Elbit Systems Land and C4I Tadiran MICOM-DS125W Licensed Non-Broadcast Station Transmitter - MICOM Z-Dash User Manual MICOM Z MME fp

Elbit Systems Land and C4I - Tadiran Ltd. Licensed Non-Broadcast Station Transmitter - MICOM Z-Dash MICOM Z MME fp

Service Manual

Download:
Mirror Download [FCC.gov]
Document ID	2016247
Application ID	W077Lh64Jn20Iu0nb+DUzg==
Document Description	Service Manual
Short Term Confidential	No
Permanent Confidential	No
Supercede	No
Document Type	User Manual
Display Format	Adobe Acrobat PDF - pdf
Filesize	476.4kB (5954980 bits)
Date Submitted	2013-07-15 00:00:00
Date Available	2013-07-16 00:00:00
Creation Date	2011-01-04 09:55:49
Producing Software	GPL Ghostscript 8.15
Document Lastmod	2012-10-11 14:37:48
Document Title	Microsoft Word - MICOM-Z-MME-fp.doc
Document Creator	PScript5.dll Version 5.2
Document Author:	Owner

MM-E 2072-09333-00
SERVICE MANUAL
FOR
MICOM-Z
HF-SSB TRANSCEIVERS
Revision A
JULY 2011
MM-E 2072-09333-00
WARNINGS, CAUTIONS AND NOTES
The following notations are used to place special emphasis on procedures, or to call attention to
precautionary measures.
WARNING
An operating procedure, practice and so forth, which if not followed
correctly, could result in personal injury, or loss of life.
CAUTION
An operating procedure, practice and so forth, which if not followed
correctly, could result in damage to, or destruction of equipment.
NOTE
An operating procedure, condition and so forth, to which special
attention should be paid.
GENERAL SAFETY PRECAUTIONS
Review Micom-Z Operator Manual with respect to safety precautions,
and installation and operation instructions. In particular, remember that
during transmission, high RF voltages may appear at internal points of
the printed circuit board, at the radio set and test station RF
connectors, the antenna cable, and on the dummy load or antenna
connected to the radio. Avoid touching the antenna and the RF
connectors of a radio set while it operates.
Operating and maintenance personnel must be familiar with the
applicable safety requirements before attempting to install, operate or
maintain the radio set.
WARNING
The backup battery is a Lithium battery that contains dangerous
chemicals. Handle and dispose of batteries according to the
prescribed safety regulations. In particular, observe the following
precautions:
1. Do not short-circuit the battery.
2. Do not damage battery case and do not tamper with battery in any
way.
3. Do not expose to heat or flame.
4. Do not dispose of used batteries by burning.
MM-E 2072-09333-00
SAFETY SUMMARY
The following are general safety precautions that are not related to any specific procedures and
therefore do not appear elsewhere in this publication. These are recommended precautions that
personnel must understand and apply during various phases of operation and maintenance.
KEEP AWAY FROM LIVE CIRCUITS. Operating personnel must at all times observe all safety
regulations. Do not replace components or make adjustments inside the equipment with the high
voltage supply turned on. Under certain conditions, dangerous potentials may exist even when the
power control is in the OFF position, due to charges retained by capacitors. To avoid casualties,
always remove power and discharge and ground a circuit before touching it.
DO NOT SERVICE OR ADJUST ALONE. Under no circumstances should any person reach into the
equipment enclosure for the purpose of servicing or adjusting the equipment except in the presence of
someone who is capable of rendering aid.
RESUSCITATION. Personnel working with or near high voltages should be familiar with modern
methods of resuscitation.
USE SAFETY APPROVED EQUIPMENT. When cleaners and primers are being applied, approved
explosion-proof lights, blowers, and other equipment shall be used. Insure that firefighting equipment is
readily available and in working order.
GIVE CLEANERS SPECIAL CARE. Keep cleaners in special polyethylene bottles or in safety cans
and in minimum quantities. Discard soiled cleaning cloths into safety cans.
ii
MM-E 2072-09333-00
TABLE OF CONTENTS
Page
Chapter 1
1-1.
Chapter 2
INTRODUCTION
SCOPE .......................................................................................................................... 1-1
THEORY OF OPERATION
Section I. GENERAL DESCRIPTION............................................................................................ 2-1
2-1.
MICOM-Z DESCRIPTION ............................................................................................. 2-1
2-2.
2-3.
2-1.1
2-1.2
2-1.3
Micom-Z Dash-Mount Version ................................................................................... 2-1
Micom-Z Trunk-Mount Version .................................................................................. 2-9
Micom-Z Cooling Tray ............................................................................................. 2-15
2-3.1
2-3.2
Micom-Z Connector Data......................................................................................... 2-17
Cooling Tray Connectors ......................................................................................... 2-19
OPTIONS AND ACCESSORIES................................................................................. 2-16
CONNECTOR DATA................................................................................................... 2-17
Section II. CIRCUIT ANALYSIS ................................................................................................... 2-21
2-4.
LORD MODULE .......................................................................................................... 2-21
2-4.1
2-4.2
2-4.3
2-4.4
2-4.5
2-4.6
2-4.7
2-4.8
2-4.9
2-4.10
Audio Subsystem..................................................................................................... 2-21
DSP Subsystem....................................................................................................... 2-21
ISB Option ............................................................................................................... 2-22
IF and RF Transmit Path ......................................................................................... 2-22
RF Front End ........................................................................................................... 2-25
Receive IF Path ....................................................................................................... 2-26
Synthesizer Subsystem ........................................................................................... 2-26
Main Microcomputer Subsystem ............................................................................. 2-29
Power Supply Subsystem........................................................................................ 2-30
LORD Module Test Point Data ................................................................................ 2-31
2-5.1
2-5.2
2-5.3
2-5.4
2-5.5
2-5.6
Power Amplifier (PA) ............................................................................................... 2-33
TX/RX Switch........................................................................................................... 2-33
Harmonic Filter Bank ............................................................................................... 2-33
Power Sensor .......................................................................................................... 2-34
ALC Circuits............................................................................................................. 2-34
Power Supply Subsystem........................................................................................ 2-37
2-6.1
2-6.2
CONTROL HEAD Module for Dash-Mount Version................................................. 2-38
CONTROL HEAD Module for Trunk-Mount Version ................................................ 2-40
2-5.
HI POWER MODULE.................................................................................................. 2-33
2-6.
CONTROL HEAD MODULE........................................................................................ 2-38
2-7.
2-8.
INTERCONNECTION MODULE ................................................................................. 2-42
FAN CONTROL MODULE .......................................................................................... 2-42
Chapter 3
MAINTENANCE
3-1.
3-2.
3-3.
3-4.
SCOPE .......................................................................................................................... 3-1
HANDLING PRECAUTIONS DURING MAINTENANCE .............................................. 3-1
CLEANING .................................................................................................................... 3-3
TESTING ....................................................................................................................... 3-3
3-5.
TROUBLESHOOTING .................................................................................................. 3-4
3-6.
MICOM-Z REPAIR PROCEDURES ............................................................................ 3-21
3-4.1
3-4.2
Micom-Z Testing ........................................................................................................ 3-3
Module Testing and Alignment .................................................................................. 3-3
3-5.1
3-5.2
3-5.3
3-5.4
3-5.5
Overview of Troubleshooting Procedures.................................................................. 3-4
BIT Error Codes......................................................................................................... 3-4
Troubleshooting Procedure ....................................................................................... 3-6
Micom-Z Troubleshooting Charts .............................................................................. 3-9
Module Troubleshooting Procedures....................................................................... 3-16
3-6.1
3-6.2
Micom-Z Dash-Mount Version Repair ..................................................................... 3-21
Repair of Micom-Z Trunk-Mount Version................................................................. 3-27
Appendix A SCHEMATIC CIRCUIT DIAGRAMS
Appendix B PARTS LISTS
Section I. MICOM-Z DASH-MOUNT VERSION ............................................................................ B-1
Section II. MICOM-Z TRUNK-MOUNT VERSION........................................................................ B-93
Section III. COOLING TRAY ....................................................................................................... B-119
iii
MM-E 2072-09333-00
LIST OF ILLUSTRATIONS
Page
Figure 2-1.
Figure 2-2.
Figure 2-3.
Figure 2-4.
Figure 2-5.
Figure 2-6.
Figure 2-7.
Figure 2-8.
Figure 2-9.
Figure 2-10.
Figure 2-11.
Figure 2-12.
Figure 2-13.
Figure 2-14.
Figure 2-15.
Figure 2-16.
Figure 2-17.
Figure 2-18.
Figure 2-19.
Figure 2-20.
Micom-Z Dash-Mount Version Structure .................................................................................. 2-1
Micom-Z Dash-Mount Wiring Diagram ..................................................................................... 2-2
Micom-Z Dash-Mount Version, Functional Block Diagram...................................................... 2-5
Frequency Conversion Scheme................................................................................................ 2-7
Transmit Path Frequency Conversion Scheme ....................................................................... 2-8
Receive Path Frequency Conversion Scheme......................................................................... 2-8
Micom-Z Trunk-Mount Version, Structure of Body Assembly ................................................. 2-9
Micom-Z Trunk-Mount Version, Structure of Control Head ................................................... 2-10
Micom-Z Trunk-Mount Wiring Diagram .................................................................................. 2-11
Micom-Z Trunk-Mount Version, Functional Block Diagram................................................... 2-13
Micom-Z Cooling Tray Structure ............................................................................................. 2-15
LORD Module, Block Diagram ................................................................................................ 2-23
Synthesizer 1, Functional Block Diagram ............................................................................... 2-27
Synthesizer 2, Functional Block Diagram ............................................................................... 2-28
LORD Module, Typical Test Point Signal Frequencies and Levels....................................... 2-31
LORD Test Points Map............................................................................................................ 2-32
HI POWER Module, Functional Block Diagram ..................................................................... 2-35
CONTROL HEAD Module for Dash-Mount Version, Functional Block Diagram ................. 2-38
CONTROL HEAD Module for Trunk-Mount Version, Functional Block Diagram................. 2-40
INTERCONNECTION Module, Functional Block Diagram ................................................... 2-42
Figure 3-1.
Figure 3-2.
Figure 3-3.
Figure 3-4.
Figure 3-5.
Figure 3-6.
Figure 3-7.
Figure 3-8.
Figure 3-9.
Figure 3-10.
Figure 3-11.
Figure 3-12.
Figure 3-13.
Figure 3-14.
Figure 3-15.
Figure 3-16.
Figure 3-17.
Figure 3-18.
Figure 3-19.
MICOM-Z Checkout Chart......................................................................................................... 3-9
MICOM-Z Troubleshooting Chart 1......................................................................................... 3-11
MICOM-Z Troubleshooting Chart 2......................................................................................... 3-12
MICOM-Z Troubleshooting Chart 3......................................................................................... 3-13
MICOM-Z Troubleshooting Chart 4......................................................................................... 3-14
MICOM-Z Troubleshooting Chart 5......................................................................................... 3-15
MICOM-Z Troubleshooting Chart 6......................................................................................... 3-15
MICOM-Z Troubleshooting Chart 7......................................................................................... 3-16
Receiver Troubleshooting Flowchart ...................................................................................... 3-17
Transmitter Troubleshooting Flowchart ................................................................................. 3-19
Gaining Access to Modules ..................................................................................................... 3-21
Micom-Z with Front Panel Removed....................................................................................... 3-21
Removal of LORD Assembly................................................................................................... 3-22
Removal of LORD Module....................................................................................................... 3-23
Removal of HI POWER Module.............................................................................................. 3-25
Replacement of CONTROL HEAD Module............................................................................ 3-26
Gaining Access to Micom-Z Trunk-Mount Version Modules ................................................. 3-27
Micom-Z Trunk-Mount Version with Front Cover Removed.................................................. 3-27
Replacement of CONTROL HEAD Module............................................................................ 3-29
Figure A-1.
Figure A-2.
Figure A-3.
Figure A-4.
Figure A-5.
LORD Module, Schematic Circuit Diagram .............................................................................A-3
HI POWER Module, Schematic Circuit Diagram ...................................................................A-39
CONTROL HEAD Module, Schematic Circuit Diagram) .......................................................A-63
INTERCONNECTION Module, Schematic Circuit Diagram..................................................A-69
FAN CONTROL Module, Schematic Circuit Diagram ...........................................................A-65
iv
MM-E 2072-09333-00
LIST OF ILLUSTRATIONS (Cont'd)
Page
Figure B-1.
Figure B-2.
Figure B-3.
Figure B-4.
Figure B-5.
Figure B-6.
Figure B-7.
Figure B-8.
Figure B-9.
Figure B-10.
Figure B-11.
Figure B-12.
Figure B-13.
Micom-Z Assembly Dash Version ............................................................................................B-2
LORD Assembly.........................................................................................................................B-4
LORD Module, Identification of Components ........................................................................B-55
HI POWER Module, Identification of Components ................................................................B-74
Dash Front Panel, Control Head Assembly............................................................................B-79
CONTROL HEAD Module (Dash Mount Version), Identification of Components................B-91
Micom-Z Assembly, Trunk Version ........................................................................................B-94
Trunk Front Panel, Control Head Assembly...........................................................................B-98
CONTROL HEAD Module (Trunk Mount Version), Identification of Components .............B-113
INTERCONNECTION Module, Identification of Components.............................................B-118
Cooling Tray Assembly ..........................................................................................................B-119
FAN CONTROL Module, Identification of Components ......................................................B-120
Fan Harness Assembly..........................................................................................................B-121
MM-E 2072-09333-00
LIST OF TABLES
Page
Table 2-1.
Table 2-2.
Table 2-3.
Table 2-4.
Table 2-5.
Table 2-6.
Table 2-7.
Table 2-8.
Available Options...................................................................................................................... 2-16
Accessories .............................................................................................................................. 2-16
Micom-Z Microphone Connector, Pin Functions .................................................................... 2-17
ACCESSORY Connector Pin Functions................................................................................. 2-17
Micom-Z VDC IN Power Connector, Pin Functions ............................................................... 2-18
Micom-Z 44-Pin/25-Pin Adapter Cable Wiring Diagram ........................................................ 2-19
Cooling Tray 25-Pin ACCESSORY Connector Pin Functions............................................... 2-19
Harmonic Filter Frequency Ranges and Controlling Relays .................................................. 2-34
Table 3-1.
Table 3-2.
Table 3-3.
Tightening Torques for Screws ................................................................................................. 3-2
BIT Error Codes ......................................................................................................................... 3-4
Troubleshooting Procedure ....................................................................................................... 3-6
Table B-1.
Table B-2.
Table B-3.
Table B-4.
Table B-5.
Table B-6.
Table B-7.
Table B-8.
Table B-9.
Table B-10.
Table B-11.
Table B-12.
Table B-13.
Table B-14.
Table B-15.
Micom-Z Assembly Dash Version, Parts List ...........................................................................B-1
LORD Assembly, Parts List .......................................................................................................B-4
LORD Module, Parts List ...........................................................................................................B-5
HI POWER Module, Parts List ................................................................................................B-59
Dash Front Panel, Control Head Assembly, Parts List ..........................................................B-79
CONTROL HEAD Module (Dash Mount Version), Parts List................................................B-80
Micom-Z Assembly, Trunk Version, Parts List .......................................................................B-93
LORD Assembly, Parts List .....................................................................................................B-96
HI POWER Module, Parts List ................................................................................................B-97
Trunk Front Panel, Control Head Assembly, Parts List..........................................................B-98
CONTROL HEAD Module (Trunk Mount Version), Parts List...............................................B-99
INTERCONNECTION Module, Parts List.............................................................................B-115
Cooling Tray Assembly, Parts List.........................................................................................B-119
FAN CONTROL Module, Parts List ......................................................................................B-120
Fan Harness Assembly, Parts List ........................................................................................B-121
vi
MM-E 2072-09333-00
Chapter 1
INTRODUCTION
1-1.
SCOPE
This Service Manual provides the information needed to maintain Micom-Z HF-SSB radio sets in
accordance with manufacturer’s recommendations.
For a description of Micom-Z characteristics and capabilities, and for installation and operation
procedures, refer to the Micom-Z Operator Manual, Publication OM-E 2072-09689-00. The Micom-Z
Operator Manual also describes the cooling tray, available as an accessory for Micom-Z transceivers.
This Service Manual is organized as follows:
Chapter 1
Introduction: describes the scope and organization of the manual.
Chapter 2
Theory of Operation: presents the theory of operation of Micom-Z transceivers.
Chapter 3
Maintenance: provides test, troubleshooting and repair instructions for Micom-Z
transceivers and cooling tray.
Appendix A Schematic Circuit Diagrams: presents the schematic circuit diagrams of the
Micom-Z transceivers and the cooling tray.
Appendix B Parts Lists: lists and identifies the parts needed to maintain Micom-Z
transceivers and the cooling tray.
To facilitate equipment maintenance, the manufacturer offers two spare parts kits:
• Recommended spare boards kit for Micom-Z dash mount version, Mfg. Cat. No.
2072-09246-00
• Recommended spare boards kit for Micom-Z trunk mount version, Mfg. Cat. No.
2072-09247-00.
It is also possible to order 4-year extended warranties, in accordance with the options installed in each
transceiver:
• 4-year extended warranty for basic Micom-Z, Mfg. Cat. No. 2000-17777-90
• 4-year extended warranty for FRN8525 vocoder (FRN8529), Mfg. Cat. No. 2072-00235-00
• 4-year extended warranty for FRN8526 modem (FRN8530), Mfg. Cat. No. 2072-00236-00
• 4-year extended warranty for FRN8527 vocoder/modem (FRN8534), Mfg. Cat. No.
2072-00237-00.
Contact the manufacturer, or your local distributor, for any additional information you may need.
1-1
MM-E 2072-09333-00
Intentionally Left Blank
1-2
MM-E 2072-09333-00
Chapter 2
THEORY OF OPERATION
Section I. GENERAL DESCRIPTION
2-1.
MICOM-Z DESCRIPTION
2-1.1
Micom-Z Dash-Mount Version
2-1.1.1
Structure
Figure 2-1 shows the structure of the Micom-Z dash-mount version. Micom-Z dash-mount version
consists of two main assemblies, attached by means of four screws:
• Body assembly. The body assembly includes two main modules, LORD and HI POWER,
interconnected by a few cables. The LORD module is actually an assembly protected by a shield
that also carries the optional GPS receiver and a backup battery for protecting the operational
parameters. The external connectors are located on the two modules, but are attached to the rear
panel, for physical support. The LORD and HI POWER modules can be accessed after opening
the top cover (not shown in Figure 2-1), and separating the front panel assembly (it is not
necessary to remove the rear panel, but connectors must be released from the panel before it is
possible to extract the modules).
• Front panel assembly. This assembly includes the operator interface (controls, keypad, LCD), a
microphone connector, an internal speaker, and the CONTROL HEAD module. The front panel
assembly is connected to the LORD module by a single flat cable.
Body Assembly
Internal GPS
Antenna Cable
LORD
Rear Panel
Front Panel
Assembly
RX Coaxial
Cable
TX Coaxial
Cable
Flat Cable
to LORD
Backup
Battery
Flat Cable
LORD - HI POWER
HI POWER
GPS Receiver
Flat Cable
GPS - LORD
CONTROL HEAD
Module
Figure 2-1. Micom-Z Dash-Mount Version Structure
2-1
MM-E 2072-09333-00
2-1.1.2
Wiring Diagram
Figure 2-2 shows the wiring diagram of the Micom-Z dash-mount version. Micom-Z dash-mount
version comprises the following main modules:
a. LORD module, includes the following main circuits:
(1) Audio signal processing circuits for the receive and transmit paths.
(2) Digital signal processor (DSP) and its auxiliary circuits.
(3) RF and IF modulation/demodulation and signal processing circuits for the receive and
transmit paths.
(4) Synthesizer and local oscillator circuits, and the Micom-Z frequency reference.
(5) Main microcomputer subsystem used to control the operation of the Micom-Z circuits. It
is part of the Micom-Z management subsystem, which also includes a microcomputer
subsystem located in the CONTROL HEAD module.
The module also includes the optional GPS receiver, and its interface.
Front Panel Assembly
Body Assembly
Backup
Battery
Socket
for SD
Memory
Card
GPS
GPS
Receiver
J4
J8
J4
J3
P3
J6
J5
ACCESSORY
LCD
LORD
P2
J2
J1
TX
RX
J3
P4
P1
P4
P2
P3
ANT
P6
Microphone
HI POWER
E1
VDC IN
E2
Figure 2-2. Micom-Z Dash-Mount Wiring Diagram
b. HI POWER module, includes the following main circuits:
(1) Main power supply, provides the regulated voltages needed by the Micom-Z circuits, and
provides power for an external antenna tuner unit (ATU), connected to Micom-Z.
(2) Receiver front end circuits, connected via a coaxial cable to the LORD RF receive path.
(3) RF power amplifier for the transmit path, and its power supply, control and protection
circuits. The drive signal for the RF power amplifier is provided via a coaxial cable by the
LORD RF transmit path.
2-2
MM-E 2072-09333-00
c. CONTROL HEAD module, includes the following main circuits:
(1) Microcomputer subsystem, built around a microcontroller, used to manage the operator
interface, transfers the operator commands to the main microcomputer subsystem located
on the LORD module, and controls the LCD and its operational conditions.
(2) Serial RS-232 port for communication with the Micom-Z management subsystem.
(3) Audio subsystem, including the microphone amplifier, the audio power amplifier for the
internal speaker, and the volume control/ON-OFF switch.
2-1.1.3
Functional Block Diagram
The functional block diagram of Micom-Z dash-mount version is shown in Figure 2-3.
2-1.1.3.1
Transmit Path
a. Selection of Signal Source. The transmit path can receive modulation signals from a
microphone connected to the front panel audio connector or signals from equipment connected
to the rear panel ACCESSORY connector (audio from an accessory device, a modem, or
telegraphy). Each source provides a different PTT signal, and therefore the selection of the
signal to be transmitted is made in accordance with the active PTT signal:
•
MIC PTT – PTT from the microphone connected to the front panel connector, transmits the
voice signal provided by the microphone.
•
Voice PTT – PTT from an accessory connected to Micom-Z through the ACCESSORY
connector, transmits the voice signal from the accessory device.
•
Data PTT – PTT from a data device, for example, a modem, connected to Micom-Z through
the ACCESSORY connector, causes Micom-Z to switch to the data mode and transmit the
modem signal.
•
CW PTT – PTT from a Morse key connected to Micom-Z through the ACCESSORY
connector, causes the radio to switch to the CW (Morse) transmission mode.
In parallel, the radio operating mode is automatically adapted for best performance with the
signal expected for the detected PTT type.
b. Processing of Transmit Signal. The selected audio modulation signal is converted to a digital
data stream by the A/D converter section of a codec, for processing by the DSP subsystem. The
DSP outputs a digital representation of the signal, in accordance with the modulation mode
selected by the operator (LSB, USB, AME or PILOT). This digital representation is converted
to the actual IF modulated signal, on a carrier frequency of 1.05 MHz, by a digital sideband
modulator (DSM).
c. ISB Option. When the ISB option is installed, the master sideband signal is processed as
explained above. In addition, the transmit signal received through the TX_AUDIO_ISB line of
the ACCESSORY connector is converted to a digital data stream by an additional codec. The
codec supplies the data stream to the DSP, which processes the signal in parallel with the other
(master sideband) data stream, and generates the representation of an ISB signal for the DSM.
d. Generation of RF Transmit Signal.
(1) The 1.05 MHz transmit IF signal generated by the DSM is converted by the second mixer
to 45.1 MHz, by mixing it with a 46.15 MHz local oscillator signal provided by
synthesizer 2 (para. 2-1.1.3.3).
The 45.1 MHz is filtered and amplified by the first IF processor.
(2) The 45.1 MHz IF transmit signal is down-converted to the desired RF frequency by the
first mixer. The conversion is performed by mixing the IF signal with the variable local
oscillator signal provided by synthesizer 1 (para. 2-1.1.3.3).
The resulting low-level RF signal is amplified by the exciter amplifier, and supplied to
the RF power amplifier in the HI POWER module.
2-3
MM-E 2072-09333-00
(3) The RF power amplifier in the HI POWER module generates an RF signal at the power
level selected by the operator (LOW, MED, HIGH, or MAX). The transmit signal is
connected by the TX/RX switch to the harmonic filter, which attenuates harmonics and
unwanted spurious signals. The filtered signal then passes to the ANT connector through
a power sensor, which generates DC voltages, VFWD and VREV, proportional to the
forward and reflected power.
The ANT connector can be connected either directly to a broadband antenna, or to an
external ATU unit. DC power for the ATU unit is provided from the internal protected
DC power line, through a switch controlled by the LORD module.
An automatic level control (ALC) loop maintains the transmit output power close to the
selected transmit power. The automatic level control loop compares the VFWD sample
with the transmit power control signal provided by the microcomputer subsystem in the
LORD module, and adjusts the input RF signal power reaching the amplifier.
The VREV sample is used for mismatch protection: if the VSWR (Voltage Standing
Wave Ratio) exceeds 2:1, the transmit power is proportionally reduced, to prevent
damage.
The RF power amplifier also includes thermal protection: when the internal temperature
exceeds the maximum permitted, the transmit power is automatically reduced until the
temperature returns to normal. If nevertheless the temperature continues to increase even
when operating at the LOW level, the transmission is stopped until the temperature
returns to normal.
2-1.1.3.2
Receive Path
a. Processing of Received RF Signal.
(1) The received RF signal is filtered by the harmonic filter, and is then connected by the
TX/RX switch to the preselector in the LORD module.
(2) The preselector provides further filtering of the RF signal, to improve the rejection of
out-of-band signals. The resulting signal is supplied to the first mixer, which converts the
signal to the first IF frequency, 45.1 MHz, by mixing it with the local oscillator 1 signal
provided by synthesizer 1 (para. 2-1.1.3.3).
b. IF Signal Path.
(1) The first IF processor filters and amplifies the 45.1 MHz provided by the first IF mixer.
The filtered signal is then converted to the second IF frequency, 450 kHz, by the second
mixer, which mixes the 45.1 MHz signal with the local oscillator signal provided by the
synthesizer 2.
(2) The second IF signal is filtered and amplified by the second IF processor, and is then
converted to the third IF frequency, 20 kHz, by the third mixer. The local oscillator signal
for the third mixer, 430.77 kHz, is obtained by dividing the 16.8 MHz reference
frequency.
(3) The third IF signal is converted to a digital data stream, which is supplied to the DSP
subsystem. The DSP demodulates the IF signal, and extracts the original modulation
signal.
c. Audio Signal Paths.
(1) The data stream demodulated signal, provided by the DSP, is converted by the D/A
converter section of the codec to an audio signal. The audio signal is amplified and
supplied to the speaker located on the front panel, and to the other audio and data outputs
in the ACCESSORY connector.
(2) When the ISB option is installed, the DSP provides an additional data stream which
represents the slave sideband. This data stream is converted by a codec to an audio signal,
RX_AUDIO_ISB, which is available in the ACCESSORY connector.
2-4
MM-E 2072-09333-00
Body Assembly
MIC
Audio Connector
LORD
Front Panel Assembly
MIC
Audio
Amplifier
Audio and Data Sources
MIC PTT
Serial Control Channel
MIC PTT
Codec
A/D Section
Voice PTT
Data PTT
CW PTT
ISB Option
First
Mixer
First IF (45.1 MHz)
Processor
Second
Mixer
Receiver Second IF
(450 kHz)
Processor
Third
Mixer
Receiver Third IF
(20 kHz)
Processor
TX
Amplifier
DSP
Subsystem
HI POWER
Digital SSB
Modulator
(DSM)
1.05 MHz
ANT
Power
Sensor
Harmonic
Filter
Local Oscillator 1
45.2 to 75.1 MHz
TX/RX
Switch
Power
Amplifier
Exciter
Amplifier
Synthesizer 1
Local Oscillator 2
44.05 to 46.15 MHz
16.8 MHz
Reference
Frequency
TX_AUDIO_ISB
To ACCESSORY
Preselector and
Receiver Front End
Processor
Codec
RX
Amplifier
RX_AUDIO_ISB
Local Oscillator 3
430.77 kHz
Codec
D/A Section
Synthesizer 2
16.8 MHz
Reference
Frequency
Divider
by 39
Audio and Data Outputs
Amplifier
VFWD
16.8 MHz
to PLLs
ALC
16.8 MHz
to DSP
Audio Receive
Circuits
Temperature
Power
Control
ATU DC
Switch
16.8 MHz
Reference
Backup
Battery
CONTROL HEAD
Analog
Indications
SW_BATT
Frequency
Control Data
SPKR
Frequency
Control Data
Control and
Status LInes
Calibration
Data
Local
Regulators
GPS
GPS
Receiver
VDC IN
SD Socket
VREV
ON/OFF
Switch
and
Protection
Switching
Regulator
Regulated
Voltages
Regulated
Voltages
Main
Microcomputer
Subsystem
Serial Control Channel
Microcontroller
Front Panel
ON_OFF_CONT
SW_BATT
Local
Regulators
Lighting and
Heating
Control
Figure 2-3. Micom-Z Dash-Mount Version, Functional Block Diagram
2-5/2-6
MM-E 2072-09333-00
2-1.1.3.3
Frequency Conversion Subsystem
The Micom-Z frequency conversion scheme is described in Figure 2-4.
1.6 MHz
30 MHz
0.1 MHz
30 MHz
45.1 MHz
First IF amplifier
45.1 MHz
First IF amplifier
1.05 MHz
Second IF amplifier
450 kHz
Second IF amplifier
20 kHz
Third IF amplifier
DS
pr
oc
es
sin
DSP processing
DSM
Audio
Audio
A. Transmit Path
B. Receive Path
Figure 2-4. Frequency Conversion Scheme
The conversion is implemented as follows:
• Transmit path: the analog section performs double frequency conversion, as shown in Figure 2-4.
• Receive path: the analog section performs triple frequency conversion, as shown in Figure 2-4.
Two synthesizers provide two local oscillator (LO) signals for the transmit and receive paths:
• The first LO signal covers the 45.2 to 75.1 MHz range in three subranges, and is generated by a
PLL (phase locked loop) using three VCOs (voltage controlled oscillators). Refer to Figure 2-5.
• The second LO signal is generated by a PLL covering the 44 to 46 MHz range with one VCO.
Refer to Figure 2-6.
In both synthesizers, the VCO frequencies are higher than the LO frequencies: to achieve the final
frequencies, the first synthesizer divides its output frequency by 2, and the second synthesizer divides
its output frequency by 8. Using frequency division decreases spurious levels without degrading the
lock-in time of the PLL, and also improves the frequency resolution.
Thus, the first synthesizer provides a resolution of 8.75 kHz, and the second synthesizer provides a
resolution of 1.25 kHz. The additional processing needed to achieve an overall frequency resolution of
10 Hz is performed by the DSP.
Both synthesizers use a single reference frequency, generated by a 16.8 MHz oscillator. As a result,
the overall radio frequency stability and accuracy are determined by the accuracy and stability of this
single reference oscillator.
The standard reference oscillator is a digitally temperature-compensated crystal oscillator (DTCXO).
An optional ovenized crystal oscillator (OCXO) with higher accuracy and stability can be ordered, for
enhanced frequency accuracy.
2-7
MM-E 2072-09333-00
DSP
RF Output
1.6 - 30 MHz
1.05 MHz
IF Processor
45.1 MHz
DSM
Synthesizer Subsystem
First LO
Frequency = 46.7 - 75.1 MHz
Step = 8.75 kHz
Second LO
Frequency = 46.15 MHz
Step = 1.25 kHz
÷2
÷8
VCO 1, 2, 3
VCO 4
0 to 1.25 kHz
10 Hz Resolution
Frequency = 368.4 MHz
Step = 10 kHz
Figure 2-5. Transmit Path Frequency Conversion Scheme
DSP
IF Processor
45.1 MHz
RF Input
0.1 - 30 MHz
IF Processor
450 kHz
Synthesizer Subsystem
First LO
Frequency = 45.2 - 75.1 MHz
Step = 8.75 kHz
430.77 kHz
Second LO
Frequency = 44.05 - 46.15 MHz
Step = 1.25 kHz
÷2
÷8
VCO 1, 2, 3
VCO 4
0 to 3 kHz
10 Hz Resolution
Frequency = 352.4 - 369.2 MHz
Step = 10 kHz
Figure 2-6. Receive Path Frequency Conversion Scheme
2-1.1.3.4
Control Subsystem
The Micom-Z control subsystem includes the main microcomputer subsystem located on the LORD
module, and a microcontroller located on the CONTROL HEAD module.
a. The CONTROL HEAD microcontroller provides the interface to the front panel keypad and
LCD, which enables the operator to control Micom-Z operation and monitor its status. In
addition, the microcontroller can also communicate with external equipment, for example, a PC
running the RSS or MRC utility, via an additional serial asynchronous control channel
terminated in the front panel audio connector.
The microcontroller communicates with the main microcomputer subsystem via a serial
asynchronous control channel. This serial channel is used to transfer the commands entered by
the operator using the front panel keypad, and data received via the serial control channel from
RSS or MRC (this data includes operational parameters, and radio set calibration data for the
transmit power and frequency accuracy).
In addition to the functions described above, the microcontroller also controls the LCD heating,
and the LCD and keypad backlighting.
The microcontroller supports the connection of an external memory card using the SD format,
which can be plugged into the SD socket at the top of the front panel.
2-8
MM-E 2072-09333-00
b. The main microcomputer subsystem in the LORD module controls the operation of all the
Micom-Z circuits, monitors their status, measures the various analog voltages that represent
power levels, temperatures, supply voltages, etc., and manages self-test.
The microcomputer subsystem uses the information received from the front panel
microcontroller and the PTT commands to select the desired operating mode, and stores the
operational parameters in a battery-protected memory. The calibration data is written into an
EEPROM, and therefore it is always preserved, even when backup battery is replaced.
The main microcomputer subsystem sends to the front panel microcontroller the data regarding
the current operational parameters and indications, for display on the front panel LCD.
The microcomputer subsystem also includes several UARTs, which can be used to
communicate with other equipment connected via the ACCESSORY connector, and via the
optional GPS receiver.
2-1.1.3.5
Power Supply Subsystem
The Micom-Z power source is connected via the VDC IN connector to the HI POWER module, which
includes the ON/OFF electronic switch and the input voltage protection circuits.
The ON/OFF switch, integrated with the protection circuits, is controlled by the ON_OFF_CONT line
from the front panel. It connects the supply voltage to the internal supply voltage line, SW_BATT,
when the operator turns the Micom-Z on, provided the polarity of the supply voltage is correct, and
within the allowed limits.
The SW_BATT line provides power to the local regulators on the various modules. The supply
voltage is also connected via current limiting devices to the ACCESSORY connector.
2-1.2
Micom-Z Trunk-Mount Version
2-1.2.1
Structure
The Micom-Z trunk-mount version consists of two main assemblies:
• Body assembly, shown in Figure 2-7. The Micom-Z trunk-mount version body assembly is
identical to the Micom-Z dash-mount version body assembly, but its front side has a cover that
carries the INTERCONNECTION module.
Body Assembly
Internal GPS
Antenna Cable
LORD
RX Coaxial
Cable
Rear Panel
Front Cover
INTERCONNECTION
Connector for
Flat Cable
to LORD
Backup
Battery
TX Coaxial
Cable
Flat Cable
LORD - HI POWER
GPS
Receiver
Flat Cable
GPS - LORD
HI POWER
Figure 2-7. Micom-Z Trunk-Mount Version, Structure of Body Assembly
The INTERCONNECTION module, which connects to the LORD module by a single flat cable,
provides the functions needed to enable connecting to the control head via a long cable.
2-9
MM-E 2072-09333-00
• Control head, shown in Figure 2-8. This is a separate unit that includes the operator interface and
CONTROL HEAD module, which are similar to the front panel of the Micom-Z dash-mount
version, except that the speaker is external. The access to the CONTROL HEAD module is
through a rear cover fastened by four screws to the front panel.
The control head is connected to the body assembly by a cable, which also includes a branch for
connecting an external speaker.
LCD
Rear Cover
CONTROL HEAD
Module
Front Panel
Figure 2-8. Micom-Z Trunk-Mount Version, Structure of Control Head
2-1.2.2
Wiring Diagram
Figure 2-9 shows the wiring diagram of the Micom-Z trunk-mount version.
a. Body Assembly. This assembly comprises the following main modules:
(1) LORD module: same as the Micom-Z dash-mount version module.
(2) HI POWER module: same as the Micom-Z dash-mount version module.
(3) INTERCONNECTION module: contains interface circuits that enable the microcomputer
system in the LORD module to communicate with that in the CONTROL HEAD module
via the interconnecting cable, an interface for the microphone signal, and a supply voltage
switch for the control head.
b. Control Head. This assembly comprises the CONTROL HEAD module, similar to the
CONTROL HEAD module in the dash-mount version, except that it includes interface circuits
that enable the module to communicate with the LORD module via the interconnecting cable.
The cable also provides the connection to an external speaker.
2-10
MM-E 2072-09333-00
Body Assembly
Backup
Battery
GPS
Control Head
GPS
Receiver
J4
Socket
for SD
Memory
Card
P501
Interconnection
Cable
LCD
P2
P1
J8
J6
J5
ACCESSORY
J3
INTERCONNECTION
J4
LORD
P2
J2
J1
TX
RX
J3
P4
P4
P2
ANT
P3
P6
E1
E2
VDC IN
HI POWER
Microphone
Speaker
Figure 2-9. Micom-Z Trunk-Mount Wiring Diagram
2-1.2.3
Functional Block Diagram
The functional block diagram of Micom-Z trunk-mount version is shown in Figure 2-10.
2-1.2.3.1
Transmit Path
a. Selection of Signal Source. The transmit path can receive modulation signals from a
microphone connected to the audio connector of the control head, or signals from equipment
connected to the rear panel ACCESSORY connector (audio from an accessory device, a
modem, or telegraphy). Each source provides a different PTT signal, and therefore the selection
of the signal to be transmitted is made in accordance with the active PTT signal:
•
MIC PTT – PTT from the microphone connected to the control head connector, transmits the
voice signal provided by the microphone. The microphone signal passes through a buffer,
which converts the signal to a balanced signal, for transmission to the body assembly through
the interconnection cable. Another buffer located on the INTERCONNECTION module
converts the balanced signal to a single-ended signal, which is supplied to the audio amplifier.
The PTT signal also passes through an RS-485 line driver, for transmission to the body
assembly through the interconnection cable. An RS-485 line receiver located on the
INTERCONNECTION module converts the balanced RS-485 signal to the internal logic
levels.
2-11
MM-E 2072-09333-00
•
Voice PTT – PTT from an accessory connected to Micom-Z through the ACCESSORY
connector, transmits the voice signal from the accessory device.
•
Data PTT – PTT from a data device, for example, a modem, connected to Micom-Z through
the ACCESSORY connector, causes Micom-Z to switch to the data mode and transmit the
modem signal.
•
CW PTT – PTT from a Morse key connected to Micom-Z through the ACCESSORY
connector, causes the radio to switch to the CW (Morse) transmission mode.
In parallel, the radio operating mode is automatically adapted for best performance with the
signal expected for the detected PTT type.
b. Processing of Transmit Signal. See para. 2-1.1.3.1.b.
c. ISB Option. See para. 2-1.1.3.1.c.
d. Generation of RF Transmit Signal. See para. 2-1.1.3.1.d.
2-1.2.3.2
Receive Path
a. Processing of Received RF Signal. See para. 2-1.1.3.2.a.
b. IF Signal Path. See para. 2-1.1.3.2.b.
c. Audio Signal Paths. See para. 2-1.1.3.2.c. The only difference is that an external speaker is used
(this speaker is connected via a branch of the interconnection cable).
2-1.2.3.3
Frequency Conversion Subsystem
The Micom-Z frequency conversion scheme is described in para. 2-1.1.3.3.
2-1.2.3.4
Control Subsystem
The Micom-Z control subsystem includes the main microcomputer subsystem located on the LORD
module, and a microcontroller subsystem located on the CONTROL HEAD module, which are similar
to these described in para. 2-1.1.3.4. The only difference is the use of RS-485 transceivers that transfer
the control channel via the interconnection cable.
2-1.2.3.5
Power Supply Subsystem
The Micom-Z power source is connected via the VDC IN connector to the HI POWER module, which
includes the ON/OFF electronic switch and the input voltage protection circuits.
The ON/OFF switch, integrated with the protection circuits, is controlled by the ON_OFF_CONT line
from the control head. It connects the supply voltage to the internal supply voltage line, SW_BATT,
when the operator turns the Micom-Z on, provided the polarity of the supply voltage is correct, and
within the allowed limits. The SW_BATT line provides power to the local regulators on the other
modules. The supply voltage is also connected via current limiting devices to the ACCESSORY
connector.
The connection of the SW_BATT line to the control head passes through a supply voltage control
circuit, also controlled by the ON_OFF_CONT line: this circuit connects the supply voltage only
when the operator passes through control head ON/OFF button to turn the Micom-Z on. Therefore, if
the interconnection cable, or the control head, is disconnected from the body assembly, Micom-Z is
automatically turned off.
2-12
MM-E 2072-09333-00
LORD
MIC PTT
MIC PTT
PTT and
MIC Buffers
MIC
Audio
Amplifier
PTT and
MIC Buffers
MIC
Audio and Data Sources
Serial Control Channel
Voice PTT
Codec
A/D Section
Audio Connector
Control Head Assembly
Body Assembly
Data PTT
CW PTT
First IF (45.1 MHz)
Processor
Second
Mixer
Receiver Second IF
(450 kHz)
Processor
Third
Mixer
Receiver Third IF
(20 kHz)
Processor
TX
Amplifier
DSP
Subsystem
TX_AUDIO_ISB
To ACCESSORY
First
Mixer
Codec
HI POWER
ANT
Digital SSB
Modulator
(DSM)
1.05 MHz
Power
Sensor
Harmonic
Filter
RX
Amplifier
RX_AUDIO_ISB
TX/RX
Switch
Exciter
Amplifier
VFWD
Local Oscillator 1
45.2 to 75.1 MHz
Synthesizer 1
VREV
Local Oscillator 2
44.05 to 46.15 MHz
16.8 MHz
Reference
Frequency
ALC
Codec
D/A Section
Synthesizer 2
16.8 MHz
Reference
Frequency
Temperature
ATU DC
Switch
Local Oscillator 3
430.77 kHz
Divider
by 39
16.8 MHz
to PLLs
16.8 MHz
to DSP
Audio Receive
Circuits
Power
Control
Local
Regulators
Frequency
Control Data
SPKR
16.8 MHz
Reference
Backup
Battery
SW_BATT
Interconnection
Cable
Audio and Data Outputs
Amplifier
SD Socket
Power
Amplifier
INTERCONNECTION
ISB Option
Preselector and
Receiver Front End
Processor
To External
Speaker
Analog
Indications
Frequency
Control Data
Control and
Status LInes
Front Panel
Calibration
Data
GPS
ON/OFF
Switch
and
Protection
Switching
Regulator
Regulated
Voltages
Regulated
Voltages
CONTROL HEAD
GPS
Receiver
VDC IN
Main
Microcomputer
Subsystem
Serial Control Channel
RS-485
Transceiver
RS-485
Transceiver
Microcontroller
ON_OFF_CONT
SW_BATT
Supply
Voltage
Control
Local
Regulators
Lighting and
Heating Control
Figure 2-10. Micom-Z Trunk-Mount Version, Functional Block Diagram
2-13/2-14
MM-E 2072-09333-00
2-1.3
Micom-Z Cooling Tray
Figure 2-11 shows the structure of the Micom-Z cooling tray.
The cooling tray includes one module, the FAN CONTROL module, which provides point-to-point
connections between the two 25-pin connectors of the cooling tray. The module also includes the fan
control circuit, which enables to turn the supply voltage to the fan ON or OFF in accordance with the
control signal provided by the Micom-Z installed on the tray.
The connections between the radio side connector, the front panel jacks, and the fan are made by a
harness, which connects to the 9-pin D-type connector on the module.
Internal
Fan Cable
FAN CONTROL
Module
Cooling
Fan
Figure 2-11. Micom-Z Cooling Tray Structure
2-15
MM-E 2072-09333-00
2-2. OPTIONS AND ACCESSORIES
The following tables list the options and accessories that can be ordered for Micom-Z. Contact the
manufacturer or your local representative if you need an option or accessory not listed below.
Table 2-1. Available Options
Option
Mfg. Cat. No.
Description
G434
2072-09870-30 PC-based control and programming software package
S809
2072-09048-00 Interface cable kit for CW key and headphones
G431
2072-09197-10 Internal GPS receiver with polling application
FRN8525
2072-09460-00 Vocoder with digital audio quality enhancer (subject to export
license), includes interface cable and operator manual
FVN5228
2072-09780-00 Digital Advanced Encryption Standard option for FRN8525
(subject to export license)
FRN8526
2072-09720-00 4800bps single-tone high speed data modem (MDM4800) with
Micom-Net E-mail Gateway software package
FVN5229
2072-09790-00 Digital Advanced Encryption Standard option for FRN8526
(subject to export license)
FRN8527
2072-09820-00 4800bps single-tone high speed data modem (MDM4800) with
Micom-Net E-mail Gateway software package integrated with
vocoder and digital voice quality enhancer
FVN5230
2072-09800-00 Digital Advanced Encryption Standard option for FRN8527
(subject to export license)
Table 2-2. Accessories
Option
Mfg. Cat. No.
Description
Mobile Station Accessories
FAD1410
2072-09010-20 Automatic tuning whip antenna
F2265
2072-09030-10 Automatic antenna tuner
FAD1400
2072-92270-10 12 ft whip antenna (not required for FAD1410)
FLN3660
2072-90174-00 Cooling tray
FLN2818
2072-09676-00 1.6 – 30MHz, 125W PEP/average heavy duty automatic antenna
tuner for fixed and mobile installations, for use in data system
applications. Includes 30m RF coaxial cable and operator manual
(requires long wire or whip antenna)
HSN1600
2072-90410-00 External speaker
Fixed Station Accessories
FMN5542
–
FPN5600
2-16
2072-09803-00 Desk microphone
2072-09031-10 Kit for continuous duty data transmission, includes junction box
2072-09736-00 110/220VAC AC power supply
MM-E 2072-09333-00
2-3. CONNECTOR DATA
2-3.1
Micom-Z Connector Data
Table 2-3. Micom-Z Microphone Connector, Pin Functions
Pin
Designation
Description
SWA+
Power output to the microphone
RXD
Serial communication line (input)
TXD
Serial communication line (output)
GND
Ground line
MIC AUDIO
Input audio signals generated by the microphone (600 Ω
impedance; 300 mV tone is required for full output power).
PTT MIC
Activates transmission by short to ground.
MONITOR
Mutes the speaker before transmission is enabled (short
momentary to ground to open speaker).
AUDIO OUT
Receive audio output to earphone (600 Ω, 300 mVRMS)
Table 2-4. ACCESSORY Connector Pin Functions
Pin
Designation
Description
SPKR-
Differential output to external 8Ω, 5W speaker
STOP SCAN
Digital control input for stop scan function (optional function)
SPKR+
Differential output to external 8Ω, 5W speaker
EXT RX AUDIO+
EXT RX AUDIO-
Differential received audio output (0 dBm/600Ω; not controlled by
volume)
EXT TX AUDIO+
EXT TX AUDIO-
Differential transmit audio input (600Ω input impedance, 0 dBm is
required for full power)
PTT IN VOICE
Transmission command (short to ground) for voice signals
PTT IN DATA
Transmission command (short to ground) for data signals
10
PTT IN CW
Transmission command (short to ground) for CW (Morse) signals
11
SW A+
Primary DC voltage current limited output (max 1A)
12
DSI/KW CC
BDM – Data serial in/optional external amplifier channel change
13
KW ON/OFF
Optional external amplifier power on/off output
14
REV CLOSE LOOP
Close the radio ALC loop (input from optional external amplifier)
15
RXA
Receive input (point-to-point protocol to host/HLC)
16
TXA
Transmit output (point-to-point protocol to host/HLC)
17
EX RESET
External RESET input (for BDM)
18
GND
Ground
19
KW PTT
PTT output to optional external amplifier (active low)
20
EXT ALARM
External alarm output (open collector, pulled to ground when external
alarm is activated)
21
VPP
Flash programming voltage, input to BDM
2-17
MM-E 2072-09333-00
Table 2-4. ACCESSORY Connector Pin Functions (Cont’d)
Pin
Designation
Description
22
DSC/KW_ALC
BDM – Data serial clock/optional external amplifier ALC
23
SQ GATE
Squelch open/closed indication output
24
DSO/FAN_ON_OFF BDM – Data serial out/Fan control
25
FREEZE/KW TUNE
BDM – Freeze/optional external RF power amplifier tune
26
GND
Ground
27
FWD CLOSE LOOP ALC radio loop closure input (from optional external amplifier)
28
RXC
Receive input (point-to-point protocol to host/HLC)
29
TXB
RS-232 transmit output to “smart” external accessories
30
AMP REV
Maintain constant power at transceiver output (optional function)
31
RXD
Receive input (point-to-point protocol to host/HLC)
32
TX AUDIO OUT
Input to LORD baseband TX path from external device (for example,
modem)
33
RXB
RS-232 protocol receive input to “smart” external accessories
34
RX AUDIO OUT
Input to LORD baseband RX path from external device (for example,
modem)
35
RX AUDIO IN
Output from LORD baseband RX path to external device (for example,
modem)
36
AMP FWD
Maintain constant power at transceiver output (from optional external
amplifier)
37
VP PTT
PTT output (active low) (optional function)
38
TXD
Transmit output (point-to-point protocol to host/HLC)
39
TXC
Transmit output (point-to-point protocol to host/HLC)
40
TX AUDIO IN
Output from LORD baseband TX path to external device (for example,
modem)
41
EXT RX AUDIO(2)+
42
EXT TX AUDIO(2)-
43
EXT RX DATA-
44
EXT RX DATA+
Audio output from the optional ISB processor (secondary sideband)
Baseband output (0 dBm, 600 Ω), unsquelched
Table 2-5. Micom-Z VDC IN Power Connector, Pin Functions
Pin
2-18
Designation
Description
Power
Positive input line
Ground
Return (negative) line
MM-E 2072-09333-00
2-3.2
Cooling Tray Connectors
Table 2-6. Micom-Z 44-Pin/25-Pin Adapter Cable Wiring Diagram
44-Pin
25-Pin
44-Pin
25-Pin
Connector Connector Connector Connector
43
14
44
15
15
16
16
17
17
18
18
19
19
20
20
21
21
22
22
10
10
23
23
11
11
24
24
12
12
25
25
13
13
Table 2-7. Cooling Tray 25-Pin ACCESSORY Connector Pin Functions
Pin
Designation
Description
SPKR-
Differential output to the external 8Ω, 5W speaker
EXT RX DATA+
Baseband output (0 dBm, 600Ω) to external device, unsquelched
SPKR+
Differential output to the external 8Ω, 5W speaker
EXT RX AUDIO+
EXT RX AUDIO-
Differential receive audio output (0 dBm, 600Ω; not affected by the
volume control, but controlled by the squelch)
EXT TX AUDIO+
EXT TX AUDIO-
Differential transmit input (600Ω input impedance; 0 dBm is required for
full power)
PTT IN VOICE
Transmission command (short to ground) for voice signals
PTT IN DATA
Transmission command (short to ground) for data signals
10
PTT IN CW
Transmission command (short to ground) for CW (Morse) signals
11
SW A+
Primary DC voltage current limited output (max. 1A)
12
DSI/KW CC
BDM – Data serial in/optional RF power amplifier channel change
13
KW ON/OFF
Optional RF power amplifier power on/off output
14
EXT RX DATA-
Baseband output (0 dBm, 600Ω) to external device, unsquelched
15
RXA
Receive input (point-to-point protocol to host/HLC)
16
TXA
Transmit output (point-to-point protocol to host/HLC)
17
EX RESET
External RESET input (for BDM)
18
GND
Ground
19
KW PTT OUT
PTT output to optional RF power amplifier (active low)
2-19
MM-E 2072-09333-00
Table 2-7. Cooling Tray 25-Pin ACCESSORY Connector Pin Functions (Cont’d)
Pin
Designation
Description
20
EXT ALARM
External alarm output (open collector, pulled to ground when external
alarm is activated
21
VPP
Flash programming voltage, input to BDM
22
DSC/KW_ALC
BDM – Data serial clock/optional RF power amplifier ALC
23
SQ GATE
Squelch open/closed indication output
24
DSO/FAN ON/OFF BDM – Data serial out/fan control
25
FREEZE/KW TUNE BDM – Freeze/kW amplifier tune
2-20
MM-E 2072-09333-00
Section II. CIRCUIT ANALYSIS
2-4. LORD MODULE
The schematic circuit diagram of the LORD module is shown in Figure A-1, and the module block
diagram is shown in Figure 2-12.
2-4.1
Audio Subsystem
Refer to Figure A-1.C. The audio subsystem uses the 8V_AUDID_ISB voltage, provided by the linear
voltage regulator U6098, and a bias voltage, 4V_AUDID_BIAS, generated by part of U4000.
2-4.1.1
Audio Transmit Path
a. Microphone Signal Path. The MIC_IN signal from the front panel passes through the analog
switch in U6085 to an amplifier, followed by a voiceband bandpass filter in U4003. The
resulting signal is sent to the codec U6040 via the MIC line.
b. EXT_TX_AUDIO Signal Path. The EXT_TX_AUDIO signal from the ACCESSORY
connector is converted to a single-ended signal by an amplifier in U4000, and then is connected
through the analog switches in U6085 to the microphone signal path.
2-4.1.2
Audio Receive Path
a. SPKR Signal Path. The RX_AUDIO signal received from the codec U6040 is converted to a
single-ended signal by an amplifier in U4003, passes through an analog switch in U6084 to the
digitally-controlled potentiometer U6081, which serves as a volume control.
U6081 output is connected by another section of U6084 to an amplifier in U4000, which drives
the audio power amplifier U4002. U4002 balanced output signal, SPKR, is sent to the front
panel assembly.
b. Baseband and Modem Signal Outputs. The single-ended RX_AUDIO output signal is directly
connected to a driver built around U6082, which drives the balanced EXT_RX_DATA lines in
the ACCESSORY connector.
In addition, the signal can also be connected via analog switches in U6084 to another driver
built around U6082, which drives the balanced EXT_RX_AUDIO lines in the ACCESSORY
connector.
2-4.2
DSP Subsystem
Refer to Figure A-1.D.
The main supply voltage for the DSP subsystem, +3.3V, is provided by a linear voltage regulator,
U6097.
2-4.2.1
Transmit Path
a. The modulation signal, MIC, is applied to the input, INP, of the analog/digital conversion
section of the coder, U6040. This section includes an anti-aliasing filter, followed by a
programmable gain amplifier. The resulting signal is converted to a digital data stream, DOUT,
at a rate determined by the MCLK (main clock) signal received from a timer, TI02, in the DSP
U6042. The codec operates in the pulse mode, that is, it generates a continuous stream of bits
that represent the modulation signal.
The codec data stream, DOUT, and the associated clock, SCLK, are supplied to the enhanced
synchronous serial interface (ESSI 1) of the DSP.
b. DSP Functions. The DSP, U6042, is a digital signal processor with a 24-bit core. Its clock
signal is 16.8 MHz, received from the frequency reference generator via the DSP_16.8MHz. It
is controlled by the microcontroller, U5008, via the data and address buses, which connect to
2-21
MM-E 2072-09333-00
the DSP host port interface, and by a few discrete control lines. The RAM U6038 connected to
the DSP, address and data buses, is used by the DSP to store temporary variables and data.
The DSP has two ESSIs: ESSI 1 is used to connect to the codec U6040, and ESSI 0 is used to
connect to the DSM, U6000.
The operations performed by the DSP are determined by the program data loaded from the
microcontroller through the HPI. After processing the data stream received from the codec, the
DSP sends the resulting data stream, through ESSI 0, to the DSM, U6000.
c. DSM Functions. The DSM is a special-purpose digital processing component that converts the
incoming serial data stream to an analog signal, DSM_OUT. U6000 uses the same clock
frequency as U6042, 16.8 MHz.
The DSM_OUT signal is generated by an A/D converter, comprising a weighted network of
resistors connected to DSM FIR outputs.
The resulting signal is the transmit IF, an SSB (or AME) signal (in accordance with the
modulation mode selected by the user), on a 1.05 MHz virtual carrier.
2-4.2.2
Receive Path
a. The receive path of the DSP subsystem receives the digital stream representing the third IF
signal, generated by the serial output A/D converter, U1115. This stream, A_D_DATA, is
connected to the receive input, SRD0, of ESSI 0. U1115 conversion rate and timing are
synchronized by the clock and strobe signals, SR_CLK and CONVST, provided by the DSP.
The DSP can also control the operation mode of U1115, via the serial data stream SR_DATA.
b. The DSP processes the received data streams, and converts it to a data stream that represents the
demodulated IF signal. This stream is sent via ESSI 1 to the input, DIN, of the digital/analog
conversion section of the codec U6040.
The resulting analog signal is provided as a balanced signal at the OUTP and OUTM outputs.
These outputs are connected via the RX_AUDIO line to the audio receive path (para. 2-4.1.2).
2-4.3
ISB Option
Refer to Figure A-1.E.
The ISB option includes a codec, U6088, similar to U6040.
a. The A/D conversion path of U6088 processes the slave sideband signal, received from the
ACCESSORY connector via EXT_TX_AUDIO_ISB line. This signal is amplified and filtered
by U6089. The resulting data stream is sent to the DSP via the HYB_ESSI_STD line.
b. The D/A conversion path of U6088 receives the serial HYB_ESSI_SRD data stream from the
DSP, and converts it to a balanced audio signal. This signal is amplified by U6089, and sent to
the ACCESSORY connector via the EXT_RX_AUDIO_ISB line.
2-4.4
IF and RF Transmit Path
Refer to Figure A-1.M, Figure A-1.N, Figure A-1.P.
a. The 1.05 MHz signal generated by the DSM passes through a bandpass filter to the IF RX/TX
switch. In the transmit mode, CR1905 is forward biased and connects the signal to the second
mixer, U1108.
b. U1108 mixes the signal with the local oscillator signal, TX_SEC_INJ, provided by
synthesizer 2 (para. 2-4.7.3). The resulting signal, TRANS_IF, at 45.1 MHz, is applied to the
transmit section of the bidirectional IF amplifier, Q1006.
c. The amplified signal passes through the crystal filters FL2, FL1. The filtered signal bypasses the
first IF amplifier, Q1001, via the PIN diode switch CR1011, CR1012, and reaches the first
mixer, U1000.
2-22
MM-E 2072-09333-00
To
HI POWER
Preselector
Control Data
VCC
Band Selection
Control
U1, Q1-Q8
RF IN
Preselector
CR1-CR16
BIT Noise
Generator
Q9, Q30,
Q2901
9T
Front-End
Attenuator
(RAGC)
Q1000,
Q1013-Q1015
CR1000, CR1008
Front-End
Amplifier
Q1002,
Q1007
First
IF Amplifier
Q1011
First
Mixer
U1000
45.1 MHz
Crystal Filter
FL1, FL2
30 dB
Attenuator
Bidirectional 45.1 MHz Second
IF Amplifier
Mixer
Q1003, Q1006
U1108
CR1011,
CR1012
Local Oscillator 2
44.05 to 46.15 MHz
SW_A+
SW_A+
SW_A+
+5V Reg.
U6024
+6V Reg.
U2004
+5V Regulator
U6025
9V
+5V Regulator
U1107
9T/9R
Generator
U1100, Q1008,
Q1109, Q1017,
Q1018
VDD
9R
MIC
to J6
TX Audio
and Data
Sources from
ACCESSORY
J5
Third
Mixer
U1111
CR1904,
CR1905
Local Oscillator 3
430.77 kHz
20 kHz
Amplifier
P/O U1110
Antialias
Filter
P/O U1110
A/D
Converter
U1115
STEP_AGC_10_2
Digital SSB
Modulator
(DSM)
U6000
DSP
Subsystem
U6042, U6038
Data Bus
TX Amplifier
P/O U6089
HPI
Address Bus
Synthesizer 2
Divider by 2
U2009
Divider by 8
U2010
Amplifier
U2002
Amplifier
U2003
90.2-150.4 MHz
PLL
U6075, Q2006, Q9040,
Q9020, Q9000,
Q9063-Q9065
Codec
U6088
RX_AUDIO_ISB
to J5
RX Amplifier
P/O U6089
Divider by 39
U1113, U1114,
U1109
352.4-369.2 MHz
PLL
U6076, Q2007
SINE_16.8 MHz
Reference Frequency
Codec
D/A Section
P/O U6040
VRH
CR5000
Main Microcomputer Subsystem
R/W
Microcontroller
U5008
Flash Memory
U5001, U6035
EEPROM
Access
Control
SRAM
U5009, U5010
To Control Head via J6,
and to ACCESSORY J5
INT to
U5008
UART Unit
U6062, U6063,
U6078
EEPROM
U6043
GPS Interface
U5007, U5006
A/D Converter
Inputs
Address Bus (ADDR0-19)
To DSP
HPI
Data Bus (DATA0-15)
I/O
Ports
XTAL
To UARTs
BIAS_OUT
ADDR9-11
I/O Decoder
U6079
Input/Output
Ports
U6068, U6069,
U6070
Control
Signals
Status and
Input Signals
Audio Power
Amplifier
U4002
SPKR
to Speaker
via J6
SW_A+
OCXO
Option
10V
Regulator
U3004
Crystal
Oscillator
U3001
Calibration
Data
EXTAL
Y5000 or Y5002
38.4 kHz
16.8 MHz Reference Generator
To GPS
Receiver
(Option)
via J8
RX Audio
and Data
Sources to
ACCESSORY
J5
Audio Receive
Circuits
P/O U4000,
P/O U4003,
U6081
DSP_16.8 MHz
to DSP
Buffers
and Filters
Q3001, Q3002
Frequency Control Data
Write Protect
VCC
Amplifier
U6082,
P/O U4003
IF_16.8 MHz
Reference Frequency
SINE_16.8 MHz
Reference Frequency
CR5004
OVEN_TEMP_CONT
8V_AUDIO_ISB 4V_AUDIO_ISB
TX_AUDIO_ISB
to J5
Bandpass
Filter
VCC
D/A
Converter
U1104
MIC
Codec
A/D Section
P/O U6040
ISB Option
Bandpass
Filter
Frequency Control Data
Control and
Status Lines
+3.3V
to DSP Subsystem
Second IF Processor
Q1020-Q1023, FL3, FL4
To Backup
Battery
J4
Analog
Indications
Audio Circuits
Supply
U6098,
P/O U4000
Audio
Amplifier
P/O U4000,
U4003
RX_AUDIO
9T
+5V
Regulator
U6021
Power-Up RESET
Control
U5014
To other
Circuits
3.3V Regulator
U6097
1.05 MHz
Synthesizer 1
+9V
Regulator
U1106
SW_A+
PTT Signals to
U5008 via J5, J6
450 kHz
Local Oscillator 1
45.2 to 75.1 MHz
Exciter
Amplifier
Q1004, Q1005
STEP_AGC_30_2
IF RX/TX
Switch
9T
Q1019
Bypass
Switch
9T
RF RX/TX
Switch
9R
STEP_AGC_10 STEP_AGC_20
TX
SW_A+
STEP_AGC_30
VCC (+5V)
or
OCXO
U3002
HEAT_CONT
D/A
Converter
U3010
Heater
Control
U3000, Q3000
RF Power and
Oven Temp
Control Data
OVEN_TEMP_CONT
from U1104
Figure 2-12. LORD Module, Block Diagram
2-23/2-24
MM-E 2072-09333-00
d. The first mixer converts the 45.1 MHz transmit IF signal to the final RF transmit frequency, by
mixing with the local oscillator signal, FIRST_INJ, provided by synthesizer 1 (para. 2-4.7.2).
e. In the transmit mode, the mixer output signal passes through the PIN diode CR1010 to the
exciter amplifier (CR1009 is reverse-biased).
f. The mixer output signal is filtered by a low-pass filter, and is then amplified by Q1004, Q1005.
Q1012 and Q1010 provide the bias current for Q1004, Q1005 (bias current is provided only in
the transmit mode, under the control of the 9R line).
g. The amplified RF drive signal, at the collector of Q1005, is coupled to the HI POWER module
via the TX line.
CR1001 provides a DC voltage proportional to the drive signal peak level, PWR_LEVEL,
which is monitored by U5008 via the PAD6/AN6 input of its internal A/D converter.
2-4.5
RF Front End
Refer to Figure A-1.H, Figure A-1.I, Figure A-1.N.
2-4.5.1
Preselector
a. The preselector receives the RF IN signal from the HI POWER module via J1. CR2008,
CR2009, VR4 and VR5 protect against excessive signal levels.
b. During receive path self-test, the BIT noise generator can be activated by a low level on the
NOISE_CONTROL line; to add noise to the signal appearing on the RF IN line.
c. The RF IN signal passes through a low-pass filter to the preselector. The preselector consists of
seven high-pass filters, and an additional non-selective branch. The desired filter is inserted in
the received signal path by two sets of PIN diode switches: CR1 to CR8 at the input, and CR9 to
CR16 at the output.
The pair of PIN diodes corresponding to the operating frequency band is turned on by control
signal received via the SPI interface, U1: U1 is a serial/parallel converter, which converts the
serial preselector control word received via the SPI_DATA_OUT line to discrete control signals
for the PIN diode drivers, Q1 to Q8 (a pair of PIN diodes is turned on when the corresponding
driver is turned on by a high level at the corresponding U1 output).
d. The preselector output signal, PS_OUT, is connected to the RAGC attenuator. The RAGC
attenuator consists of two sections: a 10-dB attenuator (series resistors R1016, R1017) and a
20-dB attenuator (the series resistors and the shunt resistor R1023), which can be inserted in the
signal path by the PIN diode switches CR1000 and CR1008. These PIN diode switches are
controlled by the STEP_AGC_10 and STEP_AGC_20 lines, via the drivers Q1000, Q1013 to
Q1015.
The lines used to control the AGC step attenuators are generated by a serial/parallel converter,
U1112, using the data received via the SR_DATA line (the data updates the control lines status
when the CONVST line assumes a low level).
e. The RF signal is applied to the front-end amplifier, Q1002, which operates only in the receive
mode (its bias voltage is connected by Q1007 only in the receive mode, under the control of the
9T line).
f. The amplified signal passes through a low pass filter, a 9-dB attenuator pad and the PIN diode
CR1009 to the first mixer, U1000 (CR1010 is reverse-biased via the 9R line).
U1000 converts the RF signal to the first IF, 45.1 MHz, by mixing with the FIRST_INJ signal
provided by synthesizer 1 (para. 2-4.7.2).
2-25
MM-E 2072-09333-00
2-4.6
Receive IF Path
Refer to Figure A-1.M, Figure A-1.N.
2-4.6.1
First IF Processor
a. The 45.1 MHz IF signal generated by U1000 is amplified by Q1001 (the PIN diodes CR1011
and CR1012 are reverse-biased). The bias voltage for Q1001 is provided by Q1011, which is
turned on in the receive mode by the low level on the 9T line).
b. The amplified signal at the drain of Q1001 passes through an attenuator pad to the 45.1 MHz
bandpass crystal filters FL1 and FL2.
c. The filtered signal is amplified by the receive section, Q1003, of the IF bidirectional amplifier.
The resulting signal is applied to the second mixer, U1108, via the TRANS_IF line.
The STEP_AGC_30 control line is used to add an attenuation of 30 dB (when a high level is
provided by U1112) in the receive signal path, by reducing the input impedance and gain of the
amplifier stage built around Q1003.
2-4.6.2
Second IF Processor
a. The second mixer, U1108, converts the 45.1 MHz IF signal to the second receive IF frequency,
450 kHz, by mixing it with the TX_SEC_INJ signal provided by synthesizer 2 (para. 2-4.7.3).
b. In the receive mode, the PIN diode CR1904 is forward-biased, and CR1905 is reverse-biased.
This connects the 450 kHz IF signal to the second IF processor, comprising Q1021, the 450 kHz
bandpass crystal filter FL4, Q1022, the 450 kHz bandpass crystal filter FL3, and the output
amplifier Q1021.
R1832 is used to adjust the gain of the receive path to the prescribed value.
c. The gain of Q1021 can be reduced, as part of the operation of the 30-dB step attenuator, by
applying a low level on the STEP_AGC_30_2 line provided by U1112 (this turns off Q1020).
2-4.6.3
20 kHz IF Processor
a. The 450 kHz IF signal provided by Q1021 is applied to the third mixer, built around the quad
analog switch, U1111. U1111 operates as a balanced mixer, which converts the 450 kHz signal
to 20 kHz (nominal) by mixing it with 430.77 kHz. The 430.77 kHz signal is provided by the
divider by 39, U1113, U1114, via the duty cycle equalizer comprising the Schmitt trigger
inverters in U1109.
b. The two complementary waveforms generated by the two branches of the mixer U1111 are
combined by an amplifier in U1110, and then amplified by a variable-gain amplifier, also part
of U1110. The gain is controlled by the STEP_AGC_10_2 line provided by U1112 (a high level
reduces the gain).
c. The amplified 20 kHz passes through an antialiasing filter, part of U1110, and then it is
converted to a digital data stream by the A/D converter U1115 (para. 2-4.2.2.a).
2-4.7
Synthesizer Subsystem
Refer to Figure A-1.J, Figure A-1.K.d, Figure A-1.L.
2-4.7.1
Frequency Reference
Depending on the installed option, the reference frequency, 16.8 MHz, is generated either by the
DTCXO, U3001, or by the OCXO, U3002.
2-4.7.1.1
DTCXO Option
U3001 is a 16.8 MHz digitally temperature compensated crystal oscillator. Its frequency is controlled
via the SPI port: the temperature compensation data is received via the SPI_DATA_OUT line, and it is
latched into U3001 on the rising edge of the PENDULLUM_SEL line.
2-26
MM-E 2072-09333-00
U5008 can measure the voltage proportional to the ambient temperature near the oscillator (provided
by the thermistor R3023) by means of its internal A/D converter, through the AMB_TEMP line
connected to the AN5/PDA5 input.
2-4.7.1.2
OCXO Option
U3002 is an ovenized crystal oscillator, which includes circuits that enable to maintain the oscillator at
a constant temperature, higher than the ambient. The power for the OCXO is provided by a +10V
linear voltage regulator, U3004.
a. Temperature Control Loop. When U3002 is installed, its temperature indication output,
TEMP_SENSE, is compared by a differential amplifier built around U3000 with the
OVEN_TEMP_CNTL voltages provided by D/A converter U1104. The resulting error voltage
is amplified, and used to drive, via Q3000, the HEAT_CONT input of the OCXO. The current
flowing through Q3000 is monitored by the OCXO using R3024, R3025, via the CUR_SENSE
input.
b. Frequency Adjustment. The microcontroller U5008 adjusts the OCXO frequency in accordance
with the stored calibration data. The required information is sent via the SPI_DATA_OUT, and
it is latched in the D/A converter U3010 on the rising edge of the PENDULLUM_SEL line. The
resulting DC voltage is applied to the D2A_FREQ input of U3002.
2-4.7.1.3
Distribution of 16.8 MHz Reference Frequency
The squarewave provided by U3001 or U3002 is connected to two amplifiers, Q3001 and Q3002:
a. The signal developing at the collector of Q3001 is filtered by a bandpass filter and applied on
the IF_16.8MHz line. The IF_16.8MHz line is converted to a squarewave by the Schmitt trigger
in U1109, for use as the frequency reference for synthesizer 2; in addition, the signal passes
through an additional Schmitt trigger in U1109 to the DSP_16.8MHz line, for the DSP
subsystem.
The output signal of the Schmitt trigger is also applied to the clock inputs of the 4-bit
programmable counters U1113, U1114, which operate as a divider by 39 (para. 2-4.6.3).
b. Q3002 receives the signal through a bandpass filter, and provides the SINE_16.8MHz reference
signal for synthesizer 1.
2-4.7.2
Synthesizer 1
The functional block diagram of synthesizer 1 is shown in Figure 2-13.
SW_A+RF
+5V Regulator
U6024
VOS
+6V Regulator
U2004
VP1
VCO Selection
(FILT_VCO_SEL)
Lock Indication
PLL1 Control Data
VCO 1
90.4-107 MHz
Q9000, Q9063
U6075
OSC_IN
SINE_16.8MHz
Reference
Divider
Phase,
Frequency
and
Lock
Detector
CP
Loop
Filter
VCO 2
107-126.5 MHz
Q9020, Q9064
VCO 3
126-150.2 MHz
Q9040, Q9065
PIN Diode Switch
CR2001-CR2003
VCO Bank
FO_LD
90.4 to 150.2 MHz,
in 17.5 kHz steps
Amplifier
Q2006
Amplifier
U2002
.2
U2009
Filter
FIRST_INJ
46.7 to 75.1 MHz,
in 8.75 kHz steps
Programmable
Divider
FIN
Figure 2-13. Synthesizer 1, Functional Block Diagram
2-27
MM-E 2072-09333-00
a. PLL Control. Synthesizer 1 is a PLL using the frequency synthesizer control subsystem U6075
to generate a control voltage for one of the three VCOs used to cover the required frequency
range.
The control voltage is derived by the loop filter C2142, C2117, R2047, R2045, C2118, which
integrates the pulses appearing at the phase/frequency detector output, CP. These pulses are
generated by comparing the reference frequency connected to the OSC_IN input with a sample
of the selected VCO output, connected to the FIN input. Both signals undergo frequency
division inside U6075: the division ratio is determined by the data carried by the SR_DATA
line, when the PLL_1_SEL line rises to a high level.
b. VCO Selection. The VCO corresponding to the current operating frequency range is enabled by
a high level applied on the corresponding FILT_VCO_SEL line. A high level also turns on the
corresponding PIN diode, CR2001 to CR2003, thereby connecting the VCO output signal to the
amplifier, Q2006. A sample of the Q2006 output signal is connected to the FIN input of U6075,
to close the PLL loop.
c. Output Circuits. The output signal of Q2006 is also applied to the amplifier U2002. U2002
output signal drives the clock input of the divider by 2, U2009. U2009 output is filtered by a
bandpass filter, and connected via the FIRST_INJ line to the first mixer.
d. The regulated supply voltages needed by the synthesizer 1 are provided by two linear regulators,
built around U2004 and U6024.
e. The FO_LD lock indication provided by U6075 is combined by CR2000 with the lock
indication of U6076, to obtain the SYNTH_LOCK synthesizer status line (high level indicates
loss of lock).
2-4.7.3
Synthesizer 2
Figure 2-14 shows the functional block diagram of the synthesizer 2.
SW_A+RF
+5V Regulator
U6025
VOS2
Lock Indication
FO_LD
TX: 368.4 MHz, 10 kHz steps
RX: 352.4 to 369.2 MHz, 10 kHz steps
U6076
OSC_IN
16.8 MHz
Reference
Divider
Phase,
Frequency
and
Lock Detector
CP
Loop
Filter
VCO 4
Q9060
Amplifier
Q2007
Amplifier
U2003
.8
U2010
TX_SEC_INJ
Filter
TX: 46.15 MHz, 1.25 kHz steps
RX: 44.05 to 46.15 MHz, 1.25 kHz steps
Programmable
Divider
FIN
PLL2 Control Data
Figure 2-14. Synthesizer 2, Functional Block Diagram
a. PLL Control. Synthesizer uses a PLL control built around U6076, which is similar to U6075
(see para. 2-4.7.2.a). The control voltage generated by the loop filter is applied to the frequency
control input of VCO 4.
b. VCO 4 output signal is amplified by Q2007. A sample of the Q2007 output signal is connected
to the FIN input of U6076, to close the PLL loop.
c. Output Circuits. The output signal of Q2007 is also applied to the amplifier U2003. U2003
output signal drives the clock input of the divider by 8, U2010. U2010 output is filtered by a
bandpass filter, and connected via the TX_SEC_INJ line to the second mixer.
d. The regulated supply voltage needed by the synthesizer 2 is provided by a linear regulator built
around U6025.
2-28
MM-E 2072-09333-00
2-4.8
Main Microcomputer Subsystem
Refer to Figure A-1.F, Figure A-1.G.
2-4.8.1
Microcontroller U5008
The main microcomputer subsystem is built around U5008, a 16-bit microcontroller with a 2K internal
RAM, and 48KB masked ROM. U5008 has a large number of I/O ports, a serial peripheral interface
(SPI), and two serial communication interfaces (UARTs), and an internal 8/10-bit A/D converter with
8 multiplexed analog inputs.
U5008 includes an internal clock synthesizer, which uses the 38.4 kHz crystal, Y5000 or Y5002, as its
frequency reference. The internal clock frequency is 16.8 MHz (nominal).
U5008 addresses the other circuits via a 19-bit address bus, ADDR0 to ADDR18. Data is transferred
via a 16-bit bidirectional data bus, DATA0 to DATA15. The direction of data flow over the bus is
controlled by the R/W_ line, and the components that can access the data bus are selected by chipselect (CS) lines generated by U5008.
U508 is powered by +5V from the VCC line, and by +5V provided by the regulator U6021. A
power-up controller, U5014, monitors the VCC line and provides a reset signal to restart the
microcontroller and other LORD circuits when the voltage on the VCC line rises to the normal level.
2-4.8.2
Memory Subsystem
a. Flash Memory. The flash memory, used to store the application software, comprises two 256K
units with 16-bit words, U5001 and U6035. Each unit can be separately accessed, under the
control of the FLASH1 and FLASH2 lines provided by U5008.
The VPP write protect line (inverted by Q5005) prevents accidental write access to the flash
memory.
b. RAM. The RAM includes two 512K units, U5009 and U5010. In addition to the storage of
temporary variables during program execution, the RAM is also used to store operational
parameters, and therefore its supply voltage line, VBAT, can receive +5V from the VCC supply
line, or the voltage provided by the backup battery via connector J4.
The RESET line provided by U5014 is used to prevent accidental access to the RAM during
power-up, or whenever the VCC supply voltage is not within the allowed limits.
c. EEPROM. The EEPROM, U6043, is a 32K unit used to store calibration data. Access to the
EEPROM is controlled by U5008, via an access control circuit built around U6099.
2-4.8.3
Input/Output Ports
The general-purpose I/O ports of U5008 are used to generate discrete control signals, and to monitor
various status lines provided by other circuits.
In addition to its own ports, U5008 uses a set of output ports, implemented by means of the external
latches U6068, U6069, U6070, to generate control signals that change only when the operating mode
or conditions change. The access to these ports is controlled by an I/O decoder, implemented by the
latch U6079.
2-4.8.4
Handling of Analog Signals
a. U5008 has an internal A/D converter that is used to measure analog voltages. The voltages to
measured are connected to the AN0/PADA0 to AN7/PADA7 ports, and an internal multiplexer
selects the signal to be digitized at each instant.
b. The D/A converter U1104 is used to generate the BIAS OUT power control reference for the HI
POWER module, and the oven temperature control signal for the OCXO option.
2-29
MM-E 2072-09333-00
2-4.8.5
SPI
The SPI comprises a serial data line, SPI_DATA, and an associated clock line, SPI_CLK. These lines
are used to communicate with other circuits, via serial/parallel converters.
Each converter also receives a load (strobe) command, which indicates when to update its outputs. The
functions of the various serial/parallel converters are described next to the circuits which are
controlled by them.
2-4.8.6
UARTs
a. U5008 includes two internal UARTs: one of them is used to communicate with the CONTROL
HEAD module, via the CH_RXD and CH_TXD lines.
b. In addition, U5008 also uses the four UARTs in U6078 to add four additional asynchronous
communication channels, identified as A, B, C, and D, which are available in the ACCESSORY
connector, J5. These channels pass through the RS-232 transceivers, U6062 and U6063.
U5008 ECLK output provides the clock signal to the UARTs, and selects the appropriate UART
in U6078 by means of chip-select lines provided by the I/O decoder U6079.
Each UART connects to the data bus lines DATA8 to DATA15, and signals U5008 that it needs
access to the bus via interrupt lines, INTA to INTB.
c. When the optional GPS receiver is installed, the B channel (RXB, TXB) is routed by the
switches U5007, U5008 to connector J8, for connection to the GPS receiver UART lines.
2-4.9
Power Supply Subsystem
LORD module uses the +5V supply voltage provided by the HI POWER module via the VCC line. In
addition, the LORD module includes a set of local regulators, which are powered from the protected
raw supply voltage line, SW_A+, also received from the HI POWER module.
These local voltage regulators are used to provide the regulated supply voltages needed by the
microcontroller (U6021), the DSP subsystem (U6097), the audio subsystem (U6098), the synthesizers
(U6024, U6025, U2004), and the IF and RF subsystem (U1106, U1107).
The 9V supply voltage generated by U1106 is used by circuits in the common parts of the IF and RF
subsystem: a separate circuit is used to generate the 9R voltage used only by the receive path circuits,
and the 9T voltage used only by the transmit path circuits.
2-30
MM-E 2072-09333-00
2-4.10 LORD Module Test Point Data
The LORD module has several test points, which enable measurement of signal levels and frequencies
using a spectrum analyzer. Figure 2-16 provides a map of the available test points, and Figure 2-15
provides typical signal levels and frequencies at critical points (these test points are identified by a
larger type in Figure 2-16). These test points can be used for troubleshooting purposes.
Gain (dB)
-3
-2.5
13
10
-6
12
-4
15
P (dBm)
-95
-98
-100
-100
-86
-98
-104
-88±4
-97
-82
F (MHz)
FIN
FIN
FIN
FIN
FIN
FIN
45.1
45.1
45.1
45.1
Designation
*1
*2
PS_OUT AMP_1 AMP_2
Second AMP_4 AMP_3 XTAL_OUT
Mixer
IF2_3
RX IN
Bidirectional
IF amplifier
Gain (dB)
-6
22
-1.5
-1.5
13
28
P (dBm)
-82
-88
-66
-67.5
-59.5
-61
-48
-48
-20
-20
F (MHz)
45.1
0.45
0.45
0.45
0.45
0.45
0.45
0.02
0.02
0.02
Designation
IF2_3
IF3_1
IF3_2
IF3_3
IF3_4
IF3_5
IF3_6
AF_2
AF_3
ADC_IN
Second
mixer
Second
IF amplifier
Second
IF amplifier
Second
IF amplifier
Gain (dB)
-6
15
-4
-6
-6
25
-6
P (dBm)
-25
-31
-15±4
-21
-27
-33
-6
-6
-12
F (MHz)
1.05
45.1
45.1
45.1
45.1
FOUT
FOUT
FOUT
FOUT
Second
Mixer
EX_AMP_LPF
*3
EX_AMP_OUT
Designation DSM_N IF2_3 XTAL_OUT AMP_3 AMP_4
30 MHz
TX LPF
Attenuator
Figure 2-15. LORD Module, Typical Test Point Signal Frequencies and Levels
2-31
2-32
FS
DCSI
TMS
DE_
ALTIN
TD1
JTAG_RESET
TRST
TD0
TCK
DTXCP
DTXCM
DSM_OUT
GND
HA0
HREQ_
HA1
HA2
HRW
EX_AMP_OUT
TP_1
TP_2
R9701
AF_3
16.8_SQR
IF3_4
IF3_6 IF3_5
AF_2
XTAL_OUT
AMP_3
EX_AMP_IN
IF3_3
IF3_2
SYN2_D
SYN2_RF_TO_MIXER
SYN2_CLK
SYN2_LD SYN2_LE
SYN2_CONTROL
Figure 2-16. LORD Test Points Map
ADC_IN
EX_AMP_LPF
DSM_N
TEMP_CONT_IN
TEMP_SENSE
TEMP_CONT
SYN1_16.8MHZ
FREQ_CONT
D2A_TEMP_CONT
SYN2_VCO_OUT
SYN1_CONTROL
IF2_3
IF3_1
SYN1_D
SYN1_LD
AMP 4
SYN1_LE
SYN1_CLK
SYN1_RF_TO_MIXER
MIX_1
LPF 1
AMP 2
ATT2
ATT2+
PS OUT
ATT1
AMP 1
MM-E 2072-09333-00
MM-E 2072-09333-00
2-5. HI POWER MODULE
The functional block diagram of the HI POWER module is shown in Figure 2-17. The HI POWER
module comprises the power amplifier subsystem, the harmonic filter circuits and their control
circuits, and the Micom-Z power supply subsystem.
2-5.1
Power Amplifier (PA)
2-5.1.1
ALC Attenuator
Refer to Figure A-2.B.
The RF_INPUT_TX signal received via connector P4 from the LORD module is connected to the
ALC attenuator, comprising R77 and the PIN diodes CR8, CR9.
The attenuation is controlled by the V_ALC voltage: a higher voltage increases the attenuation.
2-5.1.2
Power Amplification Chain
Refer to Figure A-2.B.
a. Predriver. The ALC attenuator output signal is amplified by the predriver stages Q5 and Q7.
The supply voltage to Q5 and Q7, VDD_PREAMP, is connected only in the transmit mode, by
a switch comprising Q10, Q12: the switch connects the SW_BATT line only when 9V appear
on the 9T line.
The bias voltage for Q5 and Q7 (3V nominal) is provided by the +3.3V linear regulator, U1, via
voltage dividers connected to their gates.
The bias voltage is present only when the PA_INHIBIT line is at a high level.
b. Driver. The predriver output, PRE_DRIVER, is amplified by a push-pull stage comprising Q3
and Q4. The bias voltages are provided by the +5V linear voltage regulator U6, via the
potentiometers R67, R73.
The bias voltage is present only when the BIAS_EN line is at a high level.
c. Power Amplifier. The driver output signal is amplified by a push-pull stage comprising Q6 and
Q11. The bias voltage is derived from the +3.3V provided by the linear regulator U11, via the
source follower stage, Q8: Q8 source voltage is determined by the collector voltage of Q2,
which can be adjusted by means of potentiometer R22.
The bias voltage is present only when the BIAS_EN line is at a high level, and both the +5V
and +10V voltages are present.
2-5.2
TX/RX Switch
Refer to Figure A-2.C.
The RF output of the power amplifier, PA_OUT, is connected to the TX/RX switch, the relay K1.
a. In the receive mode, K1 is not energized and connects the harmonic filter output to the
RX_TO_LORD line.
b. In the transmit mode, and also in the BIT mode, K1 is energized by the 9T and/or BIT lines, and
connects the PA_OUT line to the harmonic filter bank.
2-5.3
Harmonic Filter Bank
Refer to Figure A-2.C, Figure A-2.D.
The harmonic filter is used to attenuate the unwanted spurious and harmonics of the transmitted and
received signals. The direction of flow through the harmonic filter is determined by the TX/RX
switch, K1, as explained in para. 2-5.2.
The harmonic filter contains seven low pass filters. The filter corresponding to the operating frequency
2-33
MM-E 2072-09333-00
is inserted in the signal path by a pair of relays, controlled by the LORD module via the serial data line
SPI_DATA.
The relay control data is loaded into the serial/parallel converter U4 at the rate of the SPI_CLK clock
signal, and updates the U4 outputs when the SPI_SEL line rises to a high level. Each U4 output drives
one pair of relays, via Darlington stages in U3: at any time, only one U4 output assumes a high level,
causing the corresponding pair of relays to energize and insert a filter in the RF signal path.
The filter ranges and the corresponding relays are listed in Table 2-8.
Table 2-8. Harmonic Filter Frequency Ranges and Controlling Relays
2-5.4
Filter
Frequency Range
Relays
1.6 to 2.43 MHz
K101, K102
2.43 to 3.7 MHz
K201, K202
3.7 to 5.6 MHz
K301, K302
5.6 to 8.5 MHz
K401, K402
8.5 to 13 MHz
K501, K502
13 to 19.8 MHz
K601, K602
19.8 to 30 MHz
K701, K702
Power Sensor
Refer to Figure A-2.C.
The forward/reflected power sensor, comprising T4 and the rectifiers CR6 and CR7, is inserted
between the filters and the antenna connector, J2.
During transmission, it generates two DC signals:
a. V_FWD_RADIO, proportional to the forward RF power delivered to the antenna
b. V_REV_RADIO, proportional to the RF power reflected from the antenna.
The signals are sent to both the ALC control circuits, and to the microcomputer system in the LORD
module, for controlling the transmit power as a function of the following parameters (see para. 2-5.5):
• VSWR value: if the VSWR increases above 2:1, the output power is gradually decreased, to
protect the radio from high reflected power.
• Harmonic filter insertion losses: if the harmonic filter insertion loss is too high, the output power
level is decreased.
2-5.5
ALC Circuits
Refer to Figure A-2.E.
a. Internal/External Power Amplifier Selector. Normally, Micom-Z uses its internal RF power
amplifier, and a low level is applied to Q807 via the EXT_AMP_EN line. The analog switches
in U12 then connect the V_FWD_RADIO and V_REV_RADIO lines to the ALC circuits.
b. Forward Power Control. The V_FWD_RADIO voltage passes through the peak detector (U5,
CR809) to the ALC error amplifier, U13. U13 compares the level with the ALC_REF_DAC
power reference received from the LORD module via the non-inverting buffer U15: a higher
V_FWD_RADIO level causes the output (pin 4) of U13 to assume a lower voltage, resulting in
a higher voltage at the emitter of Q23, which drives the V_ALC line.
This increases the attenuation of the ALC attenuator, tending to return the transmit power to its
normal level. The reverse action occurs when V_FWD_RADIO is less than normal.
2-34
MM-E 2072-09333-00
To LORD
P2
RX_OUT
SW_BATT
Q10, Q12
9T
P4 RF_INPUT_TX
ALC
Attenuator
CR8, CR9
Predriver
Amplifier
Q5, Q7
SW_BATT
SW_BATT
Driver
Amplifier
Q3, Q4
TX/RX
Switch
K1
Power Amplifier
Q6, Q11
Harmonic Filter
J2
K102
K101
PA_OUT
Band 1 (1.6 - 2.43 MHz)
PWR_AMP_BIAS
ALC_REF_DAC
ALC Circuit
U5, U13, U14
V_FWD_RADIO
V_REV_RADIO
R67
Predriver Bias
Generator
U1
PA_INHIBIT
R73
V_REV_RADIO
K302
K301
Band 3 (3.7 - 5.6 MHz)
9T
BIT
K402
K401
Band 4 (5.6 - 8.5 MHz)
K502
K501
Driver Bias
Generator
U6
V_FWD_RADIO
Band 2 (2.43 - 3.7 MHz)
Driver
Q801
To ANT
K202
K201
VALC
Power Sensor
T4, CR6, CR7
PA Bias
Generator
Q2, Q8, U11
Band 5 (8.5 - 13 MHz)
R22
K602
K601
Band 6 (13 - 19.8 MHz)
10VDC
+10VDC
+5V
+10VDC
K701
K702
Band 7 (19.8 - 30 MHz)
V_TEMP_PA
Temp Sensor
RT3, Q806, U9
Relay Control Signals
TEMP1
Overheat
Protection
Q10
9T
BIAS_EN
SPI_SEL
From LORD
SPI_CLK
Serial/Parallel
Converter
U4
Relay Drivers
U3
SPI_DATA
CH_CHANGE
Protection
Circuit
U22, U19
ATU DC
Switch
Q17, Q15,
Q802, Q803
Tuner Current Limit
E1
DC_PWR_IN
E2
ON/OFF
Switch
and Surge SW_BATT
Protector
U23, Q14,
Q26
Filter
DC_PWR_EN
BATT_CHECK
SW_BATT_PS
Dual
Switching
Regulator
U20
+10V
Regulator
Q13, U21
+10VDC
+8V
Regulator
U16
+5V
Regulator
Q1, U2
+8VDC
+5VDC
Battery Voltage
Monitor
U10, VR4
Figure 2-17. HI POWER Module, Functional Block Diagram
2-35/2-36
MM-E 2072-09333-00
c. Reverse Power Protection. The V_REV_RADIO voltage passes through the peak detector (U14,
CR811) to the reverse power comparator, U13: when the reverse power increases, the output
(pin 5) voltage decreases, resulting in a higher voltage at the emitter of Q23, which drives the
V_ALC line.
d. Overheat Protection. The thermistor RT3 causes the voltage on the V_TEMP_PA line
(monitored by U5008, located on the LORD module), to be proportional to the internal
temperature.
When the temperature is too high, the voltage on the V_TEMP_PA line exceeds the threshold of
the comparator U9, and the TEMP1 lines assumes a high level. This turns Q19 on, and turns off
the bias voltages via the BIAS_EN line.
2-5.6
Power Supply Subsystem
Refer to Figure A-2.F.
a. ON/OFF Switch and Surge Protector. The ON/OFF switch comprising the MOSFETs Q14,
Q26, connects the DC input voltage to the internal power supply line, SW BAT, only if the
GATE output of the surge stopper U23 provides a sufficiently high gate drive voltage. This
occurs only when the Micom-Z is turned on (provided the polarity of the input voltage is
correct: otherwise, U23 shut down input is pulled to ground even if the DC_PWR_EN line is
connected to ground by switching the Micom-Z ON).
Moreover, Q14 and Q26 will be turned off by U23 if the input voltage line, DC_PWR_IN, is
not within the allowed range.
When Q14 and Q26 are both ON, the input voltage is connected to the internal protected supply
voltage line, SW_BATT.
The SW_BATT line is monitored by U5008, located on the LORD module, via the battery
voltage monitor, U10.
b. Micom-Z Power Supply. The SW_BATT line is used to power the dual switching regulator,
U20.
One section of U20 drives the step-down converter that powers the +10V linear regulator, U21.
The linear regulator U16 uses the +10 VDC voltage to provide +8 VDC.
The other section of U20 drives the step-down converter that powers the +5 VDC linear
regulator, U2.
c. ATU DC Power Switch. The SW_BATT line can be connected to the DC_ANT_CPLR line by
the switch Q15.
To turn Q15 on, the LORD module provides a high level on the CH_CHANGE line.
The current flowing through Q15 is monitored by Q802: if the current is too high, Q803
saturates, and resets the latch U22. The resulting low level on the LATCH line turns Q15 off.
The TUNER_CURR_LIM line is also monitored by the LORD module.
2-37
MM-E 2072-09333-00
2-6. CONTROL HEAD MODULE
Figure A-3 shows the schematic circuit diagram of the CONTROL HEAD module for both the
dash-mount and trunk-mount versions.
2-6.1
CONTROL HEAD Module for Dash-Mount Version
Figure 2-18 shows the functional block diagram of the CONTROL HEAD module used in the
Micom-Z dash-mount version.
2-6.1.1
Microcontroller
Refer to Figure A-3.B.
a. Microcontroller. The microcontroller, U1, is a 16-bit microcontroller with a 8 kB data RAM, a
128 kB flash memory that stores the application program, two A/D converters with 8
multiplexed inputs, two D/A converters, two UARTs and a large number of input and output
ports. Its internal clock oscillator uses the 7.3728 MHz crystal Y1 as a frequency reference.
b. Keypad Interface. The keypad (Figure A-3.C) is a 5×5 matrix of switches, with the row lines
connected to the 3V3_IF line via series resistors. The row and the column lines are connected to
ten of the I/O ports of U1, which can thus detect the pressing of each key, including the volume
control keys.
P3
P6
Audio
Connector
3V3
3.3V
Regulator
U4
3V
Regulator
U5
3V0
5V0
Panel
Serial Control Channel
(UART 0)
J3
Microcontroller
U1
To
LORD
LCD
P4
P2
Y1
Keypad Lighting
Control
Q504, Q506
LCD Heater
Control
U7, Q1, Q3, Q501
14V7
DC/DC
Converter
U6, Q2
13V8DC
LED Lighting
Control
Q502, Q503
Figure 2-18. CONTROL HEAD Module for Dash-Mount Version, Functional Block Diagram
2-38
MM-E 2072-09333-00
c. ON/OFF Control. The ON/OFF push-button, SW26, is normally open: when pressed to turn the
Micom-Z on, it connects ground to the ON_OFF_CONT line, which turns the power supply
subsystem on the HI POWER module on.
When Micom-Z operates, the microcontroller U1 can read the status of the switch via an
inverter in U3: when the switch is pressed again, the microcontroller is alerted to the turn-off
request, and keeps the ON_OFF_CONT line at a low level by turning Q507 on via the
POW_OFF_CPU line, until it completes its shut-down routine.
d. LCD Interface. The LCD interfaces with U1 via the CPU_D0 to CPU_D7 data bus.
e. Communication with LORD module. U1 communicates with the microcomputer subsystem on
the LORD module via a serial control channel, connected to the internal UART 0.
2-6.1.2
Auxiliary Power Supply
Refer to Figure A-3.E.
The 13V8DC supply line received via the LORD module is converted to 14.7V by the DC/DC
converter comprising the pulse-width modulation (PWM) controller U6, which drives the switching
MOSFET Q2.
The resulting pulses at the secondary of T1 are rectified by CR2, and filtered by C72, C79, C83 to
obtain the 14V7 auxiliary supply voltage line.
U6 starts operating only when a high level is applied by U1 on the VLED_HEAT_EN line, to turn Q7
on.
2-6.1.3
LCD Heater and Backlighting Control
a. LCD Backlighting. The 14V7 line can be connected by Q503 to the VLED_BL_LCD line by
applying a high level on the LCD_BL_EN line, thereby turning Q505 on.
b. LCD Heating. The 14V7 line can be connected by Q1 to the VHEAT_LCD line by applying a
high level on the LCD_HEAT_EN line. This causes Q3 to cut off. U7 output falls to a low level
to turn Q1 on, thereby connecting power to the VHEAT_LCD line.
The voltage on the VHEAT_LED line is regulated by U1, using feedback from the voltage
R158, R581, R159, R167, R536: by applying a high level on the LCD_HEAT_LEVEL line,
which turns Q501 on, the voltage can be reduced, thereby reducing the heating power to the
LCD.
2-6.1.4
Keypad Lighting
The 14V7 line can be connected by Q504 to the VLED_BL_KB line by applying a high level on the
KB_BL_EN line, thereby turning Q506 on.
2-6.1.5
MIC Connector Interface
The MIC connector, P6, includes the following interface lines:
a. Serial control channel (RXD, TXD), connected directly to the LORD side connector, P3.
b. PTT_MIC line, inverted by U3 and connected to connector P3.
c. MIC_IN line, connected to connector P3.
2-6.1.6
Power Supply Subsystem
The power for the CONTROL HEAD module is provided by the 5V0 line. The +5V supply voltage is
converted by the linear regulator U4 to +3.3V on the 3V3 line.
The linear regulator U3 provides +3V to the VDD_LCD_3V0 line.
2-39
MM-E 2072-09333-00
2-6.2
CONTROL HEAD Module for Trunk-Mount Version
Figure 2-19 shows the functional block diagram of the CONTROL HEAD module used in the
Micom-Z trunk-mount version.
8V0_AUDIO
P501
P6
MIC_IN
Amplifier
U503
TX_AUDIO
Audio
Connector
PTT_MIC
RS-485
Line Driver
U506
PTT
3V3
3.3V
Regulator
U4
3V
Regulator
U5
3V0
5V0
Serial Control Channel (UART 0)
RS-485
Line Receiver
U504
CH_RXD
TX_UART0
RS-485
Line Driver
U505
CH_TXD
14V7
Voltage
Regulator
U6, Q2
5V0
Voltage
Regulator
U501
8V0_AUDIO
Voltage
Regulator
U502
RX_UART0
J3
Microcontroller
U1
LCD
P4
To INTERCONNECTION
Panel
P2
Y1
Keypad Lighting
Control
Q504, Q506
LCD Heater
Control
U7, Q1, Q3, Q501
LED Lighting
Control
Q502, Q503
13V8DC
Figure 2-19. CONTROL HEAD Module for Trunk-Mount Version, Functional Block Diagram
2-6.2.1
Microcontroller
Refer to Figure A-3.B, Figure A-3.C.
The microcontroller subsystem is similar to that used in the dash-mount version (para. 2-6.1.1). The
connection of the serial control channel to the LORD module (via the INTERCONNECTION module)
2-40
MM-E 2072-09333-00
is made via an RS-485 transceiver, comprising the line receiver U504 and the line driver U505 (refer
to Figure A-3.E).
2-6.2.2
Auxiliary Power Supply
Refer to Figure A-3.E.
The auxiliary power supply is similar to that of the dash-mount version (para. 2-6.1.2).
2-6.2.3
LCD Heater and Backlighting Control
The LCD heater and backlighting control circuits are similar to the dash-mount version (para. 2-6.1.3).
2-6.2.4
Keypad Lighting
The keypad lighting control circuits are similar to the dash-mount version (para. 2-6.1.4).
2-6.2.5
MIC Connector Interface
Refer to Figure A-3.F.
a. The MIC_IN signal is amplified and converted to a balanced signal (TX_AUDIO_P,
TX_AUDIO_N) by the amplifiers in U503, for transmission over the interconnection cable.
b. The PTT_MIC signal is converted to a RS-485 balanced signal by the RS-485 line driver U506.
2-6.2.6
Power Supply Subsystem
Refer to Figure A-3.D.
The power for the CONTROL HEAD module is provided via the 13V8DC line:
a. The linear regulator U501 converts the 13V8DC line to +5V on the 5V0_INT line.
b. The linear regulator U502 converts the 13V8DC line to +8V on the 8V0_AUDIO line. U503
derives a +4V voltage, AUDIO_BIOS, for the MIC IN audio amplifier.
c. The +5V supply voltage is converted by the linear regulator U4 to +3.3V on the 3V3 line.
d. The linear regulator U3 provides +3V to the VDD_LCD_3V0 line.
2-41
MM-E 2072-09333-00
2-7. INTERCONNECTION MODULE
Refer to Figure A-4.
Figure 2-20 shows the functional block diagram of the INTERCONNECTION module.
P2
P1
Amplifier
U1
TX_AUDIO
MIC_IN
To Internal Circuits
13V8_RADIO_TRUNK
To
Control
Head
Voltage
Regulator
Q1, U2
13V8_DC_RADIO
ON_OFF_CONT_PNL
To
LORD
PTT
Line
Receiver
U5
PTT_MIC
CH_RXD
Line Driver
U4
RX_UART0
CH_TXD
Line
Receiver
U3
TX_UART0
Figure 2-20. INTERCONNECTION Module, Functional Block Diagram
a. The TX_AUDIO_P, TX_AUDIO_N balanced signal is converted to a single-ended signal,
MIC_IN, by the audio amplifier U1.
b. The RS-485 balanced PTT signal is converted to a single-ended signal, PTT_MIC, by the
RS-485 line receiver U5.
c. The RS-485 balanced CH_TXD signal is converted to a single-ended signal, TX_UART0, by
the RS-485 line receiver U3.
d. The RX_UART0 signal is converted to a RS-485 balanced signal, CH_TXD, by the RS-485 line
driver U4.
e. The 13V8_DC_RADIO supply voltage received from the LORD module is connected to the
voltage regulator built around U2 and Q1.
Q1 connects the supply voltage to the 13V8_RADIO_TRUNK line supply voltage, which
powers the control head assembly through the interconnection cable.
In addition, the 13V8_RADIO_TRUNK line supply voltage is used to provide power to the
amplifier U1. Another amplifier in U1 provides the AUDIO_BIAS reference voltage for the
audio amplifier.
2-8. FAN CONTROL MODULE
Refer to Figure A-5.
The cooling tray includes the FAN CONTROL module. This module provides the connections
between the radio side connector, J2, and the user’s side connector, J3. In addition, it includes a
voltage regulator comprising U1 and Q2, which provides +12VDC to the fan installed in the tray. The
voltage regulator starts providing the voltage when a high level is applied on the DSO/FAN_ON_OFF
line: this turns Q1 on, and enables U1.
2-42
MM-E 2072-09333-00
Chapter 3
MAINTENANCE
3-1.
SCOPE
This Chapter provides maintenance instructions for Micom-Z.
The information presented in this Chapter covers testing, troubleshooting procedures, and repair
instructions. Use Appendix B to identify components and find other data needed for troubleshooting
and repair.
3-2.
HANDLING PRECAUTIONS DURING MAINTENANCE
Equipment maintenance is performed in accordance with standard practice. During equipment
maintenance, observe the following precautions:
a. To preserve equipment reliability, the equipment should be serviced only in a protected, clean
environment.
b. Electronic components, in particular CMOS and RF devices, are susceptible to damage by
electrostatic discharge (ESD). Electrostatic charge is created by friction between different
bodies, including the human body, especially under dry conditions. Damage can be latent,
resulting in failures occurring weeks or months later. Therefore, special precautions must be
taken to prevent device damage during disassembly, troubleshooting, and repair. To prevent
damage, use the following precautions:
•
Eliminate static generators (plastics, styrofoam, etc.) in the work area.
•
Remove nylon or double-knit polyester jackets, roll up long sleeves, and remove or tie back
loose hanging neckties.
•
Disconnect all power from the unit before starting repair activities.
•
Use a static safeguarded workstation, which can be accomplished through the use of an antistatic kit, which typically includes a wrist strap, two ground cords, a static-control table mat,
and a static-control floor mat.
When these items are not readily available, observing the following techniques will
minimize chance of damage:

If a static-sensitive device is to be temporarily set down, use a conductive surface for
placement of the device.

Make skin contact with a conductive work surface first and maintain this contact when
the device is set down or picked up.
c. Keep any module (good or defective) in the original packaging, even when the module is placed
on the workbench.
d. Handle modules carefully; do not drop modules, and avoid piling them up, because the exposed
components may be damaged by physical stress and shock. Always use the original packaging
of the module and do not use alternative packaging, unless the original one is damaged or lost.
The original packaging is designed to absorb mechanical shocks and to protect the equipment
against electrostatic discharge.
e. Hold a module by its sides, and avoid touching its connectors or electronic components installed
on the module. This practice will prevent mechanical damage, oily deposits on contacts and
damage due to electrostatic discharge.
3-1
MM-E 2072-09333-00
f. Micom-Z modules make extensive use of surface-mounted (SMT) components and
miniaturization, therefore personnel involved in troubleshooting and repair must be thoroughly
familiar with the applicable workmanship procedures. No special tools are needed for repair,
except for a standard technician’s toolbox and a soldering/desoldering station with an
appropriate set of tips, considering the component types used in the module (in particular multilead and SMT components). Use standard workmanship practice for repair and component
replacement procedures:
•
Pay special attention to avoid overheating or damage to adjacent components. Use only a
soldering tool with a temperature-controlled tip, and minimize heating time.
•
Pay attention to the orientation of polarized components.
•
During soldering of RF transistors, use minimum solder and make sure that the solder does
not flow to other areas.
Clean the module after any repair, and thoroughly remove any remaining foreign matter, in
particular solder remnants. Inspect visually after repairs are completed.
g. Whenever a cover or a PCB is fastened by multiple screws, first insert all the screws and tighten
them by hand, and then use a screwdriver, to tighten completely the screws. Tighten the screws
alternately, starting with the screws at the opposite ends of one diagonal, then those at the ends
of the other diagonal. Do not tighten one screw completely and then the others: take up one turn
at a time for each screw, sequentially, in the order described.
Avoid exerting excessive torque when tightening screws. Table 3-1 provides standard tightening
torques for screws (the allowed torque tolerance is ±10%).
Table 3-1. Tightening Torques for Screws
Screw Size
Thread Forming
Metallic Surface
Threaded Metallic
Surface
Plastic
Surface
Metric System Screws
M3
10 kgf/cm
10 kgf/cm
6 kgf/cm
M4
15 kgf/cm
15 kgf/cm
7 kgf/cm
M5, M6
22 kgf/cm
18 kgf/cm
8 kgf/cm
American System Screws
3-2
4-40
10 kgf/cm
7 kgf/cm
6 kgf/cm
6-32
15 kgf/cm
15 kgf/cm
7 kgf/cm
8-32, 10-32
22 kgf/cm
18 kgf/cm
8 kgf/cm
MM-E 2072-09333-00
3-3.
CLEANING
WARNING
Prolonged breathing of cleaning compounds may be dangerous; make
certain that adequate ventilation is provided. Do not use near a flame.
Avoid contact with the skin. If contact with skin is made, immediately
wash off with water.
Before performing any maintenance actions, clean the equipment in accordance with the following
procedure:
a. Inspect the exterior of the unit. The surfaces should be clean and free of dirt, grease and other
contaminants.
b. Remove dust and other loose dirt with a soft clean cloth. If dirt is difficult to remove, dampen
the cloth with water; mild soap may be used for more effective cleaning.
c. Remove grease, fungus and ground-in dirt from the cases: use a lightly dampened cloth (not
wet) with an approved cleaning compound.
d. Remove dirt from connectors with a brush.
3-4.
TESTING
3-4.1
Micom-Z Testing
a. Full Performance Tests. The Micom-Z radio sets are tested by means of an automatic test
station, Mfg. Cat. No. 2089-08892-00. Refer to the test station documentation for detailed
procedures.
b. Periodic Alignment and Calibration. The transmit power and frequency accuracy of Micom-Z
radio can be calibrated using the PC-based Radio Service Software (RSS), option G424
(FVN4841). Refer to the RSS User Guide, Publication 6886867J01, for detailed instructions.
3-4.2
Module Testing and Alignment
The following automatic test stations are used to test and align Micom-Z modules:
• LORD module – use test station Mfg. Cat. No. 2072-08001-00.
• HI POWER module - use test station Mfg. Cat. No. 2072-08503-00.
Refer to the test station documentation for detailed procedures.
3-3
MM-E 2072-09333-00
3-5. TROUBLESHOOTING
The purpose of the troubleshooting procedures is to return a defective Micom-Z unit to normal service
as soon as possible, by isolating the malfunction to a replaceable subassembly or module, and then
repairing the subassembly or module.
3-5.1
Overview of Troubleshooting Procedures
In case a malfunction is detected (either during field operation, or during testing), perform the
following steps in the order presented below, until the problem is isolated and corrected:
1. Refer to the troubleshooting instructions given in para. 3-7.2 of the Micom-Z Operator Manual,
which provides instructions for isolating the fault to a replaceable subassembly or module.
These instructions include preliminary troubleshooting, followed by the use of the BITE
function in accordance with para. 3-7.2 of the Micom-Z Operator Manual. After collecting the
error codes, refer to para. 3-5.2 for their interpretation.
2. If the problem is detected during testing, collect and analyze the results of the electrical test
procedures, and then refer to para. 3-5.4 for quick troubleshooting instructions. If the problem
cannot be corrected using the instructions in para. 3-5.4, refer to para. 3-5.5 for systematic
troubleshooting procedures.
Refer to para. 3-6 for Micom-Z disassembly, module replacement, and assembly procedures.
3. After identifying the defective subassembly or module, refer to para. 3-5.5 for module
troubleshooting instructions.
Remember that visual inspection may often detect faults without testing or making measurements.
Therefore, after opening the Micom-Z case, perform a thorough visual inspection and inspect its
wiring and module assemblies for physical damage. In particular, check for any external signs of
damaged components and/or damaged printed circuit boards. The possibility of intermittent faults
should not be overlooked. To reveal such defects, check the wiring, the coaxial cables, and the various
plugs and jacks of the modules. If the inspection reveals damage, replace the suspected part in
accordance with the applicable procedure of para. 3-6 before starting any other troubleshooting
procedures.
After completing the troubleshooting procedure and the associated repair tasks, repeat the full set of
performance checks listed in para. 3-4 to verify that the equipment has been returned to fully
operational condition.
NOTE
After replacing the LORD and/or the HI POWER module, it is
necessary to calibrate the RF transmit power using the RSS.
3-5.2
BIT Error Codes
Table 3-2 explains the meaning of the error codes generated by the BIT function, and lists their most
probable cause.
Table 3-2. BIT Error Codes
Error Code
3-4
Meaning
Probable Cause
00
O.K. – no errors
01
DSP boot checksum fail (during
download)
LORD board problem
02
DSP PLL unlock
LORD board problem
03
DSP external RAM memory
LORD board problem
04
Not applicable
05
DSP internal RAM memory
LORD board problem
MM-E 2072-09333-00
Table 3-2. BIT Error Codes (Cont’d)
Meaning
Error Code
Probable Cause
06
Not applicable
07
Not applicable
08
HC16 flash memory checksum
LORD board problem
09
HC16 RAM memory
LORD board problem
10
No 16.8 MHz clock
Check for good power cable connection.
Possible LORD board problem
11
Battery low
Weak internal battery: replace battery to correct
problem
12
Control head wake-up
Control head problems
13
Control head is not responding
Control head problems
14
Radio not programmed
Problem experienced during programming.
Program radio (connect MRC or RSS at 1200 bps)
15
Database fail
ALE scanned channels do not match the channels
programmed by means of the MRC or RSS
16
VCO 1 first injection
LORD board problem
17
VCO 2 first injection
LORD board problem
18
VCO 3 first injection
LORD board problem
19
VCO second injection
LORD board problem
20
Synthesizer unlock
LORD board problem
21
Receiver failure
LORD board problem
22
Preselector range 1
LORD board problem
23
Preselector range 2
LORD board problem
24
Preselector range 3
LORD board problem
25
Preselector range 4
LORD board problem
26
Preselector range 5
LORD board problem
27
Preselector range 6
LORD board problem
28
Preselector range 7
LORD board problem
29
Preselector range 8
LORD board problem
30
Exciter test
HI POWER board problem
31
Antenna mismatch
Problem with antenna: check antenna and its
connections. If problem persists, it is a HI POWER
board problem
32
Harmonic filter range 1
HI POWER board problem
33
Harmonic filter range 2
HI POWER board problem
34
Harmonic filter range 3
HI POWER board problem
35
Harmonic filter range 4
HI POWER board problem
36
Harmonic filter range 5
HI POWER board problem
37
Harmonic filter range 6
HI POWER board problem
38
Harmonic filter range 7
HI POWER board problem
39
Power amplifier fail
HI POWER board problem
3-5
MM-E 2072-09333-00
3-5.3
Troubleshooting Procedure
The purpose of the troubleshooting procedure presented in this Section is to rapidly return a defective
Micom-Z to service by replacing suspected modules:
a. Identify the closest description of the problem under “Problem Symptom” in Table 3-3.
b. Perform the required corrective actions listed under “Corrective Actions” in the table in the
order of appearance, until the problem is corrected.
If the replacement of an item (module, PCB, assembly) during the troubleshooting procedure
does not correct the problem, reinstall the original item before continuing to the next step.
c. After a trouble is isolated, follow the repair instructions given in para. 3-6.
d. After correcting the trouble and repairing the unit, repeat the performance checks in accordance
with para. 3-4.
Table 3-3. Troubleshooting Procedure
No.
Problem Symptom
Transceiver cannot be turned on
Suspected Module(s)
• LORD module
• HI POWER module
• CONTROL HEAD module
• INTERCONNECTION module (trunk version only)
No receive audio
• LORD module
• CONTROL HEAD module
• INTERCONNECTION module (trunk version only)
Check also the flat cables and the coaxial cables
connections
No RF transmit power but transceiver
switches to the transmit mode
• LORD module
• HI POWER module
• CONTROL HEAD module
• INTERCONNECTION module (trunk version only)
Low RF transmit power
First try to calibrate the RF transmit power using the
RSS.
• LORD module
• HI POWER module
• TUNER module
Transceiver cannot be switched to
transmit mode by pressing the
microphone PTT
• LORD module
• CONTROL HEAD module
• INTERCONNECTION module (trunk version only)
• Microphone
No LCD backlight
CONTROL HEAD module
Blank LCD screen
• LORD module
• CONTROL HEAD module
LCD displays jumbled characters
• CONTROL HEAD module
• LCD
POWER LATCH message appears
• HI POWER module (harmonic filter)
• LORD module
3-6
MM-E 2072-09333-00
Table 3-3. Troubleshooting Procedure (Cont’d)
No.
Problem Symptom
10
Distorted audio receive signal
Suspected Module(s)
• LORD module
• CONTROL HEAD module
• Speaker
11
Excessive current consumption in
receive, or standby mode
• LORD module
• HI POWER module
• INTERCONNECTION module (trunk version only)
12
13
Excessive current consumption in
transmit mode
• HI POWER module
Low audio receive signal
• LORD module
• Transmitter calibration
• HI POWER module
14
Low modulation of transmit signal
• Microphone problem
• LORD module
• HI POWER module
15
Excessive distortion of audio receive
signal
LORD module
16
Transceiver enters the transmit mode,
and cannot be returned to the receive
mode
• LORD module
17
NO CLOCK message appears
LORD module
18
Transceiver cannot be switched to
transmit mode by the voice PTT line in
the ACCESSORY connector
LORD module
19
Transceiver cannot be switched to
transmit mode by the data PTT line in
the ACCESSORY connector
LORD module
20
Transceiver cannot be switched to
transmit mode by the CW PTT (Morse)
line in the ACCESSORY connector
LORD module
21
LORD flash memory cannot be updated LORD module
22
The icons related to the installed
options are not displayed
LORD module
23
SYNT FAIL message appears
LORD module
24
Keypad does not operate normally, or
no response to key pressing
• CONTROL HEAD module
• CONTROL HEAD module
• Keypad
• INTERCONNECTION module (trunk version only)
25
GPS receiver cannot provide position fix • LORD module
• GPS receiver
• Defective GPS antenna
• GPS antenna cable
26
No fan control command (cooling tray
OK)
LORD module
27
No output supply voltage for external
devices in the ACCESSORY connector
LORD module
3-7
MM-E 2072-09333-00
Table 3-3. Troubleshooting Procedure (Cont’d)
No.
Problem Symptom
28
No receive output signals for external
devices in the ACCESSORY connector
LORD module
29
No 13.8 VDC output for ATU in ANT
connector
• HI POWER module
MRC or RSS cannot communicate with
the transceiver via the ACCESSORY
connector
• LORD module
MRC or RSS cannot communicate with
the transceiver via the front panel MIC
connector
• LORD module
32
No front and rear RSS communication
LORD module
33
Excessive harmonic levels
• HI POWER module
30
31
Suspected Module(s)
• Tuner option not selected
• CONTROL HEAD module
• CONTROL HEAD module
• INTERCONNECTION module (trunk version only)
• LORD module
34
35
3-8
Transceiver does not return to last
operating state after being turned off
• Internal battery
Transceiver remains in the power-up
self-test state
LORD module
• LORD module
MM-E 2072-09333-00
3-5.4
Micom-Z Troubleshooting Charts
1. Perform the checks presented in Figure 3-1.
2. If a problem is detected at a checkout step of Figure 3-1, refer to the troubleshooting chart
identified next to the corresponding step, and then perform the troubleshooting activities listed
in the chart until the problem is corrected.
3. After correcting the problem, repeat the checkout procedure in accordance with Figure 3-1.
Start
Perform visual inspection of equipment. Ensure
there is no physical damage.
If damage is found, repair or replace damaged
components before proceeding with checkout
Connect power cable to the power connector
and a wattmeter and dummy load to the ANT
connector. Attempt to turn on
No
Radio
powered on?
Proceed to
troubleshooting
chart 1
Yes
No
Normal display?
Yes
Proceed to
troubleshooting
chart 2
Connect a microphone to
the mic jack. Key the mic
and whistle into it
No
Radio keyed?
Proceed to
troubleshooting
chart 3
No
Proceed to
troubleshooting
chart 4
Yes
Transmit power
present?
Yes
Run the automatic BIT routine
Yes
Any errors
displayed?
Proceed to
Table 3-2
No
Continue to checkout
step 6
Figure 3-1.A. MICOM-Z Checkout Chart (Sheet 1 of 2)
3-9
MM-E 2072-09333-00
Turn radio on and adjust the volume to midrange.
Press the SQ key to alternate between squelch on and
squelch off
Static heard
in the speaker
when squelch
is off?
No
Proceed to
troubleshooting
chart 5
Yes
Select USB mode and connect a signal
generator to the ANT connector. Inject -100 dBm
signal at the radios (operating frequency +1 kHz)
into the radio. Turn on the squelch and vary the
input frequency in a range of ± 500 Hz.
The radio should break squelch and audio
should be heard in the speaker
No
Squelch
operates correctly?
Yes
Proceed to
troubleshooting
chart 6
Perform oscillator calibration and
power output calibration (refer to
RSS user's guide)
No
Proceed to
troubleshooting
chart 7
Any problems?
Checkout complete
Figure 3-1.B. MICOM-Z Checkout Chart (Sheet 2 of 2)
3-10
Yes
MM-E 2072-09333-00
From Checkout Step
Ensure the power supply is on and provides 13.8 VDC
to the radio. Check inline fuse: replace if necessary
Radio
powered on?
No
Yes
Open radio and do a visual
inspection of the boards. If
visible damage is found, correct
by replacing or repairing
appropriate part
No
Radio
powered on?
Yes
Using a DC voltmeter, check
for 13.8V at J3 pin 13 and J6
pin 11 on the LORD module
No
13.8 VDC
present?
Verify the condition of the flat
cable from the LORD module
to the HI POWER module
using an ohmmeter
No
Replace cable and
proceed to step 1 of
checkout
Cable good?
Yes
Problem in control head.
Replace or repair as necessary
Yes
Problem is in HI POWER module.
Replace or repair as necessary
Proceed to step 1
of checkout
Figure 3-2. MICOM-Z Troubleshooting Chart 1
3-11
MM-E 2072-09333-00
From Checkout Step
Yes
Pop sound heard
in speaker when the power
switch is turned on?
No
Verify the condition of the flat
cable from the LORD module to
the front panel CONTROL HEAD
module using an ohmmeter
Yes
Yes
Blank display?
The firmware was not loaded correctly
or an incorrect version was loaded.
Load the correct firmware version.
If loading the firmware fixes the
problem, proceed to step 2 of the
checkout. If the problem persists,
replace the LORD module
No
No
Any error
displayed?
Verify the condition of the
flat cable from the LORD
module to the front panel
CONTROL HEAD module
using an ohmmeter
Yes
Cable good?
Yes
Proceed to troubleshooting
chart 8
No
Problem is with the
CONTROL HEAD board.
Replace or repair as
necessary
Replace cable and
proceed to step 2 of
the checkout
Figure 3-3. MICOM-Z Troubleshooting Chart 2
3-12
Cable good?
No
MM-E 2072-09333-00
From Checkout Step
Possibly a bad microphone: try a
different microphone and key it
again, or connect pin 6 to ground
on the mic jack
No
No
Problem is with the LORD module.
Replace or repair as necessary.
Proceed to step 3 of the checkout
Connect J5
pin 8 to ground.
Radio keyed?
Radio keyed?
Yes
Yes
Problem found. Replace
microphone and proceed
to step 3 of checkout
Verify the condition
of the flat
No
cable from the LORD module to
the front panel CONTROL HEAD
module using an ohmmeter
Yes
Cable good?
Problem is with the CONTROL HEAD
module. Replace or repair as
necessary. Proceed to step 3 of the
checkout
No
Replace cable and
proceed to step 3 of
the checkout
Figure 3-4. MICOM-Z Troubleshooting Chart 3
3-13
MM-E 2072-09333-00
From Checkout Step
PW Latch error
displayed on the screen
when whistling?
Yes
No
Possibly a bad microphone, try a
different microphone and key/whistle
again, or connect 0 dBm audio to
pin 5 on the mic jack. Key the radio
by shorting J5 pin 8 to ground
Problem is on the HI POWER module.
Replace or repair as necessary.
Proceed to step 4 of the checkout
No
Connect a 0 dBm
audio signal to J5
pins 6 & 7 and key
the radio
No
Problem found.
Replace microphone
and proceed to
step 4 of checkout
Yes
TX power
present
Verify the condition of
the flat cable from the
LORD module to the HI
POWER module using
an ohmmeter
Verify the condition of
the RF cables from the
LORD module to the HI
POWER module using
an ohmmeter
Yes
No
No
Yes
Cables good?
Key the radio, whistle
and check J3 pin 11 for
AC voltage going to the
HI POWER module
Yes
Cables good?
Replace cable and
proceed to step 4
of the checkout
No
Voltage present?
Problem is on the
HI POWER module.
Replace or repair as
necessary. Proceed to
step 4 of the checkout
Problem is with the
LORD module. Replace
or repair as necessary.
Proceed to step 4 of
the checkout
Figure 3-5. MICOM-Z Troubleshooting Chart 4
3-14
Yes
TX power
present
Problem is with the
CONTROL HEAD module.
Replace or repair as
necessary. Proceed to
step 4 of the checkout
MM-E 2072-09333-00
From Checkout Step
Check that
the volume is at
midrange or beyond
Yes
Using an AC
voltmeter, check for
audio voltage on J5
pins 1 and 3
No
No
Turn up the volume
and proceed to
step 6 of checkout
Yes
Voltage present?
Verify the condition of the
flat cable from the LORD module to
the front panel CONTROL HEAD
module using an ohmmeter
Problem is with the LORD module.
Replace or repair as necessary.
Proceed to step 6 of the checkout
No
Yes
Cable good?
Check for audio at the
speaker connection on
the front panel connector
Replace cable and
proceed to step 6
of checkout
No
Audio present?
Problem is in the CONTROL HEAD
module. Replace or repair as
necessary. Proceed to step 6 of the
checkout
Yes
Replace defective speaker
and proceed to step 6 of
checkout
Figure 3-6. MICOM-Z Troubleshooting Chart 5
From Checkout Step
Yes
Check that
the volume is at
midrange or beyond
Problem is with the LORD module.
Replace or repair as necessary.
Proceed to step 7 of the checkout
No
Turn up the volume
and proceed to step 7
of checkout
Figure 3-7. MICOM-Z Troubleshooting Chart 6
3-15
MM-E 2072-09333-00
From Checkout Step
If you are following the instructions in
the RSS Owner's Guide, and the
oscillator or power output will not
adjust, the problem is in the LORD
module.
Replace or repair as necessary.
Proceed to step 8 of the checkout
Figure 3-8. MICOM-Z Troubleshooting Chart 7
3-5.5
Module Troubleshooting Procedures
WARNING
To prevent permanent damage to printed circuit boards, the
following troubleshooting procedures must be performed only by
qualified, authorized personnel, familiar with the theory of
operation of the Micom-Z circuits, and trained in the maintenance
of electronic circuits.
Refer to para. 3-2 for safety precautions and component and
module handling and repair procedures.
Use the following charts, in conjunction with the relevant schematic circuit diagrams given in
Appendix A, to troubleshoot a module down to the component level.
• Refer to Figure 3-9 for systematic troubleshooting of the receive path circuits.
• Refer to Figure 3-10 for systematic troubleshooting of the transmit path circuits.
Use Appendix B for logistic data on individual components.
NOTE
After replacing the LORD and/or the HI POWER module, it is
necessary to calibrate the RF transmit power using the RSS.
The required RF power values are as follows:
1.
2.
3.
4.
5.
3-16
TUNE – 7W
LOW – 25W
MED – 60W
HIGH – 100W
MAX – 125W.
MM-E 2072-09333-00
Start
Is any sound
heard in the
speaker?
Yes
Check the harmonic
filter range switching
Problem
found
Check harmonic filter
range and its control
lines
Problem
found
Check coax cables
Problem
found
Check LORD board
No
Check from CONTROL
HEAD board to speaker
Problem
found
Ranges OK
Check coax from
HI POWER to LORD
Reception possible
Check path from
LORD RF input to
speaker output
Is the input
signal to the
first mixer OK?
Yes
Check first
local oscillator
Problem
found
Check synthesizer
Check 45.1 MHz
signal (IF filter)
Problem
found
Check first mixer
No
Check front-end
preselector
Figure 3-9.A. Receiver Troubleshooting Flowchart (Sheet 1 of 2)
3-17
MM-E 2072-09333-00
Check second
local oscillator
Problem
found
Check synthesizer
Check 450 kHz
signal (IF filter)
Problem
found
Check second mixer
Check 20 kHz signal
Problem
found
Check 450 kHz
ceramic filter
Check A/D
converter
Problem
found
Check A/D
DC voltage
Check DSP output
signal
Problem
found
Check VCC
Check audio amplifier
Problem
found
Check A+
(13.8 V)
Reception possible
Check flat cable to
CONTROL HEAD
Figure 3-9.B. Receiver Troubleshooting Flowchart (Sheet 2 of 2)
3-18
MM-E 2072-09333-00
Start
Transmit to a
dummy load
Problem persists
No
Is transmission
in AME mode
posible?
Check the harmonic
filter ranges
Transmission
possible
Antenna and/or
antenna tuner problem
Problem in
one range
Check the harmonic
filter and/or
its control lines
Yes
Problem in all ranges
Check the 9T, 9R, PA
DISABLE lines
Problem
found
Check the PTT path
from the
mic connector
to the LORD board
Problem
persists
Check PA power
transistors
No problem found
Check from HI
POWER module to
antenna
Transmission possible
Check DSM & DSP
Problem
found
Check from the mic
audio input to DSM
output
Problem
found
Check from the mic
audio input to
CONTROL HEAD
module output
Problem
found
Transistors OK
Problem
persists
Check PA
Problem
found
Check the HI POWER
as a separate unit
Problem
found
Problem persists
Problem
found
Check the flat cable
between the
CONTROL HEAD and
the LORD module
Figure 3-10.A. Transmitter Troubleshooting Flowchart (Sheet 1 of 2)
3-19
MM-E 2072-09333-00
Check second mixer
output
(45.1 MHz)
Problem
found
Check second
synthesizer
Problem
found
Check first
synthesizer
Problem
found
Check coax cable
Problem persists
Check first mixer
output
(the frequency of the
working channel)
Problem persists
Check LORD module
output to HI POWER
module input
Figure 3-10.B. Transmitter Troubleshooting Flowchart (Sheet 2 of 2)
3-20
MM-E 2072-09333-00
3-6. MICOM-Z REPAIR PROCEDURES
3-6.1
3-6.1.1
Micom-Z Dash-Mount Version Repair
Gaining Access to Modules
1. Refer to Figure 3-11: release the 8 screws fastening the top cover, and then remove the top
cover.
Top Cover
Fastening Screws
(8 places)
Top Cover
Rear Panel
Fastening Screws
(4 places)
Body Assembly
Front Panel
Fastening Screws
(4 places)
Figure 3-11. Gaining Access to Modules
2. Release the four screws fastening the front panel to the body assembly. Keep screws and
washers for reuse.
3. Carefully separate the front panel, and then disconnect the flat cable connecting the front panel
to the LORD connector. Figure 3-12 shows the front panel after being removed.
LORD
Module
Flat Cable
to LORD
Figure 3-12. Micom-Z with Front Panel Removed
3-21
MM-E 2072-09333-00
CAUTION
The rear panel need not be removed to gain access to the modules.
Do not attempt to remove the rear panel before removing the LORD
and HI POWER modules as explained below.
4. To reassemble the front panel, reverse the procedure described above.
3-6.1.2
Replacing Components of LORD Assembly
The LORD assembly includes the LORD module (covered by a shield), the backup battery, and the
GPS receiver. All these components can be replaced after removing the LORD assembly from the
Micom-Z body.
CAUTION
The ACCESSORY and GPS connectors of the LORD module are
attached to the rear panel.
3-6.1.2.1
Removal of LORD Assembly
1. If necessary, open the Micom-Z case in
accordance with para 3-6.1.1.
Nut
Fasteners
2. Release the two fasteners of the
ACCESSORY connector.
3. Release the nut of the GPS connector.
The recommended tool is Mfg. Cat. No.
2072-08013-00.
4. Refer to Figure 3-13: disconnect the coaxial RX and TX cables from the LORD module
connectors.
5. Disconnect the flat cable connected to the HI POWER module.
6. Release the two screws fastening the LORD handles to the chassis. Keep screws and washers
for reuse.
7. Carefully pull the handles to remove the LORD assembly. After moving the assembly by 2 to 3
centimeters (one inch), push the GPS connector in, and then continue to pull out the LORD
module. Make sure that the GPS connector is pulled out together with the assembly as the
LORD assembly is retracted.
Backup Battery
LORD
GPS Cable
GPS Receiver
TX Cable
Flat Cable to HI POWER Module
RX Cable
LORD Handles (2 places)
Handle Fastening Screws
Figure 3-13. Removal of LORD Assembly
3-22
MM-E 2072-09333-00
3-6.1.2.2
Replacing the Backup Battery
The backup battery is fastened by a clamp to the top of the LORD module, and its harness connects to
connector J4 on the module. Before starting, pay attention to the orientation of the battery.
1. Disconnect the battery harness from connector J4 of the LORD module.
2. Release the screw fastening the battery clamp, and then remove the battery.
3. Place the replacement battery in position, in accordance with its original orientation, and then
fasten it with the clamp removed in step 2 above.
4. Reconnect the battery harness to connector J4 on the LORD module.
3-6.1.2.3
Replacing the GPS Receiver
The GPS receiver is attached to the LORD shield by a pad, and connects by a flat cable to connector
J8 on the LORD module. Before starting, pay attention to the orientation of the GPS receiver on the
LORD shield.
1. Release the flat cable connected to the GPS receiver.
2. Pull the GPS receiver case, to separate it from the attachment pad on the LORD shield.
3. Place the replacement GPS receiver in the correct position on the shield, and press its case to
attach it to the shield.
4. Reconnect the flat cable from the LORD module to the GPS receiver.
3-6.1.2.4
Replacing the LORD Module
Refer to Figure 3-14.
Shield Screws
Shield
Heatsink Screws
Upper RFI Contacts
LORD Module
Lower RFI Contacts
LORD Base
Spread heatsink compound on these surfaces
Figure 3-14. Removal of LORD Module
1. Disconnect the battery harness from connector J4 of the LORD module.
2. Release the eight screws that fasten the shield. Keep screws and washers for reuse.
3. Remove the shield and upper RFI contacts.
4. Release the two heatsink screws. Keep screws and washers for reuse.
5. Pull the LORD module straight up, and remove it.
3-23
MM-E 2072-09333-00
6. Clean the remnants of heatsink compound from the areas identified in Figure 3-14, and then
spread a thin layer of fresh compound.
7. Position the replacement LORD module over the lower RFI contacts, place them together in
their original positions on the LORD base, and then fasten the LORD module with the two
heatsink screws removed in Step 4 above.
8. Position the upper RFI contacts over the LORD module, place the shield over the assembly, and
then fasten the shield with the eight screws removed in Step 2 above.
9. Reconnect the battery harness to connector J4 on the LORD module.
3-6.1.2.5
Reinstalling the LORD Assembly
1. Insert the LORD assembly in the corresponding slot of the body assembly, slide it halfway, and
then insert the GPS connector in its hole in the rear panel.
2. Fasten the GPS connector with its nut. The recommended tool is Mfg. Cat. No. 2072-08013-00.
3. Push the LORD assembly fully into the body assembly, and then fasten the ACCESSORY
connector to the rear panel with its two fasteners.
4. Fasten the two LORD handles to the body assembly with the two original screws.
5. Reconnect the coaxial RX and TX cables to the LORD module connectors.
6. Reconnect the flat cable connected to the HI POWER module.
7. You may now close the Micom-Z case in accordance with para. 3-6.1.1.
3-6.1.3
Replacing the HI POWER Module
The HI POWER module is installed on a heatsink, fastened to the body assembly by nine screws. The
module is also attached to the VDC IN connector, and is connected by a coaxial cable to the ANT
connector.
CAUTION
The ANT and VDC IN connectors are attached to the rear panel.
3-6.1.3.1
Removing the HI POWER Module
1. Remove the LORD module
accordance with para. 3-6.1.1.
in
2. Release the two fasteners of the VDC
IN connector.
3. Release the nut of the ANT connector.
4. Disconnect the cables connected to the
front side of the HI POWER module.
Fasteners
Nut
5. Refer to Figure 3-15, and release the nine screws fastening the module to the body. Keep screws
and washers for reuse.
6. Insert the tip of a narrow blade screwdriver in the slot located under the HI POWER module
heatsink, and press lightly to raise the module.
7. You can now pull the HI POWER module out: after moving the assembly by 2 to 3 centimeters
(one inch), push the ANT connector in, and then continue to pull out the HI POWER module.
Make sure that the ANT connector is pulled out together with the assembly as the HI POWER
assembly is retracted.
3-24
MM-E 2072-09333-00
ANT Cable
Figure 3-15. Removal of HI POWER Module
3-6.1.3.2
Installing the Replacement HI POWER Module
1. Clean the remnants of heatsink compound from the body assembly and the HI POWER module.
2. Spread a thin layer of fresh compound on the bottom area of the HI POWER module.
3. Route the coaxial cable with the ANT connector over the HI POWER module as shown in
Figure 3-15.
4. Insert the HI POWER module in the corresponding slot of body assembly, slide it halfway, and
then insert the ANT connector in its hole in the rear panel.
5. Fasten the ANT connector with its nut.
6. Push the HI POWER module fully into the body assembly, and then fasten the VDC IN
connector to the rear panel with its two fasteners.
7. Fasten the HI POWER module to the body with the nine original screws.
8. Reconnect the coaxial cables between the LORD and HI POWER modules in accordance with
Figure 3-13.
9. Reconnect the flat cable between the LORD and HI POWER modules in accordance with
Figure 3-13.
10. You may close now the Micom-Z case in accordance with para. 3-6.1.1.
3-6.1.4
3-6.1.4.1
Replacement of Components on Front Panel Assembly
Replacement of CONTROL HEAD Module
Refer to Figure 3-16.
1. Release the 13 screws fastening the RF shield. Keep screws and washers for reuse.
2. Remove the RF shield.
3. Disconnect the speaker cable from the CONTROL HEAD module.
4. Remove the CONTROL HEAD module. Make sure that the keypad and the inserts remain in
their place, on the front panel.
3-25
MM-E 2072-09333-00
NOTE
To remove the LCD, release its four fastening screws, and then
disconnect it from the module. Also disconnect the two harnesses
connected to connectors P2 and P4 on the module.
5. If necessary, move the LCD to the replacement module.
6. Orient the replacement module in accordance with Figure 3-16, and place it on the spacers.
7. Reconnect the speaker cable to the corresponding module connector.
8. Reinstall the RF shield.
CONTROL HEAD
Module
LCD
Screws
Speaker
Cable
Shield Screws
Spacers
RF Shield
Gasket
Front Panel
Keypad
Inserts
Speaker Holder
Speaker
Speaker Screws
Figure 3-16. Replacement of CONTROL HEAD Module
3-6.1.4.2
Replacement of Speaker
1. Release the 13 screws fastening the RF shield. Keep screws and washers for reuse.
2. Remove the RF shield.
3. Disconnect the speaker cable from the CONTROL HEAD module.
4. Release the screws fastening the speaker holder, and then remove the speaker. Keep the gasket
and holder for reuse.
5. Install the replacement speaker by reversing the procedure given above.
3-26
MM-E 2072-09333-00
3-6.2
3-6.2.1
Repair of Micom-Z Trunk-Mount Version
Gaining Access to Modules
1. Refer to Figure 3-17: release the 8 screws fastening the top cover, and then remove the top
cover.
Top Cover
Top Cover
Fastening Screws
(8 places)
Rear Panel
Fastening Screws
(4 places)
Body Assembly
Front Cover
Fastening Screws
(4 places)
Figure 3-17. Gaining Access to Micom-Z Trunk-Mount Version Modules
2. Release the four screws fastening the front cover to the body assembly. Keep screws and
washers for reuse.
3. Carefully separate the front cover, and then disconnect the flat cable connecting the front cover
to the LORD connector. Figure 3-18 shows the front cover after being removed.
LORD
Module
Front Cover
Flat Cable
to LORD
Figure 3-18. Micom-Z Trunk-Mount Version with Front Cover Removed
3-27
MM-E 2072-09333-00
CAUTION
The rear panel need not be removed to gain access to the modules.
Do not attempt to remove the rear panel before removing the LORD
and HI POWER modules as explained below.
4. To reassemble the front cover, reverse the procedure described above.
3-6.2.2
Replacing Components of LORD Assembly
Refer to para. 3-6.1.2.
3-6.2.3
Replacing the HI POWER Module
Refer to para. 3-6.1.3.
3-6.2.4
Replacement of INTERCONNECTION Module
1. Remove the front cover in accordance with
para. 3-6.2.1.
INTERCONNECTION
Module
2. Release the four screws fastening the
INTERCONNECTION module to the front
cover. Keep screws and washers for reuse.
3. Remove the INTERCONNECTION module.
4. Position the replacement module, oriented as
seen in the figure, on the front cover, and then
fasten it with the four original screws.
3-6.2.5
Fastening Screws
(4 places)
Replacement of CONTROL HEAD Module on Control Head Assembly
Refer to Figure 3-19.
1. Release the 13 screws fastening the rear panel of the control head. Keep screws and washers for
reuse.
2. Remove the rear panel.
3. Release the nine screws fastening the CONTROL HEAD module to the front panel. Keep
screws and washers for reuse.
4. Remove the CONTROL HEAD module. Make sure that the keypad and the inserts remain in
their place, on the front panel.
NOTE
To remove the LCD, release its four fastening screws, and then
disconnect it from the module. Also disconnect the two harnesses
connected to connectors P2 and P4 on the module.
5. If necessary, move the LCD to the replacement module.
6. Orient the replacement module in accordance with Figure 3-19.
7. Fasten the replacement module with the nine original screws removed in Step 3.
8. Reinstall the rear panel on the control head.
3-28
MM-E 2072-09333-00
Rear Panel
Captive Screws
(4 places)
CONTROL HEAD
Module
LCD
Screws
Rear Panel
Inserts
Module Fastening
Screws
(9 places)
Keypad
Front Panel
Figure 3-19. Replacement of CONTROL HEAD Module
3-29
MM-E 2072-09333-00
Intentionally Left Blank
3-30
MM-E 2072-09333-00
Appendix A
SCHEMATIC CIRCUIT DIAGRAMS
NOTE
Components designated as OPTION or LAB in the schematic circuit
diagrams are optional, and are not installed on the PCBs. Therefore,
ignore such components.
A-1
MM-E 2072-09333-00
Intentionally Left Blank
A-2
MM-E 2072-09333-00
CPU_AUDIO
LOW_RF
DIGITAL_16 .8Mhz
DSM_OUTPUT_1.05Mhz
SPI_CLK
SPI_DATA_OUT
DIGITAL_16.8Mhz
DSM_OUTPUT_1.05Mhz
SPI_CLK
SPI_DATA_OUT
RESET
A_D_DATA
SR_DATA
SR_CLK
DSM_AGC_EN
CONVST
3.3V
PWR_LEVEL
GND
SH1
GND_SLOT_1
GND
SH3
GND_SLOT_2
GND
SH5
GND_SLOT_3
GND
SH7
GND_SLOT_4
PENDULL UM_SEL
L OW_RF_SEL
PTT_IN
AMB _TEMP
PWR_LEVEL
GND
SH2
GND_SLOT_5
GND
SH4
GND_SLOT_6
SH6
SH8
GND_EDGE_1
GND_EDGE_2
EDGE1
GND_EDGE_3
GND
GND
GND
NOISE_CONTROL
VCO1_SEL
VCO2_SEL
VCO2_SEL
VCO3_SEL
VCO3_SEL
SPI_CLK_UP
SYNTH_LOCK
VCO1_SEL
SPI_DATA_OUT_UP
GND
3.3V
D2A_OVEN_SEL
NOISE_CONTROL
DR6
HOLE_157
GND
CONVST
D2A_OVEN_SEL
AMB _TEMP
DR5
HOLE_157
GND
DSM_AGC_EN
FRAC_N_2_SEL
PTT_OUT
DR4
HOLE_138
GND
SR_CLK
FRAC_N_1_SEL
LOW_RF_SEL
DR3
HOLE_138
GND
SR_DATA
FRAC_N_2_SEL
SYNTH_LOCK
DR2
HOLE_138
GND
A_D_DATA
FRAC_N_1_SEL
PENDULL UM_SEL
DR1
HOLE_138
SPI_DATA_OUT_UP
SPI_CLK_UP
Figure A-1.A. LORD Module, Schematic Circuit Diagram (Sheet 1 of 15 – Module Interconnection Diagram)
A-3/A-4
MM-E 2072-09333-00
41
EXT_RX_AUDIO_ISB
42
EXT_TX_AUDIO_ISB
12
DSI|KW_C_C
24
DSO|FAN_ON_OFF
25
FREEZE|KW_TUNE
22
BKPT_DSC|KW_ALC
21
VPP
DSP_UNIT
C9534
16
TXA
15
RXA
29
TXB
33
RXB
39
TXC
DSO
FL3
FREEZE
FL4
BKPT_DSCK
RXC
38
TXD
IN
IN
31
RXD
IN
19
KW_PTT
17
EX_RESET
10
37
FL32
FL24
FL29
FL23
FL9
PTT_IN_VOICE
PTT_IN_DATA
F_VP_VOCODER_PTT
IN
KW_ON_OFF
STOP_SCAN
CLK_OUT
DSP_REQ
DSP_REQ
TXC
OUT
RXC
OUT
OUT
OUT
OUT
SW_A+
F1
PA_ MUTE
CS_
SPKR+
SPKRSPKR+
EXT_RX_AUDIO+
EXT_RX_AUDIO-
EXT_TX_AUDIO+
astic
EXT_RX_AUDIO+
TX_AUDIO_OUT
TX_AUDIO_OUT
TX_AUDIO_OUT
40
TX_AUDIO_IN
TX_AUDIO_IN
TX_AUDIO_IN
RX_AUDIO_OUT
RX_AUDIO_OUT
35
RX_AUDIO_IN
FRAC_N_2_SEL
D2A_OVEN_SEL
U|D_
INC_
U|D_
PEND|OCXO_SEL
INC_
LOW_RF_SEL
EXT_AUDIO_SW
EXT_AUDIO_SW
SYNTH_LOCK
AUDIO_C_P_SW
AUDIO_C_P_SW
AMB_TEMP
BAT+
MIC
RX_AUDIO-
RX_AUDIO_IN
RX_AUDIO_IN
BAT_IN
VCO1
EXT_TX_AUDIO-
32
RX_AUDIO_OUT
PA_ MUTE
CS_
EXT_TX_AUDIO+
EXT_TX_AUDIO-
34
EXT_ALAR M_CONT
SQ_SW
EXT_RX_AUDIOastic/modem
NOISE_CONTROL
FRAC_N_1_SEL
EXT_RX_DATAEXT_ALARM
STOP_SCAN
EXT_ALAR M_CONT
EXT_RX_DATA+
EXT_ALARM
KW_ON_OFF
SPI_DATA_OUT
EXT_RX_DATA-
RX_AUDIO+
BAT-
VCO2
VCO3
SQ_SW
PWR_LEVEL
BAT_ IN
VCO1_SEL
PTT_OUT
TXC_MODEM_TTL
RX_AUDIO-
RX_AUDIO+
VCO2_SEL
RXC_MODEM_TTL
VCO3_SEL
AMP_ON_OFF
BATTERY
CONNECTOR
SQ_GATE
IN
26
GND
18
GND
TO RF
SECTION
VCO2_SEL
470
R9529
VCO3_SEL
470
SPI_CLK_UP
470
BIT
16
C7021
270PF
V_FWD_PA
11
V_REV_TUNE
PA_TEMP
10
pll _1_fil ter
C7001
10PF
470
V_FWD_HF
V_REV_HF
SPI_DATA_OUT_UP
PA_INHIBIT
TUNE_CH_CHANGE
TUNE_CUR_LIM
C7028
270PF
PTT_OUT
C7012
0.1uf
C7011
0.1uf
HIGH_POWER(1:9)
C7016
0.1uf
C7014
0.1uf
C7013
0.1uf
C7018
0.1uf
C7017
0.1uf
C7015
0.1uf
R7007
C7019
0.1uf
47K
VCC
RESET
C9535
270PF
SPI_CLK
R9530
NOISE_CONTROL
470
SPI_DATA_OUT
C7009
270PF
R7000
FRAC_N_1_SEL
470
FRAC_N_2_SEL
C7008
270PF
R7001
D2A_OVEN_SEL
470
PENDULLU M_SEL
3.3V
TO RF
SECTION
SW_A+
3.3V
470
CF2124V0R0
R9612
OPTION
C7010
0.01UF
R9597
4.7k
R9598
4.7k
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
TP_1
TP_2
13.8VDC
C7007
270PF
R7002
TXC_MODEM_TTL
LOW_RF_SEL
SYNTH_LOCK
RXC_MODEM_TTL
R9609
OPTION
C7020
0.01UF
AMB_TEMP
PWR_LEVEL
RX_AUDIO_IN
RX_AUDIO_OUT
BAT_ IN
R9551
TX_AUDIO_IN
F_VP_VOCODER_PTT
R9633
R9610
OPTION
TX_AUDIO_OUT
3.3V
L9080
22UH
PTT_OUT
RESET
R9613
100
R9614
100
C9556
0.1uf
C9551
0.1uf
R9611
OPTION
PTT_IN_VOICE
PTT_IN_DATA
VR5009
5.6V
C9563
270PF
SQ_GATE
VR5010
5.6V
VCC
C9562
270PF
L9081
22UH
C9568
0.1uf
AUDIO(1:3)
23
VCO1_SEL
470
R9528
C7002
10PF
J4
SPI_CLK
R9527
VCO3
R7003
CONVST
MIC
RESET
ISB_EXT_AUDIO_SW
pll_1_fil ter
R7006
BIT
TO RF
SECTION
SPI_DATA_OUT
TU_CUR_LIM
SPI_CLK
SR_CLK
VCO2
A_D_DATA
A_D_DATA
CONVST
PA_ INHIB
33UF
VCO1
TU_CH_CHNG
VP_PTT
EXT_RX_DATA+
SPKR-
V_REV_HF
PTT_IN_CW
43
KW_PTT
PTT_IN_DATA
SW_A+
V_FWD_HF
FL7
AUDIO UNIT
V_REV_TUNE
RXD
FL10
OUT
PA_TE MP
PTT_IN_VOICE
OUT
V_FWD_PA
TXD
EX_RESET
44
20
QUAD
UART
C7006
C7005
33UF
DIGITAL_16.8 Mhz
16.8MHZ
RXB
OUT
C7004
0.1uf
SR_DATA
DSM_AGC_EN
DSM_AGC_EN
AUDIO_SW
AUDIO_SW
FL8
FL28
HOST_RW
CLK_ IN
RXA
FL?
IN
SR_CLK
HOST_ADD(0:18)
TXA
TXB
FUSE_MINISMD050
HOST_ADD(0:18)
HOST_ADD(0:18)
SR_DATA
HOST_DATA(0:15)
DSP_RW
FL13
FL30
HOST_DATA(0:15)
FL11
PTT_IN_CW
13
11
FL19
DSP_CS
C7003
0.1uf
DSM_OUTPUT_1.05Mhz
DSM_OUT
DSP_RESET
FL12
FL18
IN
DSP_RESET
DSP_CS
HOST_DATA(0:15)
VPP
IN
28
HOST_UNIT
FL2
270PF
3.3V
3.3V
ISB_EXT_AUD IO_SW
FL1
C9532
270PF
VCC
EXT_TX_AUDIO_ISB
DSI
C9533
270PF
EXT_RX_AUDIO_ISB
FL14
KW_PTT
C9564
0.1uf
R9668
OPTION
VCC
VCC
C7022
0.1uf
5vdc
A+
A+
15
A+
14
A+
13
GND
18
13.8vdc
C7027
100NF
SW_A+
C7030
J7
15uf
C7029
100NF
J7 OPTION
CONNECTOR
CR9077
MMBD914T
C9548
100NF
R9582
10K
SW_A+
29
SW_A+
31
SW_A+
33
AMP_ON_OFF
13.8vdc
17
R9583
10K
500w/1kw
36
AMP_FWD
500w/1kw
30
AMP_REV
500w/1kw
IN
IN
27
FWD_CLOSE_LOOP
14
REV_CLOSE_LOOP
FL27
FL31
500w/1kw
IN
FL33
46
24
FWD_CLOSE_LOOP
22
REV_CLOSE_LOOP
20
OUT
500w/1kw
FL6
GND
SW_A+_CONT
VCC
A+
L 9085
A+_13.8_DC
GND
22UH
J5
ACCESSORY
CONNECTOR
26
AMP_REV
OUT
ON_OFF_CONT
45
AMP_FWD
OUT
TX_AUDIO-
22
23
10
TX_AUDIO+
SPARE_2
16
SPARE_1
18
GND GND
17
15
20
14
21
13
19
VCC
12
C9621
C9620
15UF
15UF
C7031
100NF
J3
HIGH POWER
CONNECTOR
A+
24
11
J6 - CONTROL HEAD
CONNECTOR
Figure A-1.B. LORD Module, Schematic Circuit Diagram (Sheet 2 of 15 – DSP Subsystem Organization)
A-5/A-6
R9697
MM-E 2072-09333-00
ISB_EXT_AUDIO_SW
8V_AUDID_ISB
R4003
8V_AUDID_ISB
10K
R4004
10K
EXT_AUDIO_SW
R9586
10K
Q4004
R4005
20K
3904L
R9587
10K
8V_AUDID_ISB
AUDIO_C_P_SW
Q9066
3904L
C4000
33NF
R9580
20K
R4401
3.3K
C4002
270PF
C4004
1UF
8V_AUDID_ISB
L4001
22UH
EXT_TX_AUDIO-
C9559
C4007
1000PF
C4008
1000PF
16
C4009
1UF
R4013
560
Y0
CX
1UF
MC78M08BDTRK
1 VIN
8V_AUDID_ISB
VOUT 3
EXT_TX_AUDIO+
U6098
C9615
0.39UF
VEE
C4021
1000PF
R4026
100K
C4023
Y1
R4200
100K
C4013
3.3NF
U4003
R4024
100K
ENH
R9559
150K
4V_AUDID_BIAS
R9533
100K
C4035
C4011
1UF
R4015
220
MIC
10
C4014
390PF
MC33174
U4003
R4020
OPTION
R4028
14.7K
C4015
R4021
1500PF
301K
R9602
560
4V_AUDID_BIAS
R4014
220
1UF
4V_AUDID_BIAS
4V_AUDID_BIAS
680PF
R4017
6.8K
U6085
R4008
3K
C4012
HC4053-M
C4022
1000PF
0.1UF
R4016
5.6K
13
X1
R9603
560
R4022
39K
R4030
2K
GND
C9614
U6085
R4018
10K
15
HC4053-M_PWR
GND
U4000
20K
12
X0
14
10
R4019
CY
11
VCC
L4002
22UH
1UF
10
R4012
SW_A+
R4007
10K
C4010
20K
C4016
R4011
8.25K
IN_AUDIO_C_P_SW
0.1UF
R4009
2K
R4006
27K
R4025
C4018
100NF
20K
C4020
330PF
4V_AUDID_BIAS
R4055
27K
C4052
330PF
R9579
20K
1UF
C4053
1UF
8V_AUDID_ISB
8V_AUDID_ISB
C9543
680PF
4V_AUDID_BIAS
U4000
RX_AUDIO_OUT
C4039
0.01UF
U6082
MC33174
R4037
2.7K
C4040
10UF
C4038
C4017
1UF
C9531
1UF
100NF
R4044
560
Q4001
C4043
C4044
33UF
10UF
8V_AUDID_ISB
R4065
10K
MIC_IN
3904L
C9549
100NF
C4045
10UF
R4047
10K
C4047
R4073
10K
SW_A+
MM BD914T
C9544
680PF
R4049
10K
R9690
604
MC33174
CR9070
TX_AUDIO_IN
R9691
604
TX_AUDIO_OUT
1000PF
SW_A+
R4064
1K
10K
RX_AUDIO_IN
R4043
20K
EXT_RX_AUDIO+
10
R4041
MC33174
C4054
10UF
R4063
10K
4V_AUDID_BIAS
MC33174
R4060
270
R9578
20K
U4000
R4033
20K
R4058
3.3K
R9577
20K
8V_AUDID_ISB
R4074
10K
13
R4075
270
VCC
C4061
10UF
EXT_RX_AUDIO-
14
12
U6082
MC33174_PWR
11
R4084
10K
R4085
1K
U4003
EXT_ALARM
R4050
R9576
27K
6.8K
R9593
10K
EXT_ALARM_CONT
Q4003
3904L
R9531
5.11K
C9545
330PF
THIS IS FULL MUTE
R9532
100K
R9594
10K
C9542
1UF
SW_A+
SQ_SW
R9536
3.3K
IN_AUDIO_C_P_SW
4V_AUDID_BIAS
R4051
4.7K
VR4000
MMBZ5254L
Q9067
Q4000
3904L
4V_AUDID_BIAS
3904L
R4054
10K
R4052
10K
4V_AUDID_BIAS
CZ
CY
Y0
15
HC4053-M_C
U6084
HC4053-M
Y1
Z0
C9554
10UF
EXT_RX_DATA+
U6082
MC33174
10K
R9600
R9698
8V_AUDID_ISB
Z1
R9588
R9675
17.8K
10
R4059
100K
R9538
270
R9581
20K
1K
TDA_MUTE
R4053
100K
CL
R9596
150K
U6084
R9591
R9676
10K
10K
R4056
10K
4V_AUDID_BIAS
R9688
100
C4055
1UF
8V_AUDID_ISB
C4057
0.01UF
C4056
680PF
10K
VCC
R4066
27K
RX_AUDIO+
U|D_
R4071
39K
R4068
51K
C4060
R4078
39K
RX_AUDIO-
12PF
C4059
C4062
1UF
13
12PF
INC_
14
MC33174_PWR
CS_
12
R9601
560
U4003
11
R4077
51K
R4079
2K
U|D_
NC2
INC_
VL
NC3
NC6
11
CS_
NC7
10
NC4
VB
14
DS1666
8V_AUDID_ISB
R9589
10K
NC5
15
VH
12
VW
13
C9555
4.7UF
C4071
C4073
680PF
R4083
20K
8V_AUDID_ISB
R4062
10K
C9558
0.1UF
C4058
1UF
C4042
100NF
R9595
150K
R9599
1K
VP
R4072
NINV
OUT1
INV
OUT2
150K
RR
C4072
1UF
U6081
0.01UF
MC33174
C4067
100NF
R4070
150K
1UF
C4300
EXT_RX_DATA-
U6082
R4069
150K
GND
R4080
27K
C4074
0.39UF
16
VCC
NC1
C9553
10UF
4V_AUDID_BIAS
R9537
270
A+
R4061
20K
C4070
15UF
R4067
2K
R9592
10K
R9590
PA_MUTE
3904L
Q4002
C9561
0.1UF
Q9069
3904L
R4057
10K
16
R4086
6.8K
11
VCC
CX
X0
14
R4082
10K
12
14
12
HC4053-M_PWR
GND
VEE
X1
13
U4000
MC33174_PWR
U6084
R4088
20K
C4068
1000PF
C4069
4.7UF
M|SS
GND1
R4076
OPTION
GND2
5 U4002
TDA1519A
SW_A+
C4064
1000PF
C4066
1000PF
C4065
1000PF
TDA_MUTE
VCC
13
R4081
18
11
SPKR+
SPKR-
R4087
2.7K
Figure A-1.C. LORD Module, Schematic Circuit Diagram
(Sheet 3 of 15 – Audio Circuits)
A-7/A-8
MM-E 2072-09333-00
3.3V
C9483
0.01UF
3.3V
C9482
10NF
3.3V
C9485
0.01UF
3.3V
3.3V
3.3V
3.3V
C9486
0.01UF
3.3V
3.3V
3.3V
14
3.3V
C9501
0.1UF
C6002
0.1UF
0.1UF
3.3V
40212212354
ADP3338AKC-3.3
3.3V
3.3V
C9484
0.01UF
C9489
0.01UF
C9487
0.01UF
C9502
0.1UF
3.3V
C9490
0.01UF
134
DSP_RESET
R9425
OPTION
VCC
HA0
R6041
100
HA1
HA2
R6009
39K
43
42
10
41
11
12
40
13
36
35
15
34
HOST_ADD(0:18)
MODA|IRQA_
A1
MODB|IRQB_
MODE 5
A2
MODC|IRQC_
MODE 7
A3
A4
HAD0
A6
A7
HAD1
HAD2
HOST
HAD3
ADDRESS
BUS
INTERFACE
HAD4
A8
A9
A10
HAD5
A11
HAD6
A12
HAD7
A13
A14
32
31
A0
A5
37
14
RESET
MODD|IRQD_
33
HA0
A15
HA1
A16
HA2
A17
DSP_ADDR(0:15)
72
73
76
77
78
79
82
83
84
85
88
10
89
11
92
12
10
93
13
11
94
14
12
97
15
13
98
14
99
15
82
81
49
48
47
46
45
44
37
36
35
34
33
32
100
99
55
11
20
78
79
61
70
91
U6038
IS61LV6424TQ
FAST SRAM
64K X 24
21
R9489
C6015
100PF
17
U6065
3.3V
R6018
39K
R6016
39K
R9409
39K
R9410
39K
750
R6033
16
17
DSM_OUT
18
19
750
DSM_OUT
R6034
20
21
24
C6034
0.1UF
750
R6036
25
26
R6037
27
VCC1
SSI_DATA
FIR_4
SSI_CLK
FIR_5
LOAD_DIV
FIR_6
RESET
FIR_7
DSM_EN
CLK_IN
U6000
ASIC_DSM
FIR_8
FIR_9
FIR_10
FIR_11
113
STD0
DSP
SCK0
1.2K
R6038
R6500
1K
11
R6035
D11
143
SCK1
SC12
144
SC11
11
SC10
SCLK
15
TXD
14
RXD
138
TDI
140
141
139
142
28
27
R6032
10K
D16
D17
D18
13
53
D19
SCI
TXD
RXD
1.8K
D20
D21
D22
TRST_
D23
TDI
JTAG
ONCE
TCK
TDO
DE_
TMS_
TI00
TI01
TI02
3.3V
59
55
R6042
OPTION
R9490
WR_
RD_
AA0
BUS AA1
CONTROL AA2
AA3
TA_
TIMER
BR_
XTAL
BCLK_
PINIT|NMI
CLKOUT
BG_
PLL
BB_
EXTAL
R9513
114
CAS_
BCLK
45
117
121
17
124
18
125
19
128
20
131
21
132
22
133
23
12
3.3V
17
R9418
39K
16
19
22
10
CODEC_1
MASTER
FS
11
FLAG_TP
12
13
14
15
16
21
23
24
25
26
27
3.3V
R9416
OPTION
C9498
0.1UF
FRAME MODE
38
18
R9417
39K
10
PULSE MODE
17
VMID_TP
18
19
3.3V
43
11
3.3V
20
20
21
R9495
OPTION
23
R9419
39K
R9496
39K
83
84
97
98
86
88
92
93
RX_AUDIO+
22
35
36
37
39
41
44
32
31
SW_A+
RX_AUDIO-
MIC
47
48
3.3V
U6040
TLV320AIC10
C6091
1UF
ISB
SW_A+
HYB_3.3V
DSP_DATA (0:23)
SW_EXT_TX_AUDIO_ISB
SW_EXT_TX_AUDIO_ISB
ISB_EXT_AUDIO_SW
ISB_EXT_AUDIO_SW
AUDIO_SW
AUDIO_SW
EXT_TX_AUDIO_ISB
EXT_TX_AUDIO_ISB
PTT_OUT
PTT_OUT
HYB_RESET
68
70
69
3.3V
51
R6020
39K
63
71
28
15
16
123
61
30
13
14
122
62
15
13
118
50
34
11
12
C9421
10UF
10
115
116
C9499
0.1UF
C9500
0.1UF
67
D15
SCLK
TRST
ESSI1
10K
N.C.1
D10
SRD0
D12
12
D9
ESSI0
SC02
D14
29
10
49
910
FIR_3
110
D13
TDO
DSM_FS
109
D8
DATA
BUS
HYB_MCLK
HYB_ESSI_FSD
EXT_RX_AUDIO_ISB
EXT_RX_AUDIO_ISB
HYB_ESSI_STD
HYB_ESSI_SRD
HYB_ESSI_SCK
HYB_CODEC_FC
HYB_GND
R9411
39K
R9412
39K
HYBRID_OPT
64
52
60
PCAP
910
OUT|FIR_1
FIR_2
108
D7
STD1
TMS
13
D6
U6042
XC56303PV100
SRD1
TCK
R6026
R6027
DE_
1.2K
107
20 NC1
48 NC2
GNDP1
19
GNDQ1
54
GNDQ2
90
GNDQ3
127
GNDQ4
75
GNDA1
81
GNDA2
87
GNDA3
96
GNDA4
104
GNDD1
112
GNDD2
120
GNDD3
130
GNDD4
58
GNDC1
66
GNDC2
39
GNDH
GNDS1
26
GNDS2
47
GNDP
45
46 VCCP
VCC2
R6023
VCC3
VCC4
1.8K
15
D5
16
JTAG_RESET
23
106
C6016
0.1UF
R6030
39K
105
D4
R6028
39K
D3
HDS_
SC01
U6065
HACK_
SC00
10
HREQ_
HCS_
16
26
27
28
29
30
31
38
39
101
D1
102
D2
12
HREQ_
HRW
R6022
3.3V
C9420
10UF
94
10
21
95
96
23
C6014
100PF
100
60
71
24
D0
90
HRW
64
66
17
76
77
40
85
87
67
89
22
30
DSP_REQ
1.8K
3.3V
C9419
1UF
R9420
39K
80
56
57
58
59
62
63
68
69
72
73
74
75
12
13
18
19
22
23
24
25
HOST_RW
DSP_CS
C6020
0.1UF
U6097
14
29
135
C6021
0.1UF
GND
42
46
136
VCC
33
40
119
44
137
14
129
VCCD4
111
VCCD2
103
VCCD1
57
65
VCCC2
38
VCCH
VCCC1
126
91
VCCQ3
VCCQ4
56
VCCQ2
18
VCCQ1
25
VCCS2
VCCA1
HOST_DATA(0:15)
VCCS1
39K
95
R6000
39K
VCCA4
R9421
39K
74
R9422
86
R6002
10K
VCCA3
R9423
39K
C9481
0.01UF
80
39K
0.1UF
C9472
1UF
VOUT2
42
15
43
50
41
51
52
65
53
54
R9607
13
C6019
VOUT1
VIN
VCC
11
U6065
VCCA2
12
C6000
10UF
C6013
3.3V
3.3V
C6006
0.1UF
3.3V
C9488
0.01UF
C6010
0.1UF
VCC
0.1UF
3.3V
3.3V
C9507
VCCD3
SPARE
C6008
0.1UF
C6004
0.1UF
3.3V
C9508
0.1UF
3.3V
C9496
10NF
N.C.2
R6039
3.3V
GND3
GND1
R6040
GND2
1.8K
GND4
18
LOGIC_00
GND
28
NP-R6500
22
14
C6039
0.1UF
U6065
10
C9407
0.39UF
C9515
0.1UF
DSM_AGC_EN
CLK_OUT
16.8MHZ
L6000
680NH
R9464
1K
R9465
1K
VCC
ESSI(0:3)
A_D_DATA
C6041
270PF
C6040
270PF
R6045
OPTION
CONVST
C9506
0.1UF
SR_DATA
Figure A-1.D. LORD Module, Schematic Circuit Diagram
(Sheet 4 of 15 – DSP Subsystem Circuits)
SR_CLK
A-9/A-10
MM-E 2072-09333-00
3.3V
3.3V
C9612
10UF
C9611
10UF
3.3V
C9578
100NF
R9669
OPTION
C9579
100NF
FRAME MODE
R9642
10K
R9687
OPTION
PULSE MODE
R9639
10K
45
3.3V
HYB_ESSI_FSD
HYB_CODEC_FC
HYB_ESSI_SRD
17
16
19
22
R9689
OPTION
FLAG
DCSI
ALTIN
R9641
10K
R9640
10K
30
8V_AUDID_ISB
8V_AUDID_ISB
28
VMID
SLAVE MODE
U6088
TLV320AIC10
21
23
24
25
26
27
C9574
100NF
DTXOP
R9661
2K
DTXOM
R9643
39K
38
C9575
100NF
R9644
39K
10
43
12PF
13
C9601
24K
12PF
C9580
1UF
VCC
11
R9638
51.1K
R9679
2K
PTT_OUT
R9652
10K
R9648
20K
MAX325ESA
MC33174_PWR
R9646
27.4K
C9598
680PF
20
R9657
3.32K
U6089
12
R9678
3.32K
C9604
100NF
C9602
330PF
14
R9660
2K
11
R9647
R9645
27.4K
R9637
51.1K
C9600
18
R9685
OPTION
R9670
274
U6089
MC33174
R9686
OPTION
4V_AUD
ID_BIAS
V-
V+
C9613
10UF
IN1
COM1
EXT_RX_AUDIO_ISB
NO
OPTION
R9684
COM2
IN2
NC2
R9664
1K
U6096
C9592
0.39UF
35
36
37
39
41
44
32
31
HYB_MCLK
C9599
680PF
12
HYB_ESSI_STD
HYB_ESSI_SCK
R9667
OPTION
15
13
HYB_RESET
R9666
OPTION
R9665
1K
34
47
48
C9584
1UF
R9630
10K
8V_AUDID_ISB
C9585
22NF
OPTION
R9711
ISB_EXT_AUDIO_SW
R9656
3.32K
R9663
10K
C9581
1UF
L9083
22UH
R9655
6.8K
EXT_TX_AUDIO_ISB
R9654
6.8K
R9662
2K
C9595
1000PF
C9596
1000PF
10
R9636
100K
U6089
MC33174
C9617
1UF
R9659
6.19K
R9699
CZ
R9700
Z1
U6085
R9653
10K
C9593
OPTION
8V_AUDID_ISB
4V_AUD
ID_BIAS
C9597
2.7NF
U6089
MC33174
R9628
150K
R9631
14.7K
4V_AUD
ID_BIAS
R9658
2K
HC4053-M_C
CL
R9629
100K
Z0
C9582
1UF
C9594
1.5NF
R9632
301K
R9671
221
C9573
100NF
R9672
221
C9603
330PF
C9583
1UF
R9649
20K
4V_AUD
ID_BIAS
AUDIO_BIAS
R4000
10K
AUDIO_SW
R4001
10K
R4002
20K
Q4005
3904L
Figure A-1.E. LORD Module, Schematic Circuit Diagram (Sheet 5 of 15 – ISB Processor Circuits)
A-11/A-12
OPTION
MM-E 2072-09333-00
FOR ANALOG INPUT FROM J5 PIN 39
VCC
L5002
22UH
VCC
R9677
6.8K
VCC
C9606
0.1UF
R9682
R9681
OPT
ION
OPT
ION
ANAOLG_INPUT
C5004
0.1UF
C5003
0.1UF
C5007
33UF
VCC
C5005
0.1UF
VCC
TXC
C5002
0.1UF
SW_A+
1 VOUT
C5006
0.01UF
C5001
0.1UF
C5000
100NF
C6035
C5009
0.1UF
R5007
39K
RS232_TTL_SW
UART_CL
CR5002
MMBD701LT
VR5001
5.6V
CR5000
MMBD701LT
VBAT
OMIT THIS WHEN USE ANALOG INPUT
AMB_TEMP
107
DATA3
106
ADDR23|CS10_|ECLK
DATA4
104
DATA5
103
IRQ3_|PF3
DATA6
102
UARTB_INT
78
DATA7
101
UARTC_INT
75
IRQ4_|PF4
DATA8
100
UARTD_INT
72
IRQ7_|PF7
DATA9
99
74
73
IRQ6_|PF6
V_REV_TUNE
44
AN0|PADA0
V_FWD_PA
45
PA_TEMP
46
VCC
VCC
IRQ5_|PF5
68HC16
U5008A
AN1|PADA1
AN2|PADA2
AN3|PADA3
10K
R5101
FREEZE
R9618
R9619
R9620
R9623
Y1
C9570
C9569
100PF
BDM_FREEZE
Z0
Z1
J9
TSW-105-23-5-D
BDM DEBUG
C9571
100PF
BKPT_DSCK
Z0
HC4053-M_C
U5006
CL
Z1
KW_ALC
26
12
15 A5
I|O4
26
12
I|O5
27
13
14
I|O5
27
13
13 A7
I|O6
28
14
A8
I|O7
29
15
A6
A6
I|O5
40
13 A7
I|O6
28
14
I|O6
42
A8
I|O7
29
15
I|O7
44
A9
A9
25
10
31
A10
32
10
31
A10
32
24
WR_ 5
30
11
A11
21
12
A12
WR_ 5
30
10
12
11
23
13
A13
12
14
11
A14
13
26
I|O8
I|O8
11
A10
I|O9
32
11
A10
I|O9
32
11
A11
A11
I|O10
34
10
12
A11
I|O10
34
10
12
12
A12
13
A12
36
11
13
A12
36
11
13
A13
14
A13
39
12
14
A13
39
12
14
11
A14
15
15
16
10 A16
I|O11
I|O12
A14
I|O13
41
A14
I|O13
41
A15
I|O14
43
14
16
A15
I|O14
43
14
48
A16
I|O15|A
45
15
17
48
A16
I|O15|A
45
15
R9703
18
17
A17
18
17
A17
OE_
CE1_
CE2
A15
N.C.
15
16
10 A16
CE2
A15
GND
N.C.
I|O3
A4
I|O4
A5
I|O5
A6
I|O6
A7
I|O7
U5009
16
12
17
13
18
14
19
15
A8
A9
A10
CE
A11
WE
A12
OE
20
27
22
A13
A14
GND
GND
24
CS18LV10245
U5010
OE_
CE1_
A3
14
24
U6043
AT28C256_15SC
CS18LV10245
15
26
CE
NC3
15
16
28
OE
NC4
16
11
WE
ADDR3
23
13
NC1
NC5
13
NC1
NC5
ADDR4
24
14
NC2
NC6
10
14
NC2
NC6
10
ADDR5
25
12
RESET
12
RESET
ADDR6
26
47
BYTE
47
BYTE
ADDR7
27
ADDR8
28
ADDR9
30
ADDR10
10
OC1|PGP3
31
32
11
OC2|OC1|PGP4
ADDR11
ADDR12
33
12
OC3|OC1|PGP5
ADDR13
34
13
OC4|OC1|PGP6
35
14
IC4|OC5|OC1|PGP7
ADDR14
ADDR15
36
15
IC1|PGP0
ADDR16
37
16
IC2|PGP1
ADDR17
38
17
DSP_CS
ADDR18
39
18
DSP_RW
HOST_ADD(0:18)
CH_RXD+
BAS
CH_TXD+
BAS
17 RXD
18
TXD|PQS7
R5016
R5023
R5029
4.7K
R5027
IC3|PGP2
86 DS_|PE4
85 AS_|PE5
10
TU_CH_CHNG
12
11
KW_TUNE
10
12
11
R5056
PTT_OUT
VCC
100
81 SIS1|PE7
128
PWMA
127
PWMB
VCC
R9516
4.7K
U5005
74HC14
20MHZHC16OPTION
CLK
R5050
4.7K
R9604
OPTION
R|W_
R5039
10M
ONLY ONE
ASSEMBLED
2K
R5022
1K
VCC
VCC
16
VCC
E3
10 2
11 3
A0
VCC
14
O_1
A1
O_2
13
A2
O_3
12
O_4
11
O_5
10
E1_
O_6
E2_
O_7
PORT_2
UART CS_A
UART CS_B
UART CS_C
UART CS_D
R5051
39K
C5033
20PF
VCO1_SEL
HC16_SELECT_EEPROM_MSB
12
R5044
13
10K
CX
X0
HC4053-M_PWR
X1
14
R5068
10K
7002
U5005
74HC14
R5067
200
Y1
U6099
15
RESET
Z1
R9704
10K
CZ
U6099
CL
18
A2
17 A3
VCO2_SEL
18
A2
I|O1
VCO3_SEL
17 A3
I|O2
23
D1
Q1
BIT
16 A4
I|O3
25
11
16 A4
I|O3
25
11
11
D2
Q2
15 A5
I|O4
26
12
15 A5
I|O4
26
12
12
Q3
KW_ON_OFF
BATT_CHK
11
D3
13 D4
14 D5
Q3
10
13
A8
A9
32
10
31
A10
WR_ 5
CE1_ 30
11
A11
12
12
A12
13
A13
D3
13 D4
14 D5
Q4 12
Q5 15
17 D6
18 D7
Q6 16
Q7 19
CS_
NOISE_CONTROL
Q4 12
Q5 15
17 D6
18 D7
R9554
AUDIO_C_P_SW
Q6 16
Q7 19
SQ_SW
GND
INC_
U|D_
U6069
74VHC273
VCC
GND
10
10
C9511
0.1UF
R5063
39K
SW_A+
10
11
R5065
39K
_MR
14 A6
I|O5
27
13
13 A7
I|O6
28
14
I|O7
29
15
A9
10
31
A10
11
A11
12
12
A12
13
A13
A8
14
11 A14
15
16
10 A16
OE_
CE2
A15
N.C.
R9535
2K
Q5004
IS62C1024AL
U6095
24
I|O2
23
10
10
14 A6
I|O5
27
13
13 A7
I|O6
28
14
14
I|O7
29
15
15
OE_
32
14
11
A14
15
A15
16
10 A16
GND
RXC_MODEM_TTL
RS232_TTL_SW
WR_ 5
CE1_ 30
CE2
N.C.
GND
IS62C1024AL
U6094
D8
D9
D10
D11
D12
D13
D14
D15
TXC_MODEM_TTL
D1
Q1
PA_MUTE
D2
Q2
FAN_ON_OFF
D3
13 D4
14 D5
Q3
PA_INHIB
17 D6
18 D7
Q6 16
Q7 19
GND
10
AMP_ON_OFF
R9561
39K
TXC_MODEM_TTL
RXC_MODEM_TTL
RS232_TTL_SW
RXA
INTA
UARTB_INT
INTB
UARTC_INT
INTC
TXA
RXB
24
UARTD_INT
TXA
RXB
TXB
INTD
RXC
RESET
Q9068
7002
Q4 12
Q5 15
RXA
UARTA_INT
SHDN1_
VP_PTT
Q0
D0
U6068
74VHC273
I|O1
21
22
3904L
CP
AUDIO_SW
SQ_GATE
PORT_2
15
10
14
Z0
HC4053-M_C
HC4053-M
R5066
CY
Y0
Q2
12
I|O0
OPTION
Q1
11
EX_RESET_MR_
A1
D2
VCC
R9709
19
D1
SELECT_EEPROM_MSB
R9710
20 A0
U6070
74VHC273
GND
RD_
U6099
VEE
I|O0
OPTION
VCC
A1
CH_RST
R9707
A0
19
20
16
VCC
20
Q0
CP
C9616
0.1UF
11
R9705
VCC
D0
VPP_WP
Q0
15
VCC
R9708
D0
13
U6079
74VHC138
VCC
CP
A0
A1
A2
WR_
21
22
12
GND
_MR
11
_MR
11
14
BEER
VPP_WP
15
PORT_1
PORT_1
O_0
EXT_AUDIO_SW
C5032
20PF
VCC
VBAT
20
UART_UNIT
VCC
C9536
0.1UF
VBAT
C5013
0.1UF
20
Q5005
3906L
46
VCC
R9627
39K
Y5000
38.4KHZ
GND1
VCC
C9557
0.1UF
VCC
R5048
39K
Y5002
38.4KHZ
27
MONITOR
R5043
39K
SELECT_EEPROM_MSB
VCC
VCC
R5041
39K
VCC
OPTION
R9712
GND
46
RESET
U5005
74HC14
R5042
270K
R5060
100
GND1
27
80
39K
R5052
4.7K
GND
VCC
PA1
PCL K
129
126
10
71 BERR_
65 TSTME_|TS C
11
R5040
74HC14
U5005
74HC14
87 AVEC_|PE2
130
BKPT_|DSCLK
69 RESET_
66
FREEZE|QUOT
68 IPIPE1|DSI
67 IPIPE0|DSO
131
64
132
57 EXTAL
XTAL
55
MODCLK|PF0
I_O(0:12)
79
70
HALT_
150K
VPP_WP
13
I|O4
14
11
NC4
EX_RESET
Q5006
15 A5
10
15
NC3
OPT
ION
25
13
WE
39K
R9693
I|O3
38
17
39K
25
35
I|O4
I|O2
12
OE
R9701
CZ
I|O3
I|O3
A2
11
CE
10
C9572
100PF
I|O2
16
BDM_DSO
I|O1
11
1K
R9622
11
R9702
FAN_ON_OFF
BDM_CLK
10
A1
28
BDM_FREEZE
BDM_DSO
BDM_DSI
VCC
23
EEPROM I|O0
32KX8
26
R5024
17 A3
16 A4
I|O2
11
13
HC16_SELECT_EEPROM_MSB
12
I|O12
10
30
I|O11
23
33
A0
VR5003
5.6V
R9621
A9
A8
31
I|O1
13
CL
BDM_DSI
KW_TUNE
HC4053-M_C
U5007
RESET
10
30
15
DSP CS
R9696
CZ
R9552
44
22
R5047
R9692
DSO
10
R9706
100PF
A9
I|O7
21
I|O1
20
BDM_CLK
R9624
HC4053-M
U5006
R5025
R5070
A8
I|O0
A2
19
R9694
Y0
15
A1
18
90
KW_TUNE
BEER
42
R9617
R9493
I|O6
19
ADDR2
R5046
10
R5034
I|O5
29
I|O0
ADDR1
R5055
10
I|O2
10
ADDR0
CR5001
MMBD914T
CY
120
17 A3
16 A4
VCC
PCS3|PQS6
FLASH 1
FLASH 2
SRAM
SRAM
EEPROM
DECODER
PORT 1
OPT
ION
121
114
22
28
SRAM
512KX8
PCS2|PQS5
VCC
R9616
FC0|CS3_|PC0
21
I|O1
A0
OMIT THIS WHEN USE ANALOG INPUT
TXB
RXC
R9673
TXC
SHDN2_
RXD
CSA_
TXD
39K
A7
111
I|O0
A2
20
PCS1|PQS4
VR5002
5.6V
39K
18
16
10K
R5054
R9615
Y1
40
U5007
15
BGACK_|CS2_
A1
18
A0
15
HC4053-M
A6
91
FC1|CS4_|PC1
89 DSACK0_|P E0
88 DSACK1_|P E1
A7
14
DATA15
115
118
19
20
14
R5030
4.7K
C5029
0.1UF
A6
18
DATA14
110
PCS0|SS_|PQS3
R5075
C5028
0.1UF
19
19
119
FRAC_N_2_SEL
VR5007
5.6V
VCC
A5
VCC
SRAM
512KX8
VCC
A2
VCC
PEND|OCXO_SEL
R9695
A4
20
92
FC2|CS5_|PC2
STOP_SCAN
A3
21
U6035
TE28F400B5B80
C5023
0.1UF
FRAC_N_1_SEL
VPP
22
SCK|PQS2
L5001
Y0
23
38
13
PTT_MIC
10
35
R5059
39K
A1
31
I|O4
R9427
39K
24
I|O1
I|O3
R5072
39K
A0
I|O2
R5071
39K
R9560
39K
25
A5
R5021
39K
A2
29
I|O0
A4
12
12
CY
FLASH_1
256KX16
A3
ADDR19|CS6_|PC3
22UH
15
A1
20
SPI_CLK
U5005
GND 74HC14
KW_C_C
24
21
LOW_RF_SEL
KW_ALC
DSI
ADDR21|CS8_|PC5
VCC
A0
13
ADDR20|CS7_|PC4
39K
5.6V
25
VCC
VBAT
FLASH_2
256KX16
VCC
12
MOSI|PQS1
KW_C_C
13
37
11
11
PTT_IN_DATA
VR5008
VBAT
U5001
TE28F400B5B80
37
VCC
93
63 CLKOUT
10
MISO|PQS0
PTT_IN_CW
PTT_IN_VOICE
VCC
94
117
U5005
VR5006
5.6V
VCC
DATA13
116
D2A_OVEN_SEL
14
VCC
EX_RESET_MR_
C5011
0.1UF
C9509
0.1UF
DATA12
BG_|CS1_
EXT_ALARM_CONT
R5104
10K
C5010
0.1UF
DATA11
BR_|CS0_
C5026
0.1UF
OPT
ION
C9608
0.1UF
VCC
33
AN6|PADA6
R5035
2K
R5038
VCC
22
AN5|PADA5
10K
7002
MAX811MEUS-T
U5014
23
AN4|PADA4
R5100
KW_PTT
52
AN7|PADA7
MR_
RESET_
GND
49
R5017
39K
R9683
VCC
R5000
10
ANAOLG_ INPUT
PWR_LEVEL
82 SIZ0|PE6
C5021
1000PF
VCC
R9680
200
RESET
95
CSBOOT_
SW_A+
Q5003
96
48
VCC
C5022
4700PF
DATA10
V_REV_HF
SPI_DATA_IN
SPI_DATA_OUT
L5000
22UH
IRQ1_|PF1
DSP_REQ
TU_CUR_LIM
CR5003
SYNTH_LOCK
DATA2
ADDR22|CS9_|PC6
IRQ2_|PF2
VCC
VR5005
5.6V
123
53
MMBD701LT
108
76
BATT_SENSE
BAT_IN
109
DATA1
122
47
R9674
R5009
100K
MMBD701LT
HOST_DATA(0:15)
DATA0
77
V_FWD_HF
CR5004
UARTA_INT
CLK_IN
BATT_CHK
56
VDDSYN
54
51
60
XFC
VRL
VSTBY
43
50
VRH
VSSA
125
112
124
113
97
83
42
VDDA
VSSE5
VSSE6
VDDE5
VDDE6
VSSE7
VSSE3
84
62
41
98
VDDE7
VDDE8
VSSE2
VSSE1
VDDE2
61
40
VDDE1
22
VSSE4
VSSE
21
VDDE
58
59
VSS5 105
VDDE3
VSS1
VDD1
VDD3
CLK
VCC
GND
R9497
OPTION
C5017
0.1UF
GND
R5006
39K
VSS
R5001
4.7K
R5005
39K
29
R5004
39K
VSS2
R5003
39K
OPTION
R5014
4.7K
GND
C5008
0.1UF
20MHZ HC16 R9497
R5013
4.7K
NC
N.C
GND
100NF
5.6V
R5002
39K
CR5005
MMBD701LT
U6021
VRG78L05
VIN
C6032
10UF
VR5004
C9609
0.01UF
C5016
0.1UF
C6033
0.01UF
TXC
RXD
TXD
CSB_
CSC_
CLK
CSD_
RESET
UART_CL
R9553
GND
DSP_RESET
Figure A-1.F. LORD Module,
Schematic Circuit Diagram
(Sheet 6 of 15 – Host Circuits)
A-13/A-14
MM-E 2072-09333-00
SPARE
C9560
0.1UF
5V_UART
U6080
74VHC14
13
14
VCC
12
GND
R9608
39K
A2
A1
A0
NORMAL PTP
RS232_SW = HIGH
GPS MODE (J7)
RS232_SW = LOW
C9518
0.1UF
5V_UART
5V_UART
VCC
C9519
C5024
0.1UF
0.1UF
19
C9520
1UF
5V_UART
R5037
39K
R9566
39K
13
RS232_TTL_SW
12
16
VCC
5V_UART
53
D8
54
D9
55
D10
56
D11
57
D12
INTA
U6080
74VHC14
INTB
U6080
74VHC14
INTC
U6080
74VHC14
10
11
D13
58
D14
59
D15
60
D1
DSRD_
D2
CTSA_
D3
CTSB_
D4
CTSC_
D5
CTSD_
D6
RID_
D7
RIC_
RD_
IOW_
40
IOR_
ST16C554
U6078
RIA_
RIB_
32
48
16
33
47
50
30
63
19
CSA_
CSB_
11
CSC_
CSB_
38
CSC_
TXB
10
CSD_
42
CSD_
RXB
INTA
TXC
20
39
12
37
43
CSA_
TXA
RXA
INTB
RXC
INTC
TXD
INTD
RXD
14
R9571
39K
R9570
39K
R9526
39K
R9525
39K
R9524
39K
R9523
39K
R9522
39K
R9521
39K
R9520
39K
R9519
39K
HC4053-M_PWR
U5006
GND
5V_UART
VEE
X0
X1
12
15
GPS_TXD_TTL
10
13
20
11
VCC
C1+
V+
C1C2+
V-
C2-
N.C
T1IN
T1OUT
T2IN
T2OUT
R1OUT
R1IN
R2OUT
R2IN
SHDN_
NC
5V_UART
GND
EN_
C9521
1UF
C9522
1UF
R9562
R9500
14
39K
39K
17
TXA
TXB
RXA
16
RXB
18
5V_UART
C5027
0.1UF
R5053
39K
R9572
39K
R9573
39K
R9574
39K
62
16
VCC
14
29
11
CX
X0
HC4053-M_PWR
U5007
GND
41
VEE
X1
12
GPS_RXD_TTL
13
5V_UART
51
R9502
39K
5V_UART
R9509
SHDN1_
R9575
39K
U6080
RESET
DSRC_
WR_
U6080
74VHC14
INTD
D0
11
CX
5V_UART
U6062
MAX3222E
74VHC14
R9569
39K
R9567
39K
CLK
5V_UART
7_188275_6
3.3VDC_FROM _LORD
RXD_A_FEOM_GPS_TTL
C9524
0.1UF
19
C9525
T XD_A_FROM_GPS_TTL
1UF
DISCONNECT FOR INTERNAL MODEM
J10
R9625
13
CS
12
FT H_104_01_01_L_DV_P
R9634
20
5V_UART
R9635
GPS_TXD_TTL
11
VCC
C1+
U6063
MAX3222E
V+
C1C2+
V-
C2-
N.C
T1IN
T1OUT
T2IN
T2OUT
R1OUT
R1IN
R2OUT
R2IN
SHDN_
NC
GND
EN_
C9526
1UF
R9501
C9527
R9563
1UF
39K
39K
14
17
TXC
TXD
16
RXC
RXD
18
SHDN2_
R9503
39K
L9084
22UH
L9082
R9510
VCC
3.3V
5V_UART
22UH
GPS CONNECTOR
15
10
R9626
GPS_RXD_TTL
J8
5V_UART
C9523
0.1UF
C9607
0.1UF
C9605
10UF
C9610
0.01UF
C5025
0.1UF
TXC_MODEM_TTL
C9566
10UF
C9591
0.1UF
C9567
10UF
RXC_MODEM_TTL
Figure A-1.G. LORD Module, Schematic Circuit Diagram (Sheet 7 of 15 – UARTs)
A-15/A-16
MM-E 2072-09333-00
VCO1_SEL
VCO2_SEL
VCO3_SEL
DSM_AGC_EN
FILT_LOW_RF_SEL
CONVST
9T
3.3V
J3
FILT_LOW_RF_SEL
9T
SPI_DATA_TO_HF
FILT_SPI_CLK
40
PTT_IN
R3059
FILT_LOW_RF_SEL
10K
FILT_SPI_DATA
39
38
SPI_DATA_TO_HF
37
FILT_SPI_CLK
SW_A+_RF
VCO1_SEL
GND
GND
GND
32
SPI_DATA_TO_HF
J1
J1
J1
1 RF_IN
SPI_CLK
SPI_DATA_TO_HF
RF_IN
2 GND
DSM_AGC_EN
CONVST
3.3V
PWR_LEVEL
PTT_IN
A_D_DATA
SR_CLK
SR_DATA
FILT_SPI_CLK
LOW_RF_SEL
SPI_DATA _OUT
FILT_L OW_RF_SEL
FILT_FRAC_N_1_SEL
PRE_SELECTOR
PS_OUT
NOISE_CONTROL
SPI_CLK
RF_CHAIN
PS_OUT
3 GND
C3046
100NF
LOW_RF_SEL
FILT_VCO1_SEL
FRAC_N_1_SEL
FILT_VCO2_SEL
D2A_OVEN_SEL
FILT_VCO3_SEL
DSM_OUTPUT_1.05MHZ
VR5
ZENER_4813831A23
TO_HIGH_POWER
PWR_LEVEL
A_D_DATA
SR_CLK
SR_DATA
SPI_DATA _OUT_UP
SPI_CLK_UP
LOW_RF_SEL
FRAC_N_1_SEL
D2A_OVEN_SEL
DSM_OUTPUT_1.05Mhz
OVEN_TEMP_CNTL2
FILT_NOISE_CONTROL
CR2008
MMBD914T
30
VCO3_SEL
FILT_SPI_DATA
35
34
VCO2_SEL
BIAS_OUT
100NF
SPI_DATA_OUT
36
BIAS_OUT
C3048
SW_A+_RF
SW_A+_RF
FILT_SPI_CLK
OVEN_TEMP_CNTL1
FIRST_INJ
TX_SEC_INJ
NOISE_CONTROL
DSP_16.8Mhz
IF_16.8Mhz
1 TO_HIGH_POWER
GND
28
J2
C3047
100NF
2 GND
VR4
ZENER_4813831A23
J2
CR2009
MMBD914T
DIGITAL_16.8Mhz
3 GND
J2
NOISE_CONTROL
C3045
100NF
12
BIAS_OUT
OCXO_SW_A+
OCXO_SW_A+
OCXO_SW_A+
OCXO_SW_A+
OCXO_SW_A+
SPI_CLK
SPI_DATA _OUT
BIAS_OUT
PENDULLUM_SEL
19
21
FIRST_INJ
23
FILT_VCO2_SEL
FILT_VCO3_SEL
PENDULLUM_SEL
OVEN_TEMP_CNTL1
SYNTHESIZER
SYNTH_LOCK
FRAC_N_2_SEL
SPI_DATA _OUT
SPI_CLK
OVEN_TEMP_CNTL2
PLL_1_SEL
OCXO_SW_A+
J3
HIGH POWER
CONNECTOR
FILT_VCO1_SEL
SPI_CLK
25
27
TX_SEC_INJ
SPI_DATA _OUT
SINE_16.8MHZ
SYNTH_LOCK
OVEN_CXO
IF_16.8Mhz
SINE_16.8MHZ
AMB_TEMP
PLL_2_SEL
FILT_SPI_DATA
FILT_SPI_CLK
AMB_TEMP
FILT_SPI_DATA
FILT_SPI_CLK
Figure A-1.H. LORD Module, Schematic Circuit Diagram (Sheet 8 of 15 – RF Section Organization)
A-17/A-18
C47
CR8
MMBV3401
MM-E 2072-09333-00
CR9
MMBV3401
1000PF
13V
SW_A+_RF
13V
L52
C3
15UF
470
C15
0.1UF
C56
100NF
22UH
C91
0.1UF
3904L
R30
1.2K
Q5
13V
VDD_PS
C102
2.7NF
CR7
MMBV3401
VDD_PS
C58
C36
C92
6.8NF
2.7NF
MMBV3401
0.01UF
CR16
R13
R11
100K
6.8K
L51
22UH
C4
0.1UF
16
C90
0.1UF
U1
74HC595A
L5
22UH
FL1
FL2
SPI_DATA_TO_HF
C41
1.8NF
C28
0.01UF
C94
1200PF
L7
C40
1.8NF
C93
0.01UF
FL1
22UH
VCC
R29
SPI_DATA_OUT
14
SPI_CLK
11
LOW_RF_SEL
12
10
SHICLK
LATCLK
QA
15
QB
QC
QD
QE
QF
QG
QH
SQH
L39
13V
1.2K
C14
0.1UF
Q6
L12
4700NH
C16
L13
10UH
10UH
0.1UF
3904L
R14
6.8K
R10
100K
C82
CR6
MMBV3401
C43
1500PF
2.7NF
C27
C39
1.8NF
MMBV3401
CR15
0.01UF
FL3
RESET
OUTEN
9T
13
L10
10UH
13V
R28
1.2K
C130
3.3NF
C30
C179
C79
3.3NF
100PF
680PF
C97
470PF
L15
C99
470PF
10UH
FL2
FL2
Q7
3904L
GND
C13
0.1UF
R15
6.8K
C17
L25
L16
L26
8.2UH
8.2UH
3.3UH
R9
0.1UF
C96
100K
9V
C129
3.3NF
470PF
9V
R21
FL4
6.8K
R27
1.2K
C81
0.01UF
R2
100
Q8
C111
1000PF
C38
1.8NF
CR5
MMBV3401
L9
C100
3.3NF
10UH
3904L
R22
6.8K
C95
470PF
FL3
R16
6.8K
C12
0.1UF
C7
0.1UF
C60
470PF
C160
100PF
C51
620PF
R4
100
L14
C29
3.3NF
10UH
FL3
L37
L47
MMBV3401
CR14
C24
0.1UF
C18
0.1UF
L38
5600NH
5600NH
2.2UH
R3
BIT NOISE GENERATOR
C46
1000PF
CR4
MMBV3401
13V
NOISE_CONTROL
FL0
R34
18PF
FL1
C89
0.1UF
C88
R31
1.2K
100K
VDD
L6
22UH
FL0
R12
R2903
18
C31
C50
C61
470PF
100
MMBV3401
4700PF
680PF
CR13
R1
100
C34
L31
R8
100K
VDD1
R2906
100K
FL5
C6
0.1UF
VR1
MMBZ5226BL
C2
33UF
C2900
0.1UF
R2901
10K
9V
L35
C98
470PF
L4
22UH
C23
6800NH
FL4
C11
0.1UF
0.1UF
L54
L53
3.3UH
3.3UH
L36
6800NH
C49
680PF
CR3
MMBV3401
L27
6800NH
Q1
3904L
C1
33UF
0.1UF
13V
R17
6.8K
VR2
MMBZ5226BL
L8
22UH
C19
L20
1.5UH
R26
1.2K
Q2901
3906L
C107
390PF
2.7NF
6800NH
FL4
R7
100K
C42
1500PF
L30
6800NH
C103
270PF
C101
MMBV3401
CR12
2.7NF
L34
C104
270PF
R80
C85
C25
0.1UF
RF_IN
13V
0.1UF
R81
560
560
C26
6800NH
FL5
FL6
R25
1.2K
C54
470PF
C108
390PF
FL5
RX
C300
0.1UF
C8
0.1UF
RX
R82
10
0.1UF
PS_OUT
C20
L50
L49
910NH
L48
2.2UH
0.1UF
2.2UH
R33
220
C86
0.1UF
R35
6.8K
R60
18
Q2
R18
6.8K
3904L
C52
470PF
CR2
MMBV3401
R6
100K
FL7
C200
L44
Q30
R50
3K
3906L
L45
270NH
R24
1.2K
CR17
MMBV3401
R37
1.2K
22UH
C112
C66
C78
C67
68PF
120PF
68PF
C21
L43
C172
L3
L42
680NH
1200NH
0.1UF
1200NH
33PF
R5
100K
C65
180PF
CR1
MMBV3401
0.1UF
L33
6800NH
FL6
C9
0.1UF
Q3
3904L
MMBV3401
CR11
C80
220PF
FL6
13V
R19
6.8K
C110
220PF
C37
1.8NF
270NH
L55
C45
1000PF
L29
6800NH
0.1UF
C105
270PF
C62
270PF
C106
C44
180PF
1200PF
MMBV3401
CR10
FL0
L46
22UH
Q9
C84
C83
R36
0.1UF
0.1UF
6.8K
R23
1.2K
3904L
Q4
L28
6800NH
C72
270PF
C48
680PF
C77
120PF
120PF
C87
0.1UF
R20
6.8K
6800NH
FL7
3904L
L32
C109
FL7
C10
0.1UF
L22
390NH
L1
910NH
L2
C22
0.1UF
910NH
Figure A-1.I. LORD Module, Schematic Circuit Diagram
(Sheet 9 of 15 – Preselector Circuits)
R32
10
A-19/A-20
MM-E 2072-09333-00
VOS2
SYN1_CONTROL
C2081
VCC
SW
VCO3
R2045
9.09K
CTRL
FILT _VCO3_SEL
FIRST SECTION
FIRST_IN J
0.1UF
FN
C2061
C2142
3.9NF
1000PF
C2118
1.5NF
C2117
100NF
FILT _VCO2_SEL
GND
R2048
1K
R2000
270
SYNTH_LOCK
R2071
300
SYN1_RF_TO_MIXER
R2082
18
FILT _VCO1_SEL
R2047
4.75K
SECOND SECTION
SYN2_CONTROL
VCC
R2046
5.62K
C2146
6.8NF
GND
0.1UF
R2052
7.5K
C2067
1000PF
R2070
300
C2114
0.1UF
SHOULD BE 330PF (1206) FOR BSF OPERATION
VDD2
SYN2_VCO_OUT
C2083
0.1UF
C2085
0.1UF
C2002
SYN2_LD
NP- C2126
VOS
NP- L2015
VDD1
NP- C2128
VCC
CTRL
FN
C2130
OPTION
C2129
OPTION
C2062
L2014
120NH
VCAP
C2150
C2128
OPTION
C2127
OPTION
NP - R2076
C2048
100NF
C2126
OPTION
R2076
OPTION
15
VCC1
VCC2
R2017
20PF
14
C2000
16.8MHZ
C2079
0.1UF
12
FILT _SPI_DATA
FILT_SPI_CLK
11
PLL_1_SEL
13
FO_LD
OSC_IN
VP
FIN
CE
FIN_
C2056
15PF
L2006
100NH
150
C2016
FIN_
12
11
PLL_2_SEL
13
LE
33PF
68NH
TX_SEC_INJ
C2074
0.1UF
R2012
4 .7K
SYN2_RF_TO_MIXER
OP TI O N A L A DF 4110
R2062
300
C2043
SYN2_LE
51PF
4.7K
FLO
U6076
ADF4110
OP TI O N A L L M X2316
OP TI ON
LE
L2012
R2011
CLOCK
OPTIONAL ADF4110
C2050
VP 16
CE 10
DATA
SPI_CLK
C2093
0.1UF
CPO
FO_LD
GND1 GND2
R2008
R2036
75PF
CLOCK
L2007
100NH
10
DATA
GND1 GND2
SINE_16.8MHZ
16
FLO
U6075
ADF4110
CR2002
MMBV3401
CPO
15
VCC2
FIN
SPI_DATA_OUT
R2083
18
VCC1
OSC_IN
10
1000PF
GND
VP1
14
16.8MHZ
C2054
SHOULD BE 47PF (1206) FOR BSF OPERATION
SYN1_D
C2094
0.1UF
NP- C2150
1K
OPTION
SYN1_LD
C2006
4.7UF
C2116
0.1UF
NP- L2014
C2049
100NF
NP- C2131
R2049
R2007
SYN1_LE
L2016
35.5NH
NP- C2130
C2084
0.1UF
0.1UF
SYN1_CLK
L2015
35.5NH
C2131
OPTION
NP- C2129
SW
VCO2
OPTIONAL LMX2316
C2072
NP- L2016
NP- C2127
4.7UF
C2080
0.1UF
C2121
3.9NF
C2120
100NF
18
CR2000
TRIPLE_DIODE
0.1UF
FN
R2078
C2086
0.1UF
CTRL
C2112
CR2001
MMBV3401
VCO4
GND3
R2077
18
SYN2_D
C2095
10UH
0.1UF
SYN2_CLK
L2020
L2027
L2004
GND3
R2063
300
270NH
120NH
VDD2
C2097
0.1UF
C2038
C2071
0.1UF
SYN1_16.8MHZ
100PF
VCC
C2015
SW
L2026
82NH
CTRL
C2039
75PF
20PF
51
100PF
FN
C2063
1000PF
C2124
0.1UF
R2034
VCO1
L2002
C2078
C2053
C2136
39PF
R2035
C2040
1K
C2052
GND
5.6PF
L2005
8.2NH
100PF
270NH
R2050
L2011
15NH
20PF
C2042
C2036
C2047
4.3PF
7.5PF
51
L2001
C2096
0.1UF
R2038
1200NH
68PF
R2043
3.3K
L2003
R2074
220
Q2007
C2070
270NH
CR2003
MMBV3401
C2123
11PF
C2125
5.6PF
MMBR951
680PF
C2110
0.1UF
L2023
C2046
C2035
11PF
12PF
120NH
C2045
R2056
1K
11PF
R3301
10
R2029
27
VOS
C2140
15PF
C2222
L2028
20PF
120NH
C2092
R2051
1K
C2041
68PF
510
0.1UF
VOS2
C3111
SW_A+_RF
0.1UF
SW_A+_RF
U2009
L2018
10UH
C2091
4.7UF
8.2K
ADJUST
R2058
560
0.1UF
C2010
15UF
GND
GND
GND
GND
R2009
C2018
33K
0.1UF
L2008
R2057
560
C2111
0.1UF
Q2006
0.1UF
1 IN VCC OUT 4
8 IN_
SW1 6
7 SB
SW2 3
R2044
3.3K
GND
C2139
18PF
C2138
18PF
R2084
10
C2075
R2055
1K
33PF
C2051
100NH
U2002
MC12093DR2
1K
R2066
300
GND
GND
GND
GND
L2013
R2067
300
20PF
0.1UF
L2021
10UH
C2017
C2044
75PF
51PF
0.1UF
VDD2
R2086
10
VDD1
C2073
C2032
0.1UF
0.1
R2004
R2003
U2003
MC12093DR2
C2100
C2030
0.1UF
R2060
560
C2102
18
0.1UF
C2108
C2137
39PF
0.1UF
U2010
GND
R2059
560
L2025
1.0UH
R2081
0.1UF
1 IN VCC OUT 4
8 IN_
SW1 6
7 SB
SW2 3
0.1UF
C2031
100NH
VDD2
L2022
10UH
C2098
R2079
18
L2009
C2004
4.7UF
C2101
C2106
0.1UF
68NH
C2099
0.1UF
R2054
1K
R2068
300
R2069
300
PC1678GV
C2104
VCC
C2103
0.1UF
0.1UF
$V
IN
OUT
0.1UF
R2064
300
0.1UF
C2107
C2013
4.7UF
C2134
39PF
0.1UF
C2076
C2024
0.1UF
R2080
18
C2055
R2053
C2014
15UF
VDD1
L2019
10UH
C2077
C2025
0.1UF
0.1UF
C2105
0.1UF
R2061
390
MMBR951
C2021
0.1UF
130
0.1UF
C2007
R2022
U2004
LM2931CD
INPUT
C2088
R2026
C2090
OUTPUT
GND
NC
N.C
R2037
R2002
R2065
300
150
VDD
GND
O.PUT-INH
GND
U6025
GND
C2141
15PF
C2003
4.7UF
1 VOUT
VIN
GND
SW_A+_RF
C2109
0.1UF
C2057
GND
GND
VP1
15PF
C2133
39PF
L2000
33NH
R2085
10
GND
GND
C2087
0.1UF
VDD2
GND
VDD1
GND
C2037
100PF
OUT
4.7UF
VRG78L05
GND
0.1UF
L2024
1.0UH
GND
PC1678GV
C2089
0.1UF
VDD1
L2017
10UH
IN
15UF
GND
NC
C2064
1000PF
C2008
0.1UF
C2009
VIN
C2019
VCC
C2020
NC
U6024
VRG78L05
1 VOUT
Figure A-1.J. LORD Module,
Schematic Circuit Diagram
(Sheet 10 of 15 – Synthesizer Circuits)
A-21/A-22
MM-E 2072-09333-00
VCC
VCC
R9065
C9099
R9063
C9089
200
1000PF
200
1000PF
FN
FN
C9096
47PF
C9098
390PF
3 G2
G1
CTRL
CR9075
10PF
Q9000
BF992
CR9071
BB659C-E7902
CR9066
BB659C-E7902
Q9020
BF992
CR9063
C9062
R9100
18
C9110
180PF
C9097
L9079
L9076
1 .5UH
10PF
C9069
12PF
MMBD 701 LT
1.5UH
R9020
27K
C9063
L9065
5.1PF
35 .5NH
L9077
L9070
SH9020
1.5UH
1.5UH
SHIELD
L9065A
C9000
C9020
1000PF
66 .8NH
1000PF
C9094
C9066
15PF
15PF
SW
Q9065
MUN2211T1
CR9000
BB659C-E7902
10
L9072
L9020
R9000
SHIELD
R9200
C9200
1000PF
1 .5 UH
27K
35 .5 NH
SH9000
CR9076
BB659C-E7902
D 2
3 G2
OP TI ON
L9076A
66 .8NH
1 .5UH
12PF
MMBD 701 LT
C9074
43PF
G1
C9095
CR9068
C9093
L9000
CTRL
CR9069
BB659C-E7902
BB659C-E7902
C9084
100PF
D 2
CR9079
BB659C-E7902
GND
SW
Q9063
MUN2211T1
CR9020
BB659C-E7902
GND
a. VCO 1
b. VCO 2
VCC
L9062
VCC
910 NH
R9064
C9091
R9062
C9087
200
1000PF
200
1000 PF
FN
FN
C9072
100 PF
C9075
CR9073
BB659C-E7902
3 G2
4 G1
33 PF
CTRL
CR9064
NP - C9079
C9079
OP TION
C9070
12 PF
L9073
1.5UH
C9300
L9066
28NH
SH9040
30PF
3 G2
C9078
3.3PF
NP-CR 9062
CR9062
MMBD701LT
R9300
L9064A
18
28 NH
C9060
R9040
27K
1000PF
L9064
C9081
8 NH
1PF
R9400
10
R9060
27K
L9061
910 NH
C9076
Q9064
1SV229
1000PF
SHIELD
12 PF
1000 PF
3 .3 PF
CR9078
Q9060
BF992
C9400
1 28NH
SH9060
C9067
C9080
C9061
5 .6PF
L9074
D 2
G1
1.5UH
SHIELD
CR9074
BB659C-E7902
C9082
15PF
180 PF
C9040
C9071
910 NH
MM BD 701 LT
L9066A
53 NH1
L9040
L9060
CTRL
Q9040
BF992
CR9067
BB659C-E7902
1.5UH
D 2
7 .5PF
SW
MUN2211T1
CR9040
BB659C-E7902
GND
c. VCO 3
GND
d. VCO 4
Figure A-1.K. LORD Module, Schematic Circuit Diagram (Sheet 11 of 15 – VCO Circuits)
A-23/A-24
MM-E 2072-09333-00
C3014
0.01UF
TEMP_CONT
D2A_TEMP_CONT
9V
C3027
0.01UF
TEMP_CONT
_IN
R3942
10K
OVEN_TEMP_CNTL1
13
R3044
R3006
33K
12
R3350
10K
OVEN_TEMP_CNTL2
R3004
150K
33K
14
11
R3330
TEMP_SENSE
U3000
MC33174_PWR
HEAT_CONT
C3011
10K
0.01UF
R3043
33K
TEMP_SENSE
10
C3029
C9401
0.01UF
U3000
MC33174
0.01UF
R3063
33K
R3060
10K
R3029
150K
1K
R3047
100
R3046
U3000
MC33174
U3000
MC33174
R3064
100K
R3048
10K
Q3000
3904L
CUR_SENSE
R3034
62K
R3024
R3025
1.0
C3028
0.01UF
C3031
0.01UF
1.0
R3062
10K
R3310
10M
NP-R3014
R3014
OPTION
R3011 NP-R3011
OPTION
NP-C3009
NP-R3026
C3075
0.01UF
C3026
C3009
OPTION
0.1UF
OCXO_SW_A+
R3031
150K
R3075
150K
R3026
OPT
ION
R3019
130
C3015
0.01UF
OCXO_SW_A+
NP-R3032
11
R3032
OPTION
12
13
R3027
SINE_OUT
28
FO_SQW
V_REG
V_OPT
VDD
R3028
NP-R3028
OPTION
8 IN
7 FDBK
27
26
GND
U3001
PENDUL_168MHZ
DE
L3004
10UH
29
NC
S1
SS
BANDGAP-REF
10
GND
C_EXT
NC
C3006
0.1UF
GND
GND
NC
GND
NC
NC
NC
C3023
33PF
NC
C3007
0.1UF
25
SPI_DATA_OUT
24
PENDULLUM_SEL
C3037
0.1UF
C3012
0.01UF
R3076
10.0K
6 5V_TAP
5 _ERROR
OUT
SENSE
11
CE
22
SCK
C3900
33UF
0.01UF
SPI_CLK
TEMP_SENSE
11
C3008
SDO
SDI
SCLK
NP-U3010
U3010
AD7243BR
SYNC_
CUR_SENSE
REFOUT
ROFS
10
VDD
C3500
4.7UF
VDD
C3110
0.1UF
C3010
0.1UF
C3024
33PF
16
REFIN
0.1UF
VCC
OCXO_SW_A+
R3000
C3038
21
S0
NP - U3002
REG_SW_A+
SHDN 3
GND
C3013
0.01UF
23
L3001
10UH
VDD
R3600
10M
R3050
150K
VOUT
D2A_FREQ
V_REF_OUT
U3002
HYBR_11P
TEMP_SENS
OCXO_RF_OUT
CUR_SENS
GND
13
14
6.8K
10
FREQ_CONT
HEAT_CONT
HEAT_CONT
CLR_
LDAC_
DCEN
BIN_|COMP
VDD
12
15
L3006
10UH
C3019
68PF
C3044
39PF
1.5UH
R3010
3.3K
C3021
180PF
R3051
3.3K
C3016
0.01UF
C3002
0.1UF
L3000
IF_16.8MHZ
C3034
0.1UF
C3025
39PF
R3009
Q3001
MMBR951
C3000
0.01UF
GND
C3003
0.1UF
470
R3023
50K
DGND AGND VSS
L3003
10UH
L3002
10UH
AMB_TEMP
V_REF_OUT
R3052
3.3K
C3005
0.1UF
R3300
L3007
1.5UH
R3021
10
51
R3058
10
L3005
10UH
R3056
560
C3036
0.1UF
C3035
0.1UF
0.1UF
C3033
L3008
1.5UH
C3043
180PF
SINE_16.8MHZ
C3041
68PF
Q3002
R3013
R3020
10
1K
R3016
560
R3017
560
C3040
68PF
C3042
180PF
MMBR951
R3055
560
R3054
560
R3053
1K
R3057
10
Figure A-1.L. LORD Module, Schematic Circuit Diagram (Sheet 12 of 15 – Frequency Reference Circuits)
A-25/A-26
MM-E 2072-09333-00
AMPLIFIER #1
9T
R1000
10K
9T
L1029
CR1006
MMBD914T
0.1UF
C1000
CR1002
MMBD914T
CR1005
MMBD914T
R1002
10K
L1020
0.1UF
C1002
C1003
33UF
BIDIRECTIONAL AMPLIFIER #2
9V
E1002
FERRITE_BID
18
C1006
C1007
C1008
33UF
0.1UF
0.1UF
C1011
10NF
0.1UF
R1007
R1005
10
C1005
0.1UF
Q1007
C1001
0.1UF
R1001
18
R1003
3906L
CR1007
MMBD914T
Q1011
3906L
22UH
C1004
9V
22UH
AMPLIFIER #0
R1006
68
10
10
C1018
C1009
10NF
RAGC
R1011
2K
0.1UF
R1012
2K
R1014
10
0.1UF
R1016
R1017
100
100
C1021
C1017
R1019
2K
0.1UF
PS_OUT
L1000
PS_OUT
R1020
2K
R1022
L1012
910NH
L1021
22UH
C1028
CR1008
0.1UF
MMBV3401
R1027
330
AMP_2
R1030
39PF
51
C1035
FET_MMFT6661T1
0DB
0V
8V
0V
8V
8V
0V
0V
8V
20DB
8V
0V
8V
0V
C1042
L1059
22UH
0.1UF
R1036
Q1015
3904L
2.7K
R1042
10K
L1006
L1007
270NH
270NH
L1008
270NH
R1032
22
C1039
C1038
24PF
C1062
C1047
C1052
10NF
R1060
470
R1061
470
68PF
24PF
C1049
100PF
C1050
33PF
0.1UF
RX,TX
TRANS_IF
C1041
R1088
51
Q1003
MMBR951
L1046
560NH
L1057
270NH
R1039
22
C1056
OPTION
24PF
R1043
R1044
R1045
R1046
270
270
390
2.7K
R1047
0.1UF
R1037
51
45.100M
R1040
10
C1054
C1055
27PF
22PF
R1041
10
C1057
OPTION
AMP_4
C1059
51
C1044
C1046
10NF
NP-C1056
LPF_1
L1047
560NH
FL2
24PF
IF2_3
0.1UF
R1048
C1058
0.1UF
150
R1051
270
R1062
270
R1052
270
R1063
270
ATTN
R1053
STEP_AGC_10
STEP_AGC_20
STEP_AGC_30
0DB
R1064
390
R1058
330
10DB
20DB
30DB
C1067
C1065
10NF
0.1UF
FIRST_INJ
150
9V
SELECTOR #0
9R
CR1011
$MMBV3401
C1061
0.1UF
R1059
R1056
51
10
CR1012
MMBV3401
C1063
0.1UF
CR1009
MMBV3401
R1065
C1066
33UF
C1068
0.1UF
L1027
22UH
L1028
22UH
L1022
22UH
LO
C1074
0.1UF
MIX_1
CR1010
MMBV3401
270
L1041
10UH
L1043
10UH
U1000
RMS-1LH
IF
R1069
C1064
L1045
560NH
C1072
100NF
RF
0.1UF
L1042
10UH
11PF
C1070
0.1UF
C1069
0.1UF
11PF
C1071
R1068
GND1
270
L1050
82NH
L1023
22UH
C1076
10UH
33PF
9T
9R
C1080
0.1UF
100NF
2.7PF
XTAL_OUT
L1054
120PF
C1075
C1079
C1162
2.7PF
C1163
9T
R1070
270
2.7K
Q1006
MMBR951
C1073
R1071
270
R1074
R1055
10
R1057
R1067
C1077
10NF
NP-C1057
9T
390
150
0.1UF
Q1001
10NF
C1048
L1018
22UH
R1066
C1036
2.7PF
AMP_3
C1045
Q1013
3904L
10NF
C1161
2.7PF
C1043
Q1014
3904L
560
C1160
C1031
10NF
0.1UF
C1051
C1060
C1030
24PF
NP-C1033
22PF
R1034
18
ATT2
C1053
100PF
2.7K
C1033
OPTION
C1029
R1035
68
AMP_1
10K
R1054
STEP_AGC_30
R1033
68
C1040
24PF
20PF
45.100M
FET_MMFT6661T1
Q1002
R1038
Q1000
3904L
FL1
ATT2-
10DB
L1048
560NH
L1049
560NH
C1032
OPTION
RX
R1031
10
ATT2+
0.1UF
ATT1
ATT1-
R1028
330
LPF #0
L1052
10UH
NP-C1032
C1037
ATT1+
2.7K
RX,TX
10NF
RX,TX
9 DB PAD
ATT2+
R1025
18
C1026
0.1UF
R1026
10
270NH
0.1UF
ATTN
0.1UF
R1018
10NF
C1023
0.1UF
R1024
330
C1024
L1016
0.1UF
270
C1034
ATT1+
C1015
33UF
0.1UF
C1019
C1022
0.1UF
C1025
0.1UF
C1014
C1013
0.1UF
10
R1023
R1029
560
C1012
L1044
10UH
R1021
18
L1017
22UH
22UH
C1027
R1050
10NF
10
CR1000
$MMBV3401
C1016
10
0.1UF
R1049
10
R1015
C1020
2K
470
Q1019
3904L
R1010
L1030
22UH
R1009
R1013
C1010
0.1UF
9R
R1008
E1001
FERRITE_BID
R1075
R1076
270
270
C1078
0.1UF
L1033
22UH
R1077
51
C1081
0.1UF
C1084
33UF
C1082
0.1UF
R1072
R1073
10K
3K
C1083
0.1UF
TX
STEP_AGC_10
STEP_AGC_20
TO_EXCITER
Figure A-1.M. LORD Module, Schematic Circuit Diagram (Sheet 13 of 15 – Front End Circuits)
A-27/A-28
9R
MM-E 2072-09333-00
9T
9T_IF
VDD_IF
TX 1.05MHZ BANDPASSFILT
ER
VDD
L1800
L1801
22UH
L1802
1.0UH
TX_SEC_INJ
100
1.0UH
C1803
0.1UF
R1800
33UF
C1802
0.1UF
VDD_IF
C1801
C1800
C1997
C1804
0.1UF
0.1UF
0.1UF
L1803
L1804
1.0UH
1.0UH
R1801
1K
LO
RX,TX
TRANS_IF
C1807
0.1UF
C1808
1.8NF
L1805
22UH
IF
RF
R1802
100
C1810
0.1UF
MMBV3401
C1812
4700PF
C1820
0.1UF
RX
14
11
12
OUT
C1815
220PF
10
C1817
0.1UF
R1816
100
C1821
0.1UF
AMP #33
CONT.
RX
U1111
MC14066B
10 DB GAIN VERIATIONS
R1825
ALLOVERTHE RX CHAIN
R1829
4.7K
R1830
C1835
20PF
CONSIDERREMOVINGTHIS ECAP
4.7UF
R1837
1.5K
R1832
10K
FL4
450K
C1838
0.1UF
R1839
39K
IN
1.5K
FL3
450K
C1843
0.1UF
OUT
C1845
0.1UF
Q1022
3904L
RX
C1832
4.7K
220PF
IN
OUT
13 CONT.
39K
R1857
R1858
R1859
3.3K
330
10K
RX
C1828
16
VCC
R1834
560
STEP_AGC_10
U1109
STEP_AGC_30_2
14
VCC
R1838
560
STEP_AGC_10_2
13
GND
STEP_AGC_10_2
560
STEP_AGC_30
74VHC14
R1828
100
R1841
10K
R1833
STEP_AGC_20
VDD_IF
15
QA
QB
QC
QD
QE
QF
QG
0.1UF
QH
SQH
13
OUTEN
DSM_AGC_EN
C1956
0.01UF
U1110
10
C1836
C1837
C1839
0.01UF
0.01UF
0.01UF
R9514
R1853
270
11
LATCLK
12
10
GND
C9530
R1850
3.3K
SHICLK
RESET
0.1UF
R1848
10K
R1854
270
SR_DATA
14
C1841
MC33174
R1852
39K
R1856
0.01UF
0.1UF
VDD_SWITCH
R1847
1.8K
R1855
1.8K
2.2NF
C1847
0.1UF
C1826
R1822
3.3K
C1827
R1823
10K
C1829
0.1UF
Q1925
7002
C1840
R1843
100K
GND
Q1023
C1848
0.1UF
68PF
Q1021
R1820
1K
14
VDD_IF
R1831
3904L
R1842
220
U1110
U1112
74HC595A
R1845
220
3904L
R1851
3K
C1844
0.1UF
C1823
0.1UF
13
11
R1962
560
IN
3904L
C1852
R1899
560
SR_CLK
ADC_IN
12
RX
R3303
51
U1111
MC14066B
R1819
1K
12
C1846
0.1UF
C1824
1.8NF
R1821
1.2K
IF3_5
OUT
GND
R1846
27
0.1UF
IF3_6
R1840
IF3_4
U1110
R1911
3.3K
CONT.
C1890
R1836
1.5K
R1835
39K
0.1UF
C1842
0.1UF
R1998
10K
IF3_3
IF3_2
R3302
100
R1824
1.5K
IN
C1833
4.7K
C1834
C1830
0.1UF
R1827
100
C1825
0.01UF
MC33174
OUT
R1826
100
C1831
0.1UF
4.7K
C1822
4.7UF
THIS TRIMMERSHOULD COMPENSATE
100
R1818
AF_2
C3112
0.1UF
C9423
10UF
C9492
0.1UF
R1815
10K
U1110
9R_IF
R1809
33K
R1808
680
R1812
AF_3
IN
R1810
1.8K
51PF
R1811
470
A_D_DATA
U1115
3.3V
20K
OUT
9R_IF
U1111
MC14066B
9R_IF
C1814
0.1UF
C1816
R1817
1.2K
R1814
4.7K
AD7495
R1807
3K
R1813
1.5K
CONVST
C1819
0.01UF
RX
R9498
R1804
10
VSS
AMP #32
C9491
0.1UF
R1803
100K
ACTIVE_LPF
9R_IF
C1999
33UF
CONT.
C1818
0.1UF
AMP #31
C9422
10UF
U1111
MC14066B_PWR
VDD
IN
R1805
1K
9R_IF
C1806
0.1UF
C1811
0.01UF
VDD_SWITCH
C1813
1500PF
IF3_1
R1806
1K
C1809
0.1UF
9T_IF
C1998
33UF
CR1905
CR1904
MMBV3401
GND1
9R_IF
AF_AMP
DSM_OUTPUT_1.05MHZ
TX
MIX #3
VDD_IF
DSM_N
1 U1108
C1805
0.1UF
C1851
0.1UF
0.1UF
39_DIVIDER
REF_SPLITTER
Q1020
7002
VDD_IF
2.5 V REF
VDD_IF
VDD_IF
R1862
560
STEP_AGC_30_2
DUTYCYCLE EQUALYZER
C1856
U1109
U1109
74VHC14
74VHC14
11
C1854
0.1UF
U1113
74HC161
16
VCC
C1857
1000PF
0.01UF
10
U1114
74HC161
R1861
10K
C1853
0.1UF
15
RESET
RCO
LOAD
ENT
R1863
1K
R1864
1K
R1865
470
R1867
10K
L1806
22UH
U1109
74VHC14
R1866
100
ENP
CLK
14
13
12
11
C1859
0.01UF
C1860
0.1UF
C1861
0.01UF
16
VCC
C1858
1000PF
C1862
VDD_IF
Q0
P0
Q1
P1
Q2
P2
Q3
P3
15
RESET
RCO
LOAD
10
ENT
ENP
CLK
14
12
13
11
VDD_IF
Q0
P0
Q1
P1
Q2
P2
Q3
P3
0.01UF
U1109
10
GND
9R_IF
C1855
0.1UF
74v hc14
IF_16.8MHZ
R1868
1K
VDD_IF
GND
R1860
1K
`16.8_sqr
R1869
100
U1109
74vhc14
R1871
6.8K
R1872
6.8K
C1865
0.1UF
L1807
680NH
R1870
100
DSP_16.8Mhz
C1863
C1864
270PF
180PF
Figure A-1.N. LORD Module,
Schematic Circuit Diagram
(Sheet 14 of 15 – IF Circuits)
A-29/A-30
13
MM-E 2072-09333-00
9T/9R GENERATOR
VDD
C9537
0.1UF
9V
U6077
U6077
74VHC14
14
VCC
12
11
74VHC14
10
C1200
0.1UF
R9585
R9584
10K
GND
VDD
10K
9V
R1200
9V
9R
R1201
1K
VCO_SEL_FILTER
9T
100
74VHC14
470
470
14
12
100
74VHC14
R1202
R1203
470
470
Q1008
MC33074D
U1100
11
R1208
1K
R1207
Q1018
3904L
FILT_VCO2_SEL
R1211
R1212
470
470
MC33074D
U1100
C1202
0.1UF
FILT _VCO3_SEL
R1210
470
MC33074D
U1100
R1209
470
R1213
1K
Q1017
3904L
VDD
R1214
C1203
4.7UF
4.7K
R1215
51
PTT_IN
FILT _NOISE_CONTROL
C9538
C9539
100PF
C9540
EXCITER AMP. (FIRST SECTION)
C1205
0.1UF
CR1903
MMBD914T
100PF
R1206
3906L
U6077
R9547
9R
10
74VHC14
100
NOISE_CONTROL
R1205
U6077
R9546
VCO3_SEL
R1204
MC33074D
U1100
FILT_VCO1_SEL
U6077
R9545
VCO2_SEL
Q1009
3906L
74VHC14
100
VCO1_SEL
13
9T
U6077
R9544
C1201
0.1UF
9V
C9541
100PF
L1024
100PF
22UH
CR1003
MMBD914T
R1218
R1217
300
SPI FILTER
SW_A+_RF
100
11
9V
U1106
10
16
C1218
VOUT
ON_OFF
C1209
GND
VIN
ADJ
100NF
74VHC14
R9541
R1225
10K
C1214
33UF
15UF
C1215
0.1UF
D2A_OVEN_SEL
100
C1230
10K
Q4-OUT
13
R2-OUT
R1236
10K
SPI_CLK
R4-OUT
NC1
NC2
100
DOUT
100
C1206
0.1UF
R1251
10K
MC33074D
U1900
C1237
0.1UF
R1248
10K
C1208
R1224
10K
13
15
22UH
C1219
0.1UF
MC33074D
U1900
R1241
18
MS_2800
C1226
Q1004
C1227
24PF
20PF
MMBR951
R1239
1.2K
Q1005
C1228
0.1UF
R1242
470
100PF
R1228
432
C1223
0.1UF
R1240
18
C1225
24PF
C1238
C1222
0.1UF
R1238
2.7K
R1233
EX_AMP_OUT
432
L1214
22UH
MMBR951
C1229
24PF
U1105
74VHC14
R9543
FRAC_N_1_SEL
ADJ
TX
CR1001
L1015
270NH
L1014
270NH
L1013
270NH
TO_EXCITER
C1217
1000PF
C1220
0.1UF
R1237
51
OVEN_TEMP_CNTL2
EX_AMP_IN
VOUT
GND
VIN
L1034
22UH
MC33074D
U1900
U1107
TX
OVEN_TEMP_CNTL1
U1105
VDD
R1229
12
L1025
11
U1104
MC144111
FILT _LOW_RF_SEL
C1212
0.1UF
2.7K
14
100PF
TO_HIGH_POWER
C1213
0.1UF
C1221
100
R1230
2.7K
C1210
0.1UF
R1232
14
74VHC14
100
9R
12
LOW_RF_SEL
R1227
100
12
0.1UF
R1226
VSS
R1223
100
100PF
5V REGULATOR
Q1010
3906L
C1224
R9542
C1207
0.1UF
Q1012
3906L
9V
CLOCK
74VHC14
R9540
10K
Q3-OUT
11
R3-OUT
U1105
R1235
R1-OUT
10
Q2-OUT
ENABLE_
100PF
R1231
10K
R1234
DIN
C1204
0.1UF
R1221
300
10K
Q1-OUT
U1105
R1220
300
R1222
BIAS_OUT
R1247
VDD
C1211
MC33074D
U1900
0.1UF
10
100PF
R1243
10K
9V
C1216
74VHC14
R9539
SPI_DATA_OUT
ON_OFF
R1219
27
CR1004
MMBD914T
U1105
27
ALC & OCXO TEMP. D/A
9V REGULATOR
9V
300
R1216
R1253
3K
C1245
FILT_FRAC_N_1_SEL
C1233
R1255
1K
C1244
0.1UF
VR1500
5.6V
39PF
U1105
74VHC14
14
VCC
C1241
33UF
R1244
2.7
R1245
2.7
100
VDD
C1242
0.1UF
100PF
C1239
100NF
EX_AMP_LPF
R1246
100
13
12
FILT_SPI_CLK
L1056
270NH
R1254
GND
C1232
100PF
C1234
24PF
C1231
C1235
100PF
C1236
68PF
24PF
R1252
2.7K
51
PWR_LEVEL
C1240
0.1UF
Figure A-1.P. LORD Module,
Schematic Circuit Diagram
(Sheet 15 of 15 – Exciter and Regulators)
FILT_SPI_DATA
A-31/A-32
MM-E 2072-09333-00
J2
40330005401
DIPOLE
P3
1040696
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
+5_VCC_FIL
CPU
PA_INHIBIT
P4
TMP-J01X-A2
TP9
CH_CHANGE
TUNER_CUR_LIM
SW_BATT
+8VDC
+5_VCC_FIL
+5_VCC_FIL
+5_VCC_FIL
+10VDC
+10VDC
DC_TO_ANT_CPLR
9T
9T
+5_VCC_FIL
J1
40330005401
DC_TO_ANT_CPLR
WHIP
PA_OUT
RF_INPUT_TX
PA_INHIBIT
PA_INHIBIT
V_REV_TUNE
V_REV_PEP
RX_TO_LORD
BATT_CHECK
SPI_SEL_2_PA
SW_BATT
V_ALC
SPI_CLK_2_PA
CONTROL HEAD
SPI_DATA_2_PA
TEMP_1
TEMP_1
BIT
LAB
RX_TO_LORD
V_TEMP_PA
V_ALC
P2
TMP-J01X-A2
V_FWD_PEP
ALC_REF_DAC
WHIP
PA_OUT
PA_OUT
LAB
+8VDC
DIPOLE
RF_INPUT_TX
DC_PWR_EN
SW_BATT
9T
EXT_AMP_EN
BIT
V_FWD_PA_BYPASS
V_FWD_PA_BYPASS
V_REV_PA_BYPASS
V_REV_PA_BYPASS
V_REV_TUNE
SPI_SEL_2_PA
V_REV_TUNE
SPI_CLK_2_PA
SPI_DATA_2_PA
9T
V_FWD_RADIO
V_FWD_RADIO
BIT
V_REV_RADIO
V_REV_RADIO
LOW_BATT
V_REV_PA_BYPASS
INT_OSC_SET
HARMONIC_FILTER
DRIVER_POWER_AMPLIFIER
V_FWD_PA_BYPASS
SW_BATT
PA_REV
OCXO
SW_BATT
PA_FWD
+8VDC
R122
SW_BATT
C127
0.0
10U
LAB
LAB
9T
+5_VCC_FIL
+8VDC
9T
+5_VCC_FIL
EXT_AMP_EN
+5_VCC_FIL
EXT_AMP_EN
AUDIO AMP
EXT DC J5.11
+10VDC
V_ALC
V_ALC
V_REV_RADIO
TO REGULATOR U1106
V_FWD_RADIO
V_TEMP_PA
SPI_CLK_2_PA
SPI_DATA_2_PA
TEMP_1
9T
TP7
SPI_SEL_2_PA
V_TEMP_PA
TEMP_1
ALC_REF_DAC
V_FWD_PEP
V_REV_PEP
V_REV_RADIO
V_FWD_RADIO
ALC_REF_DAC
V_FWD_PEP
V_REV_PEP
PA_FWD
PA_REV
PA_FWD
PA_REV
+5_VCC_FIL
C145
C148
10U
100N
E2
8191
+10VDC
C146
C147
C150
C149
10U
10U
100N
100N
ALC
E1
8191
MC201
SCR_4_40
MC6
SCR_4_40
MC7
SCR_4_40
MC10
SCR_4_40
MC3
SCR_4_40
MC5
SCR_4_40
MC8
SCR_4_40
MC9
SCR_4_40
DC_SUPPLY
DC_PWR_IN
DC_PWR_IN
SW_BATT
+8VDC
+5_VCC_FIL
SW_BATT
+8VDC
+5_VCC_FIL
SW_BATT
C153
C154
C151
C152
4.7U
4.7U
100N
100N
DC_TO_ANT_CPLR
CH_CHANGE
INT_OSC_SET
CH_CHANGE
INT_OSC_SET
+10VDC
TUNER_CUR_LIM
LOW_BATT
BATT_CHECK
DC_TO_ANT_CPLR
+10VDC
TUNER_CUR_LIM
POWER SUPPLY SHIELD
LOW_BATT
BATT_CHECK
TP12
DC_PWR_EN
TP14
TP13
TP16
TP15
DC_PWR_EN
TP18
TP17
TP19
TP20
TP21
Figure A-2.A. HI POWER Module, Schematic Circuit Diagram (Sheet 1 of 6 – Module Interconnection Diagram)
A-39/A-40
MM-E 2072-09333-00
R30
CR10
MMBD914LT1
CW
R67
10K
L17
R44
412
R23
R29
C47
51.1
412
10N
C49
R40
68N
33.2
33.2
R43
33.2
100N
C41
R41
100N
33.2
Q3
RD16HHF1-101
T3
C48
2089-13023-00-0
PRE_DRIVER
L9
C144
330N
LAB
180P
LAB
10K
47P
LAB
C33
R34
100N
C860
T2
20721300600
R31
4.7
56P
R169
OPT
C854
C869
47U
100N
C30
C862
C861
1N
330P
330P
C25
10K
C52
DRIVER_BIAS
100N
R33
C51
51.1
412
10N
C59
C864
C29
C28
470P
470P
470P
T1
20721302600
100N
C873
15U
R21
L11
C853
C871
470P
100N
C36
C38
100N
10N
C37
1N
33.2
R24
SW_BATT
R26
33.2
412
R27
68N
33.2
PA_OUT
C852
R32
100N
C863
470P
2SC2879A
SW_BATT
R25
C865
330P
Q6
PWR_AMP_BIAS
CW
10K
470P
1 3
RD16HHF1-101
MMBD914LT1
R73
Q4
CR11
4.7
180P
LAB
C40
2SC2879A
1 3
R28
R35
LAB
Q11
C24
33.2
470P
C21
C14
100N
100N
C15
15U
E7
U11
E29
BLM31PG601SN1L
LP3961EMP-3.3
+10VDC
TP1
C55
R3
U6
10U
MIC5205BM5
VOUT
EN
GND
ADJ
DRIVER_BIAS
C94
100
R121
470P
C62
4.7U
C98
C96
100N
10N
TP5
+10VDC
10K
10N
Q12
100N
PWR_AMP_BIAS
10N
R131
VDD_PREAMP
C27
C20
100N
10N
C45
100N
C16
R130
2.2U
C26
C19
C2
100N
10N
2.2U
R78
24.9
R50
301
LAB
51.1K
C80
R132
R76
CR8
100N
R79
R80
301
301
R75
10K
R42
OPT
LAB
C31
C60
RD00HHS1
18.2
100N
R62
301
C56
R57
OPT
LAB
100N
R63
R13
301
51.1K
C43
R5
C34
100N
24.3
100N
PRE_DRIVER
R38
R45
301
301
LAB
LAB
HSMP3810
18.2
100N
56U
Q7
OPT
LAB
C76
VDD_PREAMP
C64
RD00HHS1
OPT
LAB
150
R97
V_ALC
C44
100N
Q5
HSMP3810
R98
56U
R55
301
R56
OPT
C81
CR9
E22
R153
L2
24.9
C136
TP8
L19
100N
1K
22.1
RF_INPUT_TX
R163
1.50K
R69
9T
R77
R164
1.50K
BST82
TP6
R129
C79
51.1K
C18
10N
LAB
R884
VDD_PREAMP
10N
CW
C895
1+
2-
C894
R829
C850
1.50K
0.0
10N
VR3
LM4040CEM3X-5.0
R883
R71
4.75K
TEMP_1
MMBT2222ALT1
R830
4.75K
R154
Q2
2.74K
10N
C137
Q8
SI7856DP
100
R823
C848
BIAS_EN
NT732BTTD102J3200K
R822
10K
9T
SW_BATT
RT1
R833
R819
MMBT4403LT3
RT2
NT732BLTD104J3800J
Q10
E27
BLM31PG601SN1L
47.5K
100N
24.3K
R22
Q19
C4
47U
E26
BLM31PG601SN1L
2.74K
BST82
C40, C24, C865, C863, C864, C29, C28
C17
100
71.5K
R72
FOLLOWING CAPACITORS SHOULD NOT BE ASSEMBLED:
R127
ERR
R2
R125
909K
GND
BIAS_EN
24.3K
BIAS_EN
VOUT
SD
LAB
R128
R11
VIN
10K
VIN
+5_VCC_FIL
R59
150
1K
C91
R46
1K
C89
100N
100N
E3
BLM31PG601SN1L
+10VDC
U1
LP2985AIM5-3.3
C1
10U
R1
VIN
VOUT
ON/OFF
GND
BP
100
10N
R167
C5
PA_INHIBIT
C3
4.7U
C6
10N
R4
3.32K
51.1K
Figure A-2.B. HI POWER Module, Schematic Circuit Diagram (Sheet 2 of 6 – Driver & Power Amplifier)
A-41/A-42
MM-E 2072-09333-00
DC_TO_ANT_CPLR
R36
0.0
K2
EB2-5-NU
RANGE1_OUT
RANGE1_OUT
1.6-2.429 MHz
C707
100N
C708
+5_VCC_RLY
10N
100N
+5_VCC_RLY
FLTR_2_DRIVE
RANGE2_IN
RANGE2_IN
RANGE2_OUT
RANGE2_OUT
K302
10
+5_VCC_RLY
FLTR_3_DRIVE
10
10P
C74
10P
+5_VCC_RLY
CR810
FLTR_2_DRIVE
HSMS2800
K301
EB2-5-NU
RANGE3_IN
RANGE3_IN
EB2-5-NU
3.7-5.59 MHz
RANGE3_OUT
10
RANGE3_OUT
K402
EB2-5-NU
K401
EB2-5-NU
10N
10
C23
PA_OUT
100N
+5_VCC_RLY
10
+5_VCC_RLY
FLTR_4_DRIVE
5.6-8.49 MHz
RANGE4_IN
RANGE4_IN
RANGE4_OUT
K502
100P
TX/RX_DRIVE
CR805
9T
1.21K
TX
BITE
R837
BIT
Q801
1.21K
C851
R835
10N
51.1K
RANGE5_IN
RANGE5_IN
RANGE5_OUT
RANGE5_OUT
K602
EB2-5-NU
K601
EB2-5-NU
1N
10P
1+
2-
VR803
LM4040CEM3X-5.0
FLTR_3_DRIVE
C72
C66
10P
10P
C77
R81
10P
24.9
+5_VCC_RLY
FLTR_4_DRIVE
R85
C75
R82
10P
24.9
V_REV_RADIO
CR6
CR7
HSMS2800
HSMS2800
R83
C87
1N
R92
1.21K
C82
C84
180P
47P
R86
24.9
V_REV_PA_BYPASS
0.0
R87
24.9
C78
C83
180P
47P
C88
R90
1N
51.1K
+5_VCC_RLY
R89
FLTR_5_DRIVE
51.1K
BST82
MMBD6100LT1
R836
+5_VCC_RLY
FLTR_5_DRIVE
C903
1.21K
10
C906
+5_VCC_RLY
EB2-5-NU
8.5-12.99 MHz
V_REV_TUNE
10K
K501
EB2-5-NU
10
10
RANGE4_OUT
R923
C902
C22
K1
EB2-5-NU
E19
C905
RX_TO_LORD
C65
EB2-5-NU
2.43-3.69 MHz
DIPOLE
CG2470LSTR
FLTR_1_DRIVE
K201
K202
EB2-5-NU
10
WHIP
RANGE1_IN
1 +5_VCC_RLY
10
RANGE1_IN
10
SEL_ANT_DRIVER
FLTR_1_DRIVE
LAB
T4
20721300700
+5_VCC_RLY
K101
EB2-5-NU
10
K102
EB2-5-NU
10
+5_VCC_RLY
FLTR_6_DRIVE
10
+5_VCC_RLY
FLTR_7_DRIVE
13.0-19.79 MHz
RANGE6_IN
RANGE6_IN
RANGE6_OUT
RANGE6_OUT
K702
K701
EB2-5-NU
EB2-5-NU
19.8-30.0 MHz
RANGE7_IN
RANGE7_IN
RANGE7_OUT
RANGE7_OUT
10
FLTR_6_DRIVE
10
FLTR_7_DRIVE
V_FWD_RADIO
R91
+5_VCC_RLY
V_FWD_PA_BYPASS
0.0
+5_VCC_RLY
FILTERS
+8VDC
C32
R842
18.2K
CR806
C875
U4
R844
74HC595D
24.3K
VCC
Q0
SPI_SEL_2_PA
SPI_CLK_2_PA
SPI_DATA_2_PA
13
12
10
11
14
FLTR_7_SET
1K
MMBD914LT1
U3
+5_VCC_FIL
R848
47U
Q1
OE
Q2
STCP
Q3
MR
Q4
SHCP
Q5
DS
Q6
Q7
GND
Q7S
16
15
FLTR_4_SET
FLTR_5_SET
100N
FLTR_1_SET
R840
R839
R841
R843
R845
R846
R849
FLTR_3_SET
FLTR_1_SET
FLTR_6_SET
FLTR_2_SET
24.3
24.3
FLTR_2_SET
FLTR_3_SET
24.3
FLTR_4_SET
24.3
ULQ2003LTR
I1
O1
I2
O2
I3
O3
I4
O4
I5
O5
I6
O6
I7
GND
O7
DCOM
16
15
14
13
12
11
10
FLTR_5_DRIVE
FLTR_1_DRIVE
FLTR_3_DRIVE
FLTR_6_DRIVE
FLTR_2_DRIVE
+5_VCC_RLY
C856
FLTR_5_SET
24.3
FLTR_7_DRIVE
FLTR_4_DRIVE
100N
FLTR_6_SET
FLTR_7_SET
24.3
E23
PAD_DRILLXX
24.3
C872
C858
1N
1N
C868
C870
C866
C855
C867
1N
1N
1N
1N
1N
Q805
SEL_ANT
24.3
C886
R865
1N
100K
SEL_ANT_DRIVER
BST82
R850
E24
PAD_DRILLXX
E6
BLM31PG601SN1L
+5_VCC_FIL
+5_VCC_RLY
Figure A-2.C. HI POWER Module, Schematic Circuit Diagram (Sheet 3 of 6 – Harmonic Filter, Part I)
A-43/A-44
MM-E 2072-09333-00
FILTER#1 1.6-2.43 MHZ
T=18
3.5 UH
DRILL 0.85 MM
TP4
TP24
FILTER#5 8.5-13.0 MHZ
T=16
2.8 UH
TP25
T=7
TP39
L101
20721302314
20721302313
5.20U
3.39U
C103
C107
TP42
20721302305
0.71U
0.55U
C502
RANGE1_IN
C501
RANGE5_IN
RANGE1_OUT
240P
T=6
TP41
L501
20721302306
L102
TP40
L502
TP26
RANGE5_OUT
180P
56P
470P
C101
150P
C503
C112
C113
C114
C104
C108
C102
C110
C111
C109
C105
C106
470P
470P
470P
68P
LAB
470P
470P
470P
470P
470P
470P
470P
150P
C115
180P
FILTER#2 2.43-3.7 MHZ
TP27
TP28
T=14
L202
TP30
T=13
T=6
TP44
150P
0.55U
0.55U
C603
C601
30P
82P
270P
C212
C211
C210
C202
C207
C208
470P
330P
47P
LAB
470P
470P
470P
C209
68P
C205
C204
330P
330P
C604
C606
C602
C605
150P
270P
22P
56P
FILTER#3 3.7-5.6 MHZ
T=12
TP32
FILTER#7 19.8-30.0 MHZ
TP33
L302
T=10
T=4
TP47
TP34
1.90U
1.35U
C303
C301
100P
330P
C306
C305
470P
330P
C701
RANGE7_OUT
56P
C704
C702
C706
C705
82P
100P
82P
100P
LAB
NOT ASSEMBLED: C104, C210,C705
T=8
TP37
TP38
E603
L401
20721302308
20721302307
1.12U
0.88U
C403
C401
82P
220P
E501
RANGE4_OUT
E301
C407
C404
220P
C402
390P
E602
E604
E601
E704
E702
E302
E304
RANGE4_IN
100P
0.28U
FILTER#4 5.6-8.5 MHZ
20721302301
18P
C302
C703
470P
TP50
RANGE7_IN
RANGE3_OUT
C304
L402
T=4
0.28U
470P
TP36
TP49
L701
20721302301
20721302309
TP48
L702
L301
20721302310
T=9
RANGE6_OUT
C206
RANGE2_OUT
TP35
20721302303
RANGE6_IN
RANGE2_IN
RANGE3_IN
L601
20721302305
C201
180P
TP46
L602
2.20U
C203
TP45
20721302311
C504
100P
T=5
TP43
L201
2.60U
TP31
C506
180P
FILTER#6 13.0-19.8 MHZ
TP29
20721302312
C505
180P
C406
C405
200P
200P
E703
E503
E303
E701
E502
E403
E404
E504
E401
E202
E102
E204
E104
E203
E103
E201
E101
E402
Figure A-2.D. HI POWER Module, Schematic Circuit Diagram (Sheet 4 of 6 – Harmonic Filter, Part II)
A-45/A-46
MM-E 2072-09333-00
E18
+8VDC
+8VDC
R924
R925
1K
1K
V_REV_PEP
VR802
LM4040CEM3X-5.0
LAB
C896
1+
2-
R905
100N
R68
0.0
VEE
INH
16
14
V_REV_PEP
100N
LMC6482AIMX
C90
R88
R93
1K
+8VDC
LAB
R94
9T
R916
LM2900DR
C119
R61
36.5K
C86
+8VDC
R914
R913
R58
100N
150K
100K
3.32K
CR1
R867
51.1K
V_FWD_RADIO
R64
15
LM2900DR
U5
LMC6482AIMX
MC14053BD
V+
9T
V-
R901
MMBT4403LT3
1K
LAB
R52
9T
LAB
VR801
LM4040CEM3X-5.0
LAB
LAB
560P
LAB
1+
2-
LAB
+8VDC
R876
100
R879
LMC6482AIMX
10K
LAB
100N
C61
LAB
R920
R74
CR4
MMBD914LT1
3.32K
LTC1966IMS8
U15
LAB
LAB
VCC
IN2
OUT-RTN
EN
VOUT
GND
VSS
R880
10K
LAB
1K
LAB
R919
R108
IN1
CR5
E14
100N
LAB
R898
C68
C69
100N
LAB
1N
LAB
10K
R926
C884
OPT
LMC6482AIMX
10K
LAB
R878
R873
LAB
R899 LAB
R870
4.7U
R869
LAB
R885
8.25K
R881
12
+8VDC
R173
R895
R894
+8VDC
21.5K
R172
MMBD914LT1
LAB
10
R909
LM2903D
10K
10N
LAB
10K
U9
C898
11
R171
150K
R892
14
27.4K
REF_PEP_RMS
9.76K
CR808
U13
LM2900DR
R887
475
475
SPARE
100N
MMBT2222ALT1
51.1K
C897
Q806
R871
V_TEMP_PA
U12
E16
LMC6482AIMX
R886
8.25K
10K
U10
51.1K
2.74K
27.4K
R862
C120
LAB
R868
RT3
NT732BLTD104J3800J
0.0
LAB
+8VDC
LAB
100K
MC14053BD
R928
0.0
R109
OPT
R147
16
22N
LAB
10K
LAB
R863
R908
53.6K
LAB
C890
10K
1M
5.62K
21.5K
LAB
R877
R126
R907
LM2903D
R874
10K
LAB
100
U9
ALC_REF
R917
E10
U8
LAB
+8VDC
100N
1K
LAB
LAB
MMBD914LT1
U8
LMC6482AIMX
LAB
LAB
R897
2.21K
C891 LAB
+5_VCC_FIL
5.62K
U7
100N
R896
ALC_REF_DAC
10K
R893
REF_PEP_RMS
100
LAB
C904
R875
100N
+8VDC
U15
LMC6482AIMX
E11
+8VDC
E20
E21
100
C889
R921
C92
10U
LAB
C117
V_FWD_PEP
1K
10K
V_FWD_PEP
R866
LAB
LAB
OPT
CR2
MMBT4403LT3
R84
MMBD914LT1
82.5K
150
24.3
Q18
R918
182
C85
220U
LAB
LAB
R902
R107
R54
LAB
LAB
OPT
R95
51.1
LAB
R99
10K
R882
47.5K
2.2U
475K
U12
ALC_REF
LMC6482AIMX
C58
R51
R96
Q25
82.5K
14
56.2K
U5
R903
1K
R888
U13
V_ALC
100K
100N
MA4CS101E
CR809
MMBT2222ALT1
CR809
Q23
+8VDC
R910
E12
MA4CS101E
100N
10
0.0
C57
C67
R53
E13
MMBT2222ALT1
LM2900DR
0.0
100
R60
Q22
182
U13
R105
1K
+8VDC
R906
MMBD914LT1
R922
13
10K
+8VDC
14
PA_FWD
LAB
470P
LAB
R70
10N
U13
100N
150
Q807
MMBT2222ALT1
C901
10K
10K
C887
R106
LAB
+8VDC
2.2U
475K
24.3
Q24
MMBT4403LT3
EXT_AMP_EN
100K
2.74K
R912
11
R911
R915
U14
GND
470P
CR811
MA4CS101E
C156
LMC6482AIMX
14
PA_REV
VCC
CR811
E15
12
13
U14
MA4CS101E
U12
MC14053BD
V_REV_RADIO
100
C900
TEMP_1
475K
R904
3.32K
15K
Figure A-2.E. HI POWER Module, Schematic Circuit Diagram (Sheet 5 of 6 – ALC Circuits)
A-47/A-48
MM-E 2072-09333-00
Q14
Q26
IRFS3004-7PPBF
SW_BATT
+8VDC
C173
Q20
SW_BATT
MMBT4403LT3
909K
51.1K
IN+
SNS
GAITE
C165
51.1K
OUT
100N
AOUT
Q21
R161
R170
BST82
100K
100K
C157
100N
TMR
FB
EN
10
GND
FLT
R160
10K
LAB
11
R178
R116
SW_BATT
PWM_EN
BATT_CHECK
LMC6482AIMX
100N
24.3K
VR4
LM4040CEM3X-5.0
SW_BATT_PS
C73
C129
INTVCC_5V
22U
EXT5V
R113
CR19
MBR140SFT1
100K
LAB
R112
C142
R118
15K
10N
15K
33P
SYNC
5 PLLFLTR
6 PLLIN
C54
LAB
VIN
BG1
EXTVCC
ITH1
INTVCC
9 SGND
C35
VOSENSE_5V
12
-SENSE_5V
13
+SENSE_5V
14
C42
BG2
BOOST2
V0SENSE2
SW2
SENSE2-
TG2
RUN/SS2
SENSE2+
10UH
Q13
24
23
SI9945DY-TR
R9
CR20
MBR140SFT1
22
100N
19
SW_BATT_PS
10
100K
GND
SYNC
R7
0.0
LAB
C116
C99
100N
10N
150K
R12
L3
+5.5VDC
0.02
R818
CR15
MBR140SFT1
R124
U2
MIC29152BU
R156
10UH
C9
LAB
C160
100U
C123
C140
10U
4.7U
VIN
VOUT
EN
GND
ADJ
10K
-SENSE_5V
+5_VCC_FIL
R20
31.6K
C7
1N
+SENSE_5V
51.1K
LAB
0.0
T7
22U
R19
0.0
C95
4.7U
C118
OPT
LAB
470P
R18
MOD
R146
R117
110K
OUT1
OUT2
R151
8.25K
V+
470P
SET
180P
R102
20.0K
SI9945DY-TR
R10
C97
+8VDC
R104
R158
Q1
ADJ
C71
51.1K
U17
LTC6908IS6-1
LAB
VOSENSE_5V
R133
GND
R6
LAB
VOUT
EN
Q1
LAB
2.2M
LAB
VIN
27.4K
100N
LAB
0.0
10U
SW_BATT_PS
SI9945DY-TR
R152
21.5K
MIC5205BM5
C93
C39
475K
100N
R166
U16
SW_BATT_PS
C133
R168
470P
10U
C143
47U
-SENSE_10V
+10VDC
LAB
R17
C126
C174
R179
51.1K
OPT
LAB
150K
4.7U
100U
R115
1N
Q9
ADJ
GND
C131
E31
C172
+10VDC
C159
R165
10K
E28
BLM31PG601SN1L
100N
LAB
C121
1N
C139
10U
EN
15
LAB
CR16
MBR140SFT1
51.1K
3.3V_OUT
R141
51.1K
C124
VOUT
VIN
16
33P
MMBT4403LT3
LAB
+SENSE_10V
LAB
LAB
INT_OSC_SET
R136
100N
17
R175
C161
18
+10.5VDC
C8
R148
20
0.02
C163
21
C168
1N
33P
25
MIC29152BU
22U
R157
PWM_EN
C10
R119
PGND
10 3.3VOUT
11 ITH2
3.3V_OUT
33P
LAB
15K
SW1
BOOST1
V0SENSE1
7 FCB
1N
33P
SENSE1-
T6
L1
51.1K
TP11
SHORTING_PAD
26
U21
R144
R8
27
15K
10N
VOSENSE_10V
28
C141
TG1
C11
R123
PGOOD
SENSE1+
-SENSE_10V
LAB
0.0
20.0K
0.0
RUN/SS1
+SENSE_10V
R159
R15
LTC1628IG-SYNC
R14
215K
21.5K
U20
1N
R155
VOSENSE_10V
4.75K
R150
Q13
SI9945DY-TR
PWM_EN
C63
R111
2.2U
4.7U
C166
- 2
180P
4.7U
C171
C167
100N
C135
+1
C70
C158
4.7U
21.5K
LAB
C100
22U
1K
U10
C122
R138
R142
R891
100K
SW_BATT
LAB
3.3V_OUT
R137
0.0
10K
LAB
100K
51.1K
INTVCC_5V
R174
OPT
LAB
SW_BATT
R140
INTVCC_5V
1N
R890
LOW_BATT
10N
LAB
100N
5.11K
100
C125
100
C888
R120
R37
LAB
LAB
SHDN
12
R143
22U
C155
VCC
DC_PWR_EN
LAB
+5_VCC_FIL
LT4356IDE-1
82.5K
C164
U23
750K
CR17
MBR140SFT1
CR18
MBR140SFT1
R872
T5
100N
R162
R134
51.1K
R114
100P
10
R135
0.0
R176
10
R177
R139
15U
R149
VR2
C138
15U
CR14
MURS160T3
C128
15U
MMBT2222ALT1
100N
LNBTVS6-221S
INT_OSC_SET
C134
C162
R65
10K
C169
100N
Q16
CR13
MBRS360T3
IRFS3004-7PPBF
DRAIN
DC_PWR_IN
C846
C13
47U
10N
10K
0.0
LAB
Q15
SI7483DP
SW_BATT
C53
10K
R39
L14
L18
L20
0.2
33UH
33UH
33UH
C46
R47
100N
100N
C878
C877
C882
15U
100N
100N
R145
VC C
R16
0.0
GND
C50
10N
E9
R855
21.5K
C880
51.1K
4.7U
R857
R861
Q803
R101
TUNER_CUR_LIM
MMBT2222ALT1
R49
R100
R860
10K
BST82
U19
NC7SZ08P5X
CH_CHANGE
+5_VCC_FIL
86.6
Q17
100N
LATCH
10K
100N
R852
R48
+5_VCC_FIL
C130
U22
MMBT4403LT3
C132
51.1K
C12
Q802
+5_VCC_FIL
DC_TO_ANT_CPLR
10K
1K
R110
100N
+5_VCC_FIL
R103
10K
51.1K
R66
LAB
C170
100N
LAB
14
VCC
SD1
D1
CP1
Q1
Q1
100N
LATCH
CD1
10
C885
10K
10K
74VHC74MTCX
SD2
12
D2
Q2
11
CP2
Q2
CD2
13
GND
10K
Figure A-2.F. HI POWER Module, Schematic Circuit Diagram (Sheet 6 of 6 – Power Supply)
A-49/A-50
MM-E 2072-09333-00
J3
FH28-40S-0.5SH(05)
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
V0_LCD
CPU
MZ_CPU
C1
2.2U
V1
C2
2.2U
V2
C3
2.2U
V3
V4
C4
2.2U
C5
2.2U
R213
0.0
R214
0.0
C10
C6P
R12
2.2U
C11
2.2U
C12
2.2U
C1P
C7
2.2U
C8
2.2U
C9
2.2U
V0_LCD
XCS_N_LCD
RST_N_LCD
RST_N_LCD
V0_LCD
RD_N_CPU
WR_N_CPU
WR_N_CPU
CPU_D[7:0]
VDD_LCD_3V0
68P
IF3
IF2
IF1
10K
R3
XCS_N_LCD
10K
KEY_Y[4:0]
R6
0.0
80P
R10
OPTION
SCL_CPU
R11
OPTION
MOSI_CPU
ON_OFF_SW
SDF_SW_DET
RST_N_LCD
10K
OPTION
RD_N_CPU
CPU_D7
CPU_D6
OPTION
PTT_MIC_N
0.0
R7
R8
R5
R9
RX_UART0_TTL
RX_UART0_TTL
RX_UART1_TTL
C501
1N
0.0
DASH ONLY
CPU_D2
221
R502
RADIO_RX_UART0_TTL
CPU_D4
CPU_D3
KEY_X[4:0]
KB_BL_EN
KB_BL_EN
KEY_Y[4:0]
LCD_BL_EN
LCD_BL_LEVEL
LCD_BL_EN
LCD_BL_LEVEL
LCD_HEAT_EN
LCD_HEAT_EN
ON_OFF_SW
LCD_HEAT_LEVEL
LCD_HEAT_LEVEL
POW_OFF_CPU
POW_OFF_CPU
VR501
MMSZ5227BT1G
TAD_CODAN_MODE
3V6
CPU_D1
3V3
CPU_D0
PTT_MIC_P
PTT_MIC_P_CPU
PTT_MIC_P_CPU
PTT_MIC_N
RX_UART0_TTL
TX_UART0_TTL
TX_UART0_TTL
RX_UART1_TTL
TX_UART1_TTL
TX_UART1_TTL
XIL_MONITOR
XIL_MONITOR
SH_DN_232_N
SH_DN_232_N
UART1
TAD_CODAN_MODE
PTP_TXD
PTP_TXD
TX_UART1_TTL
RX_UART1_TTL
RX_UART1_TTL
SH_DN_232_N
3V3
5V0
3V3
5V0
ASSEMBLED FOR TRUNK ONLY
A0_CPU
0.0
C6
VDD_LCD_3V0
2.2U
P4
SM02B-SRSS
<=LCD
P2
53261-0290
VLED_BL_LCD
CATODE(BLACK)
VHEAT_LCD
ANODE(RED)
P501
43045-1618
SPKR_P
INTERFACE
SPKR_M
MZ_IF
SPKR_M
SPKR_P
OPTION
P3
DASH_CONNECTOR
LAB
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
R503
1K
LAB
104549-3
LAB
R504
1K
KEY_Y[4:0]
DASH ONLY
MOSI_CPU
TRUNK ONLY
SCL_CPU
R505
VLED_BL_KB
10K
SPEAKER
XCS_N_SDF
MISO_CPU
MOSI_CPU
SDF_SW_DET
SCL_CPU
MISO_CPU
SDF_SW_DET
PTP_TXD
3V3
PTP_RXD
TX_AUDIO_P
RX_AUDIO_P
CH_RXD_M
CH_TXD_P
XCS_N_SDF
SPKR1_2_P
CH_RXD_P
KEY_Y[4:0]
CH_TXD_M
P1
53261-0290
OPTION
PTT_M
KEY_X[4:0]
PTT_P
KEY_X[4:0]
C506
3V3
100N
TX_AUDIO_M
R601
VLED_BL_KB
ON_OFF_CONT
10K
3V3
13V8_RADIO_TRUNK
TAD_CODAN_MODE
10
11
12
13
14
15
16
NOT ASSEMBLED IN DASH MODE
R215
42
NOT ASSEMBLED IN TRUNK MODE
CH_TXD_P
CH_TXD_P
PTP_RXD
SH_DN_232_N
CH_TXD_M
CH_TXD_M
TX_UART0_TTL
PTP_RXD
TRUNK_RX_UART0_TTL
TRUNK_RX_UART0_TTL
CH_RXD_P
TX_UART1_TTL
UART0
PTT_P
PTT_P
CH_RXD_M
TX_UART0_TTL
PTT_M
PTT_M
PTT_MIC_P
CH_RXD_M
XCS_N_SDF
XCS_N_SDF
SDF_SW_DET
3V3
WR_N_CPU
RS_INTERFACE_BLK
RS_INTERFACE
CH_RXD_P
R501
TRUNK_RX_UART0_TTL
CPU_D5
VLED_HEAT_EN
VLED_HEAT_EN
KEY_X[4:0]
OPTION
R1
A0_CPU
RD_N_CPU
CPU_D[7:0]
R4
C5P
XCS_N_LCD
A0_CPU
C1N
C7P
SCL_CPU
MOSI_CPU
2.2U
C2N
C3P
SCL_CPU
MOSI_CPU
MISO_CPU
1M
C13
VLCD_INOUT
C2P
C4P
MISO_CPU
VDD_LCD_3V0
FOR TAD/COD MODES RESOLVING
MIC_IN
13V8_RADIO_TRUNK
5V0_RADIO
POWER_SUPPLY
R582
CH_TXD+
POW_SUPPLY
RADIO_RX_UART0_TTL
5V0
0.0
CH_RXD+
R229
R13
10
R14
10
POW_OFF_CPU
4.75K
ON_OFF_CONT
POW_OFF_CPU
ON_OFF_SW
5V0
TX_UART0_TTL
R16
R180
PTT_MIC_POS
PTP_TXD
R181
PTP_RXD
C21
4.75K
0.0
LAB
13V8_RADIO_TRUNK
5V0_RADIO
PTT_MIC_P
5V0
5V0_RADIO
3V3
1N
VDD_LCD_3V0
ON_OFF_CONT
C34
1N
LAB
R2
10
4.7U
L5
13V8_DC
L7
PTP_RXD
C33
RX_AUDIO_P
C505
180P
C504
180P
1N
13V8_DC
8V0_AUDIO
TO CHECK
0.0
13V8_RADIO_TRUNK
PTT_MIC_P_CPU
3V3
VLED_HEAT_EN
VLED_HEAT_EN
KB_BL_EN
KB_BL_EN
LCD_BL_EN
LCD_BL_LEVEL
LCD_BL_EN
LCD_BL_LEVEL
LCD_HEAT_EN
LCD_HEAT_LEVEL
LCD_HEAT_EN
LCD_HEAT_LEVEL
PTT_MIC_N
PTT_MIC_N
VLED_BL_KB
VLED_BL_LCD
VHEAT_LCD
ON_OFF_CONT
ON_OFF_SW
13V8_DC
8V0_AUDIO
5V0
3V3
TABLE 1
VDD_LCD_3V0
MODE
VLED_BL_KB
P/N
PART LIST
DASH
2072-95211-00
20729521100 PL
TRUNK
2072-95211-10
20729521110 PL
VLED_BL_LCD
VHEAT_LCD
4.7U
PTP_TXD
P6
43090-0003
MIC_IN
L6
TXD
4.7U
C502
180P
L3
C503
180P
MIC_AUDIO
4.7U
C39
1N
C36
1N
RXD
L4
ASSY DASH 2072-95211-00 PL
4.7U
C35
1N
ASSY TRUNK 2072-95211-10 PL
PLACE TO THE SILK SCREEN
PTT_MIC_N
AUDIO
AUDIO_BIOS_BLK
4.7U
L1
AUDIO_OUT
TXD = TO PC
PTT_MIC_P
R15
PTT_MIC
RXD =FROM PC
XIL_MONITOR
PTT_MIC_P
4.75K
C44
100N
C42
4.7U
50V
MIC_IN
MIC_IN
L2
TX_AUDIO_P
TX_AUDIO_P
TX_AUDIO_M
TX_AUDIO_M
4.7U
C43
1N
8V0_AUDIO
8V0_AUDIO
ASSEMBLED FOR TRUNK ONLY
Figure A-3.A. CONTROL HEAD Module, Schematic Circuit Diagram (Sheet 1 of 6 – Module Interconnection Diagram)
A-51/A-52
MM-E 2072-09333-00
SCL_CPU
MISO_CPU
MOSI_CPU
XCS_N_LCD
RST_N_LCD
A0_CPU
RD_N_CPU
V0_LCD
WR_N_CPU
CPU_D[7:0]
E26
BLM18PG600SN1
VLED_HEAT_EN
3V3
3V3_CPU
KB_BL_EN
KEY_X[4:0]
C26
C14
LCD_BL_EN
LCD_BL_LEVEL
KEY_Y[4:0]
100N
10U
25V
C27
4.7U
50V
LCD_HEAT_EN
LCD_HEAT_LEVEL
SDF_SW_DET
XCS_N_SDF
E502
BLM18PG600SN1
3V3
3V3_CPU_AN
PTT_MIC_P_CPU
C553
C552
10U
100N
25V
RX_UART0_TTL
TX_UART0_TTL
RX_UART1_TTL
TX_UART1_TTL
3V3
XIL_MONITOR
3V3_CPU_AN
C15
4.7U
C45
TP501
50V
3V3_CPU
POW_OFF_CPU
C22
100N
C23
C24
100N
100N
C16
4.7U
R532
C555
100N
100N
22.1
C554
C545
4.7U
100N
0.0
0.0625
LAB
C544
50V
0.0
0.0625
3V3_CPU
R506
ACTIVE LOW
50V
R531
50V
SH_DN_232_N
TAD_CODAN_MODE
4.7U
3V3_CPU_AN
100N
ON_OFF_SW
C551
E3
TX_UART1_TTL
R33
22.1
RX_UART1_TTL
R32
22.1
R31
22.1
R30
22.1
R29
22.1
R28
22.1
REMAINS FROM INT0_N
KEY_X0
A0_CPU
RST_N_LCD
KEY_X3
R48
22.1
KEY_X4
R49
22.1
KEY_Y0
R50
22.1
KEY_Y1
R51
22.1
KEY_Y2
R52
22.1
KEY_Y3
R53
22.1
KEY_Y4
R54
22.1
3V3_CPU
TSW-102-23-S-S
100K
TDO_CPU
MR_N
R116
1K
C46
100N
16V
C47
1U
10V
C19
C20
33P
Y1
7.3728MHZ
22.1
22.1
R114
22.1
R222
22.1
R223
22.1
3V3_CPU
10K
10K
10K
10K
R111
R112
R113
R118
10K
10K
R104
10K
10K
R103
VREF2
VREFD
12
16
17
15
VREF
VREF0
AV+1
A12/P5.4
AIN2.5/A13/P1.5
C8051F126-GQ
A13/P5.5
AIN2.6/A14/P1.6
A14/P5.6
AIN2.7/A15/P1.7
A15/P5.7
A8M/A0/P2.0
A8M/A0/P6.0
A9M/A1/P2.1
A9M/A1/P6.1
A10M/A2/P2.2
A10M/A2/P6.2
A11M/A3/P2.3
A11M/A3/P6.3
A12M/A4/P2.4
A12M/A4/P6.4
A13M/A5/P2.5
A13M/A5/P6.5
A14M/A6/P2.6
A14M/A6/P6.6
A15M/A7/P2.7
A15M/A7/P6.7
TMS
AD0/D0/P7.0
TCK
AD1/D1/P7.1
TDI
AD2/D2/P7.2
TDO
AD3/D3/P7.3
RST
AD4/D4/P7.4
CP1-
AD5/D5/P7.5
CP1+
AD6/D6/P7.6
CP0-
AD7/D7/P7.7
CP0+
DAC0
XTAL1
DAC1
XTAL2
MONEN
22.1
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
100
99
CPU_D7
LCD_HEAT_EN
R58
22.1
R56
22.1
SDF_SW_DET
R59
22.1
KB_BL_EN
R55
22.1
LCD_BL_EN
R60
22.1
LCD_BL_LEVEL
R61
22.1
LCD_HEAT_LEVEL
R62
22.1
R68
22.1
R67
22.1
VLED_HEAT_EN
R69
22.1
R66
22.1
R70
22.1
R65
22.1
R64
22.1
R63
22.1
ACTIVE HIGH
ACTIVE HIGH = F(T,LED_ON)
ACTIVE HIGH
ACTIVE HIGH
ACTIVE HIGH
ACTIVE HIGH
XIL_MONITOR
TAD_CODAN_MODE
E8
E11
E10
E9
E7
E5
SH_DN_232_N
R80
22.1
R79
22.1
R78
22.1
R77
22.1
R76
22.1
E33
ON_OFF_SW
R75
22.1
POW_OFF_CPU
R74
22.1
PTT_MIC_N
R73
22.1
PTT_MIC_P_CPU
R71
22.1
R72
22.1
33P
R115
R117
U1
R57
RESET_CPU
22.1
A11/P5.3
AIN2.4/A12/P1.4
88
87
86
85
84
83
82
81
ACTIVE LOW
3V3_CPU
E32
E36
3V3_CPU
P5
TSW-105-23-S-D
E35
R17
TDI_CPU
AIN2.3/A11/P1.3
CPU_D6
22.1
P7
R18
26
27
28
A10/P5.2
22.1
R90
TCK_CPU
A9/P5.1
AIN2.2/A10/P1.2
CPU_D5
R89
TMS_CPU
46
45
44
43
42
41
40
39
AIN2.1/A9/P1.1
22.1
22.1
A8/P5.0
CPU_D4
R88
R47
AIN2.0/A8/P1.0
22.1
KEY_Y[4:0]
KEY_X2
AD7/D7/P3.7
CPU_D3
R35
KEY_X[4:0]
22.1
~WR/P0.7
CPU_D2
22.1
22.1
R26
AD6/D6/P3.6
22.1
R34
R27
KEY_X1
XCS_N_LCD
36
35
34
33
32
31
30
29
~RD/P0.6
R24
CPU_D[7:0]
10K
WR_N_CPU
22.1
AD5/D5/P3.5
CPU_D1
10K
22.1
R21
ALE/P0.5
CPU_D0
22.1
R119
R22
AD4/D4/P3.4
22.1
R20
10K
RD_N_CPU
P0.4
R19
R121
22.1
AD3/D3/P3.3
54
53
52
51
50
49
48
47
R120
R23
XCS_N_SDF
P0.3
10K
22.1
AD2/D2/P3.2
10K
R46
AD1/D1/P3.1
P0.2
R99
MOSI_CPU
P0.1
R100
22.1
10K
22.1
R45
10K
R44
MISO_CPU
R97
SCL_CPU
AD0/D0/P3.0
R98
22.1
P0.0
10K
R43
~WR/P4.7
AIN0.7
10K
RX_UART0_TTL
62
61
60
59
58
57
56
55
~RD/P4.6
R96
22.1
ALE/P4.5
AIN0.6
10K
22.1
R42
AIN0.5
R95
R40
P4.4
AIN0.4
10K
22.1
P4.3
R94
22.1
R41
P4.2
AIN0.3
3V3_CPU
98
97
96
95
94
93
92
91
R93
R38
AIN0.2
AGND2
22.1
P4.1
E1
ACTIVE HIGH
R81
0.0
TCK_CPU
R86
0.0
TMS_CPU
R85
0.0
TDO_CPU
R84
0.0
TDI_CPU
R83
0.0
R82
0.0
E2
C32
100N
10
3V3
GND
TCK
TMS
TDO
TDI
CPU_JTAG
10
13
E17
R39
P4.0
AIN0.1
AGND1
22.1
AIN0.0
DGND3
E16
E23
R36
18
19
20
21
22
23
24
25
38
63
89
10K
E14
R110
C121
10K
10K
22.1
TX_UART0_TTL
10K
R108
R109
221K
E15
E22
22.1
R92
V0_LCD_DIV
E21
R212
100N
1M
R107
E25
R37
R91
DGND2
TERM_M
0.0
V0_LCD
10K
10K
R106
R105
E24
AV+2
TERMISTOR
3V3_CPU
R102
1N
VDD3
37
64
90
C550
232261513103
R584
VDD1
RT1
DGND1
100N
VDD2
E4
C25
12.1K
11
14
R25
R101
3V3_CPU_AN
R87
10K
Figure A-3.B. CONTROL HEAD Module, Schematic Circuit Diagram (Sheet 2 of 6 – Microcontroller)
A-53/A-54
MM-E 2072-09333-00
3V3_IF
KEYPAD
20K
12345
PAD6 !!!
SW4
PAD_SW_KEY6
SW5
PAD_SW_KEY6
R583
67890
PAD6
SW10
PAD_SW_KEY6
3+
1-
R569
VR510
3+
1-
R139
SW13
PAD_SW_KEY6
SW14
PAD_SW_KEY6
SW15
PAD_SW_KEY6
R233
R563
SW20
PAD_SW_KEY5
DS1
150
ENTER
PAD6
ARRDN
PAD3
SW25
PAD_SW_KEY2
150
DS4
KPT-1608CGCK-RY
KPT-1608CGCK-RY
DS11
KPT-1608CGCK-RY
DS10
DS13
DS12
VLED_BL_KB
14V7
R128
150
DS14
150
KPT-1608CGCK-RY
DS21
KPT-1608CGCK-RY
KPT-1608CGCK-RY
KPT-1608CGCK-RY
DS23
KPT-1608CGCK-RY
DS22
DS19
DS18
DS20
DS17
KPT-1608CGCK-RY
DS16
KPT-1608CGCK-RY
KPT-1608CGCK-RY
DS15
KPT-1608CGCK-RY
KPT-1608CGCK-RY
R127
KEY_X4
KPT-1608CGCK-RY
DS9
DS7
DS6
KPT-1608CGCK-RY
3+
1-
R529
KPT-1608CGCK-RY
KPT-1608CGCK-RY
DS5
KPT-1608CGCK-RY
KPT-1608CGCK-RY
DS25
DS24
VOL_UP
PAD2
VOL_DN
PAD2
R125
R124
R123
R122
150
150
150
150
VR505
VR506
3+
1-
VR503
VR504
MMBZ5229BLT1
MMBZ5229BLT1
VR502
MMBZ5229BLT1
MMBZ5229BLT1
3+
1-
3+
1-
VR507
MMBZ5229BLT1
3+
1-
MMBZ5229BLT1
3+
1-
3+
1-
KEY_Y3
R126
SW24
PAD_SW_KEY2
C65
KPT-1608CGCK-RY
DS3
1.10K
SW23
PAD_SW_KEY6
100P
R142
MMBZ5229BLT1
20K
KEY_Y4
KEY_Y1
ARRUP
PAD3
SW22
PAD_SW_KEY3
KEY_Y2
SW21
PAD_SW_KEY3
KPT-1608CGCK-RY
KPT-1608CGCK-RY
DS8
KEY_X3
R141
MORE
PAD5
KPT-1608CGCK-RY
DS2
VR508
3V3_IF
KPT-1608CGCK-RY
R533
1.10K
C64
SW19
PAD_SW_KEY4
3+
1-
100P
KEY_Y0
F1 F2 F3 F4
PAD4
SW18
PAD_SW_KEY4
VR509
20K
SW17
PAD_SW_KEY4
KPT-1608CGCK-RY
MMBZ5229BLT1
3V3_IF
R140
SW16
PAD_SW_KEY4
41.2
KEY_X2
1.10K
C63
SW12
PAD_SW_KEY6
100P
SW11
PAD_SW_KEY6
KEY_X1
MMBZ5229BLT1
3V3_IF
20K
M P * GPS #
PAD6
50V
25V
1.10K
C62
SW9
PAD_SW_KEY6
100P
SW8
PAD_SW_KEY6
10U
C54
4.7U
C60
100N
C59
100N
C53
VR511
20K
SW7
PAD_SW_KEY6
KEY_X0
MMBZ5229BLT1
3V3_IF
R138
SW6
PAD_SW_KEY6
3V3_IF
3V3
1.10K
C61
SW3
PAD_SW_KEY6
100P
SW2
PAD_SW_KEY6
SW1
PAD_SW_KEY6
E19
BLM18PG600SN1
KEY_X[4:0]
R137
4V3
KEY_Y[4:0]
3V3_IF
R144
51.1K
R146
51.1K
R145
51.1K
R143
51.1K
R148
OPTION
3V3_IF
J4
DM3A-SF-PEJ
XCS_N_SDF
BLM18BB750SN1D
MOSI_CPU
BLM18BB750SN1D
SCL_CPU
BLM18BB750SN1D
MISO_CPU
BLM18BB750SN1D
E29
E20
E27
E28
DAT2
CD/DAT3
CMD
VDD
CLK
VSS
DAT0
DAT1
10
11
GND9
12
GND10
13
GND1
14
GND2
15
GND5
16
GND6
3V3_IF
GND7
GND8
R133
10K
SDF_SW_DET
R147
OPTION
C69
22P
C68
C66
C67
22P
22P
22P
Figure A-3.C. CONTROL HEAD Module, Schematic Circuit Diagram (Sheet 3 of 6 – Keypad)
A-55/A-56
MM-E 2072-09333-00
3V3
ON_OFF_CONT
13V8_DC
3V3
VLED_BL_LCD
KB_BL_EN
KB_BL_LEVEL
VHEAT_LCD
PTT_MIC_N
PTT_MIC_P
14
U502
R166
ON_OFF_SW
TO CPU
10
SW26
2+1
5+4
2+3
5+6
L501
13V8_DC
R540
10U
TRUNK ONLY
MHPS2266
VLED_BL_KB
LCD_HEAT_EN
LCD_HEAT_LEVEL
74HC132D
10K
C509
100N
R539
POW_OFF_CPU
8V0_AUDIO
33.2
ON_OFF_SW
POW_OFF_CPU
25V
Q507
1K
BST82
U501
LM2940SX-5.0
51.1
TRUNK ONLY
R537
C98
C97
C99
15U
4.7U
15U
50V
25V
50V
25V
C511
1U
DS26
5V0
R151
100
5V0
DS27
R538
40.2
VIN
KPT-1608CGCK-RY
C512
22U
35V
U5
LP3985IM5X-3.0
VOUT
GND
OUT
GND
3V3
EN
C81
KPT-1608CGCK-RY
5V0_INT
IN
GND
100V
LP3985IM5-3.3
NEW LEDS
33UH
C85
51.1
1W
13V8_DC
4.7U
25V
ACTIVE GND
U4
L8
13V8_RADIO_TRUNK
C508
100N
R514
8V0_AUDIO
C507
10U
16V
R603
5V0
OUT
GND
C510
15U
13V8_DC
5V0_RADIO
IN
20
.5W
ON_OFF_CONT
MC78M08BDTRK
LCD_BL_EN
LCD_BL_LEVEL
U3
R528
CR501
MMSD4148T1
VDD_LCD_3V0
13V8_RADIO_TRUNK
RBP
C86
100N
100N
50V
C80
1U
100V
R170
33.2
C88
100N
VIN
GND
VDD_LCD_3V0
VOUT
EN
C87
100N
RBP
C89
100N
50V
5V0_RADIO
R535
0.0
5V0_INT
R534
0.0
5V0
Q503
T1
MMBT4403LT3
22U
C90
R197
100P
31.6K
R196
R155
R160
0.1
0.0
511
100
BST82
R518
Q502
R520
LCD_BL_LEVEL
100
BST82
R523
10K
10K
R178
U6_FB
Q504
MMBT4403LT3
3.01K
R152
14V7
0.0
R521
VLED_BL_KB
10K
30.1K
BST82
ACTIVE HIGH
511
Q505
R508
10K
511
R194
R525
100
50V
R507
VLED_HEAT_EN
0.1
C93
100N
10K
ACTVIVE HIGH
R195
100N
R602
R512
4.7U
50V
C95
10K
35V
LCD_BL_EN
4.12K
4V3
R187
C71
R193
MMBT2222ALT1
FB
Q2
C79
47U
35V
VLED_BL_LCD
86.6
R519
CR2
MBRS360T3
50V
SI4450DY-TR
5.1
Q4
-1
AGND
R156
+3
ISEN
PGND
4.75K
10K
DR
SD
R186
COMP
VIN
100N
R198
C83
47U
50V
4.7U
22P
C72
4.7U
C70
LM3488MM
C91
C96
VR2
MMBZ5229BLT1
U6
R541
C84
15U
25V
C73
4.7U
50V
C513
100N
14V7
13V8_DC
Q7
R513
R509
KB_BL_EN
ACTIVE HIGH
100
Q506
R522
33.2
R202
33.2
1K
BST82
10K
R201
14V7
14V7_CONT2
VHEAT_LCD_FOR
Q1
IRFR9220
R515
0.0
U7
LM2903D
2.67K
U3
74HC132D
R527
10K
0.125
3.01K
Q3
LCD_HEAT_LEVEL
'1'=>9V0
'0'=>6V3
R517
100
R524
10K
G ND
U3
74HC132D
R159
475
R536
8.25K
R220
10
R221
10
10
14
U7
LM2903D
BST82
PTT_MIC_P
5.11K
R167
Q501
0.125
LAB
4V3
MMBT2222ALT1
100N
14
VCC
R226
10
14
0.125
3+
1-
PTT_MIC_N
MMBZ5229BLT1
ACTVIVE LOW
C78
ACTVIVE HIGH
R516
3V3
50V
VR1
14V7_CONT3
R526
10K
50V
VHEAT_LCD
33.2
1W
C76
4.7U
R581
3V3
11
4.75K
220P
100N
R177
12
13
C94
C92
1.10K
1 G
C74
4.7U
R207
1U
0.125
R158
R206
C82
3.01K
4D
0.125
33.2
1W
0.125
100V
R157
R204
LCD_HEAT_EN
R530
33.2
5.11K
R203
5.11K
14V7
TP3
U3
74HC132D
Figure A-3.D. CONTROL HEAD Module, Schematic Circuit Diagram (Sheet 4 of 6 – Power Supply Circuits)
A-57/A-58
MM-E 2072-09333-00
R552
MIC_IN
20K
TX_AUDIO_P
4 11
TX_AUDIO_M
10
R551
R553
20K
20K
8V0_AUDIO
U503
MC33174DR2
330P
C520
R547
R560
470N
4.75K
C517
4 11
C524
MIC_IN
10K
10K
R546
U503
MC33174DR2
1N
R557
C526
274
4.7U
10V
8V0_AUDIO
L503
TX_AUDIO_P
4.7U
C515
R543
1K
C516
1N
1N
C528
R548
100N
R545
13
12
14
11
R554
C529
20K
100N
16V
C523
10U
10K
AUDIO_BIOS
R544
AUDIO_BIOS
U503
MC33174DR2
U503
MC33174DR2
10K
R558
C525
274
4.7U
10V
R559
2.74K
L502
TX_AUDIO_M
4.7U
R542
1K
C514
1N
C518
1N
8V0_AUDIO
25V
R549
10K
R556
C527
100N
C522
10U
25V
Q508
MMBT2222ALT1
20K
4 11
R555
10K
C519
33U
562
R550
C521
10K
10U
10V
25V
Figure A-3.E. CONTROL HEAD Module, Schematic Circuit Diagram (Sheet 5 of 6 – Audio Amplifier, Trunk Mount Version Only)
A-59/A-60
MM-E 2072-09333-00
5V0_RS
PTT_M
PTT_MIC_P
3V3_UART
E601
BLM18PG600SN1
E501
BLM18PG600SN1
5V0
3V3
PTT_P
CH_RXD_M
C602
100N
C601
10U
TRUNK_RX_UART0_TTL
CH_RXD_P
C530
10U
25V
C543
100N
25V
CH_TXD_M
TX_UART0_TTL
CH_TXD_P
5V0
3V3
TX_UART1_TTL
RXD
(PTP_RXD)
RX_UART1_TTL
TXD
(PTP_TXD)
SH_DN_232_N
ACTIVE LOW
OPSTATUS
5V0_RS
R579
TX_UART0_TTL
10
L505
5V0_RS
U505
C557
100N
LTC485IS8
DI
VCC
RO
DE
RE
GND
R567
1K
F_OFF_N
EN_N
T_OUT
R_OUT
SHDN
FORCEON
HIGH_Z
ACTIVE
NORMAL (AUTOSHDN)
ACTIVE
ACTIVE
YES
AUTOSHDN
HIGH_Z
HIGH_Z
NO
CH_TXD_M
4.7U
R561
C539
1K
180P
C540
180P
3V3_UART
L504
CH_TXD_P
4.7U
CH_TXD_P_INT
C542
C541
180P
U507
180P
C548
C531
180P
R565
1K
L509
CH_RXD_P
4.7U
C534
180P
C546
U504
4.7U
C532
180P
100N
C558
L506
100N
LTC485IS8
DI
VCC
DE
RO
RE
GND
R578
C556
100N
MAX3224EEAP
5V0_RS
CH_RXD_M
VALID
TRUNK_RX_UART0_TTL
10
R572
10
TX_UART0_TTL
R577
10
PTP_RXD
R573
10
CH_RXD_P_INT
R574
10
1K
C533
180P
100N
TX_UART1_TTL
R562
13
12
16
18
C1+
VCC
C1-
V+
C2+
V-
C2-
INVALID
T1I
T1O
T2I
T2O
R1I
R1O
R2I
R2O
RDY
FORCEON
GND
FORCEOFF
19
11
17
15
10
14
20
C549
C547
10
R570
PTP_TXD
10
R575
CH_TXD_P_INT
10
R571
RX_UART1_TTL
10
R576
TRUNK_RX_UART0_TTL
3V3_UART
R568
10
CH_RXD_P_INT
100N
100N
10K
R604
SH_DN_232_N
ACTIVE LOW
5V0_RS
PTT_MIC_P
R570-573-OPTION FOR TRUNK/CDN/UART1-UART0 MODE
R580
10
5V0_RS
C559
100N
LTC485IS8
VCC
L508
R564
1K
U506
DI
RO
DE
RE
GND
PTT_P
4.7U
R566
1K
C535
180P
C536
180P
L507
PTT_M
4.7U
C538
180P
C537
180P
Figure A-3.F. CONTROL HEAD Module, Schematic Circuit Diagram (Sheet 6 of 6 – Interface Circuits, Trunk Mount Version Only)
A-61/A-62
P2
43045-1618
5V0
C26
180P
PTT_M
PTT_P
C27
180P
CH_RXD_P
CH_RXD_M
L5
PTT_M
CH_TXD_M
DI
4.7U
CH_TXD_P
C28
180P
100N
LTC485IS8
R5
1K
10K
L11
U5
4.7U
SPKR_M
R13
C35
L6
PTT_P
SPKR_P
10
11
12
13
14
15
16
VCC
DE
RO
RE
GND
PTP_TXD
22U
R25
C16
1N
PTT_MIC_POS
10
C17
1N
PTP_TXD_PNL
PTP_RXD_PNL
C29
180P
R12
PTP_TXD_PNL
10K
L10
PTP_RXD_PNL
PTP_RXD
22U
TX_AUDIO_P
C14
1N
TX_AUDIO_M
ON_OFF_CONT_PNL
SPKR_M
R30
13V8_RADIO_TRUNK
0.0
C6
1N
OPSTATUS
PANEL_TO_FROM
SPKR_P
R29
C15
1N
INT_SPKR1_2_M
0.125
0.0
SPKR1_2_P
0.125
FORCEON
F_OFF_N
EN_N
T_OUT
R_OUT
VALID
SHDN
HIGH_Z
ACTIVE
NORMAL (AUTOSHDN)
ACTIVE
ACTIVE
YES
AUTOSHDN
HIGH_Z
HIGH_Z
NO
5V0
R24
5V0
L4
CH_RXD_M
U4
C23
180P
R4
1K
L3
4.7U
C24
180P
U6
LTC485IS8
DI
VCC
DE
RO
RE
GND
C34
C41
100N
100N
C43
RADIO_RX_UART0_TTL
R36 LAB
CH_TXD_P_INT
R37
470N
10
10
LAB
1K
C25
180P
R32
LAB
11
14
C1+
VCC
C1-
V+
C2+
V-
C2-
INVALID
T1I
T1O
R1I
R1O
EN
FORCEON
GN D
100N
C40
LAB
MAX3221EEUE+
5V0
4.7U
C22
180P
CH_RXD_P
RADIO_RX_UART0_TTL
10
FORCEOFF
15
10
13
12
16
C44
10
470N
C45
470N
LAB
10
R34
CH_RXD_P_INT
R35
LAB
R33
LAB
TX_UART0_TTL
5V0
10K
LAB
CH_RXD_P_INT
ONLY ASSEMBLED IN CDN MODE
5V0
C33
L2
U3
4.7U
C18
180P
C19
180P
R6
1K
L1
CH_TXD_P
4.7U
C20
180P
100N
LTC485IS8
DI
VCC
DE
RO
RE
GND
R23
TX_UART0_TTL
P1
10
104549-3
C21
180P
SPKR1_2_P
CH_TXD_P_INT
RADIO ONLY
R9
C1
TX_AUDIO_M
390N
0.125
C7
10K
C9
1N
R15
20K
R22
43.2K
562
C2
390N
56.2K
MIC_IN
C8
1N
R10
RX_AUDIO_P
1N
R17
L7
22U
R1
TX_AUDIO_P
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
INT_SPKR1_2_M
C3
390N
10K
R16
U1
261
5V0
20K
C4
390N
C10
1N
390N
13V8_DC_RADIO
MIC_IN
R18
MC33072ADR2
R20
C11
1N
R2
RADIO_RX_UART0_TTL
CH_TXD+
TX_UART0_TTL
CH_RXD+
20K
L8
22U
C5
100K
PTT_MIC_POS
AUDIO_BIAS_T
PTP_TXD
PTP_RXD
ON_OFF_CONT
13V8_RADIO_TRUNK
C39
1N
13V8_DC_RADIO
C38
100N
L9
22U
R14
10K
ON_OFF_CONT
R27
562
1/2W
R7
61.9
OUT
IN
FDBCK
5VTAP
SENS
ERR
STDN
GND
1U
100V
13V8_RADIO_TRUNK
AUDIO_BIAS_T
Q1
D45H8
C36
100N
C37
100N
U2
LP2951CMX
10K
R11
ON_OFF_CONT_PNL
C31
10U
25V
RADIO_DASH_TO_FROM
C42
R3
R19
15.4K
1%
20K
RADIO_DASH_TO_FROM
CH_TXD_M
PANEL_TO_FROM
NOT ASSEMBLED IN DASH MODE
MM-E 2072-09333-00
R8
10K
R21
C32
10N
C30
10U
U1
MC33072ADR2
R26
2.67K
25V
1.82K
1W
1%
0.125W
Figure A-4. INTERCONNECTION Module, Schematic Circuit Diagram
A-69/A-64
MM-E 2072-09333-00
SW_FAN
12VDC
Q2
MJD2955T4
12VDC
U1
LP2951CMX
470P
C7
R7
1K
R1
110
L1
CW
R2
56.2K
J1
CD729S31D4
R6
475
C10
C6
10N
2.2U
22U
C4
1N
C3
1N
IN
OUT
FDBCK
SENS 5VTAP
STDN
ERR
GND
SPKR-
MMBT3904LT1
10K
DSO/FAN_ON_OFF
C2
1N
C8
IN_FROM_RADIO
C9
10N
Q1
L2
22U
1N
R3
R4
511
511
C5
C1
1N
2.2U
SPKR+
R5
OUT_FROM_RADIO
J2
J3
CD7225S31D4
CD7225S31D4
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
PTT_IN_CW
12VDC
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
Figure A-5. FAN CONTROL Module, Schematic Circuit Diagram
A-65/A-66
MM-E 2072-09333-00
Appendix B
PARTS LISTS
Section I. MICOM-Z DASH-MOUNT VERSION
Table B-1. Micom-Z Assembly Dash Version, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-90715-00
MICOM-Z ASSEMBLY, DASH
Figure B-1
BL1
2072-95170-10
HI POWER MODULE
1.0
BL2
2072-90833-00
FRONT PANEL DASH ASSY
1.0
BL3
2072-90832-00
LORD ASSY
1.0
BL5
4053-10013-16
WASHER, SPRING, CRS, PASSIVATED, #10
1.0
BL6
4053-00037-16
WASHER, FLAT, CRS, PASSIVATED, .219
2.0
BL7
4051-00011-16
NUT, HEX, CRS, PASSIVATED, #10-32
1.0
BL8
2089-41660-00
KNOB
1.0
BL10
4053-10012-15
WASHER, SPRING, CRS, BLACK, #8
8.0
BL12
4053-16001-00
SPRING LOCK WASHERS, M3
11.0
BL13
2072-45002-10
REAR PANEL
1.0
BL16
2072-09296-00
CABLE COAX, LORD-H.P PA
2.0
BL17
2072-09295-00
CABLE, FLAT, LORD-H.P PA
1.0
BL18
2072-90160-00
CABLE, FLAT, TO CHASSIS
1.0
BL19
2072-90890-00
GPS ANTENNA TRANSITION
1.0
BL20
2072-34007-00
CABLE, FLAT, STRIP GPS
1.0
BL21
2072-90900-00
GPS CARD
1.0
BL22
4052-12019-88
SCREW, PH PHIL CRES, M 3X
9.0
BL23
2072-45011-00
BOX, MICOM-Z
1.0
BL24
4053-15002-00
WASHER, FLAT
9.0
BL25
2201-63202-03
HEATSINK COMPOUND, DC340
.200
BL26
2072-45041-00
LOCK PAD
2.0
BL27
4052-15003-00
SCREW, CROSS RECESSED, PAN HEAD
2.0
BL28
2072-90838-00
CONNECTOR ASSY, POWER
1.0
BL30
2072-45032-00
SCREW, M4X10, HEXAGON
8.0
BL31
2072-56022-00
SPACER FOR CONNECTOR SUB-D
4.0
BL32
4052-30011-16
SCREW, #10-32X3/4
1.0
BL33
2072-45042-00
PLUG COVER, D-TYPE, 9 PIN
1.0
BL34
2072-45031-00
SCREW, M3X4, FH, BLACK
8.0
BL35
2072-45013-00
COVER
1.0
BL37
2072-72707-00
PACKAGE BOX, DASH
1.0
B-1
MM-E 2072-09333-00
Figure B-1.A. Micom-Z Assembly Dash Version (Sheet 1 of 2)
B-2
MM-E 2072-09333-00
Figure B-1.B. Micom-Z Assembly, Dash Version (Sheet 2 of 2)
B-3
MM-E 2072-09333-00
Table B-2. LORD Assembly, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-90832-00
LORD ASSEMBLY
BL1
2072-95196-10
LORD MODULE
1.0
BL2
2072-48195-10
LORD PAD MACHINING
1.0
BL3
2072-48165-10
SHIELD HOUSING MACHINING
1.0
BL4
2072-90050-00
BATTERY ASSY, 0102703K64
1.0
BL5
4053-16001-00
WASHER, SPRING LOCK, M3
3.0
BL6
4052-15003-00
SCREW, CROSS RECESSED, PAN HEAD
3.0
BL7
2072-52004-00
SCREW, M3XP0.5X16
6.0
BL8
2072-40160-00
LOWER CONTACTS, 3904382P
1.0
BL9
2072-40150-00
UPPER CONTACTS, 3904381P
1.0
BL12
2072-48060-00
BATTERY HOLDER, LORD, MI
1.0
BL14
2072-45031-00
SCREW, M3X4, FH BLACK
4.0
BL15
2072-45018-00
HOLDER RIGHT, MICOM-Z
1.0
BL16
2072-45017-00
HOLDER LEFT, MICOM-Z
1.0
Figure B-2. LORD Assembly
B-4
Figure B-2
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-95196-10
LORD MODULE
Figure B-3
BL1
2072-32200-50
PCB LORD
1.0
BL2
2072-41030-00
SPACER
2.0
BL3
4053-10010-16
WASHER, SPRING, CRS, PASSIVATED, #4
2.0
C1
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C2
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C3
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C4
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C8
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C10
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C11
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C12
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C13
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C14
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C15
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C16
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C17
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C18
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C19
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C20
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C21
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C22
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C23
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C24
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C25
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C26
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C27
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C28
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C29
2072-17032-00
CAPACITOR, CHIP, X7R, 3.3NF
1.0
C30
2072-17032-00
CAPACITOR, CHIP, X7R, 3.3NF
1.0
C31
4017-20267-00
CAPACITOR, CHIP, X7R, 4.7NF, 10%
1.0
C34
2072-17025-00
CAPACITOR, CHIP, X7R, 2.7NF
1.0
C36
2072-17025-00
CAPACITOR, CHIP, X7R, 2.7NF
1.0
C37
2072-17031-00
CAPACITOR, CHIP, X7R, 1.8NF
1.0
C38
2072-17031-00
CAPACITOR, CHIP, X7R, 1.8NF
1.0
C39
2072-17031-00
CAPACITOR, CHIP, X7R, 1.8NF
1.0
C40
2072-17031-00
CAPACITOR, CHIP, X7R, 1.8NF
1.0
B-5
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C41
2072-17031-00
CAPACITOR, CHIP, X7R, 1.8NF
1.0
C42
4017-20261-00
CAPACITOR, 0603, X7R, 1.5N, 50V
1.0
C43
4017-20261-00
CAPACITOR, 0603, X7R, 1.5N, 50V
1.0
C44
2072-17030-00
CAPACITOR, CHIP, X7R, 1.2NF
1.0
C45
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C46
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C47
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C48
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C49
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C50
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C51
2072-17028-00
CAPACITOR, CHIP, X7R, 620PF
1.0
C52
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C54
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C56
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C58
2072-17026-00
CAPACITOR, CHIP, X7R, 6.8NF
1.0
C60
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C61
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C62
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C65
4017-25274-00
CAPACITOR, 0603, NP0 180P 50V
1.0
C66
4017-25269-00
CAPACITOR, 0603, NP0 68P, 50V
1.0
C67
4017-25269-00
CAPACITOR, 0603, NP0 68P, 50V
1.0
C72
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C77
2072-17056-00
CAPACITOR, CHIP, CL1, +/-30, 120P
1.0
C78
2072-17056-00
CAPACITOR, CHIP, CL1, +/-30, 120P
1.0
C79
4017-25081-00
CAPACITOR, CHIP, CERAMIC, C0G, 680PF
1.0
C80
4017-25075-00
CAPACITOR, CHIP, CERAMIC, C0G, 220PF
1.0
C81
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C82
2072-17025-00
CAPACITOR, CHIP, X7R, 2.7NF
1.0
C83
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C84
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C85
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C86
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C87
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C88
4017-25062-00
CAPACITOR, CHIP, CERAMIC, C0G, 18PF
1.0
C89
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C90
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C91
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C92
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C93
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C94
2072-17030-00
CAPACITOR, CHIP, X7R, 1.2NF
1.0
B-6
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C95
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C96
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C97
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C98
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C99
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C100
2072-17032-00
CAPACITOR, CHIP, X7R, 3.3NF
1.0
C101
2072-17025-00
CAPACITOR, CHIP, X7R, 2.7NF
1.0
C102
2072-17025-00
CAPACITOR, CHIP, X7R, 2.7NF
1.0
C103
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C104
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C105
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C106
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C107
2072-17009-00
CAPACITOR, CHIP, 1206, 390PF, 5%
1.0
C108
2072-17009-00
CAPACITOR, CHIP, 1206, 390PF, 5%
1.0
C109
2072-17056-00
CAPACITOR, CHIP, CL1, +/-30, 120P
1.0
C110
4017-25075-00
CAPACITOR, CHIP, CERAMIC, C0G, 220PF
1.0
C111
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C112
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C129
2072-17032-00
CAPACITOR, CHIP, X7R, 3.3NF
1.0
C130
2072-17032-00
CAPACITOR, CHIP, X7R, 3.3NF
1.0
C160
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C172
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C179
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C200
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C300
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1000
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1001
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1002
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1003
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1004
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1005
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1006
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1007
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1008
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1009
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1010
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1011
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1012
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1013
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1014
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-7
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C1015
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1016
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1017
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1018
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1019
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1020
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1021
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1022
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1023
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1024
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1025
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1026
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1027
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1028
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1029
4017-25063-00
CAPACITOR, CHIP, CERAMIC, C0G, 22PF
1.0
C1030
4017-60219-00
CAPACITOR
1.0
C1031
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1034
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1035
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C1036
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1037
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1038
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1039
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C1040
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1041
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1042
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1043
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1044
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1045
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C1046
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1047
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C1048
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1049
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1050
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1051
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1052
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1053
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1054
2187-17001-00
CAPACITOR, CHIP, 27PF, 5%
1.0
C1055
4017-25063-00
CAPACITOR, CHIP, CERAMIC, C0G, 22PF
1.0
C1058
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-8
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C1059
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1060
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1061
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1062
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1063
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1064
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1065
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1066
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1067
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1068
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1069
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1070
2072-17017-00
CAPACITOR, CHIP, 0603, 11PF
1.0
C1071
2072-17017-00
CAPACITOR, CHIP, 0603, 11PF
1.0
C1072
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C1073
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1074
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1075
2072-17056-00
CAPACITOR, CHIP, CL1, +/-30, 120P
1.0
C1076
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C1077
4017-20171-00
CAPACITOR, CHIP, CERAMIC, 10NF, 100V
1.0
C1078
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1079
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1080
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C1081
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1082
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1083
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1084
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1160
4017-25252-00
CAPACITOR, CHIP, 2.7PF, 50V
1.0
C1161
4017-25252-00
CAPACITOR, CHIP, 2.7PF, 50V
1.0
C1162
4017-25252-00
CAPACITOR, CHIP, 2.7PF, 50V
1.0
C1163
4017-25252-00
CAPACITOR, CHIP, 2.7PF, 50V
1.0
C1200
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1201
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1202
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1203
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C1204
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1205
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1206,
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1207
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1208
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1209
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
B-9
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C1210
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1211
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C1212
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1213
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1214
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1215
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1216
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1217
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C1218
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1219
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1220
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1221
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1222
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1223
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1224
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1225
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1226
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C1227
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1228
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1229
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1230
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1231
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1232
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1233
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C1234
2072-17019-00
CAPACITOR, CHIP, 0603, 24PF
1.0
C1235
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1236
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C1237
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1238
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1239
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C1240
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1241
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1242
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1244
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1245
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C1800
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1801
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1802
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1803
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1804
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-10
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C1805
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1806
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1807
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1808
4017-25293-10
CAPACITOR, CHIP, NP0, 1800PF, 1%
1.0
C1809
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1810
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1811
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1812
4017-20267-00
CAPACITOR, CHIP, X7R, 4.7NF, 10%
1.0
C1813
4017-20261-00
CAPACITOR, 0603, X7R, 1.5N, 50V
1.0
C1814
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1815
4017-25075-00
CAPACITOR, CHIP, CERAMIC, C0G, 220PF
1.0
C1816
4017-25285-00
CAPACITOR, CHIP, 0603, NP0, 51PF
1.0
C1817
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1818
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1819
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1820
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1821
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1822
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C1823
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1824
4017-25293-10
CAPACITOR, CHIP, NP0, 1800PF, 1%
1.0
C1825
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1826
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1827
4017-20263-00
CAPACITOR, CHIP, X7R, 2.2NF, 10%
1.0
C1828
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1829
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1830
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1831
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1832
4017-25075-00
CAPACITOR, CHIP, CERAMIC, C0G, 220PF
1.0
C1833
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1834
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C1835
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C1836
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1837
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1838
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1839
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1840
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1841
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1842
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1843
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1844
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-11
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C1845
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1846
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1847
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1848
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1851
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1852
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C1853
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1854
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1855
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1856
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1857
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C1858
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C1859
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1860
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1861
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1862
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1863
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C1864
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C1865
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1890
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C1956
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C1997
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1998
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C1999
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C2000
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2002
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C2003
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C2004
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C2006
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C2007
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C2008
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C2009
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C2010
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C2013
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C2014
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C2015
2072-17021-00
CAPACITOR, CHIP, 0603, 75PF
1.0
C2016
2072-17021-00
CAPACITOR, CHIP, 0603, 75PF
1.0
C2017
2072-17021-00
CAPACITOR, CHIP, 0603, 75PF
1.0
C2018
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C2019
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
B-12
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C2020
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C2021
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C2024
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C2025
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C2030
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2031
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2032
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2035
4017-25260-00
CAPACITOR, 0603, NP0, 12 PF, 50V
1.0
C2036
2072-17015-00
CAPACITOR, CHIP, 0603, 4.3PF
1.0
C2037
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C2038
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C2039
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C2040
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C2041
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C2042
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C2043
4017-25285-00
CAPACITOR, CHIP, 0603, NP0, 51PF
1.0
C2044
4017-25285-00
CAPACITOR, CHIP, 0603, NP0, 51PF
1.0
C2045
2072-17017-00
CAPACITOR, CHIP, 0603, 11PF
1.0
C2046
2072-17017-00
CAPACITOR, CHIP, 0603, 11PF
1.0
C2047
2072-17016-00
CAPACITOR, CHIP, 0603, 7.5PF
1.0
C2048
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C2049
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C2050
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C2051
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C2052
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C2053
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C2054
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C2055
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C2056
4017-25261-00
CAPACITOR, 0603, NP0, 15P 50V
1.0
C2057
4017-25261-00
CAPACITOR, 0603, NP0, 15P 50V
1.0
C2061
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2062
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2063
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2064
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2067
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2070
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C2071
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2072
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2073
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2074
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-13
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C2075
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2076
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2077
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2078
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2079
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2080
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2081
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2083
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2084
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2085
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2086
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2087
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2088
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2089
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2090
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2091
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2092
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2093
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2094
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2095
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2096
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2097
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2098
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2099
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2100
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2101
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2102
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2103
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2104
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2105
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2106
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2107
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2108
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2109
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2110
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2111
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2112
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2114
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2116
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2117
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-14
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C2118
4017-20261-00
CAPACITOR, 0603, X7R, 1.5N, 50V
1.0
C2120
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C2121
4017-20266-00
CAPACITOR, CHIP, X7R, 3.9NF, 50V
1.0
C2123
2072-17017-00
CAPACITOR, CHIP, 0603, 11PF
1.0
C2124
4017-25256-00
CAPACITOR, CHIP, 5.6PF, 100V
1.0
C2125
4017-25256-00
CAPACITOR, CHIP, 5.6PF, 100V
1.0
C2133
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C2134
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C2136
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C2137
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C2138
4017-25062-00
CAPACITOR, CHIP, CERAMIC, C0G, 18PF
1.0
C2139
4017-25062-00
CAPACITOR, CHIP, CERAMIC, C0G, 18PF
1.0
C2140
4017-25061-00
CAPACITOR, CHIP, CERAMIC, C0G, 15PF
1.0
C2141
4017-25061-00
CAPACITOR, CHIP, CERAMIC, C0G, 15PF
1.0
C2142
4017-20266-00
CAPACITOR, CHIP, X7R, 3.9NF, 50V
1.0
C2146
4017-20269-00
CAPACITOR, 0603, X7R, 6.8NF, 50V
1.0
C2222
2072-17012-00
CAPACITOR, CHIP, 0805 20PF, 5%
1.0
C2900
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3000
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3002
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3003
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3005
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3006
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3007
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3008
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3010
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3011
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3012
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3013
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3014
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3015
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3016
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3017
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3019
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C3021
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C3023
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C3024
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C3025
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C3026
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3027
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
B-15
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C3028
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3029
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3031
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3033
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3034
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3035
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3036
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3037
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3038
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3040
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C3041
4017-25269-00
CAPACITOR, 0603, NP0, 68P, 50V
1.0
C3042
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C3043
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C3044
4017-25066-00
CAPACITOR, CHIP, CERAMIC, C0G, 39PF
1.0
C3045
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C3046
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C3047
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C3048
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C3075
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C3110
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3111
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3112
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C3500
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C3900
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C4000
4017-20276-00
CAPACITOR, CHIP, X7R, 33NF, 25V
1.0
C4002
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C4004
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4007
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4008
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4009
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4010
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4011
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4012
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4013
2072-17032-00
CAPACITOR, CHIP, X7R, 3.3NF
1.0
C4014
4017-25278-00
CAPACITOR, 0603, NP0, 390P 50V
1.0
C4015
4017-20261-00
CAPACITOR, 0603, X7R, 1.5N, 50V
1.0
C4016
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4017
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4018
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C4020
4017-25077-00
CAPACITOR, CHIP, CERAMIC, C0G, 330PF
1.0
B-16
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C4021
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4022
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4023
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C4035
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4038
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C4039
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C4040
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C4042
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C4043
2072-17104-00
CAPACITOR, TANTALUM, CHIP, 10UF, 16V
1.0
C4044
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C4045
2072-17104-00
CAPACITOR, TANTALUM, CHIP, 10UF, 16V
1.0
C4047
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4052
4017-25077-00
CAPACITOR, CHIP, CERAMIC, C0G, 330PF
1.0
C4053
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4054
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C4055
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4056
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C4057
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C4058
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4059
4017-25060-00
CAPACITOR, CHIP, CERAMIC, C0G, 12PF
1.0
C4060
4017-25060-00
CAPACITOR, CHIP, CERAMIC, C0G, 12PF
1.0
C4061
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C4062
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4064
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4065
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4066
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4067
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C4068
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C4069
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C4070
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C4071
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4072
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C4073
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C4074
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C4300
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C5000
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C5001
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5002
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5003
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5004
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-17
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C5005
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5006
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C5007
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C5008
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5009
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5010
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5011
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5013
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5016
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5017
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5021
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C5022
4017-20267-00
CAPACITOR, CHIP, X7R, 4.7NF, 10%
1.0
C5023
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5024
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5025
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5026
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5027
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5028
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5029
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C5032
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C5033
2072-17018-00
CAPACITOR, CHIP, 0603, 20PF
1.0
C6000
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C6002
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6004
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6006
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6008
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C6010
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6013
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6014
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C6015
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C6016
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6019
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6020
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6021
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6032
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C6033
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C6034
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C6035
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100N, 50V
1.0
C6039
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C6040
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
B-18
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C6041
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C6091
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
C7001
4017-25259-00
CAPACITOR, CHIP, CG, 10PF, 5%
1.0
C7002
4017-25259-00
CAPACITOR, CHIP, CG, 10PF, 5%
1.0
C7003
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7004
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7005
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C7006
2072-17107-00
CAPACITOR, TANTALUM, CHIP, 33UF, 16V
1.0
C7007
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C7008
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C7009
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C7010
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C7011
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7012
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7013
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7014
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7015
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7016
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7017
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7018
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7019
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7020
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C7021
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C7022
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C7027
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C7028
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C7029
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C7030
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C7031
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C9000
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9020
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9040
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9060
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9061
4017-25056-00
CAPACITOR, CHIP, CERAMIC, C0G, 5.6PF
1.0
C9063
4017-60307-00
CAPACITOR
1.0
C9066
4017-25061-00
CAPACITOR, CHIP, CERAMIC, C0G, 15PF
1.0
C9067
4017-25060-00
CAPACITOR, CHIP, CERAMIC, C0G, 12PF
1.0
C9069
4017-25060-00
CAPACITOR, CHIP, CERAMIC, C0G, 12PF
1.0
C9070
4017-25060-00
CAPACITOR, CHIP, CERAMIC, C0G, 12PF
1.0
C9071
4017-25061-00
CAPACITOR, CHIP, CERAMIC, C0G, 15PF
1.0
B-19
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C9072
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C9074
2072-17014-00
CAPACITOR, CHIP, 0805 43PF, 5%
1.0
C9075
4017-25265-00
CAPACITOR, CHIP, 0603, NP0, 33PF
1.0
C9076
2072-17011-00
CAPACITOR, CHIP, 0805 7.5PF
1.0
C9078
4017-25053-00
CAPACITOR, CHIP, CERAMIC, C0G, 3.3PF
1.0
C9080
4017-25053-00
CAPACITOR, CHIP, CERAMIC, C0G, 3.3PF
1.0
C9081
4017-25347-00
CAPACITOR, CHIP, CH, 1PF, 5%
1.0
C9082
2072-17001-00
CAPACITOR, CHIP, 0805, 30PF, 5%
1.0
C9084
4017-25071-00
CAPACITOR, CHIP, CERAMIC, C0G, 100PF
1.0
C9087
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9089
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9091
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9093
4017-25259-10
CAPACITOR, CHIP, CG, 10PF, 1%
1.0
C9094
4017-25061-00
CAPACITOR, CHIP, CERAMIC, C0G, 15PF
1.0
C9095
4017-25060-00
CAPACITOR, CHIP, CERAMIC, C0G, 12PF
1.0
C9096
4017-25067-00
CAPACITOR, CHIP, CERAMIC, 47PF, 50V
1.0
C9097
4017-25060-00
CAPACITOR, CHIP, CERAMIC, C0G, 12PF
1.0
C9098
4017-25073-10
CAPACITOR, CHIP, 150PF, 1%, 50V
1.0
C9099
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9110
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C9200
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9300
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C9400
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9401
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9407
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C9419
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9420
4017-20930-00
CAPACITOR, X5R, 10UF, 10V 0805
1.0
C9421
4017-20930-00
CAPACITOR, X5R, 10UF, 10V 0805
1.0
C9422
2072-17104-00
CAPACITOR, TANTALUM, CHIP, 10UF, 16V
1.0
C9423
2072-17104-00
CAPACITOR, TANTALUM, CHIP, 10UF, 16V
1.0
C9472
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9481
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9482
4017-20567-00
CAPACITOR, CHIP, X7R, 10NF, 16V
1.0
C9483
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9484
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9485
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9486
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9487
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9488
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9489
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
B-20
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C9490
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9491
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9492
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9496
4017-20567-00
CAPACITOR, CHIP, X7R, 10NF, 16V
1.0
C9498
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9499
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9500
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9501
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9502
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9506
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9507
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9508
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9509
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9511
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9515
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9518
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9519
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9520
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9521
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9522
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9523
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9524
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9525
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9526
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9527
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9530
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9531
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9532
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C9533
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C9534
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C9535
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C9536
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9537
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9538
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C9539
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C9540
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C9541
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C9542
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9543
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C9544
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
B-21
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C9545
4017-25077-00
CAPACITOR, CHIP, CERAMIC, C0G, 330PF
1.0
C9548
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C9549
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C9551
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9552
4016-26040-10
RESISTOR, CHIP, 0603, 604, 1%
1.0
C9553
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C9554
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C9555
4017-80125-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 25V
1.0
C9556
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9557
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9558
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9559
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9560
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9561
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9562
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C9563
4017-25276-00
CAPACITOR, CHIP, CG, 270PF, 5%
1.0
C9564
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9566
4017-20930-00
CAPACITOR, X5R, 10UF, 10V 0805
1.0
C9567
4017-20930-00
CAPACITOR, X5R, 10UF, 10V 0805
1.0
C9568
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9573
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9574
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9575
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9578
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9579
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9580
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9581
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9582
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9583
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9584
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
C9585
4017-20275-00
CAPACITOR, CHIP, X7 22NF, 25V
1.0
C9591
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9592
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C9594
4017-20261-00
CAPACITOR, 0603, X7R, 1.5N, 50V
1.0
C9595
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C9596
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C9597
4017-30033-00
CAPACITOR, PPS 0603, 2.7NF, 16V
1.0
C9598
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C9599
2072-17029-00
CAPACITOR, CHIP, X7R, 680PF
1.0
C9600
4017-60513-00
CAPACITOR
1.0
B-22
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C9601
4017-60513-00
CAPACITOR
1.0
C9602
4017-25077-00
CAPACITOR, CHIP, CERAMIC, C0G, 330PF
1.0
C9603
4017-25077-00
CAPACITOR, CHIP, CERAMIC, C0G, 330PF
1.0
C9604
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C9605
4017-20931-00
CAPACITOR, 1206, 10UF, 16V
1.0
C9606
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9607
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9608
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9609
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9610
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9611
4017-20930-00
CAPACITOR, X5R, 10UF, 10V 0805
1.0
C9612
4017-20930-00
CAPACITOR, X5R, 10UF, 10V 0805
1.0
C9613
4017-20930-00
CAPACITOR, X5R, 10UF, 10V 0805
1.0
C9614
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C9615
4017-20085-00
CAPACITOR, CHIP, CERAMIC, X7R, 100NF
1.0
C9616
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C9617
2072-17110-00
CAPACITOR, CHIP, 0603, X7R, 1UF
1.0
C9619
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C9620
2072-17105-00
CAPACITOR, TANTALUM, CHIP, 15UF, 25V
1.0
C1FL1
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL2
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL3
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL4
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL5
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL6
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL7
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL8
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL9
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL10
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL11
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL12
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL13
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL14
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL15
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL17
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL18
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL19
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL20
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL21
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL23
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
B-23
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C1FL24
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C1FL27
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL28
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL29
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C1FL30
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL31
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C1FL32
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C1FL33
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL1
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL2
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL3
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL4
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL5
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL6
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL7
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL8
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL9
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL10
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL11
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL12
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL13
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL14
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL15
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL17
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL18
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL19
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL20
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL21
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL23
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2FL24
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2FL27
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL28
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL29
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2FL30
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL31
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
C2FL32
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C2FL33
4017-20559-00
CAPACITOR, CHIP, X7R, 1NF, 10%
1.0
CR1
2072-21025-00
DIODE, PIN
1.0
CR2
2072-21025-00
DIODE, PIN
1.0
CR3
2072-21025-00
DIODE, PIN
1.0
B-24
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
CR4
2072-21025-00
DIODE, PIN
1.0
CR5
2072-21025-00
DIODE, PIN
1.0
CR6
2072-21025-00
DIODE, PIN
1.0
CR7
2072-21025-00
DIODE, PIN
1.0
CR8
2072-21025-00
DIODE, PIN
1.0
CR9
2072-21025-00
DIODE, PIN
1.0
CR10
2072-21025-00
DIODE, PIN
1.0
CR11
2072-21025-00
DIODE, PIN
1.0
CR12
2072-21025-00
DIODE, PIN
1.0
CR13
2072-21025-00
DIODE, PIN
1.0
CR14
2072-21025-00
DIODE, PIN
1.0
CR15
2072-21025-00
DIODE, PIN
1.0
CR16
2072-21025-00
DIODE, PIN
1.0
CR17
2072-21025-00
DIODE, PIN
1.0
CR1000
2072-21025-00
DIODE, PIN
1.0
CR1001
4021-10114-35
DIODE, SCHOTTKY, HSMS2800
1.0
CR1002
4021-10721-35
DIODE
1.0
CR1003
4021-10721-35
DIODE
1.0
CR1004
4021-10721-35
DIODE
1.0
CR1005
4021-10721-35
DIODE
1.0
CR1006
4021-10721-35
DIODE
1.0
CR1007
4021-10721-35
DIODE
1.0
CR1008
2072-21025-00
DIODE, PIN
1.0
CR1009
2072-21025-00
DIODE, PIN
1.0
CR1010
2072-21025-00
DIODE, PIN
1.0
CR1011
2072-21025-00
DIODE, PIN
1.0
CR1012
2072-21025-00
DIODE, PIN
1.0
CR1903
4021-10721-35
DIODE
1.0
CR1904
2072-21025-00
DIODE, PIN
1.0
CR1905
2072-21025-00
DIODE, PIN
1.0
CR2000
2072-21014-00
DIODE, TRIPLE
1.0
CR2001
2072-21025-00
DIODE, PIN
1.0
CR2002
2072-21025-00
DIODE, PIN
1.0
CR2003
2072-21025-00
DIODE, PIN
1.0
CR2008
4021-10721-35
DIODE
1.0
CR2009
4021-10721-35
DIODE
1.0
CR5000
4021-10115-35
DIODE, SCHOTTKY
1.0
CR5001
4021-10721-35
DIODE
1.0
CR5002
4021-10115-35
DIODE, SCHOTTKY
1.0
CR5003
4021-10115-35
DIODE, SCHOTTKY
1.0
B-25
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
CR5004
4021-10115-35
DIODE, SCHOTTKY
1.0
CR5005
4021-10115-35
DIODE, SCHOTTKY
1.0
CR9000
4021-10360-35
VARICAP
1.0
CR9020
4021-10360-35
VARICAP
1.0
CR9040
4021-10360-35
VARICAP
1.0
CR9063
4021-10115-35
DIODE, SCHOTTKY
1.0
CR9064
4021-10115-35
DIODE, SCHOTTKY
1.0
CR9066
4021-10360-35
VARICAP
1.0
CR9067
4021-10360-35
VARICAP
1.0
CR9068
4021-10115-35
DIODE, SCHOTTKY
1.0
CR9069
4021-10360-35
VARICAP
1.0
CR9070
4021-10721-35
DIODE
1.0
CR9071
4021-10360-35
VARICAP
1.0
CR9073
4021-10360-35
VARICAP
1.0
CR9074
4021-10360-35
VARICAP
1.0
CR9075
4021-10360-35
VARICAP
1.0
CR9076
4021-10360-35
VARICAP
1.0
CR9077
4021-10721-35
DIODE
1.0
CR9078
2072-21029-00
DIODE, VARACTOR
1.0
CR9079
4021-10360-35
VARICAP
1.0
E1001
2072-18001-00
INDUCTOR, BEAD, CHIP
1.0
E1002
2072-18001-00
INDUCTOR, BEAD, CHIP
1.0
F1
4023-60003-00
MULTIFUSE CHIP, 500MA
1.0
FL1
2072-14006-00
CRYSTAL FILTER
1.0
FL2
2072-14006-00
CRYSTAL FILTER
1.0
FL3
2072-14003-00
FILTER, CERAMIC, BP, 450KHZ
1.0
FL4
2072-14003-00
FILTER, CERAMIC, BP, 450KHZ
1.0
J1
2072-33016-00
COAX, RECEPTABLE, 002 PIN
1.0
J2
2072-33016-00
COAX, RECEPTABLE, 002 PIN
1.0
J3
2072-33007-00
HEADER, RT, 40 PIN
1.0
J4
4033-51109-01
CONNECTOR, 2 PIN, 1.25mm
1.0
J5
2072-33008-00
CONNECTOR, D-TYPE, 44 PIN
1.0
J6
2072-33006-00
CONNECTOR, HEADER, 24 PIN
1.0
J7
2072-33167-00
CONNECTOR, FPC VERTICAL
1.0
J8
2072-33151-00
HEADER, 8P
1.0
J10
4033-60052-01
CONNECTOR, MICRO 6S
1.0
L1
4018-12329-00
INDUCTOR, CHIP, 910NH
1.0
L2
4018-12329-00
INDUCTOR, CHIP, 910NH
1.0
L3
2072-18009-00
INDUCTOR, CHIP, 680NH, 5%
1.0
L4
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
B-26
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
L5
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L6
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L7
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L8
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L9
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L10
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L12
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L13
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L14
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L15
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L16
4018-12036-50
INDUCTOR, RFC, 3.3UH, 5%
1.0
L20
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L22
4018-12022-20
INDUCTOR, RFC, 390NH, 2%
1.0
L25
2072-18006-00
INDUCTOR, CHIP, 8200NH, 5%
1.0
L26
2072-18006-00
INDUCTOR, CHIP, 8200NH, 5%
1.0
L27
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L28
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L29
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L30
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L31
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L32
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L33
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L34
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L35
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L36
2072-18005-00
INDUCTOR, CHIP, 6800NH, 5%
1.0
L37
2072-18004-00
INDUCTOR, CHIP, 5600NH, 5%
1.0
L38
2072-18004-00
INDUCTOR, CHIP, 5600NH, 5%
1.0
L39
2072-18003-00
INDUCTOR, CHIP, 4700NH, 5%
1.0
L42
2072-18002-00
INDUCTOR, CHIP, 1200NH, 5%
1.0
L43
2072-18002-00
INDUCTOR, CHIP, 1200NH, 5%
1.0
L44
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%,
1.0
L45
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%,
1.0
L46
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L47
2072-18010-00
INDUCTOR, CHIP, 2200NH, 10%
1.0
L48
2072-18010-00
INDUCTOR, CHIP, 2200NH, 10%
1.0
L49
2072-18010-00
INDUCTOR, CHIP, 2200NH, 10%
1.0
L50
4018-12329-00
INDUCTOR, CHIP, 910NH, 5%
1.0
L51
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L52
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L53
4018-12036-50
INDUCTOR, RFC, 3.3UH, 5%
1.0
B-27
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
L54
4018-12036-50
INDUCTOR, RFC, 3.3UH, 5%
1.0
L55
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1000
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1006
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1007
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1008
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1012
4018-12329-00
INDUCTOR, CHIP, 910NH, 5
1.0
L1013
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1014
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1015
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1016
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1017
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1018
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1020
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1021
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1022
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1023
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1024
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1025
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1027
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1028
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1029
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1030
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1033
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1034
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1041
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L1042
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L1043
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L1044
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L1045
4018-12024-20
INDUCTOR, RFC, 0.560UH, 2%
1.0
L1046
4018-12024-20
INDUCTOR, RFC, 0.560UH, 2%
1.0
L1047
4018-12024-20
INDUCTOR, RFC, 0.560UH, 2%
1.0
L1048
4018-12024-20
INDUCTOR, RFC, 0.560UH, 2%
1.0
L1049
4018-12024-20
INDUCTOR, RFC, 0.560UH, 2%
1.0
L1050
4018-12014-00
COIL CHIP, 82NH, 5%
1.0
L1052
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L1054
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L1056
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1057
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L1059
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
B-28
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
L1214
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1800
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1801
4018-12029-20
INDUCTOR, RFC, 1UH, 2%
1.0
L1802
4018-12029-20
INDUCTOR, RFC, 1UH, 2%
1.0
L1803
4018-12029-20
INDUCTOR, RFC, 1UH, 2%
1.0
L1804
4018-12029-20
INDUCTOR, RFC, 1UH, 2%
1.0
L1805
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1806
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1807
2072-18009-00
INDUCTOR, CHIP, 680NH, 5%
1.0
L2000
4018-12419-00
INDUCTOR, RFC, CHIP, 33NH, 5%
1.0
L2001
2072-18002-00
INDUCTOR, CHIP, 1200NH, 5%
1.0
L2002
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L2003
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L2004
4018-12320-10
INDUCTOR, RFC, 0.27 UH, 1%
1.0
L2005
2072-18007-00
INDUCTOR, CHIP, 8.2NH, 5%
1.0
L2006
4018-12015-20
INDUCTOR, RFC, 100NH, 2%
1.0
L2007
4018-12015-20
INDUCTOR, RFC, 100NH, 2%
1.0
L2008
4018-12015-20
INDUCTOR, RFC, 100NH, 2%
1.0
L2009
4018-12015-20
INDUCTOR, RFC, 100NH, 2%
1.0
L2011
4018-12006-00
COIL CHIP, 15NH, 5%
1.0
L2012
4018-12013-00
INDUCTOR, RFC, 68NH, 10%
1.0
L2013
4018-12013-00
INDUCTOR, RFC, 68NH, 10%
1.0
L2017
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L2018
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L2019
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L2020
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L2021
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L2022
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L2023
4018-12016-20
INDUCTOR, RFC, 120NH, 2%
1.0
L2024
4018-12029-20
INDUCTOR, RFC, 1UH, 2%
1.0
L2025
4018-12029-20
INDUCTOR, RFC, 1UH, 2%
1.0
L2026
4018-12014-00
COIL, CHIP, 82NH, 5%
1.0
L2027
4018-12016-20
INDUCTOR, RFC, 120NH, 2%
1.0
L2028
4018-12016-20
INDUCTOR, RFC, 120NH, 2%
1.0
L3000
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L3001
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L3002
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L3003
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L3004
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L3005
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
B-29
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
L3006
2072-18008-00
INDUCTOR, CHIP, 10000NH, 5%
1.0
L3007
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L3008
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L4001
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L4002
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L5000
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L5001
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L5002
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L6000
2072-18009-00
INDUCTOR, CHIP, 680NH, 5%
1.0
L9000
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9020
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9040
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9060
4018-12329-00
INDUCTOR, CHIP, 910NH
1.0
L9061
4018-12329-00
INDUCTOR, CHIP, 910NH
1.0
L9062
4018-12329-00
INDUCTOR, CHIP, 910NH
1.0
L9064A
4018-20024-00
COIL, VARIABLE, 28NH
1.0
L9065A
4018-20006-00
COIL, VARIABLE, 67NH
1.0
L9066A
4018-20004-00
COIL, VARIABLE, 53NH
1.0
L9070
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9072
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9073
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9074
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9076A
4018-20006-00
COIL, VARIABLE, 67NH
1.0
L9077
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9079
4018-12032-20
INDUCTOR, RFC, 1.5UH, 2%
1.0
L9080
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L9081
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L9082
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L9083
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L9084
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L9085
4018-10142-00
INDUCTOR, 22UH
1.0
L1FL1
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL2
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL3
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL4
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL5
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL6
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL7
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL8
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL9
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
B-30
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
L1FL10
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL11
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL12
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL13
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL14
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL15
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL17
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL18
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL19
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL20
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL21
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL23
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL24
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL27
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL28
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL29
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL30
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL31
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL32
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
L1FL33
4018-12206-00
INDUCTOR, CHIP, 22UH, 5%
1.0
Q1
4021-00342-35
TRANSISTOR, NPN
1.0
Q2
4021-00342-35
TRANSISTOR, NPN
1.0
Q3
4021-00342-35
TRANSISTOR, NPN
1.0
Q4
4021-00342-35
TRANSISTOR, NPN
1.0
Q5
4021-00342-35
TRANSISTOR, NPN
1.0
Q6
4021-00342-35
TRANSISTOR, NPN
1.0
Q7
4021-00342-35
TRANSISTOR, NPN
1.0
Q8
4021-00342-35
TRANSISTOR, NPN
1.0
Q9
4021-00342-35
TRANSISTOR, NPN
1.0
Q30
4021-00343-35
TRANSISTOR, PNP
1.0
Q1000
4021-00342-35
TRANSISTOR, NPN
1.0
Q1001
2072-21024-01
MOSFET, N-CHANNEL
1.0
Q1002
2072-21024-01
MOSFET, N-CHANNEL
1.0
Q1003
2072-21026-00
TRANSISTOR, RF
1.0
Q1004
2072-21026-00
TRANSISTOR, RF
1.0
Q1005
2072-21026-00
TRANSISTOR, RF
1.0
Q1006
2072-21026-00
TRANSISTOR, RF
1.0
Q1007
4021-00343-35
TRANSISTOR, PNP
1.0
Q1008
4021-00343-35
TRANSISTOR, PNP
1.0
Q1009
4021-00343-35
TRANSISTOR, PNP
1.0
B-31
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
Q1010
4021-00343-35
TRANSISTOR, PNP
1.0
Q1011
4021-00343-35
TRANSISTOR, PNP
1.0
Q1012
4021-00343-35
TRANSISTOR, PNP
1.0
Q1013
4021-00342-35
TRANSISTOR, NPN
1.0
Q1014
4021-00342-35
TRANSISTOR, NPN
1.0
Q1015
4021-00342-35
TRANSISTOR, NPN
1.0
Q1017
4021-00342-35
TRANSISTOR, NPN
1.0
Q1018
4021-00342-35
TRANSISTOR, NPN
1.0
Q1019
4021-00342-35
TRANSISTOR, NPN
1.0
Q1020
4021-00176-35
MOSFET, N-CHANNEL
1.0
Q1021
4021-00342-35
TRANSISTOR, NPN
1.0
Q1022
4021-00342-35
TRANSISTOR, NPN
1.0
Q1023
4021-00342-35
TRANSISTOR, NPN
1.0
Q1925
4021-00176-35
MOSFET, N-CHANNEL
1.0
Q2006
2072-21026-00
TRANSISTOR, RF
1.0
Q2007
2072-21026-00
TRANSISTOR, RF
1.0
Q2901
4021-00343-35
TRANSISTOR, PNP
1.0
Q3000
4021-00342-35
TRANSISTOR, NPN
1.0
Q3001
2072-21026-00
TRANSISTOR, RF
1.0
Q3002
2072-21026-00
TRANSISTOR, RF
1.0
Q4000
4021-00342-35
TRANSISTOR, NPN
1.0
Q4001
4021-00342-35
TRANSISTOR, NPN
1.0
Q4002
4021-00342-35
TRANSISTOR, NPN
1.0
Q4003
4021-00342-35
TRANSISTOR, NPN
1.0
Q4004
4021-00342-35
TRANSISTOR, NPN
1.0
Q4005
4021-00342-35
TRANSISTOR, NPN
1.0
Q5003
4021-00176-35
MOSFET, N-CHANNEL
1.0
Q5004
4021-00342-35
TRANSISTOR, NPN
1.0
Q5005
4021-00343-35
TRANSISTOR, PNP
1.0
Q5006
4021-00176-35
MOSFET, N-CHANNEL
1.0
Q9000
2072-21019-00
TRANSISTOR, FET
1.0
Q9020
2072-21019-00
TRANSISTOR, FET
1.0
Q9040
2072-21019-00
TRANSISTOR, FET
1.0
Q9060
2072-21019-00
TRANSISTOR, FET
1.0
Q9063
2072-21015-00
TRANSISTOR, W/RES BIAS
1.0
Q9064
2072-21015-00
TRANSISTOR, W/RES BIAS
1.0
Q9065
2072-21015-00
TRANSISTOR, W/RES BIAS
1.0
Q9066
4021-00342-35
TRANSISTOR, NPN
1.0
Q9067
4021-00342-35
TRANSISTOR, NPN
1.0
Q9068
4021-00176-35
MOSFET, N-CHANNEL
1.0
B-32
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
Q9069
4021-00342-35
TRANSISTOR, NPN
1.0
R1
4016-41000-10
RESISTOR, 2512, 100, 1%, 1W
1.0
R2
4016-41000-10
RESISTOR, 2512, 100, 1%, 1W
1.0
R3
4016-41000-10
RESISTOR, 2512, 100, 1%, 1W
1.0
R4
4016-41000-10
RESISTOR, 2512, 100, 1%, 1W
1.0
R5
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R6
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R7
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R8
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R9
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R10
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R11
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R12
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R13
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R14
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R15
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R16
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R17
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R18
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R19
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R20
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R21
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R22
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R23
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R24
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R25
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R26
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R27
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R28
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R29
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R30
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R31
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R32
4016-20100-50
RESISTOR, CHIP, 10 5%, 1/16W
1.0
R33
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R34
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R35
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R36
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R37
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R50
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R60
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
B-33
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R82
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R1000
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1001
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R1002
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1003
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R1005
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1006
4016-26819-10
RESISTOR, CHIP, 0603, 68.1, 1%
1.0
R1007
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1008
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1009
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R1010
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1011
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R1012
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R1013
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1014
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1015
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1016
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1017
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1018
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1019
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R1020
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R1021
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1022
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R1023
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R1024
4016-23320-10
RESISTOR, 332, 1%, 1/16W
1.0
R1025
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R1026
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R1027
4016-23320-10
RESISTOR, 332, 1%, 1/16W
1.0
R1028
4016-23320-10
RESISTOR, 332, 1%, 1/16W
1.0
R1029
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1030
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1031
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R1032
4016-22219-10
RESISTOR, 22.1, 1%, 1/16W
1.0
R1033
4016-26819-10
RESISTOR, CHIP, 0603, 68.1, 1%
1.0
R1034
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R1035
4016-26819-10
RESISTOR, CHIP, 0603, 68.1, 1%
1.0
R1036
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1037
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1038
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1039
4016-22219-10
RESISTOR, 22.1, 1%, 1/16W
1.0
B-34
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R1040
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R1041
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R1042
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1043
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1044
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1045
4016-23920-10
RESISTOR, 392, 1%, 1/16W
1.0
R1046
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1047
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1048
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R1049
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1050
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1051
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1052
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1053
4016-23920-10
RESISTOR, 392, 1%, 1/16W
1.0
R1054
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1055
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R1056
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R1057
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R1058
4016-23320-10
RESISTOR, 332, 1%, 1/16W
1.0
R1059
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1060
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1061
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1062
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1063
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1064
4016-23920-10
RESISTOR, 392, 1%, 1/16W
1.0
R1065
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R1066
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R1067
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R1068
4016-32740-10
RESISTOR, CHIP, 0805, 274, 1%
1.0
R1069
4016-32740-10
RESISTOR, CHIP, 0805, 274, 1%
1.0
R1070
4016-32740-10
RESISTOR, CHIP, 0805, 274, 1%
1.0
R1071
4016-32740-10
RESISTOR, CHIP, 0805, 274, 1%
1.0
R1072
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1073
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R1074
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1075
4016-32740-10
RESISTOR, CHIP, 0805, 274, 1%
1.0
R1076
4016-32740-10
RESISTOR, CHIP, 0805, 274, 1%
1.0
R1077
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1088
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1200
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
B-35
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R1201
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1202
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1203
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1204
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1205
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1206,
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R1207
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R1208
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1209
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1210
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1211
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1212
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1213
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1214
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R1215
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1216
4016-22749-10
RESISTOR, 27.4, 1%, 1/16W
1.0
R1217
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R1218
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R1219
4016-22749-10
RESISTOR, 27.4, 1%, 1/16W
1.0
R1220
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R1221
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R1222
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1223
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1224
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1225
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1226
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1227
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1228
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R1229
4016-23659-10
RESISTOR, CHIP, 0603, 36.5, 1%
1.0
R1230
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1231
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1232
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1233
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R1234
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1235
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1236
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1237
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1238
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1239
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R1240
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
B-36
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R1241
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R1242
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1243
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1244
4016-30279-50
RESISTOR, CHIP, 2.7 5%, 1/10W
1.0
R1245
4016-30279-50
RESISTOR, CHIP, 2.7 5%, 1/10W
1.0
R1246
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1247
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1248
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1251
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1252
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R1253
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R1254
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R1255
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1800
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1801
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1802
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1803
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R1804
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R1805
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1806
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1807
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R1808
4016-26810-10
RESISTOR, 681, 1%, 1/16W
1.0
R1809
4016-23322-10
RESISTOR, 33.2K, 1%, 1/16W
1.0
R1810
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R1811
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1812
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R1813
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R1814
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R1815
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1816
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1817
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R1818
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R1819
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1820
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1821
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R1822
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R1823
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1824
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R1825
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1826
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
B-37
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R1827
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1828
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1829
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R1830
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R1831
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R1832
4016-60102-00
TRIMPOT, 10K
1.0
R1833
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1834
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1835
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R1836
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R1837
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R1838
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1839
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R1840
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R1841
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1842
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R1843
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R1845
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R1846
4016-22749-10
RESISTOR, 27.4, 1%, 1/16W
1.0
R1847
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R1848
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1850
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R1851
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R1852
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R1853
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1854
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R1855
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R1856
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R1857
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R1858
4016-23320-10
RESISTOR, 332, 1%, 1/16W
1.0
R1859
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1860
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1861
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1862
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1863
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1864
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R1865
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R1866
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1867
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R1868
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
B-38
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R1869
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1870
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1871
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R1872
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R1899
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1911
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R1962
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R1998
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R2000
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R2002
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R2003
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R2004
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R2008
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R2009
4016-23322-10
RESISTOR, 33.2K, 1%, 1/16W
1.0
R2012
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R2017
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R2022
4016-28251-10
RESISTOR, 8.25K, 1%, 1/16W
1.0
R2026
4016-21300-10
RESISTOR, 130, 1%, 1/16W
1.0
R2029
4016-22749-10
RESISTOR, 27.4, 1%, 1/16W
1.0
R2034
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R2035
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R2036
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R2037
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R2038
4016-25110-10
RESISTOR, 511, 1%, 1/16W
1.0
R2043
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R2044
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R2045
4016-29091-10
RESISTOR, 9.09K, 1%, 1/16W
1.0
R2046
4016-25621-10
RESISTOR, CHIP, 0603, 5.62K, 1%
1.0
R2047
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R2048
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2049
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2050
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2051
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2052
4016-27501-10
RESISTOR, 7.5K, 1%, 1/16W
1.0
R2053
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2054
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2055
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2056
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R2057
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R2058
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
B-39
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R2059
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R2060
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R2061
4016-23920-10
RESISTOR, 392, 1%, 1/16W
1.0
R2062
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2063
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2064
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2065
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2066
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2067
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2068
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2069
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2070
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2071
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R2074
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R2077
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2078
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2079
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2080
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2081
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2082
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2083
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2084
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R2085
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R2086
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R2901
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R2903
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R2906
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R3000
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R3004
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R3006
4016-23322-10
RESISTOR, 33.2K, 1%, 1/16W
1.0
R3009
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R3010
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R3013
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R3016
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R3017
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R3019
4016-21300-10
RESISTOR, 130, 1%, 1/16W
1.0
R3020
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R3021
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R3023
4016-91491-00
THERMISTOR, NTC
1.0
R3024
4016-40109-50
RESISTOR, 2512, 1.0 5%, 1W
1.0
B-40
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R3025
4016-40109-50
RESISTOR, 2512, 1.0 5%, 1W
1.0
R3027
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R3029
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R3031
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R3034
4016-26192-10
RESISTOR, CHIP, 0603, 61.9K, 1%
1.0
R3043
4016-23322-10
RESISTOR, 33.2K, 1%, 1/16W
1.0
R3044
4016-23322-10
RESISTOR, 33.2K, 1%, 1/16W
1.0
R3046
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R3047
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R3048
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R3050
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R3051
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R3052
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R3053
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R3054
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R3055
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R3056
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R3057
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R3058
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R3059
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R3060
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R3062
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R3063
4016-23322-10
RESISTOR, 33.2K, 1%, 1/16W
1.0
R3064
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R3075
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R3076
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R3300
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R3301
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R3302
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R3303
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R3310
4016-20106-50
RESISTOR, CHIP, 10M 5%, 1/16W
1.0
R3330
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R3350
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R3600
4016-20106-50
RESISTOR, CHIP, 10M 5%, 1/16W
1.0
R3942
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4000
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4001
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4002
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4003
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4004
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
B-41
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R4005
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4006
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R4007
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4008
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R4009
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R4011
4016-28251-10
RESISTOR, 8.25K, 1%, 1/16W
1.0
R4012
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4013
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R4014
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R4015
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R4016
4016-25621-10
RESISTOR, CHIP, 0603, 5.62K, 1%
1.0
R4017
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R4018
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4019
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4021
4016-23013-10
RESISTOR, 301K, 1%, 1/16W
1.0
R4022
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R4024
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R4025
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4026
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R4028
4016-21472-10
RESISTOR, 14.7K, 1%, 1/16W
1.0
R4030
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R4033
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4037
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R4041
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4043
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4044
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R4047
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4049
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4050
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R4051
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R4052
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4053
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R4054
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4055
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R4056
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4057
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4058
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R4059
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R4060
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R4061
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
B-42
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R4062
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4063
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4064
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R4065
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4066
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R4067
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R4068
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R4069
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R4070
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R4071
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R4072
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R4073
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4074
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4075
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R4077
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R4078
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R4079
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R4080
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R4081
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R4082
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4083
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4084
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4085
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R4086
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R4087
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R4088
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R4200
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R4401
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R5000
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R5001
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R5002
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5003
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5004
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5005
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5006
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5007
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5009
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R5013
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R5014
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R5016
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
B-43
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R5017
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5021
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5022
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R5023
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R5024
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R5025
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R5027
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R5029
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R5030
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R5034
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R5035
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R5037
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5038
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5039
4016-20106-50
RESISTOR, CHIP, 10M 5%, 1/16W
1.0
R5040
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5041
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5042
4016-22743-10
RESISTOR, 274K, 1%, 1/16W
1.0
R5043
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5044
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5046
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R5047
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5048
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5050
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R5051
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5052
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R5053
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5054
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5055
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5056
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R5059
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5060
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R5063
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5065
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5066
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5067
4016-22000-10
RESISTOR, 200, 1%, 1/16W
1.0
R5068
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5070
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R5071
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5072
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R5075
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
B-44
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R5100
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5101
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5104
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R6000
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R6002
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R6009
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R6016
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R6018
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R6020
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R6022
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R6023
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R6026
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R6027
4016-19090-10
RESISTOR, CHIP, 909, 1%, 1/8W
1.0
R6028
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R6030
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R6032
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R6033
4016-27500-10
RESISTOR, CHIP, 0603, 750, 1%
1.0
R6034
4016-27500-10
RESISTOR, CHIP, 0603, 750, 1%
1.0
R6035
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R6036
4016-27500-10
RESISTOR, CHIP, 0603, 750, 1%
1.0
R6037
4016-19090-10
RESISTOR, CHIP, 909, 1%, 1/8W
1.0
R6038
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R6039
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R6040
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R6041
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R6042
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R7000
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R7001
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R7002
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R7003
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R7006
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R7007
4016-24752-10
RESISTOR, 47.5K, 1%, 1/16W
1.0
R9000
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R9020
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R9040
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R9060
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R9062
4016-22000-10
RESISTOR, 200, 1%, 1/16W
1.0
R9063
4016-22000-10
RESISTOR, 200, 1%, 1/16W
1.0
R9064
4016-22000-10
RESISTOR, 200, 1%, 1/16W
1.0
R9065
4016-22000-10
RESISTOR, 200, 1%, 1/16W
1.0
B-45
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R9100
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R9200
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R9300
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R9400
4016-20100-50
RESISTOR, CHIP, 10, 5%, 1/16W
1.0
R9409
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9410
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9411
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9412
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9417
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9418
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9419
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9420
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9421
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9422
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9423
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9427
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9464
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R9465
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R9489
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9493
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9496
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9498
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9500
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9501
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9502
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9503
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9509
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9510
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9513
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9514
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9516
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R9519
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9520
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9521
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9522
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9523
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9524
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9525
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9526
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9527
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
B-46
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R9528
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R9529
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R9530
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R9531
4016-25111-10
RESISTOR, 5.11K, 1%, 1/16W
1.0
R9532
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R9533
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R9535
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R9536
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R9537
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R9538
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R9539
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9540
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9541
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9542
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9543
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9544
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9545
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9546
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9547
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9551
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9552
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9553
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9554
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9559
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R9560
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9561
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9562
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9563
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9564
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9565
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9566
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9567
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9568
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9569
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9570
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9571
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9572
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9573
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9574
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9575
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
B-47
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R9576
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R9577
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R9578
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R9579
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R9580
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R9581
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R9582
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9583
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9584
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9585
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9586
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9587
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9588
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9589
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9590
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9591
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9592
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9593
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9594
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9595
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R9596
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R9597
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R9598
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R9599
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R9600
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R9601
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R9602
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R9603
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
R9607
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9608
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9613
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9614
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R9621
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9625
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9626
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9627
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9628
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R9629
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R9630
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W 1
1.0
R9631
4016-21472-10
RESISTOR, 14.7K, 1%, 1/16W
1.0
B-48
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R9632
4016-23013-10
RESISTOR, 301K, 1%, 1/16W
1.0
R9633
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9634
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9635
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9636
4016-51003-10
RESISTOR, CHIP, 0402, 100K
1.0
R9637
4016-55112-10
RESISTOR, CHIP, 0402, 51.1K, 1%
1.0
R9638
4016-55112-10
RESISTOR, CHIP, 0402, 51.1K, 1%
1.0
R9639
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R9640
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R9641
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R9642
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R9643
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9644
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9645
4016-52742-10
RESISTOR, CHIP, MF, 27K, 0.05W
1.0
R9646
4016-52742-10
RESISTOR, CHIP, MF, 27K, 0.05W
1.0
R9647
4016-22432-10
RESISTOR, 24.3K, 1%, 1/16W
1.0
R9648
4016-52002-10
RESISTOR, CHIP, MF, 20K, 0.063W
1.0
R9649
4016-52002-10
RESISTOR, CHIP, MF, 20K, 0.063W
1.0
R9652
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R9653
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R9654
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
R9655
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R9656
4016-53321-10
RESISTOR, CHIP, MF, 3.32K, 0.063
1.0
R9657
4016-53321-10
RESISTOR, CHIP, MF, 3.32K, 0.063
1.0
R9658
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R9659
4016-26191-10
RESISTOR, 6.19K, 1%, 1/16W
1.0
R9660
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R9661
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R9662
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R9663
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R9664
4016-51001-10
RESISTOR, CHIP, 0402, 1K
1.0
R9665
4016-51001-10
RESISTOR, CHIP, 0402, 1K
1.0
R9670
4016-52740-10
RESISTOR, CHIP, 0402, 274
1.0
R9671
4016-52210-10
RESISTOR, CHIP, 0402, 221
1.0
R9672
4016-52210-10
RESISTOR, CHIP, 0402, 221
1.0
R9673
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9674
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9675
4016-21782-10
RESISTOR, 17.8K, 1%, 1/16W
1.0
R9676
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9677
4016-26811-10
RESISTOR, CHIP, 0603, 6.81K, 1%
1.0
B-49
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R9678
4016-53321-10
RESISTOR, CHIP, MF, 3.32K, 0.063
1.0
R9679
4016-22001-10
RESISTOR, 2.0K, 1%, 1/16W
1.0
R9680
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R9688
4016-21821-10
RESISTOR, 1.82K, 1%, 1/16W
1.0
R9690
4016-26040-10
RESISTOR, CHIP, 0603, 604, 1%
1.0
R9691
4016-26040-10
RESISTOR, CHIP, 0603, 604, 1%
1.0
R9692
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9693
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9694
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9695
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9696
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9697
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9698
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9699
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9700
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9702
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R9704
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9705
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9706
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9707
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9708
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R9709
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R9710
4016-23922-10
RESISTOR, 39.2K, 1%, 1/16W
1.0
R1FL1
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL2
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL3
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL4
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL5
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL6
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL9
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL10
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL11
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL12
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL13
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL14
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL15
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL17
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL18
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL19
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL20
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
B-50
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R1FL21
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL23
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1FL24
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1FL27
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL28
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL29
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1FL30
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL31
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R1FL32
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R1FL33
4016-51000-10
RESISTOR, CHIP, 0402, 100
1.0
R2FL20
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R3FL20
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
U1
4021-60063-50
SHIFT REGISTER, 74HC595
1.0
U1000
4014-60015-00
MIXER, 500MHZ, LO-10DB
1.0
U1100
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U1104
2072-21039-00
D/A CONVERTER, 6 BIT, 4 CHANNELS
1.0
U1105
4021-44014-64
HEX SCHMITT TRIGGER
1.0
U1106
2072-21042-00
IC REGULATOR, 9.3V
1.0
U1107
2072-21042-00
IC REGULATOR, 9.3V
1.0
U1108
4014-60015-00
MIXER
1.0
U1109
4021-44014-64
HEX SCHMITT TRIGGER
1.0
U1110
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U1111
4021-70007-54
ANALOG SWITCH
1.0
U1112
4021-60063-50
SHIFT REGISTER, 74HC595
1.0
U1113
4021-31161-50
COUNTER, 74HC161
1.0
U1114
4021-31161-50
COUNTER, 74HC161
1.0
U1115
2072-21056-00
A/D CONVERTER
1.0
U1900
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U2002
2112-21805-00
DIVIDER, 8/2,4,8
1.0
U2003
2112-21805-00
DIVIDER, 8/2,4,8
1.0
U2004
2072-21044-00
IC
1.0
U2009
2072-21058-00
AMPLIFIER
1.0
U2010
2072-21058-00
AMPLIFIER
1.0
U3000
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U3001
2072-24012-00
OSCILLATOR, EPIC, 16.8MHZ
1.0
U3004
4021-20010-54
VOLTAGE REGULATOR, ADJUSTABLE, LP2951
1.0
U4000
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U4002
2072-21035-00
AMPLIFIER, AUDIO
1.0
U4003
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U5001
2072-21048-00
FLASH MEMORY, 256KX16,512KX8
1.0
B-51
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
U5005
4021-31014-64
HC, HEX SCHMITT TRIGGER
1.0
U5006
2072-21130-00
MUX/DMUX
1.0
U5007
2072-21130-00
MUX/DMUX
1.0
U5008A
2072-21036-00
IC, 68HC16
1.0
U5009
4021-62025-64
SRAM, 128KX8
1.0
U5010
4021-62025-64
SRAM, 128KX8
1.0
U5014
4021-75017-54
P.S. RESET, CONTROLLER
1.0
U6000
2072-21031-00
ASIC, DSM
1.0
U6021
2072-21045-00
REGULATOR, 5V
1.0
U6024
2072-21045-00
REGULATOR, 5V
1.0
U6025
2072-21045-00
REGULATOR, 5V
1.0
U6035
2072-21048-00
FLASH MEMORY, 256KX16,512KX8
1.0
U6038
2072-21052-00
SRAM, 64Kx24BIT, MEMORY
1.0
U6040
2072-21054-00
CODEC, 16BIT
1.0
U6042
2072-21050-00
DSP, 56303
1.0
U6043
2072-21051-00
EEPROM, 32Kx8BIT
1.0
U6062
2072-21057-00
RS-232 TRANSCEIVERS, 5V
1.0
U6063
2072-21057-00
RS-232 TRANSCEIVERS, 5V
1.0
U6065
4021-35000-54
2-INPUT NAND GATE, QUAD
1.0
U6068
2072-33137-00
OCTAL D-TYPE, FLIP FLOP
1.0
U6069
2072-33137-00
OCTAL D-TYPE, FLIP FLOP
1.0
U6070
2072-33137-00
OCTAL D-TYPE, FLIP FLOP
1.0
U6075
2072-21129-00
SYNTHESIZER, RF PLL
1.0
U6076
2072-21129-00
SYNTHESIZER, RF PLL
1.0
U6077
4021-44014-64
HEX SCHMITT TRIGGER
1.0
U6078
2072-21125-00
UART WITH 16-BYTE, QUAD
1.0
U6079
4021-44138-64
DECODER, VHC 3 TO 8
1.0
U6080
4021-44014-64
HEX SCHMITT TRIGGER
1.0
U6081
2072-21113-00
POTENTIOMETER, DIGITAL, 128TAP
1.0
U6082
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U6084
2388-21830-00
IC, 14053
1.0
U6085
2388-21830-00
IC, 14053
1.0
U6089
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
U6096
4021-76014-54
ANALOG SWITCH, DUAL, SPST, 2.7F
1.0
U6097
4021-22123-54
VOLTAGE REGULATOR, 3.3V
1.0
U6098
4021-22114-50
VOLTAGE REGULATOR, 8V
1.0
U6099
2072-21130-00
MUX/DMUX
1.0
VR1
4021-10420-35
ZENER, 3.3V
1.0
VR2
4021-10420-35
ZENER, 3.3V
1.0
VR4
2072-21028-00
ZENER, 10V
1.0
B-52
MM-E 2072-09333-00
Table B-3. LORD Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
VR5
2072-21028-00
ZENER, 10V
1.0
VR1500
4021-10421-35
ZENER, 5.6V
1.0
VR4000
4021-10422-35
ZENER, 27V
1.0
VR5001
4021-10421-35
ZENER, 5.6V
1.0
VR5002
4021-10421-35
ZENER, 5.6V
1.0
VR5003
4021-10421-35
ZENER, 5.6V
1.0
VR5004
4021-10421-35
ZENER, 5.6V
1.0
VR5009
4021-10421-35
ZENER, 5.6V
1.0
VR5010
4021-10421-35
ZENER, 5.6V
1.0
Y5002
2072-24011-00
CRYSTAL, MC-306-38.400KHZ
1.0
B-53
MM-E 2072-09333-00
Intentionally Left Blank
B-54
MM-E 2072-09333-00
COMPONENT SIDE
Figure B-3.A. LORD Module, Identification of Components (Sheet 1 of 2)
B-55/B-56
MM-E 2072-09333-00
PRINT
SIDE
Figure B-3.B. LORD Module, Identification of Components (Sheet 2 of 2)
B-57/B-58
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-95170-10
HI POWER MODULE
Figure B-4
BL1
2072-45014-00
POWER PAD
1.0
BL2
2072-32170-00
HI POWER PCB
1.0
BL3
4052-15003-00
SCREW, CROSS RECESSED, PAN HEAD
8.0
BL4
2072-33051-00
SPACER
1.0
BL5
2072-53004-00
WASHER, SHLDR 1483967A03
1.0
BL6
2072-40050-00
SHIELD, 2683423K03
1.0
BL7
2072-48026-00
SHIELD, RF
1.0
BL8
4052-12014-16
SCREW, M2X16, PAN HEAD
10.0
BL9
4053-70003-16
WASHER, SPRING, M2
10.0
BL10
4068-00007-20
WIRE, EL UNINSULATED, AWG, 20
.10
BL11
4053-16001-00
WASHER, SPRING, LOCK, M3
4.0
BL12
2201-63202-03
HEATSINK COMPOUND, DC340
.200
BL14
2201-64113-19
RTV734, CLEAR
.10
BL15
2072-90210-10
CABLE ANTENNA
1.0
BL16
2201-64106-05
ELECOLIT 631, A+B
.50
BL17
2338-56025-00
ADHESIVE BACK MOUNTS
1.0
BL18
2388-56043-00
STRIP, SST, 1.5M
1.0
BL19
2072-72024-00
IDENTIFICATION LABEL FOR 207295170F
1.0
C1
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C2
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C3
4017-80116-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 20V
1.0
C4
4017-80115-20
CAPACITOR, CHIP, TANTALUM, 47U
1.0
C5
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C6
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C8
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C10
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C11
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C12
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C13
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C14
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C15
4017-80226-00
CAPACITOR, CHIP, TANTALUM, 15UF, 35V
1.0
C16
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C17
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C18
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C19
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C20
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C21
4017-20181-00
CAPACITOR, 1210, X7R, 100NF, 200V
1.0
C22
4017-20102-00
CAPACITOR, CHIP, 10NF, 200V
1.0
B-59
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C23
4017-20181-00
CAPACITOR, 1210, X7R, 100NF, 200V
1.0
C24
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C26
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C27
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C28
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C29
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C30
4017-25101-00
CAPACITOR, CHIP, CERAMIC, 1NF, 200V
1.0
C32
4017-80115-20
CAPACITOR, CHIP, TANTALUM, 47U
1.0
C34
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C36
4017-20181-00
CAPACITOR, 1210, X7R, 100NF, 200V
1.0
C37
4017-25101-00
CAPACITOR, CHIP, CERAMIC, 1NF, 200V
1.0
C38
4017-20102-00
CAPACITOR, CHIP, 10NF, 200V
1.0
C40
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C41
4017-20181-00
CAPACITOR, 1210, X7R, 100NF, 200V
1.0
C43
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C44
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C45
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C46
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C47
4017-25093-00
CAPACITOR, CHIP, CERAMIC, C0G, 10NF
1.0
C48
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C49
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C50
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C51
4017-25093-00
CAPACITOR, CHIP, CERAMIC, C0G, 10NF
1.0
C52
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C53
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C55
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C56
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C57
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C58
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C59
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C60
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C62
4017-80116-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 20V
1.0
C63
4017-25265-10
CAPACITOR, CHIP, NP0, 33PF, 1%
1.0
C65
2089-17003-00
CAPACITOR, PORCELAN, 10PF, 5%
1.0
C66
2089-17003-00
CAPACITOR, PORCELAN, 10PF, 5%
1.0
C67
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C70
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C71
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C72
2089-17003-00
CAPACITOR, PORCELAN, 10PF, 5%
1.0
C73
4017-80105-02
CAPACITOR, CHIP, TANTALUM, 22UF, 25V
1.0
B-60
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C74
2089-17003-00
CAPACITOR, PORCELAN, 10PF, 5%
1.0
C75
2089-17003-00
CAPACITOR, PORCELAN, 10PF, 5%
1.0
C76
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C77
2089-17003-00
CAPACITOR, PORCELAN, 10PF, 5%
1.0
C78
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C79
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C80
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C82
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C83
4017-25267-00
CAPACITOR, CHIP, 0603, NP0, 47PF
1.0
C84
4017-25267-00
CAPACITOR, CHIP, 0603, NP0, 47PF
1.0
C86
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C87
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C88
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C89
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C90
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C91
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C93
4017-20109-00
CAPACITOR, 1206, X7R, 10UF,
1.0
C94
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C95
4017-80116-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 20V
1.0
C96
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C97
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C98
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C99
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C100
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C101
2089-17022-00
CAPACITOR, PORCELAN, 150PF, 5%
1.0
C102
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C103
2089-17026-00
CAPACITOR, PORCELAN, 240PF, 5%
1.0
C105
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C106
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C107
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C108
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C109
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C110
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C111
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C112
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C113
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C114
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C115
2089-17023-00
CAPACITOR, PORCELAN, 180PF, 5%
1.0
C116
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C118
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
B-61
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C121
4017-80234-00
CAPACITOR, CHIP, TANTALUM, 100UF, 20V
1.0
C122
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C123
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C124
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C126
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C128
4017-80226-00
CAPACITOR, CHIP, TANTALUM, 15UF, 35V
1.0
C129
4017-80105-02
CAPACITOR, CHIP, TANTALUM, 22UF, 25V
1.0
C130
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C131
4017-80115-20
CAPACITOR, CHIP, TANTALUM, 47U
1.0
C132
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C134
4017-80226-00
CAPACITOR, CHIP, TANTALUM, 15UF, 35V
1.0
C135
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C136
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C137
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C138
4017-80226-00
CAPACITOR, CHIP, TANTALUM, 15UF, 35V
1.0
C139
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C140
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C141
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C142
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C143
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C145
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C146
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C147
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C148
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C149
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C150,
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C151
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C152
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C153
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C154
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C155
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C156
4017-25279-00
CAPACITOR, CHIP, CG, 470PF, 5%
1.0
C157
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C158
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C160
4017-80234-00
CAPACITOR, CHIP, TANTALUM, 100UF, 20V
1.0
C161
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C162
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C163
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C164
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C165
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
B-62
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C166
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C167
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C168
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C169
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C171
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C173
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C174
4017-20109-00
CAPACITOR, 1206, X7R, 10UF
1.0
C201
2089-17022-00
CAPACITOR, PORCELAN, 150PF, 5%
1.0
C202
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C203
2089-17023-00
CAPACITOR, PORCELAN, 180PF, 5%
1.0
C204
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C205
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C206
2089-17027-00
CAPACITOR, PORCELAN, 270PF, 5%
1.0
C207
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C208
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C209
2089-17015-00
CAPACITOR, PORCELAN, 68PF, 5%
1.0
C211
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C212
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C301
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C302
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C303
2089-17019-00
CAPACITOR, PORCELAN, 100PF, 5%
1.0
C304
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C305
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C306
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C401
2089-17025-00
CAPACITOR, PORCELAN, 220PF, 5%
1.0
C402
2089-17031-00
CAPACITOR, PORCELAN, 390PF, 5%
1.0
C403
2089-17017-00
CAPACITOR, PORCELAN, 82PF, 5%
1.0
C404
2089-17025-00
CAPACITOR, PORCELAN, 220PF, 5%
1.0
C405
2089-17024-00
CAPACITOR, PORCELAN, 200PF, 5%
1.0
C406
2089-17024-00
CAPACITOR, PORCELAN, 200PF, 5%
1.0
C407
2089-17019-00
CAPACITOR, PORCELAN, 100PF, 5%
1.0
C501
2089-17023-00
CAPACITOR, PORCELAN, 180PF, 5%
1.0
C502
2089-17013-00
CAPACITOR, PORCELAN, 56PF, 5%
1.0
C503
2089-17022-00
CAPACITOR, PORCELAN, 150PF, 5%
1.0
C504
2089-17019-00
CAPACITOR, PORCELAN, 100PF, 5%
1.0
C505
2089-17023-00
CAPACITOR, PORCELAN, 180PF, 5%
1.0
C506
2089-17023-00
CAPACITOR, PORCELAN, 180PF, 5%
1.0
C601
2089-17017-00
CAPACITOR, PORCELAN, 82PF, 5%
1.0
C602
2089-17007-00
CAPACITOR, PORCELAN, 22PF, 5%
1.0
C603
2089-17009-00
CAPACITOR, PORCELAN, 30PF, 5%
1.0
B-63
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C604
2089-17022-00
CAPACITOR, PORCELAN, 150PF, 5%
1.0
C605
2089-17013-00
CAPACITOR, PORCELAN, 56PF, 5%
1.0
C606
2089-17027-00
CAPACITOR, PORCELAN, 270PF, 5%
1.0
C701
2089-17013-00
CAPACITOR, PORCELAN, 56PF, 5%
1.0
C702
2089-17019-00
CAPACITOR, PORCELAN, 100PF, 5%
1.0
C703
4017-60012-20
CAPACITOR, PORC. 18PF, 2%
1.0
C704
2089-17017-00
CAPACITOR, PORCELAN, 82PF, 5%
1.0
C706
2089-17017-00
CAPACITOR, PORCELAN, 82PF, 5%
1.0
C707
4017-20181-00
CAPACITOR, 1210, X7R, 100NF, 200V
1.0
C708
4017-20102-00
CAPACITOR, CHIP, 10NF, 200V
1.0
C846
4017-80115-02
CAPACITOR, CHIP, 47UF, 10V
1.0
C848
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C850
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C851
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C852
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C853
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C854
4017-80115-02
CAPACITOR, CHIP, 47UF, 10V
1.0
C855
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C856
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C858
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C860
2089-17013-00
CAPACITOR, PORCELAN, 56PF, 5%
1.0
C861
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C862
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C863
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C864
2089-17033-00
CAPACITOR, PORCELAN, 470PF, 5%
1.0
C865
2089-17029-00
CAPACITOR, PORCELAN, 330PF, 5%
1.0
C866
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C867
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C868
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C869
4017-20181-00
CAPACITOR, 1210, X7R, 100NF, 200V
1.0
C870
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C871
4017-20181-00
CAPACITOR, 1210, X7R, 100NF, 200V
1.0
C872
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C873
4017-80226-00
CAPACITOR, CHIP, TANTALUM, 15UF, 35V
1.0
C875
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C877
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C878
4017-80226-00
CAPACITOR, CHIP, TANTALUM, 15UF, 35V
1.0
C880
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C882
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C884
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
B-64
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C885
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C886
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C887
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C888
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C889
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C895
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C896
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C897
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C898
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C900
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C901
4017-20271-00
CAPACITOR, CHIP, X7R, 10NF, 10%
1.0
C902
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C903
4017-25259-00
CAPACITOR, CHIP, CG, 10PF, 5%
1.0
C904
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C905
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C906
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
CR1
4021-10721-35
DIODE
1.0
CR6
4021-10114-35
DIODE, SCHOTTKY, HSMS2800
1.0
CR7
4021-10114-35
DIODE, SCHOTTKY, HSMS2800
1.0
CR8
2072-21018-00
DIODE, PIN
1.0
CR9
2072-21018-00
DIODE, PIN
1.0
CR10
4021-10721-35
DIODE
1.0
CR11
4021-10721-35
DIODE
1.0
CR13
4021-10403-35
DIODE, RECTIFIER, SCHOTTKY, MBRS360
1.0
CR14
4021-10282-35
DIODE, RECTIFIER
1.0
CR15
4021-10745-35
DIODE, SCHOTTKY
1.0
CR16
4021-10745-35
DIODE, SCHOTTKY
1.0
CR17
4021-10745-35
DIODE, SCHOTTKY
1.0
CR18
4021-10745-35
DIODE, SCHOTTKY
1.0
CR19
4021-10745-35
DIODE, SCHOTTKY
1.0
CR20
4021-10745-35
DIODE, SCHOTTKY
1.0
CR805
4021-10722-35
DIODE, DUAL
1.0
CR806
4021-10721-35
DIODE
1.0
CR809
4021-10513-35
DIODE, SCHOTTKY
1.0
CR810
4021-10114-35
DIODE, SCHOTTKY, HSMS2800
1.0
CR811
4021-10513-35
DIODE, SCHOTTKY
1.0
E1
4033-10178-01
SCREW TERMINAL, PC MOUNT
1.0
E2
4033-10178-01
SCREW TERMINAL, PC MOUNT
1.0
E3
4018-60032-00
BEAD, EMI, 600 OHM, 1.5A
1.0
E6
4018-60032-00
BEAD, EMI, 600 OHM, 1.5A
1.0
B-65
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
E19
4023-00014-00
ARRESTOR
1.0
E26
4018-60032-00
BEAD, EMI, 600 OHM, 1.5A
1.0
E27
4018-60032-00
BEAD, EMI, 600 OHM, 1.5A
1.0
E28
4018-60032-00
BEAD, EMI, 600 OHM, 1.5A
1.0
E29
4018-60032-00
BEAD, EMI, 600 OHM, 1.5A
1.0
K1
2338-31031-00
RELAY, 5V, DPDT
1.0
K101
2338-31031-00
RELAY, 5V, DPDT
1.0
K102
2338-31031-00
RELAY, 5V, DPDT
1.0
K201
2338-31031-00
RELAY, 5V, DPDT
1.0
K202
2338-31031-00
RELAY, 5V, DPDT
1.0
K301
2338-31031-00
RELAY, 5V, DPDT
1.0
K302
2338-31031-00
RELAY, 5V, DPDT
1.0
K401
2338-31031-00
RELAY, 5V, DPDT
1.0
K402
2338-31031-00
RELAY, 5V, DPDT
1.0
K501
2338-31031-00
RELAY, 5V, DPDT
1.0
K502
2338-31031-00
RELAY, 5V, DPDT
1.0
K601
2338-31031-00
RELAY, 5V, DPDT
1.0
K602
2338-31031-00
RELAY, 5V, DPDT
1.0
K701
2338-31031-00
RELAY, 5V, DPDT
1.0
K702
2338-31031-00
RELAY, 5V, DPDT
1.0
L1
4018-10117-00
INDUCTOR, 10UH
1.0
L2
4018-01022-00
COIL, 56UH, 10%
1.0
L3
4018-10117-00
INDUCTOR, 10UH
1.0
L11
4018-16024-00
COIL, CHIP, AIR, 68NH
1.0
L14
4018-10116-00
INDUCTOR, 33UH
1.0
L17
4018-16024-00
COIL, CHIP, AIR, 68NH
1.0
L18
4018-10116-00
INDUCTOR, 33UH
1.0
L19
4018-01022-00
COIL, 56UH, 10%
1.0
L20
4018-10116-00
INDUCTOR, 33UH
1.0
L101
2072-13023-13
COIL, RF, 3.39uH
1.0
L102
2072-13023-14
COIL, RF, 5.20uH
1.0
L201
2072-13023-11
COIL, RF, 2.20uH
1.0
L202
2072-13023-12
COIL, RF, 2.60uH
1.0
L301
2072-13023-09
COIL, RF, 1.35uH
1.0
L302
2072-13023-10
COIL, RF, 1.90uH
1.0
L401
2072-13023-07
COIL, RF, 0.88uH
1.0
L402
2072-13023-08
COIL, RF, 1.12uH
1.0
L501
2072-13023-05
COIL, RF, 0.55uH
1.0
L502
2072-13023-06
COIL, RF, 0.71uH
1.0
L601
2072-13023-03
COIL, RF, 0.55uH
1.0
B-66
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
L602
2072-13023-05
COIL, RF, 0.55uH
1.0
L701
2072-13023-01
COIL, RF, 0.28uH
1.0
L702
2072-13023-01
COIL, RF, 0.28uH
1.0
P2
2072-33016-00
RECEPTACLE, COAX
1.0
P3
2072-33007-00
HEADER, RT, 40 PIN
1.0
P4
2072-33016-00
RECEPTACLE, COAX
1.0
Q1
4021-00302-35
TRANSISTOR, N-CHANNEL, DUAL
1.0
Q2
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q3
4021-06065-35
FET, RF
1.0
Q4
4021-06065-35
FET, RF
1.0
Q5
4021-06061-35
FET, RF
1.0
Q6
2072-21086-00
TRANSISTOR, POWER
1.0
Q7
4021-06061-35
FET, RF
1.0
Q8
4021-07057-35
TRANSISTOR, N-CHANNEL
1.0
Q10
4021-00341-35
TRANSISTOR, PNP
1.0
Q11
2072-21086-00
TRANSISTOR, POWER
1.0
Q12
4021-00415-35
FET, RF
1.0
Q13
4021-00302-35
TRANSISTOR, N-CHANNEL, DUAL
1.0
Q14
4021-07181-35
TRANSISTOR, N-CHANNEL
1.0
Q15
4021-07085-35
TRANSISTOR, P-CHANNEL
1.0
Q16
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q17
4021-00415-35
FET
1.0
Q19
4021-00415-35
FET
1.0
Q20
4021-00341-35
TRANSISTOR, PNP
1.0
Q22
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q23
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q26
4021-07181-35
TRANSISTOR, N-CHANNEL
1.0
Q801
4021-00415-35
FET
1.0
Q802
4021-00341-35
TRANSISTOR, PNP
1.0
Q803
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q805
4021-00415-35
FET
1.0
Q806
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q807
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
R1
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R2
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R4
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R5
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R6
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
R7
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
R8
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
B-67
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R9
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
R11
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R13
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R15
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R18
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R20
4016-23162-10
RESISTOR, CHIP, 0603, 31.6K, 1%
1.0
R21
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R22
4016-60102-00
TRIMPOT, 10K OHM
1.0
R23
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R24
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R25
4016-25119-10
RESISTOR, CHIP, 0603, 51.1, 1%
1.0
R26
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R27
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R28
4016-40479-50
RESISTOR, CHIP, 4.7, 5%, 1W
1.0
R29
4016-14120-10
RESISTOR, CHIP, 412, 1%, 1/8W
1.0
R30
4016-14120-10
RESISTOR, CHIP, 412, 1%, 1/8W
1.0
R31
4016-40479-50
RESISTOR, CHIP, 4.7, 5%, 1W
1.0
R32
4016-14120-10
RESISTOR, CHIP, 412, 1%, 1/8W
1.0
R33
4016-14120-10
RESISTOR, CHIP, 412, 1%, 1/8W
1.0
R34
4016-11002-10
RESISTOR, CHIP, 10.0K, 1%, 1/8W
1.0
R35
4016-11002-10
RESISTOR, CHIP, 10.0K, 1%, 1/8W
1.0
R36
4016-60000-50
RESISTOR, CHIP, 0 OHM, 1/2W
1.0
R39
4016-32900-10
RESISTOR, CHIP, 0.2, 1%, 1W
1.0
R40
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R41
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R43
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R44
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R46
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R47
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R48
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R49
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R50
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R51
4016-24753-10
RESISTOR, CHIP, 0603, 475K, 1%
1.0
R53
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R55
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R57
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R58
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R59
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R60
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R61
4016-23652-10
RESISTOR, 36.5K, 1%, 1/16W
1.0
B-68
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R62
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R63
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R64
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R65
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R66
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R67
4016-60102-00
TRIMPOT, 10K OHM
1.0
R68
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R69
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R70
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R71
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R72
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R73
4016-60102-00
TRIMPOT, 10K OHM
1.0
R75
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R76
4016-21829-10
RESISTOR, CHIP, 0603, 18.2, 1%
1.0
R77
4016-12499-10
RESISTOR, CHIP, 24.9, 1%, 1/8W
1.0
R78
4016-12499-10
RESISTOR, CHIP, 24.9, 1%, 1/8W
1.0
R79
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R80
4016-23010-10
RESISTOR, CHIP, 0603, 301, 1%
1.0
R81
4016-12499-10
RESISTOR, CHIP, 24.9, 1%, 1/8W
1.0
R82
4016-12499-10
RESISTOR, CHIP, 24.9, 1%, 1/8W
1.0
R83
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R85
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R86
4016-12499-10
RESISTOR, CHIP, 24.9, 1%, 1/8W
1.0
R87
4016-12499-10
RESISTOR, CHIP, 24.9, 1%, 1/8W
1.0
R88
4016-24753-10
RESISTOR, CHIP, 0603, 475K, 1%
1.0
R89
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R90
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R91
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R92
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R97
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R98
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R100,
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R101
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R102
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R103
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R104
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R105
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R106
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R107
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R110
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
B-69
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R111
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R112
4016-21502-10
RESISTOR, 15.0K, 1%, 1/16W
1.0
R114
4016-28252-10
RESISTOR, CHIP, 0603, 82.5K, 1%
1.0
R116
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R117
4016-21103-10
RESISTOR, 110K, 1%, 1/16W
1.0
R118
4016-21502-10
RESISTOR, 15.0K, 1%, 1/16W
1.0
R119
4016-21502-10
RESISTOR, 15.0K, 1%, 1/16W
1.0
R120
4016-25111-10
RESISTOR, 5.11K, 1%, 1/16W
1.0
R121
4016-29093-10
RESISTOR, 909K, 1%, 1/16W
1.0
R123
4016-21502-10
RESISTOR, 15.0K, 1%, 1/16W
1.0
R124
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R125
4016-22432-10
RESISTOR, 24.3K, 1%, 1/16W
1.0
R127
4016-27152-10
RESISTOR, 71.5K, 1%, 1/16W
1.0
R128
4016-22432-10
RESISTOR, 24.3K, 1%, 1/16W
1.0
R129
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
R130
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
R131
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
R132
4016-21008-50
RESISTOR, CHIP, 0603, 1 OHM, 5%
1.0
R133
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R134
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R135
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R136
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R137
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R138
4016-22432-10
RESISTOR, 24.3K, 1%, 1/16W
1.0
R143
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R144
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R145
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R148
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R149
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R150,
4016-22152-10
RESISTOR, 21.5K, 1%, 1/16W
1.0
R151
4016-28251-10
RESISTOR, 8.25K, 1%, 1/16W
1.0
R153
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R154
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R155
4016-22153-10
RESISTOR, CHIP, 0603, 215K, 1%
1.0
R156
4016-80080-00
RESISTOR, CHIP, MF, 0.02E, 0.25W
1.0
R157
4016-80080-00
RESISTOR, CHIP, MF, 0.02E, 0.25W
1.0
R158
4016-22002-01
RESISTOR, 20.0K, 0.1%, 1/16
1.0
R159
4016-22002-01
RESISTOR, 20.0K, 0.1%, 1/16
1.0
R161
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R162
4016-27503-10
RESISTOR, 750K, 1%, 1/16W
1.0
B-70
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R163
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R164
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R165
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R166
4016-22152-10
RESISTOR, 21.5K, 1%, 1/16W
1.0
R167
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R171
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R172
4016-21502-10
RESISTOR, 15.0K, 1%, 1/16W
1.0
R173
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R174
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R175
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R176
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R177
4016-29093-10
RESISTOR, 909K, 1%, 1/16W
1.0
R178
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R179
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R818
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R819
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R822
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R823
4016-24752-10
RESISTOR, 47.5K, 1%, 1/16W
1.0
R829
4016-22219-10
RESISTOR, 22.1, 1%, 1/16W
1.0
R830
4016-21501-10
RESISTOR, 1.50K, 1%, 1/16W
1.0
R833
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R835
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R836
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R837
4016-21211-10
RESISTOR, 1.21K, 1%, 1/16W
1.0
R839
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R840
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R841
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R842
4016-21822-10
RESISTOR, 18.2K, 1%, 1/16W
1.0
R843
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R844
4016-22432-10
RESISTOR, 24.3K, 1%, 1/16W
1.0
R845
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R846
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R848
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R849
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R850
4016-22439-10
RESISTOR, 24.3, 1%, 1/16W
1.0
R852
4016-28669-10
RESISTOR, CHIP, 0603, 86.6, 1%
1.0
R855
4016-22152-10
RESISTOR, 21.5K, 1%, 1/16W
1.0
R857
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R860
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R861
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
B-71
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R862
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R863
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R865
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R867
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R868
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R870
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R871
4016-29761-10
RESISTOR, CHIP, 9.76K, 1%, /16W
1.0
R872
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R874
4016-21004-10
RESISTOR, 1.0M, 1%, 1/16W
1.0
R875
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R876
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R881
4016-24750-10
RESISTOR, 475, 1%, 1/16W
1.0
R883
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R884
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R885
4016-28251-10
RESISTOR, 8.25K, 1%, 1/16W
1.0
R886
4016-28251-10
RESISTOR, 8.25K, 1%, 1/16W
1.0
R887
4016-22742-10
RESISTOR, 27.4K, 1%, 1/16W
1.0
R888
4016-28252-10
RESISTOR, CHIP, 0603, 82.5K, 1%
1.0
R891
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R893
4016-25621-10
RESISTOR, CHIP, 0603, 5.62K, 1%
1.0
R894
4016-22152-10
RESISTOR, 21.5K, 1%, 1/16W
1.0
R895
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R901
4016-24752-10
RESISTOR, 47.5K, 1%, 1/16W
1.0
R902
4016-28252-10
RESISTOR, CHIP, 0603, 82.5K, 1%
1.0
R903
4016-25622-10
RESISTOR, CHIP, 0603, 56.2K, 1%
1.0
R904
4016-23321-10
RESISTOR, 3.32K, 1%, 1/16W
1.0
R905
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R906
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R907
4016-22152-10
RESISTOR, 21.5K, 1%, 1/16W
1.0
R908
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R909
4016-24753-10
RESISTOR, CHIP, 0603, 475K, 1%
1.0
R910
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R911
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R912
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R913
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R914
4016-21503-10
RESISTOR, 150K, 1%, 1/16W
1.0
R915
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R916
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R917
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R918
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
B-72
MM-E 2072-09333-00
Table B-4. HI POWER Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R919
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R921
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R922
4016-21820-10
RESISTOR, 182, 1%, 1/16W
1.0
R923
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R924
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R928
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
RT1
4016-91495-00
THERMISTOR. NTC, 1K
1.0
RT2
4016-91494-00
THERMISTOR, NTC, 100K
1.0
RT3
4016-91494-00
THERMISTOR, NTC, 100K,
1.0
T1
2072-13004-00
RF POWER TRANSFORMER
1.0
T2
2072-13006-00
RF TRANSFORMER
1.0
T3
2089-13023-00
TRANSFORMER
1.0
T4
2072-13007-00
COIL, TOROID 2583727K-0
1.0
U1
4021-22155-54
VOLTAGE REGULATOR, 3.3V
1.0
U2
4021-22138-84
VOLTAGE REGULATOR, ADJUSTABLE
1.0
U3
4021-00039-35
TRANSISTOR, NPN, DARLINGTON, ARRAY, ULQ2003
1.0
U4
4021-60063-50
HCMOS, SHIFT REGISTER, 74HC595
1.0
U5
4021-20311-54
OPERATIONAL AMPLIFIER, DUAL
1.0
U6
4021-20127-54
VOLTAGE REGULATOR, ADJUSTABLE
1.0
U9
4021-20504-54
COMPARATOR, DUAL
1.0
U10
4021-20311-54
OPERATIONAL AMPLIFIER, DUAL
1.0
U11
4021-22122-74
VOLTAGE REGULATOR
1.0
U12
2388-21830-00
IC, 14053
1.0
U13
2072-21043-00
OPERATIONAL AMPLIFIER, QUAD
1.0
U14
4021-20311-54
OPERATIONAL AMPLIFIER, DUAL
1.0
U15
4021-20311-54
OPERATIONAL AMPLIFIER, DUAL
1.0
U16
4021-20127-54
VOLTAGE REGULATOR, ADJUSTABLE
1.0
U19
4021-41708-35
2-IN AND GATE, SINGLE
1.0
U20
4021-22307-64
DC/DC CONTROLLER
1.0
U21
4021-22138-84
VOLTAGE REGULATOR, ADJUSTABLE
1.0
U22
4021-44074-64
DUAL D-FLIPFLOP
1.0
U23
4021-22021-64
CONTROLLER OVERVOLT PROTECTION
1.0
VR2
4021-10585-35
TVS, UNI-DIRECTIONAL
1.0
VR3
4021-20129-54
REFERENCE VOLTAGE, 5.0V
1.0
VR4
4021-20129-54
REFERENCE VOLTAGE, 5.0V
1.0
VR801
4021-20129-54
REFERENCE VOLTAGE, 5.0V
1.0
VR802
4021-20129-54
REFERENCE VOLTAGE, 5.0V
1.0
VR803
4021-20129-54
REFERENCE VOLTAGE, 5.0V
1.0
B-73
MM-E 2072-09333-00
Figure B-4.A. HI POWER Module, Identification of Components (Sheet 1 of 3)
B-74
MM-E 2072-09333-00
COMPONENT SIDE
Figure B-4.B. HI POWER Module, Identification of Components (Sheet 2 of 3)
B-75/B-76
MM-E 2072-09333-00
PRINT SIDE
Figure B-4.C. HI POWER Module, Identification of Components (Sheet 3 of 3)
B-77/B-78
MM-E 2072-09333-00
Table B-5. Dash Front Panel, Control Head Assembly, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-90833-00
DASH FRONT PANEL ASSY
Figure B-5
BL1
2072-45001-10
FRONT PANEL
1.0
BL2
2072-95211-00
DASH FRONT PANEL MODULE
1.0
BL3
2072-45004-00
KEYPAD
1.0
BL4
2072-90115-00
DISPLAY ASSY
1.0
BL5
2072-45007-00
WINDOW, LC
1.0
BL6
2072-45008-00
HOLDER SPEAKER
1.0
BL7
2072-45020-00
PLUG
1.0
BL8
2072-31050-00
SPEAKER (MIRS) 5002236P
1.0
BL9
4052-15003-00
SCREW, CROSS RECESSED, PAN HEAD
13.0
BL10
2072-45030-00
SCREW, M2X6, PH, BLACK
6.0
BL11
2072-45036-00
INSERT
1.0
BL12
2072-56010-00
GASKET, SPEAKER ROGG. 32
1.0
BL13
2072-45033-00
RF SHIELD
1.0
BL14
2072-45034-00
SPACER
11.0
BL15
2072-90150-00
SPEAKER CABLE
1.0
Figure B-5. Dash Front Panel, Control Head Assembly
B-79
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-95211-00
DASH FRONT PANEL MODULE
BL1
2072-32211-00
FRONT PANEL PCB
1.0
BL2
2072-45003-00
STUD FOR MICOM-Z
4.0
C1
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C2
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C3
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C4
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C5
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C6
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C7
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C8
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C9
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C10
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C11
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C12
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C13
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C14
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C15
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C16
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C19
4017-25265-10
CAPACITOR, CHIP, NP0, 33PF, 1%
1.0
C20
4017-25265-10
CAPACITOR, CHIP, NP0, 33PF, 1%
1.0
C21
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C22
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C23
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C24
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C25
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C26
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C27
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C32
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C33
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C35
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C36
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C39
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C42
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C43
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C44
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C45
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C46
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C47
4017-20161-00
CAPACITOR, CHIP, X7R, 1UF, 10V
1.0
C53
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
B-80
Figure B-6
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C54
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C59
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C60
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C61
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C62
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C63
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C64
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C65
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C66
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C67
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C68
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C69
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C70
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C71
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C72
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C73
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C74
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C76
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C78
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C79
4017-80304-00
CAPACITOR, 47UF, 35V
1.0
C80
4017-20191-00
CAPACITOR, 1210, X7R, 1UF, 100V
1.0
C81
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C82
4017-20191-00
CAPACITOR, 1210, X7R, 1UF, 100V
1.0
C83
4017-80304-00
CAPACITOR, 47UF, 35V
1.0
C84
2089-17202-00
CAPACITOR, 1812, X7R, 15UF, 25V
1.0
C85
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C86
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C87
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C88
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C89
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C90
4017-25286-00
CAPACITOR, CHIP, C0G, 100PF, 1%
1.0
C91
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C92
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C93
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C94
4017-25275-00
CAPACITOR, CHIP, CG, 220PF, 5%
1.0
C95
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C96
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C97
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C98
2089-17202-00
CAPACITOR, 1812, X7R, 15UF, 25V
1.0
C99
2089-17202-00
CAPACITOR, 1812, X7R, 15UF, 25V
1.0
B-81
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C121
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C501
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C502
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C503
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C504
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C505
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C506
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C513
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C544
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C545
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C550
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C551
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C552
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C553
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C554
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C555
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
CR2
4021-10403-35
DIODE, RECTIFIER, SCHOTTKY, MBRS360
1.0
CR501
4021-10098-35
DIODE, SWITCHING
1.0
DS1
4021-80052-35
LED, GREEN
1.0
DS2
4021-80052-35
LED, GREEN
1.0
DS3
4021-80052-35
LED, GREEN
1.0
DS4
4021-80052-35
LED, GREEN
1.0
DS5
4021-80052-35
LED, GREEN
1.0
DS6
4021-80052-35
LED, GREEN
1.0
DS7
4021-80052-35
LED, GREEN
1.0
DS8
4021-80052-35
LED, GREEN
1.0
DS9
4021-80052-35
LED, GREEN
1.0
DS10
4021-80052-35
LED, GREEN
1.0
DS11
4021-80052-35
LED, GREEN
1.0
DS12
4021-80052-35
LED, GREEN
1.0
DS13
4021-80052-35
LED, GREEN
1.0
DS14
4021-80052-35
LED, GREEN
1.0
DS15
4021-80052-35
LED, GREEN
1.0
DS16
4021-80052-35
LED, GREEN
1.0
DS17
4021-80052-35
LED, GREEN
1.0
DS18
4021-80052-35
LED, GREEN
1.0
DS19
4021-80052-35
LED, GREEN
1.0
DS20
4021-80052-35
LED, GREEN
1.0
DS21
4021-80052-35
LED, GREEN
1.0
DS22
4021-80052-35
LED, GREEN
1.0
B-82
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
DS23
4021-80052-35
LED, GREEN
1.0
DS24
4021-80052-35
LED, GREEN
1.0
DS25
4021-80052-35
LED, GREEN
1.0
DS26
4021-80052-35
LED, GREEN
1.0
DS27
4021-80052-35
LED, GREEN
1.0
E19
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
E20
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E26
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
E27
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E28
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E29
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E502
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
J3
4033-60109-00
CONNECTOR, FPC/FFC, 40S
1.0
J4
4033-53021-00
SD MEMORY CARD CONNECTOR
1.0
L1
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L2
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L3
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L4
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L5
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L6
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L7
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L8
4018-10116-00
INDUCTOR, 33UH
1.0
P1
4033-51109-01
CONNECTOR, 2 PIN, 1.25mm
1.0
P2
4033-51109-01
CONNECTOR, 2 PIN, 1.25mm
1.0
P3
4033-51201-01
HEADER, 24PIN
1.0
P4
4033-51007-01
HEADER, 2PIN
1.0
P5
4033-50225-01
STRIP, DOUBLE ROW, 5 PIN
1.0
P6
2072-33325-00
CONNECTOR, MICROPHONE
1.0
P7
4033-50212-01
STRIP, SINGLE ROW, 2 PIN
1.0
Q1
4021-00183-35
MOSFET, P-CHANNEL
1.0
Q2
4021-00299-35
MOSFET, N-CHANNEL
1.0
Q3
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q4
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q7
4021-00415-35
FET
1.0
Q501
4021-00415-35
FET
1.0
Q502
4021-00415-35
FET
1.0
Q503
4021-00341-35
TRANSISTOR, PNP
1.0
Q504
4021-00341-35
TRANSISTOR, PNP
1.0
Q505
4021-00415-35
FET
1.0
Q506
4021-00415-35
FET
1.0
B-83
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
Q507
4021-00415-35
FET
1.0
R1
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R2
4016-11009-10
RESISTOR, CHIP, 10.0K, 1%, 1/8W
1.0
R3
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R12
4016-21004-10
RESISTOR, 1.0M, 1%, 1/16W
1.0
R13
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R14
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R15
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R16
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R17
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R18
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R19
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R20
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R21
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R22
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R23
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R24
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R25
4016-21212-10
RESISTOR, 12.1K, 1%, 1/16W
1.0
R26
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R27
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R28
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R29
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R30
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R31
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R32
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R33
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R34
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R35
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R36
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R37
4016-21004-10
RESISTOR, 1.0M, 1%, 1/16W
1.0
R38
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R39
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R40
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R41
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R42
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R43
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R44
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
B-84
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R45
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R46
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R47
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R48
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R49
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R50
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R51
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R52
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R53
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R54
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R55
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R56
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R57
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R58
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R59
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R60
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R61
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R62
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R63
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R64
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R65
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R66
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R67
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R68
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R69
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R70
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R71
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R72
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R73
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R74
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R75
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R76
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R77
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R78
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R79
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R80
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R81
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R82
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R83
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R84
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
B-85
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R85
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R86
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R87
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R88
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R89
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R90
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R91
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R92
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R93
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R94
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R95
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R96
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R97
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R98
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R99
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R100
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R101
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R102
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R103
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R104
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R105
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R106
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R107
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R108
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R109
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R110
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R111
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R112
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R113
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R114
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R115
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R116
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R117
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R118
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R119
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R120
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R121
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R122
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R123
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R124
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
B-86
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R125
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R126
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R127
4016-11500-10
RESISTOR, CHIP, 150, 1%, 1/8W
1.0
R128
4016-11500-10
RESISTOR, CHIP, 150, 1%, 1/8W
1.0
R133
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R137
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R138
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R139
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R140
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R141
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R142
4016-11500-10
RESISTOR, CHIP, 150, 1%, 1/8W
1.0
R143
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R144
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R145
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R146
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R151
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R152
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R155
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R156
4016-10519-50
RESISTOR, CHIP, 5.1, 5%, 1/8W
1.0
R157
4016-13011-10
RESISTOR, CHIP, 3.01K, 1%, 1/8W
1.0
R158
4016-14751-10
RESISTOR, CHIP, 4.75K, 1%, 1/8W
1.0
R159
4016-15111-10
RESISTOR, CHIP, 5.11K, 1%, 1/8W
1.0
R160
4016-25110-10
RESISTOR, 511, 1%, 1/16W
1.0
R166
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R167
4016-14750-10
RESISTOR, CHIP, 475, 1%, 1/8W
1.0
R170
4016-23329-10
RESISTOR, CHIP, 0603, 33.2, 1%
1.0
R177
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R178
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R181
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R186
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R187
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R193
4016-24121-10
RESISTOR, 4.12K, 1%, 1/16W
1.0
R194
4016-23012-10
RESISTOR, CHIP, 0603, 30.1K, 1%
1.0
R195
4016-31900-10
RESISTOR, CHIP, 0.1, 1%, 1W
1.0
R196
4016-31900-10
RESISTOR, CHIP, 0.1, 1%, 1W
1.0
R197
4016-23162-10
RESISTOR, CHIP, 0603, 31.6K, 1%
1.0
R198
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R201
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R202
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R203
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
B-87
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R204
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R206
4016-25111-10
RESISTOR, 5.11K, 1%, 1/16W
1.0
R207
4016-25111-10
RESISTOR, 5.11K, 1%, 1/16W
1.0
R212
4016-22213-10
RESISTOR, 221K, 1%, 1/16W
1.0
R213
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R214
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R215
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R220
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R221
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R222
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R223
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R226
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R229
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R233
4016-14129-10
RESISTOR, CHIP, 41.2, 1%, 1/8W
1.0
R502
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R507
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R508
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R509
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R512
4016-25110-10
RESISTOR, 511, 1%, 1/16W
1.0
R513
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R514
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R515
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R516
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R517
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R518
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R519
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R520
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R521
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R522
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R523
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R524
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R525
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R527
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R528
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R529
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R530
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R531
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R532
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R533
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R535
4016-60000-50
RESISTOR, CHIP, 0 OHM, 1/2W
1.0
B-88
MM-E 2072-09333-00
Table B-6. CONTROL HEAD Module (Dash Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R536
4016-18251-10
RESISTOR, CHIP, 8.25K, 1%, 1/8W
1.0
R538
4016-24029-10
RESISTOR, CHIP, 0603, 40.2, 1%
1.0
R539
4016-23329-10
RESISTOR, CHIP, 0603, 33.2, 1%
1.0
R541
4016-28669-10
RESISTOR, CHIP, 0603, 86.6, 1%
1.0
R563
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R569
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R581
4016-12671-10
RESISTOR, CHIP, 2.67K, 1%, 1/8W
1.0
R582
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R583
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R584
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R601
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R602
4016-25110-10
RESISTOR, 511, 1%, 1/16W
1.0
RT1
4016-91103-20
THERMISTOR, NTC
1.0
SW26
2036-31016-00
SWITCH, DPDT, LOCKING
1.0
T1
4018-10178-00
TRANSFORMER, DUAL WINDING, SHIELDED
1.0
U1
4021-50043-64
MICROCONTROLLER, 8051
1.0
U3
4021-31132-50
SCHMITT TRIGGER, 74HC132
1.0
U4
4021-22111-54
VOLTAGE REGULATOR, 3.3V
1.0
U5
4021-22108-54
VOLTAGE REGULATOR, 3.0V
1.0
U6
4021-22020-64
PWM CONTROLLER
1.0
U7
4021-20504-54
COMPARATOR, DUAL
1.0
VR1
4021-10471-35
ZENER, 4.3V
1.0
VR2
4021-10471-35
ZENER, 4.3V
1.0
VR501
4021-10810-35
ZENER, 3.6V
1.0
VR502
4021-10471-35
ZENER, 4.3V
1.0
VR503
4021-10471-35
ZENER, 4.3V
1.0
VR504
4021-10471-35
ZENER, 4.3V
1.0
VR505
4021-10471-35
ZENER, 4.3V
1.0
VR506
4021-10471-35
ZENER, 4.3V
1.0
VR507
4021-10471-35
ZENER, 4.3V
1.0
VR508
4021-10471-35
ZENER, 4.3V
1.0
VR509
4021-10471-35
ZENER, 4.3V
1.0
VR510
4021-10471-35
ZENER, 4.3V
1.0
VR511
4021-10471-35
ZENER, 4.3V
1.0
Y1
4022-50026-00
CRYSTAL QUARTZ, 7.3728 MHz
1.0
B-89
MM-E 2072-09333-00
Intentionally Left Blank
B-90
MM-E 2072-09333-00
COMPONENT SIDE
PRINT SIDE
Figure B-6. CONTROL HEAD Module (Dash Mount Version), Identification of Components
B-91/B-92
MM-E 2072-09333-00
Section II. MICOM-Z TRUNK-MOUNT VERSION
Table B-7. Micom-Z Assembly, Trunk Version, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-90719-20
MICOM-Z ASSEMBLY, TRUNK
BL1
2072-95170-10
HI POWER MODULE
Figure B-7
1.0
BL2
2072-45029-10
BLANK PANEL
1.0
BL3
2072-90832-00
LORD ASSY
1.0
BL5
4053-10013-16
WASHER, SPRING, CRS, PASSIVATED, #10
1.0
BL6
4053-00037-16
WASHER, FLAT, CRS, PASSIVATED, .219
2.0
BL7
4051-00011-16
NUT, HEX, CRS, PASSIVATED, #10-32
1.0
BL8
2089-41660-00
KNOB
1.0
BL10
4053-10012-16
WASHER, SPRING, CRS, BLACK, #8
8.0
BL12
4053-16001-00
WASHER, SPRING, LOCK, M3
1.0
BL13
2072-45002-10
REAR PANEL
1.0
BL14
2072-72108-00
LABEL DISASSEMBLY
1.0
BL15
2072-72109-00
LABEL DISASSEMBLY
1.0
BL16
2072-09296-00
CABLE COAX, LORD-H.P PA
2.0
BL18
2072-90160-00
CABLE, FLAT, TO CHASSIS
1.0
BL19
2072-34007-00
CABLE, FLAT, STRIP, GPS
1.0
BL20
2072-90890-00
GPS ANTENNA TRANSITION
1.0
BL21
2072-90900-10
GPS CARD
1.0
BL22
4052-12019-88
SCREW, PH PHIL CRES, M 3X
9.0
BL23
2072-45011-00
BOX, MICOM-Z
1.0
BL24
4053-15002-00
WASHER, FLAT
1.0
BL25
2201-63202-03
HEATSINK COMPOUND, DC340
.200
BL26
2072-45041-00
LOCK PAD
2.0
BL27
4052-60248-88
SCREW, PH PHIL CRES, M 3X
1.0
BL28
2072-93405-00
INTERNAL CABLE
1.0
BL30
4052-60247-88
SCREW, CAP SOCK CRES, M 4
8.0
BL31
2072-56022-00
SPACER FOR CONNECTOR SUB-D
4.0
BL32
4052-30011-16
SCREW, #10-32X3/4
1.0
BL33
2072-45042-00
PLUG COVER, D-TYPE, 9 PIN
1.0
BL34
2072-45031-00
SCREW, M3X4, FH, BLACK
8.0
BL35
2072-45013-00
COVER
1.0
BL36
2072-09295-00
CABLE, FLAT, LORD-H.P
1.0
BL37
2072-90831-00
FRONT PANEL ASSY, TRUNK
1.0
BL38
2072-95212-00
MODULE INTERCONNECTION
1.0
BL39
2072-44015-00
BUSHING FOR TUNER
1.0
BL40
2072-33019-00
INSULATOR TO-220 CHAS, 1480075
1.0
BL41
4053-00068-16
WASHER, FLAT, CRS, PASSIVATED, .143
1.0
BL42
2072-09727-00
CABLE PANEL RADIO 16
1.0
BL44
4052-60246-88
SCREW, PH PHIL CRES, M 3X
3.0
B-93
MM-E 2072-09333-00
Figure B-7.A. Micom-Z Assembly, Trunk Version (Sheet 1 of 2)
B-94
MM-E 2072-09333-00
Figure B-7.B. Micom-Z Assembly, Trunk Version (Sheet 2 of 2)
B-95
MM-E 2072-09333-00
Table B-8. LORD Assembly, Parts List
The LORD assembly used in the Micom-Z trunk version is identical to the LORD assembly used in
the Micom-Z dash version.
See page B-4 to page B-58.
B-96
MM-E 2072-09333-00
Table B-9. HI POWER Module, Parts List
The HI POWER module used in the Micom-Z trunk version is identical to the HI POWER module
used in the Micom-Z dash version.
See page B-59 to page B-78.
B-97
MM-E 2072-09333-00
Table B-10. Trunk Front Panel, Control Head Assembly, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-90831-00
FRONT PANEL TRUNK ASSY
BL1
2072-45015-10
FRONT PANEL
1.0
BL2
2072-95211-10
FRONT PANEL MODULE TRUNK
1.0
BL3
2072-45004-00
KEYPAD
1.0
BL4
2072-90115-00
DISPLAY ASSY
1.0
BL5
2072-45007-00
WINDOW LC
1.0
BL6
2072-45036-00
INSERT
1.0
BL7
2072-45020-00
PLUG
1.0
BL8
2072-45027-10
REAR PANEL
1.0
BL9
4052-15003-00
SCREW, CROSS RECESSED, PAN HEAD
9.0
BL10
2072-45030-00
SCREW, M2X6 PH BLACK
6.0
BL12
4053-10012-15
WASHER, SPRING, CRS, BLACK, #8
4.0
BL13
2072-48180-00
SCREW, CAPTIVE FOR CHASSIS
4.0
Figure B-8. Trunk Front Panel, Control Head Assembly
B-98
Figure B-8
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
2072-95211-10
FRONT PANEL MODULE TRUNK
Figure B-9
BL1
2072-32211-00
FRONT PANEL PCB
1.0
BL2
2072-45003-00
STUD FOR MICOM-Z
4.0
C1
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C2
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C3
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C4
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C5
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C6
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C7
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C8
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C9
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C10
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C11
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C12
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C13
4017-20153-00
CAPACITOR, CHIP, CERAMIC, 2.2UF, 25V
1.0
C14
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C15
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C16
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C19
4017-25265-10
CAPACITOR, CHIP, NP0, 33PF, 1%
1.0
C20
4017-25265-10
CAPACITOR, CHIP, NP0, 33PF, 1%
1.0
C21
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C22
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C23
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C24
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C25
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C26
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C27
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C32
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C33
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C35
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C36
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C39
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C42
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C43
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C44
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C45
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C46
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C47
4017-20161-00
CAPACITOR, CHIP, X7R, 1UF, 10V
1.0
C53
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
B-99
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C54
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C59
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C60
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C61
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C62
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C63
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C64
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C65
4017-25271-00
CAPACITOR, CHIP, CG, 100PF, 5%
1.0
C66
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C67
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C68
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C69
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C70
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C71
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C72
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C73
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C74
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C76
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C78
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C79
4017-80304-00
CAPACITOR, 47UF, 35V
1.0
C80
4017-20191-00
CAPACITOR, 1210, X7R, 1UF, 100V
1.0
C81
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C82
4017-20191-00
CAPACITOR, 1210, X7R, 1UF, 100V
1.0
C83
4017-80304-00
CAPACITOR, 47UF, 35V
1.0
C84
2089-17202-00
CAPACITOR, 1812, X7R, 15UF, 25V
1.0
C85
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C86
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C87
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C88
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C89
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C90
4017-25286-00
CAPACITOR, CHIP, C0G, 100PF, 1%
1.0
C91
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C92
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C93
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C94
4017-25275-00
CAPACITOR, CHIP, CG, 220PF, 5%
1.0
C95
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C96
4017-25263-10
CAPACITOR, CHIP, NP0, 22PF, 1%
1.0
C97
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C98
2089-17202-00
CAPACITOR, 1812, X7R, 15UF, 25V
1.0
C99
2089-17202-00
CAPACITOR, 1812, X7R, 15UF, 25V
1.0
B-100
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
C121
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C501
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C502
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C503
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C504
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C505
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C506
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C507
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C508
4017-20151-00
CAPACITOR, CHIP, X7R, 100NF, 25V
1.0
C509
4017-20151-00
CAPACITOR, CHIP, X7R, 100NF, 25V
1.0
C510
4017-80126-02
CAPACITOR, CHIP, TANTALUM, 15UF, 16V
1.0
C511
4017-20191-00
CAPACITOR, 1210, X7R, 1UF, 100V
1.0
C512
4017-80308-00
CAPACITOR, 22UF, 35V
1.0
C513
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C514
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C515
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C516
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C517
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C518
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C519
4017-80127-02
CAPACITOR, CHIP, TANTALUM, 33UF, 10V
1.0
C520
4017-25277-00
CAPACITOR, CHIP, CG, 330PF, 5%
1.0
C521
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C522
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C523
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C524
4017-20201-00
CAPACITOR, CHIP, X7R, 470NF, 16V
1.0
C525
4017-80102-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 10V
1.0
C526
4017-80102-02
CAPACITOR, CHIP, TANTALUM, 4.7UF, 10V
1.0
C527
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C528
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C529
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C530
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C531
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C532
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C533
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C534
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C535
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C536
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C537
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C538
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C539
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
B-101
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
C540
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C541
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C542
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C543
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C544
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C545
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C546
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C547
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C548
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C549
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C550
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C551
4017-20192-00
CAPACITOR, 1210, X7R, 4.7UF, 50V
1.0
C552
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C553
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C554
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C555
4017-20578-00
CAPACITOR, CHIP, 0402, 100NF
1.0
C556
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C557
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C558
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C559
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C601
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C602
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
CR2
4021-10403-35
DIODE, RECTIFIER, SCHOTTKY, MBRS360
1.0
CR501
4021-10098-35
DIODE, SWITCHING
1.0
DS1
4021-80052-35
LED, GREEN
1.0
DS2
4021-80052-35
LED, GREEN
1.0
DS3
4021-80052-35
LED, GREEN
1.0
DS4
4021-80052-35
LED, GREEN
1.0
DS5
4021-80052-35
LED, GREEN
1.0
DS6
4021-80052-35
LED, GREEN
1.0
DS7
4021-80052-35
LED, GREEN
1.0
DS8
4021-80052-35
LED, GREEN
1.0
DS9
4021-80052-35
LED, GREEN
1.0
DS10
4021-80052-35
LED, GREEN
1.0
DS11
4021-80052-35
LED, GREEN
1.0
DS12
4021-80052-35
LED, GREEN
1.0
DS13
4021-80052-35
LED, GREEN
1.0
DS14
4021-80052-35
LED, GREEN
1.0
DS15
4021-80052-35
LED, GREEN
1.0
DS16
4021-80052-35
LED, GREEN
1.0
B-102
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
DS17
4021-80052-35
LED, GREEN
1.0
DS18
4021-80052-35
LED, GREEN
1.0
DS19
4021-80052-35
LED, GREEN
1.0
DS20
4021-80052-35
LED, GREEN
1.0
DS21
4021-80052-35
LED, GREEN
1.0
DS22
4021-80052-35
LED, GREEN
1.0
DS23
4021-80052-35
LED, GREEN
1.0
DS24
4021-80052-35
LED, GREEN
1.0
DS25
4021-80052-35
LED, GREEN
1.0
DS26
4021-80052-35
LED, GREEN
1.0
DS27
4021-80052-35
LED, GREEN
1.0
E19
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
E20
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E26
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
E27
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E28
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E29
4018-60030-00
BEAD, EMI, 75 OHM, 200mA
1.0
E501
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
E502
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
E601
4018-60017-00
BEAD, EMI, 60 OHM, 500mA
1.0
J3
4033-60109-00
CONNECTOR FPC/FFC, 40S
1.0
J4
4033-53021-00
SD MEMORY CARD CONNECTOR
1.0
L1
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L2
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L3
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L4
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L5
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L6
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L7
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L8
4018-10116-00
INDUCTOR, 33UH
1.0
L501
4018-10202-00
INDUCTOR, 10UH
1.0
L502
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L503
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L504
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L505
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L506
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L507
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L508
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L509
4018-12052-00
COIL, FIXED, 4.7UH
1.0
P2
4033-51109-01
CONNECTOR, 2 PIN, 1.25mm
1.0
B-103
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
P4
4033-51007-01
HEADER, 2 PIN
1.0
P5
4033-50225-01
STRIP, DOUBLE ROW, 5 PIN
1.0
P6
2072-33325-00
CONNECTOR, MIC
1.0
P7
4033-50212-01
STRIP, SINGLE ROW, 2 PIN
1.0
P501
4033-51315-00
CONNECTOR, HEADER, DUAL ROW, 16 PIN
1.0
Q1
4021-00183-35
MOSFET, P-CHANNEL
1.0
Q2
4021-00299-35
MOSFET, N-CHANNEL
1.0
Q3
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q4
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
Q7
4021-00415-35
FET
1.0
Q501
4021-00415-35
FET
1.0
Q502
4021-00415-35
FET
1.0
Q503
4021-00341-35
TRANSISTOR, PNP
1.0
Q504
4021-00341-35
TRANSISTOR, PNP
1.0
Q505
4021-00415-35
FET
1.0
Q506
4021-00415-35
FET
1.0
Q507
4021-00415-35
FET
1.0
Q508
4021-00202-35
TRANSISTOR, NPN, MMBT2222A
1.0
R1
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R2
4016-11009-10
RESISTOR, CHIP, 10.0K, 1%, 1/8W
1.0
R3
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R4
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R5
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9
4016-22210-10
RESISTOR, 221, 1%, 1/16W
1.0
R12
4016-21004-10
RESISTOR, 1.0M, 1%, 1/16W
1.0
R13
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R14
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R15
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R16
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R17
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R18
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R19
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R20
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R21
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R22
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R23
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R24
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R25
4016-21212-10
RESISTOR, 12.1K, 1%, 1/16W
1.0
R26
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R27
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
B-104
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R28
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R29
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R30
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R31
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R32
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R33
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R34
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R35
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R36
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R37
4016-21004-10
RESISTOR, 1.0M, 1%, 1/16W
1.0
R38
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R39
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R40
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R41
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R42
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R43
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R44
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R45
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R46
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R47
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R48
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R49
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R50
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R51
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R52
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R53
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R54
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R55
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R56
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R57
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R58
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R59
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R60
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R61
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R62
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R63
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R64
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R65
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R66
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R67
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
B-105
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R68
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R69
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R70
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R71
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R72
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R73
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R74
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R75
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R76
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R77
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R78
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R79
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R80
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R81
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R82
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R83
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R84
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R85
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R86
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R87
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R88
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R89
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R90
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R91
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R92
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R93
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R94
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R95
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R96
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R97
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R98
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R99
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R100
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R101
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R102
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R103
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R104
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R105
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R106
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R107
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
B-106
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R108
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R109
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R110
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R111
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R112
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R113
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R114
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R115
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R116
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R117
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R118
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R119
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R120
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R121
4016-51002-10
RESISTOR, CHIP, MF, 10K, 0.06W
1.0
R122
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R123
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R124
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R125
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R126
4016-21500-10
RESISTOR, CHIP, MF, 150E, 0.063W
1.0
R127
4016-11500-10
RESISTOR, CHIP, 150, 1%, 1/8W
1.0
R128
4016-11500-10
RESISTOR, CHIP, 150, 1%, 1/8W
1.0
R133
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R137
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R138
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R139
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R140
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R141
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R142
4016-11500-10
RESISTOR, CHIP, 150, 1%, 1/8W
1.0
R143
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R144
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R145
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R146
4016-25112-10
RESISTOR, 51.1K, 1%, 1/16W
1.0
R151
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R152
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R155
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R156
4016-10519-50
RESISTOR, CHIP, 5.1, 5%, 1/8W
1.0
R157
4016-13011-10
RESISTOR, CHIP, 3.01K, 1%, 1/8W
1.0
R158
4016-14751-10
RESISTOR, CHIP, 4.75K, 1%, 1/8W
1.0
R159
4016-15111-10
RESISTOR, CHIP, 5.11K, 1%, 1/8W
1.0
R160
4016-25110-10
RESISTOR, 511, 1%, 1/16W
1.0
B-107
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R166
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R167
4016-14750-10
RESISTOR, CHIP, 475, 1%, 1/8W
1.0
R170
4016-23329-10
RESISTOR, CHIP, 0603, 33.2, 1%
1.0
R177
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R178
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R181
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R186
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R187
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R193
4016-24121-10
RESISTOR, 4.12K, 1%, 1/16W
1.0
R194
4016-23012-10
RESISTOR, CHIP, 0603, 30.1K, 1%
1.0
R195
4016-31900-10
RESISTOR, CHIP, 0.1, 1%, 1W
1.0
R196
4016-31900-10
RESISTOR, CHIP, 0.1, 1%, 1W
1.0
R197
4016-23162-10
RESISTOR, CHIP, 0603, 31.6K, 1%
1.0
R198
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R201
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R202
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R203
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R204
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R206
4016-25111-10
RESISTOR, 5.11K, 1%, 1/16W
1.0
R207
4016-25111-10
RESISTOR, 5.11K, 1%, 1/16W
1.0
R212
4016-22213-10
RESISTOR, 221K, 1%, 1/16W
1.0
R213
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R214
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R215
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R220
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R221
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R222
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R223
4016-52219-10
RESISTOR, CHIP, 0402, 22.1
1.0
R226
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R229
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R233
4016-14999-10
RESISTOR, CHIP, 49.9, 1%, 1/8W
1.0
R501
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R505
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R507
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R508
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R509
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R512
4016-25110-10
RESISTOR, 511, 1%, 1/16W
1.0
R513
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R514
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R515
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
B-108
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R516
4016-23011-10
RESISTOR, 3.01K, 1%, 1/16W
1.0
R517
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R518
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R519
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R520
4016-21000-10
RESISTOR, 100, 1%, 1/16W
1.0
R521
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R522
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R523
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R524
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R525
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R527
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R528
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R529
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R530
4016-43329-10
RESISTOR, CHIP, 33.2, 1%, 1W
1.0
R531
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R532
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R533
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R534
4016-60000-50
RESISTOR, CHIP, 0 OHM, 1/2W
1.0
R535
4016-60000-50
RESISTOR, CHIP, 0 OHM, 1/2W
1.0
R536
4016-18251-10
RESISTOR, CHIP, 8.25K, 1%, 1/8W
1.0
R537
4016-45119-10
RESISTOR, 2512 51.1, 1%, 1W
1.0
R538
4016-24029-10
RESISTOR, CHIP, 0603, 40.2, 1%
1.0
R539
4016-23329-10
RESISTOR, CHIP, 0603, 33.2, 1%
1.0
R540
4016-62009-10
RESISTOR, CHIP, 20, 1%, 1/2W
1.0
R541
4016-28669-10
RESISTOR, CHIP, 0603, 86.6, 1%
1.0
R542
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R543
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R544
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R545
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R546
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R547
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R548
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R549
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R550
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R551
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R552
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R553
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R554
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R555
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R556
4016-25620-10
RESISTOR, CHIP, 0603, 562, 1%
1.0
B-109
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
R557
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R558
4016-22740-10
RESISTOR, 274, 1%, 1/16W
1.0
R559
4016-22741-10
RESISTOR, 2.74K, 1%, 1/16W
1.0
R560
4016-24751-10
RESISTOR, 4.75K, 1%, 1/16W
1.0
R561
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R562
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R563
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R564
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R565
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R566
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R567
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R568
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R569
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R574
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R575
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R576
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R577
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R578
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R579
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R580
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
R581
4016-12671-10
RESISTOR, CHIP, 2.67K, 1%, 1/8W
1.0
R582
4016-20000-50
RESISTOR, CHIP, 0603, JUMPER
1.0
R583
4016-21101-10
RESISTOR, 1.10K, 1%, 1/16W
1.0
R584
4016-50000-50
RESISTOR, CHIP, 0402, JUMPER
1.0
R601
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R602
4016-25110-10
RESISTOR, 511, 1%, 1/16W
1.0
R603
4016-45119-10
RESISTOR, 2512 51.1, 1%, 1W
1.0
R604
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%
1.0
RT1
4016-91103-20
THERMISTOR, NTC
1.0
SW26
2036-31016-00
SWITCH, DPDT, LOCKING
1.0
T1
4018-10178-00
TRAFO, DUAL WINDING, SHIELDED
1.0
U1
4021-50043-64
MICROCONTROLLER, 8051
1.0
U3
4021-31132-50
SCHMITT TRIGGER, 74HC132
1.0
U4
4021-22111-54
VOLTAGE REGULATOR, 3.3V
1.0
U5
4021-22108-54
VOLTAGE REGULATOR, 3.0V
1.0
U6
4021-22020-64
PWM CONTROLLER
1.0
U7
4021-20504-54
COMPARATOR, DUAL, 2-36V
1.0
U501
4021-20045-84
VOLTAGE REGULATOR, FIXED
1.0
U502
4021-22114-50
VOLTAGE REGULATOR, FIXED
1.0
U503
4021-20170-54
OPERATIONAL AMPLIFIER, QUAD
1.0
B-110
MM-E 2072-09333-00
Table B-11. CONTROL HEAD Module (Trunk Mount Version), Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
U504
4021-70098-54
LINE TRANSCEIVER, RS-485
1.0
U505
4021-70098-54
LINE TRANSCEIVER, RS-485
1.0
U506
4021-70098-54
LINE TRANSCEIVER, RS-485
1.0
U507
4021-70697-64
RS232, 2TX+2RX
1.0
VR1
4021-10471-35
ZENER, 4.3V
1.0
VR2
4021-10471-35
ZENER, 4.3V
1.0
VR501
4021-10810-35
ZENER, 3.6V
1.0
VR502
4021-10471-35
ZENER, 4.3V
1.0
VR503
4021-10471-35
ZENER, 4.3V
1.0
VR504
4021-10471-35
ZENER, 4.3V
1.0
VR505
4021-10471-35
ZENER, 4.3V
1.0
VR506
4021-10471-35
ZENER, 4.3V
1.0
VR507
4021-10471-35
ZENER, 4.3V
1.0
VR508
4021-10471-35
ZENER, 4.3V
1.0
VR509
4021-10471-35
ZENER, 4.3V
1.0
VR510
4021-10471-35
ZENER, 4.3V
1.0
VR511
4021-10471-35
ZENER, 4.3V
1.0
Y1
4022-50026-00
CRYSTAL QUARTZ, 7.3728 MHz
1.0
B-111
MM-E 2072-09333-00
Intentionally Left Blank
B-112
MM-E 2072-09333-00
COMPONENT SIDE
PRINT SIDE
Figure B-9. CONTROL HEAD Module (Trunk Mount Version), Identification of Components
B-113/B-114
MM-E 2072-09333-00
Table B-12. INTERCONNECTION Module, Parts List
Ref. Des.
Mfg. Catalog No.
Description
Qty.
2072-95212-00
INTERCONNECTION MODULE
Figure B-10
BL1
2072-32212-00
INTERCONNECTION PCB
1.0
C1
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C2
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C3
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C4
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C5
2072-17821-00
CAPACITOR, CHIP, X7R, 390NF, 16V
1.0
C6
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C7
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C8
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C9
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C10
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C11
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C14
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C15
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C16
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C17
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
C18
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C19
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C20
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C21
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C22
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C23
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C24
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C25
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C26
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C27
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C28
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C29
4017-25274-00
CAPACITOR, 0603, NP0, 180PF, 50V
1.0
C30
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C31
4017-20109-25
CAPACITOR, CHIP, X7R, 10UF
1.0
C32
4017-20567-00
CAPACITOR, CHIP, X7R, 10NF, 16V
1.0
C33
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C34
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C35
4017-20284-00
CAPACITOR, CHIP, CERAMIC, 100NF, 16V
1.0
C36
4017-20151-00
CAPACITOR, CHIP, X7R, 100NF, 25V
1.0
C37
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C38
4017-20165-00
CAPACITOR, CHIP, CERAMIC, 100NF, 50V
1.0
C39
4017-25282-00
CAPACITOR, CHIP, CG, 1NF, 5%
1.0
B-115
MM-E 2072-09333-00
Table B-12. INTERCONNECTION Module, Parts List (Cont’d)
Ref. Des.
Description
Mfg. Catalog No.
Qty.
L1
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L2
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L3
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L4
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L5
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L6
4018-12052-00
COIL, FIXED, 4.7UH
1.0
L7
4018-10016-00
COIL, CHIP, 22UH, 10%
1.0
L8
4018-10016-00
COIL, CHIP, 22UH, 10%
1.0
L9
4018-10016-00
COIL, CHIP, 22UH, 10%
1.0
L10
4018-10016-00
COIL, CHIP, 22UH, 10%
1.0
L11
4018-10016-00
COIL, CHIP, 22UH, 10%
1.0
P1
4033-51201-01
HEADER, 0.05", 24 PIN, DUAL ROW
1.0
P2
4033-51315-00
CONNECTOR, HEADER,16 PIN, DUAL ROW
1.0
Q1
2072-21060-00
TRANSISTOR, PNP, 60V
1.0
R1
4016-15620-10
RESISTOR, CHIP, 562, 1%, 1/8W
1.0
R2
4016-12610-10
RESISTOR, CHIP, 261, 1%, 1/8W
1.0
R3
4016-21542-10
RESISTOR, 15.4K, 1%, 1/16W
1.0
R4
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R5
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R6
4016-21001-10
RESISTOR, 1.00K, 1%, 1/16W
1.0
R7
4016-16199-10
RESISTOR, CHIP, 61.9, 1%, 1/8W
1.0
R8
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R9
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R10
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R11
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R12
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R13
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R14
4016-21002-10
RESISTOR, 10.0K, 1%, 1/16W
1.0
R15
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R16
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R17
4016-25622-10
RESISTOR, CHIP, 0603, 56.2K, 1%
1.0
R18
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R19
4016-22002-10
RESISTOR, 20.0K, 1%, 1/16W
1.0
R20
4016-21003-10
RESISTOR, 100K, 1%, 1/16W
1.0
R21
4016-41821-10
RESISTOR, 2512, 1.82K, 1%, 1W
1.0
R22
4016-24322-10
RESISTOR, 43.2K, 1%, 1/16W
1.0
R23
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%,
1.0
R24
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%,
1.0
R25
4016-21009-10
RESISTOR, CHIP, 0603, 10, 1%,
1.0
R26
4016-22671-10
RESISTOR, 2.67K, 1%, 1/16W
1.0
B-116
MM-E 2072-09333-00
Table B-12. INTERCONNECTION Module, Parts List (Cont’d)
Ref. Des.
Mfg. Catalog No.
Description
Qty.
R27
4016-65620-10
RESISTOR, CHIP, 562, 1%, 1/2W
1.0
R29
4016-10000-10
RESISTOR, CHIP, 1/8W, JUMPER
1.0
R30
4016-10000-10
RESISTOR, CHIP, 1/8W, JUMPER
1.0
U1
4021-20084-54
OPERATIONAL AMPLIFIER, MC33072D
1.0
U2
4021-20010-54
VOLTAGE REGULATOR, ADJUSTABLE, LP2951
1.0
U3
4021-70098-54
LINE TRANSCEIVER, RS-485
1.0
U4
4021-70098-54
LINE TRANSCEIVER, RS-485
1.0
U5
4021-70098-54
LINE TRANSCEIVER, RS-485
1.0
B-117
MM-E 2072-09333-00
COMPONENT SIDE
PRINT SIDE
Figure B-10. INTERCONNECTION Module, Identification of Components
B-118
MM-E 2072-09333-00
Section III. COOLING TRAY
Table B-13. Cooling Tray Assembly, Parts List
Ref. Des.
Description
Mfg. Catalog No.
Qty.
BL1
2072-45037-00
COOLING TRAY
BL2
4056-90028-88
PROTECTIVE BUFFER
Figure B-11
4.0
BL3
2072-52039-00
SCREW, M3×10, PHILIPS BLACK
4.0
BL4
4052-15008-00
CROSS COUNTERSUNK HEAD
4.0
BL5
2072-40970-00
GRILL FOR FAN, 1308116L0
1.0
BL6
2072-51002-00
NUT, M4X0.7 HEX SSTP
4.0
BL7
4053-15001-00
FLAT WASHER
8.0
BL8
4053-70002-16
WASHER, SPRING, M4
4.0
BL9
2072-41030-00
SPACER, 4-40 X 3116, 03MB
4.0
BL10
4053-16001-00
SPRING LOCKWASHERS, M3
4.0
BL12
4052-60246-88
SCREW, PH PHIL CRES, M 3X
7.0
BL13
2072-51004-00
NUT, M3 DIN 93,4 02MB0000
4.0
BL14
2072-93014-00
INTERNAL CABLE, 9 PIN TO FAN
1.0
BL15
2072-95235-00
FAN CONTROL MODULE
1.0
Figure B-11. Cooling Tray Assembly
B-119
MM-E 2072-09333-00
Table B-14. FAN CONTROL Module, Parts List
Ref. Des.
Mfg. Catalog No.
Description
Qty.
2072-95235-00
FAN CONTROL MODULE
C1
4017-25282-00
CAPACITOR, 1NF, 06035A102JAT2A
C2
4017-25282-00
CAPACITOR, 1NF, 06035A102JAT2A
C3
4017-25282-00
CAPACITOR, 1NF, 06035A102JAT2A
C4
4017-25282-00
CAPACITOR, 1NF, 06035A102JAT2A
C5
4017-80112-02
CAPACITOR, 2.2UF, 293D225X0035C2T
C6
4017-80112-02
CAPACITOR, 2.2UF, 293D225X0035C2T
C7
4017-25279-00
CAPACITOR, 470PF, CM105CG471J50AT
C8
4017-25282-00
CAPACITOR, 1NF, 06035A102JAT2A
C9
4017-20271-00
CAPACITOR, 10NF, CM105X7R103K50AT
C10
4017-20271-00
CAPACITOR, 10NF, CM105X7R103K50AT
J1
4033-40091-02
CONNECTOR, 25 PIN, FEMALE, CD729S31D4
J2
4033-40093-02
CONNECTOR, CD7225S31D4
J3
4033-40093-02
CONNECTOR, CD7225S31D4
L1
4018-12206-00
INDUCTOR, 22 UH, NL252018T-220J
L2
4018-12206-00
INDUCTOR, 22 UH, NL252018T-220J
Q1
4021-00342-35
TRANSISTOR, PNP, MMBT3904LT1
Q2
4021-00179-35
TRANSISTOR, NPN, MJD2955T4
R1
4016-11100-10
RESISTOR, 1K, CRCW12061100FRT2
R2
4016-11001-10
RESISTOR, 1K, CRCW12061001FRT2
R3
4016-45110-10
RESISTOR, 511, CRCW25125110FR67
R4
4016-45110-10
RESISTOR, 511, CRCW25125110FR67
R5
4016-21002-10
RESISTOR, 10K, CRCW06031002FRT1
R6
4016-14750-10
RESISTOR, 475, CRCW12064750FRT2
R7
4016-25622-10
RESISTOR, 56.2K, CRCW06035622FRT1
U1
4021-20010-54
VOLTAGE REGULATOR, ADJUSTABLE, LP2951CMX
COMPONENT SIDE
PRINT SIDE
Figure B-12. FAN CONTROL Module, Identification of Components
B-120
Figure B-12
MM-E 2072-09333-00
Table B-15. Fan Harness Assembly, Parts List
Description
Ref. Des.
Qty.
WIRE HARNESS
Figure B-13
CONNECTOR, 9 PIN, D-TYPE, FEMALE
FAN, 298DHLP11000
5.3 mm DC PHONE JACK
1/4" PHONE JACK
SCREW, 4-40 UNC, 23.0 mm
LABEL
HEATSHRINK TUBING
OUTER MOLD, 45 PIN, PVC
Connector
P2
Connector
P1
Connector
P1
Color
Connector
P2
Connector
P3
Connector
P4
Red
Black
Orange
Blue
Green
White
Connector
P3
Connector
P4
Figure B-13. Fan Harness Assembly
B-121
MM-E 2072-09333-00
Intentionally Left Blank
B-122

Source Exif Data:

File Type                       : PDF
File Type Extension             : pdf
MIME Type                       : application/pdf
PDF Version                     : 1.6
Linearized                      : No
XMP Toolkit                     : Adobe XMP Core 4.2.1-c041 52.342996, 2008/05/07-20:48:00
Create Date                     : 2011:01:04 09:55:49Z
Creator Tool                    : PScript5.dll Version 5.2
Modify Date                     : 2012:10:11 14:37:48-07:00
Metadata Date                   : 2012:10:11 14:37:48-07:00
Format                          : application/pdf
Creator                         : Owner
Title                           : Microsoft Word - MICOM-Z-MME-fp.doc
Producer                        : GPL Ghostscript 8.15
Document ID                     : uuid:acf3a589-f651-4dc5-8f6b-550e11217b0b
Instance ID                     : uuid:7519abcf-fe5d-48ed-afd7-714bcfada0cc
Has XFA                         : No
Page Count                      : 225
Author                          : Owner

EXIF Metadata provided by EXIF.tools

Elbit Systems Land and C4I Tadiran MICOM-DS125W Licensed Non-Broadcast Station Transmitter - MICOM Z-Dash User Manual MICOM Z MME fp

Elbit Systems Land and C4I - Tadiran Ltd. Licensed Non-Broadcast Station Transmitter - MICOM Z-Dash MICOM Z MME fp

Contents

Service Manual

FCC ID Filing: YO5MICOM-DS125W

Navigation menu

Namespaces

Views

Navigation