Marelli ASTU13 Automotove Keyless Entry System Transmitter User Manual MEASUREMENT TECHNICAL REPORT
Calsonic Kansei Corporation Automotove Keyless Entry System Transmitter MEASUREMENT TECHNICAL REPORT
Marelli >
Contents
- 1. Manual
- 2. Test Report more
Test Report more
EMISSION TEST REPORT Test Report No. : 21BE0029YW-1 Applicant: CALSONIC KANSEI CORP. Type of Equipment: Keyless Entry System (Transmitter) Model No.: ASTU13 Test standard: FCC Part 15 Subpart C Test Result: Complies This report may not be reproduced in full, partial reproduction may only be made with the written consent of the laboratory. The results in this report apply only to the sample tested. Date of test: September 14, 2000 Tested by: Naoki Sakamoto Issued date: Approved by: October 5, 2000 Kazutoyo Nakanishi Section Manager of EMC section Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 2of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 Table of Contents Page 1 GENERAL INFORMATION 1.1 Product Description 1.2 Tested System Details 1.3 Tested Methodology 1.4 Test Facility 2 SYSTEM TEST CONFIGURATION 2.1 Operation Environment 2.2 Justification 2.3 EUT Exercise Software 2.4 Test Procedure Figure 2.1 Configuration of Tested System 3 RADIATED MEASUREMENT PHOTOS Figure 3.1 Radiated Measurement Photos 3.1 Measurement Uncertainty 4 RADIATED EMISSION DATA 4.1 Field Strength Calculation 5 TEST EQUIPMENT USED 11 APPENDIX A:Test Data 12 A1 – A3 Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 3of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 1 GENERAL INFORMATION APPLICANT : CALSONIC KANSEI CORP. TRADE NAME : CALSONIC KANSEI ADDRESS : 5-24-15 Minamidai, Nakano-ku, Tokyo 164-8602 Japan Tel: +81-283-21-8136 Fax: +81-283-23-9191 REGULATION(S) : FCC Part 15 Subpart C MODEL NUMBER : ASTU13 FCC ID : KBRASTU13 SERIAL NUMBER :- KIND OF EQUIPMENT : Keyless Entry System (Transmitter) TESTED DATE : September 14, 2000 RECEIPT DATE OF SAMPLE : September 14, 2000 REPORT FILE NUMBER : 21BE0029YW-1 TEST SITE : A-PEX Yokowa NO.3 Open Test Site Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 4of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 1.1 Product Description Model: ASTU13 (referred to as the EUT in this report) is a Keyless Entry System (Transmitter). The specification is as following : Operation Frequency : 4 MHz Carrier Frequency : 315 MHz Operation Voltage : DC 3.2V 1.2 Tested Equipment Details Model FCC ID (1) CALSONIC KANSEI M/N: ASTU13 KBRASTU13 Description Keyless Entry System (Transmitter) Cable description Backshell Material --- P.V.C (EUT) 1.3 Tested Methodology Radiated testing were performed according to the procedures in FCC/ANSI C63.4 (1992). 1.4 Test Facility The open area test site and conducted measurement facility used to collect the radiated data is located on 108 Yokowa-cho, Ise-shi, Mie-ken 516-1106 Japan. This site has been fully described in a report submitted to FCC office, and listed on September 12, 2000 (Registration number: 90412). Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 5of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 2 SYSTEM TEST CONFIGURATION 2.1 Operation Environment Temperature : 23℃ Humidity 60% Power supply : DC 3.2V 2.2 Justification The system was configured in typical fashion (as a customer would normally use it) for testing. 2.3 EUT Exercise Software The EUT exercise program used during radiated testing was designed to exercise the various system components in a manner similar to typical use. The sequence is used: Operation Mode Transmitting 2.4 Test Procedure Tabletop Equipment Radiated Emissions EUT was placed on a platform of nominal size, 1m by 1.5m, raised 80cm above the conducting ground plane. Test was made with the antenna positioned in both the horizontal and vertical planes of polarization. The measurement antenna was varied in height above the conducting ground plane to obtain the maximum signal strength. The measurement distance was 3m. Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 6of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 Figure2.1 Configuration of Tested System Front View (1):EUT * Test data was taken under worse case conditions. Top View (1):EUT * Test data was taken under worse case conditions. Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 7of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 3 RADIATED MEASUREMENT PHOTOS Figure 3.1 Radiated Measurement Photos Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 8of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 3.1 Measurement Uncertainty Radiated Emission Test The measurement uncertainty (with a 95% confidence level) for this test was ±3.3dB. ■ The data listed in this test report may exceed the test limit because it does not have enough margin (more than 3.3dB). □ The data listed in this test report has enough margin, more than 3.3dB. Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 9of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 4 RADIATED EMISSION DATA The initial step in collecting radiated data was a spectrum analyzer peak scan of the measurement range (30MHz-3300MHz). The final data was reported in the worst-case emissions. The minimum margin to the limit is as follows : Frequency (MHz) Receiver Reading (dBμV) 315.00 78.2 Correction Factor (dBμV) -3.8 Field Strength (dBμV/m) 74.4 Limit (dBμV/m) 75.6 Margin (dBμV) 1.2 * quasi-peak mode The Fundamental Frequency of this equipment is 315MHz. The peak of output level of fundamental frequency was confirmed at the 315MHz by perfarming the meaurement. It was corroborated that equipment was within of the tolerance which is prescribed in the FCC requlation Part 15 Subpart C sec. 15.231 (c). Since the fundamental frequency is 315MHz, the upper limit could be 315.8 MHz and lower limit could be 314.2MHz. The measurement result was 315.2MHz when the limit was 315.8MHz and also another measurement result was 314.8 MHz when the limit was 314.2MHz. Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 10of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 5.1 Field Strength Calculation The field strength is calculated by adding the Antenna Factor, Cable Factor and Antenna Pad, and subtracting the Amplifier Gain from the measured reading. The sample calculation is as follows : FS = RA + AF + CF + AT - AG where FS = Field Strength RA = Receiver Amplitude AF = Antenna Factor CF = Cable Factor AT = Antenna Pad AG = Amplifier Gain Assume a receiver reading of 78.2 dBμV is obtained. The antenna Factor of 14.0 dB, Cable Factor of 4.5 dB and Antenna Pad of 6.0 dB is added. The Amplifier Gain of 28.3 dB is subtracted, giving a field strength of 74.4 dBμV/m. FS = 78.2 + 14.0 + 4.5 + 6.0 – 28.3 = 74.4 dBμV/m Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 11of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 6 TEST EQUIPMENT USED INSTRUMENTS Mfr. MODEL C/N Calibrated Until ■ Pre Amplifier Hewlett Packard 8447D AF1 November 16, 2000 □ Pre Amplifier Anritsu MH648A AF3 November 16, 2000 ■ Pre Amplifier Hewlett Packard 8449B AF4 November 16, 2000 □ Attenuator Anritsu MP721B AT6 June 8, 2001 □ Biconical Antenna Schwarzbeck BBA9106 BA1 April 28, 2001 □ Biconical Antenna Schwarzbeck BBA9106 BA3 April 28, 2001 ■ Biconical Antenna Schwarzbeck BBA9106 BA5 April 28, 2001 ■ Horn Antenna A.H. Systems SAS200/571 HA1 February 4, 2001 ■ Logperiodic Antenna Schwarzbeck UHAP9108-A LA6 April 29, 2001 □ Logperiodic Antenna Schwarzbeck UKLP9140-A □ Loop Antenna Rohde & Schwarz HFH2-Z2 LP1 November 3, 2000 □ LISN Rohde & Schwarz ESH2-Z5 LS1 November 15, 2000 □ LISN Rohde & Schwarz ESH3-Z5 LS2 November 15, 2000 □ LISN Schwarzbeck NSLK8127 LS3 November 15, 2000 □ LISN Rohde & Schwarz ESH3-Z5 LS4 November 15, 2000 □ LISN Schwarzbeck NNLK8121 LS5 November 15, 2000 □ LISN Rolf Heine NNB-4/200 LS6 November 15, 2000 □ LISN Schwarzbeck NNLK8126 LS7 November 15, 2000 □ LISN Schwarzbeck NSLK8127 LS10 April 8, 2001 □ Spectrum Analyzer Hewlett Packard 8567A SA3 December 13, 2000 ■ Spectrum Analyzer Hewlett Packard 8567A SA4 December 13, 2000 ■ Spectrum Analyzer Advantest R3271 SA5 September 27, 2000 □ Test Receiver Rohde & Schwarz ESHS-20 TR1 March 30, 2001 ■ Test Receiver Rohde & Schwarz ESVS-30 TR2 July 13, 2001 □ Test Receiver Rohde & Schwarz ESCS30 KTR1 August 7, 2001 LA8 April 29, 2001 ■ indicates EMI Test Equipment used. *All measurement equipment is traceable to national standard. Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232 Test report Our reference : 21BE0029YW-1 Page : 12of 12 Issued date : October 5, 2000 FCC ID : KBRASTU13 APPENDIX A : Test Data Radiated emissions A1 – A3 Testing Laboratory A-pex International Co., Ltd. 108 Yokowa-cho, Ise-shi Mie-ken 516-1106 JAPAN Telephone: +81 596 39 1485 Facsimile: +81 596 39 0232
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.2 Linearized : No Producer : Acrobat Distiller 4.05 for Windows Creator : Microsoft Word 9.0 Modify Date : 2000:12:21 08:04:55-07:00 Author : ??:?2??? Title : MEASUREMENT/TECHNICAL REPORT Create Date : 2000:12:21 08:04:32 Page Count : 12 Page Mode : UseNoneEXIF Metadata provided by EXIF.tools