E F Johnson 2424310 Non-Broadcast Transceiver User Manual 4300ServMan VHF
E. F. Johnson Company Non-Broadcast Transceiver 4300ServMan VHF
Contents
- 1. manual part 1
- 2. manual part 2
- 3. manual part 3
- 4. manual part 4
manual part 2
As forward biasing current increases, the impedance decreases to a low level. Therefore, the RF level of the signal applied to Q6 increases as the bias current from the power control circuit increases. 5.2.2.2 PA RF DEVICE (Q6) Impedance matching for Q6 is provided by several capacitors, inductors, and sections of microstrip. Q6 is an N-channel enhancement mode lateral MOSFET. The bias voltage (which is required for the device to turn on) is controlled by the transmit signal. It is applied to the gate and controlled by the logic through shift register U1. Therefore, this device is turned off in the receive mode which improves isolation. Several capacitors, inductors, and resistors isolate this supply from RF. Likewise, the 13-volt RAW BAT supply applied to the drain is isolated by similar components. From the output of the variable attenuator, the signal is fed to Q6. Q6 operates as a single-ended device. It produces an output power of up to 35 watts. 5.2.2.3 FORWARD POWER DETECTOR, ANTENNA SWITCH, LOW-PASS FILTER The power control circuit senses Q6 output power to control the power output. A directional coupler senses the forward power signal. This signal is then rectified by CR8 and applied to the power control circuit. This signal is a DC voltage that increases in proportion to the level of forward power. Refer to Section 5.2.2.4 for more information on power control. PIN diodes CR9, CR11, CR12, and CR15 form an antenna switch that switches the antenna to the transmitter in the transmit mode and the receiver in the receive mode. As stated in Section 5.2.2.1, PIN diodes have very high impedance when in the off mode and very low impedance when forward biased. Transistors Q7 and Q9 are on in the transmit mode and off in the receive mode. In the transmit mode all four diodes are forward biased. The transmit signal then has a low impedance path through CR9 to the low-pass filter and is blocked from the receiver by a grounded quarter-wave line formed by C64, L15, and C66. A grounded quarter-wave lines presents very high impedance at the non-grounded end. PIN diodes CR11 and CR15 and a second quarter-wave line formed by C76, C77, and L17 provide additional isolation. In the receive mode, all four diodes are in the off mode. Therefore, the receive signal from the antenna is blocked from the power amplifier by CR9 and has a low impedance path through L15, C74, L17, and C67 to the receiver in the RF module. From the antenna switch the RF signal is applied to a low-pass filter formed by L11-L13 and several capacitors and sections of microstrip. This filter attenuates harmonic frequencies above the transmit band that could cause adjacent channel interference. R53 dissipates static buildup in the antenna. 5.2.2.4 POWER CONTROL Introduction 51 The power control circuit maintains a constant power output as changes occur in power amplifier temperature and voltage. It does this by sensing forward power and then varying the drive to Q6 to maintain a constant output power. The drive to Q6 is controlled by varying the voltage applied to the variable attenuator circuit described in Section 5.2.2.1. In addition, the current applied to final amplifier Q6 is sensed, and if it becomes excessive, power is cut back to a low level. The power output level is set in 127 steps by a Digital-to-Analog (D/A) converter formed by shift register U1 and several resistors. This converter is controlled by the microcontroller to provide the following functions: • It allows the RF power output level to be adjusted using the PCTune™ software. • It allows the microcontroller to cut back power if the power amplifier temperature sensed by thermistor TR1 becomes excessive. • It allows high and low power levels to be selected by the user or to be fixed by programming using the PCConfigure™ software. Forward Power Sense The forward power signal from the directional coupler is applied to pin 2 of amplifier U2-A. This is a DC signal that increases proportionally to forward power. The other input to U2-A on pin 3 is a DC reference voltage from the D/A converter. This signal sets the power output of the transmitter. U2-A is a difference amplifier which amplifies the difference between the reference voltage on pin 3 and the forward power signal on pin 2. The turn-on time of U2-A is controlled by the time constant of C17 and R28, and negative AC feedback to prevent oscillation is also provided by C17. This circuit operates as follows: Assume the output power attempts to increase. The DC voltage applied to U2-A, pin 2 then increases which causes the output voltage on pin 1 to decrease. Transistors Q1 and Q2 then turn off slightly which decreases the supply voltage to the variable attenuator circuit. The input power to Q6 then decreases. The Q10 output power then decreases to maintain a constant power output. R26 and R24 limit the voltage gain of Q2 and Q1 to approximately two volts. Delayed PTT Transistor Q3 is used to delay power output for a short time after the transmitter is keyed. This allows the synthesizer and exciter to stabilize so that the transmitter does not transmit off frequency. The signal which controls Q3 is from microcontroller on the logic board. In the receive mode this output is low, so Q3 is off. Pin 2 of U2-A is then pulled high by the 8-volt supply applied through R29 and CR1. This causes the output on pin 1 of U2-A to go low which shuts off Q2 and Q1. Then when the transmitter is keyed, after a short delay Q3 then turns on and diode CR1 is reverse-biased. Only the forward power signal is then applied to pin 2 of U2-A. Over-Current Shutdown Current to Q6 is monitored by sensing the voltage drop across R33. Pins 3 and 6 of U3 are connected across this resistor. As current increases, the output voltage on U3 pin 8 increases. This voltage is applied to Schmitt trigger U2-B. When the voltage on pin 6 rises above the reference on pin 5, the output on pin 7 goes low. This lowers the voltage applied to U2-A, pin 3 which 52 lowers the power control voltage to the variable attenuator. This results in lowering the power output to approximately 25% of full power. 53 SECTION 6 ALIGNMENT PROCEDURE 6.1 GENERAL 6.1.1 INTRODUCTION The following alignment procedure should be performed if repairs are made that could affect the factory alignment or if adjustments may have changed for some other reason. To verify radio operation, the performance tests in Sections 6.5 and 6.6 can be run. To perform transceiver alignment, the following are required: • PC-compatible computer • Remote Programming Interface (RPI), Part No. 023-5300-000. • PCTune software, Part No. 023-9998-499. All adjustments are set digitally using the computer. Therefore, there is no need to disassemble the transceiver to access adjustment points. In addition, audio test signals are generated internally, so an audio generator is not required. The required test equipment is shown in Figure 6-1. 6.1.2 TUNE SOFTWARE General The PCTune software is a Windows® program. Minimum software and hardware requirements are as follows: 54 • Windows® 95/98/NT/2000 (3.1 cannot be used) • Pentium® processor or equivalent • 16 MB of RAM • A hard disk drive with at least 3 MB of free space • A CD-ROM drive • An available serial port Software Installation Proceed as follows to install this software: 1. Close all applications that are currently running (other than Windows). 2. Insert the CD-ROM containing the PCTune software into the drive. 3. From the Windows taskbar, choose RUN and open SETUP.EXE on the drive being used. Alternatively, use File Explorer and double click SETUP.EXE. 4. Follow the instructions on the screen. The program is automatically loaded on the hard drive and startup shortcuts or groups are created. Starting PCTune Select Start in the taskbar, then Programs > PCTune > PCTune. Exiting PCTune Select File > Exit or click the button. Online Help Online help is not available. 6.1.3 PCTUNE VERSION REQUIRED PCTune, Version 2.0.0 or later is required to tune the RF board. The version number can be displayed by selecting the Help > About menu. 6.2 MAIN SCREEN The main PCTune screen is shown in Figure 6-2. Information on the various parts of this screen follows: 55 Menu Bar - Used to select the menus described in Sections 6.3.1-6.3.5. Tool Bar - These buttons are used to quickly select functions as follows: - Displays the screen used to set serial port parameters (see Section 6.3.3). - Selects the Partial Tune mode the same as the Transfer > Tune Partial menu (see Section 6.3.3) This mode allows manual selection of the desired Tune Category and then automatically steps through the various settings for that adjustment. - Selects the Edit Mode which allows parameters in the selected screen to be changed without stepping through each adjustment. - Reads and displays the current parameters programmed in the radio the same as the Radio > Read Tune Parameters menu (see Section 6.3.3). - Writes the current tune parameters to the radio the same as the Transfer > Write Tune Parameters menu (see Section 6.3.3). This occurs automatically when a Partial Tune adjustment is completed. - Exits the current Tune Category without writing parameters to the radio. Radio Information When tuning parameters are read from a radio by clicking the button or selecting the Transfer > Read Parameters menu, the following information is displayed in the top part of the screen: Type - The Radio Series selected by the Radio menu (see Section 6.3.2). The correct series must 56 be selected for communication with the radio to occur. Band - The radio frequency band of the radio displayed after information is read from radio. Do not select the band using Tools > Set Band (Section 6.3.4) because this may make the radio nonfunctional. Software DSP - The first number is the version number of the radio firmware (Flash/operating code), and the second number is the version number of the DSP software. ESN - The Electronic Serial Number electronically stored in the radio. Tuning Categories These buttons select the tuning adjustment to be performed. Different functions are displayed for the 51xx and 53xx. If the Partial tune mode is selected, these buttons select the particular adjustment that is performed. Mode/Tool Tip Information on the bottom line of the screen indicates the current tune mode and information on the selected button on other information. 6.3 MENU BAR DESCRIPTION 6.3.1 FILE MENU Selecting File > Exit closes the PCTune program. 6.3.2 RADIO MENU [Insert 4300 radio menu] The Radio menu shown above selects the radio type. [Insert correct selections for 4300] The correct radio type must be selected for communication with the radio to occur. 6.3.3 TRANSFER MENU COM Ports - Displays the following screen which selects the serial port (1-12) and baud rate 57 (9600/ 19200) used for communication with the radio. Select the computer port to which the test cable is connected (see Section 6.4.1), and 19200 baud is normally selected. These parameters default to the last selected condition the next time the program is started. Read Tune Parameters - Selecting this function or clicking the button reads the tune parameters currently programmed in the transceiver and displays them in the various screens. NOTE: Values in the various screens are for reference only and adjustments should be done only by using the Partial Tune function. Write Tune Parameters - Selecting this function or clicking the button writes the current tune parameters to the radio. This occurs automatically when a Partial Tune adjustment is completed. Tune Complete – Not available. This function automatically steps through all the tests required to tune the radio. Tune Partial - Selecting this function or clicking the button selects the Partial Tune mode. This mode automatically steps through all the adjustments of the currently selected Tune Category. 6.3.4 TOOLS MENU Reset Radio - Resets the radio control logic similar to cycling power. This can be used, for example, to change the radio series or band or exit an adjustment before it is complete. Set Band - Selects the operating band of the radio. All tuning values are reset to the factory defaults. 58 CAUTION: Do not select this function because it can make the radio non-functional. Reset Passwords - Erases all password information contained in the radio. This function can be used, for example, to allow reprogramming of passwords if they are lost. NOTE: Radio personality information is not erased by this function. Erase EEPROM CAUTION: This function erases important radio programming information as described below. Complete -Erases all EEPROM information, including factory programmed parameters. CAUTION: Do not select this function because the radio must be returned to the factory to make it operational again. Parms Only - Erases all personality information. NOTE: The radio must be reprogrammed after this function is selected. Tx/Rx Tests - Selects a screen which is used to check digital (Project 25) receive and transmit performance. Refer to Section 6.5 for more information. Restore Rx Front End Parameters - Programs the radio with default receive front end tune parameters. Other parameters remain unchanged. 6.3.5 HELP MENU Displays the version number of the PCTune software and other information. 6.4 TUNING PROCEDURE 6.4.1 CONNECTING TEST SETUP 1. With transceiver power turned off, connect the RPI to an unused serial port of the computer using a suitable cable (see Section 4.1.3). 2. Connect the RPI to the microphone jack of the transceiver using programming cable, Part No. 023-5300-005 (see Figure 6-1). 3. If the receiver squelch adjustment will be made, connect a SINAD meter to the Speaker Audio Out jack on the RPI (see Figure 6-3). This is a low level fixed audio output, and a 2.6 mm (3/32”) phone jack is used. 59 Figure 6-3 RPI Front Panel 4. Connect a wattmeter and a suitable load to the antenna jack of the transceiver for the transmitter tests. For the receiver tests, connect the signal generator to the antenna jack through a 6 dB or greater isolation pad. 6.4.2 STARTING AND CONFIGURING PCTUNE 1. Start the program as described in Section 6.1.2 and turn transceiver power on. Select Transfer > COM Port and make sure that the correct serial port and the 19200 baud rate are selected (see Section 6.3.3). 2. Select the Radio menu and make sure the correct radio series (43xx) is selected [What is the correct menu selection?] (see Section 6.3.2). 3. Select Transfer > Partial Tune and click the button for the desired Test Category. 4. Follow the instructions displayed on the screen to complete the various adjustments required for a particular setting. Then repeat for other applicable Test Categories. 6.5 DIGITAL PERFORMANCE TESTS 6.5.1 GENERAL This section describes how to check the performance of the radio on digital Project 25 channels. The PCTune software includes a Tools > Tx/Rx Tests menu that displays the screen used for these tests. • To perform these tests, a Digital Communication Analyzer such as Motorola R2670 or IFR 2975 is required. • These tests follow the TIA-102-CAAA-A “Digital C4FM/CQPSK Transceiver Measurement Methods” specification. Refer to that document for more information. • A P25 conventional channel preprogrammed by the PCConfigure software is used for testing. The PCTune software does not select a specific test channel. The test channel must be programmed with the following options: 60 NAC - 293 (hex) TGID (Talk Group ID) -1 Frequency - Any frequency in radio operating band 6.5.2 RECEIVE TEST SETUP 1. Connect the test setup and start and configure the PCTune software as described in Section 6.4. Select the Tools > Tx/Rx Tests menu to display the Tx/Rx Tests screen. Then in the Test Type drop-down list select Receive to display the following screen. 2. Connect the Digital Communication Monitor to the antenna jack using a 6 dB or greater isolation pad. Set the Monitor output for the “1011” test pattern. 6.5.3 RECEIVE SENSITIVITY TEST 1. A tone should be heard from the radio speaker if the analyzer is set properly. Select the “Short” or “Long” test in the Test drop down list and the radio should mute. 2. Set the analyzer output level for 0.35 µV (–116 dBm) at the receiver antenna jack. The Bit Error Rate (BER) should be 5% or less. (This is a ratio of the receive bit errors to the total number of bits transmitted.) 3. Increase the analyzer output level to 1000 µV (–47 dBm). The BER rate should be less than 0.01%. This is the BER Rate Floor. 6.5.4 TRANSMITTER TESTS 1. If applicable select the Tools > Tx/Rx Tests menu to display the Tx/Rx Tests screen. Then in the Test Type drop-down list select Transmit to display the following screen. Connect a dummy load to the radio antenna jack. Monitor the transmit signal with the Digital Communication Monitor. 61 2. Select the Low Deviation test and set the analyzer as required to measure transmitter deviation. This test generates continuous repetitions of bits 10100000. Deviation should be 8481037 Hz. 3. Click the “PTT” button to transmit the tone. When finished, click that button again to turn the transmitter off. 4. Select the “High Deviation” test which transmits a standard transmitter test pattern. Deviation should be 2544-3111 Hz. 5. The “1011 Hz” test transmits a standard 1011 Hz tone similar to that used for the receiver test. This tone can be used to check the operation of other radios. 6. The “Silence” test transmits a standard silence test pattern which produces no receive audio output by the receiving radio. This tone can also be used to test other radios. 7. Select “Normal” to transmit a standard voice signal by speaking into the radio microphone. 6.6 ANALOG PERFORMANCE TESTS 6.6.1 GENERAL The PCTune software is not used for analog channel performance testing. Simply program the desired channels using the PCConfigure software as described in Section 4. The RPI is still required to monitor the audio output signal from the radio. Depending on the application, 12.5 kHz and 25 kHz test channels may need to be ® programmed. Also, test channels programmed with or without Call Guard (CTCSS/DCS) squelch control may be required. 6.6.2 RECEIVER PERFORMANCE TESTS 1. Connect a signal generator to the antenna jack using a 6 dB or greater pad. Set the output for the channel frequency, modulated with 1 kHz at the following deviation: 12.5 kHz Channels - 1.5 kHz 25 kHz Channels - 3.0 kHz 2. Connect a SINAD meter to the receive audio jack of the RPI (see Figure 6-3) This is a low level fixed audio output. SINAD Sensitivity 62 3. Set the signal generator output level for 1000 µV (–47 dBm) at the antenna jack. 4. Decrease the signal generator output to obtain 12 dB SINAD. The signal generator output should be 0.35 µV (–116 dBm) or less for 25 kHz channels, or 0.50 µV (–113 dBm) or less for 12.5 kHz channels. Audio Power Output and Distortion 5. Connect a distortion meter across the speaker load. Return the generator output to 1000 µV. Distortion should be 3% or less. Squelch Sensitivity 6. Increase the signal generator output from zero and note the SINAD when unsquelching occurs. It should be approximately 8 dB. 6.6.3 TRANSMITTER PERFORMANCE TESTS 1. Connect a wattmeter and dummy load to the antenna jack. Monitor the transmit signal with a communication monitor. Transmit Frequency 2. Monitor the transmit frequency and at room temperature it should ±100 Hz. At other temperatures [–22° to +140° F (–30° to +60° C)], it must be within 2.5 PPM. This also checks the receive frequency. Transmit Power 3. Transmit power should be in the following ranges. High and low levels can be preset anywhere in this range by PCTune. The factory default for high power is the maximum shown below, and low power is half that value. Standard Models -10-50 Watts Transmit Modulation 4. Monitor the transmit modulation with a modulation meter. Speak into the microphone with a normal voice. Modulation should be approximately as follows with no CTCSS/DCS signaling present: 12.5 kHz Channels - 1.4 kHz 25 kHz Channels - 3.4 kHz 63 5. Select a channel programmed with Call Guard (CTCSS/DCS) signaling. Maximum total Call Guard and voice modulation should be approximately as follows: 12.5 kHz Channels - 2.3 kHz 25 kHz Channels - 4.7 kHz 64 SECTION 7 PARTS LIST 65 SECTION 7 PARTS LIST Ref No. Description Part No. encryp mod CHASSIS, HARDWARE, AND MISCELLANEOUS HW 001 Captive screw, cover 537-9007-045 HW 002 Screw, 6-32 x 5/16 Torx 575-0006-010 HW 003 Plug, option (in unused chass 032-0792-075 hole) HW 004 Audio amp U1 clip 023-5567-212 Receiver/exciter assembly (UHF) (see separate listing on page TBD) HW 005 O-ring, 1/8 x 1/4 cover screw 574-2002-001 HW 006 Nylon washer, cover screw A 301 Accessory pigtail cable (internal) 597-2002-230 HW 007 Split rubber grommet 1/8ID 574-0002-015 A 302 Remote/acc pigtail cable (internal) 597-2002-249 HW 009 Flat washer, cover screw 596-9408-009 A 303 Remote pigtail cable (internal 597-2002-251 for second control unit) HW 010 Screw, 4-40 x 5/16 phil pan hd 575-0604-010 A 400 Logic board assembly 023-5500-600 (see separate listing on page TBD) HW 011 Washer, No 4 split lock 596-1304-008 596-1304-008 VHF 50W PA bd assy 50W 023-5315-531 mod. (see separate listing on page 7-Error! Reference source not found.) HW 012 Washer, No. 4 split lock A 500 HW 020 1/4 x 1.20 x 1.90 urethane pad 018-1007-250 HW 150 Screw, 4-40 x 5/16 phil pan hd 575-0604-010 HW 151 Screw, 6-32 x 3/8 phil flat hd 575-8206-012 HW 152 Screw, 8-32 x 3/8 hex socket 575-9076-012 hd HW 202 Screw, 4-40 x 1-1/8 mach pan hd 575-1604-036 A 200 Interface board assembly (see separate listing which follows) 023-5500-200 A 300 Receiver/exciter assembly (VHF) (see separate listing on pageTBD) 023-5517-212 UHF 40W PA bd assembly 023-5365-501 (see separate listing on page 7-Error! Reference source not found.) A 810 Front panel assembly (frt mt) 023-5300-810 (see separate listing on page 7-) 017-9700-001 596-4408-015 CH 101 Chassis, std VHF models 015-0970-001 J 002 RF – PA board connector 515-9006-110 Chassis, std UHF models 015-0970-002 J 200 Connector, 28-pin inline header 515-7181-038 EP 001 No. 6 terminal lug 586-0005-106 EP 002 Ferrite bead, .375 x .375 517-2002-003 EP 003 Ferrite block (for J200) 517-2002-020 MP 002 Cover, top black 015-0970-007 EP 920 Snubber, bot shield for 018-1134-136 MP 003 Cover, bottom black 015-0970-009 66 MP 004 Gasket, blank front panel (remote) 032-0792-068 MP 005 Front panel, blank (remote) 032-0792-005 MP 156 Gasket, top cover 018-1136-136 MP 157 Gasket, bottom cover 018-1136-134 MP 300 Foam tape, dbl side 574-3002-013 MP 505 Grounding clip (rx/ex assy) 017-9700-003 MP 601 Shield, low-pass filter wrap around 017-9700-010 C 029 470 pF ±10% 25V cer smd 510-3681-471 CR 001 10V zener SOT-23 523-2016-100 CR 002 Switching diode SOT-23 523-1504-002 J 201 Connector, 20-pin 515-7111-230 J 202 Connector, 30-pin 515-7106-430 L 001 270 nH smd inductor 542-9017-274 L 002 270 nH smd inductor 542-9017-274 L 003 270 nH smd inductor 542-9017-274 P 100 Header, 2-pin friction lock 515-9031-201 W 103 Cable assy, display - logic bd 023-5300-025 P 101 Header, 3-pin friction lock 515-9031-202 W 110 Interface pigtail, motorcycle F P 102 Header, 3-pin friction lock 515-9031-202 MP 602 Cover, low-pass filter cover 017-9700-011 NP 001 Label, RS 5300 559-5300-100 NP 002 Label, EFJohnson 559-9001-310 597-2002-280 DB25 W 501 Pwr pigtail cable assembly, std PA 597-2002-235 PC 001 PC board, interface revision 035-5500-200 2 W 502 RF pigtail cable assembly, std PA 597-2002-240 Q 001 NPN general purpose 576-0003-658 Q 002 NPN general purpose 576-0003-658 Q 003 NPN general purpose 576-0003-658 Q 004 NPN general purpose 576-0003-658 INTERFACE BOARD Part No. 023-5500-200 C 002 470 µF 25V electrolytic 510-4064-471 C 003 100 µF 25V electrolytic 510-4425-101 R 002 2.2 ohm ±5% 1W smd 569-0175-229 C 004 1.0 µF 10V tantalum smd 510-2624-109 R 003 10k ohm ±5% 1/8W smd 569-0105-103 C 005 .1 µF ±5% X7R 50V cer smd 510-3609-104 R 004 47k ohm ±5% 1/8W smd 569-0105-473 C 006 .1 µF ±5% X7R 50V cer smd 510-3609-104 R 005 10k ohm ±5% 1/8W smd 569-0105-103 C 007 .1 µF ±5% X7R 50V cer smd 510-3609-104 R 006 7.5k ohm ±5% 1/8W smd 569-0105-752 C 009 470 pF ±5% NPO cer smd 510-3602-471 R 008 1k ohm ±5% 1/8W smd 569-0115-102 C 010 .1 µF ±10% X7R 50V cer smd 510-3606-104 R 009 1k ohm ±5% 1/8W smd 569-0115-102 C 011 .1 µF ±10% X7R 50V cer smd 510-3606-104 R 010 1k ohm ±5% 1/8W smd 569-0115-102 R 011 39k ohm ±5% 1/8W smd 569-0155-393 C 012 .1 µF ±10% X7R 50V cer smd 510-3606-104 R 012 12k ohm ±5% 1/8W smd 569-0155-123 R 013 10k ohm ±5% 1/8W smd 569-0115-103 C 013 4.7 µF 10V tantalum smd 510-2624-479 R 014 10k ohm ±5% 1/8W smd 569-0115-103 C 014 4.7 µF 10V tantalum smd 510-2624-479 R 015 Zero ohm jumper 569-0115-001 C 015 .01 µF ±5% X7R 50V cer smd 510-3609-103 R 016 10k ohm ±5% 1/8W smd 569-0115-103 C 028 .1 µF ±5% X7R 50V cer smd 510-3609-104 R 017 3k ohm ±5% 1/8W smd 569-0115-302 67 R 018 10k ohm ±5% 1/8W smd 569-0115-103 R 019 Zero ohm jumper 569-0115-001 R 020 10k ohm ±5% 1/8W smd 569-0115-103 R 021 10k ohm ±5% 1/8W smd 569-0115-103 R 022 10k ohm ±5% 1/8W smd 569-0105-103 R 023 12k ohm ±5% 1/8W smd 569-0115-123 R 024 12k ohm ±5% 1/8W smd 569-0155-123 R 025 20k ohm ±5% 1/8W smd 569-0155-203 R 026 13k ohm ±5% 1/8W smd 569-0155-133 R 027 10k ohm ±5% 1/8W smd 569-0115-103 R 028 100k ohm ±5% 1/8W smd 569-0115-104 R 029 100k ohm ±5% 1/8W smd 569-0115-104 R 030 100k ohm ±5% 1/8W smd 569-0115-104 R 031 10k ohm ±5% 1/8W smd 569-0115-103 R 032 10k ohm ±5% 1/8W smd 569-0115-103 R 033 10k ohm ±5% 1/8W smd 569-0115-103 R 034 10k ohm ±5% 1/8W smd 569-0115-103 MP 002 Metal RF board housing 015-0970-014 R 035 10k ohm ±5% 1/8W smd 569-0115-103 MP 003 Cover for housing MP2 015-0970-015 R 036 10k ohm ±5% 1/8W smd 569-0115-103 MP 004 Grounding clip 537-5001-005 R 037 39k ohm ±5% 1/8W smd 569-0155-393 W 001 Coax assy, right angle 597-3008-001 R 038 470 ohm ±5% 1/8W smd 569-0155-471 R 039 10k ohm ±5% 1/8W smd 569-0155-103 R 040 470 ohm ±5% 1/8W smd 569-0155-471 R 041 10k ohm ±5% 1/8W smd 569-0155-103 VHF RECEIVER/EXCITER ASSEMBLY Part No. 023-5517-212 A 001 Interconnect board assembly 023-5500-050 (see separate listing which follows) A 100 RF board assembly, VHF 585-5500-100 HW 001 Screw, 2-56 x 3/16 pan hd 575-1602-006 HW 002 Screw, 4-40 x 1/4 pan hd 575-1604-008 HW 003 Lockwasher, internal 596-2102-006 HW 004 Washer, split lock #4 ZPS 596-1304-008 INTERCONNECT BOARD ASSEMBLY Part No. 023-5500-050 C 001 39 pF ±5% NPO 50V cer smd 510-3674-390 C 002 39 pF ±5% NPO 50V cer smd 510-3674-390 C 005 39 pF ±5% NPO 50V cer smd 510-3674-390 U 001 Audio amp, 22W TDA1519 544-2004-003 U 002 Voltage regulator, adj REG103UA 544-2603-057 U 003 Op amp, dual LM2904 544-2019-004 U 004 Dig potentiometer, 2-ch AD8402 544-0004-213 C 007 39 pF ±5% NPO 50V cer smd 510-3674-390 U 006 Voltage regulator, adj REG103UA 544-2603-057 C 008 39 pF ±5% NPO 50V cer smd 510-3674-390 U 007 Multiplexer, triple 4053 544-1014-053 C 009 510-3674-390 U 008 Voltage regulator, adj REG103UA 544-2603-057 39 pF ±5% NPO 50V cer smd C 011 510-3674-390 CPLD prog logic device XC2C64 544-5001-420 39 pF ±5% NPO 50V cer smd C 012 510-3674-390 Op amp, dual LM2904 544-2019-004 39 pF ±5% NPO 50V cer smd C 014 39 pF ±5% NPO 50V cer 510-3674-390 U 009 U 010 68 smd C 016 39 pF ±5% NPO 50V cer smd 510-3674-390 C 017 .1 µF X7R ±10% 50V cer smd 510-3675-104 C 018 39 pF ±5% NPO 50V cer smd 510-3674-390 C 019 39 pF ±5% NPO 50V cer smd 510-3674-390 C 020 39 pF ±5% NPO 50V cer smd 510-3674-390 C 021 39 pF ±5% NPO 50V cer smd 510-3674-390 C 022 39 pF ±5% NPO 50V cer smd 510-3674-390 C 024 39 pF ±5% NPO 50V cer smd 510-3674-390 C 025 39 pF ±5% NPO 50V cer smd 510-3674-390 C 026 39 pF ±5% NPO 50V cer smd 510-3674-390 C 027 39 pF ±5% NPO 50V cer smd C 028 C 029 VHF 15W PA BOARD ASSEMBLY Part No. nr3-4315-513 C 001 .01 µF X7R ±10% chp 510-3605-103 C 002 .1 µF X7R ±10% chip 510-3606-104 C 003 .018 µF X7R ±10% chp 510-3605-183 C 004 330 pF NPO ±5% chp 510-3601-331 C 005 .01 µF X7R ±10% chp 510-3605-103 C 006 330 pF NPO ±5% chp 510-3601-331 C 007 330 pF NPO ±5% chp 510-3601-331 C 008 330 pF NPO ±5% chp 510-3601-331 C 009 330 pF NPO ±5% chp 510-3601-331 C 010 330 pF NPO ±5% chp 510-3601-331 C 011 330 pF NPO ±5% chp 510-3601-331 C 012 330 pF NPO ±5% chp 510-3601-331 C 013 330 pF NPO ±5% chp 510-3601-331 C 014 330 pF NPO ±5% chp 510-3601-331 510-3674-390 C 015 Capacitor, 10 pF, 1%, high Q, 0805 510-3661-100 39 pF ±5% NPO 50V cer smd 510-3674-390 C 016 .01 µF X7R ±10% chp 510-3605-103 C 017 .01 µF X7R ±10% chp 510-3605-103 39 pF ±5% NPO 50V cer smd 510-3674-390 C 018 330 pF NPO ±5% chp 510-3601-331 C 019 330 pF NPO ±5% chp 510-3601-331 C 020 330 pF NPO ±5% chp 510-3601-331 C 021 330 pF NPO ±5% chp 510-3601-331 C 022 330 pF NPO ±5% chp 510-3601-331 C 023 470 µF 16V LOW ESR 100 510-4056-471 kHZ C 024 330 pF NPO ±5% chp 510-3601-331 C 025 .018 µF X7R ±10% chp 510-3605-183 C 026 .018 µF X7R ±10% chp 510-3605-183 C 027 330 pF NPO ±5% chp 510-3601-331 C 028 330 pF NPO ±5% chp 510-3601-331 C 029 .0047 µF X7R ±10% chip 510-3606-472 C 030 6.8 µF 35V SMD TANT 510-2635-689 C 031 330 pF NPO ±5% chp 510-3601-331 C 032 330 pF NPO ±5% chp 510-3601-331 C 033 .018 µF X7R ±10% chp 510-3605-183 EP 001 Ferrite bead smd 517-2503-002 EP 002 Ferrite bead smd 517-2503-002 J 001 Connector, 26-pin ZIF (revised bd) 515-7111-526 J 002 Connector, 30-pin 515-7111-430 PC 001 PC board, interconnect 035-5500-050 R 005 0 ohm jumper 569-0165-001 R 007 0 ohm jumper 569-0165-001 R 008 0 ohm jumper 569-0165-001 69 C 034 6.8 µF 35V SMD tant 510-2635-689 C 035 .001 µF ±5% chip 510-3602-102 C 067 330 pF NPO ±5% chp 510-3601-331 C 036 330 pF NPO ±5% chp 510-3601-331 C 069 330 pF NPO ±5% chp 510-3601-331 C 037 .018 µF X7R ±10% chp 510-3605-183 C 070 100 pF NPO ±5% chp 510-3601-101 C 038 6.8 µF 35V SMD tant 510-2635-689 C 071 330 pF NPO ±5% chp 510-3601-331 C 039 330 pF NPO ±5% chp 510-3601-331 C 072 .018 µF X7R ±10% chp 510-3605-183 C 040 100 pF NPO ±5% chp 510-3601-101 C 073 330 pF NPO ±5% chp 510-3601-331 C 041 330 pF NPO ±5% chp 510-3601-331 C 074 330 pF NPO ±5% chp 510-3601-331 C 042 330 pF NPO ±5% chp 510-3601-331 C 075 Capacitor, 33 pF, 1%, high Q 510-3661-330 C 044 Capacitor, 6.8 pF, 1%, high 510-3661-689 C 076 Capacitor, 18 pF, 1%, high Q 510-3661-180 C 077 Capacitor, 18 pF, 1%, high Q 510-3661-180 C 045 Capacitor, 150 pF, 1%, high 510-3661-151 C 078 Capacitor, 180 pF, 1%, high 510-3661-181 C 046 Capacitor, 43 pF, 1%, high Q 510-3661-430 C 079 C 048 Capacitor, 10 pF, 1%, high Q 510-3661-100 1500 µF 25V low ESR 100 510-4055-152 kHZ C 049 Capacitor, 39 pF, 1%, high Q, C 082 1 µf 16V chip cap 510-3606-105 C 083 10 µF 25V SMD TANT 510-2627-100 C 050 Capacitor, 240 pF, 1%, high 510-3661-241 C 084 1 µf 16V chip cap 510-3606-105 C 051 Capacitor, 240 pF, 1%, high 510-3661-241 C 085 .1 µF X7R ±10% chip 510-3606-104 C 086 470 µF 16V low ESR 100 kHZ 510-4056-471 C 087 .018 µF X7R ±10% chp 510-3605-183 C 088 330 pF NPO ±5% chp 510-3601-331 C 089 1 µf 16V chip cap 510-3606-105 C 090 470 µF 16V low ESR 100 kHZ 510-4056-471 510-3661-390 C 054 330 pF NPO ±5% chp C 055 Capacitor, 22 pF, 1%, high Q 510-3666-220 SMD Q, 510-3601-331 C 056 Capacitor, 15 pF, 1%, high Q 510-3666-150 SMD C 057 Capacitor, 22 pF, 1%, high Q SMD C 091 1 µf 16V chip cap 510-3606-105 C 058 Capacitor, 240 pF, 1%, high 510-3661-241 C 092 330 pF NPO ±5% chp 510-3601-331 C 059 330 pF NPO ±5% chp 510-3601-331 C 093 330 pF NPO ±5% chp 510-3601-331 C 060 Capacitor, 10 pF, 1%, high Q 510-3666-100 SMD C 095 1 µf 16V chip cap 510-3606-105 C 096 Capacitor, 10 pF, 1%, high Q 510-3666-100 SMD Capacitor, 10 pF, 1%, HIGH 510-3661-100 Q, 0805 C 097 Capacitor, 330 pF, 1%, high 510-3666-331 Q SMD Capacitor, 10 pF, 1%, HIGH 510-3661-100 Q, 0805 C 098 Capacitor, 12 pF, 1%, high Q 510-3666-120 SMD Capacitor, 4.7 pF, 1%, HIGH 510-3661-479 Q, 0805 C 099 Capacitor, 22 pF, 1%, high Q, 510-3661-220 Capacitor, 15 pF, 1%, HIGH 510-3661-150 Q, 0805 C 100 C 065 330 pF NPO ±5% chp 510-3601-331 Capacitor, 13 pF, 1%, HIGH 510-3666-130 Q SURFACE MOUNT C 066 Capacitor, 18 pF, 1%, high 510-3661-180 C 230 .1 µF X7R ±10% chip C 061 C 062 C 063 C 064 510-3666-220 70 510-3606-104 C 560 1 µf 16V chip cap 510-3606-105 L 010 330 nH 0805 SMD 10% inductor 542-9003-338 L 011 2T .230” ID air die SMD inductor 016-0020-082 L 012 2T .230” ID air die SMD inductor 016-0020-082 L 013 2T .230” ID air die SMD inductor 016-0020-082 L 016 9700 DC line filter, fieldinstalled 542-5010-003 L 018 330 nH 0805 SMD 10% inductor 542-9003-338 L 019 220 nH 0805 SMD 10% inductor 542-9003-228 L 020 39 nH 0805 SMD 10% inductor 542-9003-397 L 021 3T .080-in ID air die SMD inductor 18 AWG 542-0020-033 CR 001 Switching diode SOT-23 523-1504-002 CR 002 Switching diode SOT-23 523-1504-002 CR 003 Switching diode SOT-23 523-1504-002 CR 004 Diode, HIPAX PIN 523-1504-036 CR 005 Diode, HIPAX PIN 523-1504-036 CR 006 Diode, HIPAX PIN 523-1504-036 CR 007 Diode, HIPAX PIN 523-1504-036 CR 008 HC diode SOT-23 523-1504-016 CR 009 Diode, HIPAX PIN 523-1504-036 CR 010 Diode, 1 amp SMD fast recovery 523-1600-001 CR 011 Diode, SOT PIN SW 523-1504-001 CR 012 Diode, HIPAX PIN 523-1504-036 CR 014 Zener overvoltage transient suppressor 523-2907-016 L 022 3T .080-in ID air die SMD inductor 18 AWG 542-0020-033 CR 015 Diode, SOT PIN SW 523-1504-001 L 080 330 nH 0805 SMD 10% inductor 542-9003-338 D 001 523-1601-550 Q 001 XSTR, switching PNP 576-0003-612 Q 002 XSTR,3904,SI,NPN SOT23(T&R) 576-0003-658 Q 003 XSTRSI, NPN SOT-23 576-0003-658 J 001 Diode, 5 amp SMD fast recovery Conn 2O POS bot entry SFMT 515-7111-230 J 002 SMT Receptacle MMS 515-7111-470 Q 004 XSTR, switching PNP 576-0003-612 J 003 SMT Receptacle MMS 515-7111-470 Q 005 XSTR, SI, NPN SOT-23 576-0003-658 Q 006 330 nH 0805 SMD 10% inductor 542-9003-338 LDMOS 35-W VHF/UHF 12.5-V FET 576-0006-453 L 001 Q 007 XSTR, SI, NPN SOT-23 576-0003-658 L 002 10 nH 0805 SMD 10% inductor 542-9003-107 Q 008 PNP power Darlington XSTR TO-220 576-0007-013 L 003 330 nH 0805 SMD 10% inductor 542-9003-338 Q 009 XSTR, SI, NPN SOT-23 576-0003-658 L 004 10 nH 0805 SMD 10% inductor 542-9003-107 Q 010 XSTR, switching PNP 576-0003-612 L 005 Ferrite bead SMD 517-2503-010 R 001 20k ohm ±5% chip 569-0105-203 L 006 Ferrite bead SMD 517-2503-010 R 002 20k ohm ±5% chip 569-0105-203 L 007 8T .120-in id air die SMD inductor 542-0020-058 R 003 10k ohm ±5% chip 569-0105-103 R 004 20k ohm ±5% chip 569-0105-203 L 008 33 nH SMD 10% inductor 542-9003-337 R 005 10k ohm ±5% chip 569-0105-103 L 009 330 nH SMD 10% inductor 542-9003-338 R 006 20k ohm ±5% chip 569-0105-203 71 R 007 10k ohm ±5% chip 569-0105-103 R 049 100 ohm ±5% chip 569-0105-101 R 008 4.3k ohm ±5% chip 569-0105-432 R 050 100 ohm ±5% chip 569-0105-101 R 009 20k ohm ±5% chip 569-0105-203 R 051 1.0k ohm ±5% chip 569-0105-102 R 010 10k ohm ±5% chip 569-0105-103 R 052 200 ohm ±5% chip 569-0105-201 R 011 100K ohm 1% SMD resistor 569-0101-501 R 053 220k ohm ±5% chip 569-0105-224 R 012 20k ohm ±5% chip 569-0105-203 R 054 220k ohm ±5% chip 569-0105-224 R 013 10k ohm ±5% chip 569-0105-103 R 055 100k ohm ±5% chip 569-0105-104 R 015 10k ohm ±5% chip 569-0105-103 R 056 100 ohm ±5% chip 569-0105-101 R 016 20k ohm ±5% chip 569-0105-203 R 057 100 ohm ±5% 0.75-W SMD 569-0135-101 R 017 10k ohm ±5% chip 569-0105-103 R 058 220k ohm ±5% chip 569-0105-224 R 018 20k ohm ±5% chip 569-0105-203 R 059 510 ohm ±5% chip 569-0105-511 R 019 Zero ohm ±5% SMD 569-0115-001 R 060 510 ohm ±5% chip 569-0105-511 R 020 100k ohm ±5% chip 569-0105-104 R 061 220k ohm ±5% chip 569-0105-224 R 021 47k ohm ±5% chip 569-0105-473 R 062 51 ohm ±5% 1-W SMD 569-0175-510 R 022 2.2k ohm ±5% chip 569-0105-222 R 063 68k ohm ±5% chip 569-0105-683 R 024 1.8k ohm ±5% chip 569-0105-182 R 064 47k ohm ±5% chip 569-0105-473 R 025 120 ohm ±5% chip 569-0105-121 R 065 47k ohm ±5% chip 569-0105-473 R 026 1.0k ohm ±5% chip 569-0105-102 R 066 100k ohm ±5% chip 569-0105-104 R 027 7.5k ohm ±5% chip 569-0105-752 R 067 560 ohm ±5% chip 569-0105-561 R 028 10k ohm ±5% chip 569-0105-103 R 068 47k ohm ±5% chip 569-0105-473 R 029 10k ohm ±5% chip 569-0105-103 R 069 100 ohm ±5% chip 569-0105-101 R 031 1.8k ohm ±5% chip 569-0105-182 R 070 1.2k ohm ±5% smd 569-0115-122 R 032 51 ohm ±5% SMD 569-0175-510 R 071 1.2k ohm ±5% smd 569-0115-122 R 033 .015 ohm 2W 5% 569-2019-157 R 072 1.2k ohm ±5% smd 569-0115-122 R 034 47k ohm ±5% chip 569-0105-473 R 073 560 ohm ±5% chip 569-0105-561 R 035 510 ohm ±5% chip 569-0105-511 R 074 510 ohm ±5% chip 569-0105-511 R 036 47k ohm ±5% chip 569-0105-473 R 270 220k ohm ±5% chip 569-0105-224 R 037 4.3k ohm ±5% chip 569-0105-432 R 370 5.1k ohm ±5% chip 569-0105-512 R 038 51 ohm ±5% smd 569-0175-510 R 039 620 ohm ±5% chip 569-0105-621 R 040 47k ohm ±5% chip 569-0105-473 R 042 47k ohm ±5% chip R 043 TR 001 Chip therm 10k ohm ±5% 569-3013-007 569-0105-473 U 001 Shift reg. 8-STG SOIC 544-3016-094 220 ohm ±5% chip 569-0105-221 U 002 Dual op amp SO-8 544-2019-004 R 044 1.2k ohm ±5% chip 569-0105-122 U 003 R 045 100 ohm ±5% chip 569-0105-101 AMP, HI-side current sense, 544-2039-002 SO-8 R 046 100 ohm ±5% chip 569-0105-101 U 004 Regulator, adjustable, 5 amp 544-2500-001 R 047 100 ohm ±5% chip 569-0105-101 R 048 100 ohm ±5% chip 569-0105-101 72 LOGIC BOARD ASSEMBLY Part No. 023-5500-600 A 001 C 001 SEM encryption module 023-5000-980 C 184 .01 µF ±10% 10V cer smd 510-3681-103 C 185 .01 µF ±10% 10V cer smd 510-3681-103 C 186 .01 µF ±10% 10V cer smd 510-3681-103 C 190 .01 µF ±10% 10V cer smd 510-3681-103 C 191 .01 µF ±10% 10V cer smd 510-3681-103 C 192 .01 µF ±10% 10V cer smd 510-3681-103 C 196 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 197 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 198 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 199 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 200 .01 µF ±10% X7R 25V cer smd 510-3675-104 C 201 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 202 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 203 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 204 .1 µF ±10% X7R 25V cer smd 510-3675-104 .01 µF ±10% X7R 25V cer smd 510-3675-103 .1 µF ±10% X7R 25V cer smd 510-3675-104 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 052 33pF ±10% 10V cer smd 510-3681-330 C 053 33pF ±10% 10V cer smd 510-3681-330 C 054 33pF ±10% 10V cer smd 510-3681-330 C 055 33pF ±10% 10V cer smd 510-3681-330 C 056 33pF ±10% 10V cer smd 510-3681-330 C 057 33pF ±10% 10V cer smd 510-3681-330 C 058 0.01 µF ±10% 10V cer smd 510-3681-103 C 064 0.1 µF +80-20% Z5U 25V cer smd 510-3680-104 C 065 0.01 ±10% 10V cer smd 510-3681-103 C 066 2.2 µF 16V ceramic smd 510-3925-225 C 069 0.1 µF+80-20% Z5U 25V cer smd 510-3680-104 C 205 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 070 0.01 µF ±10% 10V cer smd 510-3681-103 C 206 510-3675-104 C 071 2.2 µF 16V ceramic smd 510-3925-225 .1 µF ±10% X7R 25V cer smd C 078 2.2 µF 16V ceramic smd 510-3925-225 C 207 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 079 1 µF +80-20% Z5U 25V cer 510-3631-105 smd C 208 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 080 .01 µF ±10% 10V cer smd 510-3681-103 C 209 1.5F electrolytic 510-9510-057 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 081 C 125 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 210 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 126 .01 µF ±10% 10V cer smd 510-3681-103 C 211 510-3675-104 C 127 .01 µF ±10% 10V cer smd 510-3681-103 .1 µF ±10% X7R 25V cer smd C 128 .01 µF ±10% 10V cer smd 510-3681-103 C 212 .01 µF ±10% 10V cer smd 510-3681-103 C 129 .01 µF ±10% 10V cer smd 510-3681-103 C 213 .01 µF ±10% 10V cer smd 510-3681-103 C 130 .01 µF ±10% 10V cer smd 510-3681-103 C 214 .01 µF ±10% 10V cer smd 510-3681-103 C 131 .01 µF ±10% 10V cer smd 510-3681-103 C 215 .01 µF ±10% 10V cer smd 510-3681-103 C 183 .01 µF ±10% 10V cer smd 510-3681-103 C 216 .01 µF ±10% 10V cer smd 510-3681-103 C 013 C 014 73 C 217 .01 µF ±10% 10V cer smd 510-3681-103 C 246 1 µF ±20% Z5U 25V cer smd C 218 .01 µF ±10% 10V cer smd 510-3681-103 C 219 .01 µF ±10% 10V cer smd 510-3681-103 C 220 .01 µF ±10% 10V cer smd 510-3681-103 C 221 .01 µF ±10% 10V cer smd 510-3681-103 C 222 .01 µF ±10% 10V cer smd 510-3681-103 C 223 .01 µF ±10% 10V cer smd 510-3681-103 C 224 .01 µF ±10% 10V cer smd 510-3681-103 C 225 .01 µF ±10% 10V cer smd 510-3681-103 C 226 10 µF 10V cer smd 510-3755-106 C 227 .1 µF ±10% X7R 25V cer smd C 247 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 248 4700 pF 10% X7R 25V cer smd 510-3675-472 C 249 470 pF ±5% NPO 25V cer smd 510-3674-471 C 250 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 251 220 pF ±5% NPO 25V cer smd 510-3674-221 510-3675-104 C 252 220 pF ±5% NPO 25V cer smd 510-3674-221 C 228 3300 pF ±10% 10V cer smd 510-3681-332 C 253 C 229 56 pF ±5% 50V cer smd 510-3684-560 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 230 47 pF ±10% cer smd 510-3681-470 C 254 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 231 1 µF ±20% Z5U 25V cer smd 510-3636-105 C 255 10 µF 10V tantalum smd C 232 1 µF ±20% Z5U 25V cer smd 510-3636-105 C 257 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 233 220 pF ±5% NPO 25V cer smd 510-3674-221 C 258 10 µF 10V tantalum smd C 261 C 234 470 pF ±5% NPO 25V cer smd 510-3674-471 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 262 C 235 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 263 C 236 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 263 C 237 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 264 C 238 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 265 C 239 1 µF ±20% Z5U 25V cer smd 510-3636-105 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd C 266 510-3674-471 C 240 1 µF ±20% Z5U 25V cer smd 510-3636-105 470 pF ±5% NPO 25V cer smd C 267 510-3674-471 C 241 220 pF ±5% NPO 25V cer smd 510-3674-221 470 pF ±5% NPO 25V cer smd C 268 510-3674-471 C 242 .1 µF +80-20% Z5U 25V cer 510-3680-104 smd 470 pF ±5% NPO 25V cer smd C 269 510-3674-471 C 243 100 pF ±5% NPO 25V cer smd 510-3674-101 470 pF ±5% NPO 25V cer smd C 270 510-3674-471 C 245 1 µF ±20% Z5U 25V cer smd 510-3636-105 470 pF ±5% NPO 25V cer smd C 271 470 pF ±5% NPO 25V cer 510-3674-471 74 510-3636-105 510-2624-100 510-2624-100 smd C 272 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 470 pF ±5% NPO 25V cer smd 510-3674-471 C 287 470 pF ±5% NPO 25V cer smd 510-3674-471 C 288 470 pF ±5% NPO 25V cer smd 510-3674-471 C 289 470 pF ±5% NPO 25V cer smd 510-3674-471 C 290 470 pF ±5% NPO 25V cer smd 510-3674-471 C 291 470 pF ±5% NPO 25V cer smd 510-3674-471 C 292 470 pF ±5% NPO 25V cer smd 510-3674-471 C 293 470 pF ±5% NPO 25V cer smd 510-3674-471 C 294 470 pF ±5% NPO 25V cer smd 510-3674-471 C 273 C 274 C 275 C 276 C 277 C 278 C 279 C 281 C 282 C 283 C 284 C 285 C 286 75 C 295 470 pF ±5% NPO 25V cer smd 510-3674-471 C 296 470 pF ±5% NPO 25V cer smd 510-3674-471 C 299 470 pF ±5% NPO 25V cer smd 510-3674-471 C 302 470 pF ±5% NPO 25V cer smd 510-3674-471 C 303 470 pF ±5% NPO 25V cer smd 510-3674-471 C 304 470 pF ±5% NPO 25V cer smd 510-3674-471 C 305 470 pF ±5% NPO 25V cer smd 510-3674-471 C 306 470 pF ±5% NPO 25V cer smd 510-3674-471 C 308 0.01 µF ±10% X7R 25V cer 510-3675-103 smd C 309 470 pF ±5% NPO 25V cer smd 510-3674-471 C 312 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 313 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 314 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 315 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 316 10 µF 10V cer smd 510-3755-106 C 317 8.2pF +/-.1pF NPO cer smd 510-3673-829 C 318 22 µF ±10% 16V X5R smd 510-3607-226 C 319 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 320 10 µF 10V cer smd 510-3755-106 C 321 10 pF ±.1 pF NPO cer smd 510-3673-100 C 322 10 pF ±.1 pF NPO cer smd 510-3673-100 C 323 22 µF ±10% 16V X5R smd 510-3607-226 C 324 .1 µF ±10% X7R 25V cer smd 510-3675-104 C 325 4.7 µF 20V tantalum smd 510-2626-479 C 326 0.01 µF ±10% X7R 25V cer 510-3675-103 smd C 327 0.01 µF ±10% X7R 25V cer 510-3675-103 smd C 328 .01 µF ±10% 10V cer smd 510-3681-103 CR 003 Silicon switching diode 523-1004-021 C 329 .01 µF ±10% 10V cer smd 510-3681-103 CR 004 Zener diode, 5.6V 523-2016-569 C330 .01 µF ±10% 10V cer smd 510-3681-103 CR 005 Zener diode, 18V 523-2601-180 C331 .01 µF ±10% 10V cer smd 510-3681-103 CR 006 Zener diode, 5.1V 523-2601-519 C332 .1 µF ±10% X7R 25V cer smd 510-3675-104 CR 010 Zener diode, 3.6V 523-2016-369 CR 011 Zener diode, 3.6V 523-2016-369 C333 .1 µF ±10% X7R 25V cer smd 510-3675-104 CR 012 Silicon switching diode 523-1004-021 C334 .1 µF ±10% X7R 25V cer smd 510-3675-104 CR 013 LED, green 549-4003-011 CR 014 LED, green 549-4003-011 C335 .01 µF ±10% 10V cer smd 510-3681-103 CR 015 LED, green 549-4003-011 C336 .01 µF ±10% 10V cer smd 510-3681-103 C337 .01 µF ±10% 10V cer smd 510-3681-103 D 002 523-1504-022 C338 .1 µF ±10% X7R 25V cer smd 510-3675-104 Dual switching diode, com cath D 003 523-1504-022 .1 µF ±10% X7R 25V cer smd 510-3675-104 Dual switching diode, com cath D 004 523-1504-022 .1 µF ±10% X7R 25V cer smd 510-3675-104 Dual switching diode, com cath D 005 523-1504-022 C 341 100 pF ±10% 25V cer smd 510-3681-101 Dual switching diode, com cath C 342 100 pF ±10% 25V cer smd 510-3681-101 D 006 Dual switching diode, com cath 523-1504-022 C 343 .01 µF ±10% 10V cer smd 510-3681-103 C 344 .01 µF ±10% 10V cer smd 510-3681-103 F 001 Fuse, 0.5A smd 534-5002-009 C 345 .01 µF ±10% 10V cer smd 510-3681-103 C 346 .01 µF ±10% 10V cer smd 510-3681-103 J 001 Connector, 16-pin 515-7000-668 C 347 .01 µF ±10% 10V cer smd 510-3681-103 J 002 Connector, 25-pin 515-7113-071 C 348 .01 µF ±10% 10V cer smd 510-3681-103 J 005 Connector, 13-pin 515-7111-262 C 349 0.01 µF ±10% X7R 25V cer 510-3675-103 smd J 006 Connector, 13-pin 515-7111-262 C 350 .01 µF ±10% 10V cer smd 510-3681-103 J 007 Connector, 5-pin 515-7111-254 C 351 2.2 µF 16V cer smd 510-3925-225 J 008 Connector, 12-pin 515-7111-261 C 352 .1 µF ±10% X7R 25V cer smd 510-3675-104 J 009 Connector, 2 14-pin 515-9500-045 J 011 Connector, 5-pin 515-7111-254 C 353 .1 µF ±10% X7R 25V cer smd 510-3675-104 J 012 Connector, 13-pin 515-7111-262 J 016 Connector, 25-pin 515-7113-071 C 354 .1 µF ±10% X7R 25V cer smd 510-3675-104 J 018 Connector, 25-pin 515-7113-071 C 355 .1 µF ±10% X7R 25V cer smd 510-3675-104 C339 C 340 L 015 - Inductor, ferrite smd 542-9230-023 L 053 CR 001 Silicon switching diode 523-1004-021 CR 002 Silicon switching diode 523-1004-021 76 L 054 8.2 µH ±5% smd 542-9000-829 L 055 Bead, ferrite smd 542-9230-005 R 002 51k ohm ±5% 1/16W smd 569-0165-513 L 056 Bead, ferrite smd 542-9230-005 R 003 51k ohm ±5% 1/16W smd 569-0165-513 L 057 Inductor, ferrite smd 542-9230-021 R 004 51k ohm ±5% 1/16W smd 569-0165-513 L 058 Inductor, ferrite smd 542-9230-021 R 006 4.7k ohm ±5% 1/16W smd 569-0165-472 L 059 Inductor, ferrite smd 542-9230-021 R 007 4.7k ohm ±5% 1/16W smd 569-0165-472 L 060 Inductor, ferrite smd 542-9230-021 R 008 4.7k ohm ±5% 1/16W smd 569-0165-472 L 061 Inductor, ferrite smd 542-9230-021 R 009 4.7k ohm ±5% 1/16W smd 569-0165-472 L 062 Inductor, ferrite smd 542-9230-021 R 010 4.7k ohm ±5% 1/16W smd 569-0165-472 L 063 Bead, ferrite smd 542-9230-005 R 011 4.7k ohm ±5% 1/16W smd 569-0165-472 L 064 10 µH power inductor 542-9009-100 R 012 4.7k ohm ±5% 1/16W smd 569-0165-472 L 065 10 µH power inductor 542-9009-100 R 013 4.7k ohm ±5% 1/16W smd 569-0165-472 R 014 4.7k ohm ±5% 1/16W smd 569-0165-472 R 015 4.7k ohm ±5% 1/16W smd 569-0165-472 R 016 4.7k ohm ±5% 1/16W smd 569-0165-472 R 017 4.7k ohm ±5% 1/16W smd 569-0165-472 R 018 100k ohm ±5% 1/16W smd 569-0165-104 R 019 4.7k ohm ±5% 1/16W smd 569-0165-472 R 020 4.7k ohm ±5% 1/16W smd 569-0165-472 R 021 4.7k ohm ±5% 1/16W smd 569-0165-472 R 022 4.7k ohm ±5% 1/16W smd 569-0165-472 R 023 4.7k ohm ±5% 1/16W smd 569-0165-472 R 024 4.7k ohm ±5% 1/16W smd 569-0165-472 R 025 4.7k ohm ±5% 1/16W smd 569-0165-472 R 029 51k ohm ±5% 1/16W smd 569-0165-513 R 030 51k ohm ±5% 1/16W smd 569-0165-513 R 031 51k ohm ±5% 1/16W smd 569-0165-513 R 038 47k ohm ±5% 1/16W smd 569-0155-473 R 039 47k ohm ±5% 1/16W smd 569-0155-473 R 040 620 ohm ±5% smd 569-0105-621 R 041 620 ohm ±5% smd 569-0105-621 R 076 100 ohm ±5% 1/16W smd 569-0165-101 R 078 10 ohm ±5% 1/16W smd 569-0165-100 R 080 1k ohm ±5% 1/16W smd 569-0155-102 R 095 220k ohm ±5% 1/16W smd 569-0155-224 R 098 10k ohm ±5% 1/16W smd 569-0155-103 R 099 10k ohm ±5% 1/16W smd 569-0155-103 R 100 10k ohm ±5% 1/16W smd 569-0155-103 R 101 4.7k ohm ±5% 1/16W smd 569-0165-472 PC 001 PC board, 5500 logic rev 1 035-5500-600 Q 005 N-chan MOSFET 60V 1A 576-0003-725 Q 006 NPN general purpose 576-0003-658 Q 009 NPN general purpose 576-0003-658 Q 010 NPN general purpose 576-0003-658 Q 011 NPN general purpose 576-0003-658 Q 012 NPN general purpose 576-0003-658 Q 013 NPN general purpose 576-0003-658 Q 014 NPN general purpose 576-0003-658 Q 015 NPN general purpose 576-0003-658 Q 017 NPN general purpose 576-0003-658 Q 018 NPN general purpose 576-0003-658 Q 020 NPN general purpose 576-0003-658 Q 021 NPN general purpose 576-0003-658 Q 022 NPN general purpose 576-0003-658 Q 023 NPN general purpose 576-0003-658 Q 024 NPN general purpose 576-0003-658 Q 025 NPN general purpose 576-0003-658 Q 026 NPN general purpose 576-0003-658 Q 027 NPN general purpose 576-0003-658 Q 028 NPN general purpose 576-0003-658 Q 029 NPN general purpose 576-0003-658 R 001 10k ohm ±5% 1/16W smd 569-0165-103 77 R 102 4.7k ohm ±5% 1/16W smd 569-0165-472 R 255 10 ohm ±5% 1/16W smd 569-0165-100 R 103 100k ohm ±5% 1/16W smd 569-0165-104 R 256 10 ohm ±5% 1/16W smd 569-0165-100 R 104 100k ohm ±5% 1/16W smd 569-0165-104 R 257 1k ohm ±5% 1/16W smd 569-0165-102 R 105 220k ohm ±5% 1/16W smd 569-0165-224 R 258 2k ohm ±5% 1/16W smd 569-0155-202 R 106 220k ohm ±5% 1/16W smd 569-0165-224 R 259 10M ohm ±5% 1/16W smd 569-0165-106 R 107 1k ohm ±5% 1/16W smd 569-0165-102 R 260 2k ohm ±5% 1/16W smd 569-0155-202 R 108 220k ohm ±5% 1/16W smd 569-0165-224 R 261 220k ohm ±5% 1/16W smd 569-0165-224 R 109 2k ohm ±5% 1/16W smd 569-0165-202 R 262 330 ohm ±5% 1/16W smd 569-0155-331 R 110 4.7k ohm ±5% 1/16W smd 569-0165-472 R 263 100k ohm ±5% 1/16W smd 569-0165-104 R 111 2k ohm ±5% 1/16W smd 569-0165-202 R 264 100k ohm ±5% 1/16W smd 569-0165-104 R 112 2k ohm ±5% 1/16W smd 569-0165-202 R 265 100k ohm ±5% 1/16W smd 569-0165-104 R 113 220k ohm ±5% 1/16W smd 569-0165-224 R 266 6.8k ohm ±5% 1/16W smd 569-0155-682 R 114 4.7k ohm ±5% 1/16W smd 569-0165-472 R 267 330 ohm ±5% 1/16W smd 569-0155-331 R 115 220k ohm ±5% 1/16W smd 569-0165-224 R 268 100k ohm ±5% 1/16W smd 569-0165-104 R 117 220k ohm ±5% 1/16W smd 569-0165-224 R 269 220k ohm ±5% 1/16W smd 569-0165-224 R 118 220k ohm ±5% 1/16W smd 569-0165-224 R 270 62k ohm ±5% 1/16W smd 569-0155-623 R 119 220k ohm ±5% 1/16W smd 569-0165-224 R 271 150k ohm ±5% 1/16W smd 569-0155-154 R 120 220k ohm ±5% 1/16W smd 569-0165-224 R 272 6.8k ohm ±5% 1/16W smd 569-0155-682 R 121 220k ohm ±5% 1/16W smd 569-0165-224 R 273 6.8k ohm ±5% 1/16W smd 569-0155-682 R 122 220k ohm ±5% 1/16W smd 569-0165-224 R 274 220k ohm ±5% 1/16W smd 569-0165-224 R 123 220k ohm ±5% 1/16W smd 569-0165-224 R 275 330 ohm ±5% 1/16W smd 569-0155-331 R 124 220k ohm ±5% 1/16W smd 569-0165-224 R 276 6.8k ohm ±5% 1/16W smd 569-0155-682 R 125 220k ohm ±5% 1/16W smd 569-0165-224 R 277 100k ohm ±5% 1/16W smd 569-0165-104 R 126 220k ohm ±5% 1/16W smd 569-0165-224 R 278 100k ohm ±5% 1/16W smd 569-0165-104 R 127 220k ohm ±5% 1/16W smd 569-0165-224 R 279 100k ohm ±5% 1/16W smd 569-0165-104 R 128 220k ohm ±5% 1/16W smd 569-0165-224 R 280 330 ohm ±5% 1/16W smd 569-0155-331 R 129 220k ohm ±5% 1/16W smd 569-0165-224 R 281 220k ohm ±5% 1/16W smd 569-0165-224 R 130 220k ohm ±5% 1/16W smd 569-0165-224 R 282 0 ohm jumper 569-0155-001 R 131 220k ohm ±5% 1/16W smd 569-0165-224 R 283 100k ohm ±5% 1/16W smd 569-0165-104 R 132 4.7k ohm ±5% 1/16W smd 569-0165-472 R 284 100k ohm ±5% 1/16W smd 569-0155-104 R 141 47k ohm ±5% 1/16W smd 569-0155-473 R 285 10k ohm ±5% 1/16W smd 569-0155-103 R 224 10k ohm ±5% 1/16W smd 569-0165-103 R 286 100k ohm ±5% 1/16W smd 569-0165-104 R 225 10k ohm ±5% 1/16W smd 569-0165-103 R 287 20k ohm ±5% 1/16W smd 569-0155-203 R 226 10k ohm ±5% 1/16W smd 569-0165-103 R 288 56k ohm ±5% 1/16W smd 569-0155-563 R 249 10k ohm ±5% 1/16W smd 569-0155-103 R 289 390k ohm ±5% 1/16W smd 569-0155-394 R 251 10k ohm ±5% 1/16W smd 569-0155-103 R 290 6.8k ohm ±5% 1/16W smd 569-0155-682 R 252 10 ohm ±5% 1/16W smd 569-0165-100 R 291 47k ohm ±5% 1/16W smd 569-0155-473 R 253 10 ohm ±5% 1/16W smd 569-0165-100 R 292 47k ohm ±5% 1/16W smd 569-0155-473 78 R 293 6.8k ohm ±5% 1/16W smd 569-0155-682 R334 47k ohm ±5% 1/16W smd 569-0155-473 R 294 100k ohm ±5% 1/16W smd 569-0155-104 R336 100 ohm ±5% 1/16W smd 569-0155-101 R 295 150 ohm ±5% 1/16W smd 569-0155-151 R338 10k ohm ±5% 1/16W smd 569-0155-103 R 296 6.8k ohm ±5% 1/16W smd 569-0155-682 R339 10k ohm ±5% 1/16W smd 569-0155-103 R 297 100k ohm ±5% 1/16W smd 569-0155-104 R 340 47k ohm ±5% 1/16W smd 569-0155-473 R 298 150 ohm ±5% 1/16W smd 569-0155-151 R 344 10k ohm ±5% 1/16W smd 569-0155-103 R 299 6.8k ohm ±5% 1/16W smd 569-0155-682 R 345 470 ohm ±5% 1/16W smd 569-0155-471 R 300 100k ohm ±5% 1/16W smd 569-0155-104 R 346 10k ohm ±5% 1/16W smd 569-0155-103 R 301 100k ohm ±5% 1/16W smd 569-0155-104 R 348 10k ohm ±5% 1/16W smd 569-0155-103 R 302 100k ohm ±5% 1/16W smd 569-0155-104 R 350 10k ohm ±5% 1/16W smd 569-0155-103 R 303 6.8k ohm ±5% 1/16W smd 569-0155-682 R 351 47k ohm ±5% 1/16W smd 569-0155-473 R 304 68k ohm ±5% 1/16W smd 569-0165-683 R 353 10k ohm ±5% 1/16W smd 569-0155-103 R 305 0 ohm jumper 569-0155-001 R 355 47k ohm ±5% 1/16W smd 569-0155-473 R 307 100k ohm ±5% 1/16W smd 569-0155-104 R 356 10k ohm ±5% 1/16W smd 569-0155-103 R 308 0 ohm jumper 569-0155-001 R 357 100 ohm ±5% 1/16W smd 569-0155-101 R 309 100k ohm ±5% 1/16W smd 569-0155-104 R 358 100 ohm ±5% 1/16W smd 569-0155-101 R 310 6.8k ohm ±5% 1/16W smd 569-0155-682 R 360 10 ohm ±5% 1/16W smd 569-0155-100 R 311 100k ohm ±5% 1/16W smd 569-0155-104 R 361 47k ohm ±5% 1/16W smd 569-0155-473 R 312 100k ohm ±5% 1/16W smd 569-0155-104 R 362 4.7k ohm ±5% 1/16W smd 569-0155-472 R 313 100k ohm ±5% 1/16W smd 569-0155-104 R 364 10k ohm ±5% 1/16W smd 569-0155-103 R 315 10k ohm ±5% 1/16W smd 569-0155-103 R 365 10k ohm ±5% 1/16W smd 569-0155-103 R 316 47k ohm ±5% 1/16W smd 569-0155-473 R 366 100k ohm ±5% 1/16W smd 569-0155-104 R 318 10k ohm ±5% 1/16W smd 569-0155-103 R 367 47k ohm ±5% 1/16W smd 569-0155-473 R 319 47k ohm ±5% 1/16W smd 569-0155-473 R 368 10k ohm ±5% 1/16W smd 569-0155-103 R 320 10k ohm ±5% 1/16W smd 569-0155-103 R 369 10k ohm ±5% 1/16W smd 569-0155-103 R 321 10k ohm ±5% 1/16W smd 569-0155-103 R 370 1k ohm ±5% 1/16W smd 569-0155-102 R 322 10k ohm ±5% 1/16W smd 569-0155-103 R 371 10k ohm ±5% 1/16W smd 569-0155-103 R 323 1k ohm ±5% 1/16W smd 569-0155-102 R 372 100k ohm ±5% 1/16W smd 569-0155-104 R 324 10k ohm ±5% 1/16W smd 569-0155-103 R 373 33.2k ohm ±1% 0.1W smd 569-0151-451 R 325 10k ohm ±5% 1/16W smd 569-0155-103 R 374 10k ohm ±5% 1/16W smd 569-0155-103 R 326 10k ohm ±5% 1/16W smd 569-0155-103 R 377 10k ohm ±5% 1/16W smd 569-0155-103 R 327 10k ohm ±5% 1/16W smd 569-0155-103 R 378 10k ohm ±5% 1/16W smd 569-0155-103 R 328 10k ohm ±5% 1/16W smd 569-0155-103 R 379 10k ohm ±5% 1/16W smd 569-0155-103 R 329 100 ohm ±5% 1/16W smd 569-0155-101 R 392 10k ohm ±5% 1/16W smd 569-0155-103 R330 10k ohm ±5% 1/16W smd 569-0155-103 R 393 10k ohm ±5% 1/16W smd 569-0155-103 R331 10k ohm ±5% 1/16W smd 569-0155-103 R 394 10k ohm ±5% 1/16W smd 569-0155-103 R332 470 ohm ±5% 1/16W smd 569-0155-471 R 395 10k ohm ±5% 1/16W smd 569-0155-103 R333 10k ohm ±5% 1/16W smd 569-0155-103 R 396 10k ohm ±5% 1/16W smd 569-0155-103 79 R 399 100k ohm ±5% 1/16W smd 569-0165-104 R 709 1k ohm ±5% 1/16W smd 569-0165-102 R 400 634k ohm ±1% 0.1W smd 569-0151-578 R 710 1k ohm ±5% 1/16W smd 569-0165-102 R 401 100k ohm ±1% 0.1W smd 569-0151-501 R 711 1k ohm ±5% 1/16W smd 569-0165-102 R 402 100k ohm ±5% 1/16W smd 569-0165-104 R 712 1k ohm ±5% 1/16W smd 569-0165-102 R 403 255k ohm ±1% 0.1W smd 569-0151-551 R 713 10k ohm ±5% 1/16W smd 569-0165-103 R 404 100k ohm ±1% 0.1W smd 569-0151-501 R 714 10k ohm ±5% 1/16W smd 569-0165-103 R 405 10k ohm ±5% 1/16W smd 569-0155-103 R 715 10k ohm ±5% 1/16W smd 569-0165-103 R 406 10k ohm ±5% 1/16W smd 569-0155-103 R 716 1k ohm ±5% 1/16W smd 569-0165-102 R 407 10k ohm ±5% 1/16W smd 569-0155-103 R 717 1k ohm ±5% 1/16W smd 569-0165-102 R 408 10k ohm ±5% 1/16W smd 569-0155-103 R 718 1k ohm ±5% 1/16W smd 569-0165-102 R 409 10k ohm ±5% 1/16W smd 569-0155-103 R 719 1k ohm ±5% 1/16W smd 569-0165-102 R 410 10k ohm ±5% 1/16W smd 569-0155-103 R 720 1k ohm ±5% 1/16W smd 569-0165-102 R 412 100k ohm ±5% 1/16W smd 569-0165-104 R 721 1k ohm ±5% 1/16W smd 569-0165-102 R 413 100k ohm ±5% 1/16W smd 569-0165-104 R 722 4.7k ohm ±5% 1/16W smd 569-0165-472 R 683 68k ohm ±5% 1/16W smd 569-0155-683 R 723 4.7k ohm ±5% 1/16W smd 569-0165-472 R 685 27k ohm ±5% 1/16W smd 569-0155-273 R 724 15k ohm ±5% 1/16W smd 569-0165-153 R 686 100k ohm ±5% 1/16W smd 569-0165-104 R 725 18k ohm ±5% 1/16W smd 569-0165-183 R 687 100k ohm ±5% 1/16W smd 569-0165-104 R 726 180 ohm ±5% 1/16W smd 569-0165-181 R 688 51k ohm ±5% 1/16W smd 569-0165-513 R 727 180 ohm ±5% 1/16W smd 569-0165-181 R 689 100k ohm ±5% 1/16W smd 569-0165-104 R 728 180 ohm ±5% 1/16W smd 569-0165-181 R 690 100k ohm ±5% 1/16W smd 569-0165-104 R 729 10k ohm ±5% 1/16W smd 569-0165-103 R 691 100k ohm ±5% 1/16W smd 569-0165-104 R 730 24 ohm ±5% 1/16W smd 569-0165-240 R 692 4.7k ohm ±5% 1/16W smd 569-0165-472 R 731 24 ohm ±5% 1/16W smd 569-0165-240 R 693 4.7k ohm ±5% 1/16W smd 569-0165-472 R 732 100k ohm ±5% 1/16W smd 569-0165-104 R 694 10k ohm ±5% 1/16W smd 569-0165-103 R 733 7.5k ohm ±1% 1/8W smd 569-0111-385 R 695 10k ohm ±5% 1/16W smd 569-0165-103 R 734 7.5k ohm ±1% 1/8W smd 569-0111-385 R 696 10k ohm ±5% 1/16W smd 569-0165-103 R 735 10k ohm ±5% 1/16W smd 569-0165-103 R 697 10k ohm ±5% 1/16W smd 569-0165-103 R 736 10k ohm ±5% 1/16W smd 569-0165-103 R 698 4.7k ohm ±5% 1/16W smd 569-0165-472 R 737 10k ohm ±5% 1/16W smd 569-0165-103 R 699 10k ohm ±5% 1/16W smd 569-0165-103 R 738 51 ohm ±5% 1/16W smd 569-0155-510 R 700 10k ohm ±5% 1/16W smd 569-0165-103 R 739 51 ohm ±5% 1/16W smd 569-0155-510 R 701 15k ohm ±5% 1/16W smd 569-0165-153 R 740 10k ohm ±5% 1/16W smd 569-0155-103 R 702 20k ohm ±5% 1/16W smd 569-0165-203 R 741 100k ohm ±5% 1/16W smd 569-0165-104 R 703 30k ohm ±5% 1/16W smd 569-0155-303 R 742 100k ohm ±5% 1/16W smd 569-0165-104 R 704 10k ohm ±5% 1/16W smd 569-0165-103 R 744 0 ohm jumper 569-0165-001 R 705 15k ohm ±5% 1/16W smd 569-0165-153 R 745 0 ohm jumper 569-0165-001 R 706 20k ohm ±5% 1/16W smd 569-0165-203 R 746 0 ohm jumper 569-0165-001 R 707 30k ohm ±5% 1/16W smd 569-0155-303 R 747 0 ohm jumper 569-0165-001 80 R 748 10 ohm ±5% 1/16W smd 569-0165-100 R 749 10 ohm ±5% 1/16W smd 569-0165-100 R 752 10k ohm ±5% 1/16W smd 569-0165-103 R 753 10k ohm ±5% 1/16W smd 569-0165-103 S 001 T 001 Switch, momentary norm open Isolation transformer 10BASE-T 583-9512-002 592-9017-003 U 001 DSP TMS3205510AGGWA1 544-5003-133 U 002 CODEC, dual TLV320AIC211 544-3016-057 U 003 Schmitt trig, inv TC7S14FTE85L 544-3123-014 U 004 Op Amp OPA340NA 544-2020-023 U 011 Regulator, 5V 400mA 544-2603-055 REG113EA-5 U 013 Regulator, 5V 400mA 544-2603-055 REG113EA-5 U 015 Regulator, 3.8V, 50 mA LP2982 544-5001-335 U 020 SRAM 256k x 16 CY62146V 544-5001-213 U 021 Flash, 8M X 8 bit 544-5001-255 AM29DL640G90 U 048 Bus xcvr, octal 74LVCC3245 544-1010-250 U 049 Op am, quad MC3303 544-2020-008 U 056 Multiplexer triple 4053 544-1014-053 U 057 Microcontroller PowerPC MPC850 544-5003-127 U 058 EEPROM 32k x 8 M24256 544-1019-376 U 059 Multiplexer triple 4053 544-1014-053 U 060 Op am, quad MC3303 544-2020-008 U 061 Op am, quad MC3303 544-2020-008 U 063 Flip flop octal 74HC574 544-3764-576 U 064 Flip flop octal 74HC574 544-3764-576 U 065 Flip flop octal 74HC574 544-3764-576 U 066 Multiplexer triple 4053 544-1014-053 U 067 Converter, A/D 8-bit ser TLC5481 544-1010-548 U 069 RS-232 bus xcvr MAX3221EAE 544-2023-036 U 070 Analog switch, SPDT NLAS4599 544-4002-007 U 071 SRAM 512k x 16 CY62157CV30 544-5001-215 U 072 SRAM 512k x 16 CY62157CV30 544-5001-215 U 073 Tri state buffer, 3.3V NC7SZ125P5 544-3914-125 U 074 DC-DC converter TPS6200 544-4006-011 U 075 DC-DC converter TPS6200 544-4006-011 U 079 Tri state buffer, 3.3V NC7SZ125P5 544-3914-125 U 080 Regulator 5V LT1121IST-5 544-1011-121 U 081 Buffer, quad 74LCX125 544-3776-127 544-5001-419 U 022 Buffer, quad 74LCX125 544-3776-127 U 023 SRAM 512k x 16 CY62157CV30 544-5001-215 U 024 Tri state buffer, 3.3V NC7SZ125P5 544-3914-125 U 025 Buffer, quad 74LCX125 544-3776-127 U 082 Programmable logic U 026 3-state buffer, quad 74ACT125 544-3776-117 U 083 Op amp, quad OPA4340EA 544-2020-013 U 084 Op amp, quad OPA4340EA 544-2020-013 U 027 Schmitt trig, inv TC7S14FTE85L 544-3123-014 U 085 Transceiver, 10BASE-T 3V 544-2023-050 U 042 Triple supply monitor LT1727 544-5001-341 U 086 Reg, 3.3V 400 mA REG113EA-3.3 U 045 RS-232 bus xcvr MAX3221EAE 544-2023-036 U 087 Op amp, quad OPA4340EA 544-2020-013 U 046 RS-485 bus transceiver ADM483 544-2023-073 Y 002 Crystal, 4.9152 MHz smd 81 544-2603-056 521-3060-022 Y 003 TCXO, 12.288 MHz smd 518-7012-200 Y 004 Oscillator, 20.000 MHz smd 561-9004-200 FRONT PANEL ASSEMBLY Part No. 023-5300-810 MP 103 Light pipe 032-0792-032 MP 108 Support-keypad 017-2226-090 MP 151 Gasket, front lens 018-1136-130 MP 152 Control knob 032-0792-010 MP 153 Control knob 032-0792-010 A 151 Plastic front panel assembly 587-9650-002 MP 154 Speaker membrane 018-1136-138 A 815 Display controller board MP 155 Spacer, display board 018-1136-140 MP 158 Front panel lens 032-0792-034 MP 160 Spacer (between boards) 013-1188-053 023-5300-813 (see separate listings) C 750 4.7 µF 10V tantalum smd 510-2624-479 MP 161 Keypad, standard 032-0792-031 C 754 1.0 µF 35V tantalum smd 510-2628-109 MP 162 Speaker retainer 016-2187-250 C 755 4.7 µF 10V tantalum smd 510-2624-479 MP 163 Speaker gasket, silicone 018-1136-128 MP 990 Gasket, microphone jack silicone 018-1136-132 NP 001 Johnson label raised 559-9001-310 NP 002 Label, RS 5300 559-5300-100 PC 010 Flex circuit, std push on-off 035-5300-010 Flex circuit, motorcycle rot on-off 035-5300-015 DS 700 Dual color, red/grn LED 549-4001-215 DS LED, green smd 701DS706 549-4001-145 DS LED, green smd 707DS726 549-4003-011 DS 727 LCD assembly 549-4501-010 EP 101 Key cap kit (see Section 2.8) 587-5300-001 HW 010 Washer, .438 x .274 x .030 596-9410-010 HW 011 Nut, spanner 3/8 x 7mm 013-1313-018 HW 012 Screw, 2-56 x 1/4 575-1602-008 HW 013 Lockwasher, internal No. 2 596-2102-006 J 703 J 705 Connector, 13-pin circular recept 515-1009-025 Connector, 31-pin 515-7109-129 LS 001 Speaker, 2 x 3 in 16-ohm 589-1015-006 PC 815 PC board, display 035-5300-815 Q 710 PNP general purpose 576-0003-650 Q 711 NPN general purpose 576-0003-658 Q 712 NPN general purpose 576-0003-658 R 800 180k ohm ±5% 1/8W smd 569-0105-184 R 801 100k ohm ±5% 1/8W smd 569-0105-104 R 802 100k ohm ±5% 1/8W smd 569-0105-104 R 803 62 ohm ±5% 2010 .75W smd 569-0135-620 R 804 62 ohm ±5% 2010 .75W smd 569-0135-620 R 805 62 ohm ±5% 2010 .75W smd 569-0135-620 R 806 62 ohm ±5% 2010 .75W smd 569-0135-620 R 807 510 ohm ±5% 1/8W smd R 808 62 ohm ±5% 2010 .75W smd 569-0135-620 R 809 62 ohm ±5% 2010 .75W smd 569-0135-620 R 810 510 ohm ±5% 1/8W smd 569-0105-511 569-0105-511 MP 101 Display bezel 017-2226-046 R 811 10k ohm ±5% 1/8W smd 569-0105-103 MP 102 Display gasket 018-1136-120 R 812 10k ohm ±5% 1/8W smd 569-0105-103 82 S 001 DIP switch, 10-position 583-5100-210 S 154 On-off/Vol push on w/50k pot std 562-0018-075 On-off/Vol rot on-off , motorcycle 562-0018-077 Switch rotary and push 583-2042-001 S 155 U 710 LCD driver, PCF8576TD 544-2027-010 U 711 LCD driver, PCF8576TD 544-2027-010 U 712 Regulator, 8V 0.5A 78M08 544-2003-081 C 020 .01µF ±10% X7R cer smd 510-3675-103 C 021 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 022 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 023 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 024 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 029 1.0 µF 10V tantalum smd 510-2624-109 C 030 10 µF 25V tantalum smd 510-2627-100 C 031 4.7 µF 25V tantalum smd 510-2627-479 C 032 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 126 .01 µF ±10% X7R cer smd 510-3675-103 C 127 1.0 µF 10V tantalum smd 510-2624-109 C 128 1.0 µF 10V tantalum smd 510-2624-109 C 129 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 130 .047 µF ±10% X7R cer smd 510-3605-473 W 103 Cable assy, display - logic bd 023-5300-025 DISPLAY CONTROLLER BOARD C 001 4.7 µF 25V tantalum smd 510-2627-479 C 002 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 003 10 µF 25V tantalum smd 510-2627-100 C 004 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 005 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 006 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 007 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 009 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 010 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 011 .1 µF ±10% X7R 50V cer smd 510-3675-104 C 012 4.7 µF 25V tantalum smd C 013 CR 001 5.6V zener SOT-23 523-2016-569 CR 002 5.6V zener SOT-23 523-2016-569 CR 003 5.6V zener SOT-23 523-2016-569 CR 004 5.6V zener SOT-23 523-2016-569 CR 005 5.6V zener SOT-23 523-2016-569 CR 006 5.6V zener SOT-23 523-2016-569 CR 007 5.6V zener SOT-23 523-2016-569 CR 008 5.6V zener SOT-23 523-2016-569 CR 009 5.6V zener SOT-23 523-2016-569 CR 010 5.6V zener SOT-23 523-2016-569 CR 011 5.6V zener SOT-23 523-2016-569 CR 012 PIN switching diode 523-1504-001 510-2627-479 CR 013 5.6V zener SOT-23 523-2016-569 .1 µF ±10% X7R 50V cer smd 510-3675-104 CR 014 PIN switching diode 523-1504-001 C 016 .1 µF ±10% X7R 50V cer smd 510-3675-104 DS 727 LCD assembly 549-4501-010 C 017 4.7 µF 25V tantalum smd 510-2627-479 F 001 Fuse 2.0 A smd 534-5001-009 C 018 .1 µF ±10% X7R 50V cer smd 510-3675-104 J 700 Connector, 16-pin 515-7000-668 83 J 701 Connector, micro-miniature 515-7113-073 R 028 100k ohm ±5% 1/16W smd 569-0155-104 J 702 Connector, 9-pin ZIF flex 515-7111-321 R 029 100k ohm ±5% 1/16W smd 569-0155-104 J 704 Connector, 5-pin (PA bd cable) 515-7111-254 R 030 10k ohm ±5% 1/16W smd 569-0155-103 R 031 300ohm ±5% 1/16W smd 569-0155-301 R 032 47k ohm ±5% 1/16W smd 569-0155-473 R 033 47k ohm ±5% 1/16W smd 569-0155-473 R 035 47k ohm ±5% 1/16W smd 569-0155-473 R 036 620 ohm ±5% 1/8W smd 569-0105-621 R 037 620 ohm ±5% 1/8W smd 569-0105-621 R 038 47k ohm ±5% 1/16W smd 569-0155-473 R 039 300ohm ±5% 1/16W smd 569-0155-301 R 040 10k ohm ±5% 1/16W smd 569-0155-103 R 041 3.3k ohm ±5% 1/16W smd 569-0155-332 R 042 10k ohm ±5% 1/16W smd 569-0155-103 R 043 4.7k ohm ±5% 1/16W smd 569-0155-472 R 044 10k ohm ±5% 1/16W smd 569-0155-103 R 045 10k ohm ±5% 1/16W smd 569-0155-103 R 046 47k ohm ±5% 1/16W smd 569-0155-473 R 047 10k ohm ±5% 1/16W smd 569-0155-103 R 048 47k ohm ±5% 1/16W smd 569-0155-473 R 049 47k ohm ±5% 1/16W smd 569-0155-473 R 050 47k ohm ±5% 1/16W smd 569-0155-473 R 051 47k ohm ±5% 1/16W smd 569-0155-473 R 052 47k ohm ±5% 1/16W smd 569-0155-473 R 054 10k ohm ±5% 1/16W smd 569-0155-103 R 055 4.7k ohm ±5% 1/16W smd 569-0155-472 R 056 10k ohm ±5% 1/16W smd 569-0155-103 R 057 4.7k ohm ±5% 1/16W smd 569-0155-472 R 058 10k ohm ±5% 1/16W smd 569-0155-103 R 059 47k ohm ±5% 1/16W smd 569-0155-473 R 060 47k ohm ±5% 1/16W smd 569-0155-473 R 061 47k ohm ±5% 1/16W smd 569-0155-473 R 062 10k ohm ±5% 1/16W smd 569-0155-103 R 063 10k ohm ±5% 1/16W smd 569-0155-103 R 064 10k ohm ±5% 1/16W smd 569-0155-103 R 065 10k ohm ±5% 1/16W smd 569-0155-103 R 066 3.3k ohm ±5% 1/16W smd 569-0155-332 R 067 47k ohm ±5% 1/16W smd 569-0155-473 PC 001 PC board, display controller 035-5300-810 5 rev. 5 Q 002 NPN general purpose 576-0003-658 Q 004 NPN digital w/resistors 576-0003-616 Q 005 NPN digital w/resistors 576-0003-616 Q 006 NPN digital w/resistors 576-0003-616 R 002 330k ohm ±5% 1/16W smd 569-0155-334 R 003 10k ohm ±5% 1/16W smd 569-0155-103 R 005 100k ohm ±5% 1/16W smd 569-0155-104 R 006 10k ohm ±5% 1/16W smd 569-0155-103 R 007 10k ohm ±5% 1/16W smd 569-0155-103 R 008 10k ohm ±5% 1/16W smd 569-0155-103 R 009 10k ohm ±5% 1/16W smd 569-0155-103 R 010 10k ohm ±5% 1/16W smd 569-0155-103 R 011 47k ohm ±5% 1/16W smd 569-0155-473 R 012 47k ohm ±5% 1/16W smd 569-0155-473 R 013 47k ohm ±5% 1/16W smd 569-0155-473 R 014 47k ohm ±5% 1/16W smd 569-0155-473 R 015 200k ohm ±5% 1/16W smd 569-0155-204 R 016 200k ohm ±5% 1/16W smd 569-0155-204 R 017 47k ohm ±5% 1/16W smd 569-0155-473 R 018 47k ohm ±5% 1/16W smd 569-0155-473 R 019 300 ohm ±5% 1/8W smd 569-0105-301 R 020 47k ohm ±5% 1/16W smd 569-0155-473 R 021 100k ohm ±5% 1/16W smd 569-0155-104 R 022 300 ohm ±5% 1/8W smd 569-0105-301 R 023 10k ohm ±5% 1/16W smd 569-0155-103 R 024 10k ohm ±5% 1/16W smd 569-0155-103 R 025 10k ohm ±5% 1/16W smd 569-0155-103 R 026 10k ohm ±5% 1/16W smd 569-0155-103 R 027 51 ohm ±5% 1/8W smd 569-0105-510 84 R 068 10k ohm ±5% 1/16W smd 569-0155-103 R 110 10k ohm ±5% 1/16W smd 569-0155-103 R 069 10k ohm ±5% 1/16W smd 569-0155-103 R 111 47k ohm ±5% 1/16W smd 569-0155-473 R 070 10k ohm ±5% 1/16W smd 569-0155-103 R 112 100k ohm ±5% 1/16W smd 569-0155-104 R 071 47k ohm ±5% 1/16W smd 569-0155-473 R 113 100k ohm ±5% 1/16W smd 569-0155-104 R 072 10k ohm ±5% 1/16W smd 569-0155-103 R 114 100k ohm ±5% 1/16W smd 569-0155-104 R 073 10k ohm ±5% 1/16W smd 569-0155-103 R 115 1k ohm ±5% 1/16W smd 569-0155-102 R 074 10k ohm ±5% 1/16W smd 569-0155-103 R 116 47k ohm ±5% 1/16W smd 569-0155-473 R 075 10k ohm ±5% 1/16W smd 569-0155-103 R 076 10k ohm ±5% 1/16W smd 569-0155-103 U 002 Op am, quad MC3303 544-2020-008 R 077 10k ohm ±5% 1/16W smd 569-0155-103 U 003 RS-485 driver SN65176 544-2023-027 R 078 10k ohm ±5% 1/16W smd 569-0155-103 U 009 544-9100-007 R 079 5.1kohm ±5% 1/16W smd 569-0155-512 Microcontroller MC68HC908 R 080 300ohm ±5% 1/16W smd 569-0155-301 U 012 5V regulator, 300 mA ADP3367 544-2032-009 R 082 47k ohm ±5% 1/16W smd 569-0155-473 U 045 3.3k ohm ±5% 1/16W smd 569-0155-332 3-state noninv amp TC74VHC125 544-3991-125 R 083 R 084 10k ohm ±5% 1/16W smd 569-0155-103 U 047 544-2032-009 R 085 100k ohm ±5% 1/16W smd 569-0155-104 5V regulator, 300 mA ADP3367 R 087 10k ohm ±5% 1/16W smd 569-0155-103 U 054 Schmitt trigger, hex 74HC14 544-3991-014 R 089 1k ohm ±5% 1/16W smd 569-0155-102 U 055 Flip-flop, dual 74HC74 544-3991-074 R 090 10k ohm ±5% 1/16W smd 569-0155-103 U 056 Buffer, open drain hex MM74C906 544-3716-906 R 091 10k ohm ±5% 1/16W smd 569-0155-103 R 092 10k ohm ±5% 1/16W smd 569-0155-103 Y 002 4.9152 MHz crystal 521-3060-024 R 093 10k ohm ±5% 1/16W smd 569-0155-103 R 094 10k ohm ±5% 1/16W smd 569-0155-103 R 095 10k ohm ±5% 1/16W smd 569-0155-103 R 096 10k ohm ±5% 1/16W smd 569-0155-103 R 097 10k ohm ±5% 1/16W smd 569-0155-103 R 098 10k ohm ±5% 1/16W smd 569-0155-103 R 099 10k ohm ±5% 1/16W smd 569-0155-103 R 100 10k ohm ±5% 1/16W smd 569-0155-103 R 101 10k ohm ±5% 1/16W smd 569-0155-103 R 102 10k ohm ±5% 1/16W smd 569-0155-103 R 103 1.2M ohm ±5% 1/16W smd 569-0155-125 R 104 200k ohm ±5% 1/16W smd 569-0155-204 R 105 240k ohm ±5% 1/16W smd 569-0155-244 R 107 82k ohm ±5% 1/16W smd 569-0155-823 R 108 160k ohm ±5% 1/16W smd R 109 1k ohm ±5% 1/16W smd REMOTE CONTROL UNIT UNIQUE PARTS A 001 Remote audio amp bd assy (rev) 023-5300-751 Remote audio amp bd assy (unrev) 023-5300-750 (see separate listing which follows) A 002 Front panel assembly 023-5300-810 (see preceding listing) A 755 Audio PA board cable HW 001 Washer, poly 0.937 diameter 596-6400-015 Washer, SS spring 3/4 OD 569-0155-164 HW 002 569-0155-102 HW Screw, captive pan head .75 575-9606-018 85 023-5300-755 596-9260-001 003 MP 001 Knob, remote control unit 032-0792-015 MP 002 Mounting bracket, rem ctrl unit 017-2226-050 MP 003 Gasket 032-0792-066 MP 005 Housing, remote control unit 032-0792-130 EP 003 Ring terminal, 3/8 10-12 AWG 586-0001-019 F 101 Fuse, 15 amp 32V 534-0003-038 HW 000 Key extraction tool 017-2226-000 HW 002 Screw, 4-40 x 3/8 pan head (1) 575-0604-012 HW 003 Screw, 4-24 x 1/4 phil (3) 575-3604-008 Screw, 4-20 x 5/8 phil (3) 575-5604-020 MP 006 Rear cover, remote control unit 032-0792-135 NP 002 Johnson label 559-9001-310 W 003 Control cable, 17-ft 597-2002-262 HW 004 Control cable, 8-ft motorcycle 597-2002-259 MP 001 Heavy-duty mic clip Control cable, 50-ft 597-2002-263 W 104 Control unit pigtail cable, std 597-2002-264 Ctrl unit pigtail cable, motorcycle 597-2002-274 Fused DC Power Cable Part No. 023-9650-008 EP 101 Female crimp pin 15 µF 20V tantalum smd 510-2626-150 C 002 15 µF 20V tantalum smd 510-2626-150 C 003 0.1 µF X7R ±10% 50V cer smd 510-3606-104 C 004 1 µF 35V tantalum smd 510-2628-109 C 005 0.1 µF X7R ±10% 50V cer smd 510-3606-104 J 001 Header, 2-pin right angle 515-7100-602 J 002 Connector, 5-pin 515-7111-254 PC 001 PC board, audio amp revised 035-5300-75002 Q 001 NPN general purpose smd 576-0003-616 R 001 7.5k ohm ±5% 1/8W smd 569-0155-752 R 003 10k ohm ±5% 1/8W smd 569-0155-103 U 001 Audio amp, 3W TDA7056A 544-2006-025 Std. DC Power Cable Assembly Part No. 023-9750-010 A 001 Fused DC power cable 023-9650-008 (see separate listing) A 002 Mic clip ground wire EP 002 Ring terminal, 3/4 10-12 AWG 023-7171-911 586-0001-036 86 515-9032-540 FH 001 Fuse holder in-line includes: AUDIO AMP BOARD (REVISED) Part No. 023-5300-751 C 001 023-3514-001 HW 101 Contact 534-1004-037 Body 534-1004-031 Knob 534-1004-032 Spring 534-1004-035 Wire seal 574-9025-035 ML 001 Negative ground warning tag 559-4014-001 ML 002 Jump start warning label 559-4057-010 P 101 515-9032-535 2-pin female power connector W 101 Wire, 12 AWG stranded blue 597-7021-206 W 102 Wire, 12 AWG stranded red 597-7021-202 Accessory Wire Harness Kit Part No. 023-9750-011 Fuseholder components: EP 001 Contact 586-9004-001 F 001 Fuse, 1A 250V FB AGC 534-0003-020 MP001 Fuseholder body 534-1004-031 MP002 Fuseholder knob 534-1004-032 MP003 Fuseholder spring 534-1004-035 HW 001 Pin contact, crimp type 515-1501-055 P 101 8-pin receptacle housing 515-1501-050 S 001 Front Mounting Bracket Assembly Part No. 023-9750-012 Leaf switch SPST 583-1004-031 15 Watt, 4.0-Ohm Speaker (Black) HW 001 Self-drilling screw 1/4 (4) 575-9077-565 HW 002 Self-drilling screw #10 (4) 575-9077-545 Part No. 250-0151-006 HW001 Strain relief (in case back) 574-0003-008 HW002 Screw, self drilling 574-9077-543 MP 101 Knob 10-32 1/2 547-0016-007 HW003 Screw, 4-20 x 1/2 pan head 575-5604-016 MP 201 Transceiver mounting bracket 017-2226-034 HW005 Foam gasket 018-1126-001 HW006 Urethane foam, 1/16 thick 042-0361-318 HW008 Screw, 6-19 x 1/4 pan hd phillips 575-5606-008 HW009 Terminal lug 586-0005-106 LS001 Speaker, 5'' 15W 4.0 ohm 589-1016-003 MP001 Case front (black) 032-0758-004 MP002 Case back (black) 032-0759-004 EP002 Mic cord w/Hirose connector 597-2002-255 MP003 Mounting bracket (black) 032-0760-004 EP004 Terminal (on hanger) 022-0069-011 MP004 Tri knob 10-32 547-0016-004 HW001 Screw 4-20 x 3/8 575-5604-012 NP001 Overlay, speaker front 559-0072-010 HW004 Screw 2-56 x 3/8 575-1602-012 P 001 515-5010-055 MK001 Dynamic mic cartridge 589-1011-003 MP001 Case front black 032-0426-100 W 001 Speaker wire, 22 AWG (6 ft 597-2006-002 used) MP002 Case back black 032-0427-100 MP003 Actuator black 032-0428-050 15W 4.0-Ohm Motorcycle Speaker MP004 Cartridge gasket 032-0429-075 Part No. 250-0151-015 MP005 Blast filter 018-1033-002 MP006 Switch bracket 017-1885-030 Rubber switch boot 574-3500-153 MP007 Hanger button 013-1216-005 HW002 Screw, self drilling 574-9077-543 MP008 Crimp retainer 017-2222-006 HW003 Screw, 4-20 x 1/2 pan head 575-5604-016 MP009 Rubber bumper 018-0798-009 HW005 Foam gasket 018-1126-001 MP010 Backing plate 015-0876-026 HW006 Urethane foam, 1/16 thick 042-0361-318 MP011 Strain relief, mic cord 032-0429-086 575-5606-008 MP012 Shim support, rubber bumper 017-2222-007 HW008 Screw, 6-19 x 1/4 pan hd phillips MP020 Foam support 018-0798-012 HW009 Terminal lug 586-0005-106 NP001 Nameplate 559-0039-026 LS001 Speaker, 5'' 15W 4.0 ohm 589-1016-003 PC001 PC board, amplifier 035-0441-020 MP001 Case front (black) 032-0758-004 Q 001 NPN amplifier SOT-23 576-0003-658 032-0759-006 R 001 51k ohm ±5% 1/8W chip 569-0115-513 MP002 Case back, motorcycle (black) R 002 18 ohm ±5% 1/8W chip 569-0115-180 MP003 Mounting bracket (black) 032-0760-004 Amplified Dynamic Microphone Part No. 250-0740-310 C 001 3.3 µF 16V tantalum chip 510-2625-339 C 002 220 pF ±5% NPO 50V cer chip 510-3602-221 EP001 Contact .038" diameter 586-9008-100 87 Crimp wire contact HW001 Strain relief (in case back) 574-0003-008 MP004 Tri knob 10-32 547-0016-004 NP001 Overlay, speaker front 559-0072-010 S 001 583-0006-061 Switch, SPST toggle W 001 Speaker wire, motorcycle 023-0151-011 88 Ref No. Description smd Part No. HANDHELD CONTROL UNIT Part No. 250-5300-101 C 022 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 023 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 025 180 pF ±5% NPO 25V cer 510-3674-181 smd A 001 Main board assembly 023-5300-705 A 002 Keypad board assembly 023-5300-707 C 029 1.0 µF 10V tantalum smd 510-2624-109 A 130 Junction box assembly 023-5300-130 C 030 10 µF 25V tantalum smd 510-2627-100 C 031 4.7 µF 20V tantalum smd 510-2626-479 C 032 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 126 0.01 µF ±10% X7R 25V cer smd 510-3675-103 C 127 1.0 µF 10V tantalum smd 510-2624-109 C 128 1.0 µF 10V tantalum smd 510-2624-109 C 129 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 130 4.7 µF 25V tantalum smd 510-2627-479 C 131 10 µF 25V tantalum smd 510-2627-100 C 132 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 133 10 µF 25V tantalum smd 510-2627-100 C 134 10 µF 25V tantalum smd 510-2627-100 C 135 4.7 µF tantalum smd 510-2622-479 C 136 0.1 µF ±10% X7R 25V cer 510-3675-104 smd 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 137 0.01 µF ±10% X7R 25V cer smd 510-3675-103 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 138 1.0 µF 35V tantalum smd 510-2628-109 C 015 0.01 µF ±10% X7R 25V cer smd 510-3675-103 C 139 0.22 F 5.5V electrolytic 510-9510-055 C 016 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 140 10 µF 25V tantalum smd 510-2627-100 C 141 C 017 4.7 µF 25V tantalum smd 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 018 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 142 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 019 390 pF ±5% NPO 25V cer 510-3674-391 smd C 143 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 020 0.01 µF ±10% X7R 25V cer smd C 144 0.047 µF X7R ±10% cer smd C 021 0.1 µF ±10% X7R 25V cer 510-3675-104 C 145 0.1 µF ±10% X7R 25V cer 510-3675-104 smd (see separate listing) C 001 4.7 µF 25V tantalum smd C 002 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 003 10 µF 25V tantalum smd C 005 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 007 510-2627-479 510-2627-100 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 008 33 pF ±5% NPO 25V cer smd C 009 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 010 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 011 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 013 C 014 510-3674-330 510-2627-479 510-3675-103 89 510-3605-473 C 146 0.1 µF ±10% X7R 25V cer 510-3675-104 smd CR 004- 5.6V zener backlighting 523-2016-569 CR 11 CR 012 Pin switching diode 523-1504-001 CR 013 5.6V zener 523-2016-569 CR 020 5.6V zener 523-2016-569 CR 021 5.6V zener 523-2016-569 CR 023 5.6V zener 523-2016-569 CR 024 Dual color LED, red/grn 549-4001-215 CR 025- 5.6V zener 523-2016-569 MP 03a Keypad, rubber revised 032-0792-059 2 MP 03b Elastomeric connector 515-9900-010 MP 004 Fiber sheet 12 x 21 058-0021-002 MP 005 Fiber sheet 12 x 21 058-0021-002 MP 006 Gasket seal assembly 587-0792-048 MP 008 Front housing assembly 587-0792-058 MP 009 Water barrier, microphone 574-5300-001 MP 010 Lens, front housing 032-0792-052 MP 011 Lens gasket, front housing 574-3500-080 MP 012 Lens PSA, front housing 574-3500-082 NP 001 Label, EFJ logo front 559-5000-550 P 001 Connector, 11-pin single row 515-9036-021 P 003 Connector, 12-pin single row 515-5300-003 PC 001 Main PC board, rev 3 035-5300-700 3 PC 001 Keypad board, rev 0 035-5300-707 Q 002 NPN general purpose 576-0003-658 Q 004 NPN digital w/resistors 576-0003-616 Q 005 NPN digital w/resistors 576-0003-616 Q 006 NPN digital w/resistors 576-0003-616 Q 007 NPN general purpose 576-0003-658 CR 29 CR 030 Dual diodes, com anodes 523-1504-024 CR 031 Dual diodes, com anodes 523-1504-024 CR 033 Dual diodes, com anodes 523-1504-024 CR 034 Dual diodes, com anodes 523-1504-024 DS 001 LCD, glass 549-4501-011 DS 002 Fiber optics, backing 549-4501-032 DS 024 LED, green 549-4003-011 DS27-35 LED, green 549-4003-011 EP 001 586-0003-034 Spade terminal #6 HW 01a Screw, 6-32 x 5/16 575-1606-010 HW 01b Spacer, keypad board 013-1188-055 HW 01c Screw, 4-40 x 1/4 575-1604-008 HW 02a Screw, 2-56 x 5/8 Torx black 575-8002-020 HW 02b Washer, split lock #4 596-1304-008 Q 008 NPN general purpose 576-0003-658 HW 003 Lockwasher, internal #6 596-1106-009 Q 009 NPN general purpose 576-0003-658 J 003 515-5300-001 Q 010 PNP general purpose 576-0003-650 Q 012 Power MOSFET 20 volt 576-0006-243 Q 013 Power MOSFET 20 volt 576-0006-243 R 002 330k ohm ±5% 1/16W smd 569-0155-334 R 003 10k ohm ±5% 1/16W smd 569-0155-103 R 005 100k ohm ±5% 1/16W smd 569-0155-104 R 006 47k ohm ±5% 1/16W smd 569-0155-473 Connector, 12-pin socket .100 MK 001 Microphone cartridge 589-0301-003 MP 01a Mic hanger button 013-1216-007 MP 01b Display bezel 017-2226-048 3 MP 01c Mic element isolator 032-0757-834 MP 02a Back housing 032-0792-056 MP 02b Backplate, fiber optic 032-0792-054 90 R 007 47k ohm ±5% 1/16W smd 569-0155-473 R 065 10k ohm ±5% 1/16W smd 569-0155-103 R 008 47k ohm ±5% 1/16W smd 569-0155-473 R 066 3.3k ohm ±5% 1/16W smd 569-0155-332 R 009 47k ohm ±5% 1/16W smd 569-0155-473 R 067 2.2k ohm ±5% 1/16W smd 569-0155-222 R 010 47k ohm ±5% 1/16W smd 569-0155-473 R 068 10k ohm ±5% 1/16W smd 569-0155-103 R 011 2.2k ohm ±5% 1/16W smd 569-0155-222 R 069 10k ohm ±5% 1/16W smd 569-0155-103 R 012 2.2k ohm ±5% 1/16W smd 569-0155-222 R 070 10k ohm ±5% 1/16W smd 569-0155-103 R 013 2.2k ohm ±5% 1/16W smd 569-0155-222 R 071 2.2k ohm ±5% 1/16W smd 569-0155-222 R 015 200k ohm ±5% 1/16W smd 569-0155-204 R 072 47k ohm ±5% 1/16W smd 569-0155-473 R 016 200k ohm ±5% 1/16W smd 569-0155-204 R 073 47k ohm ±5% 1/16W smd 569-0155-473 R 017 2.2k ohm ±5% 1/16W smd 569-0155-222 R 074 47k ohm ±5% 1/16W smd 569-0155-473 R 018 2.2k ohm ±5% 1/16W smd 569-0155-222 R 075 47k ohm ±5% 1/16W smd 569-0155-473 R 019 300 ohm ±5% 1/8W smd 569-0105-301 R 076 47k ohm ±5% 1/16W smd 569-0155-473 R 021 100k ohm ±5% 1/16W smd 569-0155-104 R 077 10k ohm ±5% 1/16W smd 569-0155-103 R 022 300 ohm ±5% 1/8W smd 569-0105-301 R 078 10k ohm ±5% 1/16W smd 569-0155-103 R 028 100k ohm ±5% 1/16W smd 569-0155-104 R 079 5.1k ohm ±5% 1/16W smd 569-0155-512 R 029 100k ohm ±5% 1/16W smd 569-0155-104 R 080 300 ohm ±5% 1/16W smd 569-0155-301 R 034 2.2k ohm ±5% 1/16W smd 569-0155-222 R 082 47k ohm ±5% 1/16W smd 569-0155-473 R 040 10k ohm ±5% 1/16W smd 569-0155-103 R 083 3.3k ohm ±5% 1/16W smd 569-0155-332 R 042 10k ohm ±5% 1/16W smd 569-0155-103 R 084 10k ohm ±5% 1/16W smd 569-0155-103 R 043 4.7kohm ±5% 1/16W smd 569-0155-472 R 087 10k ohm ±5% 1/16W smd 569-0155-103 R 044 10k ohm ±5% 1/16W smd 569-0155-103 R 090 10k ohm ±5% 1/16W smd 569-0155-103 R 045 10k ohm ±5% 1/16W smd 569-0155-103 R 093 10k ohm ±5% 1/16W smd 569-0155-103 R 046 47k ohm ±5% 1/16W smd 569-0155-473 R 095 10k ohm ±5% 1/16W smd 569-0155-103 R 047 10k ohm ±5% 1/16W smd 569-0155-103 R 096 10k ohm ±5% 1/16W smd 569-0155-103 R 051 47k ohm ±5% 1/16W smd 569-0155-473 R 097 10k ohm ±5% 1/16W smd 569-0155-103 R 052 47k ohm ±5% 1/16W smd 569-0155-473 R 098 10k ohm ±5% 1/16W smd 569-0155-103 R 053 33k ohm ±5% 1/16W smd 569-0155-333 R 099 10k ohm ±5% 1/16W smd 569-0155-103 R 054 10k ohm ±5% 1/16W smd 569-0155-103 R 100 10k ohm ±5% 1/16W smd 569-0155-103 R 055 4.7k ohm ±5% 1/16W smd 569-0155-472 R 101 10k ohm ±5% 1/16W smd 569-0155-103 R 056 10k ohm ±5% 1/16W smd 569-0155-103 R 102 10k ohm ±5% 1/16W smd 569-0155-103 R 057 4.7k ohm ±5% 1/16W smd 569-0155-472 R 103 R 058 10k ohm ±5% 1/16W smd 569-0155-103 1.2M ohm ±5% 1/16W smd R 059 2.2k ohm ±5% 1/16W smd 569-0155-222 R 104 200k ohm ±5% 1/16W smd 569-0155-204 R 060 2.2k ohm ±5% 1/16W smd 569-0155-222 R 105 240k ohm ±5% 1/16W smd 569-0155-244 R 061 2.2k ohm ±5% 1/16W smd 569-0155-222 R 106 47k ohm ±5% 1/16W smd 569-0155-473 R 062 10k ohm ±5% 1/16W smd 569-0155-103 R 107 82k ohm ±5% 1/16W smd 569-0155-823 R 063 10k ohm ±5% 1/16W smd 569-0155-103 R 108 160k ohm ±5% 1/16W smd 569-0155-164 R 064 10k ohm ±5% 1/16W smd 569-0155-103 R 109 1k ohm ±5% 1/16W smd 91 569-0155-125 569-0155-102 R 110 10k ohm ±5% 1/16W smd 569-0155-103 R 153 1k ohm ±5% 1/8W smd 569-0115-102 R 111 47k ohm ±5% 1/16W smd 569-0155-473 R 154 1k ohm ±5% 1/8W smd 569-0115-102 R 112 100k ohm ±5% 1/16W smd 569-0155-104 R 155 1k ohm ±5% 1/8W smd 569-0115-102 R 113 100k ohm ±5% 1/16W smd 569-0155-104 R 156 1k ohm ±5% 1/8W smd 569-0115-102 R 114 100k ohm ±5% 1/16W smd 569-0155-104 R 115 1k ohm ±5% 1/16W smd 569-0155-102 S 001 10 Pos DIP switch 583-5100-210 R 116 47k ohm ±5% 1/16W smd 569-0155-473 S 022 Light touch switch 583-4020-015 R 118 10k ohm ±5% 1/16W smd 569-0155-103 S 027 Light touch switch 583-4020-015 R 119 2.2k ohm ±5% 1/16W smd 569-0155-222 S 029 Light touch switch 583-4020-015 R 120 2.2k ohm ±5% 1/16W smd 569-0155-222 S 030 583-9228-003 R 121 10k ohm ±5% 1/16W smd 569-0155-103 KT series switch, right angle R 122 47k ohm ±5% 1/16W smd 569-0155-473 R 123 47k ohm ±5% 1/16W smd 569-0155-473 U 002 Op amp, quad MC3303 544-2020-008 R 124 10k ohm ±5% 1/16W smd 569-0155-103 U 003 RS-485 bus transceiver ADM483 544-2023-073 R 125 2.2k ohm ±5% 1/16W smd 569-0155-222 U 009 510 ohm ±5% 1/8W smd Microcontroller MC68HC908 544-9100-007 R 126 R 127 10k ohm ±5% 1/16W smd 569-0155-103 U 012 544-2032-009 R 128 510 ohm ±5% 1/8W smd Regulator, 5V 300mA ADP3367 R 129 100k ohm ±5% 1/16W smd 569-0155-104 U 045 Non-inverting buffer, quad 544-3991-125 TC74VHC125 R 130 150 ohm ±5% 3/4W smd 569-0135-151 U 047 R 131 150 ohm ±5% 3/4W smd 569-0135-151 Regulator, 5V 300mA ADP3367 R 134 100 ohm ±5% 3/4W smd 569-0135-101 U 054 Schmitt trigger, hex 74C14 544-3991-014 R 135 100 ohm ±5% 3/4W smd 569-0135-101 U 056 544-3716-906 R 136 100 ohm ±5% 3/4W smd 569-0135-101 Open drain buffer, hex 74C906 R 137 100 ohm ±5% 3/4W smd 569-0135-101 U 057 Regulator, 5V 300mA ADP3367 544-2032-009 R 138 4.7k ohm ±5% 1/16W smd 569-0155-472 U 058 Regulator, 8V 0.5A 78M08 544-2003-081 R 139 4.7k ohm ±5% 1/16W smd 569-0155-472 U 059 Univ LCD driver PCF8576 544-2027-010 R 140 100k ohm ±5% 1/16W smd 569-0155-104 U 060 Univ LCD driver PCF8576 544-2027-010 R 141 100k ohm ±5% 1/16W smd 569-0155-104 U 061 100k ohm ±5% 1/16W smd 569-0155-104 Voltage reference, 2.5V LM4120 544-2032-008 R 142 R 143 100k ohm ±5% 1/16W smd 569-0155-104 U 062 D flip-flop TC7W74FU 544-1010-014 R 144 100k ohm ±5% 1/16W smd 569-0155-104 U 063 D flip-flop TC7W74FU 544-1010-014 R 145 180k ohm ±5% 1/16W smd 569-0155-184 R 146 100k ohm ±5% 1/16W smd 569-0155-104 W 001 Coil cord assembly 597-2002-272 R 147 100k ohm ±5% 1/16W smd 569-0155-104 W 503 R 150 10k ohm ±5% 1/16W smd 569-0155-103 Control cable, 17 ft. junc - 597-2002-267 xcvr R 151 10k ohm ±5% 1/16W smd 569-0155-103 Y 002 Crystal, 4.9152 MHz smd 521-3060-024 R 152 10k ohm ±5% 1/16W smd 569-0155-103 569-0115-511 569-0115-511 92 544-2032-009 HHC Junction Box Assembly Part No. 023-5300-130 510-2626-229 C 026 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 027 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 001 2.2 uF 20V tantalum smd C 002 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 028 1µF X7R ±10% 16V cer smd C 003 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 029 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 004 2.2 uF 20V tantalum smd C 030 C 005 0.1 µF ±10% X7R 25V cer 510-3675-104 smd 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 006 0.1 µF ±10% X7R 25V cer 510-3675-104 smd F 001 Fuse 2.0 A smd C 008 0.1 µF ±10% X7R 25V cer 510-3675-104 smd 510-2626-229 C 009 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 010 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 011 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 012 510-3606-105 534-5001-009 HW 001 Spacer, 4-40 Hex male/fem 013-1160-103 HW 002 Screw, 4-40 x .25 575-0604-008 HW 003 Screw, 8-18 hex hd sht mtl 575-3908-016 HW 004 Polarizing key box cnt 515-7109-010 J 001 Connector, 10-pin 515-7104-005 J 002 Connector, 15-pin PC mt female 515-0506-115 J 003 Connector, 15-pin 515-0506-119 J 005 3.6 mm (1/8) jack enclosed 515-2001-011 J 006 3.6 mm (1/8) jack enclosed 515-2001-011 J 007 2.5 mm (3/32) audio jack, 515-2002-040 stereo 1µF X7R ±10% 16V cer smd 510-3606-105 C 013 1µF X7R ±10% 16V cer smd 510-3606-105 C 014 1µF X7R ±10% 16V cer smd 510-3606-105 C 015 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 016 0.1 µF ±10% X7R 25V cer 510-3675-104 smd MP 002 Extrusion 014-0777-023 MP 003 Front Panel 017-5300-001 C 018 0.1 µF ±10% X7R 25V cer 510-3675-104 smd MP 004 Back Panel, revision 2 017-5300-003 2 C 019 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 020 0.1 µF ±10% X7R 25V cer 510-3675-104 smd C 021 C 022 MP 005 Mounting bracket, junction 017-5300-005 box MP 130 Fiber sheet, 12 x 21 058-0021-002 NP 001 Label, HHC junction box 559-5000-501 0.1 µF ±10% X7R 25V cer 510-3675-104 smd PC 001 PC board, junction box rev 035-5300-130 2 1µF X7R ±10% 16V cer smd 510-3606-105 Q 001 NPN general purpose 576-0003-658 Q 002 NPN general purpose 576-0003-658 C 023 2.2 uF 35V tantalum smd 510-2628-338 C 024 10 uF 25V tantalum smd 510-2627-100 R 001 30k ohm ±5% 1/16W smd 569-0155-303 C 025 0.1 µF ±10% X7R 25V cer 510-3675-104 smd R 002 20k ohm ±5% 1/16W smd 569-0155-203 R 003 220k ohm ±5% 1/16W smd 569-0155-224 93 R 004 39k ohm ±5% 1/16W smd 569-0155-393 R 040 20k ohm ±5% 1/16W smd 569-0155-203 R 005 62k ohm ±5% 1/16W smd 569-0155-623 R 041 100k ohm ±5% 1/16W smd 569-0155-104 R 006 62k ohm ±5% 1/16W smd 569-0155-623 R 042 20k ohm ±5% 1/16W smd 569-0155-203 R 007 10k ohm ±5% 1/16W smd 569-0155-103 R 043 20k ohm ±5% 1/16W smd 569-0155-203 R 008 1k ohm ±5% 1/16W smd 569-0155-102 R 044 20k ohm ±5% 1/16W smd 569-0155-203 R 009 2.7k ohm ±5% 1/16W smd 569-0155-272 R 045 100k ohm ±5% 1/16W smd 569-0155-104 R 010 8.2k ohm ±5% 1/16W smd 569-0155-822 R 046 20k ohm ±5% 1/16W smd 569-0155-203 R 012 20k ohm ±5% 1/16W smd 569-0155-203 R 047 100k ohm ±5% 1/16W smd 569-0155-104 R 013 30k ohm ±5% 1/16W smd 569-0155-303 R 049 150 ohm ±5% 1/16W smd 569-0115-151 R 014 20k ohm ±5% 1/16W smd 569-0155-203 R 050 10k ohm ±5% 1/16W smd 569-0155-103 R 015 20k ohm ±5% 1/16W smd 569-0155-203 R 051 10k ohm ±5% 1/16W smd 569-0155-103 R 016 20k ohm ±5% 1/16W smd 569-0155-203 R 017 220k ohm ±5% 1/16W smd 569-0155-224 S 001 544-1020-035 R 018 20k ohm ±5% 1/16W smd 569-0155-203 Relay, photo MOS 1.3A 100V R 019 39k ohm ±5% 1/16W smd 569-0155-393 S 002 Relay, photo MOS 1.3A 100V 544-1020-035 R 020 62k ohm ±5% 1/16W smd 569-0155-623 R 021 20k ohm ±5% 1/16W smd 569-0155-203 U 001 Op amp, quad MC3303 544-2020-008 R 022 62k ohm ±5% 1/16W smd 569-0155-623 U 003 Op amp, quad MC3303 544-2020-008 R 023 20k ohm ±5% 1/16W smd 569-0155-203 U 004 20k ohm ±5% 1/16W smd 569-0155-203 Audio amp, stereo 150 mW TPA122 544-2006-030 R 024 R 025 20k ohm ±5% 1/16W smd 569-0155-203 U 005 544-3016-066 R 026 200k ohm ±5% 1/16W smd 569-0155-204 Switch, bilateral MC14066B R 027 20k ohm ±5% 1/16W smd 569-0155-203 U 006 Op amp, quad MC3303 544-2020-008 R 028 20k ohm ±5% 1/16W smd 569-0155-203 U 007 Comparator, dual LM2903 544-2025-009 R 029 20k ohm ±5% 1/16W smd 569-0155-203 U 009 Regulator, 5V 0.5A 78M05 544-2003-079 R 030 20k ohm ±5% 1/16W smd 569-0155-203 R 031 20k ohm ±5% 1/16W smd 569-0155-203 R 032 300 ohm ±5% 1/16W smd 569-0155-301 R 033 300 ohm ±5% 1/16W smd 569-0155-301 R 034 20k ohm ±5% 1/16W smd 569-0155-203 R 035 20k ohm ±5% 1/16W smd 569-0155-203 R 036 20k ohm ±5% 1/16W smd 569-0155-203 R 037 100k ohm ±5% 1/16W smd 569-0155-104 R 038 20k ohm ±5% 1/16W smd 569-0155-203 R 039 20k ohm ±5% 1/16W smd 569-0155-203 SIREN CONTROLLER KIT Part No. 250-5300-101 A 001 Siren wire kit 023-5300-101 (see separate listing) A 015 Siren system, w/ctrlr, amp, 585-5300-015 cable Siren Wire Kit Part No. 023-5300-101 F 001 Fuse, 15A 32V 534-0332-015 94 FH001 Fuseholder, in-line 534-1100-003 HW001 Ring terminal, 1/4 12-16 AWG 586-0001-150 HW002 Solder splice terminator .100-.175 586-0007-085 W 001 Wire, zip cord 14 AWG 597-2006-004 W 002 Wire, 14 AWG black stranded 597-7021-400 W 003 Wire, 14 AWG red stranded 597-7021-402 REMOTE PROG. INTERFACE (RPI) Part No. 023-5300-000 J 004 Header, 10-pin shrouded 515-7104-005 J 007 Jack, 2-pin sgl in-line hdr 515-7100-002 J 008 Jack, mini enclosed 515-2002-011 MP 001 Extruded metal enclosure 014-0777-021 MP 002 Back panel (DB9 end) 017-2206-017 MP 003 Front panel (LED end) 017-2206-016 MP 007 Spacer, 4-40 hex male/female 013-1160-103 NP 001 ID/nameplate 559-5000-500 PC 001 PC board 035-5300-030 Q 001 NPN general purpose SOT- 576-0003-658 23 Q 005 NPN general purpose SOT- 576-0003-658 23 C 003 .1 µF ±10% X7R 50V smd 510-3606-104 C 004 .1 µF ±10% X7R 50V smd 510-3606-104 C 005 .1 µF ±10% X7R 50V smd 510-3606-104 C 010 10 µF 25V tantalum smd 510-2627-100 C 011 10 µF 25V tantalum smd 510-2627-100 C 014 4.7 µF 10V tantalum smd 510-2624-479 C 015 4.7 µF 10V tantalum smd 510-2624-479 R 009 1k ohm ±5% 1/8w SMD 569-0115-102 C 016 10 µF 16V tantalum smd 510-2625-100 R 010 200 ohm ±5% 1/8W smd 569-0115-201 C 017 10 µF 16V tantalum smd 510-2625-100 R 012 10k ohm ±5% 1/8W smd 569-0105-103 C 018 10 µF 25V tantalum smd 510-2627-100 R 013 10k ohm ±5% 1/8W smd 569-0105-103 R 020 10k ohm ±5% 1/8W smd 569-0105-103 CR 001 Schottky diode, 1A/100V 523-0519-031 R 024 10k ohm ±5% 1/8W smd 569-0115-103 CR 002 Schottky diode, 1A/100V 523-0519-031 R 025 3k ohm ±5% 1/8W smd 569-0115-302 CR 003 Schottky diode, 1A/100V 523-0519-031 R 028 3k ohm ±5% 1/8W smd 569-0115-302 CR 004 Schottky diode, 1A/100V 523-0519-031 R 029 3k ohm ±5% 1/8W smd 569-0115-302 CR 006 Switching diode SOT-23 523-1504-002 R 032 10k ohm ±5% 1/8W smd 569-0115-103 CR 007 Switching diode SOT-23 523-1504-002 R 035 300 ohm ±5% 1/8W smd 569-0115-301 CR 008 5.6V zener SOT-23 523-2016-569 R 036 3k ohm ±5% 1/8W smd 569-0115-302 DS 001 Red/grn LED rt angle 549-4006-001 R 037 Zero ohm ±5% 1/8W smd 569-0115-001 R 038 10k ohm ±5% 1/8W smd 569-0105-103 R 039 10k ohm ±5% 1/8W smd 569-0115-103 R 040 10k ohm ±5% 1/8W smd 569-0115-103 HW 006 Screw, TT 4-40 x .25 pan hd 575-0604-008 HW 012 Polarizing key 515-7109-010 R 041 100k ohm ±5% 1/8W smd 569-0115-104 J 001 Jack, 3.6 mm enclosed 515-2001-011 S 009 DIP switch, 8-pos SPST J 002 Jack, 9-pos PC mt 515-0506-043 J 003 Jack, power PC mt 515-2007-010 U 001 Regulator, 5V 0.5A 78M05 544-2003-079 95 583-5100-108 U 004 RS-232 rx/tx, dual MAX232 544-2023-019 U 005 RS-485 bus xcvr SN65176 544-2023-027 U 006 Ref No. Schmitt trigger 74HC14 544-3766-014 Description Part No. VHF RF BOARD B11 PCA, VHF, RF, TRANSCEIVER, EFJ E3,E4,J3,L5,L9,L12,L16,L26,L49,L82,P1,P2,P3,R7,R18,R19, R21,R22,R28,R29,R30,R40,R82,R85,R106,R107 NOT PLACED NP C1,C10,C13,C21,C26,C36,C37,C45,C229,C232,C242,C318 NOT PLACED NP J2 PCB, FLEX, EFJ 0P795/D PCB, VHF, RF TRANSCEIVER, EFJ 0P811/B CP1,CP2,CP3,CP4 CAP, 4 UP, 47 PF, ±10%, 50V, NPO, 1206 1C424-470 C2,C6,C42,C43,C44,C47,C96,C97,C99,C109,C120,C121,C141, C164,C182,C192,C195,C285,C288,C291,C304 CAP, CER, 0.1 UF, ±10%,10V, X7R, 0603 1C455-104 C3,C19,C55,C126,C135,C136,C142,C143,C181,C193,C194, C287,C292,C305 CAP, CER, 100 PF, ±5%, NPO, 0603 1C113-101 C4,C20,C29,C69,C101,C102,C106,C110,C111,C114,C127,C128, CAP, CER, 0.01 UF, ±10%, X7R, 0603 C129,C130,C131,C134,C137,C140,C145,C150,C151,C152,C153, C163,C169,C176,C189,C199,C200 1C148-103 C5 CAP, PPS FILM, .0047 UF, ±5%, 16V, LOW ESR, 0805 1C478-472 C7,C9 CAP, CER, 180 PF, NPO, 0603 1C113-181 C8,C274,C303 CAP, CER, 10 PF, ±5%, NPO, 0603 1C113-100 C11,C14,C17,C23,C24,C25,C33,C34,C46,C48,C49,C50,C61,C62, CAP, CER 1000 PF, ±5%, NPO, 0603 C63,C65,C67,C70,C95,C107,C113,C118,C122,C148,C149,C155, C156,C157,C159,C162,C165,C166,C167,C205,C206,C222,C223, C224,C225,C226,C240,C276,C295,C296,C297,C299,C300,C301, C307 1C113-102 C12 CAP, PPS FILM, 0.018 UF. ±5%, 16V, 3216 1C733-B183 C15,C298 CAP, CER, 47 PF, ±5%, NPO, 0603 1C113-470 C16 CAP, PPS FILM, .015 UF, ±5%, 16V, 3216 1C478-153 C18,C230,C234,C235,C277 CAP, CER, 39 PF, ±2%, NPO, 0603 1C731-390 C22 CAP, PPS FILM, 0.68 UF, ±10%, 16V, LOW ESR, 3216 1C478-684 C27,C272,C273,C312,C313 CAP, CER, 3.3 PF, ±0.25 PF, 0603 1C450-3R3 C28 CAP, FILM, 0.15 UF, ±20%, 16V, 3216 1C353-J154 96 C30,C293 CAP, PPS FILM, 0.22 UF, ±10%, 25V, LOW ESR, 3216 1C478-224 C31,C139 CAP, CER, 200 PF, ±5%, NPO, 0603 1C113-201 C32 CAP, TANT, 4.7 UF, ±20%, 16V, B CASE 1C166-475 C35,C125,C132,C133,C168,C171,C174,C175,C202,C203,C286, C289,C290,C302 CAP, TANT, 4.7 UF, ±20%, 16V, A CASE 1C573-A475 C38,C115 CAP, CER, 33 PF, ±5%, NPO, 0603 1C113-330 C39 CAP, CER, 8.2 PF, ±0.25 PF, 0603 1C450-8R2 C40 CAP, CER, 1.0 PF, ±0.1 PF, NPO, 0603 1C731-1R0 C41,C90,C294 CAP, CER, 470 PF, ±5%, NPO, 0603 1C113-471 C51,C72 CAP, CER, 22 PF, ±5%, LOW E, NPO, 0603 1C731-220 C56 CAP, CHIP, 1.0 UF, ±20%, 10V, X7R, 0603 PKG 73550 C60 CAP, CER, 18 PF, ±5%, NPO, 0603 1C113-180 C64 CAP, CER, 15 PF, ±2%, LOW ESR, HIGH-Q, 0603 1C731-150 C68,C241 CAP, CER, 12 PF, ±5%, NPO, 0603 PKG 1C113-120 C89 CAP, CER, 5.6 PF, ±0.25 PF, 0603 1C450-5R6 C98,C123,C154,C284 CAP, TANT, 10 UF, ±20%, 10V, A CASE 1C117-106 C100,C108,C112,C116,C117 CAP, CER, 56 PF, ±5%, NPO, 0603 1C113-560 C103 CAP, CER, 0.012 UF, ±5%, 50V, X7R, 0805 1C399-123 C104,C160,C311 CAP, CER, 4700 PF, ±10%, X7R, 0603 1C148-472 C105,C146,C147,C161,C172,C177,C196,C310 CAP, TANT, 1.0 UF, ±20%, 16V, A CASE 1C118-105 C119,C236,C237 CAP, CER, 82 PF, ±2%, LOW ESR, HI- 1C731-820 Q, 0603 C138 CAP, CER, 0.022 UF, ±10%, 50V, X7R, 1C143-223 0805 C144 CAP, CER, 2200 PF, ±10%, X7R, 0603 1C148-222 C158 CAP, CER, 120 PF, ±5%, NPO, 0603 1C113-121 C210 CAP, CER, 82000 PF, ±10%, X7R, 0603 1C148-823 C231,C233,C238,C239 CAP, CER, 6.2 PF, ±0.1 PF, LOW ESR, 1C731-6R2 HI-Q, 0603 C270 CAP, CER, 2.7 PF, ±0.25 PF, NPO, 0603 1C113-2R7 C271 CAP, CER, 6.8 PF, ±0.1 PF, LOW ESR, 1C731-6R8 HI-Q, 0603 97 C306 CAP, FILM CHIP, 1200 PF, ±5%, 16V, 0805 73697 C308 CAP, FILM CHIP, 4700 PF, ±5%, 16V, 0805 73699 C309 CAP, FILM CHIP, 3300 PF, ±5%, 16V, 0805 73698 D4,D10 TRANS, MOSFET, P-CH, SOT23 1T158SI2323 D9 DIODE, SILICON, TUNING, SOT23, MV2105 72672 D12,D13 DIODE, PIN, HIGH AVG POWER SMQ, MELF 72663 EC1 SHIELD,COVER, IF LARGE 3M797-2 EC2 SHIELD, COVER, IF SMALL 3M809-2 EC5 SHIELD, COVER, PLL 3M813-2 EC7 SHIELD, POWER AMPLIFIER 3M800 EC9 CLIP, GROUND, 3638001000 72673 EC10 CLIP, SPRINGS, 97-251-02 72674 E1 SHIELD, FENCE, IF LARGE 3M797-1 E2 SHIELD, FENCE, IF SMALL 3M809-1 E5 SHIELD, FENCE, PLL 3M813-1 FB1,FB2,FB3 INDUCTOR, FERRITE LEAD, SMT, 0121 1L1371210S0 FB4,FB5,FB6,FB7,FB8,FB9,FB10 INDUCTOR, FERRITE BEAD, SMT, 0805 1L137-3 F1 FUSE, FAST-ACTING, 2A, SMT, 0603 1X619-2R0 J1 CONN, COAX PLUG, SMT L1,L2,L7 INDUCTOR, 270 NH, ±2%, SMT, 1008 1L498-271 L3 INDUCTOR, 68 NH, ±10%, SMT, 1008 1L190-680 L4 INDUCTOR, 390 NH, ±5%, SMT, 0603 1L177-391 L6,L8 INDTR, 12 NH, ±2%, SMT, 0603 1L177-120G L10,L33 INDTR, 120 NH, ±2%, SMT, 0603 1L177-121G L11,L21,L22 INDTR, CHIP, 51 NH, ±2%, HIGH-Q, 0805 78261 L19,L32,L36 INDTR, 180 NH, ±2%, SMT, 0603 1L177-181G L27 INDTR, CHIP, 180 NH, ±2%, 1008 PKG 78126 L28 INDUCTOR, 150 UH, ±10%, 1210 1L514-154 L29,L30 INDUCTOR, WIREWOUND, 10 UH, 1206 1L575-102 L31 INDUCTOR, 220 NH, ±10%, SMT, 1008 1L190-221 98 1J607-2 L35 INDUCTOR, 39 NH, ±5%, SMT, 0603 1L177-390 L40 INDUCTOR, 100 NH, ±5%, SMT, 0603 1L177-101 L44 INDUCTOR, 82 NH, ±5%, SMT, 0603 1L177-820 L46,L47,L48 INDTR, CHIP, 470 NH, 5%, 0603LS 1L835-471 L50,L51,L53,L54 INDTR, 150 NH, ±2%, SMT, 1008 (REFERENCE 78127) 1L498-151 L77,L78 INDTR, 72 NH, ±2%, SMT, 0603 1L177-720G L81 INDUCTOR, 330 NH, ±5%, SMT, 0603 1L177-331 MX1 MIXER, 100-500 MHZ, 7 DB CL, 5 DBM LO 72668 P4,P5,P6,P7,P8 SPRING CONTACT,ELECTRICAL 3C799 Q1,Q2 TRANSISTOR, SMT, NPN, SS RF, SOT-2 1T153-941 Q3,Q4,Q5,Q6,Q7 TRANSISTOR, MOSFET, RDSO, SOT- 1T15923 7002CT RP1 RES, ARRAY, 1K X 4, SMT 1R230-102 R1 RES, 18K, ±5%, SMT, 0603 1R105-183 R2,R6 RES, 560 OHM, ±5%, SMT, 0603 1R105-561 R3 RES, 12K OHM, ±5%, SMT, 0603 1R105-123 R4,R62,R64 RES, 120 OHM, ±5%, SMT, 0603 1R105-121 R5,R8,R109 RES, 620 OHM, ±5%, SMT, 0603 1R105-621 R9 RES, CHIP, 390K OHM, ±5%, 0603 PKG 75886 R10,R113 RES, 240 OHM, ±5%, SMT, 0603 1R105-241 R11,R15,R43,R52,R59,R98 RES, 1.0K OHM, ±5%, SMT, 0603 1R105-102 R12,R14,R32,R42,R58,R69,R76,R102,R103 RES, 10K OHM, ±5%, SMT, 0603 1R105-103 R13 RES, 30 OHM, ±5%, SMT, 0603 1R105-300 R16 RES, CHIP, 12 OHM, ±5%, 0603 PKG 75476 R17 RES, 200 OHM, ±5%, SMT, 0603 1R105-201 R20,R45,R57,R60,R79,R83,R84,R86,R87,R88,R108,R124,R125, RES, 0 OHM, ±5%, SMT, 0603 R126,R130 1R105-0R0 R23,R48,R70,R116 1R105-510 RES, 51 OHM, ±5%, SMT, 0603 R24,R33,R34,R35,R73,R74,R77,R78,R81,R111,R112,R114,R115 RES, 330 OHM, ±5%, SMT, 0603 1R105-331 R25,R27 RES, 470 OHM, ±5%, SMT, 0603 1R105-471 R26 RES, 10 OHM, ±5%, SMT, 0603 1R105-100 R31 RES, 160 OHM, ±5%, SMT, 0603 1R105-161 R36,R117 RES, 2.7K, ±5%, SMT, 0603 1R105-272 R37 RES, 22K OHM, ±5%, SMT, 0603 1R105-223 99 R38 RES, 6.2K, ±5%, SMT, 0603 1R105-622 R39 RES, 36K, ±5%, SMT, 0603 1R105-363 R41 RES, 15K, ±5%, SMT, 0603 1R105-153 R44 RES, 3K OHM, ±5%, SMT, 0603 1R105-302 R46,R54 RES, 220 OHM, ±5%, SMT, 0603 1R105-221 R47,R49,R71,R119 RES, 100 OHM, ±5%, SMT, 0603 1R105-101 R50 RES, 24 OHM, ±5%, SMT, 0603 1R105-240 R51 RES, 3.9K OHM, ±5%, SMT, 0603 1R105-392 R53 RES, 4K OHM, ±5%, SMT, 0603 1R105-473 R55,R61 RES, 100K OHM, ±5%, SMT, 0603 1R105-104 R56 RES, 1.0M OHM, ±5%, SMT, 0603 1R105-105 R63,R65,R66,R67 RES, 75 OHM, ±5%, SMT, 0603 1R105-750 R68 RES, 9.1 OHM, ±5%, SMT, 1206 1R103-9R1 R72 RES, 62 OHM, ±5%, SMT, 0603 1R105-620 R80 RES, 18 OHM, ±5%, SMT, 0603 1R105-180 R99,R100,R101 RES, 390 OHM, ±5%, SMT, 0603 1R105-391 R104,R105 RES, 4.7K OHM, ±5%, SMT, 0603 1R105-472 R110 RES, 270K OHM, ±5%, SMT, 0603 1R105-274 R118 RES, CHIP, 82 OHM, 5%, 0603 75449 R121,R122 RES, CHIP, 1.6K OHM, ±1%, 0603 75885 R123 RES, 2.0K OHM, ±5%, SMT, 0603 1R105-202 U1 VCO, 200-239 MHZ, UMZ-1154-D16 4V510-11 U2,U25 CRYSTAL, 64.455 MHZ, SMT 1Y496-4 U3 MODULE RF AMP, 135-175MHZ, 6.5W 1Q129RA07M U6 IC, RF AMP, 150-2500 MHZ, GAAS HBT 1Q129RF2361 U7 SWITCH, PHEMT, SPDT, DC-2.5 GHZ, 71728 AS169-73 U9 IC, TEMP SENSOR, -40 TO +125, SOT 1Q126LM50B1Z U10,U27,U34 IC, REG, LOW DROP OUT, 5.0V, SMT, 1Q127-7081SO 50 U11 IC, IF DIGITIZING SUB-SYSTEM, SM 1Q130-9864 U12,U13 IC, REG, LOW DROP OUT, 3.3V, SMT, 1Q127-7081SO 33 U14,U15 IC, CMOS, SCHMMIT INVERTER, SINGLE 100 1Q12874V1G14S
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.3 Linearized : No Modify Date : 2005:02:07 14:07:31-06:00 Create Date : 2005:02:07 14:07:12-06:00 Title : Microsoft Word - 4300ServMan-VHF.doc Creator : PScript5.dll Version 5.2.2 Producer : Acrobat Distiller 6.0.1 (Windows) Page Count : 50EXIF Metadata provided by EXIF.tools