MMB Research LKT00 802.15.4 Zigbee single module User Manual

MMB Research Inc. 802.15.4 Zigbee single module

User Manual

MMB#Networks#LKT00#ZigBee#Module#based#on#the#NCS36510##The#MMB#Networks#LKT00#ZigBee#module#is#a#drop-in#ZigBee/802.15.4#module#for#use#in#wireless#mesh#networking#applications.##The#module#is#based#on#ON#Semiconductor’s#NCS36510#SoC.##The#NCS36510#is#a#low#power,#fully#integrated,#System#on#Chip#that#integrates#a#2.4#GHz#IEEE#802.15.4−2006#compliant#transceiver,#ARM®#Cortex®−M3#microprocessor,#RAM#and#FLASH#memory,#a#true#random#number#generator,#and#multiple#peripherals#to#support#design#of#a#complete#and#secure#wireless#network#with#minimal#external#components.##The#NCS36510#incorporates#an#industry#leading#32#bit#ARM#Cortex−M3#for#high#performance,#low#power#and#low#cost#processing.#The#NCS36510#includes#640#kB#of#embedded#FLASH#memory#for#program#storage#along#with#48#kB#of#RAM#for#data#storage.#NCS36510#uses#a#hardware#accelerated#MAC#to#minimize#processor#overhead#while#maximizing#available#processor#power#for#running#application#software.##Peripherals#include#DMA,#UART(2),#SPI(2),#I2C(2),#PWM,#RTC,#three#programmable#timers,#WDT,#18#GPIO,#10#bit#ADC#with#four#external#inputs#and#integrated#temperature#and#voltage#sensors.#!! !LKT00#Document#Rev#0.2#DRAFT#<MODULE#PHOTO#GOES#HERE>#
!Table!of!Contents!1# General#Information#.................................................................................................................#1#2# Memory#....................................................................................................................................#1#3# Module#Pinout#..........................................................................................................................#1#3.1#Debug#and#Programming#Interface#................................................................................................#1#4# Electrical#Specifications#............................................................................................................#2#4.1#Absolute#Maximum#Ratings#...........................................................................................................#2#4.2#Recommended#Operating#Conditions#............................................................................................#2#4.3#DC#Electrical#Characteristics#...........................................................................................................#2#4.3.1#Core#Power#Consumption#.......................................................................................................#2#4.4#TX#Power#Setting#............................................................................................................................#3#5# RF#Specifications#.......................................................................................................................#3#5.1#Receive#Specifications#....................................................................................................................#3#5.2#Transmit#Specifications#..................................................................................................................#3#6# Mechanical#Specifications#........................................................................................................#3#6.1#Physical#Dimensions#.......................................................................................................................#3#6.2#Recommended#Land#Pattern#(Surface#Mount)#..............................................................................#4#6.3#Labeling#..........................................................................................................................................#4#7# Soldering#Temperature#Time#Profile#for#Reflow#Soldering#(Lead-Free#Solder)#........................#4#8# Regulatory#Approvals#...............................................................................................................#5#8.1#Approved#Antennae#.......................................................................................................................#5#8.2#Federal#Communications#Commission#(FCC#-#US)#..........................................................................#5#8.2.1#RF#Output#Power#Settings#.......................................................................................................#5#8.2.2#FCC#Notice#...............................................................................................................................#5#8.2.3#Modular#Approval#...................................................................................................................#5#8.2.4#Labeling#Requirements#............................................................................................................#5#8.3#Industry#Canada#(IC)#.......................................................................................................................#6#8.3.1#RF#Output#Power#Settings#.......................................................................................................#6#8.3.2#IC#Notice#..................................................................................................................................#6#8.3.3#Labeling#Requirements#............................................................................................................#6#8.4#ETSI#(EU)#.........................................................................................................................................#6#8.4.1#RF#Output#Power#Settings#.......................................................................................................#6#8.4.2#ETSI#Approval#..........................................................................................................................#6#9# Ordering#Information#...............................................................................................................#7###
# #Rev#0.2#DRAFT## Page#1#of#7# LKT00#Module#Datasheet#DRAFT#1 General!Information!Note#that#some#of#the#specifications#refer#to#either#“NCS36510”#or#“Module”.#Please#note#specifications#cited#as#NCS36510#are#taken#from#the#NCS36510#datasheet#(this#should#also#be#noted#where#referred#to).#“Module”#means#measurements#taken#with#the#MMB#Networks#production#module.#2 Memory!RAM#(kB)#On-Chip#Flash#(kB)#48#640#3 Module!Pinout!Module#Pad#NCS36510#GPIO#(NCS36510#Pin#Number)#1#Test#(35)#2#DIO17#(40)#3#DIO10#(1)#4#DIO16#(4)#5#VDDIO#(5)#6#GND#7#DIO8#(3)#8#DIO7#(7)#9#DIO6#(8)#10#DIO5#(9)#11#DIO4#(10)#12#DIO3#(11)#13#DIO2#(12)#14#DIO1#(13)#15#DIO0#(14)#16#nReset#(36)#17#DIO9#(2)#18#VDD#(22,#34)#19#GND#20#A0#(23)#21#DIO13#(37)#22#DIO12#(38)#23#DIO11#(39)#24#GND#25#A1#(24)#26#DIO15#(6)#27#DIO14#(15)#28#A2#(29)#29#A3#(30)#3.1 Debug!and!Programming!Interface!DRAFT#TBD#
# #Rev#0.2#DRAFT## Page#2#of#7# LKT00#Module#Datasheet#DRAFT#4 Electrical!Specifications!4.1 Absolute!Maximum!Ratings!Parameter#Minimum#Maximum#Units#Supply#Voltage#(VDD,#VDDIO)#-0.3#3.9#V#Voltage#on#any#GPIO#(DIO0:DIO17,#nReset,#Test)#-0.3#VDDIO+0.3,#<=3.9#V#Analog#pin#voltage#(A0:A3)#-0.3#VDD+0.3,#<=3.9#V#Storage#Temperature#Range#-40#+125#°C#4.2 Recommended!Operating!Conditions!Parameter#Minimum#Typical#Maximum#Units#Supply#Voltage#(VDD)#–#3V#Mode#TBD#3.3#3.6#V#Supply#Voltage#(VDDIO)#TBD#3.3#3.6#V#Ambient#Temperature#Range#-40#27#85#°C######4.3 DC!Electrical!Characteristics!For#typical#values#TA#=#27°C,#for#min/max#values#TA#=#−40°C#to#85°C;#unless#otherwise#noted.#Power#supplies#VDD#=#3.3#V,#VDDIO#=#3.3#V,#unless#otherwise#noted.##Parameter#Test#Condition#Minimum#Typical#Maximum#Units#Coma#Mode#Sleep#Current1#3#V#Mode,#Switching#Regulator#!3#V#Mode,#Linear#Regulator2!#0.65#4.96##μA#μA#FLASH#Erase#Cycles#Before#Failure3##10k###cycles#FLASH#Read#Current3####2.3#mA#FLASH#Erase#Current3####5#mA#FLASH#Write#Current3####3#mA#Data#Retention#at#85°C##10###years##4.3.1 Core!Power!Consumption!#Parameter#Test#Condition#Minimum#Typical#Maximum#Units#3V#Mode#Transmit#Current#–#Switching#Regulator4#+7.6#dBm#(Max.#Power#Setting)##0#dBm##−16#dBm#(Min.#Power#Setting)##TBD#TBD#TBD##mA#mA#mA#3V#Mode#Transmit#Current#–#Linear##Regulator4#+7.6#dBm#(Max.#Power#Setting)##0#dBm##−16#dBm#(Min.#Power#Setting)##TBD#TBD#TBD##mA#mA#mA#3V#Mode#Receive#Current##–#Switching#Regulator4###TBD##mA#3V#Mode#Receive#Current##–#Linear#Regulator4###TBD######mA###Notes:#1.##Coma#mode#=#CPU#running#on#internal#32#kHz#osc#and#waiting#for#interrupt,#both#retention#RAMS#disabled,#all#other#functions#powered#down#
# #Rev#0.2#DRAFT## Page#3#of#7# LKT00#Module#Datasheet#DRAFT#2.##VDD#=#2.0V#3.##Guaranteed#by#design#4.##Peripherals#disabled,#CPU#halted,#32#MHz#crystal#oscillator,#CW#Mode,#2.44GHz,#ON#Semiconductor#evaluation#board,#conducted#measurement,#50#ohm#system##Please#refer#to#the#NCS36510#data#sheet#for#DIO#specifications#including#internal#resistor#values,#switching#voltages,#thresholds,#etc.##4.4 TX!Power!Setting!The#RF#Output#power#of#the#Module#can#be#adjusted#via#the#SoC’s#TX#Power#settings.#The#Transmit#Current#will#also#vary#according#to#the#TX#Power#setting.#The#charts#below#show#the#relationship#between#the#Transmit#Current#or#Output#Power#vs#the#TX#Power#setting.##CHART#TBD##5 RF!Specifications!5.1 Receive!Specifications!Parameter#Test#Condition#Minimum#Typical#Maximum#Units#Frequency#range##2400##2485#MHz#Sensitivity###-97#-92#dBm#RSSI#range###40#60#dB########5.2 Transmit!Specifications!Parameter#Test#Condition#Minimum#Typical#Maximum#Units#Output#Power#Max#Power#Setting!2#7.6#10#dBm#Error#Vector#Magnitude#(EVM)#Max#Power!#10#35#%#Spurious#emissions,#relative#Max#power###-20#dBc!Spurious#emissions,#absolute#Max#power###-30#dBm##6 Mechanical!Specifications!6.1 Physical!Dimensions!Dimension#Drawing#TBD##Symbol!Description!Distance!L#Length#of#the#module!#W#Width#of#the#module!#H#Height#of#the#module##A1#Pitch##A2#Distance#center#of#pad#to#PCB#edge##
# #Rev#0.2#DRAFT## Page#4#of#7# LKT00#Module#Datasheet#DRAFT#Symbol!Description!Distance!A3#Distance#center#of#pad#to#PCB#edge##A#Length#of#keep-out#zone##B#Width#of#keep-out#zone##C#Keep-out#zone#from#corner#of#PCB##D#Keep-out#zone#from#corner#of#PCB###6.2 Recommended!Land!Pattern!(Surface!Mount)!Land#Pattern#TBD##Symbol!Description!Distance!F1#Distance#pad#edge#to#pad#edge!#F2#Distance#pad#edge#to#pad#edge!#F3#Distance#pad#edge#to#pad#center##F4#Pitch##F5#Module#silkscreen#outline##F6#Module#silkscreen#outline##6.3 Labeling!##7 Soldering!Temperature!Time!Profile!for!Reflow!Soldering!(Lead-Free!Solder)!#
# #Rev#0.2#DRAFT## Page#5#of#7# LKT00#Module#Datasheet#DRAFT#8 Regulatory!Approvals!8.1 Approved!Antennae!The#LKT00#module#has#been#certified#with#one#onboard#chip#antenna.#See#the#individual#jurisdictions#below#for#the#detailed#output#power#settings.#8.2 Federal!Communications!Commission!(FCC!-!US)!8.2.1 RF!Output!Power!Settings!For#the#LKT00#module#using#the#onboard#chip#antenna,#the#approved#power#level#settings#are#10#(max#power)#for#channels#11-#25#and#X#for#channel#26.##8.2.2 FCC!Notice!The#LKT00#device#complies#with#Part#15#of#the#FCC#rules.#Operation#is#subject#to#the#following#two#conditions:##(1)#This#device#may#not#cause#harmful#interference,#and#(2)#This#device#must#accept#any#interference#received,#including#interference#that#may#cause#undesired#operation.##To#comply#with#FCC#RF#Exposure#requirements,#users#of#this#device#must#ensure#that#the#module#be#installed#and/or#configured#to#operate#with#a#separation#distance#of#20cm#or#more#from#all#persons.#Usage#of#Channel#26#at#full#power#will#result#in#non-compliance#to#FCC#standards.#MMB#recommends#avoiding#use#of#channel#26#and#if#necessary#only#use#with#a#reduced#power#setting.#For#further#details#please#contact#MMB.#8.2.3 Modular!Approval!The#LKT00LKT00#device#meets#the#requirements#for#modular#transmitter#approval#as#detailed#in#the#FCC#public#notice#DA#00-1407.##It#should#be#noted#that:##“While#the#applicant#for#a#device#into#which#an#authorized#module#is#installed#is#not#required#to#obtain#a#new#authorization#for#the#module,#this#does#not#preclude#the#possibility#that#some#other#form#of#authorization#or#testing#may#be#required#for#the#device#(e.g.,#a#WLAN#into#which#an#authorized#module#is#installed#must#still#be#authorized#as#a#PC#peripheral,#subject#to#the#appropriate#equipment#authorization).”#--#FCC#Public#Notice#DA#00-1407##Caution:!Changes#or#modifications#not#expressly#approved#by#the#party#responsible#for#compliance#could#void#the#user’s#authority#to#operate#the#equipment.#8.2.4 Labeling!Requirements!The#user#of#this#device#is#responsible#for#meeting#the#FCC#labeling#requirements.#A#clearly#visible#label#on#the#exterior#enclosure#of#an#incorporating#device#must#list#the#MMB#Research#Inc.#FCC#ID#“XFF-LKT00”#and#the#FCC#Notice#above#.##The#exterior#label#should#use#the#wording#“Contains”#or#“Contains#Transmitter#Module”.#For#example:##Contains(FCC(ID:(XFF-LKT00(#
# #Rev#0.2#DRAFT## Page#6#of#7# LKT00#Module#Datasheet#DRAFT#or#(Contains(Transmitter(Module(FCC(ID:(XFF-LKT00(#Any#similar#wording#that#expresses#the#same#meaning#may#be#used.##8.3 Industry!Canada!(IC)!8.3.1 RF!Output!Power!Settings!For#the#LKT00#module#using#the#onboard#chip#antenna,#the#approved#power#level#settings#are#10#(max#power)#for#channels#11-#25#and#X#for#channel#26.#8.3.2 IC!Notice!This#device#complies#with#Industry#Canada#licence-exempt#RSS#standard(s).#Operation#is#subject#to#the#following#two#conditions:##(1)#this#device#may#not#cause#interference,#and#(2)#this#device#must#accept#any#interference,#including#interference#that#may#cause#undesired#operation#of#the#device.##Le#présent#appareil#est#conforme#aux#CNR#d’Industrie#Canada#applicables!aux$appareils$radio$exempts$de$licence.$L’exploitation,est,autorisée,aux,deux,conditions,suivantes,:##(1)#l’appareil#ne#doit#pas#produire#de#brouillage,#et#(2)$l’utilisateur$de$l’appareil$doit$accepter$tout$brouillage$radioélectrique$subi,$même$si$le$brouillage#est#susceptible#d’en#compromettre#le#fonctionnement.##8.3.3 Labeling!Requirements!The#host#device#shall#be#properly#labeled#to#identify#the#modules#within#the#host#device.#The#Industry#Canada#certification#label#of#a#module#shall#be#clearly#visible#at#all#times#when#installed#in#the#host#device,#otherwise#the#host#device#must#be#labeled#to#display#the#Industry#Canada#certification#number#of#the#module,#preceded#by#the#words#“Contains#transmitter#module”,#or#the#word#“Contains”,#or#similar#wording#expressing#the#same#meaning,#as#follows:##Contains(transmitter(module(IC:(8365A-LKT00(#8.4 ETSI!(EU)!8.4.1 RF!Output!Power!Settings!For#the#LKT00#module#using#the#onboard#chip#antenna,#the#approved#power#level#settings#are#10#(max#power#for#all#channels).##8.4.2 ETSI!Approval!Provided#that#the#above#TX#Power#settings#are#used,#the#LKT00#module#is#compliant#with#the#following#EU#standards:#ETSI#EN#300#328#(v1.9.1),#ETSI#EN#301#489#1#(v1.9.2)#and#ETSI#EN#301#489#17#(v2.2.1)##
# #Rev#0.2#DRAFT## Page#7#of#7# LKT00#Module#Datasheet#DRAFT#9 Ordering!Information!SKU!Description!NCAT00LKT00082G4MNG###

Navigation menu