Orolia PLB-3-GPS Fastfind User Manual 32223 fstfnd manual 120x120
Orolia Ltd Fastfind 32223 fstfnd manual 120x120
Orolia >
User manual
![](/img.php?id=1072590&img=bg1.png)
USER
MANUAL
FAST FIND MODELS
200 & 210
GET FOUND WITH FAST FIND
32223 fstfnd manual 120x120 28/1/09 12:09 Page 2
![](/img.php?id=1072590&img=bg2.png)
Your PLBs unique
identification information
Stick copy
Programming label here
CAUTION: Avoid using chemical solvents
to clean the PLB as some solvents can
damage the case material.
CAUTION: Radio licensing, the PLB is a
radio transmitter. Some administrations may
require that the user holds a valid radio
license to cover its ownership and use.
CAUTION: The PLB will not float;
fit a lanyard restraint when near water to
avoid loss.
RADIO FREQUENCY EXPOSURE WARNING
WARNING: The PLB emits low levels of
radio frequency radiation; avoid handling the
antenna once activated.
REGISTRATION
WARNING: The PLB must be promptly
registered with the appropriate National
Authority. Failure to register the PLB could
delay a Search and Rescue (SAR) response
and may be unlawful.
SAFETY NOTICES
WARNING: A Personal Locator Beacon
(PLB) is an emergency radio beacon;
Use only in situations of grave and imminent
danger to life.
CAUTION: False alerts endanger lives
and cause expensive disruption to Search
and Rescue services, deliberate misuse of the
PLB could result in penalty and fine.
CAUTION: Spring action antenna
deployment; tilt the PLB away from your face
when deploying the antenna.
CAUTION: Do not dismantle the PLB,
contains no user-serviceable parts.
CAUTION: Contains lithium batteries. Do
not incinerate, puncture, deform, short-circuit
or recharge.
CAUTION: Dispose of a used PLB in
accordance with local waste disposal
regulations. Refer to End of Life Statement.
32223 fstfnd manual 120x120 28/1/09 12:09 Page 3
![](/img.php?id=1072590&img=bg3.png)
3
GET FOUND WITH FAST FIND
INTRODUCTION
Congratulations on purchasing the
Fast
Find Personal Location Beacon
(PLB). When carrying a
Fast
Find you enjoy the reassurance of a last resort
safeguard against any life threatening incidents that may occur anywhere in
the world. If you find yourself in a remote area without any other form of
emergency communication, on land or at sea, your
Fast
Find can call for help.
Fast
Find will transmit a unique emergency identifier to the Cospas Sarsat satellite
system which can determine your location anywhere on the earth’s surface. In most
cases the emergency alert is received within 5 minutes of activation but depending
on satellite coverage at the time this can sometimes extend to 45 minutes.
When the emergency alert message is received at a Rescue Co-ordination Centre
(RCC) it is cross referenced using the unique identifier (often called Hex ID) against
your registration details. Detail of the alert is forwarded to the appropriate local
Search And Rescue (SAR) teams. Keeping your registration details up to date is
critical to ensuring a quick SAR response.
Fast
Find has a secondary ‘homing’ transmitter which allows SAR teams to direction
find or ‘home’ on it once they arrive on scene.
Fast
Find has a storage life of 5 years and
once activated will continue to transmit emergency alerts for a minimum of 24 hours.
For further information visit Cospas Sarsat on line at www.cospas-sarsat.org and
www.mcmurdo.co.uk. The ‘frequently asked questions’ section is a good place to start.
32223 fstfnd manual 120x120 28/1/09 12:09 Page 4
![](/img.php?id=1072590&img=bg4.png)
GPS VERSION
Fast
Find 210 has a built-in Global Positioning
System (GPS) receiver to potentially reduce
the time for SAR teams to arrive on scene. If
the sky view is obscured by tree canopy or a
steep-sided canyon, the GPS may take longer,
or possibly fail to obtain a position fix. In this
case the distress alert may be transmitted
without GPS location information.
RADIO LICENSE
U.S. users are not required to hold a radio
license for a PLB. Other national
administrations may require the PLB user to
be licensed, for further advice check with
your dealer or contact your national
communications licensing authority.
USER REGISTRATION
The PLB’s unique identifier must be registered
with the national authority indicated in the
white area on the rear of the PLB. Complete
the user registration form and return it to the
address indicated on the form. Some national
authorities allow online registration, a good
starting place is the online emergency
beacon registration database called IBRD at
www.406registration.com. IBRD will not
accept all registrations and where appropriate
you will be re-directed to your national
authority. Some countries (including USA and
UK) will send the registered user a DECAL
label which you are obliged to fit to the rear
of the PLB as ‘proof of registration’.
Battery
expiry date
Country name
& Hex ID
Fit “proof-of-registration”
DECAL label here
32223 fstfnd manual 120x120 28/1/09 12:09 Page 5
![](/img.php?id=1072590&img=bg5.png)
OVERVIEW
Red pull handle
Pull to expose antenna
Only pull in an emergency
Pulling breaks the plastic anti-tamper seal that can
not be reset by the user.
White indicator Light
Flashes every 3 seconds once PLB is active, Long flash
every 50 seconds means satellite transmission OK
For PLB 210 only
Flashes twice a second when GPS is searching
3 rapid flashes means GPS location sent
Antenna
Unwraps and stands vertical once cover is off
GPS antenna zone
(PLB 210 only)
Do not obstruct
Needs a clear view of the sky for best operation
ON button
Press once to activate PLB.
When the PLB is on, push the ON button again to
make the indicator light flash an SOS signal pattern.
TEST / OFF button
Push and hold to start the self test feature, a flash of
white light indicates that the self test is successful.
Once PLB is active
Hold TEST to turn PLB off
Eyelet for lanyard
5
GET FOUND WITH FAST FIND
32223 fstfnd manual 120x120 28/1/09 12:09 Page 6
![](/img.php?id=1072590&img=bg6.png)
ACTIVATING THE FASTFIND PLB
Only ever activate in situations of grave or imminent danger.
2) Hold the end of the antenna.
Unwrap the antenna until
it stands vertical
CAUTION
Spring action antenna deployment; tilt the
PLB away from your face before deploying
the antenna.
3) Press the ON button
Transmission of the first emergency alert message
takes place 50 seconds after initial activation,
in the event of an accidental or false activation
this delay allows time for the user to turn off the
Fast
Find before the first alert is transmitted.
1) Flip up the red pull handle,
Pull the antenna cover off
IMPORTANT
The antenna cover is an anti-tamper seal,
once broken it can not be refitted.
32223 fstfnd manual 120x120 28/1/09 12:09 Page 7
![](/img.php?id=1072590&img=bg7.png)
DEPLOYING THE PLB
• Always position the PLB so that the antenna stands vertical
• If it’s windy, rotate the PLB so that the white indicator light faces into the wind
Use around water
The
Fast
Find will NOT float but is waterproof to 10 meters submersion for
short periods. To avoid loss if dropped into water fit a retaining lanyard
through the eye hole in the base of the PLB and fasten it securely to your
clothing or personal floatation device.
The PLB is not a substitute for an EPIRB that may be required under
maritime regulation.
Note: In some countries the
Fast
Find PLB may be sold with an auxiliary flotation device but is
not designed to float in an upright position or transmit a distress alert when floating in water.
Do NOT hold
the antenna
Do NOT allow
the PLB
to tip over
Do NOT allow
the antenna
to sit in a
puddle of water
Do NOT
cover the GPS
antenna zone
YES
YES
NO
NO
7
GET FOUND WITH FAST FIND
32223 fstfnd manual 120x120 28/1/09 12:09 Page 8
![](/img.php?id=1072590&img=bg8.png)
INDICATOR LIGHT
The indicator light will start flashing
immediately the
Fast
Find is activated
FAST FIND 200 Light indication
FAST FIND 210 WITH GPS Light indication
PLB ACTIVE
1 flash every 3 seconds
SATELLITE TRANSMISSION OK
Large flash once every 50 seconds
GPS SEARCHING
2 flashes every 1 second
SATELLITE TRANSMISSION SENT WITH
GPS LOCATION OK
Sequence repeats every 50 seconds
PLB ACTIVE
1 flash every 3 seconds
FLASH SOS FEATURE
When the PLB is active, pressing the ON
button will cause the indicator light to flash a
Morse code SOS pattern. This can be used to
attract attention after nightfall. The SOS
pattern is repeated four times on each press.
To conserve battery life a maximum of
30 presses are allowed, after which this
feature is disabled.
32223 fstfnd manual 120x120 28/1/09 12:09 Page 9
![](/img.php?id=1072590&img=bg9.png)
DE-ACTIVATION AFTER USE
To turn off the
Fast
Find, press and hold the
TEST button for several seconds until the
indicator light stops flashing.
We recommend the antenna is re-wound
under the plastic peg. If possible, the yellow
antenna cover should
be pushed back in
place and temporarily
taped over, to avoid
accidentally pressing
of the ON button.
Important
As soon as possible the PLB should be
returned to a service agent, who will fit a new
antenna cover and check the battery
condition. If the PLB was active for more than
a few hours we recommend fitting a fresh
battery to ensure the full 24 hour operational
life is still available.
SELF TEST
Self-test verifies operation of the PLB by
checking all key features including the battery
and alert transmitters.
TEST button
Push and hold the
SELF TEST button for
a minimum of 2
seconds, the
indicator light will flash once to indicate the
start of the self test sequence.
After a few seconds, a good self-test will
result in the indicator light flashing a number
of times in quick succession depending on
battery usage;
fresh battery self test pass
minimum usage self test pass
medium usage self test pass
NO FLASH self test fail PLB requires service
The PLB will switch off automatically when
the self-test has completed
Important
Each self-test draws small amounts of energy
from the battery pack. Unnecessary testing of
the PLB will reduce the run time of the PLB in
an emergency. On average, the PLB should
only be self tested 12 times per year, or a total
of 60 times during the 5 year battery lifetime.
9
GET FOUND WITH FAST FIND
32223 fstfnd manual 120x120 28/1/09 12:09 Page 10
![](/img.php?id=1072590&img=bga.png)
GPS POSITION ACQUISITION TEST
When testing the GPS, take the PLB outside
into an open space with a clear view of the
surrounding sky.
Self testing of the in-built GPS is restricted to
a maximum of 10 tests throughout the 5 year
storage life of the battery. Once all the tests
have been used up, attempting further tests
will cause the indicator light to flash 4 times
in quick succession and the PLB to power off.
The GPS self-test feature can only be
accessed after first completing a standard
PLB self-test routine;
Push and hold the TEST button for a minimum
of 2 seconds, the indicator light will flash
once to indicate the start of the self test
sequence. Release the TEST button.
After a few seconds the standard self-test
routine will complete and should result in the
indicator light flashing a number of times in
quick succession depending on the past
battery usage.
Immediately after the indicator light stops
flashing, hold down the TEST button for
around 30 seconds. The GPS test routine
starts when the indicator light begins to
flash, now release the TEST button. The light
will continue to flash slowly for up to 5
minutes; you should continue to watch the
PLB throughout this period.
A successful GPS test is signalled by the
indicator light flashing a number of longer
flashes in quick succession.
Important
To preserve battery life, GPS testing is
restricted to a maximum of 10 tests
throughout the 5 year battery life. Once used
up, further GPS tests are prohibited.
CHOOSING THE BEST LOCATION
The
Fast
Find works best under an
unobstructed view of the sky. This ensures
the emergency alert message reaches the
satellite system and gives the GPS receiver
(
Fast
Find 210) the best signals to work with.
If it’s not possible to pick a location with an
unobstructed view of the sky, then try to
maximize the amount of sky available.
Tree canopy degrades performance. Find a
clearing with as much sky view as possible.
Ravines, canyons, caves and overhangs
should be avoided if at all possible.
GPS self test pass
10 – 4 GPS tests remaining
GPS self test pass
3 – 1 GPS tests remaining
GPS self test pass
No GPS tests remaining
32223 fstfnd manual 120x120 28/1/09 12:09 Page 11
![](/img.php?id=1072590&img=bgb.png)
Stay put - Rescue teams expect you to remain
stationary. Trying to walk for help is generally
not advised and will probably slow down the
rescue effort.
On foot
If you must walk for help, ensure the
Fast
Find
antenna remains vertical.
Aircraft
A PLB is often used as an additional carry-off
safety device. The PLB should NOT be
activated aboard an aircraft. The signal will
be blocked by metalwork and the PLB may be
damaged by any impact. Activate the PLB
after landing, away from the aircraft, as it may
cause shadowing.
Vehicles
The PLB will not work well inside a vehicle
due to metalwork shadowing. Exit the
vehicle, activate the PLB, and place it on the
roof, the hood, or just on the ground away
from the vehicle.
Land
Find the best sky view, then place the PLB
on flat ground. Keep the antenna pointing
towards the sky and ensure wind doesn’t
knock the PLB over. Do NOT allow the
antenna to sit in a puddle of water.
Aboard ship
Place the PLB flat on the deck, choosing a
position with the best sky view.
Liferaft
Try to keep the PLB flat and try to elevate the
PLB to avoid bodies blocking the signal.
Consider holding the PLB outside the canopy.
But first attach a lanyard between the PLB
and your clothing to avoid loss of the PLB.
Lifejacket
Attach a lanyard cord between the PLB and
clothing to avoid loss of the PLB. Hold the PLB
flat on top of the life vest and try to keep it
above any wave wash. Keep the antenna
vertical. Avoid holding the antenna, or
blocking the GPS zone with your hand.
False alerts
If the PLB has been accidentally activated, or
if rescue has been effected before arrival of
the rescue services:
• Switch off the PLB and notify the
appropriate rescue services or authorities
at the earliest possible time.
• Contact the rescue services, coastguard, or
police by radio or telephone to advise them
of the false alert.
In the U.S. call 1-800-851-3051
In the UK call MRCC Falmouth
+44 1326 317575
11
GET FOUND WITH FAST FIND
32223 fstfnd manual 120x120 28/1/09 12:09 Page 12
![](/img.php?id=1072590&img=bgc.png)
TRANSPORTATION
Passenger Aircraft;
These products contain small lithium metal
batteries. They can normally be carried on
board passenger aircraft as a personal item in
carry-on baggage. McMurdo always
recommends declaring the PLB to airline staff
at check in, in the same way you would for a
laptop PC or video camera.
As air cargo;
These products contain small lithium metal
batteries. Due to the overall low level of
lithium content they are not restricted as air
cargo under IATA SP 188 - PI 970, always
check with the carrier concerned for any
additional restrictions that could apply.
END OF LIFE STATEMENT
At the end of the products useful life, it is vital
that the battery is removed from the main
body of the PLB to prevent false alerts. False
alerts cause expensive disruption to Search
and Rescue services and may endanger lives
as a consequence.
Safe disposal
Contains traces of lithium, may contain lead
and brominated flame retardants (BFRs), both
in the housing material and circuit boards.
DO NOT INCINERATE
McMurdo strongly recommends that this PLB
product is disposed of in a sensible and
considerate manner. For example, do not
simply discard the product in the domestic
waste. Instead take it to
a civil recycling facility,
or contact McMurdo
for advice.
32223 fstfnd manual 120x120 28/1/09 12:09 Page 13
![](/img.php?id=1072590&img=bgd.png)
FAST FIND 200, 210
13
GET FOUND WITH FAST FIND
STANDARDS COSPAS-SARSAT
APPLIED T.001/T.007 class2
RTCM SC110 STD 11010.2
ETSI EN 302-152-1
AS/NZS 4280.2
NSS-PLB06
ENVIRONMENTAL
Exterior Finish Highly visible yellow
Sealing Temporary immersion to
10m (30 ft) for 5 mins.
(IP 58, IPX7)
Operating Class 2, -20°C to +55°C
temperature (-4°F to +131°F)
Storage Temperature Class 2, -30°C to +70°C
(-22°F to +158°F)
Altitude MIL-STD-810E
(10,000 feet)
BATTERY
Battery Type 6V Lithium Metal
Battery storage 5 years
Battery By service centre
replacement
Battery use Logged by microcontroller.
OPERATION
Activation Three stage manual activation
Self test Tests transmitters,
battery and light
SOS flash light Morse code SOS pattern
(30 operations allowed)
TRANSPORTATION
Air cargo UN 3091, not restricted,
IATA SP 188 - PI 970
ELECTRICAL
406.037 MHz ± 1KHz, 5W ± 2dB
transmitter
121.5 MHz ± 3KHz, 50mW ± 3dB PERP
transmitter
Homer sweep UP or DOWN
direction
Transmit Antenna Deployable flexible
vertical blade
Programming Optical Infra-red link
interface
PHYSICAL
Fast Find 200, 210 Category 2, will not float
Size (D x W x L) 34 x 47 x 106 mm
(1.34” x 1.85” x 4.17”)
Weight 150g ( 5.3 oz)
GPS (Fast Find 210 only )
50 channel
Receive Antenna Ceramic Patch
GPS Self test Position acquisition test
(10 operations allowed)
PART NUMBER
91-001-200A Fast Find 200 PLB retail pack
91-001-210A Fast Find 210 PLB (with GPS)
retail pack
FAST FIND 200, 210 models do not float and are not
recommended for use on or in water unless provided
with an auxiliary flotation device.
A Fast Find PLB is not an ELT or an EPIRB and does not
meet the regulatory requirements for an ELT or an EPIRB.
32223 fstfnd manual 120x120 28/1/09 12:09 Page 14
![](/img.php?id=1072590&img=bge.png)
DISCLAIMER
McMurdo is a brand name operated by Signature Industries Limited.
The information and illustrations contained in this publication are to the best of our knowledge correct at the
time of going to print. We reserve the right to change specifications, equipment, installation and
maintenance instructions without notice as part of our policy of continuous product development and
improvement. No part of this publication may be reproduced, stored in a retrieval system or transmitted in
any form, electronic or otherwise without permission in writing from McMurdo, Signature Industries Limited.
No liability can be accepted for any inaccuracies or omissions in the publication, although every care has
been taken to make it as complete and accurate as possible.
DISCLAIMER
McMurdo is a brand name operated by Signature Industries Limited.
The information and illustrations contained in this publication are to the best of our knowledge correct at the
time of going to print. We reserve the right to change specifications, equipment, installation and
maintenance instructions without notice as part of our policy of continuous product development and
improvement. No part of this publication may be reproduced, stored in a retrieval system or transmitted in
any form, electronic or otherwise without permission in writing from McMurdo, Signature Industries Limited.
No liability can be accepted for any inaccuracies or omissions in the publication, although every care has
been taken to make it as complete and accurate as possible.
DISCLAIMER
McMurdo is a brand name operated by Signature Industries Limited.
The information and illustrations contained in this publication are to the best of our knowledge correct at the
time of going to print. We reserve the right to change specifications, equipment, installation and
maintenance instructions without notice as part of our policy of continuous product development and
improvement. No part of this publication may be reproduced, stored in a retrieval system or transmitted in
any form, electronic or otherwise without permission in writing from McMurdo, Signature Industries Limited.
No liability can be accepted for any inaccuracies or omissions in the publication, although every care has
been taken to make it as complete and accurate as possible.
91-210 Iss 1
32223 fstfnd manual 120x120 28/1/09 12:09 Page 1