OV TWA=1 -skin- TWA=2 mg/m3 OV OV/N95 TWA=5 mg/m3 (AIHA) OV/N95 See comment E on page 8 3M 3510 Monitor See comment D on page 8 See comment D on page 8 Tetrachlorosilane 10026-04-7 Silicon chloride, Silicon tetrachloride C=1 (AIHA) AG/N95 Tetraethylene glycol diacrylate 17831-71-9 Tetraethylene pentamine 112-57-2 Tetraethyl lead (as Pb) 78-00-2 1,1,1,2Tetrafluoroethane 811-97-2 Tetrafluoroethylene 116-14-3 2-Propionic acid, oxy-bis (2,1- ethane-diyoxy-2,1ethanediol) ester; TTEGDA 1,2-Ethanediamine, N-(2-aminoethyl)-N'-(2((2-aminoethyl)amino) ethyl); DEH 26; TEPA; Tetraethyl pentamine; Tetren 1,4,7,10,13-Pentaazatridecane Lead tetraethyl, TEL Fluorocarbon 134a, HFA 134a, HFC 134a, Tetrafluoroethane 40 mg/m3 TWA=1 mg/m3 (AIHA) -skin- TWA=5 mg/m3 (AIHA) -skin- OV/P95 (F)OV TWA=0.075 mg/m3 OV (OSHA) -skin- TWA=1000 (AIHA) SA 1,1,2,2-Tetrafluoroethylene; Fluoroplast 4; Perfluoroethene; Perfluoroethylene; Tetrafluoroethene; TFE TWA=2 SA Reacts rapidly with moisture yielding HCl and silica See comment D on page 8 Ineffective sorbents 108 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. Respirator 109 Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments 2,3,3,3Tetrafluoropropene 754-12-1 Tetrahydrofuran 109-99-9 Diethylene oxide, Tetramethylene oxide, THF 20000 Tetrahydrofurfuryl alcohol 97-99-4 Tetrahydro-2-furancarbinol, Tetrahydro-2-furanmethanol, Tetrahydro-2-furylmethanol, THFA Tetrakis (hydroxymethyl) phosphonium chloride 124-64-1 Proban CC, Pyroset TKC, Retardol C, Tetrahydroxymethyl phosphonium chloride, THPC Tetrakis (hydroxymethyl) phosphonium sulfate 55566-30-8 bis tetrakis-(hydroxymethyl) phosphonium sulfate, Octakis (hydroxymethyl) phosphonium sulfate, Pyroset TKO, Retardol S, THPS TWA=500 (AIHA) SA TWA=50 OV STEL=100 -skin- TWA=0.5 (AIHA) OV -skin- TWA=2 mg/m3 N95 TWA=2 mg/m3 N95 3M 3510 Monitor Tetramethyl lead (as Pb) 75-74-1 Tetramethyl succinonitrile 3333-52-6 Tetranitromethane 509-14-8 Tetryl 479-45-8 Thallium, elemental and soluble compounds (as Tl) 7440-28-0 4,4'-Thiobis(6-tertbutyl-m-cresol) 96-69-5 Lead tetramethyl, TML TMSN Tetan 40 mg/m3 5 5 TWA=0.075 mg/m3 (OSHA) -skin- TWA=0.09 (inhalable fraction and vapor) -skin- TWA=0.005 OV OV/N95 OV 2,4,6Trinitrophenylmethylnitramine, Nitramine, N-Methyl-N2,4,6-tetranitroaniline, Tetralite TWA=1.5 mg/m3 N95 Thallium acetate, Thallium 20 mg/m3 TWA=0.02 mg/m3 N95 carbonate, Thallium hydroxide (inhalable fraction) -skin- 4,4'-Thiobis(3-methyl-6-tertbutyl phenol) TWA=15 mg/m3 N95 (OSHA) TWA=1 mg/m3 (inhalable fraction) TWA=5 mg/m3 (OSHA, respirable fraction) See comment D on page 8 110 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 111 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Thioglycolic acid 68-11-1 Thionyl chloride 7719-09-7 Thiram 137-26-8 Mercaptoacetic acid, Thioranic acid Sulfur oxychloride, Sulfurous oxychloride Tetramethylthioram disulfide, TMT, TMTD, TMTDS Tin and inorganic compounds (except SnH4 and In2O5Sn) (as Sn) 7440-31-5 Tin, organic compounds (as Sn) Titanium dioxide 13463-67-7 Titanium tetrachloride 7550-45-0 Anatase, Brookite, Rutile Titanium chloride 59000 TWA=1 -skin- C=0.2 1500 mg/m3 TWA=0.05 mg/m3 (inhalable fraction and vapor) 400 mg/m3 TWA=2 mg/m3 (inhalable particulate) TWA=0.1 mg/m3 STEL=0.2 mg/m3 -skin- TWA=10 mg/m3 TWA=0.5 mg/m3 (AIHA) (F)OV (F)AG OV/N95 N95 OV/N95 N95 AG/N95 See comment D on page 8 See comment D on page 8 Toluene 108-88-3 Toluene diamine 25376-45-8 95-80-7 Toluene-2,6diisocyanate 91-08-7 Aantisal 1a, Methacide, Methyl benzene, Methylbenzol, Monomethyl benzene, Phenyl methane, Tol, Toluol, Tolu-sol Diaminotoluene, TDA, Tolyenediamine 2000 2,6-TDI, 10 2,6-Toluene diisocyanate Toluene-2,4diisocyanate 584-84-9 2,4-TDI, 2,4-Toluene diisocyanate p-Toluenesulfonyl chloride 98-59-9 m-Toluidine 108-44-1 o-Toluidine 95-53-4 4-Methyl-benzenesulfonyl chloride, Tosyl chloride m-Aminotoluene 1-Methyl-1,2-aminobenzene; 100 2-Methylaniline; o-Aminotoluene; o-Methylaniline TWA=20 OV C=300 (OSHA) 3M 3510 Monitor TWA=0.005 (AIHA) N95 -skin- TWA=0.001 (inhalable fraction and vapor) STEL=0.005 (inhalable fraction and vapor) -skin- TWA=0.001 (inhalable fraction and vapor) STEL=0.005 (inhalable fraction and vapor) -skin- C=5 mg/m3 (AIHA) OV/N95 OV/N95 (F)OV/AG/ N95 TWA=2 -skin- TWA=2 -skin- (F)OV (F)OV See comment E on page 8 See comment E on page 8 See comment D on page 8. HCl and p-toluene sulfuric acid produced by hydrolysis 112 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 113 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments p-Toluidine 106-49-0 p-Aminotoluene, Tributyl phosphate TBP, Tri-n-butyl phosphate 125 126-73-8 Trichloroacetic acid 76-03-9 TCA 1,2,4-Trichlorobenzene 120-82-1 25000 1,1,2-Trichloroethane b-Trichloroethane, 500 79-00-5 Vinyl trichloride Trichloroethylene 79-01-6 1,1,2-TCE, 1-Chloro-2,2- dichloroethylene, Ethylene trichloride, TCE, TricleneTM 1000 Trichlorofluoromethane CFC-11, Fluorotrichloromethane, 10000 75-69-4 FreonTM 11, Refrigerant 11, Trichloromonofluoromethane TWA=2 -skin- TWA=5 mg/ m3 (Inhalable fraction and vapor) TWA=0.5 (F)OV OV/P95 (F)OV/AG C=5 OV TWA=10 -skin- TWA=10 STEL=25 C=200 (OSHA) TWA=1000 (OSHA) C=1000 (F)OV OV SA See comment E on page 8 Irritation also provides warning 3M 3510 Monitor Short OV service life Trichloronaphthalene HalowaxTM, Nibren wax, 1321-65-9 Seekay wax 1,2,3-Trichloropropane Allyl trichloride, Glycerin 1000 96-18-4 trichlorohydrin, Glycerol trichlorohydrin, Trichlorohydrin Trichlorosilane 10025-78-2 Silicochloroform 1,1,2-Trichloro-1,2,2- trifluoroethane 76-13-1 FC-113, Freon® 113, Halocarbon 113, Refrigerant 113, TTE 4500 Triethanolamine 102-71-6 2,2,2-Nitrilotriethanol, Daltogen, Sterolamide, TEA, Trihydroxytriethylamine Triethoxysilane 998-30-1 Triethylamine 121-44-8 Silane, triethoxy- N,N-Diethylanamine, N-Triethylamine, TEA 1000 Triethylene glycol diacrylate 1680-21-3 2-Propenoic acid, 2-ethanediylbis-(oxy-2,1ethanediyl) ester; TREGDA TWA=5 mg/m3 -skinTWA=0.005 -skin- C=0.5 (AIHA) TWA=1000 STEL=1250 TWA=5 mg/m3 OV/N95 (F)OV (F)AG SA OV/P95 TWA=0.05 (AIHA) TWA=0.5 STEL=1 (F)SA (F)OV TWA=1 mg/m3 (AIHA) -skin- OV/P95 See comment D on page 8 Short OV service life. See comment D on page 8 Unknown sorbent effectiveness AM not specifically approved, but 3M recommended for longer service life 114 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 115 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Triethylenetetramine 112-24-3 Triethylphosphate 78-40-0 Trifluorobromomethane 75-63-8 1,1,1-Trifluoro-2,2dichloroethane 306-83-2 1,1,1-Trifluoroethane 420-46-2 2,2,2-Trifluoroethanol 75-89-8 1,3,5-Triglycidyl-striazinetrione 2451-62-9 1,4,7,10-Tetraazadecane; 1,8-Diamino-3,6-diazaoctane; 3,6-Diazaoctane-1,8-diamine; N, N'-bis(2-aminoethyl)-1,2,ethane diamine; TECZA; TETA, Trientine Phosphoric acid triethyl ester 17000 Bromotrifluoromethane, 50000 Freon® 13B1, Halocarbon 13B1, HalonTM 1301, Refrigerant 13B1 FC-123, HCFC-123, Hydrofluorocarbon 123 FC-143a, HFC-143a, Hydrofluorocarbon 143a 2,2,2-Trifluoroethyl alcohol; 55000 Ethanol, 2,2,2,-Trifluoro; TFE 1,3,5-Triazine-2,4,6-(1H,3H,5H)trione, Araldite PT-810, TEPIC TWA=1 (AIHA) OV -skin- TWA=7.45 mg/m3 (AIHA) TWA=1000 OV/P95 SA TWA=50 (AIHA) SA TWA=1000 (AIHA) SA TWA=0.3 (AIHA) SA TWA=0.05 mg/m3 N95 See comment E on page 8. R or P filter, if filter required Short OV service life Short OV service life Ineffective sorbents Ineffective sorbents Trimellitic anhydride 552-30-7 Anhydrotrimellitic acid, TMA, TMAN, Trimellitic acid anhydride TWA=0.0005 mg/m3 (inhalable fraction and vapor) STEL=0.002 mg/m3 (inhalable fraction and vapor) OV/N95 Chemical manufacturer's recommendation. See comment D on page 8 Trimethoxysilane 2487-90-3 TWA=0.05 (AIHA) (F)OV Trimethylamine 75-50-3 N,N-Dimethyl methanamine, 20000 N-Trimethylamine, TMA TWA=1 (AIHA) STEL=15 (F)AM AIHA WEEL is lower than TLV of 5 ppm. AM not specifically approved Trimethyl benzene 25551-13-7 Hemimellitene, Mesitylene, Pseudocumene 8000 TWA=25 OV 3M 3510 Monitor Trimethylchlorosilane 75-77-4 Trimethyl phosphite 121-45-9 Chlorotrimethylsilane, Monochlorotrimethylsilicon, Trimethyl chlorosilane Methyl phosphite, Phosphorus acid trimethylester C=5 (AIHA) TWA=2 (F)OV/AG (F)OV Trimethylolpropane triacrylate 15625-89-5 2-Propenoic acid, 2-ethyl-2(((1oxo-2-propenyl) oxy) methyl)1,3-propanediyl ester TWA=1 mg/m3 (AIHA) -skin- OV/P95 Trimethylolpropane trimethacrylate 3290-92-4 Acrylic acid, triester w/2-ethyl 2 (hydroxymethyl) 1,3 propanediol TWA=1 mg/m3 (AIHA) -skin- OV/P95 116 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 117 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments 2,4,6-Trinitrotoluene (TNT) 118-96-7 Triorthocresyl phosphate 78-30-8 Triphenyl phosphate 115-86-6 sym-Trinitrotoluene, TNT, Trinitrotoluene, Trinitrotoluol o-Tritolyl phosphate, TCP, TOCP, Tricresylphosphate Phenyl phosphate, TPP 1000 mg/m3 TWA=0.1 mg/m3 (inhalable fraction and vapor) -skin- 40 mg/m3 TWA=0.02 mg/m3 (inhalable fraction and vapor) -skin- TWA=3 mg/m3 OV/N95 R95 P95 N95 Trisodium phosphate Sodium o-phosphate, TSP 7601-54-9 Tungsten and compounds, the absence of cobalt 7440-33-7 STEL=5 mg/m3 (AIHA) (F)N95 TWA=3 mg/m3 N95 (respirable particulate matter) See comment D on page 8 See comment D on page 8 OV/N95 may be preferable if heat is involved N95 acceptable with appropriate eye/face protection Turpentine 8006-64-2 Uranium, insoluble compounds (as U) 7440-61-1 Uranium, soluble compounds (as U) 7440-61-1 Urea 57-13-6 Gum spirits, Gum turpentine, Turps, Wood turpentine 1500 TWA=20 30 mg/m3 TWA=0.2 mg/m3 STEL=0.6 mg/m3 (F)OV N95 20 mg/m3 TWA=0.05 mg/m3 N95 (OSHA) Carbamide, Carbonyldiamide, Carbonyldiamine, Isourea TWA=10 mg/m3 N95 (AIHA) n-Valeraldehyde 110-62-3 Vanadium pentoxide 1314-62-1 Pentanal, Valeric aldehyde Vanadic anhydride, Vanadium oxide Vanadium pentoxide fume 1314-62-1 Vanillin 121-33-5 Vanilla, Vanillaldehyde, Vanillic aldehyde TWA=50 (F)OV 70 mg/m3 TWA= 0.05 mg/m3 N95 (inhalable fraction) C=0.5 mg/m3 (OSHA, respirable fraction) 70 mg/m3 TWA=0.05 mg/m3 N95 (inhalable fraction) C=0.1 mg/m3 (OSHA) TWA=10 mg/m3 N95 (AIHA) See comment E on page 8 See 10 CFR 20 subpart H AG/N95 if halides. See 10 CFR 20 subpart H AM/N95 may be preferable if heat is involved 118 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 119 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Vegetable oil Vinyl acetate 108-05-4 Vinyl bromide 593-60-2 Vinyl Chloride 75-01-4 1-Acetoxyethylene, Ethenyl acetate Bromoethylene 26000 Chloroethene, Chloroethylene, 36000 Monochloroethylene, VC, VCM, Vinyl chloride monomer TWA=15 mg/m3 (OSHA) TWA= 5 mg/m3 (OSHA, respirable fraction) TWA=10 STEL=15 TWA=0.5 R95 P95 (F)OV (F)SA TWA=1 SA STEL=5 (OSHA) 3M 3510 Monitor Short OV service life OSHA allows OV for very short use periods. See 29 CFR 1910.1017. 3M 3530 Monitor 4-Vinylcyclohexene 100-40-3 Vinyl cyclohexene dioxide 106-87-6 1-Vinylcyclohexene-3, 4-Ethenyl-1-1-cyclohexene, 4-Vinyl-1-cyclohexene, 4-Vinylcyclohex-1-ene, 4-Vinylcyclohexene, 4-Vinylcyclohexene-1butadiene dimer, VCH Vinylcyclohexane dioxide TWA=0.1 OV TWA=0.1 -skin- (F)OV Vinyl fluoride Fluoroethene, Fluoroethylene, 26000 TWA=1 SA 75-02-5 Monofluoroethylene Short OV service life Vinylidene chloride 1,1-Dichloroethylene, VDC 65000 TWA=5 OV 75-35-4 Short service life Vinylidene fluoride 1,1-Difluoroethene; 55000 TWA=500 SA 75-38-7 1,1-Difluoroethylene; Ethene, 1,1-difluoro; Ethylene,1,1-difluoro; Halocarbon 1132A; VDF; Vinylidene difluoride Ineffective sorbents N-Vinyl-2-pyrrolidone 88-12-0 1-Ethenyl-2-pyrrolidinone, 1-Vinylpyrrolidinone, N-Vinylpyrrolidinone, Vinylbutyrlactam, Vinylpyrrolidinone, Vinylpyrrolidone TWA=0.05 OV Vinyl toluene 25013-15-4 Vinyltrichlorosilane 75-94-5 Methyl styrene, Tolyethylene 5000 Silane trichloroethenyl, Silane trichlorovinyl, Trichlorovinyl silicane, Trichlorovinylsilane, Trichlorovinylsilicon, Vinylsilicon trichloride TWA=50 STEL=100 C=1 (AIHA) (F)OV OV/AG See comment E on page 8. 3M 3510 Monitor. Wood dust (All varieties except western red cedar) TWA=1 mg/m3 N95 (inhalable fraction) 120 NOTE: See important warnings, definitions, and explanation of column headings and abbreviations starting on page 1. 121 Respirator Chemical Name IDLH OEL (Exposures < both CAS # Synonym (ppm) (ppm) APF x OEL and IDLH) Comments Wood dust (Western red cedar) Xylene (o-, m-, p- isomers) 1330-20-7 95-47-6 108-38-3 106-42-3 m-Xylene a,a'-diamine 1477-55-0 Xylidine 1300-73-8 Yttrium, metal and compounds (as Y) 7440-65-5 Zinc chloride fume 7646-85-7 Dimethylbenzene (o-, m-, p-isomers), 1,2-Dimethylbenzene, 1,3-Dimethylbenzene, 1,4-Dimethylbenzene MXDA 1000 Aminodimethyl benzene, 150 Aminoxylene dimethyl aniline, Dimethylaminobenzene TWA=0.5 mg/m3 N95 (inhalable fraction) TWA=100 OV STEL=150 C=0.1 mg/m3 -skin- OV/N95 TWA=0.5 (inhalable OV/N95 fraction and vapor) -skin- TWA=1 mg/m3 N95 4800 mg/m3 TWA=1 mg/m3 N95 STEL=2 mg/m3 3M 3510 Monitor See comment D on page 8 See comment E on page 8 Zinc chromate (as Cr) 13530-65-9 11103-86-9 37300-23-5 Zinc oxide 1314-13-2 Zirconium and compounds (as Zr) 7440-67-7 Basic zinc chromate, Chromates of zinc, Zinc potassium chromate, Zinc yellow Zinc white, Zincite 30 mg/m3 TWA=0.0002 mg/m3 N95 (as Cr(VI), inhalable fraction) STEL=0.0005 mg/m3 (as Cr(VI), inhalable fraction) 2500 mg/m3 TWA=15 mg/m3 N95 (OSHA) TWA=2 mg/m3 (respirable fraction) STEL=10 mg/m3 (respirable fraction) 500 mg/m3 TWA=5 mg/m3 N95 STEL=10 mg/m3 122 Respirator Codes and Descriptions (F) Full facepiece, helmet, hood, loose fitting facepiece, or half facepiece with appropriate eye protection (with appropriate cartridges and filters) AG Acid Gas Respirator AM Ammonia/Methylamine Respirator FORM Formaldehyde Respirator HF Hydrogen Fluoride Respirator Hg Mercury Vapor Respirator MG Multi-gas/Vapor Respirator N100 N100 Particulate Respirator N95 N95 Particulate Respirator OV Organic Vapor Respirator OZ Ozone Respirator P100 P100 Particulate Respirator P95 P95 Particulate Respirator R95 R95 Particulate Respirator SA Supplied Air Respirator SA(F) Supplied air respirator with full facepiece, helmet, hood, or loose fitting facepiece; or supplied air with half half facepiece with appropriate eye protection Note: Respirator abbreviations may be combined. For example, (F)OV/AG/P95 is a full facepiece respirator with an organic vapor/acid gas cartridge and a P95 particulate filter. HEPA filters are used for PAPRs instead of N, R, P type particle filters. 3MTM Select and Service Life Software helps you select an appropriate type of respirator or estimate service life of 3M gas/vapor cartridges. Both programs are easy to use, accurate and give printable reports. 3M.com/sls Data for this guide compiled August, 2019. Always refer to latest TLV Guide and OSHA standards for possible changes and rulings. TLVs from ACGIH®, 2019 TLVs® and BEIs® Book. Copyright 2019. Reprinted with permission. 3M is a trademark of 3M Company, used under license in Canada. Celogen is a registered trademark of U.S. Rubber Company. Dalapon and Triclene are trademarks of Diamond Shamrock. Dowtherm is a trademark and Carbitol is a registered trademark of Dow Chemical. Cellosolve, Dymel and Freon are registered trademarks of E. I. du Pont de Nemours and Company. E-Mycin is a trademark of Upjohn Pharmaceuticals. Genetron is a trademark of Honeywell International Inc. Halon is a trademark of Allied Chemical. Halowax is a trademark of Bakelite Corp./Union Carbide. 3M PSD products are for occupational use only. 3 Personal Safety Division 3M Center Building 235-2W-70 St. Paul, MN 55144-1000 For more information: In U.S. Technical Assistance 1-800-243-4630 Customer Care Center 1-800-328-1667 3M.com/PPESafety In Canada Technical Assistance Customer Care 3M.ca/PPESafety 1-800-267-4414 1-800-364-3577 3M and all other trademarks used herein are trademarks of 3M Company, used under license in Canada. Please recycle. Printed in U.S.A. © 3M 2019 All rights reserved. 70-0715-7412-6