MMB Research LKT00 802.15.4 Zigbee single module User Manual

MMB Research Inc. 802.15.4 Zigbee single module

User Manual

MMB#Networks#LKT00#ZigBee#Module#based#on#the#NCS36510#
#
The#MMB#Networks#LKT00#ZigBee#module#is#a#drop-in#
ZigBee/802.15.4#module#for#use#in#wireless#mesh#networking#
applications.##The#module#is#based#on#ON#Semiconductor’s#
NCS36510#SoC.##The#NCS36510#is#a#low#power,#fully#
integrated,#System#on#Chip#that#integrates#a#2.4#GHz#IEEE#
802.15.4−2006#compliant#transceiver,#ARM®#Cortex®−M3#
microprocessor,#RAM#and#FLASH#memory,#a#true#random#
number#generator,#and#multiple#peripherals#to#support#
design#of#a#complete#and#secure#wireless#network#with#
minimal#external#components.#
#
The#NCS36510#incorporates#an#industry#leading#32#bit#ARM#
Cortex−M3#for#high#performance,#low#power#and#low#cost#processing.#The#NCS36510#includes#640#kB#of#
embedded#FLASH#memory#for#program#storage#along#with#48#kB#of#RAM#for#data#storage.#NCS36510#
uses#a#hardware#accelerated#MAC#to#minimize#processor#overhead#while#maximizing#available#processor#
power#for#running#application#software.#
#
Peripherals#include#DMA,#UART(2),#SPI(2),#I2C(2),#PWM,#RTC,#three#programmable#timers,#WDT,#18#
GPIO,#10#bit#ADC#with#four#external#inputs#and#integrated#temperature#and#voltage#sensors.#
!
! !
LKT00#
Document#Rev#0.2#DRAFT#
<MODULE#PHOTO#GOES#HERE>#
!
Table!of!Contents!
1# General#Information#.................................................................................................................#1#
2# Memory#....................................................................................................................................#1#
3# Module#Pinout#..........................................................................................................................#1#
3.1#Debug#and#Programming#Interface#................................................................................................#1#
4# Electrical#Specifications#............................................................................................................#2#
4.1#Absolute#Maximum#Ratings#...........................................................................................................#2#
4.2#Recommended#Operating#Conditions#............................................................................................#2#
4.3#DC#Electrical#Characteristics#...........................................................................................................#2#
4.3.1#Core#Power#Consumption#.......................................................................................................#2#
4.4#TX#Power#Setting#............................................................................................................................#3#
5# RF#Specifications#.......................................................................................................................#3#
5.1#Receive#Specifications#....................................................................................................................#3#
5.2#Transmit#Specifications#..................................................................................................................#3#
6# Mechanical#Specifications#........................................................................................................#3#
6.1#Physical#Dimensions#.......................................................................................................................#3#
6.2#Recommended#Land#Pattern#(Surface#Mount)#..............................................................................#4#
6.3#Labeling#..........................................................................................................................................#4#
7# Soldering#Temperature#Time#Profile#for#Reflow#Soldering#(Lead-Free#Solder)#........................#4#
8# Regulatory#Approvals#...............................................................................................................#5#
8.1#Approved#Antennae#.......................................................................................................................#5#
8.2#Federal#Communications#Commission#(FCC#-#US)#..........................................................................#5#
8.2.1#RF#Output#Power#Settings#.......................................................................................................#5#
8.2.2#FCC#Notice#...............................................................................................................................#5#
8.2.3#Modular#Approval#...................................................................................................................#5#
8.2.4#Labeling#Requirements#............................................................................................................#5#
8.3#Industry#Canada#(IC)#.......................................................................................................................#6#
8.3.1#RF#Output#Power#Settings#.......................................................................................................#6#
8.3.2#IC#Notice#..................................................................................................................................#6#
8.3.3#Labeling#Requirements#............................................................................................................#6#
8.4#ETSI#(EU)#.........................................................................................................................................#6#
8.4.1#RF#Output#Power#Settings#.......................................................................................................#6#
8.4.2#ETSI#Approval#..........................................................................................................................#6#
9# Ordering#Information#...............................................................................................................#7#
#
#
# #
Rev#0.2#DRAFT## Page#1#of#7# LKT00#Module#Datasheet#DRAFT#
1 General!Information!
Note#that#some#of#the#specifications#refer#to#either#“NCS36510”#or#“Module”.#Please#note#specifications#cited#as#
NCS36510#are#taken#from#the#NCS36510#datasheet#(this#should#also#be#noted#where#referred#to).#“Module”#means#
measurements#taken#with#the#MMB#Networks#production#module.#
2 Memory!
RAM#(kB)#
On-Chip#Flash#(kB)#
48#
640#
3 Module!Pinout!
Module#Pad#
1#
2#
3#
4#
5#
6#
7#
8#
9#
10#
11#
12#
13#
14#
15#
16#
17#
18#
19#
20#
21#
22#
23#
24#
25#
26#
27#
28#
29#
3.1 Debug!and!Programming!Interface!
DRAFT#TBD#
# #
Rev#0.2#DRAFT## Page#2#of#7# LKT00#Module#Datasheet#DRAFT#
4 Electrical!Specifications!
4.1 Absolute!Maximum!Ratings!
Parameter#
Minimum#
Maximum#
Units#
Supply#Voltage#(VDD,#VDDIO)#
-0.3#
3.9#
V#
Voltage#on#any#GPIO#(DIO0:DIO17,#nReset,#Test)#
-0.3#
VDDIO+0.3,#<=3.9#
V#
Analog#pin#voltage#(A0:A3)#
-0.3#
VDD+0.3,#<=3.9#
V#
Storage#Temperature#Range#
-40#
+125#
°C#
4.2 Recommended!Operating!Conditions!
Parameter#
Minimum#
Typical#
Maximum#
Units#
Supply#Voltage#(VDD)#–#3V#Mode#
TBD#
3.3#
3.6#
V#
Supply#Voltage#(VDDIO)#
TBD#
3.3#
3.6#
V#
Ambient#Temperature#Range#
-40#
27#
85#
°C#
#
#
#
#
#
4.3 DC!Electrical!Characteristics!
For#typical#values#TA#=#27°C,#for#min/max#values#TA#=#−40°C#to#85°C;#unless#otherwise#noted.#Power#supplies#VDD#=#3.3#
V,#VDDIO#=#3.3#V,#unless#otherwise#noted.#
#
Parameter#
Test#Condition#
Minimum#
Typical#
Maximum#
Units#
Coma#Mode#Sleep#Current1#
3#V#Mode,#Switching#Regulator#!
3#V#Mode,#Linear#Regulator2!
#
0.65#
4.96#
#
μA#
μA#
FLASH#Erase#Cycles#Before#
Failure3#
#
10k#
#
#
cycles#
FLASH#Read#Current3#
#
#
#
2.3#
mA#
FLASH#Erase#Current3#
#
#
#
5#
mA#
FLASH#Write#Current3#
#
#
#
3#
mA#
Data#Retention#at#85°C#
#
10#
#
#
years#
#
4.3.1 Core!Power!Consumption!
#
Parameter#
Test#Condition#
Minimum#
Typical#
Maximum#
Units#
3V#Mode#Transmit#Current#–#
Switching#Regulator4#
+7.6#dBm#(Max.#Power#Setting)##
0#dBm##
−16#dBm#(Min.#Power#Setting)#
#
TBD#
TBD#
TBD#
#
mA#
mA#
mA#
3V#Mode#Transmit#Current#–#
Linear##Regulator4#
+7.6#dBm#(Max.#Power#Setting)##
0#dBm##
−16#dBm#(Min.#Power#Setting)#
#
TBD#
TBD#
TBD#
#
mA#
mA#
mA#
3V#Mode#Receive#Current##–#
Switching#Regulator4#
#
#
TBD#
#
mA#
3V#Mode#Receive#Current##–#
Linear#Regulator4#
#
#
TBD#
#
####mA#
#
#
Notes:#
1.##Coma#mode#=#CPU#running#on#internal#32#kHz#osc#and#waiting#for#interrupt,#both#retention#RAMS#disabled,#all#other#functions#powered#down#
# #
Rev#0.2#DRAFT## Page#3#of#7# LKT00#Module#Datasheet#DRAFT#
2.##VDD#=#2.0V#
3.##Guaranteed#by#design#
4.##Peripherals#disabled,#CPU#halted,#32#MHz#crystal#oscillator,#CW#Mode,#2.44GHz,#ON#Semiconductor#evaluation#board,#conducted#measurement,#
50#ohm#system#
#
Please#refer#to#the#NCS36510#data#sheet#for#DIO#specifications#including#internal#resistor#values,#switching#voltages,#
thresholds,#etc.#
#
4.4 TX!Power!Setting!
The#RF#Output#power#of#the#Module#can#be#adjusted#via#the#SoC’s#TX#Power#settings.#The#Transmit#Current#will#also#vary#
according#to#the#TX#Power#setting.#The#charts#below#show#the#relationship#between#the#Transmit#Current#or#Output#
Power#vs#the#TX#Power#setting.#
#
CHART#TBD#
#
5 RF!Specifications!
5.1 Receive!Specifications!
Parameter#
Test#Condition#
Minimum#
Typical#
Maximum#
Units#
Frequency#range#
#
2400#
#
2485#
MHz#
Sensitivity#
#
#
-97#
-92#
dBm#
RSSI#range#
#
#
40#
60#
dB#
#
#
#
#
#
#
#
5.2 Transmit!Specifications!
Parameter#
Test#Condition#
Minimum#
Typical#
Maximum#
Units#
Output#Power#
Max#Power#
Setting!
2#
7.6#
10#
dBm#
Error#Vector#Magnitude#(EVM)#
Max#Power!
#
10#
35#
%#
Spurious#emissions,#relative#
Max#power#
#
#
-20#
dBc!
Spurious#emissions,#absolute#
Max#power#
#
#
-30#
dBm#
#
6 Mechanical!Specifications!
6.1 Physical!Dimensions!
Dimension#Drawing#TBD#
#
Symbol!
Description!
Distance!
L#
Length#of#the#module!
#
W#
Width#of#the#module!
#
H#
Height#of#the#module#
#
A1#
Pitch#
#
A2#
Distance#center#of#pad#to#PCB#edge#
#
# #
Rev#0.2#DRAFT## Page#4#of#7# LKT00#Module#Datasheet#DRAFT#
Symbol!
Description!
Distance!
A3#
Distance#center#of#pad#to#PCB#edge#
#
A#
Length#of#keep-out#zone#
#
B#
Width#of#keep-out#zone#
#
C#
Keep-out#zone#from#corner#of#PCB#
#
D#
Keep-out#zone#from#corner#of#PCB#
#
#
6.2 Recommended!Land!Pattern!(Surface!Mount)!
Land#Pattern#TBD#
#
Symbol!
Description!
Distance!
F1#
Distance#pad#edge#to#pad#edge!
#
F2#
Distance#pad#edge#to#pad#edge!
#
F3#
Distance#pad#edge#to#pad#center#
#
F4#
Pitch#
#
F5#
Module#silkscreen#outline#
#
F6#
Module#silkscreen#outline#
#
6.3 Labeling!
#
#
7 Soldering!Temperature!Time!Profile!for!Reflow!Soldering!(Lead-Free!Solder)!
#
# #
Rev#0.2#DRAFT## Page#5#of#7# LKT00#Module#Datasheet#DRAFT#
8 Regulatory!Approvals!
8.1 Approved!Antennae!
The#LKT00#module#has#been#certified#with#one#onboard#chip#antenna.#See#the#individual#jurisdictions#below#for#the#
detailed#output#power#settings.#
8.2 Federal!Communications!Commission!(FCC!-!US)!
8.2.1 RF!Output!Power!Settings!
For#the#LKT00#module#using#the#onboard#chip#antenna,#the#approved#power#level#settings#are#10#(max#power)#for#
channels#11-#25#and#X#for#channel#26.#
#
8.2.2 FCC!Notice!
The#LKT00#device#complies#with#Part#15#of#the#FCC#rules.#Operation#is#subject#to#the#following#two#conditions:#
#
(1)#This#device#may#not#cause#harmful#interference,#and#
(2)#This#device#must#accept#any#interference#received,#including#interference#that#may#cause#undesired#operation.#
#
To#comply#with#FCC#RF#Exposure#requirements,#users#of#this#device#must#ensure#that#the#module#be#installed#and/or#
configured#to#operate#with#a#separation#distance#of#20cm#or#more#from#all#persons.#Usage#of#Channel#26#at#full#power#
will#result#in#non-compliance#to#FCC#standards.#MMB#recommends#avoiding#use#of#channel#26#and#if#necessary#only#use#
with#a#reduced#power#setting.#For#further#details#please#contact#MMB.#
8.2.3 Modular!Approval!
The#LKT00LKT00#device#meets#the#requirements#for#modular#transmitter#approval#as#detailed#in#the#FCC#public#notice#DA#
00-1407.#
#
It#should#be#noted#that:#
#
“While#the#applicant#for#a#device#into#which#an#authorized#module#is#installed#is#not#required#to#obtain#a#new#
authorization#for#the#module,#this#does#not#preclude#the#possibility#that#some#other#form#of#authorization#or#testing#may#
be#required#for#the#device#(e.g.,#a#WLAN#into#which#an#authorized#module#is#installed#must#still#be#authorized#as#a#PC#
peripheral,#subject#to#the#appropriate#equipment#authorization).”#
--#FCC#Public#Notice#DA#00-1407#
#
Caution:!
Changes#or#modifications#not#expressly#approved#by#the#party#responsible#for#compliance#could#void#the#user’s#authority#
to#operate#the#equipment.#
8.2.4 Labeling!Requirements!
The#user#of#this#device#is#responsible#for#meeting#the#FCC#labeling#requirements.#A#clearly#visible#label#on#the#exterior#
enclosure#of#an#incorporating#device#must#list#the#MMB#Research#Inc.#FCC#ID#“XFF-LKT00”#and#the#FCC#Notice#above#
.##
The#exterior#label#should#use#the#wording#“Contains”#or#“Contains#Transmitter#Module”.#For#example:#
#
Contains(FCC(ID:(XFF-LKT00(
#
# #
Rev#0.2#DRAFT## Page#6#of#7# LKT00#Module#Datasheet#DRAFT#
or#
(
Contains(Transmitter(Module(FCC(ID:(XFF-LKT00(
#
Any#similar#wording#that#expresses#the#same#meaning#may#be#used.#
#
8.3 Industry!Canada!(IC)!
8.3.1 RF!Output!Power!Settings!
For#the#LKT00#module#using#the#onboard#chip#antenna,#the#approved#power#level#settings#are#10#(max#power)#for#
channels#11-#25#and#X#for#channel#26.#
8.3.2 IC!Notice!
This#device#complies#with#Industry#Canada#licence-exempt#RSS#standard(s).#Operation#is#subject#to#the#following#two#
conditions:#
#
(1)#this#device#may#not#cause#interference,#and#
(2)#this#device#must#accept#any#interference,#including#interference#that#may#cause#undesired#operation#of#the#device.#
#
Le#présent#appareil#est#conforme#aux#CNR#d’Industrie#Canada#applicables!aux$appareils$radio$exempts$de$licence.$
L’exploitation,est,autorisée,aux,deux,conditions,suivantes,:#
#
(1)#l’appareil#ne#doit#pas#produire#de#brouillage,#et#
(2)$l’utilisateur$de$l’appareil$doit$accepter$tout$brouillage$radioélectrique$subi,$même$si$le$brouillage#est#susceptible#d’en#
compromettre#le#fonctionnement.#
#
8.3.3 Labeling!Requirements!
The#host#device#shall#be#properly#labeled#to#identify#the#modules#within#the#host#device.#The#Industry#Canada#
certification#label#of#a#module#shall#be#clearly#visible#at#all#times#when#installed#in#the#host#device,#otherwise#the#host#
device#must#be#labeled#to#display#the#Industry#Canada#certification#number#of#the#module,#preceded#by#the#words#
“Contains#transmitter#module”,#or#the#word#“Contains”,#or#similar#wording#expressing#the#same#meaning,#as#follows:#
#
Contains(transmitter(module(IC:(8365A-LKT00(
#
8.4 ETSI!(EU)!
8.4.1 RF!Output!Power!Settings!
For#the#LKT00#module#using#the#onboard#chip#antenna,#the#approved#power#level#settings#are#10#(max#power#for#all#
channels).#
#
8.4.2 ETSI!Approval!
Provided#that#the#above#TX#Power#settings#are#used,#the#LKT00#module#is#compliant#with#the#following#EU#standards:#
ETSI#EN#300#328#(v1.9.1),#ETSI#EN#301#489#1#(v1.9.2)#and#ETSI#EN#301#489#17#(v2.2.1)#
#
# #
Rev#0.2#DRAFT## Page#7#of#7# LKT00#Module#Datasheet#DRAFT#
9 Ordering!Information!
SKU!
Description!
NCAT00LKT00082G4MNG#
#
#

Navigation menu