Snapper Lt 100 Series Users Manual PartsManual
2015-01-24
: Snapper Snapper-Lt-100-Series-Users-Manual-226633 snapper-lt-100-series-users-manual-226633 snapper pdf
Open the PDF directly: View PDF 
.
Page Count: 50
| Download | |
| Open PDF In Browser | View PDF |
Parts Manual for HYDRO DRIVE ELECTRIC CLUTCH LAWN TRACTOR LT-100 SERIES MODEL CLT23460 (7800344) CLT24520 (7800345) LT23460 (7800207) LT24520 (7800212) SLT23460 (7800342) SLT24520 (7800343) McDonough, GA, 30253 U.S.A. Briggs & Startton Yard Power Products Group Copyright © 2008 Briggs & Startton Corporation Milwaukee, WI USA. All Rights Reserved Manual No. Revision C, 1/30/2008 7006261 TP 400-5330-C-TC-N Table Of Contents PAGE 4 8 10 14 18 20 22 26 30 32 34 36 38 40 42 44 46 GROUP Hood / Seat Group Steering Group Main Frame Group Motion Drive Group Fuel Tank Group Engine Group 46" Mower Housing Assembly 46" Mower Deck Group 50" Mower Housing Assembly 50" Deck Blade Drive Assembly 50" Deck Housing Suspension Assembly 52" Mower Housing Assembly 52" Deck Blade Drive Assembly 52" Deck Housing Suspension Assembly Decals Electrical Group Wiring Schematic HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 3 7006261 TP 400-5330-C-TC-N Manual No. 7006261 TP 400-5330-C-TC-N 4 HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Hood / Seat Group Item Part No 1 2 3 4 5 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 33 34 35 36 7091016 721487 7101355 1960392 1732031 1732030 1933896 7090952 7101493 7101770 7101771 725181 722858 722411 7300677D 1727294D 1727295D 1722110D 1731891 1960295 1930641 7102076 7300820 7101894 7300805 7101891 7102074 7300696Z 7300697Z 7300810Z 7400252Z 7101860 721257 7300875D 720102 720360 721259 Qty 4 1 1 2 1 1 2 4 1 1 1 1 16 2 1 1 1 1 1 12 12 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 Description Note HWST 1/4CX5/8 BEARING, STEERING CONSOLE TRACTOR SCREW, PHILLIPS HD HOOD GUIDE, RH HOOD GUIDE, LH (not shown) NUT, HEX LOCK 10C W/ NYL INSERT BZ SCREW, 1/4-20 THREAD CUTTING CUTTING HEIGHT INDICATOR POD W/ DETENT POD W/ COMPARTMENT CONTAINER, BATTERY CAPSCREW, 5/16-18 SPRING, COMPRESSION 2.43LENGTH SEAT DECK PANEL HOOD RH SIDE PANEL HOOD LH SIDE HOOD, W/ LOUVERS AIR DUCT, PLASTIC SCREW, HEX WZ LOCK FLNG 1/4-20X0.625 BLK HFLN, 1/4-20 LARGE BLK CRUISE ROD LINK LATCH, CRUISE ROD, PIVOT CRUISE CHANNEL - CRUISE CRUISE - ACTUATOR PULL KNOB, 1/4-20 THREAD DASH, SUPPORT BRKT RH DASH, SUPPORT BRKT LH BRACKET, SUPPORT CRUISE WELDMENT, CLUTCH ROD SUPPORT SEAT, HI BACK SUPPORT, SEAT SUPPORT, SEAT BOLT, SHOULDER 5/16-18 CAP, PUSH ON ROD, PIVOT (was 7400261, weldment) used on model SLT24520 Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 5 7006261 TP 400-5330-C-TC-N Hood / Seat Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 6 LT-100 SERIES Hood / Seat Group Item Part No 37 38 39 40 41 42 43 44 44 45 46 47 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 721214 722851 720163 721425 720101 721258 727614 721531 7300794D 7091298 720146 721276 7300865Z 720182 7101772 7101773 7300818Z 7300772Z 7300658Z 7300657Z 7101657 720142 7101458 1727296 1728973 1728974 1723451 1677371 1728059D 7101810 Qty 1 4 2 2 1 1 1 1 1 2 1 1 1 12 1 1 1 1 1 1 2 2 1 1 1 1 2 2 1 1 Description Note SPRING, LEAF SCREW 1/4-14X.38”STFW, .34X.62X16GA BOLT, WING, 0.62L X 5/16-18 UNC 2A BOLT, SHOULDER 1/4-20 X 3.652 2A WASHER, CUP, 1.50 OD X 0.344 ID SPRING, COMPRESSION 4.57 FREE LENGTH PIVOT, BRACKET SEAT BRACKET SEAT PIVOT HLN, 5/16-18-3B YZ ESNA NUT, 1/4-20 HF PLATE, INDEX PLATE, INDEX FASTENER PANEL MAT, LEFT MAT, RIGHT STIFFENER, STEERING BULKHEAD HOOD, PIVOT LH HOOD, PIVOT RH BOLT, SHOULDER NUT, HEX FLANGE, 3/8-16 NC HARNESS, HEADLIGHT, TCT, 1/4 TERMINALS HEADLIGHT ASSY (Includes #'s 59, 60, 61, & 62) REFLECTOR, HEADLIGHT LENS, HEADLIGHT SOCKET, LIGHT BULB, 12.8V (1141) GRILLE, SNAPPER INSERT, LIGHT BAR used on model SLT24520 used on model SLT24520 Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 7 7006261 TP 400-5330-C-TC-N Steering Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 8 LT-100 SERIES Steering Group Item Part No 1 2 3 4 5 6 7 8 9 10 11 729275 727628 720973 7101525 722867 721242 725138 720119 722620 721318 7101566 Qty 1 1 1 1 2 1 1 1 2 2 2 Description Note COVER, INTEGRA STEERING WHEEL (SOFT RIM) BELLOWS - STEERING POST STEERING POST - 24.56” LONG CAPSCREW 5/16-18 BEARING - LOWER GEAR PINION SNAP RING, 0.543”ID FW, 1.862X .765 X 16GA HUB CAP WHEEL & TIRE ASSY, 18X6.50-8 Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 9 7006261 TP 400-5330-C-TC-N Main Frame Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 10 LT-100 SERIES Main Frame Group Item Part No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 7400221Z 7300869 7300870 722858 729075 7300876 7300866 7300864 7300689 7300741 722616 7300819 720099 7300877 7091809 7091619 7013866 725131 7500525 7300868 721221 7300863 7300817 7300830 7091008 7500601 7300831 7400237 7092081 7300751 725130 7010935 729160 7400232 7400231 720142 720166 Qty 1 1 1 54 5 1 1 1 1 1 1 1 1 1 3 6 2 2 1 2 3 1 1 1 2 1 1 1 2 1 4 4 1 1 1 2 2 Description Note ASSEMBLY, MAIN FRAME RAIL, FRAME LH RAIL, FRAME RH CAPSCREW 5/16-18 SCREW, THREAD FORMING 10-24X.340MIN THREADS TOP, REAR PLATE PLATE, REAR PLATE, HITCH PLATE, IDLER PULLEY HYDRO GEAR BRACKET, BATTERY SUPPORT WASHER PLAIN .406 X 2.25 BRACKET, PIVOT SHOULDER BOLT, 1.563L X 0.75D X 9/16 X 3/8-16 LIFT HANDLE LINK PIN, COTTER 1/8 X 1.25 YZ HFLN, 3/8-16 YZ WASHER 1-1/2 OD SPACER - LIFTER PIVOT LIFTER WELDMENT PLATE, STIFFENING PIN - THREADED SHOULDER PLATE, ENGINE BRACKET, MUFFLER MOUNTING BRACKET, TRANSAXLE LH RHSSNB, 3/8CX2-1/2 ASSY, IDLER BRKT (SECONDARY) BRACKET, TRANSAXLE RH WELDMENT - BRAKE LEVER HFLN, 5/16-24 BZ BRACKET, HANGER REAR BEARING SPINDLE WASHER, .77X1.13X.06 GT AXLE - CAST IRON WELDMENT - SPINDLE LH WELDMENT - SPINDLE RH NUT, HEX FLANGE, 3/8-16 NC FW, .41 X.82 X 16GA (includes 1 thru 54 below) was M721603 was M721604 was M728900 was M728478 was M726871 was 7300741 was M721190 was M725122 was M728409 was M721187 was M725215 was M721271 was M721270 was M721456 Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 11 7006261 TP 400-5330-C-TC-N Main Frame Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 12 LT-100 SERIES Main Frame Group Item Part No 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 720192 722580 7300861 7300860 7300742 720211 7500524 7090585 720103 7300867Z 721293 721240 721241 7027168 7101805Z 7101806Z 7091619 721095 Qty 2 2 1 1 1 2 1 3 2 1 2 1 1 1 1 1 2 2 Description Note BOLT, HEX, 3/8-16 UNC X 1.50 BRIGHT ZINC WASHER, FLAT, 25/64” ID X 1” OD X 14 GA. HANGER, DECK RH HANGER, DECK LH AXLE, HANGER HHB, 5/16-24 X 2.75 BOLT SECTOR GEAR ASSY (GEAR DRIVE - LT) HFLN, 5/16-18 BZ BOLT, SHOULDER 3/8-16 PLATE, STEERING MT SCREW - GUIDE GEAR - SECTOR BEARING - SECTOR GEAR HHCS, 5/16-18 X 1 YZ DRAG, LINK LH DRAG, LINK RH HFLN, 3/8-16 YZ FITTING - LUBRICATION (1/4-28 Self-Tap) was M721198 was M721199 was M728334 Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 13 7006261 TP 400-5330-C-TC-N Motion Drive Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 14 LT-100 SERIES Motion Drive Group Item Part No 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 7101332 7101669 7101569 7101568 7101567 7012234 7101563 7101562 7101558 7012234 720215 727761 722440 721204 725137 720145 722620 720010 721318 720142 2860694 7300888 7091495 7900057 7101653 7035500 720258 720139 720018 7300684Z 7300701Z 7101542 720069 7101453 7102053 7046451 7300682Z Qty 1 1 2 1 1 1 2 1 1 1 4 1 1 1 1 4 2 2 2 1 2 1 2 3 1 1 2 8 4 1 1 1 5 1 1 1 1 Description Note TRANSAXLE, HYDRO GEAR #310-0510 TRANSAXLE, HYDRO GEAR #310-0610 ASSY, WHEEL & TIRE, 22X9.50-12 (incl. next 3 items) TIRE, 22X9 50-12 2PLY K358 RIM, 12X7 INT W/3 5 LG HUB SILVER VALVE STEM, TR 412 ASSY, WHEEL & TIRE, 20X10-8 (incl. next 3 items) TIRE, 20X10-8 2PLY K358 RIM, 8 X 7 BROACHED HUB WHEEL SILVER VALVE STEM, TR 412 HHB, 5/16-18X2.50 BOLT, 3/8-16 x 2” Square Neck Carriage SPRING, Extension Lift STUD, Spring Mounting (5/16-18) STUD, Swivel (3/8-16) NUT, HEX FLANGE LOCK, 5/16-18 NC FW, 1.862X .765 X 16GA E-RING, .750D X .050T HUB CAP NUT, HEX FLANGE, 3/8-16 NC NUT, 1/4-20 Hex Flange Lock (Nyloc) PLATE, Forward Stop SCREW, 1/4-20 x 3/4” Hex Head Cap, GR 5 SCREW, #12-24X.50 HWST FAN 7.0” (TEN BLADE) BELT, DUAL SPINDLE BRAKE 3/16 SQ KEY - REAR WHEELS HEX NUT, 5/16-18 FLANGE SER YZ BOLT, 5/16-18 x 5/8” Hex Head, GR 5 TORQUE BRACKET - HYDRO BRKT, ROLL RELEASE ROLL RELEASE LEVER HAIR PIN, .56D-.092T ROD - REAR DRIVE ROD, PIVOT DRIVE SWIVEL, Adjustment (3/8-24) BRACKET SUPPORT used on 21 H. P. used on 23 H.P. & 24 H.P. used on 23 H.P. & 24 H.P. used on 21 H. P. HA Sect.; 85.4” Effective Length Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 15 7006261 TP 400-5330-C-TC-N Motion Drive Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 16 LT-100 SERIES Motion Drive Group Item Part No 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 7200130 722598 7400248Z 1721675 720049 727933 7101454 7500602 722451 721419 725178 725167 725177 720148 721420 7300934 720100 7101801 720164 720387 726795 7101489 7101455 720870 720257 Qty 2 2 1 1 3 1 1 1 1 1 1 1 1 2 1 1 1 1 2 1 1 1 1 1 1 Description Note SPACER, AXLE WASHER, 3/4 I.D. x 1-1/4” Flat WELDMENT, FOOT CONTROL PAD, FORWARD FOOT BOLT CARRIAGE, 5/16-18 X .62 SPRING, Extension ROD - FRONT DRIVE (3/8-24) WELDMENT, IDLER ARM SPRING CLUTCH PIVOT BUSHING IDLER PULLEY - 3” DIA. SPACER 1/2” TO 17MM IDLER PULLEY - 2.75 DIA. NUT FLANGE, 3/8-16 ZINC PLATED NUT-TEE (3/8-16) LINK, Clutch SHOULDER BOLT, 1/4-20X3.75 SPRING, HYDRO BRAKE WASHER, .39 Flat PIN, .090 x 3/4” Cotter LATCH - PARKING BRAKE ROD - CLUTCH DRIVE (3/8-16) ROD - PARKING BRAKE GRIP CLUTCH / BRAKE PEDAL Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 17 7006261 TP 400-5330-C-TC-N Fuel Tank Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 18 LT-100 SERIES Fuel Tank Group Item Part No 1 2 3 4 5 6 7101521 7101520 727333 7300653Z 722866 7091016 Qty 1 1 1 1 2 2 Description Note FUEL TANK, TRACTOR W/CAP (SNAPPER) FUEL TANK, TRACTOR FUEL CAP TANK BRKT SCREW .25-20 X0.59 HEX HWST 1/4CX5/8 (or 7101421 Cap w/tether) Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 19 7006261 TP 400-5330-C-TC-N Engine Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 20 LT-100 SERIES Engine Group Item Part No Qty 1 1 1 1 2 3 4 5 6 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 1 1 2 1 1 1 1 1 4 2 1 1 1 1 4 1 1 1 1 1 1 1 720663 727816 725220 725221 1727817 1722955 720045 720664 7500533Z 7101543 7101706 7101323 722861 728664 722866 722605 720183 721325 721180 7300662 Description Note * ENGINE, 19.5HP B&S INTEK SINGLE CYL Mod. 445577-0755- (not shown) E1 * ENGINE, 23HP B&S ELS 2-CYL, Mod. 44L777-0125-B1 * ENGINE, 24HP B&S, ELS, Mod. 44M777-0113-E1 (not shown) SCREW, TORX HEAD 5/16-18 X 5/8 YZ all EXHAUST TUBE SINGLE 21 H.P. EXHAUST TUBE RH 23 H.P. & 24 H.P. EXHAUST TUBE LH 23 H.P. & 24 H.P. THROTTLE ASSY, DUAL LEVER 23 H.P. & 24 H.P. THROTTLE, SINGLE (not shown) 21 H.P. HHST, 3/8-16X1.25 all WASHER, 5/16-18 HEX HEAD all ASSY - HEAT SHIELD all ADAPTER - ELECTRIC PTO all CLUTCH, ANCHOR PAD all CLUTCH, ELECTRIC OGURA all SCREW - THREAD FORMING, 0.88 X 3/16-15 all BRKT - MUFFLER all SCREW .25-20 X0.59 HEX all WASHER .470- 1.00.25 FLT all WASHER, .43-.074 X .04 STAR all MUFFLER - SINGLE 21 H.P. MUFFLER 23 H.P. & 24 H.P. GUARD, HEAT SHIELD (EURO) 23 H.P. Footnotes: NOTE: * Purchase engine parts from engine manufacturer dealer. HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 21 7006261 TP 400-5330-C-TC-N 46" Mower Housing Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 22 LT-100 SERIES 46" Mower Housing Assembly Item Part No Qty Description Note 1 2 3A 3B 4 5 7300671 722397 726069 7101744 721447 726958 1 3 2 2 3 1 MOWER DECK HOUSING, 46” NUT-NYLOCK RING - PULLEY 9/16-18 S.S. PULLEY 46” PULLEY JACKSHAFT HOUSING ASSY SHAFT, SPLINED 6 726957 2 BALL BEARING, JACKSHAFT 7 726959 1 JACKSHAFT HOUSING 8 721095 1 FITTING - LUBRICATION (1/4-28 Self-Tap) 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 720097 726498 722511 720049 726831 720139 720142 722485 726830 720045 728320 7400226 720091 720989 721308 721310 722858 720145 727317 725149 721309 722512 728319 721446 725179 720658 722601 722600 2 2 1 19 1 3 2 1 1 15 1 1 5 1 1 1 4 6 1 1 1 1 1 2 3 3 3 3 SHOULDER BOLT, 3/8-16X1.06 PLATE SUSPENSION SPRING, TORSION RH BOLT CARRIAGE, 5/16-18 X .62 BRACKET, RIGHT REAR HEX NUT, 5/16-18 FLANGE SER YZ NUT, HEX FLANGE, 3/8-16 NC SPRING BRACKET, BELL CRANK HHST, 3/8-16X1.25 BRACKET, COVER ASSY - IDLER ARM, 46”, RH SHOULDER BOLT, 0.75 X 0.60 X 3/8-16 GUIDE, BELT BRACKET - BRAKE MTG 46' BRACKET, BRAKE PLATE CAPSCREW 5/16-18 NUT, HEX FLANGE LOCK, 5/16-18 NC BRACKET, LEFT GAUGE WHEEL BRACKET, PULLEY COVER BRACKET, LEFT LIFTER SPRING, TORSION RH BRACKET, HINGE SPACER, PULLEY BLADE ADAPTER BLADE (15.68") WASHER-BELLEVILLE 1.0 X .625 X .200 WASHER - HARDENED 1.0OD X .625ID X .188 (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 23 7006261 TP 400-5330-C-TC-N 46" Mower Housing Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 24 LT-100 SERIES 46" Mower Housing Assembly Item Part No 37 38 39 40 41 42 722382 720908 721364 728906 720053 720372 Qty 3 2 1 1 1 1 Description Note NUT, BLADE, 9/16-18 ZINC PLATE YELLOW CHROMATE GUIDE, SCREW BRACKET, RIGHT GAUGE WHEEL BRACKET, FRONT DECK CARRIAGE BOLT BOLT RETAINER Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 25 7006261 TP 400-5330-C-TC-N 46" Mower Deck Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 26 LT-100 SERIES 46" Mower Deck Group Item Part No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 721222 720161 721250 721402 725226 722579 720069 720098 725230 720142 721313 722871 721315 729075 720416 720404 720148 725225 720091 7500566 727459 720163 720387 722441 721311 722510 725171 725167 7400227 7500565 720392 720173 721118 721197 721376 721263 722858 Qty 2 2 2 2 2 3 2 2 2 6 1 3 1 2 1 1 2 1 3 1 1 1 1 1 1 2 1 2 1 1 2 2 2 2 2 1 2 Description Note KNOB WASHER FLAT, 1.0 X .328 X 16GA FRICTION PAD PIN - HANGER 3/8-16 X 1.25 LINK, LIFT WASHER - FLAT, 1.0”OD X 0.550” HAIR PIN, .56D-.092T SHOULDER BOLT, 3/8-16 X .600OD X.95L BRACKET, REAR SUSPENSION NUT, HEX FLANGE, 3/8-16 NC COVER, LEFT PULLEY SCREW COVER, RIGHT PULLEY SCREW, THREAD FORMING 10-24X.340MIN THREADS BELT, PRIMARY (88.30" HA) 46” MOWER BELT, SECONDARY (47.10" HA) 46” MOWER NUT FLANGE, 3/8-16 ZINC PLATED PULLEY IDLER SHOULDER BOLT, 0.75 X 0.60 X 3/8-16 BRAKE ASSEMBLY CENTER LINK BELLCRANK FW, .34X.62X16GA PIN - COTTER, 0.75 X 0.090 SPRING BELLCRANK SPRING, TORSION BRAKE PULLEY BACKSIDE IDLER, 4.0 OD SPACER 1/2” TO 17MM ASSY - IDLER ARM, 46” ASSY - BRAKE LH 46” CLIP - HAIR PIN WASHER, FLAT, .81 X .550 X 16GA WHEEL GAGE BOLT AXLE, 3/8-16 X 3.0 ROD, DECK SUSPENSION ROD, HANGER CAPSCREW 5/16-18 Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 27 7006261 TP 400-5330-C-TC-N 46" Mower Deck Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 28 LT-100 SERIES 46" Mower Deck Group Item Part No 38 39 40 41 42 43 44 45 46 721346 721312 720390 721453 720983 720982 720360 722504 721017 Qty 1 1 1 1 1 1 1 1 1 Description Note BRACKET, FRONT SUSPENSION STIFFENER COTTER PIN ROLLER DEFLECTOR, INSIDE DEFLECTOR, CHUTE CAP, PUSH ON SPRING - TORSION ROD, DEFLECTOR Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 29 7006261 TP 400-5330-C-TC-N 50" Mower Housing Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 30 LT-100 SERIES 50" Mower Housing Assembly Item Part No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 726814 722858 720049 720139 720145 726824 720097 726498 722511 722512 726373 720142 728319 727152 726473 726823 721457 721336 726790 721399 Qty 1 4 26 20 3 1 2 2 1 1 1 2 1 1 1 1 2 1 1 1 Description Note BLADE HOUSING 50/52 CAPSCREW 5/16-18 BOLT CARRIAGE, 5/16-18 X .62 HEX NUT, 5/16-18 FLANGE SER YZ NUT, HEX FLANGE LOCK, 5/16-18 NC BRACKET GAGE WHEEL RH REAR SHOULDER BOLT, 3/8-16X1.06 PLATE SUSPENSION SPRING, TORSION RH SPRING, TORSION RH BRACKET LIFTER RH 50” NUT, HEX FLANGE, 3/8-16 NC BRACKET, HINGE BRACE LH LIFTER BRACKET LIFTER LH BRACKET GAGE WHEEL LH REAR BRACKET GAGE WHEEL 52” BRACKET FRONT DECK 50” BAFFLE 48/52 RH BOTTOM BRACKET CHUTE SUPPORT Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 31 7006261 TP 400-5330-C-TC-N 50" Deck Blade Drive Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 32 LT-100 SERIES 50" Deck Blade Drive Assembly Item Part No Qty Description Note 1 2 3 7500607 721447 721446 1 3 1 ASSY, MOWER HOUSING 48/50/52” JACKSHAFT HOUSING ASSY SPACER, PULLEY 4 726957 2 BALL BEARING, JACKSHAFT 5 726958 1 SHAFT, SPLINED 6 726959 1 JACKSHAFT HOUSING 7 721095 1 FITTING - LUBRICATION (1/4-28 self-Tap) 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 720142 725179 721334 722600 722382 720192 7090122 721385 7300924 720148 720139 720049 7300923 720091 726842 726855 726069 726507 721313 722871 722859 721315 720045 728320 722438 7400265 725167 725225 721081 725149 1 3 3 6 3 1 1 1 1 1 2 2 1 1 1 1 4 3 1 3 2 1 15 1 1 1 1 1 1 1 NUT, HEX FLANGE, 3/8-16 NC BLADE ADAPTER BLADE 50/52 (17.66") WASHER - HARDENED 1.0OD X .625ID X .188 NUT, BLADE, 9/16-18 ZINC PLATE YELLOW CHROMATE BOLT, HEX, 3/8-16 UNC X 1.50 BRIGHT ZINC WASHER, 3/8” Flat SAE PULLEY BACKSIDE IDLER ARM - IDLER NUT FLANGE, 3/8-16 ZINC PLATED HEX NUT, 5/16-18 FLANGE SER YZ BOLT CARRIAGE, 5/16-18 X .62 BRACKET - BRAKE MOUNTING SHOULDER BOLT, 0.75 X 0.60 X 3/8-16 BELT SECONDARY 52.75" HA V-BELT A WEDGE 103.10 HA S.S. PULLEY 46” NUT PULLEY COVER, LEFT PULLEY SCREW SCREW THREAD FORMING COVER, RIGHT PULLEY HHST, 3/8-16X1.25 BRACKET, COVER SPRING, EXTENSION ASSEMB-IDLER ARM 50” SPACER 1/2” TO 17MM PULLEY IDLER ROD BELT GUIDE BRACKET, PULLEY COVER (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) ref. 725117 & 7300922) ref. 726514 ref. 1734048 (was 721338) Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 33 7006261 TP 400-5330-C-TC-N 50" Deck Housing Suspension Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 34 LT-100 SERIES 50" Deck Housing Suspension Assembly Item Part No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 7500606 721380 720161 721402 728667 720142 720098 721212 721197 721118 722579 720392 720360 721017 720982 721453 722858 728665 720390 721376 720069 721263 721312 720185 Qty 1 2 2 2 2 8 2 2 4 4 6 4 2 1 1 1 4 1 1 2 2 1 1 4 Description Note ASSY, BLADE DRIVE 50/52” WINGNUT WASHER FLAT, 1.0 X .328 X 16GA PIN - HANGER 3/8-16 X 1.25 LINK, LIFT NUT, HEX FLANGE, 3/8-16 NC SHOULDER BOLT, 3/8-16 X .600OD X.95L BRACKET, REAR SUSPENSION BOLT AXLE, 3/8-16 X 3.0 WHEEL GAGE WASHER - FLAT, 1.0”OD X 0.550” CLIP - HAIR PIN CAP, PUSH ON ROD, DEFLECTOR DEFLECTOR, CHUTE ROLLER CAPSCREW 5/16-18 BRACKET, SUSPENSION FRONT COTTER PIN ROD, DECK SUSPENSION HAIR PIN, .56D-.092T ROD, HANGER STIFFENER WASHER ref. 7300921D ref. 7300826D ref. 7300767D ref. 7300871D Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 35 7006261 TP 400-5330-C-TC-N 52" Mower Housing Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 36 LT-100 SERIES 52" Mower Housing Assembly Item Part No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 726814 722858 720049 720139 720145 726824 720097 726498 722511 722512 726373 720142 728319 727152 726473 726823 721457 721336 726790 721399 Qty 1 4 26 20 3 1 2 2 1 1 1 2 1 1 1 1 2 1 1 1 Description Note BLADE HOUSING 50/52 CAPSCREW 5/16-18 BOLT CARRIAGE, 5/16-18 X .62 HEX NUT, 5/16-18 FLANGE SER YZ NUT, HEX FLANGE LOCK, 5/16-18 NC BRACKET GAGE WHEEL RH REAR SHOULDER BOLT, 3/8-16X1.06 PLATE SUSPENSION SPRING, TORSION RH SPRING, TORSION RH BRACKET LIFTER RH 50” NUT, HEX FLANGE, 3/8-16 NC BRACKET, HINGE BRACE LH LIFTER BRACKET LIFTER LH BRACKET GAGE WHEEL LH REAR BRACKET GAGE WHEEL 52” BRACKET FRONT DECK 50” BAFFLE 48/52 RH BOTTOM BRACKET CHUTE SUPPORT Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 37 7006261 TP 400-5330-C-TC-N 52" Deck Blade Drive Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 38 LT-100 SERIES 52" Deck Blade Drive Assembly Item Part No Qty Description Note 1 2 3 7500607 721447 721446 1 3 1 ASSY, MOWER HOUSING 48/50/52” JACKSHAFT HOUSING ASSY SPACER, PULLEY 4 726957 2 BALL BEARING, JACKSHAFT 5 726958 1 SHAFT, SPLINED 6 726959 1 JACKSHAFT HOUSING 7 721095 1 FITTING - LUBRICATION (1/4-28 self-Tap) 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 720142 725179 721334 722600 722382 720192 7090122 721385 7300924D 720148 720139 720049 7300923 720091 726842 1734048 726069 726507 721313 722871 722859 721315 720045 728320 722438 7400265 725167 725225 721081 725149 1 3 3 6 3 1 1 1 1 1 2 2 1 1 1 1 4 3 1 3 2 1 15 1 1 1 1 1 1 1 NUT, HEX FLANGE, 3/8-16 NC BLADE ADAPTER BLADE 50/52 (17.66") WASHER - HARDENED 1.0OD X .625ID X .188 NUT, BLADE, 9/16-18 ZINC PLATE YELLOW CHROMATE BOLT, HEX, 3/8-16 UNC X 1.50 BRIGHT ZINC WASHER, 3/8” Flat SAE PULLEY BACKSIDE IDLER ARM - IDLER NUT FLANGE, 3/8-16 ZINC PLATED HEX NUT, 5/16-18 FLANGE SER YZ BOLT CARRIAGE, 5/16-18 X .62 BRACKET - BRAKE MOUNTING SHOULDER BOLT, 0.75 X 0.60 X 3/8-16 BELT SECONDARY 52.75” HA V-BELT A WEDGE 103.10" HA S.S. PULLEY 46” NUT PULLEY COVER, LEFT PULLEY SCREW SCREW THREAD FORMING COVER, RIGHT PULLEY HHST, 3/8-16X1.25 BRACKET, COVER SPRING, EXTENSION ASSEMB-IDLER ARM 50” SPACER 1/2” TO 17MM PULLEY IDLER ROD BELT GUIDE BRACKET, PULLEY COVER (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) (per Jackshaft Housing Assembly) ref. 725117 & 7300922) ref. 726514 ref. 726855 -52 (was 721338) Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 39 7006261 TP 400-5330-C-TC-N 52" Deck Housing Suspension Assembly Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 40 LT-100 SERIES 52" Deck Housing Suspension Assembly Item Part No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 7500606 721380 720161 721402 7300921D 720142 720098 7300826D 721197 721118 722579 720392 720360 721017 720982 721453 722858 7300767D 720390 721376 720069 721263 7300871D 720185 Qty 1 2 2 2 2 8 2 2 4 4 6 4 2 1 1 1 4 1 1 2 2 1 1 4 Description Note ASSY, BLADE DRIVE 50/52” WINGNUT WASHER FLAT, 1.0 X .328 X 16GA PIN - HANGER 3/8-16 X 1.25 LINK, LIFT NUT, HEX FLANGE, 3/8-16 NC SHOULDER BOLT, 3/8-16 X .600OD X.95L BRACKET, REAR SUSPENSION BOLT AXLE, 3/8-16 X 3.0 WHEEL GAGE WASHER - FLAT, 1.0”OD X 0.550” CLIP - HAIR PIN CAP, PUSH ON ROD, DEFLECTOR DEFLECTOR, CHUTE ROLLER CAPSCREW 5/16-18 BRACKET, SUSPENSION FRONT COTTER PIN ROD, DECK SUSPENSION HAIR PIN, .56D-.092T ROD, HANGER STIFFENER WASHER Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 41 7006261 TP 400-5330-C-TC-N Decals Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 42 LT-100 SERIES Decals Item Part No 1 2 3 4 5 6 7 8 8 8 9 10 10 10 11 12 13 14 15 16 17 7102191 7102192 7101965 7102196 7102211 7101933 7101937 7102197 7102198 7102199 7101936 7102193 7102194 7102195 7101939 7101938 7101934 7101940 7101935 7101394 724017 7101663 7101664 7101665 7102210 724023 724026 Qty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 Description Note DECAL, Snapper Name Plate, RH DECAL, Snapper Name Plate, LH DECAL, Ignition DECAL, Snapper Logo, Rear DECAL, Snapper Logo, Steering Wheel DECAL, Operation DECAL, Deck Level DECAL, 19.5 hp (not shown) DECAL, 23 hp DECAL, 24 hp (not shown) DECAL, Drive Pedal DECAL, 46” Deck (not shown) DECAL, 42” Deck (not shown) DECAL, 52” Deck DECAL, Belt/Clutch DECAL, Height of Cut DECAL, Park Brake DECAL, Weight Limitation DECAL, Roll Release DECAL, Warning, Rear Discharge Door DECAL, Gage Wheel Instruction DECAL-Umber (not shown) DECAL-No Step (not shown) DECAL, Danger Do Not Operate w/o Deflector (not shown) DECAL, Height of Cut Snapper (not shown) DECAL, Deck Level (not shown) DECAL, Gage Wheel Leveling (not shown) Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 43 7006261 TP 400-5330-C-TC-N Electrical Group Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 44 LT-100 SERIES Electrical Group Item Part No 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 7101446 721516 721249 720123 720349 720057 720588 720348 7060618 1722887 7026343 727338 721461 722851 722393 721615 7023354 1726556 1726557 1727185 Qty 1 1 1 2 1 2 1 1 1 1 1 1 1 3 2 1 1 1 1 1 Description Note HARNESS, WIRING, HYDRO TCT, ELEC PTO SWITCH, LIMIT, NO, SNAP-IN SWITCH, LIMIT, NO/NC, SNAP-IN WINGNUT, 1/4-20 NC-2 TAP CABLE, BAT 8GA 12.00L - BLACK CARRIAGE BOLT, 0.63L X 1/4-20 2A BOOT, BATTERY POSITIVE CABLE, BAT 8GA 18.00L - RED BATTERY, 12 VOLT, 230 CCA SWITCH, PTO, YELLOW, VERTICAL SYMBOLS SWITCH, IGNITION-AFTERFIRE SOLENOID CAP, IGNITION SWITCH KEY, IGNITION SCREW, 1/4-14X.38”ST NUT, HEX LOCK 1/4-20 BZ SOLENOID, 3 POLE SWITCH, SEAT SWITCH, REV MOW OPTION MODULE ONLY W/KEY KEY (CHERRY) KEY W/ HANG TAG replaces 7100449 (not shown) (not shown) (not shown) Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 45 7006261 TP 400-5330-C-TC-N Wiring Schematic Manual No. 7006261 TP 400-5330-C-TC-N HYDRO DRIVE ELECTRIC CLUTCH 46 LT-100 SERIES Wiring Schematic Item Part No 1 Qty 1 Description Note Wiring Schematic for Harness # 7101446 Footnotes: HYDRO DRIVE ELECTRIC CLUTCH LT-100 SERIES Manual No. 47 7006261 TP 400-5330-C-TC-N Parts Manual for HYDRO DRIVE ELECTRIC CLUTCH LAWN TRACTOR LT-100 SERIES IT IS THE POLICY OF BRIGGS & STRATTON CORP TO IMPROVE ITS PRODUCTS WHENEVER IT IS POSSIBLE AND PRACTICAL TO DO SO. WE RESERVE THE RIGHT TO MAKE CHANGES OR ADD IMPROVEMENTS AT ANY TIME WITHOUT INCURRING ANY OBLIGATION TO MAKE SUCH CHANGES ON PRODUCTS McDonough, GA, 30253 U.S.A. Briggs & Startton Yard Power Products Group Copyright © 2008 Briggs & Startton Corporation Milwaukee, WI USA. All Rights Reserved Manual No. Revision C, 1/30/2008 7006261 TP 400-5330-C-TC-N
Source Exif Data:
File Type : PDF File Type Extension : pdf MIME Type : application/pdf PDF Version : 1.5 Linearized : No Page Count : 50 Page Layout : SinglePage XMP Toolkit : XMP toolkit 2.9.1-13, framework 1.6 About : uuid:31195612-049c-4b47-8cc7-92a4d998de0c Producer : Acrobat Distiller 6.0 (Windows) Creator Tool : PScript5.dll Version 5.2 Modify Date : 2008:01:30 13:55:03-05:00 Create Date : 2008:01:30 13:47:36-05:00 Metadata Date : 2008:01:30 13:55:03-05:00 Document ID : uuid:ef98f3e6-7181-4fa4-ab73-b5cf1b5f1805 Format : application/pdf Title : PartsManual Creator : 200316 Author : 200316EXIF Metadata provided by EXIF.tools